PARTS CATALOGUE VER. 6 JUNE 2019 JUNE 2019.pdfF77, F87 PICKUP & TRAYBACK 17 F73, F78 (COIL SPRINGS) 18 FORD COURIER PC, PD, PE, PG, PH 19 EVEREST UA1 Models 20 EVEREST UA2 Models 22

PARTS CATALOGUEVER. 6

JUNE 2019

WWW.TOUGHDOG.COM.AU

2 WWW.TOUGHDOG.COM.AU

Vehicle fitment sheet must be completed when suspension fitted. Failure to do so may affect warranty.Fitment sheet can be found on page 200 of this catalogue

TABLE OF CONTENTS

WARRANTYTERMS & CONDITIONS 5

PURCHASE ORDER FORMROCK DOG

SLOW SPEED COMPETITION USE ONLY 7RECOVERY GEAR

RECOVERY EQUIPMENT 8ASIA MOTORS

ROCSTAJD, JS 10

DAEWOOMUSSO

INCLUDING UTE 11DIAHATSU

F10 F20, F50, F60INCLUDING SCAT 12

F25, F55, F65FEROZA

CX12, F300 14FEROZA II

F310 15ROCKY

6/84-89 - F80, F85 16F77, F87 PICKUP & TRAYBACK 17F73, F78 (COIL SPRINGS) 18

FORDCOURIER

PC, PD, PE, PG, PH 19EVEREST

UA1 Models 20EVEREST

UA2 Models 22EXPLORER

UN, UP, UQ 24F250

Live Axle Front, Quad Rear Shocks 25BRONCO

Third Generation 26RANGER

PJ & PK, 2.5L & 3.0L 27

PX & PX II- All Models 28PXIII All Models 30

GREAT WALLUTE (WINGLE, SAILOR)

V200, 240, 2.4L 324 DOOR (HOVER, SAFE, HAVAL)

X240 33HOLDEN

FRONTERA LWB & SWB2 DOOR & 4 DOOR, 3.2L V6, 2.2L TDI 34

JACKAROO, ISUZU TROOPERUBS13, 16, 52L 35UBS16, 17, 52, 55 36

JACKAROO, MONTEREYUBS26, 69, 73 ( INC WIDE BODY) 37

RODEOKB4, KBD4 38TFS, G3, G6, R7, R9 40

RODEO & COLORADORA-RC 42

COLORADORG, MMU142, GM1700 44

COLORADO 7/TRAILBLAZERALL MODELS 46

HYUNDAITERRACAN

HP 47ISUZU

D-MAXMY09-MY11 48TFS85, V-CROSS, MY12 50

MU-XMY13 On 52

JEEPCHEROKEE

XJ Limited, Sport 54WG, WJ - 6/99-05 55

GRAND CHEROKEEWRANGLER

TJ 56

Unless specified otherwise, all listings in this catalogue are for 4WD (Four Wheel Drive) vehicles only.

Version 6 - June 2019

3P: (02) 9672 8899 | F: (02) 9672 8099

Freight should be added where required. When determining spring choice, include only permenant accessories & weights. Towing requirements are not included in constant load determination

JK 57LAND ROVER

80, 88 SWB, 109 LWBSERIES I, II, IIA & III 58110 COUNTY ONLY 59

DEFENDER90, 110, 130 Series 60

DISCOVERYSERIES I 62SERIES III (4/05-2009) 64

RANGE ROVERNON AIR SUSPENSION 65WITH AIR SUSPENSION 66

LADANIVA

ALL 67MAZDA

B2500, B2600PC, PD, PE, PG, PH 68

BT-50B2500, B3000 69MY11 On 70

MERCEDES-BENZX-CLASS UTE

X250D/X350D 72MITSUBISHI

CHALLENGERPA - LEAF REAR 74PA II - COIL REAR 75MY10, 11LS & XLS 76

L200 4WDMA, MB, MC, MD 78

L300 4WDSC, SD, SE, SF, SG, SH 79

PAJERO / MONTEROLEAF REAR 80 COIL REAR 81NM onwards (LWB) 82NM onwards (SWB) 84

PAJERO SPORT

MY16 on 86TRITON

ME, MF, MG, MH, MK 88ML MN (To MY15) 90MQ (From MY16) 92

NISSANNAVARA

D21, D22 94D40 - 2.5L, 4.0L 96D40 - 3.0L STX-550 V6 98NP300 - Coil Rear Only 100NP300 - Leaf rear only 102

PATHFINDERWNYD21, WHYD21 104 R50 (Series I, II, III) 105R51 - 2.5L, 4.0L 106R51 - 3.0L V6 108

PATROL9/80-85 MQ, MK 110GQ Patrol (Y60) - 2” Lift 112GU Patrol (Y61) - 2” Lift 114GQ, GU Patrol (Y60, Y61) - 3” Lift 116GQ, GU Patrol (Y60, Y61) - 4” Lift 118GQ, GU Patrol (Y60, Y61) - 5” Lift 120GQ, GU Patrol (Y60, Y61) - 6” Lift 122GQ Cab Chassis (Leaf/Leaf) 124GQ, GU Cab Chassis (Coil/Leaf) 126GQ, GU Cab Chassis (Coil/Coil) 128Y62 (Non Hydraulic Suspension Only) 130

TERRANO IIR20 132

SSANGYONGMUSSO (INC SPORT UTE)

ALSO SEE DAEWOO 133SUZUKI

JIMNYSN413 (JB33/43/48) 134JB74 136

SIERRALEAF SPRING ONLY 138

VITARA


TABLE OF CONTENTSVersion 6 - June 2019



INCLUDES GRAND VITARA & XL-7 139TOYOTA

FORTUNER04 - 12/15 14015 On 142

4RUNNERIFS WITH LEAF REAR 144IFS WITH COIL REAR 145

HILUXLEAF/LEAF 4WD 146TORSION BAR FRONT 148TORSION BAR FRONT 150KUN26R (COIL/LEAF) 152KUN26R - MINING APPLICATIONS 154AN120/130 (COIL/LEAF) 156

LANDCRUISER40, 42 SERIES 15845, 47 SERIES 16060, 61, 62 SERIES 16270 SERIES BUNDERA 16471, 74 SERIES SWB & LWB 16570, 73, 74 SERIES 16675 SERIES 16876 SERIES WAGON 17077 SERIES FZJ77, HZJ77, PZJ77 172 78 SERIES WITH COIL SPRINGS 17378, 79 SERIES INC V8 (EXCEPT DUAL CAB) 17478, 79 SERIES INC V8 (EXCEPT DUAL CAB) 17579 SERIES DUAL CAB 17680 & 105 SERIES 17880 & 105 SERIES 3” LIFT 18080 & 105 SERIES 4” LIFT 18280 & 105 SERIES 5” LIFT 18480 & 105 SERIES 6” LIFT 186100 SERIES (IFS) 188200 Series 190

PRADO95 SERIES 192120 SERIES LWB & SWB 194150 SERIES LWB & SWB 196

FJ CRUISER

All Models 198RAV 4

SAX 10, 11 200TUNDRA

UCK, UPK, USK 55, 56 201UAZ

ALL MODELSUAZ, HUNTER, PATRIOT 202

VOLKSWAGENAMAROK

All Models 203FITTING SHEET

PLEASE COMPLETE THIS FORM BEFORE ANY FITMENT 204

CLAIMS FORMWARRANTY & RETURNS

DISCLAIMER FORMVEHICLES LIFTED MORE THAN 50MM 206

VEHICLE WEIGHTGVM & RELATED INFORMATION 207


TABLE OF CONTENTSVersion 6 - June 2019

5P: (02) 9672 8899 | F: (02) 9672 8099


TERMS & CONDITIONSWARRANTY

ACCOUNTSAccount Applications that are approved must comply with the following Term & Condtiions1. All export orders must be prepaid before shipment2. Credit terms are 30 days from the end of the trading

month3. Credit will be suspensded if payment is not made within

the trading terms.4. Unpaid accounts at 30 days are on stop supply.5. If no credit arrangement exists, all goods must be prepaid

before leaving 4Way Suspension premesis.6. If Applicant is a company, the Directors Guarantee must

be completed by all relevant parties.

FREIGHT & INSURANCEAll Prices are quoted Ex-Warehouse and do not include freight. Goods pass to the buyer at the time they leave the 4Way Suspension Premesis. Unless specified otherwise, freight will be added to the total cost of goods using the Supplier’s preferred freight company.

CREDIT & WARRANTY RETURNSGoods for credit or exchange must be returned within fourteen (14) days of invoice date accompanied by a completed Returns Form. Goods returned for the purpose of warranty claim must also be accompanied by the returns form along with a copy of the customer invoice. Freight for returned goods can be arranged by the returned or by 4Way Suspension, but in both cases, the associated costs remain the responsibility of the returner.

15% OF THE TOTAL VALUE OF THE RETURNED GOODS WILL BE CHARGED IN THE EVENT

THAT REPACKAGING IS REQUIREDWARRANTY EXCLUSIONS1. Parts that have been incorrectly installed.2. Struts that have been assembled with the use of any tool

other than hand tools (no rattle guns etc)3. Load bearing strut bushes that have been tightened while

hanging. Strut bushes must be tightened while the vehicle is on the ground supporting its own load.

4. Interference between shock absorber and other suspension components.

5. Parts that have been involved in a motor vehicle accident or have been bent or have been physically damaged by impact of any kind.

6. Parts showing evidence of improper tightening of the mounting bolts causing parts to wear or bend.

7. Gripping tool marks (vice grips or multi grips) or any other tool made mark on the polished chrome section of the shock absorber shaft.

8. All parts subjected to abuse.9. All parts used in Off-road or other racing events or

activities.10. Any special order parts11. Parts fitted to vehicles weighing more than original GVM.Please Note: Any components built to a special order or

specification outside the catalogue listings is not covered by warranty. The manufacturer is unable to design components to withstand stresses in applications that R&D has not approved.

PROOF OF PURCHASEA Copy of proof of purchase by the retail customer must be attached to the claim including the kilometre reading at the time of fitment (if applicable). Each 4WD Suspension fitted must have a fitting sheet completed and kept on file by either the vehicle owner or the fitment centre performing the work. Failure to produce the fitting sheet may affect the warranty of the product.

WARRANTY PERIODS

53mm Ralph (standard use) 3 Year/unlimited km

53mm Ralph (Commercial Use) 2 Year/unlimited km

45mm Adjustable 3 Year/unlimited km

45mm Adjustable (Comm. Use) 2 Year/unlimited km

35mm Nitro Gas Shocks 2 Year/unlimited km

Foam Cell & 40mm Adjustable 3 Year/unlimited km

RTC/EXT/SV Dampers 3 Year/unlimited km

Leaf Springs 3 Year/unlimited km

Coil Springs (up to 2”) 3 year/unlimited km

Coil Springs (above 2”) 2 year/unlimited km

Recovery Equipment 3 years (material & manufacture)

SELF FIT (DIY) SUSPENSIONSDIY suspension fitment does not affect the warranty application or term as long as the following conditions are adhered to:1. A fitting sheet is completed prior to the suspension being

fitted and filed for later reference.2. The above fitment sheet accurately and clearly includes

bottom of rim to wheel arch measurments for all four corners of the vehicle both before, after and at the 500km check service.

3. U-Bolts must be replaced at the time of fitment. U-Bolts are a ‘stretch fit’ item, and should not be torqued to tightness twice. Re-using U-Bolts puts the vehicle and occupants at risk.

WARRANTY LIMITS4way Suspension Products Pty Ltd’s product warranty is limited to the repair or replacment of defective or faulty parts and does not include any costs incurred in labour for the removal or re-fitment of parts or damage incurred as a result of the product’s fitment.

Please note: All Warranty Claims are to be made to the place of original purchase



PURCHASE ORDER FORM

CUSTOMER DETAILS

Name: Date:

ABN No Staff Member:

Address:Phone Number

Fax Number:

Suburb P’Code: Email

SHIPPING DETAILS - Note: Must be a Business Address - No Drop Shipping

AddressOrder Number:

Freight Service: Standard Air / Express

Freight (circle)4WAY Default

Other (specify): Freight A/C No:

Send order by Fax or email to [email protected] or (02) 9672 8099

Please Complete this form in the event that your sales system is unable to generate a purchase order. Electronic PDF forms are available - call (02) 9672 8899

PART NO. QTY Description & Notes Cost

7P: (02) 9672 8899 | F: (02) 9672 8099


SLOW SPEED COMPETITION USE ONLYROCK CRAWLING COMPETITION COILOVERS

ROCK DOG

SHOCK ABSORBERSBMX45305 2 Shock - 12” Travel (505/810mm) $ 400 ea

Includes Heim JointsBMX45355 2 Shock - 14” Travel (565/910mm) $ 400 ea

BMX45406 2 Shock - 16” Travel (610/1015mm) $ 400 ea

COIL SPRINGSTDC-BMX160 2 160lbs Coil Spring $ 170 ea

TDC-BMX180 2 180lbs Coil Spring $ 170 ea

TDC-BMX100 2 100lbs Tender Coil Spring $ 135 ea

TDC-BMX180T 2 180lbs Dual Rate (Tapered) Coil $ 330 ea One Piece Design - Tender Built In

Custom Coil Design Available - Contact us on (02) 9672 8899COMPONENTS

TDUK-2000 1 Urethane Spring Connector $ 40 ea Urethane seating Collar

TDUK-2001 1 Urethane Protector Sleeve $ 31 ea Protects shock body from spring

361321 1 QA1 Heim Joints $ 57 ea Replacement Unit

PART NO. QTY DESCRIPTION RRP inc GST NOTES

QA1 Heim Joints

Urethane Spring Connector

Urethane Protector Sleeve

100 Lbs Tender Coil

160 & 180 Lbs Coil Springs

Dual Rate Tapered Coil Spring

Raw Shock Absorber

Coilover setup can be complex - Please call (02) 9672 8899 to tailor a solution



RECOVERY GEAR

RECOVERY KITSTDRK-08T 1 8T Complete Recovery Kit $ 389 ea Includes 8 Tonne Snatch Strap

TDRK-11T 1 11T Complete Recovery Kit $ 399 ea Includes 11 Tone Snatch Strap

INDIVIDUAL RECOVERy COMPONENTSTDRG-001 1 8 Tonne Snatch Strap $ 69 ea 9 Metres 20% Stretch

TDRG-002 1 11T Snatch Strap $ 99 ea 9 Metres 20% Stretch

TDRG-003 1 10T Tree Trunk Protector $ 40 ea 3 Metres Double Stitched

TDRG-004 1 10T Winch Extension Strap $ 149 ea 20 Metres

TDRG-005 1 10T Pulley Block $ 69 ea Greasable centre pin

TDRG-006 1 4.75T W.L.L Bow Shackle $ 12.50 ea Hot Dipped Galvanised Coating

PART NO. QTY DESCRIPTION RRP inc GST NOTESRECOVERY KITS & COMPONENTS

RECOVERy COMPONENTSTDRG-001 9 M 8,000 kg Yellow 100% Nylon, 20% Stretch

TDRG-002 9 M 11,000 kg Orange 100% Nylon, 20% Stretch

TDRG-003 3 M 10,000 kg Purple

TDRG-004 20 M 10,000 kg Green

TDRG-005 10,000 kg Yellow Greasable centre pin

TDRG-006 4.75T W.L.L Yellow Hot Dipped Galvanised Coating

Damper Blanket Black PVC Blanket with weight pockets

Gloves Black Synthetic outer leather palm with grip palm & finger pads

Storage Bag Red/Black 1200 Denier Material, Self supporting main opening.

PART NO. LENGTH M.B.S COLOUR NOTESPRODUCT DETAILS

RECOVERY EQUIPMENT

9P: (02) 9672 8899 | F: (02) 9672 8099


RECOVERY GEARCOMPLETE KIT INCLUDES

1 9T Snatch Strap

OR

1 11T Snatch Strap

1 10T Winch Extension Strap

1 10T Tree Trunk Protector

1 10T Pulley Block

2 4.75T W.L.L Bow Shackles

1 Pair Gloves

1 Recovery Damper Blanket

1 Heavy Duty Recovery Bag

8T & 11T Snatch Strap

10T WinchExtension Strap

10T Tree Trunk Protector

4.75T Bow Shackles

Heavy Duty Gloves

10T Pulley Block

Heavy Duty1200 Denier

Recovery Bag


FRONT SUSPENSIONPART NO. QTY DESCRIPTION RRP inc GST NOTES


ESTIMATED LIFT:

REPLACEMENT BUSHINGS

REAR SUSPENSION

50mm

JD, JS7/93-00ROCSTAASIA MOTORS

SHOCK ABSORBERSBD1102T 2 35mm Nitrogen Gas Shock $ 140 ea

Suits OE Height OnlyBM401102 2 40mm 9 Stage Adjustable Shock $ 207 ea

BD1104T 2 35mm Nitrogen Gas $ 140 eaSuits 50mm Lift

BM401104 2 40mm 9 Stage Adjustable $ 207 ea

COMPONENTSSD5700 1 Steering Damper $ 120 ea

COMPONENTSTDUK-001 1 Urethane Shackle Bushing Kit $ 65 ea

TDUB-001 2 U-Bolt Kit $ 31 ea


Suit OE HeightBM401364 2 40mm 9 Stage Adjustable Shock $ 207 ea

BD1366T 2 35mm Nitrogen Gas $ 140 eaSuit 50mm Lift




QUANTITY PER SHOCKTW959 2 Front Top Pin Mount $ 3 ea Pin Style Bushing

404702 1 Bottom Front Eyering $3 ea Eyering Bushing

404702 2 Top & Bottom Rear Eyering $3 ea Eyering Bushing

11P: (02) 9672 8899 | F: (02) 9672 8099


INCLUDING UTE7/98-02

MUSSODAEWOO

SHOCK ABSORBERSBD2057T 2 35mm Nitrogen Gas Shock $ 140 ea Suits up to 35mm Lift

TORSION BARS4WTB-1800 1 Replacement Torsion Bars (Pair) $ 290 pr 26mm/1040mm

Adjust Torsion bars after fitting shocks - Ensure a minimum of 60mm Droop is Maintained

PART NO. QTY DESCRIPTION RRP inc GST NOTESFRONT SUSPENSION ESTIMATED LIFT: 35mm

REAR SUSPENSIONSHOCK ABSORBERS

BD1104T 2 35mm Nitrogen Gas Shock $ 140 eaSuit OE Height

BM401104 2 40mm 9 Stage Adjustable Shock $ 207 ea



COIL SPRINGSTDC100 2 0-300KG Load $ 135 ea 35mm Lift

TDC100H 2 CONSTANT 300Kg Load $ 135 ea 35mm Lift

SHOCK CHOICE SPRING CHOICE RRP inc GST CONTENTS

REPLACEMENT BUSHINGSQUANTITY PER SHOCK

TW959 2 Front Top Pin Mount $ 3 ea Pin Style Bushing

412772 1 Bottom Front Eyering $ 6 ea Eyering Bushing

TW959 2 Rear Top Pin Mount $ 3 ea Pin Style Bushing

404702 1 Bottom Rear Eyering $ 3 ea Eyering Bushing

35mm Nitrogen Gas ANY $ 830

40mm 9 StageAdjustable

ANY $ 964

Includes4 x Shocks 2 x Coil Springs

COMPLETE KIT PRICE REFERENCE




ESTIMATED LIFT:


REAR SUSPENSION

No Springs Avail.

INCLUDING SCAT8/75-84F10 F20, F50, F60DIAHATSU





COMPONENTSTDUK-019 1 Urethane Shackle Bushing Kit $ 88 ea All Excluding F50

TDUK-020 1 Urethane Shackle Bushing Kit $ 68 ea Suits F50 Only






COMPONENTSTDUK-019 1 Urethane Shackle Bushing Kit $ 88 ea All Excluding F50

TDUK-020 1 Urethane Shackle Bushing Kit $ 68 ea Suits F50 Only


QUANTITY PER SHOCK404702 2 Suits Top & Bottom Front & Rear $3 ea Eyering Bushing

13P: (02) 9672 8899 | F: (02) 9672 8099


2/80-84F25, F55, F65

DIAHATSU

PART NO. QTY DESCRIPTION RRP inc GST NOTESFRONT SUSPENSION ESTIMATED LIFT: No Springs Avail.


REAR SUSPENSION













QUANTITY PER SHOCK404702 2 Suits Top & Bottom Front Shock $ 3 ea Eyering Bushing

404702 1 Suits Top Eyering Mount Rear $ 3 ea Eyering Bushing

TW959 2 Suits Bottom Pin Mount Rear $ 3 ea Pin Style Bushing




ESTIMATED LIFT:


REAR SUSPENSION

40mm

CX12, F30010/88-98FEROZADIAHATSU





LEAF SPRINGST67 2 0-300Kg Load $ 155 ea 40mm Lift



QUANTITY PER SHOCKTW959 2 Suits Top Front Pin Bushing $ 3 ea Pin Style Bushing

412772 1 Suits Bottom Front Eye Bushing $ 6 ea Eyering Bushing

TW959 2 Suits Top Rear Pin Bushing $ 3 ea Pin Style Bushing

404702 1 Suits Bottom Rear Eye Bushing $ 3 ea Eyering Bushing

SHOCK ABSORBERSBD2057T 2 35mm Nitrogen Gas Shock $ 140 ea All Applications




35mm Nitrogen Gas 0-300KG $ 1042


0-300KG $ 1176

Includes2 x Leaf Springs 4 x Shocks

1x Urethane Kits 2x U-Bolt Kits


15P: (02) 9672 8899 | F: (02) 9672 8099


F3104/93-99

FEROZA IIDIAHATSU








LEAF SPRINGST76 2 0-300Kg Load $ 196 ea 40mm Lift



QUANTITY PER SHOCKTW959 2 Suits Top Front Pin Bushing $ 3 ea Pin Style Bushing

412772 1 Suits Bottom Front Eye Bushing $ 6 ea Eyering Bushing

TW959 2 Suits Top Rear Pin $ 3 ea Pin Style Bushing

404702 2 Suits Bottom Rear Eyering $ 3 ea Eyering Bushing

SHOCK ABSORBERSBD2057T 2 35mm Nitrogen Gas Shock $ 140 ea All Applications




35mm Nitrogen Gas 0-300KG $ 1123


0-300KG $ 1257







ESTIMATED LIFT:


REAR SUSPENSION

40mm

6/84-89 - F80, F856/84-93 - F70, F75ROCKYDIAHATSU





LEAF SPRINGST64 2 0-300Kg Load $ 130 ea Suits LWB Only

T64M 2 0-300Kg Load $ 130 ea Suits SWB Only



QUANTITY PER SHOCKTW959 2 Suits Top Pin - Front & Rear $ 3 ea Pin Style Bushing

404702 2 Suits Bottom Eye - Front & Rear $ 3 ea Eyering Bushing


35mm Nitrogen Gas0-300KG SWB $ 1402

0-300KG LWB $ 1402


0-300KG SWB $ 1670

0-300KG LWB $ 1670




SHOCK ABSORBERSBD1102TB 2 35mm Nitrogen Gas Shock $ 140 ea


BD1104TB 2 35mm Nitrogen Gas $ 140 eaSuit 40mm Lift


LEAF SPRINGST65 2 Petrol/Diesel/Bar $ 125 ea Suits LWB Only

T65C 2 Petrol/Diesel/Bar $ 125 ea Suits SWB Only


TDUB-002 1 U-Bolt Kit $ 31 ea Suits D/S (1 Kit Req’d)

TDUB-027 1 U-Bolt Kit $ 31 ea Suits P/S (1 Kit Req’d)

17P: (02) 9672 8899 | F: (02) 9672 8099


F77, F87 PICKUP & TRAYBACK11/86-93

ROCKYDIAHATSU

PART NO. QTY DESCRIPTION RRP inc GST NOTESFRONT SUSPENSION ESTIMATED LIFT: No Springs Avail.







COMPONENTSTDUB-027 2 U-Bolt Kit $ 31 ea

QUANTITY PER SHOCKTW959 2 Suits Pin - Front & Rear $ 3 ea Pin Style Bushing

404702 1 Suits Eye - Front & Rear $ 3 ea Eyering Bushing

SHOCK ABSORBERSBD1102TB 2 35mm Nitrogen Gas Shock $ 140 ea


BD1104TB 2 35mm Nitrogen Gas $ 140 eaSuit 40mm Lift







ESTIMATED LIFT:


REAR SUSPENSION

40mm

F73, F78 (COIL SPRINGS)8/93-99ROCKYDIAHATSU

SHOCK ABSORBERSFC41184 2 41mm Foam Cell Shock $ 176 ea


COIL SPRINGSTDC066 2 0-300Kg Load $ 135 ea 40mm Lift

QUANTITY PER SHOCKTW959 2 Suits Top Front Pin $ 3 ea Pin Style Bushing

412772 1 Suits Bottom Front Eye $6 ea Eyering Bushing



41mm Foam Cell 0-300KG $ 974

Foam Cell Front Adjustable Rear

0-300KG $ 1036

Includes4 x Shock Absorbers 2 x Coil Springs


SHOCK ABSORBERSFC42019B 2 41mm Foam Cell Shock $ 176 ea

TORSION BARS4WTB-0198 1 Replacement Torsion Bars $ 260 pr 26mm/1093mm


19P: (02) 9672 8899 | F: (02) 9672 8099


PC, PD, PE, PG, PH5/87-10/06

COURIERFORD




BD1232T 2 35mm Nitrogen Gas Shock $ 140 ea Suits Up to 40mm Lift

FC41232 2 41mm Foam Cell Shock $ 176 ea Suits Up to 40mm Lift

BM401232 2 40mm 9 Stage Adjustable $ 207 ea Suits Up to 40mm Lift

LEAF SPRINGSFS365 2 0-300kg Load $ 200 ea 40mm Lift

FS367 2 CONSTANT 300Kg Load $ 210 ea 40mm Lift



QUANTITY PER SHOCKTW959 + TW961 2 Suits Top Front & Rear Pin $ 3 ea Pin Style Bushing

412772 1 Suits Bottom Front & Rear Eye $ 6 ea Eyering Bushing

ADJ00191 1 Suits Top Rear Eyering $ 3 eaSuit Foam Cell Shocks

SPF420-02 1 Suits Bottom Rear Eyering $ 6 ea

230100 1 Suits Top Rear Eyering $ 8 eaSuit 40mm Adjustable Shocks

230002 1 Suits Bottom Rear Eyering $ 5 ea

SHOCK ABSORBERSFC42051B 2 41mm Foam Cell Shock $ 176 ea Suits up to 40mm Lift

TDSK-020 1 Shock Mount Strengthening Kit $90 ea Top Pin Mount Bracket

Please Note: - Failure to fit TDSK-020 will cause top mount failure. Fitting instructions at toughdog.com.au




Foam Cell Front Nitro gas Rear

0-300KG $ 1308

Constant 300kg $ 1328

41mm Foam Cell0-300KG $ 1382


Foam Cell FrontAdjustable Rear

0-300KG $ 1442


Includes2 x Leaf Springs 4 x Shocks 1 x Urethane Kits

2 x U-Bolt Kits 1 x Shock Strengthening Kit





ESTIMATED LIFT: 40mm

UA1 Models2015 - 08/2018EVERESTFORD


REAR SUSPENSION

SHOCK ABSORBERSFC404500 2 40mm Foam Cell Strut $ 248 ea

BM404500 2 40mm Adjustable Strut $ 310 ea 9 Stage Adjustable

COIL SPRINGSTDC452 2 40mm Lift Spring $ 135 ea Petrol/Diesel/Bar

TDC452HL 2 40mm Lift Spring $ 135 ea Petrol/Diesel/Bar/Winch

COMPLETE STRUT ASSEMBLYMAZ-005 2 BM404500/TDC452 $ 518 ea Petrol/Diesel/Bar

MAZ-006 2 BM404500/TDC452HL $ 518 ea Petrol/Diesel/Bar/Winch

MAZ-007 2 FC404500/TDC452 $ 456 ea Petrol/Diesel/Bar

MAZ-008 2 FC404500/TDC452HL $ 456 ea Petrol/Diesel/Bar/Winch

REPLACEMENT STRUT TOPMAZ-4051 2 Strut Top $ 73 ea Replacement Strut Top

SHOCK ABSORBERSFC43013 2 41mm Foam Cell Shock $ 176 ea Suits Up to 40mm Lift


COIL SPRINGSTDC453 2 0-300kg Load $ 135 ea 40mm Lift

TDC453L 2 CONSTANT 300Kg Load $ 135 ea 40mm Lift

AIR ASSIST BAGSTDAA-004 1 Coil insert bag kit $ 420 ea Suits 40mm Lift

QUANTITY PER SHOCKMAZ-4051 1 Replacement Strut Top $ 73 ea Available As Complete Unit Only

ADJ00305 1 Suits Bottom Front Eye $ 6 ea Eyering Bonded Bushing

21P: (02) 9672 8899 | F: (02) 9672 8099


UA1 Models2015 - 08/2018

EVERESTFORD

Foam CellStruts Require

AssemblyIncludes

4 x Coil Springs4 x Shocks

ANY $ 1388

Foam CellComplete Assembly

StrutsIncludes

2 x Front Strut Assy2 x Coil Springs2 x Rear Shocks

ANY $ 1534

40mm Adjustable Struts Require

AssemblyIncludes


ANY $ 1574

40mm Adjustable Complete Assembly

StrutsIncludes


ANY $ 1720

SHOCK CHOICE SPRING CHOICE RRP inc GST CONTENTS COMPLETE KIT PRICE REFERENCE





UA2 Models08/2018 onEVERESTFORD


REAR SUSPENSION



COIL SPRINGSTDC1006 2 40mm Lift Spring $ 135 ea Diesel no accessories

TDC1007 2 40mm Lift Spring $ 135 ea Diesel with Bar or Bar+Winch

COMPLETE STRUT ASSEMBLYFOR-005 2 BM404520/TDC1006 $ 560 ea Diesel no accessories

FOR-006 2 BM404520/TDC1007 $ 560 ea Diesel with Bar or Bar+Winch

FOR-007 2 FC404520/TDC1006 $ 498 ea Diesel no accessories

FOR-008 2 FC404520/TDC1007 $ 498 ea Diesel with Bar or Bar+Winch

REPLACEMENT STRUT TOPFOR-4520 2 Strut Top $ 115 ea Replacement Strut Top








23P: (02) 9672 8899 | F: (02) 9672 8099


UA2 Models08/2018 on

EVERESTFORD


AssemblyIncludes


ANY $ 1388


StrutsIncludes


ANY $ 1618


AssemblyIncludes


ANY $ 1574


StrutsIncludes


ANY $ 1804





ESTIMATED LIFT:

REAR SUSPENSION

40mm

UN, UP, UQ10/96-05EXPLORERFORD



Includes4 x Shocks




Please Note:

1) The “Limited” comes standard with (Self Levelling) air shocks. These can be retained or removed as desired. If the (Self Levelling) air shocks are removed, the self levelling indicator light in the dash will turn on and off intermittently.The air hoses should be sealed off and fastened to the chassis for later use if needed.

