Jaltest 17.3 Presentation - eclipse-tech.co.uk · PDF fileZF TraXon transmission - Iveco protocol (system under generic paths) Note: The systems listed can also be found in IRISBUS

www.jaltest.com

September

2017

Jaltest 17.3 Presentation

2

September 2017 Jaltest 17.3

INDEX

1. OVERVIEW ................................................................................................................................................3

2. JALTEST 17.3, NEXT RELEASE ....................................................................................................................4

2.1. JALTEST SOFT 17.3, NEW FUNCTIONS ............................................................................................................. 4 2.1.1. Vehicle search by VIN .................................................................................................................... 4 2.1.2. Customer’s troubleshootings and procedures ............................................................................... 5 2.1.3. Verification marks in troubleshootings and procedures steps ...................................................... 6 2.1.4. Report management improvements ............................................................................................. 7 2.1.5. Shortcuts to System Display .......................................................................................................... 8 2.1.6. System Scan: main systems undetected are warned ..................................................................... 9 2.1.7. Others .......................................................................................................................................... 10

2.2. GRP ....................................................................................................................................................... 10 2.2.1. Improvement in the management of customers with towed vehicles ........................................ 10 2.2.2. GRP Network ............................................................................................................................... 11

JALTEST 17.3, NEW DIAGNOSIS FUNCTIONS .................................................................................................... 14

2.3. DAF TRUCKS............................................................................................................................................ 14 2.4. IVECO TRUCKS ........................................................................................................................................ 15 2.5. MAN TRUCKS .......................................................................................................................................... 15 2.6. MERCEDES-BENZ TRUCKS ....................................................................................................................... 16 2.7. RENAULT TRUCKS ................................................................................................................................... 17 2.8. SCANIA TRUCKS ...................................................................................................................................... 17 2.9. VOLVO TRUCKS ....................................................................................................................................... 18 2.10. BUSES ..................................................................................................................................................... 20

2.10.1. IVECO/IRISBUS ............................................................................................................................. 20 2.10.2. MERCEDES-BENZ/SETRA.............................................................................................................. 20 2.10.3. SCANIA ......................................................................................................................................... 21 2.10.4. VOLVO ......................................................................................................................................... 21 2.10.5. Others .......................................................................................................................................... 22

2.11. TRAILER SYSTEMS ...................................................................................................................................... 23 2.11.1. Wabco Systems ........................................................................................................................... 24 2.11.2. Haldex Systems ............................................................................................................................ 24 2.11.3. Knorr-Bremse Systems ................................................................................................................. 24

2.12. LCV ....................................................................................................................................................... 27 2.12.1. FORD ............................................................................................................................................ 27 2.12.2. IVECO ........................................................................................................................................... 27 2.12.3. MAZDA ........................................................................................................................................ 28 2.12.4. MERCEDES ................................................................................................................................... 28 2.12.5. PSA GROUP .................................................................................................................................. 28 2.12.6. VOLKSWAGEN ............................................................................................................................. 28

2.13. OTHERS .................................................................................................................................................. 29

3


1. OVERVIEW

New version Jaltest 17.3 software once again offers more improvements and innovations which

show that it is the benchmark multibrand diagnostic tool for commercial, agricultural and OHW (Off

High-Way) vehicles.

- Vehicle search by VIN. Access to models through VIN number or directly through plate number

from client portfolio.

- Parameter files backup copy to network.

- Possibility for the customer to create specific troubleshootings.

- Report management improvements, possibility for adding comments at any time during the

diagnostic session.

- And much more…

Some of the most important innovations of this new version are listed below. With these

functionalities, amongst others, Jaltest has a very wide coverage to meet the needs of workshop.

Use “Jaltest Report” to access to additional information about the specific coverage for each

brand.

- DAF: Function extension of Paccar PCI and PMCI-2 systems. Modification of speed limit in ECS-

DC5 systems.

- IVECO: New AEBS ARS327 radar control system, which includes technical information.

- MAN: Improvement and adaptation of ECAS CAN 2 system functions for articulated buses.

- MERCEDES: SCR-Related memory reset and torque limitation disabling in Bluetec systems.

- SCANIA: Calibration of distance sensor in DIS 2 system for the adaptive cruise control function.

- RENAULT: Engine cooling fan clutch test, vehicles with V3 technologies.

- VOLVO: Suspension calibration for 4x2 and 6x2 vehicles, V4 technologies.

- TRAILER: Printing of reports of end-of-line test (EOLT) in EBS Trailer systems.

