Upload
rolandas1970
View
202
Download
3
Tags:
Embed Size (px)
Citation preview
Published by SaS/WS 1065 BU TV Consumer Care, the Netherlands Subject to modification EN 3122 785 18842
2010-Jun-25
©Copyright 2010 Koninklijke Philips Electronics N.V.All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips.
Colour Television Chassis
TPM5.2ELA
18840_000_100322.eps 100322
Contents Page1. Revision List 22. Technical Specifications, Connections 23. Precautions, Notes, and Abbreviation List 54. Mechanical Instructions 95. Service Modes, Error Codes, and Fault Finding 146. Alignments 197. Circuit Descriptions 228. IC Data Sheets 259. Block Diagrams
Wiring Diagram 19", 22" 31Wiring Diagram 26" 32Block Diagram 33
10. Circuit Diagrams and PWB Layouts Drawing PWBPower Board: 19", 22" (A01) 34 35-36Power Board: 26" (A01) 37 38-39SSB: Power-1 (B01) 40 53-54SSB: Power-2 (B02) 41 53-54SSB: Tuner (B03) 42 53-54SSB: MT5363 By-pass/Trap (B04) 43 53-54SSB: MT5363 peripheral/USB2.0 (B05) 44 53-54SSB: DDR2 memory (B06) 45 53-54SSB: Flash/JTAG/UART/IR (B07) 46 53-54SSB: CI card (B08) 47 53-54SSB: Scart1/Scart2 (B09) 48 53-54SSB: YPbPr/VGA input (B10) 49 53-54SSB: HDMI 1/ HDMI 2 (B11) 50 53-54SSB: Audio Amp/Headphone out (B12) 51 53-54SSB: LVDS output (B13) 52 53-54IR/LED Board (J) 55 56
11. Styling SheetsStyling Sheet 19" 57Styling Sheet 22" 58Styling Sheet 26" 59
Revision ListEN 2 TPM5.2E LA1.
2010-Jun-25
1. Revision List
Manual xxxx xxx xxxx.0• First release.Manual xxxx xxx xxxx.1• Chapter 6: Corrected the panel codes in Table 6-3 for
26PFL3405H/12_2 and 26PFL3405H/05_1.
Manual xxxx xxx xxxx.2• Chapter 2: Add the models in Table 2-1 for
22PFL3415H/12_1, 22PFL3415H/60_1, 19HFL3232D/10_1, 22HFL3232D/10_1 and 26HFL3232D/10_1.
• Chapter 6: Add the panel codes in Table 6-3 for 22PFL3415H/12_1, 22PFL3415H/60_1, 19HFL3232D/10_1, 22HFL3232D/10_1 and 26HFL3232D/10_1.
• Chapter 6: Deleted the “LCD Panel Flicker Adjustment”.
2. Technical Specifications, Connections
Index of this chapter:2.1 Technical Specifications2.2 Directions for Use2.3 Connections2.4 Chassis Overview
Notes:• Figures can deviate due to the different set executions.• Specifications are indicative (subject to change).
2.1 Technical Specifications
For on-line product support please use the links in. Here is product information available, as well as getting started, user manuals, frequently asked questions and software & drivers.
Table 2-1 Described Model Numbers
Note: The given Model Numbers are subject to change.
2.2 Directions for Use
Directions for use can be downloaded from the following websites:http://www.philips.com/supporthttp://www.p4c.philips.com
Model Number Styling Published in
19HFL3232D/10 PICO 3122 785 18842
19PFL3405H/12 PICO 3122 785 18840
19PFL3405H/05 PICO 3122 785 18840
22HFL3232D/10 PICO 3122 785 18842
22PFL3405H/12 PICO 3122 785 18840
22PFL3405H/05 PICO 3122 785 18840
22PFL3415H/12 PICO 3122 785 18842
22PFL3415H/60 PICO 3122 785 18842
26HFL3232D/10 PICO 3122 785 18842
26PFL3405H/05 PICO 3122 785 18840
26PFL3405H/12 PICO 3122 785 18840
Technical Specifications, Connections EN 3TPM5.2E LA 2.
2010-Jun-25
2.3 Connections
Figure 2-1 Connection overview
Note: The following connector colour abbreviations are used (acc. to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green, Gy= Grey, Rd= Red, Wh= White, Ye= Yellow.
2.3.1 Side Connections
1 - Common Interface68p- See diagram B08
SSB: CI card. ��
2 - Cinch: Audio - InYe - Video CVBS 1 VPP / 75 ٠��Rd - Audio R 0.5 VRMS / 10 k٠��
Wh - Audio L 0.5 VRMS / 10 k٠��
3 - USB2.0
Figure 2-2 USB (type A)
1 - +5V �
2 - Data (-) ��3 - Data (+) ��
4 - Ground Gnd �
4 - Head phone (Output)Bk - Head phone 80 - 600 ٠/ 10 mW ��
1
6
2
3
4
5
7
8 9 11 12
10 13
18840_001_100323.eps100428
1 2 3 4
10000_022_090121.eps090121
Technical Specifications, ConnectionsEN 4 TPM5.2E LA2.
2010-Jun-25
5 - HDMI: Digital Video, Digital Audio - In
Figure 2-3 HDMI (type A) connector
1 - D2+ Data channel �2 - Shield Gnd �
3 - D2- Data channel �
4 - D1+ Data channel �5 - Shield Gnd �
6 - D1- Data channel �
7 - D0+ Data channel �
8 - Shield Gnd �9 - D0- Data channel �
10 - CLK+ Data channel �
11 - Shield Gnd �12 - CLK- Data channel �
13 - n.c. 14 - n.c. 15 - DDC_SCL DDC clock �
16 - DDC_SDA DDC data ��
17 - Ground Gnd �18 - +5V �
19 - HPD Hot Plug Detect �
20 - Ground Gnd �
2.3.2 Rear Connections
6 - HDMI 1: Digital Video, Digital Audio - InSee 5 - HDMI: Digital Video, Digital Audio - In.
7 - EXT2: Video YPbPr - In, Audio - InGn - Video - Y 1 VPP / 75 W ��
Bu - Video - Pb 0.7 VPP / 75 W ��Rd - Video - Pr 0.7 VPP / 75 W ��
Wh - Audio - L 0.5 VRMS / 10 kW ��
Rd - Audio - R 0.5 VRMS / 10 kW ��
8 - TV ANTENNA - InSignal input from an antenna, cable or satellite.
9 - EXT1: Video RGB/YC - In, CVBS - In/Out, Audio - In/Out
Figure 2-4 SCART connector
1 - Audio R 0.5 VRMS / 1 kΩ �
2 - Audio R 0.5 VRMS / 10 kΩ �
3 - Audio L 0.5 VRMS / 1 kΩ �
4 - Ground Audio Gnd �
5 - Ground Blue Gnd �6 - Audio L 0.5 VRMS / 10 kΩ �
7 - Video Blue/C-out 0.7 VPP / 75 ٠��
8 - Function Select 0 - 2 V: INT4.5 - 7 V: EXT 16:99.5 - 12 V: EXT 4:3 �
9 - Ground Green Gnd �10 - n.c. 11 - Video Green 0.7 VPP / 75 Ω �
12 - n.c. 13 - Ground Red Gnd �
14 - Ground P50 Gnd �
15 - Video Red/C 0.7 VPP / 75 Ω �16 - Status/FBL 0 - 0.4 V: INT
1 - 3 V: EXT / 75 Ω �
17 - Ground Video Gnd �18 - Ground FBL Gnd �
19 - Video CVBS 1 VPP / 75 Ω �
20 - Video CVBS/Y 1 VPP / 75 Ω �21 - Shield Gnd �
10 - Cinch: S/PDIF - OutBk - Coaxial 0.4 - 0.6VPP / 75 ohm ��
11 - PC IN:VGA
Figure 2-5 VGA connector
1 - Video Red 0.7 VPP / 75 Ω �
2 - Video Green 0.7 VPP / 75 Ω �3 - Video Blue 0.7 VPP / 75 Ω �
4 - n.c.5 - Ground Gnd �6 - Ground Red Gnd �
7 - Ground Green Gnd �
8 - Ground Blue Gnd �9 - +5VDC +5 V �
10 - Ground Sync Gnd �
11 - Ground Red Gnd �12 - DDC_SDA DDC data �
13 - H-sync 0 - 5 V �
14 - V-sync 0 - 5 V �15 - DDC_SCL DDC clock �
12 - Audio - In: Left / Right, VGAGn - Audio L/R in 0.5 VRMS / 10 kW ��
13 - Service / UART1 - Ground Gnd �
2 - UART_TX Transmit �
3 - UART_RX Receive �
2.4 Chassis Overview
Refer to 9. Block Diagrams for PWB/CBA locations.
10000_017_090121.eps090428
19 1
18 2
21
20
1
2
10000_001_090121.eps090121
1
610
11
5
15
10000_002_090121.eps090127
Precautions, Notes, and Abbreviation List EN 5TPM5.2E LA 3.
2010-Jun-25
3. Precautions, Notes, and Abbreviation List
Index of this chapter:3.1 Safety Instructions3.2 Warnings3.3 Notes3.4 Abbreviation List
3.1 Safety Instructions
Safety regulations require the following during a repair:• Connect the set to the Mains/AC Power via an isolation
transformer (> 800 VA).• Replace safety components, indicated by the symbol �,
only by components identical to the original ones. Any other component substitution (other than original type) may increase risk of fire or electrical shock hazard.
Safety regulations require that after a repair, the set must be returned in its original condition. Pay in particular attention to the following points: • Route the wire trees correctly and fix them with the
mounted cable clamps.• Check the insulation of the Mains/AC Power lead for
external damage. • Check the strain relief of the Mains/AC Power cord for
proper function.• Check the electrical DC resistance between the Mains/AC
Power plug and the secondary side (only for sets that have a Mains/AC Power isolated power supply): 1. Unplug the Mains/AC Power cord and connect a wire
between the two pins of the Mains/AC Power plug. 2. Set the Mains/AC Power switch to the “on” position
(keep the Mains/AC Power cord unplugged!). 3. Measure the resistance value between the pins of the
Mains/AC Power plug and the metal shielding of the tuner or the aerial connection on the set. The reading should be between 4.5 MΩ and 12 MΩ.
4. Switch “off” the set, and remove the wire between the two pins of the Mains/AC Power plug.
• Check the cabinet for defects, to prevent touching of any inner parts by the customer.
3.2 Warnings
• All ICs and many other semiconductors are susceptible to electrostatic discharges (ESD ). Careless handling during repair can reduce life drastically. Make sure that, during repair, you are connected with the same potential as the mass of the set by a wristband with resistance. Keep components and tools also at this same potential.
• Be careful during measurements in the high voltage section.
• Never replace modules or other components while the unit is switched “on”.
• When you align the set, use plastic rather than metal tools. This will prevent any short circuits and the danger of a circuit becoming unstable.
3.3 Notes
3.3.1 General
• Measure the voltages and waveforms with regard to the chassis (= tuner) ground (�), or hot ground (), depending on the tested area of circuitry. The voltages and waveforms shown in the diagrams are indicative. Measure them in the Service Default Mode with a colour bar signal and stereo sound (L: 3 kHz, R: 1 kHz unless stated otherwise) and picture carrier at 475.25 MHz for PAL, or 61.25 MHz for NTSC (channel 3).
• Where necessary, measure the waveforms and voltages with (�) and without (�) aerial signal. Measure the voltages in the power supply section both in normal operation ( ) and in stand-by (�). These values are indicated by means of the appropriate symbols.
3.3.2 Schematic Notes
• All resistor values are in ohms, and the value multiplier is often used to indicate the decimal point location (e.g. 2K2 indicates 2.2 kΩ).
• Resistor values with no multiplier may be indicated with either an “E” or an “R” (e.g. 220E or 220R indicates 220 Ω).
• All capacitor values are given in micro-farads (μ = × 10-6), nano-farads (n = × 10-9), or pico-farads (p = × 10-12).
• Capacitor values may also use the value multiplier as the decimal point indication (e.g. 2p2 indicates 2.2 pF).
• An “asterisk” (*) indicates component usage varies. Refer to the diversity tables for the correct values.
• The correct component values are listed on the Philips Spare Parts Web Portal.
3.3.3 Spare Parts
For the latest spare part overview, consult your Philips Spare Part web portal.
3.3.4 BGA (Ball Grid Array) ICs
IntroductionFor more information on how to handle BGA devices, visit this URL: http://www.atyourservice-magazine.com. Select “Magazine”, then go to “Repair downloads”. Here you will find Information on how to deal with BGA-ICs.
BGA Temperature ProfilesFor BGA-ICs, you must use the correct temperature-profile. Where applicable and available, this profile is added to the IC Data Sheet information section in this manual.
3.3.5 Lead-free Soldering
Due to lead-free technology some rules have to be respected by the workshop during a repair:• Use only lead-free soldering tin. If lead-free solder paste is
required, please contact the manufacturer of your soldering equipment. In general, use of solder paste within workshops should be avoided because paste is not easy to store and to handle.
• Use only adequate solder tools applicable for lead-free soldering tin. The solder tool must be able:– To reach a solder-tip temperature of at least 400°C.– To stabilize the adjusted temperature at the solder-tip.– To exchange solder-tips for different applications.
• Adjust your solder tool so that a temperature of around 360°C - 380°C is reached and stabilized at the solder joint. Heating time of the solder-joint should not exceed ~ 4 sec. Avoid temperatures above 400°C, otherwise wear-out of tips will increase drastically and flux-fluid will be destroyed. To avoid wear-out of tips, switch “off” unused equipment or reduce heat.
• Mix of lead-free soldering tin/parts with leaded soldering tin/parts is possible but PHILIPS recommends strongly to avoid mixed regimes. If this cannot be avoided, carefully clear the solder-joint from old tin and re-solder with new tin.
3.3.6 Alternative BOM identification
It should be noted that on the European Service website, “Alternative BOM” is referred to as “Design variant”.
Precautions, Notes, and Abbreviation ListEN 6 TPM5.2E LA3.
2010-Jun-25
The third digit in the serial number (example: AG2B0335000001) indicates the number of the alternative B.O.M. (Bill Of Materials) that has been used for producing the specific TV set. In general, it is possible that the same TV model on the market is produced with e.g. two different types of displays, coming from two different suppliers. This will then result in sets which have the same CTN (Commercial Type Number; e.g. 28PW9515/12) but which have a different B.O.M. number.By looking at the third digit of the serial number, one can identify which B.O.M. is used for the TV set he is working with.If the third digit of the serial number contains the number “1” (example: AG1B033500001), then the TV set has been manufactured according to B.O.M. number 1. If the third digit is a “2” (example: AG2B0335000001), then the set has been produced according to B.O.M. no. 2. This is important for ordering the correct spare parts!For the third digit, the numbers 1...9 and the characters A...Z can be used, so in total: 9 plus 26= 35 different B.O.M.s can be indicated by the third digit of the serial number.
Identification: The bottom line of a type plate gives a 14-digit serial number. Digits 1 and 2 refer to the production centre (e.g. AG is Bruges), digit 3 refers to the B.O.M. code, digit 4 refers to the Service version change code, digits 5 and 6 refer to the production year, and digits 7 and 8 refer to production week (in example below it is 2006 week 17). The 6 last digits contain the serial number.
Figure 3-1 Serial number (example)
3.3.7 Board Level Repair (BLR) or Component Level Repair (CLR)
If a board is defective, consult your repair procedure to decide if the board has to be exchanged or if it should be repaired on component level.If your repair procedure says the board should be exchanged completely, do not solder on the defective board. Otherwise, it cannot be returned to the O.E.M. supplier for back charging!
3.3.8 Practical Service Precautions
• It makes sense to avoid exposure to electrical shock. While some sources are expected to have a possible dangerous impact, others of quite high potential are of limited current and are sometimes held in less regard.
• Always respect voltages. While some may not be dangerous in themselves, they can cause unexpected reactions that are best avoided. Before reaching into a powered TV set, it is best to test the high voltage insulation. It is easy to do, and is a good service precaution.
3.4 Abbreviation List
0/6/12 SCART switch control signal on A/V board. 0 = loop through (AUX to TV), 6 = play 16 : 9 format, 12 = play 4 : 3 format
AARA Automatic Aspect Ratio Adaptation: algorithm that adapts aspect ratio to remove horizontal black bars; keeps the original aspect ratio
ACI Automatic Channel Installation: algorithm that installs TV channels directly from a cable network by means of a predefined TXT page
ADC Analogue to Digital ConverterAFC Automatic Frequency Control: control
signal used to tune to the correct frequency
AGC Automatic Gain Control: algorithm that controls the video input of the feature box
AM Amplitude ModulationAP Asia PacificAR Aspect Ratio: 4 by 3 or 16 by 9ASF Auto Screen Fit: algorithm that adapts
aspect ratio to remove horizontal black bars without discarding video information
ATSC Advanced Television Systems Committee, the digital TV standard in the USA
ATV See Auto TVAuto TV A hardware and software control
system that measures picture content, and adapts image parameters in a dynamic way
AV External Audio VideoAVC Audio Video ControllerAVIP Audio Video Input ProcessorB/G Monochrome TV system. Sound
carrier distance is 5.5 MHzBDS Business Display Solutions (iTV)BLR Board-Level RepairBTSC Broadcast Television Standard
Committee. Multiplex FM stereo sound system, originating from the USA and used e.g. in LATAM and AP-NTSC countries
B-TXT Blue TeleteXTC Centre channel (audio)CEC Consumer Electronics Control bus:
remote control bus on HDMI connections
CL Constant Level: audio output to connect with an external amplifier
CLR Component Level RepairComPair Computer aided rePairCP Connected Planet / Copy ProtectionCSM Customer Service ModeCTI Color Transient Improvement:
manipulates steepness of chroma transients
CVBS Composite Video Blanking and Synchronization
DAC Digital to Analogue ConverterDBE Dynamic Bass Enhancement: extra
low frequency amplificationDCM Data Communication Module. Also
referred to as System Card or Smartcard (for iTV).
DDC See “E-DDC”D/K Monochrome TV system. Sound
carrier distance is 6.5 MHzDFI Dynamic Frame Insertion
10000_024_090121.eps100105
MODEL :
PROD.NO:
~
S
32PF9968/10 MADE IN BELGIUM220-240V 50/60Hz
128W
AG 1A0617 000001 VHF+S+H+UHF
BJ3.0E LA
Precautions, Notes, and Abbreviation List EN 7TPM5.2E LA 3.
2010-Jun-25
DFU Directions For Use: owner's manualDMR Digital Media Reader: card readerDMSD Digital Multi Standard DecodingDNM Digital Natural MotionDNR Digital Noise Reduction: noise
reduction feature of the setDRAM Dynamic RAMDRM Digital Rights ManagementDSP Digital Signal ProcessingDST Dealer Service Tool: special remote
control designed for service technicians
DTCP Digital Transmission Content Protection; A protocol for protecting digital audio/video content that is traversing a high speed serial bus, such as IEEE-1394
DVB-C Digital Video Broadcast - CableDVB-T Digital Video Broadcast - TerrestrialDVD Digital Versatile DiscDVI(-d) Digital Visual Interface (d= digital only)E-DDC Enhanced Display Data Channel
(VESA standard for communication channel and display). Using E-DDC, the video source can read the EDID information form the display.
EDID Extended Display Identification Data (VESA standard)
EEPROM Electrically Erasable and Programmable Read Only Memory
EMI Electro Magnetic InterferenceEPG Electronic Program GuideEPLD Erasable Programmable Logic DeviceEU EuropeEXT EXTernal (source), entering the set by
SCART or by cinches (jacks)FDS Full Dual Screen (same as FDW)FDW Full Dual Window (same as FDS)FLASH FLASH memoryFM Field Memory or Frequency
ModulationFPGA Field-Programmable Gate ArrayFTV Flat TeleVisionGb/s Giga bits per secondG-TXT Green TeleteXTH H_sync to the module HD High DefinitionHDD Hard Disk DriveHDCP High-bandwidth Digital Content
Protection: A “key” encoded into the HDMI/DVI signal that prevents video data piracy. If a source is HDCP coded and connected via HDMI/DVI without the proper HDCP decoding, the picture is put into a “snow vision” mode or changed to a low resolution. For normal content distribution the source and the display device must be enabled for HDCP “software key” decoding.
HDMI High Definition Multimedia InterfaceHP HeadPhoneI Monochrome TV system. Sound
carrier distance is 6.0 MHzI2C Inter IC busI2D Inter IC Data busI2S Inter IC Sound busIF Intermediate FrequencyIR Infra RedIRQ Interrupt RequestITU-656 The ITU Radio communication Sector
(ITU-R) is a standards body subcommittee of the International Telecommunication Union relating to radio communication. ITU-656 (a.k.a.
SDI), is a digitized video format used for broadcast grade video. Uncompressed digital component or digital composite signals can be used. The SDI signal is self-synchronizing, uses 8 bit or 10 bit data words, and has a maximum data rate of 270 Mbit/s, with a minimum bandwidth of 135 MHz.
ITV Institutional TeleVision; TV sets for hotels, hospitals etc.
LS Last Status; The settings last chosen by the customer and read and stored in RAM or in the NVM. They are called at start-up of the set to configure it according to the customer's preferences
LATAM Latin AmericaLCD Liquid Crystal DisplayLED Light Emitting DiodeL/L' Monochrome TV system. Sound
carrier distance is 6.5 MHz. L' is Band I, L is all bands except for Band I
LPL LG.Philips LCD (supplier)LS LoudspeakerLVDS Low Voltage Differential SignallingMbps Mega bits per secondM/N Monochrome TV system. Sound
carrier distance is 4.5 MHzMHEG Part of a set of international standards
related to the presentation of multimedia information, standardised by the Multimedia and Hypermedia Experts Group. It is commonly used as a language to describe interactive television services
MIPS Microprocessor without Interlocked Pipeline-Stages; A RISC-based microprocessor
MOP Matrix Output ProcessorMOSFET Metal Oxide Silicon Field Effect
Transistor, switching deviceMPEG Motion Pictures Experts GroupMPIF Multi Platform InterFaceMUTE MUTE LineMTV Mainstream TV: TV-mode with
Consumer TV features enabled (iTV)NC Not ConnectedNICAM Near Instantaneous Compounded
Audio Multiplexing. This is a digital sound system, mainly used in Europe.
NTC Negative Temperature Coefficient, non-linear resistor
NTSC National Television Standard Committee. Color system mainly used in North America and Japan. Color carrier NTSC M/N= 3.579545 MHz, NTSC 4.43= 4.433619 MHz (this is a VCR norm, it is not transmitted off-air)
NVM Non-Volatile Memory: IC containing TV related data such as alignments
O/C Open CircuitOSD On Screen DisplayOAD Over the Air Download. Method of
software upgrade via RF transmission. Upgrade software is broadcasted in TS with TV channels.
OTC On screen display Teletext and Control; also called Artistic (SAA5800)
P50 Project 50: communication protocol between TV and peripherals
PAL Phase Alternating Line. Color system mainly used in West Europe (color carrier= 4.433619 MHz) and South America (color carrier PAL M=
Precautions, Notes, and Abbreviation ListEN 8 TPM5.2E LA3.
2010-Jun-25
3.575612 MHz and PAL N= 3.582056 MHz)
PCB Printed Circuit Board (same as “PWB”)PCM Pulse Code ModulationPDP Plasma Display PanelPFC Power Factor Corrector (or Pre-
conditioner)PIP Picture In PicturePLL Phase Locked Loop. Used for e.g.
FST tuning systems. The customer can give directly the desired frequency
POD Point Of Deployment: a removable CAM module, implementing the CA system for a host (e.g. a TV-set)
POR Power On Reset, signal to reset the uPPSDL Power Supply for Direct view LED
backlight with 2D-dimmingPSL Power Supply with integrated LED
driversPSLS Power Supply with integrated LED
drivers with added Scanning functionality
PTC Positive Temperature Coefficient, non-linear resistor
PWB Printed Wiring Board (same as “PCB”)PWM Pulse Width ModulationQRC Quasi Resonant ConverterQTNR Quality Temporal Noise ReductionQVCP Quality Video Composition ProcessorRAM Random Access MemoryRGB Red, Green, and Blue. The primary
color signals for TV. By mixing levels of R, G, and B, all colors (Y/C) are reproduced.
RC Remote ControlRC5 / RC6 Signal protocol from the remote
control receiver RESET RESET signalROM Read Only MemoryRSDS Reduced Swing Differential Signalling
data interfaceR-TXT Red TeleteXTSAM Service Alignment ModeS/C Short CircuitSCART Syndicat des Constructeurs
d'Appareils Radiorécepteurs et Téléviseurs
SCL Serial Clock I2CSCL-F CLock Signal on Fast I2C busSD Standard DefinitionSDA Serial Data I2CSDA-F DAta Signal on Fast I2C busSDI Serial Digital Interface, see “ITU-656”SDRAM Synchronous DRAMSECAM SEequence Couleur Avec Mémoire.
Color system mainly used in France and East Europe. Color carriers= 4.406250 MHz and 4.250000 MHz
SIF Sound Intermediate FrequencySMPS Switched Mode Power SupplySoC System on ChipSOG Sync On GreenSOPS Self Oscillating Power SupplySPI Serial Peripheral Interface bus; a 4-
wire synchronous serial data link standard
S/PDIF Sony Philips Digital InterFaceSRAM Static RAMSRP Service Reference ProtocolSSB Small Signal BoardSSC Spread Spectrum Clocking, used to
reduce the effects of EMISTB Set Top BoxSTBY STand-BYSVGA 800 × 600 (4:3)
SVHS Super Video Home SystemSW SoftwareSWAN Spatial temporal Weighted Averaging
Noise reductionSXGA 1280 × 1024TFT Thin Film TransistorTHD Total Harmonic DistortionTMDS Transmission Minimized Differential
SignallingTS Transport StreamTXT TeleteXTTXT-DW Dual Window with TeleteXTUI User InterfaceuP MicroprocessorUXGA 1600 × 1200 (4:3)V V-sync to the module VESA Video Electronics Standards
AssociationVGA 640 × 480 (4:3)VL Variable Level out: processed audio
output toward external amplifierVSB Vestigial Side Band; modulation
methodWYSIWYR What You See Is What You Record:
record selection that follows main picture and sound
WXGA 1280 × 768 (15:9)XTAL Quartz crystalXGA 1024 × 768 (4:3)Y Luminance signalY/C Luminance (Y) and Chrominance (C)
signalYPbPr Component video. Luminance and
scaled color difference signals (B-Y and R-Y)
YUV Component video
Mechanical Instructions EN 9TPM5.2E LA 4.
2010-Jun-25
4. Mechanical Instructions
Index of this chapter:4.1 Cable Dressing4.2 Service Positions4.3 Assembly/Panel Removal4.4 Set Re-assembly.
Notes:• Figures below can deviate slightly from the actual situation,
due to the different set executions.
4.1 Cable Dressing
Figure 4-1 Cable dressing (19")
18840_101_100324.eps 100324
Mechanical InstructionsEN 10 TPM5.2E LA4.
2010-Jun-25
Figure 4-2 Cable dressing (22")
18840_102_100324.eps 100324
Mechanical Instructions EN 11TPM5.2E LA 4.
2010-Jun-25
Figure 4-3 Cable dressing (26")
4.2 Service Positions
For easy servicing of a TV set, the set should be put face down on a soft flat surface, foam buffers or other specific workshop tools. Ensure that a stable situation is created to perform measurements and alignments. When using foam bars take care that these always support the cabinet and never only the display. Caution: Failure to follow these guidelines can seriously damage the display! Ensure that ESD safe measures are taken.
4.3 Assembly/Panel Removal
Instructions below apply to the 19PFL3405H/xx, but are similar for other models.
4.3.1 Rear Cover
Warning: Disconnect the mains power cord before removing the rear cover.1. Remove the fixation screws that secure the stand at the
bottom of the stand. Then remove the stand.2. Remove fixation screws [1], [2] and [3] that secure the rear
cover, see Figure 4-4.3. The rear cover is secured with locking clips at the side and
top of the cabinet. Pull the rear cover from the TV. This may require more than average force. Be sure to oppose to the stand support. Make sure that wires and flat foils are not damaged while lifting the rear cover from the set, see Figure 4-5 and Figure 4-6.
Figure 4-4 Rear cover removal [1/3]
18840_104_100324.eps 100324
18840_106_100422.eps 100422
3
1 1 1 1
2
Mechanical InstructionsEN 12 TPM5.2E LA4.
2010-Jun-25
Figure 4-5 Rear cover removal [2/3]
Figure 4-6 Rear cover removal [3/3]
4.3.2 Small Signal Board (SSB)
Caution: it is mandatory to remount all different screws at their original position during re-assembly. Failure to do so may result in damaging the SSB.1. Release the Connector from the Flat Foil connectors.
Caution: be careful, as these are very fragile connectors! Take the flat foils out of their connectors.
2. Unplug all other connectors.3. Remove the fixation screw near the L-R audio side inputs.4. Remove all other fixation screws from the SSB.5. Take the SSB out.
4.3.3 Power Supply Unit (PSU)
Caution: it is mandatory to remount all different screws at their original position during re-assembly. Failure to do so may result in damaging the PSU.1. Release the Power board cables from their clamps.2. Unplug power connector from the SSB and LCD panel.3. Remove all fixation screws from the PSU.4. The PSU can now be taken out of the set.When defective, replace the whole unit.
4.3.4 Speakers
1. Release the speaker cable from its clamps.2. Unplug the speaker connector from the SSB.3. Take the speakers out.When defective, replace the whole unit.
4.3.5 Stand removal
Caution: it is mandatory to remount all different screws at their original position during re-assembly. Be sure to put the set in the Service Position.1. Remove the speaker cables as described earlier.2. Remove the fixation screws.3. Take the stand out.
4.3.6 IR/LED Board
4. Unplug the connectors from the IR/LED board.5. Remove the fixation screw.6. Release the clips that hold the board and take it out from
the bezel.When defective, replace the whole unit.
4.3.7 Keyboard Control Panel
Refer to Figure 4-7.1. Unplug the connector [1] on the IR/LED board that leads to
the Local Control board, as it is not unplug-able at the Local Control board itself (soldered connector).
2. Release the cable from its tape.3. Put your thumbs against the front bezel while pulling the
Local Control board in the direction of the arrow .When defective, replace the whole unit.
Figure 4-7 Keyboard Control Panel
18840_107_100422.eps 100422
Pull up
18840_108_100422.eps 100422
Pull up
18840_103_100324.eps100429
1
Mechanical Instructions EN 13TPM5.2E LA 4.
2010-Jun-25
4.3.8 LCD Panel
1. Remove the SSB as described earlier.2. Remove the PSU as described earlier.3. Remove the speaker as described earlier.4. Remove the stand as described earlier.5. Release the tape that fix the Keyboard Control cable near
the Keyboard Control panel.6. Remove the fixation screws that secure the LCD panel with
the bezel.7. Lift the LCD Panel from the bezel.8. Remove the fixation screws that secure the panel with the
Metal frame.9. Take the panel out. Remove the Flat Foil connector from
the panel.When defective, replace the whole unit.
4.4 Set Re-assembly
To re-assemble the whole set, execute all processes in reverse order.
Notes:• While re-assembling, make sure that all cables are placed
and connected in their original position. See Figure 4-1 and Figure 4-2.
• Pay special attention not to damage the EMC foams on the SSB shields. Ensure that EMC foams are mounted correctly.
Service Modes, Error Codes, and Fault FindingEN 14 TPM5.2E LA5.