2) The air compressor must be turned off. The switch is located in the left hand rear inspection console. If further electrical work is required, please consult an Automotive Electrician.

25P: (02) 9672 8899 | F: (02) 9672 8099


03-06F250

FORD

PART NO. QTY DESCRIPTION RRP inc GST NOTESFRONT SUSPENSION ESTIMATED LIFT: 100 mm


BMX3501 2 45mm 9 Stage Adjustable $ 285 ea Forward of Rear Axle - OE Height

BMX3502 2 45mm 9 Stage Adjustable $ 285 ea Rear of Rear Axle - OE Height

BMX3501/4 2 45mm 9 Stage Adjustable $ 285 ea Forward of Rear Axle - 100mm lift

BMX3502/4 2 45mm 9 Stage Adjustable $ 285 ea Rear of Rear Axle - 100mm lift


FS027H 2 CONSTANT 500Kg Load $ 360 ea 100mm Lift

COMPONENTSTDUK-064 1 Shackle Bushing Kit $ 52 ea Kit fitted to springs when ordered




0-500KG $ 3448


Includes4 x Leaf Springs 6 x Shocks 2 x Bushing Kits

4 x U-Bolt Kits 1 x Panhard Rod


SHOCK ABSORBERSTDR3500 2 53mm ‘Ralph’ Big Bore $ 285 ea Suits OE Height Only

BMX3500/4 2 45mm 9 Stage Adjustable $ 285 ea Suits 100mm Lift

LEAF SPRINGSFS026 2 Petrol/Diesel/Alloy Bar $ 260 ea 100mm Lift

FS026H 2 Petrol/Diesel/Bar/Winch $ 270 ea 100mm Lift

STEERING DAMPERSS5250-XHD 1 XHD Return To Centre Damper $ 310 ea When fitted to OE height vehicle,

Low ground clearance occursSV5250 1 ‘SV’ 9 Stage Adjustable Damper $ 310 ea

COMPONENTSTDUK-064 1 Shackle Bushing Kit $ 52 ea Kit fitted to springs when ordered


TDPR-250 1 Adjustable Panhard Rod $ 270 ea

Live Axle Front, Quad Rear Shocks


TW038-16 1 Suits top mount all shocks $ 6 ea Eyering Bonded Bushing

TW038-12 1 Suits bottom mount all shocks $ 6 ea Eyering Bonded Bushing




ESTIMATED LIFT:

REAR SUSPENSION

No Springs Avail.

Third Generation3/81-89BRONCOFORD

SHOCK ABSORBERS (ALL EXCL. QUAD SHOCK)FC41130B 2 41mm Foam Cell Shock $ 176 ea Suits up to 30mm Lift

SHOCK ABSORBERS (QUAD SHOCK)FC41102B 2 41mm Foam Cell Shock $ 176 ea OE Height - Front of Axle

FC41130B 2 41mm Foam Cell Shock $ 176 ea OE Height - Rear of Axle

SHOCK ABSORBERS (ALL MODELS)FC41379 2 41mm Foam Cell Shock $ 176 ea Suits Up to 30mm Lift


TW959 2 Suits Top Front Pin $ 3 ea Pin Style Bushing (#1102B ONLY)

404702 1 Suits Bottom Front Eye $ 3 ea Eyering Bushing (#1102B ONLY)

404702 1 Suits Top Rear $ 3 ea Eyering Bushing

SPF420 1 Suits Bottom Rear $ 3 ea Eyering Bushing

REPLACEMENT BUSHINGS SUIT 06-2011 Ranger (not Bronco)QUANTITY PER SHOCK

TW959 (x1)+TW961 (x1) 1 + 1 Suits Top Front Pin (1 each req’d) $ 3 ea Pin Style Bushing

412772 1 Suits Bottom Front Eye $ 6 ea Eyering Bushing


4W-SPF420-02 1 Suits Bottom Rear Eyering $ 6 ea



27P: (02) 9672 8899 | F: (02) 9672 8099


PJ & PK, 2.5L & 3.0L12/06-10/11RANGER

FORD






LEAF SPRINGSFS368C 2 0-300kg Load $ 250 ea 45mm Lift

FS368L 2 CONSTANT 300Kg Load $ 285 ea 45mm Lift


TDUB-040 2 U-Bolt Kit $ 31 ea Suits FS368C only

TDUB-039 2 U-Bolt Kit $ 31 ea Suits FS368L only

TDGS-386/1 1 Greasable Shackle Kit $ 93 ea

TDGP-668 1 Greasable Pin Kit $ 83 ea

AIR ASSIST BAGSTDAA-101 1 Bellows bag kit $ 716 ea Suits 45mm Lift








0-300KG $ 1439Includes

2 x Leaf Springs4 x Shocks

1 x Urethane Kit2 x U-Bolt Kits

1 x Shock Mount Kit41mm Foam Cell

0-300KG $ 1511



0-300KG $ 1573






ESTIMATED LIFT:


40mm

REAR SUSPENSION

PX & PX II- All Models11/2011 - 08/2018RANGERFORD









REPLACEMENT STRUT TOPMAZ-4051 2 Strut Top $73 ea Replacement Strut Top

SHOCK ABSORBERSBD1232T 2 35mm Nitrogen Gas Shock $ 140 ea Up to 40mm Lift (For Comfort)





FS369LL 2 CONSTANT 500Kg Load $ 285 ea 40mm Lift


TDUB-039 2 U-Bolt Kit $ 31 ea Suits FS369L & LL Spring

TDUB-040 2 U-Bolt Kit $ 31 ea Suits FS369C Spring Only

TDGS-390 1 Greasable Shackle Kit $ 93 ea


TDSP-007 1 Transmission Spacer Kit $ 57 ea Must Be fitted to All Lift Kits








29P: (02) 9672 8899 | F: (02) 9672 8099


PX & PXII - All Models11/2011 - 08/2018

RANGERFORD


AssemblyIncludes

2x Front Struts2x Rear Shocks2x Front Coils

2x Leaf Springs1x Urethane Kit2x U-Bolt Kits

1x Transmission Spacer

FS369C(Foam Front Gas Rear)

$ 1740

FS369C(Foam Cell All)

$ 1812

FS369LCONSTANT 300KG

$ 1922

FC369LLCONSTANT 500KG

$ 1982


StrutsIncludes

2x Front Strut Assy2x Rear Shocks2x Leaf Springs1x Urethane Kit2x U-Bolt Kits

1x Transmission Space


$ 1886


$ 1958


$ 2068

FS369LLCONSTANT 500KG

$ 2128


AssemblyIncludes




FS369C0-300KG

$ 1998


$ 2108


$ 2168


StrutsIncludes



FS369C0-300KG

$ 2144


$ 2254


$ 2314


35mm Nitro Gas shocks should be used when extra comfort is desired in vehicles carrying little to no load. They are not suitable for heavy load carrying applications

Note: Transmission spacer fitting instructions available

at toughdog.com.au




ESTIMATED LIFT:


40mm

REAR SUSPENSION

PXIII All Models08/2018 onRANGERFORD





COMPLETE STRUT ASSEMBLYFOR-001 2 BM404520/TDC455 $ 560 ea Petrol/Diesel/Bar

FOR-002 2 BM404520/TDC455HL $ 560 ea Petrol/Diesel/Bar/Winch

FOR-003 2 FC404520/TDC455 $ 498 ea Petrol/Diesel/Bar

FOR-004 2 FC404520/TDC455HL $ 498 ea Petrol/Diesel/Bar/Winch

REPLACEMENT STRUT TOPFOR-4520 2 Strut Top $115 ea Replacement Strut Top

QUANTITY PER SHOCKFOR-4520 1 Replacement Strut Top $ 115 ea Available As Complete Unit Only

ADJ00306 1 Suits Bottom Front Eye $ ea Eyering Bonded Bushing





SHOCK ABSORBERSBD1232T 2 35mm Nitrogen Gas Shock $ 140 ea Up to 40mm Lift (For Comfort)













31P: (02) 9672 8899 | F: (02) 9672 8099


PXIII - All Models08/2018 onRANGER

FORD


AssemblyIncludes





$ 1740


$ 1812


$ 1922


$ 1982


StrutsIncludes




$ 1970


$ 2042


$ 2152


$ 2212


AssemblyIncludes




FS369C0-300KG

$ 1998


$ 2108


$ 2168


StrutsIncludes



FS369C0-300KG

$ 2228


$ 2338


$ 2398


35mm Nitro Gas shocks should be used when extra comfort is desired in vehicles carrying little to no load. They are not suitable for heavy load carrying applications

Note: Transmission spacer fitting instructions available

at toughdog.com.au




ESTIMATED LIFT: 45 mm

V200, 240, 2.4L6/09 OnUTE (WINGLE, SAILOR)GREAT WALL



BD1382T 2 35mm Nitrogen Gas Shock $ 140 ea

Suits OE HeightFC41382 2 41mm Foam Cell Shock $ 176 ea



Suits 45mm LiftFC41388 2 41mm Foam Cell Shock $ 176 ea









412772 1 Suits Bottom Front Eyering $ 6 ea Eyering Bushing

404702 2 Suits Top & Bottom Rear Eyering $ 3 ea Eyering Bushing






0-300KG $ 1246





0-300KG $ 1380



1 x Urethane Kits 2 x U-Bolt Kits


33P: (02) 9672 8899 | F: (02) 9672 8099


X24005- On

4 DOOR (HOVER, SAFE, HAVAL)GREAT WALL









TW959 2 Suits Top & Bottom Rear Pin $ 3 ea Pin Style Bushing

TW038/16 1 Suits Bottom Rear Eyering $ 6 ea Eyering Bushing




0-300KG $ 1036

Includes2 x Coil Springs 4 x Shocks









2 DOOR & 4 DOOR, 3.2L V6, 2.2L TDI10/95-99 & 3/99-04FRONTERA LWB & SWBHOLDEN


FC41200 2 41mm Foam Cell Shock $ 176 ea Check Mounts before ordering Suits Eye/Eye VehiclesBM401200 2 40mm 9 Stage Adjustable $ 207 ea

FC41201B 2 41mm Foam Cell Shock $ 176 ea Check Mounts before ordering Suits Pin/Eye VehiclesBM401201 2 40mm 9 Stage Adjustable $ 207 ea

COIL SPRINGSTDC290 2 0-300kg Load $ 135 ea OE Height (10/95-99 ONLY)

TDC267 2 0-300kg Load $ 135 ea 40mm Lift (10/95-99 ONLY)

TDC267 2 0-300kg Load $ 135 ea 35mm Lift (3/99-04 ONLY)

TDC267H 2 CONSTANT 300Kg Load $ 135 ea 35mm Lift (3/99-04 ONLY)


TORSION BARS4WTB-1559 1 Replacement Torsion Bars $ 495 pr 30mm/1145mm - 3/99-04 ONLY






0-300KG $ 1036




35P: (02) 9672 8899 | F: (02) 9672 8099


UBS13, 16, 52L11/81-86

JACKAROO, ISUZU TROOPERHOLDEN

















404702 2 Suits Top & Bottom Rear Eye $ 3 ea Eyering Bushing



FC42057B 2 41mm Foam Cell Shock $ 176 ea Suits up to 45mm Lift



35mm Nitro Gas 0-300KG $ 1049




0-300KG $ 1255








UBS16, 17, 52, 5511/86-92JACKAROO, ISUZU TROOPERHOLDEN






BD1106TB 2 35mm Nitrogen Gas Shock $ 140 ea
















35mm Nitro Gas 0-300KG $ 1049




0-300KG $ 1255




37P: (02) 9672 8899 | F: (02) 9672 8099


UBS26, 69, 73 ( INC WIDE BODY)5/92-98 & 2/98-04

JACKAROO, MONTEREYHOLDEN




FC41200 2 41mm Foam Cell Shock $ 176 ea Suits up to 40mm Lift

BM401200 2 40mm 9 Stage Adjustable $ 207 ea Suits up to 40mm Lift

COIL SPRINGSTDC267 2 0-300kg Load $ 135 ea

40mm LiftSuit UBS25, 69

TDC267H 2 CONSTANT 300Kg Load $ 135 ea

TDC267HH 2 CONSTANT 500Kg Load $ 135 ea

TDC267H 2 0-300kg Load $ 135 ea 40mm LiftSuit UBS26, 73 Wide BodyTDC267HH 2 CONSTANT 300Kg Load $ 135 ea





TORSION BARS4WTB-1549 1 Replacement Torsion Bars $ 495pr 29.3mm/1220mm


41mm Foam Cell ANY $ 974


ANY $ 1036






KB4, KBD41/81-88RODEOHOLDEN











FS113HM 2 CONSTANT 500Kg Load $ 270 ea 40mm Lift





QUANTITY PER SHOCK404702 2 Suits Top & Bottom Rear Eye $ 3 ea Eyering Bushing

TORSION BARS4WTB-1536 1 Replacement Torsion Bars $ 550 pr 26mm/927mm (1/81-83 ONLY)

4WTB-1546 1 Replacement Torsion Bars $ 260 pr 26mm/926mm (83-88 ONLY)


39P: (02) 9672 8899 | F: (02) 9672 8099


KB4, KBD41/81-88

RODEOHOLDEN

35mm Nitro GasRear

FS1130-300KG Spring

$ 769

FS113HCONSTANT 300KG

Spring$ 859

Includes2x Rear Shocks2x Leaf Springs1x Urethane Kit2x U-Bolt Kits

41mm Foam CellRear

FS1130-300KG Spring

$ 841


Spring$ 931Includes

2x Rear Shocks2x Leaf Springs1x Urethane Kit2x U-Bolt Kits FS113HM

CONSTANT 500KG Spring

$ 1011

40mm AdjustableRear

FS1130-300KG Spring

$ 903


Spring$ 993Includes

2x Rear Shocks2x Leaf Springs1x Urethane Kit2x U-Bolt Kits FS113HM


$ 1073






TFS, G3, G6, R7, R98/88-03RODEOHOLDEN









LEAF SPRINGSCheck No. of Leaves - Rare special editions have heavier leaf packs from factory

FS113 2 0-300kg Load $ 185 ea 40mm Lift


FS113HM 2 CONSTANT 500Kg Load $ 270 ea 40mm Lift









TORSION BARS4WTB-1548 1 Replacement Torsion Bars $ 290 pr 26mm/997mm - 36mm Spline

4WTB-1566 1 Replacement Torsion Bars $ 370 pr 27mm/998mm - 33mm Spline

Check Spline & Diameter prior to ordering


41P: (02) 9672 8899 | F: (02) 9672 8099


TFS, G3, G6, R7, R98/88-03

RODEOHOLDEN

35mm Nitro GasFS113

0-300KG Spring$ 1090


Spring$ 1180

Includes2x Front Shocks2x Rear Shocks2x Leaf Springs1x Urethane Kit2x U-Bolt Kits

Nitro Gas FrontFoam Cell Rear

FS1130-300KG Spring

$ 1162


Spring$ 1252


FS113HMCONSTANT 500KG

Spring$ 1332

Nitro Gas FrontAdjustable Rear

FS1130-300KG Spring

$ 1224


Spring$ 1314



Spring$ 1394






RA-RC2/03-2012RODEO & COLORADOHOLDEN






















43P: (02) 9672 8899 | F: (02) 9672 8099


RA-RC2/03-2012

RODEO & COLORADOHOLDEN

Foam Cell Front Nitro Gas Rear

FS2130-300KG Spring

$ 1246Includes2x Front Shocks2x Rear Shocks2x Leaf Springs1x Urethane Kit2x U-Bolt Kits

41mm Foam CellFS213



Spring$ 1328



FS2130-300KG Spring

$ 1380


Spring$ 1390






ESTIMATED LIFT:


40mm

REAR SUSPENSION

RG, MMU142, GM170011/11 OnCOLORADOHOLDEN




TDC974 2 40mm Lift Spring $ 135 ea Petrol/Diesel/Bar/Winch

COMPLETE STRUT ASSEMBLYHOL-001 2 BM404200/TDC270 $ 518 ea Petrol/Diesel/Bar

HOL-002 2 BM404200/TDC974 $ 518 ea Petrol/Diesel/Bar/Winch

HOL-003 2 FC404200/TDC270 $ 456 ea Petrol/Diesel/Bar

HOL-004 2 FC404200/TDC974 $ 456 ea Petrol/Diesel/Bar/Winch

REPLACEMENT STRUT TOP - Strut top special info sheet at toughdog.com.auTOY-1081 2 Strut Top $ 73 ea Replacement Strut Top

SHOCK ABSORBERSBD1382T 2 35mm Nitrogen Gas Shock $ 140 ea Suits Up to 40mm Lift










TDSK-021 1 Handbrake Relocation kit $ 26 ea Req’d for MY17 vehicles

Handbrake Relocation kit is required for all vehicles MY17 onwards (06/16 release onward)


QUANTITY PER SHOCKTOY-1081 1 Replacement Strut Top $ 73 ea Available As Complete Unit Only

ADJ00300/40 1 Suits Bottom Front Eye $ 6 ea Eyering Bonded Bushing


45P: (02) 9672 8899 | F: (02) 9672 8099


RG, MMU142, GM170011/11 On

COLORADOHOLDEN



AssemblyIncludes




$ 1723


$ 1795


$ 1855


$ 1915


StrutsIncludes



$ 1869


$ 1941


$ 2001


$ 2061


AssemblyIncludes



FS214C0-300KG

$ 1981


$ 2041


$ 2101


StrutsIncludes


FS214C0-300KG

$ 2127


$ 2187


$ 2247

Note: Kit price reference does notinclude handbrake relocation kit.

Please add to kit for MY17 on vehicles




ESTIMATED LIFT:


40mm

REAR SUSPENSION

ALL MODELS11/11 OnCOLORADO 7/TRAILBLAZERHOLDEN




TDC974 2 40mm Lift Spring $ 135 ea Petrol/Diesel/Bar/Winch

COMPLETE STRUT ASSEMBLYHOL-001 2 BM404200/TDC270 $ 518 ea Petrol/Diesel/Bar

HOL-002 2 BM404200/TDC974 $ 518 ea Petrol/Diesel/Bar/Winch

HOL-003 2 FC404200/TDC270 $ 456 ea Petrol/Diesel/Bar

HOL-004 2 FC404200/TDC974 $ 456 ea Petrol/Diesel/Bar/Winch

REPLACEMENT STRUT TOPTOY-1081 2 Strut Top $ 73 ea Replacement Strut Top









TW040/14 1 Suiits Rear Bottom Eye $ 6 ea Eyering Bush

TW959 2 Suits Rear Top Pin $ 3 ea Pin Style Bushing


41mm Foam Cell

Note: To use gas rear

Any $ 1388

Any (Complete Assy) $ 1534

9 Stage AdjustableAny $ 1574

Any (Complete Assy) $ 1720

Front Struts can be purchased Assembled or as Separate Components

47P: (02) 9672 8899 | F: (02) 9672 8099


45 mm

HP12/01 On

TERRACANHYUNDAI


FRONT SUSPENSION

SHOCK ABSORBERSFC41120B 2 41mm Foam Cell Shock $ 176 ea

Suits OE HeightBM401120 2 40mm 9 Stage Adjustable $ 207 ea

FC41121B 2 41mm Foam Cell Shock $ 176 eaSuits 45mm Lift



TDC632SL 2 CONSTANT 300Kg Load $ 135 ea 45mm Lift

QUANTITY PER SHOCK402267 2 Suits Top Front Pin $ 3 ea Pin Style Bushing

402267 2 Suits Top Rear Pin $ 3 ea Pin Style Bushing

ADJ00191 1 Suits Bottom Rear Eye $ 3 ea Eyering Bushing




TORSION BARS4WTB-1725 1 Replacement Torsion Bars $ 290 pr 27.5mm/1275mm





0-300KG $ 1036



ESTIMATED LIFT:PART NO. QTY DESCRIPTION RRP inc GST NOTES

REAR SUSPENSION





MY09-MY1104/08-12D-MAXISUZU






















49P: (02) 9672 8899 | F: (02) 9672 8099


Foam Cell FrontNitro Gas Rear

FS2130-300KG Spring

$ 1246Includes2x Front Shocks2x Rear Shocks2x Leaf Springs1x Urethane Kit2x U-Bolt Kits

41mm Foam CellFS213



Spring$ 1328



FS2130-300KG Spring

$ 1380


Spring$ 1390


MY09-MY114/08-12

D-MAXISUZU





ESTIMATED LIFT:


40mm

REAR SUSPENSION

TFS85, V-CROSS, MY1205/12 OnD-MAXISUZU



COIL SPRINGSTDC270 2 40mm Lift Spring $ 135 ea Petrol/Diesel/Up to Alloy Bar

TDC974 2 40mm Lift Spring $ 135 ea Petrol/Diesel/Bar

TDC974H 2 40mm Lift Spring $ 135 ea Petrol/Diesel/Bar/Winch

COMPLETE STRUT ASSEMBLYHOL-001 2 BM404200/TDC270 $ 518 ea Petrol/Diesel/Up to Alloy Bar

HOL-002 2 BM404200/TDC974 $ 518 ea Petrol/Diesel/Steel Bar

HOL-005 2 BM404200/TDC974H $ 518 ea Petrol/Diesel/Bar/Winch

HOL-003 2 FC404200/TDC270 $ 456 ea Petrol/Diesel/Up to Alloy Bar

HOL-004 2 FC404200/TDC974 $ 456 ea Petrol/Diesel/Steel Bar

HOL-006 2 FC404200/TDC974H $ 456 ea Petrol/Diesel/Bar/Winch












TDSK-021 1 Handbrake Relocation kit $ 26 ea Req’d for up to MY15.5 vehicles

Handbrake Relocation kit is required for all vehicles to MY15.5 (04/16 release) Not req’d for 04/16 onward.





51P: (02) 9672 8899 | F: (02) 9672 8099


TFS85, V-CROSS, MY1205/12 OnD-MAX

ISUZU


AssemblyIncludes



1x Handbrake Bkt Kit


$ 1749


$ 1821


$ 1881


$ 1941


StrutsIncludes




$ 1895


$ 1967


$ 2027


$ 2087


AssemblyIncludes




FS214C0-300KG

$ 2007


$ 2067


$ 2127


StrutsIncludes

2x Front Struts2x Rear Shocks2x Leaf Springs1x Urethane Kit2x U-Bolt Kits


FS214C0-300KG

$ 2153


$ 2213


$ 2273


Note: Kit price reference includeshandbrake relocation kit.

