Pioneer Dvh 335u,Dvh 3390ub

PIONEER CORPORATION 1-1, Shin-ogura, SaiwPIONEER ELECTRONICS (USA) INC. P.O. Box 1760, LonPIONEER EUROPE NV Haven 1087, Keetberglaan 1, 912PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253

PIONEER CORPORATION 2010

DVH-335UB/XNRC

ai-ku, Kawasaki-shi, Kanagawa 212-0031, Japg Beach, CA 90801-1760, U.S.A.0 Melsele, Belgium Alexandra Road, #04-01, Singapore 159936

ORDER NO.

CRT4677

DVD RECEIVER

DVH-335UB/XNRC

DVH-335UB/XNRD

DVH-335UB/XNRI

DVH-3390UB/XNID

This service manual should be used together with the following manual(s):

DTS and DTS Digital Out are registered trademarks and the DTS logos and Symbol are trademarks of DTS, Inc.Manufactured under license from Dolby Laboratories. Dolby, Pro Logic, and the double-D symbol are trademarks of Dolby Laboratories.

Model No. Order No. Mech.Module Remarks

CX-3250 CRT4300 LS1 DVD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly

For details, refer to "Important Check Points for Good Servicing".

an

K-ZZZ DEC. 2010 Printed in Japan

C

D

F

A

B

E

1 2 3 4

SAFETY INFORMATION

Where in a manufacturer’s service documentation, for example in circuit diagrams or listsof components, a symbol is used to indicate that a specific component shall be replaced onlyby the component specified in that documentation for safety reasons, the following symbol shallbe used:

This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer.Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safety repaircomplex products such as those covered by this manual.Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.If you are not qualified to perform the repair of this product properly and safety, you should not risk trying to do soand refer the repair to a qualified service technician.

CAUTION:USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE.

- Safety Precautions for those who Service this Unit. When checking or adjusting the emitting power of the laser diode exercise caution in order to get safe, reliable results.

Caution: 1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept. 2. During repair or tests, do not view laser beam for 10 seconds or longer.

WARNING!The AEL (accessible emission level )of the laser power output is less than CLASS 1but the laser component is capable of emitting radiation exceeding the limit for CLASS 1.A specially instructed person should do servicing operation of the apparatus.

Laser diode characteristicsWave length:

DVD:660 nm to 670 nmCD:780 nm to 800 nm

Focus lens on Maximum output:CD:6.26 mW(Emitting period :9 sec.)

DVD:1.27 mW (Emitting period : unlimited)

CAUTIONThis product is a class 1 laser product classi-fied under the Safety of laser products, IEC60825-1:2007, and contains a class 1M lasermodule. To ensure continued safety, do not re-move any covers or attempt to gain access tothe inside of the product. Refer all servicing toqualified personnel.

CAUTION—CLASS 1M INVISIBLE LASER RADIATION WHEN OPEN, DO NOT VIEW DIRECTLY WITH OPTICAL INSTRUMENTS.

DVH-335UB/XNRC21 2 3 4

C

D

F

A

B

E

5 6 7 8

CAUTIONDanger of explosion if battery is incorrectly replaced.Replaced only with the same or equivalent type recommended by the manufacture.Discord used batteries according to the manufacture's instructions.

Additional Laser Caution

Transistors Q1103 and Q1104 in PCB drive the laser diodes for DVD and CD respectively. When Q1103 or Q1104 is shorted between their terminals, the laser diodes for DVD or CD will radiate beam. If the top cover is removed with no disc loaded while such short-circuit is continued, the naked eyes may be exposed to the laser beam.

DVH-335UB/XNRC 35 6 7 8

C

D

F

A

B

E

1 2 3 4

[Important Check Points for Good Servicing]In this manual, procedures that must be performed during repairs are marked with the below symbol.Please be sure to confirm and follow these procedures.

1. Product safety

Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by following the safety instructions described in this manual.

1 Use specified parts for repair.

Use genuine parts. Be sure to use important parts for safety.

2 Do not perform modifications without proper instructions.

Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as radio/TV interference and foreign noise.

3 Make sure the soldering of repaired locations is properly performed.

When you solder while repairing, please be sure that there are no cold solder and other debris.Soldering should be finished with the proper quantity. (Refer to the example)

4 Make sure the screws are tightly fastened.

Please be sure that all screws are fastened, and that there are no loose screws.

5 Make sure each connectors are correctly inserted.

Please be sure that all connectors are inserted, and that there are no imperfect insertion.

6 Make sure the wiring cables are set to their original state.

Please replace the wiring and cables to the original state after repairs.In addition, be sure that there are no pinched wires, etc.

7 Make sure screws and soldering scraps do not remain inside the product.

Please check that neither solder debris nor screws remain inside the product.

8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord.

Damaged power cords may lead to fire accidents, so please be sure that there are no damages.If you find a damaged power cord, please exchange it with a suitable one.

9 There should be no spark traces or similar marks on the power plug.

When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure connections and suitable usage. Please exchange the power cord if necessary.

a Safe environment should be secured during servicing.

When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries. Please pay attention to your surroundings and repair safely.

2. Adjustments

To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification.Adjustments should be performed in accordance with the procedures/instructions described in this manual.

4. Cleaning

For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper cleaning should be performed to restore their performances.

3. Lubricants, Glues, and Replacement parts

Use grease and adhesives that are equal to the specified substance. Make sure the proper amount is applied.

5. Shipping mode and Shipping screws

To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual.


C

D

F

A

B

E

5 6 7 8

CONTENTS SAFETY INFORMATION .....................................................................................................................................21. SERVICE PRECAUTIONS................................................................................................................................6

1.1 SERVICE PRECAUTIONS .........................................................................................................................61.2 NOTES ON SOLDERING...........................................................................................................................6

2. SPECIFICATIONS.............................................................................................................................................72.1 SPECIFICATIONS ......................................................................................................................................72.2 DISC/CONTENT FORMAT.........................................................................................................................92.3 PANEL FACILITIES.....................................................................................................................................92.4 CONNECTION DIAGRAM........................................................................................................................13

3. BASIC ITEMS FOR SERVICE ........................................................................................................................153.1 CHECK POINTS AFTER SERVICING .....................................................................................................153.2 PCB LOCATIONS.....................................................................................................................................163.3 JIGS LIST .................................................................................................................................................163.4 CLEANING ...............................................................................................................................................16

4. BLOCK DIAGRAM ..........................................................................................................................................184.1 BLOCK DIAGRAM....................................................................................................................................18

5. DIAGNOSIS ....................................................................................................................................................235.1 OPERATIONAL FLOWCHART.................................................................................................................235.2 INSPECTION METHOD OF PICKUP UNIT .............................................................................................245.3 DIAGNOSIS FLOWCHART ......................................................................................................................275.4 ERROR CODE LIST.................................................................................................................................535.5 CONNECTOR FUNCTION DESCRIPTION .............................................................................................56

6. SERVICE MODE.............................................................................................................................................576.1 DISPLAY TEST MODE.............................................................................................................................576.2 DVD TEST MODE ....................................................................................................................................58

7. DISASSEMBLY ...............................................................................................................................................628. EACH SETTING AND ADJUSTMENT............................................................................................................71

8.1 DVD ADJUSTMENT .................................................................................................................................718.2 PCL OUTPUT CONFIRMATION...............................................................................................................79

9. EXPLODED VIEWS AND PARTS LIST ..........................................................................................................809.1 PACKING ..................................................................................................................................................809.2 EXTERIOR (1) ..........................................................................................................................................829.3 EXTERIOR (2) ..........................................................................................................................................849.4 DVD MECHANISM MODULE...................................................................................................................86

10. SCHEMATIC DIAGRAM................................................................................................................................9010.1 TUNER AMP UNIT (GUIDE PAGE)........................................................................................................9010.2 KEYBOARD UNIT ..................................................................................................................................9610.3 DVD CORE UNIT (GUIDE PAGE) ..........................................................................................................9810.4 CONNECT PCB....................................................................................................................................10410.5 WAVEFORMS.......................................................................................................................................105

11. PCB CONNECTION DIAGRAM ..................................................................................................................10811.1 TUNER AMP UNIT ...............................................................................................................................10811.2 KEYBOARD UNIT ................................................................................................................................11211.3 DVD CORE UNIT..................................................................................................................................11411.4 CONNECT PCB....................................................................................................................................116

12. ELECTRICAL PARTS LIST .........................................................................................................................118

DVH-335UB/XNRC 55 6 7 8

C

D

F

A

B

E

1 2 3 4

1. SERVICE PRECAUTIONS1.1 SERVICE PRECAUTIONS

1.2 NOTES ON SOLDERING

1. You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and should keep the safety during servicing by following the safety instructions described in this manual.2. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by electrostatic induction.3. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors during power-on mode may damage the ICs inside the unit.4. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment (shorting-solder) by referring to "the DISASSEMBLY" .5. After replacing the pickup unit, be sure to skew adjustment. 6. ICs (IC1011, 1021) and the heat sink becomes hot areas. Be careful not be burn yourself.7. Mechanism cover(Sheet : CNN2525) is NOT reusable. If you removed it, please replace it with the new one.

For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit. Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs accompanied by reworking of soldering.

Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C. Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of the soldering iron.

Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden).

The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia.


C

D

F

A

B

E

5 6 7 8

2. SPECIFICATIONS2.1 SPECIFICATIONS

GeneralRated power source...............14.4 V DC

(allowable voltage range:12.0 V to 14.4 V DC)

Grounding system.................. Negative typeMaximum current consumption

....................................................10.0 A

Dimensions (W × H × D):DIN

Chassis.....................178 mm × 50 mm ×163 mm

Nose...........................188 mm × 58 mm × 23 mmD

Chassis.....................178 mm × 50 mm ×163 mm

Nose...........................170 mm × 46 mm × 23 mmWeight .........................................1.4 kg

AudioMaximum power output .......50 W × 4Continuous power output ...22 W × 4 (50 Hz to

15 000 Hz, 5 % THD,4 load, both channels dri-ven)

Load impedance ..................... 4 (4 to 8 allowable)Preout maximum output level

...................................................2.0 VTone controls:

BassFrequency................100 HzGain ...........................±12 dB

MidFrequency................1 kHzGain ...........................±12 dB

TrebleFrequency................10 kHzGain ...........................±12 dB

DVD PlayerSystem.........................................DVD video, Video CD, CD,

WMA, MP3, AAC, DivX,JPEG system

Region number:for Middle East Asian and South African models

......................................... 2for Southeast Asian models

......................................... 3for South American and Oceanian models

......................................... 4Usable discs .............................DVD video, Video CD, CD,

CD-R/RW, DVD-R/RW/R DL

Frequency response...............5 Hz to 44 000 Hz (with DVD,at sampling frequency96 kHz)

Signal-to-noise ratio...............96 dB (1 kHz) (IEC-A net-work) (RCA level)

Number of channels ..............2 (stereo)MP3 decoding format ...........MPEG-1 & 2 Audio Layer 3WMA decoding format .........Ver. 7, 7.1, 8, 9, 10, 11, 12

(2 ch audio)(Windows Media Player)

AAC decoding format............MPEG-4 AAC (iTunes en-coded only) (.m4a)(Ver. 9.0.3 and earlier)

DivX decoding format............Home Theater Ver. 3, 4, 5.2,6 (.avi, .divx)

USBUSB standard specification

...................................................USB 2.0 full speedMaximum current supply ....500 mAUSB Class..................................MSC (Mass Storage Class)File system.................................FAT16, FAT32MP3 decoding format ...........MPEG-1 & 2 Audio Layer 3WMA decoding format .........Ver. 7, 7.1, 8, 9, 10, 11, 12




FM tunerFrequency range..................... 87.5 MHz to 108.0 MHzUsable sensitivity.................... 9 dBf (0.8 µV/75 , mono,

S/N: 30 dB)Signal-to-noise ratio...............72 dB (IEC-A network)

AM tunerFrequency range..................... 531 kHz to 1 602 kHz (9 kHz)

530 kHz to 1 640 kHz(10 kHz)

Usable sensitivity.................... 25 µV (S/N: 20 dB)Signal-to-noise ratio.............. 62 dB (IEC-A network)

NoteSpecifications and the design are subject to mod-ifications without notice.

DVH-335UB

Backup current ........................ 5.0 mA or less

DVH-335UB/XNRC 75 6 7 8

C

D

F

A

B

E

1 2 3 4

DVH-3390UB

Backup current ........................ 5.0 mA or less

GeneralRated power source...............14.4 V DC

(allowable voltage range:12.0 V to 14.4 V DC)

Grounding system...................Negative typeMaximum current consumption

...................................................10.0 A

Dimensions (W × H × D):DIN

Chassis.....................178 mm × 50 mm ×163 mm

Nose...........................188 mm × 58 mm × 23 mmD

Chassis.....................178 mm × 50 mm ×163 mm

Nose...........................170 mm × 46 mm × 23 mmWeight .........................................1.4 kg

AudioMaximum power output .......50 W × 4Continuous power output ...22 W × 4 (50 Hz to

15 000 Hz, 5 % THD,4 load, both channels dri-ven)

Load impedance ..................... 4 (4 to 8 allowable)Preout maximum output level

...................................................2.0 VTone controls:

BassFrequency................100 HzGain ...........................±12 dB

MidFrequency................1 kHzGain ...........................±12 dB

TrebleFrequency................10 kHzGain ...........................±12 dB

DVD PlayerSystem.........................................DVD video, Video CD, CD,

WMA, MP3, AAC, DivX,JPEG system

Region number ....................... 5Usable discs .............................DVD video, Video CD, CD,

CD-R/RW, DVD-R/RW/R DLFrequency response...............5 Hz to 44 000 Hz (with DVD,

at sampling frequency96 kHz)

Signal-to-noise ratio...............96 dB (1 kHz) (IEC-A net-work) (RCA level)

Number of channels ..............2 (stereo)MP3 decoding format ...........MPEG-1 & 2 Audio Layer 3

WMA decoding format .........Ver. 7, 7.1, 8, 9, 10, 11, 12(2 ch audio)(Windows Media Player)



USBUSB standard specification

...................................................USB 2.0 full speedMaximum current supply ....500 mAUSB Class..................................MSC (Mass Storage Class)File system.................................FAT16, FAT32MP3 decoding format ...........MPEG-1 & 2 Audio Layer 3WMA decoding format .........Ver. 7, 7.1, 8, 9, 10, 11, 12




FM tunerFrequency range..................... 87.5 MHz to 108.0 MHzUsable sensitivity.................... 9 dBf (0.8 µV/75 , mono,

S/N: 30 dB)Signal-to-noise ratio...............72 dB (IEC-A network)

AM tunerFrequency range..................... 531 kHz to 1 602 kHz (9 kHz)

530 kHz to 1 640 kHz(10 kHz)

Usable sensitivity.................... 25 µV (S/N: 20 dB)Signal-to-noise ratio...............62 dB (IEC-A network)

NoteSpecifications and the design are subject to mod-ifications without notice.


C

D

F

A

B

E

5 6 7 8

2.2 DISC/CONTENT FORMAT

2.3 PANEL FACILITIES

Fastening the front panelIf you do not plan to detach the front panel, the front panel can be fastened with the supplied screw.

Screw : XXX7020

Head unit

12 4 5 63

7 8 a b c d9

traPtraP

1 S (SRC/OFF) 8(Back/display/

scroll)

2 (eject) 9

3 (list) a (clock)

4MULTI-CONTROL(M.C.)

b

1 to 61/S.Rtrv/DVDMENU2/PAUSE3/BOOKMARK4/AUDIO5/ /SUBTITLE6/ /ANGLE

5 Disc loading slot cAUX input jack(3.5 mm stereojack)

6 USB port d Detach button

7 B (BAND/ESC)

CAUTIONUse an optional Pioneer USB cable (CD-U50E) toconnect the USB audio player/USB memory asany device connected directly to the unit will pro-trude out from the unit and may be dangerous.Do not use unauthorized products.

NoteThe function of is different depending on thesetting of the display connection (refer to V.OUT(display connection)).

DVH-335UB/XNRC 95 6 7 8

C

D

F

A

B

E

1 2 3 4

Remote control

Button names DVH mode DVD mode

1 VOLUME Press to increase or decrease volume.

2 /MUTE Press to mute. Press again to unmute.

3 SRC/OFFPress to cycle through all the available sources. Press and hold to turn the sourceoff.

4

AUDIO(Only in DVD source)Press to change the audio language/audio system during DVD/DivX playback.

SUBTITLE(Only in DVD source)Press to change the subtitle language during DVD/DivX playback.

ANGLE(Only in DVD source)Press to change the viewing angle during DVD playback.

5 AUTO PLAY(Only in DVD source)Press to turn the DVD auto-playback function on or off.

6 RETURN(Only in DVD source)Press to display the PBC (playback control) menu during PBC playback.

7 BOOKMARK Not used.

(Only in DVD source)Press to turn the bookmark functionon or off. For details, refer to Resumeplayback (Bookmark).

4

1 2 3

56

7

8

9

10

17

16

15141312

11

DVH-335UB/XNRC101 2 3 4

C

D

F

A

B

E

5 6 7 8

Button names DVH mode DVD mode

8Remote control operationmode switch

Switch the operation mode between DVD and DVH modes. Normally, set to DVH.For details, refer to Using the remote control operation mode switch.

9 DIRECT Press to select tracks (chapters) directly. Not used.

10

PLAY/PAUSE( ) Press to pause or resume playback.(Only in DVD source)Press to switch sequentially be-tween playback and pause.

REVERSE( )(Only in DVD source)Press to perform fast reverse.

FORWARD( )(Only in DVD source)Press to perform fast forward.

PREVIOUS( )(Only in DVD source)Press to return to the previous track (chapter).

NEXT( )(Only in DVD source)Press to go to the next track (chapter).

STEP( )(Only in DVD source)Press to move ahead one frame at a time during DVD/Video CD/DivX playback.Press and hold for one second to activate slow playback.

STOP( ) Not used.(Only in DVD source)Press to stop playback.

11 0 to 10, CLEAR

When pressing DIRECT, press 0 to 10 toinput numbers. Press CLEAR to clear theinput numbers. Press 1 to 6 to select thedesired preset station for the tuner.

Press to select to a desired titlenumber on a DVD.Press to select a menu item on avideo CD featuring PBC (playbackcontrol).

12 BAND/ESCPress to select among three FM bandsand one AM band and to cancel controlmodes of functions.

Press to switch between media filetypes. (Refer to Switching the mediafile type.)

13 DISPPress to turn the information display on or off when the video is displayed.Depending on the selected source, pressing this button can switch the display in-dication.

14 A.MENU Press to select various sound quality controls.

15 FUNC Press to select functions.

16

Move the thumb pad

Functions are the same as onthe head unit.Move to operate fast forward, reverse andtrack search controls. Also used for con-trolling functions.

Use to select a menu on the DVDmenu.

Click the thumb padClick to display the track title list, folderlist or file list depending on the source.

Click to select a menu on the DVDmenu.

17MENU Press to display the DVD menu during DVD playback.

TOP MENU Press to return to the top menu during DVD playback.

Using the remote controloperation mode switchThere are two remote control operation modeson the remote control. If you want to operatethis unit by remote control, select DVH mode.In this case, both the head unit’s buttons andremote control can control this unit.

DVH mode operationWhen operating this unit by remote control,the mode is normally switched to DVH.

DVD mode operationIf you switch the mode to DVD, the thumb padand 0 to 10 operations are changed for theDVD player.

When you want to operate the follow-ing functions, switch the mode to DVD:

When operating the DVD menu by usingthe thumb pad. (Refer to Operating the DVDmenu.)When operating the PBC menu by using 0to 10. (Refer to PBC playback.)When specifying title or track by using 0 to10. (Refer to Specifying title andSpecifying track.)When operating the DVD setup menu byusing the thumb pad. (Refer to Setting upthe DVD player.)

DVH-335UB/XNRC 115 6 7 8

C

D

F

A

B

E

1 2 3 4

Display indication1

23 5 7 9 abc4 6 8

Indicator Operation

1Main dis-play sec-tion

Tuner: band and frequencyBuilt-in DVD player and USB:elapsed playback time and lit-eral information

2 (artist)The disc (track) artist name is dis-played.

3 (disc)The disc (album) name is dis-played.

4 (song)

The track (song) name is dis-played.A playable file is displayed duringviewing the file name list of discand a USB storage device.

5An upper tier of the folder ormenu exists.

6 (list)The list function is being oper-ated.

7A lower tier of the folder or menuexists.

8 LOC Local seek tuning is on.

9LOUD

(loudness)The loudness is on.

a (stereo)Receiving the stereo broadcast-ing.

b (repeat) Track or folder repeat is on.

c(ran-

dom)Random play is on.

NoteWhen you set the display connection (refer toV.OUT (display connection)) to on, theindicators of 2 to 7 do not appear.

DVH-335UB/XNRC121 2 3 4

C

D

F

A

B

E

5 6 7 8

2.4 CONNECTION DIAGRAM

Po

wer

cab

leco

nn

ecti

on

Bla

ck (

chas

sis

grou

nd)

Con

nect

to a

cle

an, p

aint

-fre

e m

etal

loca

tion.

Yel

low

C

onne

ct to

the

cons

tant

12

V s

uppl

y te

rmin

al.

Red

C

onne

ct to

term

inal

con

trol

led

by ig

nitio

n sw

itch

(12

V D

C).

Fus

e (1

0 A

)

Fuse

res

isto

r

Thi

s pr

oduc

t

Ant

enna

jack

Blu

e/w

hite

Con

nect

to s

yste

m c

ontr

ol te

rmin

al o

f the

po

wer

am

p or

aut

o-an

tenn

a re

lay

cont

rol

term

inal

(m

ax. 3

00 m

A 1

2 V

DC

).

Rig

htLe

ft

Fro

nt s

peak

erF

ront

spe

aker

Rea

r sp

eake

r

Whi

teG

ray

Gra

y/bl

ack

Whi

te/b

lack

Gre

enV

iole

t

Gre

en/b

lack

Vio

let/b

lack

Rea

r sp

eake

r

With

a 2

spe

aker

sys

tem

, do

not c

onne

ct

anyt

hing

to th

e sp

eake

r le

ads

that

are

not

co

nnec

ted

to s

peak

ers.

DVH-335UB/XNRC 135 6 7 8

C

D

F

A

B

E

1 2 3 4

Wh

enco

nn

ecti

ng

tose

par

atel

yso

ldp

ow

eram

p

Con

nect

with

RC

A c

able

s (s

old

sepa

rate

ly) P

erfo

rm th

ese

conn

ectio

ns w

hen

us

ing

the

optio

nal a

mpl

ifier

.

Pow

er a

mp

(sol

d se

para

tely

)

Sys

tem

rem

ote

cont

rol

Rea

r sp

eake

rR

ear

spea

ker

Thi

s pr

oduc

tR

ear

outp

ut

Blu

e/w

hite

Con

nect

to s

yste

m c

ontr

ol

term

inal

of t

he p

ower

am

p or

au

to-a

nten

na r

elay

con

trol

te

rmin

al (

max

. 300

mA

12

V D

C).

Wh

enu

sin

ga

dis

pla

yco

nn

ecte

dto

vid

eoo

utp

uts

WA

RN

ING

Nev

erin

stal

lthe

disp

lay

ina

loca

tion

whe

reit

isvi

sibl

eto

the

driv

erw

hile

driv

ing.

Dis

play

with

R

CA

inpu

t jac

ks(s

old

sepa

rate

ly)

To v

ideo

inpu

t

RC

A c

able

(s

old

sepa

rate

ly)

Thi

s pr

oduc

tV

ideo

out

put

(Onl

y fo

r S

outh

east

Asi

an m

odel

s)A

udio

inpu

t In

put t

he s

ound

from

ext

erna

l dev

ices

(e.

g. T

V).

DVH-335UB/XNRC141 2 3 4

C

D

F

A

B

E

5 6 7 8

3. BASIC ITEMS FOR SERVICE3.1 CHECK POINTS AFTER SERVICING

To keep the product quality after servicing, please confirm following check points.

No. Procedures Item to be confirmed1 Confirm whether the customer complain has

been solved.If the customer complain occurs with thespecific media, use it for the operation check.

The customer complain must not bereappeared.Display, video, audio and operations must benormal.

2 DVD Measure playback error rates at theinnermost and outermost tracks by using thetest mode with the following disc.DVD test disc (TDV-582)

Deterioration of mecha-drive can bechecked.The error rate must be less than thethreshold value.(Refer to the chapter of DIAGNOSIS for thethreshold value.)

3 DVD Play back a DVD.(Menu operation; Title/chapter search)

Display, video, audio and operations must benormal.

4 CD Play back a CD.(Track search)

Display, audio and operations must benormal.

5 FM/AM tuner Check FM/AM tuner action.(Seek, Preset)Switch band to check both FM and AM.

Display, audio and operations must benormal.

6 Check whether no disc is inside the product. The media used for the operating check mustbe ejected.

7 Appearance check No scratches or dirt on its appearance afterreceiving it for service.

For check items concerning image and voice, please refer to the followings:

Check items concerning image Check items concerning voiceBlock-noise DistortionCrosscut noise NoiseDot noise Low volumeDistorted image (Image skip) High volumeLow brightness Changes in levelToo bright Pause of soundColor fadingPartial discoloration

DVH-335UB/XNRC 155 6 7 8

C

D

F

A

B

E

1 2 3 4

3.2 PCB LOCATIONS

3.3 JIGS LIST

3.4 CLEANING

A

B Keyboard Unit

C

Tuner Amp Unit

DVD Core Unit

D Connect PCB

A:DVH-335UB/XNRCB:DVH-3390UB/XNIDC:DVH-335UB/XNRDD:DVH-335UB/XNRIUnit Number : QWM3247(A) : QWM3250(B) : QWM3248(C) : QWM3249(D)Unit Name : Tuner Amp UnitUnit Number :Unit Name : Keyboard UnitUnit Number : YWX5019Unit Name : DVD Core UnitUnit Number :Unit Name : Connect PCB

- Grease List NameGreaseGreaseGreaseLocking agentsBondBond

Jig No.GEM1024GEM1038GEM10451401MGEM10331530

RemarksDVD Mechanism ModuleDVD Mechanism ModuleDVD Mechanism ModuleSkew adjustment (1401M:produced by THREE BOND)Skew adjustmentSkew adjustment (1530:produced by THREE BOND)

Disc TDV-582 Skew adjustment, Check points after servicing, Inspection method of Pickup UnitDisc TCD-782 Inspection method of Pickup Unit

Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools:

Portions to be cleaned Cleaning toolsDVD pickup lenses Cleaning liquid : GEM1004 Cleaning paper : GED-008

DVH-335UB/XNRC161 2 3 4

C

D

F

A

B

E

5 6 7 8

DVH-335UB/XNRC 175 6 7 8

C

D

F

A

B

E

T

ENS

2

USB5INN

ILM

LG

LVOUT

Q10

VST,VC

+B02188F84

SWVDQ104

R5523IC1

Q751(

Q1051V REG.

1 2 3 4

4. BLOCK DIAGRAM4.1 BLOCK DIAGRAM

BSENS

ASENS 18

17

3

1

TUNL

SL

CE1

TUNPCK

TUNPDI

95

10

63

64

65

66

TUNPDO84

CE2

1

VDD3 5

RESET

VDD

VDD3V REG.

Vin

ON/OFF

VINVOUT

Vout

AS

2VDD1

BUP

AMUTE

48MUTE

70VMUTE

CN101

1

4

25

17

2322

7

VD5

AMUTERXLS1STANDBY

IRQPWTXLS1

VDCONT5

8 1

12 4STANBY13 12

3611

Q111SYS+B

XRESET

19DSENS

5SWVDD

SYSPW

USBCTL

XRES9 11

10 8IRQPWR

D+D-

113

23

5

1291

113

1211

43

59

46

24SYNC

VDCONT8

3442

404133

Q112

Q321

VD5

VD5

4A3A1A

1A2A4A

4Y3Y1Y

1Y2Y4Y

P1191

P1121

P1131

LSL

LSV

IECOUT

LOUT

19 COMPOSITOPT3

OPT2(OPTOUT)

B2B1 D-

D+

1OE2OE

A1A2

12

5

4

VDD

VE

VDD5

VD

ILMPW3

50

82 1

F3USBFLG

85

BUP VIN

CONTRO

BUP

4

ROT0

ROT1 1

2

DPDT

KYDT 30

29

8

7

VCCCL1

VCC

5VCCCL2

10CL1

3CL2

27EN2

34SYNC

41EXTVCC

26EN1

VD3

3

1

ON/OFF

VINVOUT

46

1

Q1191

OUTL2

OUTH2

48SW2

15

12

Q1151

OUTL1

OUTH1

21FB1

39FB2

13SW1

TC7SET08FUS1IC311OPT

1|3

IC111TC74VHCT08AFKS1

IC112TC74VHC08FK

TC7MBL6126SFKIC122

D/D CONVERTERIC1103

BD9013KV

VD8

VD3V REG.

BUS SWITCH

IC1111S-1200B33-M5

SYSIC1

NJM23

RESETIC661

S-80835CNMC-B8U

24

75 DRIVER +6dBAMP

IC181NJM2561F1

IC1001S-1200B33-M5

SYS u-COMIC601(1/2)

SYS u-COMIC601(2/2)

PEG753A

BA

CD

:DVH-335UB/XNRC:DVH-3390UB/XNID:DVH-335UB/XNRD:DVH-335UB/XNRI

TUNER AMP UNITA

FM_ANT3

AM_ANT1

10SL5

Lch23

DI

FM/A

M T

UN

ER

UN

IT

DO149

8

CE2

CE1

CK

6

4

13

17

VCCROM_VDD

VDD_3.3

JA471

2,3

1

SYS+B

VDD

ANTENNA

SYS+B13

NJM2885DL1-33IC1011

INOUT

CN

1901

C

49AMPPW

BUP

Q1052

45ACCPW

VDD5

MS5→SRX

S→MS5TX

3V→5V

5V→3V

PEG753ATUNER3V REG.

DVH-335UB/XNRC181 2 3 4

C

D

F

A

B

E

1

4

VD5

V

VIN

CO

N

V

5 6 7 8

6Front_L

7Rear_L

3IN3_L

IN1_L1

IN2_L

4

TUNL

CN821

BUP

JA282

RCA

ACC 5

1B.U

OPT-OUT

JA321

MUTE

BSENS

ASENS

6

10

1315

11

19

5

4

8

3

20

OPT3OPT2(OPTOUT)

32

1

3

1

Q282

RL

BUP

IN4+_L

CN701

RL

1

Vo

4VCRL

FL

RL

AUXV

ILM+B

CN1821

JA1901

AUXL19

5

4

FRONTAUXAUXL 2

AUXR 3AUXGND 1

2

1

5

4ROT1

ROT0

4

6

S1845MULTI-CONTROL

KYDT

DPDT

20

18DPDT

KYDT

10

8

LCD DRIVER/KEY CONTROLLER

IC1801PD6497A

DSEN

USB5V

DPDM

3

20

11

1315

1

REMOTE CONTROLSENSOR

IC1802GP1UXC14RK

CN1911

USB

USB5V

DPDM

2

43

SWVDD

DPDT

KYDT

USB5V

D-D+

ROT0

ROT1

DSENS

BUP

2 SYS+B

SWVDD

Q291

DD

USB5V REG.VINEN

VOUT 5

ILM+B

1

FLG3

NTROLVOUT

4

AUXL

ILM+BQ1061

2

VST,VCK,VDT

SYS+BIC1021

JM2388F84

Q1062

Q292

SWVDDQ1041

R5523N001BIC1101

VCR IN

VMUTE

IC231NJM4558MD

KDT0 15

KDT3

1625

KDT1

26

KST014

KST113

KST212

KST311

KST428

KDT2

E-VOL MAESTRO2

IC201PML014B

Q261(1/2)

Q261(2/2)

CONNECTORPOWER

Q751(2/2)

Q751(1/2)

VDD

Q1051

Q1052

DD5V REG.

5

3

21

23

FL+

FL-

RL+

RL-FLIN12

RLIN14

4 STBY

25B.REMOTE

10

12

11

9

4

RL-

RL+

FL-

FL+

BREM

AMPIC271

PA2030AMUTE22

KEYBOARD UNITB

17REM

A B

1 3OUT1 IN+1

VCRL

KST1

KDT2

D1851,D1852,D1853, D1913D1854,D1855,D1856,D1857,D1858,D1859,D1860,D1861,D1862,D1863,D1864,D1865,D1866,D1867

3

KEY MATRIX

LCDV1801

LSL

AUXL

DVH-335UB/XNRC 195 6 7 8

C

D

F

A

B

E

RES

ONT2ONT1

EJ

EJ

OME

DIN

RGDRV

HALF

VIDEOIC1

N2DS0

1 2 3 4

NRES

HWP(HW+),HWM(HW-)

HVP(HV+),HVM(HV-)

HUP(HU+),HUM(HU-)

HWP(HW+),HWM(HW-)

HVP(HV+),HVM(HV-)

HUP(HU+),HUM(HU-)

NRES

70 N

12 RESET

89

12

567

34

12

3231

272628

14

VHALFTDFD

CRGDRV

MDCONT1CONT2

FOPFOMTOPTOM

CTL1CTL2

FG

FCO+FCO-TKO-TKO+

FCINSLIN

VCTKIN

LDINSPIN

W

HB

SL/LDO-SL/LDO+

VU

SLOPOUT

CN1201

CN101

CN701

CRG/LE+

COIL_U

1718

166

3

4

5

987

HALL_BIAS-HALL_BIAS+

COIL_V

COIL_W

67127126

66

716463

FGCC

12

08

H

62

MLD

CFDTD

343635

33

55

49

65

CRG/LE- 110 V

DVD CORE UNIT

VCC5

BRGY

CRG-CRG+

V COIL VU COIL UW COIL W

VUW

H- HALL BIAS-H+

H-H+ HALL BIAS+

HOME

8SNS

DSCSNS

HOME

8cm

12cm(DSCSNS)

CONNECT PCB

SPINDLE MOTOR

LS1 MECHA UNIT

21

313

16

15

14

101112

123

410

123

410

MLOADING/CARRIAGE

H3

H2

H1

MOTOR

HOMES101

8cmS102

12cmS103

D

C

FLASH 16MIC1401

CWW2689

FLASH 16MIC1402

CWW2690

NRES

NRES 12 RESET

SDRAMIC1480

IS42S16400F-7TL

MOTOR DRIVERIC1201

BD8231EFV

M

DVH-335UB/XNRC201 2 3 4

C

D

F

A

B

E

70

67127126

66

716463

62

55

49

65

110

5 6 7 8

AVCC5

VOUTL 7BCK

LRCKDATA

MD

1

32

13

LOUT

MLMC

SCK

SRCK

LRCKADOUT

SDODAC

LTDACSCKDAC

DACCK

USB_CLOCK

1514

16

149

150151

57

5658

148

50 2

SRCKADOUT

SDODACLRCK

LTDACSCKDAC

DACCK

TRCSTTRCDATA3TRCDATA2TRCDATA1TRCDATA0

TRCCLKEXTRG0

1234

9

7

12

8

13

56

Q1104Q1102

VREFVCC5

CN1101

CN1951

78LD

F+H_G+HE+G_E+F

F+H/G+HE+G/E+F

LPCO2

8

23

4

1415

12

1817

13

2022

7

5

11

Q1103Q110165LD

VCCVref

LPCO1

TRCDATA2 79TRCDATA3

TRCDATA0

TRCST80

77

81

TRCCLK 76

SDATASCLOCK

SDATA 73

SCLOCK 72

EXTRG0

F+H_G+HE+G_E+F

VIN4RFVIN2RFVIN1RF

VIN3RF

VIN8

DVDMPDTEMPRFINP

CDMPD

LPCO2LPCO1

74

112111

999897

100

116105

ACD

B

FE1FE2

RF12296

103

106104

513

VINVOUT

ON/OFF

VCC5

VD8

543

VINVOUT

ON/OFF

A10

B

CD

FE1FE2

78MDCDMPD65MDDVDMPDTEMP

RF

ROUTLOUT

COMPOSITE

152146144138

STANDBY 191

CMDCOMN 53STSCOMN 54

IRQPWR 48

EXTRG1 75

D+

4

D-

AMUTE

2425

2326

F-F+

FOMFOP

TOPTOM

T+T-

TRCDATA1 78

IFCOUTD+D-

SCLSDA

RESET

COMPOSITSTANBYSLVSTS

HSTCMDSTSCOMNCMDCOMN

COMPOSITESTANDBY

ISC_SCLI2C_SDACP_Reset

IRQPWRAMUTE

VD8

XRESETNRES

X1950

ANALOG LOUT

CN1901

9

3

17

25

272829

23

1110

13

8

7

12

1

2219

VREF

NRES

IECOUT

I2C_SDACP_Reset

474661

I2C_SCL

121VDSENS

FGCONT2CONT1

12EJ

08EJ

HOME

MDLDIN

CRGDRVFDTD

120VIN1

109VREFH

119VIN2

118VIN4

117VIN3

114VIN6

113VIN5

VHALF

VIN7 115

13VCC33 VDD5

VCC33

INOUT

28 VDD5VCC12 VINVDD

CE

LX5

VOUT

VDD5VD5

PU (DP10)

DEBUG

34

VIDEO+AUDIOIC1501

MN2DS0018MA

IC1951TC7SZU04FU

AUDIO 2CH ANALOG OUTIC1801

PCM1753DBQ

CN101A

VCC5 REG.IC1002

S-1133850-U5

AVCC5 REG.IC1003

S-1200B50-M5

3.3V REG.IC1004

NJM2885DL1-33

1.2V REG.IC1005

R1232D121B

.2

DVH-335UB/XNRC 215 6 7 8

C

D

F

A

B

E

1 2 3 4

FM/AM TUNER UNIT

A

A

A

A

FM ANT

1

3

AM ANTATT

ATT

NC

CE

2

7 6

RO

M_V

DD SL

13 5

DI

CK

CE

1

NC

DO

NC

NC

NC

NC

10 9 8 11 14 18 19 20 21

FMRF

ANT adjRF adj

FMRF

OSC

IC3EEPROM 5.0V

LPF

IC55V→3.3V

T51 CF52

IC13.3V

MIXER, IF AMP

3.3V 2.5VIC4

3.3V→2.5V

2.5VIC2

DET, FM MPX 23Lch

RFG

ND

OS

CG

ND

DG

ND

AU

DIO

GN

D

NC

VC

C

VD

D_3

.3

2 12 15 22 16 4 17

DVH-335UB/XNRC221 2 3 4

C

D

F

A

B

E

5 6 7 8

5. DIAGNOSIS5.1 OPERATIONAL FLOWCHART

VDD = 5 VPin 14, 60

BSENSPin 17

ASENSPin 18

DSENSPin 19

BSENS = L

DSENS = L

Startscommunication

with Grillemicrocomputer.