2010-Jun-25
5. Service Modes, Error Codes, and Fault Finding
Index of this chapter:5.1 Service Modes5.2 Service Tools5.3 Software Upgrading5.4 Error Codes5.5 Fault Finding and Repair Tips
5.1 Service Modes
The Customer Service Mode (CSM) is used for communication between the call centre and the customer, while the Service Alignment Mode (SAM) offers several features for the service technician.
This chassis also offers the option of using ComPair, a hardware interface between a computer and the TV chassis. It offers the abilities of structured troubleshooting, error code reading, and software version read-out for all chassis.
5.1.1 Customer Service Mode (CSM)
PurposeThe Customer Service Mode shows error codes and information on the TV's operation settings.The call centre can instruct the customer (by telephone) to enter CSM in order to identify the status of the set.This helps the call centre to diagnose problems and failures in the TV set before making a service call.The CSM is a read-only mode; therefore, modifications are not possible in this mode.
How to Activate CSMKey in the code “123654” via the standard RC transmitter. Note: Activation of the CSM is only possible if there is no (user) menu on the screen!
Figure 5-1 CSM Menu 1
Figure 5-2 CSM Menu 2
Figure 5-3 CSM Menu 3
How to NavigateBy means of the “CURSOR-DOWN/UP” knob (or the scroll wheel) on the RC-transmitter, can be navigated through the menus.
General• 1.1 Set Type NVM read/write (max. 16 characters).• 1.2 Production code NVM read/write (max. 16
characters).• 1.3 Installation date Date the software was installed.• 1.4 Option Code Store in NVM (set feature grouping as
option) panel code.• 1.5 Codes Error code Layer 2. Store in NVM. 10 error
buffers: 000 = No problem, 011 = I2C bus error, 012 = tuner error, 013 = panel.
• 1.6 SSB 12NC NVM read/write (12 characters).• 1.7 Display 12NC NVM read/write (12 characters).• 1.8 PSU 12NC NVM read/write (12 characters).• 2.1 Current Main SW Detects and displays software
version.• 2.2 Stand-by SW Detects and displays software version.• 2.3 SW version of other μP Detects and displays software
version.• 2.4 Reserved Not applicable.• 2.5 Reserved Not applicable.• 2.6 NVM version Detects and displays software version.• 3.1 Signal Quality/Present analog/digital signal strength.• 3.2 Child lock Detects and displays.• 3.3 HDCP keys Detects and displays.• 3.4 CI slot present Detects and displays.• 3.5 HDMI input format per Supported format. e.g.
576i 50 Hz, 576p 50 Hz, 720p 50 Hz, 1080i 50 Hz, 1080p 50 Hz.
• 3.6 HDMI audio format input stream Per supported format e.g. Dolby TrueHD, DTS-HD Master Audio, MPCM.
• 3.7 HDMI video format input stream Per Supported format. e.g. 576i 50 Hz, 576p 50 Hz, 720p 50 Hz, 1080i 50 Hz, 1080p 50 Hz
How to Exit CSMPress “MENU” on the RC-transmitter.
18840_200_100324.eps 100324
18840_201_100324.eps100429
18840_202_100324.eps100428
Service Modes, Error Codes, and Fault Finding EN 15TPM5.2E LA 5.
2010-Jun-25
5.1.2 Service Alignment Mode (SAM)
How to enterTo enter the factory mode, use the following method:• Press the following key sequence on the remote control
transmitter: “062596” directly followed by the “INFO” button.
After entering the factory mode, the following screen is visible on the top and right of the panel.
Figure 5-4 Example of SAM - 1 -
Press “OK” to check the Version information of the software when you select the “0. F/W Version”.
Figure 5-5 Example of SAM - 2 -
Table 5-1 Contents of SAM
18840_203_100324.eps 100324
18840_207_100422.eps 100422
Number Action Items Range Default Value Description
19" 22" 26"
0 F/W Version Press OK Press OK Press OK Version description
1 Panel_ID 119 120 121 panel identification
2 Err Code:000 000 000 000 000 - - - Show the latest 5 error code status
3 Clear Error Buffer Press OK Press OK Press OK Reset CSM ERROR Code to 0
4 NVM Address 0 0 0 The address in the NVM
5 NVM Value 1 1 1 The value in the NVM
6 NVM Store Press OK Press OK Press OK Store in the NVM
7 NVM Copy TV to USB Press OK Press OK Press OK Use this to copy the NVM data from the TV to the USB
8 NVM Read USB to TV Press OK Press OK Press OK Use this to copy the NVM data from the USB to the TV
9 CLR_Temp_R 0 - 255 119 128 126 Back-End Scaler R G B Gain NVM has for YPbPr four settings: NORMAL, WARM, COOL, CUSTOMER. Other source use offset with hardcoding.10 CLR_Temp_G 0 - 255 128 128 128
11 CLR_Temp_B 0 - 255 116 80 100
12 Auto_Color Press OK Press OK Press OK PC: any pattern has black and white YPbPr: SMPTE bar (colour bar), any timing.
13 ADC_Gain_R 0 - 255 79 0 85 Analogue to Digital Converter Gain for Red, AutoColor affects this and it value is depends on the input
14 ADC_Gain_G 0 - 255 78 0 87 Analogue to Digital Converter Gain for Green, AutoColor affects this and it value is de-pends on the input
15 ADC_Gain_B 0 - 255 79 0 87 Analogue to Digital Converter Gain for Blue, AutoColor affects this and it value is depends on the input
16 ADC_Offset_R 0 - 255 113 128 113 Analogue to Digital Converter Offset for Red, AutoColor affects this and it value is de-pends on the input
17 ADC_Offset_G 0 - 255 109 128 109 Analogue to Digital Converter Offset for Green, AutoColor affects this and it value is de-pends on the input
18 ADC_Offset_B 0 - 255 100 128 100 Analogue to Digital Converter Offset for Blue, AutoColor affects this and it value is de-pends on the input
19 Virgin_Mode Off Off Off Reset the set to manufacturer's mode
20 Gamma_Table On On On use gamma table or not
21 E-Fuse On On On use efuse as default ADC value or not
22 Ageing Mode Off Off Off turn on ageing mode
23 Reset_PBS_PWD Press OK Press OK Press OK Clear NVM EEP_OFFSET_BDS_PCODE_1_4, EEP_OFFSET_BDS_PCODE_2_4,EEP_OFFSET_BDS_PCODE_3_4, EEP_OFFSET_BDS_PCODE_4_4
24 V-COM Press OK Press OK Press OK This starts V-COM
25 Video_PWM_Medium 0 - 255 128 128 128 PWM value at contrast 50%
26 Video_PWM_Minmum 0 - 255 240 240 240 Minimum PWM value
27 Video_PWM_Maximun 0 - 255 0 0 0 Maximum PWM value
28 Video_PWM_Ratio_Top 0 - 100 90 90 90 PWM value at Best Power
29 Video_PWM_Ratio_Bottom 0 - 100 5 5 5 PWM value at Best Picture
30 Video_PWM_Ratio_STD 0 - 100 95 95 95 PWM value at standard
31 YPBPR_PHASE 0 - 255 InValid InValid InValid 480i, 480p, 576i, 576p, 720p 50 Hz, 720p 60 Hz,1080i 25 Hz,1080i 30 Hz, 1080p 24 Hz,1080p 50 Hz,1080p 60 Hz
32 AUD_GAIN_LINEIN 0 - 36 29 29 22 Audio gain by different sources
33 AUD_GAIN_HDMI 0 - 36 29 29 22 Audio gain for HDMI inputs
34 AUD_GAIN_ATV 0 - 36 29 29 22 Audio gain for analogue TV signals
35 AUD_GAIN_DTV 0 - 36 29 29 22 Audio gain for digital TV signal
36 AUD_GAIN_USB 0 - 36 29 29 22 Audio gain for the USB input
37 AUD_LIPSYNC_SPK -272 - +272 200 200 200 Audio delay to the speaker, “+” is delay, “-” is ahead. NVM value = Delay (ms)/0.147
38 AUD_LIPSYNC_HP -272 - +272 200 200 200 Audio delay to the head-phone, “+” is delay, “-” is ahead. NVM value = Delay (ms)/0.147
Service Modes, Error Codes, and Fault FindingEN 16 TPM5.2E LA5.
2010-Jun-25
How to NavigateWith the up/down cursor keys can be used to navigate through the menu, while with the Left/Right cursor the values can be changed.
How to EXITChoose “EXIT”, and press the “OK” button. Turn “Off” the TV via the side control key and then turn “On” the TV again.
5.2 Service Tools
5.2.1 ComPair
IntroductionComPair (Computer Aided Repair) is a Service tool for Philips Consumer Electronics products. and offers the following:1. ComPair helps to quickly get an understanding on how to
repair the chassis in a short and effective way.2. ComPair allows very detailed diagnostics and is therefore
capable of accurately indicating problem areas. No knowledge on I2C or UART commands is necessary, because ComPair takes care of this.
3. ComPair speeds up the repair time since it can automatically communicate with the chassis (when the uP is working) and all repair information is directly available.
4. ComPair features TV software upgrade possibilities.
SpecificationsComPair consists of a Windows based fault finding program and an interface box between PC and the (defective) product. The ComPair II interface box is connected to the PC via an USB cable. For the TV chassis, the ComPair interface box and the TV communicate via a bi-directional cable via the service connector(s).The ComPair fault finding program is able to determine the problem of the defective television, by a combination of automatic diagnostics and an interactive question/answer procedure.
How to ConnectThis is described in the chassis fault finding database in ComPair.
Figure 5-6 ComPair II interface connection
Caution: It is compulsory to connect the TV to the PC as shown in the picture above (with the ComPair interface in between), as the ComPair interface acts as a level shifter. If one connects the TV directly to the PC (via UART), ICs will be damaged!
How to OrderComPair II order codes:• ComPair II interface: 3122 785 90630.• Programming software can be downloaded from the Philips
Service portal. • ComPair UART interface cable for TPM5.2x xx.
3122 785 90630. Note: While having problems, contact the local support desk.
39 AUD_LIPSYNC_SPDIF -272 - +272 200 200 200 Audio delay to the S/P-DIF output, “+” is delay, “-” is ahead. NVM value = Delay (ms)/0.147
40 Tuner_ID 95 95 95 Tuner Identification, 94: NXP 95: LG
41 OPT AV2 Scart2 0, 2 0 0 0 0: not available, 2: CVBS + YC
42 OPT HDMI2 0/1 0 0 1 On/Off
43 OPT Reset Option 0/1 Press OK Press OK Press OK after reset, should restart the set immediately
44 Esticker NVM 1 0 - 61, 255 32 32 32 0~61: Icon number. 255: no icon
45 Esticker NVM 2 0 - 61, 255 79 79 79 0~61: Icon number. 255: no icon
46 Esticker NVM 3 0 - 61, 255 77 77 83 0~61: Icon number. 255: no icon
47 Esticker NVM 4 0 - 61, 255 35 35 85 0~61: Icon number. 255: no icon
48 Esticker NVM 5 0 - 61, 255 7 7 45 0~61: Icon number. 255: no icon
49 Esticker NVM 6 0 - 61, 255 45 45 2 0~61: Icon number. 255: no icon
50 Esticker NVM 7 0 - 61, 255 0 0 58 0~61: Icon number. 255: no icon
51 Esticker NVM 8 0 - 61, 255 58 58 48 0~61: Icon number. 255: no icon
52 Esticker NVM 9 0 - 61, 255 48 48 81 0~61: Icon number. 255: no icon
53 Esticker NVM 10 0 - 61, 255 64 64 64 0~61: Icon number. 255: no icon
54 Esticker NVM 11 0 - 61, 255 77 77 86 0~61: Icon number. 255: no icon
55 Esticker NVM 12 0 - 61, 255 76 76 76 0~61: Icon number. 255: no icon
56 Esticker NVM 13 0 - 61, 255 71 71 71 0~61: Icon number. 255: no icon
57 Esticker NVM 14 0 - 61, 255 70 70 70 0~61: Icon number. 255: no icon
58 Esticker NVM 15 0 - 61, 255 74 74 74 0~61: Icon number. 255: no icon
59 Esticker NVM 16 0 - 61, 255 72 72 72 0~61: Icon number. 255: no icon
60 Esticker NVM 17 0 - 61, 255 78 78 78 0~61: Icon number. 255: no icon
61 Esticker NVM 18 0 - 61, 255 255 255 255 0~61: Icon number. 255: no icon
62 Esticker NVM 19 0 - 61, 255 255 255 255 0~61: Icon number. 255: no icon
63 Esticker NVM 20 0 - 61, 255 255 255 255 0~61: Icon number. 255: no icon
64 Esticker Reset Press OK Press OK Press OK Executing this resets the e-sticker
65 Exit_Factory Press OK Press OK Press OK Exit factory mode
Number Action Items Range Default Value Description
19" 22" 26"
10000_036_090121.eps091118
TOUART SERVICECONNECTOR
TOUART SERVICECONNECTOR
TOI2C SERVICECONNECTOR
TO TV
PC
HDMII2C only
Optional power5V DC
ComPair II Developed by Philips Brugge
RC outRC in
OptionalSwitch
Power ModeLink/Activity I2C
ComPair IIMulti
function
RS232 /UART
Service Modes, Error Codes, and Fault Finding EN 17TPM5.2E LA 5.
2010-Jun-25
5.3 Software Upgrading
5.3.1 Introduction
Philips continuously tries to improve its products, and we recommend that you update the TV software when updates are available. Software update files can be obtained from your dealer or can be downloaded from the following websites:http://www.philips.com/support
Preparing a portable memory for software upgradeYou require the following:1. A personal computer connected to the Internet.2. An archive utility that supports the ZIP-format (e.g. WinZip
for Windows or Stufflt for Mac OS).3. A USB flash drive (preferably empty).
Note:1. Only FAT/DOS-formatted flash drives are supported.2. Only use software update files that can be found on the
http://www.philips.com/support web site.
5.3.2 Check the current TV software version
Before starting the software upgrade procedure, it is advised to check that what the current TV software:1. Press the “Menu” button on your remote control.2. Select “Setup” and press “OK”, then select [Software
update] > [Current software].If the current software version of your TV is the same as the latest update file found on http://www.philips.com/support, it is not necessary to update the TV software.
5.3.3 Download the latest software
1. Point your web browser to http://www.philips.com/support.2. Find information and software related to your TV.3. Select the latest software update file and download it to
your PC.4. Insert a USB flash drive into one of the USB ports of your
PC.5. Decompress the downloaded ZIP file and copy the
“autorun.upg” to the root directory of the USB flash drive.
5.3.4 Update the TV software
1. Insert the USB flash drive that contains the software update file.
2. Then a window jumps out as Figure 5-7. Note: If the USB flash drive is not detected after power up, disconnect it and re-insert it.
3. Select [Update] and press OK.4. To proceed, In next menu select [Start] and press OK to
start software updates. See Figure 5-8.5. Upgrading will now begins and the status of the updating
progress will be displayed. 6. When the TV software is updated. Remove your USB flash
drive, then select [Restart] and press OK to restart the TV.See Figure 5-9.
Figure 5-7 Update the TV software 1
Figure 5-8 Update the TV software 2
Figure 5-9 Update the TV software 3
Note:• Do not remove the USB flash drive during the software
update.• If a power failure occurs during the update, do not remove
the USB flash drive from the TV. The TV will continue the software update as soon as power comes back.
• If an error occurs during the update retry the procedure or contact your dealer.
• We do not recommend downgrading to an older version.• Once the upgrade is finished, use your PC to remove the
TV software from your USB portable memory.
18850_204_100204.eps100204
18850_205_100204.eps100204
18850_206_100204.eps100204
Service Modes, Error Codes, and Fault FindingEN 18 TPM5.2E LA5.
2010-Jun-25
5.4 Error Codes
The error code buffer contains all errors detected since the last time the buffer was erased. The buffer is written from left to right. When an error occurs that is not yet in the error code buffer, it is displayed at the left side and all other errors shift one position to the right.
Basically there are three kinds of error codes:
5.5 Fault Finding and Repair Tips
5.5.1 Speakers
Make sure that the volume is set to minimum during disconnecting the speakers in the ON-state of the TV. The audio amplifier can be damaged by disconnecting the speakers during ON-state of the set!
5.5.2 Tuner
Attention: In case the tuner is replaced, always check the tuner options.
Error Code Event
000 No problem
011 I2C bus error
012 Tuner error
013 panel
Alignments EN 19TPM5.2E LA 6.
2010-Jun-25
6. Alignments
Index of this chapter:6.1 General Alignment Conditions6.2 Hardware Alignments6.3 YPbPr Mode display adjustment6.4 PC mode display adjustment6.5 Option Settings6.6 Serial Number Definition
Note: The Service Alignment Mode (SAM) are described in chapter 5. Service Modes, Error Codes, and Fault Finding. Menu navigation is done with the CURSOR UP, DOWN, LEFT or RIGHT keys of the remote control transmitter.
6.1 General Alignment Conditions
Perform all electrical adjustments under the following conditions:• Power supply voltage: 195 - 264 VAC, 50/ 60 ± 3 Hz.• Connect the set to the mains via an isolation transformer
with low internal resistance.• Allow the set to warm up for approximately 15 minutes.• Measure voltages and waveforms in relation to correct
ground.Caution: It is not allowed to use heatsinks as ground.
• Test probe: Ri > 10 MΩ, Ci < 20 pF.• Use an isolated trimmer/screwdriver to perform
alignments.
6.2 Hardware Alignments
Not applicable.
6.3 YPbPr Mode display adjustment
6.3.1 General set-up
Equipment Requirements:Minolta CS-200 or equivalent Colour analyser, Quantum Data Pattern Generator 802G, 802BT or equivalent instrument.
Input requirements:Input Signal Type: YPbPr signal• 1080i mode, TVBar100 pattern by 802G or 802BT.• Select Picture mode to User mode and check the x, y data.
Input Signal Strength:1 Vpp for Y signal; 700 mVpp for Pb & Pr signal
Input Injection Point:YPbPr (RAC jack)
6.3.2 Alignment method
Quantum Data Pattern Generator 802G or 802BT. Apply 1080i, and the pattern TVBAR100 with a Quantum colour analyser.
Initial Set-up:1. Select source as “EXT2”.2. Set Smart Picture mode as “Standard” and off the
“Dynamic contrast/Dynamic backlight”.3. Apply “TVBar100” pattern with colour bar pattern by signal
generator.4. Enter factory mode menu: press numeric keys
“062596” + INFO key (FAC mode menu).
Alignment:1. At SAM mode menu, select AUTO_COLOR item. Then
press “OK” key to adjust ADC_GAIN_R, ADC_GAIN_G, ADC_GAIN_B and ADC_OFFSET_R, ADC_OFFSET_G, ADC_OFFSET_B. Then store those values to NVM.
2. Apply 100% white pattern.3. Set colour temperature to “NORMAL”.4. At FAC mode menu, adjust the CLR TEMP R, CLR TEMP
G, CLR TEMP B values to meet “NORMAL” colour coordinates specification below. Then store those values to NVM (R/G/B gain value <= 128).
5. Set colour temperature to “COOL”.6. At FAC mode menu, adjust the CLR TEMP R, CLR TEMP
G, CLR TEMP B values to meet “COOL” colour coordinates specification below. Then store those values to NVM (R/G/B gain value <= 128).
7. Set colour temperature to “WARM”.8. At FAC mode menu, adjust the CLR TEMP R, CLR TEMP
G, CLR TEMP B values to meet “WARM” colour coordinates specification below. Then store those values to NVM (R/G/B gain value <= 128).
Colour temperature Normal/Warm/Cool (x, y) co-ordinates specification:
Table 6-1 Reading with Minolta CS-200
If you have not such equipment, the below value is for your reference.
Table 6-2 Reference value
Note:• Check Luminance:
Use Minolta CS-200 or Equivalent Colour analyser for colour coordinates and luminance check. Then Set CS-200 receiver at the centre of the screen.when Brightness/ Contrast / Video Contrast setting at 100 and CLR_TEMP_R / CLR_TEMP_G / CLR_TEMP_B = 128. The Luminance need arrive at(1) 19PFL3405H or 22PFL3405H Luminance > 240 cd/m2. (2) 26PFL3405H Luminance > 320 cd/m2.
• equivalent Colour analyser need to calibration with Minolta CS-200.
Picture Mode x y
Normal (9000K) 0.287 ± 0.003 0.296 ± 0.003
Cool (11000K) 0.276 ± 0.003 0.282 ± 0.003
Warm (6500K) 0.313 ± 0.003 0.329 ± 0.003
Picture Mode Size
Colour temperature
Red Green Blue
Normal (9000K) 19" 128 128 107
22" 116 128 111
26" 126 128 100
Cool (11000K) 19" 119 128 116
22" 105 128 124
26" 111 128 120
Warm (6500K) 19" 128 116 70
22" 128 128 80
26" 128 109 56
AlignmentsEN 20 TPM5.2E LA6.
2010-Jun-25
6.4 PC mode display adjustment
6.4.1 Display quality adjustment
Use the POPO (pixel on pixel off) pattern to adjust the clock until no stripe and adjust the phase until clear picture (“Auto” will be done every time switching to PC mode and mode change).
6.4.2 WHITE-D adjustment
Equipment Requirements:Minolta CS-200 or Equivalent Chroma 2250 or equivalent PC signal generator.
Input requirements:Input Signal Type: PC VGA signal, 1366 × 768/60 Hz PC mode with “five white block” pattern.
Figure 6-1 Five white blocks pattern
Input Signal Strength:0.7 Vp-p linear voltage.
Input Injection Point:PC D-SUB input.
6.4.3 Alignment method
Initial Set-up:1. Select source as “PC”.2. Set Contrast = 50 (Sharp) and Brightness=50 (Sharp), at
normal menu mode.3. Apply “5 white block” pattern by VGA pattern generator,
see Figure 6-1.4. Enter factory mode menu: press numeric keys “062596” +
INFO key (FAC mode menu).
6.4.4 Alignment
1. At FAC mode menu, select the item AUTO_COLOR item. Then press “OK” key to adjust ADC_GAIN_R, ADC_GAIN_G, ADC_GAIN_B and ADC_OFFSET_R, ADC_OFFSET_G, ADC_OFFSET_B. Then store those values to NVM.
18290_201_090330.eps090416
Alignments EN 21TPM5.2E LA 6.
2010-Jun-25
6.5 Option Settings
6.5.1 Reset Options
In SAM, after reset “Reset option code”, restart the set immediately.
6.5.2 Option Code Overview
Table 6-3 Option code overview
6.6 Serial Number Definition
Table 6-4 BOM Code
CTN_ALT BOM# Panel Type Panel ID
19PFL3405H/12_1 LG LC185EXN-SCA1 119
19PFL3405H/12_2 AUO M185XW01 V6 122
19PFL3405H/05_1 LG LC185EXN-SCA1 119
22PFL3405H/12_1 LG LC216EXN-SCA1 120
22PFL3405H/12_2 CMO V216B1-LE1 123
22PFL3405H/05_1 LG LC216EXN-SCA1 120
26PFL3405H/12_1 LG LC260EXN-SCB1 121
26PFL3405H/12_2 AUO T260XW06 V1 124
26PFL3405H/05_1 LG LC260EXN-SCB1 121
22PFL3415H/12_1 LG LC216EXN-SCA1 120
22PFL3415H/60_1 LG LC216EXN-SCA1 120
19HFL3232D/10_1 LG LC185EXN-SCA1 119
22HFL3232D/10_1 LG LC216EXN-SCA1 120
26HFL3232D/10_1 LG LC260EXN-SCB1 121
Panel Supplier Code
AU 1
CPT 2
LPL (LG) 3
QDI 4
CMO 5
HSD 6
SVA 7
Circuit DescriptionsEN 22 TPM5.2E LA7.
2010-Jun-25
7. Circuit Descriptions
Index of this chapter:7.1 Introduction7.2 Power Architecture
Notes: • Only new circuits (circuits that are not published recently)
are described. • Figures can deviate slightly from the actual situation, due
to different set executions.• For a good understanding of the following circuit
descriptions, please use the wiring, block (see chapter 9. Block Diagrams) and circuit diagrams (see chapter 10. Circuit Diagrams and PWB Layouts).Where necessary, you will find a separate drawing for clarification.
7.1 Introduction
The TPM5.2E LA chassis is using the MT5363 main processor.
7.1.1 TPM5.2E Architecture Overview
• For details about the chassis block diagrams refer to chapter 9. Block Diagrams. An overview of the TPM5.1E LA architecture can be found in Figure 7-1.
Figure 7-1 Architecture of TPM5.2E LA
64 MB DDR2 × 2
NAND Flash 16MB24C64NVM
SPI
24C02HDMI EDID
REAR HDMI
TUNERNOR Flash 512KB
LED LCD Panel
CVBS1
24C02HDMI EDID
REAR HDMI
SIDE HDMI
ADIN4_SRV,ADIN2_SRV
IF BPF
CVBS1
SIDE AV
VGA24C02
VGA EDID OIRI, OPCTRL0
R1,G1,B1Component
VDAC_OUT1HP AMP
TPA6132A2
Audio AMPTPA3113D2
SCART AR0 AL0SCART
MP3/JPEGS/W upgrade/NVM clone
AR0,AL0
DRV603
CI card IN
TTL/ LVDS
18840_208_100422.eps100428
Circuit Descriptions EN 23TPM5.2E LA 7.
2010-Jun-25
7.1.2 SSB Cell Layout
Figure 7-2 SSB layout cells (top view)
18840_206_100406.eps100428
AUDIO CLA SS - D
DC/DC
TUNER
ANALOG I/O
S ERVICE CONNECTOR
MT5363
DIGITAL I/O
COMMON INTERFACE
ANALOG I/O
DIGITAL I/O
Circuit DescriptionsEN 24 TPM5.2E LA7.
2010-Jun-25
7.2 Power Architecture
Refer to figure Figure 7-3 for the power architecture of this platform (DC/DC power conversion).
Figure 7-3 Power Architecture
7.2.1 Power Supply Unit
All power supplies are a black box for Service. When defective, a new board must be ordered and the defective one must be returned, unless the main fuse of the board is broken. Always replace a defective fuse with one with the correct specifications! This part is available in the regular market.Consult the Service website for the order codes of the boards.
The output voltages to the chassis are:• +5-STANDBY (stand-by-mode only)• +12V (on-mode)• +24V (audio power)
18840_205_100324.eps1004288
V21_RWP
V5_RWP_BTS
42 2D3113APTPMA-oiduA
157UFU36T309G
107U3049PM
KCUB
tiucriC CL
057UFU34T33-7111G
rotalugeR A1
33VD
33VA
RDD_81VD
pihC niaMCD ot CD oiduA
LENAP
BS33VD
WS_V5
BSRWPO
RENUT_V5
YB DNATS
407Q1244NOA
SOMC
207U31-LD7111PArotalugeR A1
257UFU34T33-7111G
rotalugeR A1
357U31-LD7111PA
rotalugeR
21VA
xaM A5.2
3635TM
11VD
BTS_V5
BTS_V5
WS
xaM A5.1
Q750
AON4421
CMOS
FFO/NO_CCV_LENAP
BTS_V5
CCV_LENAP
114URTS1712SPMTS
CCV_21C
0504hTCRTP REWOP_BSU
AICMCP11VD
pma-erPtuo TRACS
701URTUBA21L87L
V21
ylno”62
457UTRTESH5124CS
IC Data Sheets EN 25TPM5.2E LA 8.
2010-Jun-25
8. IC Data Sheets
This section shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic” ICs).
8.1 Diagram B04 SSB: MT5363 By-pass/Trap, MT5363LIMG BGA-522(IC U401)
Figure 8-1 Internal block diagram
18850_300_100107.eps100222
Block diagram
DVB-T ATD
CVBS/YC Input
VADCx4
TVDecoder
HDMI Rx
HDMI In I/F
AudioDemod
Audio Input
AudioADC
Panel
LVDS
CVBS
VDAC
TVE
DDR DRAM
Controller
ARM
BIM
TSDemux
VDO-In
PreProc
MDDi
Audio In
JPEG,MPEGH.264
2-D Graphic
Mix andPost Processing
OSDscaler
Vplanescaler/PIP
Audio DSP IO Bus Standby uP CKGEN
Audio I/F
Audio DAC
SPDIF, I2S
BScan PVR RTC UART MS,SD PWM NAND Flash
JTAG IrDA SIF USB2.0 Watchdog Serial Flash Servo ADC
IC Data SheetsEN 26 TPM5.2E LA8.
2010-Jun-25
Figure 8-2 Pin configuration (1)
18850_301_100107.eps100222
Pinning informationLT 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
A
B VCC2IO
C
D RA9
E
F RA5
G
H RBA2
J
K RCKE
L
M RA13
N
P RA8
R
T RDQ19
U
V RDQM2
W
Y RDQS3
AA
AB RDQ16
AC
AD RCLK1
AE
AF VCC2IO
AG
AH GPIO44
AJ
AK JTRST_
AL
AM VCCK
AN
AP OSDA0
AR
AT POCE0_
AU
RCLK0_
VCC2IO
RA12
RA10
RBA1
RCAS_
RA11
VCC2IO
RDQ22
RDQS2_
RDQS3_
RDQ21
VCC2IO
GPIO38
JTDI
VCCK
VCCK
PDD0
POOE_
RCLK0
VCC2IO
RA7
RBA0
RWE_
RA2
RCS_
RDQ20
RDQS2
DVSS
RDQ23
RCLK1_
VCC2IO
GPIO43
JTCK
VCCK
OSCL0
POWE_
RDQ10
RDQ13
VCC2IO
RA3
DVSS
DVSS
RA0
VCC2IO
RDQ17
DVSS
RDQ29
RDQ18
VCC2IO
GPIO41
JTMS
VCCK
VCCK
PAALE
PACLE
RDQ8
RDQ5
VCC2IO
RA1
MEMTN
RA4
RRAS_
RDQ30
RDQ28
RDQ24
REXTDN
VCC2IO
GPIO37
JTDO
VCCK
VCCK
PDD1
PARB_
RDQ15
RDQS1_
RDQ2
VCC2IO
DVSS
DVSS
RODT
VCC2IO
RDQM3
DVSS
RDQ26
VCC2IO
GPIO39
GPIO42
VCCK
VCCK
POCE1_
PDD2
PDD3
RDQS1
RDQ0
RDQ7
VCC2IO
MEMTP
RA6
RVREF
RDQ25
RDQ27
RDQ31
VCC2IO
GPIO40
VCCK
VCCK
VCCK
PDD4
PDD5
RDQS0_
DVSS
DVSS
DVSS
RVREF
DVSS
VCCK
VCCK
PDD6
PDD7
RDQS0
DVSS
DVSS
DVSS
AVSS12_U SB
AVSS33_U
SB
AVSS33_U
SB
RDQ14
RDQM1
RDQM0
DVSS
AVDD12_U SB
USB_VRT
USB_DM
USB_DP
RDQ11
RDQ9
RDQ6
RDQ1
AVDD33_U SB
AVDD12_H
DMI
AVSS33_U
SB
RDQ12
VCC2IO
VCC2IO
RDQ3
VCCK
HDMI_SCL
2
AVSS33_H
DMI
RX2_C
RX2_CB
VCC2IO
VCC2IO
VCC2IO
RDQ4
AVDD12_M EMPLL
AVSS12_M
EMPLL
VCCK
VCCK
DVSS
DVSS
VCCIO33-1
AVDD33_H DMI
RX2_0
RX2_0B
VCC2IO
VCC2IO
VCC2IO
DVSS
DVSS
VCCK
DVSS
VCCK
DVSS
VCCK
HDMI_SDA 2
HDMI_CEC
RX2_1
RX2_1B
AO0N
AO0P
AVDD33_L VDS
AVDD33_L
VDS
DVSS
DVSS
DVSS
VCCK
DVSS
VCCK
VCCIO33-1
PWR5V_2
RX2_2
RX2_2B
AO1N
AO1P
AE0N
AE0P
AVDD12_L VDS
VCCK
DVSS
DVSS
DVSS
DVSS
VCCK
PWR5V_1
HDMI_HPD 2
RX1_C
RX1_CB
AO2N
AO2P
AE1N
AE1P
AVSS12_L VDS
DVSS
DVSS
DVSS
DVSS
VCCK
HDMI_SCL 1
RX1_0
RX1_0B
AOCKN
AOCKP
AE2N
AE2P
AVSS33_L VDS
AVDD12_V PLL
DVSS
DVSS
DVSS
DVSS
DVSS
VCCK
HDMI_HPD 1
HDMI_SDA
1
RX1_1
RX1_1B
AO3N
AO3P
AECKN
AECKP
TP_VPLL
AVSS12_V PLL
DVSS
DVSS
DVSS
DVSS
VCCK
OPCTRL1
RX1_2
RX1_2B
AV 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
IC Data Sheets EN 27TPM5.2E LA 8.
