Upload
others
View
4
Download
0
Embed Size (px)
Citation preview
HWG
Humboldt Working Group (HWG) Groundrules
2
• Participate in an active and focused manner – commit to process success.
• Interact with all other members respectfully.• Communicate interests, not positions. • Be brief in communications, and be prepared. • Help involve all.• Seek solutions for all.• Commit to a good faith effort.• Share relevant information.• Communicate effectively—open, frank communications with the
larger community, “not-for-attribution” to individuals in the group. • Attend all meetings; start on time.• Keep cell phones on silent.
HWG
Facilitator Responsibilities
3
• Maintain a neutral position as project issues are discussed.
• Help the group accomplish its objectives.
• Help guide the discussion.
• Enforce participant ground rules.
• Help involve all.
• Ask “why” to clarify interests.
• Ensure a smooth process.
• Retain confidential information as confidential to individual participants.
• Manage time.
• Track actions, next steps, deadlines.
HWG
Agenda
4
• I. Light Supper/Snacks..…………….……….…5:30 p.m. – 6:00 p.m.
• II. Review Agenda, Groundrules.…………....6:00 p.m. – 6:10 p.m.
• III. Updates………………………………………..….6:10 p.m. – 6:15 p.m.
• IV. Patterns of Use: Whales, Green Sturgeon and Juvenile Salmon……………………..…………………………….6:15 p.m. – 7:00 p.m.
• V. Break…………..……….………………………….7:00 p.m. – 7:15 p.m.
• VI. Lessons Learned from Other Wave Energy Experiences……….. …………..……….……………………………..……….…7:15 p.m. – 8:00 p.m.
• VII. Wave Energy 101 – Part Two.……………..8:00 p.m. – 8:15 p.m.
• VIII. Next Steps, Adjourn…..………………....….……….………8:15 p.m.
HWG
Regulatory context for T&E species, marine mammals
• Discuss species likely to be exposed to the project
• Threatened and endangered fish species protected by Federal and State Endangered Species Act (ESA)
• Marine mammals protected by Marine Mammal Protection Act, some species also protected by ESA
• Consultation with NOAA and/or USFWS required if HWCP project may affect marine mammals, ESA-listed species, or critical habitat
HWG
Pacific salmon and steelhead potentially in the HWCP area
7
Coho salmon (Oncorhynchus k isutch)– Southern Oregon/Northern California Coasts ESU (FT, ST)– Central California Coast ESU (FE, SE)
Chinook salmon (Oncorhynchus tshawytscha)– Upper Klamath and Trinity Rivers ESU (not warranted)– Southern Oregon/Northern California Coastal ESU (not warranted)– California Coast ESU (FT)– Sacramento River winter-run ESU (FE, SE)– Central Valley spring-run ESU (FT, ST)
Steelhead (Oncorhynchus mykiss)– Northern CA DPS (FT)– Central Valley DPS (FT)– Central California Coast DPS (FT)
HWG
Ocean Distribution
• Coho salmon– 3 year life cycle– 1+ years at sea
• Chinook salmon– 2 to 3+ years at
sea
• Steelhead– Up to 3 years at
sea
9
(Beamish et al. 2005)
HWG
At-sea summer distribution: juvenile Chinook and coho salmon stocks
10(Brodeur et al. 2004)
HWCP site
Chinook salmon Coho salmon
HWG
Coastal upwelling
• Water quality– Cold– Salty– Nutrients– Oxygen
• Productivity
http://www.piscoweb.org/research/science-by-discipline/coastal-oceanography/upwelling-regions
HWG
Green sturgeon (Acipenser medirostris)
14
• Southern DPS federally threatened; spawns only in Sacramento River
• Critical habitat for Southern DPS includes marine waters in HWCP area out to 60 fathoms depth (360 feet)
• Northern DPS “species of special concern”, spawns in Eel River and north
• Green sturgeon tagged with VEMCO acoustic tags detected in Humboldt Bay
HWG
Marine migration of green sturgeon
15(Lindley et al. 2007)
HWCP site
(Erickson and Hightower 2007)
HWG
Humboldt Offshore Habitat Diversity
16
Pinniped Species (6)• Seals: 2 • Sea Lions: 2 • Fur Seals: 2
Cetacean Species (13-31)• Baleen Whales: 5
(+ 3 very unlikely)• Toothed Whales: 8
(+ 15 very unlikely)
HWG
Marine Mammals of Humboldt County
17
“In the Humboldt Wave Connect Project Area”
• Marine mammals are very acoustic• Sound travels very well underwater• HWCP an uncharacterized noise source• Close by – physical contact, loudest• Further away – acoustic only
Need to determine noise sourcelevels and propagation.
