Of M/s. Aqua Chem Industries

DRAFT EIA/EMP REPORT FOR

Production of Unsaturated Polyester Resin (500 MTPM)

At Proposed Manufacturing Unit

Of

M/s. Aqua Chem Industries (Survey No.: 50/2, Village: Jodhpar (Nadi), Tehsil &

District: Morbi, Gujarat – 363641)

Category: 5 (f) Baseline Monitoring Period: December 2018 to February 2019

Baseline Study Carried by: T. R. Associates Laboratory (NABL Certificate Number: TC-7896)

PREPARED BY

T. R. ASSOCIATES [NABET ACCREDITED EIA CONSULTANT]

A-401, S. G. Business Hub,

B/w sola Bhagwat & Gota Over Bridge, Near Umiya Campus, S. G. Highway, Ahmedabad – 380060.

Contact No.: 0-98253 71099 EMAIL: [email protected]

NABET ACCREDITATION NO.: NABET/EIA/1619/SA 073

April, 2019

IT’S

Environmental Impact Assessment Report M/s. Aqua Chem Industries

Survey No.: 50/2, Village: Jodhpar (Nadi), Tehsil & District: Morbi, Gujarat – 363641.

T. R. Associates (Ahmedabad) NABET Accredited

TOR Compliance 1

TERMS OF REFERENCE (TOR) COMPLIANCE

Point wise compliance to the ToR points issued by SEAC/SEIAA (Gujarat) vide their letter no. SEIAA/GUJ/TOR/5(f)/513/2019 dated 25th March, 2019 (attached as Annexure – 1) for proposed manufacturing of Synthetic Organic Chemical (Resin) at Survey No.: 50/2, Village: Jodhpar (Nadi), Tehsil & District: Morbi, Gujarat – 363641. A tabular chart with index for point wise compliance is as given below:

ToR No.

ToR Condition Compliance Page No

Specific TOR

1 Compliance of MoEF&CC’s OM dated 01/05/2018 regarding "Corporate Environment Responsibility" (CER). Fund allocation for Corporate Environment Responsibility (CER) shall be made as per MoEF&CC's O.M. No. 22-65/20-17-IA.III dated 01/05/2018 for various activities therein. The details of fund allocation and activities for CER shall be incorporated in EIA/EMP report.

Please refer section – 8.6 of Chapter - 8

8.2 - 8.3

2 Explore the use of renewable energy to the maximum extent possible. Details of provisions to make the project energy-efficient through energy efficient devices and adoption of modes of alternative eco-friendly sources of energy like solar water heater, solar lighting etc. Measures proposed for energy conservation.

Solar system will be installed by the unit to conserve the energy.

--

3 A tabular chart for the issues raised and addressed during public hearing/consultation and commitment of the project proponent on the same should be provided. An action plan to address the issues raised during public hearing and the necessary allocation of funds for the same should be provided.

It will be included in EIA report after public hearing.

--

4 PP shall furnish status of all the applicable rules, acts, regulation, clearances in a

Please refer section – 1.7 of Chapter – 1.

1.7 – 1.9




TOR Compliance 2

ToR No.


tabular form. 5 PP shall ensure participation of people

during Public Hearing with equality in gender so as to encourage woman participation in Public hearing & at the same time their issues shall also be given weightage.

It will be included in EIA report after public hearing.

--

6 Leak Detection and Repairing Programme (LDAR) for all the volatile organic solvent proposed for use in-house with detailed chemical properties including vapor pressure. LDAR shall endeavour prevention of losses of solvents to the best minimum extent.


7.45 – 7.46

7 Safety precautions including flame proof electric fittings to be taken to avoid fire hazard during unloading, storage, transportation, handling and processing of Solvents.


7.27 – 7.29

8 Treatability & adequacy report for complete ZLD for additional wastewater. Feasibility report for complete reuse condensate wastewater for industrial purpose.

Please refer Annexure – 10.

--

9 No objection Certificate from the Concern Authority regarding nearby Machhu Dam.


--

10 Permission from CGWA for withdrawal of ground water.


--

11 Compliance of NOC obtained from Irrigation department vide letter dated 13/12/2016.


--

Standard TOR

1 A tabular chart with index for point-wise compliance of below mentioned TORs.

Given below. --

2 Executive summary of the project – giving a prima facie idea of the objectives of the

Attached with EIA --




TOR Compliance 3

ToR No.


proposal, use of resources, justification, etc. In addition, it should provide a compilation of EIA report, including EMP and the post-project monitoring plan in brief.

report.

3 Justification for selecting the proposed product and unit size.

Please refer section - 1.4 & 1.5 of Chapter – 1.

1.2 – 1.5

4 Land requirement for the project including its break up for various purposes, its availability and optimization.


2.8

5 Land possession documents. Copy of NA order showing permission to use the project land for industrial purpose. If located in GIDC, copy of plot holding certificate obtained from GIDC Authority.


--

6 Location of the project site and nearest habitats with distances from the project site to be demarcated on a toposheet (1: 50000 scale).


2.1 – 2.4

7 Topography details of the project area. Please refer figure – 2.3 of Chapter – 2.

2.4

8 Geological features and geo-hydrological status of the study area.


3.35 – 3.38

9 In case of project located outside notified area: Legal Undertaking stating that unit is complying the three conditions [i.e. water consumption less than 25 M3/day; Fuel consumption less than 25 TPD; and not covered in the category of MAH units as per the Management, Storage, Import of Hazardous Chemical Rules (MSIHC Rules), 1989] as per the amendment to EIA Notification, 2006 vide SO 1599 (E) dated 25/06/2014.


--




TOR Compliance 4

ToR No.


10 Present land use pattern of the study area shall be given based on satellite imagery.


3.39 – 3.46

11 Layout plan of the factory premises clearly demarcating various units within the plant. Provision of separate entry & exit and adequate margin all-round the periphery for unobstructed easy movement of the emergency vehicle / fire tenders without reversing back. Mark the same in the plant layout.

Please refer figure – 2.6 of Chapter – 2.

2.9

12 Technical details of the plant/s along with details on best available technologies (BAT), proposed technology and reasons for selecting the same.


2.11 – 2.12

13 Product spectrum (Proposed products along with production Capacity) and processes.


2.10 – 2.12

14 Chemical name of each proposed product to be manufactured. Details on end use of each product. (Provide CAS number of all the products & raw materials. In case of Dyes, CI number).


2.10

15 Details on raw materials, source and storage within the premises.


2.13

16 Details of complete manufacturing process / operations of each product along with chemical reactions, process flow diagram describing each unit processes and unit operations along with material balance, consumption of raw materials etc.


2.11 – 2.12

17 Details on strategy for the implementation of cleaner production activities.


10.14

18 Assessment of source of the water supply Please refer Annexure – --




TOR Compliance 5

ToR No.


with adequacy of the same to meet with the requirements for the project. Permission obtained from the concern authority for supply of raw water.

9.

19 Undertaking stating that no bore well shall be dug within the premises (If project is located within the Industrial estate).

Not Applicable --

20 Details on water balance including quantity of effluent generated, recycled & reused. Details of methods to be adopted for the water conservation.

Please refer section – 2.9 & figure – 2.7 of Chapter – 2.

2.16 – 2.18

21 Efforts to minimize effluent discharge and to maintain quality of receiving water body.

There will not be any discharge of effluent from proposed unit into water body.

--

22 Explore the possibilities for Zero Liquid Discharge (ZLD) option for the proposed project.

Please refer section – 2.9.1 (B) of Chapter – 2.

2.16 – 2.19

23 Segregation of waste streams, characterization and quality with specific treatment and disposal of each stream including action plan for maximum recycle of treated waste water and minimum discharge for effluent.


2.16 – 2.19

24 Capacity of ETP in KL/day. Details of ETP including dimensions of each unit along with schematic flow diagram. Inlet, transitional and treated effluent qualities with specific efficiency of each treatment unit in reduction in respect of all concerned/regulated environmental parameters. Inlet effluent quality should be based on worst case scenario considering production of most polluting products that can be manufactured in the plant

Please refer section – 2.9.1 (B) & Table – 2.13 of Chapter – 2.

2.16 & 2.19




TOR Compliance 6

ToR No.


concurrently.

25 In case of discharge into GIDC drainage / Pipeline:

Not Applicable.

--

I Copy of permission letter with quantity (KL/day) from the concern authority of drainage network / pipeline with confirmation for spare capacity available to take additional effluent.

II Characteristics of the combined effluent and treated water to be sent to Common pipeline with reference to the MoEFCC/CPCB/GPCB discharge norms.

III Provision for Continuous Monitoring System for waste water discharge.

26

a

In case of waste water sent to Common Facilities (CF) like CETP, MEE, Spray Dryer etc.

Details of Common facilities including

(1) Total capacity of the CF

(2) Copy of CC&A of the CF.

(3) Actual load at present (Qualitative and Please refer Quantitative – KL per day)

(4) Booked quantity & Spare capacity of CF

(5) Copies of XGN generated Inspection reports with analysis reports of the water/Air/Hazardous samples collected by GPCB (Last 2 year).

Copies of instructions issued by GPCB in last 2 year and point wise compliance thereof.

Not Applicable.

--




TOR Compliance 7

ToR No.


(6) Copies of Show- cause notices, closure notices etc. served by the GPCB and its

compliance

(6) Recommendations and suggestions of the last two Environment Audit reports of CETP and its compliance report.

(7) Common Facility Up gradation scheme, if any.

b Status of compliance to the 18(1) (b) direction issued by the CPCB with respect to CETP compliance & CEPI area action plan along with relevant supportive document.

Not Applicable. --

c Give status of compliance of Environmental norms of existing Common Infrastructure i.e. CETP, MEE & Spray Dryer (Whichever is applicable) in which you are a member.

Not Applicable. --

d Submit adequacy of Common Infrastructure i.e. CETP, MEE & Spray Dryer for additional load (Whichever is applicable) along with written confirmation/membership certificate mentioning the same (Total consented quantity, total quantity booked so far, quantity booked for the unit, spare quantity available).

Not Applicable. --

27 In case of Zero Liquid Discharge (ZLD) :

I Action plan for ‘Zero’ discharge of effluent shall be included. Notarized undertaking for assuring that underground drainage connection will not be taken in the unit and there shall be no effluent discharge outside the plant premises.


2.16


--




TOR Compliance 8

ToR No.


Economical and technical viability of the effluent treatment system to achieve Zero Liquid Discharge (ZLD).

Please refer Table – 2.13 & 2.14 of Chapter – 2.

2.19

Certification of adequacy of proposed ZLD scheme through credible institutes of National repute.


--

To estimate & monitor ground water quality & its contamination status, piezometer wells, one on up gradient of the groundwater flow and other three on the down gradient side of the ground water flow of the proposed project at different depth based on available ground water depth shall be established and all the parameters mentioned in IS 10:500 for potable water standard shall be monitored.

