OWNER’SMANUAL - Cool Fab Racing · basculante completo complete swing arm ensemble bras oscillant protector basculante slider chain protecteur bras oscillant protector paso cadena

MINI50GP

MINISP70GP

OWNER’SMANUAL

www.FAB-Racing.co.ukModels Fitted with the MK Motor

WARNING

� THIS VEHICLE IS DESIGNED AND MANUFACTURED FOR COMPETITION USE ONLY. IT DOES NOT CONFORM TO THE SAFETY MEASURES OF A HOMOLOGATED

VEHICLE FOR PUBLIC ROADS. ITS USE ON STREETS, ROADS OR HIGHWAYS IS ILLEGAL. THE LAW PROHIBITS THE OPERATION OF THIS VEHICLE EXCEPT IN CLOSE

CIRCUITS OR IN ORGANIZED COMPETITIVE EVENTS.

� THIS MOTORCYCLE IS SOLD WITHOUT WARRANTY. ANY DEFECT DETECTED AFTER PURCHASE THE BUYER ASSUMES ALONE THE ENTIRE COST OF REPAIR AS

WELL AS NECESSARY MATERIAL.

MAINTAINANCE

� WHEN RIDING THE NEW MACHINE IT IS NECESSARY TO DO A RUNNING BELOW 10.000 RPM DURING ONE HOUR. A 30 MINUTES

RUNNING SHOULD BE DONE WHEN THE THERMODYNAMIC GROUP IS NEW.

� TIGHTEN THE AXLES AND THE FRAME SCREWS AFTER EVERY TIME YOU USE THE VEHICLE.

� THE CYLINDER SHOULD BE DISASSEMBLED TO CHECK THE NEEDLE BEARINGS, PIN, RING, SPARKING PLUG AND TO REPLACE

GASKETS EVERY 1.000 KMS OF FUNCTIONING.

� THE VEHICLE HAS STANDARD CARBURETTOR ADJUSTMENTS. IT SHOULD BE ADJUSTED TO WEATHER CONDITIONS,

TEMPERATURE AND ATMOSPHERE PRESSURE.

� THE FUNCTIONING AND ANCHORAGE OF THE FRONT AND REAR BRAKES SHOULD BE CHECKED BEFORE GOING OUT TO THE TRACK.

� IF THE BRAKE LEVER’S TACT IS SPONGY YOU SHOULD DRAIN THE SYSTEM.

� CHECK REGULARLY THE BRAKE PADS WEARING AWAY.

� THE CHAIN’S TIGHTEN IS MEASURE IN THE FOOTREST ZONE A SEPARATION OF 20 MM +/- 5 MM SHOULD BE LEFT BETWEEN THE CHAIN AND THE SWING ARM.

� DUE TO THE MATERIAL WITH WHICH THE FUEL TANK IS DONE, IT SHOULD BE CHECKED REGULARLY TO CLEAN SMALL

FIBRE PARTS THAT COULD LOOSEN AS WELL AS CHECKING THE FUEL VALVE AND CLEARING THE FILTER.

� VERIFY THE DRIVE CAP’S PLAY. IN CASE THERE IS PLAY, IT SHOULD BE RETIGHTEN (0.3-0.5 KG.).

� IN CASE OF REPLACING THE OIL OF THE FORK THE QUANTITY IS OF 180 ML (0.048 G) SAE 5

� CHECK OFTEN THE FIBRE’S FASTENINGS.

� THE HANDLEBARS TIGHTEN SHOULD BE CHECKED PERIODICALLY.

TORQUE WRENCH SETTING

ENGINE THREAD WRENCH KG SEALING

HEAD NUT 7X100 1.7

CYLINDER STUD TO CRANKBASE 7X100 2.1 BLUE

CYLINDER HEAD STUD 7X100 1.8 BLUE

CYLINDER BASE NUT 7X100 1.7

IGNITION NUT 12X125 3.5

PRIMARY NUT 12X125 5.5 BLUE

BALANCE SHAFT NUT 10X125 2.5 GREEN

CLUTCH BELL NUT 15X150 6 BLUE

CLUTCH SPRINGS SCREWS 5X0.8 BY TOUCH

SPARK 14X125 2.3

PRIMARY COVER SCREWS 6X100 0.8

CRANKCASE SCREWS 6X100 1.0

SELECTOR SCREWS 6X100 0.8 BLUE

SELECTOR FIXING SHIFT SCREW 6X100 0.8 BLUE

IGNITION BRACKET SCREWS 5X0.8 BY TOUCH BLUE

NOTE:

APPLY GENERAL RULES TO ANY SCREW OR NUT NOT SPECIFIED, IF DOUBTS CONTACT US

GENERAL SCREW NUT

M5 0.5 0.4

M6 1 0.8

M7 1.7 1.3

M8 2.2 1.8

M10 3.8 3.2


STEERING THREAD WRENCH KG SEALING

UPPER TRIPLE CLAMP 8X125 1.5

LOWER TRIPLE CLAMP 8X125 1.2

CONIC BERARING NUT 0.25

UPPER TRIPLE CLAMP SCREW 2.5 BLUE

HANDLEBAR CLAMP 6X100 1

HANDLE BAR TUBE 6X100 0.8

FORK TOP 8X125 2.0

FRONT AXLE NUT 12X125 4.5

BRAKE DISC 8X125 1.1

BRAKE CALLIPER 10X125 3.0 BLUE

STEERING SHOCK 8X125 2.2 BLUE

NOTE:



FRAME THREAD WRENCH KG. SEALING

FRONT STAND 6X100 0,8

SIDES FRAME 10X125 3 BLUE

ENGINE FASTENER BRACKET 8X125 2.2

FRAME ENGINE PLATES 8X125 2.2

ENGINE PLATES SCREW 8X125 2.5

SWING ARM AXLE 12X125 4.5

SHOCK UPPER SCREW 10X100 2.5

SHOCK LOWER SCREW 10X150 3

SEAT SCREWS 6X100 1

FOOTREST BRACKETS 8X125 2.2 BLUE

FOOTREST 8X125 2.5 BLUE

REAR MASTER CYLINDER 6X100 0.8

REAR BRAKE CALLIPER 6X100 0.8

STAND BRACKET 8X125 1.5

REAR BRAKE DISC 6X100 0.8

REAR SPROCKET 8X125 2.2

REAR WHEEL AXLE 14X150 6.5

NOTE:


TECHNICAL ENGINE SPECS

ENGINE

SINGLE CYLINDER 2 STROKE

MEASURES 39,84 X 40MM (50) / 44,50 X 44,90 MM (70)

CYLINDER CAPACITY 49.86CC (50) / 69.83 CC (70)

GEARS 6 GEAR

RATIO

1 13/37

2 15/32

3 18/31

4 21/31

5 23/30

6 23/27

PRIMARY 20/62

CLUTCH Hydraulic with automatic adjustment COMPOSITION 5 Clutch discs 4 1.5mm plates 1 1.2mm plate

TECHNICAL ENGINE SPECS

CLUTCH ROD SHOVE SETTING BALANCE SHAFT

LUBRICATION RECOMMENDED

MIX AT 3% GRO RACING-1

GEARBOX OIL CAPACITY 450 C.C GRO EXTREM 75

IGNITION

DIGITAL

SETTING 2.6 BTDC (50) 3,3 BTDC (70)

PLUG NGK - 50 BR-9EIX - 70 BR-10EIX PLUG GAP 0.65 MM.

NOTE:


CHASIS TUBULAR

TUBULAR FRAME

CADRE TUBULAIRE

SUBCHASIS TRASERO

SEAT RAIL

CADRE ARRIERE

CARTELAS LATERALES ALUMINIO

SIDE ALUMINIUM FRAME

PLETINE ALUMINIUM

RODAMIENTOS DIRECCIÓN

STEERING BEARING

ROULEMENTS DIRECTION

CTO. EJE SOPORTE SUP. AMORTIGUADOR

SHOCK PIN ASSY

ENSEMBLE AXE SUPÉRIEUR AMORTISSEUR

TORNILLERÍA CHASIS

FRAME BOLT KIT

ENSEMBLE VIS CADRE

TOPES DE DIRECCIÓN NYLON

NYLON STEERING STOP

BUTOIR DE DIRECTION NYLON

TORNILLERÍA COLÍN

SEAT BOLT KIT

ENSEMBLE VIS SIÈGE

CARTELA LATERAL IZQUIERDA

LEFT SIDE FRAME

PLETINE GAUCHE

CARTELA LATERAL DERECHA

RIGHT SIDE FRAME

PLETINE DROITE

10 1 810K0702

9 1 810K0700

810K0703

8 1 810K1156

7 1 810K1302

6 1

2

4

5

3

2

CUADRO - FRAME - CADRE

810K0706

810K0701

810K5607

1

1

1

1

810K0717

810K0002

1

Nº QTY DESCRIPCIÓN - NAME - DESIGNATIONCOD.

LÁMINA

DIAGRAM 1FEUILLE

HORQUILLA COMPLETA INFANTIL 2006

2006 CHILD COMPLETE FORK

FOURCHE TELESCOPIQUE ENFANT 2006

CONJUNTO PLETINA DIRECCIÓN 2006

2006 STEM ASSEMBLY LOWER PLATE

ENSEMBLE PLATINES DIRECTION

RETEN HORQUILLA

FORK OIL SEAL

JOINT SPY FOURCHE

HORQUILLA - FORK - FOURCHE

Nº QTY COD. DESCRIPCIÓN - NAME - DESIGNATION

2 1 810K0101

1 1 810K0011

3 2 810K0015

LÁMINA

DIAGRAM 2

FEUILLE

BASCULANTE COMPLETO

COMPLETE SWING ARM

ENSEMBLE BRAS OSCILLANT

PROTECTOR BASCULANTE

SLIDER CHAIN

PROTECTEUR BRAS OSCILLANT

PROTECTOR PASO CADENA

CHAIN GUARD

GUIDE DE CHAÎNE

CONJUNTO EJE BASC. MOTOR METRAKIT

SWING ARM AXLE ASSY METRAKIT ENGINE

ENSEMBLE AXE BRAS OSC.MOTEURR METRAKIT

TENSOR CADENA COMPLETO

COMPLETE CHAIN TIGHTNER

TENDEUR DE ROUE

AMORTIGUADOR ADULTO STANDARD

ADULT STANDARD SHOCK ABSORBER

AMORTISSEUR ADULTE STANDARD

AMORTIGUADOR MULTIREGULABLE

MULTIADJUSTABLE SHOCK ABSORBER

AMORTISSEUR MULTIREGLABLE

CASQUILLO NYLON CABALLETE

STANDARD NYLON ABSORBER

ENTRETOISE NYLON BEQUILLE

RODAMIENTOS BASCULANTE

SWING ARM BEARINGS

JEUX ROULEMENTS BRAS OSCILLANT

Nº QTY DESCRIPCIÓN - NAME - DESIGNATION

BASCULANTE - SWING ARM - BRAS OSCILLANT

810K1101

COD.