SWVDD <- HPin 5

Source keysoperative

Source ON

SYSPW <- HPin 50

Completes power-on operation.(After that, proceed to each source operation)

500 ms

500 ms

In case of the above signal, the communicationwith Grille microcomputer may fail.If the time interval is not 500 msec, the oscillatormay be defective.

Power ON

ASENS = L

DVH-335UB/XNRC 235 6 7 8

C

D

F

A

B

E

1 2 3 4

5.2 INSPECTION METHOD OF PICKUP UNIT

Disc to be used CD-DA: TCD-782

DVD-Video: TDV-582

Execution method

START

Is it OK?

Is it OK?

Ckeck partsother than PICK UP

PICK UPcleaned?

Perform lenscleaning

SKEW ADJ.

Is it OK?

LD current check

RF level check

RF level check

Yes

Error rate check

Finished

LD turned on? Check partsNo

Is it OK? PICK UPcleaned?

Perform lenscleaning

Error rate check

Is it OK?

Replace the PICK UP

Replace the PICK UP

Replace the PICK UP

Replace the PICK UP

Check point:AS MAX check

Check point:LD current check

Check point:Error rate check

YesNo

YesNo

YesNo

YesNo

YesNo

YesNo

YesNo

Check point:AS MAX check

Check point:Error rate check

DVH-335UB/XNRC241 2 3 4

C

D

F

A

B

E

5 6 7 8

LD current check

CheckStatus: [Foucs closed] of TEST MODE

Notes: Please pay attention to the laser diode damage by static electricity.

Threshold

2 TCD-782 CDLD1-VCC5_3 60 - 360 (mV) 10 - 60 (mA)

NO. Disc Check Point

Check Point

DVDLD1-VCC5_3

NO.

1

Disc

GGV1025

Remarks: LD current

10 - 65 (mA)

Threshold

60 - 390 (mV)

Expansion

Expansion

Remarks: LD current

DVH-335UB/XNRC 255 6 7 8

C

D

F

A

B

E

1 2 3 4

ASMAX checkASMAX value shows the value of RF level.Status: [Foucs closed] of TEST MODE

No. Disc Check Point Threshold Remarks:8 digits value of

ASMAXmore than

on display 0000 0B008 digits value of

ASMAXmore than

on display 0000 0C00

Error rate checkStatus: [Tracking Closed] of TEST MODE

No. Disc Check Point Threshold Remarks:less than

1.000E-03less than

1.000E-03less than

2.500E-033 TCD-782 ID: HOME Position

2 GGV1025 ID: 200000

1 GGV1025 ID: 40000

1 GGV1025Only four last digits aredisplayed according to

the product.

2 TCD-782Only four last digits isdisplayed according to

the product.

In this case, the value is displayed for a split second.When you tried to perform [FOCS CLOSE],the display will charge automatically in the following order.[1FFF0000]->[FEMAX]->[FE MIN]->[AS MAX]->[ENV MAX]->[FE normal]->[Spindle gain]->[TEMAX]->[TEMIN] ->[20000000]Watch carefully the value of ASMAX.

DVH-335UB/XNRC261 2 3 4

C

D

F

A

B

E

5 6 7 8

5.3 DIAGNOSIS FLOWCHART

BA

CK

EN

D s

ectio

n flo

w

Sta

ndby

OK

?E

xecu

tech

eck

1.

Can

the

play

back

sta

rt?

NO

YE

S

YE

S

YE

S

YE

S

YE

SY

ES

YE

SY

ES

YE

S

YE

S

YE

S

YE

S

NO

NO

NO

NO

NO

YE

S

YE

S

YE

S

NO

YE

SY

ES

NO

ST

AR

T

EN

D

EN

DY

ES

NO

NO

NO

NO

NO

YE

S

YE

S

NONO

NO

YE

S

NO

NO

NO

YE

S

YE

S

NO

YE

S

Doe

s th

e op

erat

ion

take

tim

e?

Go

to F

E

sect

ion

chec

k.

Go

to F

E

sect

ion

chec

k.

Is th

e life

of f

lash

m

emor

y O

K?

Cond

uct c

heck

item

12.

Is th

e im

age

in e

rror

?

Is th

e vi

deo

circ

uit O

K?

Exe

cute

che

ck 1

1.

Is A

VC

C5

volta

ge O

K?

Exe

cute

che

ck 8

.

Rep

lace

the

unit.

Is V

DD

5(V

CC

33, V

CC

12)

pow

er s

uppl

y vo

ltage

OK

? E

xecu

te c

heck

2.

Res

et O

K?

Exe

cute

che

ck 3

.

Is V

SE

NS

O

K?

Exe

cute

che

ck 4

.

Is 2

7 M

Hz

OK

?E

xecu

te c

heck

5.

Is 4

8 M

Hz

OK

? E

xecu

te c

heck

13.

Rep

lace

the

unit.

Rep

lace

the

unit.

Go

to F

E

sect

ion

chec

k.

Go

to F

E

sect

ion

chec

k.

Is V

D8,

VC

C5

pow

er s

uppl

y vo

ltage

OK

? E

xecu

te c

heck

7.

Is S

DR

AM

IF

OK

? E

xecu

te c

heck

6.

Is th

e so

und

in e

rror

?Is

the

US

B p

lay

in e

rror

?

Is A

VC

C5

volta

ge O

K?

Exe

cute

che

ck 8

.

Is D

ACCL

K no

rmal

?Ex

ecut

e ch

eck

9.

Is th

e au

dio

circu

it O

K?

Exec

ute

chec

k 10

.

Rep

air

the

defe

ctiv

e pa

rt.

Nor

mal

?

Nor

mal

?

Is F

E s

ectio

n no

rmal

?

Go

to F

E r

elat

ed

repa

ir pr

oces

s.

Is th

e U

SB

circ

uit O

K?

Exe

cute

che

ck 1

4.

DVH-335UB/XNRC 275 6 7 8

C

D

F

A

B

E

1 2 3 4

Check 1: Standby OK?

<Check> Check the voltage at the “STANBY” test point while the power is on. Use the “DGND1” test point at the reference.

NO. Check point Module No. Specification value UnitSTANBY-DGND1 ALL VCC33 V-

0.6 V or moreV

Side A

1

Fig 1.1: STANBY check pointSTANBY

DGND1

DVH-335UB/XNRC281 2 3 4

C

D

F

A

B

E

5 6 7 8

VCC33 (= 3.3 V)5DDV

VCC12 (= 1.2 V)

1 VDD5_1 - DGND12 VCC33_1 - DGND13 VCC12_1 - DGND1

VDD5_1

DGND1

VCC12_1

VCC33_1

Check 2: Is VDD5 (VCC33, VCC12) power supply voltage OK?

Fig 2.1: Power supply configuration

IC10043.3 V output regulator

IC1005DC/DC converter1.2 V output

IC1501 DV5U power supply

IC1401 FLASH power supply (Data)IC1402 FLASH power supply (Program)IC1481 SDRAM power supplyIC1501 DV5U power supply

<Check> Check the voltage at the “VDD5_1, VCC33_1 and VCC12_1” test point while the power is on. Use the “DGND1” test point at the reference.

Side A

NO. Check point Module No. Specification value Unit

Fig 2.2: VDD5, VCC33, VCC12 voltage check points

ALLALLALL

5.0 ± 0.43.3 ± 0.151.2 ± 0.12

VVV

DVH-335UB/XNRC 295 6 7 8

C

D

F

A

B

E

1 2 3 4

NRES

DGND1

Check 3: Reset OK?

NO. Check point Module No. Specification value Unit1 XRES-DGND1 ALL VCC33 ×

0.7 or moreV

Side A

<Check> Check the voltage at the “XRES” test point while the power is on. Use the “DGND1” test point at the reference.

Fig 3.1: RESET check point

DVH-335UB/XNRC301 2 3 4

C

D

F

A

B

E

5 6 7 8

CN1901HOST I/F

SNESV8DV

33CCV5DDV

VCC12

STANBYXRES

1 VSENS - DGND1 ALL 0.95 - 1.07 VVD8 = 8.0 ± 0.4 V

IC1501DV5U

IC1004Regulator

IC1005DC/DC converter

VSENS

DGND1

Check 4: Is VSENS OK?

Fig 4.1: Power supply configuration and VSENS

<Check> Check the voltage at the “VSENS” test point while the power is on. Use the “DGND1” test point at the reference.

NO. Check point

Side A

Module No. Specification value Unit

Fig 4.2: VSENS check point

R1004,R1007

DVH-335UB/XNRC 315 6 7 8

C

D

F

A

B

E

1 2 3 4

IC1501

DVD-LSIX150127 MHzcrystal

VCC33 VCC12

Check 5: 27 MHz Normal?

<Outline> Each clock is created inside the IC1501 using the 27 MHz master crystal oscillator (X1501).

Fig 5.1: Clock configuration

<Check method> Turn the power on, and check with DGND being the reference. In case of NG, check the applicable line, periphery of IC1501, soldering of the peripheral components and defective components.


2 IC1501 169pin ALL 27 MHz± 50 ppm ppm

GNDFig 5.2: Clock specification value

Side A

Specificationvalue

Fig 5.3: 27 MHz check point

IC1501 158pin

DGND1

OSCO

OSCI

DVH-335UB/XNRC321 2 3 4

C

D

F

A

B

E

5 6 7 8

MA0 - 11MDQ0 - 15MCKXWE(NWE)XCAS(NCAS)XRAS(NRAS)XCSM(NCSM)DQM0DQM1BA0BA1

IC1480SDRAM

IC1501DV5U

Fig 6.1: SDRAM I/F

Check 6: Is SDRAM I/F OK?

<Outline> In order to secure the MPEG stream data as the buffer, the capacity of communication I/F SDRAM between the LSI and the memory is 64Mbit. Be careful as XCSM, XWE, XCAS and XRAS of IC1480 are called differently in IC1501, namely NCSM, NWE, NCAS, NRAS.

DVH-335UB/XNRC 335 6 7 8

C

D

F

A

B

E

1 2 3 4

123456789

10111213141516171819202122232425262728293031323334353637

MA0MA1MA2MA3MA4MA5MA6MA7MA8MA9MA10MA11MDQ0MDQ1MDQ2MDQ3MDQ4MDQ5MDQ6MDQ7MDQ8MDQ9MDQ10MDQ11MDQ12MDQ13MDQ14MDQ15MCKXWEXCASXRASXCSMDQM0DQM1BA0BA1

56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %0.17 ohm or lower56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %

IC1480 23pinIC1480 24pinIC1480 25pinIC1480 29pinIC1480 30pinIC1480 31pinIC1480 32pinIC1480 33pinIC1480 34pinIC1480 33pinIC1480 22pinIC1480 35pinIC1480 2pinIC1480 4pinIC1480 5pinIC1480 7pinIC1480 8pinIC1480 10pinIC1480 11pinIC1480 13pinIC1480 42pinIC1480 44pinIC1480 45pinIC1480 47pinIC1480 48pinIC1480 50pinIC1480 51pinIC1480 53pinIC1480 38pinIC1480 16pinIC1480 17pinIC1480 18pinIC1480 19pinIC1480 15pinIC1480 39pinIC1480 20pinIC1480 21pin

IC1501 201pinIC1501 203pinIC1501 207pinIC1501 209pinIC1501 208pinIC1501 206pinIC1501 202pinIC1501 200pinIC1501 198pinIC1501 194pinIC1501 199pinIC1501 192pinIC1501 160pinIC1501 162pinIC1501 164pinIC1501 168pinIC1501 170pinIC1501 172pinIC1501 176pinIC1501 178pinIC1501 177pinIC1501 175pinIC1501 171pinIC1501 169pinIC1501 167pinIC1501 163pinIC1501 161pinIC1501 159pinIC1501 183pinIC1501 181pinIC1501 188pinIC1501 189pinIC1501 190pinIC1501 179pinIC1501 180pinIC1501 193pinIC1501 197pin

<Check> Check the conductivity at “check point 1” and “check point 2” without power. In case of NG, check the soldering and defective components throughout the “output t input” of the applicable section.

NO. Signal name Check point 1 Check point 2 Specification value

DVH-335UB/XNRC341 2 3 4

C

D

F

A

B

E

5 6 7 8

Side B

Side A

Check point 1 (IC1480)

Check point 2 (IC1501)

Fig 6.2: SDRAM I/F check point

DVH-335UB/XNRC 355 6 7 8

C

D

F

A

B

E

1 2 3 4

VD8_1

PGND3VD

VD8_1

PGND1

VCC5_1

AGND3

Check 7: Is VD8, VCC5 power supply voltage OK?

F.E. driver system

IC1002REG IC for VCC 5 V.


Power supply for PU

NO. Check point Module No. Specification value Unit123

VD8_1 - PGND3VD - PGND3VCC5_1- AGND1

ALLALLALL

8.0 ± 0.48.0 ± 0.45.0 ± 0.1

VVV

Side A

<Check> Check the voltage at the “VD8_1, VD and VCC5_1” test point while the power is on. Use the “PGND3 and AGND1” test point at the reference.

Fig 7.2: VD8, VCC5 voltage check points

VD8_2 VCC5 (= 5.0 V)

DVH-335UB/XNRC361 2 3 4

C

D

F

A

B

E

5 6 7 8

DV IC1801Audio-DAC

GNDAU1PGND3VD

AVCC5

Fig 8.2: VD8, AVCC5 voltage check points

Side A

Check 8: Is AVCC5 voltage OK?


IC1003REG IC for AVCC 5 V.

<Check> Playback DVD-REF-A1 TITLE 1 and check the voltage at the stylus. Check with PGND and GNDAU being the reference.

NO. Check pointVD - PGND_3AVCC5 - GNDAU1

Module No. Specification value Unit12

ALLALL

8.0 ± 0.45.0 ± 0.1

VV

AVCC5 (= 5.0 V)

DVH-335UB/XNRC 375 6 7 8

C

D

F

A

B

E

1 2 3 4


Check 9: Is DACCLK normal?<Outline> DACCLK for Audio-DAC is created by IC1501 using the 27 MHz master crystal oscillator (X1501).

DACCLK

<Check method> DVD: DVD-REF-A1 TITLE 1CD: Playback a normal CDDA.Common to all DVD-V compatible modules.Check with DGND being the reference.In case of NG, check the applicable line, the periphery of IC1501, soldering of the peripheral components and defective components.

IC1501

DVD-LSIX150127 MHz crystal

IC1801Audio-DAC

VCC33 VCC12

GND

Fig 9.2: Clock specification value

Specificationvalue 1

Specificationvalue 2 Specification

value 3

NO. Check point 1 (stylus) Media Specification value 1 Specification value 2 Specification value 312

DACCKDACCK

DVDCD

2.0 V~VCC33 V2.0 V~VCC33 V

DGND~0.8 VDGND~0.8 V

36.864 0 MHz ± 300 ppm33.868 8 MHz ± 300 ppm

DVH-335UB/XNRC381 2 3 4

C

D

F

A

B

E

5 6 7 8

DGND2

Side B

Side A

Fig 9.3: 27 MHz, DACCLK check point

Check point 1 (DACCK stylus)

Check point 2 (IC1501 148 pin)

DVH-335UB/XNRC 395 6 7 8

C

D

F

A

B

E

1 2 3 4

CN1901HOST I/F

IECOUT

OLKCRLADOUT

ORKCRS

GNDAU

IC1801Audio-DAC

IC1501DVD-LSI

Fig 10.1: Audio circuit

Check 10: Is the audio circuit OK?<Outline> The serial 3 lines digital output + DACCLK, output from DVD-LSI (IC1501), are converted to analog audio signal at Audio-DAC (IC1801) and are output from the HOST I/F (CN1901). Simultaneously, the analog MUTE signal is also output from DVD-LSI (IC1501) via the HOST I/F. The digital audio signal (IECOUT), output from DVD-LSI (IC1501).

<Check method> Playback DVD-REF-A1 TITLE 2 CHAPTER 1 (48 k/16 bit 1 kHz 0 dB), and check with DGND being the reference. In case of NG, check the applicable line, periphery of major components as described in the above drawing, soldering of the peripheral components and defective components.

NO. Check point 1 (stylus)123

Specification value 1 Specification value 2 Reference waveformADOUT3SRCKLRCK

VCC33 V-0.6 V or higherVCC33 V-0.6 V or higherVCC33 V-0.6 V or higher

0.4 V or lower0.4 V or lower0.4 V or lower

Waveform 1Waveform 2Waveform 3

GND

Fig 10.2: Serial 3 lines specification value



DVH-335UB/XNRC401 2 3 4

C

D

F

A

B

E

5 6 7 8

SRCK

LRCK

ADOUTDGND2

Fig 10.3: Serial 3 lines check points

Side A

Side B

DVH-335UB/XNRC 415 6 7 8

C

D

F

A

B

E

1 2 3 4

LORO GNDAU1

The following checks shall be conducted using the following measurement circuits with GNDAU1 being the reference.

NO.45

Fig 10.4: Analog audio out (LO, RO) specification value.

Side A

Specification value is the root-mean-square value (rms).

Check point 1 (stylus)1 400 ± 150 mV1 400 ± 150 mV

Specification value (rms) Reference waveformWaveform 4Waveform 4

LORO

LO GNDAU1 RO

47 kohm 47 kohm

Fig 10.5: Analog audio out check point

Check with DGND being the reference.

NO. Check point 1 (stylus) Specification value 1 Specification value 2 Reference waveform6 IEC VCC33 V-0.6 V or higher 0.4 V or lower Waveform 5

DVH-335UB/XNRC421 2 3 4

C

D

F

A

B

E

5 6 7 8

IEC DGND2

Fig 10.6: Digital audio signal (IECOUT) check point

Side A

DVH-335UB/XNRC 435 6 7 8

C

D

F

A

B

E

1 2 3 4

Check 11: Is the video circuit OK?

<Outline> Composite signal and component signal are output from DVD-LSI (IC1501), and are output from the HOST I/F (CN1901) via a buffer circuit.

CN1901HOST I/F

Composite COMPOSITE

Fig 11.1: Video circuit

<Checking method> Playback DVD-REF-A1 TITLE2 CHAPTER5 (WHITE 100%), and monitor COMPOSITE signal with an oscilloscope with GNDV1 (stylus) being the reference. Set the trigger mode to “TV trigger” and the trigger line to “150 line”.

IC1501DVD_LSI

VideoDACsection

NO.

Check point 1 (stylus)

Specification value Reference waveform1 COMPOSITE 1 000 mVpp ± 5 % Waveform 6

In case of NG, check the applicable line, the periphery of the major components in the drawing above, soldering of the peripheral components and defective components.

PEAK

COMPOSITE signal Referencevalue

Color burstPedestal level

BOTTOMHorizontal sync signal

Fig 11.2: Waveform for the case of composite white 100% output

DVH-335UB/XNRC441 2 3 4

C

D

F

A

B

E

5 6 7 8

Side A

COMPOSITE GNDV

Fig 11.3: VIDEO signal check point

DVH-335UB/XNRC 455 6 7 8

C

D

F

A

B

E

1 2 3 4

Check 12:How to judge whether the flash memory has reached its life or not.

If the reaction to user operation is slow or operation is slow in general, there is a possibility that the flash memory has reached its life.Make judgment regarding the flash memory life by looking at the display of the LD energizing time.

1.Let the LD energizing time displayed. (Refer to the FE test mode for the method of displaying the LD energizing time.) 2.If the second digit from the left of the energizing time display is showing E, such as “ E ”, it means that the flash memory has reached its life.

Example:

0E000BB8

DVH-335UB/XNRC461 2 3 4

C

D

F

A

B

E

5 6 7 8

USB_CLOCK

IC1501

DVD-LSIX195048 MHz

VCC33 VCC12

Check 13: 48 MHz Normal?<Outline> Each clock is created inside the IC1501 using the 48 MHz master crystal oscillator (X1501).


crystal

Fig 13.2: Clock specification value

<Check method> Turn the power on, and check with DGND1 being the reference. In case of NG, check the applicable line, periphery of IC1501, soldering of the peripheral components and defective components.


2 IC1501 50pin-DGND1 ALL 48 MHz± 50 ppm ppm

GND

Specificationvalue

DVH-335UB/XNRC 475 6 7 8

C

D

F

A

B

E

1 2 3 4

Side A

DGND1

IC1501 50pin

Fig 13.3: 48 MHz check point

DVH-335UB/XNRC481 2 3 4

C

D

F

A

B

E

5 6 7 8

CN1901HOST I/F

No.1 CP_RESET2 SDATA VCC33*0.7or more VCC33*0.2 or less

VCC33*0.7or more VCC33*0.2 or lessVCC33*0.7or more VCC33*0.3 or lessVCC33*0.7or more VCC33*0.3 or less

3 SCLOCK4 D+5 D-

Fig. 14.2: USB Circuit Communication Wave

VCC33*0.7or more

IC1501DVD-LSI

D-

D+

I2C_SCL

I2C_SDA

CP_RESE

Standard value 1

Standard value 1

Standard value 2

Standard value 2

DGND

Check 14: Is USB Circuit OK?<Outline>The data is transmitted through D+, D- and SDA of HOST I/F while playing USB/IPOD.USB memory uses only D+ and D-, but IPOD uses SDA (DATA) and SCL (CLOCK)in addition to D+ and D-.

Fig. 14-1: USB Circuit

<Check Method>1.USB Memory: Play a song from USB memory and check D+ and D- with the DGND standards.2.iPod: Connect iPod and check CP_RESET, SDA and SCL with the DGND standards until the pioneer log appears.Play a song from iPod and check D+/D- with the DGND standards.When it does not conform to the standards, check appropriate line, main parts shown in the above figure, soldering of peripheral parts and malfunctions in parts.

Checking spot (stylus)

*Until the pioneer log appears after connecting the iPod*Until the pioneer log appears after connecting the iPod

DVH-335UB/XNRC 495 6 7 8

C

D

F

A

B

E

1 2 3 4

Side A

SCLOCK

SDATA

D-

CP_RESET

D+ DGND2

DVH-335UB/XNRC501 2 3 4

C

D

F

A

B

E

5 6 7 8

AUDIO

Reference voltage: DGND2 1 V/div. 5 usec/div Reference voltage: GNDAU2 1 V/div. 500 usec/div

Reference voltage: DGND2 1 V/div. 5 usec/div Reference voltage: DGND2 1 V/div. 500 nsec/div

CH1:LRCK

CH1:SRCK

CH1:ADOUT3

CH1:LOCH2:RO

CH1:IECOUT

Reference voltage: DGND2 1 V/div. 5 usec/div

G->

G->

->G->G

G->

G->

Waveform 1 Waveform 4

Waveform 2

Waveform 3

Waveform 5

DVH-335UB/XNRC 515 6 7 8

C

D

F

A

B

E

1 2 3 4

VIDEO

USB memoryUSB memory USB memory

[WHITE 100IRE]

CH1:COMPO

Reference voltage: GNDV1 200 mV/div. 10 usec/div

-D-D

DNGDDNGD+D+D

Waveform 6

Waveform 7 Waveform 8

Reference voltage:DGND 1 ms/div 2 V/div Reference voltage:DGND 200 ns/div 2 V/div

DVH-335UB/XNRC521 2 3 4

C

D

F

A

B

E

5 6 7 8

5.4 ERROR CODE LIST* The label peeling is not notified as an error status. It is notified as bit of BD value.

Error status OSD LCD UART *2

Meaning Disc USB(MSC)

USB(iPod)

ACCOff/On

SourceOff/On

Eject/ PlayKey

Media Error UNPLAYABLEDISC " NON-PLAY " 00h A disc containing the unplayable format only

(The error status is treated as there is no error.) X - - X X X -

INCOMPATIBLEDEVICE " NON-PLAY " 00h USB device that doesn't correspond - X X X X X -

UNPLAYABLEFILE " NON-PLAY " 00h USB device of format alone that cannot be

reproduced - X - X X X -

Open (No display) 10h Door open error X - -Read Error ERROR-02-99 "ERROR02-99"

"ERROR02-90"

20h Transfer start error X - - X X X XFocus Error(Focus Error inmechanism set up) ERROR-02-90 21h Focus error X - - X X X X

Surface Error ERROR-02-9E "ERROR02-9E" 22hFocus error during set up(A focus has neverbeen achievedwith that disc.) X - - - - X -

Address not found(Invalid Track) ERROR-02-80 "ERROR02-80" 23h Address not found X - - X X X X

Spindle Lock ERROR-02-91 "ERROR02-91" 24h Spindle lock NG(the disc cannot rotate) X - - X X X X

Carriage HOME ERROR-02-92 "ERROR02-92" 25hCarriage home NG(The pick up tries to return to carriagehome, but it cannot go back and stopped.)

X - - X X X X

ID/SUBCODE Read Error ERROR-02-94 "ERROR02-94" 26h ID/SUBCODE Read Error (ID/SUBCODEcannot be read due to scratch or stain.) X - - X X X X

AV CHIP decode Error ERROR-02-9A "ERROR02-9A" 2Ah AV CHIP decode NG(AV chip cannot bedecoded.) X X X X X X X

AV CHIP Recovery NG ERROR-02-9B "ERROR02-9B" 2Bh AV CHIP recovery NG X X - X X X XError of PLAY BACK ModeStatus ERROR-02-9C "ERROR02-9C" 2Ch Playback state error

(An error due to software bug.) X X - X X X X

Disc Data Error ERROR-02-9D "ERROR02-9D" 2Dh Disc Data NG X - - X X X X

Temp Error(In Case of High Temperature)

THERMALPROTECTION INMOTION

" HEAT " 30hHigh temperature(Playback is stoppedbecause the pick uptemperature is 89 C orhigher.)

X - - X - - -

No Disc(including Disc loading andejecting)

(No display) 40hDisc has not been inserted.(Including Load in process or Eject inprocess.)

X - - * * * *

Loading_Mecha Error (No display) 50hLoading mechanism error(The disc cannot be clamped.) X

X*11

X*11

X -X

*12X

*14X

*14X

*14X

*14

-

Communication fault attestingiPod ERROR-02-60 "ERROR02-60" 60h Communication fault attesting iPod

X*13

- X X - -

iPod authentication data isabnormal ERROR-02-61 "ERROR02-61" 61h iPod authentication data is abnormal

X*13

- X X - -

iPod attestation retrying failure ERROR-02-62 "ERROR02-62" 62h iPod attestation retrying failureX

*13- X X - -

iPod attestation time out ERROR-02-63 "ERROR02-63" 63h iPod attestation time outX

*13- X X - -

Error when iPod is connected/Itis generated STALL by the USBcommunication

ERROR-02-64 "ERROR02-64" 64hError when iPod is connected/It is generated STALL by the USBcommunication

- - X X - X -

Error setting iPod ERROR-02-65 "ERROR02-65" 65h Error setting iPod - - X X - X -Demand timeout wheninitial is communicated ERROR-02-66 "ERROR02-66" 66h

Demand timeout when initial iscommunicated - - X X - X -

Protocol versionnon-correspondence

ERROR-02-67 "ERROR02-67" 67hProtocol version non-correspondence(It is necessary to upgrade iPod main unitwith iTunes)

- - X X - X -

Timeout when protocolversion is judged ERROR-02-68 "ERROR02-68" 68h Timeout when protocol version is judged - - X X - X -

No songs error (No display) " STOP " 69hNo songs error(It is necessary to import a track in iPod fromiTunes.)

- - X X - X -

iPod control forwarding/Intarapta forwarding error ERROR-02-6A "ERROR02-6A" 6Ah

iPod control forwarding/Intarapta forwardingerror - - X X - X -

Demand timeoutiPod's reproducing ERROR-02-6B "ERROR02-6B" 6Bh Demand timeout iPod's reproducing - - X X - X -

Remote switch error ERROR-02-6C "ERROR02-6C" 6Ch Remote switch error - - X X - X -Remote switch demandtimeout ERROR-02-6D

"ERROR02-6D"6Dh Remote switch demand timeout - - X X - X -

DRM Error PROTECTEDDISC " PROTECT " 70h

DRM error (All music cannot be played backdue to DRM.) X - - X X X -

NO ACCESSIBLE DATA AVAILABLE " PROTECT " 70h

DRM error (All music cannot be played backdue to DRM.) - X - X X X -

Region code Error DIFFERENTREGION DISC "REGIONERR" 90h

Region code NG (Unable to be played backdue to incorrect mechanism region.) X - - X X X -

REQUEST error ERROR-02-A0 "ERROR02-A0" A0h REQUEST error X - - X X X XFailure in issuing readcommand (chip dependent) ERROR-02-A1 "ERROR02-A1" A1h Failure in issuing the read command X - - X X X X

Adjustment of L0 is NG ERROR-02-A2 "ERROR02-A2" A2h L0 adjustment is NG X - - X X X XAdjustment of L1 is NG ERROR-02-A3 "ERROR02-A3" A3h L1 adjustment is NG X - - X X X XLD system NG ERROR-02-A4 "ERROR02-A4" A4h LD system NG X - - X X X XGain adjustment system NG ERROR-02-A5 "ERROR02-A5" A5h Gain adjustment system NG X - - X X X X

Method of resetGeneration

DVH-335UB/XNRC 535 6 7 8

C

D

F

A

B

E

1 2 3 4

Error status OSD LCD UART *2

Meaning Disc USB(MSC)

USB(iPod)

ACCOff/On

SourceOff/On

Eject/ PlayKey

Gain determining system NG ERROR-02-A6 "ERROR02-A6" A6h Gain determining system NG X - - X X X XServo initial setting related itemsNG. ERROR-02-A7 "ERROR02-A7" A7h Servo initial setting related items NG X - - X X X X

Disc is not clamped yet ERROR-02-A8 "ERROR02-A8" A8h Disc is not clamped yet X - - X X X XTracking system NG ERROR-02-A9 "ERROR02-A9" A9h Tracking system NG X - - X X X XMedia setting system NG ERROR-02-AA "ERROR02-AA" AAh Media setting system NG X - - X X X XFocus Error ERROR-02-AB "ERROR02-AB" ABh JUMP over layers NG X - - X X X XError of PLAY BACK Mode Status ERROR-02-B0 "ERROR02-B0" B0h Navigation command error X - - X X X XError of PLAY BACK Mode Status ERROR-02-B1 "ERROR02-B1" B1h Retry over X - - X X X XError when MCS is connected/Itis generated STALL by the USBcommunication

ERROR-02-D0 "ERROR02-D0" D0hError when MCS is connected/It is generatedSTALL by the USB communication

- X - - - X -

CBW and CSW forwarding error ERROR-02-D1 "ERROR02-D1" D1h CBW and CSW forwarding error - X - - - X -Audio class band securing failure ERROR-02-D8 "ERROR02-D8" D8h Audio class band securing failure - - X X - X -Audio class FS setting failure ERROR-02-D9 "ERROR02-D9" D9h Audio class FS setting failure - - X X - X -Undefined Error ERROR-FF-FF "ERRORFF-FF" FFh Undefined error X - - X X X X

X: Cancel the error by operation. -: Error is not cancelled by operation. *: No setting*1 Even in the Disc source, it is released without the Device.*2 A parameter of UART command, such as “receipt error notice”, that the DVD mechanism transmits.*3 CPPM(Content Protection for Prerecorded Media) : A copyright protection technique used in DVD-A. The protection is realized by using the keys recorded on the media and the device key held by the player.*4 DVD-A compatible model only. When an error has occurred, only the audio output will be muted but playback operation will continue. Furthermore, acceptance of the user operation will be the same as usual.*5 AWM (Audio WaterMark): Electronic watermark. Information on the copyright owner or CCI (copy control information) are recorded so that illegally copied discs can be identified.*6 It is not notified as an error status, however, it is notified that an error is being generated in the operation status notice.*7 CPRM(Content Protection for Recordable Media) : A copyright protection technique for digital contents used for re-writable DVD or memory card.*8 DVD-VR compatible model only.*9 It is generated when the audio property information notice is sent from DVD mecha and the audio property activation notice is not returned. The time for the generation is the time set by the audio property notice wait time set by the connection confirmation command.*10 It is generated when the DRM information update notice is sent from DVD mecha and the response of DRM information update is not returned.*11 Even in the USB source, it is notified as an error of Disc source.*12 Even in the USB source, it is released by ejecting the Disc only.*13 Even in the Disc source, it is notified as an error of USB source.

Method of resetGeneration

DVH-335UB/XNRC541 2 3 4

C

D

F

A

B

E

5 6 7 8

USB audio player/USB memory

noitcAesuaCegasseM

FRMT READ (FORMAT READ) Sometimes there is a delay betweenthe start of playback and when youstart to hear any sound.

Wait until the message disappears and youhear sound.

SKIPPED (FILE SKIPPED) The connected USB portable audioplayer/USB memory contains WMAfiles that are protected by WindowsMedia DRM 9/10.

Play an audio file not embedded withWindows Media DRM 9/10.

PROTECT (NO ACCESSIBLEDATA AVAILABLE)

All the files on the connected USBportable audio player/USB memoryare protected by Windows MediaDRM 9/10.

Transfer audio files not protected by WindowsMedia DRM 9/10 to the USB portable audioplayer/USB memory and connect.

N/A USB (INCOMPATIBLE DE-VICE)

The USB device connected to is notsupported by this unit.

Connect a USB portable audio player or USBmemory that is USB Mass Storage Classcompliant.

The USB device is not formattedwith FAT16 or FAT32.

The connected USB device should be for-matted with FAT16 or FAT32.

CHECK USB The USB connector or USB cablehas short-circuited.

Check that the USB connector or USB cableis not caught in something or damaged.

The connected USB portable audioplayer/USB memory consumesmore than 500 mA (maximum allow-able current).

Disconnect the USB portable audio player/USB memory and do not use it. Turn the igni-tion switch to OFF, then to ACC or ON andthen connect a compliant USB portableaudio player/USB memory.

ERROR-02-DX Communication failed. Perform one of the following operations.–Turn the ignition switch OFF and back ON.–Disconnect the USB portable audio player/USB memory.–Change to a different source.Then, return to the USB portable audioplayer/USB memory.

EXPIRED (THIS DivX RENTALHAS EXPIRED.)

The inserted external storage devicecontains expired DivX VOD content.

Select a file that can be played.

WRITE FAIL (CAN NOT SAVEDATA)

This unit’s flash memory used asthe temporary storage area is full.


ERROR (YOUR DEVICE IS NOTAUTHORIZED TO PLAY THISDivX PROTECTED VIDEO)

This unit’s DivX registration codehas not been authorized by the DivXVOD contents provider.

Register this unit to the DivX VOD contentsprovider.

NON-PLAY (UNPLAYABLE FILE) This type of file cannot be played onthis unit.

Select the playable file.

There are no songs. Transfer the audio files to the USB portableaudio player/USB memory and connect.

Security for the connected USBmemory is enabled.

Follow the USB memory instructions to dis-able security.

NON-PLAY (VIDEO RESOLU-TION NOT SUPPORTED)

The inserted external storage devicecontains a high definition DivX file.


NON-PLAY (VIDEO FRAME-RATE NOT SUPPORTED)

DivX file’s frame rate is more than30 fps.


NO AUDIO (AUDIO FORMATNOT SUPPORTED)

This type of file is not supported onthis unit.


DVH-335UB/XNRC 555 6 7 8

C

D

F

A

B

E

1 2 3 4

5.5 CONNECTOR FUNCTION DESCRIPTION

DVH-335UB/XNRC561 2 3 4

C

D

F

A

B

E

5 6 7 8

6. SERVICE MODE6.1 DISPLAY TEST MODE

Key

2

1

Processing

Move to the next display test contents (B)

Contents (A) Contents (B)

Move to the next display test contents (A)

All lighting of displayPattern(1) lighting

Lighting of display

The same contents as the left


All lights out of displayQWW number is displayedPEG number is displayed

Pattern(2) lighting


System microcomputer version is displayed

LS1 mechanism version is displayed

System version display

Normal display

Display STOPROM Correction version display

Display test mode (1)/(2) confirm ROM correction information and the lighting of all segments of a LCD display.

Display test mode (1)

Display test mode (2)

Valid only during display test mode (1)


LIST Transition to “The lighting of all segments is turned off”

DISP/BACK Transition to LCD check mode H display

Transition to LCD check mode F display

Transition to QWW number display

6

4


Remarks

Transition to “The lighting of all segments is turned on” is valid only during display test mode (1)

Valid only during display test mode (1)Transition to default color illumination display5 Valid only during display test mode (1)

Operation Key Processing

LEFT + DOWNEnter display test mode (1)Transition to “The lighting of all segments is turned on”

Press “LEFT” and “DOWN” keys simultaneously to start resetting.

Press “1” and “3” keys simultaneously to start resetting.

DVH-335UB/XNRC 575 6 7 8

C

D

F

A

B

E

1 2 3 4

6.2 DVD TEST MODE

Image of the test mode.

[Note] Higher level 4 characters only. Lower level 4 characters are spaces.

)2()1(

Start of the test mode.

TEST

FE test selection EDC1 test selection

Hereafter, to FE test mode image.

Hereafter, to EDC1 test mode image.

[Note] In order to move on to another test after selecting a test (FE/EDC1/EDC2), it is necessary to restart the DVD mechanism in the test mode.

(3)

EDC2 test selection

Hereafter, to EDC2 test mode image.

(4)

LD power on time mode selection

Hereafter, to LD power on time mode image.

(5)

Simple FE test mode

Hereafter, to simple FE test mode.

Legend: … Key operation

… Operation state

… The content displayed on the DVD mechanism (video only)8 characters data is sent to the product side (HOST) by UART communication.

Image of the front end test mode.