2010-Jun-25
Figure 8-3 Pin configuration (2)
18850_302_100107.eps100222
Pinning information 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 RT
A 0DXRTE 2DXRTE 0DXTTE 3OIPG 12OIPG 53OIPG N4OA
AO4P
AE3N
AE3P
DVSS
DVSS
AE4N
AE4P
GPIO36
DVSS
DVSS
GPIO32
GPIO34
GPIO33
VCCIO33
GPIO28
GPIO30
GPIO29
GPIO31
GPIO26
GPIO27
GPIO24
GPIO25
GPIO22
GPIO20
GPIO19
GPIO23
GPIO17
GPIO18
GPIO16
GPIO15
GPIO11
GPIO12
GPIO14
GPIO13
GPIO9
GPIO10
GPIO8
GPIO7
GPIO4
GPIO6
GPIO5
VCCIO33
FSRC_WR
ETTXD3
ETTXEN
ETPHYCLK
VCCIO33
AOSDATA3
IF_AGC
ETTXD1
ETTXD2
ETCOL
GPIO2
ALIN
ETRXCLK
ETTXCLK
CI_MCLKO
CI_MISTR
T
ASPDIF
RF_AGC
ETRXD3
ETTXER
CI_MIVAL
OPWM0
AOBCK
ETRXD1
ETRXER
CI_MCLKI
CI_MDI0
GPIO0
AOMCLK
ETRXDV B
ETCRS C
ETMDIO D
ETMDC E
CI_MOSTR
TF
CI_MOVAL G
CI_MDO0 H
OPWM1 J
GPIO1 K
AOSDATA0 L
AOLRCK M
DVSS
DVSS
DVSS
DVSS
DVSS
DVSS
VCCK
DVSS
DVSS
DVSS
DVSS
DVSS
VCCK
DVSS
DVSS
DVSS
VCCK
VCCK
AVSS33_A DAC1
OSCL2
AVDD33_A DAC1
VCCIO33
AOSDATA4
OSDA1
AL1
OSDA2
OPWM2
AR1
TUNER_DA
TA
OSCL1
AR2
AOSDATA1
U1TX
AL2
TUNER_CL
K
U1RX
AR3
N
AOSDATA2 P
R
VCXO T
U
AL3 V
DVSS DVSS VCCK AVDD33_R
EF_AADC VCCIO33 VCCIO33 VCCIO33 W
DVSS
DVSS
DVSS
DVSS
DVSS
DVSS
VCCK
VCCK
VCCK
AVSS33_R EF_AADC
VMID_AAD
C
AVDD33_A ADC
AIN1_L_AA
AIN4_L_AA
DC
AVSS33_A ADC
AIN4_R_A
AIN5_L_AA
DC
AIN5_R_A ADC
AIN2_R_A
AIN6_L_AA
DC
AIN6_R_A
ADCY
AA
AIN3_R_A
DVSS
VCCK
DVSS
DVSS
VCCK
DVSS
DVSS
DVSS
DVSS
AVDD12_T
VDPLL
AVDD12_A
DC
AIN1_R_A
ADC
AVDD12_S
ADC
AIN0_L_AA
DC
AVDD33_
ADAC0
AIN0_R_A
ADC
AVSS33_A
DAC0
AVDD33_
ADC
AIN2_L_AA
DC
AVICM
AIN3_L_AA
DC
AR0
AVSS33_D
ADCAB
AC
AD
AE
AL0 AF
OPWRSB
OPCTRL0
ORESET_
AVDD10_L
AVSS33_V
GA_STB
AVDD12_R
AVSS12_P
LL
AVSS33_SI
F
FS_VDAC
PLL
AVSS33_D
IG
AVDD33_S
IF
AVSS12_P
LL
AVDD33_D
IG
BYPASS0
YSPLL
ADIN0_SR
V
AVDD12_A
DCPLL
ADIN1_SR
V
AF
DEMOD1
XTALO
ADIN3_SR
V
ADCINN_D
EMOD
AVDD33_X
TAL_STB
ADIN2_SR
EMOD1 AG
ADCINP_D
EMOD AH
XTALI AJ
AVSS33_X
TALAK
ADIN5_SR
V AL
ADIN4_SR
OPCTRL2
OPCTRL3
OPCTRL4
U0TX
U0RX
OIRI
HSYNC
VSYNC
DO
SOG
BP
AVDD33_V
GA_STB
COM
GP
GB
SOY1
RP
AVSS12_R
GB
COM1
Y1P
PR1P
PB1P
Y0P
SOY0
PB0P
COM0
AVDD33_V
DAC
AVSS33_V
DAC
PR0P
VDAC_OUT 1
VDAC_OUT
2
AVDD33_C
VBS
AVSS33_C
VBS
SY0
SC0
MPXP
SY1
SC1
V
CVBS2P
CVBS3P
V AM
MPXN AN
TUNER_BY
PASSAP
CVBS0N AR
CVBS0P AT
CVBS1P AU
20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 RB
IC Data SheetsEN 28 TPM5.2E LA8.
2010-Jun-25
8.2 Diagram B01 SSB: Power-1, MP9403 (IC U701)
Figure 8-4 Internal block diagram and pin configuration
18840_303_100406.eps100406
Block diagram
Pinning information
BS
IN
SW
GND
SS
EN
COMP
FB
CONNECT EXPOSED PAD AND GND PIN TO A CERTAINGROUND PLANE
1
2
3
4
8
7
6
5
TOP VIEW
INTERNALREGULATORS
IN
EN
+ERROR
AMPLIFIER6υA
1.2V
OVP
RAMP
CLK
0.8V
0.3V
CURRENTCOMPARATOR
CURRENTSENSE
AMPLIFIER0.95V
SHUTDOWNCOMPARATOR
COMP
SS
FB
GND
OSCILLATOR
340KHz
S
R
Q
SW
BS
IN
5V
OVP
IN < 3.95V
+
Q
+
+
1.3 V +
+
+
--
--
--
--
--
--
IC Data Sheets EN 29TPM5.2E LA 8.
2010-Jun-25
8.3 Diagram B12 SSB: Audio Amp/Headphone out, TPA6132A2RTER 25mW QFN-16 (IC U602)
Figure 8-5 Internal block diagram and pin configuration
18850_304_100107.eps100222
Block diagram
Pinning information
Click-and-PopSuppression
+
–
HPVDD
HPVSS
+
–
HPVDD
HPVSS
ChargePump
INR+
INR-
INL+
INL-OUTL
OUTR
CPP
CPN
HPVSS
G0
EN
ThermalProtection
GainSelect
G1
VDD
SupplyControl
PGND
SGND
HPVDD
ResistorArray
1 F
1 F
2.2 F
Short-CircuitProtection
ResistorArray
HPVDD
1 HPVDD
CPP
INL-
INL+
INR+
INR-
PGND
CPN
2
3
4
12
11
10
9
16 15 14 13
5 6 7 8
RT
UO
G0
G1 S
SV
PH
LT
UO
DN
GS
DD
V
NE
IC Data SheetsEN 30 TPM5.2E LA8.
2010-Jun-25
8.4 Diagram B12 SSB: Audio Amp/Headphone out, TPA3113D2PWPR 6W TSSOP-28 (IC U601)
Figure 8-6 Internal block diagram and pin configuration
18840_304_100406.eps100428
Block diagram
Pinning information
12
3456
78910
2827
26252423
22212019
SDFAULT
LINPLINN
GAIN0GAIN1AVCCAGNDGVDD
PLIMIT
PVCCLPVCCLBSPLOUTPLPGNDOUTNLBSNLBSNROUTNRPGND
RINNRINP
NC
11121314
18171615
OUTPRBSPRPVCCRPVCCRPBTL
PWP (TSSOP) PACKAGE(TOP VIEW)
PWMLogic
GateDrive
GateDrive
PVCCL
PVCCL
GVDD
PVCCL
PVCCL
BSPL
PGND
OUTPL
OUTNL
PGND
GVDD
BSNL
PWMLogic
GateDrive
GateDrive
PVCCL
PVCCL
GVDD
PVCCL
PVCCL
BSNR
PGND
OUTNR
OUTPR
PGND
GVDD
BSPR
LINP
LINN
RINP
RINN
UVLO/OVLO
SC Detect
DC Detect
ThermalDetect
Startup ProtectionLogic
Biases andReferences
FAULT
SD
GAIN0
PLIMIT
AGND
AVCC
GAIN1Ramp
Generator
AVDD
GVDD
GVDD
LDORegulator
GainControl
PLIMIT
PBTL
GainControl
TTLBuffer
PBTLSelect
PBTL Select
PBTL Select
OUTPL FB
OUTNL FB
OUTNN FB
OUTNP FB
OUTPR FB
OUTNR FB
OUTNL FB
OUTPL FB
PLIMIT
GainControl
TTLBuffer
PLIMITReference
Block Diagrams EN 31TPM5.2E LA 9.
2010-Jun-25
9. Block Diagrams
Wiring Diagram 19", 22"
18840_401_100407.eps100428
KE
YB
OA
RD
CO
NT
RO
L PA
NE
L(1
057)
CN70113. 12. STB_PWR 5V11. STB_PWR 5V10. PWR 24V9. PWR 24V8. GND7. GND6. GND5. +12V4. +12V3. +12V2. BRIGHT_ADJ1. INVERTER_ON_OFF
CN
11.
N2.
LCN40112.11.5V_SW10.9. KEY28. KEY17. GND6. DV33SB5. DV33SB4. GND3. RC62. LED_G1. LED_R
WIRING DIAGRAM 19" & 22" (Dali)
SSB(1053)B
MAIN POWER SUPPLY(1054)
CN9021. STATUS2. 3. STB4. +24V5. GND6. GND7. GND8. +5.2V9. +5.2V10. DIM11. DIM12. LED-ON/OFF
RIGHT SPEAKER
Board Level Repair
Component Level RepairOnly For Authorized Workshop
CN
601
1. R
OU
T-2.
RO
UT
+3.
LO
UT-
4. L
OU
T+
A
LEFT SPEAKERIR/LED BOARD(1056)
CN0014P
CN3017P J
CN9031. +24V2. +24V3. +24V4. +24V5. +24V6. GND7. GND8. GND9. GND10.GND11. 12. LED-ON/OFF13. DIM14. STATUS
LCD DISPLAY
CN40930. GND29. AV3328. 5. ...4. VCC3. VCC2. VCC1. VCC
8409
8409
EN 32TPM5.2E LA 9.Block Diagrams
2010-Jun-25
Wiring Diagram 26"
18840_402_100407.eps100428
KE
YB
OA
RD
CO
NT
RO
L PA
NE
L(1
057)
CN70113. 12. STB_PWR 5V11. STB_PWR 5V10. PWR 24V9. PWR 24V8. GND7. GND6. GND5. +12V4. +12V3. +12V2. BRIGHT_ADJ1. INVERTER_ON_OFF
CN
11.
N2.
L
CN40112.11.5V_SW10.9. KEY28. KEY17. GND6. DV33SB5. DV33SB4. GND3. RC62. LED_G1. LED_R
WIRING DIAGRAM 26" (Dali)
SSB(1053)B
MAIN POWER SUPPLY(1054)
CN9021. STATUS2. 3. STB4. +24V5. GND6. GND7. GND8. +5.2V9. +5.2V10. DIM11. DIM12. LED-ON/OFF
RIGHT SPEAKER
Board Level Repair
Component Level RepairOnly For Authorized Workshop
CN
601
1. R
OU
T-2.
RO
UT
+3.
LO
UT-
4. L
OU
T+
A
LEFT SPEAKERIR/LED BOARD(1056) CN001
4PCN3017P J
CN9031. +24V2. +24V3. +24V4. +24V5. +24V6. GND7. GND8. GND9. GND10.GND11. 12. LED-ON/OFF13. DIM14. STATUS
LCD DISPLAY
CN40930. GND29. AV3328. 5. ...4. VCC3. VCC2. VCC1. VCC
8408
8401
Block Diagrams EN 33TPM5.2E LA 9.
2010-Jun-25
Block Diagram
18840_400_100412.eps100428
64 MB DDR2 × 2
NAND Flash 16MB24C64NVM
SPI
24C02HDMI EDID
REAR HDMI
TUNERNOR Flash 512KB
LED LCD Panel
CVBS1
24C02HDMI EDID
REAR HDMI
SIDE HDMI
ADIN4_SRV,ADIN2_SRV
IF BPF
CVBS1
SIDE AV
VGA24C02
VGA EDID OIRI, OPCTRL0
R1,G1,B1Component
VDAC_OUT1HP AMP
TPA6132A2
Audio AMPTPA3113D2
SCART AR0 AL0SCART
MP3/JPEGS/W upgrade/NVM clone
AR0,AL0
DRV603
CI card IN
TTL/ LVDS
EN 34TPM5.2E LA 10.Circuit Diagrams and PWB Layouts
2010-Jun-25
10. Circuit Diagrams and PWB Layouts
Power Board: 19", 22"
18840_500_100408.eps100428
AdapterA01 A01
2010-04-02A
715G3897Adapter
BD901 A1C900 D1C901 D2C902 A7C903 B3C904 B8C905 B7C906 D7C907 B3C908 F1C909 G6C910 E8C911 A8C912 E3C913 C8C914 C9C915 A6C916 E6C917 C3C918 B8C919 B4C920 B5C921 B8C922 B9C923 C8C924 D1C925 C6C926 F8C927 C10C928 C10C929 F4C930 E10C931 C5C932 G10C933 B5C934 D10C935 G6C936 B7C937 E9C938 D9C939 D9C951 E3CN901 H1CN902 B11CN903 C11D901 B6D903 B5D904 C4D905 A7D906 C7D907 C7D908 E2F901 G2FB901 A2FB902 G1FB903 H2FB904 F2FB905 B6FB906 D2FB907 D1FB908 C2FB909 C1HD905 B7HQ903 D5IC901 C3IC902 E6IC903 F8J902 G1J906 A2J907 F2J910 D6J915 H2
J919 E1J920 E1L902 E1L903 B8L904 A8L905 C1Q901 E4Q902 E5Q903 C6Q904 D9Q905 E9Q906 F10R900 F1R901 D2R902 F9R903 B7R904 B7R905 B7R906 G9R907 E2R908 F3R909 E5R910 B4R911 E2R912 C7R913 F11R914 F5R915 B6R916 A7R917 A7R918 C4R919 C5R920 C5R921 A7R922 D4R923 E7R924 F9R925 F6R926 E7R927 F7R928 E9R929 E9R930 G11R931 F8R932 F9R933 F11R934 B9R935 F10R936 A2R937 A5R939 E11R940 C9R941 D9R942 E10R944 D9R945 E11R946 E7RV901 E1SG901 E2SG902 E1SG903 C2SG904 C1T901 A6TH901 F1ZD902 B9ZD903 F7ZD904 F2ZD906 A5
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
A A
B B
C C
D D
E E
F F
G G
H H
HOT COLD
STB
NC
+24V
+5.2V
!
!
!
!
!
!
!
!
!
!
!
!
!
HV
!!
!
!
DIM
LED-ON/OFF
Status
L905LF-009561(NC)
L905LF-009561(NC)
1
2
4
3
R9113.3M 1/4W(NC)R9113.3M 1/4W(NC)
C912220P 50VC912220P 50V
FB907BEAD(NC)FB907BEAD(NC)
12
R9153.3 OHM 1/4WR9153.3 OHM 1/4W
C9351500pF / 250V(NC)C9351500pF / 250V(NC)
R901
3.3M 1/4W(NC)
R901
3.3M 1/4W(NC)
Q902PMBS3904(NC)Q902PMBS3904(NC)
C916220P 50VC916220P 50V
R9073.3M 1/4W(NC)R9073.3M 1/4W(NC)
R94447K +-5% 1/8WR94447K +-5% 1/8W
R9250R39 5% 1WR9250R39 5% 1W
D905SRF1060D905SRF1060
1
2
3
R908430KOHM +-5% 1/8W(NC)R908430KOHM +-5% 1/8W(NC)
SG901GS41-201MASG901GS41-201MA
+ C9131000uF 35V
+ C9131000uF 35V
R91910R 1/8W 5%R91910R 1/8W 5%
CN902
Wire Harness
CN902
Wire Harness
123456789
101112
J920JUMPERJ920JUMPER
12
C939
2U2 25V(NC)
C939
2U2 25V(NC)
ZD906P6KE150AZD906P6KE150A
12
IC902EL817M(X)
IC902EL817M(X)
1
23
4
J902JUMPERJ902JUMPER
12
R9391K 1/4W 5%R9391K 1/4W 5%
R946
430 OHM 1/4W
R946
430 OHM 1/4W
D903
FR103
D903
FR103
R917100 OHM 1/4WR917100 OHM 1/4W
C900
470pF/250V
C900
470pF/250V
C9150.0022uF/500VC9150.0022uF/500V
L9033.5uHL9033.5uH
R92022K 1/4WR92022K 1/4W
CN901
SOCKET
CN901
SOCKET
12
R916100 OHM 1/4WR916100 OHM 1/4W
SG902GS41-201MASG902GS41-201MA
T901
POWER X'FMR
T901
POWER X'FMR
1
2
35
6
78
910
1112
4
J919JUMPERJ919JUMPER
12
+ C92022uF/50V(NC)
+ C92022uF/50V(NC)
FB902BEAD(NC)FB902BEAD(NC)
12
+
C9382U2 50V+
C9382U2 50V
D901FR107D901FR107
J906JUMPERJ906JUMPER
1 2
C9061500pF / 250VC9061500pF / 250V
C934100N 50V
C934100N 50V
FB909BEADFB909BEAD
12
R936330 OHM 1/4W(NC)R936330 OHM 1/4W(NC)
R9331K 1/4W 5%(NC)R9331K 1/4W 5%(NC)
C925100PF 1KVC925100PF 1KV
J910
JUMPER(NC)
J910
JUMPER(NC)
12
C927100N 50V
C927100N 50V
F901FUSEF901FUSE
R903100 OHM 1/4WR903100 OHM 1/4W
R904100 OHM 1/4WR904100 OHM 1/4W
C9042.2nF 100V
C9042.2nF 100V
R9002M4 5% 1/2WR9002M4 5% 1/2W
R9421KOHM +-5% 2WS(NC)R9421KOHM +-5% 2WS(NC)
Q904AO4443
Q904AO4443
S1
S2
S3
G4
D8
D7
D6
D5
ZD903UDZSNP6.2BZD903UDZSNP6.2B
12
C928100N 50V(NC)C928100N 50V(NC)
-+
BD901GBU406
-+
BD901GBU406
2
1
3
4
FB901BEAD(NC)FB901BEAD(NC)
1 2
FB905BEAD(NC)FB905BEAD(NC)
12
C924
0.22UF275V(NC)
C924
0.22UF275V(NC)
R9060R051/8WR9060R051/8W
C9182.2nF 100V
C9182.2nF 100V
R92968K OHMR92968K OHM
R9451KOHM +-5% 2WS(NC)
R9451KOHM +-5% 2WS(NC)
R921100 OHM 1/4WR921100 OHM 1/4W
R9233K3 +-5% 1/8WR9233K3 +-5% 1/8W
R909
200OHM +-5% 1/8W
R909
200OHM +-5% 1/8W
FB908BEADFB908BEAD
12
R927100R 1/8W 5%R927100R 1/8W 5%
C9101N 50V(NC)C9101N 50V(NC)
L9043.5uHL9043.5uH
R9322K4 1/8W 1%R9322K4 1/8W 1%
CN903
Wire Harness
CN903
Wire Harness
123456789
1011121314
+ C930100uF 35V(NC)
+ C930100uF 35V(NC)
R93410 OHM 1/4W
R93410 OHM 1/4W
R90222R +-5% 1/8WR90222R +-5% 1/8WFB904
BEAD(NC)FB904BEAD(NC)
12
R94147K +-5% 1/8W
R94147K +-5% 1/8W
SG903GS41-201MA(NC)SG903GS41-201MA(NC)
C95110N 50V
C95110N 50V
C926100N 50VC926100N 50V
Q906RK7002FD5T116(NC)Q906RK7002FD5T116(NC)
D904
1N4148W
D904
1N4148W
C919100N 50V
C919100N 50V
L902
LF-009561
L902
LF-009561
1
2
4
3
tTH901SCK13074MMY502tTH901SCK13074MMY502
12
R905100 OHM 1/4WR905100 OHM 1/4W
D907SF35GD907SF35G
SG904GS41-201MA(NC)SG904GS41-201MA(NC)
C933220P 100V(NC)
C933220P 100V(NC)
RV901TVR14511KFC4FY
RV901TVR14511KFC4FY
R94047K +-5% 1/8WR94047K +-5% 1/8W
C91747N 50VC91747N 50V
ZD902P6KE20AZD902P6KE20A
12
R91020K +-5% 1/8WR91020K +-5% 1/8W
C932100N 50V(NC)C932100N 50V(NC)
+C914470UF 35V
+C914470UF 35V
Q905PMBT3904
Q905PMBT3904
R9141K 1/10W(NC)R9141K 1/10W(NC)
+ C907100uF 450V
+ C907100uF 450V
C901
470pF/250V
C901
470pF/250V
C9362.2nF 100VC9362.2nF 100V
C937100N 50VC937100N 50V
J907JUMPERJ907JUMPER
12
HQ903HQ903
1
2
C90310nFC90310nF
+ C9231000uF 35V(NC)
+ C9231000uF 35V(NC)
Q903STP10NK70ZFPQ903STP10NK70ZFP
R937100KOHM +-5% 2WS(NC)
R937100KOHM +-5% 2WS(NC)
+ C9051000uF/16V(NC)
+ C9051000uF/16V(NC)
R912100 OHM 1/4W(NC)R912100 OHM 1/4W(NC)+ C931
22uF/50V+ C931
22uF/50V
R930330K 1/8W 5%(NC)R930330K 1/8W 5%(NC)
IC901
LD7576AGR
IC901
LD7576AGR
CT1
COMP2
CS3
GND4
OUT5VCC6
HV8
C9112N2 50VC9112N2 50V
C929330N 25V(NC)C929330N 25V(NC)
R935100R 1/8W 5%(NC)R935100R 1/8W 5%(NC)
HD905HD905
1
2
D9081N4148(NC)D9081N4148(NC)
R913330K +-5% 1/8W(NC)R913330K +-5% 1/8W(NC)
IC903KIA431A-AT/PIC903KIA431A-AT/P
C9091500pF / 250V(NC)C9091500pF / 250V(NC)
R918100OHM +-5% 1/8WR918100OHM +-5% 1/8W
C9080.33UFC9080.33UF
J915JUMPERJ915JUMPER
12
FB903BEAD(NC)
FB903BEAD(NC)
12
C9022N2 50VC9022N2 50V
R92413K7 1/8W 1%(NC)R92413K7 1/8W 1%(NC)
ZD904UDZSNP6.2B(NC)ZD904UDZSNP6.2B(NC)
12
R9283K9 1/8W 1%
R9283K9 1/8W 1%
D906SF35GD906SF35G
FB906BEAD(NC)
FB906BEAD(NC)
12
R9221 MOHM +-5% 1/4W(NC)R9221 MOHM +-5% 1/4W(NC)
R9260R051/8WR9260R051/8W
+
C922470UF 16V
+
C922470UF 16V
Q901RK7002FD5T116(NC)Q901RK7002FD5T116(NC) R931
1K5 +-5% 1/8W
R931
1K5 +-5% 1/8W
+ C9211000uF 25V
+ C9211000uF 25V
Circuit Diagrams and PWB Layouts EN 35TPM5.2E LA 10.
2010-Jun-25
Layout Power Board 19", 22" (Top Side)
18840_501_100408.eps100428
SL9
M7
H1
IC902
TH901
C915
C913
C921
RV
901
HQ903
C90
8
D901ZD906
C92
5R900
L903
L904
H5
D905
C90
3
CN901
J903
L902
R925
RV902S
G90
2
SG
901
C922
C914
H6
FB901
C906
C900
C901
J910
BD901
H4F901
Q903
J904
FB
903
J915
L905C923
CN
902
CN
903
C924
R937
D903
FB905
J909
J905
J906
J912
C935
SG
904
SG
903
H2
C907
R942
D90
8
R945
J919
FB
906
J920
FB
907
J914
FB
908
FB
909
HD905
C909
D906
D907
R946
C931
C920
J901
C905
ZD
902
J921
J922
FB
902
FB904
J902
J907
J913
R929
C930
R93
3
R93
9
C938
T901
IC903
H7
H3
EN 36TPM5.2E LA 10.Circuit Diagrams and PWB Layouts
2010-Jun-25
Layout Power Board 19", 22" (Bottom Side)
18840_502_100408.eps100428
FD1
FD2
R904
R903
R916
R917
R92
7
R93
1
R919
R909
R92
3
R926
R928
R932
R910
R915R908
C91
7
C91
9C926
C95
1
C92
7C
928
C91
0
C912
C929
C93
3
R905
R921
R902 R901R907
R922
R920
R936
D904
ZD903
ZD904
C902
C90
4
C911
C918
R934
Q90
1
R914
C91
6
J916
J918
J917
C936
C93
7
R940
R941
R94
4Q90
4
R91
1
R906
Q90
2
C932
C93
4
R92
4
R930
R935
R918
Q906
C939
Q905
IC90
1
Circuit Diagrams and PWB Layouts EN 37TPM5.2E LA 10.
2010-Jun-25
Power Board: 26"
18840_503_100408.eps100408
AdapterA01 A01
2010-04-02A
715G3924Adapter
1
1
2
2
3
3
4
4
5
5
A A
B B
C C
D D
STB
Status
+12V
+24Vsnd
+24V
+5.2V
!
!
! !
!
!
!
!
! !
!
!
!
!
!
!
!
HV
!
!
!