Please remove from kit forMY15.5 on vehicles





MY13 On8/14 OnMU-XISUZU



COIL SPRINGSTDC270 2 40mm Lift Spring $ 135 ea Petrol/Diesel/Up to Alloy Bar



COMPLETE STRUT ASSEMBLYHOL-001 2 BM404200/TDC270 $ 518 ea Petrol/Diesel/Up to Alloy Bar

HOL-002 2 BM404200/TDC974 $ 518 ea Petrol/Diesel/Steel Bar

HOL-005 2 BM404200/TDC974H $ 518 ea Petrol/Diesel/Bar/Winch

HOL-003 2 FC404200/TDC270 $ 456 ea Petrol/Diesel/Up to Alloy Bar

HOL-004 2 FC404200/TDC974 $ 456 ea Petrol/Diesel/Steel Bar

HOL-006 2 FC404200/TDC974H $ 456 ea Petrol/Diesel/Bar/Winch







COIL SPRINGSTDC272SL 2 0-300kg Load $ 135 ea O.E Height

TDC272 2 0-300kg Load $ 135 ea 40mm Lift





TW040/14 1 Suiits Rear Bottom Eye $ 6 ea Eyering Bush


53P: (02) 9672 8899 | F: (02) 9672 8099


MY13 On8-14 OnMU-X

ISUZU


AssemblyIncludes


ANY

(Foam FrontGas Rear)

$ 1316

ANY

(Foam Cell All)$ 1388


StrutsIncludes


ANY

(Foam FrontGas Rear)

$ 1462

ANY

(Foam Cell All)$ 1534


AssemblyIncludes


ANY $ 1574


StrutsIncludes


ANY $ 1720






XJ Limited, Sport4/94-01CHEROKEEJEEP



FC41241 2 41mm Foam Cell Shock $ 176 eaSuits OE Height


FC41249 2 41mm Foam Cell Shock $ 176 eaSuits 35mm Lift


LEAF SPRINGSFS025H 2 0-300kg Load $ 285 ea 35mm Lift

COMPONENTSTDUK-027 1 Urethane Shackle Bushes $ 212 ea

TDUB-027 2 U-bolt Kit $ 31 ea

TDSP-002 1 Transmission Spacer $ 98 ea


404702 1 Suits Bottom Rear Eye $ 3 ea Eyering Bushing

Bar Pin Style Bushings are not User Servicable - Contact 4Way Suspension for Replacement Service



9 Stage Adjustable ANY $ 2040

Includes2 x Coil Springs 4 x Shocks2 x Leaf Springs 2 x U-Bolts

1 x Urethane kit 1 x Transmission Spacer





COIL SPRINGSTDC333 2 35mm Lift $ 135 ea Petrol/Diesel/Bar

TDC352 2 35mm Lift $ 135 ea Petrol/Diesel/Bar/Winch

STEERING DAMPERSSS5922-P/S 1 Return to Centre Damper $ 175 ea Power Steering

SV5922 1 9 Stage Adjustable Damper $ 207 ea


Note: Transmission spacer fitting instructions availableat toughdog.com.au

55P: (02) 9672 8899 | F: (02) 9672 8099



30mm

REAR SUSPENSION

WG, WJ - 6/99-05ZG - 4/96-99

GRAND CHEROKEEJEEP


BM401068 2 40mm Adjustable Shock $ 207 ea 9 Stage Adjustable

COIL SPRINGSTDC358 2 40mm Lift Spring $ 135 ea 30mm Lift-ZG 4/96-99 ONLY

TDC360 2 40mm Lift Spring $ 135 ea 30mm Lift-WG, WJ 6/99-05 ONLY

STEERING DAMPERSSS5922-P/S 1 Return to Centre Damper $ 175 ea

ZG 4/96-99 ONLYSV5922 1 9 Stage Adjustable Damper $ 207 ea

SS5924-P/S 1 Return to Centre Damper $ 175 eaWG, WJ 6/99-05 ONLY


SHOCK ABSORBERSFC41444 2 41mm Foam Cell Shock $ 176 ea ZG 4/96-99 ONLY

Suits up to 30mm LiftBM401444 2 40mm 9 Stage Adjustable $ 207 ea

FC41190 2 41mm Foam Cell Shock $ 176 ea WG, WJ 6/99-05 ONLYSuits up to 30mm LiftBM401190 2 40mm 9 Stage Adjustable $ 207 ea

COIL SPRINGSTDC359 2 0-300kg Load $ 135 ea 30mm Lift-ZG 4/96-99 ONLY

TDC361 2 0-300kg Load $ 135 ea 30mm Lift-WG, WJ 6/99-05 ONLY


41mm Foam Cell Any $ 1244

9 Stage Adjustable Any $ 1368



404702 1 Suits Top Rear Eye (ZG) $ 3 ea Eyering Bushing


PART NO. QTY DESCRIPTION RRP inc GST NOTESESTIMATED LIFT:FRONT SUSPENSION




ESTIMATED LIFT:


45mm

REAR SUSPENSION

TJ10/96-07WRANGLERJEEP

SHOCK ABSORBERSBD1063T 2 35mm Nitro Gas Shocks $ 140 ea

Suits OE HeightBM401063 2 40mm Adjustable Shock $ 207 ea

BD1068T 2 35mm Nitro Gas Shocks $ 140 eaSuits 45mm Lift

BM401068 2 40mm Adjustable Shock $ 207 ea

COIL SPRINGSTDC354 2 40mm Lift Spring $ 135 ea Suits up to Bullbar (45mm Lift)

STEERING DAMPERSSS5922-P/S 1 Return to Centre Damper $ 175 ea Power Steering


TRANSMISSION SPACERSTDSP-001 1 Transmission Spacer $ 98 ea Man & Auto - 10/96-03 ONLY

TDSP-005 1 Transmission Spacer $ 104 ea Auto - 03-07 ONLY

TDSP-006 1 Transmission Spacer $ 98 ea Manual - 03-07 ONLY

SHOCK ABSORBERSBD1443T 2 35mm Nitro Gas Shocks $ 140 ea

Suits OE HeightBM401443 2 40mm Adjustable Shock $ 207 ea

BD1461T 2 35mm Nitro Gas Shocks $ 140 eaSuits 45mm Lift



SHOCK & SPRING SPACER RRP inc GST CONTENTS COMPLETE KIT PRICE REFERENCE

35mm Nitro GasAny Spring

TDSP-001 $ 1198

TDSP-005 $ 1204

TDSP-006 $ 1198

9 Stage AdjustableAny Spring

TDSP-001 $ 1466

TDSP-005 $ 1472

TDSP-006 $ 1466


1 x Transmission Spacer




57P: (02) 9672 8899 | F: (02) 9672 8099


40 mm

JK3/07 On

WRANGLERJEEP


ESTIMATED LIFT:


REAR SUSPENSION

SHOCK ABSORBERSBM401069 2 40mm Adjustable Shock $ 207 ea Suits up to 40mm Lift

COIL SPRINGSTDC331 2 40mm Lift Spring $ 135 ea Petrol SWB - Up to bullbar

TDC332 2 40mm Lift Spring $ 135 ea Petrol SWB - Bullbar & Winch

TDC337 2 40mm Lift Spring $ 135 ea Petrol LWB - Up To Bullbar

TDC338 2 40mm Lift Spring $ 135 ea Petrol LWB - Bullbar & Winch

TDC332 2 40mm Lift Spring $ 135 ea Diesel SWB - Up to Bullbar

TDC338 2 40mm Lift Spring $ 135 ea Diesel SWB - Bullbar & Winch

TDC338 2 40mm Lift Spring $ 135 ea Diesel LWB - Up to Bullbar

TDC342 2 40mm Lift Spring $ 135 ea Diesel LWB - Bullbar & Winch

STEERING DAMPERSSV5926 1 9 Stage Adjustable Damper $207 ea instructions at toughdog.com.au

PANHARD RODSTDPR-017 1 Adjustable Panhard Rod $ 310 ea

SHOCK ABSORBERSBM401463 2 40mm 9 Stage Adjustable Shock $ 207 ea Suits 40mm Lift

COIL SPRINGSTDC340 2 0-300kg Load $ 135 ea 40mm Lift (suits SWB only)

TDC339 2 CONSTANT 300Kg Load SWB $ 135 ea 40mm Lift (also 0-300kg for LWB)

TDC341 2 CONSTANT 300Kg Load LWB $ 135 ea 40mm Lift


9 Stage Adjustable Any $ 1368



4W-SPF420-04 1 Suits Bottom Front Eyering $ 6 ea Eyering Bushing

Bar Pin Style Bushings (rear) are not User Servicable - Contact 4Way Suspension for Replacement Service




ESTIMATED LIFT:


No Springs Avail.

REAR SUSPENSION

SERIES I, II, IIA & III53-8380, 88 SWB, 109 LWBLAND ROVER

SHOCK ABSORBERSBD2000T 2 35mm Nitro Gas Shocks $ 140 ea Suits up to 50mm Lift

FC42000 2 41mm Foam Cell Shocks $ 176 ea Suits up to 50mm Lift

STEERING DAMPERSEXT5000 1 H/Duty Steering Damper $ 140 ea Suits SI, II, IIA & III

SS5000-M/S 1 Return to Centre Damper $ 175 ea Suits Series I ONLY

SV5000 1 9 Stage Adjustable Damper $ 207 ea Suits SII, IIA, III ONLY

SHOCK ABSORBERSBD3005T 2 35mm Nitro Gas Shocks $ 140 ea Suits ‘53-83 SI, II, IIA, III SWB

And ‘53-58 SI LWBFC43005 2 41mm Foam Cell Shock $ 176 ea

BD1399T 2 35mm Nitro Gas Shocks $ 135 eaSuits ‘58-83 SII, III LWB

FC41399 2 41mm Foam Cell Shock $ 170 ea

QUANTITY PER SHOCK4W-SPF390 2 Suits Top & Bottom Front Eye $ 4 ea Eye Ring Bushing

4W-SPF390 2 Suits Top & Bottom Rear Eyering $ 4 ea Eyering Bushing for #3005 shocks

4W-SPF390 1 Suits Top Eye Mount $ 4 ea Eyering Busing for #1399 shocks

TW959 2 Suits Bottom Rear Pin Mount $ 3 ea Pin Bushing for #1399 shocks

59P: (02) 9672 8899 | F: (02) 9672 8099


30 mm

110 COUNTY ONLY11/84-91

DEFENDERLAND ROVER


ESTIMATED LIFT:


REAR SUSPENSION

SHOCK ABSORBERSFC41049 2 41mm Foam Cell Shocks $ 176 ea Suits up to 30mm Lift

BM401049 2 40mm Adjustable Shock $ 207 ea Suits up to 30mm Lift

BMX1049/2 2 45mm Adjustable Shock $ 285 ea Suits up to 30mm Lift

TDR1049B 2 53mm ‘Ralph’ Shock $ 285 ea Suits up to 30mm Lift

COIL SPRINGSTDC511 2 30mm Lift Spring $ 135 ea Suits Petrol with Bar

TDC513 2 30mm Lift Spring $ 135 ea Suits Diesel with Bar

TDC508H 2 30mm Lift Spring $ 135 ea Suits All with bar & Winch

STEERING DAMPERSEXT5009 1 H/Duty Steering Damper $ 140 ea

SS5009-P/S 1 Return to Centre Damper $ 175 ea


PANHARD RODSTDPR-002 1 Panhard Rod (14mm Sleeve) $ 250 ea Up to Chassis #2A626645

TDPR-018 1 Panhard Rod (16mm Sleeve) $ 250 ea Up to Chassis #2A626646


BM401397 2 40mm Adjustable Shock $ 207 ea Fit this part number if the lower rubber bushes are conical in shape & fit into a metal housing.

BMX1397/2 2 45mm Adjustable Shock $ 285 ea

TDR1397B 2 53mm ‘Ralph’ Shock $ 285 ea


BM401398 2 40mm Adjustable Shock $ 207 ea Fit this part number if the lower rubber bushes are flat & approx.

45mm in diameterBMX1398/2 2 45mm Adjustable Shock $ 285 ea

TDR1398 2 53mm ‘Ralph’ Shock $ 285 ea


TDC512HH 2 CONSTANT 300Kg Load $ 165 ea 30mm Lift


QUANTITY PER SHOCKTW957 4 Suits Top & Bottom Front Pin $ 4 ea

TW967 2 Suits Bottom Rear Pin $ 4 ea Pin Style Bushing #1397 Shocks

415024 1 Suits Top Rear Eye $ 4 ea Eyering Bushing #1397 Shocks

ADJ00191 1 Suits Top Rear Eye $ 4 ea Eyering Bushing #1398 Shocks


FOR COMPLETE KIT PRICING REFERENCE PLEASE USELAND ROVER DEFENDER 90-130 SERIES ON NEXT PAGE





90, 110, 130 Series92 OnDEFENDERLAND ROVER


REAR SUSPENSION





COIL SPRINGSTDC505 2 30mm Lift Spring $ 135 ea Suits 90 S Petrol with Bar

TDC535 2 30mm Lift Spring $ 135 eaSuits 90 S Petrol Bar/Winch Or Dies with Bar

TDC504 2 30mm Lift Spring $ 135 ea Suits 90 Series with Bar & Winch

TDC520 2 30mm Lift Spring $ 135 ea Suits 110, 130 with Bar

TDC514 2 30mm Lift Spring $ 135 ea Suits 110, 130 with Bar & Winch





TDPR-018 1 Panhard Rod (16mm Sleeve) $ 250 ea Up to Chassis #2A626646









COIL SPRINGSTDC518 2 0-300kg Load $ 135 ea 30mm Lift - Suit 90s SWB

TDC518H 2 CONSTANT 300Kg Load $ 135 ea 30mm Lift - Suit 90s SWB

TDC504 2 CONSTANT 500Kg Load $ 135 ea 30mm Lift - Suit 90s SWB

TDC536 2 0-300kg Load $ 165 ea 30mm Lift - Suit 110s

TDC523 2 0-500kg Load $ 185 ea 30mm Lift - Suit 130s LWB

TDC522H 2 CONSTANT 500Kg Load $ 216 ea 30mm Lift - Suit 130s LWB

FOR REPLACEMENT BUSHING PART NUMBERS, PLEASE SEELAND ROVER DEFENDER 110 COUNTY ON PAGE 58

61P: (02) 9672 8899 | F: (02) 9672 8099


90, 110, 130 Series92 On

DEFENDERLAND ROVER

41mm Foam Cell

$ 135 Coil(Front & Rear)

$ 1244

$ 165 Rear Coil $ 1304

Includes2x Front shocks2x Rear Shocks2x Front Coils2x Rear Coils

$ 185 Rear Coil $ 1344

$ 216 Rear Coil $ 1406

40mm Adjustable


$ 1368

$ 165 Rear Coil $ 1428


$ 185 Rear Coil $ 1468

$ 216 Rear Coil $ 1530

45mm Big BoreAdjustable


$ 1680

$ 165 Rear Coil $ 1740


$ 185 Rear Coil $ 1780

$ 216 Rear Coil $ 1842

53mm ‘Ralph’Big Bore


$ 1680

$ 165 Rear Coil $ 1740


$ 185 Rear Coil $ 1780

$ 216 Rear Coil $ 1842






SERIES I4/91-99DISCOVERYLAND ROVER


REAR SUSPENSION





COIL SPRINGSTDC505 2 30mm Lift Spring $ 135 ea Suits All with Bar

TDC504 2 30mm Lift Spring $ 135 ea Suits All with Bar & Winch


SS5000-P/S 1 Return to Centre Damper $ 175 ea Power Steering













QUANTITY PER SHOCKTW967 2 Suits Bottom & Top Front Pin $ 4 ea Pin Style Bushing #1397 Shocks

415024 1 Suits Top Front Eye $ 4 ea Eyering Bushing #1397 Shocks

ADJ00191 1 Suits Top Rear Eye $ 3 ea Eyering Bushing #1398 Shocks


TW957 4 Suits Front Shock Top & Bottom $ 4 ea Pin Style Bushing #1049 Shocks

63P: (02) 9672 8899 | F: (02) 9672 8099


SERIES I4/91-99

DISCOVERYLAND ROVER

41mm Foam Cell

ANY $ 1244Includes2x Front shocks2x Rear Shocks2x Front Coils2x Rear Coils

40mm Adjustable


45mm Big BoreAdjustable









SERIES III (4/05-2009)SERIES II (3/99 - 4/05)DISCOVERYLAND ROVER

REAR SUSPENSION

SHOCK ABSORBERSFC41043 2 41mm Foam Cell Shock $ 176 ea Suits up to 35mm Lift (S2 ONLY)

BM401043 2 40mm Adjustable Shock $ 207 ea Suits up to 35mm Lift (S2 ONLY)

COIL SPRINGSTDC530 2 35mm Lift Spring $ 135 ea Suits S2 with Bar

TDC530H 2 35mm Lift Spring $ 135 ea Suits S2 with Bar & Winch

TDC545 2 40mm Lift Spring $ 135 ea Suits S3 with Bar

TDC545H 2 40mm Lift Spring $ 135 ea Suits S3 with Bar & Winch

STEERING DAMPERSEXT5003 1 H/Duty Steering Damper $ 140 ea (S2 ONLY)

SS5003-P/S 1 Return to Centre Damper $ 175 ea (S2 ONLY) Power Steering

SV5003 1 9 Stage Adjustable Damper $ 207 ea (S2 ONLY)

SHOCK ABSORBERSFC41396 2 41mm Foam Cell Shock $ 176 ea Suits up to 35mm Lift (S2 ONLY)

BM401396 2 40mm Adjustable Shock $ 207 ea Suits up to 35mm Lift (S2 ONLY)

COIL SPRINGSTDC508 2 0-300kg Load $ 135 ea 35mm Lift (S2 ONLY)

TDC508H 2 CONSTANT 300Kg Load $ 135 ea 35mm Lift (S2 ONLY)

TDC546 2 0-300kg Load $ 165 ea 40mm Lift (S3 ONLY)

TDC546H 2 CONSTANT 300Kg Load $ 165 ea 40mm Lift (S3 ONLY)

PLEASE TAKE CAREFUL NOTE OF PARTS SUITABILITY FOR SERIES II AND SERIES IIISERIES II PARTS ARE NOT COMPATIBLE WITH SERIES III VEHICLES


41mm Foam CellAll $ 135 Coils $ 1244

$ 165 Rear Coils $ 1304

9 Stage AdjustableAll $ 135 Coils $ 1368

$165 Rear Coils $ 1428


65P: (02) 9672 8899 | F: (02) 9672 8099


NON AIR SUSPENSION6/72-4/95

RANGE ROVERLAND ROVER


REAR SUSPENSION

SHOCK ABSORBERSFC41049 2 41mm Foam Cell Shock $ 176 ea Suits up to 35mm Lift

BM401049 2 40mm Adjustable Shock $ 207 eaSuits all models withoutAir Suspension (6/72-94)



COIL SPRINGS (Non Air Suspension Models Only)TDC501 2 O.E Height Spring $ 135 ea Suits Petrol with Bar

TDC505 2 35mm Lift Spring $ 135 ea Suits Diesel with Bar

TDC504 2 35mm Lift Spring $ 135 ea Suits All with Bar & Winch





TDPR-018 1 Panhard Rod (16mm Sleeve) $ 250 ea


BM401398 2 40mm Adjustable Shock $ 207 eaSuits all models withoutAir Suspension (6/72-94)



COIL SPRINGSTDC502 2 0-300kg Load $ 135 ea Suits OE Height Only


TDC508 2 CONSTANT 300Kg Load $ 135 ea 35mm Lift


35 mmESTIMATED LIFT:



9 Stage Adjustable ANY $ 1368

9 Stage Adjustable45mm Big Bore

ANY $ 1680

53mm ‘Ralph’ ANY $ 1680


FRONT SUSPENSION

FOR REPLACEMENT BUSHING PART NUMBERS, PLEASE SEELAND ROVER DEFENDER 110 COUNTY ON PAGE 53




ESTIMATED LIFT: AIR SYSTEM

WITH AIR SUSPENSION5/95-00RANGE ROVERLAND ROVER


BM401008 2 40mm Adjustable Shock $ 207 eaSuits all models with

Air Suspension (5/95-00)BMX1008/2 2 45mm Adjustable Shock $ 285 ea







FC41397 2 41mm Foam Cell Shock $ 176 ea Suits up to 35mm Lift

BM401397 2 40mm Adjustable Shock $ 207 eaSuits all models with

Air Suspension (5/95-00)BMX1397/2 2 45mm Adjustable Shock $ 285 ea



TW957 2 Suits Top & Bottom Front Pin $ 3 ea Pin Style Bushing #1008 Shocks

415024 1 Suits Top Rear Eye $ 4 ea Eyering Bushing #1397 Shocks


67P: (02) 9672 8899 | F: (02) 9672 8099


ALL7/93-96NIVA

LADA


COIL SPRINGSTDC402 2 25mm Lift Spring $ 135 ea All Applications

REAR SUSPENSION


TW959 4 Suits Top Front Pin $ 3 ea Pin Style Bush

412773 1 Suits Bottom Front Eye $ 6 ea Eyering Bush

404702 1 Suits Top Rear Eye $ 3 ea Eyering Bush

4W-SPF420-02 1 Suits Bottom Rear Eye $ 6 ea Eye Style Bus

PART NO. QTY DESCRIPTION RRP inc GST NOTES25 mmESTIMATED LIFT:FRONT SUSPENSION


COIL SPRINGSTDC403 2 25mm Lift Spring $ 135 ea All Applications


35mm Nitro Gas ANY $ 1100





ESTIMATED LIFT:

PC, PD, PE, PG, PH5/87-10/06B2500, B2600MAZDA

40mm







FS367 2 CONSTANT 300Kg Load $ 210 ea 40mm Lift



QUANTITY PER SHOCKTW959 + TW961 1 (ea) Suits Top Front Pin $ 3 ea Pin Style Bushing

412772 1 Suits Bottom Front & Rear Eye $ 6 ea Eyering Bushing






TDSK-020 1 Shock Mount Strengthening Kit $ 90 ea Top Pin Mount Bracket






0-300KG $ 1308





0-300KG $ 1442


Includes2 x Leaf Springs 4 x Shocks 1 x Urethane Kits

2 x U-Bolt Kits1 x Shock Strengthening Kit


69P: (02) 9672 8899 | F: (02) 9672 8099


B2500, B300011/06-10/11

BT-50MAZDA














TDUB-040 2 U-Bolt Kit $ 31 ea Suits FS368C only

TDUB-039 2 U-Bolt Kit $ 31 ea Suits FS368L only






0-300KG $ 1439Includes

2 x Leaf Springs4 x Shocks

1 x Urethane Kit2 x U-Bolt Kits

1 x Shock Mount Kit41mm Foam Cell

0-300KG $ 1511



0-300KG $ 1573



Replacement bushes listed on p 26




ESTIMATED LIFT:


40mm

REAR SUSPENSION

MY11 On11/11 OnBT-50MAZDA









REPLACEMENT STRUT TOPMAZ-4051 2 Strut Top $73 ea Replacement Strut Top

SHOCK ABSORBERSBD1232T 2 35mm Nitrogen Gas Shock $ 140 ea Up to 40mm Lift (Comfort Use)



















71P: (02) 9672 8899 | F: (02) 9672 8099


MY11 On11/11 On

BT-50MAZDA


AssemblyIncludes





$ 1740


$ 1812


$ 1923


$ 1983


StrutsIncludes




$ 1886


$ 1958


$ 2068


$ 2128


AssemblyIncludes




FS369C0-300KG

$ 1998


$ 2108


$ 2168


StrutsIncludes



FS369C0-300KG

$ 2144


$ 2254


$ 2314






ESTIMATED LIFT:


35mm

REAR SUSPENSION

X250D/X350D2017 OnX-CLASS UTEMERCEDES-BENZ

SHOCK ABSORBERSFC41369 2 41mm Foam Cell Shock $ 176 ea Up to 35mm Lift

BM401369 2 40mm 9 Stage Adjustable $ 207 ea Up to 35mm Lift



TDC774VHL 2 CONSTANT 500Kg Load $ 165 ea 35mm Lift

COMPONENTSTDPR-300 1 Adjustable Panhard Rod $ 240 ea


QUANTITY PER SHOCKNIS-3030 1 Replacement Strut Top $ 73 ea Available As Complete Unit Only

ADJ300/40 1 Suits Bottom Front Eyering $ 6 ea Eyering Bonded Bushing

404702 1 Suits Rear Top Eyering $ 6 ea Eyering Bushing

TW040/14 1 Suits Rear Bottom Eyering $ 6 ea Eyering Bushing



COIL SPRINGSTDC1008 2 35mm Lift Spring $ 135 ea Suits vehicles with no accessories

TDC1009 2 35mm Lift Spring $ 135 ea Suits with Bar or Bar+Winch

COMPLETE STRUT ASSEMBLYMER-001 2 BM404925/TDC1008 $ 518 ea Diesel with no accessories

MER-002 2 BM404925/TDC1009 $ 518 ea Diesel Bar or Bar+Winch

MER-003 2 FC404925/TDC1008 $ 456 ea Diesel with no accessories

MER-004 2 FC404925/TDC1009 $ 456 ea Diesel Bar or Bar+Winch

REPLACEMENT STRUT TOPNIS-3030 2 Strut Top $73 ea Replacement Strut Top

73P: (02) 9672 8899 | F: (02) 9672 8099


X250D/X350D2017 On

X-CLASS UTEMERCEDES-BENZ


Assembly

TDC0-300KG Spring

$ 1388

TDCCONSTANT 300KG

Spring$ 1388Includes

2x Front Struts2x Rear Shocks2x Front Coils2x Rear Coils

TDCCONSTANT 500KG

Spring$ 1448


Struts

TDC0-300KG Spring

$ 1534

TDCCONSTANT 300KG


2x Front Strut Assembly2x Rear Shocks

2x Rear Coils TDCCONSTANT 500KG

Spring$ 1594

40mm AdjustableStruts Require

Assembly

TDC0-300KG Spring

$ 1574

TDCCONSTANT 300KG



TDCCONSTANT 500KG

Spring$ 1634

40mm AdjustableComplete Assembly

Struts

TDC0-300KG Spring

$ 1720

TDCCONSTANT 300KG

Spring$ 1720

Includes2x Front Strut Assembly

2x Rear Shocks2x Rear Coils TDC


$ 1780





ESTIMATED LIFT:


REAR SUSPENSION

35mm

PA - LEAF REAR3/98-00CHALLENGERMITSUBISHI








COMPONENTSTDSK-023 1 Anti inversion bracket kit $ 26 Must be fitted with all leaf springs

TDUK-066/31 1 Urethane Shackle Bushing Kit $ 114 ea



412772 1 Suits Bottom Front Eye $ 6 ea Eyering Bonded Bushing




0-300KG $ 1314



0-300KG $ 1448

Includes2 x Leaf Springs 4 x Shocks 1 x Urethane Kit

2 x U-Bolt Kits 1 x Anti Inversion Kit


75P: (02) 9672 8899 | F: (02) 9672 8099


PA II - COIL REAR8/00-08

CHALLENGERMITSUBISHI


REAR SUSPENSION







TDC632SL 2 CONSTANT 300Kg Load $ 135 ea 35mm Lift


412772 1 Suits Bottom Front Eye $ 6 ea Eyering Bonded Bushing

404702 1 Suits Top Rear Eyering $ 3 ea Eyering Bushing

TW038/16 1 Suits Bottom Rear Eye $ 6 ea




0-300KG $ 1036



PART NO. QTY DESCRIPTION RRP inc GST NOTESESTIMATED LIFT: 35 mmFRONT SUSPENSION




ESTIMATED LIFT:


25mm

REAR SUSPENSION

MY10, 11LS & XLS09-2015PB CHALLENGER/PAJERO SPORTMITSUBISHI





COMPLETE STRUT ASSEMBLYMIT-060/01 2 BM404800/TDC670 $ 528 ea Petrol/Diesel/Bar

MIT-060/02 2 BM404800/TDC670H $ 528 ea Petrol/Diesel/Bar/Winch

MIT-060/03 2 FC404800/TDC670 $ 466 ea Petrol/Diesel/Bar

MIT-060/04 2 FC404800/TDC670H $ 466 ea Petrol/Diesel/Bar/Winch

REPLACEMENT STRUT TOPMIT-4040 2 Strut Top $83 ea Replacement Strut Top

SHOCK ABSORBERSFC41440B 2 41mm Foam Cell Shock $ 176 ea Suits Up to 25mm Lift


COIL SPRINGSTDC636L 2 0-300kg Load $ 135 ea 25mm Lift

TDC636HL 2 CONSTANT 300Kg Load $ 135 ea 25mm Lift

Use of CONSTANT load spring without load will result in tailshaft vibrations.

