Embed Size (px)
Citation preview
Page 1 of 1
11/30/2010https://www.lennoxdavenet.net/apps/rph/graphics/G23-1.gif
LENNOXOEMPARTS.COM
G23Q2/3-75 11/30/2010 Page 1
G23Q2/3-75 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
Category:CABINET PARTS
BUSHING-SNAP 64K0001 SIGHT1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1
PANEL-SET LB-95970A HEAT & BLR ACCESS SET INCLHANDLE(Q2/3) 1 1
PANEL-SET LB-95970C HEAT & BLR ACCESS SET INCLHANDLE(Q4/5) 1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1 1 1
CLIP 18J2501 FILTER2 2 2 2 2 2
FILTER 31J8101 "14"" X 25"" X1"",WASHABLE(Q2/3)" 1 1 1 1 1 1
FASTENER 42J7801 FILTER DOOR2 2 2 2 2 2
DOOR LB-63005 FILTER(Q4/5)1 1 1 1 1 1
DOOR LB-65608 FILTER(Q2/3)1 1 1 1 1 1
CLIP LB-65612 REAR-FILTER1 1 1 1 1 1
FILTER P-8-7831 "20"" X 25"" X1"",WASHABLE(Q4/5)" 1 1 1 1 1 1
1 PANEL LB-64637 HEAT ACCESS-LOUVER(Q2/3)1 1 1 1
1 PANEL LB-64695 HEAT ACCESS-LOUVER(Q4/5)1 1 1 1
2 PANEL LB-64363A BLOWER ACCESS(Q2/3)1 1 1 1
2 PANEL LB-64363C BLOWER ACCESS(Q4/5)1 1 1 1
3 PANEL LB-63559 CAB TOP(Q4/5)1 1 1 1 1 1
3 PANEL LB-64631 CAB TOP(Q2/3)1 1 1 1 1 1
4 GASKET LB-65617 CAB TOP(Q2/3)1 1 1 1 1 1
4 GASKET LB-65618 CAB TOP(Q4/5)1 1 1 1 1 1
5 COVER LB-64237 "CONTROL BOX (6""HEIGHT)"1 1 1 1
5 COVER LB-90698 "CONTROL BOX (7""HEIGHT)"1 1 1 1
Category:HEATING PARTS
PLATE-CORBEL LB-91527 LP1 1
ORIFICE-BURNER LB-74093 NAT(DRILL SIZE .0917)3 3 3 3 3 3
LENNOXOEMPARTS.COM
G23Q2/3-75 11/30/2010 Page 2
G23Q2/3-75 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
ORIFICE-BURNER LB-83508 LP(DRILL SIZE 1.45MM)3 3 3 3 3 3
ORIFICE-PILOT 31J9101 LP1 1 1 1
BRACKET LB-68602A PILOT1 1 1 1
LEAD W082201030 FLAME SENSOR1 1 1 1 1 1
PLUG 25J5801 "PLASTIC 1/2"""1 1 1 1 1 1
TEE 31J7701 "PLASTIC 1/4"""1 1 1 1 1 1
HARNESS-WIRING LB-73867 MAKE UP BOX1 1 1 1 1 1
KIT-TUBING LB-96015A PRESS SWITCH1 1 1 1 1 1
BRACKET LB-90702 BRACKET - HSI1 1
10 HEAT EXCHANGER LB-65729B (Q2/3 X UNITS)1 1 1 1
10 HEAT EXCHANGER LB-65729F (Q4/5 X UNITS)1 1 1 1
10 HEAT EXCHANGER LB-91001B (Q2/3 UNITS)1 1 1 1 1 1
10 HEAT EXCHANGER LB-91001F (Q4/5 UNITS)1 1 1 1 1 1
11 BAFFLE LB-64660A HEAT EXCHANGER(X UNITS)3 3 3 3
12 DIVERTER LB-64617 BOX-FLUE1 1 1 1 1 1
13 GASKET LB-65609 DIVERTER1 1 1 1 1 1
14 SWITCH-ROLLOUT 31J9501 MANUAL RESET(X UNITS)1 1
14 SWITCH-MANUAL 31J9601 MANUAL RESET1 1 1 1
14 SWITCH 71G1201 MANUAL RESET1 1
15 BURNER-MAIN LB-64500B CLUSTER ASSY1 1 1 1 1 1
16 MANIFOLD-GAS LB-63016B LESS ORIFICES1 1 1 1 1 1
18 VALVE-GASLP(FOOTNOTE 1)1 1 1 1 1 1
18 VALVE-GAS 31L3701 "NAT,L/IGN CTL 1/2""(WRODGERS)" 1
18 VALVE-GAS 31L8201 "NAT, L/IGN CTL1/2""(HONEYWELL)" 1
18 VALVE-GAS 41K3701 "NAT,L/IGN CTL-1/2"" H'WELL"1 1
18 VALVE-GAS 58K7301 "NAT,L/IGN CTL 1/2"" (WRODGERS W/TOGGLE 1 1
LENNOXOEMPARTS.COM
G23Q2/3-75 11/30/2010 Page 3
G23Q2/3-75 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
18 VALVE-GAS 93J5101 "NAT,L/IGN CTL 1/2"" (WRODGERS BLUE MAN 1
19 BURNER-PILOT 69J3701 PILOT W/ELECTRODE .1 1 1 1
19 BURNER-PILOT 81J0501PR PILOT CONVERSIONKIT-CONVERTS UNIT TO BR 1 1 1 1
20 SENSOR-FLAME 18G8901 SENSOR-FLAME1 1 1 1
20 SENSOR-FLAME KIT LB-94701A INCLUDES SENSOR & BRACKET1 1
21 CONTROL-LIMIT 18J3701 "OUT 205F,IN 175F,SPST(Q4/5)(FOOTNOTE 5 1 1 1 1
21 CONTROL-LIMIT 25J3001 "OUT 125F,IN 155F,SPST(Q2/3)"1 1
21 CONTROL-LIMIT 73K1801 "OUT 140F,IN 170F,SPST(Q2/3)"1 1 1 1
21 CONTROL-LIMIT 79J2301 "OUT 195F,IN 165F,SPST(Q4/5) &X UNITS)" 1 1 1 1 1 1
22 SWITCH-PRESS 18J3301 ".34WC,SPST,N.O."1 1 1 1
22 SWITCH-PRESS 67K3201 ".34WC,SPST,N.O."1 1
23 IGNITOR 41K5601 IGNITOR1 1
Category:INDUCED DRAFT ASSEMBLY
40 BLOWER-COMB AIR LB-65734C COMPLETE ASSY ONLY1 1 1 1 1 1
41 GASKET LB-65611 COMB AIR1 1 1 1 1 1
42 ADAPTER LB-65403B FLUE TRANSITION1 1 1 1 1 1
43 GASKET LB-65616 FLUE OUTLET1 1 1 1 1 1
Category:CONTROL PANEL PARTS
BOARD-CIRCUIT 24L8501 INTEGRATED CONTROL1 1
HARNESS-WIRING LB-100429A KIT REPLACES UPPER & LOWER1 1
HARNESS-WIRING LB-94615 UPPER1 1
HARNESS-WIRING LB-94616 LOWER1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2
HARNESS-WIRING LB-73864 CONTROL-UPPER(J20)1 1 1 1
HARNESS-WIRING LB-73865 CONTROL-LOWER(P20 TO J20)1 1 1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2 2 2
LENNOXOEMPARTS.COM
G23Q2/3-75 11/30/2010 Page 4
G23Q2/3-75 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
17 CONTROL-IGN LB-90087A 24V1 1
17 CONTROL-IGN LB-90701A 24V1 1
30 TRANSFORMER 42J3201 "120V PRI,24V SEC,40VA,L/FUSE"1 1 1 1 1 1
31 BREAKER-CIRC 37J5601 250V1 1 1 1 1 1
32 SWITCH 25J1301 SWITCH, INTERLOCK1 1 1 1 1 1
33 BOARD-CIRCUIT LB-90089A CONTROL-BCC1 1 1 1
Category:BLOWER PARTS FOR Q2/3 BLOWER
PLATE-CUTOFF LB-65691 CUTOFF PLATE1 1 1 1 1 1
HARNESS-WIRING LB-73868 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790A HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 21L9201 "1/3HP,1075RPM,115/60/1,W/MOUNTS" 1 1
51 MOTOR-BLOWER 37J2501 "1/3HP,1075RPM,115/60/1,W/MOUNTS" 1 1 1 1
52 WHEEL-BLOWER LB-29333BJ "1/2""BORE,10"" X 8"""1 1 1 1 1 1
53 CAPACITOR-BLR MTR 59C9201 "5MFD,370VAC"1 1 1 1 1 1
Category:BLOWER PARTS FOR Q4/5 BLOWER
PLATE-CUTOFF LB-65856 CUTOFF PLATE1 1 1 1 1 1
MOUNT-MOTOR LB-97863A MOTOR FRAME SECTION SA3 3 3 3 3 3
HARNESS-WIRING LB-73870 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790H HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 28F0101 "3/4HP,1075RPM,115/60/1L/MOUNTS" 1 1
51 MOTOR-BLOWER 45H3301 "3/4HP,1075RPM,115/60/1L/MOUNTS" 1 1 1 1
52 WHEEL-BLOWER LB-29333BBP "1/2"" BORE,11-1/2"" X 9"""1 1 1 1 1 1
53 CAPACITOR 39H5801 "40MFD,370VAC"1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q2/3-75 11/30/2010 Page 5
NOTE
Note1:ORDER 41K3701 NATURAL GAS VALVE AND 48G2201 LP CONVERSION KIT.Note2:ORDER 93J5101 OR58K7301 NATURAL GAS VALVE AND 28G6101 LP CONVERSIONKIT.Note3:ORDER 31L8201 NATURAL GAS VALVEAND 48G2201 LP CONVERSION KIT.Note4:ORDER 31L3701 NATURAL GAS VALVE AND 28G6101 LPCONVERSION KIT.Note5:DASH 3,4,5,6 NON-NOX UNITS WERE MANUFACTURED WITH 79J2301. USE 18J3701ASA REPLACEMENT.
