LG PD92A CHASSIS 42PQ1100 PLASMA TV SM.pdf

7/21/2019 LG PD92A CHASSIS 42PQ1100 PLASMA TV SM.pdf

1/54

PLASMA TV

SERVICE MANUAL

CAUTION

BEFORE SERVICING THE CHASSIS,

READ THE SAFETY PRECAUTIONS IN THIS MANUAL.

CHASSIS : PD92A

MODEL : 42PQ1100 42PQ1100-ZE

North/Latin America http://aic.lgservice.com

Europe/Africa http://eic.lgservice.com

Asia/Oceania http://biz.lgservice.com

Internal Use Only

P/NO : MFL58138612(0906-REV00) Printed in Korea


2/54

CONTENTS

CONTENTS ............................................................................................................................... 2

SAFETY PRECAUTIONS...........................................................................................................3

SPECIFICATION.........................................................................................................................4

ADJUSTMENT INSTRUCTION..................................................................................................7

BLOCK DIAGRAM ...................................................................................................................13

EXPLODED VIEW ...................................................................................................................16

SVC. SHEET ................................................................................................................................


3/54

SAFETY PRECAUTIONS

Many electrical and mechanical parts in this chassis have special safety-related characteristics. These parts are identified by in the

Schematic Diagram and Exploded View.

It is essential that these special safety parts should be replaced with the same components as recommended in this manual to prevent

X-RADIATION, Shock, Fire, or other Hazards.

Do not modify the original design without permission of manufacturer.

General Guidance

An isolation Transformer should always be used during the

servicing of a receiver whose chassis is not isolated from the AC

power line. Use a transformer of adequate power rating as this

protects the technician from accidents resulting in personal injury

from electrical shocks.

It will also protect the receiver and it's components from beingdamaged by accidental shorts of the circuitry that may be

inadvertently introduced during the service operation.

If any fuse (or Fusible Resistor) in this monitor is blown, replace it

with the specified.

When replacing a high wattage resistor (Oxide Metal Film Resistor,

over 1W), keep the resistor 10mm away from PCB.

Keep wires away from high voltage or high temperature parts.

Due to high vacuum and large surface area of picture tube,

extreme care should be used in handling the Picture Tube.

Do not lift the Picture tube by it's Neck.

Leakage Current Cold Check(Antenna Cold Check)With the instrument AC plug removed from AC source, connect an

electrical jumper across the two AC plug prongs. Place the ACswitch in the on position, connect one lead of ohm-meter to the AC

plug prongs tied together and touch other ohm-meter lead in turn to

each exposed metallic parts such as antenna terminals, phone

jacks, etc.

If the exposed metallic part has a return path to the chassis, the

measured resistance should be between 1M and 5.2M.

When the exposed metal has no return path to the chassis the

Leakage Current Hot Check (See below Figure)Plug the AC cord directly into the AC outlet.

Do not use a line Isolation Transformer during this check.

Connect 1.5K/10watt resistor in parallel with a 0.15uF capacitor

between a known good earth ground (Water Pipe, Conduit, etc.)

and the exposed metallic parts.

Measure the AC voltage across the resistor using AC voltmeter

with 1000 ohms/volt or more sensitivity.

Reverse plug the AC cord into the AC outlet and repeat AC voltage

measurements for each exposed metallic part. Any voltage

measured must not exceed 0.75 volt RMS which is corresponds to

0.5mA.

In case any measurement is out of the limits specified, there is

possibility of shock hazard and the set must be checked and

repaired before it is returned to the customer.

Leakage Current Hot Check circuit

1.5 Kohm/10W

To Instrument's

exposed

METALLIC PARTS

Good Earth Ground

such as WATER PIPE,

CONDUIT etc.

AC Volt-meter

IMPORTANT SAFETY NOTICE

0.15uF


4/54

SPECIFICATIONS

NOTE : Specifications and others are subject to change without notice for improvement.

1. Application RangeThis spec is applied to the 42/50 PLASMA TV used PD92A Chassis.

2. Specification

Each part is tested as below without special appointment.

1) Temperature : 255C (779F), CST : 405

2) Relative Humidity: 6510%

3) Power Voltage: Standard Input voltage (100-240V~, 50/60Hz)

* Standard Voltage of each product is marked by models.

4) Specification and performance of each parts are followed each drawing and specification by part number in accordance with SBOM.

5) The receiver must be operated for about 20 minutes prior to the adjustment.

3. Test Method1) Performance : LGE TV test method followed.

2) Demanded other specification

Safety : CE, IEC specification

EMC : CE, IEC

Chassis

PD92A

Albania, Austria, Belgium, Bosnia, Bulgaria, Croatia, Czech, Denmark, Estonia,

Finland France, Germany, Greece, Hungarym Ireland, Italy, Kazekhstan, Latvia,Lthuania, Luxembourg, Morocco,Netherlands, Norway,

Poland, Portugal Romania, Russia, Sebia, Slovakia, Lovenia, Spain, Sweden,

Swtzerland, Turkey, UK, Ukraine

LG

Market Brand Remark

Safety : IEC60065

EMC : EN55013EN55022

EN55020

EN55024

Albania, Austria, Belgium, Bosnia, Bulgaria, Croatia, Czech, Denmark,

Estonia, Finland France, Germany, Greece, Hungarym Ireland, Italy,Kazekhstan, Latvia, Lthuania, Luxembourg, Morocco,Netherlands, Norway,

Poland, Portugal Romania, Russia, Sebia, Slovakia, Lovenia, Spain,

Sweden, Swtzerland, Turkey, UK, Ukraine

ApplianceMarket

TEST

Remark


5/54

4. Module Specification

(1) 50

(2) 42

Display Screen Device

Aspect Ratio

PDP Module

Operating Environment

Storage Environment

Input Voltage

1

2

3

4

5

6

No Item Specification Remark

50 inch Wide Color Display Module

16:9

PDP50XG2####,

RGB Closed Type

1) Temp. : 0 ~ 40deg2) Humidity : 20 ~ 80%

3) Temp. : -20 ~ 60deg

4) Humidity : 10 ~ 90%

AC100-240V~, 50/60Hz

PDP

LGE SPEC.

Maker LG

Display Screen Device

Aspect Ratio

PDP Module

Operating Environment

Storage Environment

Input Voltage

1

2

3

4

5

6


42 inch Wide Color Display Module

16:9

PDP42XG2####,

RGB Closed Type

1) Temp. : 0 ~ 40deg

2) Humidity : 20 ~ 80%

3) Temp. : -20 ~ 60deg

4) Humidity : 10 ~ 90%

AC100-240V~, 50/60Hz

PDP

LGE SPEC.

Maker LG


6/54

5. Model General Specification

Market

Broadcasting system

Receiving system

Scart Jack(2EA)

Video Input (1EA)

S-Video Input (1EA)

Component Input (1EA)

RGB Input(1EA)

HDMI Input(3EA)

Audio Input (5EA)

Audio Out(1EA)

USB(1EA)

1

2

3

4

5

6

7

8

9

10

11

12


Albania, Austria, Belgium, Bosnia, Bulgaria,

Croatia, Czech, Denmark, Estonia, Finland France,

Germany, Greece, Hungarym Ireland, Italy, Kazekhstan,

Latvia, Lthuania, Luxembourg, Morocco, Netherlands,

Norway, Poland, Portugal Romania, Russia, Sebia,

Slovakia, Slovenia, Spain, Sweden, Swtzerland,

Turkey, UK, Ukraine

1) PAL-BG

2) PAL-DK

3) PAL-I,I

4) DVB-T (ID TV)

5) SECAM- L/L

Analog : Upper Heterodyne

Digital : COFDM

PAL, SECAM

PAL, SECAM, NTSC

PAL, SECAM, NTSC

Y/Cb/Cr, Y/Pb/Pr

RGB-PC

HDMI- DTV &SOUND

PC Audio, Component(1EA), AV(3EA)

SPDIF(1EA)

Divx, MP3, JPEG

Analog Only

4 System : PAL, SECAM,NTSC,PAL60

4 System : PAL, SECAM,NTSC,PAL60

L/R Input(PC 1EA, SCART 2EA, SIDE

AV 1EA, Component 1EA)

MP3, JPEG: 42/50PQ3000-ZA

DIVX, MP3, JPEG: 42/50PQ6000-ZA


7/54

6. Chroma & Brightness

6.1 WXGA module (42G2,42G2A module,SET With 38%Glass Filter)No Item Min Typ Max Unit Remark

*) Peak Brightness Mode

-1/100 white Window pattern

(Typically 1%Window size)

1. White peak 42G2 315 362 - cd/m2 -100IRE (255Gray)

brightness -Picture: Vivid (Medium)

-Input: HDMI- PC(1920*1080 60Hz)*Peak Brightness Condition may Slightly

different between sets.

170 189 42G2

161 183- cd/m2

42G2A-25/ 100 white Window pattern

- 100% Window White Pattern

2. White average brightness 47 54 - cd/m2 - 100IRE(255Gray)

- Picture: Vivid(Medium )

3. Brightness uniformity -10 0 +10 %- 85IRE(216Gray) 100% Window White Pattern

- Picture: Vivid(Medium)

X 0.270 0.285 0.300White

Y 0.278 0.293 0.308 - White : 85IRE(216Gray)

X 0.635 0.640 - 100% Window White Pattern

4. ColorRed

Y 0.318 0.330 0.340 - R/G/B : 100IRE(255Gray)

Coordinate X 0.242 0.300 0.305 100% Window White PatternGreen

Y 0.595 0.600 - - Picture: Vivid(Medium )X - 0.150 0.158 - 100% Window

BlueY - 0.060 0.070

- 85IRE 100% Window White Pattern5. Color coordinate uniformity -0.01 Average +0.01

- Picture: Vivid(Medium)

-1/100 white window pattern(Peak mode)

6. Contrast ratio 42G2 100k:1 1000k:1 -100IRE(255Gray)

at dark room -Picture:Vivid(Medium)

-Input:HDMI-PC (1920*1080 60Hz)

7. Color X 0.261 0.276 0.291

TemperatureCool

Y 0.268 0.283 0.298

X 0.270 0.285 0.300 - 85IRE 100% Window White PatternMedium

Y 0.278 0.293 0.308 - APC : Vivid(Medium)


8/54

ADJUSTMENT INSTRUCTION

1. Application RangeThis spec sheet is applied all of the PDP TV, PD92A chassis.

2. Specification.(1) Because this is not a hot chassis, it is not necessary to use

an isolation transformer. However, the use of isolation

transformer will help protect test instrument.(2) Adjustment must be done in the correct order.

(3) The adjustment must be performed in the circumstance of

255C of temperature and 6510% of relative humidity if

there is no specific designation.

(4) The input voltage of the receiver must keep 100~240V,

50/60Hz.

(5) The receiver must be operated for about 5 minutes prior to

the adjustment when module is in the circumstance of over

15

- In case of keeping module is in the circumstance of 0C,it should be placed in the circumstance of above 15C for

2 hours

- In case of keeping module is in the circumstance of below

-20C, it should be placed in the circumstance of above

15C for 3 hours,.

O After RGB Full White in HEAT-RUN Mode, the receiver

must be operated prior to the adjustment.

O Enter into HEAT-RUN MODE

(1) Press the POWER ON KEY on R/C for adjustment.(2) OSD display and screen display PATTERN MODE.

* Set is activated HEAT run without signal generator in this

mode.

* Single color pattern (WHITE) of HEAT RUN MODE uses to

check panel.

Caution: If you turn on a still screen more than 20 minutes

(Especially digital pattern, cross hatch pattern), an

after image may be occur in the black level part of thescreen.

3. PCB assembly adjustment methodCaution: Using power on button of the control R/C, power on

TV.