QUANTITY PER SHOCKMIT-4040 1 Replacement Strut Top $ 83 ea Available As Complete Unit Only



TW038/16 1 Suits Bottom Rear Eye $ 6 ea Eyering Bushing

77P: (02) 9672 8899 | F: (02) 9672 8099


MY10. 11LS & XLS09 On

PB CHALLENGER/PAJERO SPORTMITSUBISHI


Assembly

ANY $ 1388

Includes2x Front Struts2x Rear Shocks4x Coil Springs


Struts

ANY $ 1554

Includes2x Front Strut Assy

2x Rear Shocks2x Rear Coils


Assembly

ANY $ 1574



Struts

ANY $ 1740







ESTIMATED LIFT:


REAR SUSPENSION

40mm

MA, MB, MC, MD5/79-86L200 4WDMITSUBISHI

TORSION BARS4WTB-1726 1 Replacement Torsion Bars $ 290 pr 26mm/1277.5mm








COMPONENTSTDUK-021/35 1 Urethane Shackle Bushing Kit $ 88 ea


QUANTITY PER SHOCK404702 2 Suits Top & Bottom Rear Eyering $ 3 ea Eyering Bushing

79P: (02) 9672 8899 | F: (02) 9672 8099


SC, SD, SE, SF, SG, SH4/83-94

L300 4WDMITSUBISHI

REAR SUSPENSION

SHOCK ABSORBERSBD2058T 2 35mm Nitro Gas Shock $ 140 ea


TORSION BARS4WTB-1726 1 Replacement Torsion Bars $ 290 pr 26mm/1277.5mm - SC, SD, SE



Suits OE HeightSC, SD, SE (5/83-86) ONLYFC41366 2 41mm Foam Cell Shock $ 176 ea


BD1382T 2 35mm Nitro Gas Shock $ 140 eaSuits 40mm LiftSC, SD, SE (5/83-86) ONLY



BD1386T 2 35mm Nitro Gas Shock $ 140 eaSuits OE HeightSF, SG, SH (10/86-94) ONLY



BD1400T 2 35mm Nitro Gas Shock $ 140 eaSuits 40mm LiftSF, SG, SH (10/86-94) ONLY



COMPONENTSTDUK-005 1 Urethane Shackle Bushing Kit $ 68 ea 35mm Lift

TDUB-006 2 U-Bolt Kit $ 31 ea 35mm Lift



TW959 2 Suits Top Front Pin $ 3 ea Pin Style Mount

404702 2 Suits Top & Bottom Rear Eyering $ 3 ea Eyering Bushing (#1366 & #1382)

404702 1 Suits Top & Bottom Rear Eyering $ 3 ea Eyering Bushing (#1386 & #1400)

TW959 2 Suits Bottom Rear Pin $ 3 ea Pin Style Mount (#1386 & #1400)

412772 1 Suits Bottom Front Eyering $ 6 ea Eyering Bushing (#42057B)

FRONT SUSPENSION ESTIMATED LIFT: 40 mm




ESTIMATED LIFT:


REAR SUSPENSION

40mm

LEAF REAR7/83-91 (NA-NG) & 5/91-96PAJERO / MONTEROMITSUBISHI

SHOCK ABSORBERSFC42058B 2 41mm Foam Cell Shock (bar pin) $ 176 ea 40mm Lift (7/83-91 ONLY)

FC42057B 2 41mm Foam Cell Shock (sleeve) $ 176 ea 40mm Lift (5/91-96 ONLY)



STEERING DAMPERSSS5013-P/S 1 Return to Centre Damper $ 210 ea Damper Mounts Present in Vehicle

SS5016-P/S 1 Return to Centre Damper $ 250 ea Mounts Not Present in Vehicle











412772 1 Suits Bottom Front Eyering $ 6 ea Eyering Bushing (#2057B ONLY)



CONSTANT 300KG $ 1350


0-300KG $ 1376





81P: (02) 9672 8899 | F: (02) 9672 8099


COIL REAR8/88-91 (NF-NG) & 5/91-00 (NH-NL

PAJERO / MONTEROMITSUBISHI



FC41439 2 41mm Foam Cell Shock $ 176 ea Up to 40mm Lift (7/88-91 ONLY)

BM401439 2 40mm 9 Stage Adjustable $ 207 ea Up to 40mm Lift (7/88-91 ONLY)

FC41170B 2 41mm Foam Cell Shock $ 176 ea Suits OE Height (5/91-00 ONLY)

BM401170 2 40mm 9 Stage Adjustable $ 207 ea Suits OE Height (5/91-00 ONLY)

FC41178B 2 41mm Foam Cell Shock $ 176 ea Up to 40mm Lift (5/91-00 ONLY)

BM401178 2 40mm 9 Stage Adjustable $ 207 ea Up to 40mm Lift (5/91-00 ONLY)

COIL SPRINGSTDC632SL 2 0-300kg Load $ 135 ea 40mm Lift



412772 1 Suits Bottom Front Eye $ 3 ea Eyering Bushing (#2057B)

402267 2 Suits Top Pin Mount Rear $ 3 ea Eyering Bushing (#1170 & 78)


PART NO. QTY DESCRIPTION RRP inc GST NOTESESTIMATED LIFT: 40 mm

SHOCK ABSORBERSFC42058B 2 41mm Foam Cell Shock $ 176 ea 40mm Lift (7/88-91 ONLY)

FC42057B 2 41mm Foam Cell Shock $ 176 ea 40mm Lift (5/91-00 ONLY)


4WTB-0203 1 Replacement Torsion Bars $ 310 pr 27.5mm/1307mm (NH, NJ, NK)

Check bars first! - Adjust torsion bars after fitting shocks - Ensure a minimum of 60mm Droop is Maintained

STEERING DAMPERSSS5013-P/S 1 Return to Centre Damper $ 210 ea Damper Mounts Present in Vehicle

SS5016-P/S 1 Return to Centre Damper $ 250 ea Mounts Not Present in Vehicle



0-300KG $ 1036


FRONT SUSPENSION




ESTIMATED LIFT:


40mm

REAR SUSPENSION

NM onwards (LWB)5/00 onPAJERO / MONTEROMITSUBISHI



COIL SPRINGSTDC631 2 OE Height Spring $ 135 ea

TDC633 2 40mm Lift Spring $ 135 ea Petrol/Bar

TDC633L 2 40mm Lift Spring $ 135 ea Diesel/Bar


COMPLETE STRUT ASSEMBLYMIT-050/01 2 BM404300/TDC633 $ 528 ea PetrolBar

MIT-050/02 2 BM404300/TDC633L $ 528 ea Diesel/Bar


MIT-050/04 2 FC404300/TDC633 $ 466 ea PetrolBar

MIT-050/05 2 FC404300/TDC633L $ 466 ea Diesel/Bar


REPLACEMENT STRUT TOPMIT-4038 2 Strut Top $ 83 ea Replacement Strut Top


COIL SPRINGSTDC635S 2 0-300kg Load $ 165 ea OE Height

TDC635 2 CONSTANT 300Kg Load $ 165 ea OE Height



TDC635HH 2 CONSTANT 500Kg Load $ 165 ea 40mm Lift

AIR ASSIST BAGSTDAA-006 1 Coil insert bag kit $ 420 ea suits 20mm Lift



TW959 2 Suits Top Rear Pin Style $ 3 ea Pin Style Bushing

TW-038/16 1 Suits Bottom Rear Eyering $ 4 ea Eyering Bushing

83P: (02) 9672 8899 | F: (02) 9672 8099


NM onwards5/00 on



Assembly

ANY $ 1448



Struts

ANY $ 1614



Adjustable FrontFoam Cell RearStruts Require

AssemblyANY $ 1572


Adjustable FrontFoam Cell Rear

Complete Assembly Struts

ANY $ 1738




Note: Front Strut Fitting Instructions available at toughdog.com.au




ESTIMATED LIFT:


40mm

REAR SUSPENSION

NM onwards (SWB)5/00 on - SHORT WHEEL BASEPAJERO / MONTEROMITSUBISHI



COIL SPRINGSTDC631 2 OE Height Spring $ 135 ea

TDC633 2 40mm Lift Spring $ 135 ea Petrol/Bar



COMPLETE STRUT ASSEMBLYMIT-050/01 2 BM404300/TDC633 $ 528 ea PetrolBar



MIT-050/04 2 FC404300/TDC633 $ 466 ea PetrolBar





COIL SPRINGSTDC635S 2 0-300kg Load $ 165 ea 40mm Lift

TDC635 2 CONSTANT 300Kg Load $ 165 ea 40mm Lift




TW959 2 Suits Top Rear Pin Style $ 3 ea Pin Style Bushing

TW-038/16 1 Suits Bottom Rear Eyering $ 4 ea Eyering Bushing

85P: (02) 9672 8899 | F: (02) 9672 8099


NM onwards5/00 on - SHORT WHEEL BASE



Assembly

ANY $ 1448



Struts

ANY $ 1614



Adjustable FrontFoam Cell RearStruts Require

AssemblyANY $ 1572


Adjustable FrontFoam Cell Rear

Complete Assembly Struts

ANY $ 1738




Note: Front Strut Fitting Instructions available at toughdog.com.au





MY16 on2015 OnPAJERO SPORTMITSUBISHI



FC41440B 2 41mm Foam Cell Shock $ 176 ea Suits Up to 20mm Lift




Use of CONSTANT load spring without load will result in tailshaft vibrations.





TW038/16 1 Suits Bottom Rear Eye $ 6 ea Eyering Bushing



COIL SPRINGSTDC681 2 20mm Lift Spring $ 135 ea Diesel


TDC681HL 2 20mm Lift Spring $ 135 ea Diesel/Bar/Winch

COMPLETE STRUT ASSEMBLYMIT-061/01 2 BM404800/TDC681 $ 528 ea Diesel


MIT-061/03 2 BM404800/TDC681HL $ 528 ea Diesel/Bar/Winch

MIT-061/05 2 FC404800/TDC681 $ 466 ea Diesel


MIT-061/07 2 FC404800/TDC681HL $ 466 ea Diesel/Bar/Winch


87P: (02) 9672 8899 | F: (02) 9672 8099


MY16 on2015 on

PAJERO SPORTMITSUBISHI


Assembly

ANY $ 1388



Struts

ANY $ 1554




Assembly

ANY $ 1574



Struts

ANY $ 1740







ESTIMATED LIFT:


REAR SUSPENSION

40mm

ME, MF, MG, MH, MK10/86-06TRITONMITSUBISHI

SHOCK ABSORBERSBD2058T 2 35mm Nitro Gas Shock $ 140 ea Up to 40mm Lift (Up to MK)

BD2057T 2 35mm Nitro Gas Shock $ 140 ea Up to 40mm Lift (MK 10/96-06)

FC42057B 2 41mm Foam Cell Shock $ 176 ea Up to 40mm Lift (MK 10/96-06)


4WTB-1736 1 Replacement Torsion Bars $ 290 pr 26mm/1370mm

Check bars first! - Adjust torsion bars after fitting shocks - Ensure a minimum of 60mm Droop is Maintained

SHOCK ABSORBERSBD1388T 2 35mm Nitro Gas Shock $ 140 ea Suits Up to 40mm Lift





Some special edition models equipped with H/Duty leaf packs from factory - Check prior to ordering.

COMPONENTSTDSK-023 1 Anti Inversion Kit $ 26 kit Must be fitted with all leaf springs

TDUK-021/31 1 Urethane Shackle Bushing Kit $ 98 ea




412772 1 Suits Bottom Front Eye $ 6 ea Eyering Bushing (#2057)


89P: (02) 9672 8899 | F: (02) 9672 8099


ME, MF, MG, MH, MK10/86-06

TRITONMITSUBISHI

35mm Nitro Gas


1 X Anti Inversion Bkts

0-300KG Spring $ 1226


$ 1262

41mm Foam Cell



0-300KG Spring $ 1370


$ 1406




0-300KG Spring $ 1432


$ 1468





ESTIMATED LIFT:


25mm

REAR SUSPENSION

ML MN (To MY15)7/06-15TRITONMITSUBISHI

SHOCK ABSORBERSBD1383T 2 35mm Nitro Gas Shocks $ 140 ea Suits Up to 25mm Lift






COMPONENTSTDUK-021/41 1 Urethane Shackle Bushing Kit $ 88 ea Suits OEM Spring ONLY

TDUk-021/31 1 Urethane Shackle Bushing Kit $ 98 ea Suits Tough Dog Spring ONLY





ADJ00300/50 1 Suits Bottom Front Eyering $ 6 ea Eyering Bushing (FC and BM Pts)

402702 2 Suits Top & Bottom Rear Eyering $ 3 ea Eyering Bushing (Foam Cell)

TW038-16 1 Suits Top Rear Eyering $ 6 ea Eyering Bushing (Adjustable)

404702 1 Suits Bottom Rear Eyering $ 3 ea Eyering Bushing (Adjustable)





COMPLETE STRUT ASSEMBLYMIT-060/01 2 BM404800/TDC670 $ 528 ea Petrol/Diesel/Bar


MIT-060/03 2 FC404800/TDC670 $ 466 ea Petrol/Diesel/Bar



91P: (02) 9672 8899 | F: (02) 9672 8099


ML MN (To MY15)7/06-15

TRITONMITSUBISHI


AssemblyIncludes




$ 1606


$ 1678


$ 1692


$ 1738


StrutsIncludes



$ 1772


$ 1844


$ 1858


$ 1904


AssemblyIncludes



FS122C0-300KG

$ 1864


$ 1878


$ 1924


StrutsIncludes


FS122C0-300KG

$ 2030


$ 2044


$ 2090





ESTIMATED LIFT:


20mm

REAR SUSPENSION

MQ (From MY16)01/15 OnTRITONMITSUBISHI

SHOCK ABSORBERSBD3012T 2 35mm Nitro Gas Shocks $ 135 ea Suits Up to 20mm Lift










TDSP-008 1 Centre Bearing Strengthening Kit $ 108 ea Required with all Lift Kits





TW038-16 1 Suits Bottom Rear Eyering $ 6 ea Eyering Bushing



COIL SPRINGSTDC681 2 20mm Lift Spring $ 135 ea Diesel


TDC681HL 2 20mm Lift Spring $ 135 ea Diesel/Bar/Winch

COMPLETE STRUT ASSEMBLYMIT-061/01 2 BM404800/TDC681 $ 528 ea Diesel


MIT-061/03 2 BM404800/TDC681HL $ 528 ea Diesel/Bar/Winch

MIT-061/05 2 FC404800/TDC681 $ 466 ea Diesel


MIT-061/07 2 FC404800/TDC681HL $ 466 ea Diesel/Bar/Winch


93P: (02) 9672 8899 | F: (02) 9672 8099


MQ (From MY16)01/15 On

TRITONMITSUBISHI



AssemblyIncludes



1x Centre Bearing Kit


$ 1749


$ 1831


$ 1907


$ 1967


StrutsIncludes

2x Complete Struts2x Rear Shocks2x Leaf Springs1x Urethane Kit2x U-Bolt Kits



$ 1925


$ 1997


$ 2073


$ 2119


AssemblyIncludes




FS123C0-300KG

$ 2017


$ 2093


$ 2153


StrutsIncludes



FS123C0-300KG

$ 2183


$ 2259


$ 2319

Note: Centre bearing strengthen-ing kit fitting instructions availableat toughdog.com.au




ESTIMATED LIFT:


REAR SUSPENSION

40mm

D21, D221/86-15NAVARANISSAN

SHOCK ABSORBERSFC42052B 2 35mm Foam Cell Shock $ 176 ea Up to 40mm Lift

TORSION BARS4WTB-1456 1 Replacement Torsion Bars $ 260 pr 26mm/1203mm ‘1/86-97 ONLY

4WTB-1446 1 Replacement Torsion Bars $ 260 pr 26mm/890mm ‘97 On ONLY


STEERING DAMPERSSD14035 1 H/D Replacement Damper $ 110 ea Suits D21 Vehicles Only

EXT5925 1 H/D Replacement Damper $ 185 ea Suits D22 Vehicles OnlyFitting instructions found at toughdog.com.au




Suits OE HeightFC41366B 2 41mm Foam Cell Shock $ 176 ea


BD1382T 2 35mm Nitro Gas Shock $ 140 ea

Suits 40mm LiftFC41382B 2 41mm Foam Cell Shock $ 176 ea


LEAF SPRINGST63 2 0-300kg Load $ 190 ea 40mm Lift

T63H 2 CONSTANT 300Kg Load $ 207 ea 40mm Lift






QUANTITY PER SHOCKTW959 2 Suits Front Top Pin $ 3 ea Pin Style Bushing


412773 1 Suits Front Bottom Eye $ 6 ea

95P: (02) 9672 8899 | F: (02) 9672 8099


NISSANNAVARA

1/86-15D21, D22

Foam Cell Front Nitro Gas Rear

T630-300KG Spring

$ 1142

T63HCONSTANT 300KG

Spring$ 1176


41mm Foam CellT63


T63HCONSTANT 300KG

Spring$ 1248



T630-300KG Spring

$ 1276

T63HCONSTANT 300KG

Spring$ 1310






ESTIMATED LIFT:


40mm

REAR SUSPENSION

D40 - 2.5L, 4.0L12/05-15NAVARANISSAN

SHOCK ABSORBERSBD1368T 2 35mm Nitro Gas Shock $ 140 ea Up to 40mm Lift (Comfort Use)

FC41368 2 41mm Foam Cell Shock $ 176 ea Up to 40mm Lift


LEAF SPRINGST85C 2 0-300kg Load $ 260 ea 40mm Lift

T85L 2 CONSTANT 300Kg Load $ 295 ea 40mm Lift

T85LL 2 CONSTANT 500Kg Load $ 315 ea 40mm Lift









TW040-14 1 Suits Rear Bottom Eyering $ 6 ea Eyering Bushing





COMPLETE STRUT ASSEMBLYNIS-040/01 2 BM404700/TDC770 $ 518 ea Petrol/Diesel/Bar

NIS-040/02 2 BM404700/TDC770H $ 518 ea Petrol/Diesel/Bar/Winch

NIS-040/04 2 FC404700/TDC770 $ 456 ea Petrol/Diesel/Bar

NIS-040/05 2 FC404700/TDC770H $ 456 ea Petrol/Diesel/Bar/Winch


97P: (02) 9672 8899 | F: (02) 9672 8099


D40 - 2.5L, 4.0L12/05-15

NAVARANISSAN


AssemblyIncludes



T85C(Foam Front Gas Rear)

$ 1763

T85C(Foam Cell All)

$ 1835

T85LCONSTANT 300KG

$ 1905

T85LLCONSTANT 500KG

$ 1945


StrutsIncludes



$ 1909

T85C(Foam Cell All)

$ 1981

T85LCONSTANT 300KG

$ 2051

T85LLCONSTANT 500KG

$ 2091


AssemblyIncludes



T85C0-300KG

$ 2021

T85LCONSTANT 300KG

$ 2091

T85LLCONSTANT 500KG

$ 2131


StrutsIncludes


T85C0-300KG

$ 2167

T85LCONSTANT 300KG

$ 2237

T85LLCONSTANT 500KG

$ 2277


Note: Urethane Bushing kit fitting

instructions available attoughdog.com.au




ESTIMATED LIFT:


40mm

REAR SUSPENSION

D40 - 3.0L STX-550 V611-15NAVARANISSAN

SHOCK ABSORBERSBD1368T 2 35mm Nitro Gas Shock $ 140 ea Up to 40mm Lift (Comfort Use)
























99P: (02) 9672 8899 | F: (02) 9672 8099


D40 - 3.0L STX-550 V611-15

NAVARANISSAN


AssemblyIncludes




$ 1763

T85C(Foam Cell All)

$ 1835

T85LCONSTANT 300KG

$ 1905

T85LLCONSTANT 500KG

$ 1945


StrutsIncludes



$ 1909

T85C(Foam Cell All)

$ 1981

T85LCONSTANT 300KG

$ 2051

T85LLCONSTANT 500KG

$ 2091


AssemblyIncludes



T85C0-300KG

$ 2021

T85LCONSTANT 300KG

$ 2091

T85LLCONSTANT 500KG

$ 2131


StrutsIncludes


T85C0-300KG

$ 2167

T85LCONSTANT 300KG

$ 2237

T85LLCONSTANT 500KG

$ 2277







ESTIMATED LIFT:


35mm

REAR SUSPENSION

NP300 - Coil Rear Only7/15 OnNAVARANISSAN






COMPONENTSTDPR-300 1 Adjustable Panhard Rod $ 240 ea




TW038-16 1 Suits Rear Top Eyering $ 6 ea Eyering Bushing











101P: (02) 9672 8899 | F: (02) 9672 8099


NP300 - Coil Rear Only7/15 On

NAVARANISSAN


Assembly

TDC7740-300KG Spring

$ 1388

TDC774HCONSTANT 300KG



TDC774VHLCONSTANT 500KG

Spring$ 1448


Struts


$ 1534



2x Front Strut Assembly2x Rear Shocks

2x Rear Coils TDC774VHLCONSTANT 500KG

Spring$ 1594


Assembly


$ 1574




TDC774VHLCONSTANT 500KG

Spring$ 1634


Struts


$ 1720


Spring$ 1720

Includes2x Front Strut Assembly

2x Rear Shocks2x Rear Coils TDC774VHL


$ 1780






REAR SUSPENSION

NP300 - Leaf rear only7/15 onNAVARANISSAN



















REPLACEMENT STRUT TOPNIS-3030 2 Strut Top $ 73 ea Replacement Strut Top


NIS-3030 1 Replacement Strut Top $ 73 ea Available As Complete Unit Only



404702 1 Suits Rear Bottom Eyering $ 4 ea Eyering Bushing

103P: (02) 9672 8899 | F: (02) 9672 8099


NP300 - Leaf rear only7/15 on

NAVARANISSAN


AssemblyIncludes



T86C $ 1730

T86LCONSTANT 300KG

$ 1870

T86LLCONSTANT 500KG

$ 1940


StrutsIncludes


T86C $ 1876

T86LCONSTANT 300KG

$ 2016

T86LLCONSTANT 500KG

$ 2086


AssemblyIncludes



T86C0-300KG

$ 1916

T86LCONSTANT 300KG

$ 2056

T86LLCONSTANT 500KG

$ 2126


StrutsIncludes


T86C0-300KG

$ 2062

T86LCONSTANT 300KG

$ 2202

T86LLCONSTANT 500KG

$ 2272







ESTIMATED LIFT:


REAR SUSPENSION

30mm

WNYD21, WHYD2112/86-95PATHFINDERNISSAN

SHOCK ABSORBERSBD2057T 2 35mm Nitro Gas Shock $ 140 ea Up to 30mm Lift

FC42057B 2 41mm Foam Cell Shock $ 176 ea Up to 30mm Lift



STEERING DAMPERSSD14035 1 H/D Replacement Damper $ 110 ea Suits D21 Vehicles Only







QUANTITY PER SHOCKTW959 2 Suits Top Front Pin Mount $ 3 ea Pin Style Bushing

404702 2 Suits Rear Top & Bottom Eyering $ 3 ea Eyering Bushing



35mm Nitro gas ANY $ 830



ANY $ 1036



105P: (02) 9672 8899 | F: (02) 9672 8099


11/95-99 & 2/99-05 PATHFINDER R50NISSAN


REAR SUSPENSION

SHOCK ABSORBERSBDS4002 (D/S) 1 Twin Tube McPherson Strut $ 280 ea OE Height Suit 11/95-99 ONLY

BDS4003 (P/S) 1 Twin Tube McPherson Strut $ 280 ea OE Height Suit 11/95-99 ONLY

BDS4024 2 Twin Tube McPherson Strut $ 325 ea Suits up to 30mm (all models)

COIL SPRINGSTDC784S 2 OE Height Lift Spring $ 135 ea OE Height only

TDC784 2 30mm Lift Spring $ 135 ea Suits up to Steel Bar

TDC784H 2 30mm Lift Spring $ 135 ea Suits Bar & Winch

SHOCK ABSORBERSBD3009T 2 35mm Nitro Gas Shock $ 140 ea OE Height Suit 11/95-99 ONLY

FC43009 2 41mm Foam Cell Shock $ 176 ea OE Height Suit 11/95-99 ONLY

BD3010T 2 35mm Nitro Gas Shock $ 140 ea 30mm Lift Suit 11/95-99 ONLY

FC43010 2 41mm Foam Cell Shock $ 176 ea 30mm Lift Suit 11/95-99 ONLY

BD3011T 2 35mm Nitro Gas Shock $ 140 ea OE & 30mm 11/99-05 ONLY

FC43011 2 41mm Foam Cell Shock $ 176 ea OE & 30mm 11/99-05 ONLY





35mm Nitrogen Gas30mm Lift $ 1470

OE Height (95-99) $ 1380

Nitrogen Gas FrontFoam Cell Rear

30mm Lift $ 1542

OE Height (99-05) $ 1452

Includes2 x Struts 4 x Coil Springs

2 x Rear Shocks


R50 (Series I, II, III)

FRONT SUSPENSION ESTIMATED LIFT: 30mm




ESTIMATED LIFT:


40mm

REAR SUSPENSION

R51 - 2.5L, 4.0L11/05-15PATHFINDERNISSAN





TDC771XHD 2 CONSTANT 500Kg Load $ 135 ea 40mm Lift













107P: (02) 9672 8899 | F: (02) 9672 8099


R51 - 2.5L, 4.0L11/05-15

PATHFINDERNISSAN


Assembly


$ 1388




TDC771XHDCONSTANT 500KG

Spring$ 1388


Struts


$ 1534



2x Complete Struts2x Rear Shocks

2x Rear Coils TDC771XHDCONSTANT 500KG

Spring$ 1534


Assembly


$ 1574





Spring$ 1574


Struts


$ 1720


Spring$ 1720

Includes2x Complete Struts

2x Rear Shocks2x Rear Coils TDC771XHD


$ 1720

REAR SUSPENSIONSHOCK CHOICE SPRING CHOICE RRP inc GST CONTENTS




ESTIMATED LIFT:


40mm

REAR SUSPENSION

R51 - 3.0L V611/05-15PATHFINDERNISSAN





TDC771XHD 2 CONSTANT 500Kg Load $ 135 ea 40mm Lift












4W-BS101CH 1 Suits top & bottom rear eyering $ 4 ea

109P: (02) 9672 8899 | F: (02) 9672 8099


R51 - 3.0L V611/05-15

PATHFINDERNISSAN


Assembly


$ 1388





Spring$ 1388


Struts


$ 1534



2x Complete Struts2x Rear Shocks

2x Rear Coils TDC771XHDCONSTANT 500KG

Spring$ 1534


Assembly


$ 1574





Spring$ 1574


Struts


$ 1720


Spring$ 1720

Includes2x Complete Struts

2x Rear Shocks2x Rear Coils TDC771XHD


$ 1720

REAR SUSPENSIONSHOCK CHOICE SPRING CHOICE RRP inc GST CONTENTS






9/80-85 MQ, MK

PATROLNISSAN


Suit OE HeightFC41005 2 41mm Foam Cell Shocks $ 176 ea


BD1007T 2 35mm Nitrogen Gas $ 140 ea

Suit 40mm LiftFC41007 2 41mm Foam Cell Shocks $ 176 ea


LEAF SPRINGSBPN-007 2 Petrol/Diesel/Bar $ 217 ea Suits MQ, MK ONLY

BPN-007H 2 Petrol/Diesel/Bar/Winch $ 260 ea Suits MQ, MK ONLY

STEERING STABILIZERSEXT5005 1 H/Duty Replacement Damper $ 140 ea

SS5005-P/S 1 Return to Centre Damper $ 175 ea Suits Power Steering

SS5005-M/S 1 Returbn to Centre Damper $ 175 ea Suits Manual Steering

COMPONENTSTDUK-036 1 Urethane Shackle Bushing Kit $ 47 ea Suits MQ O.E Springs

TDUK-009 1 Urethane Shackle Bushing Kit $ 68 ea Suits MQ, MK with T.D Springs

TDUK-009 Bush Kit must be used when fitting Tough Dog leaf springs to both MQ and MK VehiclesTDUB-009 1 U-Bolt Kit $ 41 ea Suits MQ, MK

