Upload
others
View
3
Download
2
Embed Size (px)
Citation preview
PRE-FEASIBILITY REPORT OF
RED OCHRE AND CHINA CLAY MINING PROJECT OF MOHAMMAD FARUQ
LEASE AREA –4.524 HECTARES
MINING PROJECT - CATEGORY-“B”
VILLAGE- SAND, TEHSIL- BHADESAR,
DISTRICT- CHITTORGARH STATE- RAJASTHAN
PROJECTPROPONENT
SHRI MOHAMMAD FARUQ
Village & Post: Sawa
Tehsil & District-Chittorgarh (Raj)
Pin-312001
PROJECT CONSULTANT
M/S. GREENCINDIA CONSULTING PRIVATE LIMITED
607-611, SHOPPRIX MALL, LEVEL-5SECTOR-5, VAISHALI,
GAZIABAD-201010
GHAZIABAD NABET/EIA/RA014/041 607-611, SHOPPRIX MALL, LEVEL-5 5, VAISHALI GHAZIABAD- 201010
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
TOC
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 1
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
TABLE OF CONTENTS
1 EXECUTIVE SUMMARY ...................................................................................................................................... 1
1.1 Salient feature of the project: ...................................................................................................................... 1
2 INTRODUCTION OF THE PROJECT/BACKGROUND INFORMATION .......................................................... 4
2.1 Identification of Project Proponent, In case of mining project, a copy of mining lease /letter of intent should be given.......................................................................................................................................................... 4
2.1.1 Project Proponent: .............................................................................................................................. 4
2.1.2 Address of the Lessee: ....................................................................................................................... 4
2.1.3 Mining Lease Area .............................................................................................................................. 4
2.2 Brief Description of Nature of Project: ........................................................................................................ 4
2.2.1 Extent of Mechanization: .................................................................................................................... 5
2.3 Need for the project and its importance to the country and region ........................................................... 5
2.3.1 Need for the project and importance in the country ......................................................................... 5
2.3.2 Demand and Supply Gap ................................................................................................................... 6
2.3.3 Imports V/s indigenous production .................................................................................................... 6
2.3.4 Export possibility ................................................................................................................................. 6
2.3.5 Domestic/Exports Markets ................................................................................................................. 6
2.3.6 Employment Generation (Direct & Indirect) due to the project ........................................................ 7
3 PROJECT DESCRIPTION ................................................................................................................................... 8
3.1 Type of Project including interlinked and interdependent projects, if any ................................................ 8
3.2 Location (map showing general location, specific location, and project boundary & project site layout) with coordinates. ........................................................................................................................................................ 8
3.3 Details of alternate sites considered and the basis of selecting the proposed site, particularly the environmental considerations gone into should be highlighted. ............................................................................. 8
3.4 Size and Magnitude of Operation ............................................................................................................... 8
3.5 Project description with process details (a schematic diagram/flow chart showing the project layout, components of the project etc. should be given) ..................................................................................................... 9
3.6 Raw material required along with estimated quantity, likely source, marketing area of final products/s, Mode of transport of raw Material and Finished Product. ..................................................................................... 11
3.7 Resource optimization/recycling and reuse envisaged in the project, if any, should be briefly outlined. 11
3.8 Availability of water its source, Energy/power requirement and source should be given...................... 11
3.9 Quantity of wastes to be generated (liquid and solid) and scheme for their management/disposal .... 12
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
TOC
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 2
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
3.9.1 The nature & quality of top soil over burden/waste and mineral rejects likely to be generated during next 5 years ............................................................................................................................................. 12
3.9.2 Land chosen for disposal of waste with proposed justification: ..................................................... 12
3.10 Schematic representations of the feasibility drawing which give information of EIA purpose............... 13
4 SITE ANALYSIS.................................................................................................................................................. 15
4.1 Connectivity ................................................................................................................................................ 15
4.2 Land Form, Land use and land Ownership .............................................................................................. 15
4.3 Topography ................................................................................................................................................ 15
4.4 Existing land use pattern (agriculture, non-agriculture, forest, water bodies (including area under CRZ)), shortest distances from the periphery of the project to periphery of the forests, national park, wild life sanctuary, eco sensitive areas, water bodies (distance from the HFL of the river), CRZ. In case of notified industrial area, a copy of the Gazette notification should be industrial AREA; a copy of the Gazette notification should be given........................................................................................................................................................ 15
4.4.1 Shotest distance from the Eco Sensitive Areas: ............................................................................. 16
4.5 Existing Infrastructure ................................................................................................................................ 17
4.6 Soil classification:....................................................................................................................................... 18
4.7 Climate data from Secondary Sources: .................................................................................................... 18
4.7.1 Climate Condition (30 years IMD Data)........................................................................................... 18
4.8 Social Infrastructure Available................................................................................................................... 22
5 PLANNING BRIEF .............................................................................................................................................. 23
5.1 Planning concept (type of industries, facilities, transportation etc) Town and country Planning/Development authority Classification ..................................................................................................... 23
5.2 Population Projections ............................................................................................................................... 23
5.3 Land Use planning (breakup along with green belt etc.) ......................................................................... 23
5.4 Assessment of Infrastructure Demand (Physical & Social) ..................................................................... 24
5.5 Amenities/Facilities .................................................................................................................................... 24
6 PROPOSED INFRASTRUCTURE..................................................................................................................... 25
6.1 Industrial Area (Processing Area) ............................................................................................................. 25
6.2 Resident Area (Non Processing Area) ..................................................................................................... 25
6.3 Afforestation: .............................................................................................................................................. 25
6.3.1 Progressive Afforestation during proposal period:.......................................................................... 25
6.4 Social Infrastructure ................................................................................................................................... 25
6.5 Connectivity (Traffic and transportation Road/Rail/Metro/Water ways etc) ........................................... 25
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
TOC
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 3
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
6.6 Drinking Water Management (Source & supply of water) ....................................................................... 25
