-~rJ1OJH. N D E EIiIRE

FEATURES67 SAE net hp (50 kW)

Single-lever loader controlPower Shift Hi-la-Reverse

Dura-Trax'" undercarriage with boron-steeldeep-heat-treated, strutted, sealed track links;deep-heat-treated sealed rollers; boron-steelthrough-hardened grousers; sealed front idlerand carrier roller

Self-adjusting, oil-cooled steeringclutches and brakes

Roll-over protective structure (ROPS)

Vandal protection

ADD VERSATILITY WITH:Winch

Fairleadand drawbar

Ripper

Backhoe

Multipurpose bucket

log and lumber fork

Integral 'log arch

ENGINE PERFORMANCE

,900 1300 1700 2100 2500

ENGINE SPEED-RPM

LOADER SPECIFICATIONS

Buckets:Digging

Multipurpose

SAE HeapedCapacity1% cu. yd.(0.96 m3)1% cu. yd.(0.96 m3)

Width72.25 in.(1.84 m)

73 in.(1.85m)

Operating Information:Breakout force .15,174 lb. (68 kN) (6883 kg)SAE tipping load. . . . . . . . . . . .11,000 lb. (4990 kg)Maximum dumping angle. . . . . . . . . . . . . . . .50 deg.Raisingtime 7.0sec.Dumpingtime 1.6sec.Loweringtime 4.0sec.

4

~_. -

455D LOADER

-'wWI?;>--'!!:-a:w?;0c..wCfJa:0I

tuz

- - _:i~~~~~~~:_~-~~p~~~1!~:~: -;/~-::-

---1--

..'.~2.6 in.(66 mm)

i

10ft.9in.(3.28m)

8 ft. 5.9 in.(2.59 m) 8 ft. 7 in.

(2.62m)

6.42 in.(163 mm) --'- -- -- -Lf---r-

1 3.0 in. (76mm)13 ft. 8.25 in. (4.17 m)

NrT) Ib-It

258 190

f 244

TORQUE--180

230 170

217 160lJz 203 150

190 140hp kW

t-- -HOR EPOWER 70 52

60 45

50 37

Ib/ 40 30

g/kWh hph 30 22-' 274 0,45 t-- - FUEL CONSUMPTI N- t--

243 0.40lL 213 0,35

455D LOADER SPECIFICATIONS

(Specifications and design subject to change w~hout notice. Wherever applicable, specifications are in accordance with ICED and SAE Standards. Except where otherwise noted, thesespecifications are based on a unit equipped w~ 1V4cu. yd. (0.96 m3)digging bucket w/teeth. roll-over protective structure, full fuel tank, 17S-lb. (79 kg operator) and standard equipment)

Power (@ 2500 engine rpm): SAEGross 72hp(53.7kW)Net 67hp(50kW)

DIN

50kWNet engine power is with standard equipment including air cleaner, exhaust system, alter-nator and cooling Ian. Gross power is without cooling Ian. Power ratings are at standardconditions per SAE J1349 and DIN 6270. No derating is required up to 10,0001eet (3050 m)altitude.

Engine: John Deere 4-cylinder turbocharged diesel, 4-stroke cycleBore and. stroke . . . . . . . . . . . . . . . . . . . 4.02x4.33 in. (102x 110 mm)Piston displacement 219cu.in.(3.589L)Compression ratio.. . . . . . . .. .. . .. . . . . .. . .. . . . .. . . . . . . 16.2 to 1Maximum torque @ 1400 rpm 190 Ib-ft (258 Nm) (26.3 kg-m)Torquerise 35percentNACCor AMA(U.S. Tax) horsepower 25.8Lubrication.. . . . . . . . . . . . . . . . . . . . Pressure system w/full-flow filterMainbearings 5Cooling. . . . . . . . . . . . . . Pressurized w/thermostat and fixed bypassFan BlowerAir cleaner w/restriction indicator DryElectrical system 12-voltw/alternatorBattery (12 volt) . . . . . . . . . . . . . . . . . . Reserve capacity: 180 minutes

Transmission. . . . . . . . . . . . . H-L-R: 4 speed ranges; with high, lowand reverse speeds shifted hydraulically without clutching in eachrange.