TDUB-004 1 U-Bolt Kit $ 31 ea Suits MQ, MK

TDGP-470 1 Greasable pins $ 83 ea

TDGS-355 1 Greasable Shackles $ 124 ea Suits MQ, OE springs

TDGS-665 1 Greasable Shackles $ 124 ea Suits MQ, MK with T.D Springs

TDGS-665 must be fitted when using Tough Dog springs to both MQ and MK VehiclesNAK-005 1 Offset Kingpin $ 260 ea 0.5 Degree

NAK-075 1 Offset Kingpin $ 260 ea 0.75 Degree


QUANTITY PER SHOCKTW959 4 Suits Top & Bottom Front Pin $ 3 ea Pin Style Bushing

111P: (02) 9672 8899 | F: (02) 9672 8099


REAR SUSPENSION

9/80-85 MQ, MK

PATROLNISSAN



Suit OE HeightSuits MQ, MK ONLY

FC41400 2 41mm Foam Cell Shocks $ 176 ea


BD1441T 2 35mm Nitrogen Gas $ 140 eaSuit 40mm LiftSuits MQ, MK ONLY



LEAF SPRINGSBPN-008 2 0-300kg Load $ 310 ea Suits MQ, MK ONLY

BPN-008H 2 CONSTANT 300Kg Load $ 330 ea Suits MQ, MK ONLY

COMPONENTSTDUK-010 1 Urethane Shackle Bushing Kit $ 98 ea Suits MQ, MK

TDUB-010 2 U-Bolt Kit $ 41 ea Suits MQ & MK


TDGS-664 1 Greasable Shackles $ 124 ea Suits MQ, MK


35mm Nitro GasMQ, MK Only

BPN007+BPN008 $ 1934


2 x Urethane Bushing Kits 4 x U-Bolt Kits

BPN007H+BPN008 $ 2020

BPN007+BPN008H $ 1974

BPN007H+BPN008H $ 2060

41mm Foam CellMQ, MK Only

BPN007+BPN008 $ 2078

BPN007H+BPN008 $ 2164

BPN007+BPN008H $ 2118

BPN007H+BPN008H $ 2824


MQ, MK Only

BPN007+BPN008 $ 2202

BPN007H+BPN008 $ 2288

BPN007+BPN008H $ 2242

BPN007H+BPN008H $ 2328







GQ Patrol (Y60) - 2” Lift2/88-98PATROLNISSAN


BM401047 2 40mm 9 Stage Adjustable Shock $ 207 ea Suits up to 50mm Lift

BMX1047/2 2 45mm 9 Stage Adjustable Shock $ 285 ea Suits 50mm Lift ONLY

TDR1047B 2 53mm ‘Ralph’ Big Bore Shock $ 285 ea Suits up to 50mm Lift

COIL SPRINGSTDC731 2 25mm Lift Coil $ 135 ea Suit SWB with Alloy Bar

TDC734SL 2 25mm Lift Coil $ 135 ea Suit LWB up to Bullbar

TDC734HSL 2 25mm Lift Coil $ 135 ea Suit LWB with Bullbar & Winch

TDC734CL 2 50mm Lift Coil $ 135 ea Suit LWB with 2.8L/Alloy Bar

TDC734L 2 50mm Lift Coil $ 135 ea Suit LWB up to Bullbar

TDC734HL 2 50mm Lift Coil $ 135 ea Suit LWB with Bullbar & Winch


Suits 2/88-8/89 GQ ONLYSS5612-P/S 1 Return to Centre Damper $ 176 ea


EXT5613 1 H/Duty Replacement Damper $ 140 ea

Suits 9/89-98 GQ ONLYSS5613-P/S 1 Return to Centre Damper $ 176 ea


CASTER CORRECTIONTDUK-054/2 1 2 Degree Caster Correction Bush $ 207 ea instructions at toughdog.com.au

PANHARD ROD (Check Bushes Prior to Ordering)TDPR-004 1 Adjustable Panhard Rod $ 250 ea Suits GQ

TDPR-014 1 Adjustable Panhard Rod $ 290 ea Suits GQ LHD ONLY

COMPONENTSTDUK-041 1 Front Radius Rod to Chassis $ 68 ea 1 Kit required per vehicle

TDUK-050 1 Front Radius Rod to Diff $ 207 ea 1 Kit required per vehicle

TDUK-051 1 Panhard Rod Bush Kit $ 68 ea 1 Kit required per panhard rod

TDUK-1734/15 1 Urethane Spring Spacer 15mm $ 37 ea 1 required per coil as required






ADJ00191 1 Suits Top Rear Eyering $ 3 ea Eyering Bushing


113P: (02) 9672 8899 | F: (02) 9672 8099


KIT PRICING REFERENCECOMPONENTS AS PER IMAGE

please order using part numbers

REAR SUSPENSION

GQ Patrol (Y60) - 2” Lift2/88-98

PATROLNISSAN


SHOCK ABSORBERS - Fitting BMX? instructions at toughdog.com.auFC41206 2 41mm Foam Cell Shocks $ 176 ea Suits up to 50mm Lift



TDR1206 2 53mm ‘Ralph’ Big Bore Shock $ 285 ea Suits up to 50mm Lift

COIL SPRINGSTDC733 2 25mm Lift 0-300Kg Load $ 135 ea Suit SWB

TDC732SL 2 25mm Lift 0-300Kg Load $ 135 ea Suit LWB

TDC732HSL 2 25mm Lift CONSTANT 300kg $ 135 ea Suit LWB

TDC732CL 2 50mm Lift No Load (Comfort) $ 135 ea Suit LWB

TDC732L 2 50mm Lift 0-300Kg Load $ 135 ea Suit LWB

TDC749HL 2 50mm Lift CONSTANT 300kg $ 165 ea Suit LWB

PANHARD ROD (Check Bushes Prior to Ordering)TDPR-005 1 Adjustable Panhard Rod $ 240 ea Suits GQ

COMPONENTSTDUK-052 1 Trailing Arm Bushing Kit $ 170 ea 2 Kits required Upper & Lower






41mm Foam Cell$135 Rear Coils $ 1244





45mm Big Bore9 Stage Adjustable



53mm Big Bore ‘Ralph’









GU Patrol (Y61) - 2” Lift12/97-2015PATROLNISSAN





COIL SPRINGSTDC734SL 2 25mm Lift Coil $ 135 ea Suit LWB up to Bullbar

TDC734HSL 2 25mm Lift Coil $ 135 ea Suit LWB with Bullbar & Winch

TDC734L 2 50mm Lift Coil $ 135 ea Suit LWB up to Bullbar

TDC734HL 2 50mm Lift Coil $ 135 ea Suit LWB with Bullbar & Winch


Suits 12/97-00 GU ONLYSS5000-P/S 1 Return to Centre Damper $ 176 ea






PANHARD ROD (Check Bushes Prior to Ordering)TDPR-004 1 Adjustable Panhard Rod $ 250 ea Suits GU Utes

TDPR-012 1 Adjustable Panhard Rod $ 290 ea Suits GU Wagon ONLY

TDPR-014 1 Adjustable Panhard Rod $ 290 ea Suits GU Utes LHD ONLY

TDPR-016 1 Adjustable Panhard Rod $ 300 ea Suits GU Wagon LHD ONLY



TDUK-055 1 Panhard Rod Bush (Diff End) $ 37 ea 1 Kit required (diff end only)

TDUK-056 1 Panhard Rod Bush (Chassis End) $ 50 ea 1 Kit required (chassis end only)









115P: (02) 9672 8899 | F: (02) 9672 8099




REAR SUSPENSION

GU Patrol (Y61) - 2” Lift12/97-2015PATROL

NISSAN






COIL SPRINGSTDC742SL 2 25mm Lift 0-300Kg Load $ 135 ea Suit LWB

TDC742HSL 2 25mm Lift CONSTANT 300kg $ 135 ea Suit LWB

TDC742L 2 50mm Lift 0-300Kg Load $ 135 ea Suit LWB

TDC742HL 2 50mm Lift CONSTANT 300kg $ 165 ea Suit LWB

PANHARD ROD (Check Bushes Prior to Ordering)TDPR-005 1 Adjustable Panhard Rod $ 240 ea Suits GU Utes


COMPONENTSTDUK-052 1 Trailing Arm Bushing Kit $ 170 ea 2 Kits required Upper & Lower


TDUK-056 1 Panhard Rod Bush (Chassis End) $ 50ea 1 Kit required (chassis end only)




















ESTIMATED LIFT: 75mm (3”)


2/88-2015PATROLNISSAN

SHOCK ABSORBERSFC41047/3 2 41mm Foam Cell Shocks $ 176 ea Suits 75mm Lift

BM401047/3 2 40mm 9 Stage Adjustable Shock $ 207 ea Suits 75mm Lift

BMX1047/3 2 45mm 9 Stage Adjustable Shock $ 285 ea Suits 75mm Lift

COIL SPRINGSTDC734/3 2 75mm Lift Coil $ 175 ea Suit LWB up to Bullbar

TDC734/3H 2 75mm Lift Coil $ 175 ea Suit LWB with Bullbar & Winch


Suits 2/88-9/89 GQ ONLYSS5612-P/S 1 Return to Centre Damper $ 176 ea



Suits 8/89-98 GQ ONLYSS5613-P/S 1 Return to Centre Damper $ 176 ea









PANHARD ROD (Check Bushes Prior to Ordering)TDPR-004 1 Adjustable Panhard Rod $ 250 ea Suits GQ (all) & GU Utes


TDPR-014 1 Adjustable Panhard Rod $ 290 ea Suits GQ (all) & GU Utes LHD

TDPR-016 1 Adjustable Panhard Rod $ 300 ea Suits GU Wagon LHD



TDUK-051 1 Pan Hard Rod Bushes $ 68 ea Suits TDPR-004 & 014 ONLY

TDUK-055 1 Panhard Rod Bush (Diff End) $ 37 ea (diff end) TDPR-012, 013 & 016

TDUK-056 1 Panhard Rod Bush (Chassis End) $ 50 ea (chasss end)TDPR-012,013 & 016




FOR REPLACEMENT BUSHING PART NUMBERS, PLEASE SEERELEVANT NISSAN PATROL PAGES (P104) PREVIOUS IN CATALOGUE

GQ, GU Patrol (Y60, Y61) - 3” Lift

117P: (02) 9672 8899 | F: (02) 9672 8099




REAR SUSPENSION

GQ, GU Patrol (Y60, Y61) - 3” Lift2/88-2015PATROL

NISSAN


SHOCK ABSORBERS - Fitting BMX? instructions at toughdog.com.auFC41206/3 2 41mm Foam Cell Shocks $ 176 ea Suits 75mm Lift

BM401206/3 2 40mm 9 Stage Adjustable Shock $ 207 ea Suits 75mm Lift


COIL SPRINGSTDC732/3 2 75mm Lift 0-300Kg Load $ 175 ea Suit LWB

TDC732/3H 2 75mm Lift CONSTANT 300kg $ 175 ea Suit LWB



COMPONENTSTDUK-051 1 Pan Hard Rod Bushes $ 68 ea Suits TDPR-005 ONLY

TDUK-052 1 Trailing Arm Bushing Kit $ 170 ea 2 Kits required Upper & Lower



TRANSMISSION SPACERTDSP-004/2 1 Transmission Spacer Kit $ 129 ea instructions at toughdog.com.au

BRAKE HOSE KITSTDBH-001 1 Non ABS Rubber Hose $ 145 ea SUIT VEHICLES UP TO 2002

TDBH-194 1 Non ABS Braided Hose $ 270 ea SUIT VEHICLES UP TO 2002

TDBH-390 1 With ABS Rubber Hose $ 217 ea SUIT VEHICLES 98 ON

TDBH-190 1 With ABS - Braided Hose $ 400 ea SUIT VEHICLES 98 ON

TDBH-400 1 Wiith ABS & Stability - Rubber $ 290 ea SUIT VEHICLES 98 ON


41mm Foam CellTO SUIT GQ $ 2375

TO SUIT GU $ 2425


TO SUIT GQ $ 2499

TO SUIT GU $ 2549


TO SUIT GQ $ 2811

TO SUIT GU $ 2861


1 x Caster correction kit 2 x Panhard Rods1 x Transmission Spacer 1 x Brake Hose Kit

(Brake Hose kit is rubber non ABS - adjust price if required)









BMX1047/4/5 2 45mm 9 Stage Adjustable Shock $ 285 ea Suits 100mm Lift



STEERING STABILIZERSSS5613-XHD 1 H/Duty Return to Centre Damper $ 310 ea Comes with brackets, fitting

instructions at toughdog.com.auSV5613/4 1 9 Stage Adjustable Damper $ 310 ea








TDUK-051 1 Pan Hard Rod Bushes $ 68 ea Suits TDPR-004 & 014 ONLY








119P: (02) 9672 8899 | F: (02) 9672 8099




REAR SUSPENSION


NISSAN


SHOCK ABSORBERS - Fitting BMX? instructions at toughdog.com.auFC41206/4 2 41mm Foam Cell Shocks $ 176 ea Suits 100mm Lift

BMX1206/4/5 2 45mm 9 Stage Adjustable Shock $ 285 ea Suits 100mm Lift
















41mm Foam CellTO SUIT GQ $ 2438

TO SUIT GU $ 2488


TO SUIT GQ $ 2874

TO SUIT GU $ 2924





VEHICLES LIFTED 100MM OR MORE REQUIRE THE REAR TAILSHAFT TO BE SPUN 180 DEGREES SO THAT THE CLEARANCE BETWEEN THE CROSS MEMBER AND THE TAILSHAFT IS INCREASED.







SHOCK ABSORBERSBMX1047/4/5 2 45mm 9 Stage Adjustable Shock $ 285 ea Suits 125mm Lift ONLY



STEERING STABILIZERSSS5613-XHD 1 H/Duty Return to Centre Damper $ 310 ea Comes with brackets, fitting


CASTER CORRECTIONTDCP-005 1 5 Degree Caster Correction Plate $ 240 ea instructions at toughdog.com.au







TDUK-051 1 Pan Hard Rod Bushes $65 ea Suits TDPR-004 & 014 ONLY








121P: (02) 9672 8899 | F: (02) 9672 8099




REAR SUSPENSION


NISSAN


SHOCK ABSORBERS - Shock fitting instructions at toughdog.com.auBMX1206/4/5 2 45mm 9 Stage Adjustable Shock $ 285 ea Suits 125mm Lift ONLY

















TO SUIT GQ(0-300 rear)

$ 2844

TO SUIT GQ(300kg + rear)

$ 2886

TO SUIT GU(0-300 rear)

$ 2894

TO SUIT GU(300kg + rear)

$ 2936





VEHICLES LIFTED 100MM OR MORE REQUIRE THE REAR TAILSHAFT TO BE SPUN 180 DEGREES SO THAT THE CLEARANCE BETWEEN THE CROSS MEMBER AND THE TAILSHAFT IS INCREASED.







SHOCK ABSORBERSBMX1047/6 2 45mm 9 Stage Adjustable Shock $ 285 ea Suits 150mm Lift ONLY



STEERING STABILIZERSSS5613-XHD 1 H/Duty Replacement Damper $ 310 ea Comes with brackets, fitting









TDUK-051 1 Pan Hard Rod Bushes $68 ea Suits TDPR-004 & 014 ONLY








123P: (02) 9672 8899 | F: (02) 9672 8099




REAR SUSPENSION


NISSAN


SHOCK ABSORBERS - Shock fitting instructions at toughdog.com.auBMX1206/6 2 45mm 9 Stage Adjustable Shock $ 285 ea Suits 150mm Lift ONLY

















SUIT GQ (0-300kg) $ 2906

SUIT GQ (Bar+Winch)

$ 2928

SUIT GQ(Bar+Winch+300kg Rear)

$ 2928

SUIT GU (0-300kg) $ 2956

SUIT GU (Bar+Winch)

$ 2978

SUIT GU(Bar+Winch+300kg Rear)

$ 2978










GQ Cab Chassis (Leaf/Leaf)2/88-98PATROLNISSAN

SHOCK ABSORBERSFC41108 2 41mm Foam Cell Shocks $ 176 ea


FC41113 2 41mm Foam Cell Shocks $ 176 eaSuit 50mm Lift


LEAF SPRINGSFS37 2 50mm Lift Spring $ 196 ea Petrol/Diesel/Bar

FS37H 2 50mm Lift Spring $ 217 ea Petrol/Diesel/Bar/Winch

STEERING STABILIZERSEXT5005 1 H/Duty Replacement Damper $ 140 ea Eye/Eye Mounting

Check Vehicle Prior to Ordering.SS5005-P/S 1 Return to Centre Damper $ 175 ea

EXT5613 1 H/Duty Replacement Damper $ 140 eaPin/Pin MountingCheck VehiclePrior to Ordering.


SV5613 1 9 Stage Adjustable Dampers $ 207 ea




TDGS-666 1 Greasable Shackles $ 93 ea





ADJ00191 1 Suits Bottom Front Eyering $ 3 ea Eyering Bushing


TW959 2 Suits Bottom Rear Pin $ 3 ea Pin Style Bushing

125P: (02) 9672 8899 | F: (02) 9672 8099




REAR SUSPENSION

GQ Cab Chassis (Leaf/Leaf)2/88-98

PATROLNISSAN



Suit 50mm LiftBM401404 2 40mm 9 Stage Adjustable $ 207 ea

LEAF SPRINGSBPN-010 2 0-300kg Load $ 362 ea 50mm Lift Spring

BPN-010H 2 CONSTANT 300Kg Load $ 392 ea 50mm Lift Spring

FS39M 2 CONSTANT 500Kg Load $ 485 ea 50mm Lift Spring

FS38M 2 Mine Spec - CONSTANT GVM $ 485 ea 50mm Lift Spring







41mm Foam Cell

FS37+BPN-010 $ 2080

FS37H+BPN-010 $ 2122

FS37+BPN-010H $ 2140

FS37H+BPN010H $ 2182

FS37+FS38/39M $ 2326

FS37H+FS38/39M $ 2368


FS37+BPN-010 $ 2204

FS37H+BPN-010 $ 2246

FS37+BPN-010H $ 2264

FS37H+BPN010H $ 2306

FS37+FS38/39M $ 2450

FS37H+FS38/39M $ 2492









92-15PATROLNISSAN



TW959 2 Suits Bottom Rear Pin $ 3 ea Pin Style Bushing





COIL SPRINGSTDC734L 2 50mm Lift Coil $ 135 ea Suit up to Bullbar

TDC734HL 2 50mm Lift Coil $ 135 ea Suit with Bullbar & Winch

STEERING STABILIZERSEXT5613 1 H/Duty Replacement Damper $ 135 ea Suits GQ ONLY (Pin/Pin)

Please Check Mountings Prior to Ordering - Model is not consistent in application.



EXT5000 1 H/Duty Replacement Damper $ 140 ea Suits GU ONLY (Pin/Pin)Please Check Mountings Prior to Ordering - Model is not consistent in application.



CASTER CORRECTIONTDUK-054/2 1 2 Degree Caster Correction Bush $ 207 ea 1 Kit required per vehicle

PANHARD ROD (Check Bushes Prior to Ordering)TDPR-004 1 Adjustable Panhard Rod $ 250 ea Suits GQ & GU Utes

TDPR-014 1 Adjustable Panhard Rod $ 290 ea Suits GQ & GU Utes LHD









GQ, GU Cab Chassis (Coil/Leaf)

127P: (02) 9672 8899 | F: (02) 9672 8099


41mm Foam Cell

BPN-010 $ 1828

BPN-010H $ 1888

FS38/39M $ 2074


BPN-010 $ 1952

BPN-010H $ 2012

FS38/39M $ 2198


BPN-010 $ 2264

BPN-010H $ 2324

FS38/39M $ 2510


BPN-010 $ 2264

BPN-010H $ 2324

FS38/39M $ 2510


2 x Leaf Springs 1 x Urethane Kit2 x U-Bolt Kits



REAR SUSPENSION

GQ, GU Cab Chassis (Coil/Leaf)92-15

PATROLNISSAN



BM401404 2 40mm 9 Stage Adjustable $ 207 ea Suits up to 50mm Lift



LEAF SPRINGSBPN-010 2 0-300kg Load $ 362 ea 50mm Lift Spring

BPN-010H 2 CONSTANT 300Kg Load $ 392 ea 50mm Lift Spring


FS38M 2 Mine Spec - CONSTANT GVM $ 485 ea 50mm Lift Spring












92-15PATROLNISSAN








COIL SPRINGSTDC734L 2 50mm Lift Coil $ 135 ea Suit up to Bullbar

TDC734HL 2 50mm Lift Coil $ 135 ea Suit with Bullbar & Winch

STEERING STABILIZERSEXT5613 1 H/Duty Replacement Damper $ 140 ea Suits GQ ONLY (Pin/Pin)

Please Check Mountings Prior to Ordering - Model is not consistent in application.



EXT5000 1 H/Duty Replacement Damper $ 140 ea Suits GU ONLY (Pin/Pin)Please Check Mountings Prior to Ordering - Model is not consistent in application.



CASTER CORRECTIONTDUK-054/2 1 2 Degree Caster Correction Bush $ 207 ea 1 Kit required per vehicle

PANHARD ROD (Check Bushes Prior to Ordering)TDPR-004 1 Adjustable Panhard Rod $ 250 ea Suits GQ & GU Utes









GQ, GU Cab Chassis (Coil/Coil)

129P: (02) 9672 8899 | F: (02) 9672 8099




REAR SUSPENSION

GQ, GU Cab Chassis (Coil/Coil)92-15

PATROLNISSAN






COIL SPRINGSTDC749HL 2 50mm Lift 0-300Kg Load $ 165 ea

TDC749VHL 2 50mm Lift CONSTANT 300kg $ 196 ea

PANHARD ROD (Check Bushes Prior to Ordering)TDPR-005 1 Adjustable Panhard Rod $ 240 ea





















ESTIMATED LIFT:


40mm

REAR SUSPENSION

Y62 (Non Hydraulic Suspension Only)10 OnPATROLNISSAN



BMX1220/2 2 45mm 9 Stage Adjustable $ 285 ea Up to 40mm Lift


TDC795L 2 CONSTANT 120-300Kg Load $ 185 ea 40mm Lift



4WAY-002 1 Suits Bottom Front Eyering $ 10 ea Eyering Bonded Bushing

Retainer-W 1 Suits Rear Top Pin $ 7 ea Eyering Bushing

Retainer-X 1 Suits Rear Bottom Pin $ 5 ea Eyering Bushing



BMX454750 2 45mm Adjustable Strut $ 360 ea 9 Stage Big Bore Adjustable

COIL SPRINGSTDC790L 2 40mm Lift Spring $ 165 ea Petrol With Bar

TDC790HL 2 40mm Lift Spring $ 165 ea Petrol with Bar & Winch

TDC791L 2 40mm Lift Spring-45mm Adj Only $ 165 ea Petrol With Bar

TDC791HL 2 40mm Lift Spring-45mm Adj Only $ 165 ea Petrol with Bar & Winch

COMPLETE STRUT ASSEMBLYNIS-062/02 2 FC404750/TDC790L $ 496 ea Petrol With Bar

NIS-062/03 2 FC404750/TDC790HL $ 496 ea Petrol with Bar & Winch

NIS-062/07 2 BM404750/TDC790L $ 558 ea Petrol With Bar

NIS-062/08 2 BM404750/TDC790HL $ 558 ea Petrol with Bar & Winch

NIS-062/10 2 BMX454750/TDC791L (45mm) $ 608 ea Petrol With Bar

NIS-062/11 2 BMX454750/TDC791HL (45mm) $ 608 ea Petrol with Bar & Winch


131P: (02) 9672 8899 | F: (02) 9672 8099



AssemblyIncludes





StrutsIncludes





AssemblyIncludes





StrutsIncludes





AssemblyIncludes





StrutsIncludes




Y62 (Non Hydraulic Suspension Only)13 On

PATROLNISSAN






R203/97-00TERRANO IINISSAN


REAR SUSPENSION








COIL SPRINGSTDC739 2 0-300Kg Load $ 135 ea 30mm Lift


QUANTITY PER SHOCKTW959 2 Suits Top Front Pin Mount $ 3 ea Pin Style Bushing




35mm Nitro gas ANY $ 830



ANY $ 1098



133P: (02) 9672 8899 | F: (02) 9672 8099


SSANGYONGMUSSO (INC SPORT UTE)

8/96-04ALSO SEE DAEWOO










COIL SPRINGSTDC100 2 0-300KG Load $ 135 ea 35mm Lift




TW959 2 Front Top Pin Mount $ 3 ea Pin Style Bushing

412772 1 Bottom Front Eyering $ 6 ea Eyering Bushing

TW959 2 Rear Top Pin Mount $ 3 ea Pin Style Bushing

404702 1 Bottom Rear Eyering $ 3 ea Eyering Bushing

35mm Nitrogen Gas ANY $ 830

Gas FrontAdjustable Rear

ANY $ 964

Includes4 x Shocks 2 x Coil Springs





ESTIMATED LIFT: 40-80mm

SUZUKIJIMNY10/98-2017SN413 (JB33/43/48)

SHOCK ABSORBERSBD1133TB 2 35mm Nitro Gas Shock $ 140 ea Suits 40mm Lift ONLY

BD1134TB 2 35mm Nitro Gas Shock $ 140 ea Suits 60 & 80mm Lift

COIL SPRINGSTDC836 2 40mm Lift Coil $ 124 ea

Suits 10/98-05 1.3LTDC838L 2 60mm Lift Coil $ 124 ea

TDC824 2 80mm Lift Coil $ 124 ea

TDC824H 2 80mm Lift Coil $ 124 ea Suits with Bar & Winch

TDC838L 2 40mm Lift Coil $ 124 ea

Suits 05 On M13AAVVT 1.5LTDC824 2 60mm Lift Coil $ 124 ea

TDC824H 2 80mm Lift Coil $ 124 ea

STEERING STABILIZERSSD5610 1 H/Duty Replacement Damper $ 180 ea Includes Mounting Brackets

Fitting instructions available at toughdog.com.au

SS5610-M/S 1 Return to Centre Damper $ 220 ea


CASTER CORRECTIONTDUK-063 1 3 Degree Caster Correction Bush $ 196 ea 1 Kit required per vehicle

PANHARD RODTDPR-009 1 Adjustable Panhard Rod $ 218 ea Suits RHD Vehicles Only

TDPR-011 1 Adjustable Panhard Rod $ 232 ea Suits LHD Vehicles Only

COMPONENTSTDUK-039 1 Replacement Trailing Arm Bushes $ 212 ea (0 Degrees Adjustment)

TDSK-022 1 ABS relocation Bracket $ 16 eaRelocation Bracket for ABS Kitfitting instructions at toughdog.com.au


402267 2 Suits Top Front Pin Mount $ 3 ea Pin Style Bushing



4W-SPF420-02 1 Suits Bottom Rear Eyering $ 6 ea Eyering Bushing

135P: (02) 9672 8899 | F: (02) 9672 8099


SUZUKIJIMNY

10/98-2017SN413 (JB33/43/48)

REAR SUSPENSION

SHOCK ABSORBERSBD1192TB 2 35mm Nitro Gas Shock $ 140 ea Suits 40mm Lift ONLY

BD1193TB 2 35mm Nitro Gas Shock $ 140 ea Suits 60 & 80mm Lift


TDC839L 2 60mm Lift Coil $ 124 ea


TDC826 2 80mm Lift Coil - O/S MODELS $ 124 ea

COMPONENTSTDUK-039 1 Replacement Trailing Arm Bushes $ 212 ea

PANHARD RODTDPR-010 1 Adjustable Panhard Rod $ 222 ea

BRAKE HOSE KITSTDBH-199 1 Brake Hose Kit 60-80mm $ 62 ea Single Rear Hose (Front not req’d)