4. Insert Tool OPTION and ModelName Download

(1) Press IN_START key on R/C to insert Tool OPTION

(2) On the Tool Option 1, Insert Tool Option by a number

key

(3) Press the ENTER(V)

(4) Press ENTER(V) again.

(5) Select OK to Download by usingF/G(VOL +/-) and press

G(VOL +)

Model Name Model Option Value

50PG3000-ZA 471742PQ3000-ZA 4461

50PG6000-ZA 8814

42PQ6000-ZA 8558

50PQ2000-ZA 2669

42PQ2000-ZA 2413

50PS3000-ZB 4781

50PS6000-ZC 8878

42PQ1000-ZD 260

42PQ1100-ZE 1050042PQ1000-ZA 12548

60PS4000-ZA 7085

50PQ1000-ZD 580

50PQ1100-ZE 10820

50PQ1000-ZA 12868

Tool Option 4782

Model Name : 50PS1000-ZD

INCH : 50

Tool : PS60

EYE : 1

Media Player : EMF-PMM

HDMI Type : 3-HDMI

XD Plazma : 0

OK to Download

DOWNLOAD : OK

Tool

Tool Option


9/54

5. EDID(The Extended Display

Identification Data) Download(1) Press the ADJ KEY on R/C and enter EZ ADJUST.

(2) Select 5.EDID D/L by using D/E(CH +/-) and press

ENTER(V).

(3) Select Start and press navigation key(G).

(4) EDID download is executed automatically.

(5) Press EXIT key on R/C

5.1. EDID DATA1) Analog RGB

O Detail EDID Options are below ( , , , )

Product ID

2) HDMI

O Detail EDID Options are below ( , , , , )

Product ID

Week, Year

=> Controlled on production line:

ex) Week: 03 -> 03

Year: 2009 -> 13

Model Name(Hex)

Product IDMODEL NAME Product ID

HEX EDID Table

42PQ3000 40433 9DF1 F19D

42PQ6000 40431 9DEF EF9D

50PQ3000 50250 C44A 4AC4

50PQ6000 50248 C448 48C4

42PQ2000 40467 9E13 139E

50PQ2000 50276 C464 64C4

50PS3000 50278 C466 66C4

50PS6000 50280 C468 68C4

60PS4000 50290 C472 72C4

42PQ1000 40473 9E19 199E

42PQ1100 40475 9E1B 1B9E

50PQ1000 50296 C478 78C4

Product IDMODEL NAME Product ID

HEX EDID Table

42PQ3000 40433 9DF1 F19D

42PQ6000 40431 9DEF EF9D

50PQ3000 50250 C44A 4AC4

50PQ6000 50248 C448 48C4

42PQ2000 40467 9E13 139E

50PQ2000 50276 C464 64C4

50PS3000 50278 C466 66C4

50PS6000 50280 C468 68C4

60PS4000 50290 C472 72C4

42PQ1000 40473 9E19 199E

42PQ1100 40475 9E1B 1B9E

50PQ1000 50296 C478 78C4


10/54

5.2 Confirmation

1) Press InStart Key on Factory SVC Remote Controller, It ispossible to check ADC & EDID ADJ

2) Select Channel Recovery and press navigation key(G).

6. SET assembly adjustment method

Caution : Each PCB assembly must be checked by check JIG set.

(Because power PCB Assembly damages to PDP Module,

especially be careful)

7. POWER PCB Assembly VoltageAdjustment (Va, Vs voltage Adjustment)

7.1. Test Equipment: D.M.M 1EA

7.2. Connection Diagram for Measuring:Refer to fig.1

7.3. Adjustment Method(1) Va adjustment

1) Connect + terminal of D. M.M. to Va pin of P811, connect -

terminal to GND pin of P811.

2) After turning VR901,voltage of D.M.M adjustment as same

as Va voltage which on label of panel right/top (deviation;

0 5V)

8. Download Serial Number (RS-232C)(1) Press Power on key of service R/C.(Baud rate : 115200

bps)

(2) Connect RS232 Signal Cable to RS-232 Jack.

(3) Write Serial number by use RS-232.

(4) Must check the serial number at the Diagnostics of SET

UP menu.

(Refer to below 6.SET INFORMATION).

9. Adjustment of White Balance

9.1. Required Equipment(1) Remote controller for adjustment

(2) Color Analyzer (CS-1000, CA-100,100+,CA-210 or same

product) : CH 10 (PDP)

[ Please adjust CA-210, CA-100+ by CS-1000 before

measuring

(3) Auto W/B adjustment instrument(only for Auto adjustment)(4) 9 Pin D-Sub Jack(RS232C) is connected to the AUTO W/B

EQUIPMENT.

9.2. AUTO White Balance ProcessBefore Adjust of White Balance, Please press POWER ONLY

key

Adjust Process will start by execute RS232C Command

O Color temperature standards according to CSM and Module

O CS-1000/CA-100+/CA-210(CH 10) White balance

adjustment coordinates and color temperature.

PLASMA Remark

11000K

9300K

6500K

Cool

Medium

Warm

CSM

Color Coordinate

x y

0.283

0.293

11,000K

9,300K

0.002

0.002

0.276

0.285

Cool

Medium

CSM TempColor

Coordinate


11/54

9.3. Manual W/B Process (using adjusts Remote control)

Please Adjust in AV 1 MODE, Turn off Energy Saving Mode.

(1) Enter PICTURE RESET on Picture Mode, then turn off

Fresh Contrast and Fresh colour in Advanced Control

(2) After enter Service Mode by pushing ADJ key,

(3) Enter White Pattern off of service mode, and change off ->

on.

(4) Enter W/B ADJUST by pushing G key at 3. W/B

ADJUST.

(5) Adjust W/B DATA, for all CSM, choose COPY ALL

[ Gain Max Value is 192. So, Never make any Gain Value

over 192 and please fix one Value on 192, between R, G

and B.

9.4. Auto-control Interface and Directions(1) Adjust in the place where the influx of light like floodlight

around is blocked.

(Illumination is less than 10ux).

(2) Measure and adjust after sticking the Color Analyzer (CA-

100+, CA210 ) to the side of the module.

(3) Aging time

After aging start, keep the Power on (no suspension of

power supply) and heat-run over 5 minutes

9.5. Auto Adjustment Map(RS232C)

10. Checking the EYE-Q Operation

(1) Press the EYE Key on the adjustment remote controller.(2) Check the Sensor DATA (It must be under 10) and keep

the data longer than 1.5s

(3) Check OK

(Sensor DATA 0 ~ 4095, Power Saving Mode 0 ~ 12)

[ IF you press IN-STAP Button, change Green Eye-check OSD.

11. Set Information(Serial No & Model name)

11.1. Check the Serial Number & Model Name(1) Push the menu button in DTV mode.

(2) Check the Serial NumberSelect the STATION ==> Diagnostics ==> To set


12/54

12. SW Download Guide.* Put a *.bin to USB Stick and Turn on TV

1. Put the USB Stick to the USB socket2. Automatically detecting update file in USB Stick

* If your downloaded program version in USB Stick is Low, it

didnt work.But your downloaded version is High, USB data isautomatically detecting.

3. Show the message Copying files from memory

4. Updating is staring.

5. Updating Completed, The TV will restart automatically.After turn on TV, Please press IN-STOP button on ADJ

Remote-control.* IF you dont have ADJ R/C, enter Factory Reset in OPTIONMENU.

6. When TV turn on, check the Updated version on DiagnosticsMENU.


13/54

BLOCK DIAGRAM

LVDS

LVA

_[0:4

]

_L/R

_IN

SATU

RN4

(IC1

00)

TAS5709

IC1000

SP(R)

SP(L)

P1000

CISlot

(P800)

I2C_

A_

TU

KEY1/2

DDRMem

ory

512Mb(IC301)

232

2)D

DCUART-Tx/Rx

PCM_ADD

PCM_DATA

TS_Parallel

KIC7SZ32FU

(IC802)

PCM_CD_ON

CI_CD

_1/2

I2S

MUTE, AMP_RST

P402

LED

_G/R&IR

Flas

hMem

ory

16MB(IC1

03)

BS

_IN

UT

_OUT

PDP

Panel

TS_Serial

RS232C_Tx/Rx

2C_

D_

TU

SPDIF

_OUT

DDRMem

ory

512Mb(IC300)

SPI_SCK

SPI_SDI

SPI_SD0

SPI_CSN

_1

EEPROM

(IC111)

SYSTEM

_SCL

SYSTEM

_SDA

MDATA[0:1

6]

MDATA[17:3

1]P

1100

17V

12V

5V

SCL/SDA_

SUB/AMP

SCL/SDA_SUB/AMP

HDCPEEPROM

(IC102)

SYSTEM

_SCL

SYSTEM

_SDA

EEPROM

HDMI_CEC

TDMSHPD

5V_HDMI_1, 2, 3

EEPROM

EEPROM

DDC_

SCL,SDA_

1,2,3

HDMI_I2C

CE365

(IC501)

+

TS

_DATA


14/54

POWER FLOW DIAGRAM

AP2125

3.3VST

Mstar

FET

(Q303)

AZ1084S-3.3

AZ1117H

-ADJ

3.3V_

MST

1.8V_

MST

1.3V_

VDDC

MP2305DS

AZ1117H-1.2

1.2V_P

VSB

VSBIC

DDR

5VST

FET

(Q504)

Power_

SW

VSB

_Ctrl

5V_

MST

AVDD_M

PLL

VDDP

AVDD_MEMPLL

AVDD_ADC

AVDD_DM

AVDD_O

TG

AVDD_AU

AVDD_LPLL

AVDD_33

AVDD_D

DR

1.3

V_VD

DC

AVDD_M

LINK

DD

R1

.8V

3.3V_

PVSB

1.2

V_DV

DD

3.3

V_DV

DD

3.3

V_AV

DD

USB

MIC2019YM6

5V

5V_

USB

HDMI

switch

12V

KIA7808AF

5V_

TU

Tuner

Audio

AMP

HDCP

NVRAM

Serial

Flash

17V

EEPROM

(RGB)

MAX3232

EEPROM

(HDMI)

L312

L326L313

L301

L325

IC301

L323

L308

L307

L306

L305

L304

L303

L302

L309

L321

L316

L319

L320

L504

IC30

2IC305

IC304

IC804

IC503

IC502 3

.3V

_AMP

_DVDD

3.3

V_

AMP

_AVDD

L1011

L1010

L501

L503

L324

L331

ce

>

AZ1117

H-ADJ

IC505


15/54

HW Power On Sequence (LGE2872A)


16/54

EXPLODED VIEW

A10

900

901

400

520

590

240

250

300

305

3

01

03

302

200

580 2

60

270

603

602

501

A2

LV1

601

600

Many electrical and mechanical parts in this chassis have special safety-related characteristics. These

parts are identified by in the Schematic Diagram and EXPLODED VIEW.

It is essential that these special safety parts should be replaced with the same components as

recommended in this manual to prevent X-RADIATION, Shock, Fire, or other Hazards.




17/54

EXPLODED VIEW

A10

900

901

400

520

590

240

250

300

305

3

01

03

302

200

580 2

60

270

603

602

501

A2

LV1

601

600

Many electrical and mechanical parts in this chassis have special safety-related characteristics. These

parts are identified by in the Schematic Diagram and EXPLODED VIEW.

It is essential that these special safety parts should be replaced with the same components as

recommended in this manual to prevent X-RADIATION, Shock, Fire, or other Hazards.