81009602

810K1001

810K1100

810K0709

1

2

1

2

4

5

3 1

1

1

6 1 810K1330

7 2 810K1202

965K0010

810K07088 1

LÁMINA

DIAGRAM 3FEUILLE

COLÍN 2006

SEAT 2006

SIÈGE 2006

ESPUMA COLIN

SEAT RUBBERS

CAOUTCHOUCS SIÈGE

CARENADO SUPERIOR 2006

UPPER FAIRING 2006

CARÉNAGE SUPERIEUR 2006

CARENADO INFERIOR 2006

LOWER FAIRING 2006

CARÉNAGE INFERIEUR 2006

FIJACIONES LATERALES CARENADO

FAIRINGS SIDE FASTENERS

FIXATIONS LATERALES CARÉNAGE

CIERRE RÁPIDO CARENADO

FAIRINGS FAST BOLTS

FERMETURE RAPIDE

PANTALLA + REMACHES 2006

SCREEN + RIVET 2006

ÉCRAN + RIVETS 2006

GUARDABARROS TRASERO

REAR MUDGUARD

GARDE-BOUE ARRIERE

GUARDABARROS DELANTERO 2006

FRONT MUDGUARD 2006

GARDE-BOUE AVANT 2006

DEPÓSITO DE GASOLINA 2004

FUEL TANK 2004

RÉSERVOIR D'ESSENCE 2004

TAPA DEPÓSITO 2006

FUEL TANK COVER 2006

COUVER RESERVOIR 2006

11 1 810K1611

9 1 810K0312

10 1 810K0610

6 1 810K1107

8 1 810K0305

7 1 810K1118

1

2

1

2

4

5

3 1

1

1 810K1113

COD.

810K1215

810K1106

810K1214

810K1212


CARENADO - FAIRING - CARENAGELÁMINA

DIAGRAM 4FEUILLE

GOMAS SOPORTE DEPÓSITO GASOLINA

FUEL TANK RUBBERS MOUNT

GOMMES SUPPORT RÉSERVOIR D'ESSENCE

GRIFO DE GASOLINA

FUEL VALVE

ROBINET D'ESSENCE

MANGUITO DESPAVORIZADOR GASOLINA

FUEL TANK TUBE

TUBE AÉRATION D'ESSENCE

TAPÓN DEPÓSITO GASOLINA 2004

FUEL TANK CAP 2004

BOUCHON RÉSERVIOR D'ESSENCE 2004

TORNILLERIA CARENADO

FAIRING SCREWS

ENSEMBLE VIS CARÉNAGE

CARENADO - FAIRING - CARENAGE


1

4

1

810K0614

810K0603

810K0601

810K0602

1

12

13

15

16

14

1 810K1109

LÁMINA

DIAGRAM 4FEUILLE

SEMIMANILAR DERECHO

RIGHT HANDLEBAR

BRACELET DROIT

SEMIMANILLAR IZQUIERDO

LEFT HANDLEBAR

BRACELET GAUCHE

CONJUNTO PUÑO GAS

THROTTLE GRIP ASSEMBLY

POIGNEE DE GAZ COMPLETE

CONJUNTO CABLE GAS 50cc.

CABLE THROTTLE ASSEMBLY 50cc.

GAINE ET CABLE DE GAZ 50cc.

