Upload
lamthu
View
247
Download
2
Embed Size (px)
Citation preview
OVERHEAD CONSTRUCTION MANUAL
EARTHING CONCRETE POLE Go to SECTION INDEX Back to MAIN INDEX
DESCRIPTION PAGE PAGE
INDEX
C
24/8/07
24 1640 1
HARD COPYUNCONTROLLED
C. Noel
C.Avenell
B
Sh 1
CONSTRUCTION CONSTRUCTION
L. Burton
DESCRIPTION
EARTHING CONCRETE POLE
deep drilled
ECPT/COM
EA
EAR
ECPT/COM/DD
EADDC
EC/HVE
1638
1622
1586
CONSTRUCTION
TRANSFORMER CONCRETE POLE EARTHING
HV EARTHING CONCRETE POLE
Construction code guide - Transformer & OHEW
EA
EAR
Overhead earth wire common earth - New pole
HV earth
Transformer concrete pole common earth
Transformer concrete pole common earth
1849
EA
EAR
1850EC/OHX/COM Overhead earth wire common earth - Existing pole
EA
EAR
EA
EAR
EC/OHX/SEP
New pole
Overhead earth wire separate earth grading ring
Existing pole
Overhead earth wire separate earth grading ring
EC/OH/SEP
EC/OH/COM
1852/1
1852/2
1624/1
deep drilled
Transformer concrete pole common earth 1624/2
C 2.2.16
9.4.13
A ORIGINAL ISSUE
DRAWN
DATE
PASSED
APPROVED
Ergon Energy Corporation Ltd
ABN 50 087 646 062
OVERHEAD DISTRIBUTION
FILE: 5Page
L. Burton
EC/PT/COM/DD
EARTH TRANSFORMER
PT = Pole Transformer COM = Common
TYPE
DD = Deep drilled
(Omit where driven rods used)
SYSTEM
CONSTRUCTION CODE GUIDE
detail drawings in this manual.
appears on relevant construction
Code shown within dashed box
A
24 1638 11638
EXAMPLE:-
THREE PHASE TRANSFORMER EARTHING CONCRETE POLE - CONSTRUCTION CODE
EC = Earth Concrete Pole
EC/PT/COM/DD = Earth Concrete Pole, Pole transformer with common earth system (CMEN), deep drilled.
22.8.07HARD COPYUNCONTROLLED
EARTHING CONCRETE POLE
C. Avenell
C. Noel
B 7.3.13
B
TRANSFORMER & OHEW
EARTH
COM = Common
SYSTEM
detail drawings in this manual.
appears on relevant construction
Code shown within dashed box
A
EXAMPLE:-
EC = Earth Concrete Pole
OVERHEAD EARTH WIRE CONCRETE POLE - CONSTRUCTION CODE
EC/OH/SEP
SEP = Separate
POLE TYPE
OH = Overhead New Pole
OHX = Overhead Existing Pole
EC/OH/SEP = Earth Concrete Pole, Overhead on New Pole with Separate Earthing System.
DRAWN
DATE
PASSED
APPROVED
Ergon Energy Corporation Ltd
A ORIGINAL ISSUE
ABN 50 087 646 062
OVERHEAD DISTRIBUTION
Dwg ShFILE: 5
TRANSFORMER COMMON EARTH
MATERIAL
ASSY DESCRIPTION QTY
140-14
141-18 2
162424 1624 1
2080-1 Downlead cable / transformer earth HV
Earth butt concrete pole
1
1
1
19.9.07
L. Burton
Earth additional - deep drilled AR
MATERIAL - ADDITIONAL EARTH
ASSY DESCRIPTION QTY
124-1
12081-7
Cable insulated annealed Cu. 70mm†
DEEP DRILLED
Earth HV (35mm†) to concrete pole - deep drilled
2080-10
EARTHING CONCRETE POLE
Lug, compression 70mm† M12
HARD COPYUNCONTROLLED
2.
NOTES:
1.Earthing to run in direction of mains.
B 27.2.14
C
C. Avenell
C. Noel
C 11.11.15
DO NOT ADD WATER.
at 20m, then the additional earthing must be spaced at least 40m.
depth of adjacent earthing electrode. For example if adjacent earthing is
4. The additional earthing if required must be spaced at least two times the
immediately with dry earth enhancing compound.
- The holes are to be refilled
- A drilling rig using nominal 75mm bit is required.
releases water content - similar to mud.
proportion of water so that when squeezed by hand it holds its form and
- Good moisture is defined as extracted bore hole soil containing adequate
minimum of 20m unless good moisture is reached.