There will not be any wastewater discharge from proposed unit. Therefore, there is no requirement of installation of Piezometer.

--

28 In case of in-house MEE/Spray dryer for waste water treatment:

Capacity of MEE/Spray dryer in KL/hr. Technical details of MEE including evaporation capacity, steam required for evaporation, adequacy of the proposed boiler to supply steam for evaporation in addition to the steam required for the process etc. Techno-economical viability of the evaporation system. Control measures proposed for the evaporation system in order to avoid/reduce gaseous emission/VOC from evaporation of industrial effluent containing solvents & other chemicals.

Not Applicable --

29 Technical details of ATFD/Crystallizer/ spray Dryer, RO/NF system etc. (If any).

Not Applicable --

30 Details of the treatability and feasibility of wastewater to be disposed off by means of

Not Applicable --




TOR Compliance 9

ToR No.


spray dryer and its impact on environment and Human Health

31 Undertaking stating that a separate electric meter will be provided for the waste water treatment system viz. ETP, RO, MEE, Spray dryer etc. (Whichever is applicable)


--

32 Economical and technical viability of the effluent treatment system.


2.16 – 2.19

33 Plans for management, collection and disposal of waste streams to be generated from spillage, leakages, vessel washing, used container washing etc. Measures proposed for preventing effluent discharge during unforeseen circumstances.

Please refer section – 2.9.1 of Chapter – 2.

2.16 – 2.19

34 Action plan for reuse of liquid waste streams like Spent acids, Poly Aluminium Chloride etc. within premises to convert into valuable products instead of sending outside to actual end-users.

Not Applicable. There will not be generation of Spent acid from proposed unit.

--

35 Adequacy of the proposed EMS with respect to the pollution load envisaged in terms of Air, Water and hazardous waste.


--

36 One season Site-specific micro-meteorological data using temperature, relative humidity, hourly wind speed and direction and rainfall should be incorporated.


--

37 Anticipated environmental impacts due to the proposed project/production may be evaluated for significance and based on corresponding likely impacts VECs (Valued Environmental Components) may be identified. Baseline studies may be conducted within the study area for all the

Please refer section – 4.6 & 4.7 of Chapter – 4.

4.18 – 4.22




TOR Compliance 10

ToR No.


concerned/identified VECs and likely impacts will have to be assessed for their magnitude in order to identify mitigation measures.

38 One complete season base line ambient air quality data (except monsoon season) to be given along with the dates of monitoring. The parameters to be covered shall be in accordance with the revised National Ambient Air Quality Standards (NAAQS) as well as project specific parameters like NH3, HCl, Cl2, HBr, VOC etc. Locations of the monitoring stations should be so decided so as to take into consideration the pre-dominant downwind direction, population zone and sensitive receptors. There should be at least one monitoring station in the upwind direction. There should be at least one monitoring station in the pre dominant downwind direction at a location where maximum ground level concentration is likely to occur.


--

39 Modelling indicating the likely impact on ambient air quality due to proposed activities. The details of model used and input parameters used for modelling should be provided. The air quality contours may be shown on location map clearly indicating the location of sensitive receptors, if any, and the habitation. The wind rose showing pre-dominant wind direction should also be indicated on the map. Impact due to vehicular movement shall also be included into the prediction using suitable model. Results of Air dispersion modeling should be superimposed on satellite Image /


4.12 – 4.18




TOR Compliance 11

ToR No.


geographical area map.

40 Base line status of the noise environment, impact of noise on present environment due to the project and proposed measures for noise reduction including engineering controls.


3.13 – 3.16

41 Specific details of

a) Process gas emission from each unit process with its quantification.

There will not be any process gas emission from proposed unit. Hence, there will not be any requirement for installing APCM.

--

b) Air pollution Control Measures (APCM) proposed for process gas emission. Adequacy of the air pollution control measures (APCM) for process gas emission measures to achieve the GPCB norms.

c) Details of the utilities required. Please refer section – 2.8.5 of Chapter – 2.

2.15 – 2.16

d) Type and quantity (MT/hr & MT/Day) of fuel to be used for each utility.


2.15

e) Flue gas emission rate emission from each utility.


2.19 – 2.20

f) Air Pollution Control Measures (APCM) proposed to each of the utility along with its adequacy

Please refer section – 2.9.2 (A) of Chapter – 2.

2.19 – 2.20

g) List the project specific sources of fugitive emission along with its quantification and proposed measures to control it.


2.20 – 2.21

h) Details on tail gas treatment.(If any) Not Applicable --

42 Provision of CEMS (Continuous Emission Monitoring system).

Unit will make necessary provision for CEMS.

--




TOR Compliance 12

ToR No.


43 Action plan for odour control to be submitted.


2.22 – 2.23

44 Management plan for hazardous/Solid waste including storage, handling, utilization and safe disposal as per the Hazardous and Other Wastes (Management and Transboundary Movement) Rules 2016. CPCB guidelines in respect of specific treatment, such as solar evaporation, incineration, etc., need to be followed.


2.21 – 2.22

45 How the manual handling of the hazardous wastes will be minimized? Methodology of decontamination and disposal of discarded containers and its record keeping.


2.21 – 2.22

46 Management of by-products which fall under the purview of the Hazardous and Other Wastes (Management and Transboundary Movement) Rules 2016 as per the said rules and necessary permissions from the concern authority.

Not Applicable --

47 Membership of Common Environmental Infrastructure like TSDF, Common Incineration Facility (CHWIF), MEE, Spray dryer etc.

Unit will take membership of TSDF site after obtaining EC.

--

48

Name and quantity of each type of solvents to be used for proposed production. Details of in-house solvent recovery system including mass balance, solvent loss, recovery efficiency (% recovery), feasibility of reusing the recovered solvents etc. for each type of solvent.

Not Applicable --




TOR Compliance 13

ToR No.


49 Appropriate monitoring network has to be designed and proposed, to assess the possible residual impacts on VECs.


3.8

50 A detailed EMP including the protection and mitigation measures for impact on human health and environment as well as detailed monitoring plan and environmental management cell proposed for implementation and monitoring of EMP. The EMP should also include the concept of waste minimization, recycle/reuse/recover techniques, energy conservation, and natural resource conservation. Total capital cost and recurring cost/annum earmarked for environment pollution control measures.


10.4 – 10.8

51 Details of in-house monitoring capabilities and the recognized agencies if proposed for conducting monitoring.


6.2 – 6.3

52 Permission from PESO, Nagpur for storage of solvents, other toxic chemicals, if any.

Unit will obtain permission from PESO.

--

53 Occupational health impacts on the workers and mitigation measures proposed to avoid the human health hazards along with the personal protective equipment to be provided. Provision of industrial hygienist and monitoring of the occupational injury to workers as well as impact on the workers. Plan for periodic medical checkup of the workers exposed. Details of work place ambient air quality monitoring plan as per Gujarat Factories Rules.


7.29 – 7.31




TOR Compliance 14

ToR No.


54 Details on volatile organic compounds (VOCs) from the plant operations and occupational safety and health protection measures. Proposal for Leak Detection and Repair (LDAR) program as per the CPCB guidelines.


7.29 – 7.31

55 Risk assessment including prediction of the worst-case scenario and maximum credible accident scenarios should be carried out. The worst-case scenario should take into account the maximum inventory of storage at site at any point of time. The risk contours should be plotted on the plant layout map clearly showing which of the facilities would be affected in case of an accident taking place. Based on the same, proposed safeguard measures including On-Site / Off-Site Emergency Plan should be provided.


Please refer section – 7.9.2 & 7.9.8 of Chapter – 7.

7.17 – 7.24

7.35 & 7.48

56 MSDS of all the products and raw materials. Please refer Annexure – 6.

--

57 Details of hazardous characteristics and toxicity of raw materials and products to be handled and the control measures proposed to ensure safety and avoid the human health impacts. This shall include the details of Antidotes also.


7.3 – 7.5

58 Details of quantity of each hazardous chemical (including solvents) to be stored, Material of Construction (MOC) of major hazardous chemical storage tanks, dyke details, threshold storage quantity as per schedules of the Manufacture, Storage & Import of Hazardous Chemicals Rules of major hazardous chemicals, size of the biggest storage tank to be provided for



7.5 – 7.6

7.31




TOR Compliance 15

ToR No.


each raw material & product etc. How the manual handling of the hazardous chemicals will be minimized?

59 Details of the separate isolated storage area for flammable chemicals. Details of flame proof electrical fittings, DCP extinguishers and other safety measures proposed. Detailed fire control plan for flammable substances and processes showing hydrant pipeline network, provision of DG Sets, fire pumps, jockey pump, toxic gas detectors etc.


Please refer section – 7.9.6 of Chapter – 7

7.27 – 7.29 7.37 – 7.39

60 Submit checklist in the form of Do’s & Don’ts of preventive maintenance, strengthening of HSE, manufacturing utility staff for safety related measures.


7.31 – 7.34

61 Specify safety precautions to be taken for Chemical storage, process, and handling & transportation hazard.


7.27 – 7.29

62 Details on workers training before engaging work, periodical, in-house, outside etc.


7.39 – 7.42

63 Details on various SOP to be prepared. Please refer Annexure – 16.

--

64 Details on safety audit to be carried out and their compliance status.

Not Applicable --

65 Specific safety measures to be taken for general Public living in the vicinity.


7.36

66 Details on hazard identification i.e. HAZOP, HAZAN, Fault tree analysis, Event tree analysis, Checklist, Audit etc. to be adopted for the safety operation of the plant.


Please refer Annexure – 17 for Checklist.

7.13




TOR Compliance 16

ToR No.


67 Detection and monitoring of VOC’s / gases. Please refer Table – 6.1 of Chapter – 6.

6.2 – 6.3

68 Detailed five year greenbelt development program including annual budget, planning schedule, species, width of plantations, number of trees to be planted, area under green belt development [with map], budgetary outlay etc. along with commitment of the management to carry out the tree plantation activities outside the premises at appropriate places in the nearby areas and elsewhere.


10.9 – 10.10

69 Action plan for the greenbelt development - species, width of plantations, planning schedule, etc. in accordance to CPCB published guidelines.


10.9 – 10.10

70 Detailed socio-economic development measures including community welfare program most useful in the project area for the overall improvement of the environment. Submit a detailed plan for social corporate responsibilities, with appropriate budgetary provisions for the next five years and activities proposed to be carried out; specific to the current demographic status of the area.


8.2 – 8.3

71 (a) Does the company have a well laid down Environment Policy approved by its Board of Directors? If so, it may be detailed in the EIA report. (b). Does the Environment Policy prescribe for standard operating process / procedures to bring into focus any infringement / deviation / violation of the environmental or forest norms / conditions ? If so, it may be


10.2 – 10.3




TOR Compliance 17

ToR No.


detailed in the EIA.

72 What is the hierarchical system or administrative order of the company to deal with the environmental issues and for ensuring compliance with the EC conditions? Details of this system may be given.


