Manufacturer: CAT Model: 140M3 CONFIGURATION EROPS …

MOTOR GRADERS

Date Created: 06-05-18 Location: Waco TX.

Inspector: RR Inspection #

Manufacturer: CAT Model: 140M3

Serial #: N9D00165 Year: 2014

Engine SN: SYE06263 Transmission SN:

SMU/Hrs: 2210 Last Scheduled Oil Sample:

Last CTS: Last PM:

Notes:

CONFIGURATION

EROPS OROPS Air Conditioner

High Profile Cab Low Profile Cab Push Block

Side Shift Snow Plow Snow Wing

Tip Control Variable Horsepower Front Scarifier

Ripper Diff Lock/Unlock Tier 4

Accumulators All-Wheel Drive Anti-Theft System

Lift Group Product Link Slip Clutch

CE Plate

GENERAL APPERANCE

CONDITION: N = New VG = Very Good G = Good F = Fair P = Poor NA = Not Applicable

N VG G F P NA Remarks

Radiator Grill & Shroud

Eng Enclose Hood / Stack

Draw Bar

Fuel Tank

Crankcase Guard / Battery Box

Front Frame


Rear Frame

Counterweight

Bumper

Pre-Cleaner Bowl

Cab or Canopy

Scratches & some rust on rear cab around rear glass.

Steps / Ladder

Left steps bent slightly.

Grab Irons

Paint

Sheet Metal

Guards / Screens

Yes No NA Remarks

S.O.S. Taken

Cleaning Required

Notes

SAFETY ITEMS

Yes No NA Remarks

Safety Decals In Place

Safety Decals Legible

ROPS

Rotating Beacon

Signal Lights

Warning Lights



Horn

Notes

GUAGES, OPERATOR STATION, CONSOLE



Dash Console

Meter

Gauges

Switches

Windshield Wipers

Right cab door wiper inop.

Heater

Air Conditioner

Interior Lights

Seat Cushion / Arm Rest

Floor Boards

EMS Panel / Warnings

Door Latches

Doors

Right cab door missing pin on lower latch will not open from outside.

Windows

Glass / Mirrors

Seat Belt

Yes No NA Remarks

Current Parts Manuel

Current Safety Manuel

Current O&MM

ROPS Certification Plate

Back Up Alarm

Notes

Remarks

Fuel Level

ENGINE

Yes No NA Remarks

Oil Leaks

Knocking

Water In Oil

Fluid Levels OK?

EPA Decal

Remarks

Anti-Freeze Color

R

Oil Pressure (H/L/N)

N

Smoke(B/D/L/W)

L



Turbocharger / Blower

Fuel Injection

Governor

Engine Supports

Air Cleaners

Exhaust/Muffler

Belts / Pulleys

Operating Condition

Notes

Runs o k.

COOLING SYSTEM



Radiator

Coolers

Hoses

Water Pump

Fan

Fan Drive

Notes

Yes No NA Remarks

Leaks

ELECTRICAL, STARTING AND CHARGING SYSTEM



Batteries/Cables

Starter

Alternator

Wiring

Pre-Heater

Lighting

Notes

Yes No Na Remarks

Ether Aid

Block Heater

TRANSMISSION



Case

Seals

Torque Converter

Universal Joints

Temp / Pressure Gauges

Drive Shaft

Lines/Fittings

Cooler

Pump

Operating Condition

Reverse Shifts

Forward Shifts

Yes No NA Remarks

Noisy

Leaks

Notes

STEERING



Steering Linkage

Articulate P & B

Steering Cylinder

Front Axle

Tie Rods / Rod Ends

Steering Cylinder



King Pins

Wheel Lean Cylinder

Supplemental Steer

Steering Valves / Pumps

Notes

BRAKE



Control Valve

Lines

Master Cylinder

Compressor

Brake Linkage

Pedal

Parking Brake

Hydraulic Pumps

Brake Type

Notes

Yes No NA Remarks

Leaks

Holds In What Gear?

TANDEMS



Tandems

Wheel Lugs & Rims

Differential

Differential Lock

HYDRAULICS



Operating Condition

Tank

Pumps & Valves

Hose Lines

Linkage

Side Shift Cylinder

Lift Cylinders

Tip Cylinder

Wheel Lean Cylinder

Turn Drive Box

Circle, Shoes & Plates

Notes

Yes No NA Remarks

Leaks

BLADE



Face / Moldboard

Cutting Edge Condition

Circle

A-Frame

Blade Size 14'

Notes

RIPPER



Pins & Bushings

Brackets / Studs

Beam / Frame

Shanks /GET

Bucket Linkage

Lines / Fittings

SCARIFIER



Pins & Bushings

Brackets / Studs

Beam /Frame

Shanks / Get

Lines / Fittings

SNOW WING



Operating Condition

Cylinder Condition

Rear Post

Moldboard

TIRES

Make Tread Depth in 1/32”

% Life Remaining Recapped

Tread Cuts/Chunks

Side Cuts

Yes No NA Yes No NA Yes No NA

Right Front All Bridgestone

32 90

Right Center 34 100

Right Rear 34 100

Left Front 32 90

Left Center 34 100

Left Rear 34 100

Tire Size 14.00R24

Notes

Rim Depth

Yes No NA Remarks

Spare

COMMENTS, MISC. REPAIRS, GENERAL REMARKS

Remarks

Paint & sheetmetal o k, scratches around rear glass. Circle operation pins & plates 65% - center & ripper pins tight 70%. Operator station okay, cold a/c, right cab door missing pin on latch rod, right cab door wiper inop, all other systems operate o k.

file:///C|/Users/james.carson/Pictures/N9M00165_PSRPT_2018-06-05_09.59.12.html[6/18/2018 3:42:04 PM]

Cat Electronic Technician 2017C v1.0Product Status Report

6/5/2018 9:59 AM

C9 140M3 (SYE06263)VIMS Main Module (N9M00165)Implement #2 140M3 (N9M00165)Trans/Chassis 140M3 (CM301478)Primary Display 140M3 (N9M00165)Implement 140M3 (N9M00165)Engine #1 Aftertreatment ControllerDiesel Exhaust Fluid Controller #1

Product Status Report Parameter ValueProduct ID N9M00165Equipment ID 140M3Comments

C9 140M3 (SYE06263) TOP

Parameter ValueEquipment ID 140M3Engine Serial Number SYE06263ECM Part Number 4176020-00ECM Serial Number 02756227VJSoftware Group Part Number 5156452-00Software Group Release Date OCT16Software Group Description A4-C9Operator Inducement Regulation Configuration Worldwide