LENNOXOEMPARTS.COM
G23Q2-50 11/30/2010 Page 1
G23Q2-50 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
Category:CABINET PARTS
BUSHING-SNAP 64K0001 SIGHT1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1
PANEL-SET LB-95970A HEAT & BLR ACCESS SET INCLHANDLE 1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1 1 1
CLIP 18J2501 FILTER2 2 2 2 2 2
FILTER 31J8101 "14"" X 25"" X 1"",WASHABLE"1 1 1 1 1 1
FASTENER 42J7801 FILTER DOOR2 2 2 2 2 2
DOOR LB-65608 FILTER1 1 1 1 1 1
CLIP LB-65612 REAR-FILTER1 1 1 1 1 1
1 PANEL LB-64637 HEAT ACCESS-LOUVER1 1 1 1
2 PANEL LB-64363A BLOWER ACCESS1 1 1 1
3 PANEL LB-64631 CAB TOP1 1 1 1 1 1
4 GASKET LB-65617 CAB TOP1 1 1 1 1 1
5 COVER LB-64237 "CONTROL BOX (6""HEIGHT)"1 1 1 1
5 COVER LB-90698 "CONTROL BOX (7""HEIGHT)"1 1 1 1
Category:HEATING PARTS
PLATE-CORBEL LB-91526 LP1 1
ORIFICE-BURNER LB-74093 NAT(DRILL SIZE .0917)2 2 2 2 2 2
ORIFICE-BURNER LB-83508 LP(DRILL SIZE 1.45MM)2 2 2 2 2 2
ORIFICE-PILOT 31J9101 LP1 1 1 1
BRACKET LB-68602A PILOT1 1 1 1
LEAD W082201030 FLAME SENSOR1 1 1 1 1 1
PLUG 25J5801 "PLASTIC 1/2"""1 1 1 1 1 1
TEE 31J7701 "PLASTIC 1/4"""1 1 1 1 1 1
HARNESS-WIRING LB-73867 MAKE UP BOX1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q2-50 11/30/2010 Page 2
G23Q2-50 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
KIT-TUBING LB-96015A PRESS SWITCH1 1 1 1 1 1
BRACKET LB-90702 BRACKET - HSI1 1
10 HEAT EXCHANGER LB-65729A "(Q2,Q3 X UNITS)"1 1 1 1
10 HEAT EXCHANGER LB-91001A (Q3 UNITS)1 1 1 1 1 1
10 HEAT EXCHANGER LB-96300A (Q2 UNITS)1 1 1 1 1 1
11 BAFFLE LB-64660A HEAT EXCHANGER(X UNITS)2 2 2 2
12 DIVERTER LB-64617 BOX-FLUE1 1 1 1 1 1
13 GASKET LB-65609 DIVERTER1 1 1 1 1 1
14 SWITCH-MANUAL 31J9601 MANUAL RESET1 1 1 1 1 1
15 BURNER-MAIN LB-64500A CLUSTER ASSY1 1 1 1 1 1
16 MANIFOLD-GAS LB-63016A LESS ORIFICES1 1 1 1 1 1
18 VALVE-GASLP(FOOTNOTE 1)1 1 1 1 1 1
18 VALVE-GAS 31L3701 "NAT,L/IGN CTL-1/2""(WRODGERS)" 1
18 VALVE-GAS 31L8201 "NAT,L/IGNCTL-1/2""(HONEYWELL)" 1
18 VALVE-GAS 41K3701 "NAT,L/IGN CTL-1/2"" H'WELL"1 1
18 VALVE-GAS 58K7301 "NAT,L/IGN CTL 1/2"" (WRODGERS W/TOGGLE 1 1
18 VALVE-GAS 93J5101 "NAT,L/IGN CTL 1/2"" (WRODGERS W/BLUE M 1
19 BURNER-PILOT 69J3701 "W/ELECTRODE,L/SENSOR(INCL IGN WIRE)" 1 1 1 1
19 BURNER-PILOT 81J0501PR PILOT CONVERSION KITCONVERTS UNIT TO BR 1 1 1 1
20 SENSOR-FLAME 18G8901 SENSOR-FLAME1 1 1 1
20 SENSOR-FLAME KIT LB-94701A INCLUDES SENSOR & BRACKET1 1
21 CONTROL-LIMIT 25J2701 "OUT 150F,IN 120F,SPST"1 1
21 CONTROL-LIMIT 73K1801 "OUT 170F,IN 140F,SPST(Q3)"1 1 1 1
21 CONTROL-LIMIT 73K1901 "OUT 160F,IN 130F,SPST(Q2)"1 1 1 1
22 SWITCH-PRESS 18J3301 ".34WC,SPST,N.O."1 1 1 1
22 SWITCH-PRESS 67K3201 PRESSURE SWITCH1 1
LENNOXOEMPARTS.COM
G23Q2-50 11/30/2010 Page 3
G23Q2-50 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
23 IGNITOR 41K5601 IGNITOR1 1
Category:INDUCED DRAFT ASSEMBLY
40 BLOWER-COMB AIR LB-65734B COMPLETE ASSY ONLY1 1 1 1 1 1
41 GASKET LB-65611 COMB AIR1 1 1 1 1 1
42 ADAPTER LB-65403A FLUE TRANSITION1 1 1 1 1 1
43 GASKET LB-65616 FLUE OUTLET1 1 1 1 1 1
Category:CONTROL PANEL PARTS
BOARD-CIRCUIT 24L8501 INTEGRATED CONTROL1 1
HARNESS-WIRING LB-100429A KIT REPLACES UPPER & LOWER1 1
HARNESS-WIRING LB-94615 UPPER1 1
HARNESS-WIRING LB-94616 LOWER1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2
HARNESS-WIRING LB-73864 CONTROL-UPPER(J20)1 1 1 1
HARNESS-WIRING LB-73865 CONTROL-LOWER(P20 TO J20)1 1 1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2 2 2
17 CONTROL-IGN LB-90087A 24V1 1
17 CONTROL-IGN LB-90701A 24V1 1
30 TRANSFORMER 42J3201 "120V PRI,24V SEC,40VA,L/FUSE"1 1 1 1 1 1
31 BREAKER-CIRC 37J5601 250V1 1 1 1 1 1
32 SWITCH 25J1301 SWITCH, INTERLOCK1 1 1 1 1 1
33 BOARD-CIRCUIT LB-90089A CONTROL-BCC1 1 1 1
Category:BLOWER PARTS FOR Q2 BLOWER
PLATE-CUTOFF LB-65855 CUTOFF PLATE1 1 1 1 1 1
HARNESS-WIRING LB-64288 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790E HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 21L9001 "1/5HP,1075RPM,115/60/1W/MOUNTS" 1 1
LENNOXOEMPARTS.COM
G23Q2-50 11/30/2010 Page 4
G23Q2-50 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
51 MOTOR-BLOWER 86H6601 "1/5HP,1075RPM,115/60/1W/MOUNTS" 1 1 1 1
52 WHEEL-BLOWER LB-29333BH "1/2"" BORE, 10"" X 7"""1 1 1 1 1 1
53 CAPACITOR-BLR MTR 59C9201 "5MFD,370VAC"1 1 1 1 1 1
Category:BLOWER PARTS FOR Q3 BLOWER
PLATE-CUTOFF LB-65691 CUTOFF PLATE1 1 1 1 1 1
HARNESS-WIRING LB-73868 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790A HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 21L9201 "1/3HP,1075RPM,115/60/1,W/MOUNTS" 1 1
51 MOTOR-BLOWER 37J2501 "1/3HP,1075RPM,115/60/1,W/MOUNTS" 1 1 1 1
52 WHEEL-BLOWER LB-29333BJ "1/2""BORE,10"" X 8"""1 1 1 1 1 1
53 CAPACITOR-BLR MTR 59C9201 "5MFD,370VAC"1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q2-50 11/30/2010 Page 5
NOTE
Note1:ORDER 41K3701 NATURAL GAS VALVE AND 48G22O1 LP CONVERSION KIT.Note2:ORDER 93J5101 OR58K7301 NATURAL GAS VALVE AND 28G6101 LP CONVERSIONKIT.Note3:ORDER 31L3701 NATURAL GAS VALVEAND 28G6101 LP CONVERSION KIT.Note4:ORDER 31L8201 NATURAL GAS VALVE AND 48G2201 LPCONVERSION KIT.
LENNOXOEMPARTS.COM
G23Q3-100 11/30/2010 Page 1
G23Q3-100 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
Category:CABINET PARTS
BUSHING-SNAP 64K0001 SIGHT1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1
PANEL-SET LB-95970B HEAT & BLR ACCESS SET INCLHANDLE(Q3) 1 1
PANEL-SET LB-95970C "HEAT & BLR ACCESS SET INCLHANDLE(Q3/4, 1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1 1 1
CLIP 18J2501 FILTER2 2 2 2 2 2
FASTENER 42J7801 FILTER DOOR1 1 1 1 1 1
DOOR LB-63005 "FILTER(Q3/4,Q4/5)"1 1 1 1 1 1
DOOR LB-65605 FILTER(Q3)1 1 1 1 1 1
CLIP LB-65612 REAR-FILTER1 1 1 1 1 1
FILTER P-8-7822 "16"" X 25"" X 1"",WASHABLE(Q3)"1 1 1 1 1 1
FILTER P-8-7831 "20"" X 25"" X1"",WASHABLE(Q4/5)" 1 1 1 1 1 1
1 PANEL LB-63561 HEAT ACCESS-LOUVER(Q3)1 1 1 1
1 PANEL LB-64695 "HEATACCESS-LOUVER(Q3/4,Q4/5)" 1 1 1 1
2 PANEL LB-64363B BLOWER ACCESS(Q3)1 1 1 1
2 PANEL LB-64363C "BLOWER ACCESS(Q3/4,Q4/5)"1 1 1 1
3 PANEL LB-63559 CAB TOP1 1 1 1 1 1
4 GASKET LB-65618 CAB TOP1 1 1 1 1 1
5 COVER LB-64237 "CONTROL BOX (6""HEIGHT)"1 1 1 1
5 COVER LB-90698 "CONTROL BOX (7""HEIGHT)"1 1 1 1
Category:HEATING PARTS
PLATE-CORBEL LB-91528 LP1 1
ORIFICE-BURNER LB-74093 NAT(DRILL SIZE .0917)4 4 4 4 4 4
ORIFICE-BURNER LB-83508 LP(DRILL SIZE 1.45MM)4 4 4 4 4 4
IGNITOR 41K5601 IGNITOR1 1
LENNOXOEMPARTS.COM
G23Q3-100 11/30/2010 Page 2
G23Q3-100 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
BRACKET LB-90702 BRACKET - HSI1 1
ORIFICE-PILOT 31J9101 LP1 1 1 1
BRACKET LB-68602A PILOT1 1 1 1
LEAD W082201030 FLAME SENSOR1 1 1 1 1 1
PLUG 25J5801 "PLASTIC 1/2"""1 1
TEE 31J7701 "PLASTIC 1/4"""1 1
SWITCH-PRESS 67K3001 ".55WC,SPST,N.O."1 1
HARNESS-WIRING LB-73867 MAKE UP BOX1 1
KIT-TUBING LB-96015A PRESS SWITCH1 1
PLUG 25J5801 "PLASTIC 1/2"""1 1 1 1
TEE 31J7701 "PLASTIC 1/4"""1 1 1 1
HARNESS-WIRING LB-73867 MAKE UP BOX1 1 1 1
KIT-TUBING LB-96015A PRESS SWITCH1 1 1 1
10 HEAT EXCHANGER LB-65729C (Q3 X UNITS)1 1 1 1
10 HEAT EXCHANGER LB-65729D "(Q3/4,Q4/5 X UNITS)"1 1 1 1
10 HEAT EXCHANGER LB-91001C (Q3 UNITS)1 1 1 1 1 1
10 HEAT EXCHANGER LB-91001D (Q3/4 UNITS)1 1 1 1 1 1
10 HEAT EXCHANGER LB-96300G (Q4/5 UNITS)1 1 1 1 1 1
11 BAFFLE LB-64660A HEAT EXCHANGER(X UNITS)4 4 4 4
12 DIVERTER LB-64618 BOX-FLUE1 1 1 1 1 1
13 GASKET LB-65610 DIVERTER1 1 1 1 1 1
14 SWITCH-ROLLOUT 31J9501 MANUAL RESET1 1 1 1 1 1
14 SWITCH 71G1201 MANUAL RESET1 1
15 BURNER-MAIN LB-64500C CLUSTER ASSY1 1 1 1 1 1
16 MANIFOLD-GAS LB-63016C LESS ORIFICES1 1 1 1 1 1
18 VALVE-GASLP(FOOTNOTE 1)1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q3-100 11/30/2010 Page 3
G23Q3-100 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
18 VALVE-GAS 31L3701 "NAT,L/IGN CTL,1/2"",(WRODGERS)" 1
18 VALVE-GAS 31L8201 "NAT,L/IGN CTL1/2""(HONEYWELL)" 1