10.3

73 Does the company have a system of reporting of non compliances / violations of environmental norms to the Board of Directors of the company and / or shareholders or stakeholders at large?

This reporting mechanism should be detailed in the EIA Report.


10.3

74 Phase wise project implementation schedule with bar chart and time frame, in terms of site development, infrastructure provision, EMS implementation etc.

This is small scale project & all construction activity will take minimum 2 months after obtaining EC.

--

75 Certificate of accreditation issued by the NABET, QCI to the environmental consultant should be incorporated in the EIA Report.


--

76 An undertaking by the Project Proponent on the ownership of the EIA report as per the MoEF&CC OM dated 05/10/2011 and an undertaking by the Consultant regarding the prescribed TORs have been complied with and the data submitted is factually correct as per the MoEF&CC OM dated 04/08/2009.

It is attached in the beginning of the EIA report.

--

77 All documents to be properly referenced with index and continuous page

Please see Index. --




TOR Compliance 18

ToR No.


numbering.

78 Where data are presented in the Report especially in Tables, the period in which the data were collected and the sources should be indicated.

Yes, provided. --

79 Project Proponent shall enclose all the analysis/testing reports of water, air, soil, noise etc. using the MoEF&CC/NABL accredited laboratories. All the original analysis/testing reports should be available during appraisal of the Project.


--

80 In case of Expansion of the project:

a. Need for the proposed expansion should be justified in detail.

b. Adequacy of existing EMS (Environmental Management System).

c. Explore the possibility to achieve Zero Liquid Discharge (ZLD) for existing as well as proposed activity.

d. Records of any legal breach of Environmental laws i.e. details of show- cause notices, closure notices etc. served by the GPCB to the existing unit in last five years and actions taken then after for prevention of pollution.

e. Copies of Environmental Clearances obtained for the existing plant, its point wise compliance report.

f. Environmental audit reports for last 3 years and compliance of its recommendations/Suggestions. (Include latest audit report and its compliance.)

Not Applicable --




TOR Compliance 19

ToR No.


g. Copy of Consent to Operate (CC&A) obtained along with point wise compliance status of all the conditions stipulated therein.

Copies of XGN generated inspection reports with analysis reports of the water/ air/hazardous sample collected by GPCB (last 2 year). Copies of instructions issued by GPCB last 2 year and point wise compliance thereof.

81 In case of project is located in Ankleshwar-Panoli, Vatva-Narol & Vapi GIDC.:

Compliance of MOEFCC’s OM no. J-11013/5/2010-IA.II (I) dated 25/11/2016 regarding lifting of moratorium on the consideration of projects for environmental clearance.

(B) Compliance of direction under section 18 (1) (b) of the Water (Prevention and Control of Pollution) act, 1974 issued by CPCB dated 31/03/2016 regarding compliance of CETP.

a) Action initiated by GPCB, if any, against proposed unit regarding non-compliance of prescribed

Standards under the various environmental laws.

b) Performance of CETP with respect to current hydraulic load & prescribed standards with No

Objection Certificate of CETP regarding incorporation of the proposed unit for acceptance of waste water.

Not Applicable --




TOR Compliance 20

ToR No.


c) Performance of TSDF site with respect to current load & prescribed standards with No Objection

Certificate of TSDF site regarding incorporation of the proposed unit for acceptance of hazardous waste to the common infrastructure.

d) Copies of quarterly action report taken for the above points submitted to the CPCB.

e) Report of GPCB which have conducted monitoring as per the said direction by CPCB dated 31/03/2016.




Index 1

Index Serial No. Particulars Page No.

TOR Compliance Executive Summary - English સં ી ત અહવાલ- જુરાતી

Chapter - 1 INTRODUCTION 1.1 – 1.9 1.1 Preamble 1.1 1.2 Purpose of the EIA Report 1.1 1.3 Promoters and their Background 1.2

1.4 Need of the Project and its Importance to the Country 1.2

1.5 Location of the Proposed Project and Siting Criteria 1.3

1.6 Scope of EIA Study 1.5 1.7 Regulatory Frame Work 1.7 Chapter - 2 PROJECT DESCRIPTION 2.1 – 2.25 2.1 Introduction 2.1 2.2 Project Location 2.1 2.2.1 Justification of Site Selection 2.5

2.2.2 List of Major Industries within 10 km study area 2.5

2.2.3 Salient Features of the Proposed Project Site 2.7 2.3 Details of Project Land & Plant Lay-Out 2.8 2.4 Capital Cost of the Proposed Project 2.10

2.5 Details of Product and Raw Material Consumption 2.10

2.6 Manufacturing Process 2.11 2.7 Storage details of Raw Materials and Products 2.13 2.8 Requirement of Resources 2.14

2.8.1 Electricity / Power 2.14 2.8.2 Manpower 2.14 2.8.3 Water 2.15 2.8.4 Fuel 2.15 2.8.5 Plant, Machineries & Utilities 2.15

2.9 Pollution Potential and Proposed Control Measures 2.16

2.9.1 Water Pollution 2.16 2.9.2 Air Pollution 2.19 2.9.3 Solid/Hazardous Waste 2.21 2.9.4 Noise & Vibration 2.22 2.9.5 Odor Control Plan 2.22 2.9.6 Potential Impacts & Mitigation Measures 2.23

Chapter - 3 DESCRIPTION OF ENVIRONMENT 3.1 - 3.73 3.1 Introduction 3.1

3.1.1 Baseline Study Area 3.2 3.1.2 Methodology of Baseline Study 3.2




Index 2

3.2 Air Environment 3.3 3.2.1 Climate of the Study Area 3.4

3.2.2 Site Specific Meteorology (December 2018 – February 2019) 3.5

3.2.3 Selection of AAQ Stations 3.8

3.2.4 Ambient Air Quality Monitoring Results and Observations 3.10

3.3 Noise Environment 3.13 3.3.1 Sampling Methodology 3.13 3.3.2 Sampling Frequency 3.13 3.3.3 Selection of Monitoring Locations and Results 3.13 3.3.4 Discussion of Noise Levels 3.16

3.4 Water Environment 3.16 3.4.1 Sampling and Analysis Methodology 3.16 3.4.2 Sampling Frequency 3.17 3.4.3 Selection of Monitoring Locations and Results 3.17 3.4.4 Interpretation of Water Quality Results 3.30

3.5 Soil Environment 3.31 3.5.1 Soil Type 3.31 3.5.2 Sampling Methodology 3.31 3.5.3 Sampling Frequency 3.31 3.5.4 Selection of Monitoring Locations and Results 3.31 3.5.5 Interpretation of Soil Quality Results 3.33

3.6 Geo-Hydrological Features 3.35 3.6.1 Introduction 3.35 3.6.2 Feasibility of Source at Taluka: Morbi 3.37

3.7 Land Use Status 3.39 3.7.1 Introduction 3.39 3.7.2 Land Use & Land Cover Classification Results 3.39 3.7.3 Topography 3.45

3.8 Ecology & Biodiversity 3.47 3.8.1 Data Collection Methodology 3.47 3.8.2 Detail Sampling Method & Literature Review 3.48 3.8.3 Biodiversity Status 3.49 3.8.4 Conclusion & recommendations 3.56

3.9 Socio Economic Environment 3.58 3.9.1 Introduction 3.58 3.9.2 Socioeconomics 3.58 3.9.3 Households 3.59 3.9.4 Population 3.59 3.9.5 Occupational Structure 3.60 3.9.6 Literacy 3.63 3.9.7 Amenities 3.64 3.9.8 Conclusion 3.70

3.10 Traffic Survey 3.70

Chapter - 4 ANTICIPATED ENVIRONMENTAL IMPACTS & MITIGATION MEASURES 4.1 – 4.23

4.1 Introduction 4.1 4.2 Impact Identification 4.2




Index 3

4.3 Assessment of Impacts 4.5 4.4 Quantification of Impacts 4.7

4.4.1 Environmental Attributes & Relative Importance 4.7

4.4.2 Magnitude Criteria 4.9 4.4.3 Matrix Development 4.9

4.5 Air Quality Modelling 4.12

4.6 Mitigation Measures for Impacts on Environment during Construction Phase 4.18

4.7 Mitigation Measures for Impacts on Environment during Operational Phase 4.20

4.8 Existing Traffic & Vehicular Pollution 4.23 Chapter - 5 ANALYSIS OF ALTERNATIVES 5.1 – 5.2 5.1 Introduction 5.1 5.2 Project Details 5.1 5.3 Site Alternative 5.1 5.4 Design Alternatives 5.2

5.4.1 Alternatives for Technology 5.2 5.4.2 Alternatives for Feed Stock 5.2

Chapter - 6 ENVIRONMENTAL MONITORING PROGRAM 6.1 – 6.5 6.1 Introduction 6.1 6.2 Environmental Monitoring Program 6.2

6.3 Budget for Implementation of Environmental Monitoring Program 6.3

6.4 Implementation of Good Laboratory Practices 6.5 6.5 Documentation and Reporting 6.5 Chapter - 7 ADDITIONAL STUDIES 7.1 – 7.47 7.1 Risk Assessment 7.1

7.1.1 Risk Assessment Methodology 7.2

7.2 Hazard Identification and Risk Assessment (HIRA) 7.2

7.2.1 Hazard Identification Methods 7.2

7.2.2 Identification of Hazardous Chemicals used within Premises 7.3

7.2.3 Storage Details of Raw Material and Products 7.5

7.2.4 Credible Accident Sources / Worst Case Scenarios 7.13

7.3 Consequence Modeling 7.13 7.3.1 Damage Criteria 7.13

7.3.2 Details of Model Used for Consequence Analysis 7.17

7.4 Failure Frequency 7.25

7.5 Estimation of Effect of Damage / Impact Identification 7.25

7.6 Summary 7.26 7.7 Proposed Risk Reduction Measures 7.27 7.8 Occupational Health Surveillance Program 7.29




Index 4

7.8.1 Treatment Facilities Provided to Workers affected by accidental Spillage of Chemicals

7.30

7.8.2 Minimization of the Manual Handling of Hazardous Substance 7.31

7.8.3 DO’S and DONT’S 7.31 7.9 Disaster Management Plan 7.35 7.9.1 Disaster 7.35 7.9.2 On-Site Emergency Plan 7.35 7.9.3 Site Plan of the Factory and Surrounding 7.35 7.9.4 Types of Overall Emergencies 7.36 7.9.5 Assessment of In-plant Hazards 7.37 7.9.6 Emergency Control System 7.37

7.9.7 General Procedures and Responsibilities 7.39

7.10 7.9.8

Offsite Emergency Preparedness Plan LDAR (Leak Detection & Repair

7.42 7.45

Chapter - 8 PROJECT BENEFITS 8.1 – 8.3 8.1 Introduction 8.1 8.2 Employment Potential 8.1 8.3 Improvements In Physical Infrastructure 8.1 8.4 Improvements in Social Infrastructure 8.2 8.5 Other Tangible Benefits 8.2 8.6 Corporate Environment Responsibility (CER) 8.2 Chapter - 9 ENVIRONMENTAL COST BENEFIT ANALYSIS 9.1 9.1 Environmental Cost Benefit Analysis 9.1