LED_ON/OFF
DIM
HOT COLD
HOT COLD
HOT COLD
COLD
η
T3.15AH 250V
PT-012896
t
NR901SCK13074MMY502
t
NR901SCK13074MMY502
12
ZD907UDZSNP6.2B
ZD907UDZSNP6.2B
12
L9053.5uHL9053.5uH
C9182N2 50VC9182N2 50V
FB904BEADFB904BEAD
12
IC903KIA431A-AT/PIC903KIA431A-AT/P
D903BAV21D903BAV21
R9080R051/8WR9080R051/8W
ZD913P6KE13A
ZD913P6KE13A
12
R9111K 1/6W 5%(NC)R9111K 1/6W 5%(NC)
R946
10KOHM +-5% 1/8W
R946
10KOHM +-5% 1/8W
R94747KOHM 1/8W(NC)R94747KOHM 1/8W(NC)
R9091K 1/8WR9091K 1/8W
C9101N 50V(NC)C9101N 50V(NC)
C9150.0022uF/500VC9150.0022uF/500V
IC901
LD7576AGR
IC901
LD7576AGR
CT1COMP2CS3GND4 OUT 5VCC 6
HV 8
IC904EL817M(X)
IC904EL817M(X)
1
23
4
R9121K 1/8W(NC)
R9121K 1/8W(NC)
IC902EL817M(X)
IC902EL817M(X)
1
23
4
SG904SPG-201M-LF(NC)
SG904SPG-201M-LF(NC)
R910
2.2 OHM 1/4W
R910
2.2 OHM 1/4W
R904100R +-5% 1/4WR904100R +-5% 1/4W
R903100R +-5% 1/4WR903100R +-5% 1/4W
R9363.3M 1/4WR9363.3M 1/4W
+C93410uF 50V(NC)
+C93410uF 50V(NC)
C9360.22UF275V(NC)C9360.22UF275V(NC)
ZD903UDZSNP15B
ZD903UDZSNP15B
12
R9073K6 1/8W 1%R9073K6 1/8W 1%
R9224.7K1/2W(NC)
R9224.7K1/2W(NC)
C928100N 50V
C928100N 50V
RV901
TVR14511KFC4FY
RV901
TVR14511KFC4FY
+C929470uF 16V
+C929470uF 16V
Q910
PMBS3904(NC)
Q910
PMBS3904(NC)
D9201N4148D9201N4148
+ C94647UF 50V
+ C94647UF 50V
R917 68 OHM 1/4WR917 68 OHM 1/4W
+ C907120uF 450V
+ C907120uF 450V
C92410N 50VC92410N 50V
R933
JUMPER
R933
JUMPER
1 2
R955
0R051/8W
R955
0R051/8W
R924470OHM +-5% 1/8WR924470OHM +-5% 1/8W
R93915K 1/8WR93915K 1/8W
R906150OHM +-5% 1/8WR906150OHM +-5% 1/8W
Q906PMBS3904
Q906PMBS3904
FB903BEAD(NC)FB903BEAD(NC)
12
R91668 OHM 1/4WR91668 OHM 1/4W
C9112.2nF 100V
C9112.2nF 100V + C920
470uF 35V(NC)+ C920
470uF 35V(NC)
R905100R +-5% 1/4WR905100R +-5% 1/4W
R91347 OHM 1/4WR91347 OHM 1/4W
Q901BC857CQ901BC857C
R927100OHM +-5% 1/8WR927100OHM +-5% 1/8W
R915470OHM +-5% 1/8WR915470OHM +-5% 1/8W
ZD908GDZJ15B(NC)ZD908GDZJ15B(NC)
12
R93010K OHM +-5% 1/8WR93010K OHM +-5% 1/8W
L9043.5uHL9043.5uH
C9231N 50V
C9231N 50V
J905JUMPERJ905JUMPER
12
D901FR107D901FR107
-+
BD901GBU406
-+
BD901GBU406
2
1
3
4
D902
MBRF10150CT
D902
MBRF10150CT
12
3
R937100 OHM 1/4WR937100 OHM 1/4W
R95710K 1/8W 1%R95710K 1/8W 1%
R929
51K 1/6W 1%
R929
51K 1/6W 1%
ZD904UDZSNP18B
ZD904UDZSNP18B
12
C919100N 50V
C919100N 50V
ZD915MTZJ T-72 27B(NC)ZD915MTZJ T-72 27B(NC)
12
Q907BC857CQ907BC857C
CN901
SOCKET
CN901
SOCKET
12
C930100N 50V(NC)
C930100N 50V(NC)
C9060.0022uF/250V(NC)
C9060.0022uF/250V(NC)
R9343.3M 1/4WR9343.3M 1/4W
D905SR310-24D905SR310-24
1 2
C9050.0022uF/250V(NC)
C9050.0022uF/250V(NC)
SG902SPG-201M-LFSG902SPG-201M-LF
HQ903HQ903
1
2
R94510K 1/6W 5%R94510K 1/6W 5%
C908470NFC908470NF
C91747N 50VC91747N 50V
C941220N 50VC941220N 50V
C916330N 25VC916330N 25V
D904
1N4148W
D904
1N4148W
+ C921470uF 25V
+ C921470uF 25V
ZD910BZX79-C9V1ZD910BZX79-C9V1
12
+ C9551000uF 10V
+ C9551000uF 10V
C926100N 50VC926100N 50V
D917
SR104
D917
SR104
1 2
ZD902BZX79-C9V1ZD902BZX79-C9V1
12
R9250R39 5% 1WR9250R39 5% 1W
R9261K 1/8WR9261K 1/8W
R928470K 1/4WR928470K 1/4W
C927100N 50V(NC)
C927100N 50V(NC)
R9002M4 5% 1/2WR9002M4 5% 1/2W
C935150PF 1KVC935150PF 1KV
R9433.3M 1/4WR9433.3M 1/4W
T901
POWER X''FMR
T901
POWER X''FMR
1
2
35
6
78
910
1112
4
HD902HD902
1
2
C933220P 100VC933220P 100V
R94122K +-5% 1/8WR94122K +-5% 1/8W
C9250.47UF 50VC9250.47UF 50V
+ C9541000uF 10V
+ C9541000uF 10V
R932680R 1/8W 1%R932680R 1/8W 1%
IC905
TNY277PN-TL
IC905
TNY277PN-TL
EN/UV 1BP/M 2
D 4S5S6S7S8
+C922470uF 16V
+C922470uF 16V
L9033.5uHL9033.5uH
FB906BEADFB906BEAD
12
R93868 OHM 1/4WR93868 OHM 1/4W
R95611K 1/8W 1%R95611K 1/8W 1%
CN902
Wire Harness
CN902
Wire Harness
123456789
1011121314
SG901SPG-201M-LFSG901SPG-201M-LF
SG903SPG-201M-LF(NC)SG903SPG-201M-LF(NC)
R948100R +-5% 1/4WR948100R +-5% 1/4W
R970390K +-5% 1/8WR970390K +-5% 1/8W
R9233K3 +-5% 1/8WR9233K3 +-5% 1/8W
F901FUSEF901FUSE
L906
LF-009561(NC)
L906
LF-009561(NC)
1
2
4
3
R9652M2(NC)R9652M2(NC)
IC907EL817M(X)
IC907EL817M(X)
1
23
4Q909
PMBS3904Q909
PMBS3904
R9311K 1/8WR9311K 1/8W
C952100N 50VC952100N 50V
R9403K3 +-5% 1/8WR9403K3 +-5% 1/8W
C9090.0022uF/250V
C9090.0022uF/250V
C947100P 50VC947100P 50V
C900
470pF/250V
C900
470pF/250V
C93210N 50VC93210N 50V
FB905BEAD(NC)FB905BEAD(NC)
12
ZD914P6KE160AZD914P6KE160A
12
C912100P 50VC912100P 50V
R935100KOHM +-5% 2WS
R935100KOHM +-5% 2WS
C9382.2nF 100V
C9382.2nF 100V
D908SF35G(NC)D908SF35G(NC)
R953100R 1/6W 5%R953100R 1/6W 5%
R91910OHM +-5% 1/8WR91910OHM +-5% 1/8W
D916
FR103
D916
FR103
D907
1N4148(NC)
D907
1N4148(NC)
C9581N 50V(NC)C9581N 50V(NC)
FB901BEAD(NC)
FB901BEAD(NC)
12
FB902BEAD(NC)FB902BEAD(NC)
1 2
Q911PMBS3904Q911PMBS3904
D910SF35G(NC)D910SF35G(NC)
ZD906P6KE180A(NC)ZD906P6KE180A(NC)
R921100OHM +-5% 1/8WR921100OHM +-5% 1/8W
R94210KOHM +-5% 1/8WR94210KOHM +-5% 1/8W
L902
LF-009561
L902
LF-009561
1
2
4
3D909SRF1060D909SRF1060
1
2
3C9312N2 50VC9312N2 50V
+ C913680uF 35V
+ C913680uF 35V
Q903STP10NK70ZFPQ903STP10NK70ZFP
R95147OHM +-5% 1/8W
R95147OHM +-5% 1/8W
C9392N2 50VC9392N2 50V
+ C937680uF 35V
+ C937680uF 35V
D915FR107D915FR107
ZD909UDZSNP15BZD909UDZSNP15B
12
C901
470pF/250V
C901
470pF/250V
3
T902PPH7019AL
3
T902PPH7019AL
2
1
4
5
7
8
10
9
R9020R051/8WR9020R051/8W
R91447 OHM 1/4WR91447 OHM 1/4W
C9450.0022uF/500V
C9450.0022uF/500V
C953100N 50VC953100N 50V
+ C914330uF 35V
+ C914330uF 35V
R918100OHM +-5% 1/8WR918100OHM +-5% 1/8W
C904100N 450V(NC)C904100N 450V(NC)
IC908
KIA431A-AT/P
IC908
KIA431A-AT/P
R92022K +-5% 1/8WR92022K +-5% 1/8W
HeatsinkHD909HeatsinkHD909
1
CN903
Wire Harness
CN903
Wire Harness
123456789
1011121314
RV902TVR14561KFC4FY(NC)RV902TVR14561KFC4FY(NC)
R9441K5 +-5% 1/8WR9441K5 +-5% 1/8W
ZD912BZX79-C9V1(NC)ZD912BZX79-C9V1(NC)
1 2
C9022N2 50VC9022N2 50V
BD901 A1C900 B1C901 B1C902 A4C904 A1C905 B3C906 C3C907 A2C908 C1C909 D3C910 B4C911 A4C912 B2C913 B4C914 A4C915 A3C916 D2C917 B2C918 A4C919 A2C920 A5C921 A4C922 A4C923 B3C924 C2C925 A2C926 B4C927 C5C928 C4C929 C3C930 D5C931 C3C932 D4C933 A3C934 A2C935 A3C936 B1C937 B4C938 A4C939 C3C941 B2C945 C2C946 C2C947 D2C952 D3C953 D2C954 C3C955 C3C958 B4CN901 D1CN902 C5CN903 C5D901 A3D902 A3D903 A2D904 B2D905 A3D907 B4D908 B3D909 C3D910 B3D915 C2D916 C2D917 A4D920 D1F901 D1FB901 D1FB902 A1FB903 D1FB904 B1FB905 A3FB906 B1HD902 B4HD909 C3HQ903 B3IC901 A2IC902 B3IC903 B3IC904 C4IC905 D1IC907 D3IC908 D3J905 A1L902 C1L903 A4L904 A4
L905 C3L906 B1NR901 D1Q901 D2Q903 B3Q906 B2Q907 B2Q909 D4Q910 B4Q911 B1R900 C1R902 B3R903 A3R904 A3R905 A3R906 C4R907 B4R908 D3R909 B2R910 C2R911 B4R912 B4R913 C3R914 C3R915 A3R916 A3R917 A3R918 B2R919 B2R920 B3R921 B2R922 B4R923 B3R924 D2R925 B3R926 B3R927 B3R928 D2R929 B4R930 B2R931 B4R932 C4R933 D2R934 C1R935 A2R936 C1R937 A4R938 A3R939 C2R940 D3R941 C2R942 C2R943 C1R944 C4R945 D4R946 B2R947 D4R948 A3R951 C2R953 C3R955 D3R956 D3R957 D3R965 C1R970 D2RV901 C1RV902 A1SG901 C1SG902 C1SG903 B1SG904 B1T901 A3T902 C3ZD902 D2ZD903 B3ZD904 A2ZD906 A2ZD907 D3ZD908 B3ZD909 D2ZD910 D1ZD912 C1ZD913 A4ZD914 C2
EN 38TPM5.2E LA 10.Circuit Diagrams and PWB Layouts
2010-Jun-25
Layout Power Board 26" (Top Side)
18840_504_100408.eps100428
H1
SL1
SL2
SL3
SL4
C915
NR
901
RV901
RV902
IC902
C946
C913
R925
J915
J902
C922
SG
901
C914
D903
C934
C920
C935
J925
IC904
IC907
C937
FB
902
J906
D920
ZD912
J905
G1
C904C945
C929
IC905
R922
H4
HD902
L903
L904
L905
T902
L906
HQ903
D909
Q903
R900
SG
903
SG
904
HD909
FB
905
J917
J904
ZD
913
D915
R953
R945D917
R929
ZD
915J903
J910
J908
F901
D907
CN902
J907
ZD
902
J922
J921
J920
FB903J919
FB901
J911
J914
J912
J913
G2
G3
G4
C936
ZD908
R911
R935
ZD
906 D908
D910
D905
C907
D902
CN903
C908
D901
R933 D
916
ZD
910
L902
T901
BD901
C905
C906
C909
C900
C901
ZD914C
954
C921
C957
SG
902
IC903
IC908
CN
901
FB
904
FB
906
Circuit Diagrams and PWB Layouts EN 39TPM5.2E LA 10.
2010-Jun-25
Layout Power Board 26" (Bottom Side)
18840_505_100408.eps100428
FDM6
FD
M7
C910
C912
C917
C919
C923
C924
C926
C927C928
C932
C947
C952
R918
R919
R923
R926
R927
R931
R932
R907
R940
R941
R944
R947
R955
R957
R970
R903
R904
R916
R917
Q907 Q
909
R909
C953 R956
C916
Q901
C925
C931
R915
R906
Q906
R920
C933
R924
R951
R942C930
D904
ZD903
ZD909
C911
C918
ZD907
R908
R913
R902
R939
C902C
938
C939
R905
R910
R914
R938
C958
R912
Q910
R930
R965
R943
R936
R934
ZD
904
R921
R937
C941
R946
R948
Q911
R928
J924
IC901
EN 40TPM5.2E LA 10.Circuit Diagrams and PWB Layouts
2010-Jun-25
SSB: Power-1
18840_506_100408.eps100408
Power-1B01 B01
2010-04-021
Power-1 715G3735
18840_500_100408.eps100428
18840_500_100408.eps100428
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
A A
B B
C C
D D
E E
F F
G G
H H
STAND_BY:Normal: LowStand_by: Hight
OPWRSB(DV11 ON/OFF):Normal: HighStand_By: Low
SMD/0402
STANDBY or Light_snesorNormal: HighStand_by: Low
FOR DVD model POWER
STANDBY:Normal: HighStand_by: Low
BRIGHT_ADJ:Normal:Max:+3V3, Min:0VStand_By:0V
INVERTER_ON_OFF:Normal: HighStand_By: Low
DC POWER INPUT
+5V_STB TO +5V_SW BY DV11
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
DV11(+5V_SW ON/OFF):Normal: HighStand_By: Low
PWR_24_16V TO +24_16V BY STANDBY (Sound)
STANDBY:Normal: HightStand_by: Low
SMD
STAND_BY
INVERTER_ON_OFFBRIGHT_ADJ
STANDBY
DV11
OPWRSB
STANDBY
POWER_DETECT
STANDBY
Light_Sensor
STB_PWR_5V +5V_STB
DV33
STB_PWR_5V
+5V1_DVD+5V_STB
+5V_SW
PWR_24V_16V
+5V_STB +5V_SW
DV11
+5V_STB
PWR_12V
DV18_DDR
PWR_24V_16V +24V_16V
+24V_16V
DV33
DV33
C7241UF16V
C7241UF16V
+ C732100uF 35V
+ C732100uF 35V
R70833K 1/10W
R70833K 1/10W
R725100OHM1/16W
R725100OHM1/16W
R707R707NC
Q702BC847CQ702BC847C
3
2
1
C708100N 16VC708100N 16V
FB705220R/2000mA
FB705220R/2000mA
12
FB701 120R/3000mAFB701 120R/3000mA
1 2FB702 120R/3000mAFB702 120R/3000mA
1 2
F701NC/1.5A 125V 045101.5MRL
F701NC/1.5A 125V 045101.5MRL
U702IC AP1117DL-13 TO252-3L
U702IC AP1117DL-13 TO252-3L
VIN3
VOUT2
AD
J(G
ND
)1
R70410K1/16W
R704
TP
706
TP
706
1
R724NC/10K 1/10W
R724NC/10K 1/10W
C717100N 16V
C717100N 16V
R722NC/1R 1/2W 1%R722NC/1R 1/2W 1%
R7183.3K 1/16WR7183.3K 1/16W
+ C703NC/100uF 10V
+ C703NC/100uF 10V
R733NC/22KOHM 1/10W
R733NC/22KOHM 1/10W
+ C714330UF 16V
+ C714330UF 16V
R71956R 1/10W 1%R71956R 1/10W 1%
+ C712100uF 10V
+ C712100uF 10V
R7144.7K1/16W
R7144.7K1/16W
U701MP9403
U701MP9403
BS1
IN2
SW3
GND4
FB5COMP6EN7SS8Thermal Pad9
R701NC/22KOHM 1/10WR701NC/22KOHM 1/10W
C7181500P50V
C7181500P50V
Q704AON4421
Q704AON4421
D1
D2
D3
G4
S5 D6 D7 D8
+
C721220uF 16V
+
C721220uF 16V
C70410N 50V
C70410N 50V
+
C7314.7UF 50V
+
C7314.7UF 50V
CN4071NC/CONNCN4071NC/CONN
1234
R71
712
0R 1
% 1
/10W
R71
712
0R 1
% 1
/10W
CN701
CONN
CN701
CONN
12345678910111213
C726NC/100N 16VC726NC/100N 16V
C70122uF 10VC70122uF 10V
R71647K1/16W
R71647K1/16W
C71910uF 16V
C71910uF 16V
R703NC/10K 1/4WR703NC/10K 1/4W
R710NC/4.7K1/16W
R710NC/4.7K1/16W
L70115uHL70115uH
R738NC/0R05 1/4W
R738NC/0R05 1/4W
FB707NC/220R/2000mA
FB707NC/220R/2000mA
1 2
Q706NC/BC847CQ706NC/BC847C
3
2
1
C725NC/10uF/10VC725NC/10uF/10V
TP
703
TP
703
1
C72210uF 16VC722
10uF 16V
TP
704
TP
704
1
+C702470uF 16V
+C702470uF 16V
C715100N 16VC715100N 16V
R71122KOHM 1/10W
R71122KOHM 1/10W
R728NC/43K
R728NC/43K
R7310R05 1/10WR7310R05 1/10W
R715NC/1R 1/2W 1%R715NC/1R 1/2W 1%
R7290R05 1/4W
R7290R05 1/4W
TP
701
TP
701
1
R7052K7 1/16W 5%R7052K7 1/16W 5%
R730NC/33K 1/10W
R730NC/33K 1/10W
R7121K1/16W
R7121K1/16W
R7203.92K +-1% 1/10W
R7203.92K +-1% 1/10W
C72010N 50V
C72010N 50V
D701NC/SS3P4D701NC/SS3P4
12
TP
707
TP
707
1
C7064.7UF 10V
C7064.7UF 10V
Q703NC/AON4421Q703NC/AON4421
D1
D2
D3
G4
S5 D6 D7 D8
+ C711100uF 10V
+ C711100uF 10V
C7054.7UF 10VC7054.7UF 10V
R713NC
R713
TP
705
TP
705
1
Q701NC/BC847CQ701NC/BC847C
3
2
1
C710NC/100N 16V
C710NC/100N 16V
C7091UF16V
C7091UF16V
R73515K 1/16W
R73515K 1/16W
FB703 NC/120R/3000mAFB703 NC/120R/3000mA
1 2
Q707
NC/AO4435
Q707
NC/AO4435
S1
S2
S3
G4
D8
D7
D6
D5
C735NC/100N 16V
C735NC/100N 16V
TP
702
TP
702
1
R73710K1/16W
R737
R72110.2KOHM +-1% 1/10WR72110.2KOHM +-1% 1/10W
Q705NC/BC847C
Q705NC/BC847C
+C713330UF 16V+C713330UF 16V
R702NC/33K 1/10W
R702NC/33K 1/10W
FB706220R/2000mA
FB706220R/2000mA
12
R736100K1/16WR736100K1/16W
C707NC/4.7uF 6.3V
C707NC/4.7uF 6.3V
C716NC/180P 50VC716NC/180P 50V
C701 C2C702 B5C703 F6C704 D2C705 B8C706 F6C707 C8C708 B5C709 E1C710 G6C711 G1C712 B9C713 D3C714 G3C715 D4C716 E2C717 E2C718 D3C719 D1C720 E2C721 G2C722 G3C724 G2C725 F7C726 F8C731 D7C732 D8C735 E7CN4071 F8CN701 B1D701 D2F701 F8FB701 B4FB702 B4FB703 B4FB705 D1FB706 G2FB707 F7L701 D3Q701 G6Q702 B8Q703 F6Q704 B8Q705 C3Q706 E7Q707 D7R701 G6R702 G6R703 C1R704 G6R705 B7R707 G6R708 B8R710 C3R711 B8R712 B3R713 B3R714 E1R715 F7R716 E2R717 G3R718 E2R719 G3R720 D3R721 E3
R722 F7R724 E7R725 C2R728 D7R729 D7R730 D7R731 E3R733 D7R735 D8R736 D8R737 G6R738 F6TP701 B1TP702 B1TP703 B1TP704 B1TP705 B1TP706 B1TP707 B1U701 D2U702 G2
Circuit Diagrams and PWB Layouts EN 41TPM5.2E LA 10.
2010-Jun-25
SSB: Power-2
18840_507_100408.eps100428
Power-2B02 B02
2010-04-021
Power-2 715G3735
C723 E1C727 E2C752 E3C753 E1C754 D6C755 C2C757 C3C758 B3C759 F5C761 A1C762 A2C763 C1C764 B4C765 A3C767 A4Q750 D6Q751 E6R750 E5R751 D5R752 D5R753 F5R755 E6R756 B3R757 C3R758 E6R759 E2R760 E2R761 F2R762 E2R765 E6R767 C2U750 A1U751 A3U752 B1U753 B3U754 D1
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
A A
B B
C C
D D
E E
F F
G G
H H
PANEL_VCC_ON/OFF
+5V_TUNER
AV12
DV33SB+5V_STB
AV33
+5V_SW
+5V_SW
DV33
+5V_STB
PANEL_VCC
PWR_12V
AV33
+5V_SW
AV33
+5V_STB2,6,8
DV33SB8,12,13,14
DV332,4,5,6,8,9,12,13,14
PWR_12V2
PANEL_VCC_ON/OFF6
PANEL_VCC14
+5V_TUNER4
AV124,5,6,7,12,14
GND2,4,5,6,7,8,9,10,11,12,13,14
AV336,12,14
+5V_SW2,6,8,9,11,12,13,14
Vo=1.25 x (1+1R/120R) = 1.25V
DV33 TO AV12
+5V_STB TO DV33SB+5V_SW TO AV33
+5V_SW TO DV33
PANEL_VCC_ON/OFF(PANEL_VCC ON/OFF):Normal: HighStand_By: Low
+5V_STB OR PWR_12V TO PANEL VCC
LVDS Control Interface
SMD
SMD
SMDSMD
Q7512SC2412KRQ7512SC2412KR
3
2
1
C759NC/100N 16V
C759NC/100N 16V
R7510R05 4A 1/4W
R7510R05 4A 1/4W
C76510uF 16V
C76510uF 16V
C7631UF16VC7631UF16V
+ C762100uF 10V
+ C762100uF 10V
+C752100uF 16V
+C752100uF 16V
R75533K 1/10W
R75533K 1/10W
R75010K 1/10W
R75010K 1/10W
R7650R05 1/10WR7650R05 1/10W
R7621K 1/16W 1%R7621K 1/16W 1%
+ C755100uF 16V
+ C755100uF 16V
+ C764100uF 16V
+ C764100uF 16V
R753NC/10K 1/10W
R753NC/10K 1/10W
C723100N 16VC723100N 16V
U751IC G903T63UF 0.6A/3.3V SOT-223
U751IC G903T63UF 0.6A/3.3V SOT-223
VIN3 VOUT 2
GN
D1
44
R756120R 1% 1/10W
R756120R 1% 1/10W
R7614K7 1/16W 1%R7614K7 1/16W 1%
Q750AON4421
Q750AON4421
D 1
D 2
D 3
G 4S5D6D7D8
C7611UF16V
C7611UF16V
+C753
100uF 16V
+C753
100uF 16V
R76020K 1/16W 1%R76020K 1/16W 1%
U752 IC G1117-33T43UF 1A/3.3V TO-252
U752 IC G1117-33T43UF 1A/3.3V TO-252
AD
J(G
ND
)1
VO
UT
(TA
B)
2V
IN3
C727100N 16VC727100N 16V
C7541UF16VC7541UF16V
C76710uF 16VC767
10uF 16V
C757NC/10U 16V
C757NC/10U 16V
R759
20K 1/16W
1%R
75920K
1/16W 1%
U753IC AP1117DL-13 TO252-3L
U753IC AP1117DL-13 TO252-3L
VIN3 VOUT 2
AD
J(G
ND
)1
R752NC/0R05 4A 1/4W
R752NC/0R05 4A 1/4W
R7571 OHM 1/10W
R7571 OHM 1/10W
R767NC/0R05 1/4W
R767NC/0R05 1/4W
U750 IC G1117-33T43UF 1A/3.3V TO-252
U750 IC G1117-33T43UF 1A/3.3V TO-252
AD
J(G
ND
)1
VO
UT
(TA
B)
2V
IN3
R75822KOHM 1/10W
R75822KOHM 1/10W
C75810uF 16V
C75810uF 16V
U754IC SC4215HSETRT SO-8
U754IC SC4215HSETRT SO-8
NC1EN2VIN3NC4
GND 8FB 7VO 6NC 5
TH
19
EN 42TPM5.2E LA 10.Circuit Diagrams and PWB Layouts
2010-Jun-25
SSB: Tuner
18840_508_100408.eps100428
TunerB03 B03
2010-04-021
Tuner 715G3735
H
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
A A
B B
C C
D D
E E
F F
G G
H H
TUNER_CLK_Demod
IF_AGCT
RF_AGC_NXP
IF_AGCIF_AGCT_T
TU_FAT_IN2-TU_FAT_IN2+
FAT-
T_SCLTUNER_DATA_DemodT_SDA
FAT+
LNA_ON/OFF
FAT_IN+
FAT_IN-
TUNER_BYPASS_In
TUNER_CVBS
MPX_N
MPX_PMPX_P1TU_MPX_P2
MPX_N1
CVBS0PTUNER_CVBS1
TU_MPX_P2
TUNER_CVBS1
RF_AGC_NXP
+5V_T1
+5V_T1T_SCLT_SDA
IF_AGCT_T
RF_AGC_TUNER
RF_AGC RF_AGCT
+5V_T1
FAT-FAT+
DV
12_V
AD
C
TUNER_DATA
TSYNCTCK
TDO
TVAVLID
DV33_DVBC
TUNER_DATA_Demod
CI_INDATA5
CI_INDATA4
CI_INDATA6
DV12_DVBC
TUNER_CLK_Demod
DV
12_D
VB
C
DV12_VADC
TUNER_DATA
TUNER_CLK_Demod
FAT_IN+_C
DV
12_D
VB
C
TUNER_DATA_Demod
FAT_IN-_C
TUNER_CLK
CI_INDATA1CI_INDATA2
DV
33_D
VB
C
DV33_DVBC
TUNER_CLK
CI_INDATA7
CI_INDATA3
FAT_IN-_C
FAT_IN+_C
TU_FAT_IN2-
TU_FAT_IN2+TU_FAT_IN2+_T
TU_FAT_IN2+
TU_FAT_IN2-_T TU_FAT_IN2-
TU_FAT_IN2+_T
TU_FAT_IN2-_T
SYSTEM_REST
IF_AGC_C
IF_AGC_C IF_AGC
M_AOLRCK
TCK
CI_INCLK
CI_INVALID
TDO CI_INDATA0
TVAVLID
TSYNC CI_INSYNC
GND_Tuner
GND_Tuner
GND_Tuner
GND_TunerGND_Tuner
GND_Tuner
GND_Tuner
GND_Tuner
+5V_TUNER
+5V_TUNER
GND_TunerGND_Tuner
GND_Tuner
GND_Tuner
GND_Tuner
GND_TunerGND_Tuner
GND_Tuner
GND_Tuner
AV12
AV12
DV33
DV33_DVBC
DV33_DVBC
GND_Tuner
+5V_TUNER
GND_TunerGND_TunerGND_Tuner
DV33_DVBC
DV33
FAT_IN-6FAT_IN+6TUNER_DATA6TUNER_CLK6IF_AGCT6RF_AGCT6
DV332,3,5,6,8,9,12,13,14AV333,6,12,14AV123,5,6,7,12,14
5,2 11VD
+5V_TUNER3
GND2,3,5,6,7,8,9,10,11,12,13,14
LNA_ON/OFF9
6 P_XPM6 N_XPM
TUNER_BYPASS_In6CVBS0P6
DV33SB3,8,12,13,14DV18_DDR2,7
RF_AGC_TUNER9
TDO9TCK9
TVAVLID9TSYNC9
CI_INSYNC9CI_INCLK9
CI_INDATA49CI_INDATA59CI_INDATA69CI_INDATA79
CI_INDATA09CI_INDATA19CI_INDATA29CI_INDATA39
CI_INVALID9
+5V_SW2,3,6,8,9,11,12,13,14
SYSTEM_REST9
M_AOLRCK5,6
SMD/0402 SMD/0402
Tuner Control Interface
IF BPF
A/V Filter
As Closed as to Main Chip
NUTUNE FH2607
SMD/0402
SMD/0402 SMD/0402
SMD/0402SMD/0402
SMD/0402 SMD/0402
SMD/0402
SMD/0402
SMD/0402
Close to MT5363
SMD/0402
Video Input
Others Control Interface
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402SMD/0402SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402SMD/0402
DVB-C Demod
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
DVB-C Control Interface
Item S30
FrontBack
SMD/0402
SMD/0402
10/06 TDTW-S810D
DVB-C IF Filter
SMD/0402
R100510K1/16W
R100510K1/16W
C101039pF 50VC101039pF 50V
FB1017120R/3000mA
FB1017120R/3000mA
1 2
FB1023
NC/60 OHM
FB1023
NC/60 OHM12
FB1024120R/3000mAFB1024120R/3000mA
1 2
C101833P 50VC101833P 50V
R10100R05OHM1/16WR10100R05OHM1/16W
R1041 0R05OHM1/16WR1041 0R05OHM1/16W
FB1001120R/3000mA
FB1001120R/3000mA
1 2
C1049NC/10P 50VC1049NC/10P 50V
C1101NC/100N 16VC1101NC/100N 16V
TU101TU101
NC 1
LNA ON/OFF 2
GND 3
+B(5V) 4
RF AGC 5
GND 6
SDA 7
SCL 8
MOPLL AS 9
Digital(+) 10
Digital(-) 11
IF AGC 12
NC 13
NC 14
NC 15
NC 16TH
117
TH
218
TH
319
TH
420
R10500R05 1/10W
R10500R05 1/10W
C1041NC/100N 16VC1041NC/100N 16V
FB1016120R/3000mA
FB1016120R/3000mA
1 2
C110010N 50V
C110010N 50V
C1045NC/100N 16VC1045NC/100N 16V
R100810K1/16W
R100810K1/16W
FB1012120R/3000mA
FB1012120R/3000mA
1 2
R1047 NC/0R05 1/16WR1047 NC/0R05 1/16W
TU102NC/TUNERTU102NC/TUNER
RF Pin In/Out 1
Ant Pwr 2
GND 3
NC 4
RF AGC 5
GND 6
VP(TUN) 7
VT 8
GND 9
NC 10
AS 11
SCL 12
SDA 13
NC 14
IF_AGC 15
DIF1 16
DIF2 17
WIF OUT 18
NC 19
NC 20
NC 21
NC 22
NC 23
NC 24TH
125
TH
226
TH
327
TH
428
C101933P 50VC101933P 50V
R10490R05 1/10W
R10490R05 1/10W
R1011300R 1/10W 1%
R1011300R 1/10W 1%
C1034NC/100N 16VC1034NC/100N 16V
R1021NC/0R05 1/16W
R1021NC/0R05 1/16W
C1007NC/100N 16VC1007NC/100N 16V
R10380R05OHM1/16W
R10380R05OHM1/16W
L1005NC/0.22uH 10%
L1005NC/0.22uH 10%
FB1007120R/3000mAFB1007120R/3000mA
1 2
C1004100N 16VC1004100N 16V
C1040NC/10uF 6.3VC1040NC/10uF 6.3V
R100710K1/16WR100710K1/16W
R10340R05OHM1/16W
R10340R05OHM1/16W
C1033NC/100N 16VC1033NC/100N 16V
FB1000120R/3000mA
FB1000120R/3000mA
1 2
R1004NC/4.7K1/16W
R1004NC/4.7K1/16W
C101247N16VC101247N16V
R10460R05OHM1/16W
R10460R05OHM1/16W
C100110uF 16VC100110uF 16V
R1033NC/10K1/16W
R1033NC/10K1/16W
C1044 NC/56pF 50VC1044 NC/56pF 50V
RP1003NC/0OHM 1/16W
RP1003NC/0OHM 1/16W
1234
8765
FB1011120R/3000mA
FB1011120R/3000mA
1 2
C102022P 50V
C102022P 50V
+ C1000330uF 10V
+ C1000330uF 10V
R1016NC/4.7K1/16W
R1016NC/4.7K1/16W
R1030NC/100R 1/16W 5%
R1030NC/100R 1/16W 5%
C1037NC/100N 16VC1037NC/100N 16V
R1000NC/75OHM1/16W
R1000NC/75OHM1/16W
FB1015
NC/120R/3000mA
FB1015
NC/120R/3000mA12
R1001NC/75OHM1/16W
R1001NC/75OHM1/16W
L1009 NC/0.22uH 10%L1009 NC/0.22uH 10%
R1012300R 1/10W 1%
R1012300R 1/10W 1%
C1097NC/10N 50V
C1097NC/10N 50V
R1028NC/0R05 1/10W
R1028NC/0R05 1/10W
FB1022120R/3000mA
FB1022120R/3000mA
1 2
R1018NC/0R05 1/16W
R1018NC/0R05 1/16W
R1076NC/0R05OHM1/16W
R1076NC/0R05OHM1/16W
C1096NC/100N 16VC1096NC/100N 16V
R1037NC/4.7K1/16W
R1037NC/4.7K1/16W
C102233P 50V
C102233P 50V
FB1008NC/120R/3000mAFB1008NC/120R/3000mA
1 2
L10020.33uH 10%
L10020.33uH 10%
R1027NC/0R05 1/10W
R1027NC/0R05 1/10W
FB1005120R/3000mA
FB1005120R/3000mA
1 2
C1031 100P 50VC1031 100P 50V
R1019NC/1K1/16W
R1019NC/1K1/16W
FB1014120R/3000mA
FB1014120R/3000mA
1 2
TP1000TP1000
FB1009NC/120R/3000mAFB1009NC/120R/3000mA
1 2
C1098NC/100N 16VC1098NC/100N 16V
C101347N16VC101347N16V
C1005NC/27P 50VC1005NC/27P 50V
C101547N16VC101547N16V
C101139pF 50VC101139pF 50V
L10030.33uH 10%
L10030.33uH 10%
L1008 NC/0.22uH 10%L1008 NC/0.22uH 10%
C1046NC/100N 16V
C1046NC/100N 16V
R1017NC/0R05 1/16W
R1017NC/0R05 1/16W
C102410uF 6.3VC102410uF 6.3V
C1026NC/47pF 50VC1026NC/47pF 50V
C1027NC/10N 16V
C1027NC/10N 16V
U1000NC/G552B1TA1U
U1000NC/G552B1TA1U
VOUT1
GN
D2
FLAG 3ON/ON4
VIN 5
C1016220pF 50VC1016220pF 50V
R1096NC/0R05OHM1/16W
R1096NC/0R05OHM1/16W
U101NC/Si2163U101NC/Si2163
GN
D1
AG
C_I
F2
AG
C_R
F3
SC
L_H
OS
T4
SD
A_H
OS
T5
VD
D_C
OR
E6
TS
_VA
L7
TS
_SY
NC
8
TS
_CLK
9
GN
D10
ADC_IP29ADC_IN30ADC_CP31
SDA_MAST33
ADC_CN32
SCL_MAST34RESSI_ADC35GPIO_036
VD
D_V
AD
C28
VD
DH
_AN
A27
AD
DR
26
XT
AL_
I25
XT
AL_
O24
VD
D_V
CO
RE
23
RE
SE
TB
22
TS
_ER
R/G
PIO
_221
TS
_DA
TA
720
GN
D19
TS_DATA0 11
TS_DATA1 12
TS_DATA2 13
VDD_HVIO 15
TS_DATA4 16
TS_DATA5 17
TS_DATA3 14
TS_DATA6 18
GND37
FB1002120R/3000mA
FB1002120R/3000mA
1 2
C1042NC/10P 50VC1042NC/10P 50V
C1008NC/100N 16VC1008NC/100N 16V
C1023100N 16VC1023100N 16V
C1035NC/100N 16VC1035NC/100N 16V
RP1001NC/0OHM 1/16W
RP1001NC/0OHM 1/16W
1234
8765
R1040NC/0R05 1/10W
R1040NC/0R05 1/10W
FB1006220R/2000mA
FB1006220R/2000mA
1 2
R1036NC/4.7K1/16WR1036NC/4.7K1/16W
R1043NC/0R05 1/16W
R1043NC/0R05 1/16W
R1039NC/100OHM1/16W
R1039NC/100OHM1/16W
R1026NC/0R05 1/10W
R1026NC/0R05 1/10W
C1102NC/100N 16V
C1102NC/100N 16V
R10024.7K1/16W
R10024.7K1/16W
R1025NC/0R05 1/16W
R1025NC/0R05 1/16W
C1028NC/10N 16V
C1028NC/10N 16V
L10000.22uH 10%
L10000.22uH 10%
C10091N 50VC10091N 50V
C1029NC/1N 50VC1029NC/1N 50V
C1039NC/100N 16VC1039NC/100N 16V
C1025NC/15PF50VC1025NC/15PF50V
R10480R05 1/10W
R10480R05 1/10W
C1003100N 16VC1003100N 16V
R10450R05OHM1/16W
R10450R05OHM1/16W
C1043 NC/56pF 50VC1043 NC/56pF 50V
C101447N16VC101447N16V
C109910N 50V
C109910N 50V
C1038NC/100N 16VC1038NC/100N 16V
FB1019120R/3000mA
FB1019120R/3000mA
1 2
X1000
NC/16MHz
X1000
NC/16MHz
12
34
RP1000NC/0OHM 1/16W
RP1000NC/0OHM 1/16W
1234
8765
R1024NC/100K1/16W
R1024NC/100K1/16W
FB1003120R/3000mA
FB1003120R/3000mA
1 2
C1036NC/100N 16VC1036NC/100N 16V
R1059NC/0R05OHM1/16W
R1059NC/0R05OHM1/16W
L10010.22uH 10%
L10010.22uH 10%
R1035NC/100OHM1/16W
R1035NC/100OHM1/16W
C1017220pF 50V
C1017220pF 50V
C1006NC/27P 50VC1006NC/27P 50V
FB1004120R/3000mA
FB1004120R/3000mA
1 2
Q1001NC/BC857CQ1001NC/BC857C
R1042 0R05OHM1/16WR1042 0R05OHM1/16W
R1044 NC/0R05 1/16WR1044 NC/0R05 1/16W
C102122P 50VC102122P 50V
U103NC/TS5A3157DCKR
U103NC/TS5A3157DCKR
NO1
GND2
NC3 COM 4V+ 5IN 6
C1030NC/1N 50VC1030NC/1N 50V
R1006
10K1/16W
R1006
10K1/16W
R1029NC/100R 1/16W 5%
R1029NC/100R 1/16W 5%
R10034.7K1/16WR10034.7K1/16W
C1095NC/10uF 6.3VC1095NC/10uF 6.3V
C1000 A5C1001 A5C1003 A4C1004 A5C1005 H3C1006 H3C1007 G7C1008 G7C1009 A3C1010 B3C1011 B3C1012 B4C1013 C4C1014 C6C1015 B7C1016 B5C1017 B5C1018 D4C1019 E4C1020 D4C1021 E4C1022 D4C1023 G2C1024 G2C1025 D6C1026 D7C1027 C8C1028 D8C1029 D8C1030 D8C1031 B3C1033 C1C1034 C1C1035 C1C1036 C2C1037 D1C1038 D1C1039 D1C1040 D2C1041 G2C1042 F4C1043 G6C1044 G6C1045 G7C1046 G7C1049 F5C1095 E1C1096 E1C1097 F1C1098 G2C1099 D5C1100 D5C1101 A2C1102 A1FB1000 A8FB1001 B8FB1002 B8FB1003 B8FB1004 B8FB1005 B8FB1006 A5FB1007 A4FB1008 D2FB1009 D1FB1011 B8FB1012 B8FB1014 B8FB1015 C2FB1016 B8FB1017 B8FB1019 C8FB1022 C8FB1023 F5FB1024 G2
L1000 D4L1001 D4L1002 D4L1003 D4L1005 D5L1008 G6L1009 G6Q1001 A6R1000 D7R1001 D7R1002 B5R1003 B5R1004 A2R1005 C5R1006 C6R1007 A4R1008 A7R1010 B6R1011 B5R1012 B5R1016 H2R1017 F2R1018 F2R1019 F2R1021 H2R1024 A6R1025 E1R1026 C7R1027 D7R1028 D7R1029 D8R1030 D8R1033 G2R1034 C5R1035 F3R1036 E3R1037 E3R1038 C5R1039 F3R1040 B1R1041 B4R1042 B4R1043 G2R1044 G6R1045 C4R1046 C4R1047 G6R1048 D3R1049 D3R1050 G2R1059 E5R1076 E5R1096 E5RP1000 F4RP1001 F4RP1003 F4TP1000 G3TU101 A2TU102 A1U1000 A2U101 F2U103 G4
Circuit Diagrams and PWB Layouts EN 43TPM5.2E LA 10.
