Lighting people and places

Hi-RackHigh output, energy saving fluorescent luminaire for high bay applications

Investment cost vs. running cost of solution

4x49W Hi-Rack HFS

3% 79% 18% saving

5% 40% 53% saving

■ Total investment costs ■ Total running costs over a lifetime

3% 97%

4x49W Hi-Rack HF

250W Hibay

0.00 E200,000.00 E400,000.00 E600,000.00 E800,000.00 E1,000,000.00

Average energy consumption per m2 and year kWh/m2/a

4x49W Hi-Rack HFS

4x49W Hi-Rack HF

250W Hibay

64% saving

30% saving

31.34

22.01

0.00 6.40 12.80 19.20 25.60 32.00

11.07

kWh/m2/a

E200,000.00

E150,000.00

E100,000.00

E50,000.00

0.00

Course of overall costs of solution over lifetime

Year0 1 2 3

250W Hibay 4x49W Hi-Rack HF4x49W Hi-Rack HFS

HID SwitchStart to Hi-Rack High Frequency payback

HID SwitchStart to Hi-Rack High Frequency dimming with integral sensor payback

Figure 1

Figure 2

Figure 3

Hi-Rack is particularly suited to storage, retail and industrial environments and offers a logical and cost-effective way to reduce energy costs and improve lighting quality.

For open spaces or racking aisles not in continual use, you can use Hi-Rack’s dimming and sensor capabilities to reduce lighting and power consumption to as little as 10%. Hi-Rack also offers a longer life than HID alternatives, so you can cut the cost of regular maintenance and associated downtime.

Basic to controllable savings at your demandAs demonstrated below, switching from HID luminaires to the basic Hi-Rack High Frequency (HF) model will enable you to achieve significant energy savings, while switching to the Hi-Rack High Frequency dimmable Sensor (HFS) model will enable you to achieve maximum energy savings.

Hi-Rack compared to HID solutionHID luminaires have been standard practice for high ceiling applications for decades. They are particularly ideal where occupancy is fixed or the voltage is unstable. However, where occupancy is varied or reducing energy consumption is a priority, Hi-Rack offers a flexible and energy efficient alternative.

The figures to the right compare traditional HID Hi-Bay lighting with Hi-Rack for a typical 7,740m² logistic centre*. Figure 1 demonstrates that in less than a year, both Hi-Rack products reach payback. By year three, substantial savings are achieved with Hi-Rack HF costing E19,300 less than the HID alternative and Hi-Rack HFS costing E62,110 less than the HID alternative.

When comparing the average energy consumption per m² and year (kWh/m²/a) to traditional HID lighting (Figure 2), Hi-Rack HF uses 30 % less energy and Hi-Rack HFS uses 64% less energy. Installing Hi-Rack will therefore substantially cut energy consumption and bills.

As illustrated in Figure 3, over a lifetime, running Hi-Rack HF instead of HID will reduce costs by 18%, while running Hi-Rack HFS will reduce costs by 53%.

*The comparison is based on using 270 new installation fittings, lit to 150 lux over a 15 year period, operational for two shift patterns, 16 hours a day, five days a week, with 50% aisle occupancy.

Absence of 10 mins dim down to 10% and holds for 3 hours for safety before switching off

Luminaires off as not activatedPresence detected luminaires on

ceiling

height

max 16m

100% saving as lights not activated for last 3 hours

50% saving as worker activates lights and stops half way down

Worker leaves aisle still, 50% savings

Figure 4

Total sensor control for maximum savingsHi-Rack with a high frequency sensor ensures you only use light when needed, which can reduce annual energy consumption by as much as 64%. The sensor can be used up to 16 metre mounting heights and is quick and simple to install as it is factory set or can be programmed to specific needs using a handheld programmer from the floor.Figure 4 shows the sensor factory settings and how the lighting is activated as soon as presence motion is detected. If no motion is detected after 10 minutes, lighting will automatically dim to 10%. If no motion is detected after three hours, lighting will automatically switch off. Similarly, Figure 4 also shows how the sensors ensure no unnecessary lights are switched on. If only half an aisle is used, only half the lights will be acti-vated, enabling you to achieve further energy savings.

Rapid InstallationHi-Rack comes ready to install to minimise installation time and costs:

• Lamps supplied• Choice of suspension • External wiring connection• Curved body shape for easy handling• Factory-set sensor

Emergency LightingHi-Rack provides integral emergency lighting to allow you to install just one luminaire complete with emergency options, making the need for a secondary emergency system redundant. High output emergency solutions are also available for higher mounting applications and reducing the number of emergency luminaires required.