Chapter - 10 ENVIRONMENTAL MANAGEMENT PLAN 10.1 – 10.15 10.1 Introduction 10.1 10.2 Objectives of Environmental Management Plan 10.2

10.3 Components of Environmental Management Plan 10.2

10.3.1 Environmental Management Systems (EMS) 10.2 10.3.2 Environmental, Health and Safety (EHS) 10.2 10.3.3 Environmental Management Cell (EMC) 10.3

10.4 Environmental Management Plan for the Proposed Project 10.4

10.5 Greenbelt Development Plan 10.9 10.6 Rain Water Harvesting Scheme 10.10 10.7 Occupational Health Management Plan 10.13 10.8 Fire & Safety Management Plan 10.13 10.9 Cleaner Production Technologies 10.14

10.10 Budget for Environment Protection Measures 10.14 Chapter - 11 SUMMARY & CONCLUSION 11.1 – 11.3

11.1 Introduction 11.1 11.2 Air Environment 11.1 11.3 Water Environment 11.1 11.4 Noise Environment 11.2 11.5 Land/Soil Environment 11.2




Index 5

11.6 Ecology & Biodiversity 11.2 11.7 Socio-Economic Environment 11.3 11.8 Conclusion 11.3

Chapter - 12 DISCLOSURE OF CONSULTANT ORGANIZATION 12.1 – 12.4

12.1 Declaration f or Involvement in the EIA Study 12.1 12.2 Company Profile 12.3




Index 6

List of Tables Table No. Particulars Page No.

1.1 Details of Proposed Product 1.1 1.2 Promoters and their Background 1.2 1.3 Co-ordinates of all corners of the site 1.3 1.4 General Siting Criteria 1.4 1.5 Scope of the Study 1.6 1.6 Regulatory Frame Work 1.7 2.1 (A) List of Major Industries within Study Area 2.5 2.1 (B) Salient Features of the Project Site 2.7 2.2 Area Break-up of Project Site 2.8 2.3 Break-up of Capital Cost for Proposed Project 2.10 2.4 Details of Product 2.10 2.5 Details of Raw Material Consumption 2.10 2.6 Details of Raw Materials Storage 2.13 2.7 Details of Products Storage 2.14 2.8 Manpower Requirements 2.15 2.9 Fuel Consumption Details 2.15 2.10 List of Plant Machineries & Utilities 2.15

2.11 Stream-Wise Water Consumption & Wastewater Generation 2.17

2.12 Stream wise quality of effluent 2.17 2.13 Details of Proposed Effluent Treatment Plant Units 2.19 2.14 Technical details of Evaporator 2.19 2.15 Details of Flue gas stack 2.20 2.16 Details of Hazardous Waste Management 2.21

2.17 Details of Probable Odour Sources & Control Measures 2.22

2.18 Probable Environmental Impacts and Mitigation Measures 2.24

3.1 Brief Baseline Planning 3.2 3.2 Period of Meteorological Data Collection 3.4

3.3 Monthly Mean Values of Meteorological Data (Secondary Data Year 1981 – 2010) 3.4

3.4 Site Specific Meteorological Data (December 2018 – February 2019) 3.5

3.5 Ambient Air Monitoring Locations 3.9 3.6 Ambient Air Quality Analysis Methodology 3.9 3.7 Ambient Air Quality Monitoring Results 3.11 3.8 Interpretation of Ambient Air Quality Monitoring 3.12 3.9 Noise Monitoring Locations 3.13

3.10 Noise Level Monitoring Data [Day timings in Leq dB (A)] 3.15

3.11 Noise Level Monitoring Data [Night timings in Leq dB (A)] 3.15

3.12 Surface Water Monitoring Locations 3.18 3.13 Surface Water Quality Results 3.20




Index 7

3.14 Ground Water Monitoring Locations 3.23 3.15 Ground Water Quality Results 3.25 3.16 Soil Monitoring Locations 3.32 3.17 Soil Monitoring Results 3.34 3.18 Status of ground water development in the region 3.37 3.19 Land Use Land Cover Classification 3.41 3.20 Information of Field Survey 3.47 3.21 Taxonomic Status of Plant Species 3.50 3.22 Life Form Status of Plant Species 3.51

3.23 List of Agriculture and Commercial Crop Species Recorded 3.52

3.24 Taxonomical Status of Herpetofauna 3.53 3.25 Overall Status of Terrestrial and Aquatic Birds 3.53 3.26 Overall Status of Mammals 3.56 3.27 List of Villages covered in 10 km Radius Area 3.58 3.28 Population Distribution in the Study Area 3.60 3.29 Occupational Structure in the Study Area 3.62 3.30 Literacy Status in the Study Area 3.63

3.31 Basic amenities detail for study villages covered in 10 km radius (As per census 2011) 3.65

3.32 Traffic Count Data 3.71

4.1 Impact Identification Matrix (Construction & Operation Phase) 4.3

4.2 Assessment of Impacts (Construction and Operation Phase) 4.6

4.3 Environmental Attributes 4.8

4.4 Activity – Impact Evaluation Matrix (Construction and Operation Phase) 4.10

4.5 Cumulative Impact Matrix 4.12 4.6 Details of Flue Gas Stacks 4.12 4.7 Expected Pollutants and its Emission Rate 4.13

4.8 Predicted 24 hourly short term incremental Concentrations of PM10 4.17

4.9 Predicted 24 hourly short term incremental Concentrations of SO2 4.17

4.10 Predicted 24 hourly short term incremental Concentrations of NO2 4.18

4.11 Construction Phase: Impacts & its Mitigation Measures 4.18

4.12 Operation Phase: Impacts & its Mitigation Measures 4.20

4.13 Assessment of Proposed Traffic Load 4.24 6.1 Environmental Monitoring Program 6.2

6.2 Budgetary Allocations towards Environmental Monitoring Program 6.4

7.1 Chemical and Physical Properties of Hazardous Chemicals 7.4

7.2 Toxicity of Chemicals capable of producing MAHs 7.5 7.3 (A) Storage Details of Raw Materials 7.5




Index 8

7.3 (B) Storage Details of Products 7.6

7.4 Identification of Hazards associated with Storage of Raw Materials 7.7

7.5 Identification of Process Hazards 7.10 7.6 Scenarios Considered for MCA Analysis 7.13 7.7 Damage Due to Incident Radiation Intensities 7.14 7.8 Radiation Exposure and Lethality 7.15 7.9 Damage Due to Peak Over Pressure 7.16

7.10 Consequence analysis and Damage Distance (Failure of raw material storage tanks) 7.19

7.11 Atmospheric Storage Tank Leak / Tank Fire Frequencies 7.25

7.12 Types of Emergencies 7.36 7.13 Details of Fire Extinguishers 7.39 7.14 Off-site Action Plan 7.43

8.1 Action Plan for Corporate Environment Responsibility Activities 8.3

10.1 Environment Management during Construction Phase of Proposed Project 10.4

10.2 Environment Management during Operational Phase after Proposed Project 10.5

10.3 Details of Plant Species in Greenbelt 10.9 10.4 Plant for Greenbelt Development 10.10 10.5 Details of Rain Water Harvesting 10.12

10.6 Budgetary allocation towards Environmental Management 10.14




Index 9

List of Figures Figure No. Particulars Page No.

1.1 Location of the Project Site 1.4 2.1 Index Map 2.2 2.2 Google Image showing surrounding 1, 5 & 10 km

radius area from the project site 2.3

2.3 Topo sheet showing surrounding 10 km radius area from the project site

2.4

2.4 Google image showing major industries in surrounding 10 km radius area from the project site

2.6

2.5 Area Break up 2.8 2.6 Plant Layout 2.9 2.7 Water Balance Diagram of Proposed Plant 2.18 2.8 Effluent Treatment Plant flow diagram 2.19 3.1 Automatic Weather Station installed near project

site 3.5

3.2 Wind Rose Diagram of Entire Year (Secondary Source)

3.7

3.3 Google Image showing Ambient Air Quality Monitoring Locations

3.8

3.4 Photographs showing Ambient Air Monitoring 3.10 3.5 Google Image showing Noise Monitoring Locations 3.14 3.6 Images showing Noise Monitoring 3.14 3.7 Google Image showing Surface Water Sampling

Locations 3.18

3.8 Images showing Surface Water Sampling 3.18 3.9 Google Image showing Ground Water Sampling

Locations 3.23

3.10 Images showing Ground Water Sampling 3.23 3.11 Google Image showing Soil Sampling Locations 3.32 3.12 Images showing Soil Sampling 3.32 3.13 Ground Water Prospect Map 3.38 3.14 Land use and land cover map of the 10 km radius of

the study area 3.42

3.15 Satellite image of the 10 km radius of the study area 3.43 3.16 Infrastructure Map of the 10 km radius of the study

area 3.44

3.17 Topography map of the 10 km radius of the study area

3.46

3.18 Photograph showing Socio-Economic Data Collection

3.58

3.19 Percentage of Total Population Distribution 3.60 3.20 Percentage Distribution of Workers 3.61 3.21 Distribution of Literacy Levels 3.64 3.22 Image showing Traffic Surveying Location 3.71 4.1 Ground Level Concentration of PM10 4.14 4.2 Ground Level Concentration of SO2 4.15




Index 10

4.3 Ground Level Concentration of NO2 4.16 7.1 Styrene BLEVE- Worst Case Scenario (5 m/s

weather condition – stability class D) 7.20

7.2 Styrene Pool Fire (Threat Zone) (5 m/s weather condition – stability class D)

7.21

7.3 Styrene Toxic Dispersion (5 m/s weather condition – stability class D)

7.22

7.4 Styrene BLEVE (1.5 m/s weather condition – stability class F)

7.23

7.5 Styrene Toxic Dispersion (1.5 m/s weather condition – stability class F)

7.24

7.6 Off-Site Emergency Plan 7.42 10.1 Environmental Management Cell 10.3




Index 11

List of Annexures Annexure No. Particulars

1 Terms of Reference Copy 2 NA Permission 3 AAQ Results 4 Primary Meteorological Data 5 Plant Species recorded in and around 6 Material Safety Data Sheet 7 NABET Certificate 8 NABL Certificate 9

10 11 12 13 14 15 16 17

CGWA Permission Adequacy Certificate NOC of Machhu Dam NOC Compliance Undertaking of small unit Undertaking for underground drainage Undertaking for separate electric meter SOP Checklist of Safety Audit

EXECUTIVE SUMMARY

M/s. Aqua Chem Industries

Proposed Unsaturated Polyester Resin Manufacturing Unit

PROJECT LOCATION

Survey No.: 50/2, Village: Jodhpar (Nadi), Tehsil & District: Morbi, Gujarat – 363641

PREPARED BY

T. R. ASSOCIATES

A-401, S. G. Business Hub, Between Bhagwat Vidhyapith & Gota Over Bridge, Near Umiya Campus,

S. G. Highway, Ahmedabad- 380060 Mobile – 9825371099

Email – [email protected]




Executive Summary - English 1

EXECUTIVE SUMMARY – ENGLISH & GUJARATI

Executive Summary – ENGLISH

1. INTRODUCTION

M/s. Aqua Chem Industries is a green field project proposing to manufacture Unsaturated Polyester Resin, at Survey No.: 50/2, Village: Jodhpar (Nadi), Tehsil & District: Morbi, Gujarat – 363641.