6.7 Sewerage System ...................................................................................................................................... 26
6.8 Industrial Waste Management .................................................................................................................. 26
6.8.1 Solid waste Management ................................................................................................................. 26
6.8.2 Power Requirement .......................................................................................................................... 26
The service Electric Line is connected to bore well motor in the applied lease area. The electric facility is available at applied Mining Lease area. ................................................................................................................. 26
7 REHABILITATION AND RESETTLEMENT(R&R PLAN) ................................................................................. 27
7.1 Policy to adopted (Central State) in respect of the project affected person including home outsees, land outsees and landless labour ........................................................................................................................... 27
8 PROJECT SCHEDULE AND COST ESTIMATES............................................................................................ 28
8.1 Likely date of start of construction and likely date of Completion (Time schedule for the project to be given) 28
8.2 Estimated project cost and along with analysis in terms of economic viability of them project. ........... 28
9 ANALYSIS OF PROPOSAL (FINAL RECOMMENDATION) CONCLUSION ................................................. 29
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
TOC
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 4
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
LIST OF TABLE
Table 1-1: Salient feature of the project........................................................................................................................ 1
Table 2-1: Mining lease Area......................................................................................................................................... 4
Table 2-2: Loading Equipment ...................................................................................................................................... 5
Table 2-3: Haulage Within lease holds area ................................................................................................................ 5
Table 2-4: Miscellaneous Equipment ............................................................................................................................ 5
Table 2-5: Employment Potential .................................................................................................................................. 7
Table 3-1: Location Coordinates ................................................................................................................................... 8
Table 3-2 Year wise production of minerals ................................................................................................................. 9
Table 3-3: Year-wise waste Generation ..................................................................................................................... 12
Table 4-1: Details of land use of the mine Lease Area .............................................................................................. 15
Table 4-2: Land use Pattern Of Mine Lease .............................................................................................................. 16
Table 4-3: Distance from Eco sensitive Area ............................................................................................................. 16
Table 4-4: Climatology & meteorology of the Study Area.......................................................................................... 18
Table 5-1: Details of land use breakup ....................................................................................................................... 23
Table 6-1: year Wise Afforestation Program .............................................................................................................. 25 LIST OF FIGURES
Figure 3-1: Flow chart of the project ........................................................................................................................... 11
Figure 3-2:Clearance process for category-B Project ................................................................................................ 14 ANNEX
Annex-1 Location Map
Annex-2 Coordinate Map
Annex-3 Study Area map
Annex-4 Letter Of Intent (LOI)
Annex-5 NOC From Forest Department
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
1
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 1
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
1. EXECUTIVE SUMMARY Red Ochre and China Clay mining project of Shri Mohammad Faruq is located at Village- Sand, Tehsil- Bhadesar, District-Chittorgarh and State- Rajasthan over an area of 4.524 ha. The proposed capacity of the project is Red Ochre-62863 Tonnes/Annum and China Clay-59023 Tonnes/Annum. Out of total land of 4.524 ha, 2.3038 ha is a private land and remaining 2.2202 ha is a govt. land. Open cast other than Semi mechanized mining method is adopted for this project. Brief description of the project is described below.
1.1 Salient feature of the project: Table 1-1: Salient feature of the project
Sl. No.
Parameters Description
1 Name of the project Red Ochre and China Clay mining project of Shri Mohammad Faruq
2 Nature of the project China clay and Red Ochre Mining (Major Mining)
3 Project Proponent Shri Mohammad Faruq
4 Lease period validity Proposed lease period validity is 30 years.
5 Date of grant of lease The state Govt. has issued Letter of Intent (LOI) vide letter no. Ni kha Bhu/Nimbha/CC-5/P1 (1) 160/13/4014 dated 02/06/2014. Attched as Annex-4
6 Details of the Lease Area Khasra Number-171,172-Govt. Land and
Khasra Number-172/12, 173,174,175,176,177,179- private Land
7 Total Lease area 4.524 Ha
8 Capacity of the project Red Ochre-62,863 Tonnes/Annum and China Clay-59,023 Tonnes/Annum
9 Category of the project “B”
10 Location of the project Village- Sand, Tehsil- Bhadesar, District-Chittorgarh and
State- Rajasthan
11 Lease area Coordinate Points Latitude Longitude
A N 24° 44’ 03.9” E 74° 33’ 18.9”
B N 24° 44’ 3.0” E 74° 33’ 7.9”
C N 24° 44’ 4.3” E 74° 33’ 6.7”
D N 24° 44’ 7.2” E 74° 33’ 6.4”
E N 24° 44’ 8.3” E 74° 33’ 18.4”
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
1
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 2
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
Sl. No.
Parameters Description
Coordinate map is attached as a Annex-2 12 Land Type Private Land : 2.3038 Ha
Govt. land : 2.2202 Ha
13 Method of Mining Open cast Semi Mechanized Mining 14 Operational days/year 300
15 Total water requirement 7.3 KLD
16 Source of water Tube wells & Dug wells
17 Man power requirement 49 persons
18 Nearest Railway Station / Airport along with distance in kms.
Maharana Pratap Airport-about 69 km in WSW direction.
Shambupura Railway Station-About 10 km in ENE direction
19 Nearest Town, city, District Headquarters along with distance in kms.
Nearest City- Nimbahera (About 17 km in SE direction)
District Headquarter-Chittorgarh (About 18 km in NNE direction)
20 Ecological Sensitive Areas (Wild life Sanctuaries, National Parks, Biosphere Reserves, Reserve/ Protected Forest etc)
i. RF Near Village Asawara- About 10 km in SSW direction.
ii. RF Near Village Bhadesar- About 7 km in SW direction.
iii. RF Near Village Machhlkhera- About 100 m in W direction.
iv. RF Near Village Gizand- About 14.50 km in ENE direction.
v. RF Near Village Kanchariya- About 6.3 km in NE direction.
vi. RF Near Village Sarlai- About 8 km in NW direction.
vii. RF Near Village Panchtotalo- About 7.7 km in N direction.
viii. RF Near Village Thakrava- About 12 km in NE direction. ix. RF Near Village Satpara- About 11.2 km in NE direction.
x. PF Near Village Asawara- About 3 km in SSW direction.
xi. PF Near Village Bhavnath ki Kheri- About 8.5 km in S direction
xii. PF Near Village Machhlkhera - About 1 km in NE direction.
xiii. PF Near village Sand- About 1.5 km in E direction.
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
1
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 3
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
Sl. No.
Parameters Description
xiv. PF Near village Palri- About 4 km in SSE direction.
21 Historical Places None
22 Nearest Forest PF Near Village Machhlkhera - About 1 km in NE direction.
23 Financial & Social benefit This Project is providing employment to local people directly and indirectly.
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
2
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 4
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
2. INTRODUCTION OF THE PROJECT/BACKGROUND INFORMATION
2.1 Identification of Project Proponent,(In case of mining project, a copy of mining lease /letter of intent should be given).
2.1.1 Project Proponent:
Shri Mohammad Faruq
2.1.2 Address of the Lessee:
Shri Mohammad Faruq S/O Shri Gulbaz Khan Village & Post: Sawa
Tehsil & District-Chittorgarh (Raj)
Pin-312001
2.1.3 Mining Lease Area
Table 2-1: Mining lease Area
Area Ownership/occupancy 2.3038 Ha Private land
2.2202 Ha Government land
4.524 Ha Total land
2.2 Brief Description of Nature of Project: The applied lease area is a part of the previous held and sanctioned area(M.L 25/1980).The lease area was held in favour of Ajajudeen Shaik.In the applied lease area , the mineral Red Ochre and China Clay is exposed in the tube well, old well and old trenches.The tube well cutting shows mineral availability, in the lease area.Red Ochre and China Clay mining project near village- Sand Tehsil-Bhadesar, District-Chittorgarh and State-Rajasthan over an area of 4.524 ha. The proposed capacity of the project is 62,863 Tonnes/Annum of Red Ochre and 59,023Tonnes/Annum of China Clay.