(2)

FE test mode

Disc type DVD1 layer

FE offset coefficientTE offset coefficientAS offset coefficientENV offset coefficientTG offset coefficientDBAL coefficientVIN1 offset cancel valueVIN2 offset cancel valueVIN3 offset cancel valueVIN4 offset cancel valueVIN5 offset cancel value

Power on

0000 00000FFF 0000

0 x 00 0000


… Operation state


)5()4(

Disc type DVD2 layer

Disc type CD

0000002000000010

Disc type CD-RW

0300 0000

EJECT

EJECT

[Note] If no action is taken for approximately 10 seconds after LD-ON, it will become LO-OFF automatically. If F close is selected during LD-OFF, it will become an error.During focus search (S character measurement mode), too, safety regulation applies if LD_OFF is not selected within 10 seconds. Therefore, even if focus search is selected after LD-ON, it will become LD-OFF after 9 seconds.In order to F close after focus search (S character measurement mode), set to Power_OFF first then power on again before F close.

FEMAX levelFEMIN levelASMAX levelENVMAX levelFE normalization coefficientSpindle gain coefficientTEMAX level indicationTEMIN level indication

(2)

Focus close state

)2()1(

S curve measurement

(2)

hcraesFesolcF

1A00 0000

F search

1100 0000

1FFF 0000

(3),(4)

CRG+/-

Activates while the key is being pressed.

1B00 0000 : CRG+1C00 0000 : CRG-

(5) (6)

LD-ON/OFF

When LO-ON: 1100 0000When LD-OFF: 1000 000

CRG_HOME

1D00 0000

(8)

Power_OFF

(1) (3)

a b

1 x 00 0000

(7)

CRG_OUTSIDER

1E00 0000

[4] + [6] -> BUP + ACC ONSOURCE : DVD

DVH-335UB/XNRC581 2 3 4

C

D

F

A

B

E

5 6 7 8

(2)

(1) (2)

Tracking balance

TBAL coefficient (layer 0)TBAL coefficient (layer 1)TE normalization coefficient (layer 0)TE normalization coefficient (layer 1)Off track adjustment result

Focus Jump

When L0 layer: 2000 0000When L1 layer: 2100 0000

2 x 00 0000

2FFF 0000

(3),(4)

CRG +/-

It operates while the key is being pressed.

2B00 0000 : CRG+2C00 0000 : CRG-

3000 0000

(8)

Power_OFF

(8)

Power_OFF

(5)

Performed including the tracking close processing.

FBAL coefficient (layer 0)FBAL coefficient (layer 1)Focus gain coefficient (layer 0)Focus gain coefficient (layer 1)Tracking gain coefficient (layer 0)Tracking gain coefficient (layer 1)AS normalization adjustment value (layer 0)

RF level value

3FFF 0000

Tracking close state

)2()1(

(1)

Error rate measurement

Error rateFocus gain coefficient (layer 0)Focus gain coefficient (layer 1)Tracking gain coefficient (layer 0)Tracking gain coefficient (layer 1)AS normalization adjustment value (layer 0)

RF level value indication start

5000 0000

RF level is informed every 500msec.

RF level value indication end

)8()7(

To (2)

T.OPEN Power_OFF

)4(,)3()1(

Tracking close CRG +/-

It operates while the key is being pressed.

3B00 0000 : CRG+3C00 0000 : CRG-

3FFF 0000

a b

)2()1(

Tracking close state

Error rate measurement

FBAL coefficient (layer 0)FBAL coefficient (layer 1)Focus gain coefficient (layer 0)Focus gain coefficient (layer 1)Tracking gain coefficient (layer 0)Tracking gain coefficient (layer 1)

Playback speed switching

4000 0000

4 x 00 0000

(5)

Error rateFocus gain coefficient (layer 0)Focus gain coefficient (layer 1)Tracking gain coefficient (layer 0)Tracking gain coefficient (layer 1)AS normalization adjustment value (layer 0)

Focus Jump

DVDX1.3~1.6CAV

CDX4CLV:4x00 0000

When L0 layer: 4x00 0000When L1 layer: 4x00 0000

(8)

Error display

Power_OFF

Error occurrence

L0 layer DVD X 1.3~1.6CAV, CD X 4CLV :4000 0000L1 layer DVD X 1.3~1.6CAV :4100 0000

[Note] If an error occurs at Power_OFF, reset cannot be made. In such a case, it is necessary to turn the power off and start the test mode once again.

Error occurrence at Power_OFF

Error display

The number for designation of the track number shall be selected from the track numbers previously prepared.Switch to cyclic by (3). Fix by (4).For CD: Tracks 1, 4, 10, 11 and 32For DVD: Tracks 1, 4, 10, 11, 32, 64 and 100

Change the method for ID address designation.Designation of digit by command (1) and (2). UP/DOWN of numbers by command (3) and (4). Fix by command (5).

The higher 2 digits of the designated ID are the value showing the test state. The lower 6 digits show the ID.Example) If 300000 is desired to be designated as the ID, designated ID: 4A03 0000.

)8()7(

To (2)

T.OPEN Power_OFF

)4(,)3()6(

)3()4(-)1(

)5()5(

ID Search T.Jump+/-

4A00 0000Jump+ : 4B00 0000Jump- : 4C00 0000

ID designation

ID display

Track number designation

Track number indication

Search start Jump start

DVH-335UB/XNRC 595 6 7 8

C

D

F

A

B

E

1 2 3 4

EDC. Image of the test mode

[Note] Image is the same for both EDC1 and EDC2.

(1) (2)

EDC1/2 test mode

0000 0000

Layer 0 selection Layer 1 selection

0000 0000 0100 0000

1003 0000 1103 0000

(5)

[Note] The display is updated at 0.5 seconds interval until 0/1 layer is selected or Eject is effected.

(1)-(4)

ID designation

EDC1/2 start

Layer 0: 10** ****Layer 1: 11** ****[Note] ** **** is the ID designation value

Layer 0: 20** ****Layer 1: 21** ****[Note] ** **** is the present ID designation value

**** ****[Note] **** **** is the present ID designation value

Legend:… Key operation

… Operational state


[Note] Eject can be effected any time during the EDC test mode.

Eject

After completion of EJECT operation

EJECT operation

Test mode Eject

Image of the LD power on time mode.

LD power on time mode

0000 0000

CD LD power on time indication

DVD LD power on time indication

10** ****[Note] ** **** is the CD LD

power on time.

20** ****[Note] ** **** is the DVD LD

power on time.

(1) (2)CD LD power on

time setting

Setting time designation

30** ****[Note] ** **** is the setting time.

Setting time registration

DVD LD power on time setting

Setting time designation

40** ****[Note] ** **** is the setting time.

(5) (6)

(1)-(4) (1)-(4)

(5) (5)

(8)

10** ****[Note] ** **** is the CD LD

power on time.

Setting time registration

(8)

20** ****[Note] ** **** is the DVD LD

power on time.

[Note] If the power on time is 999999 hours or more, it is always reported as 999999 hours.[Note] If the power on time is “*E** ****”, the value may not be correct due to the life of the flash memory.

[Method of setting time designation]Designate the digit by command (1) and (2). UP/DOWN of numbers by command (3) and (4). Fix by command (5). Cancel by command (8).


… Operational state


Not for service use

DVH-335UB/XNRC601 2 3 4

C

D

F

A

B

E

5 6 7 8

The selection of the figure of each screen can be selected by "Key command for the test".

TEST MODE

1: LD ON2: ASMAX3: Skew Adjustment4: Error Rate5: CRG Move Outer6: Eject

Please Input Number

NODLNODLNODL

1: DVD Single Layer 1: Power OFF2: DVD Dual Layer3: CD4: CD-RW5: Return

rebmuNtupnIesaelPgninnuRwoNrebmuNtupnIesaelP

XAMSAXAMSAXAMSA

1: DVD Single Layer 1: Power OFF2: DVD Dual Layer3: CD4: CD-RW5: Return ASMAX Level : 000000


tnemtsujdAwekStnemtsujdAwekStnemtsujdAwekS

1: DVD Single Layer 1: Power OFF

5: Return RF Level : 000000


rennI-etaRrorrErennI-etaRrorrEetaRrorrEetaRrorrE

tnemerusaeMrennI:1reyaLelgniSDVD:1 1: Power OFF2: Outer Measurement

tnemerusaeMelddiM:3DC:3

nruteR:5nruteR:5 Error Rate : 000000

NtupnIesaelPgninnuRwoNrebmuNtupnIesaelPrebmuNtupnIesaelP umber

*1 : The position in which select was done is displayed.

Error Rate -CD

DVD InnerDVD OuterDVD MiddleCD CD

Now Running

retuOevoMGRCretuOevoMGRCretuOevoMGRC

1: DVD Single Layer 1: Power OFF2: DVD Dual Layer3: CD4: CD-RW5: Return


ERROR

1: Power OFF

Code : 00000000

Please Input Number

ERROR

Code : 00000000

Please Reset

1 select

2 select

3 select

4 select

select LD ONCompletion

selectASMAX

value set

value set selectRF Level

DVD select selectError Rate

set select

select

select

select

select

ASMAXLevel display

Error Ratedisplay

RF Leveldisplay

Update 500 msec.

*1

CD select

*1

*1

Search ID0x00100000

Search IDinner :

0x00040000outer :

Search CRGhome position

5 Return select

5 Return select

5 Return select

5 Return select

5 Return select

5 select

select select

CRG moves to the most outer

5 Return select

CRG MoveCompletion

0 00200000

Simple test mode

<Flow chart>

<Error>

<Error : Power OFF>

DVH-335UB/XNRC 615 6 7 8

C

D

F

A

B

E

1 2 3 4

7. DISASSEMBLY

2

1

2

3

4

Fig.1

Fig.2

- Removing the DVD Mechanism Module (Fig.1) DVD Mechanism Module

- Removing the Tuner Amp Unit (Fig.2)

1. Remove the Case.

Remove the screw.

Remove the screw.

Remove the two screws.

Straighten the tabs at three locationsindicated and then remove the TunerAmp Unit.

2

1

2

4

4

Disconnect the connector and then remove theDVD Mechanism Module.

Tuner Amp Unit

1 Release the three latches and then removethe Panel Assy.

Remove the four screws.

- Removing the Case (not shown)

Panel Assy

1 1

3

2

2

34

2

1

DVH-335UB/XNRC621 2 3 4

C

D

F

A

B

E

5 6 7 8

1

2

1

* Don’t recycle the sheet removed, and exchange it for a new sheet.

- Removing the Sheet (Fig.3, 4)

Disconnect the FFC from the Connector. (Fig.3)

The two seals is removed, and then removed the Sheet. (Fig.4)

The Sheet is put on two places.

- How to put the Sheet (Fig.5)

1

2 2

1

1

Connector FFC

Sheet

Fig.3

Fig.4

Fig.5

DVH-335UB/XNRC 635 6 7 8

C

D

F

A

B

E

1 2 3 4

Fig.6

Fig.7

Fig.8

Fig.9

- Disassembling the Panel Part (Fig.6, 7)

2. Press the upside hook and the bottom side hook of the button at the same time, and pull out the button.

1. Remove the arm while bending the rib of the panel upward.

- Assembling the Panel Part (Fig.8, 9, 10)

1. Attach the button from the front side of the panel.

2. Attach the spring to the arm as shown in the figure.

Hitch the spring to the groove.

The bended tip of the spring is set to this side.

DVH-335UB/XNRC641 2 3 4

C

D

F

A

B

E

5 6 7 8

Fig.10

3. Fit the spring in the groove at the position shown in the figure.

4. Fit the boss on the lower side of the arm in the lower hole of the panel, and then warp the rib on the panel in the direction shown in the figure and fit the boss of the arm in the panel.

Solder temp. : 360 ± 20 C

Note: Soldering of the part shown in the figure must be done after fixing the Tuner Amp Unit to the bottom chassis.

- About the temperature management of the soldering iron

DVH-335UB/XNRC 655 6 7 8

C

D

F

A

B

E

1 2 3 4

1.Have a specified part.

Handling OK

Handling NG

How to have it

DVH-335UB/XNRC661 2 3 4

C

D

F

A

B

E

5 6 7 8

Connector (relay FFC)Relay FFC

Fig. 1 Fig. 2

GND the brown line

4V to the gray line

Mecha Module_Bringing into the Clamp State with No Disc Loaded1. Remove the relay FFC from the connector on the module PCB side (Fig. 1). (Precaution) When it is difficult to apply 4V to the motor in procedure 2 below, remove the connector on the relay PCB side, then remove the FFC, and remove the solder of the CRG motor lead and apply voltage to the lead.2. Push the Disc detection arm while applying 4V to the CRG motor (Fig. 2) By this action, the mecha moves to the clamp state and the PU moves to the outer periphery.3. Stop the motor when the PU comes to the vicinity of the intermediate periphery. (Precaution) If the PU goes to the outer most periphery, it idles. It is not a problem, but please try not to let it idle as much as possible.

DVH-335UB/XNRC 675 6 7 8

C

D

F

A

B

E

1 2 3 4

T-case washer

Drive gear

Fig. 1

Fig. 2

b.Open-lock state

There is a space

There is no space

c.Clamp state with no disc loaded

A

CRG Mecha_Bringing into the Clamp State with No Disc Loaded1.Remove the T-case washer and then remove the drive gear. (Fig. 1)2.Lift the clamp arm assy until it is in the state shown in Fig. 2_b (open-lock state).3.Put your finger on the area A of Fig. 2_c and then slide it to the direction of the arrow (the direction of the playing state).4.Push down the clamp arm.(Precaution) When bringing the CRG mecha into the ejecting state again, install the drive gear after sliding the drive lever and bringing it to the ejecting state, in order to prevent the cog of the pinion in the drive gear from chipping at the time ofits installation.

a.Ejecting state

DVH-335UB/XNRC681 2 3 4

C

D

F

A

B

E

5 6 7 8

Connector (pick up FPC)

Connector(Relay FFC)

PCB clinch screw

Short-circuit

Fig.1Fig. 2

Fig.3

Pick up FPC

Relay FFC

Fig. 4

Solder on the lead

Relay PCB clinch screw

Hook A

Hook B

Fig. 5

Hook BFig. 6

OK NGFig. 7 Fig. 8

A

Removing the Module PCB1.Short-circuit two spots on the land of the pick up FPC. (Fig. 1)2.Remove the pick up FPC and the relay FFC from the connector. (Fig. 2)3.Temporarily attach the pick up FPC to the pick up rack. (Fig. 3)(in order to prevent the damage to the pick up FPC)4.Remove the two PCB clinch screws and then remove the module PCB. (Fig. 2)

Removing/Installing the Relay PCBRemoving)1.Remove the relay FFC from the connector (remove both sides so that the entire FFC will be removed). (Fig. 2)2.Remove the solder on the lead for the CRG motor. (Fig. 4)3.Remove the one relay PCB clinch screw. (Fig. 4)4.Slide the relay PCB to the direction of the arrow and then remove the relay PCB from the hook A and the hook B. (Fig. 4)5.Turn the relay PCB over and then remove the SPDL motor FFC from the connector.Installing)1.Check the mecha is in the ejecting state (disc-load suspended state).When it is not in the ejecting state, apply 4V to the lead (motor) and then bring it to the ejecting state (4V to the brown line and GND the gray line).2.Fit the SPDL motor FFC to the connector (back of the relay PCB).3.Hold the relay PCB so that it does not touch the SW knob as in Fig. 5.4.Insert it into the hook B as it is a little off to the clockwise direction.(Precaution) This is to prevent the SW knob from getting into the NG position as in Fig. 6.5.Push down the relay PCB lightly and then rotate it to the counterclockwise direction.It sets the relay PCB in the hook A and the positioning dowel. (Precaution) Pay attention so the SW knob will not get onto the PU rack. (Fig. 6)6.As in the Figures, while supporting the location A with your fingers, screw the relay PCB. (Fig. 7 / Fig. 8)7.Solder the lead for the CRG motor.8.Fit the relay FFC to the connector.

DVH-335UB/XNRC 695 6 7 8

C

D

F

A

B

E

1 2 3 4

Fig. 2a

Permanently hooked position Temporary hooked positionFig. 2b

A

Slide to the direction of inner peripheryFig. 1

Fig. 3

B

Fig.4

Regularly installed position Install avoiding the area with blue broken line (the connected metal plate part)

The spring is installed under the resin flange and inside the bended metal plate.

Outside holderBack end of the feed screw

Removing the PU Unit1.Hook the feed screw biasing spring on the temporary hook (Fig. 2b). Be careful not to get injured by the tip of the spring.2.Hold the PU at the location A in Fig. 1 and slide and scoot it to the direction of the inner periphery.3.As in Fig. 3, shift the back end of the feed screw to the side and then to above and remove it from the outside holder.4.Remove the tucking joint for the chassis at the location B and the PU unit by lifting them up without changing their position and then remove the PU unit.(Precaution) When installing the PU again, make sure to tuck the chassis in B and the PU unit (Fig. 4) first.Moreover, do not forget to permanently hook the feed screw biasing spring (Fig. 2a).Adjustments to the PU after its installation should be made according to the service manual.

Sending the PU to the outer periphery1.Bring to the clamp state with no disc loaded according to the “Mecha Module_Bringing into the Clamp State with No Disc Loaded” manual.(Precaution) The relay FFC must be removed for certainty in order to prevent the IC damage.2.Apply 1.5V to the CRG motor and then transfer the PU to the outer periphery.(Precaution) Do not forget to reinstall the relay FFC after sending the PU to the outer periphery and take the necessary measures.

[Installation NG]The chassis is not tucked between the PU case and the PU rack.

DVH-335UB/XNRC701 2 3 4

C

D

F

A

B

E

5 6 7 8

8. EACH SETTING AND ADJUSTMENT8.1 DVD ADJUSTMENT

1) PrecautionsThis product uses 5 V and 3.3 V as standard voltages.The electrical potential that is the reference for signals,is not GND, but VREF (approximately 2.2 V) and VHALF(approximately 1.65 V) .During product adjustments, if the reference voltage ismistakenly taken as GND, and a grounding contact ismade, not only would it be impossible to measure theaccurate electrical potential, but also the servo motorwould malfunction, resulting in the application of astrong impact on the pick up. The following precautionarymeasures should be strictly adhered to, in order toavoid such problems.The reference voltage and GND should not be confusedwhen using the minus probe of a measurement device.When an oscilloscope is being used special care shouldbe taken to make sure that the reference voltage is notconnected to the probe of ch1 (on the minus side),while the probe of ch2 (on the minus side), is connectedto GND. Further, since the body frame of most measurementdevices have the same electrical potential asthe minus side of the probe, the body frame of the measurement device should be set to floating ground.

If the reference voltage is connected to GND by mistake, turn the regulator OFF immediately, or turn the power OFF. Remove the filters and wires used for measurements only after the regulator has been turned OFF. After the power supply is turned on, regulator ON the following adjustment and measurement are promptly done. Whenever the product is in the test mode, the software will not take any protective action. For this reason, special care should be taken to make sure that no mechanical or electrical shock could be applied to the product when taking measurements in the test mode. Whenever the EJECT key is pressed to eject the disk, no other keys, other than the EJECT key, should be pressed until the disk eject action has been completed. Press the EJECT key only after the disk has stopped completely. If the product hangs up turn the power OFF immediately. Laser didoes may be damaged, if the volume switch for the laser power adjustment of the pick up unit, is turned.

DVH-335UB/XNRC 715 6 7 8

C

D

F

A

B

E

1 2 3 4

Disc used:TDV-582

Measurement reference: AGND3Measurement point: RF

Expansion

Oscilloscope

RF

AGND3

- SKEW adjustmentWhen one of the following replacements has taken place, SKEW adjustment for the pick up will be required.(1) Replacement of the pick up unit(2) Replacement of the spindle motor(3) Replacement of the carriage chassis(4) Replacement of the main shaft of the pick up unit

Measurement equipment and tools/jigs: Oscilloscope Driver for SKEW adjustment -> Driver Bond for fixing the SKEW -> GEM1033 Bond for resonance -> 1530 (1530 : produced by THREE BOND) Bond for locking the screw -> 1401M (1401M : produced by THREE BOND)

Connection drawingDVD core unit

Symptom in case the adjustment is not adequate: Worsening of the error rate 10 (Normally 10 or less.) Large RF jitter RF waveform distortion Tracking drawing/Unstable servo* Caution: Do not look into the laser light during adjustment.

-3

-4

RF

AGND3

DVH-335UB/XNRC721 2 3 4

C

D

F

A

B

E

5 6 7 8

TEST MODE


Please Input Number

7. Skew AdjustmentSelect “1: DVD Single Layer.”

Skew Adjustment

1: DVD Single Layer

5: Return

Please Input Number

There are two methods of making adjustment: a method of making adjustment through monitoring RF waves by the oscilloscope (method 1) and a method of making adjustment through checking the numerical value of the RF level by OSD (method 2).Adjusting procedure is shown below, but regarding how to start the test mode and the operating procedure, please refer to the clause on the service test mode.

Adjusting Procedure:1. Install the pickup(Refer to the removal of the pickup from the mecha unit.) When handling the pickup, refer to the precautions on how to handle the PU listed below.2. Method 1:Connect the oscilloscope according to the AGND3 standards with reference to the connection diagram so that the RF signals can be monitored.Method 2:The device does not need to be set. Proceed to the procedure 3.3. Turn ON the power of the product.4. Start the simplified FE test mode.(Regarding how to start the test mode and the operating procedure, refer to the clause on the service test mode.)5. Load the disc for adjustment (TDV582).6. TEST MODESelect “3: Skew Adjustment.”

8. Adjust the Skew using a driver while checking the RF value.Refer to the following pages concerning the locations to make SKEW adjustment. Method 1: Slightly turn the skew adjusting screw A while checking the RF wave level by the oscilloscope and make adjustment so the wave level would reach its maximum. Next, slightly turn the skew adjusting screw B so the wave level would reach its maximum. Slightly turn the skew adjusting screw A again so the wave level would reach its maximum. (Make adjustment in the order of A->B->A and in the end complete adjustment by turning each screw in the clockwise direction.)

Method 2:Slightly turn the skew adjusting screw A while checking the value of the RF level through the OSD display so the wave level would reach its maximum.Next, slightly turn the skew adjusting screw B so the level would reach its maximum. Slightly turn the skew adjusting screw A again so the level would reach its maximum. (Make adjustment in the order of A->B->A and in the end complete adjustment by turning each screw in the clockwise direction.)

DVH-335UB/XNRC 735 6 7 8

C

D

F

A

B

E

1 2 3 4

Skew Adjustment

1: Power OFF

RF Level : 000000

Please Input Number

Skew Adjustment

1: Power OFF

RF Level : 000000

Please Input Number

TEST MODE


Please Input Number

TEST MODE


Please Input Number

Switch arms

9. Skew Adjustment Select “1: Power OFF.”

10. TEST MODE Select “6: Eject.”

11. TEST MODE Select “5: CRG Move Outer.”

12. In order to produce the clamping state with no disc loaded, slightly move the disc detection arm in the counterclockwise direction while moving the switch arms outward.

DVH-335UB/XNRC741 2 3 4

C

D

F

A

B

E

5 6 7 8

CRG Move Outer

1: DVD Single Layer2: DVD Dual Layer3: CD4: CD-RW5: Return

Please Input Number

CRG Move Outer

1: Power OFF

Please Input Number

TEST MODE


Please Input Number

Disc Detection Arm

13. CRG Move Outer Select “1: DVD Single Layer.”

The pickup moves to the outer periphery. Apply the adhesive to fix the skew, the resonance adhesive and the screw lock. Refer to the next page regarding the locations of adhesive joining.

14. CRG Move Outer1: Power OFF

15. TEST MODE Select “6: Eject.”

DVH-335UB/XNRC 755 6 7 8

C

D

F

A

B

E

1 2 3 4

A

B

A

B

1

1 2 3

Locations to make SKEW adjustment

Locations to adhere the SKEW 1,2,3: BOND QUICK MENDER

23

DVH-335UB/XNRC761 2 3 4

C

D

F

A

B

E

5 6 7 8

adhesive

Bond for resonance 4:Three Bond 1530

4

5

6

4

5 6

Bond for locking the screw 5,6 : Three Bond 1401M

Bond for locking the screw

DVH-335UB/XNRC 775 6 7 8

C

D

F

A

B

E

1 2 3 4

Hologram (Beware of the static)Do not touch the optical part

RF level adjusting part

Do not touch the spring

Precautions on handling the PU*Precaution: Do not touch those shaded areas in the following figures.

.

DVH-335UB/XNRC781 2 3 4

C

D

F

A

B

E

5 6 7 8

8.2 PCL OUTPUT CONFIRMATION

- PCL outputIn the normal operation mode (with the detachable panel installed, the ACC switched ON, the standby modecancelled), shift the TESTIN IC601(Pin 86) terminal to H.The clock signal is output from the PCL terminal IC601(Pin 37).The frequency of the clock signal is 468 750 Hz that is one 32th of the fundamental frequency.The clock signal should be 468 750 Hz (- 10 Hz, + 15 Hz)If the clock signal out of the range, the X’tal (X601) should be replaced with new one.

DVH-335UB/XNRC 795 6 7 8

C

D

F

A

B

E

1 2 3 4

9. EXPLODED VIEWS AND PARTS LIST

9.1 PACKING

NOTES : Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List. The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.)

""

DVH-335UB/XNRC801 2 3 4

C

D

F

A

B

E

5 6 7 8

(1) PACKING SECTION PARTS LIST

(2) CONTRAST TABLEDVH-335UB/XNRC, DVH-335UB/XNRD, DVH-335UB/XNRI and DVH-3390UB/XNID are constructed the same except for the following:

Owner's Manual,Installation Manual

Mark No. Description Part No.

1 Cord Assy QDP3011

2 Polyethylene Bag QEG3001

3 Unit Box See Contrast table (2)

4 Contain Box See Contrast table (2)

5 Protector QHP3002

6 Protector QHP3003

7 Case Assy QXA3129

8 Card type Remote Control QXA3396

9 •••••

10 •••••

11 Handle CND3707

12 Screw Assy YEA5082

* 13 Polyethylene Bag CEG-127

14 Screw TRZ50P080FTC

15-1 Owner's Manual See Contrast table (2)



* 15-4 Warranty Card See Contrast table (2)

* 15-5 Service Network See Contrast table (2)


Mark No. Description DVH-335UB/XNRC DVH-335UB/XNRD DVH-335UB/XNRI DVH-3390UB/XNID 3 Unit Box QHG3110 QHG3111 QHG3112 QHG3113 4 Contain Box QHL3110 QHL3111 QHL3112 QHL3113 15-1 Owner's Manual QRB3154 QRB3154 QRB3154 QRB3161 15-2 Owner's Manual QRB3155 QRB3157 QRB3159 Not used 15-3 Owner's Manual QRB3156 QRB3158 QRB3160 Not used

* 15-4 Warranty Card Not used Not used Not used CRY1304* 15-5 Service Network Not used Not used Not used CRY1305

Part No. Language

QRB3154 English

QRB3155 Traditional Chinese

QRB3156 Korean

QRB3157 Spanish(Espanol)

QRB3158 Portuguese(B)

QRB3159 Arabic

QRB3160 Persian

QRB3161 English

DVH-335UB/XNRC 815 6 7 8

C

D

F

A

B

E

1 2 3 4

9.2 EXTERIOR (1)

B

DVH-335UB/XNRC821 2 3 4

C

D

F

A

B

E

5 6 7 8

(1) EXTERIOR (1) SECTION PARTS LIST



1 Case CNB3542

2 Holder CND3598

3 Cord Assy QDP3011

4 Cap CNS1472

5 Resistor RS1/2PMF102J

> 6 Fuse(10 A) CEK1136

7 Panel QNS3127

8 Detachable Assy See Contrast table (2)

9 Screw BPZ20P100FTC

10 Button(SRC, BAND, LEFT) CAI3203

11 Button(LIST, RPT, UP, DOWN) CAI3204

12 Spring CBH2210

13 Knob Unit CXE3692

14 Spring YBL5010

15 Button(RIGHT, -, 1-6) QAC3052

16 Button(DETACH) QAC3053

17 Cover QNS3125

18 Segment LCD(V1801) CAW2009

19 Holder QNC3027

20 Lighting Conductor QNV3022

21 Rubber QNV3023

22 Connector YNV5192

23 Grille Unit See Contrast table (2)

24 Door CAT2921

25 Card type Remote Control QXA3396

26 Battery Cover CYN1003


Mark No. Description DVH-335UB/XNRC DVH-335UB/XNRD DVH-335UB/XNRI DVH-3390UB/XNID 8 Detachable Assy QXA3382 QXA3382 QXA3382 QXA3383 23 Grille Unit QXA3387 QXA3387 QXA3387 QXA3388

DVH-335UB/XNRC 835 6 7 8

C

D

F

A

B

E

1 2 3 4

9.3 EXTERIOR (2)

A

601

A

B

B

A

ID

DVH-335UB/XNRC841 2 3 4

C

D

F

A

B

E

5 6 7 8

(1) EXTERIOR (2) SECTION PARTS LIST



1 Screw ASZ26P050FTC

2 Screw BMZ25P040FTB

3 Screw BSZ26P060FTC


5 Cable CDE8742

6 Earth Plate CNC8915

7 Holder CND4748

8 Insulator CNN2593

9 Insulator CNN2764

10 Sheet CNN3039

11 DVD Mechanism Module(LS1) CXK6820

12 Chassis QNA3020

13 Cushion QNM3035

14 Tuner Amp Unit See Contrast table (2)

15 Screw BPZ26P080FTC



18 Holder See Contrast table (2)

19 FM/AM Tuner Unit CWE2098

20 Holder CND4324

21 Heat Sink QNR3004

22 Spring QBH3001

23 Cover QNM3029

24 Panel QNS3180

25 Arm QNV3025

26 Button QNV3026

27 Sheet See Contrast table (2)


Mark No. Description DVH-335UB/XNRC DVH-335UB/XNRD DVH-335UB/XNRI DVH-3390UB/XNID 14 Tuner Amp Unit QWM3247 QWM3248 QWM3249 QWM3250 18 Holder CND4761 CND4762 CND4762 CND4761

27 Sheet Not used Not used Not used CNN2525

DVH-335UB/XNRC 855 6 7 8

C

D

F

A

B

E

1 2 3 4

9.4 DVD MECHANISM MODULE

A

C

D

D

FE

C

B

A

B

E

G

F

G

C

D

(A) : GEM1045

(B) : GEM1038

(C) : GEM1024

(C)

(C)

(A)

(A)

(A)

(A)

(C)

(A)

(A)

(C)

(C)

(C)

(C)

(B)

(C)

(C)

DVH-335UB/XNRC861 2 3 4

C

D

F

A

B

E

5 6 7 8

DVD MECHANISM MODULE SECTION PARTS LISTMark No. Description Part No.

1 Screw BMZ20P020FTC


3 Screw(M2 x 4) CBA1835

4 Washer CBF1038

5 Spring CBH2860

6 Spring CBH3010

7 Spring CBH3011

8 Spring CBH3012

9 Spring CBH3013

10 Spring CBH3014

11 Spring CBH3015

12 Spring CBH3016

13 Spring CBH3017

14 Spring CBH3018

15 Spring CBH3019

16 Spring CBH3020

17 Spring CBH3030

18 Plate Spring CBL1822

19 Cable CDE8631

20 Pickup Unit(Service) CXX2398

21 Bracket CND4553

22 Arm CND4555

23 Lever CND5398

24 Frame CND4557

25 Frame CND4558

26 Sheet CNN2280

27 Rack CNW1170

28 Guide CNW1171

29 Roller CNW1172

30 Arm CNW2157

31 Arm CNW1174

32 Roller CNW1175

33 Lever CNW1176

34 Arm CNW1177

35 Arm CNW1178

36 Gear CNW1180

37 Gear CNW1181

38 •••••

39 Gear CNW1183

40 Rack CNW1184

41 Gear CNW1185

42 Gear CNW1186

43 Gear CNW1187

44 Gear CNW1188

45 Clamper CNW1190

46 Arm CNW1191

47 Arm CNW1192

48 Holder CNW1193

49 Holder CNW1194

50 Holder CNW1195

51 Damper CNW1197

52 Damper CNW1198

* 53 Connect PCB CWX3618

54 •••••

55 •••••

56 Motor(SPINDLE)(M2) EXM1050

57 Screw Unit CXC8894

58 Chassis Unit CXE4562

59 Arm Assy CXC8896

60 Washer CBF1037

61 Washer CBF1038

62 Arm CND4554

63 Collar CNV6906

64 Roller CNW1196

65 Gear Unit CXC8893

66 Screw IMS20P030FTC

67 Motor Unit(LOAD/CRG)(M1) CXC4026

68 Screw JFZ20P025FTC

69 Screw JGZ17P022FTC

70 Washer YE15FTC

71 Screw IMS20P030FTC

72 DVD Core Unit YWX5019


DVH-335UB/XNRC 875 6 7 8

C

D

F

A

B

E

1 2 3 4

(A) : GEM1045

(B) : GEM1038

(C) : GEM1024

(A)

(C)

(C)

(A)

(A)(C)

(C)(C)

(C)

(C)

(A)

(A)

DVH-335UB/XNRC881 2 3 4

C

D

F

A

B

E

5 6 7 8

DVH-335UB/XNRC 895 6 7 8

C

D

F

A

B

E

RO

T0

ILM

PW

FLP

IL

RO

T1

LDE

T

RC

K

RE

SE

T

NMCN721

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

C54

6N

M

C54

5N

M

C50

11u

/10

C51

01u

/10

C50

51u

/10

C50

41u

/10

C51

11u

/10

C52

51u

/10

C52

61u

/10

C54

21u

/10

C51

21u

/10

C54

11u

/10

AG

IC66

1

15

AN

I

CC1IAS1ND1

1-1

1-2

1-1

1-2

2-1

2-2

CC2IAS2ND2

R2-

1

13

R2-

2

14

L3-1

15

L3-2

16

R3-

117 18

43V

4-2

44V

5-1

45V

5-2

46V

6-1

47V

6-2

48

1234571 72 73 74 75

76

77

78

79

80

81

82

83

84

85

86

87

88

89

90

91

92

93

94

95VREF

96AVCC

97

98

99

10

00

R52

310

0

00

R54

410

0

R52

210

0

R50

90

R50

5R

546

100

R6

10R6

10

RESET

RC

K

DG

NC

ILM

PW

NC

CSENS

MODEL2

RC

K

LDE

T

NC

FLP

ILM

RO

T0

MODEL1

KEYAD

RDS-HSLK

TUNPDO

SL

USBFLG

USBCTL

RDS-LOCK

MODEL0

NC

AVss

NC

NC

TESTIN

NC

RDS-DATA

EJECT

RO

T1

KEYD

NC

NC

AUXG

DGND

FLPILM

AUXL

AUXR

DPDT

USB5V

USGND

ILMCLR1

ILMCLR2

USGND

ILMGND

ROT1

SWVDD

D+

D-

ROT0

KYDT

EJECT

ILM+B

AUXV

CSENS

1 2 3 4

10. SCHEMATIC DIAGRAM10.1 TUNER AMP UNIT (GUIDE PAGE)

A

A-aA-a A-b

A-a A-b

A-bA-a

Large sizeSCH diagram

Guide page

Detailed page

Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST".

47u/

6.3

47u/

6.3

4.7u

/16

0.01

u/16

NC1MODE1/SPI_nSS

NC2nRESET

VCC

NC

3N

C4

NC

5N

C6

NC

7

VSSI2C_SCL/SPI_SIMO

I2C_SDA/SPI_SOMI

MODE0/SPI_CLK

NC8

NC

9N

C10

NC

11N

C12

NC

13

SL

CE2

CE1

TUNPCK

TUNPDO

LDETTUNPDI

IPPW

IP_2_SYS

SYS_2_IP

ASENBO

AMUTELS_2_SYS

SYS_2_LSSTANDBY

XRST

IRQPW

LSL

LSR

LSV

VDCONT5

IPL-

IPL+

IPR-

IPR+

DPDT

SW

VD

D

SYSMUTE

CE

1

AS

EN

S

LS_2_SYS

SYS_2_IP

ASENBO

CE

2

IPPW

ACCPW

TU

NP

DI

AMUTE

TU

NP

CK

AMPPW

STANDBY

CLR

2

CLR

1

RWCLK

RWBUSY

SYSPW

AN

TP

W

VS

T

VC

K

VD

T

V5C

ON

T

SYS_2_LS

VDCONT8

RW

CN

VS

S

RWBUSY

RWCLK

RWCNVSS

DPDT

RE

SE

T

RESET

AUXL

AUXR

VD

CO

NT

5

DS

EN

S

VD

CO

NT

8

VD

CO

NT

5

TUNR

KYDT

LSV

AUXG

VCRL

VCRG

VCRR

KYDT

SY

NC

IEC

AUXV

AUXVG

D+

D-

SY

NC

US

BC

TL

FLG

VD

CO

NT

5

TELIN

IP_2_SYS

AV

SC

L

AV

SD

A

VM

UT

E

AU

XV

G

CS

EN

S

EJE

CT

AU

XL

RO

T1

KY

DT

D-

CLR

1

DP

DT

DS

EN

S

AU

XR

AU

XV

BS

EN

S

ACCPW

CLR

2

DS

EN

S

AU

XG

D+

RO

T0

RDSLK

RDT

RCK

HSLK

TUNL

IRQPW

XRST

NMCN601

1

2

3

4

5

6

7

8

9

10

CN101CKS3844

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

CKS6288CN701

1234567891011121314151617181920

100u

/16

C47

2

CC

H14

86-A

C11

95

330u

/16

C11

54

330u

/16

C11

91

47u/

16C

521

47u/

16

C53

1

C45

3

C45

6

NM

C43

4

22u/

16C

534

22u/

16C

523

C47

1

0.01

u/16

C131

0.1u/10

C15

1

0.1u

/10

C15

2

1000

p/50

C15

3

1000

p/50

C12

2

0.1u

/10

C11

01

1u/6

.3C527 NM

C11

12

0.22

u/6.

3

C45

1

C53

2

0.1u

/16

C528 NM

C11

11

0.22

u/6.

3

C529 NM

C52

4

0.1u

/16

C530 NM

C45

4

1000

p/50

C52

20.

1u/1

6

C543 NM

C1144 CCG1236

C11

92N

M

C11

51N

M

CC

G12

36-A

-TC

1131

10u/

35

C11

96C

CG

1236

-

C11

52N

M

C11

94N

M

C11

62

NM

C11

93N

M

C11

86

NM

C544 NM

C47

4

NM

C11

10.