Logged Diagnostic Codes [Diagnostic Clock = 2210.4318 hours] - C9 140M3 (SYE06263) Code Description Occ. First LastNo Logged Diagnostic Codes

Logged Event Codes [Diagnostic Clock = 2210.4318 hours] - C9 140M3 (SYE06263) Code Description Occ. First LastE1096 (1) High EGR Mass Flow Rate 1 2210 2210

Active Diagnostic Codes - C9 140M3 (SYE06263) Code DescriptionNo Active Diagnostic Codes

Active Event Codes - C9 140M3 (SYE06263) Code DescriptionNo Active Event Codes

System Communication Status - Active Problems - C9 140M3 (SYE06263) ECMs Detected Problem Data Link Diagnostic Information


No issues were reported

System Communication Status - Inactive Problems - C9 140M3 (SYE06263) ECMs Detected Problem Data Link Diagnostic InformationNo issues were reported

Current Totals - C9 140M3 (SYE06263) Description Value UnitTotal Idle Time 752:39 hoursTotal Fuel 7854 galTotal Engine #1 Fuel 7608 galTotal Idle Fuel 785 galTotal Max Fuel 26437 galEngine Lifetime Hours 2209.5 hoursAverage Load Factor 27 %Engine Starts 1180Lifetime Total Engine Revolutions 203612588 revTotal Operating Hours 2210 hoursOperator Inducement Emergency Override Total Activations 0Operator Inducement Emergency Override Total Resets 0Total Engine Idle Shutdown Count 0Total Engine Idle Shutdown Overrides Count 0Total Delayed Engine Shutdown Count 165Total Delayed Engine Shutdown Overrides Count 4Starts/Hour 0.53Average RPM 1535.87 rpmPercentage Idle Time 34.03 %Average Fuel Rate 3.55 gal/hOverall Load Factor 29 %

Configuration - C9 140M3 (SYE06263) Description Value UnitEquipment ID 140M3Engine Serial Number SYE06263ECM Part Number 4176020-00ECM Serial Number 02756227VJSoftware Group Part Number 5156452-00Software Group Release Date OCT16Software Group Description A4-C9Rating Number 1Rated Power 232 hp at 2000 rpmRated Peak Torque 850 lb-ft at 1000 rpmLow Idle Speed 800 rpmHigh Idle Speed 2150 rpmEther Solenoid Configuration Not InstalledCrankcase Pressure Sensor Installation Status Not InstalledAmbient Air Temperature Sensor Installation Status Not InstalledFuel/Water Separator Switch Installation Status Not InstalledLow System Battery Voltage Elevated Idle EnabledEngine Warm Up Elevated Idle Feature Enable Status EnabledAll Wheel Drive System Installation Status Not InstalledEngine Idle Shutdown Enable Status DisabledEngine Idle Shutdown Delay Time 5.0 minDelayed Engine Shutdown Enable Status EnabledDelayed Engine Shutdown Maximum Time 7.0 minEngine Cooling Fan Map High AmbientEngine Fan Reversing Feature DisabledEngine Fan Suspend Purge DisabledEngine Fan Manual Purge EnabledEngine Fan Purge Cycle Duration 25.0 sec


Engine Fan Purge Cycle Interval 1200 secEngine Fan Reverse Operation Early Termination Enable Status EnabledARD Manual Disable Status Not DisabledHigh Soot Load Aftertreatment Protection Enable Status EnabledOperator Inducement Progress Configuration Reduced PerformanceOperator Inducement Regulation Configuration WorldwideOperator Inducement Emergency Override Enable Status DisabledOperator Inducement Emergency Override Activation Not ActivatedOperator Final Inducement Action IdleDelayed Engine Shutdown Aftertreatment Gas Temperature Threshold 590.0 Deg FAftertreatment #1 DEF Quality Sensor Installation Status Not InstalledSystem Operating Voltage Configuration 24 VoltFLS -4FTS 20CAN Communication Protocol Write Security Seed and Key AccessCAN Communication Protocol Read Security Seed and Key AccessTotal Tattletale 177

Lifetime:Accumulated Time vs Intake Manifold Pressure - C9 140M3 (SYE06263) Intake Manifold Pressure( psi ) hours %<11.603 0.65 2.0611.603-13.052 0.30 0.9513.053-14.503 0.40 1.2714.504-15.953 0.60 1.9015.954-17.404 0.85 2.6917.405-18.854 1.30 4.1218.855-20.304 2.15 6.8120.305-21.755 3.45 10.9421.756-23.205 6.40 20.2923.206-24.655 7.05 22.3524.656-26.106 5.25 16.6426.107-27.556 2.50 7.9227.557-29.007 0.60 1.9029.008-30.457 0.05 0.1630.458-31.907 0.00 0.0031.908-33.358 0.00 0.0033.359-34.808 0.00 0.0034.809-36.258 0.00 0.0036.259-37.709 0.00 0.0037.710-39.159 0.00 0.0039.160-40.610 0.00 0.0040.611-42.060 0.00 0.0042.061-43.510 0.00 0.0043.511-44.961 0.00 0.0044.962-46.411 0.00 0.0046.412-47.861 0.00 0.0047.862-49.312 0.00 0.0049.313-50.762 0.00 0.0050.763-52.213 0.00 0.0052.214-53.663 0.00 0.0053.664-55.113 0.00 0.0055.114-56.564 0.00 0.0056.565-58.014 0.00 0.0058.015-59.464 0.00 0.0059.465-60.915 0.00 0.0060.916-62.365 0.00 0.0062.366-63.816 0.00 0.0063.817-65.266 0.00 0.0065.267-66.716 0.00 0.0066.717-68.167 0.00 0.0068.168-69.617 0.00 0.0069.618-71.067 0.00 0.0071.068-72.518 0.00 0.00


72.519-73.968 0.00 0.0073.969-75.419 0.00 0.0075.420-76.869 0.00 0.0076.870-78.319 0.00 0.0078.320-79.770 0.00 0.0079.771-81.220 0.00 0.0081.221-82.670 0.00 0.0082.671-84.121 0.00 0.0084.122-85.571 0.00 0.0085.572-87.023 0.00 0.00>87.023 0.00 0.00