Minimised Maintenance Maintenance at high mounting heights usually requires careful planning, special equipment and task downtime, making it difficult and costly to execute.

Hi-Rack minimises this burden as multi-lamp optics, full dimming capabilities and improved lumen maintenance with age, provides a longer life and minimised maintenance schedule.

Moreover, the failure of one lamp will not extinguish all lamps as with HID single lamp solutions, ensuring minimal impact on the task light.

HI-RACK 4X49W T16 WD

30°30°

60°60°

°09°09

°021°021

150° 150°

180°

150300450

cd/klm ULOR: 0% DLOR: 94% LOR: 94%

1060

310

1200

1504

390390 390

106164 194

1060 = FC KIT MSW1200 = FC KIT FIX BRA + BRA2

Lighting Controls e-Control is Thorn’s

initiative to increase the use of dimming and lighting control in products and lighting solutions.

The continuing importance of efficient energy use (on both cost and environmental grounds), together with a need for more flexible application of lighting, has led to a reassessment of lighting techniques and given a fresh impetus to the drive for more efficient controls.

Product Features Ordering Guide Dimensions

Ordering Guide Supplied complete with lamp. Mounting kits to be ordered separately

Description Ilcos Code

Socket Weight (Kg)

SAP Code

Wide Optic

HI-RACK 4X49W HF WD L840 FDH G5 5.5 96535219

HI-RACK 4X80W HF WD L840 FDH G5 5.5 96535227

Wide Optic, dimmable

HI-RACK 4X49W HFD WD L840 FDH G5 5.5 96535221

HI-RACK 4X80W HFD WD L840 FDH G5 5.5 96535229

Wide Optic, dimmable with sensor

HI-RACK 4X49W HFS WD L840 FDH G5 6.0 96535224

HI-RACK 4X80W HFS WD L840 FDH G5 6.0 96535232

Wide Optic, emergency

HI-RACK 4X49W HF E3 WD L840 FDH G5 6.6 96535220

HI-RACK 4X49W HF E3HO WD L840 FDH G5 7.0 96535240

HI-RACK 4X80W HF E3 WD L840 FDH G5 6.6 96535228

Wide Optic, dimmable, emergency

HI-RACK 4X49W HFD E3 WD L840 FDH G5 6.6 96535222

HI-RACK 4X49W HFD E3HO WD L840 FDH G5 7.0 96535223

HI-RACK 4X80W HFD E3 WD L840 FDH G5 6.6 96535230

Wide Optic, dimmable with sensor, emergency

HI-RACK 4X49W HFS E3 WD L840 FDH G5 7.6 96535225

HI-RACK 4X49W HFS E3HO WD L840 FDH G5 8.0 96535226

HI-RACK 4X80W HFS E3 WD L840 FDH G5 7.6 96535233

Rack Optic

HI-RACK 4X49W HF RK L840 FDH G5 5.5 96535203

HI-RACK 4X80W HF RK L840 FDH G5 5.5 96535211

Rack Optic, dimmable

HI-RACK 4X49W HFD RK L840 FDH G5 5.5 96535205

HI-RACK 4X80W HFD RK L840 FDH G5 5.5 96535213

Rack Optic, dimmable with sensor

HI-RACK 4X49W HFS RK L840 FDH G5 6.0 96535208

HI-RACK 4X80W HFS RK L840 FDH G5 6.0 96535216

Rack Optic, emergency

HI-RACK 4X49W HF E3 RK L840 FDH G5 6.6 96535204

HI-RACK 4X49W HF E3HO RK L840 FDH G5 7.0 96535238

HI-RACK 4X80W HF E3 RK L840 FDH G5 6.6 96535212

Rack Optic, dimmable, emergency

HI-RACK 4X49W HFD E3 RK L840 FDH G5 6.6 96535206

HI-RACK 4X49W HFD E3HO RK L840 FDH G5 7.0 96535207

HI-RACK 4X80W HFD E3 RK L840 FDH G5 6.6 96535214

Rack Optic, dimmable with sensor, emergency

HI-RACK 4X49W HFS E3 RK L840 FDH G5 7.6 96535209

HI-RACK 4X49W HFS E3HO RK L840 FDH G5 8.0 96535210

HI-RACK 4X80W HFS E3 RK L840 FDH G5 7.6 96535217

Attachments/mounting kits

HI-RACK KIT FIX BRA 2.0 96535235

HI-RACK KIT FIX BRA 2 2.0 96239583

HI-RACK KIT MSW 1.0 96535236

HI-RACK KIT PC COVER 1.5 96535237

HF - High Frequency, HFD - High Frequency dimmable, HFS - High Frequency dimming with sensor, WD - Wide reflector, RK - Rack reflector,E3 - Emergency 3 hour, E3HO - Emergency 3 hour high output, BRA - Bracket, MSW - Wire suspension