1 FC143 0 .1uF

C147

+5V SYS 4 7 FC144

4 7uF16V

MSD237HFG(SATURN4 NO-SD HD DIVX)IC100


18/54

MS_LRCK

SC1_CVBS_IN

100R102

0 .1uFC122

SIDE_L_IN

0.1uF C142

4.7KR107

SIDE_C_IN

1.2KR170

Flash_WP_1

100R144

MUTE

SCL_EXPANDER

100R114

100R110

SPI_SDI

5V_ON

SPI_SCK

AC_DET

KEY2

LED_RED

22KR133

100R185

SC_REC1

100R115

DSUB_G

TV_L_OUT

22K

R127

DTV/MNT_R_OUT

SC1_FB

DSUB_B

RS232C_TXD

SC2_L_IN

0.1uFC101

SPI_SCK

DTV/MNT_V_OUT

+3.3V_AVDD_DVI

MS_SCK

1K

R146

LED_RED

100R168 OPT

0.1uFC102

100R109

1KOPT

R145

DISP_EN

1uF25V

SC1_L_IN4.7KR106

SPI_SDI

TV_R_OUT

COMP_Pr

SPDIF_OUT

AUDIO_MASTER_CLK

SC2_CVBS_IN

SPI_SDO

COMP_Y

PC_R_IN

DSUB_VSYNC

SC1_R_IN

SYSTEM_SCL

001:D16;001:V5

VAVS_ON

DSUB_HSYNC

IR

100R192

POWER_ON/OFF1

1KOPT

R142

SYSTEM_SDA

001:D16;001:V5

KEY1

SPI_CSN_1

SIDE_CVBS_IN

AMP_RST

SC2_R_IN

DSUB_R

Flash_WP_1

MS_LRCH

100R195

22K

R128

SC2_ID

SPI_SDO

0.01uFOPT

C152

SDA_D_TU

SCL_D_TU

PC_L_IN 0.01uF

C150100R108

0

OPT

R100

DTV/MNT_L_OUT

100R169

22K

R132

100R111

SIDE_R_IN

SC_REC2

1K

R141

SPI_CSN_1

50V

COMP_Pb

TV_CVBS+

0.01uF

C149

SIDE_Y_IN

0.01uF

OPTC153

390

1%

R182

0.047uFC108 FULL SPEC

0.047uFC125



0.047uFC127



0.047uFC116

FULL SPEC0.047uFC117

FULL SPEC

0.047uFC115

47R181

47R161FULL SPEC

47R183

47R174FULL SPEC

47R190FULL SPEC

47R187

47R188FULL SPEC

47R186FULL SPEC

47R177FULL SPEC

47R172FULL SPEC

47R171

56000pFC151

56000pF

C154

LED_GRE

5V_HDMI_1

5V_HDMI_2

SC1_G

SC1_R

SC1_B

47R160FULL SPEC

SIDE_CVBS_DET

SCART2_DET

SCART1_DET

22 R131SCL_EXPANDER

SDA_EXPANDER22 R130

COMP_DET

100

R126

FULLSPEC

100

R122

USB_OCD

COMP_R_IN

COMP_L_IN


510R163FULL SPEC

510R164FULL SPEC

USB_CTL

100

R139

RS232C_RXD

CAT24WC08W-TIC102

3A2

2A1

4VSS

1A0

5SDA

6SCL

7WP

8VCC

SYSTEM_SDA001:F19;001:V5

4.7KR101

22R104

SYSTEM_SCL001:F19;001:V5

22R103

THE SYMBOL MARK OF THIS SCHEMETIC DIAGRAM INCORPORATES

SPECIAL FEATURES IMPORTANT FOR PROTECTION FROM X-RADIATION.

FILRE AND ELECTRICAL SHOCK HAZARDS, WHEN SERVICING IF IS

ESSENTIAL THAT ONLY MANUFATURES SPECFIED PARTS BE USED FORTHE CRITICAL COMPONENTS IN THE SYMBOL MARK OF THE SCHEMETIC.