Lifetime:Accumulated Time vs Engine Coolant Temperature - C9 140M3 (SYE06263) Engine Coolant Temperature( Deg F ) hours %<32.00 0.10 0.0132.00-40.99 0.05 0.0041.00-49.99 0.20 0.0150.00-58.99 0.95 0.0559.00-67.99 2.15 0.1168.00-76.99 2.95 0.1577.00-85.99 5.05 0.2686.00-94.99 8.30 0.4395.00-103.99 11.10 0.58104.00-112.99 10.40 0.54113.00-121.99 10.60 0.55122.00-130.99 10.65 0.55131.00-139.99 11.70 0.61140.00-148.99 13.30 0.69149.00-157.99 15.50 0.81158.00-166.99 29.25 1.52167.00-175.99 422.35 21.99176.00-184.99 1355.00 70.54185.00-193.99 10.60 0.55194.00-202.99 0.50 0.03203.00-211.99 0.10 0.01212.00-220.99 0.00 0.00221.00-229.99 0.00 0.00230.00-238.99 0.00 0.00239.00-247.99 0.00 0.00248.00-256.99 0.00 0.00257.00-265.99 0.00 0.00266.00-274.99 0.00 0.00275.00-283.99 0.00 0.00284.00-292.99 0.00 0.00293.00-302.00 0.00 0.00>302.00 0.00 0.00

Engine Overspeed Histogram: Accumulated Time (sec) vs Engine Speed - C9 140M3 (SYE06263) Engine Speed( rpm ) %2500.0-2599.9 6.00 85.712600.0-2699.9 0.00 0.002700.0-2799.9 1.00 14.292800.0-2899.9 0.00 0.002900.0-2999.9 0.00 0.003000.0-3099.9 0.00 0.003100.0-3199.9 0.00 0.003200.0-3299.9 0.00 0.003300.0-3400.0 0.00 0.00>3400.0 0.00 0.00


Lifetime:Accumulated Time vs Engine Speed And Percent Engine Load at Current Engine Speed - C9 140M3 (SYE06263) rpm <600.0 600.0-649.9 650.0-699.9 700.0-749.9 750.0-799.9 800.0-849.9 850.0-899.9 900.0-949.9 950.0-999.9%<0.0 0.10 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.000.0-9.9 0.00 0.00 0.15 0.95 271.60 288.00 3.35 2.30 3.0510.0-19.9 0.00 0.00 0.05 0.45 7.25 7.55 1.85 1.10 1.1520.0-29.9 0.00 0.00 0.05 0.30 2.25 2.55 1.40 0.85 0.7530.0-39.9 0.00 0.00 0.00 0.20 0.90 1.00 0.65 0.50 0.4040.0-49.9 0.00 0.00 0.00 0.10 0.25 0.30 0.25 0.25 0.2050.0-59.9 0.00 0.00 0.00 0.05 0.10 0.10 0.10 0.10 0.1060.0-69.9 0.00 0.00 0.00 0.05 0.05 0.05 0.05 0.05 0.0570.0-79.9 0.00 0.00 0.00 0.05 0.05 0.05 0.05 0.05 0.1080.0-89.9 0.00 0.00 0.00 0.00 0.00 0.00 0.05 0.05 0.0590.0-100.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.05 0.10>100.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00Total 0.10 0.00 0.25 2.15 282.45 299.60 7.75 5.30 5.95

Lifetime:Accumulated Time vs Engine Speed And Percent Engine Load at Current Engine Speed - C9 140M3 (SYE06263)

rpm 1000.0-1049.9

1050.0-1099.9

1100.0-1149.9

1150.0-1199.9

1200.0-1249.9

1250.0-1299.9

1300.0-1349.9

1350.0-1399.9

1400.0-1449.9

%<0.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.000.0-9.9 3.70 2.45 3.95 5.15 6.05 4.30 2.40 2.90 3.7010.0-19.9 1.30 1.10 1.30 1.75 1.85 1.90 1.80 2.15 3.0020.0-29.9 0.80 0.75 0.80 0.85 0.90 1.00 1.00 1.30 1.4530.0-39.9 0.40 0.45 0.50 0.45 0.45 0.50 0.50 0.55 0.6540.0-49.9 0.20 0.20 0.25 0.25 0.25 0.25 0.25 0.30 0.3050.0-59.9 0.15 0.10 0.15 0.15 0.15 0.15 0.15 0.15 0.2060.0-69.9 0.10 0.10 0.10 0.10 0.10 0.10 0.10 0.10 0.1070.0-79.9 0.10 0.10 0.10 0.10 0.10 0.10 0.10 0.10 0.1080.0-89.9 0.05 0.05 0.10 0.10 0.10 0.10 0.10 0.10 0.1090.0-100.0 0.10 0.10 0.15 0.20 0.25 0.30 0.30 0.40 0.45

>100.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00Total 6.90 5.40 7.40 9.10 10.20 8.70 6.70 8.05 10.05


rpm 1450.0-1499.9

1500.0-1549.9

1550.0-1599.9

1600.0-1649.9

1650.0-1699.9

1700.0-1749.9

1750.0-1799.9

1800.0-1849.9

1850.0-1899.9

%<0.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.000.0-9.9 3.55 4.30 6.15 5.75 3.15 3.00 2.80 2.80 3.2010.0-19.9 3.90 17.05 48.75 47.50 15.80 12.75 8.55 5.40 6.0520.0-29.9 1.90 7.85 19.60 21.85 8.45 6.35 5.25 3.05 3.8530.0-39.9 0.70 1.25 2.20 2.45 1.60 1.35 1.20 1.30 1.4540.0-49.9 0.35 0.55 0.65 0.70 0.60 0.50 0.45 0.60 0.7050.0-59.9 0.20 0.25 0.30 0.30 0.25 0.25 0.25 0.35 0.3560.0-69.9 0.15 0.15 0.20 0.20 0.15 0.15 0.15 0.20 0.2070.0-79.9 0.10 0.15 0.15 0.15 0.15 0.10 0.10 0.15 0.1580.0-89.9 0.15 0.15 0.15 0.15 0.15 0.15 0.20 0.20 0.2590.0-100.0 0.50 0.60 0.80 0.90 1.05 1.15 1.35 1.35 1.50

>100.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00Total 11.50 32.30 78.95 79.95 31.35 25.75 20.30 15.40 17.70


rpm 1900.0-1949.9

1950.0-1999.9

2000.0-2049.9

2050.0-2099.9

2100.0-2149.9

2150.0-2199.9

2200.0-2249.9

2250.0-2299.9

2300.0-2349.9

%<0.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00


0.0-9.9 4.05 3.05 2.90 2.80 46.50 55.00 0.25 0.15 0.1010.0-19.9 8.45 4.40 3.20 3.20 91.90 100.85 0.00 0.00 0.0020.0-29.9 6.10 3.40 3.60 3.75 96.15 99.55 0.00 0.00 0.0030.0-39.9 2.20 1.75 1.70 1.95 57.30 56.80 0.00 0.00 0.0040.0-49.9 1.00 0.85 0.95 1.15 27.45 27.05 0.00 0.00 0.0050.0-59.9 0.55 0.55 0.60 0.75 15.95 15.95 0.00 0.00 0.0060.0-69.9 0.30 0.30 0.30 0.45 12.00 11.80 0.00 0.00 0.0070.0-79.9 0.20 0.20 0.25 0.80 8.40 7.50 0.00 0.00 0.0080.0-89.9 0.40 0.50 0.65 0.75 4.40 4.00 0.00 0.00 0.0090.0-100.0 1.75 2.05 2.95 4.25 8.20 2.10 0.00 0.00 0.00