1u/1

0

C10

2

0.1u

/10

C43

3

NM

C10

1

0.1u

/16

C45

5

NM

C53

3

0.1u

/16

C11

98

1.0u

/35

C11

97

1.0u

/35

C1184

1.0u/35

C11

22

0.1u

/10

C11

32

0.1u

/10

C47

3

33p/

50

C60

4N

M

C65

1N

MC

652

NM

C11

02

1u/1

0

C607

100p/50

C11

99

NM

C1147 NMC1146 NM

C64

1

NM

C10

4

4.7u

/6.3

C11

20.

1u/1

0

C11

82

0.04

7u/1

6

C11

64

0.04

7u/1

6

C12

10.

1u/1

0

C605C606

C45

2

C432

NMC431

NM

C4751000p/50

CC

G12

36-A

-TC

1121

10u/

35

C11

63

220p

/50

C11

83

220p

/50

C107

NM

C10

6

C1161

3.3u/10

C1185

3.3u/10

C12

3

0.1u

/10

C11

81

0.01

u/16

C11

65

0.01

u/16

C10

5

NM

C11450.033u/50

C1141

0.033u/50

C58

1

1u/1

0

C72

6

220p

/50

C72

3

220p

/50

C11

53N

M C1143 CCG1236

C1142 1.0u/35

C705 220p/50

C71

2N

M

C701 220p/50C702 220p/50

C703 220p/50

C71

10.

1u/1

6

C704 220p/50

C457

NM

D52

1

S1G

-690

4G2P

D1192

RSX201L-30D1193

RSX201L-30

D1141

RB551V-30

D11

91

NM

D11

51N

M

D1142

RB551V-30

D52

2

S1G

-690

4G2P

D111 NM

D702 DZ2S068C

D715 NM

D713 DZ2S068C

D701 DZ2S068C

D712 DZ2S068C

D714 DZ2S068C

USGND

AGND

VIGND

USGND

AGND

RFGND

DGND

DGND

RFGND

ILMGNDDGND

AGND

LSDGND

ILMGND

DGND

USGND

DGND

DGND

DGND

VGND

AGND

USGND

AGND RFGND

ILMGND

LSD

GN

D

RFGND

RFGND

RFGND

DGND

LSDGND

RFGND

ILMGND

GNDDDC

GNDDDC

GNDDDC

DGND

RFGND

RFGND

GNDDDC

DGND

GNDDDC

DGND

RFGND

GNDDDC

DGND

DGND

RFGND

GNDDDC

GNDDDC

341S2162IC121

1

2

3

4

5

6789

10

11

12

13

14

15

16 17 18 19 20

IC1101

R5523N001B

EN1

GND2

FLG3

VIN4

5VOUT

IC1111

S-1200B33-M5

VIN1

VSS2

ON/OFF3

NC4

5VOUT

NMIC641

CS1

SK2

DI3

DO45

GND

6TEST

7NC

8VCC

HA12241FP

IC151

DIN11

ROUT2

DIN23

GND45

BUS-

6BUS+

7VCC

8STBY

IC112TC74VHC08FK

1A1

1B2

1Y3

2A4

5 2B6 2Y7 GND 8

3Y

93A

103B

114Y

124A

134B

14VCC

IC111TC74VHCT08AFKS1

1A1

1B2

1Y3

2A4

5 2B6 2Y7 GND 8

3Y

93A

103B

114Y

124A

134B

14VCC

IC122TC7MBL6126SFK

1OE1

A12

A23

A34

5 A46 4OE7 GND 8

3OE

9B4

10B3

11B2

12B1

132OE

14VCC

V

1

B

2

G3

L4

L5

R6

R7

L8

L9

V10

B11G

12

BD9013KVIC1103

OU

TH

2

1

BO

OT

2

2

CL2

3

N.C

.14

VC

CC

L25

N.C

.26

VC

C7

VC

CC

L18

N.C

.39

CL1

10

BO

OT

111

OU

TH

112

SW1

13

DGND1

14

OUTL115

N.C.416

VREG5A17

N.C.518

N.C.619

N.C.720

FB121

COMP122

SS123N.C.8

24

N.C

.9

25

EN

126

EN

227

N.C

.10

28N

.C.1

129

GN

D30

N.C

.12

31N

.C.1

332

RT

33S

YN

C34

N.C

.14

35N

.C.1

5

36

SS2

37

COMP238

FB2 39N.C.16

40EXTVCC

41N.C.17

42N.C.18

43VREG5

44N.C.19

45OUTL2

46DGND2

47SW2

48

IC601

BY

TE

6

CN

VS

S789

RE

SE

T10

XO

UT

11

VS

S1

12

XIN

13

VD

D1

14

NM

I1516171819202122232425

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70

JA471YKS5041

12

3

JA131CKS5271

1

2

3

4

5

6

7

8

9

10

11

L121

NM

12

3 4

L7011 2

34

L451 2.2u

L1153CTH1253-A

L1192CTH1253-A

CTH1358-A-T

L1131

NM

L452

10u

L641 NM

L602 NM

L472

22u

L101

CTF1389-A

L1152CTF1661-A

L115

1

CT

F16

61-A

L1141CTF1661

L151

CTF1528-A

L1108

CTH1253-A

L1191CTF1661-A

L471

1u

CTH1358-A-T

L1121

NM

P1131

CEK1286-A

P1121

CEK1286-A

P1191

CEK1344-A

LTC124EUBQ132

HA

T22

10R

JQ

1151

12345 6 7 8

HA

T22

10R

J

Q11

91

1 2 3 45678

Q112RN1910

1

2

3 4

5

6RN4982Q111

1

2

34

5

6

Q430NM

Q431NM

LSA1576UB(QRS)Q131

R143

4.7k

R14

2

22k

R74

1N

MR141

2.2k

R61

1

100k

R451 680

R630 1k

R13

8

47

R139

100

R1190 10kR1189

10k

R1141

10

R1142

10

R12

910

k

R455 680

R63

210

0k

R60

5

47k

R11

12

0

R11

11

NM

R11

01

100k

R128

390

R68

6N

M

R68

5N

M

R65

6N

M

R65

7N

M

R404

22k

R112

0

R501 1

R65

468

0

R454 680

R127

0

R126

0

R401

22k

R11

63 NM

R60

9

100k

R608

100k

R11

67

22k

R60

3

4.7k

R1161

2.2

R1188

2.2

R453 680

R502 1

R115 NM

R114 NM

R116

NM

R11

710

R123 0

R121 0

R65

31k

R102 1k

R111

0

R60

6

100k

R151

4.7k

R11

84

82k

R11

83 0R

1182

9.1k

R11

66

10k

R122 0

R628 NM

R135

1k

R436 0

R43

5

NM

R43

4

NM

R43

3

NM

R62

2N

M

R43

2

NM

R63

4

NM

R124

100k

R43

0

NM

R107

470

R108 470

R403

22k

R74

2N

M

R457 680

R152

1k

R524 22k

R402

22k

R106 470

R109

0

R65

21k

R136

100

R471 680

R607

100k

R101 470

R105 220

R103 470

R104 220

R641

47k

R624 220

R65

547

0

R11

85

NM

R63

347

k

R629 1k

R131

180

R11870

R1162

0

R625 NM

R643

NM

R64

2

NM

R11

74

470

R61

0

470

R140 1k

R13

4

22k

R651

NM

R503

NM

R132

180

R63

510

0k

R63

610

0k

R11

64

47k

R11

65

6.8k

R631 100k

R62

710

0k

R11

81

30k

R63

710

0k

R626 NM

R72

5N

M

R71

42.

2k

R71

52.

2k

R72

422

k

R72

322

k

R71

92.

2k

R71

60

R72

20

R71

32.

2k

R71

22.

2k

R71

82.

2k

R71

12.

2k

R71

70

R72

10

R72

00

R60

4 0

R43

1

NM

R437

0

R13

3

22k

R510 75

R11

7382

k

R1191

1k

R623 220

R12

510

0k

R74

3N

M

R11

720

R74

4

1k

R62

1N

M

R11

3

1k

R452 NM

R746

NM

R745

NM

R521 22k

R13

7

15

CS

N10

39-A

S74

11

2

IPR+

CLR

2

IRQPWR

TUNR

DP

DT

US

GN

D

STANBY

StoMS

AMUTE

LSVD8

BU3

OUTH1

OUTH2

VD8_2

FLG

VD8_1

TUNL

ACC5V

MANT

VCC

RFGND

MStoS

LSR

FLP

ILM

IPL+

IPL-

LSV

LSL

XRES

BS-

USBCTL

CS

EN

S

ACC3

RWBUSY

PWCLK

ILM

GN

D

DPDT1

DS

EN

S

RWCNVSS

KYDT1

ACCPW

AGND

ILM

+B

CLR

1

D-

VIGND

RO

T1

AU

XG

CPRST

SDA

T0T1

SCK

D+2

D-2

VDD5

VD8

AU

XL

DG

ND

TUN5V2

VM

UT

E

ABO

BS+

TUN3V

AU

XV

PCL

KY

DT

RO

T0

GND

D+

NC

ROMDATA

ROMLK

ROMCS

SW

VD

D

US

B5V

AU

XR

IPR-

VA703 EZJZ1V270RM

VA704 EZJZ1V270RM

TU3.3

BUP

ILM

+B

US

B5V

US

B5V

SYS+B

SYS+B

BUP

VD8

VD8

USB5V ILM+BSWVDD

VDD

VDD1

VD

5

VDD

VDD

SWVDD

VD3

VD5

VD5

VD5

VD

3

VDD

SYS+B

VDD3

SYS+B

VD5

VD3

USB5V

VDD

FLP

ILM

X601

U401

1AM_ANT

2RF_GND

3FM_ANT

4VCC

5SL

6CE2

7WC

8CE1

9CK

10DI

11LDET

12OSCGND

13ROM_VDD

14DO

15DGND

16COMP

17VDD_3.3

18RDS_CK

19RDS_DATA

20RDS_LOCK

21RDS_HSLK

22BEGND

23Lch

24Rch

P47

1

IMS

A-6

802-

01Y

900

Q40

1R

N19

03

1234 5 6

Q40

2R

N19

03

1234 5 6

C706 NM

X-2

026

FM/AM TUNER UNIT401 - 500

131 - 160IP-BUS

Ver2.0B

AGND

AMUTE

XRES

S MS5TX

VD

VGND

SCK

AGND

DGND

VD

VDD5

ROUT

LOUT

DGND

DGND

IRQPWR

D+

COMPOSIT

8.0V

VD

PGND

PGND

D-

IECOUT

STANBY

AGND

MS5 SRX

CPRST

DGND

SDA

5.1V

DGND

101 - 130LS1

5.1V

(D)

(D)

8.01V

(D)

(1/8W)

(1/8W)

(1/8W)

(D)

(F)

8.0V

(15uH)

MS VAUX V

AUX VGND

NC

SY

NC

VD

T

15.0MHz

IRQPW

NC

VC

K

AN

TP

W

DS

EN

S

PCL

NC

STANDBY

VD

D

NC

601 - 700NC

V5C

ON

T

RO

MC

K

NC

RX

RWCLK

VD

CO

NT

5

TX

SYS u-COM

VM

UT

E

VDCONT8

CE

2

NC

AV

SD

A

IPPW

DPDT

RX

2

CE

1

ILM

CLR

1

TXLS1

RWEMP

RWBUSY

TU

NP

CK

TU

NP

DI

NC

VS

S

KYDT

TELIN

RWCE

XRESET

ACCPW

MUTE

AV

SC

L

RO

MC

S

RXLS1

BS

EN

S

VS

T

AMPPW

AMUTE

ASENBO

ILM

CLR

2

RO

MD

AT

A

AS

EN

S

NC

SYSPW

ROM CORRECTION

AV SELECTOR501 - 600

1101 - 1200DD CON(15uH)

5.2V

Raychem 4A

SW

VD

D

3.0A

CW

E20

98

20p/5020p/50

3300

u/16

3.0A

(1/8W)

ILM

+B

RO

T0

AU

XG

D+

US

GN

D

DP

DT

AU

XR

D-

KY

DT

AU

XV

DS

EN

S

US

GN

D

SW

VD

D

ILM

GN

D

DG

ND

US

B5V

CLR

2

RO

T1

AU

XL

CLR

1

PEG753A

CSS1774

CTF1713

CC

G12

01

CCN1901

>

>

NM

NM

FM

/AM

TU

NE

R U

NIT

NM

> NM

NMB CN1821The > mark found on some component parts indicatesthe importance of the safety factor of the part.Therefore, when replacing, be sure to use parts ofidentical designation.

DVD/USB:+5.06 dBs

FM(30%): -25.50 dBsAM(30%): -25.37 dBs

AUX:+2.19 dBs

DS

EN

S

DVH-335UB/XNRC901 2 3 4

C

D

F

A

B

ETU

NP

DI

TU

NP

CK

CLR

2

CLR

1

RW

CN

VS

S

RE

SE

T

AV

SC

L

AV

SD

A

CS

EN

S

C527 NM

C528 NM

C529 NM

C530 NM

C543 NM

C544 NM

C60

4N

M

C605

C58

1

1u/1

0

C72

6

220p

/50

220p

/50

S1G

-690

4G2P

D52

2

S1G

-690

4G2P

LMGND

USG

D

ILMGND

89

RE

SE

T10

XO

UT

11

VS

S1

1264 65 66 67 68

R68

5N

M

R65

6N

M

R65

7N

M

R5

R65

468

0

R5

R65

547

0

R60

4 0

0 75

R74

3N

M

ILM

+B

US

B5V

SWVD

FLP

ILM

01

MS VAUX V

AUX VGND

MHz

NC

00COM

AV

SD

AIL

MC

LR1

TU

NP

CK

TU

NP

DI

AV

SC

L

ILM

CLR

2

20p/50

774

NM

5 6 7 8

A

A-b

47u/6.3

IN1_

L

IN2_

L

IN3_

L

IN4+

_L

IN4-

_L

Fro

nt_L

Rea

r_L

Vcc

Vre

f

GN

DD

AT

A

CLK

ST

B

Rea

r_R

Fro

nt_R

IN4-

_R

IN4+

_R

IN3_

R

IN2_

R

IN1_

R

FR+

FR-

FL-

RR-

RL+

TELIN

FL-

FL+

FR+

RR+

FL+

FR-

ANTPW

AMPPW

IEC

ILMPW

ACCPW

SWVDD

V5CONT

AV

SD

A

AV

SC

L

NA

VIR

NA

VIL

SYSMUTE

KEYAD

AUXG

AUXL

LSL

TUNL

TUNR

LSR

AUXR

AUXG

VC

K

VD

T

HSLK

SW

VD

D

TUNPDO

RO

T0

ILM

PW

FLP

IL

SYSPW

FLPIL

VMUTE

NAVIR

RO

T1

RR+

RR-

RL+

RL-

KEYAD

KEYD

AV

SIV

CR

LA

VS

IVC

RR

IPL+

IPR+

KEYD

AVSIVCRR

AVSIVCRL

IPR-

IPL-

VCRR

AV

SIV

CR

R

AV

SIV

CR

L

VC

RL

LDE

T

FLG

USBCTL

AMPPW

VC

RG

VC

RR

VS

T

VCRL

VM

UT

E

RC

K

SL

EJECT

VCRG

ASENS

BSENS

CSENS

NAVIL

RE

SE

T

LSV

RL-

RDT

RDSLK

NMCN721

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

NMCN1001

12

CN291CKS1238

1

2

3

4

CN821CKM1370-A

1

2

3

4

5

6

7

8

9

10

11

12

14

15

16

13

33u/

10

C26

1

NM

C16

1

NM

C10

72

330u/6.3C182

47u/16

C222

100u

/10

C10

14

CC

H14

86-A

C26

2

100u

/16

C10

52

NM

C35

1

C174

10u/

16

C23

4

1000

u/16

C10

54

220u/6.3C571

100u

/10

C10

21

NM

C10

32

10u/16

C221

100u

/16

C10

23

100u/6.3C572

33u/

10

C18

4

2.2u/50

C281

2.2u/50

C284

2.2u/50

C282

2.2u/50

C283

C28

8

1000

p/50

C55

0N

M

C50

9N

M

C54

6N

M

C772

NM

C77

3

NM

C50

3N

M

C553

NM

C77

1

NM

C10

02

0.22

u/6.

3

C50

8N

M

C54

5N

M

C580

NM

C223

0.1u/16

C10

010.

22u/

6.3

C50

11u

/10

C54

7N

M

C18

3

0.1u

/10

C50

6N

M

C171

NMC172

NM

C54

8N

M

C50

2N

M

C21

5

1u/1

0

C201

1u/10

C16

2

NM

C54

9N

M

C51

01u

/10

C202

1u/10

C50

7N

M

C50

51u

/10

C271

DCH1165-A

C26

3

0.1u

/16

C20

4

1u/1

0

C273

4.7u/16

C50

41u

/10

C272

4.7u/16

C212

1u/10

C217

1u/10

C51

11u

/10

C574 NM

C52

51u

/10

C573 NM

C255 0.47u/10

C256 0.47u/10

C251 0.47u/10

C252 0.47u/10

C32

1

NM

C206 1u/10

C52

61u

/10

C208 0.22u/16

C10

22

0.01

u/16

C10

11

2.2u

/10

C10

12N

M

C54

21u

/10

C10

31N

M

C576 NM

C575 NM

C10

71N

M

C33

1

NM

C10

42

1000

p/50

C10

73N

M

C33

2

NM

C10

510.

01u/

16

C10

53

0.01

u/16

C213 1u/10

C60

2

0.01

u/16

C801

0.1u/16

C10

61

0.1u

/16

C10

62

0.1u

/16

C75

1

0.1u

/16

C29

1

470p

/50

C671 NM

C672 NM

C673 NM

C661

0.1u/10

C51

21u

/10

C60

3

1u/1

0

C60

1

NM

C163

NM

C311

15p/50

C274

0.047u/16

C31

3

0.1u

/10

C164

NM

C233

100p/50

C243

100p/50

C253 0.47u/16

C257 0.47u/16

C258 0.47u/16

C254 0.47u/16

C29

3

NM

C2422.2u/25

C241

2.2u/25C232

2.2u/25

C35

3

NM

C2312.2u/25

C54

11u

/10

C35

2N

M

C29

2

NM

C10

41

NM

C57

71u

/10

C354

NM

C55

21u

/10

C57

81u

/10

C55

11u

/10

C371

NM

C37

2

NM

C16

5

NM

C374

NM

C373

NM

C31

2

10u/

6.3

C224 C225

NM

C27

5

10p/

50

C17

3

1000

p/50

C10

1310

u/10

C211 0.22u/16

C28

7

1000

p/50

C28

5

1000

p/50

C302

NM

C303

NM

C301

NM

C304

NM

C781

NM

C28

6

1000

p/50

D1021

CRG03D1011

NM

D82

21S

R15

4-40

0

D66

1

NM

D1012

NM

D1013

NM

D802

CRG03

D77

2

NM

D1052

CRG03 D82

11S

R15

4-40

0

D80

1

CR

G03

D771

NM

D781

MC2848-11

D753

NM

D10

51R

KZ

5.6K

G(B

2)

D752RKZ6.8KG(B2)

D751

HZU7R5(B3)

D10

71N

M

VGND

AGND

AGND

ILMGND

VGND

VGND

VIGND

VGND RFGND

RFGND

VIGND

ILMGND

VGND

VIGND

DGND

AGND

AGND

AGND

AGND

ILMGND

RFGND

RFGND

AGND

VGND

ND

VGND

AGND

VGND

AGND

GND

AGND

VIGND

RFGND

DGND

GND

GND

GND

GND

GND

GND

GND

GND

GND

AGND

DGND

GND

AGND

DGND

GND

GND

DGND

DGND

GND

GND

GNDDGND

GND

GND

NJM2885DL1-33IC1011

1IN

2G

ND

3O

UT

IC171

NM

Vout1

GND2

V+3

Vin4

5VGND

IC66

1

S-8

0835

CN

MC

-B8U

OU

T1

VD

D2

VS

S3

N.C

145

N.C

2

IC311

TC7SET08FUS1

INB1

INA2

GND3

OUTY4

5Vcc

IC1001

S-1200B33-M5

VIN1

VSS2

ON/OFF3

NC4

5VOUT

IC18

1N

JM25

61F

1

1

Vou

t2

Vsa

g3

Vin

4 5G

ND

6V

+

NM

IC371

A_OUT1

A-IN2

A+IN3

V-45

B+IN

6B-IN

7B_OUT

8V+

NJM4558MD

IC231

OUT11

IN-12

IN+13

GND45

IN+2

6IN-2

7OUT2

8VCC

NJM4558MD

IC241

OUT11

IN-12

IN+13

GND45

IN+2

6IN-2

7OUT2

8VCC

NM

IC351

OUT11

IN-12

IN+13

GND45

IN+2

6IN-2

7OUT2

8VCC

IC77

1

NM

1O

UT

2G

ND

13

GN

D2

4G

ND

35

VD

D6

IN

7G

ND

4

8G

ND

5

9G

ND

6

10D

IAG

IC20

1

PM

L014

B

1 2 3 4 5 6 7 8 9

1011121314151617181920

AN15887A

IC501

VCC1

1

BIAS1

2

GND13

L1-14

L1-25

R1-16

R1-27

L2-18

L2-29

VCC210

BIAS211GND2

12

R2-

1

13

R2-

2

14

L3-1

15

L3-2

16

R3-

117

R3-

218

L4-1

19

L4-2

20

R4-

121

R4-

222

L5-1

23L5

-224

R5-125

R5-2 26ROUT1

27LOUT1

28ROUT2

29LOUT2

30FB2

31VOUT2

32FB1

33VOUT1

34SDA

35SCL

36

V1-

137

V1-

238

V2-

139

V2-

240

V3-

141

V3-

242

V4-

143

V4-

244

V5-

145

V5-

246

V6-

1

47V

6-2

48

12345

BY

TE

6

CN

VS

S7

69 70 71 72 73 74 75

76

77

78

79

80

81

82

83

84

85

86

87

88

89

90

91

92

93

94

95VREF

96AVCC

97

98

99

100

NJM2388F84IC1021

1V

IN

2V

OU

T

3G

ND

4C

ON

TR

OL

IC271PA2030A

1

2

3

4

5

6

7

8

9

10

11

12

15

16

17

18

19

20

21

22

23

24

25

13

14

JA331CKS4124

2 3 1

JA321CKS4124-A

231

JA282

1

2

3

4

5

6

7

8

9

L181

10u

L821

CTH1280

L182

CT

F15

47-A

L781

CTF1379-A

L351

NM

L321

CTF1389-A

L601

10u

L1041

NM

L161

NM

L221

2.2u

L371NM

min

iSM

DC

075F

/24

P29

21

2

min

iSM

DC

075F

/24

P29

11

2

NMQ1032

LTC114EUBQ1062 LTC114EUB

Q1072

DTC623TUQ292

Q28

2

RN

1910

1 2 3456

Q28

1

RN

1910

1 2 3456

HN

1C01

FU

(YG

R)

Q75

11 2 3

456

NM

Q1074

1

2

3 4

5

6

RN4983

Q261

1

2

34

5

6

RN4983

Q291

1

2

34

5

6

RN4983

Q1052

1

2

3 4

5

6

Q10512SD1858(QR)

Q752NM

Q1073NM

2SA1579(R)Q321

NMQ162

LSA1576UB(QRS)Q1071

LSA1576UB(QRS)Q1061

LSA1576UB(QRS)Q1041

NMQ1031

NMQ161

LSA1576UB(QRS)Q781

R22

11k

2 14 365 87

R683

NM

R1063

10k

R263

220

R28

7

22k

R17

4

0

R10

51

22k

R28

6

22k

R10

52

2.2k

R352

NM

R35

1

NM

R35

3

NM

R753

10k

R68

6N

M

R291

1k

R57

410

0

R173

0

R175

NM

01 100

R164

NM

R757

NM

R75

6

NM

R354

NM

R52

310

0

R782

15k

R246

5.6kR240

5.6k

R679

470

R10

62

4.7k

R677

NM

R60

3

4.7k

R10

74

NM

02 100

R18

4

33k(

D)

R10

73

15k

R10

42

10k

R33

1

1kR

332

1k

R10

56

39

R37

2

NM

R358

NM

R572 220

R751

100k

R28

8

22k

R18

3R

182

R16

7

NM

R54

510

0

R22

610

0

R22

410

0

R507 100

R371

NM

R22

710

0

R206

NM

R251 1k

R541 NM

R223

NM

R75

2

47k

R57

310

0

R26

2

10k

R54

410

0

R23

9

10k

R16

1

NM

R234

22k

R236

22k

R22

510

0

R237 22k

R16

6

NM

R243

22k

R360

NM

R18

1

47k

R298

R542 NM

R242

22k

R241

22k

R185

68k (D)

R373

NM

R171

NM

R10

54 39

R172

NM

R374 NM

R356

NM

R245

22k

R16

2

NM

R508 100

R504

NM

R375

NM

R52

210

0

R37

6

NM

R771

NM

R355

NM

R165

NM

R571 220

R676

R201

0

R1061

NM

R671 R672

R35

9

NM

R50

90

R50

5

0

R54

610

0

R295

R23

8

12k

R24

4

12k

R23

3

12k

R680 47k

R66

147

0k

R601

100k

R1071820

R211

0R212

0

R202

0

R54

310

0

R314

0

R321

NM

R312

620

R503

NM

R32

3

10k

R32

2

100k

R10

53

39R

1055

39

R1021

1k

R300

R299

R297

R296

R294

R302

R301

R315

120

R506

75

R31

3

47k

R684 100k

R26

1

10k

R303

R283

820

R304

R311

0

R357

NM

R284

820

R10

64

100k

R10

22

47k

R10

75

NM

R602

100k

R678NM

R681

100k

R674R673

R682

10k

R16

3

NM

R675

R292

R293

R282

820

R10

41

2.2k

R281

820

R28

5

22k

R7814.7k

R75

5

4.7k

R75

4

47k

R1076

NM

R10

31

NM

R10

32

NM

R10

43

22k

R235

22k

R10

72

47k

VIN

RESET

VOUT

VGNDIN

VGNDOUT

OPT3

MUT

OPT1

RR-

BSEN3

OPTG

KEYD

TP601

FL-

BU1

GND2

BU2

GND1

OPT2

BREM

RR+

ASEN

ILM+

AANT

BSEN1

FR-

SYSB

RL+

BSEN2

RL-

ACC

FLP

ILM

FR+

CS

EN

S

FL+

KEYAD

VGND

TP300

TP299

TP298

TP297

TP296

TP295

TP294

TP293

TP292

TP

291

TESTIN

RC

K

VM

UT

E

TELM

TEST2

VDD5V

FA

NG

DGND3

VDD1

VDD2

FA

NB

SWVDD1V5

VDD3

VA

292

NM

VA

321

EZ

JZ1V

270R

M

VA

291

EZ

JZ1V

270R

M

VA

322

EZ

JZ1V

800A

M

BUP

SYS+B

ILM+B

VIDEO5

SYS+B

TU3.3

BUP

BUP

D

VD5

SYS+B

SYS+B

SYS+B

VDD

VD

D

SYS+B

VD

D1

VDD3

VDD1

SYS+B

VD5

VD5

VD5

FLPILM

SWVDD

NM

VR

161 1

3

2

22u/10C181

B.U

AANT

ASENS&BSENS

251 - 280AMP

751 - 800

CONNECTOR

3300

u/16

GND

FL+

(104

)

RR-

TELM

5.FL+

POWER

RL+

801 - 1000

FR+

TELM

FL-

RL-

SENS

3.FL-

1.TAB

RR+

ACCBREM

FR-

VGND

MUTE

OPT-OUTOPT

OPT

311 - 330

(BLACK)

8.4V

VDD 5VREG

POWER SUPPLY

0.75A

SYS+B1001 - 1100

8.4V

1A

ILM+B

(1/4

W)

SWVDDVIDEO5V

(1/4W)

VCR VGND

VIDEO OUT ISO +0dB

6dB

75ohm DRIVER +6dBAMP

VCR V

AV

SO

UT

L

AV

SO

UT

R

VGND(OUT)

VIDEO OUT

VIDEO IN

VGND(IN)

RC

FL

FR

RL

RR

NA

VIG

R

NA

VIG

L

RR

FR

201 - 230E-VOL MAESTRO2

REMOTE

331 - 350

WIRED

INPUT

FL

RL

NC

ILM

PW

NC

CSENS

MODEL2

RC

K

LDE

T

NC

FLP

ILM

RO

T0

MODEL1

KEYAD

RDS-HSLK

VM

UT

E

TUNPDO

SL

USBFLG

USBCTL

RDS-LOCK

MODEL0

NC

AVss

NC

NC

TESTIN

NC

NC

RDS-DATA

EJECT

RO

T1

KEYD

NC

RESET

NAVI MIXING351 - 400

161 - 200VIDEO OUT

VCR IN231 - 250

RCA281 - 310

FLPILM

AANT

FAN

SW

VD

D

NC

7.FR-

9.FR+

8.PW.GND1

20.VCC3/4

11.FRIN

12.FLIN

21.RL+

15.RRIN

23.RL-

25.B.REMOTE

24.PW.GND4

4.STBY

18.PW.GND3

14.RLIN

10.SVR

6.VCC1/2

16.ACGND

2.PW.GND2

22.MUTE

17.RR+

13.S-GND

19.RR-

3933

AUXG

DGND

FLPILM

AUXL

AUXR

701 - 750KEYBOARD UNIT

DPDT

USB5V

USGND

ILMCLR1

ILMCLR2

USGND

ILMGND

ROT1

SWVDD

D+

D-

ROT0

KYDT

EJECT

ILM+B

AUXV

CSENS

RL

RR

-

AoG

VoG

VCRG / -

VCRR / -

VCRL / -

A, B : CKB1095-AC, D : CKB1093-A

Vo

0

NM

NM

NM

NM

NM

NM

0

NM

0

ST

BY

601~700 SYS u-COM

701~750 KEYBOARD UNIT

161~200 VIDEO OUT

131~160 IP-BUS

201~230 E-VOL MAESTRO2

281~310 RCA

REFERENCE AREA MAP

1101~1200 DD CON

101~130 LS1

501~600 AV SELECTOR

1001~1100 POWER SUPPLY

351~400 NAVI MIXING

751~800 SENS A.ANT TELM

801~1000 POWER CONNECTOR

231~250 VCR IN

251~280 AMP

401~500 FM/AM TUNER UNIT

311~330 OPT

331~350 WIRED REMOTE INPUT

47k

NM

A,B / C,D

NM

: The power supply is shown with the marked box.

NM

NMNMNM

R673

10k 10k 0A, B

NM

NM

only A, B

NM

NM

NM

NM

NM

NM

14.2V

5V

5V

3V

3V

A TUNER AMP UNIT

Symbol indicates a resistor.No differentiation is made between chip resistors anddiscrete resistors.

NOTE :

Symbol indicates a capacitor.No differentiation is made between chip capacitors anddiscrete capacitors. NM : No Mount

R295 R303R298

C, D NM NMNM

*

*

*

*

A : DVH-335UB/XNRCB : DVH-3390UB/XNIDC : DVH-335UB/XNRDD : DVH-335UB/XNRI

R676NM

NM

NM

NM

47k

47k

47kR674 R675

BA

DC

47k

47k

47k47k47k

**

600uH

VCRIN:+2.28 dBs (A,B)

FM(30%): -25.51 dBsAM(30%): -25.38 dBs

AUX:+2.14 dBsDVD/USB:+5.01 dBs

VCRIN: -4.87 dBs (A,B)

FM(30%): -7.13 dBsAM(30%): -7.01 dBs


VCRIN: +9.65 dBs (A,B)

FM(30%): -7.93 dBsAM(30%): -7.84 dBs



FM(30%):+18.90 dBsAM(30%):+19.03 dBs



DVH-335UB/XNRC 915 6 7 8

C

D

F

A

B

E

TU

NR

LSR

KE

YA

D

KE

YD

DC

H11

65-A

C204

1u/10

C25

50

47u/

10

C25

10.

47u/

10

C25

20.

47u/

10

C20

61u

/10

C20

80.

22u/

16

C25

30.

47u/

16

C25

70

47u/

16

C25

40.

47u/

16

C275

0p/50

8990919211 12 13

R68

3

NM

R

R

R20

6

NM

R68

1

100k

RR

FR

NC

KE

YA

D

KE

YD

NC

11.F

RIN

12.F

LIN

10.S

VR

13.S

-GN

D

1 2 3 4

A-a

A-b

A-b

47u/

6.3

FR

+

FR

-

FL-

FL+

AM

PP

W

IEC

AVSDA

AVSCL

NAVIR

NAVIL

AU

XR

AU

XG

ROT0

ILMPW

VM

UT

E

NA

VIR

ROT1

AVSIVCRLAVSIVCRR

IPR

+

AV

SIV

CR

R

IPR

-

VC

RR

AVSIVCRR

AVSIVCRL

VCRL

VCRG

VCRR

VC

RL

SL

EJE

CT

VC

RG

CS

EN

S

NA

VIL

LSV

CN

291

CK

S12

381 2 3 4

NM

C161

330u

/6.3

C18

2

NM

C351

C17

4

10u/16

C234

220u

/6.3

C57

1

100u

/6.3

C57

2

33u/10

C184

2.2u

/50

C28

1

2.2u

/50

C28

4

2.2u

/50

C28

2

2.2u

/50

C28

3

C288

1000p/50

C550NM

C509NM

C546NM

C503NM

C55

3

NM

C508NM

C58

0

NM

C5011u/10

C547NM

C183

0.1u/10

C506NM

C17

1

NM

C17

2

NM

C548NM

C502NM

C20

1

1u/1

0

C162

NM

C549NM

C20

2

1u/1

0

C507NM

C5051u/10

C27

1

C5041u/10

C5111u/10

C57

4N

M

C5251u/10

C57

3N

M

C321

NM

C5261u/10

C5421u/10

C57

6N

M

C57

5N

M C602

0.01u/16

C291

470p/50

C5121u/10

C603

1u/10

C601

NM

C16

3

NM

C31

1

15p/

50

C313

0.1u/10

C16

4

NM

C23

3

100p

/50

C24

3

100p

/50

C293

NM

C24

22.

2u/2

5

C24

1

2.2u

/25

C23

2

2.2u

/25

C353

NM

C23

12.

2u/2

5

C5411u/10

C352NM

C292

NM

C5771u/10

C35

4

NM

C5521u/10

C5781u/10

C5511u/10

C37

1

NM

C372

NM

C165

NM

C37

4

NM

C37

3

NM

C312

10u/6.3

C173

1000p/50

C287

1000p/50

C285

1000p/50

C30

2

NM

C30

3

NM

C30

1

NM

C30

4

NM

C286

1000p/50

VG

ND

AG

ND

AG

ND

VG

ND

VG

ND

VIG

ND

VG

ND

RF

GN

D

VIG

NDV

IGN

D

AG

ND

AG

ND

AG

ND

RF

GN

D

AG

ND

VG

ND

VG

ND

AG

ND

VG

ND

AG

ND

AG

ND

GN

D

GN

D

GN

D

DG

ND

DG

ND

IC17

1

NMV

out

1

GN

D2

V+

3V

in4 5

VG

ND

IC31

1

TC

7SE

T08

FU

S1

INB

1

INA

2

GN

D3

OU

TY

45V

cc

IC181NJM2561F1

1

Vout2

Vsag3

Vin4

5GND

6V+

NM

IC37

1 A_O

UT

1

A-I

N2

A+I

N3

V-

45

B+I

N

6B

-IN

7B

_OU

T

8V

+

NJM

4558

MD

IC23

1 OU

T1

1

IN-1

2

IN+1

3

GN

D4

5IN

+2

6IN

-2

7O

UT

2

8V

CC

NJM

4558

MD

IC24

1 OU

T1

1

IN-1

2

IN+1

3

GN

D4

5IN

+2

6IN

-2

7O

UT

2

8V

CC

NM

IC35

1 OU

T1

1

IN-1

2

IN+1

3

GN

D4

5IN

+2

6IN

-2

7O

UT

2

8V

CC

AN

1588

7A

IC50

1

C1 S1

D1

2 C2 S2

D2

R2-1R2-2

14

L3-115

L3-216

R3-117

R3-218

L4-119

L4-220

R4-121

R4-222

L5-1 23L5-2

24

R5-

125

R5-

226

RO

UT

127

LOU

T1

28R

OU

T2

29LO

UT

230

FB

231

VO

UT

232

FB

133

VO

UT

134

SD

A

35S

CL

36

V1-137

V1-238V2-1

39V2-2

40V3-1

41V3-2

42V4-1

43V4-2

44V5-1

45V5-2

46 V6-1

47V6-2

1

2

3

4

939495V

RE

F96

AV

CC

979899100

IC27

1P

A20

30A

1 2 3 4 5 6 7 8 9

10

JA32

1C

KS

4124

-A2 3 1 JA

282

1 2 3 4 5 6 7 8 9

L181

10u L182

CTF1547-A

L351 NM

L321

CT

F13

89-A

L601

10u

L161

NM

L371 NM

miniSMDC075F/24

P29212

miniSMDC075F/24

P29112

DT

C62

3TU

Q29

2

Q282

RN1910

1

2

34

5

6Q281

RN1910

1

2

34

5

6

RN

4983

Q29

1

1234 5 6

2SA

1579

(R)

Q32

1

NM

Q16

2N

MQ

161

R287

22k

R174

0

R286

22k

R35

2

NM

R351

NM R353

NMR

291

1k

R574100

R17

3

0

R17

5

NM

R16

4

NM

R35

4

NM

R523100

R24

6

5.6k

R24

0

5.6k

R184

33k(D)

R372

NM

R35

8

NM

R57

222

0

R288

22k

R183R182

R167

NM

R545100

226100

224100

R50

710

0

R37

1

NM

R25

11k

R54

1N

M

R573100

R544100

R239

10k

R161

NM

R23

4

22k

R23

6

22k

R23

722

kR166

NM

R24

3

22k

R36

0

NM

R181

47k

R29

8

R54

2N

M

R24

2

22k

R24

1

22k

R18

5

68k

(D)

R37

3

NM

R17

1

NM

R17

2

NM

R37

4N

M

R35

6

NM

R24

5

22k

R162

NM

R50

810

0

R50

4

NM

R37

5

NM

R522100

R376

NM

R35

5

NM

R16

5

NM

R57

122

0

R20

1

0

R359

NM

R5090

R505

0

R546100

R29

5

R238

12k

R244

12k

R233

12k

R60

1

100k

R20

2

0

R543100

R31

4

0

R32

1

NM

R31

2

620

R323

10k

R322

100k

R30

0

R29

9

R29

7

R29

6

R29

4

R30

2

R30

1

R31

5

120

R50

6

75

R313

47k

R30

3

R28

3

820

R30

4

R31

1

0

R35

7

NM

R28

4

820

R60

2

100k

R163

NM

R29

2

R29

3

R28

2

820

R28

1

820

R285

22k

R23

5

22k

VIN

VO

UT

VG

ND

IN

VG

ND

OU

T

OP

T3

OP

T1

OP

TGOP

T2

TP

300

TP

299

TP

298

TP

297

TP

296

TP

295

TP

294

TP

293

TP

292

TP291

VD

D5V

VA292

NM

VA321EZJZ1V270RM

VA291

EZJZ1V270RM

VA322

EZJZ1V800AM

BU

P

VD

5

SY

S+B

SY

S+B

VDD

SY

S+B

VDD1

SY

S+B

VD

5

VD

5

VD

5

NMVR161

1 3

2

22u/

10C

181

5.F

L+

3.F

L-

1.T

AB

OP

T-O

UT

OP

T

OP

T

311

- 33

0

(BLA

CK

)

VC

R V

GN

D

VID

EO

OU

T IS

O +

0dB

6dB

75oh

m D

RIV

ER

+6d

BA

MP

VC

R V

AVSOUT L

AVSOUT R

VG

ND

(OU

T)

VID

EO

OU

T

VID

EO

IN

VG

ND

(IN

)

RC

FL

FR

RL

RR

NAVIG R

NAVIG L

201

- 23

0E

-VO

L M

AE

ST

RO

2

ILMPW

CS

EN

S

ROT0

SL

AV

ss

NC

NC

EJE

CTROT1

NA

VI M

IXIN

G35

1 -

400

161

- 20

0V

IDE

O O

UT

VC

R IN

231

- 25

0

RC

A28

1 -

310

7.F

R-

9.F

R+

8.P

W.G

ND

1

4.S

TB

Y

6.V

CC

1/2

2.P

W.G

ND

2

39 33

RL

RR-

AoG

VoG VC

RG

/ -

VC

RR

/ -

VC

RL

/ -

A, B

: C

KB

1095

-AC

, D :

CK

B10

93-A

Vo

0 NM

NM

NM

NM

NMNM0

NM0

STBY

A,B

/ C

,D

10k

10k

0A

, B

NM

only

A, B

NM

NM

NM

AT

UN

ER

AM

P U

NIT

R29

5R

303

R29

8

C, D

NM

NM

NM

*

* * *

A :

DV

H-3

35U

B/X

NR

CB

: D

VH

-339

0UB

/XN

IDC

: D

VH

-335

UB

/XN

RD

D :

DV

H-3

35U

B/X

NR

I

VC

RIN

:+2.