- LCV: Both new HI-Matic transmission in Iveco Daily and other new systems for brands of PSA,

VW, groups development should be highlighted… New regenerations of Diesel Particulate

Filter (DPF).

- AGV: Spool valve calibration and parameter setting on brands like Fendt or Massey Ferguson,

where new 700 Series models have been created.

- OHW: Engine management systems development on JCB brand.

- And much more…

In addition, more technical releases, wiring diagrams, fuses and relays box diagrams,

troubleshootings by symptoms and error codes, System Display, etc… are included. And in the vehicle

technical data section, there is information about the identification plate of engine types and more

data and important information such as the process for changing AdBlue/DEF module filters on some

brands have been added.

4


2. Jaltest 17.3, next release

2.1. Jaltest Soft 17.3, new functions

2.1.1. Vehicle search by VIN

Access to models through VIN number or directly through plate number from client portfolio.

5


2.1.2. Customer’s troubleshootings and procedures

Possibility for the customer to create troubleshootings and specific procedures. In addition,

they can be shared through Jaltest feedback service.

After adding a specific troubleshooting, verification steps should be determined. A compulsory

name for each step should be assigned, while the description is optional.

6


2.1.3. Verification marks in troubleshootings and procedures steps

In order to facilitate the customer the guided information monitoring, verification marks in

troubleshootings and procedures steps are enabled. The customer will be able to use these marks to

indicate either that a step has not been followed, that it has been followed correctly or the verification

has been erroneous.

7


2.1.4. Report management improvements

General comments can be included and edited in diagnostic reports. In addition, it is possible to

add comments at any time during the diagnostic session.

It is possible to add a comment to the faults reading result, either during the system checking,

in an actuation or for a system measurement, …

8


2.1.5. Shortcuts to System Display

9


2.1.6. System Scan: main systems undetected are warned

If during the System Scan process no main systems of some vehicles such as engine

management system, brake system, transmission system or others which are defined depending on

the model, are listed, a message that indicates this fact is displayed.

10


2.1.7. Others

Apart from the points explained above, other improvements and modifications to be taken

into account have been carried out.

- From the help info, hyperlink to procedures and troubleshootings which are part of the

workflow of an action.

- Some interactive releases, such as the communication bus electronic architecture, can be

displayed on the model from ‘Wiring Diagrams’.

- Important! Requirement of a license update when Jaltest Soft is open if its conditions have

changed.

2.2. GRP

2.2.1. Improvement in the management of customers with towed vehicles

When a Trailer number plate is created for a customer, the possibility of indicating the brake

system installed is offered. Therefore, access to vehicles by number plate for Trailer is improved.

11


2.2.2. GRP Network

From 17.3 version, a GRP Network could be created where several users will share diagnosis and

maintenance reports searching by the plate number or VIN. In this way, one Jaltest user will consult

maintenance tasks and the vehicle state time ago if the vehicle was repaired in a workshop belonging

to the same network. The easy steps to create and use the GRP Network are listed below.

1) Please, contact Jaltest Customer Service ([email protected]) to get further

information about how to create a GRP Network. The user will be informed by SMS or email.

2) Manage the new request directly from the Jaltest

12


3) Follow the activation wizard steps

Please, accept the terms and conditions. Then, the received activation code must be introduced to

activate the GRP Network.

4) Now, the GRP configuration menu includes GRP Synchro, GRP Enterprise and GRP Network.

Review the details of your GRP phases and configure your reports according your preferences.

With GRP Network, a GRP Enterprise including several devices can share reports with other users not belonging to this.

13


5) Go to ‘Reports Management’ menu. Your reports are listed, additionally a link to search reports

in networks is located at the bottom in the right corner.

6) Search by number plate or VIN, find reports created by user belonging to the same network.

14


Jaltest 17.3, new diagnosis functions

Note: This is only a summary of the most relevant information about this new version. For further

information, please visit Jaltest Report.

2.3. DAF Trucks

Summary of the content

- New! Diagrams of the communication bus electronic architecture in Euro 6 models.

- Troubleshootings by errors in the DTCs of ECS-DC systems.

- Troubleshootings by symptom, e.g. procedure for the checking of leaks on EBS 3 system.

Coverage improvement, new systems and functions

All models

- Variants control of new references, VIC-2, VIC-3, SWS (Steering Wheel Switches), DTCO,

Maintenance, EBS 3, and much more…

Euro 6, XF and CF models

- Immobilizer, key programming.

- PCI (Paccar Common-rail Injection), new functions controlled by reference.