DDC_SCL_3

1M

R156

DDC_SDA_3

HPD2

22R150

USB_DP

HPD3

SYSTEM_SCL

DDC_SDA/UART_TX

12MHz

X100

SIF+

USB_DM

SYSTEM_SDA

2 2 R1 55

22R154

DDC_SCL/UART_RX

+3.3V_AVDD

4.7K

R113

OPT

4.7K

OPT

R112

0.1uF

C169

SDA_EXPANDER

4.7K

R129

4.7K

R157

5V_CI_CTL

SC1_VOUT_MUTE

JTP-1127WEMSW100

12

4 3

5V_MNT

S_DET

22R151

22R149

5V_HDMI_3

100

R193

FULLSPEC

RGB_DET

0.1uFC104

0 .1uF

C170

+3.3V_EXPANDER

+1.8V_EXPANDER

+3.3V_EXPANDER

DDC_SCL_2

DDC_SDA_2

1 00 R1 52

1 00 R1 53

0.047uFC11447R176

47R173 0.047uFC119

0.047uFC12147R180

47R189 0.047uFC129

47R178FULL SPEC

0.047uFC118FULL SPEC

0.1uF C155

0 .1uF C156

0.1uF

C167

100R124

100R123

100R135

100R136

100R134

22pF50V

C159

OPT

22pF50V

C160

OPT

22pF50V

C157

OPT

22pF50V

C158

OPT

0.1uFC1230 .1uFC124

DDC_SDA/UART_TX

4.7K

R116OPT

+5V_ST

+5V_ST

47uF

16V

C166

47uF

16V

C168

R13

OPT

R12

OPT

0.047uFC111

0.047uFC110

47R165

47R175

0R15OPT

+5V_SYS

+3.3V_VDDP_ST

+3.3V_AVDD

10K

R140

10K

R148

FULL SPEC

0.047uFC11247R166

100R118

100R117

0.047uFC12047R179

10K

R196

FULL SPEC

D0-_HDMI3

CK+_HDMI1

CK-_HDMI1

D0-_HDMI1

D2-_HDMI2

D0+_HDMI2

CK-_HDMI3

D2+_HDMI3

D2+_HDMI2

D1-_HDMI3

D2+_HDMI1

D1-_HDMI1

D2-_HDMI3

D0+_HDMI3

D1+_HDMI3

D1+_HDMI2

CK-_HDMI2

D1+_HDMI1

D0+_HDMI1

D0-_HDMI2

CK+_HDMI2

D2-_HDMI1

D1-_HDMI2

CK+_HDMI3

DDC_SCL_1

DDC_SDA_1

HPD1

SC1_ID100R197

+5V_SYS

2SA1504S

Q100

E

B

C

+3.3V_VDDP_ST

1KR10

10KR14

10K

R11

KDS226

D100

A

AC

C

0R18

0R17

OPT

47uF16V

C174

12MHz

X1011M

R21

RTC_INT

RTC_INT0 RTCR20

0R22

+3.3V_EXPANDER

10KR23

OPT

10K

R25

FORHD

10KR26

OPT

10K

R24

FULL-HD

ROM_RX

ROM_TX

TU_SLEEP_MODE

CE6355_RESET_N

XC5000_RESET_N

3216

4.7uF16V

4.7uFC148

10uF6.3V

C172

10uF6.3V

C171

100R30

RL_ON

22R32

22R34

100R199

0 .1uFC177

0 .1uF

C178

10R31

33KR159

0R191

KDS181

D101

+3.3V_VDDP_ST

4.7uF10V

C179

+3.3V_VDDP_ST

100R35

470R184FULL SPEC

470R167

470R162FULL SPEC 1nFC109 FULL SPEC

1nFC131 FULL SPEC

1nFC113

LED_GRE

AT24C512BN-SH25-TIC110

3NC

2A1

4GND

1A0

5SDA

6SCL

7WP

8VCC

4.7KR36

SDA_SUB/AMP

4.7K

R120

SCL_SUB/AMP

4.7K

R121

+3.3V_CI

+3.3V_CI

4.7K

R39

SCL_GREENEYE

4.7KR38

SDA_GREENEYE

0

R40

GREENEYE_CTRL

0.1uF

C180

22R143

20pFC175

20pFC176

20pF

C161

20pFC162

LGE40RC-LF

IC109

1GPIO32

2GPIO33

3GPIO34

4GPIO35

5GND_1

6VDDP

7GND_2

8VDDC

9GPIO36

10GPIO37

11GPIO38

12GPIO39

13GPIO0

0

14GPIO0

1

15GPIO0

2

16GPIO0

3

17GPIO0

4

18GPIO0

5

19GPIO0

6

20GPIO0

7

21GPIO0

8

22GPIO0

9

23GPIO1

0

24GPIO1

1

25 GPIO12

26 GPIO13

27 GPIO14

28 GPIO15

29 HWRESET

30 XIN

31 I2C_SDA32 I2C_SCL33 GPIO1634 GPIO1735 GPIO18

36 GPIO1937

GPIO20

38

GPIO21

39

GPIO22

40

GPIO23

41

GPIO24

42

GPIO25

43

GPIO26

44

GPIO27

45

GPIO28

46

GPIO29

47

GPIO30

48

GPIO31

GPIO148U2

GPIO147T2

GPIO146P4

GPIO145P3

GPIO144N6

GPIO16F3

GPIO14E9

GPIO4V11

GPIO3V10

RXA0NH2

RXA0PH1

RXA1NJ2

RXA1PJ1

RXA2NK2

RXA2PK1

RXACKNG2

RXACKPG1

RXB0ND2

RXB0P

D1

RXB1NE2

RXB1PE1

RXB2NF2

RXB2PF1

RXBCKNC2

RXBCKPC1

RXC0NW9

RXC0PY9

RXC1NW10

RXC1PY10

RXC2NW11

RXC2PY11

RXCCKNW8

RXCCKPY8

VCLAMPG4

REXTF5

REFMG6

REFPG5

RIN0ML1

RIN0PL2

GIN0MM1

GIN0PM2

BIN0MN1

BIN0PN2

SOGIN0J5

HSYNC0L7

VSYNC0M7

RIN1PH6

GIN1PH5

BIN1PH3

SOGIN1H4

HSYNC1G7

VSYNC1G8

RIN2PL6

GIN2PL4

BIN2PL3

SOGIN2L5

HSYNC2K5

VSYNC2K6

VCOM1R1

VCOM0R2

CVBS7K4

CVBS6J4

CVBS5K3

CVBS4J3

CVBS3M3

CVBS2P1

CVBS1M4

CVBS0P2

CVBSOUTT1

DREXTM16

DACSVMN16

AUVRMN5

AUVRPN4

AUVAGU3

AUCOMV2

AUL0P5

AUR0P6

AUL1R3

AUR1R4

AUL2Y3

AUR2Y4

AUL3R5

AUR3R6

AUL4T3

AUR4T4

AUL5T5

AUR5T6

AUOUTL0Y6

AUOUTR0W4

AUOUTL1V3

AUOUTR1

U4

AUOUTL2Y5

AUOUTR2W3

PWM5R15

PWM4T15

PWM3U16

PWM2T16

PWM1P16

PWM0R16

SAR5V16

SAR4V15

SAR3U15

SAR2V14

SAR1Y12

SAR0W12

I2S_OUT_MCKE16

I3S_OUT_BCKE12

I4S_OUT_WSF16

I5S_OUT_SDE11

I6S_OUT_MUTEE10

SPDIFOE14

I2S_IN_BCKG16

I3S_IN_WSH16

I4S_IN_SDG15

SPDIFIF15

SCKY13

SDIW13

SDOY14

SCZW14

IRINM18

INTL18

USB_DM_P0A2

USB_DP_P0A1

USB_DM_P1B2

USB_DP_P1B1

USB_CID_P1E7

USB_VBUS_P1E8

TAGCM5

VR27M6

VR12N3

SIFMW2

SIFPY2

VIFMW1

VIFPY1

DDCA_SDAP15

DDCA_SCLP14

DDCDA_SDAF6

DDCDA_SCLG3

DDCDB_SDAE4

DDCDB_SCLE6

DDCDC_SDAT14

DDCDC_SCLR14

DDCR_SDAY15

DDCR_SCLW15

HOTPLUGAF4

HOTPLUDBE5

HOTPLUDCN15

CECE3

HWRESETU14

XINV1

XOUTU1

MSD237HFG(SATURN4NO-HDDIVX)IC100-*1

GP IO148U2

GP IO147T 2

GP IO146P 4

GP IO145P 3

GP IO144N6

GP IO16F 3

GP IO14E 9

GP IO4V11

GP IO3V10

RXA0NH2

RXA0PH1

RXA1NJ2

RXA1PJ1

RXA2NK2

RXA2PK1

RXACKNG2

RXACKPG1

RXB0ND2

RXB0PD1

RXB1NE 2

RXB1PE 1

RXB2NF 2

RXB2PF 1

RXBCKNC2

RXBCKPC1

RXC0NW 9

RXC0PY9

RXC1NW 10

RXC1PY10

RXC2NW 11

RXC2PY11

RXCCKNW 8

RXCCKPY8

VCLAMPG4

REXTF 5

REFMG6

REFPG5

RIN0ML 1

RIN0PL 2

GIN0MM1

GIN0PM2

BIN0MN1

BIN0PN2

S OGIN0J5

HSYNC0L 7

VSYNC0M7

RIN1PH6

GIN1PH5

BIN1PH3

S OGIN1H4

HSYNC1G7

VSYNC1G8

RIN2PL 6

GIN2PL 4

BIN2PL 3

S OGIN2L 5

HSYNC2K5

VSYNC2K6

VCOM1R1

VCOM0R2

CVBS7K4

CVBS6J4

CVBS5K3

CVBS4J3

CVBS3M3

CVBS2P 1

CVBS1M4

CVBS0P 2

CVBSOUTT 1

DREXTM16

DACSVMN16

AUVRMN5

AUVRPN4

AUVAGU3

AUCOMV2

AUL0P 5

AUR0P 6

AUL1R3

AUR1R4

AUL2Y3

AUR2Y4

AUL3R5

AUR3R6

AUL4T 3

AUR4T 4

AUL5T 5

AUR5T 6

AUOUTL0Y6

AUOUTR0W 4

AUOUTL1V3

AUOUTR1U4

AUOUTL2Y5

AUOUTR2W 3

PWM5R15

PWM4T 15

PWM3U16

PWM2T 16

PWM1P 16

PWM0R16

SAR5V16

SAR4V15

SAR3U15

SAR2V14

SAR1Y12

SAR0W 12

I2S _OUT _MCKE 16

I3S _OUT _BCKE 12

I4S _OUT _W SF 16

I5S _OUT _S DE 11

I6S _OUT _MUT EE 10

S P DIF OE 14

I2S _IN_BCKG16

I3S _IN_W SH16

I4S _IN_S DG15

S P DIF IF 15

S CKY13

S DIW 13

S DOY14

S CZW 14

IRINM18

INTL 18

US B_DM_P 0A2

US B_DP _P 0A1

US B_DM_P 1B2

US B_DP _P 1B1

US B_CID_P 1E 7

US B_VBUS _P 1E 8

TAGCM5

VR27M6

VR12N3

SIFMW 2

S IF PY2

VIFMW 1

VIF PY1

DDCA_SDAP 15

DDCA_S CLP 14

DDCDA_S DAF 6

DDCDA_SCLG3

DDCDB_S DAE 4

DDCDB_S CLE 6

DDCDC_S DAT 14

DDCDC_S CLR14

DDCR_SDAY15

DDCR_S CLW 15

HOTPLUGAF 4

HOTPLUDBE 5

HOTPLUDCN15

CE CE 3

HWRESETU14

XINV1

XOUTU1

2 .2uF16V C132

2 .2uF16V C133

2 .2uF16V C139FULL SPEC

2.2uF16V C141

FULL SPEC

2.2uF16V C135


2.2uF16V C140FULL SPEC

2.2uF16V C134


2.2uF16V C138FULL SPEC

10uF

16V

C173

47K

R105

22R137

MX25L12805DMI-20GIC103

3NC_1

2VCC

4NC_2

1HOLD

6NC_4

5NC_3

7CS

8SO

9WP/ACC

10GND

11NC_5

12NC_6

13NC_7

14NC_8

15SI

16SCLK

//BOOTSTRAP PWM[1:0]=10

EEPROM

VIDEO IN

AUDIO

I2S

FLASH

HDMI

2 009 . 04 . 15

MAIN_1 1 11

IC105: EAN43349001(STM)

I/0 EXPANSION

HDCP EEPROM

*Mstar rese t :Act ive high rese t

VOLTAGEDETECTOR

ACTIVE LOW

Flash memory CS/WP pull-up Resis tor Ready(4.7K)_080402

EAX57566204

HDMI3

SIDE HDMI

HDMI1

HDMI2

16M FLASH MEMORY

K5:CVBS OUT2 REV2

Swap port TX, RX

S houl d be on t op s i de o f P CB be c a s e o f de buggi ng

GPIO15: XOUT

1.MSG1040C --> MSG1040RC

3.G P IO : 40pc s - -> 39pc s

4.GPIO0: RTC_INT

5.GPIO15: XOUT

2.PWM is Deleted & RTC is added

REVISION

PWM pin delete

READY FOR H/W OPTION

08.07 .10

U pda t e d 08 .07 .10

OCD IS OPTTION.(see the sheet6)Be c a us e O CD func t i on of IC i s a u t oma t i c a l l y ope ra t e d .

OCD IS OPTTION.(see the sheet6)

A_IIC EXCEPT TO CHIPTUNER

MSTAR REQUEST 32.768K READY is OUT over SPEC

08.09 .12

TO POWER B/D(RL_ON)Need to check RTC_INT

Copyright 2009 LG Electronics. Inc. All right reserved.Only for training and service purposes LGE Internal Use Only

LVB 0P A DQM1

LVB_0M

1/16W22

AR200

56R225


LVA0MV20

LVA0PV19

A_MVREFE13

A DDR2 DQM[1]A10

Need to swap even to odd


19/54

LVA_1M

A_MDATA[1]

LVB_0P

PCM_OE_N

LVA_1P

A_MADR[9]

PCM_D[0-7]

LVB_CKM

A_MADR[2]

A_MDATA[0]

A_MDATA[2]

A_MADR[0]

A_MDATA[6]

TS_CLK

A_MCLK+BUF_TS_SYNC

LVA_CKM

A_MADR[7]

LVB_4P

A_BA0

PCM_CE_N

LVA_3M

A_MDATA[7]

A_MDATA[4]

LVB_2P

PCM_IOWR_N

LVA_CKP

LVB_4M A_MDATA[12]

A_MDATA[8]

A_MADR[8]

PCM_REG_N

A_RAS

A_MADR[11]

A_DQM0

BUF_TS_VAL

TS_D[0-7]

A_MDATA[14]

LVA_3P

LVB_2M

PCM_IRQA_N

TS_SYNC

A_CAS

A_MADR[10]

A_MADR[3]

LVA_2P

LVB_3P

A_DQM1

A_MCLK-

PCM_RESET

A_MDATA[13]

A_MADR[5]

LVA_4P

A_MADR[4]

LVB_1P

LVB_CKP

A_MDATA[11]

PCM_WAIT_N

A_MADR[6]

A_MDATA[15]

A_MDATA[10]

LVA_2M

A_MDATA[3]

LVB_3M

BUF_TS_DATA[0]

PCM_WE_N

PCM_A[0-14]

A_MADR[1]

LVA_0P

A_BA1

TS_VALID

A_WE

LVB_1M

A_MDATA[5]

BUF_TS_CLK

A_MDATA[9]

PCM_CD_N

A_CLKE

LVA_0M

A_MADR[12]LVA_4M

PCM_IORD_N

22 R218

22 R217

22 R214

22 R213

22 R219

22 R220

22 R216

22 R215A_DQS1M

A_DQS1P

A_DQS0M

A_DQS0P

A_ODT

1/10W 1K1%

R231

1/10W

1K

1%

R232

B_DQM0

B_MDATA[0]

B_MDATA[2]

B_MADR[12]

B_WE

B_DQS1P

B_MADR[1]

B_MDATA[12]

B_MCLK-

B_MADR[2]

B_BA1

B_MADR[6]

B_MDATA[1]

B_MADR[0]

B_MDATA[7]

B_MADR[5]

B_MDATA[6]

B_MADR[4]

B_ODT

B_MDATA[4]

B_MDATA[15]

B_MDATA[11]

B_MDATA[14]

B_RAS

B_MADR[11]

B_MDATA[9]

B_MDATA[3]

B_MCLK+

B_DQS1M

B_DQM1

B_CAS

B_MADR[7]

B_MADR[10]

B_CLKE

B_DQS0P

B_MDATA[5]

B_DQS0M

B_MADR[8]

B_MADR[9]

B_BA0

B_MDATA[13]

B_MDATA[8]

B_MDATA[10]

B_MADR[3]