>100.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00Total 25.00 17.05 17.10 19.85 368.25 380.60 0.25 0.15 0.10

Lifetime:Accumulated Time vs Engine Speed And Percent Engine Load at Current Engine Speed - C9 140M3 (SYE06263) rpm 2350.0-2400.0 >2400.0 Total%<0.0 0.00 0.00 0.100.0-9.9 0.05 0.05 753.6010.0-19.9 0.00 0.00 413.3020.0-29.9 0.00 0.00 307.7030.0-39.9 0.00 0.00 143.3040.0-49.9 0.00 0.00 67.1550.0-59.9 0.00 0.00 38.7560.0-69.9 0.00 0.00 27.9070.0-79.9 0.00 0.00 19.8080.0-89.9 0.00 0.00 13.2090.0-100.0 0.00 0.00 32.90>100.0 0.00 0.00 0.00Total 0.05 0.05 1817.70

Lifetime:Accumulated Time vs Intake Manifold Air Temperature - C9 140M3 (SYE06263) Intake Manifold Air Temperature( Deg F ) hours %<32.00 0.80 0.0432.00-40.99 5.00 0.2641.00-49.99 13.30 0.6950.00-58.99 21.75 1.1359.00-67.99 37.20 1.9468.00-76.99 74.35 3.8777.00-85.99 123.00 6.4086.00-94.99 179.95 9.3795.00-103.99 265.25 13.81104.00-112.99 289.40 15.07113.00-121.99 256.20 13.34122.00-130.99 295.30 15.37131.00-139.99 224.15 11.67140.00-148.99 77.30 4.02149.00-157.99 38.35 2.00158.00-166.99 15.35 0.80167.00-175.99 3.65 0.19176.00-184.99 0.45 0.02185.00-193.99 0.05 0.00194.00-202.99 0.00 0.00203.00-211.99 0.00 0.00212.00-220.99 0.00 0.00221.00-229.99 0.00 0.00230.00-238.99 0.00 0.00239.00-248.00 0.00 0.00>248.00 0.00 0.00


High Exhaust Temperature Prevention Derate Time - C9 140M3 (SYE06263)

Deg F <104.00 104.00-112.99

113.00-121.99

122.00-130.99

131.00-139.99

140.00-148.99

149.00-157.99

158.00-166.99

167.00-175.99

psi<8.702 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.008.702-9.862 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.009.863-11.022 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.0011.023-12.182 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00

12.183-13.342 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00

13.343-14.504 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00

>14.504 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00Total 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00

High Exhaust Temperature Prevention Derate Time - C9 140M3 (SYE06263) Deg F 176.00-184.99 185.00-193.99 194.00-202.99 203.00-212.00 >212.00 Totalpsi<8.702 0.00 0.00 0.00 0.00 0.00 0.008.702-9.862 0.00 0.00 0.00 0.00 0.00 0.009.863-11.022 0.00 0.00 0.00 0.00 0.00 0.0011.023-12.182 0.00 0.00 0.00 0.00 0.00 0.0012.183-13.342 0.00 0.00 0.00 0.00 0.00 0.0013.343-14.504 0.00 0.00 0.00 0.00 0.00 0.00>14.504 0.00 0.00 0.00 0.00 0.00 0.00Total 0.00 0.00 0.00 0.00 0.00 0.00

Lifetime:Accumulated Time vs Engine Speed - C9 140M3 (SYE06263) Engine Speed( rpm ) hours %<550.0 0.15 0.01550.0-599.9 0.00 0.00600.0-649.9 0.05 0.00650.0-699.9 0.35 0.02700.0-749.9 2.20 0.11750.0-799.9 301.00 15.67800.0-849.9 321.55 16.74850.0-899.9 8.30 0.43900.0-949.9 5.65 0.29950.0-999.9 7.50 0.391000.0-1049.9 9.40 0.491050.0-1099.9 7.40 0.391100.0-1149.9 12.05 0.631150.0-1199.9 14.10 0.731200.0-1249.9 23.70 1.231250.0-1299.9 17.10 0.891300.0-1349.9 7.20 0.371350.0-1399.9 8.45 0.441400.0-1449.9 10.55 0.551450.0-1499.9 12.05 0.631500.0-1549.9 32.95 1.721550.0-1599.9 80.20 4.181600.0-1649.9 81.15 4.221650.0-1699.9 31.90 1.661700.0-1749.9 26.20 1.361750.0-1799.9 20.80 1.081800.0-1849.9 15.90 0.831850.0-1899.9 18.40 0.961900.0-1949.9 25.65 1.341950.0-1999.9 17.85 0.932000.0-2049.9 17.85 0.932050.0-2099.9 20.75 1.08


2100.0-2149.9 374.95 19.522150.0-2199.9 386.90 20.142200.0-2249.9 0.35 0.022250.0-2299.9 0.15 0.012300.0-2349.9 0.10 0.012350.0-2399.9 0.05 0.002400.0-2449.9 0.05 0.002450.0-2499.9 0.00 0.002500.0-2549.9 0.00 0.002550.0-2599.9 0.00 0.002600.0-2649.9 0.00 0.002650.0-2699.9 0.00 0.002700.0-2749.9 0.00 0.002750.0-2799.9 0.00 0.002800.0-2849.9 0.00 0.002850.0-2899.9 0.00 0.002900.0-2949.9 0.00 0.002950.0-2999.9 0.00 0.003000.0-3049.9 0.00 0.003050.0-3099.9 0.00 0.003100.0-3149.9 0.00 0.003150.0-3199.9 0.00 0.003200.0-3249.9 0.00 0.003250.0-3299.9 0.00 0.003300.0-3349.9 0.00 0.003350.0-3400.0 0.00 0.00>3400.0 0.00 0.00

