ISUZU DIESEL ENGINE 6HK1 XYGD01 PARTS CATALOG

ISUZU

DIESEL ENGINE

2017/5/15

6HK1 XYGD01

PARTS CATALOG

FIG NO. TITLE (SUBTITLE) PAGE

0-05-1 ENGINE GASKET KIT (UP TO ENGINE SERIAL NO. 517401) 10-05-2 ENGINE GASKET KIT (ENGINE SERIAL NO. FROM 517402 TO 520296) 30-05-3 ENGINE GASKET KIT (ENGINE SERIAL NO. FROM 520297 TO 574127) 50-05-4 ENGINE GASKET KIT (FROM ENGINE SERIAL NO. 574128) 70-10-1 CYLINDER HEAD COVER (UP TO ENGINE SERIAL NO. 574127) 90-10-2 CYLINDER HEAD COVER (FROM ENGINE SERIAL NO. 574128) 100-11 CYLINDER HEAD 110-12 CYLINDER BLOCK 140-13 OIL PAN AND LEVEL GAUGE 160-14 CAMSHAFT AND VALVE 170-15 CRANKSHAFT,PISTON AND FLYWHEEL 190-20 TIMING GEAR CASE AND FLYWHEEL HOUSING 210-22 ENGINE MOUNTING 240-25 INLET MANIFOLD 250-27 EXHAUST MANIFOLD 270-28 VENTILATION SYSTEM 280-30 WATER PUMP AND CORROSION RESISTOR 300-31 THERMOSTAT AND HOUSING 320-32 WATER PIPING; ENGINE 340-33 FAN AND FAN BELT 350-36 TURBOCHARGER SYSTEM 36

0-37-1 TURBOCHARGER (UP TO ENGINE SERIAL NO. 580868) 370-37-2 TURBOCHARGER (FROM ENGINE SERIAL NO. 580869) 390-40 FUEL INJECTION SYSTEM 41

0-41-1 FUEL FILTER AND BRACKET (UP TO ENGINE SERIAL NO. 534685) 440-41-2 FUEL FILTER AND BRACKET (FROM ENGINE SERIAL NO. 534686) 460-42 FUEL PUMP AND PIPE 48

0-50-1 OIL COOLER AND OIL FILTER (UP TO ENGINE SERIAL NO. 530585) 490-50-2 OIL COOLER AND OIL FILTER (FROM ENGINE SERIAL NO. 530586) 510-51 OIL PUMP AND OIL STRAINER 530-52 OIL AND VACUUM PIPING; ENGINE 550-57 EMISSION PIPING 56

0-60-1 ENGINE ELECTRICAL CONTROL PARTS (UP TO ENGINE SERIAL NO. 574127) 580-60-2 ENGINE ELECTRICAL CONTROL PARTS (FROM ENGINE SERIAL NO. 574128) 610-65 STARTER 640-66 GENERATOR 651-30 AIR CLEANER 661-40 FUEL TANK (UP TO ENGINE SERIAL NO. 520296) 671-40 FUEL TANK (FROM ENGINE SERIAL NO. 520297) 681-41 FUEL PIPING; CHASSIS 691-50 EXHAUST PIPE AND SILENCER 708-10 WIRING HARNESS AND FUSE 718-15 FIXING PARTS; WIRING HARNESS 728-25 SWITCH AND RELAY; INSTRUMENT PANEL 74

FIGURE NUMBER INDEX

PAGE

(UP TO ENGINE SERIAL NO. 517401)(No.1)

(No.2)

0-05-1 ENGINE GASKET KIT

1/74


Part no. qty Part description Engine serial no.1 (A) 1-87815-604-0

<1-87813-038-0>1 GASKET SET; ENG OVERHAUL UP TO 517401

2 1-87815-641-0<1-87812-985-1>

1 GASKET SET; ENG HD OVERHAUL UP TO 517401

KEY No.


2/74

(ENGINE SERIAL NO. FROM 517402 TO 520296)(No.1)

(No.2)


3/74



<1-87813-163-0>1 GASKET SET; ENG OVERHAUL 517402 - 520296

2 1-87815-642-0<1-87813-070-0>

1 GASKET SET; ENG HD OVERHAUL 517402 - 520296

KEY No.


4/74


(No.2)


5/74




2 1-87815-645-0<1-87813-299-1>


KEY No.


6/74

(FROM ENGINE SERIAL NO. 574128)(No.1)

(No.2)


7/74




1 (A) 1-87815-397-0<1-87814-863-0>

1 GASKET SET; ENG OVERHAUL 587391 - UP

2 1-87815-643-0<1-87813-504-6>


2 1-87815-398-0<1-87814-865-0>

1 GASKET SET; ENG HD OVERHAUL 587391 - UP

KEY No.