- ECS-DC6 (Engine Control System – DAF/Cummins), configuration of the max. vehicle speed

with Cruise Control, the engine idle speed and the idle shutdown timer.

LF models

- ECS-DC5 (Engine Control System – DAF/Cummins), configuration of the max. vehicle speed

with Cruise Control and the vehicle speed limit.

15


2.4. IVECO Trucks


- New! Diagrams of the communication bus electronic architecture in CNG, Euro 6 and others...


All models

- Eberspächer Airtronic auxiliary heater, variants control of new references.

Euro 6 models

- New! AEBS ARS327 Radar system.

- New! ZF TraXon transmission - Iveco protocol (system under generic paths)

Note: The systems listed can also be found in IRISBUS buses.

2.5. MAN Trucks


Euro 5, Euro 6 models

- EDC 17, variants control of new references and measurements related to the HCI (Hydro-

Carbon Injection) system.

- PTM (PowerTrain Manager), configuration of the data values related to transmission,

retarder, … and configuration of the max. engine speed for the PTO (Power Take-Off). Additionally, this

system adds specific wiring diagrams configurations for TGL and TGM models.

- PriTarder, new measurements and activations.

16


Euro 6 models

- New! ROM2 Radar system, technical info is included.

Note: The systems listed can also be found in MAN and NEOPLAN buses.

2.6. MERCEDES-BENZ Trucks


- New model! Accelo 1316 (9BM979.09) – OBD.

- Troubleshootings for the errors which can be displayed during the manual procedures of calibration

of the transmission GS and AGS.


MB4 technologies

- MCM engine system, new ODR operational data, activation of the camshaft position actuator

and the EGR (Exhaust Gas Recirculation) actuator calibration.

- TCM transmission system, configuration data.

- Variants control of new references, ACM exhaust gas aftertreatment system, CPC (Common

Powertrain Controller), and much more…

Atego, Axor, Actros, … Euro 5

- SCR Bluetec, SCR-related memory reset which clears the DTCs related to the emissions for

resetting the malfunction indicator lamp and the torque limitation. Non-active long-term errors for the

authorities are not cleared.

Note: The systems listed can also be found in MERCEDES-BENZ and SETRA buses.

17


2.7. RENAULT Trucks


- The info displayed for the DTCs has been generally improved in several systems linking the component

of the wiring diagram to each one. That is for the following systems: AdBlue ACM, EMS engine, TECU

transmission, APM (Air Proccess Management), EBS brakes, ... installed in V4 technologies models.

- ECM ZD DTi3 engine system installed in D Series V3 Euro 6 (3,5 - 7,5 t), new wiring diagram

configurations for vehicles 150 hp and 180 hp.

- DCI Euro 2/3 engine system, new wiring diagram configurations for 4 cylinders engines in Midlum.


V3 technology

- EMS engine system, fan clutch test and VTG (Variable Turbine Geometry) activation.

- New system! DACU (Driver Assistant Controller Unit)

- New system! LPOS (Lane Position Object Sensor)

D Series V3 Euro 6 (3,5 - 7,5 t)

- Measurements for ECM ZD DTi3, AdBlue ADCM, and ABS/ESP systems.

V4 technology

- New system! BBM (Body Builder Module)

- RCIOM (Rear Chassis I/O Module), calibration of the suspension system, activation of the

suspension control valves (up/down) and the development of the pressure and height sensors

measurements.

- HMIIOM (Human Machine Interface I/O Module), windshield wiper and washer activations,

steering wheel switches test (right and left panels) …

- New System Display! Retarder scheme in AdBlue ACM system (the electronic control unit of

the AdBlue system is also managing the retarder functions)

2.8. SCANIA Trucks


- New! ICL2 wiring diagram configuration.

- DIS 2 Distance sensor, images and technical data.

- Troubleshootings by errors, e.g. DTC 4488 in the EMS XPI engine system and DTC 4116 in the AdBlue

Denox 1.x system.


P, G, R Series

- DIS 2 Distance sensor, calibration.

- EMS HPI engine system, clutch wear reduction and torque limitation configuration.

- EMS PDE engine system, torque limitation configuration.

- BMS brake system, steering wheel angle sensor and yaw rate sensor calibrations.

- BWS bodywork system, torque limiter parameters modification.

18


4 Series

- EDC MS6.2 engine system, cylinder test for 8 cylinders engine blocks.

Note: The systems listed can also be found in SCANIA buses.