Details of Proposed Product

Sr. No. Name of Product Quantity (MT/Month)

1. Unsaturated Polyester Resin 500

M/s. Aqua Chem Industries has a total land area of 8,601 m². Out of the stated land area approximately 2874 m2 is green belt area (approx. 33.41% of the total land area). The unit has already obtained Non Agricultural (NA) permission from the concerned authority.

Proposed manufacturing unit is a small unit having total investment of about INR 2.5 Crores. Approximately INR 25 Lakhs will be allocated towards Environmental Management Facilities.

M/s. T. R. Associates (NABET Accredited EIA Consultant) was appointed by M/s. Aqua Chem Industries to carry out the Environmental Impact Assessment study for their proposed project.

The proposed product i.e. Unsaturated Polyester Resin (being synthetic organic chemicals) falls under Category 5(f) as stated in Environment Impact Assessment Notification Published on 14th September, 2006. Further, the location of proposed project is outside the notified industrial estate and fall in Small Industrial Unit criteria as per the Notification dated 25th June 2014. Hence, project proponent has to obtain the Environmental Clearance from the State Environmental Impact Assessment Authority (SEIAA), Gujarat. As a part of this procedure, Public Hearing is required to be carried out as per the notification as well as the TOR granted to the unit by the SEIAA, Gujarat.

This study of Environment Impact assessment (EIA) is based on studies carried out during the month of December 2018 to February 2019. The environmental parameters (ambient air, water, soil, noise, flora and fauna) selected for study are those, which are likely to be most affected by the proposed project. The study area is defined as an area within 10 km radius from center of the project site.





Salient Features within 10 km radius surroundings area as follows:

Sr. No. Important Features Description

1 Location Survey No.: 50/2, Village: Jodhpar (Nadi), Tehsil & District: Morbi, Gujarat – 363641.

2 Project Site Co-ordinates Latitude: 22°46'4.48"N Longitude: 70°53'3.69"E

3 Temperature Range 9 °C – 34 °C 4 Mean Sea Level 70 m 5 Annual Rain Fall 676.1 mm

6 Nearest Railway Station Nazarbaug Railway Station – 5.93 Km – NW direction

7 Nearest Airport Rajkot Airport – 51.0 km in South direction 8 Nearest Town/City Morbi – 7.88 km in NW direction

9 Nearest Village Jodhpar(Nadi) Village – 0.37 km in West direction

10 Nearest State Highway State Highway 22 – 7.57 km in NW direction 11 Nearest National Highway National Highway 8A – 2.48 km in East direction

12 Nearest River/ Water Body/ Canal

Macchu River- 0.93 km in WSW direction Canal – 0.03 km – NW direction

13 Nearest Notified National Parks/ Sanctuary/ Eco Sensitive Zone

None Within 10 km radius circle.

2. AIR ENVIRONMENT

The base line Ambient Air Quality (AAQ) status within 10 km study area has been assessed through a monitoring network of 8 AAQ sampling stations during December 2018 to February 2019. Design of network for Ambient Air Quality monitoring locations were decided on meteorology & available infrastructure facilities. The base-line Ambient Air Quality of the study area was monitored for Particulate Matter (PM10 & PM2.5), Sulphur Dioxide (SO2) and Nitrogen Dioxide (NO2), CO & VOC. The result for the same is given as below:

Location Village

Results (98th Percentile) PM2.5 PM10 SO2 NO2

Project Site 39.96 58.72 20.62 25.77 Jodhpar (Nadi) 48.62 64.23 12.65 11.35

Virpar 44.53 57.19 8.68 14.75 Lakhdhirnagar 54.97 70.35 15.76 20.33

Paneli 45.58 61.3 11.74 15.76 Jambudiya 58.09 80.29 18.45 22.97 Makansar 55.13 75.73 10.74 13.82





Location Village

Results (98th Percentile) PM2.5 PM10 SO2 NO2

Adepar 49.70 69.44 14.76 16.98 Permissible limit

[NAAQ standards-2009] 60 μg/m3 100 μg/m3 80 μg/m3 80 μg/m3

Note: CO: Not Detected; VOC: Not Detected

Analysis of ambient air samples revealed that the Air quality is found well within the prescribed limits of National Ambient Air Quality standards.

The main source of gaseous emission is flue gas emission from stack attached to Thermic Fluid Heater & D. G. set.

Bio-coal/LDO will be used as a fuel & total fuel requirement for proposed project will be 1.5 MT/day or 300 liter/day. Adequate stack height will be provided for proper atmosphere dispersion of pollutants. The probable emitted pollutants will be PM, SO2 & NO2. Multi cyclone separator followed by Bag Filter will be provided as an APCM. Diesel will be used as a fuel for D. G. Set (back–up system). Therefore, the flue gas emission will also be well within prescribed norms and there is no need of any air pollution control measures for D. G. Set.

3. WATER ENVIRONMENT

Analysis of ground water and surface water samples revealed that it is suitable for domestic activity including agricultural activity. Ground water quality & Surface water quality in the area meets the Water Quality Standards (IS 10500) for drinking water.

Water Requirement

Total water requirement will be 9.0 kl/day, out of which fresh water requirement for the proposed project will be 7.5 kl/day which will be fulfilled by bore-well. For domestic activities 0.35 kl/day, for industrial activities 1.5 kl/day (reuse water from condenser) and for greenbelt development 7.15 kl/day water will be required.

Wastewater Generation and its Disposal

Total 0.315 kl/day domestic wastewater will be generated which will be disposed off through soak pit.

Total 2.0 kl/day of wastewater generated from 1.0 kl/day washing activities, 0.95 kl/day process effluent and 0.05 kl/day cooling tower blow down will be collected in collection tank. Effluent then will be taken to neutralization tank & will be neutralized using Lime & Alum and then taken to Nutsche Filter for sludge separation. Separated dried sludge will be collected, stored and disposed of at approved TSDF site. Filtrate water from Nutsche Filter will be taken to holding tank & then it will be evaporated through Evaporator. After that, water will be passed through condenser and condensate





water will be reused for industrial activities. Thus unit will maintain zero liquid discharge.

4. LAND / SOIL ENVIRONMENT

During operation activity the impact of air, water and solid waste pollution on soil causes direct / indirect effect on soil.

As all necessary air pollution control steps will be provided and based on the results of the dispersion model for the Ground Level Concentrations of various pollutants (after commissioning of the proposed project) it can be concluded that there will not be any adverse impact of air pollution on soil.

It may be noted that there will be no disposal of untreated effluent on land. So, there will be no adverse effect on land / soil due to water.

All necessary control steps will be provided for handling, storage and disposal of solid/hazardous waste generated from the plant. Thus, there will not be any significant impact of solid/hazardous waste on the soil environment.

5. NOISE ENVIRONMENT

Noise level was recorded at 8 locations within the study area to provide the baseline data to describe the existing situations.

Sr. No. Location

Noise Level (Leq) in dBA (Day Time)

Noise Level (Leq) in dBA (Night Time)

Measured Permissible Limit Measured Permissible

Limit 1 Project Site 50.3 75 43.8 70 2 Jambudiya 52.6 55 40.7 45 3 Jodhpar (Nadi) 49.7 55 40.0 45 4 Lalpar 52.3 55 42.1 45 5 Lakhdhirnagar 52.4 55 43.1 45 6 Lilapar 55.0 55 40.8 45 7 Makansar 48.3 55 41.9 45 8 Kalika Nagar 52.0 55 43.3 45

From the above Noise results it will be concluded that in day time and in night time noise levels are within the permissible limit at all locations.

6. SOCIO-ECONOMIC ENVIRONMENT

An assessment of socio-economic environment forms an integral part of an EIA study. Socio-economic environment – demographic & related socio-economic data was





collected from District Census Handbook to assess socio-economic status of the study area.

For proposed project activity, total 7 nos. of skilled and unskilled employees/workers will be required. The indirect employment will be generated by way of transportation, shopkeepers and other casual employment for many people.

Local people will be given preference wherever found suitable for all the jobs in the plant. Economic status of the local people will improve due to the increased business opportunities, thereby, making a positive impact. Educational, medical and housing facilities in the study area will considerably improve.

7. ECOLOGY & BIODIVERSITY

The study area was dominated by agriculture landscape. The floral and faunal diversity was very less.

Domestic tree species found in the study area are Bajri, Juwar, Gahu, Aeranda, Kamphal, Limbu, Dadam, Kapas, Magpahli and Ambo. Major crops in the study area are Bajri, Juwar, and Gahu.

The commonly spotted bird species of this area were Common Kingfisher, House Sparrow, Green Bee-eater, Rock Pigeon, House Crow, Common Myna, Rose-ringed Parakeet, Black Drongo and Common Kingfisher.

The wild mammals found other than domesticated ones from study area were Nilgai, Golden Jackal, Grey Mongoose and Wild Boar.

8. SOLID WASTE MANAGEMENT

The main hazardous waste generation will be ETP Sludge + Evaporation Residue, Used Oil and Discarded Plastic Bags/Drums.

ETP Sludge + Evaporation Residue will be disposed off at approved TSDF site. Used Oil will be reused within premises as a lubricant or sold to registered recycler. Discarded Plastic Bags/Drums will be sold to authorized vendor.

Unit will provide storage area for hazardous wastes having roof, pucca flooring with leachate collection system. Leachate, if any will be collected and treated in effluent treatment plant. Unit will take membership of TSDF site after commencement of proposed project.

Thus, hazardous waste management system provided by the unit will be adequate and there will not be any major impact on the environment due to hazardous waste.





9. ENVIRONMENTAL MANAGEMENT PLAN

An Environmental Management Plan has been prepared for mitigation of the adverse impacts.

The Environmental Management Plan describes in brief, the management’s plan for proper and adequate implementation of treatment and control system for pollutants and for maintaining the environment. It also includes development of green belt, proper safety of workers, environmental monitoring plan, rain water harvesting, fire protection system and measures etc.

An Environmental Management Cell will be formed for effective implementation of Environmental Management Plan.