18 VALVE-GAS 41K3701 "NAT,L/IGN CTL 1/2"" H'WELL)"1 1
18 VALVE-GAS 58K7301 "NAT,L/IGN CTL 1/2"" (WRODGERS/TOGGLE T 1 1
18 VALVE-GAS 93J5101 "NAT,L/IGN CTL 1/2"" (WRODGERS W/BLUE M 1
19 BURNER-PILOT 69J3701 "W/ELECTRODE,L/SENSOR(INCL IGN WIRE)" 1 1 1 1
19 BURNER-PILOT 81J0501PR PILOT CONVERSIONKIT-CONVERTS UNIT TO BR 1 1 1 1
20 SENSOR-FLAME 18G8901 SENSOR-FLAME1 1 1 1
20 SENSOR-FLAME KIT LB-94701A INCLUDES SENSOR ANDBRACKET 1 1
21 CONTROL-LIMIT 18J2701 "OUT 140F,IN 110F,(Q4/5)"1 1
21 CONTROL-LIMIT 18J2801 "OUT 165F, IN 135F,SPST"1 1 1 1 1 1
21 CONTROL-LIMIT 73K1901 "OUT 160F,IN 130F,SPST(Q4/5)"1 1 1 1
21 CONTROL-LIMIT 73K2001 "OUT 160F,IN 130F,SPST(Q3)"1 1 1 1
22 SWITCH-PRESS 18J3501 ".55WC,SPST,N.O."1 1 1 1
Category:INDUCED DRAFT ASSEMBLY
40 BLOWER-COMB AIR LB-65734D COMPLETE ASSY ONLY1 1 1 1 1 1
41 GASKET LB-65611 COMB AIR1 1 1 1 1 1
42 ADAPTER LB-65403C FLUE TRANSITION1 1 1 1 1 1
43 GASKET LB-65616 FLUE OUTLET1 1 1 1 1 1
Category:CONTROL PANEL PARTS
BOARD-CIRCUIT 24L8501 INTEGRATED CONTROL1 1
HARNESS-WIRING LB-100429A KIT REPLACES UPPER & LOWER1 1
HARNESS-WIRING LB-94615 UPPER1 1
HARNESS-WIRING LB-94616 LOWER1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2
HARNESS-WIRING LB-73864 CONTROL-UPPER(J20)1 1 1 1
LENNOXOEMPARTS.COM
G23Q3-100 11/30/2010 Page 4
G23Q3-100 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
HARNESS-WIRING LB-73865 CONTROL-LOWER(P20 TO J20)1 1 1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2 2 2
17 CONTROL-IGN LB-90087A 24V1 1
17 CONTROL-IGN LB-90701A 24V1 1
30 TRANSFORMER 42J3201 "120V PRI,24V SEC,40VA,L/FUSE"1 1 1 1 1 1
31 BREAKER-CIRC 37J5601 250V1 1 1 1 1 1
32 SWITCH 25J1301 SWITCH, INTERLOCK1 1 1 1 1 1
33 BOARD-CIRCUIT LB-90089A CONTROL-BCC1 1 1 1
Category:BLOWER PARTS FOR Q3 BLOWER
PLATE-CUTOFF LB-65691 CUTOFF PLATE1 1 1 1 1 1
HARNESS-WIRING LB-65859 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790A HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 21L9201 "1/3HP,1075RPM,115/60/1,W/MOUNTS" 1 1
51 MOTOR-BLOWER 37J2501 "1/3HP,1075RPM,115/60/1,W/MOUNTS" 1 1 1 1
52 WHEEL-BLOWER LB-29333BJ "1/2""BORE,10"" X 8"""1 1 1 1 1 1
53 CAPACITOR-BLR MTR 59C9201 "5MFD,370VAC"1 1 1 1 1 1
Category:BLOWER PARTS FOR Q3/4 BLOWER
PLATE-CUTOFF LB-10170 CUTOFF PLATE1 1 1 1 1 1
WHEEL-BLOWER LB-29333BJ "1/2"" BORE,10"" X 8"""1 1 1 1 1 1
HARNESS-WIRING LB-73868 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790G HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 21L9301 "1/2HP,1075RPM,115/60/1W/MOUNTS" 1 1
51 MOTOR-BLOWER 37J2401 "1/2HP,1075RPM,115/60/1W/MOUNTS" 1 1 1 1
53 CAPACITOR 39H8901 "7.5MFD,370VAC"1 1 1 1 1 1
Category:BLOWER PARTS FOR Q4/5 BLOWER
PLATE-CUTOFF LB-65692 CUTOFF PLATE1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q3-100 11/30/2010 Page 5
G23Q3-100 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
MOUNT-MOTOR LB-97863A MOTOR FRAME SECTION SA3 3 3 3 3 3
HARNESS-WIRING LB-73869 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790C HOUSING-BLOWER1 1 1 1 1 1
51 MOTOR-BLOWER 28F0101 "3/4HP,1075RPM,115/60/1L/MOUNTS" 1 1
51 MOTOR-BLOWER 45H3301 "3/4HP,1075RPM,115/60/1L/MOUNTS" 1 1 1 1
52 WHEEL-BLOWER LB-29333BBP "1/2""BORE,11-1/2"" X 9"""1 1 1 1 1 1
53 CAPACITOR 39H5801 "40MFD,370VAC"1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q3-100 11/30/2010 Page 6
NOTE
Note1:ORDER 31L3701 NATURAL GAS VALVE AND 28G6101 LP CONVERSION KIT.Note2:ORDER 31L8201NATURAL GAS VALVE AND 48G2201 LP CONVERSION KIT.Note3:ORDER 93J5101 OR 58K7301 NATURAL GASVALVE AND 28G6101 LP CONVERSIONKIT.Note4:ORDER 41K3701 NATURAL GAS VALVE AND 48G2201 LPCONVERSION KIT.
LENNOXOEMPARTS.COM
G23Q3/4-100 11/30/2010 Page 1
G23Q3/4-100 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
Category:CABINET PARTS
BUSHING-SNAP 64K0001 SIGHT1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1
PANEL-SET LB-95970B HEAT & BLR ACCESS SET INCLHANDLE(Q3) 1 1
PANEL-SET LB-95970C "HEAT & BLR ACCESS SET INCLHANDLE(Q3/4, 1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1 1 1
CLIP 18J2501 FILTER2 2 2 2 2 2
FASTENER 42J7801 FILTER DOOR1 1 1 1 1 1
DOOR LB-63005 "FILTER(Q3/4,Q4/5)"1 1 1 1 1 1
DOOR LB-65605 FILTER(Q3)1 1 1 1 1 1
CLIP LB-65612 REAR-FILTER1 1 1 1 1 1
FILTER P-8-7822 "16"" X 25"" X 1"",WASHABLE(Q3)"1 1 1 1 1 1
FILTER P-8-7831 "20"" X 25"" X1"",WASHABLE(Q4/5)" 1 1 1 1 1 1
1 PANEL LB-63561 HEAT ACCESS-LOUVER(Q3)1 1 1 1
1 PANEL LB-64695 "HEATACCESS-LOUVER(Q3/4,Q4/5)" 1 1 1 1
2 PANEL LB-64363B BLOWER ACCESS(Q3)1 1 1 1
2 PANEL LB-64363C "BLOWER ACCESS(Q3/4,Q4/5)"1 1 1 1
3 PANEL LB-63559 CAB TOP1 1 1 1 1 1
4 GASKET LB-65618 CAB TOP1 1 1 1 1 1
5 COVER LB-64237 "CONTROL BOX (6""HEIGHT)"1 1 1 1
5 COVER LB-90698 "CONTROL BOX (7""HEIGHT)"1 1 1 1
Category:HEATING PARTS
PLATE-CORBEL LB-91528 LP1 1
ORIFICE-BURNER LB-74093 NAT(DRILL SIZE .0917)4 4 4 4 4 4
ORIFICE-BURNER LB-83508 LP(DRILL SIZE 1.45MM)4 4 4 4 4 4
IGNITOR 41K5601 IGNITOR1 1
LENNOXOEMPARTS.COM
G23Q3/4-100 11/30/2010 Page 2
G23Q3/4-100 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
BRACKET LB-90702 BRACKET - HSI1 1
ORIFICE-PILOT 31J9101 LP1 1 1 1
BRACKET LB-68602A PILOT1 1 1 1
LEAD W082201030 FLAME SENSOR1 1 1 1 1 1
PLUG 25J5801 "PLASTIC 1/2"""1 1
TEE 31J7701 "PLASTIC 1/4"""1 1
SWITCH-PRESS 67K3001 ".55WC,SPST,N.O."1 1
HARNESS-WIRING LB-73867 MAKE UP BOX1 1
KIT-TUBING LB-96015A PRESS SWITCH1 1
PLUG 25J5801 "PLASTIC 1/2"""1 1 1 1
TEE 31J7701 "PLASTIC 1/4"""1 1 1 1
HARNESS-WIRING LB-73867 MAKE UP BOX1 1 1 1
KIT-TUBING LB-96015A PRESS SWITCH1 1 1 1
10 HEAT EXCHANGER LB-65729C (Q3 X UNITS)1 1 1 1
10 HEAT EXCHANGER LB-65729D "(Q3/4,Q4/5 X UNITS)"1 1 1 1
10 HEAT EXCHANGER LB-91001C (Q3 UNITS)1 1 1 1 1 1
10 HEAT EXCHANGER LB-91001D (Q3/4 UNITS)1 1 1 1 1 1
10 HEAT EXCHANGER LB-96300G (Q4/5 UNITS)1 1 1 1 1 1
11 BAFFLE LB-64660A HEAT EXCHANGER(X UNITS)4 4 4 4
12 DIVERTER LB-64618 BOX-FLUE1 1 1 1 1 1
13 GASKET LB-65610 DIVERTER1 1 1 1 1 1
14 SWITCH-ROLLOUT 31J9501 MANUAL RESET1 1 1 1 1 1
14 SWITCH 71G1201 MANUAL RESET1 1
15 BURNER-MAIN LB-64500C CLUSTER ASSY1 1 1 1 1 1
16 MANIFOLD-GAS LB-63016C LESS ORIFICES1 1 1 1 1 1
18 VALVE-GASLP(FOOTNOTE 1)1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q3/4-100 11/30/2010 Page 3
G23Q3/4-100 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
18 VALVE-GAS 31L3701 "NAT,L/IGN CTL,1/2"",(WRODGERS)" 1
18 VALVE-GAS 31L8201 "NAT,L/IGN CTL1/2""(HONEYWELL)" 1
18 VALVE-GAS 41K3701 "NAT,L/IGN CTL 1/2"" H'WELL)"1 1
18 VALVE-GAS 58K7301 "NAT,L/IGN CTL 1/2"" (WRODGERS/TOGGLE T 1 1
18 VALVE-GAS 93J5101 "NAT,L/IGN CTL 1/2"" (WRODGERS W/BLUE M 1
19 BURNER-PILOT 69J3701 "W/ELECTRODE,L/SENSOR(INCL IGN WIRE)" 1 1 1 1
19 BURNER-PILOT 81J0501PR PILOT CONVERSIONKIT-CONVERTS UNIT TO BR 1 1 1 1
20 SENSOR-FLAME 18G8901 SENSOR-FLAME1 1 1 1
20 SENSOR-FLAME KIT LB-94701A INCLUDES SENSOR ANDBRACKET 1 1
21 CONTROL-LIMIT 18J2701 "OUT 140F,IN 110F,(Q4/5)"1 1
21 CONTROL-LIMIT 18J2801 "OUT 165F, IN 135F,SPST"1 1 1 1 1 1
21 CONTROL-LIMIT 73K1901 "OUT 160F,IN 130F,SPST(Q4/5)"1 1 1 1
21 CONTROL-LIMIT 73K2001 "OUT 160F,IN 130F,SPST(Q3)"1 1 1 1
22 SWITCH-PRESS 18J3501 ".55WC,SPST,N.O."1 1 1 1
Category:INDUCED DRAFT ASSEMBLY
40 BLOWER-COMB AIR LB-65734D COMPLETE ASSY ONLY1 1 1 1 1 1
41 GASKET LB-65611 COMB AIR1 1 1 1 1 1
42 ADAPTER LB-65403C FLUE TRANSITION1 1 1 1 1 1
43 GASKET LB-65616 FLUE OUTLET1 1 1 1 1 1
Category:CONTROL PANEL PARTS
BOARD-CIRCUIT 24L8501 INTEGRATED CONTROL1 1
HARNESS-WIRING LB-100429A KIT REPLACES UPPER & LOWER1 1
HARNESS-WIRING LB-94615 UPPER1 1
HARNESS-WIRING LB-94616 LOWER1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2
HARNESS-WIRING LB-73864 CONTROL-UPPER(J20)1 1 1 1
LENNOXOEMPARTS.COM
G23Q3/4-100 11/30/2010 Page 4
G23Q3/4-100 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
HARNESS-WIRING LB-73865 CONTROL-LOWER(P20 TO J20)1 1 1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2 2 2