8/74

(UP TO ENGINE SERIAL NO. 574127)

Part no. qty Part description Engine serial no.1 (A) 8-98043-402-0 1 COVER; CYL HD4 (A) 8-94399-723-0 1 CAP; OIL FILLER5 (A) 8-94399-689-0 1 GASKET; OIL FILLER

ID=49 OD=5828 (A) 0-28050-870-0 11 BOLT; HD COVER

M8X70 FLANGE28 (B) 0-28050-845-0 4 BOLT; HD COVER

M8X45 FLANGE29 8-97601-849-1

<8-94392-097-0>11 RUBBER; MTG,HD COVER

39 8-94396-512-0 4 STUD; COVER,HDM8X28 L=38

UP TO 574127

69 (A) 8-94391-379-0 1 GASKET; HD TO COVER69 (B) 8-94391-380-0 1 GASKET; HD TO COVER72 8-98038-961-0 1 PLATE; INNER HD COVER93 0-28050-812-0 8 BOLT; BRKT

M8X12 FLANGE94 0-35050-408-0 6 SCREW; BAFFLE PLATE,CYL HD

COVER110 8-94390-862-3 1 COVER; CYL HEAD LWR

KEY No.

0-10-1 CYLINDER HEAD COVER

9/74

(FROM ENGINE SERIAL NO. 574128)

Part no. qty Part description Engine serial no.1 (A) 8-98043-402-0 1 COVER; CYL HD4 (A) 8-94399-723-0 1 CAP; OIL FILLER5 (A) 8-94399-689-0 1 GASKET; OIL FILLER

ID=49 OD=5828 (A) 0-28050-870-0 11 BOLT; HD COVER

M8X70 FLANGE28 (B) 0-28050-845-0 4 BOLT; HD COVER

M8X45 FLANGE29 8-97601-849-1

<8-94392-097-0>11 RUBBER; MTG,HD COVER

39 8-94396-512-0 2 STUD; COVER,HDM8X28 L=38

574128 - UP

69 (A) 8-94391-379-0 1 GASKET; HD TO COVER69 (B) 8-94391-380-0 1 GASKET; HD TO COVER72 8-98038-961-0 1 PLATE; INNER HD COVER93 0-28050-812-0 8 BOLT; BRKT

M8X12 FLANGE94 0-35050-408-0 6 SCREW; BAFFLE PLATE,CYL HD

COVER110 8-94390-862-3 1 COVER; CYL HEAD LWR

0-10-2 CYLINDER HEAD COVER

KEY No.

10/74

(No.1)

(No.2)

0-11 CYLINDER HEAD

11/74

Part no. qty Part description Engine serial no.1 8-97606-996-8 1 HEAD ASM; CYL UP TO 5741271 8-98243-820-0 1 HEAD ASM; CYL 574128 - UP2 8-97601-819-5 1 GASKET; CYL HD3 8-94396-207-3 26 BOLT; CYL HD TO BLOCK

M14X115 W/FLANGEUP TO 537500

3 8-97077-638-0 26 BOLT; CYL HD TO BLOCKM14X115 W/FLANGE

537501 - 585209

3 8-98260-005-0 26 BOLT; CYL HD TO BLOCKM14X115 W/FLANGE

585210 - UP

4 8-94390-780-0 24 GUIDE; VLV UP TO 5239044 8-97376-719-1

<8-97376-719-2>24 GUIDE; VLV 523905 - UP

5 (A) 8-94395-888-2 12 SEAT; VLV INSERTINLET

5 (B) 8-98028-875-0 12 SEAT; VLV INSERTEXHAUST

7 8-97096-826-0 1 CUP; SEALING,CYL HEADOD=51

8 (A) 1-09600-012-2 6 CUP; SEALING,WATER JACKETOD=32

8 (A) 1-09600-012-2 1 CUP; SEALING,WATER JACKETOD=32

8 (B) 1-09600-016-0 6 CUP; SEALING,WATER JACKETOD=25

8 (C) 5-11129-006-0 7 CUP; SEALING,WATER JACKETOD=16

8 (D) 9-11129-128-0 11 CUP; SEALING,WATER JACKETOD=20

10 (A) 8-94390-777-6 6 PLUG; GLOW11 (A) 8-94391-925-3 1 CONNECTOR; GLOW PLUG UP TO 52998611 (A) 8-98040-649-0 1 CONNECTOR; GLOW PLUG 529987 - UP11 (B) 8-94392-843-1 1 CONNECTOR; GLOW PLUG UP TO 52998611 (B) 8-98040-648-0 1 CONNECTOR; GLOW PLUG 529987 - UP14 8-94397-286-0 12 STUD; EXH MANIF

M10X60 L=7523 0-91180-208-0 8 NUT; CAM BRKT

M8 FLANGE41 0-28151-020-0 2 BOLT; ENG HANGER

M10X20 FLANGE58 8-97604-916-0 6 GASKET; SLEEVE,NOZZLE HOLDER

ID=26.459 8-97381-603-1 12 GUIDE; BRIDGE71 0-28050-835-0 2 BOLT; CAM BRKT

M8X35 FLANGE98 (A) 8-94322-512-2 2 STUD; CAM BRKT

M8X54 L=7998 (B) 8-94322-513-2 6 STUD; CAM BRKT

M8X41 L=66103 (A) 8-98003-416-0 1 PLUG; HD

M8X10120 (A) 8-94399-554-0 1 BOLT; CYL HD TO HSG

M10X73120 (B) 8-94399-555-0 1 BOLT; CYL HD TO HSG

M10X43138 8-97112-607-1 1 GEAR; IDLE

Z=41139 8-97186-398-1 1 SHAFT; IDLE GEAR141 8-98163-813-0 2 PLUG; RUBBER,CYL HD

KEY No.