Lifetime:Accumulated Time vs Air Inlet Temperature - C9 140M3 (SYE06263) Air Inlet Temperature( Deg F ) hours %<(-4.00) 0.10 0.01(-4.00)-4.99 0.00 0.005.00-13.99 0.00 0.0014.00-22.99 0.00 0.0023.00-31.99 1.20 0.0632.00-40.99 19.10 0.9941.00-49.99 44.85 2.3450.00-58.99 109.55 5.7059.00-67.99 196.20 10.2268.00-76.99 293.90 15.3077.00-85.99 473.35 24.6586.00-94.99 508.60 26.4895.00-103.99 259.30 13.50104.00-112.99 14.15 0.74113.00-121.99 0.20 0.01122.00-130.99 0.00 0.00131.00-139.99 0.00 0.00140.00-148.99 0.00 0.00149.00-157.99 0.00 0.00158.00-166.99 0.00 0.00167.00-176.00 0.00 0.00>176.00 0.00 0.00

High Turbo Speed Prevention Derate Time - C9 140M3 (SYE06263) Deg F <41.00 41.00-58.99 59.00-76.99 77.00-94.99 95.00-112.99 113.00-130.99 131.00-149.00 >149.00 Totalpsi<8.702 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.008.702-9.862 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.009.863-11.022 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.0011.023-12.182 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.0012.183-13.342 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00


13.343-14.504 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00>14.504 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00Total 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00

Lifetime:Accumulated Time vs DPF #1 Soot Loading Percent And ARD Manual Disable Status - C9 140M3 (SYE06263) % <40 40-49 50-59 60-69 70-79 80-89 90-99 100-109 110-119ARD Manual Disable Status0 1822.85 67.50 21.15 9.90 3.65 0.45 0.00 0.00 0.001 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00Total 1822.85 67.50 21.15 9.90 3.65 0.45 0.00 0.00 0.00

Lifetime:Accumulated Time vs DPF #1 Soot Loading Percent And ARD Manual Disable Status - C9 140M3 (SYE06263) % 120-129 130-140 >140 TotalARD Manual Disable Status0 0.00 0.00 0.00 1925.501 0.00 0.00 0.00 0.00Total 0.00 0.00 0.00 1925.50

Injector Trim Calibration - C9 140M3 (SYE06263) Injector Serial Number File VersionInjector1 000000003S5036253967 0Injector2 000000003S50362481A3 0Injector3 000000003S5036253543 0Injector4 000000003S5036247772 0Injector5 000000003S5036247675 0Injector6 000000003S503624785F 0

Monitoring System - C9 140M3 (SYE06263) Description State Trip Point Delay TimeEngine OverspeedLeast Severe (1) Always On 2600 rpm 0 secMost Severe (3) Always On 2800 rpm 0 secFuel Filter RestrictionLeast Severe (1) Always On 70 % 1 secModerate Severity (2) Always On 100 % 1 secHigh Air Inlet #1 Differential PressureLeast Severe (1) Always On 0.9 psi 0 secModerate Severity (2) Always On 0.9 psi 0 secHigh Engine Coolant TemperatureLeast Severe (1) Always On 228 Deg F 10 secModerate Severity (2) Always On 232 Deg F 20 secHigh Fuel TemperatureModerate Severity (2) Always On 174.2 Deg F 30 secHigh Fuel/Water Separator Water LevelLeast Severe (1) Always On None 40 secModerate Severity (2) Always On None 3600 secHigh Intake Manifold Air TemperatureLeast Severe (1) Always On 239.0 Deg F 4 secModerate Severity (2) Always On 248.0 Deg F 4 secLow Engine Oil PressureLeast Severe (1) Always On None 8 secMost Severe (3) Always On None 4 sec

VIMS Main Module (N9M00165) TOP


Parameter ValueMachine Serial Number N9M00165Product ID N9M00165Equipment IDECM Part Number 3402413-05ECM Serial Number 04259154RNSoftware Group Part Number 4498593-00Software Group Release Date DEC13Software Group Description PLGSM 2013C PROD 1.0Application Software Part Number UnavailableTelematic Device Software Group Part Number 449-6277-0Telematic Device Software Group Release Date AUG2013Telematic Device Software Group Description PROD-4.0.2

Logged Diagnostic Codes [Diagnostic Clock = 2210.3923 hours] - VIMS Main Module (N9M00165) Code Description Occ. First LastNo Logged Diagnostic Codes

Logged Event Codes [Diagnostic Clock = 2210.3923 hours] - VIMS Main Module (N9M00165) Code Description Occ. First LastNo Logged Event Codes

Active Diagnostic Codes - VIMS Main Module (N9M00165) Code DescriptionNo Active Diagnostic Codes

Active Event Codes - VIMS Main Module (N9M00165) Code DescriptionNo Active Event Codes

Current Totals - VIMS Main Module (N9M00165) Description Value UnitTotal Operating Hours 2210 hours

Configuration - VIMS Main Module (N9M00165) Description Value UnitData Acquisition System Installation Status UnavailableData Acquisition System Temporary Installation Status Not InstalledData Acquisition System Temporary Installation Time Remaining 15000 minCustomer Password #1 ****************Customer Password #2 ****************Product ID N9M00165Equipment IDExternal Service Lamp Installation Configuration UnavailableExternal Service Lamp Display Mode Setting UnavailableTelemetry Port Selection UnavailableTMAC Protocol Port Selection UnavailableEthernet Media Access Control (MAC) Address 00:0A:75:08:51:C8Internet Protocol Host Name VIMS3GInternet Protocol (IPv4) Address 165.26.79.218Internet Protocol (IPv4) Network Mask 255.255.255.252Network Default Gateway Internet Protocol (IPv4) Address 165.26.79.216Web Server Administrator Password adminDynamic Host Configuration Protocol (DHCP) Enable Status DisabledFleet Management System (FMS) Installation Status Not Installed


Fleet Management System (FMS) Enable Status UnavailableMaintenance Mode OffMachine Serial Number N9M00165

Implement #2 140M3 (N9M00165) TOP

Parameter ValueProduct ID N9M00165Equipment ID 140M3ECM Part Number 3656790-04ECM Serial Number 29146111QQECM Location Code 6Software Group Part Number 5069391-00Software Group Release Date MAY2016Software Group Description 140 MG Steering Cntl

Logged Diagnostic Codes [Diagnostic Clock = 2210.3540 hours] - Implement #2 140M3 (N9M00165) Code Description Occ. First LastNo Logged Diagnostic Codes

Logged Event Codes [Diagnostic Clock = 2210.3540 hours] - Implement #2 140M3 (N9M00165) Code Description Occ. First LastNo Logged Event Codes

Active Diagnostic Codes - Implement #2 140M3 (N9M00165) Code DescriptionNo Active Diagnostic Codes