1/16W

22

AR201

1/16W

22

AR202

1/16W

22

AR203





0 .1uF

50V

C214

0 .1uF

50V

C205 +1.25V_VDDC

+3.3V_AVDD_LPLL

0.1uF50V

C201

+3.3V_AVDD_MPLL

+1.8V_DDR2_MAIN

0.1uF50V

C203

+1.25V_AVDD_DVI

0 .1uF50V

C207

0 .1uF

50V

C209

+3.3V_AVDD_AU

0.1uF

50V

C206

0 .1uF50V

C213

0.1uF50V

C210

+3.3V_AVDD_MEMPLL

+3.3V_AVDD_ADC

0.1uF50V

C208

0.1uF

50V

C200

0 .1uF

50V

C215

0 .1uF50V

C204

0 .1uF

50V

C216+3.3V_VDDP

0.1uF50V

C202

+3.3V_AVDD_VIF

+3.3V_AVDD_OTG

HDMI_CEC

0.1uF

50V

C217

56R258

56R229

56R239

56R237

56R259

56R226

56R236

56R247

56R241

56R249

56R245

56R255

56R228

56R243

56R253

56R257

56R256

56R248

56R252

56R235

56R227

56R244

56R260

56R254

56R246

56R240

56R238

56R242

56R230

3 3 R2 22

3 3 R2 23

3 3 R2 24

3 3 R2 21

1 00 R 21 2

56R276 1G

56R2771G

A_BA2

B_BA2

33R234

33R251

33R233

33R250

0R278

OPT

0R279

+1.8V_DDR2_MAIN


GND_1B15

GND_2D7

GND_3D8

GND_4D12

GND_5D13

GND_6F7

GND_7J9

GND_8J10

GND_9J11

GND_10J12

GND_11J13

GND_12K9

GND_13K10

GND_14K11

GND_15K12

GND_16K13

GND_17L9

GND_18L10

GND_19L11

GND_20L12

GND_21L13

GND_22L19

GND_23L20

GND_24M9

GND_25M10

GND_26M11

GND_27M12

GND_28M13

GND_29W6

GND_30

W7

AVDD_AUP8

AVDD_LPLLK18

AVDD_MPLLN7

AVDD_MEMPLLD14

AVDD_33_1H7

AVDD_33_2J6

AVDD_33_3J7

AVDD_33_4K7

AVDD_USBF8

AVDD_VIFP7

AVDD_DMP13

VDDP_1N8

VDDP_2N12

VDDP_3P11

VDDP_4P12

AVDD_DDR_1G11

AVDD_DDR_2G12

AVDD_DDR_3G13

AVDD_DDR_4G14

AVDD_DDR_5H14

AVDD_DVIG10

VDDC_1H9

VDDC_2H10

VDDC_3J15

VDDC_4K15

VDDC_5L15

VDDC_6M15

VDDC_7N10

VDDC_8N11

VDDC_9

P10

LVA0P

LVA1MW20

LVA1PY20

LVA2MY19

LVA2PW19

LVACKMY18

LVACKPW18

LVA3MY17

LVA3PW17

LVA4MY16

LVA4PW16

LVB0MM20

LVB0PM19

LVB1MN20

LVB1PN19

LVB2MP20

LVB2PP19

LVBCKMR20

LVBCKPR19

LVB3MT20

LVB3PT19

LVB4M

U20

LVB4PU19

TS0DATA[7]V5

TS0DATA[6]T8

TS0DATA[5]T7

TS0DATA[4]R8

TS0DATA[3]R7

TS0DATA[2]U6

TS0DATA[1]U5

TS0DATA[0]V4

TS0CLKY7

TS0VALIDV6

TS0SYNCW5

TS1DATAM17

TS1CLKN18

TS1VALIDL17

TS1SYNCP18

PCM_D[7]/CI_D[7]U7

PCM_D[6]/CI_D[6]U8

PCM_D[5]/CI_D[5]U9

PCM_D[4]/CI_D[4]T9

PCM_D[3]/CI_D[3]R9

PCM_D[2]/CI_D[2]P9

PCM_D[1]/CI_D[1]R10

PCM_D[0]/CI_D[0]R11

PCM_A[14]/CI_A[14]V7

PCM_A[13]/CI_A[13]V8

PCM_A[12]/CI_A[12]U10

PCM_A[11]/CI_A[11]T10

PCM_A[10]/CI_A[10]T11

PCM_A[9]/CI_A[9]V9

PCM_A[8]/CI_A[8]U11

PCM_A[7]/CI_A[7]R12

PCM_A[6]/CI_A[6]T12

PCM_A[5]/CI_A[5]U12

PCM_A[4]/CI_A[4]V12

PCM_A[3]/CI_A[3]R13

PCM_A[2]/CI_A[2]T13

PCM_A[1]/CI_A[1]U13

PCM_A[0]/CI_A[0]V13

PCMIOR/CI_RDU18

PCMIOW/CI_WRT18

PCMREG/CI_CLKU17

PCMCEN/CI_CST17

PCMIRQ/CI_INTR17

PCMWAIT/CI_WACKR18

PCMOENV18

PCMWENV17

CI_RSTP17

CI_CDN17

A_DDR2_DQM[1]

A_DDR2_DQM[0]C9

A_DDR2_DQS[1]C8

A_DDR2_DQS[0]B9

A_DDR2_DQSB[1]B8

A_DDR2_DQSB[0]A9

A_MDATA[15]A8

A_MDATA[14]B10

A_MDATA[13]A7

A_MDATA[12]A11

A_MDATA[11]B11

A_MDATA[10]B7

A_MDATA[9]C10

A_MDATA[8]C7

A_MDATA[7]C6

A_MDATA[6]C11

A_MDATA[5]C5

A_MDATA[4]C12

A_MDATA[3]B12

A_MDATA[2]A6

A_MDATA[1]A12

A_MDATA[0]

B6

A_MADR[12]C13

A_MADR[11]D4

A_MADR[10]C14

A_MADR[9]A14

A_MADR[8]D5

A_MADR[7]B13

A_MADR[6]D6

A_MADR[5]B14

A_MADR[4]A3

A_MADR[3]A13

A_MADR[2]B3

A_MADR[1]A15

A_MADR[0]C3

A_BADR[2]F14

A_BADR[1]D10

A_BADR[0]D9

A_MCLKB5

A_MCLKZA5

A_MCLKED11

A_ODTC4

A_WEZD3

A_RASZB4

A_CASZA4

B_MVREFE15

B_DDR2_DQM[1]F18

B_DDR2_DQM[0]E20

B_DDR2_DQS[1]D20

B_DDR2_DQS[0]E19

B_DDR2_DQSB[1]D19

B_DDR2_DQSB[0]E18

B_MDATA[15]D18

B_MDATA[14]F19

B_MDATA[13]C18

B_MDATA[12]G18

B_MDATA[11]G19

B_MDATA[10]C19

B_MDATA[9]F20

B_MDATA[8]C20

B_MDATA[7]B20

B_MDATA[6]G20

B_MDATA[5]A20

B_MDATA[4]H20

B_MDATA[3]H19

B_MDATA[2]B18

B_MDATA[1]H18

B_MDATA[0]B19

B_MADR[12]K20

B_MADR[11]C15

B_MADR[10]J20

B_MADR[9]K19

B_MADR[8]A16

B_MADR[7]J17

B_MADR[6] D15

B_MADR[5]H17

B_MADR[4]B16

B_MADR[3]G17

B_MADR[2]D16

B_MADR[1]F17

B_MADR[0]C16

B_BADR[2]K17

B_BADR[1]E17

B_BADR[0]J19

B_MCLKA19

B_MCLKZA18

B_MCLKEJ18

B_ODTC17

B_WEZD17

B_RASZB17

B_CASZA17

PCM_A[0]

PCM_A[1]

PCM_A[2]

PCM_A[3]

PCM_A[4]

PCM_A[5]

PCM_A[6]

PCM_A[7]

PCM_A[8]

PCM_A[9]

PCM_A[10]

PCM_A[11]

PCM_A[12]

PCM_D[0]

PCM_A[13]

PCM_D[1]

PCM_A[14]

PCM_D[2]

PCM_D[3]

PCM_D[4]

PCM_D[5]

PCM_D[6]

TS_D[7]

TS_D[6]

TS_D[5]

TS_D[4]

TS_D[3]

TS_D[2]

TS_D[1]

TS_D[0]

PCM_D[7]

2 11MAIN_2

N e xt Re vi s i on Re a dy (S t a nd By 0 .2W)_080403

EAX57566204

for 1G Memory

for 1G Memory

2009 . 04 . 15

AIN_2



20/54


21/54

+1.8V_TU +3.3V_TU

0 1 F16V0.1uF

16V

C529

+3.3V_TU_CE+1.8V_TU_CE+1.8V_TU

+1.8V_TU_XE

CB3216PA501EL511

CB3216PA501E

L513 CB3216PA501E

L512


22/54





0 .1uF

50V

C5470.1uF

50V

C5480.1uF50V

C549

0.1uF50V

C550

0.1uF50V

C551

0.1uF50V

C552

0.1uF

50V

C5530.1uF

50V

C5540.1uF

50V

C5570.1uF

50V

C558

18pF50V

C502

+3.3V_TU_XE

TUNER_

SIF_

IF_

N

005:A11

0 .1uF

16V

C504

+1.8V_TU_XE

0.1uF

16V

C505

0.1uF

16V

C508

+3.3V_TU_XE

CM2012F2R2KT

L507

0 .1uF

16V

C509

0.1uF

C510

TUNER_

CVBS_

IF_P

0 .1uF16V

C512

0.1uF16V

C513

1000pF

50V

C514

18pF

50V

C515

0.1uF

C517

0.1uF

C518

+3.3V_TU_XE

0.1uF

16V

C519

+3.3V_TU_XE

+1.8V_TU_XE

4.99K1%R504

1000pF

50V

C521

0.1uFC522

+1.8V_TU_XE

0.1uF

16V

C525

+1.8V_TU_XE

IF_

AGC

0.1uF

C528

C529

56pF

50V

C532

SDA_

D_

TU

SCL_

D_

TU

XC5000_RESET_N

0

R508

SAM2333

D501

OPT

A2[GN]

C

A1[RD]

47KR509

OPT

33R510

+3.3V_TU_CE

+1.8V_TU_CE

DTV_

IF_

P

SCL_D_TU

TU_TS_CLK,TU_TS_DATA[0-7],TU_TS_SYNC,TU_TS_VAL

33R511

0 .1uF16V

R512

+1.8V_TU_CE

33R513

10KR515

22p

F

C538

OPT

+3.3V_TU_CE

0.1uF50V

C539

33

R516

33R517

33

R518

33R519

DTV_

IF_

N

0.1uF16V

R520

+3.3V_TU_CE

100K

OPTR521

CE6355_RESET_N

33

R522

33R523

0.1uF

16V

C541

+1.8V_TU_CE

10KR524

22p

F

C542

OPT

+1.8V_TU_CE

SDA_D_TU

10K

OPTR526

+3.3V_TU_CE

+3.3V_TU_CE

33R527

33

R528

33R529

10KR530

TU_SLEEP_MODE

0 .1uF16V

C544

OPT

+3.3V_TU_CE

1KR532

IF_AGC

0.1uF

C520

4.7K

R525

OPT

C568

+3.3V_TU_XE

0.1uF

16V

C1211

10R507

0.1uF

16V

C516

10uF

16V

C55510uF16V

C556

+3.3V_TU +3.3V_TU_XE

20.48MHz

X500

CB3216PA501EL510

0.1uF

16V

C524

0.1uF16V

C507

0.1

uF

16VC50

3

0 .1uF

16V

C501

0.1uF

16V

C526

0 .1uF

16V

C527

100R558

OPT

100R559

OPT

XC5000

IC500

1VDDA_1

2IN1

3GND_1

4IN2

5GND_2

6EXTCHOKE

7GND_3

8VDDA_2

9VDDA_3

10VDDC_1

11GND_4

12VDDC_2

13

VDDC_3

14

VDDA_4

15

VAGC

16

VIF

17

VDDA_5

18

SIF

19

GND_5

20

VDDC_4

21

VDDA_6

22

GND_6

23

VDDD_1

24

TESTMODE

25 DDI1

26 VDDC_5

27 DDI228 ADDRSEL29 X230 GND_731 X1

32 EXTREF

33 VDDD_2

34 SCL

35 SDA

36 GND_837

RESET

38

VI2C

39

VDDC_6

40

VREF_N

41

VREF_P

42

VDDC_7

43

VDDC_8

44

REXT

45

VDDA_7

46

GND_9

47

VDDC_9

48

VDDA_8

39pF

C531

0603CS-R27XGLW

270nH

L505

120pF

C530 0603CS-R39XGLW

390nH

L504

1008CS-821XGLC

820nHC546

27pF50V

C540

27pF50V

C543

22KR533

1nF50V

C545

0

R531

RCLAMP1521P

D502

OPT

0603CS-6N8XGLW6.8nHL508

CE6355

IC501

1VSS_1

2VDD_1

3VSS_2

4CLK1

5DATA1

6IRQ

7CVDD_1

8VSS_3

9RESET

10SLEEP

11STATUS

12SADD4

13VDD_2

14VSS_4

15SADD3

16SADD2

17

SADD1

18

SADD0

19

CVDD_2

20

VSS_

5

21

PLLVDD

22

PLLGND

23

XTI

24

XTO

25

VSS_

6

26

PLLTEST

27

OSCMODE

28

AVDD

29

AGND_1

30

VIN

31

VIN

32

AGND_2

33 VDD_3

34 RFLEV

35 CLK2/GPP0

36 DATA2/GPP1

37 CVDD_3

38 VSS_7

39 CVDD_4

40 VSS_8

41 AGC2/GPP2

42 AGC1

43 GPP3

44 SMTEST

45 VDD_4

46 VSS_9

47 MOSTRT

48 MOVAL

49

MDO0

50

MDO1

51

MDO2

52

MDO3

53

MDO4

54

VDD_5

55

VSS_

10

56

MDO5

57

MDO6

58

MDO7

59

CVDD_5

60

VSS_

11

61

MOCLK

62

BKERR

63

MICLK

64

CVDD_6

31.875MHz

X501

RCLAMP0502BD503 C1

A

C2

KCN-ET-0-0094

JK500

1

2

18pF

50V

C511

18pF

50V C

523

31.875MHz

X502

crystal_2

4GND_2

1

X-TAL_

1

2

GND_1

3X-TAL_

2

SC1_TV_VOUT

0.1uF

C566

+5V_TU

0.1uF16V

C561

+5V_TU

TUNER_CVBS_IF_P390

R552

ISA1530AC1

Q501

E

B

C

680R556

TV_CVBS+

001:M6

390

R550

ISA1530AC1

Q503

E

B

C

+5V_TU

2KR537

390

R541

ISA1530AC1

Q502

E

B

C

2SC3875S(ALY)