CONJUNTO CABLE GAS 70cc.SP

CABLE THROTTLE ASSEMBLY 70cc.SP

GAINE ET CABLE DE GAZ 70cc.SP

BOMBA FRENO DELANTERA

FRONT BRAKE PUMP

RÉSERVOIR LIQUIDE DE FREIN AVANT

PINZA DE FRENO DELANTERA

FRONT BRAKE CALIPER

ETRIER DE FREIN

MANETA

LEVER

MANETE

EMBRAGUE HIDRAULICO

HYDRAULIC CLUTCH LEVER

EMBRAYAGE HIDRAULIQUE

BOMBA EMBRAGUE HIDRAULICO

CLUTCH MASTER CYLINDER

MAITRE CILINDRE EMBRAYAGE HIDRAULIQUE

PASTILLAS FRENO

BRAKE PADS

PLAQUETTE DE FREIN

10 1 810K0204

8 1 81038019

9 1 81038020

7 2 810K0103

1

2

5

4

3

1

6 1 810K0201

1

1 810K0200

810K0124

810K0104

MANILLAR Y MANDOS - HANDLEBAR AND CONTROLS -

GUIDON ET COMMANDES

COD.Nº QTY DESCRIPCIÓN - NAME - DESIGNATION

1 810K0120

810K0121

1 810K0102

1

LÁMINA

DIAGRAM 5FEUILLE

BOTON DE PARO

SWITCH ENGINE STOP

INTERRUPTEUR STOP

TOPE MANILLAR

HANDLEBAR CAP

BRACELET RESSORT

1 810K1406

810K01062

MANILLAR Y MANDOS - HANDLEBAR AND CONTROLS -

GUIDON ET COMMANDES

COD.Nº QTY DESCRIPCIÓN - NAME - DESIGNATION

11

12

LÁMINA

DIAGRAM 5FEUILLE

LLANTA DELANTERA

FRONT RIM

JANTE AVANT

RODAMIENTOS LLANTA DELANTERA

FRONT WHEEL BEARING

ROULEMENTS JANTE AVANT

DISCO DELANTERO MKRD 01

MKRD01 FRONT BRAKE

DISQUE FREIN AVANT

CONJUNTO EJE RUEDA DELANTERA

2006 FRONT WHEEL AXLE ASSEMBLY

ESEMBLE AXE DE ROUE AVANT

NEUMÁTICO DELANTERO DUNLOP TT92GP

FRONT TYRE DUNLOP TT92GP

PNEUMATIQUE AVANT DUNLOP TT92GP

TORNILLO DISCO FRENO

SCREW BRAKE DISC

VIS DISQUE FREIN

5 1 810K1511

1

810K0301

810K0704

RUEDA DELANTERA - FRONT WHEEL - ROUE AVANT

3

2

1

2

1

1

810K0300

DESCRIPCIÓN - NAME - DESIGNATIONCOD.

6 3 81108034

915F0001

Nº QTY

4

LÁMINA

DIAGRAM 6FEUILLE

LLANTA TRASERA 12"

12" REAR WHEEL

JANTE ARRIERE 12"

RODAMIENTOS LLANTA TRASERA

REAR WHEEL BEARINGS

ROULEMENTS JANTE ARRIERE

DISCO TRASERO CON TORNILLOS

REAR DISC WITH SCREWS

DISQUE FREIN ARRIERE AVEC VIS

CONJUNTO EJE RUEDA TRASERA

REAR WHEEL AXLE ASSEMBLY

ENSEMBLE AXE ARRIERE

CORONA Z 35

SPROCKET Z 35

COURONNE ARRIERE Z=35

CORONA Z 36

SPROCKET Z 36


CORONA Z 37

SPROCKET Z 37


CORONA Z 38

SPROCKET Z 38


CORONA Z 39

SPROCKET Z 39


CORONA Z 40

SPROCKET Z 40


CORONA Z 41

SPROCKET Z 41



RUEDA TRASERA - REAR WHEEL - ROUE ARRIERE

COD.

810K0205

810K0705

810K0304

810K0303

1

1

1

3

4

2 1

1

5 810K1035

810K1037

810K1036

810K1038

810K1039

1 810K1040

810K1041

LÁMINA

DIAGRAM 7FEUILLE

CORONA Z 42

SPROCKET Z 42


CORONA Z 43

SPROCKET Z 43


CORONA Z 44

SPROCKET Z 44


CADENA

CHAIN

CHAINE TRANSMISION

NEUMÁTICO TRASERO DUNLOP TT92GP

REAR TYRE DUNLOP TT92GP

PNEUMATIQUE ARRIERE DUNLOP TT92GP

ESPARRAGOS LLANTA TRASERA

REAR WHEEL STUDS

TIGES JANTE ARRIERE

1 810K1000

8 4 81008116

7 1

DESCRIPCIÓN - NAME - DESIGNATION

RUEDA TRASERA - REAR WHEEL - ROUE ARRIERE

COD.

5 810K1042

Nº QTY

810K1513

810K1043

810K1044

6

LÁMINA

DIAGRAM 7FEUILLE

PALANCA DE FRENO

BRAKE PEDAL

PEDALE DE FREIN ARRIERE

SOPORTE PINZA DE FRENO TRASERO

REAR CALIPER BRACKET

SUPPORT ETRIER FREIN ARRIERE

TIRANTE DE FRENO TRASERO

REAR CALIPER FASTENER

TENDEUR DE FREIN ARRIERE

BOMBA DE FRENO TRASERA

REAR BRAKE PUMP

COMMANDE FREIN ARRIERE

PINZA DE FRENO TRASERO

REAR BRAKE CALIPER

ETRIER FREIN ARRIERE

PASTILLAS DE FRENO TRASERO

REAR BRAKE PADS

PLAQUETTE DE FREIN ARRIERE

ESTRIBO

FOOTREST

REPOSE PIED

SOPORTE ESTRIBERA DERECHA

RIGHT FOOTREST BRACKET

SUPPORT REPOSE PIED DROIT

ROTULA BOMBA DE FRENO

BRAKE PUMP KNEECAP

GENOUILLERE FREIN ARRIERE

TAPÓN ESTRIBO

PLASTIC FOOTREST CAPS

BOUCHON REPOSE-PIEDS

TORNILLO ESTRIBO

SCREW FOOTREST

VIS RESPOSE PIED

PUNTERA PALANCA

RUBBER PEDAL

CAOUTCHOUC PEDALE

810K5892

FRENO TRASERO - REAR BRAKE - FREIN ARRIERE

1

9 1 810K0213

810K02071

1

Nº QTY

12 1

DESCRIPCIÓN - NAME - DESIGNATIONCOD.