10. ENVIRONMENT MONITORING PROGRAM

Monitoring of environmental factors will enable us to identify the changes in the environmental status at various locations and effectiveness of the mitigative measures. To ensure the effective implementation of the EMP, monitoring of ambient air quality, stack emissions, analysis & monitoring of water environment and noise level will be carried out as required / specified by statutory authority.

11. RISK ASSESSMENT

Risk analysis and study have been carried out for identification of hazards, selection of maximum credible scenarios, risk mitigation measures etc. All the hazardous chemicals will be stored and handled as per MSDS guidelines. Personal protective equipments will be provided to the workers.

12. OCCUPATIONAL HEALTH AND SAFETY

Based on risk assessment study, preventive measures are identified to ensure good health and safety of workers. Such measures include: Provision of PPEs like ear plug, ear muff etc. where noise levels in excess then 80 dB (A); Regular medical check-up of workers; Provision of basic infrastructure i.e. drinking water, sanitation, first aid etc. to workers. Use of proper PPE’s during plant operation, hazardous waste handling, chemical handling etc.

13. GREEN BELT DEVELOPMENT

Total land area of 2,874 m2 (33.41 %) has been allotted for greenbelt development. This will contains common tree species found in study area which is tolerant to pollutants as well as acts as noise absorbers. This will not only mitigate the ecological problem but





also enhance the beauty of project area that will attract avifauna, small mammals & insect species, and by this way ecological balance can be maintained to great extent.

14. PROJECT BENEFITS

The proposed project will become beneficial to the surrounding area or community in terms of infrastructural development, social development, employment and other benefits.

The proposed project has a potential for employment of skilled, semi-skilled and unskilled employees during construction phase as well as operation phase. A total 7 nos. of person is likely to get employment due to the proposed project. The project will earmark 2.0 % of total capital investment for socio-economic development activities in surrounding villages.

15. CONCLUSION

Negligible impacts will occur on air quality. However, all the necessary air pollution control measures will be provided.

No ecological damage will occur. No adverse impacts will occur on water environment. Local employment opportunities will increase. Various other environment parameters like Forest/ National Park/ Sanctuary and Religious / Historical Places will not be affected.

Environment Management Plan has been formulated to control all the pollutant parameters and Environment Management Cell has been set-up to ensure that these parameters do not exceed the norms set out by the concerned authorities.

After commissioning of the proposed project the Environmental Management Cell will take care of all the pollution control measures.

It can be concluded on a positive note that after the implementation of the mitigation measures and environmental management plan during the construction & operational phase, there will be negligible impact on the environment.

સં ી ત અહવાલ

મેસસ એકવા કમ ઈ ડ ઝ [અનસે રુટડ પોલીએ ટર રઝીન ુ ંઉ પાદન કરવાની

તાિવત પ રયોજના]

એકમનુ ં થાન

સવેર્ ન.ં- ૫૦/૨, ગામ:- જોધપર(નદી),

તાલકુો અને જી લો:- મોરબી. ગજુરાત

તૈયાર કરનાર

ટ .આર.એસોિસએ સ ઓફીસ નબંર : એ/ ૪૦૧, એસ. જી. િબઝનસે હબ, સોલા ભાગવત અન ેગોતા ઓવર િબ્રજ વ ચ,ે ઉિમયા કે પસ પાસ,ે

એસ. જી. હાઈવ,ે અમદાવાદ – ૩૮૦૦૬૦, ગજુરાત.

મોબાઈલ ન:ં- ૯૮૨૫૩૭૧૦૯૯ Email – [email protected]




Executive Summary - Gujarati 1

EXECUTIVE SUMMARY – GUJARATI

સં ી ત અહવાલ

૦૧. તાવના:-

મેસસર્ એકવા કેમ ઈ ડ ટ્રીઝ એ પ્ર તાિવત એકમ છે. આ પ્ર તાિવત એકમે સવેર્ ન.ં- ૫૦/૨, ગામ:- જોધપર(નદી), તાલકુો અને જી લો:- મોરબી. ગજુરાત રાજય ખાતે અનસે યરેુટેડ પોલીએ ટર રેઝીનનુ ંઉ પાદન કરવા માટેની દરખા ત કરેલ છે.

માકં ોડ ટ ુ ંનામ મતા

૧ અનસે યરેુટેડ પોલીએ ટર રેઝીન ૫૦૦ મેટ્રીક ટન/માસ

પ્ર તાિવત એકવા કેમ ઈ ડ ટ્રીઝ એકમનો કુલ િવ તાર આશરે ૮૬૦૧ ચો.મીટર છે. માથંી

૨૮૭૪ ચો.મી. (આશરે કુલ િવ તારના ૩૩.૪૧%) જમીન ગ્રીન બે ટ માટે ફાળવવામા ંઆવશે.

એકમ ારા બીનખેતી માટેની મજૂંરી અગાઉથી સબંિધત સ ા પાસેથી મેળવેલ છે.

પ્ર તાિવત નાના પાયાના એકમને પ્ર થાિપત કરવાની િકમંત િપયા ૨.૫ કરોડ થશે. માથંી

પયાર્વરણીય યવ થાપન પ ધિત માટે આશરે ૨૫ લાખ ફાળવવામા ંઆવશે.

મેસસર્ એકવા કેમ ઈ ડ ટ્રીઝ ારા મેસસર્ ટી. આર. એસોસીએ સની પ્ર તાિવત એકમનો

પયાર્વરણીય પ ૃ થકરણ અસર અ યાસ (EIA) કરવા માટે િનમણ ૂકં કરવામા ં આવેલ છે.

અતે્ર ન ધનીય છે કે અનસે યરેુટેડ પોલીએ ટર રેઝીન (સી થેટીક ઓગેર્નીક કેિમકલ) નુ ં

પ્ર તાિવત ઉ પાદન EIA નોટીફીકેશન-૨૦૦૬ ના િવભાગ-૫(એફ)મા ં આવે છે. તદ્ઉપરાતં

એકમની જગ્યા સિૂચત ઓ ોિગક િવ તારની બહાર છે અને સિૂચત પરીયોજના ૨૫ જૂન

૨૦૧૪ના નોટીફીકેશન પ્રમાણે નાના પાયાના ઓ ોિગક એકમ અંતગર્ત આવતો હોવાથી તેની

પયાર્વરણીય મજૂંરી(ENVIRONMENTAL CLEARANCE) SEIAA (STATE

ENVIERONMENT IMPACT ASSESMENT AUTHORITY), GUJARAT પાસેથી મેળવવાની

જ રીયાત રહલે છે.





આ પ્રકીયાના ભાગ પે લોકસનુાવણી એ જાહરેનામા પ્રમાણે તથા SEIAA/SEAC ારા

યિુનટને આપેલા TOR પ્રમાણે કરવામા ંઆવશે.

પયાર્વરણ ૃ થકરણ અસર અ યાસ (ENVIRONMENTAL IMPACT ASSESSMENT

STUDY) િડસે બર ૨૦૧૮ થી ફે આુરી ૨૦૧૯ દરિમયાન કરવામા ંઆવેલ છે. પયાર્વરણીય

ઘટકો વા કે (આસપાસ ની હવા, પાણી, જમીન, વિન, વન પિતઓ અને પ્રાણીઓ)

પ્ર તાિવત એકમથી અસર પામી શકે તેમ છે, તેનો અ યાસ કરવામા ંઆ યો છે. પ્ર તાિવત

એકમને કે દ્રમા ંલઈને ૧૦ િકમી. િત્ર યાના વત ુર્ળાકાર િવ તારને અ યાિસત કે્ષત્ર તરીકે નક્કી

કરવામા ંઆવેલ છે.

આસપાસના ૧૦ કમી િ યાના િવ તારની ુ ય લા ણકતાઓ નીચે માણે છે.

માકં ુ ય લા ણ તાઓ વણન ૧ પ્ર તાિવત એકમનુ ં થાન સવેર્ ન.ં- ૫૦/૨, ગામ:- જોધપર(નદી), તાલકુો અને

જી લો:- મોરબી. ગજુરાત રાજય

૨ અક્ષાશં – રેખાશં

અક્ષાશં:- ૨૨0૪૬’૪.૪૮” N

રેખાશં:- ૭૦0૫૩’૩.૬૯”E

૩ સમદુ્રી તરના સરેરાશ ૭૦ મીટર

૪ તાપમાન ૯ °સે. થી ૩૪ °સે. (સરેરાશ)

૫ વાિષર્ક વરસાદ ૬૭૬.૧ મી.મી (સરેરાશ)

૬ નજીક નુ ંરે વે ટેશન નઝરબાગ રે વે ટેશન (૫.૯૩ િકમી) – NW Direction

૭ નજીક નુ ંએરપોટર્ રાજકોટ એરપોટર્ (૫૧.૦ િકમી) – S Direction

૮ નજીક નુ ંશહરે મોરબી (૬.૧૬ િકમી) – WNW Direction

૯ નજીક નુ ંગામ જોધપર નદી (૦.૫૩ િકમી) - WSW Direction

૧૦ નજીક નો રા ટ્રીય ધોરીમાગર્ નેશનલ હાઈવે ૮ એ ( ૨.૪૮ િકમી) - E Direction

૧૧ નજીક નો રા ય ધોરીમાગર્ રા ય ધોરીમાગર્ ૨૨ ( ૨૨ િકમી) – NW Direction

૧૨ નજીક ના જમીન પરના પાણીના ોત

મ નદી– ૦.૯૩ િકમી - WSW Direction

કેનાલ – ૦.૦૩ િકમી- NW Direction

૧૩ રા ટ્રીય ઉપવન- જગંલી પ્રાણીઓ

માટેનુ ંઅ યાર ય

૧૦ િકમી િત્રજયામા ંનથી.





૦૨. હવા ુ ંપયાવરણ (Air Environment) :-

પ્રવતર્માન આસપાસની હવાની (Ambient Air) ગણુવ ા જાણવા માટે પ્ર તાિવત એકમ થળ

થી ૧૦ િકમી િત્ર યાના વત ુર્ળાકાર િવ તારમા ં૮ અલગ અલગ થળેથી િડસે બર ૨૦૧૮ થી

ફે આુરી ૨૦૧૯ દરિમયાન નમનૂા લઈને તેની ચકાસણી કરવામા ં આવી હતી. હવાની

ગણુવ ા નક્કી કરવા માટેના થળની પસદંગી વાયશુા અને નજીકની પ્રા ત સિુવધાઓના

આધારે નક્કી કરેલ હતા. હવાની ગણુવ ા નક્કી કરવા માટે પાિટર્કલ મેટર (PM10& PM2.5),

સ ફર ડાયોકસાઈડ (SO2), નાઈટ્રોજન ડાયોકસાઈડ (NO2), CO અને VOC ની ચકાસણી

કરવામા ંઆવી હતી.

ના પિરણામો નીચેના ટેબલમા ંદશાર્ યા મજુબ છે.