2010-Jun-25
SSB: MT5363 By-pass/Trap
18840_509_100408.eps100428
MT5363 BYPASS/TRAPB04 B04
2010-04-021
MT5363 BYPASS/TRAP 715G3735
C4000 B4C4001 B4C4002 B4C4003 B4C4004 B5C4005 B5C4006 B5C4007 D4C4008 D4C4009 D5C4010 D5C4011 D6C4012 D6C4013 D7C4014 D7C4015 D8FB4000 A5R4000 E9R4001 E9R4002 E9R4003 F9R4004 F7R4005 F9R4006 E7
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
A A
B B
C C
D D
E E
F F
G G
H H
AVDD1V25_PLL
M_AOSDATA0
M_OPWM1
M_AOBCK
M_SPDIF_Out
M_AOLRCK
M_OPCTRL3
AVDD1V25_PLL
AV12
DV11
DV33
DV11
DV33
DV33
DV332,3,4,6,8,9,12,13,14AV333,6,12,14AV123,4,6,7,12,14DV112
GND2,3,4,6,7,8,9,10,11,12,13,14
M_AOLRCK4,6M_AOBCK6M_AOSDATA06M_SPDIF_Out6,11M_OPWM19M_OPCTRL38,11,12
MT5363 STRAPPING MODE
HW Strap Setting
SMD/0402
SMD/0402SMD/0402
SMD/0402SMD/0402SMD/0402SMD/0402SMD/0402
SMD/0402 SMD/0402 SMD/0402 SMD/0402 SMD/0402 SMD/0402 SMD/0402 SMD/0402
XTAL 54MHz
Strapping Mode OPWM1AOSDATA0
1 0
PDWNC Normal
Strapping Mode OPCTRL3(O)
0
AOLRCK AOBCK ASPDIF
ICE Mode + Serial Boot
Strapping Mode
ICE mode + ROM Boot 0 10 0 00
C4002100N 16VC4002100N 16V
C4013100N 16VC4013100N 16V
C4007100N 16VC4007100N 16V
C4008100N 16VC4008100N 16V
R40014.7K1/16W
R40014.7K1/16W
C4005100N 16VC4005100N 16V
R40044.7K1/16W
R40044.7K1/16W
C4014100N 16VC4014100N 16V
C4012100N 16VC4012100N 16V
C4001100N 16VC4001100N 16V
Power&Ground
U401A
MT5363
Power&Ground
U401A
MT5363
AVDD12_TVDPLL AF29AVDD12_SYSPLL AG32AVDD12_ADCPLL AH33
AVDD12_APLL AG30
DVSSY3DVSSJ4DVSSL4DVSSW4DVSSJ6DVSSL6DVSSW6DVSSC8DVSSE8DVSSG8DVSSAE8DVSSD9DVSSF9DVSSAF9
DVSSG10
DVSSAB13
DVSSAD13
DVSSN14
DVSSR14
DVSSW14DVSSAC14
DVSSP15
DVSST15DVSSV15DVSSAB15DVSSU16DVSSW16
DVSSAA16
DVSSAC16DVSST17DVSSV17DVSSY17
DVSSAB17
DVSSR18DVSSU18DVSSW18DVSSAA18DVSSAC18DVSST19DVSSV19DVSSY19
DVSSAB19
DVSSN20
DVSSR20
DVSSU20
DVSSW20DVSSAA20DVSSAC20DVSSB21DVSSD21DVSSP21DVSST21DVSSV21DVSSY21DVSSAB21
DVSSAD21DVSSE22DVSSG22DVSSR22DVSSU22DVSSW22DVSSAA22DVSSAC22
VCCK AM1VCCK AL2VCCK AN2VCCK AM3VCCK AL4VCCK AN4VCCK AK5VCCK AM5VCCK AJ6VCCK AL6VCCK AH7VCCK AK7VCCK AM7VCCK AJ8VCCK AL8VCCK AG12VCCK V13VCCK Y13VCCK U14VCCK AA14VCCK AE14VCCK Y15
VCCK AD15
VCCK R16
VCCK AE16
VCCK AD17
VCCK AE18VCCK AD19
VCCK AE20
VCCK N22
VCCK AE22VCCK N24
VCCK W24
VCCK AA24VCCK T25VCCK V25
VCCIO33 H23VCCIO33 J30VCCIO33 H31VCCIO33 V31VCCIO33 W32VCCIO33 W34VCCIO33 W36VCCIO33 AF13
AVSS12_PLL AH29
AVSS12_PLL AH31
DVSSP23
DVSST23
DVSSV23
DVSSY23
DVSSAB23
DVSSAD23
DVSSR24
DVSSU24 DVSS AC24DVSS AE24DVSS P25DVSS AD25
VCCK Y25
VCCK AB25
VCCIO33 AF15
C4011100N 16VC4011100N 16V
C4004100N 16VC4004100N 16V
R40034.7K1/16W
R40034.7K1/16W
R40054.7K1/16W
R40054.7K1/16W
R40064.7K1/16W
R40064.7K1/16W
FB4000120R/3000mA
FB4000120R/3000mA
1 2
C4000100N 16V
C4000100N 16V
C4010100N 16VC4010100N 16V
C4015100N 16VC4015100N 16V
R40004.7K1/16W
R40004.7K1/16W
C4003100N 16VC4003100N 16V
R4002NC/4.7K1/16W
R4002NC/4.7K1/16W
C4009100N 16VC4009100N 16V
C4006100N 16VC4006100N 16V
EN 44TPM5.2E LA 10.Circuit Diagrams and PWB Layouts
2010-Jun-25
SSB: MT5363 peripheral/USB2.0
18840_510_100408.eps100428
MT5363 PERIPHERAL/USB2.0B05 B05
2010-04-021
MT5363 PERIPHERAL/USB2.0
715G3735
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
A A
B B
C C
D D
E E
F F
G G
H H
USB 2.0
SMD/0402
SMD/0402
SMD/0402
SMD/0402SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
2040/DMS2040/DMS
SMD/0402
---><---|>---><---|>
USB_PWR_OCP
Tuner_ByPass_Out
IF_AGCTRF_AGCT
TUNER_CLKTUNER_DATA
BP
CVBS0PTUNER_BYPASS_In
COM1
COM0
AVDD1V25_RGB
GP
AVDD3V3_DEMOD
PR0P
PR1P
COM
SOY1
SOY0
VSYNC
RP
Y0P
Y1P
HSYNC
PB0P
SOG
AVDD3V3_CVBS
PB1P
CVBS1P
CVBS0N
FAT_IN-FAT_IN+
AVDD3V3_VDAC
YPbPr_L_InYPbPr_R_In
M_AOSDATA0
VIMD_AADC
AVDD3V3_DIG AVDD3V3_SIF
AVDD3V3_DIG
AVDD3V3_SIF
AVDD3V3_ADAC1
ADAC_VCM
AVDD3V3_AADC
AVDD3V3_REFP_AADC
VIMD_AADC
MPX_PMPX_N
AVDD3V3_AADC
AVDD3V3_ADAC0AVDD3V3_REFP_AADC
ADAC_VCM
M_AOBCK
Line_Out_RLine_Out_L
VGA_L_InVGA_R_In
PANEL_VCC_ON/OFF
BL_ON/OFF
M_AOLRCK
HP_Out_LHP_Out_R
AV1_R_InAV1_L_In
M_SPDIF_Out
SCART1_L_InSCART1_R_In
USB_PWR_EN
CVBS3P
AVDD3V3_ADAC0
AVDD3V3_ADAC1
USB_DPUSB_DM
SCART1_Out_RSCART1_Out_L
AMP_MUTE
SPDIF_DVD_IN
TX_RX_ON/OFF
+5V_STB
+5V_SW
DV33
AVDD3V3_CVBSAV33
AVDD1V25_RGB
AVDD3V3_DEMOD
AV12
AVDD3V3_VDAC
AV33
AV33
AV33 AV33
AV33
AV33
AV33
AV33
R40610R05 1/10W
R40610R05 1/10W
+
C4063100uF 10V
+
C4063100uF 10V
C4066NC/100N 16VC4066NC/100N 16V
U105NC/STMPS2171STRU105NC/STMPS2171STR
OUT1
GND2
FAULT3
EN4
IN5
R40620R05 1/10W
R40620R05 1/10W
C4052100N 16VC4052100N 16V
R4051 0R05OHM1/16WR4051 0R05OHM1/16W
FB4058120R/500mAFB4058120R/500mA
1 2
C4057100N 16VC4057100N 16V
C40681uF 25VC40681uF 25V
C40671uF 25VC40671uF 25V
Audio I/F
MT5363
U401F
Audio I/F
MT5363
U401F
AVDD33_REF_AADCW30
AVSS33_REF_AADCY29
VMID_AADCAA30
AVDD33_AADCY31 AVDD33_ADAC1T31
AVSS33_ADAC1U30
AIN4_R_AADCAB33
AIN0_L_AADCAD33
AL2V35
AVSS33_AADCY33
AIN1_R_AADCAC32
AIN0_R_AADCAC34
AL3V37
AIN4_L_AADCAA32
AIN1_L_AADCAB31
AVSS33_ADAC0AE34
AR2U34
AIN5_R_AADCY35
AIN2_R_AADCAB35
AL1U32
AR0AE36
AIN5_L_AADCAA34
AIN2_L_AADCAD35
AVDD33_ADAC0AF33
AR3U36
AIN6_R_AADCY37
AIN3_R_AADCAB37AVICM
AF35
AR1V33
AIN6_L_AADCAA36
AIN3_L_AADCAC36
AL0AF37
AVSS33_DIGAJ30
AVSS33_SIFAK29
AVDD33_DIGAK31
AVDD33_SIFAL30
AFAM33
MPXNAN36
MPXPAN34
ALINL32
AOLRCKM37
AOSDATA3K31
ASPDIFK33
AOBCKL34
AOSDATA4N32
AOSDATA1P35
AOSDATA0L36 AOMCLKM35
AOSDATA2P37
C4065NC/10U 16V
C4065NC/10U 16V
TP4050TP40501
D4050BAV99D4050BAV99
3
12
C4058100N 16VC4058100N 16V
R4053NC/4.7K1/16W
R4053NC/4.7K1/16W
C4059100N 16VC4059100N 16V
R4055NC/10K 1/10WR4055NC/10K 1/10W
C4060100N 16VC4060100N 16V
Video I/F
MT5363
U401D
Video I/F
MT5363
U401D
AVSS33_CVBSAR32 AVDD33_CVBSAN32
SY1AR34
SC1AU34
SY0AP33
SC0AT33
CVBS2PAP35
CVBS3PAT35
CVBS0NAR36
CVBS1PAU36
BYPASS0AM31
CVBS0PAT37TUNER_BYPASSAP37
AVDD33_DEMOD1AG34
ADCINN_DEMODAH35
ADCINP_DEMODAH37
AVSS33_DEMOD1AG36
AVSS33_VDACAR30 AVDD33_VDACAN30
FS_VDACAM29
VDAC_OUT1AP31 VDAC_OUT2AT31
HSYNCAR22VSYNCAU22
SOGAP23BPAT23
COMAR24GPAU24
SOY1AP25
RPAT25
AVDD12_RGBAM25
COM1AR26
Y1PAU26
PR1PAP27
PB1PAT27
AVSS12_RGBAN26
Y0PAR28SOY0AU28
PB0PAP29
COM0AT29
PR0PAU30
TUNER_DATAN34
IF_AGCM31
RF_AGCM33
TUNER_CLKN36
FB4060220R/2000mA
FB4060220R/2000mA
1 2
C4053100N 16VC4053100N 16V
R40580R05 1/10W
R40580R05 1/10W
t
TH4050PTCR
t
TH4050PTCR
1 2
R4054NC/4.7K1/16WR4054NC/4.7K1/16W
C4061100N 16VC4061100N 16V
R4050560R 1/10W 1%R4050560R 1/10W 1%
C40691uF 25VC40691uF 25V
R40560R05 1/10W
R40560R05 1/10W
D4051BAV99D4051BAV99
3
1 2
R40570R05 1/10W
R40570R05 1/10W
C4064NC/10U 16V
C4064NC/10U 16V
R40590R05 1/10W
R40590R05 1/10W
12
34 CN103
12
34 CN103
1234
65
C4050100N 16VC4050100N 16V
C4054100N 16VC4054100N 16V
R40630R05 1/10W
R40630R05 1/10W
FB4057120R/500mAFB4057120R/500mA
1 2
C4056100N 16VC4056100N 16V
C4051100N 16VC4051100N 16V
C4055100N 16VC4055100N 16V
C40621uF 25VC40621uF 25V
R40600R05 1/10W
R40600R05 1/10W
R4052 0R05OHM1/16WR4052 0R05OHM1/16W
C4050 E6C4051 E7C4052 A6C4053 B6C4054 C6C4055 B6C4056 A7C4057 B7C4058 B7C4059 C7C4060 D6C4061 D6C4062 C7C4063 F4C4064 G2C4065 G3C4066 G4C4067 A7C4068 B7C4069 C5CN103 F4D4050 F4D4051 F3FB4057 A7FB4058 B7FB4060 F4R4050 D2R4051 F3R4052 F3R4053 G3R4054 G2R4055 G4R4056 A5R4057 B5R4058 B5R4059 B7R4060 D5R4061 D5R4062 E5R4063 E7TH4050 G3TP4050 D3U105 G3U401D D3
Circuit Diagrams and PWB Layouts EN 45TPM5.2E LA 10.
2010-Jun-25
SSB: DDR2 memory
18840_511_100408.eps100428
DDR2 MEMORYB06 B06
2010-04-021
DDR2 MEMORY 715G3735
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
A A
B B
C C
D D
E E
F F
G G
H H
DDR#2DDR#1
Main Chip Bottom Side
SMD/0402 SMD/0402 SMD/0402 SMD/0402 SMD/0402
DDR2 Interface
SMD/0402 SMD/0402Bottom Side DDR#1
SMD/0402SMD/0402 SMD/0402SMD/0402 SMD/0402
SMD/0402 SMD/0402Bottom Side DDR#2
SMD/0402SMD/0402 SMD/0402SMD/0402 SMD/0402
SMD/0402
SMD/0402
SMD/0402
DRAM DE-CAP.
MT5363 DE-CAP.
SMD/0402SMD/0402
AV1V25_MEMPLL
Damping and Termination for CLK
SMD/0402
SMD/0402
CLK0
CLK0#
CLK1
CLK1#
RDQ14
RDQ16RDQ17
RDQ31
RDQ19
RDQ30
RDQ18
RDQ21RDQ20
RDQ28
RDQ23RDQ22
RDQ29
RDQ27
RDQ24RDQ25RDQ26
RDQS0#
RA10
RA1RA0
RA3RA2
RA4RA5RA6RA7RA8RA9
RA11RA12
RDQM3RDQS3RDQS3#
RCLK1#RCLK1
RCS#RCAS#
RODTRRAS#
RWE#
AV1V25_MEMPLL
RBA2RBA1RBA0
RCKE
RDQM1
RA13
RDQS1RDQS1#
RDQS0
RDQS2RDQM2
RDQS2#
RDQ1
RCLK0RCLK0#
RDQ2RDQ3
RDQ7RDQ6RDQ5
RDQ0
RDQ4
RDQM0
RDQ9
RDQ13
RDQ8
RDQ12RDQ11RDQ10
RDQ15
RVREF3
RDQ1RDQ2RDQ3
RDQ7RDQ6RDQ5
RDQ0
RDQ4
RDQS0
1_CKE
RDQS1
RDQ15RDQ14
RDQ9
RDQ13
RDQ8
RDQ12RDQ11RDQ10
RDQM1RDQM0RVREF1
RDQS1#
RDQS0#
1_RAS#1_WE#
1_A13
1_BA0
1_A01_A11_A21_A31_A41_A51_A61_A71_A81_A91_A101_A111_A12
1_BA11_BA2CLK0CLK0#1_CS#1_CAS#1_ODT
RDQS3#
RDQS2#
2_CKERVREF2
RDQ16RDQ17
RDQ31
RDQ19
RDQ30
RDQ18
RDQ21RDQ20
RDQ28
RDQ23RDQ22
RDQ29
RDQ27
RDQ24RDQ25RDQ26
RDQS2
RDQM2RDQM3
RDQS3
2_RAS#2_WE#
2_ODT
2_CS#2_CAS#
2_A02_A12_A22_A32_A42_A52_A62_A72_A82_A92_A102_A112_A12
CLK1#CLK1
2_BA02_BA12_BA2
2_A13
RCS#
1_BA21_A1
1_BA1
1_WE#1_CKE
1_BA0
1_A101_A3
1_A11
1_A9
1_A8
1_A12
1_A2
1_A7
RODT
1_CAS#
1_A13
1_A6
1_A5
RRAS#
1_A0
1_A4
RA2
1_CS#
RBA2
RBA0
RWE#RCKE
RA1
RBA1
RA10RA3
RCAS#
RA9
RA6
RA12
RA8
RA4
1_ODT
RA7
RA13
RA11
1_RAS#
RA5
RA0
2_WE#
2_BA0
2_CKE2_BA1
RRAS#RODT
2_A102_A3
2_BA22_A1
2_A72_A122_A9
2_A5
2_A11
2_A2
2_CAS#
2_A8
RCS#
2_A6
2_A13
2_A4
2_A0
RBA0
RWE#RCKERBA1
2_RAS#2_ODT
RA10RA3
RBA2RA1
RA5
RA9RA12RA7
RCAS#
RA11
RA8
2_CS#
RA2
RA13
RA6
RA0
RA4
RVREF2RVREF1
AV1V25_MEMPLL
RVREF3
RCLK0
RCLK0#
RCLK1
RCLK1#
DV18_DDR
DV18_DDR
DV18_DDR
DV18_DDR
DV18_DDR
DV18_DDR
DV18_DDRDV18_DDR
AV12
DV18_DDR
TP4100TP4100 1
RP410256R 1/16W 5%
RP410256R 1/16W 5%
1234
8765
C4122100N 16VC4122100N 16V
FB4100120R/500mAFB4100120R/500mA
1 2
RP410156R 1/16W 5%
RP410156R 1/16W 5%
1234
8765
C4117100N 16VC4117100N 16V
TP4101TP4101 1
RP410056R 1/16W 5%
RP410056R 1/16W 5%
1234
8765
C41161UF16VC41161UF16V
R4108 100OHM1/16WR4108 100OHM1/16W
U403
NT5TU32M16CG-BD
U403
NT5TU32M16CG-BD
VDDA1
NCA2
VSSA3
VSSQA7
UDQSA8
VDDQA9
DQ14B1
VSSQB2
UDMB3
UDQSB7
VSSQB8
DQ15B9
VDDQC1
DQ9C2
VDDQC3
VDDQC7
DQ8C8
VDDQC9
DQ12D1
VSSQD2
DQ11D3 DQ10D7
VSSQD8
DQ13D9
VDDE1
NCE2
VSSE3
VSSQE7
LDQSE8
VDDQE9
DQ6F1
VSSQF2
LDMF3
LDQSF7
VSSQF8
DQ7F9
VDDQG1
DQ1G2
VDDQG7
DQ0G8
VDDQG9
DQ4H1
VSSQH2
DQ3H3 DQ2H7
VSSQH8
DQ5H9
VDDLJ1
VREFJ2
VSSJ3
VSSDLJ7
CKJ8
VDDJ9
CKEK2
WEK3RASK7
CKK8
ODTK9
NC/BA2L1
BA0L2
BA1L3
CASL7CSL8
A10/APM2
A1M3
A2M7
A0M8
VDDM9
VSSN1
A3N2
A5N3
A6N7
A4N8
A7P2
A9P3
A11P7
A8P8
VSSP9
VDDR1
A12R2
NC/A14R3
NC/N15R7
NC/A13R8
VDDQG3
RP410856R 1/16W 5%RP410856R 1/16W 5%
1234
8765
RP410756R 1/16W 5%
RP410756R 1/16W 5%
1234
8765
+C4102NC/100uF 16V
+C4102NC/100uF 16V
+C4103220UF 16V
+C4103220UF 16V
C4108100N 16VC4108100N 16V
C4109100N 16VC4109100N 16V
RP411056R 1/16W 5%RP411056R 1/16W 5%
1234
8765
RP410456R 1/16W 5%
RP410456R 1/16W 5%
1234
8765
C4118100N 16VC4118100N 16V
C4110NC/10U 16V
C4110NC/10U 16V
C4127100N 16VC4127100N 16V
R411022 OHM 1/16W
R411022 OHM 1/16W
R4107100OHM1/16WR4107100OHM1/16W
C4106100N 16VC4106100N 16V
C4112100N 16VC4112100N 16V
C41111UF 16VC41111UF 16V
C4104100N 16VC4104100N 16V
R411122 OHM 1/16W
R411122 OHM 1/16W
C4113100N 16VC4113100N 16V
C413010N 50VC413010N 50V
R41011K1/10W
R41011K1/10W
R41041K1/10W
R41041K1/10W
C4105100N 16VC4105100N 16V
C4114100N 16VC4114100N 16V
C4126100N 16VC4126100N 16V
RP410656R 1/16W 5%
RP410656R 1/16W 5%
1234
8765
U402
NT5TU32M16CG-BD
U402
NT5TU32M16CG-BD
VDDA1
NCA2
VSSA3
VSSQA7
UDQSA8
VDDQA9
DQ14B1
VSSQB2
UDMB3
UDQSB7
VSSQB8
DQ15B9
VDDQC1
DQ9C2
VDDQC3
VDDQC7
DQ8C8
VDDQC9
DQ12D1
VSSQD2
DQ11D3 DQ10D7
VSSQD8
DQ13D9
VDDE1
NCE2
VSSE3
VSSQE7
LDQSE8
VDDQE9
DQ6F1
VSSQF2
LDMF3
LDQSF7
VSSQF8
DQ7F9
VDDQG1
DQ1G2
VDDQG7
DQ0G8
VDDQG9
DQ4H1
VSSQH2
DQ3H3 DQ2H7
VSSQH8
DQ5H9
VDDLJ1
VREFJ2
VSSJ3
VSSDLJ7
CKJ8
VDDJ9
CKEK2
WEK3RASK7
CKK8
ODTK9
NC/BA2L1
BA0L2
BA1L3
CASL7CSL8
A10/APM2
A1M3
A2M7
A0M8
VDDM9
VSSN1
A3N2
A5N3
A6N7
A4N8
A7P2
A9P3
A11P7
A8P8
VSSP9
VDDR1
A12R2
NC/A14R3
NC/N15R7
NC/A13R8
VDDQG3
R41001K1/10WR41001K1/10W
R41051K1/10W
R41051K1/10W
C4119100N 16VC4119100N 16V
R41021K1/10W
R41021K1/10W
C4128100N 16VC4128100N 16V
C4121100N 16VC4121100N 16V
R411222 OHM 1/16W
R411222 OHM 1/16W
R410922 OHM 1/16W
R410922 OHM 1/16W
RP411156R 1/16W 5%
RP411156R 1/16W 5%
1234
8765
C4124100N 16VC4124100N 16V
DRAM
MT5363
U401B
DRAM
MT5363
U401B
RODTN6
RCAS#L2
RA11N2
RA9D1
RWE#K3
RDQ20T3
RDQM2V1
RDQS3Y1
RDQ17U4
RCLK1#AD3
RRAS#P5
RA4M5
RA1H5
RA10G2
RDQ22U2
RDQS2#W2
RDQS3#AA2
RDQ18AC4
RCS#P3
RA8P1
RCKEK1
RBA2H1
RDQ21AC2
RDQS2V3
RDQ19T1
RCLK1AD1
RCLK0#A2
RA0N4
RBA1J2
RA5F1
RDQ23AB3
RDQ25T7
RDQ16AB1
RCLK0B3
RA6M7
RA12E2
RA3G4
RDQ28V5
RDQM3U6
RDQ27V7
REXTDNAB5
RDQ8B5
RDQ10A4
RA2M3
RBA0H3
RDQ29AA4
RDQ24Y5
RDQ9D11
RDQ0D7
RA7F3
RDQ30T5
RDQ31Y7
RDQ26AA6
RDQS1#C6
RDQ11B11
RDQ5D5
RDQS1B7
RDQ6F11
RDQ3G12
RDQS0#A8RDQS0B9RDQM0E10
RDQ2E6
RDQ15A6
RDQM1C10
RDQ4H13
RDQ7F7
RDQ13C4
RDQ14A10
RDQ1H11
RDQ12A12
VCC2IOB1
VCC2IOAF1
VCC2IOC2
VCC2IOR2
VCC2IOAE2
VCC2IOD3
VCC2IOAF3
VCC2IOE4 VCC2IOR4
VCC2IOAE4
VCC2IOF5
VCC2IOAD5
VCC2IOG6
VCC2IOR6
VCC2IOAC6
VCC2IOH7
VCC2IOAD7
VCC2IOC12
VCC2IOE12
VCC2IOB13
VCC2IOD13
VCC2IOF13
VCC2IOE14
VCC2IOG14
RA13M1
RVREFP7
RVREFN8
AVDD12_MEMPLLP13
AVSS12_MEMPLLT13
MEMTPK7 MEMTNK5
VCC2IOJ14
RP410356R 1/16W 5%
RP410356R 1/16W 5%
1234
8765
C4107100N 16VC4107100N 16V
C4115100N 16VC4115100N 16V
R41031K1/10WR41031K1/10W
C4101100N 16VC4101100N 16V
C4100100N 16VC4100100N 16V
R4106100OHM1/16WR4106100OHM1/16W
RP410556R 1/16W 5%
RP410556R 1/16W 5%
1234
8765
C4120100N 16VC4120100N 16V
C4129100N 16VC4129100N 16V
C4123100N 16VC4123100N 16V
RP4109
56R 1/16W 5%
RP4109
56R 1/16W 5%
1234
8765
C4125100N 16VC4125100N 16V
C4100 D9C4101 D6C4102 F1C4103 G1C4104 F2C4105 F2C4106 F3C4107 F3C4108 F3C4109 G3C4110 F5C4111 F6C4112 G3C4113 G2C4114 G2C4115 G3C4116 F5C4117 E2C4118 F3C4119 F4C4120 F4C4121 F6C4122 F6C4123 F7C4124 F7C4125 F7C4126 F7C4127 G3C4128 G4C4129 G4C4130 E6FB4100 E5R4100 D8R4101 D8R4102 D6R4103 D5R4104 E2R4105 E2R4106 D5R4107 D7R4108 D1R4109 D4R4110 D4R4111 D7R4112 D7RP4100 A6RP4101 B6RP4102 B6RP4103 B8RP4104 A8RP4105 B8RP4106 B8RP4107 B8RP4108 B6RP4109 C8RP4110 B6RP4111 C6TP4100 C2TP4101 C2U401B A2U402 A4U403 A7
EN 46TPM5.2E LA 10.Circuit Diagrams and PWB Layouts
2010-Jun-25
SSB: Flash/JTAG/UART/IR
18840_512_100408.eps100428
FLASH/JTAG/UART/IRB07 B07
2010-04-021
FLASH/JTAG/UART/IR 715G3735
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
A A
B B
C C
D D
E E
F F
G G
H H
---><---|>---><---|>
TO KEY PAD BOARD
128Mbit Nand Flash
SYSTEM EEPROM
LO = > WPHI = > WRITE
CL=10P
SMD/0402SMD/0402
SMD/0402SMD/0402
512KB Nor Flash for Boot Code
iTVLED_R#:Enable(Stand_By): LowDisable: High
LED_G#:Enable: LowDisable(Stand_By): High
TO IR/KEY BOARD
---><---|>---><---|>
IR Linked
LED_G:For flash function whenpress remote control
SMD/0402
SMD/0402
---><---|>
For LCD Clock
Key2
Key1
PDD3PDD2PDD1PDD0
PDD7PDD6PDD5PDD4
PARB#
POOE#POCE1#
PACLEPAALE
POWE#
U1RXU1TX
1V0SB
JTRST#
AVDD3V3_REG
OXTALOOXTALI
ORESET#
U0RXU0TX
JTDOJTMSJTCKJTDIJTRST#
OSDA0OSCL0
SCART_FS0
SYS_EEPROM_WP
AVDD3V3_XTAL
PACLE
AUDIO_MUTE
PDD2
POCE0#
PDD3
POCE1#
PDD4
POOE#
PDD5
E_FUSE
PARB#
PAALE
POWE#
1V0SB
PDD6
LED_R
PDD7
PDD0
AVDD3V3_XTAL
PDD1
AVDD3V3_REG
M_OPCTRL3
VCXO
E_FUSE
SYS_EEPROM_WPOSCL0
OSDA0
OXTALO
ORESET#
OPWRSB
ORESET#
U0RX
U0TX
DV33
PDD1POOE#
POCE0#
PDD0POCE0#
OXTALI
JTAG_DBGACK
JTDO
JTAG_DBGRQ
TVTREF#1
JTMSJTCK
JTDIJTRST#
RC6
SP_AMP_MUTE
RC6
LED_RLED_G
Key1Key2
Light_Sensor
KEY_MENU_L_R_SOURCE
KEY_UP_DN_DCSW
KEY_UP_DN_DCSW
V33
Flash_WP#
Flash_WP#
KEY_MENU_L_R_SOURCE
DVD_STATUS SP_AMP_MUTE
V33
LCD_Clock_SCLLCD_Clock_SDA
RC6
LCD_Clock_SDA
DV33SB+5V_STB
LCD_Clock_SCL
DV33SB
DV33SB
DV33
DV33
DV33SB DV33SB
1V0SB
DV33SB
DV33SB
DV33DV33
DV33 DV33