Q505

0.1uF

C560

10pFC567

100R538

SC1_VOUT_MUTE

KRA102SQ504

1

2

3

2.7uH

L502

0.1uF16V

C565

DTV_IF_P

680R555

+5V_TU

2.7uH

L501

0.1uF

C563

390

R554

SIF+

001:V7

+5V_TU

0R557

ISA1530AC1

Q506

E

B

C

390

R542

ISA1530AC1

Q507

E

B

C

DTV_IF_N005:Y4

0.1uF

C564

TUNER_SIF_IF_N 10pF

C562

1KR501

1KR502

TU_T

S_V

AL

TU_

TS_D

ATA[3]

TU_

TS_D

ATA[6]

TU_

TS_D

ATA[5]

TU_

TS_D

ATA[2]

TU_T

S_C

LK

TU_

TS_D

ATA[7]

TU_

TS_D

ATA[1]

TU_T

S_S

YNC

TU_

TS_D

ATA[0]

TU_

TS_D

ATA[4]

Tuner 5 1 1

EAX57566204

ACTIVE LOW

ACTIVE HIGH

NEED TO CHANGE NEW PAL SHIELD CASE

2008. 08 . 30

2. EMS S1 Improve

1 . F ra nc e A TV c ha nne l s k i p08.09.25 CHANGE LOAD CAP AND CRYSTAL

2009.04 .15

08.10.06 CHANGE LOAD CAP 22pF -> 27pF


C611

+5V_GENERAL

R634R613SCART1_DET 001:B6SC1_CVBS_IN

001:M6

10KR630

8OHM

L604

SCART SCART JACK is changed because of SCART DETECTION siganl.P IN 22 i s a dde d . 08 .07 .10


23/54

THE SYMBOL MARK OF THIS SCHEMETIC DIAGRAM INCORPORATESSPECIAL FEATURES IMPORTANT FOR PROTECTION FROM X-RADIATION.FILRE AND ELECTRICAL SHOCK HAZARDS, WHEN SERVICING IF ISESSENTIAL THAT ONLY MANUFATURES SPECFIED PARTS BE USED FORTHE CRITICAL COMPONENTS IN THE SYMBOL MARK OF THE SCHEMETIC.

11K

R629

1000pF50V

C603

OPT

10K

R637

560pF

50V

C637

56pF

50V

C611

DTV/MNT_L_OPOUT006:O3

12KR622

330pF

50V

C607

751%

R610

TV_R_OPOUT

006:AA9

2SC3875S(ALY)

Q606

E

B

C

0L607-*1

7 5 1%

R601 100uF

16V

C622

22R623

0L600-*1

SCART0OHM

3.9K

R633

0L611-*1

12K

R660

SC1_FB 001:M8

1KR634

SC_REC2

001:B6

7 5 1%

R602

10KR652

12KR657

2SC3875S(ALY)

Q604

E

B

C

15K

R635

751%

R613

12K

R639

0L606-*1

560pF50V

C610

10K

R632

0L608-*1

470K

R604

DTV/MNT_R_OPOUT

006:O8

560pF50V

C613

470K

R600

1000pF

50V

C623

OPT

56KR626

0L602-*1

SC2_ID

001:M11

SC1_R 001:M9

0L604-*1

100uF16V

C616

SC1_ID 001:V14

SC1_B 001:M9

SCART2_DET001:B6

1000pF50V

C626

OPT

751%

R648

470K

R643

10K

R667

SC1_TV_VOUT005:O6

56KR666

12K

R616

0 .1uF

16V

C620

0L603-*1

75R641

0L609-*1

68R612

SC2_L_IN

001:V19

10KR609

330pF50V

C609

0L601-*1

1K

R636

751%

R603

0.1uF16V

C644

330pF

50V

C630

REC_8 006:AB15

+5V_GENERAL

560pF50V

C639

10KR617

1KR670

56pF

50V

C635

2SC3875S(ALY)

Q605

E

B

C

470K

R645

1000pF

50V

C600

SC2_R_IN 001:V19

001:M6

10KR654

SC1_G 001:M9

330pF

50V

C632

CDS3C30GTH30V

D617

TV_L_OPOUT006:AA3

0R663

REC_8 006:K4

SC_REC1

001:B5

SC2_CVBS_IN001:M7

SC1_R_IN 001:V19

SC1_L_IN 001:V19

75R642

P_12V

P_12V

47uF16V

C631

47uF

16V

C625

47uF16V

C608

47uF16V

C602

0 .1uF

C619

6800pFOPT

C618

5 . 6K R 61 8

6.8KR614

33pFC617

TV_L_OPOUT

006:H11

LM324DIC600

3INPUT1+

2INPUT1-

4VCC

1OUT1

6INPUT2-

5INPUT2+

7OUT2 8 OUT3

9 INPUT3-

10 INPUT3+

11 GND

12 INPUT4+

13 INPUT4-

14 OUT4

DTV/MNT_L_OPOUT

006:Y13

10 K R 62 5

5.6KR631DTV/MNT_L_OUT

001:AB18

DTV/MNT_R_OUT

001:AB18

DTV/MNT_R_OPOUT

006:Y10

6.8K

R659

6800pFOPT

C615

10KR664

6800pFOPT

C614

6.8KR662

33pFC612

10KR658

3 3p F C 60 6

5.6KR653

P_12V

TV_R_OUT

001:AC15

TV_L_OUT001:AC15

5 . 6K R 65 1

6800pFOPT

C605

6.8KR624

3 3p F C 60 4

TV_R_OPOUT

006:H8

10 K R 61 1

11K

R669

DTV/MNT_V_OUT001:M6

82R6752SC3052

Q607

E

B

C

330

R680

2SC3052

Q601

E

B

C

330

R684

330

R688

1KR689

27K

R690

2SA1504SQ609

E

B

C

330

R686

2SC3052Q603

E

B

C

330

R683

2SA1504SQ602

E

B

C

82R682

330

R681

27K

R678

27K

R677

1KR672

470R671

2SC3052Q608

E

B

C

CB3216PA501EL612

0LCML00003B

120-ohmL605

8OHML608

8OHM

L609

BG2012B080TFL600

8OHM

BG2012B080TF

L607

8OHM

L603

8OHM

L602

BG2012B080TFL601

BG2012B080TF

L606

8OHM

L611

10uF16V

C645

10uF16V

C646

10K

R687

1.8KR673

0 .1uF

50V

C647

1KR693

6800pF

C650

1K

R692

6800pFC649

1KR691

6800pFC648

1KR694

6800pFC651

CB3216PA501EL613

0R695

OPT

0R697

OPT

JK600

1R_OUT

2R_IN

3L_OUT

4GND

5GND

6LIN

7B

8SC_ID

9.

10.

1111

1212

1313

1414

1515

1616

1717

1818

1919

2020

2121

23

23

2222

JK601

1R_OUT

2R_IN

3L_OUT

4GND

5GND

6L_IN

7.

8SC2_ID

9.

10.

1111

1212

1313

1414

1515

1616

1717

1818

1919

2020

2121

23

23

2222

0 .1uFC652

OPT

0.1uFC653

0 .1uFC654

OPT

0.1uFC655

330R696

330R674

47

R685

47

R676

GND

SCART 6 1 1

[SCART PIN 8]

5.19V / 10.91V_1Kohm(LOAD)

4.89V / 9.09V_120ohm(LOAD)

