PUZZLE - CityLift · PUZZLE Our most popular and versatile mechanicalparking solution is the Puzzle.It comes in 2, 3, 4, 5, 6, and 7 -level configurations; with or without pits and

PUZZLE

SPECIFICATION SHEET

PUZZLE

Our most popular and versatile mechanical parking solution is the Puzzle. It comes in 2, 3, 4, 5, 6, and 7-level configurations; with or without pits and is ideal for new construction or retrofits. This mechanical parking lift also works in a tandem configuration without impacting retrieval time. They are widely used in residential, mixed use, and public garages in impacted urban areas. Replacing traditional stackers with the Puzzle can drastically reduce valet costs since each space is independently accessed. The Puzzle can be used indoors or outdoors and requires a minimum clear height of 11’ 7 3/4” beginning with the 2 level system.

33 SECONDSAVERAGE RETRIEVALTIME

UP TO 7 LEVELS2 - 7 LEVEL CONFIGURATIONS

40,000SPACES INSTALLED

© CityLift Parking | www.cityliftparking.com | 844.388.0424

PUZZLE


TWO-LEVEL

MODEL NO 2LP

NOTES:• Recommended and minimum car heights:o SUV: 6’ – 3” o Sedan: 5’ – 5”• Additional sizes can be customized. See Car Sizes page.• Each dimension has a tolerance of:

6” for length, 6” for width, and 3” for height• Recommend 4” depressed slab if doing ground level installation

for flat driving onto platform• Usable space dimensions will not change for flat pallets• 6” needed from back of rear column to face of wall

CAR SIZES

RECOMMENDED MINIMUM

UPPER 6’ - 3” 5’ - 5”GROUND 7’ - 0” 6’ - 3”

HEIGHT OPTIONS

19' 35/16" min

6’ - 3”rec(seetable)


GROUND

UPPER

LENGTH WIDTH

UPPER 17’ - 03/4” 6’ - 10”GROUND 17’ - 03/4” 6’ - 10”

13’ – 7” recommended

6”

4”


TWO-LEVEL

NOTES:• Depth depends on the concrete strength specified• Typical base plate dimensions are 12”x12” design may vary based on design• 5/8” thick plate with 1/4” HSS design may vary based on actual design• Use existing building footing to support Puzzle steel column• If no existing building footing is available, then 3’x3’ footing with 2’ thick slab is

typically required


THREE-LEVEL W/PIT

MODEL NO 3LPWP

20’

UPPER

PIT

CAR SIZES

RECOMMENDED MINIMUM

UPPER 6’ - 3” 5’ - 5”GROUND 7’ - 0” 6’ - 3”

PIT 8’ - 6” 7’ - 0”

HEIGHT OPTIONS

LENGTH WIDTH

UPPER 17’ - 03/4” 6’ - 10”GROUND 17’ - 03/4” 6’ - 63/4”

PIT 17’ - 03/4” 6’ - 63/4”

GROUND

6”

2”





22’ - 3”



4”


THREE-LEVEL W/PIT

NOTES:• Rod inbedment and sizevaries

on structural wall design


THREE-LEVEL AND UP

MODEL NO 3LP, 4LP, 5LP, 6LP, 7LP

20’

GROUND

UPPER2

CAR SIZES

RECOMMENDED MINIMUM

UPPER 2 6’ - 3” 5’ - 5”UPPER 1 6’ - 3” 5' - 5”GROUND 7’ - 0” 6’ - 3”

HEIGHT OPTIONS

LENGTH WIDTH

UPPER 2 17’ - 03/4” 6’ - 10”UPPER 1 17’ - 03/4” 6’ - 63/4”GROUND 17’ - 03/4” 6’ - 63/4”

UPPER 120' -2”

6”

4”

4”








THREE-LEVEL AND UP

NOTES:• Dimensions will vary depending on size of platform and design of structure


TWO-ROW (TANDEM)

MODEL NO 2LPNPT

18’ - 77/16” 18’ -77/16”

13’ -7”4”

X”Dimension varies based on shared

column or city requirement


6’ - 3”rec

7’ - 0”rec

FLAT PALLET (OPTIONAL FEATURE)

In addition to our standard platforms, we also offer the option to have a completely flat pallet with no side bumpers.

Note: Images are prototype. Final design can change. Additional costs are incurred for flat pallet design.


TECHNICAL SPECS

Average Retrieval Time Ranges from 30-90 seconds depending on systemMaximum VehicleWeight 5,200 pounds (6,000 pounds optional)Electrical Requirement 480 3-Phase or 208 3-PhaseLifting Motor 4.0kW-4P or 2.2 kW-4P (5.5kW for +5 Systems)

Traverse Motor 0.37 kW-4PControl Method PLC controlCircuit Breaker ABB S204-C40Operation Method Button type or touch panel controlEmergency Stop Switch XB2-BS542COptoelectronic Switch LA31/K31/25/31/115Remote Monitoring Primitive Logic / AMIDrive System/Motor SEW-GermanyPLC/Sensor RockwellApplicable Code CA Building Code, 2016 editionSeismic Loads Ch.15 ASCE 7-10: Steel ordinary moment frameMachine Bolts Min tensile strength = 900 MPAnchor Bolts/Rods ASTM F1554, GR.55Welding Electrodes 480 MP (E-70 KSI) MIN


CAR SIZES

Note: Standard load is 5,200 lbs per vehicle. Heavier loads available. Individual cars should be measured for size fit. Above is a sample list of 2016 model cars that can fit on the different platform sizes given a 6’ horizontal clear height. This list is not meant to be comprehensive or exahaustive.