28 d

Bs

(A,B

)

FM

(30%

): -7

.93

dBs

AM

(30%

): -7

.84

dBs

AU

X:+

8.87

dB

sD

VD

/US

B:+

8.77

dB

sV

CR

IN:+

8.60

dB

s (A

,B)

DVH-335UB/XNRC921 2 3 4

C

D

F

A

B

E

FR

-

FL+

AU

XG

C20

1

1u/1

0C

202

VR

EF

96A

VC

C9798

4 5 6

R20

1

0R

202

5.F

L+

IL

NC

NC

EJE

CT

4.S

TB

Y

6.V

CC

1/2

5 6 7 8

A-a

A-b

A-b

IN1_L

IN2_L

IN3_L

IN4+_L

IN4-_L

Front_L

Rear_L

Vcc

Vref

GNDDATA

CLK

STB

Rear_R

Front_R

IN4-_R

IN4+_R

IN3_R

IN2_R

IN1_R

FR

+

RR

-

RL+

TE

LIN

FL-

FL+

FR

+

RR

+

FR

-

AN

TP

W

AM

PP

W

ILM

PW

AC

CP

W

SW

VD

D

V5C

ON

T

SY

SM

UT

E

KE

YA

D

AU

XG

AU

XL

LSL

TU

NL

TU

NR

LSR

AU

XR

VCK

VDT

HS

LK

TU

NP

DO

SY

SP

W

FLP

IL

RR

+

RR

-

RL+

RL-

KE

YA

D

KE

YD

IPL+

IPR

+

KE

YD

AV

SIV

CR

R

AV

SIV

CR

L

IPR

-

IPL-

LDET

FLG

US

BC

TL

AM

PP

W

VST

SL

AS

EN

S

BS

EN

S

CS

EN

S

RESET

RL-

RD

T

RD

SLK

NM

CN

721

NM

CN

1001

1

2C

N82

1C

KM

1370

-A

1 2 3 4 5 6 7 8 9 10 11 12 14 15 1613

33u/10

C261

NM C1072

47u/

16

C22

2

100u/10 C1014

CCH1486-A

C262

100u/16 C1052

1000u/16

C1054

100u/10

C1021

NM C1032

10u/

16

C22

1

100u/16

C1023

C77

2

NM

C773

NM

C771

NM

C1002

0.22u/6.3

C22

3

0.1u

/16

C10010.22u/6.3

C215

1u/10

1u/1

0

C27

1

DC

H11

65-A

C263

0.1u/16

C204

1u/10

C27

3

4.7u

/16

C27

2

4.7u

/16

C21

2

1u/1

0

C21

7

1u/1

0

C25

50.

47u/

10

C25

60.

47u/

10

C25

10.

47u/

10

C25

20.

47u/

10

C20

61u

/10

C20

80.

22u/

16

C1022

0.01u/16

C1011

2.2u/10C1012NM

C1031NM

C1071NM

C331

NM

C1042

1000p/50

C1073NM

C332

NM

C10510.01u/16

C1053

0.01u/16

C21

31u

/10

C80

1

0.1u

/16

C1061

0.1u/16

C1062

0.1u/16

C751

0.1u/16

C67

1N

M

C67

2N

M

C67

3N

M

C66

1

0.1u

/10

C27

4

0.04

7u/1

6

C25

30.

47u/

16

C25

70.

47u/

16

C25

80.

47u/

16

C25

40.

47u/

16

C1041

NM

C22

4C

225

NM

C275

10p/50

C101310u/10

C21

10.

22u/

16

C78

1

NM

D10

21

CR

G03

D10

11

NM

D8221SR154-400

D661

NM

D10

12

NM

D10

13 NM

D80

2

CR

G03

D772

NM

D10

52

CR

G03

D8211SR154-400

D801

CRG03

D77

1

NM

D78

1

MC

2848

-11

D75

3

NM

D1051RKZ5.6KG(B2)

D75

2R

KZ

6.8K

G(B

2)

D75

1

HZ

U7R

5(B

3)

D1071NM

ILM

GN

D

RF

GN

D

ILM

GN

D

VG

ND

DG

ND

AG

ND

ILM

GN

D

RF

GN

D

VIG

ND

RF

GN

D

DG

ND

GN

D

GN

D

GN

D

GN

D

GN

D

GN

D

AG

ND

DG

ND

GN

D

AG

ND

GN

D

GN

D

DG

ND

GN

D GN

D

GN

DD

GN

D

GN

D

GN

D

NJM

2885

DL1

-33

IC10

11

1IN

2GND

3OUT

IC661

S-80835CNMC-B8U

OUT1

VDD2

VSS3

N.C14

5N.C2

IC10

01

S-1

200B

33-M

5

VIN

1

VS

S2

ON

/OF

F3

NC

45V

OU

T

IC771

NM

1OUT

2GND1

3GND2

4GND3

5VDD

6IN

7GND4

8GND5

9GND6

10DIAG

IC201

PML014B

1

2

3

4

5

6

7

8

9

1011

12

13

14

15

16

17

18

19

20

72

73

74

75

7677787980818283848586878889909192939495

NJM

2388

F84

IC10

21

1VIN

2VOUT

3GND

4CONTROL

7 8 9

10 11 12 15 16 17 18 19 20 21 22 23 24 2513 14

JA33

1C

KS

4124

231

L821

CT

H12

80

L781

CT

F13

79-A

L104

1

NM

L221

2.2u

NM

Q10

32

LTC

114E

UB

Q10

62LT

C11

4EU

BQ

1072

HN1C01FU(YGR)

Q7511

2

3 4

5

6

NM

Q10

74

1234 5 6

RN

4983

Q26

1

1234 5 6

RN

4983

Q10

52

1234 5 6

Q10

512S

D18

58(Q

R)

Q75

2 NM

Q10

73N

M

LSA

1576

UB

(QR

S)

Q10

71LS

A15

76U

B(Q

RS

)Q

1061

LSA

1576

UB

(QR

S)

Q10

41N

MQ

1031

LSA

1576

UB

(QR

S)

Q78

1

R2211k

2

1

4

3 6

5

8

7

R68

3

NM

R10

63

10k

R26

3

220

R1051

22k

R1052

2.2k

R75

3

10k

R75

7

NM

R756

NM

R78

2

15k

R67

9

470

R1062

4.7k

R67

7

NM

R1074

NM

R1073

15k

R1042

10k

R331

1kR332

1k

R1056

39

R75

1

100k

R226100

R224100

R227100

R20

6

NM

R25

11k

R22

3

NM

R752

47k

R262

10k

R225100

R1054

39

R77

1

NM

R67

6

R10

61

NM

R67

1R

672

R68

047

k

R661470k

R10

7182

0

R21

1

0R

212 00

R1053

39R1055

39

R10

21

1k

R68

410

0k

R261

10k

R1064

100k

R1022

47k

R1075

NM

R67

8N

M

R68

1

100k

R67

4R

673

R68

2

10k

R67

5

R1041

2.2k

R78

14.

7k

R755

4.7k

R754

47k

R10

76

NM

R1031

NM

R1032

NM

R1043

22k

R1072

47k

RE

SE

T

MU

T

RR

-

BS

EN

3

KE

YD

TP

601

FL-BU

1

GN

D2

BU

2

GN

D1

BR

EM

RR

+

AS

EN

ILM

+

AA

NT

BS

EN

1

FR

-

SY

SB

RL+

BS

EN

2

RL-

AC

C

FR

+

FL+

KE

YA

D

VG

ND

TE

ST

IN

RCK

TE

LM

TE

ST

2

FANG

DG

ND

3

VD

D1

VD

D2

FANB

SW

VD

D1

V5

VD

D3

SY

S+B

ILM

+B

VID

EO

5

SY

S+B

TU

3.3

BU

P

BU

P

SY

S+B

VD

D

VD

D3

VD

D1

FLP

ILM

SW

VD

D

B.U

AA

NT

AS

EN

S&

BS

EN

S

251

- 28

0A

MP

751

- 80

0

CO

NN

EC

TO

R

3300u/16

GN

D

FL+

(104)

RR

-

TE

LM

PO

WE

R

RL+

801

- 10

00

FR

+

TE

LM

FL-

RL-

SE

NS

RR

+

AC

CB

RE

M

FR

-

VG

ND

MU

TE

8.4V

VD

D 5

VR

EG

PO

WE

R S

UP

PLY

0.75

ASY

S+B

1001

- 1

100

8.4V

1A

ILM

+B

(1/4W)

SW

VD

DV

IDE

O5V

(1/4

W)

RR

FR

RE

MO

TE

331

- 35

0

WIR

ED

INP

UT

FL

RL

NC

NC

CS

EN

S

MO

DE

L2

LDET

NC

MO

DE

L1

KE

YA

D

RD

S-H

SLK

TU

NP

DO

SL

US

BF

LG

US

BC

TL

RD

S-L

OC

K

MO

DE

L0NC

AV

ss NC

TE

ST

IN

RD

S-D

AT

A

KE

YD

NC

RE

SE

T

FLP

ILM

AA

NT

FA

N

NC

7.F

R-

9.F

R+

8.P

W.G

ND

1

20.V

CC

3/4

11.F

RIN

12.F

LIN

21.R

L+

15.R

RIN

23.R

L-

25.B

.RE

MO

TE

24.P

W.G

ND

4

18.P

W.G

ND

3

14.R

LIN

10.S

VR

16.A

CG

ND

22.M

UT

E

17.R

R+

13.S

-GN

D

19.R

R-

AU

XG

DG

ND

FLP

ILM

AU

XL

AU

XR

701

- 75

0K

EY

BO

AR

D U

NIT

DP

DT

US

B5V

US

GN

D

ILM

CLR

1

ILM

CLR

2

US

GN

D

ILM

GN

D

RO

T1

SW

VD

D

D+

D-

RO

T0

KY

DT

EJE

CT

ILM

+B

AU

XV

CS

EN

S

601~

700

SY

S u

-CO

M

701~

750

KE

YB

OA

RD

UN

IT

161~

200

VID

EO

OU

T

131~

160

IP-B

US

201~

230

E-V

OL

MA

ES

TR

O2

281~

310

RC

A

RE

FE

RE

NC

E A

RE

A M

AP

1101

~120

0 D

D C

ON

101~

130

LS

1

501~

600

AV

SE

LEC

TO

R

1001

~110

0 P

OW

ER

SU

PP

LY

351~

400

NA

VI M

IXIN

G

751~

800

SE

NS

A.A

NT

TE

LM

801~

1000

PO

WE

R C

ON

NE

CT

OR

231~

250

VC

R IN

251~

280

AM

P

401~

500

FM

/AM

TU

NE

R U

NIT

311~

330

OP

T

331~

350

WIR

ED

RE

MO

TE

INP

UT

47k

NM

NM

: The

pow

er s

uppl

y is

sho

wn

with

the

mar

ked

box.

NM

NM

NM

NM

R67

3 NM

NM

NM

NM

14.2

V

5V

5V

3V

3V

Sym

bol i

ndic

ates

a r

esis

tor.

No

diffe

rent

iatio

n is

mad

e b

etw

een

chip

res

isto

rs a

nddi

scre

te r

esis

tors

.

NO

TE

: Sym

bol i

ndic

ates

a c

apac

itor.

No

diffe

rent

iatio

n is

mad

e b

etw

een

chip

cap

acito

rs a

nddi

scre

te c

apac

itors

.N

M :

No

Mou

nt

R67

6N

M

NM

NM

NM

47k

47k

47k

R67

4R

675

BA DC47

k

47k

47k

47k

47k

**

600u

H

FM

(30%

): -2

5.51

dB

sA

M(3

0%):

-25.

38 d

Bs

AU

X:+

2.14

dB

sD

VD

/US

B:+

5.01

dB

sV

CR

IN: -

4.87

dB

s (A

,B)

FM

(30%

): -7

.13

dBs

AM

(30%

): -7

.01

dBs

AU

X:+

9.72

dB

sD

VD

/US

B:+

9.63

dB

sV

CR

IN: +

9.65

dB

s (A

,B)

FM

(30%

):+1

8.90

dB

sA

M(3

0%):

+19.

03 d

Bs

AU

X:+

36.3

7 dB

sD

VD

/US

B:+

36.1

3 dB

sV

CR

IN:+

35.7

8 dB

s (A

,B)

DVH-335UB/XNRC 935 6 7 8

C

D

F

A

B

E

NC

1M

OD

E1/

SP

I_nS

SN

C8

NC9NC10NC11NC12NC13

LS_2

_SY

SD

-

TE

LIN

C122

1u/10

C121

341S

2162

IC12

1

115

16

17

18

19

20

5A

46

4OE

7G

ND

83O

E

9B

4

10B

3

IC60

1

34 35 36 3789909192

NM

34

R1

R12

7

0

100k

R62

422

0R

625

NM

R62

6N

M

R1

PC

L

NC

Ver

20B

PC

L

NC

601

- 70

0N

C

KE

YA

D

TE

LIN

KE

YD

NC

RX

LS1

PE

G75

3AN

M

1 2 3 4

A-b

A-a

A-a

A-b

NC

2nR

ES

ET

VC

C

NC3NC4NC5NC6NC7

VS

SI2

C_S

CL/

SP

I_S

IMO

I2C

_SD

A/S

PI_

SO

MI

MO

DE

0/S

PI_

CLK

AM

UT

ELS

_2_S

YS

SY

S_2

_LS

ST

AN

DB

Y

XR

ST

IRQ

PW

LSL

LSR

LSV

VD

CO

NT

5

DP

DT

SWVDD

ASENS

SY

S_2

_IP

CLR2

CLR1

ROT0

ILMPW

FLPIL

RW

CLK

RW

BU

SY

SY

S_2

_LS

RWCNVSS

RESET

ROT1

AU

XL

AU

XR

DSENS

VDCONT8

VDCONT5

LSV

AU

XG

VC

RL

VC

RG

VC

RR

KY

DT

SYNC

IEC

AU

XV

AU

XV

G

D+SYNC

USBCTLFLGVDCONT5

IP_2

_SY

S

BSENS

CN

101

CK

S38

44

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30

CCH1486-A

C1195

330u/16 C1154

330u/16 C1191

47u/16 C521 47u/16

C531

22u/16 C534

22u/16 C523

C1101

1u/6.3

C550NM

C509NM

C546NM

C503NM

C508NM

C545NM

C52

7N

M

C5011u/10

C547NM

C1112

0.22u/6.3

C548NM

C502NM

C532

0.1u/16

C52

8N

M

C1111

0.22u/6.3

C52

9N

M

C524

0.1u/16

C549NM

C5101u/10

C53

0N

M

C5051u/10

C5041u/10

C5111u/10

C5220.1u/16

C54

3N

M

C5251u/10

C11

44C

CG

1236

C1192NM

C1151NM

CCG1236-A-TC1131

10u/35

C1196CCG1236-

C1152NM

C1194NM

C1162

NM

C1193NM

C1186

NM

C5261u/10

C54

4N

M

C1110.1u/10

C102

0.1u/10

C101

0.1u/16

C5421u/10

C533

0.1u/16

C1198

1.0u/35

C1197

1.0u/35

C11

84

1.0u

/35

C1122

0.1u/10 C1132

0.1u/10

C604NM

C1102

1u/10

C60

7

100p

/50C1199

NM

C5121u/10

C11

47N

MC

1146

NM

C104

4.7u/6.3

C1120.1u/10

C1182

0.047u/16

C1164

0.047u/16

0.1u/10

C60

5C

606

C5411u/10

CCG1236-A-TC1121

10u/35

C1163

220p/50

C1183

220p/50

C10

7

NM

C106

C11

61

3.3u

/10

C11

85

3.3u

/10

C123

0.1u/10

C1181

0.01u/16

C1165

0.01u/16

C105

NM

C11

450.

033u

/50

C11

41

0.03

3u/5

0

C581

1u/10

C1153NM

C11

43C

CG

1236

C11

421.

0u/3

5

D521

S1G-6904G2P

D11

92

RS

X20

1L-3

0D

1193

RS

X20

1L-3

0

D11

41

RB

551V

-30

D1191

NM

D1151NM

D11

42

RB

551V

-30

D522

S1G-6904G2P

D11

1N

M AG

ND

VIG

ND

US

GN

D

AG

ND

DG

ND

AG

ND

AG

ND

LSD

GN

D

DG

ND

DG

ND

VG

ND

LSDGND

GN

DD

DC

GN

DD

DC

GN

DD

DC

DG

ND

GN

DD

DC

GN

DD

DC

GN

DD

DC

DG

ND

DG

ND

GN

DD

DC

GN

DD

DC

2345

6

7

8

9

10

11 12 13 14

IC11

01

R55

23N

001B

EN

1

GN

D2

FLG

3V

IN45

VO

UT

IC11

11

S-1

200B

33-M

5

VIN

1

VS

S2

ON

/OF

F3

NC

45V

OU

T

IC11

2T

C74

VH

C08

FK

1A1

1B2

1Y3

2A4 5

2B6

2Y7

GN

D8

3Y

93A

103B

114Y

124A

134B

14V

CC

IC11

1T

C74

VH

CT

08A

FK

S1

1A1

1B2

1Y3

2A4 5

2B6

2Y7

GN

D8

3Y

93A

103B

114Y

124A

134B

14V

CC

IC12

2T

C7M

BL6

126S

FK

1OE

1

A1

2

A2

3

A3

411

B2

12B

1

132O

E

14V

CC

AN

1588

7A

IC50

1

VC

C1

1

BIA

S1

2

GN

D1

3

L1-1

4

L1-2

5

R1-

16

R1-

27

L2-1

8

L2-2

9

VC

C2

10

BIA

S2

11G

ND

212

R2-1

13

R2-2

14

L3-115

L3-216

R3-117

R3-218

L4-119

L4-220

R4-121

R4222

V2139

V2-240

V3-141

V3-242

V4-143

V4-244

V5-145

V5-246 V6-1

47V6-2

48

BD

9013

KV

IC11

03

OUTH2

1

BOOT2

2

CL23

N.C.14

VCCCL25

N.C.26

VCC7

VCCCL18

N.C.39

CL110

BOOT111OUTH1

12

SW

1

13

DG

ND

1

14

OU

TL1

15

N.C

.416

VR

EG

5A17

N.C

.518

N.C

.619

N.C

.720

FB

121

CO

MP

122

SS

123

N.C

.824

N.C.9

25

EN126

EN2 27N.C.10

28N.C.11

29GND

30N.C.12

31N.C.13

32RT

33SYNC

34N.C.14

35N.C.15

36

SS

2

37

CO

MP

238

FB

239

N.C

.16

40E

XT

VC

C41

N.C

.17

42N

.C.1

843

VR

EG

544

N.C

.19

45O

UT

L246

DG

ND

2

47S

W2

48

1

2

3

4

5

BYTE6

CNVSS7

8

9

RESET10

XOUT11

VSS112

XIN13

VDD114

NMI15

16

17

18

19

20

21

22

23

24

25

26 27 28 29 30 31 32 33939495

VR

EF

96A

VC

C97989910

0

L121

12

L115

3C

TH

1253

-A

L119

2C

TH

1253

-A

CT

H13

58-A

-T

L113

1

NM

L602

NM

L101

CT

F13

89-A

L115

2C

TF

1661

-A

L1151

CTF1661-A

L114

1C

TF

1661

L110

8

CT

H12

53-A

L119

1C

TF

1661

-A

CT

H13

58-A

-T

L112

1

NM

P11

31

CE

K12

86-A

P11

21

CE

K12

86-A

P11

91

CE

K13

44-A

HAT2210RJQ1151

1

2

3

45

6

7

8

HAT2210RJ

Q1191

1

2

3

45

6

7

8Q

112

RN

1910

1 2 3456

RN

4982

Q11

1

1234 5 6

R611

100k

R11

9010

kR

1189

10k

R11

41

10

R11

42 10

2910k

R605

47k

R1112

0

R1111

NM

R1101

100k

R12

8

390

R11

2

0

R50

110

0

R523100

R12

6

0

R1163

NM

R609

100k

R60

8

100k

R1167

22k

R603

4.7k

R11

61

2.2

R11

88

2.2

R50

210

0

R11

5N

M

R11

4N

M

R11

6

NM

R11710

R12

30

R12

10

R10

21k

R11

1

0

R606

100k

R1184

82k

R1183

0R1182

9.1k

R1166

10k

R12

20

R54

1N

R622NM

R12

4

R10

7

470

R544100

R10

847

0

R54

2N

R52

422

k

R10

647

0

R10

9 0

R60

7

100k

R10

147

0

R10

522

0

R50

4

NM

R10

347

0

R522100

R10

422

0

R1185

NM

R5090

R505

0

R546100

R11

870

R11

62 0

R60

1

100k

R1174

470

R610

470

R50

3

NM

R635100k

R1164

47k

R1165

6.8k

R1181

30k

R60

2

100k

R604

0

R51

075

R117382k

R11

91

1k

R62

322

0

25100k

R11720

R621NM

R113

1k

R52

122

k

IRQ

PW

R

ST

AN

BY

Sto

MS

AM

UT

E

LSV

D8BU

3

OU

TH

1

OU

TH

2

VD

8_2

FLG

VD

8_1

AC

C5V

MS

toS LS

R LSV

LSL

XR

ES

US

BC

TL

AC

C3

AG

ND

VIG

ND

CP

RS

T

SD

A

T0

T1

SC

K

D+2

D-2

VD

D5

VD

8

VD

D5V

BU

P

SY

S+B

VD

8

VD

8

VD5

VD

3

VD

5

VD

5

VD

5

VD3

VD

D

SY

S+B

VD

D3

VD

5

VD

3

US

B5V

X60

1

AG

ND

AM

UT

E

XR

ES

SM

S5T

XVD

VG

ND

SC

K

AG

ND

DG

ND

VD

VD

D5

RO

UT

LOU

T

DG

ND

DG

ND

IRQ

PW

R

D+

CO

MP

OS

IT

8.0V

VD

PG

ND

PG

ND

D-

IEC

OU

T

ST

AN

BY

AG

ND

MS

5S

RX

CP

RS

T

DG

ND

SD

A

5.1V

DG

ND

101

- 13

0LS

1

5.1V

(D)

(D)

8.01

V

(D)

(1/8

W)

(1/8

W)

(1/8

W)

(D)

(F)

8.0V

(15u

H)

MS

VA

UX

V

AU

X V

GN

D

NC

ILMPW

SYNC

15.0

MH

z

CS

EN

S

DSENS

NC

FLPILM

NC

ROT0

RX

RW

CLK

TX

SY

S u

-CO

M

NC

DP

DT

RX2

SL

ILMCLR1

TX

LS1

AV

ss

NC

RW

BU

SY

KY

DT

NC

EJE

CTROT1

BSENS

ILMCLR2

ASENS

NC

AV

SE

LEC

TO

R50

1 -

600

1101

- 1

200

DD

CO

N(1

5uH

)

5.2V

Ray

chem

4A

SWVDD

3.0A

20p/

5020

p/50

3300u/16

3.0A

(1/8

W)

CS

S17

74

CCG1201

CC

N19

01

>

>

>N

M

DV

D/U

SB

:+5.

06 d

Bs

DVH-335UB/XNRC941 2 3 4

C

D

F

A

B

E

34567

VD

CO

NT

5

DP

DT

SY

S_2

_IP

KY

DT

26 27 28

6

7

8

9

10

IC12

2T

C7M

BL6

126S

FK

1OE

114

C

R

28 29 30V

RE

F96

AV

CC

9798C

TF

1389

-A39

0

R12

6

R12

10

R12

20

CP

RS

T

SD

A

SC

KV

DD

3

VD

3S

CK

SD

A

DG

ND

IL

D

FL

TX DP

DT

ILM

NC

KY

DT

NC

EJE

CT

B

ILM

A

S

5 6 7 8

A-a

A-b

A-b

A-a

47u/6.3

47u/6.3

4.7u/16

0.01u/16

NC

1M

OD

E1/

SP

I_nS

SN

C2

nRE

SE

T

VC

C

NCNCNCNCNC

VS

SI2

C_S

CL/

SP

I_S

IMO

I2C

_SD

A/S

PI_

SO

MI

MO

DE

0/S

PI_

CLK

NC

8

NC9NC10NC11NC12NC13

SL

CE

2

CE

1

TU

NP

CK

TU

NP

DO

LDE

TT

UN

PD

I

IPP

W

IP_2

_SY

S

SY

S_2

_IP

AS

EN

BO

IPL-

IPL+

IPR

-

IPR

+

SY

SM

UT

E

CE1

LS_2

_SY

S

AS

EN

BO

CE2

IPP

W

AC

CP

W

TUNPDI

AM

UT

E

TUNPCK

AM

PP

W

ST

AN

DB

Y

RW

CLK

RW

BU

SY

SY

SP

W

ANTPW

VST

VCK

VDT

V5CONT

SY

S_2

_LS

VD

CO

NT

8

RW

BU

SY

RW

CLK

RW

CN

VS

S

DP

DT

RE

SE

T

VDCONT5

TU

NR

KY

DT

LDET

D+

D-

TE

LIN

AVSCL

AVSDA

VMUTE

RCK

AUXVG

CSENS

EJECT

AUXL

ROT1

KYDT

D-

CLR1

DPDT

DSENS

AUXR

AUXV

RESET

AC

CP

W

CLR2

DSENS

AUXG

D+

ROT0

RD

SLK

RD

T

RC

K

HS

LK

TU

NL

IRQ

PW

XR

ST

NM

CN

601

12345678910

NM

CN

721

12345678910111213141516171819202122

29 30

CK

S62

88C

N70

1

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

100u/16

C472

C453

C456

NM

C434

C471

0.01u/16C

131

0.1u

/10

C151

0.1u/10C152

1000p/50C153

1000p/50

C122

0.1u/10

C451

C454

1000p/50

C474

NM

C433

NM

C455

NM

C473

33p/50

C651NMC652NM

C67

1

C67

2C6

C66

0.1u

C641

NM

C1210.1u/10

C452

C43

2

NM

C43

1

NM

C47

510

00p/

50

C123

0.1u/10

C726

220p/50

C723

220p/50

C70

522

0p/5

0

C712NM C

701

220p

/50

C70

222

0p/5

0

C70

322

0p/5

0

C7110.1u/16

C70

422

0p/5

0

C45

7

NM

D661

NM

D70

2D

Z2S

068C

D71

5N

M

D71

3D

Z2S

068C

D70

1D

Z2S

068C

D71

2D

Z2S

068C

D71

4D

Z2S

068C

US

GN

D

RF

GN

D

DG

ND

RF

GN

D

ILM

GN

DD

GN

D

LSD

GN

D

ILM

GN

D

DG

ND

US

GN

D

DG

ND

AG

ND

US

GN

D

AG

ND

RF

GN

D

ILM

GN

D

RF

GN

D

RF

GN

D

RF

GN

D

DG

ND

LSD

GN

D

RF

GN

D

ILM

GN

D

RF

GN

DRF

GN

D

DG

ND

DG

ND

RF

GN

D

DG

ND

RF

GN

D

341S

2162

IC12

1

1234511 12 13 14 15

16

17

18

19

20

IC661

S-80835CNMC-B8U

OUT1

VDD2

VSS3

N.C14

5N.C2

NM

IC64

1

CS

1

SK

2

DI

3

DO

45

GN

D

6T

ES

T

7N

C

8V

CC

HA

1224

1FP

IC15

1 DIN

11

RO

UT

2

DIN

23

GN

D4

5B

US

-

6B

US

+

7V

CC

8S

TB

Y

A1

2

A2

3

A3

4 5A

46

4OE

7G

ND

83O

E

9B

4

10B

3

11B

2

12B

1

132O

E

VC

C

IC60

1

31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50

51

52

53

54

55

56

57

58

59

60

61

62

63

64

65

66

67

68

69

70

71

72

73

74

75

7677787980818283848586878889909192939495

JA47

1Y

KS

5041

12

3

JA13

1C

KS

5271

1 2 3 4 5 6 7 8 9 10 11

L121 NM

12 3

4

L701

12 3

4

L451

2.2u L4

52

10u

L641

NM

L472

22u

L151

CT

F15

28-A

L471 1u

LTC

124E

UB

Q13

2

Q43

0N

MQ

431

NM

LSA

1576

UB

(QR

S)

Q13

1

R14

3

4.7k

R142

22k

R741NM

R14

1

2.2k

R45

168

0

R63

01k

R138

47

R13

9

100

R12910k

R45

568

0

R632100k

R686NM

R685NM

R656NM

R657NM

R40

4

22k

R654680

R45

468

0

R12

7

00

R40

1

22k

R45

368

0

R12

30

R6531k

R15

1

4.7k

R62

8N

M

R13

5

1k

R43

60

R435

NM

R434

NM

R433

NM

R432

NM

R634

NM

R12

4

100k

R430

NM

R40

3

22k

R742NM

R45

768

0

R15

2

1k

R40

2

22k

R6521k

R13

6

100

R47

168

0

R64

1

47k

R62

422

0

R655470

R63347k

R67

R62

91k

R13

1

180

R62

5N

M

R6

R661470k

R64

3

NM

R642

NM

R14

01k

R134

22k

R65

1

NM

R13

2

180

R636100k

R6

R63

110

0k

R627100k

R637100k

R62

6N

M

R725NM

R7142.2k

R7152.2k

R72422k

R72322k

R7192.2k

R7160

R7220

R7132.2k

R7122.2k

R7182.2k

R7112.2k

R7170

R7210

R7200

R67

R431

NM

R43

7

0

R133

22k

R67

5

R62

322

0

R125100k

R743NM

R744

1k

R45

2N

M

R74

6

NM

R74

5

NM

R137

15

CSN1039-A

S74112

IPR

+

CLR2

RE

SE

T

TU

NR

DPDT

USGND

TP

601

TU

NL

MA

NT

VC

C

RF

GN

D

FLPILM

IPL+

IPL-

BS

-

CSENS

RW

BU

SY

PW

CLK

ILMGND

DP

DT

1

DSENS

RW

CN

VS

S

KY

DT

1

AC

CP

W

ILM+B

CLR1

D-

ROT1

AUXG

AUXL

TE

ST

I

RCK

DGND

TU

N5V

2

VMUTE

AB

O

BS

+

TU

N3V

AUXV

PC

L

KYDT

DG

ND

3

ROT0

GN

D

D+

NC

RO

MD

AT

A

RO

MLK

RO

MC

S

SWVDD

USB5V

AUXR

IPR

-

VA

703

EZ

JZ1V

270R

M

VA

704

EZ

JZ1V

270R

M

TU

3.3

ILM+B

USB5V

USB5V

SY

S+B

BU

P

US

B5V

ILM

+BS

WV

DD

VD

D

VD

D1

VD

D

VD

D

SW

VD

D

SY

S+B

VD

D

FLPILM

U40

1

1A

M_A

NT

2R

F_G

ND

3F

M_A

NT

4V

CC

5S

L6

CE

27

WC

8C

E1

9C

K10

DI

11LD

ET

12O

SC

GN

D13

RO

M_V

DD

14D

O15

DG

ND

16C

OM

P17

VD

D_3

.318

RD

S_C

K19

RD

S_D

AT

A20

RD

S_L

OC

K21

RD

S_H

SLK

22B

EG

ND

23Lc

h24

Rch

P471

IMSA-6802-01Y900

Q401RN1903

1

2

34

5

6

Q402RN1903

1

2

34

5

6

C70

6N

M

X-2026

FM

/AM

TU

NE

R U

NIT

401

- 50

0

131

- 16

0IP

-BU

S

Ver

2.0B

DG

ND

CP

RS

T

NC

VDT

IRQ

PW

NC

VCK

NC

ANTPW

CS

EN

S

MO

DE

L2

PC

L

RCK

LDET

NC

ST

AN

DB

Y

VDD

601

- 70

0N

C

V5CONT

ROMCK

NC

MO

DE

L1

KE

YA

D

RW

CLK

VDCONT5

SY

S u

-CO

M

RD

S-H

SLK

VMUTE

VD

CO

NT

8

CE2

TU

NP

DO

AVSDA

IPP

W

SL

US

BF

LG

US

BC

TL

CE1

RD

S-L

OC

K

MO

DE

L0NC

TX

LS1

AV

ss NC

RW

EM

PT

ES

TIN

RW

BU

SY

TUNPCK

TUNPDI

NC

VSS

TE

LIN

RW

CE

XR

ES

ET

AC

CP

W

RD

S-D

AT

A

KE

YD

MU

TE

AVSCL

NC

ROMCS

RX

LS1 VST

AM

PP

W

AM

UT

E

AS

EN

BO

ROMDATA

SY

SP

W

RO

M C

OR

RE

CT

ION

RE

SE

T

NC

CWE2098

ILM+B

ROT0

AUXG

AU

XG

DG

ND

D+

USGND

DPDT

FLP

ILM

AUXR

D-

KYDT

AU

XL

AUXV

DSENS

USGND

AU

XR

701

- 75

KE

YB

O

SWVDD

DP

DT

US

B5V

ILMGND

US

GN

D

DGND

ILM

CLR

1

ILM

CLR

2

US

GN

D

USB5V

ILM

GN

D

CLR2

RO

T1

SW

VD

D

ROT1

D+

AUXL

D-

RO

T0

KY

DT

EJE

CT

ILM

+B

AU

XV

CS

EN

S

CLR1

PE

G75

3A

CT

F17

13

47k

NM

NM FM/AM TUNER UNIT

NM

NM

BC

N18

21T

he>

mar

k fo

und

on s

ome

com

pone

nt p

arts

indi

cate

sth

e im

port

ance

of t

he s

afet

y fa

ctor

of t

he p

art.

The

refo

re, w

hen

repl

acin

g, b

e su

re to

use

par

ts o

fid

entic

al d

esig

natio

n.

*

FM

(30%

): -2

5.50

dB

sA

M(3

0%):

-25.