EAX57566204

Cha nge d 24K t o 11K be c a us e o f ID l e ve l

2008 . 07 . 11

NEED TO CHECK RESISTOR VALUE BECAUSE AUDIO OUTPUT

2008 . 08 . 30

2 0 0 9 . 0 4 . 1 5

ADD LPF IN AUDIO OUT 2008.10.24

CART


1KR725

FULL SPEC

+5V_GENERAL +3.3V_AVDD

10KR724

FULL SPEC

001 B7

RS232C

Component


24/54





30VD700

FULL SPEC

DDC_SCL/UART_RX 001:V6

100pF50V

C718FULL SPEC

CDS3C05GTA5.6V

OPT

D722

0.1uF50V

C713FULL SPEC

0.47uF25V

C730

75R727

FULL SPEC

PC_R_IN 001:V18

10K

R746FULL SPEC

75

R750

FULL SPEC

0.1uF50V

C724FULL SPEC

PEJ024-01

JK702

FULL SPEC

6B T_TERMINAL2

8 SHIELD_PLATE

7B B_TERMINAL2

5 T_SPRING

4 R_SPRING

7A B_TERMINAL1

6A T_TERMINAL1

3 E_SPRING

10KR776

FULL SPEC

COMP_Y 001:M12

22R734

FULL SPEC

100R744FULL SPEC

0.1uF

16V

C706

FULL SPEC

75

R753FULL SPEC

DSUB_HSYNC001:M10

100R761

30VD717

FULL SPEC

CDS3C30GTH30V

OPT

D710

S_DET001:B7

COMP_Pb 001:M11

12K

R742

FULL SPEC

4.7KR756

75

R713

FULL SPEC

75R707

FULL SPEC CDS3C05GTA

5.6VOPT

D712

KDS184D723FOR DEB

A2

C

A1

+3.3V_CI

75R728

FULL SPEC

10K

R739

FULL SPEC

JP712

470KR732

FULL SPEC

10KR712

FULL SPEC

CDS3C30GTH30V

D720FULL SPEC

82pF50V

C739

4.7K

R754

FOR DEB

PC_L_IN 001:V19

SIDE_Y_IN001:M7CDS3C30GTH

30VD704

FULL SPEC

CDS3C30GTHD729

100pF50V

C716FULL SPEC

10KR702

FULL SPEC

0R766

DSUB_B001:M10

+5V_USB_N

1K

R767FULL SPEC

0.47uF25V

C727

12KR777

FULL SPEC

DSUB_G001:M10

22R733

FULL SPEC

CDS3C30GTH

30VD703

FULL SPEC

COMP_Pr 001:M12

75R751

FULL SPEC

CDS3C30GTH30V

OPT

D711

100pF

50V

C717

FULL SPEC

0.1uF50V

C712FULL SPEC

0.47uF

25V

C729

CDS3C05GTA5.6V

OPTD728

+5V_GENERAL

100pF

C736FULL SPEC

0.47uF25V

C728

4.7K

R755

470KR775

FULL SPEC

CDS3C30GTHD730

30VD706

FULL SPEC

KCN-DS-1-0088JK704

1 2 3 4 5

6 7 8 9

10

30VD705

FULL SPEC

JP708

22R760FOR DEB

USB_DM001:W9

22R735FULL SPEC

+5V_GENERAL

10uF16V

C711

100pF50V

C715FULL SPEC

CDS3C05GTA5.6V

OPT

D725

10KR738

FULL SPEC

CDS3C05GTA5.6V

OPT

D724

10KR780

FULL SPEC10KR765FULL SPEC

CDS3C30GTH30V

D721FULL SPEC

18pF50V

C726

OPT

4.7KR757

FOR DEB

PPJ209-02

JK701

FULL SPEC

4A [GN]CONTACT

2A [GN]1P_CAN

3A [GN]O_SPRING

2B [BL]1P_CAN

5B [BL]C_LUG_L

2C [RD]1P_CAN1

5C [RD]C_LUG_L

2D [WH]1P_CAN

5D [WH]C_LUG_L

2E [RD]1P_CAN2

4E [RD]CONTACT

3E [RD]O_SPRING

RS232C_RXD001:O20

SIDE_C_IN

001:M7

SIDE_CVBS_IN

001:M7

PC_SER_CLK004:H12

75R726

FULL SPEC

JP7110R781

10R771

CDS3C05GTA5.6V OPT

D707

1KR770

USB_DP001:W9

10KR752

FULL SPEC

10KR736

FULL SPEC

82pF

50V

C740FOR RGB ROM D/L

USBDOWNSTREAM

KJA-UB-4-0004JK706

1

2

3

4

5

+5V_ST

SIDE_R_IN

001:V18

470KR731FULL SPEC

RS232C_TXD001:O20

12KR778

FULL SPEC

470KR730

FULL SPECCOMP_R_IN 001:V18

CDS3C30GTH30VD718FULL SPEC

CDS3C05GTA5.6VOPT

D713

DSUB_R001:M11

470K

R779FULL SPEC

MAX3232CDR

IC702

3

C1-

2

V+

4

C2+

1

C1+

6

V-

5

C2-

7

DOUT2

8

RIN2

9

ROUT2

10

DIN2

11

DIN1

12

ROUT1

13

RIN1

14

DOUT1

15

GND

16

VCC

100R745

FULL SPEC

22R748

FULL SPEC

CDS3C05GTA5.6V

OPT

D714

DDC_SDA/UART_TX001:O19;001:V6+5V_GENERAL

SIDE_L_IN

001:V18

470KR729FULL SPEC

JP709

18pF50V

C725

OPT

22R749FULL SPEC

CDS3C30GTH30V

D709

OPT

AT24C02BN-10SU-1.8

IC701FULLSPEC

3A2

2A1

4GND

1A0

5SDA

6SCL

7WP

8VCC

CDS3C30GTH

30V

D702

FULL SPEC

22pF50V

C720FULL SPEC

DSUB_VSYNC001:M10

0.1uF50V

C714FULL SPEC

0R762

OPT

22pF50V

C719FULL SPEC

75R706

FULL SPEC

PC_SER_DATA004:H12

0.47uF25V

C731

100R764

10KR737

FULL SPEC

12KR743FULL SPEC

JP710

COMP_L_IN 001:V18

22R758

FOR DEB

0R782

COMP_DET 001:B7

10KR769

CDS3C30GTH30V

D719

FULL SPEC

30VD701

FULL SPEC

10R768

SIDE_CVBS_DET

001:B8

1uF16V

C700

OPT

RGB_DET

PSJ015-02

JK705

FULL SPEC

5

4A

4B

4C

4D

3

7

+3.3V_AVDD

0R784

FULL SPEC

0R783

FULL SPEC

100pFC733

FULL SPEC

4.7KR740

FULL SPEC

4.7K

R741

FULL SPEC

CB3216PA501E

L701

KCN-DS-1-0089

JK703

FORDEB

1 2 3 4 5

6 7 8 9 10

11

12

13

14

15

16

270pF50V

C737FOR RGB ROM D/L

270pF

50V

C738

PPJ218-02

JK700

FULL SPEC

5C [RD]CONTACT

2C [RD]U_CAN

4C [RD]O_SPRING

2B [WH]U_CAN

3B [WH]C_LUG

2A [YL]U_CAN

5A [YL]CONTACT

4A [YL]O_SPRING

22R747

FULL SPEC 0

R785

PQ100

R786

PQ10

0

OPT

R787

0

OPT

R788

SMW250-04

P700PC_DEBUG

1

2

3

4

DDC_SCL/UART_RX 001:V6

DDC_SDA/UART_TX001:O19;001:V6

PPJ232-01

JK707

Dummy

1

2

3

4

I n t e r f a c e 7 11

PC

Side AV

PC AUDIO

USB

Side S-Video

2009 .04 .15EAX57566204

DUMMY_BODY

p


+5V_CI_Vs+5V_GENERAL

100R815

10K

R813

P800


25/54





R819 OPT R822 OPT0 . 1 u F

16V

C802

10KR816

0 . 1 u F

16V

C801CI_CD1

T S_ D[ 4 ]

T S_ D[ 5 ]

T S_ D[ 6 ]

T S_ D[ 7 ]

T S_ D[ 0 ]

T S_ D[ 1 ]

T S_ D[ 2 ]

T S_ D[ 3 ]

TS_CLK

TS_VALID

TS_SYNC

0 . 1 u F

16V

C808

PCM_D[0-7]

PCM_A[0-14]

PCM_RESET

10KR814

OPT47R808

47R809

10KR811

+5V_GENERAL

100R817

10KR812OPT

PCM_WAIT_N

PCM_REG_N

R820OPT

47R810

CI_CD2

0 . 1 u F16V

C803

47R838

PCM_CD_N

CI_CD1

CI_CD2

0 . 1 u F

16V

C811

+3.3V_CI

10uF

16V

C812

OPT

10KR827

OPT

+5V_GENERAL

0 . 1 u F 1 6 VC809

PCM_IRQA_N100R825

PCM_WE_N47R823

47R806

47R807PCM_IORD_N

PCM_IOWR_N

PCM_CE_N

PCM_OE_N47R824

10KR826OPT 47R829

47R830

TU_TS_SYNC

TU_TS_VAL

TU_TS_DATA[0]

TU_TS_CLK

74LVC541A(PW)

IC800

3A1

2A0

4A2

1OE1

6A4

5

A3

7A5

8A6

9A7

10GND

11Y7

12Y6

13Y5

14Y4

15Y3

16

Y2

17Y1

18Y0

19OE2

20VCC

BUF_TS_SYNC

BUF_TS_VAL

BUF_TS_DATA[0]

BUF_TS_CLK

+3.3V_CI

0 . 1 u F

16V

C800

10KR818

22K

R821

5V_CI_CTL

+5V_CI

0 . 1 u F

50V

C804

100uF16V

C806

0 . 1 u F

50V

C807

+5V_CI_Vs

0 . 1 u F

50V

C805

BUF_TS_CLK,BUF_TS_DATA[0],BUF_TS_SYNC,BUF_TS_VAL,TU_TS_DATA[1-7]

2010_A4

33AR834

2010_A4

33AR836

2010_A433

AR835

2010_A4

33AR837

33AR802

33AR801

33AR800

33AR805

33AR804

33AR803

33AR831

33AR832

RSR025P03

Q801

S D

G

KIC7SZ32FU

CMOS

I C 8 0 2

3GND

2IN_A

4 OUT_Y

1IN_B 5 VCC

2SC3052

Q800

E

B

C

10K

R831

47uF16V

C813

OPT

10067972-050LF

G1G2

57

21

52

16

10

47

41

5

36

59

23

45

54

18

49

43

13

7

38

2

25

56

20

51

15

9

46

40

4

35

58

22

53

17

11

48

42

12

6

37

1

24

55

19

50

44

14

8

39

3

2660

2761

2862

2963

3064

31

32

33

34

65

66

67

68

33K

R1254

CB3216PA501E

L800

BUF_TS_SYNC

BUF_TS_VAL

TU_TS_DATA[1]

TU_TS_DATA[2]

TU_TS_DATA[3]

TU_TS_DATA[4]

TU_TS_DATA[5]

TU_TS_DATA[6]

TU_TS_DATA[7]

BUF_TS_CLK

PCM_D[3]

PCM_D[4]

PCM_D[5]

PCM_D[6]

PCM_D[7]

PCM_D[0]

PCM_D[1]

PCM_D[2]

PCM_A[11]

PCM_A[10]

PCM_A[9]

PCM_A[8]

PCM_A[14]

PCM_A[13]

PCM_A[12]

PCM_A[7]

PCM_A[6]

PCM_A[5]

PCM_A[4]

PCM_A[3]

PCM_A[2]

PCM_A[1]

PCM_A[0]

BUF_TS_DATA[0]

PCMCIA 8 11

2009.04 .15EAX57566204

CMCIA


HDMI


26/54





D1-_HDMI3 001:O15

D1-_HDMI1 001:O18

DDC_SDA_3 009:AB7;001:V5

0 .1uFC908FULL SPEC

68K

R928FULL SPEC

AT24C02BN-10SU-1.8

IC903

FULL SPEC

3A2

2A1

4GND

1A0

5SDA

6SCL

7WP

8VCC

47KR933

FULL SPEC

100R951

FULL SPEC

MMBD301LT1G

30V

D904FULL SPEC

2SC3875S(ALY)

Q902

FULL SPEC

E

B

C

CK-_HDMI1 001:O17

HPD1 001:V4

D2+_HDMI3 001:O14

GND

1KR906

FULL SPEC

GND

DDC_SCL_1 009:AB15;001:V6

100R949

CEC_REMOTE 009:F8;009:W4

DDC_SDA_1009:N17;001:V6

HPD3 001:V4

5V_HDMI_1

CK-_HDMI3 001:O14

DDC_SCL_3009:R7;001:V5

5V_HDMI_35V_HDMI_3

D2-_HDMI3 001:O14

100R950

FULL SPEC

10KR930

FULL SPEC

HDMI_CEC 00 2:B1 1

DDC_SDA_1 009:AB15;001:V6

D0+_HDMI1 001:O18

D2+_HDMI1 001:O17

D1+_HDMI3 001:O14

D1+_HDMI1 001:O18

0 .1uF

50V

C900

KDS184

D901

A2

C

A1

100R948

1KR900

D0-_HDMI1 001:O18

CEC_REMOTE009:F8;009:L16

CK+_HDMI1 001:O17

AT24C02BN-10SU-1.8

IC901

3A2

2A1

4GND

1A0

5SDA

6SCL

7WP

8VCC

GND

10KR901

47KR931

FULL SPEC

KDS184

D903

FULL SPEC

A2

C

A1

5V_HDMI_1

BSS83

Q900

FULL SPEC

S B D

G

D0+_HDMI3 001:O15

0R907

27K

R935

OPT

0 .1uF

50V

C901

FULL SPEC

2SC3875S(ALY)

Q901

E

B

C

47K

R913

47KR916

0 .1uFC903

CK+_HDMI3 001:O14

D2-_HDMI1 001:O17

D0-_HDMI3 001:O15

OPT

D902

DDC_SCL_3 009:AB8;001:V5

DDC_SDA_3009:R8;001:V5

+3.3V_VDDP_ST

DDC_SCL_1009:N17;001:V6

100R923

FULL SPEC

5V_HDMI_2

0 .1uFC905FULL SPEC

KDS184

D905FULL SPEC

A2

C

A1

47KR922

FULL SPEC

47KR917

FULL SPEC

DDC_SCL_2

009:G8;001:V5

100R921FULL SPEC

DDC_SDA_2009:G8;001:V6

AT24C02BN-10SU-1.8

IC902

FULL SPEC

3A2

2A1

4GND

1A0

5 SDA

6SCL

7WP

8VCC

D0-_HDMI2 001:O1 7

D0+_HDMI2 001:O16

DDC_SCL_2009:AB11;001:V5

1KR920

FULL SPEC

0 .1uF

50V

C904

FULL SPEC

CEC_REMOTE 009:L16;009:W4

D1-_HDMI2 001:O16

CK-_HDMI2 001:O15

D2-_HDMI2 001:O16

CK+_HDMI2 001:O1 5

D1+_HDMI2 001:O16

GND

2SC3875S(ALY)