3

4 1

12

810K0223

810K0206

810K0901

810K0906

810K0904

810K0905

11 1

8 1

10 1

5 1 810K0208

7 1 810K0902

6 1 810K0209

LÁMINA

DIAGRAM 8FEUILLE

PALANCA CAMBIO

GEARSHIFT PEDAL

PEDALE DE SELECTEUR

REENVÍO CAMBIO

GEAR RETURN

LEVIER DE SELECTEUR

ESTRIBO

FOOTREST

RESPOSE PIED

SOPORTE ESTRIBERA IZQUIERDA

LEFT FOOTREST BRACKET

SUPPORT REPOSE PIED DROIT

TAPÓN ESTRIBO

PLASTIC FOOTREST CAPS

BOUCHON REPOSE-PIEDS

PUNTERA PALANCA

RUBBER PEDAL

CAOUTCHOUC PEDALE

TORNILLO ESTRIBO

SCREW FOOTREST

VIS RESPOSE PIED

6 1 810K5892

7 1 810K0906

1

1

81038021

4

5

3 1

810K0903

810K0905

810K0902

810K0900

DESCRIPCIÓN - NAME - DESIGNATION

CAMBIO - GEAR - SELECTEUR

COD.

11

2

Nº QTY

1

LÁMINA

DIAGRAM 9FEUILLE

MOTOR COMPLETO METRAKIT 50cc.

COMPLETE METRAKIT ENGINE 50cc.

MOTEUR COMPLETE METRAKIT 85cc.

MOTOR COMPLETO METRAKIT 70cc.

COMPLETE METRAKIT ENGINE 70cc.

MOTEUR COMPLETE METRAKIT 70c.

ENCENDIDO COMPLETO 50cc.

ASSY IGNITION 50cc.

GROUPE ALLUMAGE 50cc.

ENCENDIDO COMPLETO 70cc

ASSY IGNITION 70cc

GROUPE ALLUMAGE 70cc

CONJUNTO PLETINAS FIJACION MOTOR

BRACKETS SET ENGINE

SUP. AVANT MOTEUR

PIÑÓN SALIDA MOTOR Z 12

DRIVE SPROCKET Z 12

PIGNON SORTIE MOTEUR Z 12


DRIVE SPROCKET Z 13



DRIVE SPROCKET Z 14



DRIVE SPROCKET Z 15



DRIVE SPROCKET Z 16


PIPA BUJÍA

SPARK PLUG CAP

ANTIPARASITE

810K5616

1 81008123

4

3

810K5612

5 1 810K1402

1

810K5614

810K5615

MOTOR - ENGINE - MOTEUR


810180501

2

1

810K5613

1 81028070

1 81029022

1 81019022

LÁMINA

DIAGRAM 10

FEUILLE

BUJIA BR 10 EIX

SPARK PLUG BR 10 EIX

BUJIE BR 10 EIX

CONJUNTO ROTOR-STATOR

ASSY ROTOR-STATOR

GROUPE ROTOR-STATOR

BOBINA

COIL

BOBINE

UNIDAD CDI 50cc.

CDI UNIT 50cc.

CDI 50cc.

UNIDAD CDI 70cc.

CDI UNIT 70cc.

CDI 70cc.

CABLEADO ENCENDIDO

IGNITION CABLES

CABLAGE ALLUMAGE

1 81028025

10 1 81008026

MOTOR - ENGINE - MOTEUR


810K58706

8

1

7 1 81008023

9 1 81018025

1 81008024

LÁMINA

DIAGRAM 10

FEUILLE

CONJUNTO CARTERES

CRANKCASE ASSY

GROUPE CARTERS

JUNTA CENTRAL CARTER

INNER CRANKCASE GASKET

JOINT INTERIEUR CARTER

TAPA ENCENDIDO

IGNITION COVER

COUVERCLE ALLUMAGE

JUNTA TAPA TRASMISION PRIMARIA

TRANSMISSION PRIMARY COVER GASKET

JOINT COUVERCLE TRANSMISSION PRIMAIRE

TAPA TRANSMISION PRIMARIA

TRANSMISSION PRIMARY COVER

COUVERCLE TRANSMISSION PRIMAIRE

JUNTA TAPA EMBRAGUE

CLUTCH COVER GASKET

JOINT COUVERCLE EMBRAYAGE

TAPA EMBRAGUE

CLUTCH COVER

COUVERCLE EMBRAYAGE

JUNTA TAPA BOMBA AGUA

WATER PUMP GASKET

JOINT POMPE A EAU

TAPA BOMBA AGUA

WATER PUMP COVER

COUVERCLE POMPE A EAU

CAJA DE LAMINAS

REED BLOCK

BOITE A CLAPETS

JUNTA CAJA LAMINAS

REED BLOCK GASKET

JOINT BOITE A CLAPETS

1 81008020

11 1 81008021

10

3 1 81008029

7 1 81008012

4

1

81008015

81008013

COD.