The state govt. has issued Letter of Intent (LOI) vide letter no. Ni kha Bhu/Nimbha/CC-5/P1 (1) 160/13/4014 dated 02/06/2014. (Copy enclosed as Annex - 4).
Mine Plan has been approved by Indian Bureau of Mines, Udaipur vide letter number 682(23)(819)/2014-MCCM(N)UDAI dated 05/09/2014
The project China Clay & Red Ochre mine shall be developed by semi mechanized opencast Mining. The OB and mineral are soft and easily minable. So no drilling or blasting is required. The OB shall be removed by excavator/JCB.As per the approved mine plan, no secondary blasting is needed. There shall be no use of explosives and hence no storage of explosive is required.The main operation shall be digging, shorting and the transportation by trucks. The Mineral trucks are to be loaded by excavator. The mined mineral china clay shall be collected in the mineral stack yard and then sorted over there manually before its final dispatch to various industries through trucks. The sub-grade mineral generated shall be collected in sub-grade stack yard and then
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
2
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 5
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
shall be then mixed with high-grade mineral for use in various industries. The waste generated shall be carried through trucks to the dump yard in the southeast part of the lease area. The Bench height shall 3m and bench width shall be more than 3m.
2.2.1 Extent of Mechanization:
2.2.1.1 Loading Equipment: Table 2-2: Loading Equipment
Type Nos Bucket Capacity in Cu.m. Make Motive Power H.P.
Hydraulic excavator
(Hi-200) 1 1.2 m3 Hitechi Diesel 136HP
2.2.1.2 Haulage & Transportation Equipment
2.2.1.3.1. Haulage with in the lease holds area: Table 2-3: Haulage Within lease holds area
Type Nos Size Capacity Make Motive Power H.P.
Tipper 10 tonner 4 10 tonner Ashok Leyland
Diesel 75HP
2.2.1.3 Miscellaneous: Table 2-4: Miscellaneous Equipment
Type NOS Size Capacity
Make Motive Power H.P.
Water tanker with sprinkler arrangement with tractor
1 5000ltd. Local Diesel engine -
2.3 Need for the project and its importance to the country and region
2.3.1 Need for the project and importance in the country
Red Ochre Mineral, is one of the major ore of Iron. Red Ochre is obtained from iron or ferruginous in contaminated form. In addition to being the most important ore of iron, Red Ochre is a constituent of a number of abrasives and pigments. The principle industrial use of Red Ochre is in Tiles & Ceramic Industry, Plastic & Rubber Industry, Paints and Dyes industry, Ceramics, Fertilizer, Brake Lining and Cement Industry
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
2
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 6
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
The principal use of China Clay is in Cement Industry. Other important uses are as flux in metallurgical processes; in Glass, Ceramic, Paper, paper industry; and as soil conditioning agent in agriculture; crushed china clay stone is used for ballast and filler in concrete and asphalt. The china clay stone is used as rectangular slab in lithography.
Consumption of both of these minerals are very high in the industry. Thus requirement of these valuable minerals also is increasing day by day.
2.3.2 Demand and Supply Gap
Cement industry alone consumed about 97% of total production of the ochre. The remaining consumption was together shared by ceramic, foundry, glass, paint and paper industries. A sizeable quantity is believed to have been consumed by small-scale units as well as cottage industries.
Consumption of China Clay increased to 1,489 thousand tonnes in 2011-12, from 1,488 thousand tonnes in 2010-11. Cement Industry accounted for 45% consumption followed by ceramic (42%), the major consumer of raw china clay. Pesticide, paint, refractory, paper, cosmetic, rubber, abrasive, asbestos products, chemical, dry cell batteries, textile, electrical, electrode and glass industries together accounted for the remaining 13%.
Rajasthan continued to be the leading producing State of ochre, contributing 93% of the total production in 2011-12 followed by Andhra Pradesh 4%, Madhya Pradesh 3% and remaining minor production was contributed by Gujarat & Karnataka.
Gujarat was the leading producing state of china clay accounting for 48% of the total production in 2011-12 followed by Kerala (23%), Rajasthan (17%), Jharkhand (5%) and West Bengal (3%). The remaining 4% was shared by Andhra Pradesh, Karnataka and Madhya Pradesh.
Based on the above, it is cleared that demand is always high as compared to the supply.
(Source: Indian mineral year book 2012)
2.3.3 Imports V/s indigenous production
Development needs will be met only through indigenous production of Red Ochre and China Clay material against the high cost of imported material.
(Source: Indian Mineral Year Book 2012)
2.3.4 Export possibility
There is no proposal to export the Granite. However, mineral produced from the mine will fulfil the needs of the region and surplus if any, will be considered for export.
(Source: Indian Mineral Year book 2012).
2.3.5 Domestic/Exports Markets
Red Ochre and China Clay is produced in this mine is being marketed to cement plant and other industries. The proposed mining activity is for indigenous consumption only for industries. There is no proposal to export the mineral.
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
2
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 7
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
2.3.6 Employment Generation (Direct & Indirect) due to the project
There are 49 has employed form nearest villages. The workers are coming from semi-skilled and unskilled both sectors.
Table 2-5: Employment Potential
Mining Engineer 1 full time
Geologist 1 Part time
Mines Manager 1 full time
Mines Mate/Mines Foreman 1 full time
Watchmen
1 full time
Skilled Labours 20 full time
Operators 9 full time
Unskilled Labours 15 full time
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
3
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 8
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
3. PROJECT DESCRIPTION
3.1 Type of Project including interlinked and interdependent projects, if any
As per Gazette notification of Ministry of Environment and Forest (MoEF), New Delhi all projects less than 50 hectare falls in category “B” As in this case, the lease area is 4.524 hectare, so this project also falls in “B” category. No interlinked projects are involved.
3.2 Location (map showing general location, specific location, and project boundary & project site layout) with coordinates.
This is a China Clay and Red Ochre Mining project and located near Village Sand of Tehsil Bhadesar in the District of Chittorgarh over an area of 4.524 Ha. Out of total land of 4.52 ha, 2.3038 ha is a private land and remaining 2.2202 ha is a Govt. land. The mine lease area is not covered by any watercourses in the form of river, nallah etc. Location map and Study area map is attached as Annex-1 and Annex-3 respectively. The details of the project co-ordinate are described in below
Table 3-1: Location Coordinates
Points Latitude Longitude
A N 24° 44’ 03.9” E 74° 33’ 18.9”
B N 24° 44’ 3.0” E 74° 33’ 7.9”
C N 24° 44’ 4.3” E 74° 33’ 6.7”
D N 24° 44’ 7.2” E 74° 33’ 6.4”
E N 24° 44’ 8.3” E 74° 33’ 18.4”
3.3 Details of alternate sites considered and the basis of selecting the proposed site, particularly the environmental considerations gone into should be highlighted.