0-11 CYLINDER HEAD

12/74

Part no. qty Part description Engine serial no.KEY No.

0-11 CYLINDER HEAD

143 0-28050-816-0 1 BOLT; FIXM8X16 FLANGE

168 8-94394-071-2 1 HANGER; ENG,FRT178 8-97122-360-0 1 CLIP; ENG HARNESS188 8-97602-870-1 1 BRACKET; HARNESS,HANGER192 8-97368-853-0 6 NUT; GLOW PLUG

M4 FLANGE201 1-09639-034-0 6 GASKET; SLEEVE,INJ PUMP

OD=30266 8-98018-462-0 6 SLEEVE ASM; NOZZLE HOLDER

13/74

Part no. qty Part description Engine serial no.1 8-98206-965-0

<8-98005-279-4>1 BLOCK ASM; CYL

2 1-87813-766-1 6 LINER SET; ENG CYLOD GRADE=1X,

2 1-87813-767-1 6 LINER SET; ENG CYLOD GRADE=3X,

4 8-94391-602-1 6 LINER; C/BLOD GRD=IX,ID=NON

4 8-94391-603-1 6 LINER; C/BLOD GRD=3X,ID=NON

10 8-94396-378-0 1 CONNECTOR; WATER DRAIN30 8-94399-688-1 2 PIN; CYL HD GASKET SETTING

OD=1834 8-94393-077-1 1 VALVE; OIL RELIEF35 5-09623-035-0 1 GASKET; RELIEF VLV

ID=2836 (A) 8-97036-550-1

<1-09600-005-2>4 CUP; SEALING,WATER JACKET

OD=4536 (B) 8-94399-005-0 1 CUP; SEALING,WATER JACKET

OD=2536 (C) 8-97096-824-0 4 CUP; SEALING,WATER JACKET

OD=4036 (D) 1-09600-016-0 1 CUP; SEALING,WATER JACKET

OD=2538 8-94483-674-0 2 PIN; TIMING GEAR CASE

L=2255 9-00097-011-0 1 PLUG; OIL GALLERY56 8-98173-342-0 6 JET; OIL,PISTON COOLING81 8-94397-338-0 1 PLUG; WATER JACKET

PT 3/8

KEY No.

0-12 CYLINDER BLOCK

14/74

Part no. qty Part description Engine serial no.83 8-94483-674-0 2 PIN; FLYWHEEL HSG

L=2289 9-11129-128-0

<9-11219-192-0>3 CUP; SEALING,OIL GALLERY

OD=20122 8-94399-858-2 1 ADAPTER; OIL PRESSURE SWITCH132 8-94394-419-1 6 VALVE; CHECK,OIL

M12X18.5136 8-94393-596-1 2 BUSHING; DRIVE SHAFT,OIL PUMP UP TO 537279136 8-98091-566-0 2 BUSHING; DRIVE SHAFT,OIL PUMP 537280 - UP137 1-09680-024-0 1 COCK; DRAIN,WATER162 0-03559-300-0 1 HOSE; WATER DRAIN,C/BL

L=350, S.B.L=3000211 (A) 8-94396-207-3 14 BOLT; CRANKCASE

M14X115 W/FLANGEUP TO 574127

211 (A) 8-97077-638-0 14 BOLT; CRANKCASEM14X115 W/FLANGE

574128 - UP

211 (B) 8-94399-553-2 25 BOLT; CRANKCASEM10X82

212 8-97135-423-0 2 PIN; CRANKCASEOD=10 L=20

232 1-09302-089-0 1 STUD; WATER PUMP256 1-09630-141-0 1 GASKET; ADAPTER

ID=14.2 OD=25258 8-97602-806-0 1 ADAPTER; BLOCK HTR UP TO 537279258 8-97611-854-0 1 ADAPTER; BLOCK HTR 537280 - 574127259 1-09623-184-0 1 GASKET; ADAPTER262 (A) 1-13163-002-0 1 PLUG; ADAPTER262 (B) 9-09862-156-0 1 PLUG; ADAPTER

M14X14262 (C) 5-09605-018-0 1 PLUG; ADAPTER

PT1/8 L=8267 8-97148-892-1

<1-09704-100-0>1 CLIP; DRAIN HOSE

335 (B) 8-94399-225-0 4 PLUG; C/BL,SIDEM14

UP TO 520296

335 (B) 8-97329-617-0 4 PLUG; C/BL,SIDEM14X16.5

520297 - UP

335 (C) 8-98003-416-0 2 PLUG; C/BL,SIDEM8X10

338 5-11129-003-0 2 CUP; SEALING,GUIDE TUBE HOLEOD=15.6

403 8-94395-351-1 1 GUIDE; GALLERY413 0-41010-830-0 2 STUD; ADAPTER

M8X30 L=41414 0-91180-208-0 2 NUT; ADAPTER

M8 FLANGE465 8-94399-225-0 2 PLUG

M14UP TO 520296

465 8-97329-617-0 2 PLUGM14X16.5

520297 - 523904

465 8-94399-225-0 1 PLUGM14

523905 - UP

465 8-97329-617-0 1 PLUGM14X16.5

523905 - UP

504 8-97363-237-0 2 STUD; WATER PUMPM10X46.5 L=58.5

505 8-97611-854-0 1 ADAPTER; WATER FEED 574128 - UP

0-12 CYLINDER BLOCK

KEY No.