+5V_STBDV33SB
DV33
DV33
DV33 DV33
DV33
DV33SB
DV33SB
DV33
DV33SB
+5V_SW
DV33SB
DV33SB
CN410CN410
123
CN4051CONNCN4051CONN
12345
R4195 0R05 1/10WR4195 0R05 1/10W
R4156100 OHM 1/10W
R4156100 OHM 1/10W
R4158330 OHM 1/16W
R4158330 OHM 1/16W
R41
7410
K1/
16W
R41
7410
K1/
16W
R4180100K1/16W
R4180100K1/16W
R41
651K
1/16
WR
4165
1K1/
16W
C416710uF 16VC416710uF 16V
R41713.9K1/16WR4171
3.9K1/16W
NAND FLASH
U4051NAND128W3A2BN6E
NAND FLASH
U4051NAND128W3A2BN6E
I/O_029 I/O_130 I/O_231 I/O_332 I/O_441 I/O_542 I/O_643 I/O_744
CLE16
ALE17
CE9
RE8
WE18
WP19
R/B7
GND6
Vcc112
GND13
GND36
Vcc237
NC11
NC22
NC33
NC44
NC55
NC610
NC711
NC814
NC915
NC1020
NC1121
NC1222
NC1323
NC1424
NC1525
NC1626
NC1727
NC1828
NC1933
NC2034
NC2135
LOCK38
NC2239
NC2340
NC2445
NC2546
NC2647
NC2748
R41844.7K1/16W
R41844.7K1/16W
R4179
100 OHM 1/10W
R4179
100 OHM 1/10W
C4158NC/2.2UF10V
C4158NC/2.2UF10V
R41830R05OHM1/16W
R41830R05OHM1/16W
TP4154TP41541
C4152NC/100N 16VC4152NC/100N 16V
R4157 100 OHM 1/10WR4157 100 OHM 1/10W
R41914.7K1/16WR41914.7K1/16W
D4151BAV99D4151BAV99
3
1 2
C41684.7uF 10V
C41684.7uF 10V
R41
7710
K1/
16W
R41
7710
K1/
16W
C41501UF16VC41501UF16V
R4175100R 1/10W 1%
R4175100R 1/10W 1%
R4159100 OHM 1/10W
R4159100 OHM 1/10W
R41
6410
K1/
16W
R41
6410
K1/
16W
ZD4151NC/VPORT0603100KV05
ZD4151NC/VPORT0603100KV05
12
R41546K8 1/10W 1%R41546K8 1/10W 1%
R41550R05 1/10W
R41550R05 1/10W
R4163NC/16K 1/10W 5%R4163NC/16K 1/10W 5%
C415310N 50V
C415310N 50V
R41
6810
K1/
16W
R41
6810
K1/
16W
R4172100R 1/10W 1%
R4172100R 1/10W 1%
R42290R05 1/10W
R42290R05 1/10W
CN4052NC/CONN
CN4052NC/CONN
2468
1357
ZD4150NC/VPORT0603100KV05
ZD4150NC/VPORT0603100KV05
12
R41
6910
K1/
16W
R41
6910
K1/
16W
R41733.9K1/16W
R41733.9K1/16W
R4193
0R05OHM1/16W
R4193
0R05OHM1/16W
R41904.7K1/16WR41904.7K1/16W
R41894.7K1/16WR41894.7K1/16W
U410MAX809STRG
U410MAX809STRG
GND1
RE
SE
T2
VCC3
R4230NC/0R05OHM1/16W
R4230NC/0R05OHM1/16W
FB4152600R/200mAFB4152600R/200mA
12
R41
6610
K1/
16W
R41
6610
K1/
16W
R41864.7K1/16W
R41864.7K1/16W
TP4151TP41511
R4161NC/1K 1/10WR4161NC/1K 1/10W
U409
M24C64-WDW6TP
U409
M24C64-WDW6TP
E01
E12
E23
VSS4
SDA5 SCL6 WC7 VCC8
C4156100N 16V
C4156100N 16V
R4302NC/0R05OHM1/16W
R4302NC/0R05OHM1/16W
R4160NC/100 OHM 1/10W
R4160NC/100 OHM 1/10W
L41500U82L41500U82C4164
10P 50VC416410P 50V
CN4053
NC/PHONEJACK
CN4053
NC/PHONEJACK
12354
C4154100N 16VC4154100N 16V
R41874.7K1/16WR41874.7K1/16W
C4155100N 50VC4155100N 50V
R41
6710
K1/
16W
R41
6710
K1/
16W
R4199NC/10K1/16W
R4199NC/10K1/16W
STB I/F &Peripheral
MT5363
U401C
STB I/F &Peripheral
MT5363
U401C
AVDD10_LDOAM23
AVDD33_VGA_STBAN24
AVSS33_VGA_STBAL24
AVSS33_XTALAK37 AVDD33_XTAL_STBAK35
XTALOAJ34
ADIN2_SRVAM35
ADIN4_SRVAM37
ADIN0_SRVAL32
XTALIAJ36
ADIN3_SRVAL34
ADIN5_SRVAL36
ADIN1_SRVAK33
POCE0#AT1
PDD0AR2 POOE#AU2
PDD1AP5
POCE1#AN6
FSRC_WRL30
POWE#AT3 PARB#AT5 PACLEAU4 PAALEAR4
PDD3AU6 PDD2AR6
PDD5AT7 PDD4AP7
PDD7AU8 PDD6AR8
OSDA0AP1OSCL0AP3
OSDA2P33OSCL2P31
OSDA1R32OSCL1R34
JTRST#AK1JTDIAJ2JTCKAK3JTMSAJ4JTDOAH5
U1TXT35U1RXR36
VCXOT37
OPCTRL1AM19
OPCTRL2AN20
OPCTRL0AM21
OPCTRL3AR20
OPCTRL4AU20
OIRIAN22
OPWRSBAL20ORESET#AL22
U0TXAP21U0RXAT21
TP4150TP41501
R4181100OHM1/16W
R4181100OHM1/16W
R417010K1/16W
R417010K1/16W
X4150
54MHz
X4150
54MHz
1 2
R41824.7K1/16WR41824.7K1/16W
C416310P 50V
C416310P 50V
C41
5910
0N 5
0VC
4159
100N
50V
R4196NC/4.7K1/16W
R4196NC/4.7K1/16W
R4162 NC/16K 1/10W 5%R4162 NC/16K 1/10W 5%
D4152BAV99D4152BAV99
3
12
R41884.7K1/16W
R41884.7K1/16W
C4157100N 50VC4157100N 50V
R41854.7K1/16W
R41854.7K1/16W
C41511UF16VC41511UF16V
R419410K1/16W
R419410K1/16W
R41521 OHM 1/10W
R41521 OHM 1/10W
TP4152TP41521
R417633 OHM 1/16W
R417633 OHM 1/16W
R4198NC/4.7K1/16W
R4198NC/4.7K1/16W
C41
6010
0N 5
0VC
4160
100N
50V
C41651N 25VC41651N 25V
D4150BAV99
D4150BAV99
3
1 2
U4052
NC/MX25L4005AMI-12G
U4052
NC/MX25L4005AMI-12G
CS1
SO2
WP3
GND4
SI5SCK6HOLD7VCC8
CN401
CONN
CN401
CONN
123456789
101112
R4197NC/100 OHM 1/10W
R4197NC/100 OHM 1/10W
R41533.01K OHM +-1% 1/10WR41533.01K OHM +-1% 1/10W
R4192100OHM1/16W
R4192100OHM1/16W
C4169100N 16VC4169100N 16V
R43014.7K1/16W
R43014.7K1/16W
CN406NC/60947 20P 1.25MM
CN406NC/60947 20P 1.25MM
13579
1113151719
2468101214161820
2122
C4166100N 16VC4166100N 16V
C4150 H7C4151 F5C4152 A7C4153 F2C4154 F5C4155 F2C4156 F5C4157 F3C4158 F2C4159 D9C4160 D9C4163 B6C4164 B6C4165 C6C4166 A4C4167 B4C4168 B4C4169 B4CN401 F3CN4051 E8CN4052 G2CN4053 F1CN406 D3CN410 C7D4150 E8D4151 C6D4152 C6FB4152 F3L4150 B6R4152 B4R4153 A8R4154 B8R4155 A4R4156 D5R4157 F1R4158 F5R4159 F1R4160 H2R4161 F2R4162 F1R4163 F2R4164 D1R4165 D2R4166 D2R4167 E2R4168 E2R4169 D1R4170 B4R4171 C9R4172 D8R4173 C9R4174 D1R4175 D8R4176 D1R4177 D2R4179 D5R4180 B9R4181 E8R4182 F5R4183 E8R4184 C1R4185 G7R4186 C5R4187 C5R4188 F5
R4189 G5R4190 G5R4191 G6R4192 H5R4193 E8R4194 A3R4195 F1R4196 H1R4197 H3R4198 H1R4199 A3R4229 B4R4230 C4R4301 G6R4302 G6TP4150 B3TP4151 B3TP4152 A3TP4154 A3U401C A2U4051 E6U4052 A6U409 H6U410 A8X4150 B6ZD4150 F1ZD4151 G1
Circuit Diagrams and PWB Layouts EN 47TPM5.2E LA 10.
2010-Jun-25
SSB: CI card
18840_513_100408.eps100428
CI CARDB08 B08
2010-04-021
CI CARD 715G3735
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
A A
B B
C C
D D
E E
F F
G G
H H
Function 1 (Internal CI) CI Interface
SMD/0402
SMD/0402 SMD/0402
SMD/0402
SMD/0402
USB_PWR_OCPLED_G
LNA_ON/OFF
USB_PWR_EN
CI_OCP
CI_D1M_CI_OUTDATA2
CI_CD2#CI_D2
STAND_BY
CI_A14M_CI_INDATA1
CI_WE#M_CI_INDATA2
M_CI_INDATA3CI_IREQ#M_CI_INDATA4
M_CI_INCLKM_CI_INDATA5M_CI_INVALID
CI_A12M_CI_INDATA6
CI_A7M_CI_INDATA7
M_CI_OUTCLK
CI_RESETCI_A6
CI_A4CI_WAIT#CI_A5
CI_A2CI_REG#CI_A3
M_CI_OUTSYNCCI_A1M_CI_OUTVALID
M_CI_OUTDATA0CI_A0
M_CI_OUTDATA1CI_D0
CI_PWR_EN
BL_DIMMINGM_OPWM1
CI_VS1#
M_CI_OUTDATA3CI_CD1#CI_D4
CI_OE#
CI_A11
CI_D3
CI_A9CI_IOWR#
M_CI_INSYNC
M_CI_OUTDATA6CI_D6
CI_A8CI_IORD#CI_D7
M_CI_INDATA0
M_CI_OUTDATA7
CI_D5
CI_A10
CI_A13M_CI_OUTDATA4
M_CI_OUTDATA5
CI_CE1#
CI_CD1#
CI_VS1#
CI_INCLK
CI_IREQ#
CI_WAIT#CI_CD2#
CI_OUTCLK
M_CI_OUTDATA2
M_CI_INDATA2M_CI_INDATA1
M_CI_INDATA3M_CI_INDATA4M_CI_INDATA5
M_CI_INVALID
M_CI_INDATA6M_CI_INDATA7
M_CI_OUTVALID
M_CI_OUTDATA0M_CI_OUTSYNC
M_CI_OUTDATA1
CI_OUTSYNC
CI_OUTDATA2
CI_OUTDATA0CI_OUTDATA1
CI_OUTVALID
CI_INDATA1CI_INDATA2
CI_INDATA5
CI_INVALID
CI_INDATA4CI_INDATA3
CI_INDATA7CI_INDATA6
M_CI_INSYNC
M_CI_INCLK
CI_OUTDATA3M_CI_OUTDATA3
M_CI_OUTDATA6
CI_OUTDATA4
M_CI_INDATA0
CI_OUTDATA6CI_OUTDATA7
CI_OUTDATA5M_CI_OUTDATA4
CI_INDATA0CI_INSYNC
M_CI_OUTDATA7
M_CI_OUTDATA5CI_CE2#
CI_D7
CI_A8CI_A13
CI_CE1#
CI_A14
CI_INVALID
CI_A10
CI_A6CI_A7CI_A12
CI_A1CI_A2
CI_D1CI_D0
CI_A3CI_A4CI_A5
CI_A0
CI_D2
CI_INCLK
CI_D3CI_D4
CI_OE#
CI_WE#CI_IREQ#
CI_D5
CI_A11
CI_D6
CI_A9
CI_INDATA2
CI_OUTDATA0
CI_IOWR#
CI_OUTDATA3
CI_INDATA7CI_INDATA6
CI_INDATA3
CI_OUTDATA6
CI_REG#
CI_OUTDATA2
CI_INDATA0
CI_VS1#
CI_OUTSYNC
CI_OUTCLK
CI_INSYNC
CI_OUTDATA4
CI_OUTDATA1
CI_OUTDATA7
CI_IORD#
CI_OUTVALID
CI_INDATA1
CI_WAIT#
CI_CD1#
CI_OUTDATA5
CI_CD2#
CI_CE2#
CI_INDATA4CI_INDATA5
CI_RESET
CI_OCP
RF_AGC_TUNER
M_CI_OUTCLK CI_OUTCLK
HP_DET#POWER_DETECT
TDOTCKTVAVLIDTSYNC
SYSTEM_REST
HP_AMP_MUTE
CI_PWR_EN
CI2_VCC
DV33
CI2_VCCCI2_VCC CI2_VCC
CI2_VCC
DV33
+5V_SW
DV33
CI2_VCC
DV33
DV33 DV33
DV33
R42324.7K1/16W
R42324.7K1/16W
R4216 22 OHM 1/16WR4216 22 OHM 1/16W
R42374.7K1/16W
R42374.7K1/16W
R4205 22 OHM 1/16WR4205 22 OHM 1/16W
R423310K 1/10W
R423310K 1/10W
C42
0210
uF 1
6VC
4202
10uF
16V
PCMCIA
CN159
JACK
PCMCIA
CN159
JACK
A1520 A1619
CE1#7
OE#9
WE#15
RDY/BSY16
GND1
GND34
D030
D131
D232
D32
D43
D54
D65
D76
A029 A128 A227 A326 A425 A524 A623 A722
A812 A911
A108
A1110
A1221
A1313
A1414
WP33
VPP118 VCC17
GND68CD2#67D1066D965D864BVD163BVD262
GND35
CD1#36
D1137
D1238
D1339
D1440
D1541
CE2#42
RFSH43
RFU44
RFU45
A1746
A1847
A1948
A2049
A2150
VCC51
VPP252
A2253
A2354
A2455
A2556
RFU57
RESET58
WAIT#59
RFU60
REG#61
6969
7070
7171
7272
R4202 22 OHM 1/16WR4202 22 OHM 1/16W
R4217 22 OHM 1/16WR4217 22 OHM 1/16WR4225 10K1/16WR4225 10K1/16W
C420510P 50VC420510P 50V
R4209 22 OHM 1/16WR4209 22 OHM 1/16W
C420610P 50VC420610P 50V
R4226 10K1/16WR4226 10K1/16W
C4203100N 16VC4203100N 16V
R4227 10K1/16WR4227 10K1/16W
R4218 22 OHM 1/16WR4218 22 OHM 1/16WR422310K1/16WR422310K1/16W
C4204100N 16VC4204100N 16V
R4228 NC/10K 1/16W 5%R4228 NC/10K 1/16W 5%
R422210K1/16WR422210K1/16W
R4203 22 OHM 1/16WR4203 22 OHM 1/16W
R4208 22 OHM 1/16WR4208 22 OHM 1/16W
R423522 OHM 1/10W
R423522 OHM 1/10W
R4219 22 OHM 1/16WR4219 22 OHM 1/16W
R4224 10K1/16WR4224 10K1/16W
C420110uF 16V
C420110uF 16V
C42
0710
0N 1
6VC
4207
100N
16V
R4206 22 OHM 1/16WR4206 22 OHM 1/16W
R4204 22 OHM 1/16WR4204 22 OHM 1/16W
R42344.7K1/16W
R42344.7K1/16W
R4220 22 OHM 1/16WR4220 22 OHM 1/16W
FB4200 220R/2000mAFB4200 220R/2000mA
1 2
R4231 100K1/16WR4231 100K1/16W
R4212 22 OHM 1/16WR4212 22 OHM 1/16W
R42004.7K1/16W
R42004.7K1/16W
U411STMPS2171STR
U411STMPS2171STR
OUT1
GND2
FAULT3
EN4
IN5
R4221 22 OHM 1/16WR4221 22 OHM 1/16W
R4211 22 OHM 1/16WR4211 22 OHM 1/16W
R4213 22 OHM 1/16WR4213 22 OHM 1/16W
R423622 OHM 1/10W
R423622 OHM 1/10W
R4214 22 OHM 1/16WR4214 22 OHM 1/16W
GPIO/Int. CI/ MII
MT5363
U401H
GPIO/Int. CI/ MII
MT5363
U401H
GPIO33F23
GPIO34D23
GPIO35A22
GPIO36C22
GPIO30E24
GPIO31J24
GPIO32B23
GPIO26B25
GPIO27D25
GPIO28C24
GPIO29G24
GPIO22C26
GPIO23J26
GPIO24F25
GPIO25H25
GPIO18D27
GPIO19G26
GPIO20E26
GPIO21A26
GPIO14G28
GPIO15H27
GPIO16F27
GPIO17B27
GPIO10D29
GPIO11C28
GPIO12E28
GPIO13J28
GPIO6E30
GPIO7H29
GPIO8F29
GPIO9B29
GPIO3A30
GPIO4C30
GPIO5G30
ETPHYCLKF31
ETTXD3B31
ETTXEND31
ETCOLG32
ETTXD0A32
ETTXD1C32
ETTXD2E32
ETRXCLKB33
ETTXCLKD33
CI_MCLKOF33
CI_MISTRTH33
ETRXD2A34
ETRXD3C34
ETTXERE34
CI_MIVALG34
ETRXD1B35
ETRXERD35
CI_MOVALG36
CI_MDI0H35
ETRXD0A36
ETCRSC36
ETMDCE36
CI_MDO0H37
ETRXDVB37
ETMDIOD37
CI_MOSTRTF37
CI_MCLKIF35
GPIO44AH1
GPIO38AG2GPIO37AF5
GPIO43AH3
GPIO41AG4
GPIO39AE6
GPIO42AG6
GPIO40AF7
GPIO2J32
GPIO0K35
GPIO1K37OPWM0
J34
OPWM2T33 OPWM1J36
R4201NC/4.7K1/16W
R4201NC/4.7K1/16W
R4210 22 OHM 1/16WR4210 22 OHM 1/16W
+ C4200100uF 10V
+ C4200100uF 10V
R4215 22 OHM 1/16WR4215 22 OHM 1/16W
R4207 22 OHM 1/16WR4207 22 OHM 1/16W
C4200 B8C4201 B6C4202 B7C4203 F6C4204 F6C4205 F3C4206 E3C4207 B7CN159 D7FB4200 B7R4200 B7R4201 B6R4202 D3R4203 D3R4204 D3R4205 D3R4206 E3R4207 E3R4208 E3R4209 D3R4210 E3R4211 E3R4212 F3R4213 F3R4214 F3R4215 F3R4216 F3R4217 F3R4218 F3R4219 F3R4220 F3R4221 F3R4222 F6R4223 F6R4224 F7R4225 F7R4226 F7R4227 F7R4228 F7R4231 E8R4232 C4R4233 B7R4234 C4R4235 F3R4236 E3R4237 B6U401H A3U411 B6
EN 48TPM5.2E LA 10.Circuit Diagrams and PWB Layouts
2010-Jun-25
SSB: Scart1/Scart2
18840_514_100408.eps100428
SCART1B09 B09
2010-04-021
SCART1 715G3735
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
A A
B B
C C
D D
E E
F F
G G
H H
Full SCART
SMD/0402
SMD/0402
SMD/0402
-------><--------------><-------
SMD/0402
SMD/0402SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402SMD/0402
---><---|>
-------><-------
---><---|>
SCART1 AUDIO IN
---><---|>---><---|>
---><---|>---><---|>
SMD/0402
SMD/0402
SMD/0402
---><---|>
SMD/0402
---><---|>
SMD/0402
SMD/0402
SMD/0402
SCT1_G_IN
SCT1_FB_INSCT1_R_IN
SCT1_AUL_IN
SCT1_AV_IN
SCT1_B_IN
SCT1_AUL_OUT
SCT1_FS_IN
SCT1_AV_OUT
SCT1_AUR_OUTSCT1_AUR_IN
CVBS3P
Y0P
PR0P
PB0P
COM0
SCT1_B_IN
SCT1_R_IN
Tuner_ByPass_Out SCT1_AV_OUT
SCT1_AV1_GND
SCT1_AV_IN
SCT1_G_IN
SCART1_R_In
SCART_FS0
SCT1_AUR_IN
SCT1_AUL_IN
SCT1_FB_IN
SCT1_FS_IN
SCART1_L_In
SOY0
SCT1_AVO_GND
SCART1_RIGHT
SCART1_LEFT
SCART1_Out_L
SCART1_Out_R
OFF_MUTE
SCT1_AUR_OUT
SCART1_LEFT
OFF_MUTE
SCT1_AUL_OUT
SCART1_RIGHT
HP_SC_MUTE
VREF
VREF
VREF
HP_SC_MUTE+24V_16V +12V
+12V
C1106220pF 50VC1106220pF 50V
R1137100OHM1/16W
R1137100OHM1/16W
FB1052BEADFB1052BEAD
1 2
R109975OHM1/16W
R109975OHM1/16W
C105510N 50VC105510N 50V
C10891UF16VC10891UF16V
C10901UF16VC10901UF16V
U106RC4580IPWRU106RC4580IPWR1O
UT
11I
N-
21I
N+
3V
CC
-4
2IN
+5
2IN
-6
2OU
T7
VC
C+
8
R113875OHM1/16W
R113875OHM1/16W
R109047K1/10W
R109047K1/10W
R106075OHM1/16W
R106075OHM1/16W
L10501.8uHL10501.8uH
ZD1060NC/VPORT0603100KV05ZD1060NC/VPORT0603100KV051
2
C1087820PF 50VC1087820PF 50V
C106010uF 16VC106010uF 16V
R11330R05 1/10W
R11330R05 1/10W
ZD1063NC/VPORT0603100KV05
ZD1063NC/VPORT0603100KV05
12
C105810N 50VC105810N 50V
ZD1066NC/VPORT0603100KV05
ZD1066NC/VPORT0603100KV05
12
R11000R05OHM1/16W
R11000R05OHM1/16W
ZD1069NC/VPORT0603100KV05
ZD1069NC/VPORT0603100KV05 1
2
R10810R05OHM1/16W
R10810R05OHM1/16W
R108447K1/16WR108447K1/16W
C105310N 50VC105310N 50V
ZD1052NC/VPORT0603100KV05
ZD1052NC/VPORT0603100KV05
12
C1066100N 50VC1066100N 50V
R10710R05OHM1/16W
R10710R05OHM1/16W
ZD1050NC/VPORT0603100KV05
ZD1050NC/VPORT0603100KV05
12
R108910K1/16W
R108910K1/16W
C108247pF 50VC108247pF 50V
C106447pF 50VC106447pF 50V
FB1053BEADFB1053BEAD
1 2
R10780R05OHM1/16W
R10780R05OHM1/16W
R113568OHM 1/16W
R113568OHM 1/16W
C1063820PF 50V
C1063820PF 50V
C105910uF 16VC105910uF 16V
R113151K 1/16W 5%
R113151K 1/16W 5%
C108347pF 50V
C108347pF 50V
C106810N 50V
C106810N 50V
R10720R05OHM1/16W
R10720R05OHM1/16W
R1
Q1050DTC623TK
R1
Q1050DTC623TK
2
31
C107810N 50VC107810N 50V
ZD1065NC/VPORT0603100KV05
ZD1065NC/VPORT0603100KV05
12
R113410K1/16WR113410K1/16WR1063
68OHM 1/16WR1063
68OHM 1/16W
U108L78L12ABUTRU108L78L12ABUTR
IN3
OUT1
GN
D2
R11395K1 1/16W 5%
R11395K1 1/16W 5%
R106833K 1/16W
R106833K 1/16W
R112975 OHM 1/10WR112975 OHM 1/10W
R107733K 1/16W
R107733K 1/16W
ZD1051NC/VPORT0603100KV05
ZD1051NC/VPORT0603100KV05
12
C107910N 50V
C107910N 50V
C1080100N 50VC1080100N 50V
C1105
220pF 50V
C1105
220pF 50V
R10800R05OHM1/16W
R10800R05OHM1/16W
R1073100OHM1/16W
R1073100OHM1/16W
ZD1059NC/VPORT0603100KV05ZD1059NC/VPORT0603100KV051
2
C107710uF 16V
C107710uF 16V
R105510K1/16W
R105510K1/16W
R106275OHM1/16W
R106275OHM1/16W
C105615PF50VC105615PF50V
FB1054BEADFB1054BEAD
1 2
C106547N16VC106547N16V
C106710uF 16V
C106710uF 16V
R106175OHM1/16W
R106175OHM1/16W
R1085330 OHM 1/10W
R1085330 OHM 1/10W
R106468OHM 1/16W
R106468OHM 1/16W
C105715PF50VC105715PF50V
C108810uF 16V
C108810uF 16V
ZD1068NC/VPORT0603100KV05
ZD1068NC/VPORT0603100KV05
12
R106530KOHM 1/16W +/-5%
R106530KOHM 1/16W +/-5%
C105415PF50V
C105415PF50V
+C1081
10uF/50V
+C1081
10uF/50V
C107110uF 16V
C107110uF 16V
C1069NC/10N 50VC1069NC/10N 50V
R10915K1 1/16W 5%
R10915K1 1/16W 5%
R108747K1/16WR108747K1/16W
SCARTCN151 SCARTCN151
12
34
56
78
910
1112
1314
1516
1718
1920
21
2223
R109447K1/16WR109447K1/16W
R106730KOHM 1/16W +/-5%
R106730KOHM 1/16W +/-5%
C1084NC/47pF 50V
C1084NC/47pF 50V
R108347K1/10W
R108347K1/10W
R1088330 OHM 1/10W
R1088330 OHM 1/10W
R10790R05OHM1/16W
R10790R05OHM1/16W
ZD1067NC/VPORT0603100KV05
ZD1067NC/VPORT0603100KV05
12
R109347K1/16W
R109347K1/16W
R10860R05OHM1/16W
R10860R05OHM1/16W
R1
Q1051DTC623TK
R1
Q1051DTC623TK
2
31
C1070NC/10N 50VC1070NC/10N 50V
C1053 C5C1054 B4C1055 C5C1056 C4C1057 C4C1058 D5C1059 A7C1060 B7C1063 F2C1064 B4C1065 A5C1066 F3C1067 F4C1068 B5C1069 A6C1070 B6C1071 G2C1077 G4C1078 F6C1079 G6C1080 G8C1081 G8C1082 E1C1083 E2C1084 E2C1087 G2C1088 F2C1089 G3C1090 F3C1105 F3C1106 H3CN151 B2FB1052 B3FB1053 C3FB1054 D3L1050 E2Q1050 F5Q1051 G5R1055 G2R1060 C4R1061 B4R1062 C4R1063 D5R1064 C5R1065 A7R1067 B7R1068 H3R1071 B4R1072 A3R1073 A5R1077 F3R1078 C4R1079 D4R1080 C4R1081 F5R1083 G4R1084 F6R1085 F5R1086 H5R1087 G6R1088 G5R1089 F2R1090 F4R1091 G3R1093 G8
R1094 G8R1099 E1R1100 E2R1129 C6R1131 C7R1133 C7R1134 D7R1135 B5R1137 C5R1138 B4R1139 F3U106 F3U108 F8ZD1050 B6ZD1051 C6ZD1052 C6ZD1059 F6ZD1060 G6ZD1063 E3ZD1065 B3ZD1066 B3ZD1067 C3ZD1068 C3
Circuit Diagrams and PWB Layouts EN 49TPM5.2E LA 10.