Lamps 4x49/80W T16 (FDH) linear fluorescent. Cap: G5

Materials/Finish Housing: white steel with polycarbonate end caps Reflector: high grade aluminium, wide optic - Satinbrite, rack optic - Mirrorbrite Attachment cover: UV stable polycarbonate

Installation/Mounting Mounting kits to be ordered separately. Please note, a 100mm gap must be left between the top of the luminaire and any surface. For wire suspension, accessory kit 96535236 slides directly on to the back of the body and can be easily adjusted. Accessory kit 96535235 allows trunking mounting via 20mm holes or rod mounting via 10mm holes. For canalis trunking system mounting accessory kit 96239583 can be used via M6 screw fixings. A 2.5mm2 piano key terminal block is accessed externally via a hinged lid (Isodom). Integral sensor versions come factory pre-set as follows (off time delay - 10 minutes, after off time delay lights stay on at 10% for 3 hours then turn off, daylight linking deactivated) can be mounted up to 16m. Hand held programmer (SAP code: 96102983 SENSALINK SENLP) can be used from the floor to customise sensor settings.

Standards Designed and manufactured to comply with EN60598.Emergency versions EN605982.2.22 Class I electrical IP20

Specification To specify state: A high bay luminaire supplied with fluorescent T16/T5 (49W or 80W) linear lamps, curved body with plastic end caps, wide or rack reflector optics. Isodom connector. Pre-installed factory set sensor, electronic gear, high output emergency. As Thorn Hi-Rack

Range: 360° cone-shaped detection pattern, diameter (at floor level) = 1 x mounting height

Retail Exhibition Centres Factories Logistic Centres

Hi-Rack is an energy saving alternative for lighting indoor spaces with high ceilings

Hi-Rack not only cuts energy consumption by up to 64%, but also improves light quality. Employing high output T16 (T5) fluorescent lamps, it offers an energy efficient alternative to high intensity discharge (HID) luminaires: • Optional integrated dimming

or sensor versions for maximum energy savings

• Choice of wide or rack reflector optics to suit the application

• Excellent light quality with a colour rendition index of 80

• No warm-up delay or re-ignition time

• High output emergency solutions allow integral emergency systems to be installed at higher mounting heights

• Plastic cover attachment protects lamps and reduces dust on reflectors

At Thorn we recognise our sustainability responsibilities, and with the PEC programme we have introduced a wide-ranging philosophy that underpins our approach to lighting design and implementation. The programme is based on the principle that performance, efficiency and comfort determine the visual effectiveness of lighting.

Performance: Providing the best visual effectiveness

Efficiency: Conserving energy and effort, reducing CO2 emissions and waste, providing lighting that is practical and efficient to install, operate and maintain

Comfort: giving people satisfaction and stimulation

These key attributes are demonstrated throughout this brochure

Lighting people and places

www.pefc.org

Thorn Lighting is constantly developing and improving its products. All descriptions, illustrations, drawings and specifications in this publication present only general particulars and shall not form part of any contract. The right is reserved to change specifications without prior notification or public announcement. All goods supplied by the company are supplied subject to the company’s General Conditions of Sale, a copy of which is available on request. All measurements are in millimetres and weights in kilograms unless otherwise stated. Printed on Luxo Light.

Publication No: 430 (IS) Publication Date: 2/11

Thorn Lighting Main OfficesThorn Academy of Light Durhamgate, Spennymoor County Durham DL16 6HL, UK Tel: (44) 1388 420 042 E-mail: academy@thornlighting.com Website: www.thornacademyoflight.com

AustraliaThorn Lighting Pty Limited 43 Newton Road, Wetherill Park NSW 2164 Tel: (02) 8786 6000 Fax: (02) 9612 2700 E-mail: infoaustralia@thornlighting.com Website: www.thornlighting.com.au

AustriaThorn Licht GmbH Donau-City-Straße 1, 1220 Wien, Austria Tel: (43) 1 202 66 11 Fax: (43) 1 202 66 11 82712 E-mail: office.at@thornlighting.com Website: www.thornlighting.at

ChinaThorn Lighting (Guangzhou) Operations Ltd, No.12 Lian Yun Road, Eastern Section, GETDD, Guangzhou 510530, China Tel: (86) 20 3228 2706 Fax: (86) 20 3228 1777 E-mail: sales.cn@thornlighting.com

Thorn Lighting (Tianjin) Co. Ltd 332 Hongqi Road, Tianjin 300190, China Tel: (86) 22 8369 2303 Fax: (86) 22 8369 2302 E-mail: info.tj@thornlighting.com