15/74

Part no. qty Part description Engine serial no.1 (F) 8-98039-800-0 1 PAN ASM; OIL5 (A) 1-09623-058-0 1 GASKET; PLUG,OIL DRAIN6 (A) 1-09604-022-0 1 PLUG; OIL DRAIN

M20X17 FLANGE16 1-11367-131-0 1 GASKET; OIL PAN TO C/BL UP TO 57625623 0-28080-818-0 30 BOLT; OIL PAN

M8X18 FLANGE24 0-91180-108-0 4 NUT; OIL PAN

M8 FLANGE118 9-09571-424-0 1 GASKET; PLUG,OIL HTR

ID=24.5 OD=32119 1-09604-022-0 1 PLUG; OIL HTR BLIND

M24X17 FLANGE162 0-92002-416-0 2 PLUG; OIL PAN

M16X12175 9-09571-416-0 2 GASKET; PLUG,OIL PAN

ID=16.2 OD=24277 8-98026-085-0 1 CAP; OIL FILLER305 0-28151-016-0 1 BOLT; PIPE

M10X16 FLANGE351 8-98039-798-0 1 PIPE; OIL376 0-02309-130-0 1 HOSE; RUBBER,OIL PIPE377 8-98008-165-0 2 CLIP; HOSE

KEY No.

0-13 OIL PAN AND LEVEL GAUGE

16/74

Part no. qty Part description Engine serial no.1 8-98227-261-1 1 CAMSHAFT4 8-94395-882-2 12 VALVE; INL5 8-97209-876-4 12 VALVE; EXH7 8-94396-439-0 1 BOLT; CM/SHF GEAR

M14X408 9-09851-850-3 1 WASHER; CM/SHF GEAR

ID=14.59 (A) 8-97300-972-2 1 GEAR; CM/SHF

Z=35UP TO 590636

9 (B) 8-97601-946-2 1 GEAR; CM/SHFZ=35

UP TO 590636

9 (C) 8-98291-638-0 1 GEAR; CM/SHF 590637 - UP37 8-97386-189-0 4 METAL; CM/SHF

B=1637 8-97602-699-0 4 METAL; CM/SHF

B=2638 8-94399-487-0 1 PIN; CAM BRG SET

OD=7 L=7.553 8-97389-918-0 1 SHAFT; ROCKER ARM61 8-94394-803-0 12 SCREW; ADJ,BRIDGE

M8X2162 9-09844-574-0 12 NUT; ADJ SCREW LK BRIDGE

M8 FLANGE63 8-94392-002-3 12 BRIDGE65 5-12565-004-0 48 COLLAR; SPLIT68 (A) 8-97352-888-0 12 SPRING; VLV

MARK BLUE68 (B) 8-94395-885-1 12 SPRING; VLV

MARK WHITE

KEY No.

0-14 CAMSHAFT AND VALVE

17/74

Part no. qty Part description Engine serial no.71 (A) 8-94391-468-0 24 SEAT; SPR

LOWER71 (B) 8-94390-783-2 24 SEAT; SPR

UPPER72 8-97120-307-0 24 SEAL; VLV GUIDE UP TO 52390472 8-97376-720-0 24 SEAL; VLV GUIDE 523905 - UP75 (A) 0-28050-840-0 2 BOLT; BRKT

M8X40 FLANGE75 (B) 8-94393-131-0 5 BOLT; BRKT

M10X62 FLANGE78 (A) 8-97306-421-3 6 ARM; ROCKER

INLET78 (B) 8-97306-424-3 6 ARM; ROCKER

EXHAUST81 8-94395-024-0 12 SCREW; ADJ,ROCKER ARM

M10 FLANGE83 0-91111-510-0 12 NUT; ADJ SCREW,LK

M1084 8-94395-836-2 5 BRACKET; ROCKER SHAFT,INTER95 8-94392-999-0 6 SPRING; ROCKER SHAFT

101 (A) 0-16956-460-0 1 BOLT; THRUST COLLARM14X60

101 (B) 0-28060-816-0 3 BOLT; THRUST COLLARM8X16 FLANGE

101 (C) 0-23951-430-0 1 BOLT; THRUST COLLARM14X30

105 8-97113-167-0<8-97066-798-0>

1 BOLT; IDLE GEAR SHAFTM14X65

107 (A) 8-98060-780-0 1 SHAFT; IDLE GEAR107 (B) 8-98023-450-1 1 SHAFT; IDLE GEAR UP TO 520296107 (B) 8-98041-099-0 1 SHAFT; IDLE GEAR 520297 - UP107 (C) 8-97350-021-0 1 SHAFT; IDLE GEAR111 (A) 8-97209-728-2 2 COLLAR; THRUST,IDLE GEAR

ID=14.5 OD=46111 (B) 8-98023-616-0 1 COLLAR; THRUST,IDLE GEAR112 (A) 8-97606-767-0 1 GEAR; IDLE

Z=61112 (B) 8-97600-586-1 1 GEAR; IDLE

Z=72-60-30112 (C) 1-12523-378-1 1 GEAR; IDLE UP TO 520296112 (C) 8-98041-565-0 1 GEAR; IDLE 520297 - UP114 8-94372-221-1 1 BOLT; IDLE GEAR