35mm Nitro Gas 40mm LIFT $ 1056


35mm Nitro Gas 60 & 80mm LIFT $ 1770


1 x Caster correction kit 2 x Panhard Rods1 x Brake Hose Kit 1 x ABS Relocation Bracket



Note: Castor Correction Bushing kit fitting instructions available attoughdog.com.au




ESTIMATED LIFT: 40-80mm

SUZUKIJIMNY2019 ONJB74

SHOCK ABSORBERSFC31000 2 Foam Cell Shock $ 150 ea Suits 40mm Lift ONLY

FC31001 2 Foam Cell Shock $ 150 ea Suits 60 & 80mm Lift

COIL SPRINGSTDC1000 2 40mm Lift Coil $ 124 ea Note: When Bar or Bar & Winch

fitted, also fit TDUK-084 spacer listed below






CASTER CORRECTIONTDUK-063 1 3 Degree Caster Correction Bush $ 196 ea 1 kit required with 60 or 80mm lift

PANHARD RODTDPR-021 1 Adjustable Panhard Rod $ 245 ea Suits RHD Vehicles Only

COMPONENTSTDUK-039 1 Replacement Trailing Arm Bushes $ 212 ea (0 Degrees Adjustment)

TDSP-016 1 ABS relocation & vacuum hoses $ 25 ea Fit with all kits

TDSP-017 1 Headlight Module Bracket $ 16 ea Fit with all kits

TDSP-018 1 Crossmember Drop Kit $ 148 ea Fit with all kits

TDUK-084 1 Front Coil Spacer (pair of) $ 95 kit Fit with bar or Bar + Winch


402267 2 Suits Top Front Pin Mount $ 3 ea Pin Style Bushing



412773 1 Suits Bottom Rear Eyering $ 6 ea Suits #31002 shock only

137P: (02) 9672 8899 | F: (02) 9672 8099


SUZUKIJIMNY2019 ON

JB74

REAR SUSPENSION

SHOCK ABSORBERSFC31002 2 Foam Cell Shock $ 150 ea Suits 40mm Lift ONLY

FC31003 2 Foam Cell Shock $ 150 ea Suits 60 & 80mm Lift




COMPONENTSTDUK-039 1 Replacement Trailing Arm Bushes $ 212 ea

PANHARD RODTDPR-010 1 Adjustable Panhard Rod $ 222 ea Fit with 60 & 80mm Lift

BRAKE HOSE KITSTDBH-401 1 Rubber Brake Hose Kit $ 240 ea Fit with 60 & 80mm Lift

TDBH-402 1 Braided Brake Hose Kit $ 500 ea Fit with 60 & 80mm Lift

TDBH-403 1 Rubber Brake Hose Kit $ 65 ea Fit with all 40mm Lift


Foam Cell 40mm LIFT $ 1350

Includes4 x Coil Springs 4 x Shocks 1 x Headlight Module Kit

1 x Brake hose kit 1 x ABS Relocation Kit 1 x Crossmember Kit

Foam Cell 60 & 80mm LIFT $ 2188


1 x Caster Correction Kit 2 x Panhard Rods1 x Brake Hose Kit 1 x Headlight Module Kit1 x ABS Relocation Kit 1 x Crossmember Kit



Note: Castor Correction Bushing kit fitting instructions available attoughdog.com.au





REAR SUSPENSION

SUZUKISIERRA7/74-5/99LEAF SPRING ONLY

SHOCK ABSORBERSBD1102T 2 35mm Nitro Gas Shock $ 140 ea Suits up to 50mm Lift

LEAF SPRINGST61 2 50mm Lift Lift $ 125 ea Suits All with Bar

STEERING STABILIZERSSD14030 1 H/Duty Replacement Damper $ 110 ea

SS5611-M/S 1 Return to Centre Damper $ 175 ea


TDUB-014 1 U-Bolt Kit $ 31 ea Passenger Side

TDUB-013 1 U-Bolt Kit $ 31 ea Drivers Side


SHOCK ABSORBERSBD1364T 2 35mm Nitro Gas Shock $ 140 ea Suits OE Height

BD1366T 2 35mm Nitro Gas Shock $ 140 ea Suits 50mm Lift

BD1102T 2 35mm Nitro Gas Shock $ 140 ea Suits OE Height LJ80 & 80V

BD1104T 2 35mm Nitro Gas Shock $ 140 ea Suits 50mm Lift LJ80 & 80V

LEAF SPRINGST62 2 50mm Lift $ 145 ea





TW959 2 Suits Top Front Pin Mount $ 3 ea Pin Style Bushing






4 x U-Bolt Kits 2 x Shackle Bushing Kit


139P: (02) 9672 8899 | F: (02) 9672 8099


SUZUKIVITARA

7/88-05INCLUDES GRAND VITARA & XL-7



REAR SUSPENSION

SHOCK ABSORBERSBDS4613 2 Mini Strut Replacement $ 187 ea OE Height

BDS4000LR 2 Mini Strut (Includes Camber Bolt) $ 250 ea 30mm Lift

COIL SPRINGSTDC814 2 30mm Lift Spring $ 124 ea 88-3/98 1.6L SWB

TDC816 2 30mm Lift Spring $ 124 ea 88-3/98 2.0L SWB & 1.6L LWB

TDC818 2 30mm Lift Spring $ 124 ea 95-3/98 2.0L V6 LWB

TDC834SL 2 30mm Lift Spring $ 124 ea 98-05 1.6L, 2.0L SWB & LWB

TDC834 2 30mm Lift Spring $ 124 ea 98-05 2.5L V6 LWB

TDC834H 2 30mm Lift Spring $ 124 ea 01-05 2.7L V6

STEERING DAMPERSS5614-M/S 1 Return to Centre Damper $ 215 ea Manual Steering 7/88-02


COIL SPRINGSTDC815 2 0-300kg Load $ 124 ea 30mm Lift 88-3/98 SWB

TDC817 2 0-300kg Load $ 124 ea 30mm Lift 91-3/98 LWB

TDC835SL 2 0-300kg Load $ 124 ea 30mm Lift 4/98-7/05 SWB

TDC835 2 0-300kg Load $ 124 ea 30mm Lift 4/98-7/05 LWB

TDC838 2 0-300kg Load $ 124 ea 30mm 7/01-05 XL-7 ONLY

QUANTITY PER SHOCKTW959 2 Suits Top Rear Pin Mount $ 3 ea Pin Style Bushing

4W-SPF420-02 1 Suits Rear Bottom Eye $ 6 ea Eye Style Bushing



Includes4 x Coil Springs 2 x Rear Shocks

2 x Front Struts






ESTIMATED LIFT:


40mm

REAR SUSPENSION

04 - 12/15FORTUNERTOYOTA








ADJ00191 1 Suits Rear Bottom Eyering $ 3 ea Eyering Bushing

TW959 2 Suits Rear Top Pin $ 2.50 ea Pin Style Bushing

SHOCK ABSORBERSFC404600 2 40mm Foam Cell Strut $248 ea

BM404600 2 40mm Adjustable Strut $310 ea 9 Stage Adjustable

COIL SPRINGSTDC974S 2 OE Height Only $135 ea OE Replacement Only

TDC974 2 40mm Lift Spring $135 ea Petrol/Diesel/Bar

TDC974H 2 40mm Lift Spring $135 ea Petrol/Diesel/Bar/Winch

COMPLETE STRUT ASSEMBLYTOY-026/01 2 BM404600/TDC974 $518 ea Petrol/Diesel/Bar

TOY-026/02 2 BM404600/TDC974H $518 ea Petrol/Diesel/Bar/Winch

TOY-026/03 2 FC404600/TDC974 $456 ea Petrol/Diesel/Bar

TOY-026/04 2 FC404600/TDC974H $456 ea Petrol/Diesel/Bar/Winch

REPLACEMENT STRUT ASSEMBLYTOY-1083 2 Strut Top $73 ea Replacement Strut Top

141P: (02) 9672 8899 | F: (02) 9672 8099


All Models04 - 12/15

FORTUNERTOYOTA


Assembly

ANY $ 1388Includes

2x Front Struts2x Rear Shocks4x Coil Springs


Struts

ANY $ 1534Includes

2x Complete Struts2x Rear Shocks2x Coil Springs


Assembly

ANY $ 1574Includes

2x Front Struts2x Rear Shocks4x Coil Springs


Struts

ANY $ 1720Includes

2x Complete Struts2x Rear Shocks2x Coil Springs







REAR SUSPENSION

15 OnFORTUNERTOYOTA






COMPONENTSTDSP-010 1 Transmission Spacer Kit $ 31 ea Must be fitted with all lift kits







COIL SPRINGSTDC974 2 40mm Lift Spring $ 135 ea Petrol/Diesel/No Bar



COMPLETE STRUT ASSEMBLYTOY-026/01 2 BM404600/TDC974 $ 518 ea Petrol/Diesel/No Bar

TOY-027/02 2 BM404600/TDC983 $ 518 ea Petrol/Diesel/Bar

TOY-027/03 2 BM404600/TDC974H $ 518 ea Petrol/Diesel/Bar/Winch

TOY-026/03 2 FC404600/TDC974 $ 456 ea Petrol/Diesel/No Bar

TOY-027/06 2 FC404600/TDC983 $ 456 ea Petrol/Diesel/Bar

TOY-027/07 2 FC404600/TDC974H $ 456 ea Petrol/Diesel/Bar/Winch

REPLACEMENT STRUT ASSEMBLYTOY-1083 2 Strut Top $ 73 ea Replacement Strut Top

143P: (02) 9672 8899 | F: (02) 9672 8099


All Models15 On

FORTUNERTOYOTA


Assembly

ANY $ 1419Includes2x Front Struts2x Rear Shocks4x Coil Springs



Struts

ANY $ 1565Includes2x Complete Struts

2x Rear Shocks2x Coil Springs



Assembly

ANY $ 1605Includes2x Front Struts2x Rear Shocks4x Coil Springs



Struts

ANY $ 1751Includes2x Complete Struts

2x Rear Shocks2x Coil Springs






ESTIMATED LIFT:


REAR SUSPENSION

50mm

IFS WITH LEAF REAR11/85-894RUNNERTOYOTA




STEERING DAMPERSEXT5510 1 H/D Replacement Damper $ 140 ea

S55510-P/S 1 Return to Centre Damper $ 175 ea














ADJ00191 1 Suits Top & Bottom Rear Eye $ 3 ea Eyering Bushing

TW038-16 1 Suits Front Bottom Eye $ 6 ea Eyering Bushing


Foam Cell FrontNitro Gas Rear

T46C 0-300KG $ 1121

T46L 300KG+ $ 1131

41mm Foam CellT46C 0-300KG $ 1193

T46L 300KG+ $ 1203


T46C 0-300KG $ 1255

T46L 300KG+ $ 1265


145P: (02) 9672 8899 | F: (02) 9672 8099


TOYOTA4RUNNER

89-96


IFS WITH COIL REAR


REAR SUSPENSION





S55510-P/S 1 Return to Centre Damper $ 175 ea











ADJ00191 1 Suits Bottom Rear Eye $ 3 ea Eyering Bushing

TW038-16 1 Suits Front Bottom Eyering $ 6 ea Eyering Bushing


41mm Foam Cell ANY REAR COIL $ 974


ANY REAR COIL $ 1036



FRONT SUSPENSION ESTIMATED LIFT: 50mm





TOYOTAHILUX4/79-97LEAF/LEAF 4WD


Suit OE HeightFC41134 2 41mm Foam Cell Shock $ 176 ea


BD1109T 2 35mm Nitrogen Gas $ 140 ea

Suit 50mm LiftFC41109 2 41mm Foam Cell Shock $ 176 ea


LEAF SPRINGST75 2 Petrol/Diesel/Bar $ 140 ea 50mm Lift Spring

T78 2 Petrol/Diesel/Bar/Winch $ 145 ea 50mm Lift Spring


SS5500-M/S 1 Return to Centre Damper $ 176 ea Suits Manual Steering




TDUB-015 1 U-Bolt Kit $ 31 ea Suits D/S (1 Kit Req’d)

TDUB-016 1 U-Bolt Kit $ 31 ea Suits P/S (1 Kit Req’d)



TDDL-001 1 Adjustable Diff Locator $ 115 ea Fit with all Lift Kits


35mm Nitro GasT75 $ 794

T78 $ 804

41mm Foam CellT75 $ 866

T78 $ 876

9 Stage AdjustableT75 $ 928

T78 $ 938


2 x U-Bolt Kits 1 x Urethane Kit 1 x Diff Locator

FRONT END KIT PRICE REFERENCE

147P: (02) 9672 8899 | F: (02) 9672 8099


LEAF/LEAF 4WD4/79-97HILUX

TOYOTA

REAR SUSPENSION


Suits OE Height4/79-83 Models



BD1388T 2 35mm Nitrogen Gas $ 140 eaSuits 50mm Lift4/79-83 Models

BM401388 2 41mm Foam Cell Shocks $ 176 ea


BD1350T 2 35mm Nitrogen Gas $ 140 eaSuits OE Height11/83-97 Models



BD1377T 2 35mm Nitrogen Gas $ 140 eaSuits 50mm Lift11/83-97 Models



LEAF SPRINGST46C 2 0-300Kg Load $ 185 ea 50mm Lift Spring

T46L 2 CONSTANT 300Kg Load $ 190 ea 50mm Lift Spring

BP-002XHD 2 CONSTANT 500Kg Load $ 356 ea 50mm Lift Spring






35mm Nitro Gas

T46C $ 769

T46L $ 779

BP-002XHD $ 1111

41mm Foam Cell

T46C $ 841

T46L $ 851

BP-002XHD $ 1183

9 Stage Adjustable

T46C $ 903

T46L $ 913

BP-002XHD $ 1245


2 x U-Bolt Kits 1 x Urethane Kit

REAR END KIT PRICE REFERENCE





ESTIMATED LIFT:


REAR SUSPENSION

50mm

TORSION BAR FRONT10/88-97HILUXTOYOTA









BD1377T 2 35mm Nitrio Gas Shock $ 140 ea



LEAF SPRINGSBP-007 2 0-300kg Load $ 227 ea 50mm Lift

BP-007H 2 CONSTANT 300Kg Load $ 248 ea 50mm Lift

BP-007HH 2 CONSTANT 500Kg Load $ 310 ea 50mm Lift








149P: (02) 9672 8899 | F: (02) 9672 8099


TORSION BAR FRONT10/88-97HILUX

TOYOTA

Foam Cell FrontNitro gas Rear

Includes2 x Leaf Springs

4 x Shocks2 x U-Bolt Kits

1 x Urethane Kit

BP-0070-300KG

$ 1236

BP-007HCONSTANT 300KG

$ 1278

BP-007HHCONSTANT 500KG

$ 1402

41mm Foam Cell



1 x Urethane Kit

BP-0070-300KG

$ 1308


$ 1350


$ 1474




1 x Urethane Kit

BP-0070-300KG

$ 1370


$ 1412


$ 1536

COMPLETE KIT PRICE REFERENCESHOCK CHOICE SPRING CHOICE RRP inc GST CONTENTS




ESTIMATED LIFT:


REAR SUSPENSION

50mm

TORSION BAR FRONT10/97-05HILUXTOYOTA







SHOCK ABSORBERSPlease take note of shock application for standard and lifted height vehicles

BD1350T (D/S) 1 35mm Nitro Gas Shock $ 140 ea

Suits OE Height

BD1377T (P/S) 1 35mm Nitro Gas Shock $ 140 ea

FC41350 (D/S) 1 41mm Foam Cell Shock $ 176 ea

FC41377 (P/S) 1 41mm Foam Cell Shock $ 176 ea

BM401350 (D/S) 1 40mm 9 Stage Adjustable $ 207 ea

BM401377 (P/S) 1 40mm 9 Stage Adjustable $ 207 ea














151P: (02) 9672 8899 | F: (02) 9672 8099


TORSION BAR FRONT10/97-05HILUX

TOYOTA

Foam Cell FrontNitro gas Rear



1 x Urethane Kit

T79C0-300KG

$ 1246

T79LCONSTANT 300KG

$ 1268

T79LLCONSTANT 500KG

$ 1288

41mm Foam Cell



1 x Urethane Kit

T79C0-300KG

$ 1318

T79LCONSTANT 300KG

$ 1340

T79LLCONSTANT 500KG

$ 1360




1 x Urethane Kit

T79C0-300KG

$ 1380

T79LCONSTANT 300KG

$ 1402

T79LLCONSTANT 500KG

$ 1422






KUN26R (COIL/LEAF)4/05-15HILUXTOYOTA

REAR SUSPENSION



COIL SPRINGSTDC974S 2 OE Height Only $ 135 ea OE Replacement Only



COMPLETE STRUT ASSEMBLYTOY-026/01 2 BM404600/TDC974 $ 518 ea Petrol/Diesel/Bar

TOY-026/02 2 BM404600/TDC974H $ 518 ea Petrol/Diesel/Bar/Winch

TOY-026/03 2 FC404600/TDC974 $ 456 ea Petrol/Diesel/Bar

TOY-026/04 2 FC404600/TDC974H $ 456 ea Petrol/Diesel/Bar/Winch


COMPONENTSTDSP-011 1 Sway Bar Spacer Kit $ 62 ea 76mm hole spacing


SUITS OE HEIGHT ONLY!!BM401350 2 40mm Adjustable Shock $ 207 ea

FC41376 2 41mm Foam Cell Shock $ 176 eaSUITS 40MM LIFT ONLY!!


LEAF SPRINGST80C 2 0-300KG Load $ 196 ea 40mm Lift



FIT CONSTANT LEAVES ONLY WHERE CONSTANT LOAD FITTED - PREMATURE FAILURE MAY OCCUR

COMPONENTSTDUK-067 1 Urethane Bushing Kit $ 88 Kit


TDGS-389 1 Greasable Shackle Kit $ 93 Kit



REPLACEMENT BUSHINGSSHOCK ABSORBERS

TOY-1083 1 Top Front Replacement Assembly $ 73 ea Bushes not sold separately

ADJ00300/40 1 Bottom Front Eyering $ 6 ea Bonded eyering bushing

ADJ00191 2 Top & Bottom Rear Eyering $ 3 ea Eyering Bushing

153P: (02) 9672 8899 | F: (02) 9672 8099


KUN26R (COIL/LEAF)4/05-15HILUX

TOYOTA

Foam Cell Struts Require

Assembly

Includes2 x Coil Springs

4 x Shocks2 x Leaf Springs2 x U-Bolt Kits

1 x Urethane Kit

T80C0-300KG

$ 1660

T80LCONSTANT 300KG

$ 1732

T80LLCONSTANT 500KG

$ 1808


Struts

Includes2 x Complete Struts


1 x Urethane Kit

T80C0-300KG

$ 1806

T80LCONSTANT 300KG

$ 1878

T80LLCONSTANT 500KG

$ 1954


Assembly



1 x Urethane Kit

T80C0-300KG

$ 1846

T80LCONSTANT 300KG

$ 1918

T80LLCONSTANT 500KG

$ 1994


Struts



1 x Urethane Kit

T80C0-300KG

$ 1992

T80LCONSTANT 300KG

$ 2064

T80LLCONSTANT 500KG

$ 2140






KUN26R - MINING APPLICATIONS4/05-15HILUXTOYOTA

REAR SUSPENSION


COIL SPRINGSTDC976 2 40mm Lift Spring $ 135 ea Petrol/Diesel/Bar/Winch

COMPLETE STRUT ASSEMBLYTOY-026/05 2 FC404600/TDC976 $ 456 ea Petrol/Diesel/Bar/Winch


COMPONENTSTDSP-011 1 Sway Bar Spacer Kit $ 62 76mm hole spacing

SHOCK ABSORBERSFC41350 2 41mm Foam Cell Shock $ 176 ea SUITS OE HEIGHT ONLY!!

FC41376 2 41mm Foam Cell Shock $ 176 ea SUITS 0MM LIFT ONLY!!

LEAF SPRINGST80LL 2 500KG CONSTANT Load $ 270 ea 40mm Lift

FIT CONSTANT LEAVES ONLY WHERE CONSTANT LOAD FITTED - PREMATURE FAILURE MAY OCCUR






REPLACEMENT BUSHINGSSHOCK ABSORBERS

TOY-1083 1 Top Front Replacement Assembly $ 73 ea Bushes not sold separately

ADJ00300/40 1 Bottom Front Eyering $ 6 ea Bonded eyering bushing

ADJ00191 2 Top & Bottom Rear Eyering $ 3 ea Eyering Bushing

MINE SPEC APPLICATIONS PLEASE NOTE:

Please always be aware of the GVM of the vehicle when selecting a suspension kit.

Kerb Weight - 1765-1815kgGVM - 2810kg

Maximum Load - 995-1045 (model dependent)

155P: (02) 9672 8899 | F: (02) 9672 8099


KUN26R - MINING APPLICATIONS4/05-15HILUX

TOYOTA

41mm Foam Cell Struts Require

Assembly



1 x Urethane Kit

T80LLCONSTANT 500KG

$ 1808

41mm Foam Cell Complete Assembly

Struts



1 x Urethane Kit

T80LLCONSTANT 500KG

$ 1954

When Selecting Mining Applications:

Carrying loads above the GVM in the tray of the vehicle will result in the following problems• The Rear of the vehicle will drop down and the

front ride height will increase.• The struts will be riding at near full extension at

all times• When the vehicle is driven in this condition, the

strut will top out (reach full extension) repeatedly.• This leads to leakages and will eventually break

the lower eye bush ring from the shock body.

With a 16” Rim fitted to the vehicle, the rim to guard ride height must not exceed 780mm as an Absolute Maximum

Please Note:

Mining Spec Trays are often significantly heavier that traditional trays, and can weigh in excess of 500kg by themselves.

When fitted to the vehicle, the remaining carrying capacity (GVM minus Vehicle Weight) is 500kg.When additional permenant loads are taken into account, there may be very little carrying capacity available in the vehicle.

Extra items to consider include:

1. Personnel2. Tools & Tool Boxes3. Vehicle Fuel4. Front mounted accessories (Bar/Winch/Dual

battery)5. R.O.P.S

Please Call 4Way Suspension on (02) 9672 8899 for specialist assistance when selecting components for mining vehicle applications.






AN120/130 (COIL/LEAF)15 OnHILUXTOYOTA

REAR SUSPENSION



COIL SPRINGSTDC983S 2 OE Height Only $ 135 ea OE Replacement Only

TDC983 2 40mm Lift Spring $ 135 ea Petrol/Diesel/No bar

TDC974H 2 40mm Lift Spring $ 135 ea Petrol/Diesel/Bar

TDC974HH 2 40mm Lift Spring $ 135 ea Petrol/Diesel/Bar/Winch

COMPLETE STRUT ASSEMBLYTOY-027/01 2 BM404600/TDC983S $ 518 ea OE Replacement Only

TOY-027/02 2 BM404600/TDC983 $ 518 ea Petrol/Diesel/No bar

TOY-027/03 2 BM404600/TDC974H $ 518 ea Petrol/Diesel/Bar

TOY-027/04 2 BM404600/TDC974HH $ 518 ea Petrol/Diesel/Bar/Winch

TOY-027/05 2 FC404600/TDC983S $ 456 ea OE Replacement Only

TOY-027/06 2 FC404600/TDC983 $ 456 ea Petrol/Diesel/No bar

TOY-027/07 2 FC404600/TDC974H $ 456 ea Petrol/Diesel/Bar

TOY-027/08 2 FC404600/TDC974HH $ 456 ea Petrol/Diesel/Bar/Winch



Suit OE HeightBM403014 2 40mm Adjustable Shock $ 207 ea

BD3015T 2 35mm Nitro Gas Shock $ 140 ea Fit for Comfort Applications

FC43015 2 41mm Foam Cell Shock $ 176 eaSuit 40mm Lift


LEAF SPRINGS - FIT CONSTANT LEAVES ONLY FOR CONSTANT LOAD FITTED - FAILURE MAY OCCUR

T81C 2 0-300KG Load $ 207 ea 40mm Lift






TDGP-668 1 Greasable Pin Kit $ 83 Kit


Replacement Bushings - see p148

157P: (02) 9672 8899 | F: (02) 9672 8099


AN120/130 (COIL/LEAF)15 On

HILUXTOYOTA

Foam Cell Struts Require

Assembly



1 x Urethane Kit

T81C0-300KG

$ 1682

T81LCONSTANT 300KG

$ 1828

T81LLCONSTANT 500KG

$ 1858


Struts



1 x Urethane Kit

T81C0-300KG

$ 1828

T81LCONSTANT 300KG

$ 1974

T81LLCONSTANT 500KG

$ 2004


Assembly



1 x Urethane Kit

T81C0-300KG

$ 1868

T81LCONSTANT 300KG

$ 2014

T81LLCONSTANT 500KG

$ 2044


Struts



1 x Urethane Kit

T81C0-300KG

$ 2014

T81LCONSTANT 300KG

$ 2160

T81LLCONSTANT 500KG

$ 2190


Note: Leaf spring front eye bolt & Headlight leveling sensor fitting instructionsavailable at toughdog.com.au






40, 42 SERIES12/77-84LANDCRUISERTOYOTA





LEAF SPRINGS - Check Eye Size Prior to OrderingBP-009 2 50mm Lift Spring - 25mm Eyering $ 238 ea Petrol/Diesel/Bar

BP-009H 2 50mm Lift Spring - 25mm Eyering $ 274 ea Petrol/Diesel/Bar/Winch

BP-011 2 50mm Lift Spring - 35mm Eyering $ 238 ea Petrol/Diesel/Bar

BP-011H 2 50mm Lift Spring - 35mm Eyering $ 260 ea Petrol/Diesel/Bar/Winch




COMPONENTSTDUK-016 1 Urethane Shackle Bushing Kit $ 57 ea Suits 25mm Eye Springs

TDUK-012 1 Urethane Shackle Bushing Kit $ 68 ea Suits 35mm Eye Springs


TDGP-346 1 Greasable pins $ 83 ea Suits 25mm Eye Springs

TDGS-343 1 Greasable Shackles $ 93 ea Suits 25mm Eye Springs



QUANTITY PER SHOCK404702 2 Suits Front Top & bottom Eye $ 3 ea Eyering Bushing

404702 2 Suits Rear Top & bottom Eye $ 3 ea Eyering Bushing

159P: (02) 9672 8899 | F: (02) 9672 8099




REAR SUSPENSION

40, 42 SERIES12/77-84

LANDCRUISERTOYOTA



41mm Foam Cell

BP-009 + BP-010 $ 1894

BP-009H+BP-010H $ 2008

BP-011+BP012 $ 1936

BP-011H+BP-012H $ 2082


BP-009 + BP-010 $ 2018

BP-009H+BP-010H $ 2132

BP-011+BP012 $ 2060

BP-011H+BP-012H $ 2206



Please Check Eye Size Prior to Ordering No Exchange for Special Order Parts


SHOCK ABSORBERSFC41366 2 41mm Foam Cell Shocks $ 176 ea Suit OE Height FJ40 59-84 To

Chassis # 191114BM401366 2 40mm 9 Stage Adjustable Shock $ 207 ea

FC41382 2 41mm Foam Cell Shocks $ 176 ea Suit 50mm Lift FJ40 59-84 To Chassis # 191114BM401382 2 40mm 9 Stage Adjustable $ 207 ea