- 35mm† bare copper cable deep drilled to a
3. H.V. & L.V. electrodes
- Concrete pole = 2.0m
- Bare earth cable = 2.0m
- Earth rod = 2.0m
manholes, pillars, pits etc:
Provide the following minimum separation to communications
- Concrete pole = 0.3m
- Bare earth cable = 0.3m
- Earth rod = 0.3m
plastic sheathed / jacketed or in plastic conduit:
Provide the following minimum separation to communications cable
SEPARATION FROM COMMUNICATIONS:
and additional earthing added as necessary.
completion of work on site the installation shall be tested after 7 days
earthing is installed. Where specified resistance is not achieved prior to
Specified earth resistance may not be achieved for some days after
DEEP DRILLED EARTH TESTING:
For separation from other communications assets refer Standards Section.
1
A ORIGINAL ISSUE
DRAWN
DATE
PASSED
APPROVED
Ergon Energy Corporation Ltd
ABN 50 087 646 062
OVERHEAD DISTRIBUTION
Dwg ShFILE: 5
L.V.
H.V.
f
f
TRANSFORMER COMMON EARTH
Caution tape
(Additional)
Construction Type
162424 1624 2
Assy 2080-10
F
141-18
140-14 and
Assy Selection
F
F
19.9.07
L. Burton
F
f
F
f
Additional earthing
if required
Assy 124-1
4.0m
F
ECPT/COM/DD
EADDC
DEEP DRILLED
Assy 2081-7
Assy 2080-1
EARTHING CONCRETE POLE
Tank
To Transformer
Bushing
L.V. Neutral
To Transformer
HARD COPYUNCONTROLLED
1 ohm
Max.
CONNECTED
L.V. NEUTRAL
N
F
C. Avenell
C. Noel
Construction Code.
Dwg. 1248 Sh 3 for Additional Earthing
Refer EARTHING WOOD POLE folder,
Dwg. 1238 for Trench Sections
Refer EARTHING WOOD POLE folder,
30 ohm
Max.
DISCONNECTED
L.V. NEUTRAL
N
2
Refer note 4
DRAWN
DATE
PASSED
APPROVED
Ergon Energy Corporation Ltd
A ORIGINAL ISSUE
ABN 50 087 646 062
OVERHEAD DISTRIBUTION
Dwg ShFILE: 5
L. Burton 158624 1586 1
Pole
Conc.
F
Assy 2080-10
F
MATERIAL
ASSY DESCRIPTION QTY
Construction Type
EC / HVE
1Earth butt concrete pole
H.V. EARTH
H.V. CONNECTED
F
f
Caution tape
for Trench Sections
POLE folder, drg. 1238
Refer EARTHING WOOD
required, contact local Ergon branch.
If more than 4 additional earthrods
8.0m Min. (Double rod)
4.0m Min. (Single rod or Deep Drilled)
Earthing Construction Code
folder, drg. 1248 Sh 3 for Additional
Refer EARTHING WOOD POLE
2080-10
pole/base.
3 coils beneath
Minimum of
ASSY DESCRIPTION QTY
AR
MATERIAL - ADDITIONAL EARTH
104-1 Earth rod additional
30 ohm
Max.
104-5 AR
124-1 AR
Earth rod additional depth
Earth additional - deep drilled
EARTHING CONCRETE POLE
C. Noel
C. Avenell
23.03.13HARD COPYUNCONTROLLED
A ORIGINAL ISSUE
DRAWN
DATE
PASSED
APPROVED
Ergon Energy Corporation Ltd
ABN 50 087 646 062
OVERHEAD DISTRIBUTION
Dwg ShFILE: 5
f
F
f
F
f
NOTES:
1.
Earth rod additional
Earth rod additional depth
AR
AR
Caution tape
4.0m Min. (Single rod)
8.0m Min. (Double rod)
MATERIAL
ASSY DESCRIPTION QTY
MATERIAL - ADDITIONAL EARTH
ASSY
104-1
104-5
DESCRIPTION QTY
(Additional)
(Additional rod)
Assy selection 104-5 or 104-1 and 5
required, contact local Ergon branch.
If more than 4 additional earthrods
Additional earthing if required.