M14X365115 8-97209-728-2 1 WASHER; THRUST,IDLE GEAR196 9-09180-055-0 1 RING; SNAP UP TO 590636203 8-98041-089-0 2 WASHER; THRUST 520297 - UP212 8-94396-015-2 12 CAP; ADJ SCREW264 (A) 8-97190-117-1 1 SPRING; GEAR UP TO 590636264 (B) 8-97190-118-1 1 SPRING; GEAR UP TO 590636295 8-97213-454-0 2 PIN; CM/SHF GEAR UP TO 590636

0-14 CAMSHAFT AND VALVE

KEY No.

18/74

Part no. qty Part description Engine serial no.1 8-97603-004-0 1 CRANKSHAFT

10 8-97372-076-1 7 METAL SET; CRANKSHAFT,STANDARDBLUE

10 8-97372-077-1 7 METAL SET; CRANKSHAFT,STANDARDBLACK

10 8-97372-078-1 7 METAL SET; CRANKSHAFT,STANDARDBROWN

12 8-98228-324-0<8-98025-747-0>

1 FLYWHEEL

18 1-12371-458-2 1 PULLEY; CR/SHF20 8-94392-276-3 1 DAMPER; CR/SHF22 9-09851-935-0 4 PLATE; PULLEY

ID=17 OD=3024 0-28151-016-0 6 BOLT; DAMPER

M10X16 FLANGE28 8-94392-255-1 1 GEAR; CR/SHF

Z=4232 9-08150-816-0 2 PIN; FLYWHEEL

OD=8 L=1634 9-09878-626-0 1 PIN; GEAR SETTING

OD=5 L=635 8-94391-953-0 1 GEAR; RING38 8-94397-496-1 1 WASHER; FLYWHEEL

ID=55 OD=11040 8-94393-070-2 8 BOLT; FLYWHEEL

M16X6242 (A) 8-97386-548-0 1 WASHER; THRUST,CR/SHF42 (B) 8-97386-549-0 2 WASHER; THRUST,CR/SHF57 8-94391-156-0 1 PIN; PULLEY

OD=8 L=16

KEY No.

0-15 CRANKSHAFT,PISTON AND FLYWHEEL

19/74

Part no. qty Part description Engine serial no.58 0-10956-600-0 4 BOLT; CR/SHF PULLEY

M16X10063 8-98023-526-1 6 PISTON

GRADE=NONUP TO 574127

63 8-98152-901-1 6 PISTONGRADE=NON

574128 - UP

68 8-98017-166-0 6 RING SET; PISTON,STANDARD73 8-98064-282-0 6 METAL SET; CONN ROD,STANDARD

GREENUP TO 523904

73 8-97616-358-0 6 METAL SET; CONN ROD,STANDARDGREEN

523905 - UP

73 8-98064-281-0 6 METAL SET; CONN ROD,STANDARDYELLOW

UP TO 523904

73 8-97616-359-0 6 METAL SET; CONN ROD,STANDARDYELLOW

523905 - UP

83 8-94396-731-1 6 PIN; PISTON UP TO 57412783 8-98018-863-1 6 PIN; PISTON 574128 - UP84 8-94399-661-2 6 ROD ASM; CONN UP TO 52390484 8-98018-425-3

<8-98018-425-2>6 ROD ASM; CONN 523905 - UP

85 8-94394-613-0 6 BUSHING; CONNROD UP TO 52390485 8-94391-794-1 6 BUSHING; CONNROD 523905 - UP86 8-98091-141-0 12 BOLT; CONNROD

M13X57 FLANGE126 1-09587-081-1 12 RING; SNAP,PISTON PIN

0-15 CRANKSHAFT,PISTON AND FLYWHEEL

KEY No.

20/74

(No.1)

(No.2)

0-20 TIMING GEAR CASE AND FLYWHEEL HOUSING

21/74

Part no. qty Part description Engine serial no.2 1-11341-689-2 1 HOUSING; FLYWHEEL UP TO 5202962 8-98041-634-4 1 HOUSING; FLYWHEEL 520297 - UP

16 8-97601-153-1 1 GEAR; INJ PUMP DRIVEZ=35

32 8-97028-748-1 1 GASKET; GEAR CASE TO C/BLID=35.1

35 8-97602-378-3 1 SEAL; OIL,CRANKSHAFT FRTID=104 OD=137

43 1-09302-112-0 1 STUD; BRG COVERM12X67 L=82

51 0-28050-835-0 13 BOLT; GEAR CASE COVERM8X35 FLANGE

62 0-28080-814-0 3 BOLT; COVERM8X14 FLANGE

68 1-11321-160-1 1 COVER ASM; GEAR CASE COVER94 0-91180-214-0 1 NUT; GEAR

M14 FLANGE115 (A) 8-97306-113-1 1 SENSOR; REVOLUTION,ENG SPD115 (B) 8-98014-831-0 1 SENSOR; REVOLUTION,ENG SPD167 1-11219-163-0 1 COVER; OIL175 8-97209-342-3 1 SEAL; OIL,CR/SHF,RR177 (A) 0-28050-612-0 1 BOLT; SENSOR