HWG
Pinnipeds of Humboldt County
18
Common and coastal, haul out on rocks and/or beaches:
• Harbor seal – breeds here, present all year• California sea lion – breeds S. Calif., seasonal migrant• Steller’s sea lion – eastern stock, breeds at Cape Mendocino, seasonal (FT)
HWG
Pinnipeds of Humboldt County
20
Uncommon and/or mostly pelagic:
• Elephant seal – breeds S. Calif., Mexico- juveniles rest on local beaches in fall-winter
• Northern fur seal – breeds S. Calif., Bering Sea• Guadalupe fur seal – breeds S. Calif., Mexico
(FT, ST)
HWG
Baleen Whales of Humboldt County
21
Common and coastal:
• Gray whale – migrate past twice a year, some residents• Humpback whale (FE) – migrate, here spring to fall• Blue whale (FE) – migrate, here summer to fall
HWG
Gray Whale Migration Past Humboldt
23
Southbound Northbound
N=858 sightings, 1975-1981Sullivan and Houck 1983
HWG
Pacific Northwest Feeding Aggregation
24
Humboldt County is first place on northbound migration where there are sufficient food resources for residency.
In 1998 fifteen individual gray whales were photo-identified between Eureka and Crescent City.
About 200 gray whales remain throughout the summer from Northern California to Northern Vancouver.
Calambokidis et al. 2000
HWG
Toothed Whales of Humboldt County
29
Common and coastal:
• Harbor porpoise – continuous all year• Transient killer whale – sporadic all year
Photo by Kerry Ross, 2004
HWG
Uncommon Whales off Humboldt County
30
Uncommon and/or more pelagic:
• Minke whale• Fin whale (FE) • Sperm whale (FE)• Pacific white-sided dolphin• Risso’s dolphin• Northern right whale dolphin• Southern resident killer whale (FE)• Offshore killer whale
HWG
WEC Development Lessons Learned
33
PG&E directed a survey of WEC experiences to inform the WaveConnect WEC Selection Criteria.
There have been successful at-sea tests of WECs.
There have also been some at-sea tests that had problems.
Both provide experiences -- and valuable lessons learned --that result in improved designs.
HWG
WEC Development Lessons Learned
34
This presentation covers four WEC development events with companies/machines below:
– Osprey– Wave Dragon– Finavera– Trident Energy
The companies above did not respond to the PG&E Request for Information (RFI) and are not being considered for WaveConnect.
HWG
Why Study Lessons Learned?
35
In 1980, Willard Bascom published “Wave & Beaches,” that included lessons from Humboldt Bay Jetties starting in 1878. “The ocean is huge, powerful, and eternal. Puny humans can scarcely expect to win by overwhelming it, and anyone who counters its attack with brute-force solutions is doomed to expensive disappointment. Rather, the engineer must take advantage of the geographic and oceanographic conditions so that everything possible is in his favor. Then, on a battlefield of his choosing for the short span of human interest, he may be able to hold his own. The first and most valuable lesson on can learn about the sea is to respect it.”
HWG
Why Study Lessons Learned?
36
Willard Bascom (paraphrased)
The ocean is huge, powerful, and eternal.
Take advantage of the geographic and oceanographic conditions so that everything possible is in your favor.
Choose your projects carefully.
The first and most valuable lesson one can learn about the sea is to respect it.”
HWG
OSPREY Installation
37
The OSPREY was constructed in Glasgow and floated out from the John Brown shipyard in August, 1996. The full scale prototype followed theoretical studies and model testing.
HWG
OSPREY Installation
38
The WEC prototype derived its stability from filling the steel shell device with sand. The device was submerged.
Unfortunately the sand filling was not complete when the unit was exposed to wave action above the design value for that condition. The steel shell broke up.