EA
EAR
Construction Type
184924 1849 1
4.0m
Assy 2080-10
F
F
Earth butt concrete pole 1
L. Burton
F
2082-3 1
2080-10
Assy 2082-3
EARTHING CONCRETE POLE
SEPARATION FROM COMMUNICATIONS:
drg. 1238 for Trench Sections
Refer EARTHING WOOD POLE folder,
Construction Code
drg. 1248 Sh 3 for Additional Earthing
Refer EARTHING WOOD POLE folder,
Earthing to run in direction of mains.
assets refer Standards Section.
For separation from other communications
HARD COPYUNCONTROLLED
- Concrete pole = 2.0m
- Bare earth cable = 2.0m
- Earth rod = 2.0m
communications manholes, pillars, pits etc:
Provide the following minimum separation to
1 ohm
Max.
30 ohm
Max.
CONNECTED
L.V. NEUTRAL
DISCONNECTED
L.V. NEUTRAL
N N
- Concrete pole = 0.3m
- Bare earth cable = 0.3m
- Earth rod = 0.3m
jacketed or in plastic conduit:
to communications cable plastic sheathed /
Provide the following minimum separation
Neutral bond I.P.C. 50/95mm† with 35mm† bonding lead
COMMON EARTH - NEW POLE
OVERHEAD EARTH WIRE7/3/13
C. Avenell
C. Noel
To LV Neutral2.Butt earth to be under precast base if used
3.
are not achieved by butt earth
Assy 2081-2 to be used if earthing values
Assy 2081-2 (Refer note 3)
F
equipment
or
Telstra pit
F
f2.0m min
RESISTANCE TO GROUND
OVERHEAD EARTH WIRE SYSTEM
EC/OH/COM
A ORIGINAL ISSUE
DRAWN
DATE
PASSED
APPROVED
Ergon Energy Corporation Ltd
ABN 50 087 646 062
OVERHEAD DISTRIBUTION
Dwg ShFILE: 5
f
F
f
F
f
NOTES:
1.
Earth rod additional
Earth rod additional depth
AR
AR
Caution tape
4.0m Min. (Single rod)
8.0m Min. (Double rod)
MATERIAL
ASSY DESCRIPTION QTY
MATERIAL - ADDITIONAL EARTH
ASSY
104-1
104-5
DESCRIPTION QTY
(Additional)
(Additional rod)
Assy selection 104-5 or 104-1 and 5
required, contact local Ergon branch.
If more than 4 additional earthrods
Additional earthing if required.
EA
EAR
Construction Type
185024 1850 1
4.0m
F
1
L. Burton
F
2082-3 1
Assy 2082-3
EARTHING CONCRETE POLE
SEPARATION FROM COMMUNICATIONS:
drg. 1238 for Trench Sections
Refer EARTHING WOOD POLE folder,
Construction Code
drg. 1248 Sh 3 for Additional Earthing
Refer EARTHING WOOD POLE folder,
Earthing to run in direction of mains.
assets refer Standards Section.
For separation from other communications
HARD COPYUNCONTROLLED
- Concrete pole = 2.0m
- Bare earth cable = 2.0m
- Earth rod = 2.0m
communications manholes, pillars, pits etc:
Provide the following minimum separation to
1 ohm
Max.
30 ohm
Max.
CONNECTED
L.V. NEUTRAL
DISCONNECTED
L.V. NEUTRAL
N N
- Concrete pole = 0.3m
- Bare earth cable = 0.3m
- Earth rod = 0.3m
jacketed or in plastic conduit:
to communications cable plastic sheathed /
Provide the following minimum separation
Neutral bond I.P.C. 50/95mm† with 35mm† bonding lead
OVERHEAD EARTH WIRE7/3/13
C. Avenell
C. Noel
To LV Neutral
F
equipment
or
Telstra pit
F
f2.0m min
EC/OHX/COM
Assy 2081-2
2081-2 Earth HV (35mm†) to concrete pole
RESISTANCE TO GROUND
OVERHEAD EARTH WIRE SYSTEM
COMMON EARTH - EXISTING POLE
DRAWN
DATE
PASSED
APPROVED
Ergon Energy Corporation Ltd
A ORIGINAL ISSUE
ABN 50 087 646 062
OVERHEAD DISTRIBUTION
Dwg ShFILE: 5
F
f
NOTES:
1.
Earth rod additional
Earth rod additional depth
AR
AR
MATERIAL
ASSY DESCRIPTION QTY
MATERIAL - ADDITIONAL EARTH
ASSY
104-1
104-5
DESCRIPTION QTY
(Additional)
(Additional rod)
EA
EAR
Construction Type
185224 1852 1
1
L. Burton
2130-2 1
EARTHING CONCRETE POLE
SEPARATION FROM COMMUNICATIONS:
drg. 1238 for Trench Sections
Refer EARTHING WOOD POLE folder,
Construction Code
drg. 1248 Sh 3 for Additional Earthing
Refer EARTHING WOOD POLE folder,
Earthing to run in direction of mains.
assets refer Standards Section.