FC41382 2 41mm Foam Cell Shocks $ 176 ea Suit OE Height BJ40 12/77-80 & BJ42 - Chassis 191115 OnBM401382 2 40mm 9 Stage Adjustable Shock $ 207 ea

FC41388 2 41mm Foam Cell Shocks $ 176 ea Suit 50mm Lift BJ40 12/77-80 & BJ42 - Chassis 191115 OnBM401388 2 40mm 9 Stage Adjustable $ 207 ea

LEAF SPRINGS - Check Eye Size Prior to OrderingBP-010 2 50mm Lift Spring - 25mm Eyering $ 238 ea 0-300kg Load

BP-010H 2 50mm Lift Spring - 25mm Eyering $ 259 ea CONSTANT 300Kg Load

BP-012 2 50mm Lift Spring - 35mm Eyering $ 248 ea 0-300kg Load

BP-012H 2 50mm Lift Spring - 35mm Eyering $ 299 ea CONSTANT 300Kg Load













45, 47 SERIES1/65-84LANDCRUISERTOYOTA





LEAF SPRINGS - Check Eye Size Prior to OrderingBP-013 (45 SERIES) 2 50mm Lift Spring - 25mm Eyering $ 280 ea Petrol/Diesel/Bar

BP-013H (45 SERIES) 2 50mm Lift Spring - 25mm Eyering $ 299 ea Petrol/Diesel/Bar/Winch

BP-015 (47 SERIES) 2 50mm Lift Spring - 35mm Eyering $ 280 ea Petrol/Diesel/Bar

BP-015H (47 SERIES) 2 50mm Lift Spring - 35mm Eyering $ 300 ea Petrol/Diesel/Bar/Winch












QUANTITY PER SHOCK404702 2 Suits Front Top & bottom Eye $ 3 ea Eyering Bushing

404702 2 Suits Rear Top & bottom Eye $ 3 ea Eyering Bushing

161P: (02) 9672 8899 | F: (02) 9672 8099




REAR SUSPENSION

45, 47 SERIES1/65-84

LANDCRUISERTOYOTA



41mm Foam Cell

BP-013 + BP-014 $ 2142

BP-013H+BP-014H $ 2220

BP-015+BP016 $ 2164

BP-015H+BP-016H $ 2244


BP-013 + BP-014 $ 2266

BP-013H+BP-014H $ 2344

BP-015+BP016 $ 2288

BP-015H+BP-016H $ 2368



Please Check Eye Size Prior to Ordering No Exchange for Special Order Parts






LEAF SPRINGS - Check Eye Size Prior to OrderingBP-014 (45 SERIES) 2 50mm Lift Spring - 30mm Eyering $ 320 ea 0-300kg Load

BP-014H (45 SERIES) 2 50mm Lift Spring - 30mm Eyering $ 340 ea CONSTANT 300Kg Load

BP-016 (47 SERIES) 2 50mm Lift Spring - 35mm Eyering $ 320 ea 0-300kg Load

BP-016H (47 SERIES) 2 50mm Lift Spring - 35mm Eyering $ 340 ea CONSTANT 300Kg Load





TDGS-344/5 1 Greasable Shackles $ 93 ea Suits 30mm Eye Springs


TDGS-349/5 1 Greasable Shackles $ 93 ea Suits 35mm Eye Springs





60, 61, 62 SERIES11/80-91LANDCRUISERTOYOTA





LEAF SPRINGST43L 2 50mm Lift Spring $ 185 ea Petrol/Diesel/Bar

T43H 2 50mm Lift Spring $ 207 ea Petrol/Diesel/Bar/Winch

T53 2 50mm Lift Spring (T/Diesel ONLY) $ 247 ea Factory T.Diesel/Bar

T53H 2 50mm Lift Spring (T/Diesel ONLY) $ 270 ea Factory T.Diesel/Bar/Winch








TAK-005 1 Offset King Pin $ 260 ea 0.5 Degree




41mm Foam Cell

T43L $ 852

T43H $ 896

T53 $ 976

T53H $ 1022


T43L $ 914

T43H $ 958

T53 $ 1004

T53H $ 1084




163P: (02) 9672 8899 | F: (02) 9672 8099





REAR SUSPENSION

60, 61, 62 SERIES11/80-91

LANDCRUISERTOYOTA



41mm Foam Cell

T44L 0-300Kg $ 896

T44H 300Kg + $ 962

T44HM 500Kg + $ 1102


T44L 0-300Kg $ 958

T44H 300Kg + $ 1024

T44HM 500Kg + $ 1164



REAR KIT PRICE REFERENCE



404702 2 Suits Top & Bottom Rear Eyering $ 3 ea Eyering Bushing (#1382)

ADJ00191 2 Suits Top & Bottom Rear Eyering $ 3 ea Eyering Bushing (#1350)

SHOCK ABSORBERSFC41366 2 41mm Foam Cell Shocks $ 176 ea Suit OE Height

11/80-10/85 Models ONLYBM401366 2 40mm 9 Stage Adjustable Shock $ 207 ea

FC41382 2 41mm Foam Cell Shocks $ 176 ea Suit 50mm Lift 11/80-10/85 Models ONLYBM401382 2 40mm 9 Stage Adjustable $ 207 ea

FC41350 2 41mm Foam Cell Shocks $ 176 ea Suits Up to 50mm 10/85-91 Models ONLY BM401350 2 40mm 9 Stage Adjustable $ 207 ea

LEAF SPRINGST44L 2 0-300Kg Load $ 207 ea 50mm Lift Spring

T44H 2 CONSTANT 300Kg Load $ 240 ea 50mm Lift Spring

T44HM 2 CONSTANT 500Kg Load $ 310 ea 50mm Lift Spring








ESTIMATED LIFT:

REAR SUSPENSION

40mm

70 SERIES BUNDERA11/84-91LANDCRUISERTOYOTA

SHOCK ABSORBERSFC41005 2 41mm Foam Cell Shocks $ 176 ea OE Height

FC41007 2 41mm Foam Cell Shocks $ 176 ea 40mm Lift

COIL SPRINGSTDC941L 2 40mm Lift Spring $ 135 ea Suit Petrol/Diesel/Bar




COMPONENTSTDUK-042 1 Radius Rod to Diff $ 104 ea 2 Kits Required

TDUK-041 1 Radius Rod to Chassis $ 68 ea 1 Kit Required

SHOCK ABSORBERSFC43005 1 41mm Foam Cell Shocks $ 176 ea OE Height - D/S

FC41107 1 41mm Foam Cell Shocks $ 176 ea OE Height - P/S

FC41350 1 41mm Foam Cell Shocks $ 176 ea 40mm Lift - D/S

FC41108 1 41mm Foam Cell Shocks $ 176 ea 40mm Lift - P/S

COIL SPRINGSTDC942L 2 0-300Kg Load $ 135 ea 40mm Lift Spring

COMPONENTSTDUK-042 1 Radius Rod to Diff $ 104 ea 2 Kits Required

TDUK-041 1 Radius Rod to Chassis $ 68 ea 1 Kit Required

REPLACEMENT BUSHINGSQUANTITY PER SHOCK (check shock fittings prior to ordering)

TW959 4 Suits Top & Bottom Front Pin $ 3 ea Pin Style Bushing

TW959 2 Suits Top Rear Pin $ 3 ea Eyering Bushing #1108 & #1107

ADJ00191 2 Suits Top & Bottom Rear Eyering $ 3 ea Eyering Bushing #1350 & #3005

ADJ00191 2 Suits Top & Bottom Eye $ 3 ea Eyering Bushing #1108 & #1107


41mm Foam Cell 40mm LIFT $ 1244



165P: (02) 9672 8899 | F: (02) 9672 8099


71, 74 SERIES SWB & LWBHZJ71 & HZJ74

LANDCRUISERTOYOTA


REAR SUSPENSION

SHOCK ABSORBERSFC41050 2 41mm Foam Cell Shocks $ 176 ea Up to 50mm Lift


BMX1050/2 2 45mm 9 Stage Adjustable $ 285 ea 50mm Lift

TDR1050B 2 53mm ‘Ralph’ Big Bore $ 285 ea Up to 50mm Lift

COIL SPRINGSTDC950SL 2 50mm Lift Spring $ 135 ea Suit Petrol/Diesel/Bar

TDC950L 2 50mm Lift Spring $ 135 ea Suit Petrol/Diesel/Bar/Winch




SHOCK ABSORBERSFC41377 2 41mm Foam Cell Shocks $ 176 ea 50mm Lift

BM401377 2 40mm 9 Stage Adjustable $ 207 ea 50mm Lift


TDR1377 2 53mm ‘Ralph’ Big Bore $ 285 ea 50mm Lift



COMPONENTSTDUK-012 1 Urethane Bushing kit $ 68 ea 1 Kits Required

TDUB-017 2 U-Bolt Kits $ 31 ea 2 Kit Required



300KG + $ 1584


0-300KG $ 1642

300KG + $ 1708

45mm Adjustable or 53mm Ralph

0-300KG $ 1954

300KG + $ 2020

Includes2 X Coil Springs 2 x Leaf Springs 4 x Shocks







70, 73, 74 SERIES11/84-92LANDCRUISERTOYOTA


BM401113 2 40mm 9 Stage Adjustable $ 207 ea OE Height




TDR1163B 2 53mm ‘Ralph’ Big Bore $ 285 ea 50mm Lift

LEAF SPRINGST52 2 50mm Lift Spring $ 170 ea Suit Petrol/Diesel/Bar






TDGP-351 1 Greasable Pins $ 83 ea


TAK-005 1 Offset King Pin $ 260 ea Fits to Top of Knuckle




TW959 2 Suits Top front Pin $ 3 ea Pin Style Bushing

ADJ00191 1 Suits Bottom Front Eye $ 3 ea Eyering Bushing

ADJ00191 2 Suits Top & Bottom Rear Eyering $ 3 ea Eyering Bushing

167P: (02) 9672 8899 | F: (02) 9672 8099


70, 73, 74 SERIES11/84-92

LANDCRUISERTOYOTA


BM401350 2 40mm 9 Stage Adjustable $ 207 ea OE Height




TDR1377 2 53mm ‘Ralph’ Big Bore $ 285 ea 50mm Lift





TDGP-351 1 Greasable Pins $ 83 ea


REAR SUSPENSION


41mm Foam CellT44L 0-300Kg $ 1720

T44H 300Kg + $ 1786


T44L 0-300Kg $ 1844

T44H 300Kg + $ 1910


or53mm Ralph

T44L 0-300Kg $ 2156

T44H 300Kg + $ 2222








ESTIMATED LIFT:

41mm Foam CellT52 $ 822

T52H $ 882


T52 $ 884

T52H $ 944


T52 $ 1040

T52H $ 1100



50mm

75 SERIES11/84-99LANDCRUISERTOYOTA

SHOCK ABSORBERSFC41113B 2 41mm Foam Cell Shocks $ 176 ea Suit OE Height

FC41163B 2 41mm Foam Cell Shocks $ 176 ea Suit 50mm Lift (HZJ75 3/90-99)

FC41163 2 41mm Foam Cell Shocks $ 176 ea Suit 50mm Lift All except HZJ75


BMX1163/2 2 45mm 9 Stage Adjustable $ 285 ea Suits All Models

TDR1163B 2 53mm ‘Ralph’ Big Bore $ 285 ea

LEAF SPRINGST52 2 50mm Lift Spring $ 170 ea Petrol/Diesel/Bar












SHOCK CHOICE SPRING CHOICE RRP inc GST CONTENTS FRONT END KIT PRICE REFERENCE

169P: (02) 9672 8899 | F: (02) 9672 8099





REAR SUSPENSION

75 SERIES11/84-99

LANDCRUISERTOYOTA



41mm Foam Cell

T51 0-300Kg $ 1266

FS751M 300Kg + $ 1266

FS751HM 500Kg + $ 1308


T51 0-300Kg $ 1328

FS751M 300Kg + $ 1328

FS751HM 500Kg + $ 1370


T51 0-300Kg $ 1484

FS751M 300Kg + $ 1484

FS751HM 500Kg + $ 1526



REAR KIT PRICE REFERENCE




SHOCK ABSORBERSFC41350 2 41mm Foam Cell Shocks $ 176 ea Suit OE Height


Suit 50mm LiftBM401377 2 40mm 9 Stage Adjustable Shock $ 207 ea

BMX1377/2 2 45mm 9 Stage Adjustable $ 285 ea

TDR1377 2 53mm ‘Ralph’ Big Bore $ 285 ea

LEAF SPRINGST51 2 0-300Kg Load $ 387 ea 50mm Lift Spring


FS751HM 2 CONSTANT 500Kg Load $ 408 ea 50mm Lift Spring





AIR ASSIST BAGSTDAA-115 1 Bellows bag kit $ 825 ea Suits up to 75mm Lift





76 SERIES WAGON07 onLANDCRUISERTOYOTA


BM401050 2 40mm 9 Stage Adjustable Shock $ 207 ea Up to 50mm Lift



COIL SPRINGSTDC950SL 2 OE Height Spring $ 135 ea Suits OE Height Petrol/Diesel/Bar

TDC950L 2 50mm Lift Spring $ 135 ea Petrol/Diesel/Bar





CASTER CORRECTIONTDUK-054/2 1 2 Degree Caster Correction $ 207 ea Optional Component


COMPONENTSTDSP-013 1 Front Swaybar spacer kit $ 41 ea fit if tailshaft contacts swaybar




TDUK-1961/30 1 Urethane Spring Spacers 30mm $ 42 ea

41mm Foam Cell Includes


2 x Leaf Springs2 x U-Bolt Kits

1 x Urethane Kit(TDUK-048)

FS7610-300KG

$ 1804

FS761MCONSTANT 300KG

$ 1908


$ 1994


171P: (02) 9672 8899 | F: (02) 9672 8099




REAR SUSPENSION

76 SERIES WAGON07 On

LANDCRUISERTOYOTA




TDR1377 2 53mm ‘Ralph’ Big Bore $ 285 ea Up to 50mm Lift

LEAF SPRINGS - Check Eye Size Prior to OrderingFS761 2 0-300Kg Load $ 340 ea 50mm Lift Spring



COMPONENTSTDUK-048 1 Urethane Bushing Kit pre 01/17 $ 88 ea Use w Greasable pins & shackles (all years)

TDUK-048/14 1 Urethane Bushing Kit post 01/17 $ 145 ea


TDSP-014 1 Brake Bias Bracket $ 25 Suits up to build date 01/2017

TDSP-015 1 Handbrake relocation bracket $ 35 Fit with BMX or TDR shocks


TDGS-387/18 1 Greasable Shackles $ 93 ea






1 x Urethane Kit

FS7610-300KG

$ 1928


$ 2032


$ 2118

45mm Adjustable or53mm ‘Ralph’

Big BoreIncludes


2 x Leaf Springs

FS7610-300KG

$ 2240


$ 2344


$ 2430

SHOCK CHOICE SPRING CHOICE RRP inc GST CONTENTS COMPLETE KIT PRICE REFERENCE Final Kit price varies by TDUK. Price shown incl. TDUK-048




ESTIMATED LIFT:

REAR SUSPENSION

50mm

77 SERIES FZJ77, HZJ77, PZJ7793-99LANDCRUISERTOYOTA


TW959 2 Suits Top Front Pin $ 3 ea Pin Style Bushing

ADJ00191 1 Suits Front Bottom Eye $ 3 ea Eyering Bushing

ADJ00191 2 Suits Top & Bottom Rear Eyering $ 3 ea Eyering Bushing

SHOCK ABSORBERSFC41113B 2 41mm Foam Cell Shocks $ 176 ea Suit OE Height

FC41163B 2 41mm Foam Cell Shocks $ 176 ea

Suit 50mm LiftBM401163 2 40mm 9 Stage Adjustable Shock $ 207 ea

BMX1163/2 2 45mm 9 Stage Adjustable $ 285 ea

TDR1163B 2 53mm ‘Ralph’ Big Bore $ 285 ea

LEAF SPRINGST52 2 50mm Lift Spring $ 170 ea Petrol/Diesel/Bar













LEAF SPRINGS - Check Eye Size Prior to OrderingFS761 2 0-300Kg Load $ 340 ea 50mm Lift Spring






173P: (02) 9672 8899 | F: (02) 9672 8099


78 SERIES WITH COIL SPRINGSKZJ78 (INTERNATIONAL

LANDCRUISERTOYOTA


REAR SUSPENSION



COIL SPRINGSTDC960L 2 50mm Lift Spring $ 135 ea Suit Petrol/Diesel/Bar

TDC960HL 2 50mm Lift Spring $ 135 ea Suit Petrol/Diesel/Bar/Winch




SHOCK ABSORBERSFC41255 2 41mm Foam Cell Shocks $ 176 ea 50mm Lift


COIL SPRINGSTDC961L 2 0-300Kg Load $ 135 ea 50mm Lift Spring

TDC961HL 2 CONSTANT 300Kg Load $ 135 ea 50mm Lift Spring


41mm Foam Cell ANY COIL $ 1244


ANY COIL $ 1368






ESTIMATED LIFT:





BP-0190-200KG

$ 1950

FS781CONSTANT 400KG

$ 2024


$ 2218

FS781XHDCONSTANT 900KG

$ 2754

50mm

78, 79 SERIES INC V8 (EXCEPT DUAL CAB)10/99 OnLANDCRUISERTOYOTA









Suits 6 Cylinder ModelsSS5001-P/S 1 Return to Centre Damper $ 175 ea



Suits V8 ModelsSS5004-P/S 1 Return to Centre Damper $ 175 ea


CASTER CORRECTIONTDUK-054/2 1 2 Degree Caster Correction $ 207 ea instructions at toughdog.com.au

PANHARD RODSTDPR-079 1 Adjustable Panhard Rod $ 250 ea Suits 6 Cylinder Engine

TDPR-015 1 Adjustable Panhard Rod $ 240 ea Suit V8 only up to ‘08/16

TDPR-006 1 Adjustable Panhard Rod $ 250 ea Suit V8 from ‘09/16 (5 star ANCAP)

TDPR-019 1 Adjustable Panhard Rod $ 260 ea LHD Vehicles (6 Cylinder)


TDUK-1961/30 1 30mm Urethane Spring Spacer $ 42 ea

TDUK-043 1 Panhard Rod Bushings $ 52 ea Suits all Panhard Rods above




SHOCK CHOICE SPRING CHOICE RRP inc GST CONTENTS COMPLETE KIT PRICE REFERENCE Note: FS781XHD kit price includes rear sway bar

175P: (02) 9672 8899 | F: (02) 9672 8099


REAR SUSPENSION

78, 79 SERIES INC V8 (EXCEPT DUAL CAB)10/99 On

LANDCRUISERTOYOTA






LEAF SPRINGS - **NOTE: Include weight of tray when calculating CONSTANT LOAD**BP-019 2 0-200Kg Load $ 413 ea 50mm Lift Spring

FS781 2 CONSTANT 400Kg Load $ 450 ea 50mm Lift Spring


FS781XHD 2 CONSTANT 900Kg Load $ 570 ea 50mm Lift - Fit TDSB-008 also

COMPONENTSTDSB-008 1 Heavy Duty Sway Bar $ 490 ea Fit with Constant 800kg springs

TDUK-048 1 Urethane Shackle Bushing Kit $ 88 ea Suits V8 & w G’ Pins & Shackles

TDUK-048/14 1 Urethane Shackle Bushing Kit $ 145 ea For Utes built before 06/2009

TDUK-048/18 1 Urethane Shackle Bushing Kit $ 140 ea For T’carrier built before 06/2009


TDUB-038 2 U-Bolt Kit $ 31 ea For use with FS781XHD

TDSP-014 1 Brake Bias Bracket $ 25 ea Not req’d when built after 01/17

TDSP-015 1 Handbrake relocation bracket $ 35 ea Fit with BMX or TDR shocks







1 x Urethane Kit

BP-019 - 0-200KG $ 2074

FS781CONSTANT 400KG

$ 2148


$ 2342


$ 2878


Big BoreIncludes


2 x Leaf Springs

BP-019 - 0-200KG $ 2421

FS781CONSTANT 400KG

$ 2495


$ 2689


$ 3225

SHOCK CHOICE SPRING CHOICE RRP inc GST CONTENTS COMPLETE KIT PRICE REFERENCE Final Kit price varies by TDUK. Price shown incl. TDUK-048



Note: FS781XHD kit price includes rear sway bar





79 SERIES DUAL CAB12 OnLANDCRUISERTOYOTA









Suits V8 ModelsSS5004-P/S 1 Return to Centre Damper $ 175 ea


CASTER CORRECTIONTDUK-054/2 1 2 Degree Caster Correction $ 207 ea instructions at toughdog.com.au



TDUK-1961/30 1 30mm Urethane Spring Spacer $ 42 ea











FS781CONSTANT 300KG

$ 2024


$ 2218


$ 2754


177P: (02) 9672 8899 | F: (02) 9672 8099


REAR SUSPENSION

79 SERIES DUAL CAB12 On

LANDCRUISERTOYOTA





LEAF SPRINGS - OE vehicle weight based on cab chassis (excludes tub/tray)FS781 2 CONSTANT 300Kg Load $ 450 ea 50mm Lift Spring


FS781XHD 2 CONSTANT 800Kg Load $ 570 ea 50mm Lift - Fit TDSB-008 also

COMPONENTSTDSB-008 1 Heavy Duty Sway Bar $ 490 ea Fit with Constant 700kg springs

TDUK-048 1 Urethane Shackle Bushing Kit $ 88 ea


TDUB-038 2 U-Bolt Kit $ 52 ea For use with FS781XHD

TDSP-014 1 Brake Bias Bracket $ 25 ea Not req’d when built after 01/17

TDSP-015 1 Handbrake relocation bracket $ 35 ea Fit with BMX or TDR shocks











FS781CONSTANT 300KG

$ 2148


$ 2342


$ 2878


Big BoreIncludes



1 x Urethane Kit1 x H’brake bkt Kit

FS781CONSTANT 300KG

$ 2495


$ 2689


$ 3225


Note: FS781XHD kit price includes rear sway bar





80 & 105 SERIES3/90-07LANDCRUISERTOYOTA





COIL SPRINGSTDC943S 2 Petrol/Alloy Bar $ 135 ea

3/90-91 80 Series ApplicationSuits 25mm Lift

TDC948L 2 Diesel/Bar $ 135 ea

TDC948HL 2 Petrol/Diesel Bar & Winch $ 135 ea

TDC943 2 Petrol/Diesel Bar $ 135 ea 3/90-91 80 Series ApplicationSuits 50mm LiftTDC943H 2 Petrol/Diesel Bar & Winch $ 135 ea

TDC948SL 2 Petrol/Alloy Bar $ 135 ea 9/91-98 80 Series &3/98-07 100 Series ApplicationSuits 25mm Lift

TDC948HSL 2 Petrol/Diesel Bar & Winch $ 135 ea

TDC948L 2 Petrol Deisel Bar, Winch & D/Batt $ 135 ea

TDC943S 2 80 Series ONLY No bar $ 135 ea9/91-98 80 Series &3/98-07 100 Series Application Suits 50mm Lift

TDC948L 2 Petrol/Diesel/Bar $ 135 ea

TDC948HL 2 Petrol Diesel/Bar/Winch $ 135 ea

TDC943H 2 Petrol Diesel/Bar/Winch/D.Batt $ 135 ea






TDPR-001 1 Adjustable Panhard Rod $ 260 ea LHD ONLY






TAK-8005 1 Offset Kingpin $ 290 ea 0.5 Degree







179P: (02) 9672 8899 | F: (02) 9672 8099




REAR SUSPENSION

80 & 105 SERIES3/90-07

LANDCRUISERTOYOTA






COIL SPRINGSTDC945S 2 25mm Lift 0-300Kg Load $ 135 ea

3/90-91 80 Series ApplicationSuits 25mm Lift

TDC949L 2 25mm Lift CONSTANT 300kg $ 135 ea

TDC949HL 2 25mm Lift CONSTANT 500kg $ 175 ea

TDC945 2 50mm Lift 0-300Kg Load $ 165 ea 3/90-91 80 Series ApplicationSuits 50mm LiftTDC945H 2 50mm Lift CONSTANT 300kg $ 196 ea

TDC949SL 2 25mm Lift 0-300Kg Load $ 135 ea 9/91-98 80 Series &3/98-07 100 Series ApplicationSuits 25mm Lift

TDC949HSL 2 25mm Lift CONSTANT 300kg $ 135 ea

TDC949L 2 25mm Lift CONSTANT 500kg $ 135 ea

TDC945S 2 50mm Lift No Load $ 135 ea9/91-98 80 Series &3/98-07 100 Series Application Suits 50mm Lift

TDC949L 2 50mm Lift 0-300Kg Load $ 135 ea

TDC949HL 2 50mm Lift CONSTANT 300kg $ 175 ea

TDC945H 2 50mm Lift CONSTANT 500kg $ 196 ea


COMPONENTSTDUK-045 1 Trailing Arm Bushing Kit (Upper) $ 140 ea 1 Kit required (Upper)

TDUK-046 1 Trailing Arm Bushing Kit (Lower) $ 140 ea 1 Kit required (Lower)


TDUK-1724/15 1 Urethane Spring Spacer 15mm $ 37 ea 1 per coil as required


AIR ASSIST BAGSTDAA-010 1 Coil insert bag kit $ 370 ea Suits up to 25mm Lift

TDAA-011 1 Coil insert bag kit $ 370 ea Suits up to 50mm Lift









45mm Big Bore or 53mm ‘Ralph’








80 & 105 SERIES 3” LIFT1/90-07LANDCRUISERTOYOTA

SHOCK ABSORBERSFC41002 2 41mm Foam Cell Shocks $ 176 ea Suits 75mm Lift

BM401002 2 40mm 9 Stage Adjustable Shock $ 207 ea Suits 75mm Lift


TDR1002B 2 53mm ‘Ralph’ Big Bore Shock $ 285 ea Suits 75mm Lift

COIL SPRINGSTDC943 2 Petrol/Alloy Bar $ 135 ea 75mm Lift Spring

TDC948/3 2 Diesel/Bar $ 175 ea 75mm Lift Spring

TDC943H 2 Petrol/Diesel Bar & Winch $ 135 ea 75mm Lift Spring















BRAKE HOSE KITSTDBH-003 1 Rubber Brake Hose Kit $ 145 ea

80 & 105 Series Non ABSTDBH-197 1 Braided Brake Hose Kit $ 260 ea

TDBH-300 1 Rubber Brake Hose Kit $ 207 ea80 Series with ABS

TDBH-200 1 Braided Brake Hose Kit $ 295 ea



FOR REPLACEMENT BUSHING PART NUMBERS, PLEASE SEE PAGE (P166) PREVIOUS IN CATALOGUE

181P: (02) 9672 8899 | F: (02) 9672 8099




REAR SUSPENSION

80 & 105 SERIES 3” LIFT1/90-07

LANDCRUISERTOYOTA


SHOCK ABSORBERSFC41111 2 41mm Foam Cell Shocks $ 176 ea Suits 75mm Lift

BM401111 2 40mm 9 Stage Adjustable Shock $ 207 ea Suits 75mm Lift


TDR1111 2 53mm ‘Ralph’ Big Bore Shock $ 285 ea Suits 75mm Lift

COIL SPRINGSTDC949/3 2 75mm Lift 0-300Kg Load $ 175 ea 75mm Lift Spring

TDC945 2 75mm Lift CONSTANT 300kg $ 165 ea 75mm Lift Spring

TDC945H 2 75mm Lift CONSTANT 500kg $ 196 ea 75mm Lift Spring








41mm Foam Cell

$135 (F) $165 (R) $ 2146


4 x Shocks2 x Panhard Rods

1 x Caster Correction1 x Brake Hoses (TDBH-003)