This example highlights the importance of a full development cycle and operational procedures.
Submerging a device is a complex evolution. Stability in all phases and transitions is critical.
HWG
Wave Dragon Mooring
39
Wave Dragon is a floating, slack-moored energy converter of the overtopping type that can be deployed as a single unit or in arrays of multiple units.
HWG
Wave Dragon Mooring
40
A severe storm hit Northern Europe in January 2004. The Wave Dragon was deployed in an area where Denmark experienced the storm’s highest wind speeds. The Wave Dragon structure withstood the storm.
HWG
Wave Dragon Mooring
41
During the storm, the main mooring connection broke.The platform stranded on the beach. The unit and its mooring were inspected and secured to prevent them from drifting. The unit was undamaged.
HWG
Wave Dragon Mooring
42
The cause was a broken load cell instrument that had connected the main mooring lines to the anchor block.The load cell failed below that of the guaranteed breaking load. Investigation found a crack and indications that chloride induced stress corrosion cracking could be involved.
This example highlights the importance of design maturity and proven operational performance.
Load cells can be installed with a safety line (preventer). Material selection matters.
HWG
Finavera Test Device
43
Finavera Renewables installed a test device at sea in September 2007 near Newport, Oregon for component evaluation during development of AquaBuOY 2.0.
HWG
Finavera Test Device
44
After scheduled operations, and the successful acquisition of performance data, the device sank on 27 October 2007, just before its removal.
Finavera recovered the test device in 2008 and subsequently withdrew from the development of ocean energy projects.
The company has not released any report on the results of their failure analysis or the engineering forensics from the device recovery.
HWG
Finavera Test Device
45
Finavera attributed the failure to issues with the bilge pump and the floatation chamber.
This example illustrates the importance of design maturity, device monitoring, and contingency plans.
Failure modes and effects criticality analysis (FMECA) can be used to identify potential risks and mitigate them in design, installation and operations.
HWG
Trident Capsize During Transit
46
On September 20, 2009, the press reported that Trident’s experimental wave generator capsized while under tow and in route to its UK installation site for a yearlong offshore trial.
HWG
Trident Capsize During Transit
47
The platform grounded and was secured, inspected, recovered, and returned to harbor on a crane barge.
Trident has provided frequent updates on overall progress, but issued no announcements on its next steps.
Research is expected to understand the events contributing to the accident.
HWG
Trident Capsize During Transit
48
One possible factor is how the raised center of gravity of the system was accounted on the tow pontoon, particularly under unusual or extreme weather or confused seas.
This incident reaffirms the importance of proven operations and procedures.
Analysis of stability during all operational phases is critical.
HWG
Lessons Learned
49
The four projects reviewed in this paper illustrate the need for diligent ocean engineering and systems engineering in maritime projects.
The lessons learned from these projects suggest four general categories:
– Engineering, – Installation, – Operations, and – Communications.
HWG
Lessons Learned - Engineering
50
• Wave Dragon shows the importance of proper site characterization and material selection.
• Adequacy of all mooring components depends on the requirements of the site and the design criteria chosen.
• Collection of weather data, the design tradeoffs, and the risk analysis – are inputs to specifying an appropriate safety factor. A typical mooring specification might include the ability to withstand a 100-year storm.
The takeaway lesson is to employ conservative ocean engineering during all phases.
HWG
Lessons Learned - Installation
51
• The Osprey focus may have been on device performance and their design may not have elevated installation requirements in the early concept of operations.
• Submerging a device is a difficult operation in which stability is critical during all phases and transitions.
The takeaway lesson is to ensure a solid execution plan, including procedures for emergencies; particularly those caused or complicated by weather.
HWG
Lessons Learned - Installation
52
• Trident Energy may have had an execution plan for installation. Their problem came during transport.
• A tentative thesis for this accident is incorrect accounting for the raised center of gravity of the system when installed on the tow pontoon, especially under unusual weather.
• The root cause may have been selection of a port with shallow water that required movement on pontoons.
The takeaway lesson is to choose the site and deployment port carefully.
HWG
Lessons Learned - Operations
53
• Discoveries made during operations offer many useful lessons learned.
• Development cycles are needed to mature first-generation devices into mature designs cannot be sidestepped.