37 d

Bs

AU

X:+

2.19

dB

s

DSENS

DVH-335UB/XNRC 955 6 7 8

C

D

F

A

B

E

S1828

2

S1827

1

S1842

1

S1835

1

S1843

1

S1838

1

S1832

1

BAN/ESC

4

3

DIS/BA

DOW

1 2 3 4

10.2 KEYBOARD UNIT

B

CO

M0

CO

M1

CO

M2

CO

M3

SE

G1

SE

G2

SE

G3

SE

G4

SE

G5

SE

G6

SE

G7

SE

G8

SE

G9

SE

G10

SE

G11

SE

G12

SE

G13

SE

G14

SE

G15

SE

G16

SE

G17

SE

G18

SE

G19

SE

G20

SE

G21

SE

G22

SE

G23

SE

G24

SE

G26

SE

G27

SE

G28

SE

G29

SE

G30

SE

G31

SE

G32

SE

G33

SE

G34

SE

G35

SE

G36

SE

G37

SE

G38

SE

G39

SE

G25

SE

G0

KD

T2

SOURCE

SEG19

SEG18

SEG17

SEG16

SEG15

SEG14

SEG13

SEG12

SEG11

SEG10

SEG9

SEG8

SEG7

SEG6

SEG5

SE

G4

SE

G3

SE

G2

SE

G1

SE

G0

CO

M3

CO

M2

CO

M1

CO

M0

KS

T3

KS

T2

KS

T1

KS

T0

KD

T0

KD

T1

KDT2

KDT3

KST4

SEG39

SEG38

SEG37

SEG36

SE

G35

SE

G34

SE

G33

SE

G32

SE

G31

SE

G30

SE

G29

SE

G28

SE

G27

SE

G26

SE

G25

SE

G24

SE

G23

SE

G22

SE

G21

SE

G20

KD

T1

KST2

KST3

KD

T0

KST0

KST1

KST4

C18

66

NM

C18

65

NM

C18

64

NM

C18

01

CC

G11

92-A

C18

63

NM

C18

62

NM

C18

55

NM

C18

58

NM

C18

60

NM

C18

56

NM

C18

52

NM

C18

53

NM

C18

54

NM C

1861

NM

C18

02

1u/1

0

C18

57

NM

C18

59

NM

C18

67 NM

C18

68

NM

D18

57

D18

67D

1866

D18

56D

1858

D18

63

SM

LXA

4WB

ET

W1(

Z1)

D19

13

D18

64D

1865

D18

60

D18

51D

1852

D18

61D

1862

D18

59D

1854

D18

53N

M

D18

55

DGND

DGND

DGND

DGND

ILMGND

IC1801PD6497A

SEG4

1

SEG3

2

SE

G2

3

SE

G1

4

SE

G0

5

CO

M3

6

CO

M2

7

CO

M1

8

CO

M0

9

10 11 12 13 14 15 16

MODA21

X022

X123

VSS24

25

26

27

28

29

30

31

32

33343536373839404142434445464748

SEG1652

SEG1553

SEG1454

SEG1355

VDD56

SEG1257

SEG1158

SEG1059

SEG960

SEG861

SEG762

SEG663

SEG564

20

19

18

17

SEG1751 SEG18

50SEG19

49

GP1UXC14RKIC1802

1R

EM

2G

ND

3V

CC

L1801

NM

R18

80

270

1/4W

R1802

NM

R18

83

NM

R18

60

R18

58

R18

51

NM

R18

53

NM

R18

54

NM

R18

55

NM

R18

62

R18

64

R18

66

R18

68

R18

81

R18

82

R18

85

NM

R18

84

NM

R1826

NM

R1823

NM

R18

25 NM

R18

56

NM

R18

52

R18

24 NM

R18

01

NM

R18

03

NM

R1805 2.2k

R1806 2.2k

R1804

100

S1830

1 2

S1823

1 2

S1837

1 2

S1839

1 2

S1822

1 2

S1834

1 2

S1821

1 2

S1840

1 2

S1841

1 2

S1829

1 2

S1831

1 2

S1825

1 2S1826

1 2

S1833

1 2

S1836

1 2

S1824

1 2

V1801 CAW2009

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44

X1801

CSS1547-A

R18

99

270

1/4W

UCON&LCD 1801-1820

SWITCH&CONNENCTOR 1821-1850

LED 1851-1900

FRONT AUX 1901-1910

USB IN 1911-1920

NM

REFERENCE AREA MAP

BLUE COLOR2

SE

G35

SE

G32

SE

G31

SE

G30

SE

G29

SE

G28

SE

G23

SE

G26

SE

G25

SE

G21

SE

G33

SE

G34

SE

G22

SE

G24

SE

G20

SE

G27

NC1

KST4

KS

T1

SEG39SEG38

KS

T2

SEG37

VLC

D

SEG36

KS

T3

KS

T0 REM

DPDT

KD

T0

NC2

KYDT

KDT3

KD

T1

KST2

D1851 - D1854, D1856 - D1867 : CL-197HB1-D(CDE)

31

2

65

4

SO

UR

CE

LEF

TR

IGT

H

UP

LIS

TD

ISP

/BA

CK

DO

WN

RE

GIO

N

EJE

CT

BA

ND

/ES

C

REMOTE

1k2.2k

2.2k

2.2k

2.2k 1kNM

0 NM

56

1 2

SRC

EJECT CLOCK

LIST

LEFT UP RIGHT

LCD

5MHz

DVH-335UB/XNRC961 2 3 4

C

D

F

A

B

E

KD

T2

D18

67D

1866

D18

56D

1858

R18

60

R18

68R

1882

9

2

5

226

2

UP

DO

WN

NM

NM

OCK

GHT

5 6 7 8

B

SO

UR

CE

KD

T3

CN1911

1

2

3

4

5

6

CN1821CKS6287

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

C19

01

4700

p/50

C19

05

NM

C19

04

NM

C19

03

NM

C19

02

4700

p/50

D18

02

MC

2846

-11

D18

01

MC

2848

-11

D19

12

DZ

2S06

8C

D19

11

DZ

2S06

8C

DGND

DGND

DGND

ILMGND

USBGND

DGND

ILMGNDJA19011

2

3

4

L191

1

NM

12 3

4

NM

Q1851

1

2

34

5

6

R18

72

R18

22

10k

R18

96

R18

98

R18

97

R18

94

R18

95

R18

89

R18

74

R18

71

R18

73

R18

92

R18

75

R18

91

R1890

R18

21

NM

R18

88

R18

93

R1902

NMR1901

NMS1828

12

S1827

1 2

S1842

1 2

S1835

1 2

S1843

1 2

S1838

1 2

S1832

1 2 S1845

CSD1168

1

2

3

4

5

VA

1903

EZ

JZ1V

270R

M

VA

1902

EZ

JZ1V

270R

M

VA

1901

EZ

JZ1V

270R

M

VA

1904

NM

D18

77D

1872

D18

78

D18

82

D18

75

D18

76D

1873

D18

80

D18

83D

1879

D18

71

D18

69

D18

74

D18

70D

1868

D18

81

CKN1082

SWVDD

ILMCLR2

ROT1

KYDT

DPDT

DM

SRC

DP

AUXGND

ROT0

SWVDD

ILMGND

DGND

ILM+B

USBGND

AUXR

ILMCLR1

USBGND

USB5V

DSENS

AUXL

ILMCLR

COLOR1

CKS6267

BA

ND

/ES

C

RE

GIO

N

LIS

TD

ISP

/BA

CK

UP

DO

WN

LIS

TD

ISP

/BA

CK

65

4

23

1LEF

TR

IGT

H

SO

UR

CE

EJE

CT

FRONT_AUX

1k

0

NM

NM

NM

NM

NM

BAND/ESC

4

3

DISP/BACK

DOWN

MULTI-CONTROL

USB

AC

N701

B KEYBOARD UNIT

NM

DVH-335UB/XNRC 975 6 7 8

C

D

F

A

B

E

TD

COIL

COIL

COILW

HVM

HVP

HWM

HUP

HUM

HBM

FE

1

FE

2

HWP

HOM

08E

GND

C16

06

PGND

R15

42

10K

VC

C12

10R

1

C15

25

NM

R15

276R

8KR

1546

6R8K

NM

46 47

IRQ

PW

R48 49

US

BC

LOC

K50

VIN

511

3V

IN6

114

115

116

VIN

311

7I2

C_S

DA

I2C

_SC

L

08E

J

VIN

8

VIN

7

1 2 3 4

10.3 DVD CORE UNIT (GUIDE PAGE)

C

C-a

A9

A4

A10

A5

A11

A6

A12

A7

A13

A8

A14

A15

D15

D7

D14

D6

D13

D5

D12

D4

D11

D3

D10

D2

D9

D1

D8

A3

A2

A1

XRD

A16

A5

A10

A4

A9

A1

A2

A3

A16A15

A14

A8

A13

A7

A12

A6

XRD

A11

A19

XWR1

A18

A17 A17

A19

A18

MDQ7

MDQ6

MDQ5

MDQ15

MDQ14

MA9

MA8

MA7

MA6

MA5

MA4

DQM0

XWE

XCAS

XRAS

XCSM

BA1

MA10

BA0

MA0

MA1

MA2

MA3

MCK

MA11

MD

Q15

MD

Q0

MD

Q14

MD

Q1

MDQ13

MDQ2

MDQ12

MDQ3

MDQ11

MDQ4

MDQ10

MDQ5

MDQ7

MDQ6

DQM1

DQM0

MDQ9

MDQ8

XWE

MA9

XRAS

BA0

XCAS

XCSM

MA7

MA0

MA1

MA10

MA8

BA1

MA6

MA3

MA5

MA4

MA2

A0

XC

SF

2

XR

D

A16

XW

R1

A19

A1

A17

A6

A3

A5

A2

A4

A7

FD

XCSF1

D0

D8

D1

D9

D10

D2

D3

D4

D5

D11

D14

D13

D12

D7

D15

D4

D12

D5

D13

D6

D14

D7

D15

D10

D3

D11

D0

D8

D1

D9

D2

D6

A10

A8

A11

A9

LOUT

ROUT

SD

OD

AC

SC

KD

AC

LTD

AC

A12

IEC

OU

T

A0

MA11

TR

CD

AT

A3

SC

LOC

K

TR

CD

AT

A0

TR

CC

LK

TR

CD

AT

A1

TR

CS

T

TR

CD

AT

A2

SD

AT

A

A0

MCK

CO

MP

OS

ITE

XCSF2

EX

TR

G0

A15

A14

A13

A18

TE

MP

DQM1

COILU

COILV

COILW

MD

LDIN TOM

FOP

FOM

TOP

CONT1

CONT2

FG

CRGDRV

HWP

HVM

HVP

HUM

HUP

HWM

HBM

XWR1

NRESNRES

TD

FD

STANDBY

MDQ13

MDQ9

MDQ10

MDQ11

MDQ12

MDQ8

MDQ1

MDQ3

MDQ2

MDQ4

MDQ0

A20

A20

D+

D-

D0

DGND3

DGND2

IEC

GNDD

GNDD

GNDA

GNDA

GNDD

GNDD

GNDD

GNDD

GNDD

R14

05

100K

R1503

1M

R1406100K

R14

02

100K

C16

71

R1

C16

72

R1

C1487R1

C1481R1

C1674R1

C1480 R1

C16

03

100P

C1482R1

C1484 R1

C1509

R1

C1488R1

C16

02

100P

C1408R1

C1403R1

C1407

NMC1402

NM

C15

0210

C14044R7

C14094R7

C16

76

1

C1503 R1

VCC33

VCC12

VCC33

C1485

R1

C1504

R1

C1505

R1

C1506

R1

C1507

R1

C1508

R1

C15

18R

1

C15

19R

1

C15

14

R1

C15

11

R1

C15

13R

1

C15

16R

1

C15

17R

1

C15

15

R1

C18

05R

1

PC

M17

53D

BQ

IC18

01

BC

K1

DA

TA2

LRC

K3

DG

ND

45N

C

6V

CC

7V

OU

TL

8V

OU

TR9

AG

ND

10V

CO

M11

ZER

OR

/ZE

RO

A

12ZE

RO

L/N

A13

MD

14M

C15

ML

16S

CK

2081C

7R4

GNDAU1

R1804

820

R1803

820

C1801

4R7

R18

02

100K

C18

04

1800

P

R18

01

100K

C18

03

1800

P

GNDAU

C18

09

R1

GNDD

AV

CC

5

GNDAU

VCC33

C15

0110

GNDD

CN1951

1 2 3 4 5 6 7 8 9 1011

121314151617181920

GNDD

VCC33

TE

MP

GNDV

GNDD

R1954

15K

R195515K

C1601

R01

R1603

10K

R15

1710

K

R15

1810

K

C1673

R1

C1491 NM

C1492 NM

C1493 NM

C1494 NM

R15

2810

KR

1529

10K

R15

3010

K

R15

3110

K

C18

07

NM

R1217

1R1218

1

R12131

R1214

1R1215

1R1216

1

PGND

PGND1PGND2

VHALFVHALF

VD8

PGND

100/

16C

1201

FG

R1202 220

R1201 220

L190

1N

M

11

22

33

44

D1902NM

D1901NM

GNDD

C14

89

10

R1538

100K

R1602

12K

R1601

12K

C16

04

68P

C16

05

68P

GNDD

VCC33

C1483 NM

C1486

NM

C14

05

NM

R1212

270

AD2

AD

OU

T

CONT2

CONT1

CRGDRV

DA

CC

K

FD1

LDIN

LRC

K

LTD

AC

MD1 MD2

SC

KD

AC

SD

OD

AC

SR

CK

TD1

XWR1

C1204

2200P

GN

DD

5

R1403

NM

R1203

10K

R1204

15K

FOM2

FOP2

TOM2

TOP2

R15

3910

0K

R15

01

1R2K

R1679

NM R1675

NM

R1673

NM

GNDD

R15

0510

0

R15

0610

0

R15

0710

0

L1904

C14

90

R00

1

C12

114R

7

R1401

220

C14

01

R01

R19

50

240

R19

51

240

C1512

10P

C1510

12P

C1203

NM

C1205R1

C1207R1

C1209

R1

R15

08 220

R1512

100

C1208R01

R148356

2

1

4

36

5

8

7

R1487

56

2

1

4

36

5

8

7

R148656

2

1

4

36

5

8

7

R148856

2

1

4

36

5

8

7

R148156

2

1

4

36

5

8

7

R148056

2

1

4

36

5

8

7

R148456

2

1

4

36

5

8

7

R148256

2

1

4

36

5

8

7

R148556

2

1

4

36

5

8

7

R1490

56

R148956

C180610

R19

560R

0

R19

570R

0

R15

47

R1409NM

IC1201BD8231EFV

1VC

2 TKIN

3 FCIN

4SLIN

5SLOPOUT

6LDIN

7SPIN

8CTL1

9CTL2

10 GND1

11 TEST

12 FG

13SPCNF

14HB

15HW-

16HW+

17HV-

18HV+

19HU-

20HU+

21VM_S

22BH

23SPRNF

24SPVM

25SPGND

26U

27V

28W

29SLVM

30PGND

31SL/LDO+

32SL/LDO-

33FCO+

34FCO-

35TKO+

36

TKO- 37AVM

38PREVcc

39PREGND

40SUBGND

41GND2

MN2DS0018MAIC1501

EX

DT

1

1

EX

DT

9

2

EX

DT

23

EX

DT

104

VS

S_1

5

VD

D33

_16

EX

DT

37

EX

DT

118

EX

DT

49

EX

DT

1210

EX

DT

511

EX

DT

1312

EX

DT

613

EX

DT

1414

VS

S_2

15

VD

D33

_216

EX

DT

717

EX

DT

1518

VS

S_3

19

VD

D12

_120

EX

AD

R16

21

EX

AD

T15

22

EX

AD

T14

23

EX

AD

T13

24

EX

AD

T12

25

EX

AD

T11

26

EX

AD

T10

27

EX

AD

T9

28

EX

AD

T8

29

EX

AD

R19

30

NE

XW

E31

VS

S_4

32

VD

D33

_333

EX

AD

R18

34

EX

AD

R17

35

EX

AD

T7

36

EX

AD

T6

37

EX

AD

T5

38

EX

AD

T4

39

EX

AD

T3

40

EX

AD

T2

41

EX

AD

T1

42

VS

S_5

43

VD

D12

_244 45

VIN

411

8V

IN2

119

VIN

112

0V

DS

EN

S12

1T

EM

P12

2A

D2

123

AD

412

4A

VS

SH

125

TD

126

FD

127

AV

DD

H12

8D

AC

3OU

T12

9D

AC

2OU

T13

0D

AC

1OU

T13

1A

VD

DF

132

CO

MP

113

3V

RE

F13

4IR

EF

113

5C

OM

P2

136

AV

SS

F13

7C

OM

PO

SIT

E13

8D

AC

5OU

T13

9A

VS

SE

140

AV

DD

E14

1A

VD

DG

142

AV

SS

G14

3LO

UT

144

145

AV

SS

I

146

RO

UT

147

AV

DD

I

148

DA

CC

K

149

SR

CK

150

LRC

K

151

AD

OU

T

152

IEC

OU

T

153

VS

S_9

154

VD

D33

_6

155

OS

CI

156

OS

CO

157

VS

S_1

0

158

VD

D12

_4

159

MD

Q15

160

MD

Q0

161

MD

Q14

162

MD

Q1163

MDQ13164

MDQ2165VSS_11166VDD33_7

167MDQ12

168MDQ3

169MDQ11

170MDQ4

171MDQ10

172MDQ5

173VSS_12

174VDD33_8

175MDQ9

176MDQ6

177MDQ8

178MDQ7

179DQM0

180DQM1

181NWE

182VSS_13

183MCK

184VDD33_9

185MCKI

186VSS_14

187VDD12_5

188NCAS

189NRAS

190NCSM

191

192DQM3

193BA0

194MA9

195VSS_15

196VDD33_10

197BA1

198MA8

199MA10

200MA7

201MA0

202MA6

203MA1

204VSS_16

205VDD33_11

206MA5

207MA2

208MA4

209MA3

210VSS_17

211VDD12_6

212EXADT0

213NEXCE

214 NEXOE215 EXDT0

216EXDT8

X1501CSS1768

X11

GND12

GND24 X2 3

L1512

IC1480

IS42S16400F-7TL

VDD11

DQ02

VDDQ13

DQ14

5DQ2

6VSSQ1

7DQ3

8DQ4

9VDDQ2

10DQ5

11DQ6

12VSSQ2

13DQ7

14VDD2

15LDQM

16WE

17CAS

18RAS

19CS

20BA0

21BA1

22A10/AP

23A0

24A1

25A2

26A3

27VDD3

28VSS1

29A4

30A5

31A6

32A7

33A8

34A9

35A11

36N.C

37CKE

38CLK

39UDQM

40N.C/RFU

41VSS2

42DQ8

43VDDQ3

44DQ9

45DQ10

46VSSQ3

47DQ11

48DQ12

49VDDQ4

50DQ13

51DQ14

52VSSQ4

53DQ15

54VSS3

R15

04 12

C1808

NM

IC1401

CWW2689

A151

A142

A133

A124

5A11

6A10

7A9

8A8

9A19

10NC1

11/WE

12 /RESET13

NC214

NC315 RY_/BY16

A1817

A1718

A719

A620

A521

A422

A323

A224

A125

A0

26/CE

27Vss1

28/OE

29DQ0

30DQ8

31DQ1

32DQ9

33DQ2

34DQ10

35DQ3

36DQ11

37Vcc

38DQ4

39DQ12

40DQ5

41DQ13

42DQ6

43DQ14

44DQ7

45DQ15_A-1

46Vss2

47/BYTE

48A16

IC1402

CWW2690

A151

A142

A133

A124

5A11

6A10

7A9

8A8

9A19

10NC1

11/WE

12 /RESET13

NC214

NC315 RY_/BY16

A1817

A1718

A719

A620

A521

A422

A323

A224

A125

A0

26/CE

27Vss1

28/OE

29DQ0

30DQ8

31DQ1

32DQ9

33DQ2

34DQ10

35DQ3

36DQ11

37Vcc

38DQ4

39DQ12

40DQ5

41DQ13

42DQ6

43DQ14

44DQ7

45DQ15_A-1

46Vss2

47/BYTE

48A16

R15

110R

0

R1670

10K

R16

72

200

R1671

24K

R16

74

30K

FLASH 16M

(212

5)

(2125)(2125)

FLASH 16M

(IE

C/IP

FLG

)

SDRAM

(160

8)

(2125)

(2125)

AUDIO 2CH ANALOG OUT

ADAC

(212

5)

DEBUG

(212

5)

CP

_RE

AD

Y

STANDBY

(321

6)

27.000MHz

24

T

T

F

F

F

T

T

F

TF

S

C

C

C

S

S

S

DVH-335UB/XNRC981 2 3 4

C

D

F

A

B

E

A1

A3

A2

A4

TE

MP

C16

03

100P

C16

02

100P

TE

MP

C1

R

603

0K

R1217

R1218

R1213

R1214

R1215

R1216

R1602

12K

R1601

12K

AD2

C12

114R

7

EX

AD

T4

EX

AD

T3

40

EX

AD

T2

41

EX

AD

T1

42

VS

S_5

43V

IN1

120

VD

SE

NS

121

TE

MP

122

AD

212

3A

D4

F

5 6 7 8

C

C-b

DVDMPD

FE1

SCLOCK

SDATA

TRCCLK

TRCDATA0

TRCDATA1

TRCDATA2

TRCDATA3

B

C

A

D

LPCO1

LPCO2

FD

TD

CDMPD

STANDBY

STSCOMN

SCKDAC

COILV

COILU

COILW

HVM

HVP

HWM

HUP

HUM

HBM

XCSF1

E+G_E+F

F+H_G+H

B

A

FE2

TEMP

RF

F+

H_G

+H

E+

G_E

+F

RF

CDMPD

CRGDRV

MD

FG

FE

1

FE

2

NRESNRES

LTDAC

SDODAC

TOP

EXTRG0

AMUTE

C

D

LDIN

CONT2

CONT1

CMDCOMN

VDSENS

VDSENS

HWP

FOM

FOP

HOME

NRES

IRQPWR

CMDCOMN

STSCOMN

ROUT

D-

D+

IECOUT

LOUT

AMUTE

08EJ

TRCST

TOM

I2C_SCL

I2C_SDA

CP_Reset

I2C_SCL

I2C_SDA

IRQPWR

COMPOSITE

HOME

08EJ

A20

CP_Reset

DVDMPD

DVDLD1

AGND3

VCC5_3

GNDAGNDD

GNDA

GNDA

GNDA

GNDA

R11

03

390

R11

04

510

R11

0110

0K

C11

06

R01

C16

06

R1

VCC33

VCC5

Q11012SC4081

C15

19R

1

C15

20

R1

R1509 1K

R1510 1KSDATA

SCLOCK

C1521 R1

C1622 R033

GNDA

C1620 R22

GNDA

C1624

R1

C1625

R1

C1621 R22

ANAMONI1

ANAMONI2

C1619 5600P

C1618 100P

C1616 R1

C1617 R1

GNDA

C1612 R1

C1614 R1

C1615 R1

C1613 R1

C1611 R1

C1610 R1

GNDA

C1609 R1

VREF

VREF

C16231

C16081

VHALFR1232D121B

IC1005

PGND1

VIN2

VDD3

CE45

VOUT

6TEST

7AGND

8LX

L1004

FB12A

VCC12

C10

102R

2

C10

11 1

R10

02

100

VCC33-1

VCC33

VDD5VCC12-1

FB12B

DDF

VCC33

IC1001

NM

OUT1

VDD2

NC3

VSS4

VSENS

VD8

GNDA

DGND1

PGND

PGND4

GNDV

NRES

VDD5

VD8_1

C10

04

4R7

R1015

NM

AGND4

VCC5_1

EF1002

3

2

1

EF1001

3

2

1

PGND3

AGND1

VDD5_1

GNDAU GNDD

VDD5_2

GNDA

VCC5

GNDD

C10

011

DGND4

PGND5

GNDD

AVCC5

RO

LO

VD8

AVCC5

C1522 R1

DVDLD0

CDLD0

R1604 1M

PGND

GNDD

GNDD

VCC33

U-

HB+

HB-

W-

COM

COILU

V-

COP

U+

W+

V+

COILV

COILW

C1007

NM

C1006

NM

HOME

GNDD

R1017

NMGND_DD

C1110

R01

VREF

C11

08R

01

E+G_E+F

F+H_G+H

R11

0210

0K

GNDA

C11

05R

1

R11

06

560

Q11022SC4081

R11

05

390

C11

07

R01

CDLD1

DVDMPD

RF

601

01

CDMPD

C1523R1R1513

10K

08EJ

12EJ

IRQPWR

CMDCOMN

STSCOMN

STANBY

COMPOSITE

D+

D-

VD

C1526 R01R1523 220

R1522 100K

R1519 1K

IC1006

NM

G1

IN2

GND3

OUT4

5VCC

VD8

GNDAU

GNDAU3

GNDVGNDAU2

GNDD

C10

15

R00

1

PGND

R1536

100K

R1537

100K

R10

04

47K

R10

07

6R8K

GNDD

VD8_2

R1011

NM

GND_DD

GND_DD

GND_DCON

GND_DCON

B

A

C

D

FE1

FE2

1

1

1

1

1

1

L1003

R1534

220

GNDD

C10

16

R00

1

R1540 220

AGND2

GNDA

C16

07 10

C10

03R

1

AMUTE

R1525 10K

GNDD

R19

52

1M

IC1951TC7SZU04FU

NC1

IN_A2

GND3

OUT_Y4

5VCC

C1950R1

R15

42

10K

R1524 4R7K

48M

Hz

C11

04 R1

C16

04

68P

C16

05

68P

R151418K

R1541 220

C10

17

NM

R1526 10K

C10

051

R1222

270

TRCST

R1026

NM

R151610K

R1300

0R0

VCC5

C1524R047

C13

02

NM

R10

21

0R0

TOP1

FOP1

R1535100KCP_RESET

RESET

SDA

SCL

R15

3910

0K

NJM

2885

DL1

-33

IC10

04

1IN

2G

ND

3O

UT

2SB1132Q1104

2SB1132Q1103

C16

26

NM

C16

27

NM

C10

18

R1

L1902

L1903

GNDDPGND

C1019

R1

R19

53

680

C12

10R

1

C1528470P

WAKEUP

R1019100

R1025100

R1027100

C15

29

NM

GNDAU

C19

5210

P

C19

51

10P

C15

25

NM

C1527

NM

R11

103R

3R

1109

3R3

C11

11

R22

C11

09R

22

R1008

NM

R10

01

NM

C1953

NM

C1954

47P

10C

1101

R15

276R

8KR

1546

6R8K

R1301

NM

R15

47

NM

CN19011

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

CN1201

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

VD

D12

_244 45 46 47

IRQ

PW

R48 49

US

B_C

LOC

K50

VS

S_6

51

VD

D33

_452

CM

DC

OM

N53

ST

SC

OM

N54

12EJ55

LTDAC 56SDODAC 57SCKDAC

58XCSSR

59P13

60

61

62CONT1

63CONT2

64

65MD

66CRGDRV

67VSS_7

68VDD33_5

69NRES

70FG

71SCLOCK

72SDATA

73EXTRG0

74EXTRG1

75TRCCLK

76TRCDATA0

77TRCDATA1

78TRCDATA2

79TRCDATA3

80TRCST

81VSS_8

82VDD12_3

83AVDDD

84PLFIL1

85VREFH7

86AVSSD

87VREFL7

88AVSSC

89CCAPA

90CDATA

91AVDDC

92ANAMONI1

93ANAMONI2

94RFINN

95RFINP

96VIN1RF

97VIN2RF

98VIN4RF

99VIN3RF

100VREFH5

101VREFL5

102DVDMPD

103LPCO1

104CDMPD

105LPCO2106AVDDB

107AVSSB

108

VR

EF

H10

9

VH

ALF

110

E+

G_E

+F

111

F+

H_G

+H

112

VIN

511

3V

IN6

114

115

116

VIN

311

7V

IN4

118

VIN

211

9

IC1003

S-1200B50-M5

VIN1

VSS2

ON/OFF3

NC4

5VOUT

X1950

CSS1760X1

1GND1

2

GND24 X2 3

C13

01

NM

CN11011

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

R1532100

C1014

10C10

0910

C1013

10

C10

0810

C10

12

NM

R1543 180

R1544 180R1533

NM

C11

12

22

C11

13

22

IC1002S-1133B50-U5

NC1

VSS2

ON/OFF3

VIN4

5VOUT

CP_READY

R1114

1R5

R1111

1R5

R1112

1R5

R1115

1R5

R1116

1R5

R1117

1R5

R1113

1R5

R1118

1R5

R16051M

GNDDGNDD

LPCO1

LPCO2

PU(DP10)

(160

8)

(160

8)

(1608*4)

(1608*4)

(1608)

DEBUG

MOTOR DRIVER

12cm(DSCSNS)

8cm

5.0-3.3&1.2 V DC/DC

VOLTAGE DETECT

(160

8)

VD5

HOST I/F

AMUTE

ANALOG ROUT

(212

5)

STANBY

(160

8)

PGND

COMPOSIT

(3216)

HSTCMD

SLVSTS

PGND

XRESET

AGND

VD8

DGND

ANALOG LOUT

IRQPWR

VD8

AGND

VIDEO GND

AGND

D-

D+

DGND

COIL_U

HALL_V+

HALL_V-

HALL_U-

HALL_W+

GNDD

HALL_U+

COIL_V

HALL_W-

HALL_BIAS+

HALL_BIAS-

COIL_W

HOME

CRG/LE+

CRG/LE-

XL

H

LZ

G OUT

HL

<TC7SZ126FU>

H

IN

VD8

F+

T-

LD GND

F-

FE2

B

A

T+

78LD

C

RF

78MDG

SW

65LD

E+G/E+F

GND

D

F+H/G+H

VCC

65MDG

FE1

:PU1200->12991100->1199

:FLASH:SDRAM1480->1499

1850->1899

1670->1699 :DVN(BE)

:DVN(SYS)

:VIDEO

1900->1950

1500->1599

:AUDIO (DIGITAL)

1400->1449

1000->1049

1800->18491700->1749

:ACT+SPDL

:POWER SUPPLY

:OUTSIDE I/F

:AUDIO (ANALOG)

1600->1669 :DVN(FE)

1950->1999

(2125)

Vref

78MD

65MD

TEMP

TEMP GND

IECOUT

DGND

(1608)

(1608)

H

(1608)

LDIN

HOME

:USB

GNDD

(212

5)

CP_Reset

CP

_RE

AD

Y

I2C

_SD

A

I2C

_SC

L

08E

J

VIN

8

VIN

7

RESET

SDA

SCL

(321

6)

(1608)

(1005)

WAKEUP

DGND

USB

48.000MHz

X:Don’t CareZ:High Impedance

GNDD

C1021

680P

C1022680P

GNDV

C1934

68P

CD

DVD

C DVD CORE UNIT

ACN101

DCN701

CX

X2398

PIC

KU

P U

NIT

(SE

RV

ICE

)

1

3

F FOCUS SERVO LINETRACKING SERVO LINECARRIAGE SERVO LINESPINDLE SERVO LINERF SIGNAL

T

C

S

F

F

T

T

T

C

C

C

S

S

S

S

DVH-335UB/XNRC 995 6 7 8

C

D

F

A

B

E

CR

GD

RV

NR

ES

NR

ES

AM

UT

E

NR

ES

NR

ES

2G

ND

D

C15

22R

1C

1523

R1

R15

1310

K

C15

26R

01R

1523

220

R15

2210

0K

GN

DD

CA

MU

TE

R10

1910

0

9 10 1167

VS

S_7

68V

DD

33_5

69N

RE

S70

HS

TC

MD

XR

ES

ET

IRQ

PW

R

AC

1 2 3 4

C-a

C-b

C-b

SC

LOC

K

SD

AT

A

TR

CC

LK

TR

CD

AT

A0

TR

CD

AT

A1

TR

CD

AT

A2

TR

CD

AT

A3

B CA D

LPC

O1

LPC

O2

FD

TD

CD

MP

D

F+H_G+H

E+G_E+F

RF

FG

FE1

FE2

EX

TR

G0

TEMP

VD

SE

NS

VD

SE

NS

AM

UT

E

TR

CS

T

DV

DM

PD

GN

DA

GN

DD

GN

DA

C1603

100P

C1606

R1

C1602

100P

VC

C33

R15

091K

R15

101K

SD

AT

A

SC

LOC

K

C15

21R

1

C16

22R

033 G

ND

A

C16

20R

22

GN

DA

C16

24

R1

C16

25

R1

C16

21R

22

AN

AM

ON

I1

AN

AM

ON

I2

C16

1956

00P

C16

1810

0P

C16

16R

1

C16

17R

1

GN

DA

C16

12R

1

C16

14R

1

C16

15R

1

C16

13R

1

C16

11R

1

C16

10R

1

GN

DA

C16

09R

1

VR

EF

VR

EF

C16

231

C16

081

VH

ALF

R12

32D

121B

IC10

05

PG

ND

1

VIN

2

VD

D3

CE

45

VO

UT

6T

ES

T

7A

GN

D

8LX

L100

4

FB

12A

VC

C12

C10102R2

C10111

R1002

100 VC

C33

-1

VC

C33

VD

D5

VC

C12

-1

FB

12B

DD

F

VC

C33

IC10

01

NM

OU

T1

VD

D2

NC

3VS

S4

VS

EN

S

VD

8

GN

DA

DG

ND

1

PG

ND

PG

ND

4

GN

DV

VD

D5

VD

8_1

C1004

4R7

R10

15

NM

AG

ND

4

VC

C5_

1

EF

1002

31

EF

1001

3

2

1

PG

ND

3

AG

ND

1

VD

D5_

1

GN

DA

UG

ND

D

VD

D5_

2

GN

DA

VC

C5

GN

DD

C1001

1

DG

ND

4

PG

ND

5

AV

CC

5

VD

8

AV

CC

5

R16

041M

C10

07

NM

C10

06

NM

GN

DD

R10

17

NM

GN

D_D

D

C16

01

R01

VD

VD

8

C1015

R001

PG

ND

R1004

47K

R1007

6R8K

GN

DD

VD

8_2

R10

11

NM

GN

D_D

D

GN

D_D

D

GN

D_D

CO

N

GN

D_D

CO

N

L100

3

1016

R001

AG

ND

2

GN

DA

C1607

10

C1003R1

R15

244R

7K

R16

02

12K

R16

01

12K

C1604

68P

C1605

68P

C1017

NM

C1005

1

TR

CS

T

R15

1610

K

NJM2885DL1-33

IC1004

1IN

2GND

3OUT

C1626

NM

C1627

NM

C1018

R1

L190

2

L190

3

GN

DD

PG

ND

C10

19

R1

GN

DA

U

R10

08

NM

R1001

NM

C19

53

NM

C19

54

47P

CN

1901

1 2 3 4 5 6 7 8F

G71

SC

LOC

K72

SD

AT

A73

EX

TR

G0

74E

XT

RG

175

TR

CC

LK76

TR

CD

AT

A0

77T

RC

DA

TA

178

TR

CD

AT

A2

79T

RC

DA

TA

380

TR

CS

T81

VS

S_8

82V

DD

12_3

83A

VD

DD

84P

LFIL

185

VR

EF

H7

86A

VS

SD

87V

RE

FL7

88A

VS

SC

89C

CA

PA

90C

DA

TA

91A

VD

DC

92A

NA

MO

NI1

93A

NA

MO

NI2

94R

FIN

N95

RF

INP

96V

IN1R

F97

VIN

2RF

98V

IN4R

F99

VIN

3RF

100

VR

EF

H5

101

VR

EF

L510

2D

VD

MP

D10

3LP

CO

110

4C

DM

PD

105

LPC

O2

106

AV

DD

B

107

AV

SS

B

108

VREFH109

VHALF110E+G_E+F111F+H_G+H

112VIN5

113VIN6

114

115

116VIN3

117VIN4

118VIN2

119VIN1

120VDSENS

121TEMP

122

IC10

03

S-1

200B

50-M

5

VIN

1

VS

S2

ON

/OF

F3

NC

45V

OU

T

C10

14

10

C100910

C10

13

10

C100810

C1012

NM

IC10

02S

-113

3B50

-U5

NC 1

VS

S 2

ON

/OF

F 3V

IN 4 5VO

UT

R16

051M

GN

DD

GN

DD

(160

8)

DE

BU

G

5.0-

3.3&

1.2

V D

C/D

C

VO

LTA

GE

DE

TE

CT (1608)

VD

5

HO

ST

I/F A

MU

TE

(2125)

(1608)

PG

ND

(321

6)P

GN

D

VD

8

DG

ND

VD

8

VD

8

:PU

1200

->12

9911

00->

1199

:FLA

SH

:SD

RA

M14

80->

1499

1850

->18

99

1670

->16

99

:DV

N(B

E)

:DV

N(S

YS

)

:VID

EO

1900

->19

50

1500

->15

99

:AU

DIO

(D

IGIT

AL)

1400

->14

49

1000

->10

49

1800

->18

4917

00->

1749

:AC

T+S

PD

L

:PO

WE

R S

UP

PLY

:OU

TS

IDE

I/F

:AU

DIO

(A

NA

LOG

)

1600

->16

69

:DV

N(F

E)

1950

->19

99

(212

5)

(160

8)

(160

8)

(160

8)

:US

B

(2125)

VIN8

VIN7

(160

8)

(100

5)