It is naturally occurring rocks which is site specific due to its geological origin. No alternative sites are proposed.
3.4 Size and Magnitude of Operation Opencast semi mechanized method of mining has been proposed. Proposed five year production details are shown in the following table.
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
3
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 9
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
Table 3-2 Year wise production of minerals
Year ROM
Ore in tonnes (Red Ochre)
ROM
Ore in Tonnes(China Clay)
First year 37,932 7,258.5
Second year 3,9824 18,664.5
Third year 40,040 22,411
Fourth year 4,4216 3,6812
Fifth year 62,863 59,023
2,24,875 1,44,169
3.5 Project description with process details (a schematic diagram/flow chart showing the project layout, components of the project etc. should be given)
The proposed China Clay & Red Ochre mine shall be developed by semi mechanized opencast Mining. The main operation shall be digging, shorting and the transportation by trucks. The Mineral trucks are to be loaded by excavator. The mined mineral China Clay shall be collected in the mineral stack yard and then sorted over there manually before its final dispatch to various industries through trucks. The sub-grade mineral generated shall be collected in sub-grade stack yard and thereafter shall be then mixed with high-grade mineral for use in various industries. The waste generated shall be transported through trucks to the dump yard in the southeast part of the lease. The Bench height shall 3m and the bench width shall be more than the bench height.
1st year: The Total mineable reserve is 315462.8 MT. During the first year of mining the applicant will excavate one bench of O/B (R.L. 459-above) and then shall be advance in the western direction. Four benches of mineral Red Ochre shall be prepared (RL 459-457, 457-454, 454-451, 451-449). About 37932MT of Mineral shall be excavated. This will include 30345.6MT of recoverable mineral & 3793.2MT Sub-Grade minerals & 3793.2 MT mineral wastes. Three benches of mineral China Clay shall be prepared (RL 449-446,446-443, 443-440). About 7258.5 MT of Mineral shall be excavated. This will include 5806.6 MT of recoverable mineral & 725.95MT of Sub Grade minerals & 725.95 MT mineral wastes & 7446 MT overburden intermix of soil. The balance mineable reserve shall be 279310.6 MT.
2nd Year - The balance mineable reserve at the beginning second year will be 27,9310.6 MT. During the second year of mining the applicant will excavate further from the surface. One Bench of O/B (R.L. 459 be above) and thereafter shall be advance in the northeast direction. Four benches of mineral Red Ochre shall be prepared (RL 459-457, 457-454, 454-451, 451-449). About 39824MT of Mineral shall be excavated. This will include 31,859.2MT of recoverable mineral, 3,982.4MT Sub-Grade minerals and 3,982.4MT mineral wastes. Three benches of mineral China Clay shall be prepared (RL 449-446,446-443, 443-440). About 18664.5MT of Mineral shall be excavated. This will include 14931.6 MT of recoverable mineral & 1866.45 MT Sub Grade minerals &
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
3
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 10
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
1866.45 MT mineral wastes. The Over burden with intermix of soil shall be generated 6128MT. The balance mineable reserve shall be 232519.8 MT.
3rd Year - The balance mineable reserve at the beginning of third year will be 2,32,519.8 MT. During the third year of the Mining, the applicant will excavate further from the surface. One benches of overburden (R.L. 459- above) and thereafter shall advance in the northeast direction. Four benches of mineral Red Ochre shall be prepared (RL 459-457, 457-454, 454-451, 451-449). About 40040 MT of Mineral shall be excavated. This will include 3,2032 MT of recoverable mineral & 4,004 MT Sub Grade minerals & 4004 ,MT mineral wastes. Three benches of mineral China Clay shall be prepared (RL 449-446,446-443, 443-440). About 22411 MT of Mineral shall be excavated. This will include 17,928.8 MT of recoverable mineral & 2,241.1 MT Sub-Grade minerals & 2,241.1 MT mineral wastes. The overburden with intermix of 5,935 MT soil shall be generated. The balance mineable reserve shall be 18,2559 MT.
4th Year- The balance mineable reserve at the beginning fourth year will be 1,82,559 MT. During the fourth year of the Mining, the applicant will excavate further from the surface. Five benches of over burden (R.L. 459-above, 459-457, 457-454, 454-451, 451-449). Four benches of mineral Red Ochre shall be prepared (RL 459-457, 457-454, 454-451, 451-449). About 44,216 MT of Mineral shall be excavated. This will include 35,372.2 MT of recoverable mineral & 4421.9MT Sub Grade minerals & 4421.9MT mineral wastes. Three benches of mineral China Clay shall be prepared (RL 449-446,446-443, 443-440). About 36,812 MT of Mineral shall be excavated. This will include 29,449.4 MT of recoverable mineral & 3,681.3 MT Sub Grade minerals & 3,681.3 MT mineral wastes. The overburden with intermix soil shall be generated 38,789 MT. The balance mineable reserve shall be 11,7737.4 MT.
5th Year- The balance mineable reserve at the beginning of the fifth year will be 1,17,737.4 MT. During the fifth year of the Mining, the applicant will excavate further from the surface. Five bench of Over Burden (R.L. 459 TO ABV, 459-457, 457-454, 454-451, and 451-449) and four benches of mineral Red Ochre shall be prepared (RL 459-457, 457-454, 454-451, 451-449). About 62,863 MT of Mineral shall be excavated. This will include 50,290 MT of recoverable mineral & 6,286.5 MT Sub Grade minerals & 6,286.5 MT mineral wastes. Three benches of mineral China Clay shall be prepared (RL 449-446,446-443, 443-440). About 59,023 MT of Mineral shall be excavated. This will include 47,218 MT of recoverable mineral & 5,902.5 MT Sub Grade minerals & 5,902.5 MT mineral wastes. The overburden with intermix soil shall be generated 73,642 MT. The balance mineable reserve shall be 97,508 MT.
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
3
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 11
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
3.6 Raw materials required along with estimated quantity, likely source, marketing area of final products/s, Mode of transport of raw Material and Finished Product.
No raw material will be required for production of Red Ochre and China Clay
Marketing area: The mineral Red Ochre is used in Cement, Paints, rubber glasses, plastic Industries, foundries, lacquers colours. The mined out China Clay from the applied area shall be used in cement industry.
The mineral will be transported to the destination industries by trucks.