2.9. VOLVO Trucks


19


- The info displayed for the DTCs has been generally improved in several systems linking the component

of the wiring diagram to each one. That is for the following systems: AdBlue ACM, EMS engine, APM

(Air Process Management), EBS brakes, ... installed in V4 technologies models. That is also in TECU

transmission which adds new wiring diagram configurations and technical data for I-Shift.

- VMCU (Vehicle Master Control Unit), new wiring diagram configurations.

- The control system for the engine type D13B improves the content with new wiring diagram, images

and technical data.


V3 technology

- EMS engine system, fan clutch test and VTG (Variable Turbine Geometry) activation.

- AdBlue ACM, counter of freeze cycles.

V4 technology

- New system! SRS Airbag.

- RCIOM (Rear Chassis I/O Module), calibration of the suspension system, activation of the

suspension control valves (up/down) and the development of the pressure and height sensors

measurements.

- HMIIOM (Human Machine Interface I/O Module), windshield wiper and washer activations,

steering wheel audio switches test, rain sensor activation, …

- CCM (Climate Control Module), air leak and fuel dosing tests.

- AdBlue ACM, counter of freeze cycles. New System Display! Retarder scheme (the electronic

control unit of the AdBlue system is also managing the retarder functions)

Note: The systems listed can also be found in Volvo buses.

20


2.10. Buses

2.10.1. IVECO/IRISBUS


- DIWA 6 Transmission, wiring diagrams, images and technical data.

- Relays and fuses boxes in Euro 6 models HEULIEZ GX and Urbanway.

- Specific wiring diagrams configurations of several systems in HEULIEZ models including images and

technical data.

- New! Doors calibration procedure through the dashboard in city buses with Actia ICU.

Note: Please, look at IVECO Trucks innovations.

2.10.2. MERCEDES-BENZ/SETRA


- Specific wiring diagrams, images and technical data for buses with technologies MB4 and previous.

That is in engine systems as MR/PLD and MCM, exhaust gas aftertreatment systems as SCR Bluetec

and ACM, and much more…


All models previous to Euro 6

- New system! ABA (Active Brake Assist) system.

- HLK, ATC (Automatic Temperature Control), HLK03 version control improvement depending on

the bus configuration.

21


- EAPU (Electronic Air Process Unit), configuration data.

Note: Please, look at MERCEDES-BENZ Trucks innovations.

2.10.3. SCANIA


- New! ICL2 wiring diagram configuration with/without AIP (Adjustable Instrument Panel)

Note: Please, look at SCANIA Trucks innovations.

2.10.4. VOLVO


- New! Fuses and relays boxes for several Volvo Bus chassis with different technologies (B8R, B11R,

B7R, B7L, B12R, …) and the coach 7900H.


V3 technology

- New system! DACU (Driver Assistant Controller Unit)

- New system! LPOS (Lane Position Object Sensor)

- New system! FLS (Forward Looking Sensor)

The systems can be found in B11R.

Note: Please, look at Volvo Trucks innovations.

22


2.10.5. Others

NEOPLAN

- New model! P10 (N 2216/3 SHD TOURLINER) [2016 - …]

KING-LONG

- New model! XMQ6120C (U12) Euro 6.

- EDC 17 CV41, variants control of new references.

OTOKAR

- Euro 4/5 series improves adding new systems.

- New components location images in Euro 6 models.

SOLARIS

- Urbino Euro 6 improves adding new systems.

VAN HOOL

- New system! EHLA, electronically steering auxiliary axle. The system includes manual procedures

of calibration and info.

- Voith Retarder Vera, new wiring diagrams configurations.

VDL

- New model! Futura FDD2 Euro 6.

VOLKSWAGEN

- Diagrams of the communication bus electronic architecture in Volksbus Euro 5.

WRIGHTBUS

- New brand!

23


2.11. Trailer systems

Three general highlighted functions have been developed which applies to all Trailer EBS systems:

1. New! Report generation in all end of line tests (EOLT – End of Line Test) of EBS Trailer systems.

2. New! Modification of the load sensing and the pressures chart in only one step.

24


Note: The previous image has been printed configuring the minimum resolution of the Jaltest Soft.

Depending on the PC, all values could be displayed at the same screen.

3. New! Graphical representation of the brake pressures chart (not available in DEMO MODE)

2.11.1. Wabco Systems

Trailer EBS D

- ODR data reset.

Trailer EBS E

- New diagnosis identifiers control for TEBS E5.1 modules.

- Improvement of the System Display adding more measurements in configurations with 3rd

modulator.

2.11.2. Haldex Systems

Trailer EB+ Gen3

- ODR data reset.