Active Event Codes - Implement #2 140M3 (N9M00165) Code DescriptionNo Active Event Codes

Current Totals - Implement #2 140M3 (N9M00165) Description Value UnitTotal Operating Hours 2210 hours

Configuration - Implement #2 140M3 (N9M00165) Description Value UnitHydraulic Oil Viscosity Rating SAE 10WMain Hydraulic Pump Pressure Sensor #2 Installation Status Not InstalledAutomatic Articulation Installation Status Not InstalledAutomatic Articulation Feature Temporary Installation Status Not InstalledArticulation Lockout Status Not Locked OutAdvanced Machine Security System Installation Status Not InstalledCAN Communication Protocol Write Security UnavailableCAN Communication Protocol Read Security UnavailableTotal Tattletale 0

Calibration Status - Implement #2 140M3 (N9M00165) Calibration Status Last Successful CompletionArm Steering System/Solenoid Calibration Success 1.3 hours


Steering Cylinder Position Sensors Calibration Not Calibrated Never Successfully CalibratedArticulate Left Solenoid Calibration Success 1.3 hoursArticulate Right Solenoid Calibration Success 1.3 hoursArticulation Position Sensor Calibration Success 0.9 hours

Trans/Chassis 140M3 (CM301478) TOP

Parameter ValueProduct ID N9M00165Equipment ID 140M3Transmission Serial Number CM301478ECM Part Number 3656773-04ECM Serial Number 02656025VDECM Location Code 1Software Group Part Number 5089259-00Software Group Release Date MAY2016Software Group Description 140 MG Chassis/Trans

Logged Diagnostic Codes [Diagnostic Clock = 2210.3879 hours] - Trans/Chassis 140M3 (CM301478) Code Description Occ. First LastNo Logged Diagnostic Codes

Logged Event Codes [Diagnostic Clock = 2210.3879 hours] - Trans/Chassis 140M3 (CM301478) Code Description Occ. First LastNo Logged Event Codes

Active Diagnostic Codes - Trans/Chassis 140M3 (CM301478) Code DescriptionNo Active Diagnostic Codes

Active Event Codes - Trans/Chassis 140M3 (CM301478) Code DescriptionNo Active Event Codes

Current Totals - Trans/Chassis 140M3 (CM301478) Description Value UnitTotal Operating Hours 2210 hoursTotal Hours Coasting In Neutral 3 hoursMachine Idle Time 751.90 hoursTotal Forward Distance 11780.14 MilesTotal Reverse Distance 328.58 MilesTotal Distance 12108.72 Miles

Configuration - Trans/Chassis 140M3 (CM301478) Description Value UnitTransmission Serial Number CM301478Autoshift Feature Installation Status InstalledTransmission Maximum Forward Gear 8Transmission Maximum Reverse Gear 6Transmission Initial Forward Gear 2Transmission Initial Reverse Gear 2Transmission Maximum Forward Autoshift Gear 8


Transmission Minimum Forward Autoshift Gear 2Transmission Maximum Reverse Autoshift Gear 4Transmission Minimum Reverse Autoshift Gear 2Clutch #1 Hold Level Current Command 0.130 AmpsClutch #2 Hold Level Current Command 0.140 AmpsClutch #3 Hold Level Current Command 0.145 AmpsMachine Speed Limit 50 mphStable Grade Feature Installation Status Not InstalledStable Grade Enable Status DisabledStable Grade Sensitivity Setting 50 %Machine Speed Correction Factor 0.0000 %Transmission Deaeration System Installation Status Not InstalledTransmission Oil Type Configuration TDTO SAE 30Air Conditioning System Installation Status InstalledBattery Cable Shield Monitoring System Installation Not InstalledCold Engine Parasitic Load Reduction Installation Not InstalledForced Fuel Economy Mode Configuration Not ForcedEconomy Mode OffTotal Tattletale 0

Lifetime:Time vs Actual Gear - Trans/Chassis 140M3 (CM301478) Actual Gear( ) hours %1R 1.45 0.102R 33.95 2.383R 29.95 2.104R 13.15 0.925R 2.10 0.156R 0.05 0.001F 12.60 0.882F 456.50 31.993F 387.65 27.174F 43.65 3.065F 65.40 4.586F 71.20 4.997F 154.75 10.858F 154.50 10.83

Shift Count Matrix - Trans/Chassis 140M3 (CM301478) To N R1 R2 R3 R4 R5 R6 1 2 3 4 5 6 7 8

FromN --- 233 4647 2456 15 4 0 185 6571 2360 31 48 18 43 73

R1 115 --- 159 0 0 0 0 139 0 0 0 0 0 0 0R2 2666 33 --- 1620 0 0 0 0 3189 0 0 0 0 0 0R3 2249 2 68 --- 1171 1 0 0 1 2419 0 0 0 0 0R4 531 0 1 17 --- 177 0 0 1 480 0 0 0 0 0R5 84 0 0 0 20 --- 12 0 0 68 0 0 0 0 0R6 4 0 0 0 1 2 --- 0 0 5 0 0 0 0 01 284 141 1 0 0 0 0 --- 352 14 16 0 0 0 02 4624 3 2632 0 0 0 0 431 --- 4489 13 0 0 0 03 2907 0 1 1413 0 0 0 26 1930 --- 4316 0 0 0 04 704 0 0 153 0 0 0 20 43 605 --- 3702 7 0 05 738 0 0 118 0 0 0 5 49 110 744 --- 3544 25 196 512 0 0 64 0 0 0 1 25 17 55 1409 --- 3410 07 614 0 0 37 0 0 0 0 17 13 33 126 1861 --- 25488 647 1 0 33 0 0 0 1 17 14 26 67 63 1771 ---

Counters - Trans/Chassis 140M3 (CM301478) Description ValueParking Brake Solenoid Cycles 3469Starter Relay Cycles 1212


Service Brake Pedal Switch Cycles 40117Number of Cold Temperature Transmission Filter Bypasses 0Total Cold Temperature Transmission Oil Filter Bypass Hours 0Total Overspeed Protective Upshift Count 17Total Underspeed Protective Downshift Count 228

Primary Display 140M3 (N9M00165) TOP

Parameter ValueProduct ID N9M00165Equipment ID 140M3ECM Part Number 3696072-03ECM Serial Number 0215J007PESoftware Group Part Number 5094229-00Software Group Release Date MAY2016Software Group Description MG M3 Display

Logged Diagnostic Codes - Primary Display 140M3 (N9M00165) Code Description Occ. First LastNo Logged Diagnostic Codes