US

B

GN

DD

C10

21

680P

C10

2268

0PC

1934

68P

CD

VD

CO

RE

UN

IT

FF

OC

US

SE

RV

O L

INE

TR

AC

KIN

G S

ER

VO

LIN

EC

AR

RIA

GE

SE

RV

O L

INE

SP

IND

LE S

ER

VO

LIN

ER

F S

IGN

AL

T C S

T

DVH-335UB/XNRC1001 2 3 4

C

D

F

A

B

E

TR

CC

LK

EX

TR

G0

AM

UT

E

GN

DA

GN

DD

R10

15A

GN

D4

AG

ND

1G

ND

DD

GN

D4

PG

ND

R15

244R

7K

2 3 474

EX

TR

G1

75T

RC

CLK

76T

RC

DA

TA

0

PG

ND

(321

6)P

GN

D

VD

8

VD

8

5 6 7 8

C-a

C-b

C-b

DV

DM

PD

FE

1

A1

A2

SC

LOC

K

SD

AT

A

ST

AN

DB

Y

ST

SC

OM

N

SC

KD

AC

CO

ILV

CO

ILU

CO

ILW

HV

M

HV

P

HW

M

HU

P

HU

M

HB

M

XC

SF

1

E+G

_E+F

F+H

_G+H

B A FE

2

TE

MP

RF

CD

MP

D

CR

GD

RV

MD

FG

NR

ES

NR

ES

LTD

AC

SD

OD

AC

TO

P

AM

UT

E

C D

LDIN

CO

NT

2

CO

NT

1

CM

DC

OM

N

HW

P

FO

M

FO

P

HO

ME

NR

ES

IRQ

PW

R

CM

DC

OM

N

ST

SC

OM

N

RO

UT

D- D+

IEC

OU

T

LOU

T

08E

J

TO

M

I2C

_SC

L

I2C

_SD

A

CP

_Res

et

I2C

_SC

L

I2C

_SD

A

IRQ

PW

R

CO

MP

OS

ITE

HO

ME

08E

J

A20

CP

_Res

et

DV

DLD

1

AG

ND

3

VC

C5_

3

GN

DA

GN

DA

GN

DA

R1103

390

R1104

510

R1101100K

C1106

R01

VC

C5

Q11

012S

C40

81

C1519R1

C1520

R1

R15

091K

R15

101K

SD

AT

A

SC

LOC

K

GN

DA

NR

ES

VD

D5

NM

EF

1002

3

2

1

VD

D5_

1V

DD

5_2

GN

DD

RO

LO

C15

22R

1

DV

DLD

0

CD

LD0

PG

ND

GN

DD

GN

DD

VC

C33

U-

HB

+

HB

-W-

CO

M

CO

ILU V

-

CO

PU+

W+

V+

CO

ILV

CO

ILW

HO

ME

C11

10

R01

VR

EF

C1108R01

E+G

_E+F

F+H

_G+H

R1102100K

GN

DA

C1105R1

R1106

560

Q11

022S

C40

81

R1105

390

C1107

R01

CD

LD1

DV

DM

PD

RF

CD

MP

D

C15

23R

1R

1513

10K

08E

J

12E

J

IRQ

PW

R

CM

DC

OM

N

ST

SC

OM

N

ST

AN

BY

CO

MP

OS

ITE

D+

D-

C15

26R

01R

1523

220

R15

2210

0K

R15

191K

IC10

06

NM

G1

IN2

GN

D3

OU

T45

VC

C

GN

DA

U

GN

DA

U3

GN

DV

GN

DA

U2

GN

DD

R15

36

100K

R15

37

100K

B A C D

FE

1

FE

2

R12

17

1R

1218

1

R12

131

R12

14

1R

1215

1R

1216

1

R15

34

220

GN

DD

C1016

R001

R15

4022

0

AM

UT

E

R15

2510

K

GN

DD

R1952

1M

IC19

51T

C7S

ZU

04F

UNC

1

IN_A

2

GN

D3

OU

T_Y

45V

CC

C19

50 R1

R1542

10K

48MHz

C1104

R1

R15

1418

K

R15

4122

0

R15

2610

K

R12

22

270

R10

26

NM

R15

1610

K

R13

00

0R0

VC

C5

C15

24R

047

C1302

NM

R1021

0R0

TO

P1

FO

P1

R15

3510

0KC

P_R

ES

ET

RE

SE

T

SD

A

SC

L

R1539100K

2SB

1132

Q11

04

2SB

1132

Q11

03

L190

3

C12114R7

R1953

680

C1210R1

C15

2847

0P

WA

KE

UP

R10

1910

0

R10

2510

0

R10

2710

0

C1529

NM

C195210P

C1951

10P

C1525

NM

C15

27

NM

R11103R3

R11093R3

C1111

R22

C1109R22

10C1101

R15276R8K

R15466R8K

R13

01

NM

R1547

NM5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30

CN

1201

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

EXADT241

EXADT142

VSS_543

VDD12_244

45

46

47

IRQPWR48

49

USB_CLOCK50

VSS_651

VDD33_4 52CMDCOMN 53STSCOMN

54

12E

J55

LTD

AC

56S

DO

DA

C57

SC

KD

AC

58X

CS

SR

59P

13606162

CO

NT

163

CO

NT

26465

MD

66C

RG

DR

V67

VS

S_7

68V

DD

33_5

69N

RE

S70

FG

71S

CLO

CK

72S

DA

TA

73E

XT

RG

0

X19

50

CS

S17

60X

11

GN

D1

2

GN

D2

4X

23

C1301

NM

CN

1101

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26

R15

3210

0

R15

4318

0

R15

4418

0R

1533

NM

C1112

22

C1113

22

CP

_RE

AD

Y

R11

14

1R5

R11

11

1R5

R11

12

1R5

R11

15

1R5

R11

16

1R5

R11

17

1R5

R11

13

1R5

R11

18

1R5

LPC

O1

LPC

O2

PU

(DP

10)

(1608)

(1608)

(160

8*4)

(160

8*4)

MO

TO

R D

RIV

ER

12cm

(DS

CS

NS

)

8cm

VD

5

AM

UT

E

AN

ALO

G R

OU

T

ST

AN

BY

CO

MP

OS

IT

HS

TC

MD

SLV

ST

S

XR

ES

ET

AG

ND

DG

ND

AN

ALO

G L

OU

T

IRQ

PW

R

AG

ND

VID

EO

GN

D

AG

ND

D-

D+

DG

ND

CO

IL_U

HA

LL_V

+

HA

LL_V

-

HA

LL_U

-

HA

LL_W

+

GN

DD

HA

LL_U

+

CO

IL_V

HA

LL_W

-

HA

LL_B

IAS

+

HA

LL_B

IAS

-

CO

IL_W

HO

ME

CR

G/L

E+

CR

G/L

E-

XL

HLZ

GO

UT

HL

<TC

7SZ

126F

U>

H

IN

F+

T-

LD G

ND

F-

FE

2

B A T+

78LD

C RF

78M

DG

SW

65LD

E+G

/E+F

GN

D

DF+H

/G+H

VC

C

65M

DG

FE

1

Vre

f

78M

D

65M

D

TE

MP

TE

MP

GN

D

IEC

OU

T

DG

ND

H

LDIN

HO

ME

GN

DD

CP

_Res

et

CP_READY

I2C_SDA

I2C_SCL

08EJ

RE

SE

T

SD

A

SC

L

(3216)

WA

KE

UP

DG

ND

48.0

00M

Hz

X:D

on’t

Car

eZ

:Hig

h Im

peda

nce

GN

DV

CD

DV

D

AC

N10

1

DC

N70

1

CXX2398PICKUP UNIT (SERVICE)

1

3

F F

T TCC

C S

S S S

DVH-335UB/XNRC 1015 6 7 8

C

D

F

A

B

E

MA

5

MA

4

MA

2

MA

3M

A0

MA

1

MA

6C

1485

R1

2 187

562 1

8720

1M

A0

202

MA

620

3M

A1

204

25A

226

A3

27V

DD

328

VS

S1

29A

4

30A

5

1 2 3 4

C-b

C-a

C-a

C-b

MD

Q7

MD

Q6

MD

Q5

MD

Q15

MD

Q14

MA

9

MA

8

MA

7

MA

6

DQ

M0

XW

E

XC

AS

XR

AS

XC

SM

BA

1

MA

10

BA

0

MA

0

MA

1

MC

K

MA

11

MDQ15

MDQ0

MDQ14

MDQ1

MD

Q13

MD

Q2

MD

Q12

MD

Q3

MD

Q11

MD

Q4

MD

Q10

MD

Q5

MD

Q7

MD

Q6

DQ

M1

DQ

M0

MD

Q9

MD

Q8

XW

E

MA

9

XR

AS

BA

0

XC

AS

XC

SM

MA

7

MA

10

MA

8

BA

1

FD

TD

LOU

T

RO

UT

SDODAC

SCKDAC

LTDAC

IECOUT

MA

11

MC

K

COMPOSITE

FE1

FE2

TEMP

DQ

M1

ST

AN

DB

Y

MD

Q13

MD

Q9

MD

Q10

MD

Q11

MD

Q12

MD

Q8

MD

Q1

MD

Q3

MD

Q2

MD

Q4

MD

Q0

D+

D-

IEC

GN

DA

GN

DA

GN

DD

GN

DD

R15

03

1M

C1671

R1

C1672

R1

C14

87R

1

C14

81R

1

C16

74R

1

C14

80R

1

C1603

100P

C14

82R

1

C14

84R

1

C14

88R

1

C1602

100P

C150210

C1676

1

C15

03R

1

VC

C33

VC

C12

C15

04

R1

C15

05

R1

C15

06

R1

C15

07

R1

C1514

R1

C1511

R1

C1515

R1

C1805R1

PCM1753DBQIC1801

BCK 1DATA 2LRCK 3DGND 4

5NC

6VCC

7VOUTL

8VOUTR

9 AGND

10VCOM

11 ZEROR/ZEROA

12 ZEROL/NA13

MD14

MC15 ML16

SCK

20

81

C

7R

4

GN

DA

U1

R18

04

820

R18

03

820

C18

01

4R7

R1802

100K

C1804

1800P

R1801

100K

C1803

1800P

GN

DA

U

C1809

R1

GN

DD

AVCC5

GN

DA

U

VC

C33

C150110

GN

DD

TEMP

GN

DV

GN

DD

R19

54

15K

R19

5515

K

C16

01

R01

R16

03

10K

C16

73

R1

C14

91N

M

C14

92N

M

C14

93N

M

C14

94N

M

C1807

NM

L1901NM

11 2 2

3 344D19

02NM

D19

01 NM

GN

DD

C1489

10

R15

38

100K

R16

02

12K

R16

01

12K

C1604

68P

C1605

68P

C14

83N

M

AD

2

ADOUT

DACCK

LRCK

LTDAC

SCKDAC

SDODAC

SRCK

GNDD5

R1501

1R2K

R16

79

NM

R16

75 NM

R16

73

NM

GN

DD

R1505100

R1506100

R1507100

L190

4

C1490

R001

R1950

240R1951

240

C15

12

10P

C15

10

12P

R1508220

R15

12

100

R14

8356

2 14 365 87

R14

87

56

2 14 365 87

R14

8656

2 14 365 87

R14

8856

4 365

R14

8156

2 14 365 87

R14

8056

2 14 365 87

R14

84

4 365

R14

8256

2 14 365 87

R14

8556

2 14 365 87

R14

90

56

R14

8956

C18

0610

R19560R0

R19570R0

MN

2DS

0018

MA

IC15

01

VIN6114

115

116VIN3

117VIN4

118VIN2

119VIN1

120VDSENS

121TEMP

122AD2

123AD4

124AVSSH

125TD

126FD

127AVDDH

128DAC3OUT

129DAC2OUT

130DAC1OUT

131AVDDF

132COMP1

133VREF

134IREF1

135COMP2

136AVSSF

137COMPOSITE

138DAC5OUT

139AVSSE

140AVDDE

141AVDDG

142AVSSG

143LOUT

144

145AVSSI

146ROUT

147AVDDI

148DACCK

149SRCK

150LRCK

151ADOUT

152IECOUT

153VSS_9

154VDD33_6

155OSCI

156OSCO

157VSS_10

158VDD12_4

159MDQ15

160MDQ0

161

MDQ14

162

MDQ1

163

MD

Q13

164

MD

Q2

165

VS

S_1

116

6V

DD

33_7

167

MD

Q12

168

MD

Q3

169

MD

Q11

170

MD

Q4

171

MD

Q10

172

MD

Q5

173

VS

S_1

217

4V

DD

33_8

175

MD

Q9

176

MD

Q6

177

MD

Q8

178

MD

Q7

179

DQ

M0

180

DQ

M1

181

NW

E18

2V

SS

_13

183

MC

K18

4V

DD

33_9

185

MC

KI

186

VS

S_1

418

7V

DD

12_5

188

NC

AS

189

NR

AS

190

NC

SM

191

192

DQ

M3

193

BA

019

4M

A9

195

VS

S_1

519

6V

DD

33_1

019

7B

A1

198

MA

819

9M

A10

200

MA

7

X15

01C

SS

1768

X1

1G

ND

12

GN

D2

4X

23

L151

2

IC14

80

VD

D1

1

DQ

02

VD

DQ

13

DQ

14 5

DQ

26

VS

SQ

17

DQ

38

DQ

49

VD

DQ

210

DQ

511

DQ

612

VS

SQ

213

DQ

714

VD

D2

15LD

QM

16W

E17

CA

S18

RA

S19

CS

20B

A0

21B

A1

22A

10/A

P23

A0

24A

131

A6

32A

7

33A

8

34A

9

35A

11

36N

.C

37C

KE

38C

LK

39U

DQ

M

40N

.C/R

FU

41V

SS

2

42D

Q8

43V

DD

Q3

44D

Q9

45D

Q10

46V

SS

Q3

47D

Q11

48D

Q12

49V

DD

Q4

50D

Q13

51D

Q14

52V

SS

Q4

53D

Q15

54V

SS

3

R150412

C18

08

NM

R15110R0

R16

70

10K

R1672

200

R16

71

24K

R1674

30K

(2125)

(IEC/IPFLG)

(1608)

(212

5)

(212

5)

AU

DIO

2C

H A

NA

LOG

OU

T

AD

AC

(2125)

(2125)

ST

AN

DB

Y

VIN8

VIN7

27.0

00M

Hz

T

F

T

F

DVH-335UB/XNRC1021 2 3 4

C

D

F

A

B

E

MA

9

XC

SM

BA

1

BA

0M

A11

BA

1

DQ

M1

C15

07

R1

R14

8356

4 365

R14

87

564 3

65

18

MA

919

5V

SS

_15

196

VD

D33

_10

197

19C

S20

BA

021

BA

134

A9

35A

11

36N

.C

5 6 7 8

C-a

C-b

C-b

C-a

A9

A4

A10

A5

A11

A6

A12

A7

A13

A8

A14

A15

D15 D

7

D14 D

6

D13 D

5

D12 D

4

D11 D

3

D10 D

2

D9

D1

D8

A3

A2

A1

XR

D

A16

A5

A10

A4

A9

A1

A2

A3

A16

A15

A14

A8

A13

A7

A12

A6

XR

D

A11

A19

XW

R1

A18

A17

A17

A19

A18

MA

8

MA

7

MA

6

MA

5

MA

4

MA

10

MA

0

MA

1

MA

2

MA

3

MA

7

MA

0

MA

1

MA

10

MA

8

MA

6

MA

3

MA

5

MA

4

MA

2

A0

XCSF2

XRD

A16

XWR1

A19

A1

A17

A6

A3

A5

A2

A4

A7

XC

SF

1

D0

D8

D1

D9

D10

D2

D3

D4

D5

D11

D14

D13

D12

D7

D15

D4

D12D

5

D13D

6

D14D

7

D15

D10D

3

D11 D

0

D8

D1

D9

D2

D6

A10

A8

A11

A9

A12

A0

TRCDATA3

SCLOCK

TRCDATA0

TRCCLK

TRCDATA1

TRCST

TRCDATA2

SDATA

A0

CCC

XC

SF

2

EXTRG0

A15

A14

A13

A18

CO

ILU

CO

ILV

CO

ILW

MD

LDIN

TO

M

FO

P

FO

M

TO

P

CO

NT

1

CO

NT

2

FG

CR

GD

RV

HW

P

HV

M

HV

P

HU

M

HU

P

HW

M

HB

M

XW

R1

NR

ES

NR

ES

TD

FD

A20

A20

D0

DG

ND

3

DG

ND

2

GN

DD

GN

DD

GN

DD

GN

DD

GN

DD

R1405

100K

R14

0610

0K

R1402

100K

C15

09

R1

C14

08R

1C

1403

R1

C14

07 NM

C14

02 NM

C14

04 4R7

C14

094R

7

VC

C33

C14

85

R1

C15

08

R1

C1518R1

C1519R1

C1513R1

C1516R1

C1517R1

CN

1951

1

2

3

4

5

6

7

8

9

1011

12

13

14

15

16

17

18

19

20

GN

DD

VC

C33

PG

ND

R151710K

R151810K

R152810K

R152910K

R153010K

R153110K

R12

17

1R

1218

1

R12

131

R12

14

1R

1215

1R

1216

1

PG

ND

PG

ND

1P

GN

D2

VH

ALF

VH

ALF

VD

8

PG

ND

100/16C1201

FG

R12

0222

0

R12

0122

0

R1542

GN

DD

VC

C33

C14

86

NM

C1405

NM

R12

12

270

CO

NT

2

CO

NT

1

CR

GD

RV

FD

1

LDINMD

1M

D2

TD

1

XW

R1

C12

04

2200

P

R14

03

NM

R12

03

10K

R12

04

15K

FO

M2

FO

P2

TO

M2

TO

P2

R1539100K

C12114R7

R14

01

220

C1401

R01

C12

03 NM

C12

05R

1

C12

07R

1

C1210R1

C12

09

R1

C12

08R

01

C1525

2 187

2 187

R14

8856

2 14 365 87

R14

8456

2 14 365 87

R15276R8K

R15466R8K

R1547

NM

R14

09N

M

IC12

01B

D82

31E

FV

1V

C

2T

KIN

3F

CIN

4S

LIN

5S

LOP

OU

T

6LD

IN

7S

PIN

8C

TL1

9C

TL2

10G

ND

1

11T

ES

T

12F

G

13S

PC

NF

14H

B

15H

W-

16H

W+

17H

V-

18H

V+

19H

U-

20H

U+

21V

M_S

22B

H23

SP

RN

F24

SP

VM

25S

PG

ND

26U

27V

28W

29S

LVM

30P

GN

D

31S

L/LD

O+

32S

L/LD

O-

33F

CO

+34

FC

O-

35T

KO

+36

TK

O-

37A

VM

38P

RE

Vcc

39P

RE

GN

D40

SU

BG

ND

41G

ND

2

EXDT1

1

EXDT9

2

EXDT23

EXDT104

VSS_15

VDD33_16

EXDT37

EXDT118

EXDT49

EXDT1210

EXDT511

EXDT1312

EXDT613

EXDT1414

VSS_215

VDD33_216

EXDT717

EXDT1518

VSS_319

VDD12_120

EXADR1621

EXADT1522

EXADT1423

EXADT1324

EXADT1225

EXADT1126

EXADT1027

EXADT928

EXADT829

EXADR1930

NEXWE31

VSS_432

VDD33_333

EXADR1834

EXADR1735

EXADT736

EXADT637

EXADT538

EXADT439

EXADT340

EXADT241

EXADT142

VSS_543

VDD12_244

45

46

47

IRQPWR48

49

BA

119

8M

A8

199

MA

1020

0M

A7

201

MA

020

2M

A6

203

MA

120

4V

SS

_16

205

VD

D33

_11

206

MA

520

7M

A2

208

MA

420

9M

A3

210

VS

S_1

721

1V

DD

12_6

212

EX

AD

T0

213

NE

XC

E21

4N

EX

OE

215

EX

DT

0

216

EX

DT

8

IS42

S16

400F

-7T

L

22A

10/A

P23

A0

24A

125

A2

26A

327

VD

D3

28V

SS

1

29A

4

30A

5

31A

6

32A

7

33A

8

IC14

01

CW

W26

89

A15

1

A14

2

A13

3

A12

4 5A

116

A10

7A

98

A8

9A

1910

NC

111

/WE

12/R

ES

ET

13N

C2

14N

C3

15R

Y_/

BY

16A

1817

A17

18A

719

A6

20A

521

A4

22A

323

A2

24A

125

A0

26/C

E

27V

ss1

28/O

E

29D

Q0

30D

Q8

31D

Q1

32D

Q9

33D

Q2

34D

Q10

35D

Q3

36D

Q11

37V

cc

38D

Q4

39D

Q12

40D

Q5

41D

Q13

42D

Q6

43D

Q14

44D

Q7

45D

Q15

_A-1

46V

ss2

47/B

YT

E

48A

16

IC14

02

CW

W26

90

A15

1

A14

2

A13

3

A12

4 5A

116

A10

7A

98

A8

9A

1910

NC

111

/WE

12/R

ES

ET

13N

C2

14N

C3

15R

Y_/

BY

16A

1817

A17

18A

719

A6

20A

521

A4

22A

323

A2

24A

125

A0

26/C

E

27V

ss1

28/O

E

29D

Q0

30D

Q8

31D

Q1

32D

Q9

33D

Q2

34D

Q10

35D

Q3

36D

Q11

37V

cc

38D

Q4

39D

Q12

40D

Q5

41D

Q13

42D

Q6

43D

Q14

44D

Q7

45D

Q15

_A-1

46V

ss2

47/B

YT

E

48A

16

FLA

SH

16M

(212

5)(2

125)

FLA

SH

16MSD

RA

M

DE

BU

G

CP_READY

I2C_SDA

I2C_SCL

08EJ

(3216)

24

T TFF

F TS

C C

C

S S S

DVH-335UB/XNRC 1035 6 7 8

C

D

F

A

B

E

1 2 3 4

10.4 CONNECT PCB

D

H+

,H-,

HU

+,H

U-,

HV

+,H

V-,

HW

+,H

W-,

U,V

,W

H+

W

U

V

HW+

HW-

HV+

HV-

HU+

HU-

H-

HV-

H+

HV+

HU-

HU+

HW-

HW+

H-

W

U

V

CN701

1 CRG-

2 CRG+

3 HALL BIAS-

4 HALL U-

5 HALL U+

6 HALL V-

7 HALL V+

8 HALL W-

9 HALL W+

10 COIL V

11 COIL U

12 COIL W

13 HALL BIAS+

14 DSCSNS

15 8SNS

16 HOME

17 GND

18 GND

CSN1068-A

S101

1

234

CSN1068-A

S102

1

2 34

1 2

11

HOME

8SNS0

DSCSNS0

GND3 GND2 GND1

CRGM

CRGP

HM

HUM

HUP

HVM

HVP

HWM

HWP

V

U

W

HP

BR

1

GY

1

DSCSNS0_B

8SNS0_B

HOME_B

C10

1

0.1u

/50

R101

100

R102

100

R103

100

GND_B

HOME1_BHOME1

8SNS1 8SNS1_B

DSCSNS1 DSCSNS1_B

CN101

1V

2U

3W

4H-

5HW+

6HW-

7HU+

8HU-

9HV+

10H+

11HV-

1

2

3

4

5

6

7

8

9

10

11

CSN1068-A

S103

1

234

H3

H1

H2

M2SPINDLE MOTOR

EXM1050

M1LOAD/CRG MOTOR

CXC4026

HOME

8SNS

DSCSNS

D CONNECT PCB

CCN1201

C

CC

C

S

S

S

SS

S

DVH-335UB/XNRC1041 2 3 4

C

D

F

A

B

E

5 6 7 8

10.5 WAVEFORMS

RF 0.2 V/div(AC) 100 ns/divCDRF(x4CLV)

RF 0.2 V/div(AC) 50 ns/divDVDRF(x1.3ZCAV)

RF 0.5 V/div 100 us/divDVDRF(BD1mm)

TD1 0.2 V/div 100 us/divInterval FWD(DVD)

TD1 0.2 V/div 100 us/divInterval REV(DVD)

VHALF VHALF

2.2 V->

Traverse 1001FWD(short)(DVD)

VHALF

VHALF VHALF

0->

TD1 0.2 V/div 500 us/divMulti 32FWD(DVD)

TD1 0.2 V/div 500 us/divMulti 32REV(DVD)

CH1:TD1 0.5 V/div 10 ms/divCH2:COP-COM 2.0 V/div 10 ms/div

- Waveforms Note:1. The encircled number denote measuring points in the circuit diagram. 2. Reference voltage: 1.65 V(TD1,FD1)(=VHALF) 2.2 V(RF)(=VREF)

In the waveform, it is seeing on the GND standard.Offset of 1.65 V or 2.2 V is put in.

DVH-335UB/XNRC 1055 6 7 8

C

D

F

A

B

E

1 2 3 4

VHALF VHALFVHALF

VHALFVHALF VHALF

VHALFVHALF

0->

0->

0->

0->


Traverse 1001REV(short)(DVD)

CH2:COP-COM 2.0 V/div 100 ms/divID search Inside -> Outside(DVD)

FD1 0.5 V/div 20 ms/divPlay FD(DVD)

FD1 0.5 V/div 500 us/divFocus Jump L0 -> L1

FD1 0.5 V/div 500 us/divFocus Jump L1 -> L0

TD1 0.5 V/div 100 ms/divPlay TD (DVD)

FD1 0.5 V/div 1 ms/divFocus Close (DVD)


Traverse 5001FWD(long)(DVD)


Traverse 5001REV(long)(DVD)

DVH-335UB/XNRC1061 2 3 4

C

D

F

A

B

E

5 6 7 8

DVH-335UB/XNRC 1075 6 7 8

C

D

F

A

B

E

1

51

2

1

10

R1101

R22

3

C

C27

2

C27

3

L12

C1001

C10

02

R10R10

R1

R1

R11

R1

1001

R126

R7

R71

6

C1

5

R

C37

1

571

572

L221

122

R20

6

80

RON

1 2 3 4

11. PCB CONNECTION DIAGRAM11.1 TUNER AMP UNIT

A

A TUNER AMP UNIT

CapacitorConnector

P.C.Board Chip PartSIDE B

SIDE A

NOTE FOR PCB DIAGRAMS1.The parts mounted on this PCB include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic diagram.2.Viewpoint of PCB diagrams

1

5

1 1

1

1 5 10

15 20

30

35

40 45

25

15

1

E

1

1

5

1

5

1

5

1

5

5

11

1

E

1

5

E

E

1

5

5251

51

0302

10

51

10

1

1

1

1 5 10

15 20

25

30

3

5

40 45

15

1 5

10

15

20

1 5

1

1

1

C11

21

C11

22

IC351

Q28

1

Q28

2

C1131

IC1101

C1132

IC1103

R1111

IC171

R11

12

Q291

Q292

R23

3

R234

C11

41

IC1111

R23

5

C1142

R23

6

C11

43

R237

C11

44

R238

IC371

C11

45

R239

C11

46

C11

47

IC181

R240

R24

1R

242

R24

3

R24

4

C11

51

R245

C11

52

R24

6

C11

53

C11

54

Q1151

R251

C11

61

C1162

C11

63

C1164

D1141

C1165

D1142

R11

41

R11

42

R26

1

R262R263

P1191

D11

51

C23

1

VA291

VA292

C23

2 C23

3

C234

C1181

C11

82C

1183

C1184C1185

C11

86

R1161

C24

1

R1162

C24

2

R1163

C24

3

R1164

R1165

R28

1

R11

66

R28

2

R11

67

R28

3

R28

4

C11

91

R285

C11

92

R286

C1193

R287

C11

94

R288

Q1191

C1195

C1196

C1197

C1198

R1171

C25

1

C1199

R1172

C25

2

R1173

C25

3

R1174

C25

4

R29

1

R29

2R

293

R29

4

R29

5R

296

R29

7R

298

R29

9

R11

81

C261

R1182

R11

83

C263

R1184

R11

85

JA282

R11

87

R1188

R11

89

Q111Q112D

1191

L101

D1192

D1193

R11

90

R1191

CN291

C271 C275

C281

C282

C283 C284

Q321

C285

C286

C287

C288

C291

C29

2

C293

L321

IC231

Q161Q162

R107R108

R109

VA321

IC241

VA322

R30

0

R30

1R

302

R30

3R

304

L351

R113

L161

C1021

C10

22

C1023

R50

1R

502

R50

3

R504

R50

5

CN101

R31

1

R506

R31

2R507

R31

3

R508

R31

4

R50

9

R121

R315

R122

R12

3

R124

R125

IC

R128

R510

R12

9

R321R32

2

R32

3

L371

L181

L182R52

1

IC271

D1021

R52

2R

523

R52

4

C101

R1021

C102

R1022

C104

C105

C106

C107

R720

IC1021

C301

C30

2

C30

3

L1108

C30

4

JA321

C50

1

C50

2C

503

C50

4

C50

5

R54

1

C31

1

R542

C50

6

C312

R543

C50

7

C31

3

R54

4

C50

8

R351

R545

C50

9

C121

R54

6

C12

2

R352

C12

3

R353

R354

R161

R35

R162

R35

6

R163

R357R358

R164

C51

0

C51

1

R16

5

L1121

R359

C51

2

R16

6

R167

C32

1

R360R

171

R17

2

C712

R17

3

R174

L1131

C521

R175

C522

C523

C524

C52

5

C52

6

C527C528C529

R371R372R373

R374 R375

R181

R18

2

R376

R18

3

C530

R184 C531

R185

L1141

C532C533

C534

R571R572

R573R574

C54

1

L1151

C54

2

L115

2

C543

L1153

C544

C351

C545

C35

2

C546

C54

7

C353

C354

C54

8C

549

C161

C162

C16

3 C164

C16

5

C55

0

C551

C552

C553

D111

C17

1

C17

2

C17

3

C174

C372C373

C374

C181

C182

C183

C184

VR161

C

C

C573C574

C575

C576

C577

C578

P291

P292

C580

C581

IC501

D521

L1191

D522

L1192

IC311

IC121

IC

P1121

C1101

C1102

Q261

P1131

C1111

C11

12

1

10 20 30 40 50 60 70X

150

140

130

120

110

100

90

80

70

60

50

40

30

20

10

0

Y F

C CN1901

OPT-OUT

RCA

32647 9 8

1

2

3

DVH-335UB/XNRC1081 2 3 4

C

D

F

A

B

E

1

1

1

1

10

1

51

IC1101

R1111

R11

12

IC1111

71

C25

1

C25

2

C25

3

C25

4

C275

R107

R

IC

3

C50

7

R357

R359

C

R371R373R375

R376

R57R57

34

C351

C551

C552

C55

D111

C373

C57C57

C575

C576

C5

C578

11

C11

12

0

5 6 7 8

A

SIDE A

1

5

1

101

1

1 5

10

1

1

15

10

1520

E

E

1

1

1 510 15 20 25

30 35 40 45 50

55 60 65 70 75

80

85

9

0

95

1

00

1

1E

1

5

1

E

E

1

5251

20

E

15

1015

20

1 5150201

1

E

E

1

1

E

E

1 5 10 15 20

E E

E

1

1

1

1

1 5

10

5 1

10

E

E

1 5 10

1

L641

IC151

R401

R402

R403

R404

R211

L451

D751

R212

L452

D75

2

D753

R601R602

R603

R604

R605

R1101

R606

R607

R608

R221

R609

R22

3

R224

R225

R226

R227

R610

R611

L471

D77

1

L472

D77

2

CN601

R621R622

R623R624

R43

0

C201

R625

R431

C202

R626

R43

2

R627

R433

C204

R628

R434

R629

R43

5

D781

C206

R436

R437

C208

R630R631

R632

R633

R634

C211

R635

C212

R636

C213

R637

C215

IC771

C217

C601

C60

2

C60

3

C604C605

R641

C606

R64

2

C607

R64

3

C221

R451

C222

R452

C223

R453

C224

R454

C225R455

CN821

C801

R457

X601

R651

R65

2R

653

R65

4R

655

R656

R657

C431

R661

L104

1

C432

C43

3

C434

R471

R67

1R

672

R67

3R

674

R67

5R

676

R677

R678

R679

C255

C256

C257

C258

C641

R680

C45

1

R68

1

C45

2

R68

2

C453

R683

C454

R68

4

R685

C45

5

JA471

R686

C262

C456

C457

C65

1

Q111

C65

2

C27

2

C27

3

C274

C661

C471

C472

C473

C474

IC201

C475

D80

1

D80

2

C671

Q131

C672

Q132

C673

L121

L701

IC601

CN1001

D821

D822

C1001

C10

02

R101

R102R103

VA

703

R104

VA

704

L151

C1011

R105

C10

12

R106

C10

13

R108

C1014

R111

R112

113

R114

Q751

R115

R116

Q752

IC641

D661

C10

31

IC1001

C1032

R126

R127

Q1031

D1011

Q1032

D1012

D1013

R13

1

R13

2

R13

3

R13

4

R13

5

IC1011

C10

41

R711

R13

6

C10

42

R71

2R137

R71

3R138

R71

4

R139

U401

Q1041

271

R71

5

R71

6R

717

R718

R331

R719

R332

R14

0

IC661

R141

CN701

R142

R143

C1051

Q781

R72

1

C1052

R72

2

C1053

R723

C1054

R724

Q1051

R72

5

Q1052

R1031

C111

R1032

C112

R151

JA131

R152C

1061

C10

62

Q1061

L781

R542

Q1062

R10

41

JA331

R10

42

C12

2

R10

43

R355

C70

1

CN721

C70

2

C70

3

C70

4

C1071

C70

5R74

1

C1072

R74

2

C706

C1073

R743

R744

Q1071

D10

51

R745Q1072

D1052

R746

Q1073

Q1074

R1051

C131

R10

52

R1053R1054

R1055

C71

1

R1056

712

R751R752R753R754

C331

R755

C332

R756R757

R1061

R10

62

R10

63

R10

64

C72

3

C72

6

D1071

12

C15

1

R1071

C152

R1072

C153

R1073

R1074

R1075

R1076

R771

R78

1

R78

2

3

Q401

Q402

C751

C37

1

P471

D701

D702

C571

S741

C572

34

77

IC111

L601

IC112

L602

C771

C772

D71

2

C773

D71

3

C580

D71

4

L221

D71

5

Q430

Q431

IC122

C78

1

L821

R201

R202

R20

6

80 90 100 110 120 130 140 150 160 170

FRONTB CN1821

POWER SUPPLY

IP-BUS

WIREDREMOTE

ANTENNA

FM

/AM

TU

NE

R U

NIT

P 1121 (A,68,27) Fuse 3 A CEK1286P 1131 (A,54,49) Fuse 3 A CEK1286P 1191 (A,30,29) Fuse 4 A CEK1344

>>>

234

891011

567

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

1

2

3

DVH-335UB/XNRC 1095 6 7 8

C

D

F

A

B

E

1 2 3 4

A

A TUNER AMP UNIT

90100110120130140150160170

1

1

1

1

PCL

TESTIN

1

1

DVH-335UB/XNRC1101 2 3 4

C

D

F

A

B

E

9

5 6 7 8

A

SIDE B

10203040506070800 X

150

140

130

120

110

100

90

80

70

60

50

40

30

20

10

0

Y

1

1

1

1

DVH-335UB/XNRC 1115 6 7 8

C

D

F

A

B

E

1 2 3 4

11.2 KEYBOARD UNIT

B

SIDE AB KEYBOARD UNIT

51

1

1

40

3

5

30

25

20

1

5

10

5

1

CN

1911

JA19

01

D19

13

IC18

02

R18

23

C18

52

C18

53 C18

54

C1855

C18

56

C18

57

C1858

C18

59

C18

60

C1861

C18

62

C1863

C18

65

C18

66

C18

67

C1868

S18

21

S18

22

S18

23

S18

25 S18

26

S18

27S

1828

S18

29D18

51

D18

52

D18

53

D1854

D18

55

D1856

D18

57

S18

30

D1858

S18

31

D18

59S

1832

S18

33S

1834

S18

35S

1836

D1860

S18

38

D1861

S18

39

D1862

D1863

D1864

D1865

D18

66

D1867

S18

40D

1868

S18

41D

1869

S18

42

S18

43

S18

45

D18

70

D18

71

D18

72

D1873

D1874

D18

75

D1876

D1877

D1878

D1879

D1880

D1881

D1882

D1883

R18

83

V18

01

S18

37

S18

24

1020

3040

5060

7080

9010

011

012

013

014

015

0X

40 30 20 10

0

Y

160

US

B

AU

X

LCD

65

43

21

CLO

CK

DO

WN

RIG

HT

UP

LEF

T

LIS

T

EJE

CT S

RC

BA

ND

/ES

C

DIS

P\B

AC

K

MU

LTI-

CO

NT

RO

L

DVH-335UB/XNRC1121 2 3 4

C

D

F

A

B

E

5 6 7 8

B

SIDE BB KEYBOARD UNIT

1020

3040

5060

7080

90100

110120

130140

150

X

40302010

0Y

160

1

515

1

2010

1

1

1 5 10 15

20 25 30

35

4

0

4

5

50 55 60

1

1

X1801

C1901

C1902

C1903

C1904

C1905

R1901

R1902

D1911

D1912

L1801

C1801

C1802

CN

1821

D1801

D1802

R1801

R1802

R1803

R1804

R1805R1806

IC1801

R1821

R1822

R1824

R1825

R1826

Q1851

L1911

C1864

R1851

R1852

R1853

R1854

R1855

R1856

R1858

R1860R1862

R1864

R1866

R1868

R1871

R1872

R1873

R1874

R1875

R1880

R1881

R1882

R1884

R1885

R1888

R1889

R1890

R1891

R1892

R1893

R1894

R1895

R1896

R1897

R1898

R1899

VA1901VA1902

VA1903

VA

1904

1

1

A CN701

DVH-335UB/XNRC 1135 6 7 8

C

D

F

A

B

E

1 2 3 4

11.3 DVD CORE UNIT

C

SIDE AC DVD CORE UNIT

1

5

1

0

1

520

25

30

1 5 10 15 20 25 30 35 40 4550

65 70 75 80 85 90 95 100 105

130 135 140 145 150 155 160

195

2

00

20

5

210

215

6055

125120115110

190

185

180

175

170

165

1 5 10

1520

1 5 10 15

1

1 5 10 15 20

2530

3540

1

1 5 10 15 20 25

E

E

E

E

C15

02

C1503

C15

04

C15

05

C15

06C

1507

C15

09

CN

1901

R1101

C15

11

R1102

R11

03

C15

14

R1104

C15

15

R11

05

C15

16

R11

06

C1517

C15

18

C15

19

R11

09

C15

20

R1110

C15

21

R11

11

C1522

R11

12

C1523

R11

13

C1524

R11

14

R11

15C1526

R11

16

R11

17

C1528

R11

18

C15

29

R15

05

R15

06R

1507

R15

08

R1509

IC15

01

R15

10

R15

12

R1513R

1514

D19

01

D19

02

R1516

R15

17

R15

18

R1519

R15

22

R1523

R1524

R1525

R15

26

R1528

R15

29

R1530R1531

R15

33

R15

34

CN

1951 R15

36

R15

37

R1538

R15

39

R15

40

R1541

R15

42

C1953

R15

47

R19

50

R19

51R

1954

R19

55

R19

56

R19

57

CN

1201

C12

03

C12

04C

1205

C12

07

C1208

C1018

C10

19

C10

22

C1601

C16

02

C1603

C1604

R10

01

C16

05

C16

06

C1607

R10

04

C1608

C16

09

R10

07

R1008

IC10

01

C1610

R1201

C1611

R1202

C1612

R12

03

C16

13

R1204

C1614

C1615C1616

C16

17

C1618

IC12

01

C1619

C1620

C1621

C1622

R12

12

C1623

C1624

R10

21

C1625

C16

26C

1627

R16

01

R10

26

R16

02

R16

03

R10

27

R16

04

R1605

L1512

L190

1C

1671

C16

72

C16

73

C16

74

C16

76

R16

70R

1671

R16

72

R1673

R16

74

R1675

R1679

CN

1101

C11

04

C11

05

Q11

01

Q11

02

C11

06

Q11

03

C11

07

C11

08

Q11

04

C11

09C

1110

C11

11

C15

08

1020

3040

5060

7080

X

50 40 30 20 10

0

Y

PIC

KU

P U

NIT

(S

ER

VIC

E)

AC

N10

1

DC

N70

1

DVH-335UB/XNRC1141 2 3 4

C

D

F

A

B

E

5 6 7 8

C

SIDE BC DVD CORE UNIT

8070

6050

4030

2010

X

50403020100Y

1

1

1

5

1

1

1

1

1

5

1

5

10

15

20

25

30

35

40

45

1

5

10

15

20

25

30

35

40

45

1 5

1015

1

1

5

10

1

5

2

0

2

53035

4045

50

C1501

C1510

C1512

C1513

R1300

R1301

C1525

C1527

R1501

R1503

R1504

L1003

L1004

R1511

EF

1001

EF

1002

C1934

R1527

R1532

R1535

C1950

C1951

C1952

R1543

R1544

C1954

R1546

R1952

R1953

IC1951

C1001

C1003

C1004

C1005C

1006

C1007

C1008

C1009

C1201

C1010

C1011 C

1012

C1013

C1014

C1209

C1015

C1016

C1017

C1401

C1402

C1403

C1404

C1210

C1405

C1211

C1407

C1408

C1409

C1021

X1501

R1002

C1802

IC1002

C1803 IC

1003

C1804

IC1004

IC1005

C1805

C1806

IC1006

C1807

C1808

R1011

C1809

R1015

R1017

R1019

R1401

R1402

R1403

R1405 R

1406

R1213

R1214

R1215

IC1401

R1409

R1216

IC1402

R1217

R1218

R1025

R1222

R1801

R1802

R1803

R1804

IC1801

L1902

L1903

L1904

X1950

C1480

C1481

C1482

C1483

C1484

C1485

C1486

C1487

C1488

C1489

C1490

C1491

C1492

C1493C

1494

R1480

R1481

R1482

R1483

R1484

R1485

R1486

R1487

R1488

IC1480

R1489

R1490

C1101

C1301

C1302

C1112

C1113C

1801

1

DVH-335UB/XNRC 1155 6 7 8

C

D

F

A

B

E

1 2 3 4

11.4 CONNECT PCB

D

SIDE AD CONNECT PCB

1

5

10

15

CN701

10 20 30 40 50X

40

30

20

10

0

Y

M

M1LOAD/CRG

MOTOR

C CN1201

DVH-335UB/XNRC1161 2 3 4

C

D

F

A

B

E

5 6 7 8

D

SIDE BD CONNECT PCB

50 40 30 20 10X

40

30

20

10

0

Y

1

1

1

1 5 10R101

R102

R103

CN101

C101

S101

S102

S103

M2SPINDLE MOTOR

HOME

8SNS

DSCSNS

DVH-335UB/XNRC 1175 6 7 8

C

D

F

A

B

E

1 2 3 4

12. ELECTRICAL PARTS LISTNOTE: Parts whose parts numbers are omitted are subject to being not supplied. The part numbers shown below indicate chip components. Chip Resistor RS1/_S___J,RS1/__S___J Chip Capacitor (except for CQS.....) CKS....., CCS....., CSZS..... The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Meaning of the figures and others in the parentheses in the parts list. Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board. IC 301 (A, 91, 111) IC NJM2068V

Circuit Symbol and No. Part No.