81008014

81008010

CARTERES - CRANKCASE - GROUPE CARTERS


1

2

1

9 1

5

8 1

16

1

1

81008011

81008016

81008033

LÁMINA

DIAGRAM 11

FEUILLE

BOQUILLA ADMISION MINI GP 50

MANIFOLD MINI GP 50

PIPE D' ADMISSION MINI GP 50

BOQUILLA ADMISION MINI GP 70

MANIFOLD MINI GP 70

PIPE D' ADMISSION MINI GP 70

LAMINAS FIBRA CARBONO

CARBON REEDS SET

LAMELLES DE CARBONE

JUEGO JUNTAS MOTOR

ENGINE GASKET SET

POCHETE DE JOINTS MOTEUR

13 1 923D1610

81008117

COD.

81008028

912D1619

CARTERES - CRANKCASE - GROUPE CARTERS


12 1

1

LÁMINA

DIAGRAM 11

FEUILLE

EQUIPO MOTOR 50cc.

CYLINDER KIT 50cc.

HAUT MOTEUR 80cc.

CULATA

HEAD COVER

COUVERCLE CULASSE

SEGMENTO

RING

SEGMENT

PISTON D.39,84 A

PISTON D.39,84 A

PISTON D.39,84 A

PISTON D.39,84 B

PISTON D.39,84 B

PISTON D.39,84 B

PISTON D.39,84 C

PISTON D.39,84 C

PISTON D.39,84 C

PISTON D.39,84 D

PISTON D.39,84 D

PISTON D.39,84 D

JUEGO JUNTAS

GASKET SET

POCHETE DE JOINTS

JAULA 12x17x14,4

BEARING 12x17x14,4

CAGE AIGUILLE 12x17x14,4

BIELA

CON ROD

BIELLE

CIGÜEÑAL

CRANKSHAFT

VILOBREQUIN

KIT COJINETES Y RETENES

BEARINGS-SEAL KIT

KIT ROULEMENT JOINT SPI VILO

15 81018083

9 1 81008032

81018084

6 1 93021217

81008084

COD.

807D1615

81018072

81108258

81108255

81108256

81108257

81108254

EQUIPO MOTOR - CYLINDER KIT - HAUT MOTEUR


1

2

1

8 1

4

7 1

1

1

3

LÁMINA

DIAGRAM 12

FEUILLE

EQUIPO MOTOR 70cc.

CYLINDER KIT 70 cc.

HAUT MOTEUR 70cc.

TAPA CULATA

HEAD COVER

COUVERCLE CULASSE

CULATIN

HEAD

CULASSE

SEGMENTO 44,50x1,00 CR

RING 44,50x1,00 CR

SEGMENT 44,50x1,00 CR

PISTON D.44,50 A

PISTON D.44,50 A

PISTON D.44,50 A

PISTON D.44,50 B

PISTON D.44,50 B

PISTON D.44,50 B

PISTON D.44,50 C

PISTON D.44,50 C

PISTON D.44,50 C

PISTON D.44,50 D

PISTON D.44,50 D

PISTON D.44,50 D

JUEGO JUNTAS

GASKET SET

POCHETE DE JOINTS

JAULA 12x17x14,4

BEARING 12x17x14,4

CAGE AIGUILLE 12x17x14,4

BIELA

CON ROD

BIELLE

CIGÜEÑAL

CRANKSHAFT

VILOBREQUIN

KIT COJINETES Y RETENES

BEARINGS-SEAL KIT

KIT ROULEMENT JOINT SPI VILO

10 1 81008032

81008084

810380849 1

8 1

16 81038083

81028077

3 1 81028075

7 1 93021217

4

1

81028074

5

COD.

807D1634

81028072

EQUIPO MOTOR - CYLINDER KIT - HAUT MOTEUR


1

2

1

1

1

81028078

81028079

81028076

LÁMINA

DIAGRAM 12

FEUILLE

TORNILLO+TOPE MUELLE EMBRAGUE

SCREW + CLUTCH SPRING STOP

VIS+COUVERCLE RESSORT

JUEGO MUELLES EMBRAGUE

CLUTCH SPRINGS SET

GROUPE RESSORTS EMBRAYAGE

TAPA CIERRE EMBRAGUE

CLUTCH LOCK COVER

PLAQUE PRESSION EMBRAYAGE

CONJUNTO RODAMIENTO AXIAL

AXIAL BEARINGS SET

ENSEMBLE ROULEMENT AXIAL

CASQUILLO EMPUJE EMBRAGUE

CLUTCH BUSHING

ENTRETOISE EMBRAYAGE

TUERCA EMBRAGUE

CLUTCH NUT

ECROU EMBRAYAGE

ARANDELA PRECINTO EMBRAGUE

CLUTCH WASHER SEAL

RONDELLE EMBRAYAGE

JUEGO DISCOS EMBRAGUE

CLUTCH DISC SET

ENSEMBLE DISQUES EMBRAYAGE

CAMPANA CONDUCIDA

BELL

CLOCHE INTERNE

ARANDELA 17x30x1

WASHER 17x30x1

RONDELLE 17x30x1

CAMPANA EMBRAGUE

CLUTCH BELL

CLOCHE EMBRAYAGE

10

11 1 81008022

2 81008059

81038026

81008055

16 81008056

81008058

3 1 81008053

7 1 81008057

4

1

81008054

COD.