2010-Jun-25
SSB: YPbPr/VGA input
18840_515_100408.eps100428
YPBPR/VGA INPUTB10 B10
2010-04-021
YPBPR/VGA INPUT 715G3735
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
A A
B B
C C
D D
E E
F F
G G
H H
YPbPr_R_In
YPbPr_L_In
PR1P
COM1
PB1P
Y1P
SOY1
VGASDAVGA_AudioRIN
RP
COM
BP
GP
VGA_PLUGPWR
RED_GND
GRN_GND
RED
GRN
BLU_GNDBLU
HSYNC
VSYNC
SOG
M_OPCTRL3
VGASDA
VGA_PLUGPWR
VGASCL
VGASCL
Y_IN_1
GRN
BLU
RED
YPbPrL_IN
VSYNC#
Y_IN_1
PB_IN_1
PR_IN_1
VGA_AudioLIN
VGASCL_IN
VGASDA_IN
VSYNC#
HSYNC#
AV3_CVBS_IN CVBS1P
CVBS0N
AV3_AudioLIN
AV1_R_In
AV1_L_In
SPDIF_OUT
YPbPrL_IN
YPbPrR_IN
SPDIF_OUT
PB_IN_1
PR_IN_1
HSYNC# VGASCL_IN
VGASDA_IN
AV3_AudioRIN
AV3_AudioLIN
AV3_CVBS_IN
M_SPDIF_Out
U0RX#U0RX U0TX
TX_RX_ON/OFF
VGA_R_In
VGA_L_In
VGA_AudioRIN
VGA_AudioLIN
Y_IN_1
PB_IN_1
DVD_Y_dect
DVD_PR_IN
DVD_PB_IN
DVD_Y_IN
GRN_GND
DVD_Y_dect
DVD_Y_GND
DVD_Y_GND
PR_IN_1
DVD_R_IN
SPDIF_DVD_IN
Key2
AV3_AudioRIN
LCD_Clock_SDA
DVD_StandbyDVD_Reset
DVD_IR_Disable
YPbPrR_IN
YPbPrR_IN
BLU_GND
RC6
DVD_PR_IN
LCD_Clock_SCL
AUDIO_MUTE
DVD_PB_IN
DVD_Disk_in
DVD_Y_IN
DVD_STATUS
YPbPrL_IN DVD_L_IN
SPDIF_IN
U0TX#
DVD_Eject
RED_GND
VGA_PLUGPWR
VGA_PLUGPWR
VGA_PLUGPWR
+5V_SW
M_OPCTRL35,8,12
VSYNC6HSYNC6
6 PBSOG6
6 PGCOM6
6 PR
VGA_L_In6VGA_R_In6
GND2,3,4,5,6,7,8,9,10,12,13,14
+5V_SW2,3,6,8,9,12,13,14
CVBS1P6SOY16
6 P1YPB1P6COM16PR1P6
MPX_N4,6MPX_P4,6
CVBS0N6AV1_L_In6AV1_R_In6YPbPr_L_In6YPbPr_R_In6
M_SPDIF_Out5,6
8 XR0U8 XT0U
8 6CRDVD_STATUS8
SPDIF_DVD_IN6
TX_RX_ON/OFF6
LCD_Clock_SDA8LCD_Clock_SCL8
AUDIO_MUTE8,138 2yeK
YPbPr L/R INPUT
AV1 (Component1)
---><---|>---><---|>
AV1 AUDIO
-------><--------------><-------
-------><-------
----------><---------|
----------><---------|
VGA IN
-------><--------------><-------
-------><-------
----------><---------|
VGA/Audio L/R INPUT
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
----------><---------|----------><---------|
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
Video Input
Audio Out
Video Input
Audio Input
SIDE AV
AV3(CVBS)_Audio R/L
(Side)CVBS
---><---|>
SMD/0402
---><---|>
(Side)
---><---|>
AV_AUDIO
SPDIF
---><---|>
HW Strap Seeting
Others Control Interface
FOR DVD model interface
SMD/0402
SMD/0402
---><---|>---><---|>
VGA AUDIO
SMD/0402
SMD/0402
SMD/0402
R115710K 1/10WR115710K 1/10W
R118068OHM 1/16W
R118068OHM 1/16W
R121556R 1/16W 1%
R121556R 1/16W 1%
R119975OHM1/16W
R119975OHM1/16W
R121418 OHM +-5% 1/16W
R121418 OHM +-5% 1/16W
C1195NC/10N 50V
C1195NC/10N 50V
C11555PF 50VC11555PF 50V
ZD1154NC/VPORT0603100KV05
ZD1154NC/VPORT0603100KV05
12
R11730R05OHM1/16W
R11730R05OHM1/16W
R115530KOHM 1/16W +/-5%
R115530KOHM 1/16W +/-5%
C119247P 50VC119247P 50V
C1177NC/10N 50V
C1177NC/10N 50V
C115615PF50VC115615PF50V
ZD1161NC/VPORT0603100KV05
ZD1161NC/VPORT0603100KV05
12
C116215PF50VC116215PF50V
C1161100N 16VC1161100N 16V
R1189240R 1/10W 1%
R1189240R 1/10W 1%
R118810K1/16W
R118810K1/16W
C119815PF50VC119815PF50V
R116818 OHM +-5% 1/16WR116818 OHM +-5% 1/16W
R1181100OHM1/16W
R1181100OHM1/16W
R1167NC/100OHM1/16W
R1167NC/100OHM1/16W
R12000R05OHM1/16W
R12000R05OHM1/16W
R117475OHM1/16W
R117475OHM1/16W
R11851.5K 1/16WR11851.5K 1/16W
ZD1153NC/VPORT0603100KV05
ZD1153NC/VPORT0603100KV05
12
ZD1170NC/VPORT0603100KV05
ZD1170NC/VPORT0603100KV05
12
R1203NC/75OHM1/16WR1203NC/75OHM1/16W
C117510N 50VC117510N 50V
C119915PF50VC119915PF50V
R1213 NC/0R05OHM1/16WR1213 NC/0R05OHM1/16W
FB1167600R/200mA
FB1167600R/200mA
1 2
C118110uF 16VC118110uF 16V
A
B
C
CN111
JACK
A
B
C
CN111
JACK
2
1
4
3
5
6
R12010R05OHM1/16W
R12010R05OHM1/16W
R1165NC/100OHM1/16W
R1165NC/100OHM1/16W
C11585PF 50VC11585PF 50V
ZD1163NC/VPORT0603100KV05ZD1163NC/VPORT0603100KV05
12
ZD1160NC/VPORT0603100KV05
ZD1160NC/VPORT0603100KV05
12
C116710uF 16VC116710uF 16V
R118210K1/16WR118210K1/16W
ZD1151NC/VPORT0603100KV05ZD1151NC/VPORT0603100KV05
12
FB1162BEAD
FB1162BEAD
1 2
R11560R05OHM1/16W
R11560R05OHM1/16W
CN136
JACK
CN136
JACK
2
1
4
3
6
5
C11725PF 50VC11725PF 50V
FB1170BEADFB1170BEAD
1 2
R1204 NC/0R05OHM1/16WR1204 NC/0R05OHM1/16W
D1159BAS316D1159BAS316
A1
K2
FB1171BEADFB1171BEAD
1 2
C116410uF 16VC116410uF 16V
ZD1152NC/VPORT0603100KV05ZD1152NC/VPORT0603100KV05
12
R115868OHM 1/16W
R115868OHM 1/16W
CN4072
CONN
CN4072
CONN
123456789
10111213141516171819202122232425
FB1169BEADFB1169BEAD
1 2
R1210 NC/0R05OHM1/16WR1210 NC/0R05OHM1/16W
ZD1156NC/VPORT0603100KV05
ZD1156NC/VPORT0603100KV05 1
2
R117168OHM 1/16W
R117168OHM 1/16W
FB1160BEADFB1160BEAD
1 2
ZD1157NC/VPORT0603100KV05
ZD1157NC/VPORT0603100KV05 1
2
FB1168600R/200mA
FB1168600R/200mA
1 2
R11770R05OHM1/16W
R11770R05OHM1/16W
R1209NC/0R05OHM1/16WR1209NC/0R05OHM1/16W
A
B
C
CN116
JACK
A
B
C
CN116
JACK
2
1
4
3
5
6
R116310K1/16WR116310K1/16W
R116956R 1/16W 1%
R116956R 1/16W 1%
FB1172BEADFB1172BEAD
1 2
R11841.5K 1/16WR11841.5K 1/16W
C119715PF50VC119715PF50V
CN10488G 35315FVCL
CN10488G 35315FVCL
162738495
11
12
13
14
1510
171618
19
R117868OHM 1/16W
R117868OHM 1/16W
R117975OHM1/16W
R117975OHM1/16W
C1196NC/33P 50VC1196NC/33P 50V
C11521UF16VC11521UF16V
R12110R05OHM1/16W
R12110R05OHM1/16W
C1182NC/10N 50VC1182NC/10N 50V
C117910N 50VC117910N 50V
R1207 NC/0R05OHM1/16WR1207 NC/0R05OHM1/16W
C11731.5nF 50VC11731.5nF 50V
R115910K1/16W
R115910K1/16W
R115330KOHM 1/16W +/-5%
R115330KOHM 1/16W +/-5%
ZD1169NC/VPORT0603100KV05ZD1169NC/VPORT0603100KV05
12
R1162100OHM1/16W
R1162100OHM1/16W
R1160100OHM1/16W
R1160100OHM1/16W
C11531.5nF 50V
C11531.5nF 50V
Q11552N7002LT1 FET
Q11552N7002LT1 FET
FB1159BEADFB1159BEAD
1 2
C1169NC/10N 50VC1169NC/10N 50V
CN102
PHONEJACK
CN102
PHONEJACK
12
3
R116656R 1/16W 1%
R116656R 1/16W 1%
R1208NC/0R05OHM1/16W
R1208NC/0R05OHM1/16W
ZD1150NC/VPORT0603100KV05ZD1150NC/VPORT0603100KV05
12
R1198100OHM1/16W
R1198100OHM1/16W
R1183100OHM1/16W
R1183100OHM1/16W
ZD1166NC/VPORT0603100KV05ZD1166NC/VPORT0603100KV05
12
R115030KOHM 1/16W +/-5%
R115030KOHM 1/16W +/-5%
C118010uF 6.3VC118010uF 6.3V
R121856R 1/16W 1%
R121856R 1/16W 1%
U110
M24C02-WDW6P
U110
M24C02-WDW6P
E01
E12
E23
VSS4 SDA 5SCL 6WC 7
VCC 8
R1202NC/100OHM1/16W
R1202NC/100OHM1/16W
Q11562N7002LT1 FET
Q11562N7002LT1 FET
R1195 NC/100OHM1/16WR1195 NC/100OHM1/16W
Q1150BC847C
Q1150BC847C
3
2
1
R118775OHM1/16W
R118775OHM1/16W
C119147N16V
C119147N16V
ZD1165NC/VPORT0603100KV05ZD1165NC/VPORT0603100KV05
12
C116015PF50VC116015PF50V
C11705PF 50VC11705PF 50V
R116468OHM 1/16W
R116468OHM 1/16W
R117218 OHM +-5% 1/16W
R117218 OHM +-5% 1/16W
R1205NC/0R05OHM1/16WR1205NC/0R05OHM1/16W
C1184NC/10N 50VC1184NC/10N 50V
R115430KOHM 1/16W +/-5%
R115430KOHM 1/16W +/-5%
R121656R 1/16W 1%
R121656R 1/16W 1%
FB1173BEADFB1173BEAD
1 2
C1166NC/10N 50VC1166NC/10N 50VC1157
10N 50VC1157
10N 50V
R115230KOHM 1/16W +/-5%
R115230KOHM 1/16W +/-5%
C1187100N 50VC1187100N 50V
R115130KOHM 1/16W +/-5%
R115130KOHM 1/16W +/-5%
FB1163BEAD
FB1163BEAD
1 2
ZD1162NC/VPORT0603100KV05ZD1162NC/VPORT0603100KV051
2
R116156R 1/16W 1%
R116156R 1/16W 1%
C117610N 50V
C117610N 50V
C118310uF 16VC118310uF 16V
D1160BAS316D1160BAS316
A1 K 2
C117810N 50V
C117810N 50V
C116310N 50VC116310N 50V
R11860R05OHM1/16W
R11860R05OHM1/16W
C118933P 50VC118933P 50V
FB1161BEADFB1161BEAD
1 2
C117410uF 6.3VC117410uF 6.3V
R117018 OHM +-5% 1/16W
R117018 OHM +-5% 1/16W
R117568OHM 1/16W
R117568OHM 1/16W
ZD1155NC/VPORT0603100KV05
ZD1155NC/VPORT0603100KV05
12
R121718 OHM +-5% 1/16W
R121718 OHM +-5% 1/16W
R121218 OHM +-5% 1/16WR121218 OHM +-5% 1/16W
C115410N 50VC115410N 50V
R117675OHM1/16W
R117675OHM1/16W
FB1158BEADFB1158BEAD
1 2
C115910N 50VC115910N 50V
R12060R05OHM1/16W
R12060R05OHM1/16W
R1196NC/0R05OHM1/16W
R1196NC/0R05OHM1/16W
R119775OHM1/16W
R119775OHM1/16W
ZD1164NC/VPORT0603100KV05ZD1164NC/VPORT0603100KV05
12
R1194100 OHM 1/10WR1194100 OHM 1/10W
C11715PF 50VC11715PF 50V
C1152 F5C1153 A5C1154 A5C1155 D9C1156 A4C1157 A5C1158 E9C1159 A5C1160 B4C1161 E5C1162 B4C1163 B5C1164 A7C1166 A7C1167 B7C1169 B7C1170 C5C1171 D5C1172 D5C1173 C6C1174 C8C1175 C6C1176 C6C1177 C8C1178 C6C1179 D6C1180 B8C1181 G5C1182 G4C1183 H5C1184 H4C1187 B2C1189 C1C1191 F5C1192 F4C1195 C8C1196 G6C1197 G10C1198 G10C1199 G10CN102 E1CN104 D1CN111 A1CN116 B1CN136 F1CN4072 F8D1159 D3D1160 D2FB1158 A3FB1159 A3FB1160 B3FB1161 C4FB1162 C4FB1163 D4FB1167 B7FB1168 C7FB1169 D9FB1170 E8FB1171 G10FB1172 F10FB1173 G10Q1150 E7Q1155 D1Q1156 D2R1150 A7R1151 B7R1152 B8R1153 C8R1154 G5R1155 H5R1156 A5R1157 E7R1158 A5R1159 E6R1160 D10R1161 A4
R1162 A5R1163 D10R1164 A5R1165 E1R1166 B4R1167 E2R1168 A4R1169 B4R1170 A4R1171 B5R1172 B4R1173 A4R1174 D4R1175 C5R1176 D4R1177 C5R1178 D5R1179 C4R1180 C5R1181 C5R1182 E10R1183 E10R1184 D8R1185 E8R1186 C5R1187 D8R1188 D1R1189 B2R1194 C1R1195 G7R1196 G7R1197 E8R1198 F5R1199 F4R1200 F4R1201 F5R1202 G7R1203 G7R1204 G7R1205 G7R1206 G11R1207 G7R1208 A3R1209 G7R1210 F7R1211 A4R1212 F10R1213 G7R1214 G10R1215 G10R1216 G10R1217 G10R1218 G10U110 E6ZD1150 A3ZD1151 B3ZD1152 B3ZD1153 C4ZD1154 D4ZD1155 D4ZD1156 A6ZD1157 B6ZD1160 D8ZD1161 E8ZD1162 D10ZD1163 E10ZD1164 D2ZD1165 G3ZD1166 H3ZD1169 F3
EN 50TPM5.2E LA 10.Circuit Diagrams and PWB Layouts
2010-Jun-25
SSB: HDMI 1/ HDMI 2
18840_516_100408.eps100428
HDMI1/HDMI2 INPUTB11 B11
2010-04-021
HDMI1/HDMI2 INPUT 715G3735
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
A A
B B
C C
D D
E E
F F
G G
H H
HDMI 1 INPUT
HDMI 2 INPUT--
----
><--
----
-
HDMI 1 EDID EEPROM
----
--><
----
---
HDMI 2 EDID EEPROM
EDID_WEN:write_enable: Highwrite_disable: Low
-----------> <-------->>
HDMI1 ESD PROTECTER
---------> <-------->>
------> <------->>
----> <------->>
HDMI2 ESD PROTECTER
-----------> <-------->>
---------> <-------->>
------> <------->>
----> <------->>
-----------> <-------->>
---------> <-------->>
------> <------->>
----> <------->>
-----------> <-------->>
---------> <-------->>
------> <------->>
----> <------->>
-----------> <-------->>
---------> <-------->>
------> <------->>
----> <------->>
----
--><
----
---
----
--><
----
---
(SIDE)
(SIDE)
SMD/0402
SMD/0402
SMD/0402
SMD/0402
---------> <-------->>
-----------> <-------->>
----> <------->>
------> <------->>
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SCL_1SDA_1
RX1_2+
RX1_2-RX1_1+
RX1_1-RX1_0+
RX1_0-RX1_C+
RX1_C-CEC_1
PWR5V_2
CEC_2SCL_2
SCL_2SDA_2
RX2_2+
RX2_2-RX2_1+
RX2_1-RX2_0+
RX2_0-RX2_C+
RX2_C-CEC_2
HPLUGP2_5V
HPLUGP2_5VHDMI2_SCL
HDMI2_SDA
CEC_1SCL_1
M_OPCTRL3
SDA_2
HPLUGP1_5V
SDA_1
RX1_2+RX1_2-
RX1_1+RX1_1-
RX1_0+RX1_0-
RX1_C+RX1_C-
RX2_0-RX2_0+
RX2_1-RX2_1+
RX2_2-RX2_2+
RX2_C-RX2_C+
HDMI1_SCL#HDMI1_SDA#
M_OPCTRL3
PWR5V_1
RX1_2+RX1_2-
RX1_1+RX1_1-
RX1_0+RX1_0-
RX1_C+RX1_C-
PWR5V_1
CEC_1SCL_1
SDA_1
RX2_1-RX2_1+
RX2_2-RX2_2+
RX2_0+RX2_0-
RX2_C-RX2_C+
PWR5V_2 PWR5V_2
CEC_2SCL_2
SDA_2
HPLUGP1_5V
HDMI1_SCL#
HDMI1_SDA#
CEC_1
CEC_2
HDMI2_SCLHDMI2_SDA
PWR5V_2
HDMI_CEC
HPD2
HDMI1_SDA#HPD1
USB_DP
RX1_2+
RX1_0-
RX2_0-
HPD1
HPD2
RX1_0+
HDMI1_SCL#
USB_VRT HDMI2_SDA
RX1_C+
RX2_2-
RX2_1+
AVDD3V3_USB
RX2_C+
PWR5V_1
USB_VRT
PWR5V_1
USB_DM PWR5V_2
RX1_2-
RX1_C-
RX1_1+
AVDD1V25_HDMI
AVDD1V25_USB
HDMI1_SDAHDMI1_SCL
HDMI_CEC
HDMI2_SCL
RX2_C-
HDMI1_SDA
RX2_2+
AVDD3V3_HDMI
PWR5V_1
HDMI1_SCL
RX1_1-
RX2_1-
RX2_0+
HPLUGP1_5V
HPLUGP2_5V
+5V_SW
DV33 DV33
DV33DV33
DV33SB
+5V_SW
AVDD1V25_HDMI
AVDD1V25_USB
AVDD3V3_HDMIAV33
AV12
AVDD3V3_USB
R50227K 1/16WR50227K 1/16W
R5261K1/16WR5261K1/16W
C508NC/100N 16VC508NC/100N 16V
U504
M24C02-WDW6P
U504
M24C02-WDW6P
E01
E12
E23
VSS4
SDA5SCL6WC7VCC8
Q501NC/BC847C
Q501NC/BC847C
3
2
1
R5040R05OHM1/16W
R5040R05OHM1/16W
R525100K1/16WR525100K1/16W
R51810K1/16W
R51810K1/16W
R506NC/0R05OHM1/16WR506NC/0R05OHM1/16W
D506BAS316
D506BAS316
A1
K2
C507100N 16VC507100N 16V
Q505BC847C
Q505BC847C
3
2
1
Q502NC/2SK1828
Q502NC/2SK1828
3
1
2
R5290R05 1/10W
R5290R05 1/10W
R503NC/0R05OHM1/16W
R503NC/0R05OHM1/16W
CN502
NC/HDMI
CN502
NC/HDMI
SHELL120
SHELL221
D2+1
D2 Shield2
D2-3
D1+4
D1 Shield5
D1-6
D0+7
D0 Shield8
D0-9
CK+10
CK Shield11
CK-12
CE Remote13
NC14
DDC CLK15
DDC DATA16
GND17
+5V18
HP DET19
SHELL423
SHELL322
U502
NC/M24C02-WDW6P
U502
NC/M24C02-WDW6P
E01
E12
E23
VSS4
SDA5SCL6WC7VCC8
U513NC/RClamp0524P.TCT
U513NC/RClamp0524P.TCT
IN11
IN22
GN
D3
IN34
IN45
OUT46OUT37
GN
D8
OUT29OUT110
R52047K1/16WR52047K1/16W
R509NC/47K1/16WR509NC/47K1/16W
R5320R05 1/10W
R5320R05 1/10W
C503100N 16VC503100N 16V
HDMI & USB I/F
MT5363
U401E
HDMI & USB I/F
MT5363
U401E
AVDD12_HDMIAP11
AVSS33_HDMIAN12
RX2_CAR12
RX2_CBAU12
AVDD33_HDMIAM13
RX2_0AP13
RX2_0BAT13
HDMI_SCL2AL12
HDMI_CECAN14
RX2_1AR14
RX2_1BAU14
RX2_2AP15
RX2_2BAT15
RX1_CAR16
RX1_CBAU16
RX1_0AP17
RX1_0BAT17
RX1_1AR18
RX1_1BAU18
RX1_2AP19
RX1_2BAT19
HDMI_SDA2AL14
PWR5V_2AM15
HDMI_HPD2AN16
HDMI_SCL1AM17
HDMI_HPD1AL18
HDMI_SDA1AN18
AVSS12_USBAM9 AVDD12_USBAL10
AVDD33_USBAM11
USB_VRTAN10
USB_DPAU10
USB_DMAR10
PWR5V_1AL16
AVSS33_USBAP9
AVSS33_USBAT9
AVSS33_USBAT11
ZD503NC/VPORT0603100KV05ZD503NC/VPORT0603100KV05
12
U507NC/RClamp0524P.TCT
U507NC/RClamp0524P.TCT
IN11
IN22
GN
D3
IN34
IN45
OUT46OUT37
GN
D8
OUT29OUT110
R511 NC/100OHM1/16WR511 NC/100OHM1/16W
D503NC/BAS316D503NC/BAS316
A1
K2
R5130R05 1/10W
R5130R05 1/10W
ZD502VPORT0603100KV05ZD502VPORT0603100KV05
12
C504100N 16VC504100N 16V
U505NC/RClamp0524P.TCT
U505NC/RClamp0524P.TCT
IN11
IN22
GN
D3
IN34
IN45
OUT46OUT37
GN
D8
OUT29OUT110
ZD501VPORT0603100KV05ZD501VPORT0603100KV05
12
C505100N 16VC505100N 16V
R5230R05 1/10W
R5230R05 1/10W
CN501HDMICN501HDMI
TH120
TH221
D2+1
D2 Shield2
D2-3
D1+4
D1 Shield5
D1-6
D0+7
D0 Shield8
D0-9
CK+10
CK Shield11
CK-12
CE Remote13
NC14
DDC CLK15
DDC DATA16
GND17
+5V18
HP DET19
TH322
TH423
TH524
U512NC/RClamp0524P.TCT
U512NC/RClamp0524P.TCT
IN11
IN22
GN
D3
IN34
IN45
OUT46OUT37
GN
D8
OUT29OUT110
U506NC/RClamp0524P.TCT
U506NC/RClamp0524P.TCT
IN11
IN22
GN
D3
IN34
IN45
OUT46OUT37
GN
D8
OUT29OUT110
R516NC/4.7K1/16W
R516NC/4.7K1/16W
D507BAS316D507BAS316
A1
K2
C506100N 16VC506100N 16V
FB502NC/600R/500mA
FB502NC/600R/500mA
1 2
C5104.7UF 10VC5104.7UF 10V
C509NC/100N 16VC509NC/100N 16V
U511NC/RClamp0524P.TCT
U511NC/RClamp0524P.TCT
IN11
IN22
GN
D3
IN34
IN45
OUT46OUT37
GN
D8
OUT29OUT110
R527NC/1K1/16W
R527NC/1K1/16W
R543NC/4K7 1/16W 5%R543NC/4K7 1/16W 5%
D504NC/BAS316D504NC/BAS316
A1
K2
C511100N 16VC511100N 16V
R52433 OHM 1/16W
R52433 OHM 1/16W
R5284.7K1/16W
R5284.7K1/16W
R507NC/10K1/16WR507NC/10K1/16W
R542NC/4K7 1/16W 5%R542NC/4K7 1/16W 5%
R512NC/33 OHM 1/16W
R512NC/33 OHM 1/16W
R5625K1 1/16W 5%R5625K1 1/16W 5%
R517NC/1K1/16W
R517NC/1K1/16W
R51947K1/16WR51947K1/16W
FB501600R/500mA
FB501600R/500mA
1 2
R540NC/4.7K1/16WR540NC/4.7K1/16W
R530NC/0R05OHM1/16W
R530NC/0R05OHM1/16W
R522 100OHM1/16WR522 100OHM1/16W
R515NC/1K1/16WR515NC/1K1/16W
R541NC/4.7K1/16WR541NC/4.7K1/16W
Q504NC/BC847C
Q504NC/BC847C
3
2
1
R510 NC/100OHM1/16WR510 NC/100OHM1/16W
R521 100OHM1/16WR521 100OHM1/16W
Q508NC/2SK1828
Q508NC/2SK1828
3
1
2
R508NC/47K1/16WR508NC/47K1/16W
D502BAS316D502BAS316
A1
K2
R5310R05OHM1/16W
R5310R05OHM1/16W
R505NC/0R05OHM1/16W
R505NC/0R05OHM1/16W
R514NC/100K1/16W
R514NC/100K1/16W
Q503NC/BC847C
Q503NC/BC847C
3
2
1
ZD502 B2ZD503 D2U513 D10ZD501 E9U511 C10U512 C10U506 F10U507 G10U504 B5U505 E10U401E F5U502 D5R543 B4R562 G5R541 G2R542 D4R532 H7R540 G2R530 D4R531 B4R528 B7R529 G7R526 B3R527 B4R524 B6R525 B2R522 B2R523 F7R520 B6R521 B2R518 B6R519 B6R516 D7R517 D4R514 D2R515 D3R512 D6R513 F7R510 D2R511 D2R508 D6R509 D6R506 H2R507 D6R504 E8R505 G2R502 E9R503 E8Q505 B7Q508 G2Q503 D7Q504 B3Q501 D3Q502 G2FB501 A5FB502 D5D506 A4D507 B3D503 C4D504 D3C511 A5D502 D9C509 D2C510 H7C507 B2
C508 D5C505 G7C506 H7C503 F7C504 F7CN501 A1CN502 C1
Circuit Diagrams and PWB Layouts EN 51TPM5.2E LA 10.