M6X12 FLANGE177 (B) 0-28060-612-0 1 BOLT; SENSOR

M6X12 FLANGE177 (C) 0-28050-616-0 1 BOLT; SENSOR

M6X16 FLANGE211 0-16856-260-0 1 BOLT; HSG

M12X60211 0-28151-050-0 1 BOLT; HSG



M12X70220 0-92002-412-0 1 PLUG; GEAR CHECK HOLE

M12X09224 0-44011-435-0 2 STUD; STARTER

M14X35 L=56225 8-94396-512-0 4 STUD; OIL PAN

M8X28 L=38228 0-44011-235-0 1 STUD; AIR CMPR

M12X35 L=53235 1-09630-084-0 1 GASKET; PLUG GEAR CHECK HOLE

ID=12.2UP TO 585209

235 8-98251-344-0 1 GASKET; PLUG GEAR CHECK HOLEID=12.2

585210 - UP

241 8-94393-140-1 12 WASHER; PL,HSGID=12.5 OD=22

250 0-28080-818-0 2 BOLT; COVER,OILM8X18 FLANGE

264 0-91180-212-0 1 NUT; COVERM12 FLANGE

275 1-11327-050-1 1 POINTER; TIMING CHECK HOLE290 8-97101-974-0 1 PLUG; SENSOR HOLE356 8-94394-186-0 1 GASKET; COVER

ID=110479 1-09623-570-0 1 GASKET; COVER

ID=162

KEY No.


22/74



480 0-28151-270-0 3 BOLT; COVERM12X70 FLANGE

484 5-09700-307-1 1 CLIP; BANDL=80

485 (A) 8-97387-194-0 1 GASKET; SENSOR487 (A) 8-98023-824-1 1 COVER; HOLE487 (B) 8-97601-420-1 1 COVER; HOLE

23/74

Part no. qty Part description Engine serial no.2 8-94393-491-1 2 FOOT; ENG

20 8-94395-721-0 8 BOLT; ENG FOOTM10X20 FLANGE

KEY No.

0-22 ENGINE MOUNTING

24/74

Part no. qty Part description Engine serial no.2 8-97603-303-3 1 COVER; INL7 8-94390-775-0 1 GASKET; INL MANIF TO HD

32 (A) 0-41010-630-0 5 STUD; INL PIPEM6X30 L=38

32 (B) 8-97032-977-1<5-09302-008-1>

2 STUD; INL PIPEM10X45 L=60 PLATING

32 (C) 0-41010-825-0 3 STUD; INL PIPEM8X25 L=37

32 (D) 0-44011-025-0 2 STUD; INL PIPEM10X25 L=40

32 (E) 9-04731-080-0 4 STUD; INL PIPEM10X80

55 0-91180-108-0 3 NUT; INL PIPEM8 FLANGE

97 8-12146-830-0 1 SENSOR; INTAKE,AIR TEMPERATURE100 0-91180-210-0 2 NUT; BRKT

M10 FLANGE122 0-28161-020-0 2 BOLT; BRKT

M10X20 FLANGE323 0-28650-825-0 12 BOLT; DUCT

M8X25 FLANGE323 8-98005-842-0

<8-94174-559-2>2 BOLT; DUCT

M8X23 FLANGE324 8-97601-777-0 1 GASKET; INL PIPE TO INL CVR364 8-97374-517-0 1 GASKET372 8-97173-223-0

<8-97019-473-0>2 CLIP; HOSE

ID=10.5740 1-14110-614-2 1 PIPE; INTAKE748 1-23335-610-0 1 BRACKET; BOOST SENSOR

KEY No.

0-25 INLET MANIFOLD

25/74

Part no. qty Part description Engine serial no.779 0-28060-620-0 2 BOLT; SENSOR

M6X20 FLANGE780 0-04740-300-0 1 HOSE; SENSOR

L=50

0-25 INLET MANIFOLD

KEY No.

26/74

Part no. qty Part description Engine serial no.2 8-94393-672-4 6 GASKET; EXH MANIF TO HD5 1-14142-034-0 1 MANIFOLD; EXH,FRT6 1-14142-028-0 1 MANIFOLD; EXH,RR

16 (A) 8-94383-596-0 2 STUD; EXH PIPE TO MANIFM10X35 L=50

16 (B) 8-94156-940-0 3 STUD; EXH PIPE TO MANIFM8X60 L=72

18 (A) 0-91180-210-0 11 NUT; EXH MANIFM10 FLANGE

18 (B) 8-98205-394-0 1 NUT; EXH MANIFM10 L=51

33 1-09556-015-0 12 WASHER; EXH MANIFT=2.2

34 8-97250-073-1 12 COLLAR; DIST,EXH MANIFL=28

155 (A) 1-14149-151-0 1 RING; SEAL,EXH MANIF155 (B) 1-14149-184-0 2 RING; SEAL,EXH MANIF

KEY No.