81008052

81008051

EMBRAGUE - CLUTCH - EMBRAYAGE


1

2

5

1

5

9 1

5

8 1

LÁMINA

DIAGRAM 13

FEUILLE

JUNTA PLANA 12x25x6 EMBRAGUE

CLUTCH FLAT GASKET

JOINT EMBRAYAGE

CORONA EMBRAGUE

CLUTCH SPROCKET

COURONE EMBRAYAGE

PLACA SOPORTE JUNTAS EMBRAGUE

CLUTCH BRACKET PLATE GASKETS

PLAQUE SUPORT

TORNILLO ALLEN M6x12

ALLEN SCREW M6x12

VIS ALLEN M6x12

CONJUNTO RODAMIENTO PRIMARIO

PRIMARY BEARINGS SET

ENSEMBLE ROULEMENT PRIMAIRE

VARILLA EMPUJE EMBRAGUE

CLUTCH ROD SHOVE

TIGE POUSSE EMBRAYAGE

BOLA RODAMIENTO

BEARING BALL

BOULE ROULEMENT

81008064

117 81008065

14 1 81008062

18 1 81008066

15

1

81008063

COD.

81008060

81008061

EMBRAGUE - CLUTCH - EMBRAYAGE


12

13

5

5

1

16

LÁMINA

DIAGRAM 13

FEUILLE

COJINETE 12x32x10 EJE BALANCE

BALANCE SHAFT BEARINGS 12x32x10

ROULEMENT 12x32x10 BALANCIER

EJE DE BALANCE

BALANCE SHAFT

BALANCIER

COJINETE+RETEN 12x32x12,5

BEARINGS + SEAL 12x32x12,5

ROULEMENT + JOINT SPY 12x32x12,5

CHAVETA EJE BALANCE

BALANCE SHAFT COTTER PIN

VIS BALANCIER

PIÑON EJE BALANCE

BALANCE SHAFT SPROCKET

PIGNON BALANCIER

TUERCA M10x125 DIN 439

M10x125 DIN 439 NUT

ECROU M10x125 DIN 439

PIÑON BOMBA AGUA

WATER PUMP SPROCKET

PIGNON POMPE A EAU

CIRCLIP PIÑON BOMBA AGUA

WATER PUMP SPROCKET CIRCLIP

CIRCLIP PIGNON POMPE A EAU

COJINETE 8x22x7

BEARINGS 8x22x7

ROULEMENT 8x22x7

RETEN BOMBA AGUA

WATER PUMP SEAL

JOINT SPI POMPE A EAU

EJE BOMBA AGUA

WATER PUMP SHAFT

AXE POMPE A EAU

11 1 81008035

4

1

81008102

81108158

81008019

17

81108155

3 1 81008101

81008034

81008103

10 1

5

9

BOMBA DE AGUA - WATER PUMP - POMPE A EAU

EJE DE BALANCE - BALANCE SHAFT - BALANCIER

1

1

COD.

81008027

810081001

2

1


2

8 1

6 1 81008115

LÁMINA

DIAGRAM 14

FEUILLE

TURBINA BOMBA AGUA

WATER PUMP TURBINE

TURBINE POMPE A EAU

COJINETE 12x19x12

BEARINGS 12x19x12

ROULEMENT 12x19x12

PIÑON CIGUEÑAL

CRANKSHAFT SPROCKET

PIGNON VILO

PIÑON INTERMEDIO EJE BALANCE

BALANCE SHAFT MIDDLE SPROCKET

PIGNON INTERMEDIAIRE BALANCIER

CORONA EMBRAGUE

CLUTCH SPROCKET

COURONE EMBRAYAGE

PLACA RECUPERADOR SELECTOR

SELECTOR PLATE

PLAQUE SELECTEUR

EJE SELECTOR CAMBIO

GEAR SELECTOR SHAFT

AXE SELECTEUR

CASQUILLO DISTANCIADOR

SPACING BUSH

ENTRETOISE

RODAMIENTO AGUJAS 12x16x10

NEEDLE BEARINGS 12x16x10

CAGE AIGULLES 12x16x10

RETEN 12x20x7

SEAL 12x20x7

JOINT SPY 12x20x7

COJINETE 25x37x7

BEARINGS 25x37x7

ROULEMENT 25x37x7

12 1 81108154

22 2 81008109

13 2 81008104

16

18 81008106

14

15

1

17 1

81008060

81008105

1

81008108

19 1 81008107

21 1

20 1 81108168



1

1

COD.

81008018

81008017


LÁMINA

DIAGRAM 14

FEUILLE

ARANDELA 25x35x0,5

WASHER 25x35x0,5

RONDELE 25x35x0,5

TAMBOR DESMODRONICO

SHIFT CAM

BARRILET VITESSE

CABEZA TAMBOR DESMODRONICO

HEAD SHIFT CAM

TETE BARRILET

SOPORTE FIJACIÓN SELECTOR

SELECTOR FIXING BRACKET

SUPORT SELECTEUR

MUELLE RETORNO

RETURN SPRING

RESSORT

CHAVETA CIGUEÑAL-TRANSMISION

CRANKSHAFT-TRANSMISSION COTTER PIN

VIS VILO-TRANSMISSION



1

1

COD.