17 CONTROL-IGN LB-90087A 24V1 1
17 CONTROL-IGN LB-90701A 24V1 1
30 TRANSFORMER 42J3201 "120V PRI,24V SEC,40VA,L/FUSE"1 1 1 1 1 1
31 BREAKER-CIRC 37J5601 250V1 1 1 1 1 1
32 SWITCH 25J1301 SWITCH, INTERLOCK1 1 1 1 1 1
33 BOARD-CIRCUIT LB-90089A CONTROL-BCC1 1 1 1
Category:BLOWER PARTS FOR Q3 BLOWER
PLATE-CUTOFF LB-65691 CUTOFF PLATE1 1 1 1 1 1
HARNESS-WIRING LB-65859 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790A HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 21L9201 "1/3HP,1075RPM,115/60/1,W/MOUNTS" 1 1
51 MOTOR-BLOWER 37J2501 "1/3HP,1075RPM,115/60/1,W/MOUNTS" 1 1 1 1
52 WHEEL-BLOWER LB-29333BJ "1/2""BORE,10"" X 8"""1 1 1 1 1 1
53 CAPACITOR-BLR MTR 59C9201 "5MFD,370VAC"1 1 1 1 1 1
Category:BLOWER PARTS FOR Q3/4 BLOWER
PLATE-CUTOFF LB-10170 CUTOFF PLATE1 1 1 1 1 1
WHEEL-BLOWER LB-29333BJ "1/2"" BORE,10"" X 8"""1 1 1 1 1 1
HARNESS-WIRING LB-73868 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790G HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 21L9301 "1/2HP,1075RPM,115/60/1W/MOUNTS" 1 1
51 MOTOR-BLOWER 37J2401 "1/2HP,1075RPM,115/60/1W/MOUNTS" 1 1 1 1
53 CAPACITOR 39H8901 "7.5MFD,370VAC"1 1 1 1 1 1
Category:BLOWER PARTS FOR Q4/5 BLOWER
PLATE-CUTOFF LB-65692 CUTOFF PLATE1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q3/4-100 11/30/2010 Page 5
G23Q3/4-100 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
MOUNT-MOTOR LB-97863A MOTOR FRAME SECTION SA3 3 3 3 3 3
HARNESS-WIRING LB-73869 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790C HOUSING-BLOWER1 1 1 1 1 1
51 MOTOR-BLOWER 28F0101 "3/4HP,1075RPM,115/60/1L/MOUNTS" 1 1
51 MOTOR-BLOWER 45H3301 "3/4HP,1075RPM,115/60/1L/MOUNTS" 1 1 1 1
52 WHEEL-BLOWER LB-29333BBP "1/2""BORE,11-1/2"" X 9"""1 1 1 1 1 1
53 CAPACITOR 39H5801 "40MFD,370VAC"1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q3/4-100 11/30/2010 Page 6
NOTE
Note1:ORDER 31L3701 NATURAL GAS VALVE AND 28G6101 LP CONVERSION KIT.Note2:ORDER 31L8201NATURAL GAS VALVE AND 48G2201 LP CONVERSION KIT.Note3:ORDER 93J5101 OR 58K7301 NATURAL GASVALVE AND 28G6101 LP CONVERSIONKIT.Note4:ORDER 41K3701 NATURAL GAS VALVE AND 48G2201 LPCONVERSION KIT.
LENNOXOEMPARTS.COM
G23Q3/4-125 11/30/2010 Page 1
G23Q3/4-125 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
Category:CABINET PARTS
BUSHING-SNAP 64K0001 SIGHT1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1
PANEL-SET LB-95970C HEAT & BLR ACCESS SET INCLHANDLE(Q3/4) 1 1
PANEL-SET LB-95970D HEAT & BLR ACCESS SET INCLHANDLE(Q5/6) 1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1 1 1
CLIP 18J2501 FILTER2 2 2 2 2 2
FASTENER 42J7801 FILTER DOOR2 2 2 2 2 2
DOOR LB-63005 FILTER1 1 1 1 1 1
CLIP LB-65612 REAR-FILTER1 1 1 1 1 1
FILTER P-8-7831 "20"" X 25"" X 1"",WASHABLE"1 1 1 1 1 1
1 PANEL LB-64657 HEAT ACCESS-LOUVER(Q5/6)1 1 1 1
1 PANEL LB-64695 HEAT ACCESS-LOUVER(Q3/4)1 1 1 1
2 PANEL LB-64363C BLOWER ACCESS(Q3/4)1 1 1 1
2 PANEL LB-64363D BLOWER ACCESS(Q5/6)1 1 1 1
3 PANEL LB-64214 CAB TOP(Q3/4)1 1 1 1 1 1
3 PANEL LB-64632 CAB TOP(Q5/6)1 1 1 1 1 1
4 GASKET LB-65619 CAB TOP(Q5/6)1 1 1 1 1 1
4 GASKET LB-74058 CAB TOP(Q3/4)1 1 1 1 1 1
5 COVER LB-64237 "CONTROL BOX (6""HEIGHT)"1 1 1 1
5 COVER LB-90698 "CONTROL BOX (7""HEIGHT)"1 1 1 1
Category:HEATING PARTS
PLATE-CORBEL LB-91529 LP1 1
ORIFICE-BURNER LB-74093 NAT(DRILL SIZE .0917)5 5 5 5 5 5
ORIFICE-BURNER LB-83508 LP(DRILL SIZE 1.45MM)5 5 5 5 5 5
ORIFICE-PILOT 31J9101 LP1 1 1 1
LENNOXOEMPARTS.COM
G23Q3/4-125 11/30/2010 Page 2
G23Q3/4-125 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
BRACKET LB-68602A PILOT1 1 1 1
LEAD W082201030 FLAME SENSOR1 1 1 1 1 1
PLUG 25J5801 "PLASTIC 1/2"""1 1 1 1 1 1
TEE 31J7701 "PLASTIC 1/4"""1 1 1 1 1 1
HARNESS-WIRING LB-73867 MAKE UP BOX1 1 1 1 1 1
KIT-TUBING LB-96015A PRESS SWITCH1 1 1 1 1 1
BRACKET LB-90702 BRACKET - HSI1 1
10 HEAT EXCHANGER LB-65729E (Q5/6 X UNITS)1 1 1 1
10 HEAT EXCHANGER LB-65729G (Q3/4 X UNITS)1 1 1 1
10 HEAT EXCHANGER LB-91001E (Q5/6 UNITS)1 1 1 1 1 1
10 HEAT EXCHANGER LB-91001G (Q3/4 UNITS)1 1 1 1 1 1
11 BAFFLE LB-64660A HEAT EXCHANGER(X UNITS)5 5 5 5
12 DIVERTER LB-64618 BOX-FLUE1 1 1 1 1 1
13 GASKET LB-65610 DIVERTER1 1 1 1 1 1
14 SWITCH-MANUAL 31J9601 MANUAL RESET1 1 1 1 1 1
14 SWITCH 71G1201 MANUAL RESET1 1
15 BURNER-MAIN LB-64500D CLUSTER ASSY1 1 1 1 1 1
16 MANIFOLD-GAS LB-63016D LESS ORIFICES1 1 1 1 1 1
18 VALVE-GASLP(FOOTNOTE 1)1 1 1 1 1 1
18 VALVE-GAS 31L3701 "NAT,L/IGN CTL,1/2""(WRODGERS)" 1
18 VALVE-GAS 31L8201 "NAT,L/IGNCTL,1/2""(HONEYWELL)" 1
18 VALVE-GAS 41K3701 "NAT,L/IGN CTL-1/2"" H'WELL"1 1
18 VALVE-GAS 58K7301 "NAT,L/IGN CTL 1/2"" (WRODGERS W/TOGGLE 1 1
18 VALVE-GAS 93J5101 "NAT,L/IGN CTL 1/2"" (WRODGERS W/BLUE M 1
19 BURNER-PILOT 69J3701 "W/ELECTRODE,L/SENSOR(INCL IGN LEAD)" 1 1 1 1
19 BURNER-PILOT 81J0501PR PILOT CONVERSION KITCONVERTS UNIT TO BR 1 1 1 1
LENNOXOEMPARTS.COM
G23Q3/4-125 11/30/2010 Page 3
G23Q3/4-125 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
20 SENSOR-FLAME 18G8901 SENSOR-FLAME1 1 1 1
20 SENSOR-FLAME KIT LB-94701A INCLUDES SENSOR & BRACKET1 1
21 CONTROL-LIMIT 25J3001 "OUT 155F,IN 125F,(Q3/4)"1 1
21 CONTROL-LIMIT 37H7301 "OUT 180F,IN 150F,7""INS(Q5/6)"1 1
21 CONTROL-LIMIT 73K1701 "OUT 235F, IN 205F,SPST(Q5/6)"1 1 1 1
21 CONTROL-LIMIT 80K8901 "OUT 180F,IN 150F,(Q3/4)"1 1 1 1
22 SWITCH-PRESS 18J3501 ".55WC,SPST,N.O."1 1 1 1
22 SWITCH-PRESS 67K3001 ".55WC,SPST,N.O."1 1
23 IGNITOR 41K5601 IGNITOR1 1
Category:INDUCED DRAFT ASSEMBLY
40 BLOWER-COMB AIR LB-65734E COMPLETE ASSY ONLY1 1 1 1 1 1
41 GASKET LB-65611 COMB AIR1 1 1 1 1 1
42 ADAPTER LB-65403D FLUE TRANSITION(Q5/6)1 1 1 1 1 1
42 ADAPTER LB-65403E FLUE TRANSITION(Q3/4)1 1 1 1 1 1
43 GASKET LB-65616 FLUE OUTLET1 1 1 1 1 1
Category:CONTROL PANEL PARTS
BOARD-CIRCUIT 24L8501 INTEGRATED CONTROL1 1
HARNESS-WIRING LB-100429A KIT REPLACES UPPER & LOWER1 1
HARNESS-WIRING LB-94615 UPPER1 1
HARNESS-WIRING LB-94616 LOWER1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2
HARNESS-WIRING LB-73864 CONTROL-UPPER(J20)1 1 1 1
HARNESS-WIRING LB-73865 CONTROL-LOWER(P20 TO J20)1 1 1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2 2 2
17 CONTROL-IGN LB-90087A 24V1 1
17 CONTROL-IGN LB-90701A 24V1 1
LENNOXOEMPARTS.COM
G23Q3/4-125 11/30/2010 Page 4
G23Q3/4-125 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
30 TRANSFORMER 42J3201 "120V PRI,24V SEC,40VA,L/FUSE"1 1 1 1 1 1
31 BREAKER-CIRC 37J5601 250V1 1 1 1 1 1
32 SWITCH 25J1301 SWITCH, INTERLOCK1 1 1 1 1 1
33 BOARD-CIRCUIT LB-90089A CONTROL-BCC1 1 1 1
Category:BLOWER PARTS FOR Q3/4 BLOWER
PLATE-CUTOFF LB-65854 CUTOFF PLATE1 1 1 1 1 1
HARNESS-WIRING LB-73868 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790J HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 21L9301 "1/2HP,1075RPM,115/60/1W/MOUNTS" 1 1
51 MOTOR-BLOWER 86H7101 "1/2HP,1075RPM,115/60/1W/MOUNTS" 1 1 1 1
52 WHEEL-BLOWER LB-29333BM "1/2"" BORE,10"" X 10"""1 1 1 1 1 1
53 CAPACITOR 39H8901 "7.5MFD,370VAC"1 1 1 1 1 1
Category:BLOWER PARTS FOR Q5/Q6 BLOWER
PLATE-CUTOFF LB-65532 CUTOFF PLATE1 1 1 1 1 1
MOUNT-MOTOR LB-32877C MOUNT FS-19 (use 23J28)3 3 3 3 3 3
HARNESS-WIRING LB-73869 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790D HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 28F0101 "3/4HP,10754PM,115/60/1"1 1
51 MOTOR-BLOWER 45H3301 "3/4HP,1075RPM,115/60/1"1 1 1 1
52 WHEEL-BLOWER LB-29333BBC "1/2""BORE,12"" X 12"""1 1 1 1 1 1
53 CAPACITOR 39H5801 "40MFD,370VAC"1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q3/4-125 11/30/2010 Page 5
NOTE
Note1:ORDER 41K3701 NATURAL GAS VALVE AND 48G2201 LP CONVERSION KIT.Note2:ORDER 93J5101 OR58K7301 NATURAL GAS VALVE AND 28G6101 LP CONVERSIONKIT.Note3:ORDER 31L8201 NATURAL GAS VALVEAND 48G2201 LP CONVERSION KIT.Note4:ORDER 31L3701 NATURAL GAS VALVE AND 28G6101 LPCONVERSION KIT.