3.7 Resource optimization/recycling and reuse envisaged in the project, if any, should be briefly outlined.
Water will be accumulated in the excavated mined out pit area during rains and pits shall serve as a natural ground water recharging structure. As a result of extraction of mineral, the rate of charging of ground water is likely to be increased considerably. Water collected in the sump will be used in various purposes at the mine viz. plantation, dust suppression etc.
3.8 Availability of water its source, Energy/power requirement and source should be given
Total water requirement in the mine will be about 7.3 KLD for drinking & domestic use, dust suppression and plantation. Drinking water and water for dust suppression and plantation will be collected from nearby villages.
Figure 3-1: Flow chart of the project
REMOVAL OF TOP SOIL
DIGGING
MANUAL SHORTING
MECHANICAL LOADING
TRANSPORTATION OF MINERAL
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
3
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 12
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
Besides above, rainy water will be collected in the working pit which will be used for dust suppression and plantation purpose.
Diesel shall be used as motive source of primary energy for mine machinery. Diesel will be outsourced from nearby diesel pumps.
3.9 Quantity of Wastes generated (liquid and solid) and scheme for their management/disposal
3.9.1 The nature & quality of top soil over burden/waste and mineral rejects
likely to be generated during next 5 years
3.9.1.1 Nature and Quantity of waste: The waste rocks found in the area is overburden lying over the mineral bed and rejects of sorting of intergrowth of soil with clay. The thickness of waste shall br in varying thickness of 1.5 m. The Rock fragments of small size shall also be resulting after mining.
Table 3-3: Year-wise waste Generation
Sr.
No.
Year I
II
III
IV
V
Total
1. Top Soil 1,146 943 913 1,620 2,600 7,222
2. Mineral Waste
(Red Ochre) (MT) 3,793.2 3,982.4 4,004 4,421.9 62,86.5 22,488
3. Over burden (MT) 7,446 6,128 5,935 38,789 7,3642 1,31,940
4. Mineral Waste
(China Clay) (MT) 725.95 18,66.45 2,241.1 36,81.3 5,902.5 1,44,17.3
5. Total Waste (2+3+4)
MT 11,965.15 11,976.85 12,180.1 46,892.2 8,5831 1,68,845.3
3.9.2 Land chosen for disposal of waste with proposed justification:
3.9.2.1 Selection of waste Rock Dump Site: It is in the non-mineralized zone. The topography is favorable for dumping. The area is sufficient for long-term use. To prove the barren status of proposed site, proposal of PPP has been given in exploration program.
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
3
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 13
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
3.9.2.2 Stacking of Overburden: Top Soil (1.5-2.0 m) shall be lying over the Red Ochre & China Clay. During Red Ochre and China clay mining, intermix soil shall also be generated. It is proposed to stack the rejects produced from this mine temporarily at the sites.
3.9.2.3 Stacking of Top Soil: It is also proposed to stack the topsoil (Between Grids line 100N-150N & 150E-250E) near the area where development of a “Green Belt" has been proposed.
3.9.2.4 Stacking of Sub-grades: It is also proposed to stack the Sub grade minerals separately. The Sub-grade minerals shall be used in mixing with high-grade to minerals make marketable/Avg. grade.
3.10 Schematic representations of the feasibility drawing which give information of EIA purpose
As per the Environment Impact Assessment (EIA) notification dated 14thSept. 2006 and amendment done so far, the proposal falls under category B. EIA/EMP report shall be required to get the environmental Clearance for this project from the MoEF. The baseline studies will be undertaken as per schematic diagram given as Fig 3.2
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
3
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 14
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
Figure 3-2:Clearance process for category-B Project
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
4
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 15
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
4. SITE ANALYSIS 4.1 Connectivity The lease area is about 1.00 Km West of Village Sand, Tehsil Bhadesar, District.-Chittorgarh and the area is connected to village Sand by kaccha rasta. The lease area is 11 km connected by tar road to Tehsil Bhadesar District. - Chittorgarh.The nearest Railway Station is situated at village Shambupura at about 10 km ENE direction from the project site.
4.2 Land Form, Land use and land Ownership The mine lease area is 4.524 Ha comprising of government land and private land. The government land is a a barren land not used for agriculture or the other purpose. The total lease area is non-forest land. The details of the land are given in below Table 4.1
Table 4-1: Details of land use of the mine Lease Area
Area Ownership/occupancy
2.3038 Ha Private land
2.2202 Ha Government land
4.524 Ha Total land
4.3 Topography Topographically the applied area comprises of low hilly to flat land . The altitude of the area is 460-462 m above the MSL. There is no forestland in the lease area. Following geological sequence has been observed.
Soil Cover (1.5 to 2.0 m)
Red Ochre (10 m)
China Clay (14 m)
4.4 Existing land use pattern (agriculture, non-agriculture, forest, water bodies (including area under CRZ)), shortest distances from the periphery of the project to periphery of the forests, national park, wild life sanctuary, eco sensitive areas, water bodies (distance from the HFL of the river), CRZ. In case of notified industrial area, a copy of the Gazette notification should be given.
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
4
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 16
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
Table 4-2: Land use Pattern Of Mine Lease
Sr. No.
*All the areas are given in Hectares
Forest Land Pvt.
Ag. Land
Govt. waste Land
Pvt.
Waste Land
Grazing Land Total
1 Pits & Quarries ---- ---- ---- ---- ---- ----
2 Top soil Dump ---- ---- ---- ---- ---- ----
3 Dumps ---- ---- ---- ---- ---- ----
4 Stack Yard ---- ---- ---- ---- ---- ----
5 Sub-Grade minerals stack Yard ---- ---- ---- ---- ---- ----
6 Infrastructure ( Work shop, administrative Building)
---- ---- 0.0016 ---- ---- 0.0016
7 Roads ---- ---- ---- ---- ---- ----
8 Railway ---- ---- ---- ---- ---- ----
9 Green Belt ---- ---- ---- ---- ---- ----
10 Tailing Pond ---- ---- ---- ---- ---- ----
11 Effluent Treatment Plant ---- ---- ---- ---- ---- ----
12 Mineral Separation Plant ---- ---- ---- ---- ---- ----
13 Township ---- ---- ---- ---- ---- ----
14 Non Utilized ---- ---- 2.2186 2.3038 ---- 4.5224
Total ---- ---- 2.2202 2.3038 ---- 4.524
4.4.1 Shotest distance from the Eco Sensitive Areas:
Table 4-3: Distance from Eco sensitive Area
Item Name Distances
Reserve Forest Near Village Asawara
Near Village Bhadesar
About 10 km in SSW direction.
About 7 km in SW direction.
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
4
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 17
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
Near Village Machhlkhera
Near Village Gizand
Near Village Kanchariya
Near Village Sarlai
Near Village Panchtotalo
Near Village Thakrava
Near Village Satpara
About 100 m in W direction.