A:DVH-335UB/XNRC

B:DVH-3390UB/XNID

C:DVH-335UB/XNRD

D:DVH-335UB/XNRI

Unit Number : QWM3247(A)

: QWM3250(B)

: QWM3248(C)

: QWM3249(D)

Unit Name : Tuner Amp Unit

Unit Number :

Unit Name : Keyboard Unit

Unit Number : YWX5019

Unit Name : DVD Core Unit

Unit Number :

Unit Name : Connect PCB

AUnit Number : QWM3247(A)

: QWM3250(B): QWM3248(C): QWM3249(D)

Unit Name : Tuner Amp Unit

MISCELLANEOUS

IC 111 (A,89,56) IC TC74VHCT08AFKS1IC 112 (A,89,45) IC TC74VHC08FKIC 122 (A,78,32) IC TC7MBL6126SFKIC 181 (A,24,93) IC NJM2561F1IC 201 (A,100,87) IC PML014B

IC 231 (A,30,109) IC(A,B) NJM4558MD

IC 241 (A,30,115) IC(A,B) NJM4558MDIC 271 (A,77,138) IC PA2030AIC 311 (A,18,126) L-MOS And Gate TC7SET08FUS1IC 601 (A,121,53) IC PEG753A

IC 661 (A,99,58) IC S-80835CNMC-B8UIC 1001 (A,79,28) IC S-1200B33-M5IC 1011 (A,141,45) IC NJM2885DL1-33IC 1021 (A,6,120) IC NJM2388F84IC 1101 (A,72,24) IC R5523N001B

IC 1103 (A,31,56) IC BD9013KVIC 1111 (A,72,31) IC S-1200B33-M5Q 111 (A,77,73) Chip Transistor RN4982Q 112 (A,69,73) Chip Transistor RN1910Q 261 (A,50,124) Chip Transistor RN4983

Q 282 (A,33,123) Chip Transistor RN1910Q 291 (A,46,125) Chip Transistor RN4983Q 292 (A,46,129) Transistor DTC623TUQ 321 (A,12,124) Transistor 2SA1579Q 751 (A,103,119) Chip Transistor HN1C01FU

Q 1041 (A,135,17) Transistor LSA1576UBQ 1051 (A,147,24) Transistor 2SD1858Q 1052 (A,164,29) Chip Transistor RN4983Q 1061 (A,137,12) Transistor LSA1576UBQ 1062 (A,143,11) Transistor LTC114EUB

Q 1151 (A,33,43) FET HAT2210RJQ 1191 (A,33,69) FET HAT2210RJD 701 (A,95,7) Diode DZ2S068CD 702 (A,98,10) Diode DZ2S068CD 712 (A,122,22) Diode DZ2S068C

D 713 (A,119,22) Diode DZ2S068CD 714 (A,120,22) Diode DZ2S068CD 751 (A,96,116) Diode HZU7R5(B3)D 752 (A,99,118) Diode RKZ6.8KG(B2)D 801 (A,117,126) Diode CRG03

D 802 (A,119,126) Diode CRG03D 821 (A,123,123) Diode 1SR154-400D 822 (A,123,127) Diode 1SR154-400D 1021 (A,15,111) Diode CRG03D 1051 (A,161,23) Diode RKZ5.6KG(B2)

D 1052 (A,164,36) Diode CRG03D 1141 (A,44,61) Diode RB551V-30


DVH-335UB/XNRC1181 2 3 4

C

D

F

A

B

E

5 6 7 8

D 1142 (A,41,49) Diode RB551V-30D 1192 (A,60,20) Diode RSX201L-30D 1193 (A,60,24) Diode RSX201L-30

L 101 (A,57,64) Inductor CTF1389L 181 (A,24,98) Inductor LCYC100K2125L 182 (A,47,107) Inductor CTF1547L 221 (A,83,83) Inductor LCTAW2R2J2520L 321 (A,15,125) Inductor CTF1389

L 451 (A,144,61) Inductor LCTAW2R2J3225L 452 (A,145,69) Chip Coil LCTAW100J2520L 471 (A,147,83) Chip Coil LCTAW1R0J2520L 472 (A,158,105) Inductor LCTAW220J2520L 601 (A,137,65) Chip Coil LCTAW100J2520

L 701 (A,91,10) Inductor CTF1713L 821 (A,135,95) Choke Coil 600 uH CTH1280L 1108 (A,46,69) Inductor CTH1253L 1141 (A,28,65) Inductor CTF1661L 1151 (A,30,49) Inductor CTF1661

L 1152 (A,29,45) Inductor CTF1661L 1153 (A,46,42) Inductor CTH1253L 1191 (A,28,67) Inductor CTF1661L 1192 (A,18,47) Inductor CTH1253X 601 (A,121,68) Crystal Resonator 15.000 MHz CSS1774

P 291 (A,37,128) Poly Switch MINISMDC075F/24P 292 (A,53,131) Poly Switch MINISMDC075F/24P 471 (A,163,112) Surge Protector IMSA-6802-

01Y900> P1121 (A,68,27) Fuse 3 A CEK1286> P1131 (A,54,49) Fuse 3 A CEK1286

> P1191 (A,30,29) Fuse 4 A CEK1344VA321 (A,11,126) Varistor EZJZ1V270RMVA322 (A,15,123) Varistor EZJZ1V800AMVA703 (A,111,22) Varistor EZJZ1V270RMVA704 (A,109,22) Varistor EZJZ1V270RM

CN101 (A,65,53) Connector CKS3844CN701 (A,114,3) Connector CKS6288CN821 (A,113,134) Plug CKM1370JA282 (A,35,136) Pin Jack(A,B) CKB1095

(A,35,136) Pin Jack(C,D) CKB1093JA321 (A,13,135) Connector CKS4124

JA471 (A,169,129) Antenna Jack YKS5041FM/AM Tuner Unit CWE2098

RESISTORS

R 101 (A,85,51) RS1/16SS471JR 102 (A,89,39) RS1/16SS102JR 103 (A,87,39) RS1/16SS471JR 104 (A,87,50) RS1/16SS221JR 105 (A,85,50) RS1/16SS221J

R 106 (A,85,60) RS1/16SS471JR 107 (A,73,70) RS1/16SS471JR 108 (A,75,70) RS1/16SS471JR 109 (A,66,73) RS1/16SS0R0JR 111 (A,85,55) RS1/10SR0R0J

R 112 (A,85,43) RS1/10SR0R0JR 113 (A,77,75) RS1/16SS102JR 126 (A,82,33) RS1/16SS0R0JR 127 (A,84,29) RS1/16SS0R0JR 128 (A,59,62) RS1/16SS391J

R 173 (A,14,73) RS1/16SS0R0J

Circuit Symbol and No. Part No.R 174 (A,15,80) RS1/16SS0R0JR 181 (A,26,96) RS1/16SS473JR 182 (A,49,107) RS1/16SS390JR 183 (A,48,107) RS1/16SS330J

R 184 (A,21,89) RS1/16SS3302DR 185 (A,24,87) RS1/16SS6802DR 201 (A,113,86) RS1/16SS0R0JR 202 (A,113,88) RS1/16SS0R0JR 211 (A,87,74) RS1/16SS0R0J

R 212 (A,87,73) RS1/16SS0R0JR 221 (A,109,83) RAB4C102JR 224 (A,108,87) RS1/16SS101JR 225 (A,93,90) RS1/16SS101JR 226 (A,108,85) RS1/16SS101J

R 227 (A,93,88) RS1/16SS101JR 233 (A,22,122) (A,B) RS1/16SS123JR 234 (A,22,113) (A,B) RS1/16SS223JR 235 (A,22,120) (A,B) RS1/16SS223JR 236 (A,26,111) (A,B) RS1/16SS223J

R 237 (A,25,104) (A,B) RS1/16SS223JR 238 (A,36,107) (A,B) RS1/16SS123JR 239 (A,36,108) (A,B) RS1/16SS103JR 240 (A,21,114) (A,B) RS1/16SS562JR 241 (A,24,121) (A,B) RS1/16SS223J

R 242 (A,23,121) (A,B) RS1/16SS223JR 243 (A,27,119) (A,B) RS1/16SS223JR 244 (A,24,122) (A,B) RS1/16SS123JR 245 (A,25,114) (A,B) RS1/16SS223JR 246 (A,25,121) (A,B) RS1/16SS562J


R 284 (A,36,122) RS1/16SS821JR 287 (A,32,126) RS1/16SS223JR 288 (A,33,127) RS1/16SS223JR 291 (A,48,123) RS1/10SR102JR 292 (A,44,129) RS1/16SS0R0J

R 295 (A,29,130) (A,B) RS1/16SS103JR 298 (A,25,130) (A,B) RS1/16SS103JR 299 (A,42,129) RS1/16SS0R0JR 301 (A,19,130) RS1/16SS0R0JR 303 (A,22,130) (A,B) RS1/16SS0R0J

R 311 (A,20,123) RS1/16SS0R0JR 312 (A,20,125) RS1/16SS621JR 313 (A,20,126) RS1/16SS473JR 314 (A,17,122) RS1/16SS0R0JR 315 (A,15,127) RS1/16SS121J

R 322 (A,9,125) RS1/16SS104JR 323 (A,13,127) RS1/16SS103JR 436 (A,157,77) RS1/16SS0R0JR 437 (A,157,73) RS1/16SS0R0JR 451 (A,157,66) RS1/16SS681J


R 601 (A,131,62) RS1/16SS104J


DVH-335UB/XNRC 1195 6 7 8

C

D

F

A

B

E

1 2 3 4

R 602 (A,129,63) RS1/16SS104JR 603 (A,129,65) RS1/16SS472JR 604 (A,123,64) RS1/16SS0R0JR 605 (A,115,66) RS1/16SS473J





R 654 (A,129,41) RS1/16SS681JR 655 (A,128,41) RS1/16SS471JR 661 (A,105,59) RS1/16SS474JR 671 (A,130,38) RS1/16SS473JR 673 (A,131,38) (A,C) RS1/16SS473JR 674 (A,131,41) (B,D) RS1/16SS473J

R 675 (A,132,38) (A,D) RS1/16SS473JR 676 (A,132,41) (B,C) RS1/16SS473JR 679 (A,133,54) RS1/16SS471JR 680 (A,130,37) RS1/16SS473JR 681 (A,135,56) RS1/16SS104JR 682 (A,134,56) RS1/16SS103J


R 715 (A,105,28) RS1/16SS222JR 716 (A,83,28) RS1/16SS0R0JR 717 (A,84,28) RS1/16SS0R0JR 718 (A,127,28) RS1/16SS222JR 719 (A,128,30) RS1/16SS222J

R 720 (A,61,103) RS1/16SS0R0JR 721 (A,86,30) RS1/16SS0R0JR 722 (A,87,30) RS1/16SS0R0JR 723 (A,86,28) RS1/16SS223JR 724 (A,87,29) RS1/16SS223J




R 1051 (A,162,23) RS1/16SS223JR 1052 (A,165,24) RS1/4SA222JR 1053 (A,165,31) RS1/16SS390JR 1054 (A,164,31) RS1/16SS390JR 1055 (A,165,32) RS1/16SS390J

R 1056 (A,164,32) RS1/16SS390JR 1062 (A,141,11) RS1/16SS472JR 1063 (A,140,11) RS1/10SR103JR 1064 (A,134,9) RS1/10SR104JR 1101 (A,80,23) RS1/16SS104J

R 1112 (A,74,34) RS1/16SS0R0JR 1141 (A,25,63) RS1/8SQ100JR 1142 (A,27,45) RS1/8SQ100JR 1161 (A,37,49) RS1/8SQ2R2JR 1162 (A,45,49) RS1/10SR0R0J

R 1164 (A,45,52) RS1/16SS4702DR 1165 (A,43,53) RS1/16SS6801DR 1166 (A,42,54) RS1/16SS1002FR 1167 (A,42,51) RS1/16SS223JR 1171 (A,39,54) RS1/16SS0R0J

R 1172 (A,39,55) RS1/16SS0R0JR 1173 (A,39,56) RS1/16SS823JR 1174 (A,39,58) RS1/16SS471JR 1181 (A,41,59) RS1/16SS303JR 1182 (A,42,57) RS1/16SS9101D

R 1183 (A,43,56) RS1/16SS0R0JR 1184 (A,43,54) RS1/16SS8202DR 1187 (A,46,55) RS1/10SR0R0JR 1188 (A,38,66) RS1/8SQ2R2JR 1189 (A,26,49) RS1/10SR103J

R 1190 (A,26,63) RS1/10SR103JR 1191 (A,45,59) RS1/10SR102J

CAPACITORS

C 101 (A,58,42) CKSSYB104K16C 102 (A,69,34) CKSSYB104K10C 104 (A,69,33) CKSQYB475K6R3C 106 (A,59,47) 4.7 uF CCG1201C 111 (A,85,58) CKSSYB104K10

C 112 (A,85,46) CKSSYB104K10C 122 (A,77,27) CKSSYB104K10C 173 (A,13,80) CKSSYB102K50C 174 (A,17,92) CEJQ470M6R3C 181 (A,17,97) CEJQ220M10

C 182 (A,15,85) CEJQ331M6R3C 183 (A,24,89) CKSSYB104K10C 184 (A,19,80) CEJQ330M10C 201 (A,111,85) CKSRYB105K10C 202 (A,111,87) CKSRYB105K10

C 204 (A,109,88) CKSRYB105K10C 206 (A,109,89) CKSRYB105K10C 208 (A,109,91) CKSRYB224K16C 211 (A,92,94) CKSRYB224K16C 212 (A,91,90) CKSRYB105K10

C 213 (A,92,93) CKSRYB105K10C 215 (A,92,91) CKSRYB105K10C 217 (A,87,91) CKSRYB105K10C 221 (A,87,81) CEJQ100M16C 222 (A,87,87) CEJQ470M16


DVH-335UB/XNRC1201 2 3 4

C

D

F

A

B

E

5 6 7 8

C 223 (A,92,84) CKSSYB104K16C 231 (A,25,107) (A,B) CKSYB225K25C 232 (A,23,110) (A,B) CKSYB225K25C 233 (A,25,111) (A,B) CCSSCH101J50C 234 (A,29,101) (A,B) CEJQ100M16

C 241 (A,25,117) (A,B) CKSYB225K25C 242 (A,23,117) (A,B) CKSYB225K25C 243 (A,28,119) (A,B) CCSSCH101J50C 251 (A,75,124) CKSRYB474K10C 252 (A,73,124) CKSRYB474K10

C 253 (A,75,127) CKSQYB474K16C 254 (A,73,127) CKSQYB474K16C 255 (A,86,122) CKSRYB474K10C 256 (A,86,117) CKSRYB474K10C 257 (A,88,122) CKSQYB474K16

C 258 (A,84,120) CKSQYB474K16C 261 (A,66,125) CEJQ330M10C 262 (A,118,116) 3 300 uF/16 V CCH1486C 263 (A,63,128) CKSSYB104K16C 271 (A,69,130) 10 uF DCH1165

C 272 (A,78,125) CKSYB475K16C 273 (A,81,123) CKSYB475K16C 274 (A,117,122) CKSSYB473K16C 275 (A,73,130) CCSSCH100D50C 283 (A,35,97) CEJQ2R2M50

C 284 (A,40,96) CEJQ2R2M50C 287 (A,32,127) CKSSYB102K50C 288 (A,33,126) CKSSYB102K50C 311 (A,21,125) CCSSCH150J50C 312 (A,18,124) CKSQYB106K6R3

C 313 (A,19,122) CKSSYB104K10C 451 (A,155,59) CKSYB475K16C 452 (A,157,60) CKSSYB103K16C 453 (A,151,61) CEJQ470M6R3C 454 (A,157,68) CKSSYB102K50

C 456 (A,149,67) CEJQ470M6R3C 471 (A,154,91) CKSSYB103K16C 472 (A,152,87) CEJQ101M16C 473 (A,157,85) CCSSCH330J50C 475 (A,155,70) CKSSYB102K50

C 602 (A,135,62) CKSSYB103K16C 603 (A,136,62) CKSRYB105K10C 605 (A,123,65) CCSSCH200J50C 606 (A,121,65) CCSSCH200J50C 607 (A,107,64) CCSSCH101J50

C 661 (A,102,60) CKSSYB104K10C 701 (A,114,22) CCSRCH221J50C 702 (A,116,22) CCSRCH221J50C 703 (A,106,22) CCSRCH221J50C 704 (A,107,22) CCSRCH221J50

C 705 (A,129,24) CCSRCH221J50C 711 (A,118,22) CKSRYB104K16C 751 (A,100,121) CKSRYB104K16C 801 (A,121,129) CKSRYB104K16C 1001 (A,81,25) CKSSYB224K6R3

C 1002 (A,82,27) CKSSYB224K6R3C 1011 (A,144,57) CKSQYB225K10C 1013 (A,146,42) CKSYB106K10C 1014 (A,154,42) CEJQ101M10C 1021 (A,17,104) CEJQ101M10


C 1022 (A,21,101) CKSSYB103K16C 1023 (A,15,117) CEJQ101M16C 1042 (A,134,19) CKSSYB102K50C 1051 (A,151,16) CKSSYB103K16C 1052 (A,139,22) CEJQ101M16

C 1053 (A,162,24) CKSSYB103K16C 1054 (A,152,32) CEAT102M16C 1061 (A,132,9) CKSRYB104K16C 1062 (A,136,9) CKSRYB104K16C 1101 (A,69,25) CKSSYB105K6R3

C 1102 (A,69,22) CKSRYB105K10C 1111 (A,72,28) CKSSYB224K6R3C 1112 (A,73,34) CKSSYB224K6R3C 1121 (A,65,31) 10 uF CCG1236C 1122 (A,67,31) CKSSYB104K10

C 1131 (A,55,56) 10 uF CCG1236C 1132 (A,56,53) CKSSYB104K10C 1141 (A,28,63) CKSRYB333K50C 1142 (A,20,62) CKSYB105K35C 1143 (A,30,36) 10 uF CCG1236

C 1144 (A,27,71) 10 uF CCG1236C 1145 (A,27,49) CKSRYB333K50C 1154 (A,52,31) CEHAZL331M16C 1161 (A,39,46) CKSQYB335K10C 1163 (A,41,51) CCSSCH221J50

C 1164 (A,41,53) CKSSYB473K16C 1165 (A,38,52) CKSSYB103K16C 1181 (A,38,61) CKSSYB103K16C 1182 (A,41,61) CKSSYB473K16C 1183 (A,42,59) CCSSCH221J50

C 1184 (A,38,63) CKSYB105K35C 1185 (A,31,63) CKSQYB335K10C 1191 (A,40,79) CEHAZL331M16C 1195 (A,54,20) 3 300 uF/16 V CCH1486C 1196 (A,20,55) 10 uF CCG1236

C 1197 (A,20,58) CKSYB105K35C 1198 (A,19,36) CKSYB105K35

BUnit Number :Unit Name : Keyboard Unit

MISCELLANEOUS

IC 1801 (B,87,23) IC PD6497AIC 1802 (A,160,35) Remote IC GP1UXC14RKD 1801 (B,68,22) Diode MC2848-11D 1802 (B,71,20) Diode MC2846-11D 1851 (A,11,40) LED CL-197HB1-D(CDE)

D 1852 (A,6,33) LED CL-197HB1-D(CDE)D 1853 (A,6,23) LED CL-197HB1-D(CDE)D 1854 (A,72,5) LED CL-197HB1-D(CDE)D 1856 (A,55,29) LED CL-197HB1-D(CDE)D 1857 (A,59,20) LED CL-197HB1-D(CDE)



DVH-335UB/XNRC 1215 6 7 8

C

D

F

A

B

E

1 2 3 4


D 1911 (B,148,23) Diode DZ2S068CD 1912 (B,148,21) Diode DZ2S068CD 1913 (A,68,22) White LED SMLXA4WBETW1(Z1)X 1801 (B,76,22) Ceramic Resonator 5.00 MHz CSS1547S 1845 (A,39,18) Encoder(MULTI-CONTROL) CSD1168

VA1901 (B,139,9) Varistor EZJZ1V270RMVA1902 (B,137,9) Varistor EZJZ1V270RMVA1903 (B,132,5) Varistor EZJZ1V270RMCN1821 (B,108,9) Connector CKS6287CN1911 (A,154,22) Connector CKS6267

JA1901 (A,153,7) Jack CKN1082V 1801 (A,143,32) LCD CAW2009

RESISTORS

R 1804 (B,146,29) RS1/10SR101JR 1805 (B,74,18) RS1/10SR222JR 1806 (B,72,15) RS1/10SR222JR 1822 (B,54,27) RS1/10SR103JR 1852 (B,39,8) RS1/4SA102J

R 1858 (B,13,9) RS1/10SR222JR 1860 (B,23,16) RS1/4SA102JR 1862 (B,22,11) RS1/10SR222JR 1864 (B,49,6) RS1/10SR222JR 1866 (B,141,15) RS1/10SR222J

R 1880 (B,61,13) RS1/4SA271JR 1881 (B,19,19) RS1/10SR0R0JR 1889 (B,54,26) RS1/10SR0R0JR 1899 (B,55,21) RS1/4SA271J

CAPACITORS

C 1801 (B,149,33) 10 uF CCG1192C 1802 (B,97,24) CKSRYB105K10C 1901 (B,134,7) CKSRYB472K50C 1902 (B,136,7) CKSRYB472K50

CUnit Number : YWX5019Unit Name : DVD Core Unit

MISCELLANEOUS

IC 1002 (B,21,41) Regulator IC S-1133B50-U5IC 1003 (B,35,23) IC S-1200B50-M5IC 1004 (B,25,11) IC NJM2885DL1-33IC 1005 (B,19,21) IC R1232D121BIC 1201 (A,15,29) IC BD8231EFV

*IC1401 (B,63,36) Flash ROM Unit CWW2689*IC1402 (B,50,36) Flash ROM Unit CWW2690IC 1480 (B,59,13) SDRAM(64M) IS42S16400F-7TLIC 1501 (A,60,20) IC MN2DS0018MAIC 1801 (B,37,16) D/A Converter PCM1753DBQ

IC 1951 (B,76,32) Logic IC TC7SZU04FUQ 1101 (A,35,39) Transistor 2SC4081Q 1102 (A,46,42) Transistor 2SC4081

Circuit Symbol and No. Part No.Q 1103 (A,38,45) Transistor 2SB1132Q 1104 (A,45,49) Transistor 2SB1132

L 1003 (B,22,26) Inductor CTF1677L 1004 (B,14,17) Inductor CTF1678L 1512 (A,57,5) Inductor CTF1743L 1902 (B,5,8) Inductor CTF1487L 1903 (B,12,11) Inductor CTF1558

L 1904 (B,46,19) Inductor CTF1473X 1501 (B,43,7) Oscillator 27.000 MHz CSS1768X 1950 (B,76,35) Oscillator 48.000 MHz CSS1760EF1001 (B,5,12) Chip EMI Filter DTF1106EF1002 (B,11,13) Chip EMI Filter DTL1106

RESISTORS

R 1002 (B,18,27) RS1/16SS101JR 1004 (A,29,27) RS1/16SS4702DR 1007 (A,29,26) RS1/16SS6801DR 1019 (B,15,9) RS1/16SS101JR 1021 (A,27,15) RS1/16SS0R0J

R 1025 (B,19,11) RS1/16SS101JR 1027 (A,27,19) RS1/16SS101JR 1101 (A,35,36) RS1/16SS104JR 1102 (A,43,42) RS1/16SS104JR 1103 (A,34,41) RS1/16SS391J

R 1104 (A,36,36) RS1/16SS511JR 1105 (A,42,44) RS1/16SS391JR 1106 (A,45,39) RS1/16SS561JR 1109 (A,34,43) RS1/16SS3R3JR 1110 (A,41,43) RS1/16SS3R3J

R 1111 (A,38,39) RS1/10SR1R5JR 1112 (A,38,38) RS1/10SR1R5JR 1113 (A,49,46) RS1/10SR1R5JR 1114 (A,48,46) RS1/10SR1R5JR 1115 (A,41,38) RS1/10SR1R5J

R 1116 (A,41,39) RS1/10SR1R5JR 1117 (A,48,43) RS1/10SR1R5JR 1118 (A,49,43) RS1/10SR1R5JR 1201 (A,16,36) RS1/16SS221JR 1202 (A,17,35) RS1/16SS221J

R 1203 (A,22,35) RS1/16SS103JR 1204 (A,19,35) RS1/16SS153JR 1212 (A,7,36) RS1/16SS271JR 1213 (B,8,29) RS1/16SS1R0JR 1214 (B,8,27) RS1/16SS1R0J

R 1215 (B,8,28) RS1/16SS1R0JR 1216 (B,8,24) RS1/16SS1R0JR 1217 (B,8,25) RS1/16SS1R0JR 1218 (B,8,26) RS1/16SS1R0JR 1222 (B,26,39) RS1/16SS271J

R 1300 (B,39,24) RS1/16SS0R0JR 1401 (B,63,49) RS1/16SS221JR 1402 (B,70,27) RS1/16SS104JR 1405 (B,56,24) RS1/16SS104JR 1406 (B,54,25) RS1/16SS104J

R 1480 (B,52,21) RAB4CQ560JR 1481 (B,56,21) RAB4CQ560JR 1482 (B,61,21) RAB4CQ560JR 1483 (B,64,21) RAB4CQ560JR 1484 (B,67,21) RAB4CQ560J


DVH-335UB/XNRC1221 2 3 4

C

D

F

A

B

E

5 6 7 8

R 1485 (B,50,5) RAB4CQ560JR 1486 (B,55,5) RAB4CQ560JR 1487 (B,64,5) RAB4CQ560JR 1488 (B,68,5) RAB4CQ560JR 1489 (B,59,5) RS1/16SS560J

R 1490 (B,50,21) RS1/16SS560JR 1501 (B,46,7) RS1/16SS122JR 1503 (B,45,8) RS1/16SS105JR 1504 (B,45,13) RS1/16SS120JR 1505 (A,43,13) RS1/16SS101J


R 1511 (B,46,13) RS1/16S0R0JR 1512 (A,58,5) RS1/16SS101JR 1513 (A,66,35) RS1/16SS103JR 1514 (A,68,35) RS1/16SS183JR 1516 (A,65,36) RS1/16SS103J


R 1524 (A,64,37) RS1/16SS472JR 1525 (A,71,34) RS1/16SS103JR 1526 (A,67,34) RS1/16SS103JR 1527 (B,77,29) RS1/16SS682JR 1528 (A,78,20) RS1/16SS103J

R 1529 (A,76,18) RS1/16SS103JR 1530 (A,77,20) RS1/16SS103JR 1531 (A,75,24) RS1/16SS103JR 1532 (B,70,33) RS1/16SS101JR 1534 (A,78,30) RS1/16SS221J

R 1535 (B,70,34) RS1/16SS104JR 1536 (A,78,31) RS1/16SS104JR 1537 (A,73,35) RS1/16SS104JR 1538 (A,61,4) RS1/16SS104JR 1539 (A,77,23) RS1/16SS104J

R 1540 (A,73,32) RS1/16SS221JR 1541 (A,75,32) RS1/16SS221JR 1542 (A,77,29) RS1/16SS103JR 1543 (B,75,28) RS1/16SS181JR 1544 (B,77,28) RS1/16SS181J

R 1546 (B,75,29) RS1/16SS682JR 1601 (A,42,25) RS1/16SS123JR 1602 (A,44,25) RS1/16SS123JR 1603 (A,43,30) RN1/16SE1002DR 1604 (A,50,35) RS1/16SS105J

R 1605 (A,49,37) RS1/16SS105JR 1670 (A,34,21) RS1/16SS1002DR 1671 (A,36,21) RS1/16SS2402DR 1672 (A,45,19) RS1/16SS2000DR 1674 (A,45,20) RS1/16SS3002D

R 1801 (B,35,6) RS1/16SS104JR 1802 (B,33,6) RS1/16SS104JR 1803 (B,35,11) RS1/16SS821JR 1804 (B,34,11) RS1/16SS821JR 1950 (A,42,16) RS1/16S24R0F

Circuit Symbol and No. Part No.R 1951 (A,42,18) RS1/16S24R0FR 1952 (B,78,34) RS1/16SS105JR 1953 (B,74,34) RS1/16SS681JR 1954 (A,35,17) RS1/16SS153JR 1955 (A,40,14) RS1/16SS153J

R 1956 (A,40,18) RS1/16SS0R0JR 1957 (A,40,15) RS1/16SS0R0J

CAPACITORS

C 1001 (B,36,21) CKSRYB105K10C 1003 (B,18,44) CKSSYB104K16C 1004 (B,24,40) CKSQYB475K10C 1005 (B,32,23) CKSRYB105K16C 1008 (B,20,31) 10 uF DCH1201

C 1009 (B,18,31) 10 uF DCH1201C 1010 (B,26,18) CKSQYB225K10C 1011 (B,22,18) CKSRYB105K10C 1013 (B,15,25) 10 uF DCH1201C 1014 (B,13,25) 10 uF DCH1201

C 1015 (B,7,8) CKSSYB102K50C 1016 (B,12,10) CKSSYB102K50C 1018 (A,28,28) CKSSYB104K10C 1019 (A,10,17) CKSSYB104K10C 1021 (B,34,4) CCSRCH681J50

C 1022 (A,23,21) CCSRCH681J50C 1101 (B,31,40) 10 uF DCH1201C 1104 (A,34,42) CKSSYB104K10C 1105 (A,42,45) CKSSYB104K10C 1106 (A,37,48) CKSSYB103K16

C 1107 (A,41,49) CKSSYB103K16C 1108 (A,74,42) CKSSYB103K16C 1109 (A,56,41) CKSRYB224K16C 1110 (A,71,42) CKSSYB103K16C 1111 (A,61,39) CKSRYB224K16

C 1112 (B,40,39) 22 uF CCG1178C 1113 (B,36,38) 22 uF CCG1178C 1201 (B,12,34) CEVW101M16C 1204 (A,8,24) CKSSYB222K50C 1205 (A,13,23) CKSSYB104K16

C 1207 (A,22,25) CKSSYB104K16C 1208 (A,15,36) CKSSYB103K16C 1209 (B,10,25) CKSSYB104K16C 1210 (B,6,23) CKSSYB104K16C 1211 (B,9,22) CKSYB475K16

C 1401 (B,63,48) CKSSYB103K16C 1403 (B,69,23) CKSSYB104K10C 1404 (B,58,25) CKSQYB475K6R3C 1408 (B,47,25) CKSSYB104K10C 1409 (B,47,23) CKSQYB475K6R3

C 1480 (B,47,21) CKSSYB104K10C 1481 (B,49,23) CKSSYB104K10C 1482 (B,54,21) CKSSYB104K10C 1484 (B,59,20) CKSSYB104K10C 1485 (B,69,21) CKSSYB104K10

C 1487 (B,58,4) CKSSYB104K10C 1488 (B,52,5) CKSSYB104K10C 1489 (B,45,20) CKSQYB106K6R3C 1490 (B,45,23) CKSSYB102K50C 1501 (B,72,9) CKSQYB106K6R3


DVH-335UB/XNRC 1235 6 7 8

C

D

F

A

B

E

1 2 3 4

C 1502 (A,35,32) CKSQYB106K6R3C 1503 (A,60,4) CKSSYB104K10C 1504 (A,51,5) CKSSYB104K10C 1505 (A,53,5) CKSSYB104K10C 1506 (A,55,5) CKSSYB104K10

C 1507 (A,62,5) CKSSYB104K10C 1508 (A,66,5) CKSSYB104K10C 1509 (A,69,5) CKSSYB104K10C 1510 (B,46,5) CCSSCH120J50C 1511 (A,46,9) CKSSYB104K10

C 1512 (B,43,10) CCSSCH100D50C 1513 (B,74,12) CKSSYB104K10C 1514 (A,46,13) CKSSYB104K10C 1515 (A,45,15) CKSSYB104K10C 1516 (A,75,15) CKSSYB104K10

C 1517 (A,74,16) CKSSYB104K10C 1518 (A,75,22) CKSSYB104K10C 1519 (A,74,26) CKSSYB104K10C 1520 (A,75,30) CKSSYB104K10C 1521 (A,60,37) CKSSYB104K10

C 1522 (A,65,34) CKSSYB104K10C 1523 (A,68,37) CKSSYB104K10C 1524 (A,69,37) CKSSYB473K16C 1526 (A,68,37) CKSSYB103K16C 1528 (A,78,29) CCSSCH471J50

C 1601 (A,44,29) CKSSYB103K16C 1602 (A,42,24) CCSSCH101J50C 1603 (A,44,27) CCSSCH101J50C 1604 (A,41,27) CCSSCH680J50C 1605 (A,43,27) CCSSCH680J50

C 1606 (A,41,23) CKSSYB104K10C 1607 (A,41,35) CKSQYB106K6R3C 1608 (A,43,36) CKSRYB105K10C 1609 (A,48,35) CKSSYB104K10C 1610 (A,50,37) CKSSYB104K10

C 1611 (A,51,37) CKSSYB104K10C 1612 (A,52,34) CKSSYB104K10C 1613 (A,52,37) CKSSYB104K10C 1614 (A,53,34) CKSSYB104K10C 1615 (A,54,34) CKSSYB104K10

C 1616 (A,54,37) CKSSYB104K10C 1617 (A,54,38) CKSSYB104K10C 1618 (A,56,34) CCSSCH101J50C 1619 (A,57,34) CKSSYB562K25C 1620 (A,58,34) CKSSYB224K6R3

C 1621 (A,57,37) CKSSYB224K6R3C 1622 (A,59,35) CKSSYB333K16C 1623 (A,45,35) CKSRYB105K10C 1624 (A,58,37) CKSSYB104K10C 1625 (A,56,37) CKSSYB104K10

C 1671 (A,44,17) CKSSYB104K10C 1672 (A,45,18) CKSSYB104K10C 1673 (A,45,22) CKSSYB104K10C 1674 (A,43,21) CKSSYB104K10C 1676 (A,38,22) CKSRYB105K10

C 1801 (B,34,8) CKSQYB475K6R3C 1802 (B,32,8) CKSQYB475K6R3C 1803 (B,36,8) CCSRCH182J50C 1804 (B,31,7) CCSRCH182J50C 1805 (B,32,19) CKSSYB104K10

Circuit Symbol and No. Part No.C 1806 (B,39,9) 10 uF DCH1201C 1809 (B,43,16) CKSSYB104K10C 1934 (B,42,29) CCSRCH680J50C 1950 (B,73,33) CKSSYB104K10C 1951 (B,74,36) CCSSCH100D50

C 1952 (B,78,36) CCSSCH100D50C 1954 (B,43,49) CCSRCH470J50

DUnit Number :Unit Name : Connect PCB

MISCELLANEOUS

S 101 (B,51,37) Switch(HOME) CSN1068S 102 (B,12,23) Switch(DSCSNS) CSN1068S 103 (B,22,10) Switch(8SNS) CSN1068R 101 (B,52,27) RS1/16S101JR 102 (B,15,29) RS1/16S101J

R 103 (B,16,11) RS1/16S101JC 101 (B,51,23) CKSRYB104K50

Miscellaneous Parts List

Pickup Unit(Service) CXX2398M 1 Motor Unit(LOAD/CRG) CXC4026M 2 Motor(SPINDLE) EXM1050


DVH-335UB/XNRC1241 2 3 4

Documents

Pioneer Dvh 335u,Dvh 3390ub