LENNOXOEMPARTS.COM
G23Q3-50 11/30/2010 Page 1
G23Q3-50 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
Category:CABINET PARTS
BUSHING-SNAP 64K0001 SIGHT1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1
PANEL-SET LB-95970A HEAT & BLR ACCESS SET INCLHANDLE 1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1 1 1
CLIP 18J2501 FILTER2 2 2 2 2 2
FILTER 31J8101 "14"" X 25"" X 1"",WASHABLE"1 1 1 1 1 1
FASTENER 42J7801 FILTER DOOR2 2 2 2 2 2
DOOR LB-65608 FILTER1 1 1 1 1 1
CLIP LB-65612 REAR-FILTER1 1 1 1 1 1
1 PANEL LB-64637 HEAT ACCESS-LOUVER1 1 1 1
2 PANEL LB-64363A BLOWER ACCESS1 1 1 1
3 PANEL LB-64631 CAB TOP1 1 1 1 1 1
4 GASKET LB-65617 CAB TOP1 1 1 1 1 1
5 COVER LB-64237 "CONTROL BOX (6""HEIGHT)"1 1 1 1
5 COVER LB-90698 "CONTROL BOX (7""HEIGHT)"1 1 1 1
Category:HEATING PARTS
PLATE-CORBEL LB-91526 LP1 1
ORIFICE-BURNER LB-74093 NAT(DRILL SIZE .0917)2 2 2 2 2 2
ORIFICE-BURNER LB-83508 LP(DRILL SIZE 1.45MM)2 2 2 2 2 2
ORIFICE-PILOT 31J9101 LP1 1 1 1
BRACKET LB-68602A PILOT1 1 1 1
LEAD W082201030 FLAME SENSOR1 1 1 1 1 1
PLUG 25J5801 "PLASTIC 1/2"""1 1 1 1 1 1
TEE 31J7701 "PLASTIC 1/4"""1 1 1 1 1 1
HARNESS-WIRING LB-73867 MAKE UP BOX1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q3-50 11/30/2010 Page 2
G23Q3-50 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
KIT-TUBING LB-96015A PRESS SWITCH1 1 1 1 1 1
BRACKET LB-90702 BRACKET - HSI1 1
10 HEAT EXCHANGER LB-65729A "(Q2,Q3 X UNITS)"1 1 1 1
10 HEAT EXCHANGER LB-91001A (Q3 UNITS)1 1 1 1 1 1
10 HEAT EXCHANGER LB-96300A (Q2 UNITS)1 1 1 1 1 1
11 BAFFLE LB-64660A HEAT EXCHANGER(X UNITS)2 2 2 2
12 DIVERTER LB-64617 BOX-FLUE1 1 1 1 1 1
13 GASKET LB-65609 DIVERTER1 1 1 1 1 1
14 SWITCH-MANUAL 31J9601 MANUAL RESET1 1 1 1 1 1
15 BURNER-MAIN LB-64500A CLUSTER ASSY1 1 1 1 1 1
16 MANIFOLD-GAS LB-63016A LESS ORIFICES1 1 1 1 1 1
18 VALVE-GASLP(FOOTNOTE 1)1 1 1 1 1 1
18 VALVE-GAS 31L3701 "NAT,L/IGN CTL-1/2""(WRODGERS)" 1
18 VALVE-GAS 31L8201 "NAT,L/IGNCTL-1/2""(HONEYWELL)" 1
18 VALVE-GAS 41K3701 "NAT,L/IGN CTL-1/2"" H'WELL"1 1
18 VALVE-GAS 58K7301 "NAT,L/IGN CTL 1/2"" (WRODGERS W/TOGGLE 1 1
18 VALVE-GAS 93J5101 "NAT,L/IGN CTL 1/2"" (WRODGERS W/BLUE M 1
19 BURNER-PILOT 69J3701 "W/ELECTRODE,L/SENSOR(INCL IGN WIRE)" 1 1 1 1
19 BURNER-PILOT 81J0501PR PILOT CONVERSION KITCONVERTS UNIT TO BR 1 1 1 1
20 SENSOR-FLAME 18G8901 SENSOR-FLAME1 1 1 1
20 SENSOR-FLAME KIT LB-94701A INCLUDES SENSOR & BRACKET1 1
21 CONTROL-LIMIT 25J2701 "OUT 150F,IN 120F,SPST"1 1
21 CONTROL-LIMIT 73K1801 "OUT 170F,IN 140F,SPST(Q3)"1 1 1 1
21 CONTROL-LIMIT 73K1901 "OUT 160F,IN 130F,SPST(Q2)"1 1 1 1
22 SWITCH-PRESS 18J3301 ".34WC,SPST,N.O."1 1 1 1
22 SWITCH-PRESS 67K3201 PRESSURE SWITCH1 1
LENNOXOEMPARTS.COM
G23Q3-50 11/30/2010 Page 3
G23Q3-50 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
23 IGNITOR 41K5601 IGNITOR1 1
Category:INDUCED DRAFT ASSEMBLY
40 BLOWER-COMB AIR LB-65734B COMPLETE ASSY ONLY1 1 1 1 1 1
41 GASKET LB-65611 COMB AIR1 1 1 1 1 1
42 ADAPTER LB-65403A FLUE TRANSITION1 1 1 1 1 1
43 GASKET LB-65616 FLUE OUTLET1 1 1 1 1 1
Category:CONTROL PANEL PARTS
BOARD-CIRCUIT 24L8501 INTEGRATED CONTROL1 1
HARNESS-WIRING LB-100429A KIT REPLACES UPPER & LOWER1 1
HARNESS-WIRING LB-94615 UPPER1 1
HARNESS-WIRING LB-94616 LOWER1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2
HARNESS-WIRING LB-73864 CONTROL-UPPER(J20)1 1 1 1
HARNESS-WIRING LB-73865 CONTROL-LOWER(P20 TO J20)1 1 1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2 2 2
17 CONTROL-IGN LB-90087A 24V1 1
17 CONTROL-IGN LB-90701A 24V1 1
30 TRANSFORMER 42J3201 "120V PRI,24V SEC,40VA,L/FUSE"1 1 1 1 1 1
31 BREAKER-CIRC 37J5601 250V1 1 1 1 1 1
32 SWITCH 25J1301 SWITCH, INTERLOCK1 1 1 1 1 1
33 BOARD-CIRCUIT LB-90089A CONTROL-BCC1 1 1 1
Category:BLOWER PARTS FOR Q2 BLOWER
PLATE-CUTOFF LB-65855 CUTOFF PLATE1 1 1 1 1 1
HARNESS-WIRING LB-64288 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790E HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 21L9001 "1/5HP,1075RPM,115/60/1W/MOUNTS" 1 1
LENNOXOEMPARTS.COM
G23Q3-50 11/30/2010 Page 4
G23Q3-50 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
51 MOTOR-BLOWER 86H6601 "1/5HP,1075RPM,115/60/1W/MOUNTS" 1 1 1 1
52 WHEEL-BLOWER LB-29333BH "1/2"" BORE, 10"" X 7"""1 1 1 1 1 1
53 CAPACITOR-BLR MTR 59C9201 "5MFD,370VAC"1 1 1 1 1 1
Category:BLOWER PARTS FOR Q3 BLOWER
PLATE-CUTOFF LB-65691 CUTOFF PLATE1 1 1 1 1 1
HARNESS-WIRING LB-73868 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790A HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 21L9201 "1/3HP,1075RPM,115/60/1,W/MOUNTS" 1 1
51 MOTOR-BLOWER 37J2501 "1/3HP,1075RPM,115/60/1,W/MOUNTS" 1 1 1 1
52 WHEEL-BLOWER LB-29333BJ "1/2""BORE,10"" X 8"""1 1 1 1 1 1
53 CAPACITOR-BLR MTR 59C9201 "5MFD,370VAC"1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q3-50 11/30/2010 Page 5
NOTE
Note1:ORDER 41K3701 NATURAL GAS VALVE AND 48G22O1 LP CONVERSION KIT.Note2:ORDER 93J5101 OR58K7301 NATURAL GAS VALVE AND 28G6101 LP CONVERSIONKIT.Note3:ORDER 31L3701 NATURAL GAS VALVEAND 28G6101 LP CONVERSION KIT.Note4:ORDER 31L8201 NATURAL GAS VALVE AND 48G2201 LPCONVERSION KIT.