2010-Jun-25
SSB: Audio Amp/Headphone out
18840_517_100408.eps100428
AUDIO AMP/HEADPHONE OUTB12 B12
2010-04-021
AUDIO AMP/HEADPHONE OUT
715G3735
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
A A
B B
C C
D D
E E
F F
G G
H H
AMP_MUTE: [AOSDATA1]AUDIO_MUTE: [OPCTRL4]NORMAL: LowMUTE: High
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
7V
-------><-------
-------><--------------><-------
-------><--------------><-------
HP_AMP_MUTE: [GPIO 43]NORMAL: LowMUTE: High
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
SMD/0402
Application for BUH 1W MONO
Headphone
-------><-------
BackFront
SMD
ROUT-
LOUT-
HPOUTL
Shutdown
HP_DET#HPOUTL
HP_SC_MUTE
ROUT-
HP_SC_MUTE
HP_Out_R HP_out_R1
HP_Out_L
HPOUTR
LOUT+
ROUT+
Shutdown
ROUT+
Line_Out_R
Line_Out_L
AUDIO_VDD
LOUT+LOUT+
LOUT-
HP_out_L1
AUDIO_VDD
OFF_MUTE
SP_AMP_MUTE
OFF_MUTE
AUDIO_VDD
#SD
Vo+
#SD
HP_out_R1
HP_out_L1
HPOUTL_BATH
HPOUTR
HPOUTL
HP_AMP_MUTE
HPOUTR
HPOUTL_BATHVo-
AMP_MUTE
AUDIO_MUTE
GND_SOUND
GND_SOUND
DV33
GND_SOUND
GND_SOUND
+5V_SW
+5V_SW
GND_SOUND
GND_SOUND
GND_SOUND
GND_SOUND
GND_SOUND
GND_SOUND
GND_SOUND
GND_SOUND
GND_SOUND
GND_SOUND
GND_SOUND
GND_SOUND
+24V_16V
GND_SOUND
GND_SOUND
GND_SOUND
GND_SOUND
GND_SOUND
GND_SOUND
GND_SOUND
GND_SOUND
PWR_24V_16V STB_PWR_5V
+5V_SW
GND_SOUND
+5V_SW
DV33
DV33 DV33SB
GND_SOUND
FB603 120R/3000mAFB603 120R/3000mA
1 2
C6091UF 16VC6091UF 16V
C617NC/2.2UF10VC617
NC/2.2UF10V
C618100N 50V
C618100N 50V
R6099R1 1/10W 1%
R6099R1 1/10W 1%
R6430R05OHM1/16W
R6430R05OHM1/16W
C652NC/1uF 25V
C652NC/1uF 25V
R65224K +-1% 1/16W
R65224K +-1% 1/16W
TP
60
3T
P6
03
1
D607BAS316D607BAS316
A1
K2
FB607 NC/120R/6AFB607 NC/120R/6A1 2
C640NC/1N 50VC640NC/1N 50V
+C633220UF/35V
+C633220UF/35V
C6060.47uF 16V
C6060.47uF 16V
R625NC/0R05OHM1/16W
R625NC/0R05OHM1/16W
U602TPA6132A2RTER
U602TPA6132A2RTER
INL-1
INR+3
INL+2
OU
TL
16
HPVDD12
HP
VS
S8
G0
6
INR-4
OU
TR
5
CPP11
CPN9
EN
13
SG
ND
15
AV
DD
14
PGND10
G1
7
Th
erm
al P
ad
17
TP
60
1T
P6
01
1
R658NC/0R05OHM1/16W
R658NC/0R05OHM1/16W
R6340R05OHM1/16W
R6340R05OHM1/16W
C6191N 50VC6191N 50V
R6311K1/16W
R6311K1/16W
CN601
CONN
CN601
CONN
1234
FB611 120R/3000mAFB611 120R/3000mA
1 2
L601 47uHL601 47uH
D604BAS316
D604BAS316
A1
K2
C64410N 50V
C64410N 50V
R6440R05OHM1/16W
R6440R05OHM1/16W
FB612 120R/3000mAFB612 120R/3000mA
1 2
R621NC/10K1/16WR621NC/10K1/16W
C64310N 50VC64310N 50V
R647100OHM1/16W
R647100OHM1/16W
R650NC/27K 1/16W
R650NC/27K 1/16W
C635NC/1N 50VC635NC/1N 50V
R653NC/6.8K1/16W
R653NC/6.8K1/16W
FB604 120R/3000mAFB604 120R/3000mA
1 2
Q605BC847C
Q605BC847C
U603
NC/TPA6211A1DGN
U603
NC/TPA6211A1DGN
SHUTDOWN1
BYPASS2
IN+3
IN-4
Vo+5VDD6GND7Vo-8GND9
C6151U 25VC6151U 25V
R62010K1/16W
R62010K1/16W
R654NC/6.8K1/16W
R654NC/6.8K1/16W
FB613 120R/3000mAFB613 120R/3000mA
1 2
R627100 OHM 1/10WR627100 OHM 1/10W
R6370R05OHM1/16W
R6370R05OHM1/16W
C630220NF 25V
C630220NF 25V
C631330N 25VC631330N 25V
C6012.2UF10VC601
2.2UF10V
L604 47uHL604 47uH
C6101UF16VC6101UF16V
D603BAS316
D603BAS316
A1
K2
C6082.2UF10V
C6082.2UF10V
C651NC/1uF 25V
C651NC/1uF 25V
C649NC/0.47uF 16V
C649NC/0.47uF 16V
R6330R05OHM1/16W
R6330R05OHM1/16W
FB610 NC/120R/6AFB610 NC/120R/6A
1 2C6231UF16VC6231UF16V
FB614 120R/3000mAFB614 120R/3000mA
1 2
C626330N 25VC626330N 25V
R648100OHM1/16W
R648100OHM1/16W
R6550R05OHM1/16W
R6550R05OHM1/16W
TP
60
4T
P6
04
1
R6490R05OHM1/16W
R6490R05OHM1/16W
R635NC/100K1/16W
R635NC/100K1/16W
R6070R05OHM1/16W
R6070R05OHM1/16W
FB601120R/3000mA
FB601120R/3000mA
1 2
R666100OHM1/16W
R666100OHM1/16W
C627220NF 25V
C627220NF 25V
+C634220UF/35V
+C634220UF/35V
C650NC/1uF 25V
C650NC/1uF 25VR612
10K1/16WR612
10K1/16W
FB615 120R/3000mAFB615 120R/3000mA
1 2
R636100OHM1/16W
R636100OHM1/16W
R629NC/100K1/16WR629NC/100K1/16W
C625330N 25VC625330N 25V
R6450R05OHM1/16W
R6450R05OHM1/16W
C6411N 50VC6411N 50V
R628NC/47K1/16WR628NC/47K1/16W
D609BAS316D609BAS316
A1
K2
C613100N 50VC613100N 50V
C6241UF16VC6241UF16V
U601
TPA3113D2
U601
TPA3113D2
SDZ1
FAULTZ2
LINP3
LINN4
GAIN05
GAIN16
AVCC7
AGND8
GVDD9
PLIMIT10
RINN11
RINP12
NC13
PBTL14
PVCCL28
PVCCL27
BSPL26
OUTPL25
PGND24
OUTNL23
BSNL22
BSNR21
OUTNR20
PGND19
OUTPR18
BSPR17
PVCC16
PVCC15
Thermal Pad29
C6141N 50VC6141N 50V
R6170R05OHM1/16W
R6170R05OHM1/16W
C6361N 50VC6361N 50V
TP
60
2T
P6
02
1
R6189R1 1/10W 1%
R6189R1 1/10W 1%
FB608 NC/120R/6AFB608 NC/120R/6A
1 2+ C604
330UF 35V+ C604
330UF 35V
C628220NF 25VC628220NF 25V R640
10R 1/16W 5%R640
10R 1/16W 5%
R606NC/100K1/16WR606NC/100K1/16W
C6381N 50VC6381N 50V
R6081K1/16W
R6081K1/16W
C6050.47uF 16V
C6050.47uF 16V
R656NC/0R05OHM1/16W
R656NC/0R05OHM1/16W
C629220NF 25V
C629220NF 25V
TP605TP605
1
FB605220R/2000mA
FB605220R/2000mA
1 2
R610NC/10K1/16W
R610NC/10K1/16W
CN602PHONEJACK
CN602PHONEJACK
1762345
R6014.7K1/16W
R6014.7K1/16W
R63010 OHM 1/4W
R63010 OHM 1/4W
R63910R 1/16W 5%
R63910R 1/16W 5%
R6220R05OHM1/16W
R6220R05OHM1/16W
C602100N 50V
C602100N 50V
C64610uF 16V
C64610uF 16V
R6460R05OHM1/16W
R6460R05OHM1/16W
Q602BC857BWQ602BC857BW1
23
C6321N 50VC6321N 50V
C6120.47uF 16V
C6120.47uF 16V
R65147K OHM +-1% 1/16W
R65147K OHM +-1% 1/16W
C64510N 50V
C64510N 50V
C639NC/1N 50VC639NC/1N 50V
R6154.7K1/16WR6154.7K1/16W
R64210R 1/16W 5%
R64210R 1/16W 5%
C64710uF 16V
C64710uF 16V
R616NC/0R05OHM1/16W
R616NC/0R05OHM1/16W
R60547 OHM 1/16W
R60547 OHM 1/16W
L603 47uHL603 47uH
C64210N 50VC64210N 50V
FB606220R/2000mA
FB606220R/2000mA
1 2
R6110R05OHM1/16W
R6110R05OHM1/16W
C6070.47uF 16V
C6070.47uF 16V
C603100N 50V
C603100N 50V
D608NC/BAS316D608NC/BAS316
A1
K2
R659NC/0R05OHM1/16W
R659NC/0R05OHM1/16W
Q601BC847BW
Q601BC847BW
R624NC/47K1/16W
R624NC/47K1/16W
R657NC/0R05OHM1/16W
R657NC/0R05OHM1/16W
R6144.7K1/16W
R6144.7K1/16W
FB609 NC/120R/6AFB609 NC/120R/6A1 2
R6
26
NC
/10
0 O
HM
1/1
0W
R6
26
NC
/10
0 O
HM
1/1
0W
R64110R 1/16W 5%
R64110R 1/16W 5%
C6211UF16V
C6211UF16V
R63810K1/16W
R63810K1/16W
FB602 120R/3000mAFB602 120R/3000mA
1 2
C6161UF16VC6161UF16V
FB617NC/120R/3000mA
FB617NC/120R/3000mA
1 2
C620330N 25VC620330N 25V
D606BAS316D606BAS316
A1
K2
L602 47uHL602 47uH
R623NC/0R05OHM1/16W
R623NC/0R05OHM1/16W
C611NC/10N 50V
C611NC/10N 50V
R603100OHM1/16W
R603100OHM1/16W
R671NC/10K1/16W
R671NC/10K1/16W
C6221UF16V
C6221UF16V
C637NC/1N 50VC637NC/1N 50V
C6481UF16V
C6481UF16V
C601 E3C602 E10C603 E10C604 B2C605 F2C606 G2C607 F2C608 F4C609 F4C610 G3C611 E10C612 F2C613 A7C614 A7C615 C5C616 C5C617 G8C618 E7C619 E7C620 B9C621 B5C622 B5C623 D5C624 D5C625 C9C626 C9C627 B7C628 C7C629 C7C630 D7C631 D9C632 B7C633 A7C634 E7C635 B9C636 C7C637 B9C638 C7C639 C9C640 D9C641 D7C642 B4C643 D4C644 F1C645 G1C646 G1C647 F1C648 C5C649 G8C650 G7C651 G7C652 G7CN601 C11CN602 E11D603 B2D604 B2D606 B1D607 C1D608 D2D609 D2FB601 E3FB602 D10FB603 D10FB604 D10FB605 C4FB606 C4FB607 B8FB608 B8FB609 C9FB610 D9FB611 D10FB612 D11FB613 D11FB614 D11
FB615 D11FB617 G9L601 B8L602 C8L603 C9L604 D9Q601 A2Q602 B1Q605 F4R601 B1R603 D4R605 B2R606 C1R607 C2R608 F5R609 E4R610 G4R611 H4R612 G4R614 E10R615 E4R616 G4R617 F2R618 H4R620 A1R621 A1R622 A2R623 A2R624 F2R625 E9R626 B1R627 B1R628 G2R629 B5R630 C5R631 F5R633 B5R634 C5R635 B5R636 B4R637 G2R638 A5R639 B7R640 C7R641 C7R642 D7R643 B4R644 D4R645 F1R646 F1R647 F1R648 G1R649 B2R650 A5R651 C5R652 C5R653 G8R654 G8R655 E11R656 F9R657 E10R658 G9R659 G9R666 A2R671 G7TP601 C10TP602 C10TP603 C10TP604 C10TP605 B5U601 A6U602 F3
EN 52TPM5.2E LA 10.Circuit Diagrams and PWB Layouts
2010-Jun-25
SSB: LVDS output
18840_518_100408.eps100428
LVDS OUTPUTB13 B13
2010-04-021
LVDS OUTPUT 715G3735
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
A A
B B
C C
D D
E E
F F
G G
H H
SMD/0402
SMD/0402
SMD/0402
NEAR IC
NEAR IC
NEAR IC
BL_DIM(PWM for Bright_Adj):Max: 0VMin: +3V3
INVERTER ON/OFF
BRIGHT ADJUST
BackLight_SW:BackLight on: LowBackLight off: High
BL CONTROL
DC CONTROL
PWM CONTROL 100R
5K6
1K
1K
N/C
10U
R408 R406 C405
N/C
N/C2K
R411
1K
INVERTERON/OFF
R410
3V3
5V
Dual signal
Single Signal
AVDD3V3_LVDS
AVDD1V25_LVDS
AVDD1V25_VPLL
AVDD1V25_VPLLAVDD1V25_LVDS
AVDD3V3_LVDS
O1NO1P
OCKPOCKN
E2PE2N
O2NO2P
ECKNECKP
E0P
O0N
O3NO3P
E0N
E1N
E3NE3P
O0P
E1P
INVERTER_ON_OFF
BL_DIMMING
BRIGHT_ADJ
BL_ON/OFF
O2P
O2N
E0P
ECKP#OCKN
OCKP
ECKP
ECKNO2PO2N
OCKN#OCKP#
O0N
O1N
O3NO3P
O0P
+PANEL_VCC
O1PO1P
E0N
E1P
O2P
E2N
O3P
E1N
O2N
ECKP#
O3N OCKP#
O0P O0N
OCKN#ECKN#
E0P
E1P
O1N
O3N
E3P
O0P
OCKN#
O1N
OCKP#
E3N
ECKN#
E2N
E2P
E2P
E1N
E3P
E0NO0N
O1P
O3P
E3N
AV33
AV12
AV12DV33+5V_SW
+5V_SW
DV33
DV33DV33
PANEL_VCC
AV33
DV33SB
TP403TP4031
TP408TP4081
CN409
CONN
CN409
CONN
123456789
101112131415161718192021222324252627282930
TP417TP4171
R4111K1/10W
R4111K1/10W
R4180R05 1/10W
R4180R05 1/10W
C403100N 50V
C403100N 50V
R404NC/4.7K 1/10W
R404NC/4.7K 1/10W
TP420TP4201
TP416TP4161
R4160R05 1/10W
R4160R05 1/10W
LVDS Output
MT5363
U401G
LVDS Output
MT5363
U401G
AE0NE16
AVSS33_LVDSJ18
AO0PD15AO0NB15
AE0PG16
AE1NF17
AVDD12_LVDSN16
AO1PC16AO1NA16
AE1PH17
AVDD33_LVDSF15
AVSS12_LVDSP17
AO2PD17AO2NB17
AE2PG18AE2NE18
AVDD33_LVDSH15
AVDD12_VPLLN18
AOCKPC18AOCKNA18
AECKPH19AECKNF19
AVSS12_VPLLP19
AO3PD19AO3NB19
AE3PG20AE3NE20
AO4PC20AO4NA20
AE4PH21AE4NF21
TP_VPLLM19
R4094.7K 1/10W
R4094.7K 1/10W
R4170R05 1/10W
R4170R05 1/10W
C401NC/47uF 6.3VC401NC/47uF 6.3V
R4061K1/10WR4061K1/10W
TP419TP4191
FB403NC/120R/3000mA
FB403NC/120R/3000mA
12
CN408Wafer 2*15P 2.0picth
NC/CONN
CN408Wafer 2*15P 2.0picth
NC/CONN
2468
1012141618202224262830
1357911131517192123252729
R4074.7K 1/10W
R4074.7K 1/10W
R4200R05OHM1/16W
R4200R05OHM1/16WTP407TP4071
TP418TP4181
TP421TP421
1
TP413TP4131
TP406TP4061
R410NC/2KOHM 1/10W
R410NC/2KOHM 1/10W
Q401MMBT3904Q401MMBT3904
3
1
2
C404100N 16VC404100N 16V
R412NC/10K1/16W
R412NC/10K1/16W
FB406120R/3000mA
FB406120R/3000mA
12
TP412TP4121
TP411TP411
1
TP405TP4051
R419NC/0R05OHM1/16W
R419NC/0R05OHM1/16W
C406100N 16VC406100N 16V
L401
90R/400mA
L401
90R/400mA
1
2
4
3
Q402MMBT3904Q402MMBT3904
3
1
2
C402100N 16VC402100N 16V
C405NC/10U 16VC405NC/10U 16V
+ C407330UF 16V
+ C407330UF 16V
TP404TP4041
TP401TP4011
R408100 OHM 1/10W
R408100 OHM 1/10W
TP415TP4151
TP410TP4101
R405NC/4.7K 1/10W
R405NC/4.7K 1/10W
R4134.7K 1/10W
R4134.7K 1/10W
TP409TP4091
L402
NC/90R/400mA
L402
NC/90R/400mA
1
2
4
3
TP414TP4141
TP402TP4021
FB402120R/3000mA
FB402120R/3000mA
12
C401 F3C402 E7C403 D6C404 F7C405 E3C406 F7C407 D6CN408 B6CN409 B8FB402 C5FB403 D5FB406 C5L401 C1L402 C3Q401 F2Q402 E2R404 E2R405 E2R406 E2R407 F2R408 E3R409 E2R410 F3R411 F3R412 F2R413 F2R416 E6R417 E6R418 F6R419 B7R420 B7TP401 E8TP402 A2TP403 B2TP404 B2TP405 B2TP406 B2TP407 B2TP408 B2TP409 B2TP410 C2TP411 C2TP412 A3TP413 B3TP414 B3TP415 B3TP416 B3TP417 B3TP418 B3TP419 B3TP420 C3TP421 C3
Circuit Diagrams and PWB Layouts EN 53TPM5.2E LA 10.
2010-Jun-25
Layout Small Signal Board (Overview Top Side)
18840_519_100408.eps100428
TP4050
C609
C62
1
C616
C648
C628
C62
2
C11
66
C11
69
C11
82C
1184
C1080
C1187
C11
89
C1192
C41
50
C4151
C4155
C41
57
C4158
C41
59C
4160
C602
C60
3
C61
2
C623
C627
C61
8
C61
1
C754
C605
C718
C61
3
C606
C60
7
C608 C610
C624
C629 C630
C70
5
C70
6
C4163
C4164C4165 C761
C763
C403
C735
C72
4
C70
7
C601
C709
C10
90
C10
66
C10
05C
1006
C10
63
C1087
C1095
C1099
C1100
C767
C62
5
C1001
C10
59C
1060
C1164C1167
C11
81
C1183
C4064
C40
65
C75
7
C765
C10
88
C10
71
C647
C646
C62
0
C62
6
C63
1
C72
2
C1067
C1077
C40
1
C4201
C719
C4202
C405C701
C755
C41
02C
4103
C752
C764
C10
00
C732
R407
R721
R71
7
FB
1052
FB1053
FB1054
FB
1158
FB
1159
FB
1160
FB
1161
FB
1162
FB
1163
FB
501
L105
0
FB1169
FB
1170
R1011
R1012
R10
88
R11
57
R1189R11
94
R404
R40
5
R40
6
R40
8
R40
9
R41
0
R41
1
R413
R4156
R41
57
R41
59
R4161
R4162
R4163
R41
72R
4175
R41
79
R618
R62
6
R62
7
R701
R702
R70
8R711
R75
5
R756
R75
7
R75
8
R10
40
R40
55
R42
33
R72
4
R10
26
R10
27
R10
28
R41
60
R42
35
R41
95
R41
97
R60
9
R72
0
R728
R73
0
R73
1
R733
R71
9
R10
83
R1090
R1048
R1049
TH4050
R751
R70
3
R72
9
R75
2
R767
D604
D11
59
D11
60
D50
2
D50
6D
507
D60
3
D60
6
D60
7
C72
5
R738
R10
55
R10
91R
1077
R10
89
C753
R75
9R
760
R76
1
C1174
C11
80
C11
61
C11
77
C11
95
C71
1
R8
R7
R11
R9
R1
R2
TP4
TP5
TP6
TP8TP9
TP10
TP11
TP12
TP13
TP14
TP16TP42
TP43
TP44
TP45
TP46
TP47
TP48
TP49
TP
50
TP
51T
P52
TP53
TP
54T
P55
TP58
TP
59
TP
60
TP61 TP62
TP
63
TP64 TP65
TP
66
TP67 TP68 TP69 TP70
TP71
TP72
TP
73
TP
74
TP
75
TP
76
TP
77
TP
78
TP
79
TP
80
TP
81
TP
82
TP18
TP19
R3
TP
20T
P21
TP
23T
P24
TP
26T
P27
TP
28TP
29
TP
30
TP
31T
P32
TP
33
TP37
TP38 TP39
TP
25T
P40
TP1
TP2
TP86
TP87
TP
88
TP89
TP90
TP35
TP36
H1
H7
H2
TP
34T
P22
TP4150
TP4151 TP4152
TP1000
C1
Q1
Q601Q602
CN410
CN601
CN4051
CN701
CN
401
CN409CN408
CN136
CN602
CN4053
CN
102
CN501
CN159D
701
TU101TU102
L401
RP
4111
RP
4109
RP
4106
RP
4104
RP
4100
RP
4102
RP
4103
RP
4105
RP
4107
RP
1000
RP
1001
RP
1003
CN
4052
CN406
ZD1163
ZD
1169
ZD1050
ZD1069
ZD
1156
ZD
1157
ZD
1165
ZD
1166
ZD
1170
ZD1063
ZD1066
ZD1067
ZD
1150
ZD
1151
ZD
1153
ZD
1154
ZD
1155
ZD1160
ZD
1161
ZD
1162
ZD
1164
ZD1068
ZD
1152
ZD4150
ZD
4151
ZD
501
ZD
502
ZD
503
C731
C76
2
C42
00
C40
63
C71
2
C71
3
C70
2
C40
7
C72
1
C63
3
C63
4
C60
4
U1
U2
CN
502
FB703
FB
1000
FB
1001
FB
1002
FB
1005
FB1007
FB
4152
FB601
FB
602
FB604
FB701
FB702
L1000
L1001
L1002
L1003
L100
5
L4150
FB611
FB402
FB403
FB
1011
FB
1012
FB
1022
FB1167
FB
1168
FB406 FB
1008
FB1009
FB1014
FB1016
FB
1017
L100
8
L100
9
FB
608
FB705
FB
706
FB1006
FB4200
FB4060
FB
607
FB
609
FB
610L602 L601 L603 L604
U602
U10
1
R616
R714
R4109
R4110
R4106
R4111
R4112
R4107
R40
51
R40
52
R608
R610
R10
01R
1000
R10
02R
1003
R1005
R10
07
R1010
R1024
R1029
R1030
R11
35
R11
37
R1138
R10
60R
1062
R10
63
R10
64
R10
65R
1067
R1071
R1073
R10
78R
1079
R10
80
R10
99
R11
00
R11
88
R10
19
R1150
R1151
R11
52
R11
53
R11
54
R1155
R11
56
R11
58
R11
59
R11
60
R11
61R
1162
R11
63
R11
64
R11
65
R1166
R11
67
R11
68
R11
69
R11
70R
1171
R11
72
R11
73
R1174
R11
75
R1176
R11
77
R11
78
R1179
R11
80
R11
81
R1182
R1183
R11
84
R1185
R11
86
R11
87
R10
36
R10
38
R1197
R1198
R1199
R12
00
R1201
R4000R4001
R4003R4004
R40
05
R40
53R
4054
R4158
R41
71R
4173
R41
76
R4182
R41
85
R41
86
R41
87
R41
88
R4189R4190 R4191 R4192
R4200
R4201
R4202
R4204
R4206
R4207
R4208
R4209
R4210
R4211
R4212
R4213
R4214
R4215
R4216
R4217
R4218
R4219
R4220
R4221
R4232
R50
2
R503
R50
4
R51
4
R518
R51
9
R52
0
R52
1
R52
2
R52
4
R525
R526R527
R52
8
R543
R63
8R
622
R60
5
R652
R62
8
R62
9
R644R648
R63
5R603
R645
R70
5
R707
R62
4
R71
8
R10
41
R10
42
R611
R612
R615
R61
7
R63
3
R63
4
R63
7
R63
9
R64
0
R64
1
R64
2
R646
R647
R60
1
R606
R607
R61
4
R62
5
R4181 R4183 R4193
R41
96
R41
98R
649
R65
1
R531
R710
R71
2
R71
3
R72
5
R10
86
R62
3
R63
1
R1094
R10
25
R736
R735
R1017
R1018
R1033
R1034
R10
35
R10
37R
1039
R1043
R10
44
R10
45
R10
46
R10
47
R1093
R666 R42
0R41
9
R4301
R4302
R65
5
R65
6
R65
7
R1004
Q1051
U10
00
U103
U51
1
U50
5U
506
U50
7
U512U513
U4052
U70
1
U105
U411
Q70
6
Q11
50
Q50
4
Q505
Q701
Q70
2
Q705
Q605
Q11
55
Q1156
U10
8
U75
1
Q40
1
Q402
Q1001
U70
2
U750
U75
2
U753
U50
4
U110
U409
U10
6
U601
X4150
Q704
Q750
CN111
CN116
Q70
3
F701
R1195
R41
2
R715 R722CN4071
R4234
U401
U402
U403
C1081R
737
L701
CN
103
C70
3
C1089
C71
4
D4050
D4051
D4150
D41
51
D4152
R10
68
R11
39
R4237
CN151
U754
X10
00
R10
76
Q707
R62
1
R76
2
CN4072
R65
0
CN104
C63
7
C10
03
C10
09C
1012
C1013
C10
16C
1017
C10
20C
1021
C10
22
C1025
C10
26
C10
27
C10
28
C1029
C1030
C1031
C10
53
C10
54
C10
55
C1056
C1057
C10
58
C1065
C10
68
C1045
C10
98
C11
53
C11
54
C11
55
C11
56C
1157
C1158
C11
59
C1160
C11
62
C11
63
C1170C1171 C1172
C11
73
C11
75
C11
76
C11
78
C11
79
C1191
C42
05
C507
C509
C51
1
C715
C71
6
C710
C10
69C
1070
C10
82C
1083
C1084
C40
66
C4152
C41
53
C4154
C4156
C61
9
C63
2
C63
9
C64
1C644
C708
C720
C63
5
C64
0
C645
C63
6
C4207
C61
4
C63
8
C71
7C
704
C643
C10
04
C10
42
C10
10
C10
11
C10
07
C10
08C
1041
C10
43
C10
44
C1046
C10
96
C10
97
C1018
C1019
C11
01
C11
02
C1105
C1106
C72
3
C72
7
C10
23
C1024
C75
8
FB1024R1050
R716
EN 54TPM5.2E LA 10.Circuit Diagrams and PWB Layouts
2010-Jun-25
Layout Small Signal Board (Overview Bottom Side)
18840_520_100408.eps100428
C10
40
C1152
C4111
C4116
C75
9
C51
0
C617
C64
9
C65
2
C65
0
C65
1
C41
10
C615
R4100
R4101
R4102 R4103
R41
04
FB
502
R1129
R1133
R10
85
R40
50
R4105
R41
52
R4153 R4154
R765
R75
0
R4236
R4056
R4057
R4058
R40
59
R40
60
R40
61
R4062
R40
63R
4155
R41
6
R41
7
R41
8
R42
29
R51
3
R52
3R52
9
R532
FB1023
R75
3
R630
D50
4D
503
D608
C726
C1196
D60
9
C4167
C4168
TP3
TP41
TP83
TP84
TP85
TP601 TP602 TP603 TP604
TP701TP702TP703TP704TP705TP706TP707
TP402
TP403
TP404
TP405
TP406
TP407
TP408
TP409TP419
TP418
TP417
TP416 TP415
TP414 TP413
TP412
TP605
TP401
TP4100
TP4101
TP411
TP410TP421
TP420
TP4154
L402
RP
4101
RP
4108
RP
4110
ZD
1059
ZD
1060
ZD1051
ZD1052
ZD1065
FB4000
FB4057
FB4058
FB4100
FB603
FB1019
FB612
FB613
FB614
FB
615
FB
1003
FB1004
FB
1015
FB617
FB
605
FB
606
U60
3
R41
08R643
R1006
R1008
R10
61
R10
72
R10
84
R10
87
R4002
R41
65
R41
66
R41
67
R41
68
R41
70
R41
80
R4184
R41
94
R42
03R
4205
R42
22
R4223
R4224
R4225
R4226
R4227
R4228
R4231
R507
R50
8
R50
9
R510
R511
R51
2
R515
R51
6
R517
R540
R54
1
R542
R50
5
R50
6
R11
31
R11
34
R636
R41
64
R41
69
R41
74
R41
77
R530
R620
R4006
R41
99
R10
81
R10
16R
1021
R653
R654
R67
1
Q10
50
Q751
Q508
Q50
2Q
501
Q50
3
U41
0
U40
51
U502
R70
4
FB707
R1196
R12
02
R4230
R56
2
R1203
R658
R65
9
R1059
R1096
C41
30
C4122
C4125
C41
23
C41
24
C4126
C4121
C4120
C4106
C4107
C4108
C4104
C4118
C4119
C4105
C4114
C4112
C41
15
C4113
C41
09
C4127
C41
28
C4129
C4117
C4101
C41
00
C1014
C1015
C10
38
C4000C4001
C4002
C4003
C4004
C4005
C4006
C40
07C
4008
C4009
C4010
C4011
C4012
C40
13
C4014
C40
15
C40
2C
404
C4050
C40
51C
4052
C4053
C4054
C4055
C40
56C
4057
C4058
C40
59
C40
6
C40
60
C40
61
C41
66
C42
03C
4204
C4206
C50
3C
504
C50
5
C506
C50
8
C10
64C
1078
C10
79
C10
37
C642
C4169
C10
33
C10
34
C10
35C
1036
C1039
C1049
C40
62
C4067
C40
68
C40
69
Circuit Diagrams and PWB Layouts EN 55TPM5.2E LA 10.
2010-Jun-25
IR/LED Board
18840_521_100408.eps100428
IR/LED BoardJ J
2010-04-02A
IR/LED BOARD 715G3975
1
1
2
2
3
3
4
4
5
5
A A
B B
C C
D D
Red
Key1
LED_R
RC6
Key2
DV33SB
DV33SB
DV33SB
DV33SB
ZD202VPORT0603100KV05
ZD202VPORT0603100KV05
12
U201IRM-3636F45
U201IRM-3636F45
VS3
OUT1
GND2
LED302LED
LED302LED
12
TP1TP1
1
Q301BC847CQ301BC847C
R3041K 1/10W
R3041K 1/10W
R203100 OHM 1/10W
R203100 OHM 1/10W
TP3TP3
1TP4TP41
TP6TP6
1
R2012K7 1/10W 5%
R2012K7 1/10W 5%
CN301S1315-07RVB-S01-K
CN301S1315-07RVB-S01-K
1234
98
567
CN001CN001
123
45
R3016.2K 1/10W
R3016.2K 1/10W
TP5TP5
1
C20122U 10V
C20122U 10V
C201 C4CN001 C1CN301 B1LED302 A4Q301 B4R201 B3R203 B4R301 A4R304 B3TP1 A2TP3 B3TP4 B2TP5 C2TP6 C2U201 C4ZD202 C4
EN 56TPM5.2E LA 10.Circuit Diagrams and PWB Layouts
2010-Jun-25
Layout IR/LED Board
18840_522_100408.eps100428
C201R201
R203
R301R304
TP1
TP3
TP4
TP5
TP6
H13
FD6
Q30
1
CN301H11
H12
CN001ZD202
SPG1
LED
302
U20
1
Top
Bottom
Styling Sheets EN 57TPM5.2E LA 11.
2010-Jun-25
11. Styling Sheets
Styling Sheet 19"
18840_800_100415.eps100415
PICO 19"
Pos No. Description Remarks30 FRONT CABINET40 REAR COVER50 STAND ASSY91 STAND NECK1176 REMOTE CONTROL
FOR ELECTRICAL PARTS/ASSEMBLIES SEE WIRING DIAGRAM CHAPTER 9
30
40
50
91
EN 58TPM5.2E LA 11.Styling Sheets
2010-Jun-25
Styling Sheet 22"
18840_801_100415.eps 100426
PICO 22"
Pos No. Description Remarks 30 FRONT CABINET 40 REAR COVER 50 STAND ASSY 91 STAND NECK 1176 REMOTE CONTROL FOR ELECTRICAL PARTS/ASSEMBLIES SEE WIRING DIAGRAM CHAPTER 9
30
50
40
91
Styling Sheets EN 59TPM5.2E LA 11.
2010-Jun-25
Styling Sheet 26"
18840_802_100415.eps 100415
PICO 26"
Pos No. Description Remarks 30 FRONT CABINET 40 REAR COVER 50 STAND ASSY 68 STAND NECK 1176 REMOTE CONTROL FOR ELECTRICAL PARTS/ASSEMBLIES SEE WIRING DIAGRAM CHAPTER 9
30
50
40
90