$135 (F) $175 (R) $ 2166

$135 (F) $196 (R) $ 2208

$175 (F) $165 (R) $ 2226

$175 (F & R) $ 2246

$175 (F) $196 (R) $ 2280


$135 (F) $165 (R) $ 2270

$135 (F) $175 (R) $ 2290

$135 (F) $196 (R) $ 2332

$175 (F) $165 (R) $ 2350

$175 (F & R) $ 2370

$175 (F) $196 (R) $ 2404

45mm Big Bore or 53mm ‘Ralph’

$135 (F) $165 (R) $ 2582

$135 (F) $175 (R) $ 2602

$135 (F) $196 (R) $ 2664

$175 (F) $165 (R) $ 2662

$175 (F & R) $ 2682

$175 (F) $196 (R) $ 2716








COIL SPRINGSTDC948/4 2 Petrol/Diesel/Bar $ 175 ea 100mm Lift Spring

TDC948/4H 2 Petrol/Diesel Bar & Winch $ 185 ea 100mm Lift Spring

STEERING STABILIZERSSS5001-XHD 1 Return to Centre Damper $ 310 ea SUITS RHD VEHICLE

Fitting instructions attoughdog.com.auSV5001/4 1 9 Stage Adjustable Damper $ 310 ea

SS5002-XHD 1 Return to Centre Damper $ 310 ea SUITS LHD VEHICLEFitting instructions attoughdog.com.auSV5002/4 1 9 Stage Adjustable Damper $ 310 ea



















183P: (02) 9672 8899 | F: (02) 9672 8099




REAR SUSPENSION

80 & 105 SERIES 4” LIFT1/90-07

LANDCRUISERTOYOTA





TDC949/4H 2 100mm Lift CONSTANT 300kg $ 185 ea 100mm Lift Spring








41mm Foam Cell

$ 175 (F & R) $ 2309




$185 (F) $175 (R) $ 2329

$ 185 (F & R) $ 2349

45mm Big Bore

$ 175 (F & R) $ 2745

$185 (F) $175 (R) $ 2765

$ 185 (F & R) $ 2785






SHOCK ABSORBERSBMX1002/6 2 45mm 9 Stage Adjustable Shock $ 285 ea Suits 125mm Lift
























185P: (02) 9672 8899 | F: (02) 9672 8099




REAR SUSPENSION

80 & 105 SERIES 5” LIFT1/90-07

LANDCRUISERTOYOTA













$ 175 (F & R) $ 2715




$175 (F) $185 (R) $ 2235

$185 (F) $175 (R) $ 2735

$185 (F & R) $ 2755






























187P: (02) 9672 8899 | F: (02) 9672 8099




REAR SUSPENSION

80 & 105 SERIES 6” LIFT1/90-07

LANDCRUISERTOYOTA













ANY COIL(RHD ONLY)

$ 2755








REAR SUSPENSION

100 SERIES (IFS)98-07LANDCRUISERTOYOTA


TDR1103 2 53mm ‘Ralph’ Shock $ 285 ea Up to 25mm Lift

TORSION BARS - Strengthening Bracket fitting instructions at toughdog.com.au4WTB-1600 1 Replacement Torsion Bars $ 495 pr 32mm/1203mm (For Petrol)

4WTB-1610 1 Replacement Torsion Bars $ 495 pr 32mm/1210mm (For Diesel)

4WTB-1610/BKT 1 Torsion Bar Strengthening Kit $ 52 ea Required with torsion bars


RIM TO GUARD MEASUREMENTS (Bottom of Rim to Guard)

For 16” Rim 740mm Torsion Bars must only be adjusted so that the rim to guard measurements are not more than the measurements listed here. Lifting the vehicle higher than the specified measurement will result

in the failure of front end components including shock failure.For 17” Rim 753mm



BMX1114/2 2 45mm 9 Stage Adjustable Shocks $ 285 ea

TDR1114 2 53mm ‘Ralph’ Big Bore $ 285 ea

COIL SPRINGSTDC949HSL 2 0-300kg Load $ 135 ea OE Height

TDC949L 2 0-300kg Load $ 135 ea 25mm Lift



COMPONENTSTDUK-025 1 Trailing Arm Bush Kit $ 140 ea 1 Kit required (Upper)

TDUK-026 1 Trailing Arm Bush Kit $ 140 ea 1 Kit required (Lower)




ADJ00300/40 1 Suits Bottom Front Eyering $ 6 ea Suits TDR Ralph Shocks Only

404454B 2 Suits Front Top Pin $ 4 ea Pin type bushing

404454B 1 Suits Rear Top of Top Pin $ 4 ea Pin type bushing

404454A 1 Suits Rear Bottom of Top Pin $ 4 ea Pin type bushing

415024 1 Suits Rear Bottom Eyering $ 4 ea Eyering bushing

189P: (02) 9672 8899 | F: (02) 9672 8099


100 SERIES (IFS)98-07

LANDCRUISERTOYOTA

41mm Foam Cell


4 x Shocks1x Torsion Bar

Strengthening Bracket

$ 135 Coil $ 1026

$ 175 Coil $ 1106





$ 135 Coil $ 1088

$ 175 Coil $ 1168

53mm ‘Ralph’ Front45mm Adjustable

Rear




$ 135 Coil $ 1462

$ 175 Coil $ 1542





$ 135 Coil $ 1462

$ 175 Coil $ 1542





ESTIMATED LIFT:


40mm

REAR SUSPENSION

200 Series11/07 OnLANDCRUISERTOYOTA



BMX1114/2 2 45mm 9 Stage Adjustable $ 285 ea Up to 20mm Lift

TDR1114 2 53mm Big Bore ‘Ralph’ $ 285 ea Up to 20mm Lift





TDSB-006 1 33mm H/D Sway Bar Kit $ 465 ea Suit Non-KDSS only

AIR ASSIST BAGSTDAA-010 1 Coil insert bag kit $ 370 ea Suits up to 25mm Lift


4WAY-001 1 Suits Bottom Front Eyering $ 10 ea Eyering Bonded Bushing

404454B + 404454A 1 (ea) Suits Rear Top Pin $ 4 ea Eyering Bushing

415024 1 Suits Rear Bottom Eyering $ 4 ea



BMX454900 2 45mm Adjustable Strut $ 360 ea Does not suit factory coils

COIL SPRINGSTDC930SL 2 OE Height Spring $ 135 ea OE Height Spring

TDC930HSL 2 OE Height Spring Bar & Winch $ 135 ea OE Height Spring

TDC930L 2 40mm Lift Spring $ 135 ea With Bar (excl. Sahara)

TDC930HL 2 40mm Lift Spring $ 135 ea With Bar & Winch (incl all Sahara)

TDC932L 2 40mm Lift Spring-BMX strut only $ 135 ea With Bar (OE height for Sahara)

TDC932HL 2 40mm Lift Spring-BMX strut only $ 135 ea With Bar & Winch (incl all Sahara)

COMPLETE STRUT ASSEMBLYTOY-200/01 2 BM404900/TDC930L $ 528 ea Petrol/Diesel With Bar

TOY-200/02 2 BM404900/TDC930HL $ 528 ea Petrol/Diesel with Bar & Winch

TOY-200/04 2 FC404900/TDC930L $ 466 ea Petrol/Diesel With Bar

TOY-200/05 2 FC404900/TDC930HL $ 466 ea Petrol/Diesel with Bar & Winch

TOY-200/07 2 BMX454900/TDC932L (45mm) $ 578 ea Petrol/Diesel With Bar

TOY-200/08 2 BMX454900/TDC932HL (45mm) $ 578 ea Petrol/Diesel with Bar & Winch

REPLACEMENT STRUT TOPTOY-1020 2 Strut Top $83 ea Replacement Strut Top


191P: (02) 9672 8899 | F: (02) 9672 8099



AssemblyIncludes





StrutsIncludes





AssemblyIncludes





StrutsIncludes





AssemblyIncludes





StrutsIncludes




200 Series11/07 On

LANDCRUISERTOYOTA


Note: Vehicles fitted with KDSS require a specific fitment procedure to be followed to avoid failure.

Instructions available at toughdog.com.au




ESTIMATED LIFT:


40mm

REAR SUSPENSION

95 SERIES7/96-03PRADOTOYOTA


OE HeightBM401108 2 40mm 9 Stage Adjustable $ 207 ea

FC41113 2 41mm Foam Cell Shock $ 176 ea40mm Lift


COIL SPRINGSTDC973S 2 0-300kg Load $ 135 ea 25mm Lift





TW959 2 Suits Top Rear Pin Mount $ 3 ea Pin Style Bushing




COIL SPRINGSTDC971S 2 25mm Lift Spring $135 ea

TDC971 2 40mm Lift Spring $135 ea Petrol/Diesel/Bar

TDC971H 2 40mm Lift Spring $135 ea Petrol/Diesel/Bar/Winch

COMPLETE STRUT ASSEMBLYTOY-095/01 2 BM404100/TDC971 $518 ea All with/Diesel/Bar

TOY-095/02 2 BM404100/TDC971H $518 ea All with/Diesel/Bar/Winch

TOY-095/03 2 FC404100/TDC971 $456 ea All with/Diesel/Bar

TOY-095/04 2 FC404100/TDC971H $456 ea All with/Diesel/Bar/Winch

TOY-095/05 2 FC404100/TDC971S $456 ea All with/Diesel (OE Height)

TOY-095/06 2 BM404100/TDC971S $518 ea All with/Bar(OE Height)


193P: (02) 9672 8899 | F: (02) 9672 8099


95 Series7/96-03

PRADOTOYOTA


AssemblyIncludes


ANY $ 1388


StrutsIncludes


ANY $ 1534


AssemblyIncludes


ANY $ 1574


StrutsIncludes


ANY $ 1720





ESTIMATED LIFT:


40mm

REAR SUSPENSION

120 SERIES LWB & SWB2/03-10PRADOTOYOTA


40mm LiftBM401116 2 40mm 9 Stage Adjustable $ 207 ea

COIL SPRINGS - Please check LWB/SWB prior to orderingTDC975S 2 0-300kg Load $ 135 ea OE Height - Suit LWB

TDC975 2 0-300kg Load $ 135 ea 40mm Lift - Suit LWB

TDC975H 2 CONSTANT 300Kg Load $ 135 ea 40mm Lift - Suit LWB

TDC975S 2 0-300kg Load $ 135 ea 40mm Lift - Suit SWB

TDC975 2 CONSTANT 300Kg Load $ 135 ea 40mm Lift - Suit SWB

TDC975AB 2 0-300kg Load $ 135 ea 40mm Lift - Airbag Conversion

TDC975HAB 2 CONSTANT 300Kg Load $ 135 ea 40mm Lift - Airbag Conversion

AIR ASSIST BAGSTDAA-009 1 Coil insert bag kit $ 370 ea Suits up to 40 mm Lift

Air Assist bags are coil insert only and do not suit as OEM airbag replacements







COIL SPRINGS - Please check LWB/SWB prior to orderingTDC974S 2 OE Height Spring $ 135 ea Petrol/Diesel/Bar



COMPLETE STRUT ASSEMBLY - Please check LWB/SWB prior to orderingTOY-120/01 2 BM404400/TDC974 $ 518 ea All With Bar

TOY-120/02 2 BM404400/TDC974H $ 518 ea All With Bar/Winch

TOY-120/03 2 FC404400/TDC974 $ 456 ea All With Bar

TOY-120/04 2 FC404400/TDC974H $ 456 ea All With Bar/Winch

TOY-120/07 2 FC404400/TDC974S $ 456 ea All With Bar (OE Height)

TOY-120/08 2 BM404400/TDC974S $ 518 ea All With Bar/Winch (OE Height)



195P: (02) 9672 8899 | F: (02) 9672 8099


120 SERIES LWB & SWB2/03-2010PRADO

TOYOTA


AssemblyIncludes


1 x Sway Bar Spacer

ANY $ 1450


StrutsIncludes


1 x Sway Bar Spacer

ANY $ 1596


AssemblyIncludes


1 x Sway Bar Spacer

ANY $ 1636


StrutsIncludes


1 x Sway Bar Spacer

ANY $ 1782


OEM AIRBAG VEHICLESNOTES ON CONVERSION (Replacing Dampers only)

The electronically controlled dampers on 120 series prado can be replaced with Tough Dog shock absorbers without error indicators appearing on the instrument cluster.

It is imperative that all four shock absorbers are replaced at the same time.

If operating correctly, the electronically adjustable height control of the rear air springs will not be affected if all four dampers are replaced at the same time.

NOTES ON CONVERSION (Replacing airbags & Dampers)When converting from air springs to conventional coils at the rear of pradoo 120 series, the electronic workaround detailed in the instructions provided with the rear springs prevents the error indicator from being displayed in the instrument cluster.

The electronic workaround willl also disable the electronic damping system, it is therefore important that all four dampers must be replaced if the air bag system is converted to coil springs.

Toyota Genuine Bumpstop part number 48302-35040 spring seat sub assembly should be orderd through Toyota




ESTIMATED LIFT:


40mm

REAR SUSPENSION

150 SERIES LWB & SWB2010 OnPRADOTOYOTA



COIL SPRINGS - Please check LWB/SWB prior to orderingTDC975S 2 0-300kg Load $ 135 ea OE Height - Suit LWB

TDC975 2 0-300kg Load $ 135 ea 40mm Lift - Suit LWB

TDC975H 2 CONSTANT 300Kg Load $ 135 ea 40mm Lift - Suit LWB

TDC975S 2 0-300kg Load $ 135 ea 40mm Lift - Suit SWB

TDC975 2 CONSTANT 300Kg Load $ 135 ea 40mm Lift - Suit SWB








COIL SPRINGS - Please check LWB/SWB prior to orderingTDC974H 2 40mm Lift Spring $ 135 ea Suits with Bar - Suit LWB

TDC974HH 2 40mm Lift Spring $ 135 ea Suits with Bar & Winch - Suit LWB

TDC974S 2 40mm Lift Spring $ 135 ea Suits with Bar - Suit SWB

TDC974 2 40mm Lift Spring $ 135 ea Suits with Bar & Winch -Suit SWB

COMPLETE STRUT ASSEMBLY - Please check LWB/SWB prior to orderingTOY-150/03 2 BM404400/TDC974H $ 518 ea All with Bar - Suit LWB

TOY-150/04 2 BM404400/TDC974HH $ 518 ea All with Bar & Winch - Suit LWB

TOY-150/07 2 FC404400/TDC974H $ 456 ea All with Bar - Suit LWB

TOY-150/08 2 FC404400/TDC974HH $ 456 ea All with Bar & Winch - Suit LWB

TOY-150/01 2 BM404400/TDC974S $ 518 ea All with Bar - Suit SWB

TOY-150/02 2 BM404400/TDC974 $ 518 ea All with Bar & Winch - Suit SWB

TOY-150/05 2 FC404400/TDC974S $ 456 ea All with Bar - Suit SWB

TOY-150/06 2 FC404400/TDC974 $ 456 ea All with Bar & Winch - Suit SWB



197P: (02) 9672 8899 | F: (02) 9672 8099


150 SERIES LWB & SWB2010 On

PRADOTOYOTA


AssemblyIncludes


1 x Sway Bar Spacer

ANY $ 1450


StrutsIncludes


1 x Sway Bar Spacer

ANY $ 1596


AssemblyIncludes


1 x Sway Bar Spacer

ANY $ 1636


StrutsIncludes


1 x Sway Bar Spacer

ANY $ 1782





ESTIMATED LIFT:FRONT SUSPENSION


40mm

REAR SUSPENSION

All Models06 OnFJ CRUISERTOYOTA












COIL SPRINGSTDC974H 2 40mm Lift Spring $135 ea Suits with Bar

TDC974HH 2 40mm Lift Spring $135 ea Suits with Bar & Winch

COMPLETE STRUT ASSEMBLYTOY-150/03 2 BM404400/TDC974H $518 ea All with Bar

TOY-150/04 2 BM404400/TDC974HH $518 ea All with Bar & Winch

TOY-150/07 2 FC404400/TDC974H $456 ea All with Bar

TOY-150/08 2 FC404400/TDC974HH $456 ea All with Bar & Winch


COMPONENTSTDSP-011 1 Sway Bar Spacer Kit $ 62 ea 76mm spacing - 06-2009 vehicles

TDSP-012 1 Sway Bar Spacer Kit $ 62 ea 83mm spacing - 2010 on vehicles

Check hole spacing of sway bar mounting locations to ensure the correct kit is ordered.

199P: (02) 9672 8899 | F: (02) 9672 8099


06 OnFJ CRUISER

TOYOTA


AssemblyIncludes


1 x Sway Bar Spacer

ANY $ 1450


StrutsIncludes


1 x Sway Bar Spacer

ANY $ 1596


AssemblyIncludes


1 x Sway Bar Spacer

ANY $ 1636


StrutsIncludes


1 x Sway Bar Spacer

ANY $ 1782



FRONT SUSPENSION


PART NO. QTY DESCRIPTION RRP inc GST NOTESESTIMATED LIFT:


30mm

REAR SUSPENSION

SAX 10, 115/94-00RAV 4TOYOTA

SHOCK ABSORBERSBD1106TB 2 35mm Nitr Gas Shocks $ 140 ea


COIL SPRINGSTDC982 2 0-300kg Load $ 135 ea 30mm Lift Spring

QUANTITY PER SHOCKTW959 2 Suits Top Rear Pin Mount $ 3 ea Pin Style Bushing


SHOCK ABSORBERSBDS4001 2 Nitrogen gas Strut Insert $ 192 ea Suits up to 30mm Lift

COIL SPRINGSTDC981 2 30mm Lift Spring $ 135 ea


35mm Nitro Gas ANY COIL $ 1204

Nitro Gas FrontAdjustable Rear

ANY COIL $ 1338


2 x Front strut inserts


201P: (02) 9672 8899 | F: (02) 9672 8099


ESTIMATED LIFT:

UCK, UPK, USK 55, 5603/07 On

TUNDRATOYOTA

45mm


40mm Adjustable 0-300KG $ 2024

Includes2 x Coil Springs 2 x Shocks 2 x Front struts 1 x Urethane Bushes (TDUK-076) 2 x U-Bolt Kits


FC41117 2 41mm Foam Cell Shocks $ 176 eaSuits 45mm Lift

BM401117 2 40mm Adjustable Shocks $ 207 ea

LEAF SPRINGSFS701 2 0-300kg Load 45mm Lift Spring $ 295 ea Includes bushings in spring

COMPONENTSTDUK-074 1 Urethane Shackle Bushing Kit $ 180 ea Not required if ordering FS701

TDUK-076 1 Urethane Chassis Bush Only $ 68 ea Required for lift kit

TDUB-016HD 2 U-Bolt Kit $ 31 ea

SHOCK ABSORBERSFC404910 2 40mm Foam Cell Strut $ 248 ea Suits up to 45m Lift

BM404910 2 40mm Adjustable Strut $ 310 ea Suits up to 45m Lift

COIL SPRINGSTDC930L 2 45mm Lift Spring $ 135 ea Suits with Alloy Bar

TDC930HL 2 45mm Lift Spring $ 135 ea Suits with Bar/Winch


PART NO. QTY DESCRIPTION RRP inc GST NOTESFRONT SUSPENSION




ESTIMATED LIFT:

REAR SUSPENSION

UAZ, HUNTER, PATRIOT1965 OnALL MODELSUAZ

SHOCK ABSORBERSFC41382 2 41mm Foam Cell Shock $ 176 ea Suits UAZ 452 (65-72), UAZ 469

(72-85) & UAZ 3151 (85-03BM401382 2 40mm Adjustable Shock $ 207 ea

FC41391 2 41mm Foam Cell Shock $ 176 eaSuits Hunter (2003 On)


FC41150 2 41mm Foam Cell Shock $ 176 eaSuits Patriot (2005 On)


COIL SPRINGSTDC150SL 2 OE Height Spring $ 135 ea

TDC150L 2 40mm Lift Spring $ 135 ea Suits with Bar

TDC150HL 2 40mm Lift Spring $ 135 ea Suits with Bar & Winch

SHOCK ABSORBERSFC41382 2 41mm Foam Cell Shock $ 176 ea Suits UAZ 452 (65-72), UAZ 469

(72-85) & UAZ 3151 (85-03BM401382 2 40mm Adjustable Shock $ 207 ea

FC41389 2 41mm Foam Cell Shock $ 176 eaSuits Hunter (2003 On)


FC41389 2 41mm Foam Cell Shock $ 176 eaSuits Patriot (2005 On)


LEAF SPRINGSFS160H 2 0-300Kg Load $ 212 ea 40mm Lift Spring

FS160HH 2 CONSTANT 400Kg Load $ 217 ea 40mm Lift Spring

PART NO. QTY DESCRIPTION RRP inc GST NOTES40mm

203P: (02) 9672 8899 | F: (02) 9672 8099


ESTIMATED LIFT:

All Models10 On

AMAROKVOLKSWAGEN

20mm

SHOCK ABSORBERSFC404730 2 40mm Foam Cell Strut $ 248 ea Not suitable with OE Coils

BM404730 2 40mm Adjustable Strut $ 310 ea Not suitable with OE Coils

COIL SPRINGS - Suits 2.0L Engine Only TDC110SL 2 OE Height Spring $ 135 ea

TDC110L 2 20mm Lift Spring $ 135 ea Suits with Bar


Complete assembly not available for this vehicle. Please visit www.toughdog.com.au for installation video

COIL SPRINGS - Suits 3.0L V6 Engine OnlyTDC120L 2 20mm Lift Spring $ 135 ea Suits with Bar




LEAF SPRINGSFS710M 2 0-300Kg Load $ 310 ea 20mm Lift Spring


COMPONENTSTDUK-072 1 Urethane Bushing Kit (Leaf) $ 180 ea included in kit pricing

TDUK-075 1 Urethane Bushing Kit (Chassis) $ 115 eanot included in kit pricing (order separately if needed

Amarok chassis bush has two thicknesses - TDUK-075 includes both sizes - please use correct set.TDUB-005 2 U-Bolt Kit $ 31 ea

AIR ASSIST BAGSTDAA-114 1 Bellows bag kit $ 825 ea Suits up to 20 mm Lift

REAR SUSPENSION


41mm Foam Cell0-300kg $ 1980


9 Stage Adjustable0-300kg $ 2166


Includes2 x Coil Springs 4 x Shocks 2 x Leaf Springs1 x Urethane Kit (TDUK-072) 2 x U-Bolt Kits





PLEASE COMPLETE THIS FORM BEFORE ANY FITMENTESSENTIAL BEFORE & AFTER MEASUREMENTSFITTING SHEET

CUSTOMER DETAILS

Fitted By: Date

Owner’s Name Year

Address Make

Suburb P’Code Model

Phone Number Odometer:

Email: Comments:

Please File this form with your vehicle service records for reference. Failure tocomplete this form or may delay resolution of issues.

PASSENGER FRONT SIDE

Original Height

Height After Lift

Height 500km Service

Shock Fitted (P/N)

Spring Fitted (P/N)

Comments

DRIVERS FRONT SIDE

Original Height

Height After Lift


Shock Fitted (P/N)

Spring Fitted (P/N)

Comments

DRIVERS REAR SIDE

Original Height

Height After Lift


Shock Fitted (P/N)

Spring Fitted (P/N)

Comments

PASSENGER REAR SIDE

Original Height

Height After Lift


Shock Fitted (P/N)

Spring Fitted (P/N)

Comments

BEFORE & AFTERMEASUREMENTS

AFTERMARKET FITMENTSBEFORE & AFTERMEASUREMENTS

Measurements should be taken from the bottom of the rim to the wheel arch on each corner. In the case of a tray, measure to the same point each time

205P: (02) 9672 8899 | F: (02) 9672 8099

WARRANTY & RETURNSCLAIMS FORM

CUSTOMER DETAILS

Name:

Address:

Suburb: Postcode:

PURCHASE DETAILS

Dealer Name:

Purchase Date: Invoice No:

VEHICLE DETAILS

Year: Make Model:

Front? Rear?

Please Complete this form for all warranty and part return requests. Returned items not accompanied by a form will experience extensive delays in processing

ITEMS FOR WARRANTY/RETURNPART NO. QTY REASON FOR RETURN CREDIT AC.

REPLACEITEM



DISCLAIMER FORMVEHICLES LIFTED MORE THAN 50MM

CUSTOMER DETAILS

Rego No: Date

Owner’s Name Year

Address Make

Suburb P’Code Model

Phone Number Odometer:

Email: Comments:

Vehicles fitted with a lift kit greater than 50mm over Original Equipment height may not be suitable for on road use. Consult your local Authority or a Qualified Engineer

Declaration

The suspension components fitted to this vehicle (Registration___________________) are suitable for off-road use only and may not comply with the requirements of registration. Operation of this vehicle on a road or road related area is done so at the operator’s own risk.

Compliance with the requirements of registration is the responsibility of the owner of the vehicle and no liability shall be accepted by any other person. Compliance of the vehicle can be undertaken with the assistance of a qualified certifying Engineer.

Disclaimer4Way Suspension Products Pty Ltd markets a range of off road products that may require certification from a qualified engineer prior to driving on public roads. The fitment of these items and the operation of the vehicle on public roads or road related areas prior to certification may render the vehicle unroadworthy, and may affect the status of your registration. Please check with the relevant ADR authorities in your state or territory and a qualified Engineer. Details of suitable Engineers are provided by the state/territory authority.

Shedule of Parts Fitted

FRONT REAR

Shock Absorbers

Coil Springs

Steering Stabilizer

Panhard Rods

Castor Bushes/Plates

Transmission Spacers

Brake Hoses

Signed:__________________________________________________ Date:_____________________

Name (Print)______________________________________________

207P: (02) 9672 8899 | F: (02) 9672 8099


GVM & RELATED INFORMATIONVEHICLE WEIGHT

GVM - WHAT IT MEANS TO YOU

The GVM, or Gross Vehicle Mass of any vehicle is the weight in Kg that the manufacturer has specified as being the maximum that the vehicle can weigh when fully loaded.Exceeding the GVM (overloading the vehicle) can result in premature failure of a range of parts, including structural failure of the chassis.

VEHICLE &ACCESSORIES

CARGO DRIVER &PASSENGERS

+ + = GVMACCESSORIES & GVM

When calculating how much load you are able to carry in your vehicle, remember to consider the weight of the accessories fitted. Accessories fitted add to the weight of the car, and reduces the allowable load that the vehicle can carry. These can include:

• Bullbar• Winch• Dual Batteries• Underbody protection plates• Sidesteps and scrub bars

• Long Range Fuel Tank(s)• Draw Systems• Rear bars• Canopies• Roof rack & accessories

After adding passengers, fuel, food and water, the vehicle must remain under the specified GVM from the manufacturer to avoid potentially dangerous & expensive vehicle damage and/or component failure. Consideration should be given towards the purchase of an offroad trailer.

Failure to observe the legal GVM of your vehicle is irresponsible and illegal. This may result in legal ramifications including fines and registration. Licence cancellation as well as void insurance in the event of an accident. Vehicles operating above GVM are operating outside the tested and warrantable parameter of the suspension, and are therefore not covered by 4Way Suspension Product Warranty

SAFETY FIRST,NEVER OVERLOAD

YOUR VEHICLE!

Documents

PARTS CATALOGUE VER. 6 JUNE 2019 JUNE 2019.pdfF77, F87 PICKUP & TRAYBACK 17 F73, F78 (COIL SPRINGS) 18 FORD COURIER PC, PD, PE, PG, PH 19 EVEREST UA1 Models 20 EVEREST UA2 Models 22