LENNOXOEMPARTS.COM
G23Q4/5-100 11/30/2010 Page 1
G23Q4/5-100 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
Category:CABINET PARTS
BUSHING-SNAP 64K0001 SIGHT1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1
PANEL-SET LB-95970B HEAT & BLR ACCESS SET INCLHANDLE(Q3) 1 1
PANEL-SET LB-95970C "HEAT & BLR ACCESS SET INCLHANDLE(Q3/4, 1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1 1 1
CLIP 18J2501 FILTER2 2 2 2 2 2
FASTENER 42J7801 FILTER DOOR1 1 1 1 1 1
DOOR LB-63005 "FILTER(Q3/4,Q4/5)"1 1 1 1 1 1
DOOR LB-65605 FILTER(Q3)1 1 1 1 1 1
CLIP LB-65612 REAR-FILTER1 1 1 1 1 1
FILTER P-8-7822 "16"" X 25"" X 1"",WASHABLE(Q3)"1 1 1 1 1 1
FILTER P-8-7831 "20"" X 25"" X1"",WASHABLE(Q4/5)" 1 1 1 1 1 1
1 PANEL LB-63561 HEAT ACCESS-LOUVER(Q3)1 1 1 1
1 PANEL LB-64695 "HEATACCESS-LOUVER(Q3/4,Q4/5)" 1 1 1 1
2 PANEL LB-64363B BLOWER ACCESS(Q3)1 1 1 1
2 PANEL LB-64363C "BLOWER ACCESS(Q3/4,Q4/5)"1 1 1 1
3 PANEL LB-63559 CAB TOP1 1 1 1 1 1
4 GASKET LB-65618 CAB TOP1 1 1 1 1 1
5 COVER LB-64237 "CONTROL BOX (6""HEIGHT)"1 1 1 1
5 COVER LB-90698 "CONTROL BOX (7""HEIGHT)"1 1 1 1
Category:HEATING PARTS
PLATE-CORBEL LB-91528 LP1 1
ORIFICE-BURNER LB-74093 NAT(DRILL SIZE .0917)4 4 4 4 4 4
ORIFICE-BURNER LB-83508 LP(DRILL SIZE 1.45MM)4 4 4 4 4 4
IGNITOR 41K5601 IGNITOR1 1
LENNOXOEMPARTS.COM
G23Q4/5-100 11/30/2010 Page 2
G23Q4/5-100 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
BRACKET LB-90702 BRACKET - HSI1 1
ORIFICE-PILOT 31J9101 LP1 1 1 1
BRACKET LB-68602A PILOT1 1 1 1
LEAD W082201030 FLAME SENSOR1 1 1 1 1 1
PLUG 25J5801 "PLASTIC 1/2"""1 1
TEE 31J7701 "PLASTIC 1/4"""1 1
SWITCH-PRESS 67K3001 ".55WC,SPST,N.O."1 1
HARNESS-WIRING LB-73867 MAKE UP BOX1 1
KIT-TUBING LB-96015A PRESS SWITCH1 1
PLUG 25J5801 "PLASTIC 1/2"""1 1 1 1
TEE 31J7701 "PLASTIC 1/4"""1 1 1 1
HARNESS-WIRING LB-73867 MAKE UP BOX1 1 1 1
KIT-TUBING LB-96015A PRESS SWITCH1 1 1 1
10 HEAT EXCHANGER LB-65729C (Q3 X UNITS)1 1 1 1
10 HEAT EXCHANGER LB-65729D "(Q3/4,Q4/5 X UNITS)"1 1 1 1
10 HEAT EXCHANGER LB-91001C (Q3 UNITS)1 1 1 1 1 1
10 HEAT EXCHANGER LB-91001D (Q3/4 UNITS)1 1 1 1 1 1
10 HEAT EXCHANGER LB-96300G (Q4/5 UNITS)1 1 1 1 1 1
11 BAFFLE LB-64660A HEAT EXCHANGER(X UNITS)4 4 4 4
12 DIVERTER LB-64618 BOX-FLUE1 1 1 1 1 1
13 GASKET LB-65610 DIVERTER1 1 1 1 1 1
14 SWITCH-ROLLOUT 31J9501 MANUAL RESET1 1 1 1 1 1
14 SWITCH 71G1201 MANUAL RESET1 1
15 BURNER-MAIN LB-64500C CLUSTER ASSY1 1 1 1 1 1
16 MANIFOLD-GAS LB-63016C LESS ORIFICES1 1 1 1 1 1
18 VALVE-GASLP(FOOTNOTE 1)1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q4/5-100 11/30/2010 Page 3
G23Q4/5-100 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
18 VALVE-GAS 31L3701 "NAT,L/IGN CTL,1/2"",(WRODGERS)" 1
18 VALVE-GAS 31L8201 "NAT,L/IGN CTL1/2""(HONEYWELL)" 1
18 VALVE-GAS 41K3701 "NAT,L/IGN CTL 1/2"" H'WELL)"1 1
18 VALVE-GAS 58K7301 "NAT,L/IGN CTL 1/2"" (WRODGERS/TOGGLE T 1 1
18 VALVE-GAS 93J5101 "NAT,L/IGN CTL 1/2"" (WRODGERS W/BLUE M 1
19 BURNER-PILOT 69J3701 "W/ELECTRODE,L/SENSOR(INCL IGN WIRE)" 1 1 1 1
19 BURNER-PILOT 81J0501PR PILOT CONVERSIONKIT-CONVERTS UNIT TO BR 1 1 1 1
20 SENSOR-FLAME 18G8901 SENSOR-FLAME1 1 1 1
20 SENSOR-FLAME KIT LB-94701A INCLUDES SENSOR ANDBRACKET 1 1
21 CONTROL-LIMIT 18J2701 "OUT 140F,IN 110F,(Q4/5)"1 1
21 CONTROL-LIMIT 18J2801 "OUT 165F, IN 135F,SPST"1 1 1 1 1 1
21 CONTROL-LIMIT 73K1901 "OUT 160F,IN 130F,SPST(Q4/5)"1 1 1 1
21 CONTROL-LIMIT 73K2001 "OUT 160F,IN 130F,SPST(Q3)"1 1 1 1
22 SWITCH-PRESS 18J3501 ".55WC,SPST,N.O."1 1 1 1
Category:INDUCED DRAFT ASSEMBLY
40 BLOWER-COMB AIR LB-65734D COMPLETE ASSY ONLY1 1 1 1 1 1
41 GASKET LB-65611 COMB AIR1 1 1 1 1 1
42 ADAPTER LB-65403C FLUE TRANSITION1 1 1 1 1 1
43 GASKET LB-65616 FLUE OUTLET1 1 1 1 1 1
Category:CONTROL PANEL PARTS
BOARD-CIRCUIT 24L8501 INTEGRATED CONTROL1 1
HARNESS-WIRING LB-100429A KIT REPLACES UPPER & LOWER1 1
HARNESS-WIRING LB-94615 UPPER1 1
HARNESS-WIRING LB-94616 LOWER1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2
HARNESS-WIRING LB-73864 CONTROL-UPPER(J20)1 1 1 1
LENNOXOEMPARTS.COM
G23Q4/5-100 11/30/2010 Page 4
G23Q4/5-100 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
HARNESS-WIRING LB-73865 CONTROL-LOWER(P20 TO J20)1 1 1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2 2 2
17 CONTROL-IGN LB-90087A 24V1 1
17 CONTROL-IGN LB-90701A 24V1 1
30 TRANSFORMER 42J3201 "120V PRI,24V SEC,40VA,L/FUSE"1 1 1 1 1 1
31 BREAKER-CIRC 37J5601 250V1 1 1 1 1 1
32 SWITCH 25J1301 SWITCH, INTERLOCK1 1 1 1 1 1
33 BOARD-CIRCUIT LB-90089A CONTROL-BCC1 1 1 1
Category:BLOWER PARTS FOR Q3 BLOWER
PLATE-CUTOFF LB-65691 CUTOFF PLATE1 1 1 1 1 1
HARNESS-WIRING LB-65859 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790A HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 21L9201 "1/3HP,1075RPM,115/60/1,W/MOUNTS" 1 1
51 MOTOR-BLOWER 37J2501 "1/3HP,1075RPM,115/60/1,W/MOUNTS" 1 1 1 1
52 WHEEL-BLOWER LB-29333BJ "1/2""BORE,10"" X 8"""1 1 1 1 1 1
53 CAPACITOR-BLR MTR 59C9201 "5MFD,370VAC"1 1 1 1 1 1
Category:BLOWER PARTS FOR Q3/4 BLOWER
PLATE-CUTOFF LB-10170 CUTOFF PLATE1 1 1 1 1 1
WHEEL-BLOWER LB-29333BJ "1/2"" BORE,10"" X 8"""1 1 1 1 1 1
HARNESS-WIRING LB-73868 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790G HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 21L9301 "1/2HP,1075RPM,115/60/1W/MOUNTS" 1 1
51 MOTOR-BLOWER 37J2401 "1/2HP,1075RPM,115/60/1W/MOUNTS" 1 1 1 1
53 CAPACITOR 39H8901 "7.5MFD,370VAC"1 1 1 1 1 1
Category:BLOWER PARTS FOR Q4/5 BLOWER
PLATE-CUTOFF LB-65692 CUTOFF PLATE1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q4/5-100 11/30/2010 Page 5
G23Q4/5-100 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
MOUNT-MOTOR LB-97863A MOTOR FRAME SECTION SA3 3 3 3 3 3
HARNESS-WIRING LB-73869 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790C HOUSING-BLOWER1 1 1 1 1 1
51 MOTOR-BLOWER 28F0101 "3/4HP,1075RPM,115/60/1L/MOUNTS" 1 1
51 MOTOR-BLOWER 45H3301 "3/4HP,1075RPM,115/60/1L/MOUNTS" 1 1 1 1
52 WHEEL-BLOWER LB-29333BBP "1/2""BORE,11-1/2"" X 9"""1 1 1 1 1 1
53 CAPACITOR 39H5801 "40MFD,370VAC"1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q4/5-100 11/30/2010 Page 6
NOTE
Note1:ORDER 31L3701 NATURAL GAS VALVE AND 28G6101 LP CONVERSION KIT.Note2:ORDER 31L8201NATURAL GAS VALVE AND 48G2201 LP CONVERSION KIT.Note3:ORDER 93J5101 OR 58K7301 NATURAL GASVALVE AND 28G6101 LP CONVERSIONKIT.Note4:ORDER 41K3701 NATURAL GAS VALVE AND 48G2201 LPCONVERSION KIT.
LENNOXOEMPARTS.COM
G23Q4/5-75 11/30/2010 Page 1
G23Q4/5-75 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
Category:CABINET PARTS
BUSHING-SNAP 64K0001 SIGHT1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1
PANEL-SET LB-95970A HEAT & BLR ACCESS SET INCLHANDLE(Q2/3) 1 1
PANEL-SET LB-95970C HEAT & BLR ACCESS SET INCLHANDLE(Q4/5) 1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1 1 1
CLIP 18J2501 FILTER2 2 2 2 2 2
FILTER 31J8101 "14"" X 25"" X1"",WASHABLE(Q2/3)" 1 1 1 1 1 1
FASTENER 42J7801 FILTER DOOR2 2 2 2 2 2
DOOR LB-63005 FILTER(Q4/5)1 1 1 1 1 1
DOOR LB-65608 FILTER(Q2/3)1 1 1 1 1 1
CLIP LB-65612 REAR-FILTER1 1 1 1 1 1
FILTER P-8-7831 "20"" X 25"" X1"",WASHABLE(Q4/5)" 1 1 1 1 1 1
1 PANEL LB-64637 HEAT ACCESS-LOUVER(Q2/3)1 1 1 1
1 PANEL LB-64695 HEAT ACCESS-LOUVER(Q4/5)1 1 1 1
2 PANEL LB-64363A BLOWER ACCESS(Q2/3)1 1 1 1
2 PANEL LB-64363C BLOWER ACCESS(Q4/5)1 1 1 1
3 PANEL LB-63559 CAB TOP(Q4/5)1 1 1 1 1 1
3 PANEL LB-64631 CAB TOP(Q2/3)1 1 1 1 1 1
4 GASKET LB-65617 CAB TOP(Q2/3)1 1 1 1 1 1
4 GASKET LB-65618 CAB TOP(Q4/5)1 1 1 1 1 1
5 COVER LB-64237 "CONTROL BOX (6""HEIGHT)"1 1 1 1