Czech Republic Thorn Lighting CS spol. s.r.o., Na Březince 6/930, 150 00 Praha 5 Czech Republic Tel: (420) 224 315 252 Fax: (420) 233 326 313 E-mail: thorn.cz@thornlighting.com Website: www.thornlighting.cz

DenmarkThorn Lighting A/S Kanonbådsvej 12B, Holmen, 1437 København K, Denmark Tel: (45) 76 96 36 00 Fax: (45) 76 96 36 01 E-mail: info.dk@thornlighting.com Website: www.thornlighting.dk

FranceThorn Europhane SA 156 Boulevard Haussmann, Cedex 08, Paris 75379, France Tel: (33) 1 49 53 6262 Fax: (33) 1 49 53 6240 Website: www.thornlighting.fr

Hong Kong Thorn Lighting (Hong Kong) Limited Unit 4301, Level 43, Tower 1, Metroplaza,223 Hing Fong Road, Kwai Chung, N.T., Hong Kong Tel: (852) 2578 4303 Fax: (852) 2887 0247 E-mail: info.hk@thornlighting.com

IndiaThorn Lighting India Pvt. Ltd. 501, 5th Floor, Tanishka Opp. Gundecha Industrial Estate Akurli Road, Kandivali (E), Mumbai – 400 101, India Tel: (91) 22-42701900 Fax: (91) 22-42701907 E-mail: international_sales@thornlighting.com Website: www.thornlighting.com

International Sales Thorn Europhane SA 156 Boulevard Haussmann Cedex 08, Paris 75379, France Tel: (33) 1 49 53 6262 Fax: (33) 1 49 53 6270 Email: international_sales@thornlighting.com Website: www.thornlighting.com

Ireland Thorn Lighting (Ireland) Limited Century House Harolds Cross Road Dublin 6W Tel: (353) 1 4922 877 Fax: (353) 1 4922 724 E-mail: dublinsales@thornlighting.com Website: www.thornlighting.co.uk

ItalyThorn Europhane Spa Via G Di Vittorio, 2, Cadriano di Granarolo, Bologna 40057, Italy Tel: (39) 051 763391 Fax: (39) 051 763088 E-mail: info@thornlighting.it Website: www.thornlighting.it

New ZealandThorn Lighting (NZ) Ltd 399 Rosebank Road, Avondale, Auckland 1026 PO Box 71134, Rosebank, Auckland 1348 Tel: (64) 9 828 7155 Fax: (64) 9 828 7591 E-mail: info.NZ@thornlighting.com Website: www.thornlighting.co.nz

NorwayThorn Lighting AS Strømsveien 344, 1081 Oslo, Norway Tel: (47) 22 82 07 00 Fax: (47) 22 82 07 01 E-mail: info.no@thornlighting.com Website: www.thornlighting.no

PolandThorn Lighting Polska Sp.z.o.o., Ul. Gazowa 26A, Wrocław 50-513, Poland Tel: (48) 71 7833 740 Fax: (48) 71 3366 029 E-mail: thorn.pl@thornlighting.com Website: www.thornlighting.pl

RussiaThorn Lighting Novoslobodskaya Str., 21, office 406 Business Center “Novoslobodskaya 21”, Moscow 127030, Russia Tel: (7) 495 981 35 41 Fax: (7) 495 981 35 42 E-mail: office.moscow@thornlighting.com Website: www.thornlighting.ru

Singapore Thorn Lighting (Singapore) Pte Ltd 5 Kaki Bukit Crescent, 04-02 Koyotech Building, 416238 Singapore Tel: (65) 6844 5800 Fax: (65) 6745 7707 E-mail: info.sg@thornlighting.com

SwedenThorn Lighting AB Industrigatan, Box 305, SE-261 23 Landskrona, Sweden Tel: (46) 418 520 00 Fax: (46) 418 265 74 E-mail: info.se@thornlighting.com Website: www.thornlighting.se

United Arab EmiratesThorn Lighting Ltd Dubai Al Shoala Building, Office 301, Block E, Airport road, P.O. Box 1200, Deira, Dubai, UAE Tel: (971) 4 2940181 Fax: (971) 4 2948838 E-mail: marketing.mena@thornlighting.com Website: www.thornlighting.com

United Kingdom Thorn Lighting Ltd Durhamgate, Spennymoor, County Durham, DL16 6HL Tel: +44 (0) 1388 42 00 42 Fax: +44 (0) 1388 42 01 56 Email: brochures.uk@thornlighting.com Website: www.thornlighting.co.uk

www.thornlighting.com