About 14.50 km in ENE direction.
About 6.3 km in NE direction.
About 8 km in NW direction.
About 7.7 km in N direction.
About 12 km in NE direction.
About 11.2 km in NE direction.
Protected Forest
Near Village Asawara
Near Village Bhavnath ki Kheri
Near Village Machhlkhera
Near village Sand
Near village Palri
About 3 km in SSW direction.
About 8.5 km in S direction.
About 1 km in NE direction.
About 1.5 km in E direction.
About 4 km in SSE direction.
Water Bodies
River Bherach
River Wagon
River Gambhir
River Satkhanda
About 8.3 km in NW direction.
About 6.6 km in W direction.
About 13 km in NE direction.
About 9 km in E direction.
4.5 Existing Infrastructure Access to the applied lease area
The lease area is about 1.00 Km West of Village Sand, Tehsil Bhadesar, District.-Chittorgarh and the area is connected to village Sand by kaccha rasta. The lease area is 11 km connected by tar road to Tehsil Bhadesar District. - Chittorgarh.
Road/Rail link
The nearest Railway Station is situated at village Shambupura at about 10 km ENE direction from the project site
Availability of water
The Ground water table is 50 m (in rainy season) to 55 m (in Dry Season).
Power supply
The electric facility is available at the Mining Lease area and the service electric line is connected to the Bore Well motor located in the lease area.
Climate
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
4
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 18
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
The climate in the lease area is dry with extreme temperature variations. The Temperature varies 41° to 46° C in summer and 2°to 3.5° C in winter. The avg. Rainfall is 217.95 mm( according to IMD data) and most of the rain falls during the period of July to September.
Post Office
The nearest Post & Telegraph Office is at Tehsil Bhadesar.
Medical Facilities
Nearest Dispensary is at village Sand.
Police station
The Police Station is at Bhadesar.
Education
Facility:- Up to primary school is available at Sand Village and upto Senior Secondary level is at Tehsil Bhadesar
4.6 Soil classification: The lease area is covered by soil except Red Ochre & China Clay zone. The thickness of soil varies from 1.5 to 2.0 m. within the lease area.
4.7 Climatic data from Secondary Sources: 4.7.1 Climatic Conditions (30 years IMD Data)
The nearest IMD station for the proposed mine project is Chittorgarh and the meteorological data available from IMD Chittorgarh (average over the past 30 years) is given below
Table 4-4: Climatology & meteorology of the Study Area
Sl. No. Parameters Description of the Season
1 Rainfall in mm
Total Annual average is 217.95 mm
Winter (Dec to Feb)
Months Total rainfall (in mm)
December 3.8
January 5.6
February 3.9
Total 13.3
Summer (Mar to May)
March 1.5
April 6.6
May 11.9
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
4
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 19
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
Sl. No. Parameters Description of the Season
Total 20.0
Monsoon (June to Sept)
June 78.5
July 320.3
August 288.8
September 114.1
Total 801.7
Post-Monsoon (Oct to Dec)
October 19.3
November 13.7
December 3.8
Total 36.8
2 Temperature (Mean Daily Temp. in 0C)
Winter (Dec to Feb)
Months Max Min Avg
Dec 32.6 3.1 17.85
Jan 32.7 2.1 17.4
Feb 35.6 3.4 19.5
Average 33.63 2.86 18.25
Summer (Mar to May)
Mar 41.4 8.8 25.1
Apr 44 14.6 29.3
May 45.9 20 32.95
Average 43.76 14.46 29.11
Monsoon (June to Sept)
June 45.6 21.4 33.5
Jul 40.8 21.2 31
Aug 36.9 20.9 28.9
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
4
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 20
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
Sl. No. Parameters Description of the Season
Sep 38.9 18.7 28.8
Average 40.55 20.55 30.55
Post-Monsoon (Oct to Dec)
Oct 39.2 12 25.6
Nov 35.2 7 21.1
Dec 32.6 3.1 17.85
Average 35.66 7.36 21.52
3 Relative
Humidity in per cent
Winter (Dec to Feb)
Month 8.30hrs 17.30hrs
Dec 74 40
Jan 74 38
Feb 63 30
Average 70.33 36
Summer (Mar to May)
Mar 48 24
Apr 38 21
May 45 23
Average 43.66 22.66
Monsoon (June to Sept)
Jun 63 39
July 81 65
Aug 86 71
Sep 78 56
Average 77 57.75
Post-Monsoon (Oct to Dec)
Oct 65 36
Nov 66 37
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
4
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 21
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
Sl. No. Parameters Description of the Season
December 74 40
Average 68.33 37.66
4 Wind-speed
Winter (Dec to Feb)
Month Speed (kmph)
Dec 3.1
Jan 3.4
Feb 3.7
Average 3.4
Summer (Mar to May)
Mar 4.4
Apr 4.9
May 6.4
Average 5.23
Monsoon (June to Sept)
Jun 8.3
July 7
Aug 5.2
Sep 4.0
Average 6.12
Post-Monsoon (Oct to Dec)
Oct 3
Nov 3.2
Dec 3.1
Average 3.1
Source: (i) Climatological Table 1971 – 2000, Indian Meteorological Department, Govt. of India
Rainfall: The annual average total rainfall recorded in the region was found to be 217.95 mm
Temperature: The maximum temperature was recorded in the month of May at 45.9°C and the minimum temperature was 2.1°C in January.
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
4
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 22
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
Relative Humidity: The maximum Relative Humidity was found during the monsoon season with the month of August recording the highest at 86%
Wind Speed and Direction: The maximum average wind speed was found to be 8.3 kmph in the month of June.
4.8 Social Infrastructure Available 4.8.1 Power & Water supply
Power supply Service Electric Line is connected to bore well motor the applied lease area. The nearby villages are electrified. Water Supply Water is being supplied from a well near the mine. A small water tank is also proposed in the proposed mine office premises. This can be used for supply of water to mining work, spraying, watering the plants and drinking purposes.
4.8.2 Mine Office
Permanent mine office is proposed in the NE part of the applied lease area
Rest Shelter
Permanent rest shelter is proposed.
Latrines and Urinals
At the mine site, urinals and latrines shall be provide.
4.8.3 First Aid
Primary First aid facility is proposed at the proposed mine office. .