Logged Event Codes - Primary Display 140M3 (N9M00165) Code Description Occ. First LastNo Logged Event Codes

Active Diagnostic Codes - Primary Display 140M3 (N9M00165) Code DescriptionNo Active Diagnostic Codes

Active Event Codes - Primary Display 140M3 (N9M00165) Code DescriptionNo Active Event Codes

Configuration - Primary Display 140M3 (N9M00165) Description Value UnitProduct ID N9M00165Equipment ID 140M3Service Mode Enable Code 1234Display Language Status EnglishInformation Units Status EnglishFactory Operator Profile Display Enable Status Enabled

Implement 140M3 (N9M00165) TOP

Parameter ValueProduct ID N9M00165Equipment ID 140M3ECM Part Number 3656773-04ECM Serial Number 02056355VDECM Location Code 2Software Group Part Number 5069337-00


Software Group Release Date MAY2016Software Group Description 140 MG Master Impl Cntl

Logged Diagnostic Codes [Diagnostic Clock = 2210.3465 hours] - Implement 140M3 (N9M00165) Code Description Occ. First LastNo Logged Diagnostic Codes

Logged Event Codes [Diagnostic Clock = 2210.3465 hours] - Implement 140M3 (N9M00165) Code Description Occ. First LastNo Logged Event Codes

Active Diagnostic Codes - Implement 140M3 (N9M00165) Code DescriptionNo Active Diagnostic Codes

Active Event Codes - Implement 140M3 (N9M00165) Code DescriptionNo Active Event Codes

Current Totals - Implement 140M3 (N9M00165) Description Value UnitTotal Operating Hours 2210 hours

Configuration - Implement 140M3 (N9M00165) Description Value UnitGrade Control On Joystick Attachment Enable Status DisabledAuxiliary Valve #1 Control Lever Configuration Not InstalledAuxiliary Valve #2 Control Lever Configuration Lever #7Auxiliary Valve #3 Control Lever Configuration Not InstalledAuxiliary Valve #4 Control Lever Configuration Not InstalledAuxiliary Valve #5 Control Lever Configuration Not InstalledAuxiliary Valve #6 Control Lever Configuration Not InstalledAuxiliary Valve #7 Control Lever Configuration Not InstalledAuxiliary Lever #1 Float Enable Status DisabledAuxiliary Lever #4 Float Enable Status DisabledAuxiliary Lever #6 Float Enable Status DisabledAuxiliary Lever #9 Float Enable Status DisabledAuxiliary Valve #1 Float Installation Status Not InstalledAuxiliary Valve #2 Float Installation Status Not InstalledAuxiliary Valve #3 Float Installation Status Not InstalledAuxiliary Valve #4 Float Installation Status Not InstalledAuxiliary Valve #5 Float Installation Status Not InstalledAuxiliary Valve #6 Float Installation Status Not InstalledAuxiliary Control Pod Enable Status DisabledRipper AutoStow Enable Status EnabledMachine Shipping Mode Enable Status DisabledBlade Pitch Lockout Status Not Locked OutBlade Sideshift Lockout Status Not Locked OutCircle Sideshift Lockout Status Not Locked OutWheel Lean Lockout Status Not Locked OutBlade Rotation Angle Limit Enable Status DisabledBlade Rotation Angle Limit 33.00 DegAccuGrade System Installation Status InstalledAccuGrade Enable Status DisabledAccuGrade Temporary Installation Status Unavailable


Window Defroster Installation Status Not InstalledHeated Side Rear View Mirrors Installation Status Not InstalledOperator Seat Belt Monitor Installation Status Not InstalledCross Slope Control System Installation Status Not InstalledCross Slope Control System Temporary Installation Status Not InstalledCross Slope Control System Enable Status DisabledDrawbar Length 90 inchesBlade Width 13.123 feetLift Cylinder Ball Stud Distance 58 inches

Calibration Status - Implement 140M3 (N9M00165) Calibration Status Last Successful CompletionWheel Lean Left Solenoid Calibration Success 1.2 hoursWheel Lean Right Solenoid Calibration Success 1.2 hoursCircle Sideshift Left Solenoid Calibration Success 1.2 hoursCircle Sideshift Right Solenoid Calibration Success 1.2 hoursBlade Pitch Backward Solenoid Calibration Success 1.1 hoursBlade Pitch Forward Solenoid Calibration Success 1.1 hoursBlade Sideshift Left Solenoid Calibration Success 1.1 hoursBlade Sideshift Right Solenoid Calibration Success 1.1 hoursBlade Left Raise Solenoid Calibration Success 1.1 hoursBlade Right Raise Solenoid Calibration Success 1.1 hoursCircle Left Solenoid Calibration Success 1.1 hoursCircle Right Solenoid Calibration Success 1.1 hoursBlade Left Lower Float Solenoid Calibration Success 1.0 hoursBlade Left Lower Solenoid Calibration Success 1.0 hoursBlade Right Lower Float Solenoid Calibration Success 1.0 hoursBlade Right Lower Solenoid Calibration Success 1.0 hoursSlope Sensors Calibration Unknown Never Successfully CalibratedRight Lift Valve Calibration Unknown Never Successfully CalibratedLeft Lift Valve Calibration Unknown Never Successfully CalibratedBlade Rotation Angle Sensor Calibration Unknown Never Successfully CalibratedAuxiliary Valve #6 Port A Solenoid Not Calibrated Never Successfully CalibratedAuxiliary Valve #6 Port B Solenoid Not Calibrated Never Successfully CalibratedAuxiliary Valve #5 Port A Solenoid Not Calibrated Never Successfully CalibratedAuxiliary Valve #5 Port B Solenoid Not Calibrated Never Successfully CalibratedAuxiliary Valve #4 Port A Solenoid Not Calibrated Never Successfully CalibratedAuxiliary Valve #4 Port B Solenoid Not Calibrated Never Successfully CalibratedAuxiliary Valve #3 Port A Solenoid Not Calibrated Never Successfully CalibratedAuxiliary Valve #3 Port B Solenoid Not Calibrated Never Successfully CalibratedAuxiliary Valve #2 Port A Solenoid Success 1.2 hoursAuxiliary Valve #2 Port B Solenoid Success 1.2 hoursAuxiliary Valve #1 Port A Solenoid Not Calibrated Never Successfully CalibratedAuxiliary Valve #1 Port B Solenoid Not Calibrated Never Successfully Calibrated

Engine #1 Aftertreatment Controller TOP

Parameter ValueEquipment ID 140M3Engine Serial Number SYE06263ECM Serial Number 35247562QUSoftware Group Part Number 5296073-00Software Group Release Date MAR17Software Group Description AFT_T4F_C9.3_HWA_A5E2V1