થળ પ રણામ ( ૯૮% ટકાવાર ) μg/m3

PM2.5 PM10 SO2 NO2

ો ટ સાઈટ ૩૯.૯૬ ૫૮.૭૨ ૨૦.૬૨ ૨૫.૭૭ જોધપર નદ ૪૮.૬૨ ૬૪.૨૩ ૧૨.૬૫ ૧૧.૩૫

િવરપર ૪૪.૫૩ ૫૭.૧૯ ૮.૬૮ ૧૪.૭૫ લખધીરનગર ૫૪.૯૭ ૭૦.૩૫ ૧૫.૭૬ ૨૦.૩૩

પાનેલી ૪૫.૫૮ ૬૧.૩૦ ૧૧.૭૪ ૧૫.૭૬ ં ડુ યા ૫૮.૦૯ ૮૦.૨૯ ૧૮.૪૫ ૨૨.૯૭

મકનસર ૫૫.૧૩ ૭૫.૭૩ ૧૦.૭૪ ૧૩.૮૨

આડપર ૪૯.૭૦ ૬૯.૪૪ ૧૪.૭૬ ૧૬.૯૮

વીકાય મયાદા [નેશનલ એ બીયટં

એર વોલીટ – ૨૦૦૯] ૬૦ ૧૦૦ ૮૦ ૮૦

ન ધ:CO: Not Detected ; VOC: Not Detected એ બીયટં એરના પિરણામ પરથી તારણ કાઢી શકાય કે હવાની ગણુવતા નેશનલ એ બીયટં એરક્વોલીટીના ધારાધોરણ મજુબ છે.

ગેસ ઉ સ ન પ્રદૂષણનો મખુ્ય ોત થમીર્ક યડુ િહટર અને ડી.જી. સેટ સાથે જોડાયેલ િચમની

છે.





બળતણ માટે બાયોકોલ/ એલ.ડી.ઓ નો ઉપયોગ કરવામા ંઆવશે અને પ્ર તાિવત એક્મ માટે

કુલ બળતણની જ રીયાત ૧.૫ મેટ્રીક ટન/િદવસ અથવા ૩૦૦ િલટર/ િદવસ રહશેે.

પ્રદૂષકોના યોગ્ય ફેલાવ માટે િચમની ની પયાર્ ત ઉંચાઈ રાખવામા ંઆવશે.

સિૂચત એકમ ારા ઉ સજીર્ત પ્રદૂષકો PM, SO2, NO2 હશે. ને િનયતં્રણમા ંરાખવા માટે હવા

પ્રદૂષણ િનયતં્રણ યતં્ર તરીકે મ ટી સાયક્લોન સેપરેટર સાથે બેગ િફ ટર લગાવવામા ંઆવશે.

ડી.જી. સેટ પાવર ફેલયર વખતે વાપરવામા ંઆવશે તેમા ંબળતણ તરીકે િડઝલનો ઉપયોગ

કરવામા ંઆવશે, થી ઉ સજીર્ત થતા પ્રદૂષકો િનયત માત્રા મા ંજ રહશેે આમ કોઈપણ હવા

પ્રદૂષણ િનયતં્રણ યતં્રની જ ર તેના માટે રહતેી નથી.

૦૩. જળ પયાવરણ (Water Environment):-

ભગૂભર્ જળ અને જમીન પરના પાણીની ચકાસણી પરથી કહી શકાય કે પાણી ઘરઘ થ ુઅને

ખેતીલાયક પ્રવિૃતઓ માટે યોગ્ય છે. આ િવ તારના ભગૂભર્ જળની ગણુવ ા તથા જમીન

પરના પાણીની ગણુવ ાના ધારાધોરણો (આઇ.એસ. ૧૦૫૦૦) પ્રમાણે જોવા મળેલ છે.

પાણીની જ ર યાત:-

પ્ર તાિવત પરીયોજના માટે પાણીની ુલ જ ર યાત ૯.૦ કલો લટર/ દવસ રહશે. માથંી

ચો ખા પાણીની( શ વોટર) જ ર યાત ૭.૫ કલો લટર/ દવસ રહશે. માથંી ઘરગ થ ુ

વપરાશ માટે ૦.૩૫ િકલોલીટર/િદવસ ટલુ ંપાણી વપરાશે યારે ઓ ોિગક વપરાશ માટે

૧.૫ િકલોલીટર/ િદવસ ટલુ ંપાણી તેમજ ગ્રીન બે ટ ડેવલોપમે ટ માટે ૭.૧૫ િકલોલીટર/

િદવસ ટલુ ં પાણી વપરાશે. પ્ર તાિવત પરીયોજના માટે જ રી પાણી બોરવેલ ારા

મેળવવામા ંઆવશે.

ગદંાપાણીનો ઉદભવ અને ગદંાપાણીનો િનકાલ:-

પ્ર તાિવત પરીયોજના માથંી ૦.૩૧૫ િકલોલીટર/િદવસ ટલુ ંઘરગ થ ુગદું પાણી ઉદભવશે.

આ ઘરગ થ ુગદંા પાણીનો િનકાલ સે ટીંક ટક/ સોક્પીટ સી ટમ ારા કરવામા ંઆવશે.

પ્ર તાિવત પરીયોજનામા ંકુલ ૨.૦ િકલોલીટર/િદવસ ટલુ ંઓ ોિગક ગદું પાણી વોશીંગ વી

પ્રિકયાઓ માથંી(૧.૦ િકલોિલટર/િદવસ) િનકળશે. ૦.૯૫ િકલોલીટર/િદવસ ઉ પાદન પ્રિકયા





તથા ૦.૦૫ કુલીંગ ટાવર પ માથંી ઓ ોિગક ગદું પાણી િનકળશે તેને એકઠું કરવામા ંઆવશે

યારબાદ આ ગદંા પાણીને યટુ્રલાઈઝેશન ટકમા ંસગં્રહ કરવામા ંઆવશે. આ ટાકંીમા ંલાઈમ

અને એલમ ભેળવવામા ંઆવશે યારબાદ તેને નચ િફ ટરમાથંી પસાર કરવામા ંઆવશે. નચ

િફ ટર માથંી અલગ થયેલા લજ ને સગં્રહ કરી તેને ટી.એસ.ડી.એફ સાઈટમા ંમોકલવામા ં

આવશે. િફ ટર માથંી િનકળેલ પાણીને હો ડીંગ ટાકંીમા ંસગં્રહ કરવામા ંઆવશે અને યારબાદ

તેને ઈવોપરેટરમા ંબા પીભવન કરવામા ંઆવશે. યારબાદ આ બા પને કંડે સરમાથંી પાસ

કરવામા ંઆવશે અને કં ડે સેટ થયેલા પાણીને ફરીથી ઓ ોગીક વપરાશમા ં લેવામા ંઆવશે.

થી આ પ્રિકયામાથંી કોઈ ગદું પાણી ઉદભવશે નિહં અને એકમ ઝીરો ડી ચા રહશેે.

૦૪. જમીન પયાવરણ

કામગીરી તબક્કા દર યાન હવા, પાણી, ઘનકચરાના પ્રદૂષણથી જમીન પર સીધી અથવા

આડકતરી અસરો થાય છે.

હવાના પ્રદૂષણને રોકવા માટે જ રી બધાજ પગલા લેવામા ંઆવશે. હવાના પ્રદૂષણથી જમીન

પર સીધી અથવા આડકતરી અસરો થાય છે મા ં લા ટના કામગીરી તબક્કા દર યાન જમીન

ની સપાટી પર હવાના િવિવધ પ્રદૂષકોની માત્રા (Maximum Ground Level Concentration) ના

પરીણામો પરથી કહી શકાય કે જમીન પર કોઈ ન ધનીય આડઅસર થશે નિહં.

અતે્ર ન ધનીય છે કે ગદું પાણી જમીન પર છોડવામા ંઆવતુ ંનથી થી જમીન પર કોઈ

આડઅસર થશે નિહ.ં

ઘન કચરાને સભંાળવા, સગં્રહ કરવા અને તેના િનકાલ માટેના દરેક િનયતં્રીત પગલાઓ

લેવામા ંઆવશે થી ઘન કચરાને કારણે જમીન પર કોઈ આડઅસર થશે નિહં.

૦૫. વિન પયાવરણ :-

અ યાિસત કે્ષત્રમા ંપ્રવતર્માન વિનનુ ંમાપદંડ કાઢવા માટે ૮ અલગ- અલગ થળે ઘ ઘાટની

ચકાસણી કરવામા ંઆવી હતી. ના પરીણામો નીચે પ્રમાણે છે.

માકં થળ ઘ ઘાટ ુ તર (Leq) in dBA

( દવસ દર યાન)

ઘ ઘાટ ુ તર (Leq) in dBA

(રા ી દર યાન)





માપન વીકાય મયાદા માપન વીકાય મયાદા

૧ ો ટ સાઈટ ૫૦.૩ ૭૫ ૪૩.૮ ૭૦

૨ ં ડુ યા ૫૨.૬ ૫૫ ૪૦.૭ ૪૫

૩ જોધપર નદ ૪૯.૭ ૫૫ ૪૦.૦ ૪૫

૪ લાલપર ૫૨.૩ ૫૫ ૪૨.૧ ૪૫

૫ લખધીરનગર ૫૨.૪ ૫૫ ૪૩.૧ ૪૫

૬ લલાપર ૫૫.૦ ૫૫ ૪૦.૮ ૪૫

૭ મકનસર ૪૮.૩ ૫૫ ૪૧.૯ ૪૫

૮ કાલીકાનગર ૫૨.૦ ૫૫ ૪૩.૩ ૪૫

આસપાસના વિન માપદંડના પિરણામો પરથી એમ કહી શકાય કે િદવસ અને રાત્રી દર યાન

ઘ ઘાટના તરો તેની િનયત માત્રામા ંજોવા મળેલ છે.

૦૬. સામા ક-આિથક પયાવરણ:-

સામાજીક અથર્ ય થાનો અ યાસ એ પયાર્વરણ ૃ થકરણ અસર અ યાસ માટેની ખબૂજ

મહ વની િવગત છે આ કારણસર અ યાિસત કે્ષત્રમા ંસામાજીક અથર્ ય થાની માિહતી વીકે

વ તીનુ ંપ્રમાણ, કામગીરીનો પ્રકાર વગેરે જી લા વ તીગણતરી પિુ તકામાથંી મેળવેલ છે.

પ્ર તાિવત પરીયોજનાને કારણે આશરે ૭ ટલા માણસોને સીધી તેમજ આડકતરી રીતે

રોજગારી પ્રા ત થશે. પ્ર તાિવત પરીયોજનાને કારણે આડકતરી રીતે વીકે વાહન વહાર,

દુકાનોમા ંવગેરેમા ંરોજગારીની તકો ઉભી થશે.

થાિનક લોકોની આ લા ટની કામગીરી માટે જ ર લાગે યા ં પસદંગી કરવામા ંઆવશે.