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
5
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 23
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
5. PLANNING BRIEF
5.1 Planning concept (type of industries, facilities, transportation etc) Town and country Planning/Development authority Classification
Red Ochre and China Clay mining project of Shri Mohammad Faruq is located at Village- Sand, Tehsil- Bhadesar, District-Chittorgarh and State- Rajasthan over an area of 4.524 ha. The proposed production capacity of the project is Red Ochre-62,863 Tonnes/Annum and China Clay-59,023 Tonnes/Annum
The proposed China Clay & Red Ochre mine shall be developed by semi mechanized opencast Mining. The main operation shall be digging, shorting and the transportation by trucks. The Mineral trucks are to be loaded by excavator. The mined mineral China Clay shall be collected in the China Clay mineral stack yard and then sorted over there manually before its final dispatch to various industries through trucks. The sub grade generated shall be collected in the sub-grade stack yard and thereafter shall be then mixed with high-grade mineral for use in various industries. The waste generated shall be carried through trucks to the dump yard in the southeast part of the lease. The Bench height shall 3m and the bench width shall be more than the bench height.
5.2 Population Projections The project will employ most of the workers from nearby villages. Only supervisory staff will be hired from outside. There will not be any increase in population due to the project. However, few people from other areas may migrate in this area for business opportunities.
5.3 Land Use planning (breakup along with green belt etc.) Approximate land use pattern for the present condition, plan period and conceptual period are given below
Table 5-1: Details of land use breakup
Sr. No. *All the areas are given in Hectares Existing Condition After 5th year After life of the mine
1 Pits & Quarries ---- 1.3886 1.6504 (Water
Reservoir)
2 Top soil Dump ---- 0.1124 0.1124
3 Dumps ---- 1.1651 1.1651
4 Stack Yard ---- 0.0049 ----
5 Sub Grade stack Yard ---- 0.3770 ----
6 Infrastructure ( Work shop, administrative Building)
0.0016 0.0107 0.0107
7 Roads ---- 0.0426 0.0426
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
5
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 24
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
8 Railway ---- ---- ----
9 Green Belt ---- 0.1116 0.1116
10 Tailing Pond ---- ---- ----
11 Effluent Treatment Plant ---- ---- ----
12 Mineral Separation Plant ---- ---- ----
13 Township ---- ---- ----
14 Non Utilized 4.5224 1.3111 ----
Total 4.524 4.524 4.524
5.4 Assessment of Infrastructure Demand (Physical & Social) The road facility is already available which shall strengthened, used and properly maintained. Preference will be given to local labour from nearby villages. Other requisite infrastructures as labourers transport of mine labours is available by way of jeep and two-wheeler. Medical facility will be available for first aid at the project site.
5.5 Amenities/Facilities One small mine office and rest shelter for the staffs and the workers will be constructed. Drinking water requirements for the project area are fulfilled by tube-wells from nearby villages. First Aid box with all necessary materials will be kept ready all time in the office building for use as and when required.
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
6
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 25
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
6. PROPOSED INFRASTRUCTURE
6.1 Industrial Area (Processing Area) The lease area shall be the processing area for the mining works. No other industrial area has been proposed in the applied area.
6.2 Residential Area (Non-Processing Area) No residential area is proposed.
6.3 Afforestation: Top soil will be used for plantation purpose. 33% of total area will be used for plantation purpose at the rate of 1500 trees/ha. Maximum plantation will be done in the barrier zone and remaining will be done on both sides of the kachha road. Mango, neem, palm and other fruit beaing trees will be used for the plantation purpose.
6.3.1 Progressive Afforestation during proposal period:
Table 6-1: Year Wise Afforestation Program
Sr. No.
Year of Plantation
Target of Plantation Assumed Survival (80%)
Area to be covered in ha
1 I Yr 41 33 0.022
2 II Yr 41 33 0.022
3 III Yr 41 33 0.022
4 IV Yr 41 33 0.022 5 V Yr 41 33 0.022
6.4 Social Infrastructure This Project is providing employment to local people directly and indirectly. Indirect employers are shopkeepers, mechanic, drivers, transporters etc. The lessee will responsible for providing better social infrastructure benefits such as drinking water, health care measures, educational facilities, promotion of culture and religious activities in surroundings.
6.5 Connectivity (Traffic and transportation Road/Rail/Metro/Water ways etc)
The lease area is about 1.00 Km West of Village Sand, Tehsil Bhadesar, District.-Chittorgarh and the applied area is connected to village Sand by kaccha rasta. The lease area is 11 km connected by tar road to Tehsil Bhadesar District. - Chittorgarh. The nearest Railway Station is situated at village Shambupura at about 10 km ENE direction from the project site.
6.6 Drinking Water Management (Source & supply of water) Water required for drinking and domestic purpose will be about 2.21 KLD by providing tube wells and dug wells will be met from the nearby villages.
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
6
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 26
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
6.7 Sewerage System A Sewage system of Septic Tanks followed by soap pits shall be provided for the project area.
6.8 Industrial Waste Management 6.8.1 Solid waste Management
The waste rocks are considered as overburden over the mineral bed. The average thickness of waste is 1.5 m. During Red Ochre and China Clay mining, intermix soil shall also be generated.
Total top soil and waste generation during the plan period is 7,222 tonnes and 14,417.3 Tonnes respectively. Total mineral waste generation during the plan period is 16,8845.3 tonnes. Top soil and dump will be stored separately. Retaining wall will be constructed to protect the wash out of the top soil and over burden dump. Garland land will also be constructed.
6.8.2 Power Requirement
The electric facility is available in the villages near to the lease area. Service Electric Line shall connected to the bore well motor the applied lease area.
6.9 The service Electric Line is connected to bore well motor in the applied lease area. The electric facility is available at applied Mining Lease area.
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
7
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 27
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
7. REHABILITATION AND RESETTLEMENT(R&R PLAN)
7.1 Policy to adopted (Central State) in respect of the project affected person including home outsees, land outsees and landless labour
The mine area does not cover any habitation. Hence the mining activity does not involve any displacement of human settlement. No public buildings, places, monuments etc exist within the lease area or in the vicinity of the mine lease area. The mining operation will not disturb/ relocate any village or need resettlement. Thus no adverse impact is anticipated.
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
8
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 28
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
8. PROJECT SCHEDULE AND COST ESTIMATES
8.1 Likely date of start of construction and Completion of project (Time schedule for the project to be given)
Mining will be initiated after getting the Environmental Clearance for the.
8.2 Estimated project cost and along with analysis in terms of economic viability of them project.
Estimated cost of the project is 75 lakhs.
PRE-FEASIBILITY REPORT Red Ochre And China Clay Mining Project Of Shri Mohammad Faruq Located Near Village- Sand Tehsil-Bhadesar, District-Chittorgarh And State-Rajasthan
6
PROJECT PROPONENT SHRI MOHAMMAD FARUQ, CHITTORGARH, RAJASTHAN
Page 29
PROJECT CONSULTANT GREENCINDIA CONSULTING
PRIVATE LIMITED, NCR, GHAZIABAD
9. ANALYSIS OF PROPOSAL (FINAL RECOMMENDATION) CONCLUSION
The project is of utmost importance to the area/ region for interest of mineral development and shall greatly contribute to improve the socio-economic conditions of the local habitants. The operation of the proposed expansion project will bestow various social and economic benefits to the local communities of the area in addition to providing better employment opportunities. The mining project shall improve social infrastructure of the area, apart from increased financial benefits accruing to state and central agencies by ways of taxes, royalties, cesses etc.