Logged Diagnostic Codes [Diagnostic Clock = 2210.4318 hours] - Engine #1 Aftertreatment Controller Code Description Occ. First LastNo Logged Diagnostic Codes


Logged Event Codes [Diagnostic Clock = 2210.4318 hours] - Engine #1 Aftertreatment Controller Code Description Occ. First LastE114 (1) Aftertreatment #1 DEF Dosing Unit #1 Input Lines Not Purged 1 2204 2204

Active Diagnostic Codes - Engine #1 Aftertreatment Controller Code DescriptionNo Active Diagnostic Codes

Active Event Codes - Engine #1 Aftertreatment Controller Code DescriptionNo Active Event Codes

System Communication Status - Active Problems - Engine #1 Aftertreatment Controller ECMs Detected Problem Data Link Diagnostic InformationNo issues were reported

System Communication Status - Inactive Problems - Engine #1 Aftertreatment Controller ECMs Detected Problem Data Link Diagnostic InformationNo issues were reported

Current Totals - Engine #1 Aftertreatment Controller Description Value UnitDPF #1 Last Ash Service Engine Lifetime Hours 0.0 hoursTotal ARD Fuel 246.307 galAftertreatment #1 Total DEF Used 153.6 gal

Configuration - Engine #1 Aftertreatment Controller Description Value UnitEquipment ID 140M3Engine Serial Number SYE06263ECM Serial Number 35247562QUSoftware Group Part Number 5296073-00Software Group Release Date MAR17Software Group Description AFT_T4F_C9.3_HWA_A5E2V1ARD Auto Regeneration Enable Status EnabledFactory Installed Aftertreatment #1 Identification Number CAB099073AARD Fuel Pressure #2 System Installation Status Not Installed

Aftertreatment Regeneration History - Engine #1 Aftertreatment Controller

AftertreatmentRegenerationSpeed Type

AftertreatmentRegenerationTrigger Type

ARD AutoRegenerationEnableStatus

RegenerationStart Time

RegenerationTriggerServiceHours

ApplicationRegenerationReadinessStatus

AftertreatmentRegenerationTriggerPercent Soot

AftertreatmentRegenerationEnd SpeedType

AftertreatmentRegenerationEnd TriggerType

High Speed Start Enabled 6/5/201811:48:55 AM 2210.24 hours 1 0 % Off Off

High Speed Start Enabled 3/27/20186:36:12 PM 2210.14 hours 1 0 % High Speed Start

Low Speed Start Enabled 3/27/201812:12:37 PM 2209.59 hours 7 0 % High Speed Start


Low Speed Start Enabled 3/19/20184:21:37 PM 2208.61 hours 7 0 % Low Speed Start


High Speed Start Enabled 3/14/201811:03:09 AM 2204.76 hours 1 6 % High Speed Start


Low Speed Start Enabled 3/13/201811:09:05 AM 2198.84 hours 7 7 % Low Speed Start

Low Speed Start Enabled 3/9/201811:59:50 AM 2192.83 hours 5 7 % High Speed Start

































Regeneration EndTime

Regeneration Completion ServiceHours

Aftertreatment Regeneration EndPercent Soot

Aftertreatment Regeneration EndStatus

뇀ҢĸҢ?? 12:00:00 AM 0.00 hours 0 % Off3/27/2018 6:38:31 PM 2210.18 hours 0 % Work3/27/2018 12:16:20PM 2209.66 hours 0 % Work

3/20/2018 1:30:59 PM 2209.43 hours 0 % Complete3/19/2018 4:36:14 PM 2208.85 hours 0 % Complete3/14/2018 11:17:35AM 2205.00 hours 0 % Complete

3/13/2018 11:41:28AM 2199.38 hours 0 % Complete

3/13/2018 11:12:07AM 2198.89 hours 6 % Unsuccessful

3/9/2018 12:14:47 PM 2193.08 hours 0 % Complete3/8/2018 12:22:31 PM 2187.18 hours 0 % Complete3/7/2018 12:19:19 PM 2181.30 hours 0 % Complete3/6/2018 12:27:20 PM 2175.41 hours 0 % Complete3/5/2018 11:58:56 AM 2170.40 hours 0 % Complete3/2/2018 12:06:58 PM 2164.70 hours 0 % Complete3/1/2018 12:04:22 PM 2160.54 hours 10 % Complete2/28/2018 11:57:14AM 2154.27 hours 0 % Complete

2/27/2018 12:33:38PM 2148.54 hours 0 % Complete

2/26/2018 4:20:53 PM 2145.96 hours 0 % Complete2/21/2018 11:51:17AM 2139.07 hours 0 % Complete

2/20/2018 11:58:36AM 2132.01 hours 0 % Complete





2/9/2018 12:01:22 PM 2099.54 hours 0 % Complete2/8/2018 12:34:42 PM 2093.87 hours 0 % Complete2/2/2018 11:51:33 AM 2087.53 hours 0 % Unsuccessful2/1/2018 12:06:23 PM 2081.70 hours 0 % Complete1/25/2018 11:59:57AM 2075.56 hours 0 % Complete








1/9/2018 12:28:40 PM 2031.56 hours 0 % Complete1/8/2018 12:22:55 PM 2026.32 hours 0 % Complete

Aftertreatment Abnormal Shutdown History - Engine #1 Aftertreatment Controller

Engine Shutdown Type Engine Shutdown Engine Startup Time After Temperature Ambient Air


Service Hours Shutdown Time & Date Threshold TemperatureHot Shutdown (Above DPF InletTemperature Threshold) 502.94 hours 1/25/2016 10:11:05 AM 590.0 Deg F 61.7 Deg F

Diesel Oxidation Catalyst Replacement - Engine #1 Aftertreatment Controller Description Value UnitEngine Lifetime Hours 2209.6 hoursTotal Operating Hours 2210 hours

History DataNo history data available.

Aftertreatment #1 SCR Catalyst Replacement - Engine #1 Aftertreatment Controller Description Value UnitEngine Lifetime Hours 2209.6 hoursTotal Operating Hours 2210 hours

History DataNo history data available.

Diesel Exhaust Fluid Controller #1 TOP

Parameter ValueAftertreatment #1 DEF Dosing System Serial Number PET022831TApplication Software Part Number 4410634-00

Configuration - Diesel Exhaust Fluid Controller #1 Description Value UnitAftertreatment #1 DEF Dosing System Serial Number PET022831TApplication Software Part Number 4410634-00

Documents

Manufacturer: CAT Model: 140M3 CONFIGURATION EROPS …