81008112

81008111


1 81008113

28 1 81108189

81008110

24

27 81008114

25

1

26

23 2

LÁMINA

DIAGRAM 14

FEUILLE

CAMBIO DE MARCHAS

GEAR BOX

BOITE A VITESSE

CONJUNTO PIÑON 1ª VELOCIDAD

1 st GEAR SPROCKET SET

ENSEMBLE PIGNON 1er

VISTESSE


2 nd GEAR SPROCKET SET

ENSEMBLE PIGNON 2eme

VISTESSE

CONJUNTO PIÑON 3ª-4ª VELOCIDAD

3 rd - 4 th GEAR SPROCKET SET


- 4eme

VISTESSE

CONJUNTO PIÑON 5ª VELOCIDAD n

5 th GEAR SPROCKET SET


VISTESSE


6 th GEAR SPROCKET SET


VISTESSE

EJE SECUNDARIO CAMBIO

GEAR SECONDARY AXLE

AXE SCONDAIRE BOITE

HORQUILLA CAMBIO 3ª-4ª VELOCIDAD

GEAR FORK 3 rd - 4 th SPEED

FOURCHETTE 3eme

- 4eme

VISTESSE

HORQUILLA CAMBIO 6ª VELOCIDAD

GEAR FORK 6 th SPEED

FOURCHETTE 6eme

VISTESSE

HORQUILLA CAMBIO 5ª VELOCIDAD

GEAR FORK 5 th SPEED

FOURCHETTE 5eme

VISTESSE

EJE HORQUILLA SECUNDARIO

SECONDARY FORK AXLE

AXE FOURCHETTE SECONDAIRE

CAMBIO DE MARCHAS - GEAR BOX - BOÎTE A VITESSE

1

1

9 1

5

8 1

COD.

81008071

81008070


1

2

1

81008086

3 1 81008072

7 1 81008077

4

1

81008073

81008083

81008075

16 81008076

10

11 1 81008079

1 81008087

LÁMINA

DIAGRAM 15

FEUILLE

EJE HORQUILLA PRIMARIO

PRIMARY FORK AXLE

AXE FOURCHETTE PRIMAIRE

RODAMIENTO AGUJAS 12x19x12

NEEDLE BEARINGS 12x19x12

CAGE AIGULLES 12x19x12

COJINETE 17x40x12

BEARINGS 17x40x12

ROULEMENT 17x40x12

COJINETE 17x47x14

BEARINGS 17x47x14

ROULEMENT 17x47x14

COJINETE 12x28x8

BEARINGS 12x28x8

ROULEMENT 12x28x8

RETEN 20x40x7

SEAL 20x40x7

JOINT SPY 20x40x7

KIT ARANDELAS + CLIPS CAMBIO

WASHERS KIT + GEAR CLIPS

KIT RONDELE + CLIPS BOITE

17 81059978

1

81008088

81008089

1

13

1

14 1 81008082

18 1 81008078

15

81008080


12

CAMBIO DE MARCHAS - GEAR BOX - BOÎTE A VITESSE

1

1

16

COD.

81008104

LÁMINA

DIAGRAM 15

FEUILLE

CARBURADOR 19 MINI GP 50

CARBURETTOR 19 MINI GP 50

CARBURATEUR 19 MINI GP 50

CARBURADOR 28 MINI GP 70

CARBURETTOR 28 MINI GP 70

CARBURATEUR 28 MINI GP 70

TUBO DE ESCAPE MINI GP 50

EXHAUST PIPE MINI GP 50

TUBE D'ECHAPPEMENT MINI GP 50

TUBO DE ESCAPE MINI GP 70

EXHAUST PIPE MINI GP 70

TUBE D'ECHAPPEMENT MINI GP 70

SILENCIOSO KEVLAR

KEVLAR SILENCER

SILENCIEUX D'ECHAPPEMENT

CABALLETE TRASERO

REAR STAND

BEQUILLE ARRIERE

13

DESCRIPCIÓN - NAME - DESIGNATIONCOD.Nº QTY

91102522

81018071

1

1

CARBURADOR - CARBURETTOR - CARBURATEUR

ESCAPE Y SILENCIOSO - EXHAUST PIPE AND SILENCER

1

2

911050281

810280711

81038086

810K12014 1

LÁMINA

DIAGRAM 16

FEUILLE

RADIADOR

RADIADOR

RADIATEUR

MANGUITOS RADIADOR MOTOR

RADIATOR HOSES ENGINE

DURITE RADIATEUR MOTEUR

GOMAS SOPORTE RADIADOR

RUBBERS RADIATOR STAND

GOMMES SUPPORT RADIATEUR

TACÓMETRO MULTIFUNCIÓN

DIGITAL TACHOMETER

DIGITAL TCOMPTE TOURS

SOPORTE CARENADO Y RELOJES

FAIRING BRACKET AND CONTROLS

SUPPORT CARÉNAGE ET MONTRES

TOPE NYLON

NYLON CAP

COUVERCLE NYLON

TAPON RADIADOR

RADIATOR CAP

BOUCHON RADIATEUR

81038025

1 810K5808

1

TACOMETRO - SPEEDOMETER - TABLEAU DE BORD

RADIADOR - RADIATOR - RADIATEUR

DESCRIPCIÓN - NAME - DESIGNATIONCOD.Nº QTY

965D16351

1

810K0501

810K0502

81038024

2

11

2

4

5

3

6 1 810K0406

7

LÁMINA

DIAGRAM 17

FEUILLE

Documents

OWNER’SMANUAL - Cool Fab Racing · basculante completo complete swing arm ensemble bras oscillant protector basculante slider chain protecteur bras oscillant protector paso cadena