0-27 EXHAUST MANIFOLD

27/74

(No.1)

(No.2)

0-28 VENTILATION SYSTEM

28/74

Part no. qty Part description Engine serial no.1 1-11740-269-0 1 BREATHER; AIR3 8-97385-921-0 1 GASKET; BODY TO CAP9 1-09623-565-0 1 GASKET; AIR BREATHER

ID=59.621 (A) 0-28051-016-0 2 BOLT; CLIP

M10X16 FLANGE21 (B) 0-28060-816-0 1 BOLT; CLIP

M8X16 FLANGE21 (C) 0-28751-020-0 1 BOLT; CLIP

M10X20 FLANGE48 1-09675-085-0 1 BOLT; PIPE

M12X27 FLANGE59 (B) 8-98150-357-0

<8-94238-571-0>2 CLIP; HOSE

ID=1391 0-28151-020-0 2 BOLT; AIR BREATHER

M10X20 FLANGE93 8-97063-234-0 1 PIPE; DRAIN

151 8-97362-763-3 1 SEPARATOR; OIL,PCV179 1-09630-084-0 2 GASKET; PIPE

ID=12.2UP TO 585209

179 8-98251-344-0 2 GASKET; PIPEID=12.2

585210 - UP

188 0-28050-812-0 2 BOLT; BRKTM8X12 FLANGE

191 (A) 1-11740-284-1 1 HOSE; OIL DRAIN192 1-09707-190-0 1 CLIP; BAND

L=700272 1-13345-237-0 1 BRACKET; PIPE275 8-97389-360-0 1 CAP; PCV314 (A) 8-98046-874-0 1 COVER; RUBBER314 (B) 8-98202-590-0 1 COVER; RUBBER314 (C) 8-98202-591-0 1 COVER; RUBBER317 (A) 8-98028-181-0 1 HOSE; RUBBER,OIL SEPARATOR318 8-98030-532-0 1 ELEMENT KIT; PCV321 (A) 1-09701-266-0 1 CLIP; HOSE,SEPARATOR

ID=30X2 L=28UP TO 515424

321 (B) 1-09707-124-0 4 CLIP; HOSE,SEPARATORID=28.5

321 (C) 5-09700-350-0 1 CLIP; HOSE,SEPARATORID=12 B=14 ID=8.5

UP TO 527676

321 (C) 8-97367-984-1 1 CLIP; HOSE,SEPARATORID=12 VINYL CHLORIDE

527677 - UP

321 (D) 8-94443-021-1 2 CLIP; HOSE,SEPARATORL=100

321 (E) 8-97015-754-1 2 CLIP; HOSE,SEPARATORID=13.5

321 (F) 1-09700-969-0 1 CLIP; HOSE,SEPARATORID=31 L=30

515425 - UP

322 8-94249-317-1 1 VALVE; CHECK324 0-28156-015-0 2 BOLT; SEPARATOR

M10X150 FLANGE324 0-28060-816-0 3 BOLT; SEPARATOR

M8X16 FLANGE325 8-98028-139-0 1 BRACKET; SEPARATOR

KEY No.

0-28 VENTILATION SYSTEM

29/74

(No.1)

(No.2)

0-30 WATER PUMP AND CORROSION RESISTOR

30/74

Part no. qty Part description Engine serial no.1 1-13650-133-4 1 PUMP ASM; WATER,W/GASKET3 1-13614-021-1 1 GASKET; PUMP TO C/BL4 1-87813-736-0 1 REPAIR KIT; WATER PUMP7 8-98046-350-0 1 PULLEY; WATER PUMP

2-GROOVE D=187.68 1-13639-029-0 1 THROWER; DUST,WATER PUMP9 9-09180-168-0 1 RING; SNAP,WATER PUMP

OD=72.510 (A) 1-09800-279-0

<1-09800-302-0>1 BEARING; WATER PUMP

10 (B) 1-09800-303-0 2 BEARING; WATER PUMP11 1-13634-044-0 1 SPACER; BRG,WATER PUMP17 8-94392-090-0 1 SEAL UNIT; WATER PUMP18 1-13621-061-0 1 IMPELLER; WATER PUMP19 8-98191-713-0 1 GASKET; COVER TO BODY20 8-98186-630-0 1 COVER; WATER PUMP24 0-28050-880-0 5 BOLT; WATER PUMP

M8X80 FLANGE24 0-28055-811-0 3 BOLT; WATER PUMP

M8X110 FLANGE25 1-13642-081-0 1 CENTER; WATER PUMP28 1-09503-309-0 1 WASHER; WATER PUMP29 1-13631-093-0 1 SHAFT; WATER PUMP42 (A) 0-41010-855-0 1 STUD; WATER PUMP

M8X55 L=6754 0-28051-060-0 6 BOLT; PULLEY

M10X60 FLANGE65 9-03090-820-0

<8-98230-344-0>2 SCREW; COVER,WATER PUMP

101 (A) 8-98025-787-0 1 CLIP; WATER PIPE101 (B) 1-09701-284-0 6 CLIP; WATER PIPE125 0-91180-108-0 1 NUT; WATER PUMP

M8 FLANGE125 0-91180-110-0 1 NUT; WATER PUMP

M10 FLANGE

KEY No.