ANNEX: 1 LOCATION MAP
© GREENCINDIA Consulting Private Limited, 2014
±
Map of India State of Rajasthan, India
Project Site Chittorgarh District, Rajasthan
A B C D
A B
CD
Source: http://www.india-in-your-home.com/physical-map-of-india.htmlScale: Not to Scale
Source: http://www.hdwallpapers-3d.com/wp-content/uploads/2014/07/rajasthan-map-hd-wallpaper-4.jpgScale: Not to Scale
Source: http://www.onefivenine.com/images/DistrictMaps/418.jpgScale: Not to Scale
1. Survey of India Toposheet Map No. 45 L/5, 45 L/6, 45 L/9, 45 L/102. Google Satellite Imagery, 20143. Project layout Plan, Sh. MF
Project Site!P
DateRevision
14/11/201400
Path: D:\Projects\Mining Projects\China Clay\Farook Khan\Shp\Location Map.mxd
LegendProject Site
Project:
Project Developer:
Graphic Scale:
GREENCINDIA Consulting Private Limited
Location of Project SiteAnnex-1:
Environment Consultant:
Source:
Drafted By: Approved By:
Mr. Ankur Agarwal Mr. Rahul Singh
Checked By:
Ms. Nandini Choudhury
(An ISO:9001 QMS, ISO: 14001 EMS & OHSAS: 18001 H&S MS Certified by BSI)QCI-NABET Accrediate Environment Consultant Certificate No. NABET/EIA/014/041
(Formerly known as GIS Enabled Environment & Neo-graphic Centre)
400 0 400 800 1,200200m
Software Used:
1. Survey of India Toposheet Map No. 45 L/5, 45 L/6, 45 L/9, 45 L/102. Google Satellite Imagery, 20143. Project layout Plan, Sh. MF4. Data Provided by FAE (LU)
1. ArcGIS 10, 2. AutoCAD 2011, 3. ER Mapper 7, 4. Erdas Imagine 10
!P
Key Map of Rajasthan
Scale: Not to ScaleSource: http://www.onefivenine.com/images/StateMaps/Rajasthan.jpg
¯
Project Site
!P
China Clay and Red Ochre MineVillage: Sand, Tehsil: Bhadesar, District: Chhittorgarh, Rajasthan
Sh Mohammad Faruq
ANNEX: 2 COORDINATE MAP
74°39'0"E
74°39'0"E
74°36'0"E
74°36'0"E
74°33'0"E
74°33'0"E
74°30'0"E
74°30'0"E74°27'0"E24
°48'
0"N
24°4
8'0"
N
24°4
5'0"
N
24°4
5'0"
N
24°4
2'0"
N
24°4
2'0"
N
24°3
9'0"
N
24°3
9'0"
N
DateRevision
14/11/201400
© GREENCINDIA Consulting Private Limited, 2014 Path: D:\Projects\Mining Projects\China Clay\Farook Khan\Shp\Study Area.mxd
±Legend
Project Site
Study Area
Project:
Project Developer:
Graphic Scale:
GREENCINDIA Consulting Private Limited
Study Area of Project SiteAnnex-3:
Environment Consultant:
Source:
Drafted By: Approved By:
Mr. Ankur Agarwal Mr. Rahul Singh
Checked By:
Ms. Nandini Choudhury
(Formerly known as GIS Enabled Environment & Neo-graphic Centre)
1,500 0 1,500 3,000 4,500750m
Software Used:
1. Survey of India Toposheet Map No. 45 L/5, 45 L/6, 45 L/9, 45 L/102. Google Satellite Imagery, 20143. Project layout Plan, Sh. MF4. Data Provided by FAE (LU)
1. ArcGIS 10, 2. AutoCAD 2011, 3. ER Mapper 7, 4. Erdas Imagine 10
SettlementsStreamsRoadsRailwayForestPondsVegetationContoursLocations
(An ISO:9001 QMS, ISO: 14001 EMS & OHSAS: 18001 H&S MS Certified by BSI)QCI-NABET Accrediate Environment Consultant Certificate No. NABET/EIA/014/041
China Clay and Red Ochre MineVillage: Sand, Tehsil: Bhadesar, District: Chhittorgarh, Rajasthan
Sh Mohammad Faruq
Key Map of Rajasthan
Scale: Not to ScaleSource: http://www.onefivenine.com/images/StateMaps/Rajasthan.jpg
¯
Project Site
!P
10 km
ANNEX: 3 STUDY AREA MAP
74°33'30"E
74°33'30"E
74°33'0"E
74°33'0"E24
°44'
0"N
24°4
4'0"
N
DateRevision
14/11/201400
© GREENCINDIA Consulting Private Limited, 2014 Path: D:\Projects\Mining Projects\China Clay\Farook Khan\Shp\Co-ordinate Map.mxd
±Legend
Project Site
Study Area (500m)
Project:
Project Developer:
Graphic Scale:
GREENCINDIA Consulting Private Limited
Co-ordinate of Project SiteAnnex-2:
Environment Consultant:
Source:
Drafted By: Approved By:
Mr. Ankur Agarwal Mr. Rahul Singh
Checked By:
Ms. Nandini Choudhury
(Formerly known as GIS Enabled Environment & Neo-graphic Centre)
100 0 100 200 30050m
Software Used:
1. Survey of India Toposheet Map No. 45 L/5, 45 L/6, 45 L/9, 45 L/102. Google Satellite Imagery, 20143. Project layout Plan, Sh. MF4. Data Provided by FAE (LU)
1. ArcGIS 10, 2. AutoCAD 2011, 3. ER Mapper 7, 4. Erdas Imagine 10
(An ISO:9001 QMS, ISO: 14001 EMS & OHSAS: 18001 H&S MS Certified by BSI)QCI-NABET Accrediate Environment Consultant Certificate No. NABET/EIA/014/041
2444’03.9” N 7433’18.9” E AB
C
D E
China Clay and Red Ochre MineVillage: Sand, Tehsil: Bhadesar, District: Chhittorgarh, Rajasthan
Sh Mohammad Faruq
Key Map of Rajasthan
Scale: Not to ScaleSource: http://www.onefivenine.com/images/StateMaps/Rajasthan.jpg
¯
Project Site
!P
!!
!!
!
2444’03.0” N 7433’07.9” E
2444’04.3” N 7433’06.7” E
2444’07.2” N 7433’06.4” E
2444’08.1” N 7433’18.3” E
ANNEX: 4 LETTER OF INTENT(LOI)
ANNEX: 5 NOC FROM FOREST DEPERMENT