LARGE

BMW 5-Series Audi Q5 Tesla Model S Volvo XC60MEDIUM

Audi A6 BMW X5 Dodge Durango Jeep Grand Cherokee

SMALL

Acura ILX BMW 3-Series Honda Civic Lexus IS

LARGE MEDIUM SMALL

LENGTH WIDTH LENGTH WIDTH LENGTH WIDTH17’ - 03/4” 6’ - 10” 16’ - 5” 6’ - 10” 15’ - 9” 6’ - 10”17’ - 03/4” 6’ - 63/4” 16’ - 5” 6’ - 63/4” 15’ - 9” 6’ - 63/4”

NOT AVAILABLE NOT AVAILABLE NOT AVAILABLE NOT AVAILABLE 15’ - 9” 6’ - 43/4”

NOTES:• Recommended car sizes are listed above• Additional sizes can becustomized• Each dimension has a tolerance of:

6” for length, 6” for width, and 3” for height• Recommend 4” depressed slab if doing ground level installation for flat driving onto platform• Usable space dimensions will not change for flat pallets

SAMPLE CAR LIST


EQUIPMENT SIZES

NOTES:• Equipment Length: 6“ back clearance needed for cable tray and installation • Equipment Width: 6" clearance needed at two sides for vehicle door opening• Length and Width are measured from edge of base plate to edge of base plate• 6LP and 7LP configurations are high-rise custom-made Puzzle systems. Column and

sizes are subject to change per project based on site condition/roofing/skin/etc.


2LP LENGTHRECOMMENDED WIDTH MINIMUM WIDTH

2 BAYS 3 BAYS 2 BAYS 3 BAYSS 18'-2 3/4" 16'-11 7/8" 25'-2 3/8" 16'-1/8" 23’-8 5/8"M 18'-10 5/8" 16'-11 7/8" 25'-2 3/8" 16'-1/8" 23’-8 5/8"L 19'-6 1/2" 16'-11 7/8" 25'-2 3/8" 16'-1/8" 23’-8 5/8"

3LPWP LENGTHRECOMMENDED WIDTH MINIMUM WIDTH

2 BAYS 3 BAYS 2 BAYS 3 BAYSS 18'-8 3/4" 16'-11 7/8" 25'-2 3/8" 16'-1/8" 23’-8 5/8"M 19'-6" 16'-11 7/8" 25'-2 3/8" 16'-1/8" 23’-8 5/8"L 20'-3 1/4" 16'-11 7/8" 25'-2 3/8" 16'-1/8" 23’-8 5/8"

3LP LENGTHRECOMMENDED WIDTH MINIMUM WIDTH

2 BAYS 3 BAYS 2 BAYS 3 BAYSS 20'-2 1/2" 17'-4 7/8" 25'-7 1/4" 16'-9" 24’-7 1/2"M 20'-10 3/8" 17'-4 7/8" 25'-7 1/4" 16'-9" 24’-7 1/2"L 21'-6 1/4" 17'-4 7/8" 25'-7 1/4" 16'-9" 24’-7 1/2"

4LPWP LENGTHRECOMMENDED WIDTH MINIMUM WIDTH

2 BAYS 3 BAYS 2 BAYS 3 BAYSS 20'-8 3/8" 17'-4 7/8" 25'-7 1/4" 16'-9" 24’-7 1/2"M 21'-4 1/4" 17'-4 7/8" 25'-7 1/4" 16'-9" 24’-7 1/2"L 22'- 1/8" 17'-4 7/8" 25'-7 1/4" 16'-9" 24’-7 1/2"

4LP / 5LP LENGTHRECOMMENDED WIDTH MINIMUM WIDTH

2 BAYS 3 BAYS 2 BAYS 3 BAYSS 20'-9 5/8" 17'-4 7/8" 25'-7 1/4" 16'-9" 24’-7 1/2"M 21'-5 1/2" 17'-4 7/8" 25'-7 1/4" 16'-9" 24’-7 1/2"L 22'-1 3/8" 17'-4 7/8" 25'-7 1/4" 16'-9" 24’-7 1/2"

CAR RETRIEVAL

1. Except for the top level, one space will be missing from each level. This allows for each car to be indepently accessible via kiosk or remote key fob. For the blue car to be retrieved, 3 cars from levels 1-3 will move to the right.

2. This allows for the blue car to drop to ground level.

3. Blue car is ready to be retrieved.

1 23


CITYLIFT PARKING1901 Poplar St, Suite B, Oakland, CA 94607

[email protected]

www.cityliftparking.com

Oakland | Boston | Los Angeles | New York | Seattle

© CityLift Parking 2020

Documents

PUZZLE - CityLift · PUZZLE Our most popular and versatile mechanicalparking solution is the Puzzle.It comes in 2, 3, 4, 5, 6, and 7 -level configurations; with or without pits and