Q904

FULL SPEC

E

B

C

5V_HDMI_2

0R918

FULL SPEC

10KR924

FULL SPEC

D2+_HDMI2 001:O16

HPD2

001:V4

DDC_SDA_2009:AB11;001:V6

+5V_ST

+5V_ST

+5V_ST

JK901

1D2+

2D2_GND

3D2-

4D1+

5D1_GND

6D1-

7D0+

8D0_GND

9D0-

10CK+

11

12

13

14

15

16

17

18

19

20GND

21GND

22

JK903

FULL SPEC

1D2+

2D2_GND

3D2-

4D1+

5D1_GND

6D1-

7D0+

8D0_GND

9D0-

10CK+

11

12

13

14

15

16

17

18

19

20GND

21GND

22

JK902

FULL SPEC

14 NC

13 CEC

5 DATA1_SHIELD

20

JACK_GND

12 CLK-

11 CLK_SHIELD

2 DATA2_SHIELD

19 HPD

18 +5V_POWER

10 CLK+

4 DATA1+

1 DATA2+

17 DDC/CEC_GND

9 DATA0-

8 DATA0_SHIELD

3 DATA2-

16 SDA

7 DATA0+

6 DATA1-

15 SCL

HDMI 9 11

HDMI1

HDMI3

SIDE HDMI

2009.04 .15EAX57566204

HDMI2

HDMI


AMP


27/54





SPDIF_OUT001:V12

Fiber

Optic

JST1223-001

JK1000

1GND

2VCC

3VINPUT

4

FIX_POLE

0.1uF50V

C1005

+5V_GENERAL+5V_GENERAL

3. 3R1017

MS_LRCK001:Z13

0R1006

+3.3V_DVDD

0.01uF

C1012

0.01uF

C1025

3. 3

R1019

DBF-0822DM

EAP53148301

L1000

2S

1S 1F

2F

33

R1005

SDA_SUB/AMP004:H16;001:Y15

2200pF

C1015

22K

R1004

0.01uFC1036

0.01uF

C1024

AC_DET011:I17;001:V10

+3.3V_AU_AVDD

0.0

47uF

C1014

1000pF

OPT

C1002

200

1%

R1010

0.033uF

50V

C1020

470

R1013

18K

1%

R10120.033uF

50V

C1028

0.1uFC1016

0.01uFC1035

1uF

C1018

AVSS

AVSS

4700pFC1011

MS_SCK001:Z13

+3.3V_DVDD

470

R1014

0.1uF

C1003

33R1008

100

R1002OPT

22K

R1015

0. 033uF50V

C1019

0. 033uF50V

C1027

AMP_RST

001:O19

3. 3R1016

DBF-0822DM

EAP53148301

L1001

2S

1S 1F

2F

0. 01uF

C1022

+3.3V_DVDD

MUTE001: F 9

SCL_SUB/AMP004: H 16; 001: Y 14

AUDIO_MASTER_CLK

001: Z 13

0. 047uF

C1009

0. 01uF

C1004

2K

OPT

R1007

MS_LRCH001: Z 12

+3.3V_DVDD

P_17V

10uF 16V

C1010

+3.3V_AU_AVDD

0. 01uF

C1037

33R1009

0. 01uFC1021

1KR1003

P_17V

10uF 16V

C1001

0. 01uF

C1038

33pF

OPT

C1008

AVSS

3. 3R1018

1uF

C1017

0

OPT

R1011

33pF

OPT

C1007

1000pF

50V

OPT

C1000

4700pF

C1013

+3.3V_CI

0R1001

OPT

AVSS

0.33uF

C1029

0.33uF

C1030

0.33uF

C1033

0.33uFC1034

0.33uF

C1032

0.33uFC1031

47uFC1043

47uFC1026

47uFC1045

47uF

C1046

47uF

C1023

47uF

C1044

120-ohm

L1003

120-ohm

L1002

TAS5709PHPR

IC1000

1OUT_A

2PVDD_

A_

1

3PVDD_

A_

2

4

BST_A

5GVDD_OUT_

1

6

SSTIMER

7

OC_

AD

J

8

NC

9

AVSS

10PLL_FL

TM

11

PLL_F

LTP

12VR_A

NA

13AVDD

14TESTOUT

15MCLK

16OSC_RES

17DVSS_1

18VR_DIG

19PDN

20LRCLK

21SCLK

22

SDIN

23SDA

24SCL

25

RESET

26

STEST

27

DVDD

28

DVSS_

2

29

GND

30

AGND

31

VREG

32

GVDD_O

UT_2

33

BST_

D

34

PVDD_D_

1

35

PVDD_D_

2

36

OUT_

D

37 PGND_CD_1

38 PGND_CD_2

39 OUT_C

40 PVDD_C_1

41 PVDD_C_2

42 BST_C

43 BST_B

44 PVDD_B_1

45 PVDD_B_2

46 OUT_B

47 PGND_AB_1

48 PGND_AB_2

10uF16V

C1006

SMW250-04Q

P1000

1

2

3

4

5

4.7K

R1000

O

PT

100pF50V

C1047

AMP 10 11

SPDIF OPTIC JACK

PULLDOWN

This par t s a re Loca tedon AVSS area.

Separate DGND AND AVSS

SPK_L+

2009.04 .15EAX57566204

SPK_R-

SPK_L-

SPK_R+

AMP


+3.3V_VDDP_ST100uF25V

C1106

P_17V

+3.3V_AVDD_MEMPLL0.1uF50V

C1105

+5V ST

+3.3V_VDDP_ST

+3.3V_VDDP+3.3V_AVDD

CB3216PA501EL1119

CB3216PA501EL1109

CB3216PA501EL1113

IC1105

Stand-by&Multi +3.3V_+1.25V_MST_CorePOWER

Change LDO because of PM REV.2008. 09. 04

FOR 0.2W


28/54





0.1uF

50V

C1166

0.01uF50V

C1138

0 .1uF50V

C1149

0 .1uF

50V

C1129

1/4W

0

5%

R1133

0 .1uF

50V

C1147

0 .1uF50V

C1139

0.1uF50V

C1170

47uF16V

C1165

VAVS_ON

001:V15

0 .1uF50V

C1168

+5V_ST

0.1uFC1107

+3.3V_AVDD_LPLL

+3.3V_AVDD_MPLL

0.01uF50V

C1196

0 .1uF

50V

C1127

0.1uF

50V

C1174

+1.25V_MULTI

0 .1uF50V

C1191

AZ1117D-1.8TRE1

IC1104

1

ADJ/GND

2 OUTPUT3INPUT

0.01uF50V

C1169

0.01uF50V

C1123

+5V_GENERAL

0.01uF50V

C1144

0.1uF

50V

C1195

1/4W

0

5%

R1134

0 .1uF

50V

C1145

0 .1uF

50V

C1153

0 .1uF

50V

C1186

+5V_CI

+1.25V_VDDC

AZ1085S-ADJTR/E1

IC1107

1

ADJ/GND

2 OUTPUT3INPUT

100uF

16V

C1130

100

R1157

+3.3V_AVDD_ADC

22K

R1159OPT

4.7KR1148

+3.3V_AVDD_OTG

0.1uF50V

C1133

0 .1uF50V

C1189

+3.3V_CI

+5V_ST

0.1uFC1109

+3.3V_AVDD_AU

10KR1122

+1.25V_MULTI

47uF16V

C1167

0 .1uF

50V

C1141

15pF50V

C1103

15pF50V

C1112

0 .1uF

50V

C1183

0 .1uF

50V

C1181

+5V_SYS

2SC3875S(ALY)

Q1101

E

B

C

5V_MNT

001:V11

0.1uF

50V

C1175

+5V_ST

100

R1143

+1.8V_TU

39

1%

R1139

0.1uF

50V

C1172

25V

0.1uF50V

C1197

0 .1uF

50V

C1151

100uF

16V

C1182

0.1uF

50V

C1136 0 .1uF

50V

C1124

0 .1uF

50V

C1131

0.1uF50V

C1190

22K

R1125

0 .1uF50V

C1193

0.01uF50V

C1178

AC_DET

010:C12;001:V10

RL_ON

001:V15

+3.3V_TU

0.1uF

50V

C1194

+1.8V_DDR2_MAIN

0.01uF

50V

C1171

AZ1117D-3.3TRE1

IC1103

1

ADJ/GND

2 OUTPUT3INPUT

0.01uF50V

C1140

100uF16V

C1108

0 .1uF

50V

C1179

+3.3V_AVDD

0.1uF50V

C1134

+3.3V_AVDD

+3.3V_AVDD_VIF

+5V_TU

0.47uFC1102

50V

+1.25V_AVDD_DVI

100

R1156

+5V_ST

0.01uF50V

C1173

0.01uF50V

C1132

0.01uF50V

C1135

P_12V

0.1uF

50V

C1125

5V_ON

001:V12

AZ1085S-ADJTR/E1

IC1102

1ADJ/GND

2 OUTPUT3INPUT +3.3V_AVDD_DVI

+1.8V_EXPANDER

+3.3V_EXPANDER

100uF

16V

C1126

47uF16V

C1148

47uF16V

C1150

POWER_ON/OFF1

0.1uF50V

C1155

+5V_SYS

0.1uF50V

C1142100uF16V

C1156

+3.3V_AVDD

+3.3V_AVDD

1K1%

R1130

221%

R1128

+3.3V_VDDP_ST

AZ1085S-3.3TR/E1

IC1106

1

ADJ/GND

2 OUTPUT3INPUT

+5V_SYS

1/10W360

1%

R1120

1/10W4.3K

1%

R1121

SMW200-24CP1100

19

14

9

4

18

13

8

3

17

12

7

2

16

11

6

1

20

15

10

5

21 22

23 24

0 .1uFC1201

100uF16V

C1200

+5V_MULTI

+5V_MULTI

100R1160

RSR025P03Q1102

S

D

G

0.1uF50V

C1111

0 .1uF50V

C1203

0 .1uF50V

C1202

KEY_ON

004:T815pF50V

C1206

47uF

16V

C1210

+5V_TU

0.1uF50V

C1209

0 .1uF

50V

C1207

10uF16V

C1159

OPT

1/10W1.8K

5%

R1126

120-ohm

L1103

CB4532UK121E

470uF16V

C1188

100uF

16V

C1122

220uF16V

C1110

CB3216PA501EL1120

CB3216PA501E

L1117

CB3216PA501EL1114

CB3216PA501EL1100

CB3216PA501EL1102

CB3216PA501EL1101

CB3216PA501EL1125

CB3216PA501EL1106

CB3216PA501EL1121

CB3216PA501EL1126

CB3216PA501EL1108

CB3216PA501EL1115

CB3216PA501EL1111

CB3216PA501E

CB3216PA501EL1116

CB3216PA501EL1112

0 .1uF50V

C1212

0 .1uF

50V

C1128

15pF

50V

C1104

100uF

16V

C1213

AP2121N-3.3TRE1

IC1105

1

GND

2 VOUT3VIN

821%

R1140

10uF

16VC1137

Power 11 11

R2

V0 = 1.25(1+R2/R1)

+3.3V_AVDD

V0 = 1.25(1+R2/R1)

TUNER_CI +3.3V & +1.8V

+1.8V_DDR

R1

R2

DDR2 1.8V POWER change to ADJ TYPE_080402

R1

EXPANDER POWER 3.3V & 1.8V

2008. 07. 10Change LDO because of PM REV.MUST BE checked current spec.

PM Control

EAX57566204

PM for GPIO4

! B

5V MULTI

KEY ON(NEW POWER B/D

2009 .04 .15

OWER



29/54


30/54

PDP TV Repair Process Index- Trouble shooting by worst symptom

A. Picture Problem

8No sound/ Sound distort ionC. Sound Problem8

No. Symptom (L) Symptom (M) Page Remark

1 No Picture/Sound OK 1

2 No Picture/No sound 2

3 Mal-discharge/Noise/dark picture 3

4 Picture broken/Freezing 4

5 Vertical bar/ Horizontal Bar 5

6B. Power Problem

No Power (Not turn on) 6

7 Turn off (Instant, under watching) 7

9 E. General function Problem Remote control & Local switch checking 9

First of all, Check whether there is SVC Bulletin in GCSC System for these model.


Repair Process


31/54

Making

Repair Process

Revision

2009. 2 . 1

1/9PDP TV Symptom

A. Picture Problem

No Picture/Sound OK

1

-VY VSC VZB

Check Module pattern

by using TILT key

on SVC R/CNormal

N

Check

Vs, Va

YNormal

N

Check voltage

. -VY

. VSC

. VZB

Refer to the Module label for each voltage

Y

N

Documents

LG PD92A CHASSIS 42PQ1100 PLASMA TV SM.pdf