- ECE R13 compatibility data, including helpful information about the interpretation of the results

(not available in DEMO MODE)

2.11.3. Knorr-Bremse Systems

TEBS Gen 2

- New CN (Compatibility Numbers) are controlled in ES2090 and ES2095 modules. Please, look at

the info tables during the connection process and compare with your specific TEBS module.

- New FFD (Freeze Frame Data), the first and last occurrences are displayed for not active DTCs.

- ODR data reset in ES2090 modules.

25


Examples:

An example of a Trailer EBS System Display:

An example of the ECE R13 compatibility data:

26


An example of an EOLT report:

27


2.12. LCV

2.12.1. FORD

New models! Ranger TDCi from 2011 onwards.

Model Engine Litres KW From…

Ranger 3.2 TDCi 4X4 SA2R, SA2S, SAFA 3,2 147 2011

Ranger 3.2 TDCi SA2R, SA2S, SAFA 3,2 147 2011

Ranger 2.2 TDCi 4x4 GBVAJQW 2,2 92 2011

Ranger 2.2 TDCi 4x4 GBVAJQJ 2,2 110 2011

Ranger 2.2 TDCi GBVAJQW 2,2 92 2011

Ranger 2.2 TDCi GBVAJQJ 2,2 110 2011

2.12.2. IVECO

Iveco Daily [2014 - …]

- New system! ZF 8HP HI-Matic Transmission including System Display and wiring diagrams.

- EDC 17, variants control of new references for Euro 5 and Euro 6 which includes the following

resets: DPF differential pressure sensor, lambda, MAF sensor, and much more…


- System Display in the following systems: IPC instrument panels Marelli and Continental, ACM

climate control, ESV1 Agile transmission, …


- ECAS 4x2 SMS, copy and paste parameters.

28


2.12.3. MAZDA

BT 50 3.2 4WD (Engine type: Duratorq) [2013 - …] New Model!

2.12.4. MERCEDES

Sprinter, Vito, Viano

- System Display in the following systems: Klima 7.0, CDI6 (OM642), CDID3 (OM651), …

- FSCU2 (Fuel Sensing Control Unit), fuel pump activation.

2.12.5. PSA GROUP

The engine diesel control EDC SID 208 [2011 - …] includes the EGR valve reset and the rail control

pressure valve reset too.

Citroën New models!


Jumper 2.0 BlueHDi AHM 2 80 2015

Jumper 2.0 BlueHDi AHN 2 96 2015

Jumper 2.0 BlueHDi AHP 2 120 2015

Jumper 2.3 HDI F1C 2,3 93 2012

Peugeot New models!


Boxer 2.3 D F1C 2,3 93 2012

Boxer 2.0 BlueHDi AHP 2 120 2015

Boxer 2.0 BlueHDi AHN 2 96 2015

Boxer 2.0 BlueHDi AHM 2 80 2015


- ABS/ESP 9.0, wiring diagram and System Display.

2.12.6. VOLKSWAGEN

New models! T6 family series (Transporter, California, …) which includes the systems.

- EDC Delphi DCM 6.2

- ESP MK 100

- EBM 3.0, Battery system

29


2.13. Others

Jaltest is continuously improving and adding functions and systems for all type of commercial

vehicles, as an example, at this version the accelerator pedal can be calibrated in special vehicles with

MB technologies and ADM 2 as the engine regulation interface.

The Wabco ABS/ASR E includes new E4 family references as 446 004 649 0.

ADAS systems continue being updated, e.g. the radar calibration in Wabco OnGuard Plus or new

activations in Wabco OnLane. These systems are installed in buses OTOKAR, KING LONG, …

In the same way, Jaltest does not stop updating the coverage of all markets as South America or

Asia. TATA-DAEWOO includes a new fuses and relays box in PRIMA Euro 4. HINO engine systems for

engines such as N04C or J08E continues improving the variants control of new references. MITSUBISHI

FUSO Canter adds a new system EDC 15M1-7.10 and more wiring diagrams. Troubleshootings has been

linked to ISUZU engine systems 4HK1, 4JJ1, …

Finally, we would like to mention for this version the effort including vehicle technical data version

by version. New most recent engines are created including relevant technical data; PX5, PX7 Paccar in

DAF or the engine 4P10 Euro 6 in MITSUBISHI FUSO could be highlighted.

Please, look at the innovation documents for AGV and OHW licenses too.

Documents

Jaltest 17.3 Presentation - eclipse-tech.co.uk · PDF fileZF TraXon transmission - Iveco protocol (system under generic paths) Note: The systems listed can also be found in IRISBUS