Upload
dokien
View
220
Download
4
Embed Size (px)
Citation preview
ANNUAL GENERATOR MAINTENANCE Facility:Gen Mfgr: YEARGen S/N: Date of Maintenance:
Who Performed: VISUAL CHECK REPL TEST
Tank Vents & Overflow x xPiping x
Gas in Main Tank (if used) x Gal
Oil Change x QtsOil Filter x Type
Anti-Freeze x GalRod Heat Exchanger cleanClean Exterior of Rad x clean
Inspect duct; Clean Louvers x x cleanLouver motors & Controls x clean x
Excess Backpressure xExh sys Hangers/Supports x
Tighten wiring connections xATS Main Contracts x clean
Calib Volt-Sense Devices x x
Generator Oil x x QtsIgnition System x x x x
Injector Pump & Injectors x
Commutator & Slip Rings x cleanRotor & Stator x clean
Bearings x xBearing Grease x x
Exciter x x xVoltage Regulator x x x
Winding Resistance x
Based on NFPA 110 (1999 ed) Appendix A
ENGINE
GENERATOR
EXHAUST SYSTEM
ELECTRICAL SYSTEM
Notation of any unsatisfactory condition and the corrective action taken, including parts replaced. Tests must be documented of any repair for the appropriate time as recommended by the manufacturer.
A 1
ENTER RESULTS OF INSPECTIONSFUEL SYSTEM
LUBRICATION SYSTEM
COOLING SYSTEM
QUARTERLY GENERATOR MAINTENANCE Facility:YEAR Qrt 1 Qrt 2 Qrt 3 Qrt 4
Date of Maintenance:Who Performed:
VISUAL CHECK CLEAN TEST FUEL Strainer, Filter, Dirt Leg xLUBE Crankcase Breather x xEXHAUST Insulation & Fire Hazards xBATTERY Terminals Clean & Tight x xELECTRICAL Wire Chafing x x
SEMI-ANNUAL GENERATOR MAINTENANCE
Date of Maintenance:Who Performed:
VISUAL CHECK CLEAN TESTCOOLING Antifreeze Level x 0F Protection 0F Protection
EXHAUST Flex Exhaust Section xELECTRICAL Safeties & Alarms x xELECTRICAL Boxes, panels xGENERATOR Air Cleaner Svc x xGENERATOR Choke & Carb Adjust xGENERATOR Brush length & operation x x x
Based on NFPA 110 (1999 ed) Appendix A
Notation of any unsatisfactory condition and the corrective action taken, including parts replaced. Tests must be documented of any repair for the appropriate time as recommended by the manufacturer.
ENTER RESULTS OF INSPECTIONS
SA 1 SA 2