Embed Size (px)
Citation preview
MSA Electrolux
Front Load Washer
MSA Training Presented by Marcone Servicers Association
Safety NOW and ALWAYS…
Product Features
Product Specs
Controls
Demo Mode
Product Operation—Detergent Dispenser w/ Multi-Way Solenoid Valves
Product Operation—4-Way Compartment Dispenser
Product Operation User Interface (UI) Board
Product Operation User Interface (UI) Board
Product Operation—Main Control Board
Product Operation—Main Control Board
Product Operation—Motor Control Board
Product Operation—Motor Control Board
Electrical Component—Resistance/ Specs
Pump—Wash/Recirculation
Heating Element
Pressure Sensor
Door Lock
Main Motor
Solenoid Valves
Solenoid Valve--Symptoms Operating Principles Mechanical Jamming of
Solenoid Valve
Low Water Pressure
Drum Light
Component Access
Access Top Panel
Access Main Control Board
Access Pressure Sensor
Access Solenoid Valve
Access Rear Panel/Belt
Access Heating Element
Access Main Motor
Access Motor Control Board
Access Door Lock
Access Front Panel
Access Control Panel
Access Wash Pump
Access Drain Pump
Access Recirculation Pump
Access Drum Light
Access Leveling Leg
Diagnostics and Troubleshooting
Factory Default Reset
Enter/Exit Demo Mode
Enter/Exit Diagnostic Mode
Scrolling Through Diagnostic Mode Test
Diagnostic Test
Diagnostic Test
Washer Error Codes
Washer Error Codes
Washer Error Codes
Washer Error Codes
Washer Error Codes
Troubleshooting Tests
Troubleshooting Tests
Troubleshooting Tests
Troubleshooting Tests
Troubleshooting E 11, Fill Time Too Long
Troubleshooting E11 Fill Time Too Long
Troubleshooting E13 Water Leak in Tub Or in Pressure Sensor
Troubleshooting E21 Water Not Pumping Out Fast Enough
Troubleshooting E23 Drain TRIAC Error E24 Drain TRIAC Error Sensing
Troubleshooting E31 Electronic Pressure Switch Error E32 Pressure Sensor Calibration Problem
Troubleshooting E36 Pressure Sensor Indicates Water Overfill E38 Air Trap Clogged
Troubleshooting E41 Control Board Thinks Door Switch Is Open E42 Door Lock Device Failure E43 Door Lock TRIAC Failure E44 Door Closed Sensing Failure E45 Line Door Sensing Failure
Troubleshooting E57 High Current On Inverter E58 High Current on Motor Phase
Troubleshooting E59 No Spin Signal for 3 Seconds E55 Under Speed
Troubleshooting E5A High Temperature On Control Due to Overload
Troubleshooting E5A High Temperature On Control Due to Overload
Troubleshooting E5B Motor Control Under Voltage E5C High Voltage Experienced by Motor Control
Troubleshooting E5D Communication Problem w/Motor Control E5E Communication Problem from Motor Control E5F Motor Control is Continuously Resetting
Troubleshooting E62 Wash Temperature Too High
Troubleshooting E66 Heater Relay Problem E68 Current Leakage To Ground on Heater or Wiring E69 Heater Open E6A Heater Relay Sensing Problem
Troubleshooting E71 Drum Water NTC Failure (Tub Heated) E76 Wash Temperature Does Not Increase
Troubleshooting E84 Recirculation Pump TRIAC Series E85 Recirculation Pump TRIAC
Troubleshooting E83 Wrong Selector Reading E86 Incorrect User Interface Selection Table E87 User Interface Micro-Controller Fault E91 Communication Error user Interface To Control Board E92 User Interface To Main Board Communication Error
Troubleshooting E95 Console or Main Board Control Problem E94 Main Board Control Problem E97 Console or Main Board Control Problem
Troubleshooting E98 Console Control Problem
Troubleshooting E9C User Interface Configuration Problem
Troubleshooting E9E Key Stuck Or Contaminated
Troubleshooting EH1 Frequency of Power Out of Limits EH2 Supply Voltage Too High EH3 Supply Voltage Too Low EHE Control Relay Fault EHF Control Relay Sense Fault
Troubleshooting EF2 Too Much Soap Or Wrong Type
Troubleshooting EF5 Load Unbalanced
Troubleshooting EF6 Control Board
Troubleshooting EF9 Hot Valve Warning
That is all…
Thank you! Any Questions…