5 COVER LB-90698 "CONTROL BOX (7""HEIGHT)"1 1 1 1
Category:HEATING PARTS
PLATE-CORBEL LB-91527 LP1 1
ORIFICE-BURNER LB-74093 NAT(DRILL SIZE .0917)3 3 3 3 3 3
LENNOXOEMPARTS.COM
G23Q4/5-75 11/30/2010 Page 2
G23Q4/5-75 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
ORIFICE-BURNER LB-83508 LP(DRILL SIZE 1.45MM)3 3 3 3 3 3
ORIFICE-PILOT 31J9101 LP1 1 1 1
BRACKET LB-68602A PILOT1 1 1 1
LEAD W082201030 FLAME SENSOR1 1 1 1 1 1
PLUG 25J5801 "PLASTIC 1/2"""1 1 1 1 1 1
TEE 31J7701 "PLASTIC 1/4"""1 1 1 1 1 1
HARNESS-WIRING LB-73867 MAKE UP BOX1 1 1 1 1 1
KIT-TUBING LB-96015A PRESS SWITCH1 1 1 1 1 1
BRACKET LB-90702 BRACKET - HSI1 1
10 HEAT EXCHANGER LB-65729B (Q2/3 X UNITS)1 1 1 1
10 HEAT EXCHANGER LB-65729F (Q4/5 X UNITS)1 1 1 1
10 HEAT EXCHANGER LB-91001B (Q2/3 UNITS)1 1 1 1 1 1
10 HEAT EXCHANGER LB-91001F (Q4/5 UNITS)1 1 1 1 1 1
11 BAFFLE LB-64660A HEAT EXCHANGER(X UNITS)3 3 3 3
12 DIVERTER LB-64617 BOX-FLUE1 1 1 1 1 1
13 GASKET LB-65609 DIVERTER1 1 1 1 1 1
14 SWITCH-ROLLOUT 31J9501 MANUAL RESET(X UNITS)1 1
14 SWITCH-MANUAL 31J9601 MANUAL RESET1 1 1 1
14 SWITCH 71G1201 MANUAL RESET1 1
15 BURNER-MAIN LB-64500B CLUSTER ASSY1 1 1 1 1 1
16 MANIFOLD-GAS LB-63016B LESS ORIFICES1 1 1 1 1 1
18 VALVE-GASLP(FOOTNOTE 1)1 1 1 1 1 1
18 VALVE-GAS 31L3701 "NAT,L/IGN CTL 1/2""(WRODGERS)" 1
18 VALVE-GAS 31L8201 "NAT, L/IGN CTL1/2""(HONEYWELL)" 1
18 VALVE-GAS 41K3701 "NAT,L/IGN CTL-1/2"" H'WELL"1 1
18 VALVE-GAS 58K7301 "NAT,L/IGN CTL 1/2"" (WRODGERS W/TOGGLE 1 1
LENNOXOEMPARTS.COM
G23Q4/5-75 11/30/2010 Page 3
G23Q4/5-75 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
18 VALVE-GAS 93J5101 "NAT,L/IGN CTL 1/2"" (WRODGERS BLUE MAN 1
19 BURNER-PILOT 69J3701 PILOT W/ELECTRODE .1 1 1 1
19 BURNER-PILOT 81J0501PR PILOT CONVERSIONKIT-CONVERTS UNIT TO BR 1 1 1 1
20 SENSOR-FLAME 18G8901 SENSOR-FLAME1 1 1 1
20 SENSOR-FLAME KIT LB-94701A INCLUDES SENSOR & BRACKET1 1
21 CONTROL-LIMIT 18J3701 "OUT 205F,IN 175F,SPST(Q4/5)(FOOTNOTE 5 1 1 1 1
21 CONTROL-LIMIT 25J3001 "OUT 125F,IN 155F,SPST(Q2/3)"1 1
21 CONTROL-LIMIT 73K1801 "OUT 140F,IN 170F,SPST(Q2/3)"1 1 1 1
21 CONTROL-LIMIT 79J2301 "OUT 195F,IN 165F,SPST(Q4/5) &X UNITS)" 1 1 1 1 1 1
22 SWITCH-PRESS 18J3301 ".34WC,SPST,N.O."1 1 1 1
22 SWITCH-PRESS 67K3201 ".34WC,SPST,N.O."1 1
23 IGNITOR 41K5601 IGNITOR1 1
Category:INDUCED DRAFT ASSEMBLY
40 BLOWER-COMB AIR LB-65734C COMPLETE ASSY ONLY1 1 1 1 1 1
41 GASKET LB-65611 COMB AIR1 1 1 1 1 1
42 ADAPTER LB-65403B FLUE TRANSITION1 1 1 1 1 1
43 GASKET LB-65616 FLUE OUTLET1 1 1 1 1 1
Category:CONTROL PANEL PARTS
BOARD-CIRCUIT 24L8501 INTEGRATED CONTROL1 1
HARNESS-WIRING LB-100429A KIT REPLACES UPPER & LOWER1 1
HARNESS-WIRING LB-94615 UPPER1 1
HARNESS-WIRING LB-94616 LOWER1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2
HARNESS-WIRING LB-73864 CONTROL-UPPER(J20)1 1 1 1
HARNESS-WIRING LB-73865 CONTROL-LOWER(P20 TO J20)1 1 1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2 2 2
LENNOXOEMPARTS.COM
G23Q4/5-75 11/30/2010 Page 4
G23Q4/5-75 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
17 CONTROL-IGN LB-90087A 24V1 1
17 CONTROL-IGN LB-90701A 24V1 1
30 TRANSFORMER 42J3201 "120V PRI,24V SEC,40VA,L/FUSE"1 1 1 1 1 1
31 BREAKER-CIRC 37J5601 250V1 1 1 1 1 1
32 SWITCH 25J1301 SWITCH, INTERLOCK1 1 1 1 1 1
33 BOARD-CIRCUIT LB-90089A CONTROL-BCC1 1 1 1
Category:BLOWER PARTS FOR Q2/3 BLOWER
PLATE-CUTOFF LB-65691 CUTOFF PLATE1 1 1 1 1 1
HARNESS-WIRING LB-73868 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790A HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 21L9201 "1/3HP,1075RPM,115/60/1,W/MOUNTS" 1 1
51 MOTOR-BLOWER 37J2501 "1/3HP,1075RPM,115/60/1,W/MOUNTS" 1 1 1 1
52 WHEEL-BLOWER LB-29333BJ "1/2""BORE,10"" X 8"""1 1 1 1 1 1
53 CAPACITOR-BLR MTR 59C9201 "5MFD,370VAC"1 1 1 1 1 1
Category:BLOWER PARTS FOR Q4/5 BLOWER
PLATE-CUTOFF LB-65856 CUTOFF PLATE1 1 1 1 1 1
MOUNT-MOTOR LB-97863A MOTOR FRAME SECTION SA3 3 3 3 3 3
HARNESS-WIRING LB-73870 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790H HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 28F0101 "3/4HP,1075RPM,115/60/1L/MOUNTS" 1 1
51 MOTOR-BLOWER 45H3301 "3/4HP,1075RPM,115/60/1L/MOUNTS" 1 1 1 1
52 WHEEL-BLOWER LB-29333BBP "1/2"" BORE,11-1/2"" X 9"""1 1 1 1 1 1
53 CAPACITOR 39H5801 "40MFD,370VAC"1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q4/5-75 11/30/2010 Page 5
NOTE
Note1:ORDER 41K3701 NATURAL GAS VALVE AND 48G2201 LP CONVERSION KIT.Note2:ORDER 93J5101 OR58K7301 NATURAL GAS VALVE AND 28G6101 LP CONVERSIONKIT.Note3:ORDER 31L8201 NATURAL GAS VALVEAND 48G2201 LP CONVERSION KIT.Note4:ORDER 31L3701 NATURAL GAS VALVE AND 28G6101 LPCONVERSION KIT.Note5:DASH 3,4,5,6 NON-NOX UNITS WERE MANUFACTURED WITH 79J2301. USE 18J3701ASA REPLACEMENT.
LENNOXOEMPARTS.COM
G23Q5/6-125 11/30/2010 Page 1
G23Q5/6-125 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
Category:CABINET PARTS
BUSHING-SNAP 64K0001 SIGHT1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1
PANEL-SET LB-95970C HEAT & BLR ACCESS SET INCLHANDLE(Q3/4) 1 1
PANEL-SET LB-95970D HEAT & BLR ACCESS SET INCLHANDLE(Q5/6) 1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1 1 1
CLIP 18J2501 FILTER2 2 2 2 2 2
FASTENER 42J7801 FILTER DOOR2 2 2 2 2 2
DOOR LB-63005 FILTER1 1 1 1 1 1
CLIP LB-65612 REAR-FILTER1 1 1 1 1 1
FILTER P-8-7831 "20"" X 25"" X 1"",WASHABLE"1 1 1 1 1 1
1 PANEL LB-64657 HEAT ACCESS-LOUVER(Q5/6)1 1 1 1
1 PANEL LB-64695 HEAT ACCESS-LOUVER(Q3/4)1 1 1 1
2 PANEL LB-64363C BLOWER ACCESS(Q3/4)1 1 1 1
2 PANEL LB-64363D BLOWER ACCESS(Q5/6)1 1 1 1
3 PANEL LB-64214 CAB TOP(Q3/4)1 1 1 1 1 1
3 PANEL LB-64632 CAB TOP(Q5/6)1 1 1 1 1 1
4 GASKET LB-65619 CAB TOP(Q5/6)1 1 1 1 1 1
4 GASKET LB-74058 CAB TOP(Q3/4)1 1 1 1 1 1
5 COVER LB-64237 "CONTROL BOX (6""HEIGHT)"1 1 1 1
5 COVER LB-90698 "CONTROL BOX (7""HEIGHT)"1 1 1 1
Category:HEATING PARTS
PLATE-CORBEL LB-91529 LP1 1
ORIFICE-BURNER LB-74093 NAT(DRILL SIZE .0917)5 5 5 5 5 5
ORIFICE-BURNER LB-83508 LP(DRILL SIZE 1.45MM)5 5 5 5 5 5
ORIFICE-PILOT 31J9101 LP1 1 1 1
LENNOXOEMPARTS.COM
G23Q5/6-125 11/30/2010 Page 2
G23Q5/6-125 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
BRACKET LB-68602A PILOT1 1 1 1
LEAD W082201030 FLAME SENSOR1 1 1 1 1 1
PLUG 25J5801 "PLASTIC 1/2"""1 1 1 1 1 1
TEE 31J7701 "PLASTIC 1/4"""1 1 1 1 1 1
HARNESS-WIRING LB-73867 MAKE UP BOX1 1 1 1 1 1
KIT-TUBING LB-96015A PRESS SWITCH1 1 1 1 1 1
BRACKET LB-90702 BRACKET - HSI1 1
10 HEAT EXCHANGER LB-65729E (Q5/6 X UNITS)1 1 1 1
10 HEAT EXCHANGER LB-65729G (Q3/4 X UNITS)1 1 1 1
10 HEAT EXCHANGER LB-91001E (Q5/6 UNITS)1 1 1 1 1 1
10 HEAT EXCHANGER LB-91001G (Q3/4 UNITS)1 1 1 1 1 1
11 BAFFLE LB-64660A HEAT EXCHANGER(X UNITS)5 5 5 5
12 DIVERTER LB-64618 BOX-FLUE1 1 1 1 1 1
13 GASKET LB-65610 DIVERTER1 1 1 1 1 1
14 SWITCH-MANUAL 31J9601 MANUAL RESET1 1 1 1 1 1
14 SWITCH 71G1201 MANUAL RESET1 1
15 BURNER-MAIN LB-64500D CLUSTER ASSY1 1 1 1 1 1
16 MANIFOLD-GAS LB-63016D LESS ORIFICES1 1 1 1 1 1
18 VALVE-GASLP(FOOTNOTE 1)1 1 1 1 1 1
18 VALVE-GAS 31L3701 "NAT,L/IGN CTL,1/2""(WRODGERS)" 1
18 VALVE-GAS 31L8201 "NAT,L/IGNCTL,1/2""(HONEYWELL)" 1
18 VALVE-GAS 41K3701 "NAT,L/IGN CTL-1/2"" H'WELL"1 1
18 VALVE-GAS 58K7301 "NAT,L/IGN CTL 1/2"" (WRODGERS W/TOGGLE 1 1
18 VALVE-GAS 93J5101 "NAT,L/IGN CTL 1/2"" (WRODGERS W/BLUE M 1
19 BURNER-PILOT 69J3701 "W/ELECTRODE,L/SENSOR(INCL IGN LEAD)" 1 1 1 1
19 BURNER-PILOT 81J0501PR PILOT CONVERSION KITCONVERTS UNIT TO BR 1 1 1 1
LENNOXOEMPARTS.COM
G23Q5/6-125 11/30/2010 Page 3