For separation from other communications
HARD COPYUNCONTROLLED
30 ohm
Max.
GRADING RING - NEW POLE
7/3/13
C. Avenell
C. Noel
equipment
or
Telstra pit
F
f2.0m Min
2080-10
Grading ring earth to concrete pole
Earth butt concrete pole
Assy selection 104-5 or 104-1 and 5
required, contact local Ergon branch.
If more than 4 additional earthrods
Additional earthing if required.
F
F1.0m
F1.0mF
Assy 2130-2F F
F
150
Pole
GRADING RING
RESISTANCE TO GROUND
OVERHEAD EARTH WIRE SYSTEM
CONNECTEDF
2.0m Min. (Single rod)
4.0m Min. (Double rod)
Assy 2080-10FEarth to be 150mm below ground level
30 ohm max connected
LC
Butt earth to be under precast base if used2.
1
OVERHEAD EARTH WIRE SEPARATE EARTH
- Grading earth cable = 2.0m
- Bare earth cable = 2.0m
- Earth rod = 2.0m
communications manholes, pillars, pits etc:
Provide the following minimum separation to
- Grading earth cable = 0.3m
- Bare earth cable = 0.3m
- Earth rod = 0.3m
jacketed or in plastic conduit:
to communications cable plastic sheathed /
Provide the following minimum separation
3.
are not achieved by butt earth.
Assy 2081-2 to be used if earthing valuesAssy 2081-2 (refer note 3)
F
EC/OH/SEP
Grading ring may be round or square
for ease of trenching
F
F1.0m
A ORIGINAL ISSUE
DRAWN
DATE
PASSED
APPROVED
Ergon Energy Corporation Ltd
ABN 50 087 646 062
OVERHEAD DISTRIBUTION
Dwg ShFILE: 5
F
f
NOTES:
1.
Earth rod additional
Earth rod additional depth
AR
AR
MATERIAL
ASSY DESCRIPTION QTY
MATERIAL - ADDITIONAL EARTH
ASSY
104-1
104-5
DESCRIPTION QTY
(Additional)
(Additional rod)
EA
EAR
Construction Type
185224 1852 2
1
L. Burton
2130-2 1
EARTHING CONCRETE POLE
SEPARATION FROM COMMUNICATIONS:
drg. 1238 for Trench Sections
Refer EARTHING WOOD POLE folder,
Construction Code
drg. 1248 Sh 3 for Additional Earthing
Refer EARTHING WOOD POLE folder,
Earthing to run in direction of mains.
assets refer Standards Section.
For separation from other communications
HARD COPYUNCONTROLLED
30 ohm
Max.
7/3/13
C. Avenell
C. Noel
equipment
or
Telstra pit
F
f2.0m Min
EC/OHX/SEP
Grading ring earth to concrete pole
F
F1.0m
F1.0mF
Assy 2130-2F
F
F
150
RESISTANCE TO GROUND
OVERHEAD EARTH WIRE SYSTEM
CONNECTEDF
2.0m Min. (Single rod)
4.0m Min. (Double rod)
Assy 2081-2F
LC
2
2081-2 Earth HV (35mm†) to concrete pole
F
f1.0m Min
OVERHEAD EARTH WIRE SEPARATE EARTH
GRADING RING - EXISTING POLE
104-5 or 104-1 and 5
Assy selection
local Ergon branch.
earthrods reqd, contact
If more than 4 additional
Additional earthing if reqd.
- Grading earth cable = 2.0m
- Bare earth cable = 2.0m
- Earth rod = 2.0m
communications manholes, pillars, pits etc:
Provide the following minimum separation to
- Grading earth cable = 0.3m
- Bare earth cable = 0.3m
- Earth rod = 0.3m
jacketed or in plastic conduit:
to communications cable plastic sheathed /
Provide the following minimum separation
Pole
GRADING RING
Earth to be 150mm below ground level
30 ohm max connected
Grading ring may be round or square
for ease of trenching
F
F1.0m
DRAWN
DATE
PASSED
APPROVED
Ergon Energy Corporation Ltd
A ORIGINAL ISSUE
ABN 50 087 646 062
OVERHEAD DISTRIBUTION
Dwg ShFILE: 5