• Phased development and at-sea testing are a must.• The development of contingency plans for plausible failure
scenarios, and the prepositioning of contingency response vessels, provides additional layers of safety.
The takeaway lesson is to monitor the devices, recognize trends, and respond to indications of possible problems.
HWG
Lessons Learned - Communications
54
• How a developer reacts to and follows up after failures indicates a level of responsibility and accountability that forecasts their behavior on potential projects.
• A survey of corporate communications following portray a range of responses.
• This assessment is coincidentally parallel to each company’s perceived level of financial stability and technical credibility.
The takeaway lesson is that prompt status reports following an incident are key to maintaining trust with stakeholders.
HWG
Summary
55
The survey confirms the importance of selecting devices that have a high probability to prove themselves in array testing and proceed to commercial stage.
• A successful development history, including how past issues were resolved, will be a key selection criteria for WaveConnect.
• PG&E will review that history with each manufacturer to learn their development experiences and the resulting technical solutions. PG&E will select devices with demonstrated reliability and support.
HWG
On the brighter side
56
The survey also confirms that there have been several companies using a full development cycle that includes:
• concept development; • numerical analysis; • scale models; • tank testing; • tow testing; • scale device testing at sea; and, • full scale prototype testing.
HWG
On the brighter side
57
Wave energy companies that are known to be using a full development approach include (and are not limited to):
Aquamarine Powerwww.aquamarinepower.com
Ocean Power Technologieswww.oceanpowertechnologies.com
AWS Ocean Energywww.awsocean.com
Oceanlinxwww.oceanlinx.com
Columbia Technologieswww.columbiapowertechnologies.com
Orecon Ltd www.orecon.com
Fred Olsen Ltdwww.fredolsen.com
Pelamis Wave Powerwww.pelamiswave.com
Independent Natural Resourceswww.inri.us
Resolutewww.resolute-marine-energy.com
Ocean Energy Ltdwww.oceanenergy.ie
Wavebob Ltdwww.wavebob.com
HWG
Ten Pretty Good Guidelines
58
We are also using Lessons Learned from Wind Power (NREL):1. Develop First Principle Theories to Bound Performance and Guide Designs2. Perform Rigorous Testing3. Model the Important Physics and Validate the Models with Test Data4. Expect Prototypes Machines to Fail and Learn from the Failures5. Develop Comprehensive Standards for Ocean Energy Systems at an Early Stage6. Build Prototypes at a Practical Size. Make Them Work, Then Scale for Economy7. Develop and Verify Energy Loss Models for Arrays and Complex Flow Situations8. Develop and Verify Economics Models9. Perform Environmental Monitoring Studies at Sites10. Focus On Technology Innovation, Scale, and Reliability to Reduce Cost
HWG
Conclusions
59
Lessons learned will influence WaveConnect WEC selection and contingency planning.
• Proper planning, execution and trend analysis are essential for at-sea operations.
• Long-term at-sea operations are a necessary step in the path to achieving the commercial stage WECs -- needed for our national renewable energy portfolio.
In conclusion, we cite Bascom again in acknowledging that:
“the first and most valuable lesson one can learn about the sea is to respect it.”
HWG
Future Topics Schedule• November 2009
o WEC Deviceso Project Description
Updateo Agency Schedule Updateo Wave Energy
• December 2009o Environmental Analysis and
Baseline Info Updateo Migration Patterns of Whales
and Juvenile Salmono Lessons Learned
• January 2010o Monitoring and Adaptive
Management Overviewo Security Systems*o Hardware in the Seao Project Description Update
• February 2010o Operations and Maintenanceo WEC Device Selectiono EMF
* May repeat topic in February
HWG
Overview of Technology Types• Attenuator • Point Absorber
• Oscillating Water Column• Oscillating Wave Surge
Converter
61
HWG
Overview of Technology Types• Attenuator • Point Absorber
• Oscillating Water ColumnAquamarine Power – OysterAWS
Columbia TechnologiesFred Olsen LtdOcean Power TechnologiesRenewable Energy Wave Pump ResoluteWavebob, LtdINRI SEADOG
None submitted
Pelamis Wave PowerPerpetuWave Power Pty LtdWavebergCentipod
62
• Oscillating Wave Surge Converter
Ocean Energy Ltd