G23Q5/6-125 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
20 SENSOR-FLAME 18G8901 SENSOR-FLAME1 1 1 1
20 SENSOR-FLAME KIT LB-94701A INCLUDES SENSOR & BRACKET1 1
21 CONTROL-LIMIT 25J3001 "OUT 155F,IN 125F,(Q3/4)"1 1
21 CONTROL-LIMIT 37H7301 "OUT 180F,IN 150F,7""INS(Q5/6)"1 1
21 CONTROL-LIMIT 73K1701 "OUT 235F, IN 205F,SPST(Q5/6)"1 1 1 1
21 CONTROL-LIMIT 80K8901 "OUT 180F,IN 150F,(Q3/4)"1 1 1 1
22 SWITCH-PRESS 18J3501 ".55WC,SPST,N.O."1 1 1 1
22 SWITCH-PRESS 67K3001 ".55WC,SPST,N.O."1 1
23 IGNITOR 41K5601 IGNITOR1 1
Category:INDUCED DRAFT ASSEMBLY
40 BLOWER-COMB AIR LB-65734E COMPLETE ASSY ONLY1 1 1 1 1 1
41 GASKET LB-65611 COMB AIR1 1 1 1 1 1
42 ADAPTER LB-65403D FLUE TRANSITION(Q5/6)1 1 1 1 1 1
42 ADAPTER LB-65403E FLUE TRANSITION(Q3/4)1 1 1 1 1 1
43 GASKET LB-65616 FLUE OUTLET1 1 1 1 1 1
Category:CONTROL PANEL PARTS
BOARD-CIRCUIT 24L8501 INTEGRATED CONTROL1 1
HARNESS-WIRING LB-100429A KIT REPLACES UPPER & LOWER1 1
HARNESS-WIRING LB-94615 UPPER1 1
HARNESS-WIRING LB-94616 LOWER1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2
HARNESS-WIRING LB-73864 CONTROL-UPPER(J20)1 1 1 1
HARNESS-WIRING LB-73865 CONTROL-LOWER(P20 TO J20)1 1 1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2 2 2
17 CONTROL-IGN LB-90087A 24V1 1
17 CONTROL-IGN LB-90701A 24V1 1
LENNOXOEMPARTS.COM
G23Q5/6-125 11/30/2010 Page 4
G23Q5/6-125 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
30 TRANSFORMER 42J3201 "120V PRI,24V SEC,40VA,L/FUSE"1 1 1 1 1 1
31 BREAKER-CIRC 37J5601 250V1 1 1 1 1 1
32 SWITCH 25J1301 SWITCH, INTERLOCK1 1 1 1 1 1
33 BOARD-CIRCUIT LB-90089A CONTROL-BCC1 1 1 1
Category:BLOWER PARTS FOR Q3/4 BLOWER
PLATE-CUTOFF LB-65854 CUTOFF PLATE1 1 1 1 1 1
HARNESS-WIRING LB-73868 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790J HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 21L9301 "1/2HP,1075RPM,115/60/1W/MOUNTS" 1 1
51 MOTOR-BLOWER 86H7101 "1/2HP,1075RPM,115/60/1W/MOUNTS" 1 1 1 1
52 WHEEL-BLOWER LB-29333BM "1/2"" BORE,10"" X 10"""1 1 1 1 1 1
53 CAPACITOR 39H8901 "7.5MFD,370VAC"1 1 1 1 1 1
Category:BLOWER PARTS FOR Q5/Q6 BLOWER
PLATE-CUTOFF LB-65532 CUTOFF PLATE1 1 1 1 1 1
MOUNT-MOTOR LB-32877C MOUNT FS-19 (use 23J28)3 3 3 3 3 3
HARNESS-WIRING LB-73869 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790D HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 28F0101 "3/4HP,10754PM,115/60/1"1 1
51 MOTOR-BLOWER 45H3301 "3/4HP,1075RPM,115/60/1"1 1 1 1
52 WHEEL-BLOWER LB-29333BBC "1/2""BORE,12"" X 12"""1 1 1 1 1 1
53 CAPACITOR 39H5801 "40MFD,370VAC"1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q5/6-125 11/30/2010 Page 5
NOTE
Note1:ORDER 41K3701 NATURAL GAS VALVE AND 48G2201 LP CONVERSION KIT.Note2:ORDER 93J5101 OR58K7301 NATURAL GAS VALVE AND 28G6101 LP CONVERSIONKIT.Note3:ORDER 31L8201 NATURAL GAS VALVEAND 48G2201 LP CONVERSION KIT.Note4:ORDER 31L3701 NATURAL GAS VALVE AND 28G6101 LPCONVERSION KIT.
LENNOXOEMPARTS.COM
G23Q5/6-150 11/30/2010 Page 1
G23Q5/6-150 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
Category:CABINET PARTS
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1
PANEL-SET LB-95970D HEAT & BLR ACCESS SET INCLHANDLE 1 1
HANDLE-DOOR 77C1501 DOOR-HEAT ACCESS1 1 1 1
CLIP 18J2501 FILTER2 2 2 2 2 2
FASTENER 42J7801 FILTER DOOR2 2 2 2 2 2
DOOR LB-63005 FILTER1 1 1 1 1 1
CLIP LB-65612 REAR-FILTER1 1 1 1 1 1
FILTER P-8-7831 "20"" X 25"" X 1"",WASHABLE"1 1 1 1 1 1
1 PANEL LB-64657 HEAT ACCESS-LOUVER1 1 1 1
2 PANEL LB-64363D BLOWER ACCESS1 1 1 1
3 PANEL LB-64632 CAB TOP1 1 1 1 1 1
4 GASKET LB-65619 CAB TOP1 1 1 1 1 1
5 COVER LB-64237 "CONTROL BOX (6""HEIGHT)"1 1 1 1
5 COVER LB-90698 "CONTROL BOX (7""HEIGHT)"1 1 1 1
Category:HEATING PARTS
PLATE-CORBEL LB-91530 LP1 1
ORIFICE-BURNER LB-74093 NAT(DRILL SIZE .0917)6 6 6 6 6 6
ORIFICE-BURNER LB-83508 LP(DRILL SIZE 1.45MM)6 6 6 6 6 6
ORIFICE-PILOT 31J9101 LP1 1 1 1
BRACKET LB-68602A PILOT1 1 1 1
LEAD W082201030 FLAME SENSOR1 1 1 1 1 1
PLUG 25J5801 "PLASTIC, 1/2"""1 1 1 1 1 1
TEE 31J7701 "PLASTIC, 1/4"""1 1 1 1 1 1
HARNESS-WIRING LB-73867 MAKE UP BOX1 1 1 1 1 1
KIT-TUBING LB-96015A PRESS SWITCH1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q5/6-150 11/30/2010 Page 2
G23Q5/6-150 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
BRACKET LB-90702 BRACKET - HSI1 1
10 HEAT EXCHANGER LB-65729H (Q5/6 X UNITS)1 1 1 1
10 HEAT EXCHANGER LB-91001H (Q5/6 UNITS)1 1 1 1 1 1
11 BAFFLE LB-64660A HEAT EXCHANGER(X UNITS)6 6 6 6
12 DIVERTER LB-64245 BOX-FLUE1 1 1 1 1 1
13 GASKET LB-65871 DIVERTER1 1 1 1 1 1
14 SWITCH-ROLLOUT 31J9501 MANUAL RESET1 1 1 1
14 SWITCH 71G1201 MANUAL RESET1 1
14 SWITCH 71G1501 MANUAL RESET(X UNITS)1 1
15 BURNER-MAIN LB-64500E CLUSTER ASSY1 1 1 1 1 1
16 MANIFOLD-GAS LB-63016E L/ORIFICES1 1 1 1 1 1
18 VALVE-GASLP(FOOTNOTE 1)1 1 1 1 1 1
18 VALVE-GAS 31L3701 "NAT,L/IGN CTL 1/2""(WRODGERS)" 1
18 VALVE-GAS 31L8201 "NAT,L/IGN CTL1/2""(HONEYWELL)" 1
18 VALVE-GAS 41K3701 "NAT,L/IGN CTL-1/2"" H'WELL"1 1
18 VALVE-GAS 58K7301 "NAT,L/IGN CTL 1/2"" (WRODGERS W/TOGGLE 1 1
18 VALVE-GAS 93J5101 "NAT,L/IGN CTL 1/2"" (WRODGERS W/BLUE M 1
19 BURNER-PILOT 69J3701 "W/ELECTRODE,L/SENSOR(INCL IGN WIRE)" 1 1 1 1
19 BURNER-PILOT 81J0501PR PILOT CONVERSION KITCONVERTS UNIT TO BR 1 1 1 1
20 SENSOR-FLAME 18G8901 SENSOR-FLAME1 1 1 1
20 SENSOR-FLAME KIT LB-94701A INCLUDES SENSOR & BRACKET1 1
21 CONTROL-LIMIT 53J8901 "OUT 155F, IN 125F,SPST"1 1
21 CONTROL-LIMIT 73K2101 "OUT 175F, IN 145F,SPST"1 1 1 1
22 SWITCH-PRESS 48J4901 ".70WC,SPST,N.O."1 1 1 1
22 SWITCH-PRESS 67K2801 ".70WC,SPST,N.O."1 1
23 IGNITOR 41K5601 IGNITOR1 1
LENNOXOEMPARTS.COM
G23Q5/6-150 11/30/2010 Page 3
G23Q5/6-150 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
Category:INDUCED DRAFT ASSEMBLY
40 BLOWER-COMB AIR LB-65734F COMPLETE ASSY ONLY1 1 1 1 1 1
41 GASKET LB-65611 COMB AIR1 1 1 1 1 1
42 ADAPTER LB-65409 FLUE TRANSITION1 1 1 1 1 1
43 GASKET LB-65616 FLUE OUTLET1 1 1 1 1 1
Category:CONTROL PANEL PARTS
BREAKER-CIRC 37J5601 250V1 1 1 1 1 1
BOARD-CIRCUIT 24L8501 INTEGRATED CONTROL1 1
HARNESS-WIRING LB-100429A KIT REPLACES UPPER & LOWER1 1
HARNESS-WIRING LB-94615 UPPER1 1
HARNESS-WIRING LB-94616 LOWER1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2
HARNESS-WIRING LB-73864 CONTROL-UPPER(J20)1 1 1 1
HARNESS-WIRING LB-73865 CONTROL-LOWER(P20 TO J20)1 1 1 1
BUSHING-SNAP P-8-8278 BUSHING-BLK SNAP2 2 2 2
17 CONTROL-IGN LB-90087A 24V1 1
17 CONTROL-IGN LB-90701A 24V1 1
30 TRANSFORMER 42J3201 "120V PRI,24V SEC,40VA,L/FUSE"1 1 1 1 1 1
32 SWITCH 25J1301 SWITCH, INTERLOCK1 1 1 1 1 1
33 BOARD-CIRCUIT LB-90089A CONTROL-BCC1 1 1 1
Category:BLOWER PARTS FOR Q5/Q6 BLOWER
PLATE-CUTOFF LB-65532 CUTOFF PLATE1 1 1 1 1 1
MOUNT-MOTOR LB-32877C MOUNT FS-19 (use 23J28)3 3 1 1 1 1
HARNESS-WIRING LB-73868 MOTOR1 1 1 1
50 HOUSING-BLOWER LB-65790D HOUSING-BLR1 1 1 1 1 1
51 MOTOR-BLOWER 28F0101 "3/4HP,1075RPM,115/60/1"1 1
LENNOXOEMPARTS.COM
G23Q5/6-150 11/30/2010 Page 4
G23Q5/6-150 DASH/Revision #with Qty
Key Part Name Part Number Description 1 2 3 4 5 6
51 MOTOR-BLOWER 45H3301 "3/4HP,1075RPM,115/60/1"1 1 1 1
52 WHEEL-BLOWER LB-29333BBC "1/2"" BORE,12"" X 12"""1 1 1 1 1 1
53 CAPACITOR 39H5801 "40MFD,370VAC"1 1 1 1 1 1
LENNOXOEMPARTS.COM
G23Q5/6-150 11/30/2010 Page 5
NOTE
Note1:ORDER 93J5101 OR 58K7301 NATURAL GAS VALVE AND 28G6101 LP CONVERSIONKIT.Note2:ORDER31L8201 NATURAL GAS VALVE AND 48G2201 LP CONVERSION KIT.Note3:ORDER 31L3701 NATURAL GAS VALVEAND 28G6101 LP CONVERSION KIT.Note4:ORDER 41K3701 NATURAL GAS VALVE AND 48G2201 LPCONVERSION KIT.
LENNOXOEMPARTS.COM