Clutch.. . . . .. . . . . . . . .. . . .. .. . . . . .. .11-in. (279 mm) single-disk

Steering:Steering clutches and brakes are controlled by a single lever for eachtrack (pedal steering optional). A pedal provides braking and lock-down for parking.Clutches. . . . . . . . . Oil-cooled, hydraulically-actuated, multiple-disk,11-in. (279 mm) disks, 16 friction surfaces per clutch.Brakes. . . . . . . Self-adjusting, self-energizing, oil-cooled contractingband with bonded lining.

Hydraulic System:Control. . . . . . . . . . . . . . . . . . . . . . Single-lever triple hydraulic systemPump... .: Gear, 28gpm (1.76 Us)Pressure 2250 psi (15 514 kPa) (158.2 kg/cm2)Oil lines . . Seamless steel tubing; double-wire-braid hoseFilter Spin-onmicronic

Special Equipment:Brush screensCab (includes ROPS)Cigaret lighterLimb risers w/overhead exhaustPTO (1000 rpm)Rear counterweight for multipurpose

bucket or log loader13-in. (330 mm) rubber shoesTwo batteriesWinch drive

,.

.~

,

Hydraulic Cylinders: Bore StrokeBoom, two . . . .. . . . . .. . . .4.25 in. (108 mm) 28.25 in. (718 mm)Bucket, two. . . . . . . . . . . .. 3.5 in. (89 mm) 31.1 in. (790 mm)Cylinder rods. . . . . . Ground, heat-treated, chrome-plated, polishedBoom cylinder rods 2.25 In. (57mm)dia.Bucketcylinderrods .1.75 in. (44 mm) dia.

Undercarriage: (5-roller track frame with full-length rock guards.Dura-Trax'. deep-heat-treated components.Triple semi-grouser, open-center. . . . . . . . . . . . . . . . 14 in. (356 mm)Track shoes, each side 37Ground contact area. . . . . . . . . .. . . .. . .. . 2128 sq. in. (13729 cm2)Ground pressure. . . . . . . . . . . . . . . 8.1 psi (55.8 kPa) (0.569 kg/cm2)Length of track on ground 76in.(1.93m)Track gauge 52in.(1.32m)Carrier roller 1Adjustment HydraulicClearance at rear crossbar. .. . . . .. . . .. . . . .. . . 14.25 in. (362 mm)

Capacities: U.S.Cooling system 4gal.Fuel tank 31 gal.Crankcase, including filter 9qt.Transmission 8gal.Finaldrive(each) 6.25qt.Loader hydraulic reservoir. . . . . . . . . . . . . . . . . . 7 gal.Loaderhydraulicsystem 13gal.Steering clutch housing (each side) . . . . . . . . . . 28 qt.

Additional Standard Equipment:Boom safety lock barBottom guard counterweight

w/fixed drawbarBucket level indicatorCold-weather starting aidDeluxe cushion seat w/armrestsElectric hourmeterEngine side shieldsFront idler shieldFront hitchFront and rear bottom guardsHornKey switch w/pushbutton safety

startLightsMaster electrical disconnect switchMufflerPrecleanerRadiator sand shieldReturn to digROPS w/canopy and seat beltSprocket weightsTachometerTrash-resistant radiatorVandal protection

LIters15

1178.530

5.912749

26.5

SAE Operating Weight w/ROPS . . . . . . . . . . . . 17,150 lb. (7780 kg)

5

Gear Travel Speeds Gear Travel Speedsmph km/h mph km/h

Range 1 Range 3Low 1.3 2.1 Low 3.0 4.8High 1.8 2.9 High 4.3 6.9Reverse 1.7 2.7 Reverse 4.1 6.6

Range 2 Range 4Low 2.0 3.2 Low 4.7 7.6High 2.8 4.5 High 6.7 10.8Reverse 2.7 4.3 Reverse 6.4 10.3