આજુબાજુના િવ તારમા ં ધધંાની ઉ વળ તકોને કારણે યાનંા થાિનક લોકોની આિથર્ક

પિરિ થતી સધુરશે અને તેથી એકમને કારણે હકારા મક અસર થશે. આજુબાજુના િવ તારમા ં

સાક્ષરતા, આરોગ્ય અને રહણેીકરણીમા ંસધુારો થશે.





૦૭. વ પ ર થતી અને વ િવિવધતા શા :-

આ િવ તાર મખુ્ય વે ખેતીલાયક જમીન ધરાવે છે. થી આ િવ તારમા ં વ િવિવધતા બહુ

ઓછી જોવા મળેલ છે

અ યાિસત કે્ષત્રમા ં થાિનક વન પિત પ્રજાિતઓ વીકે બાજરી, જુવાર, ઘઉં, એરંડા, િલંબ,ુ

દાડમ, કપાસ, મગફળી અને આંબો જોવા મળેલ છે. બાજરી, જુવાર અને ઘઉં વગેરે અ યાિસત

કે્ષત્રના મખુ્ય ખેતીલાયક પાકો છે.

અ યાિસત કે્ષત્રમા ંસામા ય રીતે દેખાતા પક્ષીઓમા ંચકલી, કબતૂર, કલકલીયો, સન બડર્,

કોયલ, કાબર, પોપટ, કાગડો, હોલો, બગલો જોવા મળે છે.

અ યાિસત કે્ષત્રમા ંપાલત ુ ંપ્રાણીઓ ઉપરાતં જગંલી સ તન પ્રાણીઓ જોવા મળેલ હતા

તેમા ંઝરખ, િનલગાય, શાહુડી, િશયાળ, નોળીયો અને જગંલી ભ ૂડં નો સમાવેશ થાય છે.

૦૮. સોલીડ વે ટ મેનેજમે ટ :-

મખુ્ય હઝેાડર્સ વે ટમા ં ઈટીપી કચરો+ઈવેપોરેશન રેસીડ ,ુ વપરાયેલુ ંઓઈલ અને નકામી

થેલીઓ અને ડ્રમનો સમાવેશ થાય છે.

ઈટીપી કચરાનો + ઈવેપોરેશન રેસીડ ુનો મજુંર થયેલ TSDF સાઈટમા ં િનકાલ કરવામા ં

આવશે. વપરાયેલુ ં ઓઈલ યબુ્રીકે ટ તરીકે પનુઃ વપરાશે અથવા રજી ટડર્ રીસાઈકલરને

વેચાશે, નકામી થેલીઓ અને ડ્રમ મજૂંર થયેલ વે ડર ને વેચાશે.

એકમ હઝાડર્સ વે ટના સગં્રહ માટે છત ધરાવતી અલગથી જગ્યા ફાળવશે મા ંલીચેટથી થતા

જમીનના પ્રદૂષણને અટકાવવા માટે પક્કા લોરીંગ કરવામા ંઆવશે, આ લીચેટને કલેક્ટ કરી

તેના શિુ ધકરણ માટે તેને ઈટીપીમા ં મોકલવામા ંઆવશે. સિૂચત પરીયોજના પ્રારંભ પછી

એકમ ારા TSDF સાઈટનુ ંસ યપદ મેળવવામા ંઆવશે.

આથી એકમ ારા અપાયેલી હઝેાડર્સ વે ટ મેનેજમે ટ પિ ત પરૂતી હશે અને હઝાડર્સ વે ટ

મેનેજમે ટના લીધે પયાર્વરણ પર કોઈ આડઅસર થશે નહી.





૦૯. પયાવરણીય યવ થાપન યોજના:-

પયાર્વરણ પર થતી આડઅસરોને રોકવા/નાથવા માટે પયાર્વરણીય યવ થાપન યોજના

બનાવવામા ં આવેલ છે. આ પયાર્વરણીય યવ થાપન યોજનામા ં પયાર્વરણને યથાવત

જાળવવા માટે અને પ્રદૂષકોને િનયતં્રીત માત્રામા ં રાખવા માટે જ રી અને યોગ્ય પગલાઓં

વાકે ગ્રીન બે ટ ડેવલપ કરવો અને તેન ુ ં જતન કરવુ,ં કામદારોની યોગ્ય સલામતી,

પયાર્વરણીય ઘટકોની ચકસણી યોજનાનો અમલ કરવો, વરસાદના પાણીનો સગં્રહ કરવો, આગ

ન લાગે તેવા તકેદારીના પગલા લેવા અને આગ નાથવાના સાધનો રાખવા વગેરેનો સમાવેશ

કરવામા ંઆવે છે.

આ પયાર્વરણીય ય થાપન યોજનાના અસરકારક અમલીકરણ માટે પયાર્વરણીય ય થાપન

એકમની રચના કરવામા ંઆવશે.

૧૦. પયાવરણીય ચકાસણી યોજના:-

પયાર્વરણીય પિરબળોની ચકાસણી િવિવધ થળોએ પયાર્વરણીય અસરો તથા તેના ફેરફારો

ઓળખવા માટે મદદ પ થશે.

આ હતેથુી પયાર્વરણીય યવ થાપન યોજનાના પાલન માટે આસપાસની હવાની ગણુવ ાની

ચકાસણી, ચીમનીમાથંી િનકળતા પ્રદૂષકો તથા પાણીનુ ંપયાર્વરણની ચકાસણી તેમજ વિન

માપદંડની ચકાસણી કાયદામા ંજણા યા મજુબ કરવામા ંઆવશે.

૧૧. જોખમની આકારણી:-

જોખમી રસાયણો રાખવા માટે કરવામા ંઆવતી જોખમ આકરણીમા ંપરીબળો વાકે, જોખમનો

ોત, જોખમ થવાની મહ મ સભંાવના અને જોખમ નાથવા માટેના પગલા ંઆવરી લેવાયા

છે. બધા જ જોખમી રસાયણોનો સગં્રહણ અને િનયતં્રણ MSDS ની માગર્દિશર્કા હઠેળ કરવામા ં

આવશે.





૧૨. યવસાય આરો ય અને સલામતી

જોખમ આકારણી નો અ યાસ ારા એકમમા ંકામ કરતા લોકો માટે નીચે મજુબના સરુક્ષા મક

પગલા ંલેવામા ંઆવશે.

યિક્તગત રક્ષા મક સાધનો (પસર્નલ પ્રોટેક્ટીવ ઈક્વીપમે ટ) વાકે ઈઅર લગ યા ં વની

પ્રદૂષણ ૮૦ dB(A) થી વધ ુ હોય, કારીગરો માટે િનયમીત વા ય ચેક-અપ, પાયાની

જ રીયાતો મકે પીવાનુ ં પાણી, શૌચાલય, પ્રાથિમક સારવાર આપવામા ંઆવશે. પસર્નલ

પ્રોટેક્ટીવ ઈક્વીપમે ટનો ઉપયોગ ઈટીપી , જોખમી કચરાના િનકાલ તથા કેમીકલ હ લીંગમા ં

કરાવવામા ંઆવશે.

૧૩. ીન બે ટ ડવલપમે ટ :-

આશરે કુલ ૨૮૭૪ ચો.મી. (૩૩.૪૧%) ટલો ગ્રીન બે ટ િવ તાર પ્રો ક્ટ સાઈટની અંદર

ડેવલોપ કરવામા ં આવશે. આ ગ્રીન બે ટમા ં અ યાસીત કે્ષત્ર મા ં મળી આવતી થાિનક

વન પિત પ્રજાતીઓ ઉગાડવામા ંઆવશે કે હવા પ્રદૂષણ ને સહન કરી શકશે અને વિન

પ્રદૂષણ ને શોષી શકશે. ગ્રીન બે ટ વ પિરિ થતને લગતી સમ યાનુ ંશમન કરવાની સાથે

એકમની સુદંરતામા ંવધારો કરશે તથા પક્ષીઓ, નાના સ તન પ્રાણી, જતંઓુ વગેરેને આકષીર્ત

કરીને વ પિરિ થતીનુ ંસતંલુન જાળવવામા ંપણ મદદ પ થશે.

૧૪. ો ટ થી થતા લાભો:-

સિૂચત પ્રો ક્ટ આસપાસના િવ તારના સમદુાયના અથવા માળખાકીય િવકાસ, સામાજીક િવકાસ, રોજગાર અને અ ય ફાયદાઓની દ્રિ ટએ લાભદાયી બનશે.

સિૂચત પ્રો ક્ટ કુશળ, અધર્કુશળ અને િબનકુશળ કમર્ચારીઓને બાધંકામ તબક્કો અને કામગીરી તબક્કા દરિમયાન રોજગારી આપવાની ક્ષમતા ધરાવે છે. કુલ ૭ ટલા યિક્તઓને સિૂચત

પ્રો ક્ટ ારા રોજગાર મળી શકે છે. આ પ્રો કટ કુલ નફાના ૨.૦% ટલો ખચર્ સામાજીક તેમજ

આિથર્ક િવકાસ માટે કરશે.





૧૫. ઉપસહંાર :-

આ પયાર્વરણ અસર પ ૃ થકરણ અ યાસ પરથી કહી શકાય કે... હવાની ગણુવ ા પર નજીવી અસર થાય છે. જો કે હવા પ્રદૂષણ િનયતં્રણ માટેના

તમામ પગલા લેવામા ંઆવશે.

કોઈ ઈકોલોજીકલ નકુશાન થશે નિહ. જળ પયાર્વરણ પર કોઈ પ્રિતકૂળ અસર થશે નિહ. થાિનક રોજગારીની તકો વધશે.

િવિવધ પયાર્વરણીય પિરમાણો વા કે જગંલ, રા ટ્રીય બગીચા, અ યાર ય અને

ધામીર્ક તથા ઐતીહાિસક થળો પર કોઈ અસર થશે નિહ. પયાર્વરણીય મેનેજમે ટ યોજના બધા પ્રદૂષણ પિરમાણોને િનયિંત્રત કરવા માટે

ઘડવામા ંઆવી છે. અને આ પિરણામો સબંિધત સ ાિધકારો ારા થપાયેલ ધોરણ

કરતા વધી ના જાય એ માટે પયાર્વરણ મેનેજમે ટ એકમ ારા ખાતરી કરવામા ંઆવે

છે.

પયાર્વરણ મેનેજમે ટ સેલ સિૂચત પ્રો કટની શ આત પછી પ્રદૂષણ િનયતં્રણના ંપગલા ં લેશે.

આથી અનમુાન કરી શકાય કે બાધંકામ અને કામગીરી તબક્કા દરિમયાન મકૂવામા ંઆવેલ

પયાર્વરણીય સચંાલન યોજના અને શમનના પગલાનંા હકારા મક અમલીકરણથી પયાર્વરણ

પર થતી અસરોને ઘટાડી શકાશે.

Documents

Of M/s. Aqua Chem Industries