0-30 WATER PUMP AND CORROSION RESISTOR

31/74

(No.1)

(No.2)

0-31 THERMOSTAT AND HOUSING

32/74

Part no. qty Part description Engine serial no.1 (A) 8-97602-048-3 1 THERMOSTAT

82 CELSIUS1 (B) 8-98295-921-0

<8-97602-393-1>1 THERMOSTAT

82 CELSIUS17 1-09707-084-1 8 CLIP; WATER HOSE

ID=20UP TO 537279

17 8-98127-648-0 8 CLIP; WATER HOSEID=20

537280 - UP

28 8-94397-338-0 1 PLUG; HTRPT3/8

49 (A) 8-94390-520-1 1 PIPE; WATER OUTLET52 0-28050-880-0 3 BOLT; JOINT,THERMOSTAT

M8X80 FLANGE52 0-28650-825-0 1 BOLT; JOINT,THERMOSTAT

M8X25 FLANGE66 8-98280-281-0

<8-97300-793-0>2 GASKET; THERMOSTAT HSG

78 (A) 8-98025-330-0 1 HOSE; RUBBER,WATER PIPEL=100

78 (B) 0-03566-300-0 2 HOSE; RUBBER,WATER PIPEL=160 S.B.L=3000

78 (C) 8-97086-694-1 1 HOSE; RUBBER,WATER PIPE79 1-09704-077-0 2 CLIP; RUBBER HOSE

ID=44112 (A) 8-94390-527-0 1 PLUG

PTF1/2112 (C) 0-92002-412-0 1 PLUG

M12X9120 (A) 0-28050-845-0 3 BOLT; PIPE FIX

M8X45 FLANGE120 (B) 0-28050-825-0 1 BOLT; PIPE FIX

M8X25 FLANGE120 (C) 0-28055-811-0 1 BOLT; PIPE FIX

M8X110 FLANGE120 (D) 0-28060-812-0 1 BOLT; PIPE FIX

M8X12 FLANGE124 1-13711-806-2 1 DUCT; WATER168 (A) 1-13722-048-2 1 PIPE; WATER,COOLER168 (B) 8-98025-757-0 1 PIPE; WATER,COOLER207 8-94472-584-1 1 GASKET

T=2.5276 1-09361-035-1 1 HOSE; BYPASS

KEY No.

0-31 THERMOSTAT AND HOUSING

33/74

Part no. qty Part description Engine serial no.46 1-13614-023-1 2 GASKET; WATER DUCT,TO OIL47 0-28050-860-0 2 BOLT; DUCT,TO OIL COOLER

M8X60 FLANGE47 0-28650-825-0 2 BOLT; DUCT,TO OIL COOLER

M8X25 FLANGE173 8-94343-839-1

<5-13642-077-0>1 SPACER; WATER PIPE TO BRKT

ID=8.5 L=10177 (A) 0-28050-870-0 1 BOLT; WATER DUCT

M8X70 FLANGE177 (B) 0-28851-670-0 1 BOLT; WATER DUCT

M16X70 FLANGEUP TO 574127

177 (B) 0-28861-670-0 1 BOLT; WATER DUCTM16X70 FLANGE

574128 - UP

178 1-13710-589-0 1 DUCT; WATER,BYPASS179 1-13614-024-1 1 GASKET; WATER DUCT

KEY No.

0-32 WATER PIPING; ENGINE

34/74

Part no. qty Part description Engine serial no.1 (B) 1-13660-156-1 1 FAN; COOLING

D=650-8 BLOW13 0-91180-110-0 6 NUT; COOLING FAN

M10 FLANGE16 0-91614-710-0 6 WASHER; PL,COOLING FAN

ID=10.5 OD=26515425 - UP

32 (B) 8-98030-223-1 1 ADAPTER; FAN TO PULLEY80 1-13674-282-1 1 PLATE; ADJ81 1-13674-161-0 1 PIECE; SLIDING

M12X5982 0-91180-112-0 1 NUT; ADJ PLATE

M12 FLANGE83 8-94217-363-0 1 WASHER; PL

ID=12.5 T=5.886 1-09009-114-1 1 BOLT; ADJ

M10X155 FLANGE96 0-28151-045-0 1 BOLT; ADJ PLATE

M10X45 FLANGE111 0-43211-025-0 6 STUD; FAN DRIVE

M10X25 L=45184 8-98046-166-0 1 BELT; WATER PUMP DRIVE

L=1220 2-PIECES SET

KEY No.

0-33 FAN AND FAN BELT

35/74

Part no. qty Part description Engine serial no.1 1-14400-443-1 1 TURBOCHARGER ASM2 8-98018-855-0 1 GASKET; TURBOCHARGER TO EXH

11 1-09400-027-0 8 NUT; TURBOCHARGER12 1-09302-179-0 2 STUD; TURBOCHARGER98 8-98245-240-0

<1-09360-797-1>1 HOSE; RUBBER,TURBOCHARGER

OUTLET122 8-97061-401-1 6 NUT; ADAPTER

M8 FLANGE212 1-09503-222-0

<1-09503-033-1>4 WASHER; PL,TURBOCHARGER

ID=10360 8-94394-248-2 1 GASKET; ADAPTER TO367 8-97602-902-1 1 ADAPTER; EXH,TURBOCHARGER TO

EXH PIPE417 1-09302-106-0 4 STUD; ADAPTER TO EXH PIPE

M10X30 L=45

KEY No.

0-36 TURBOCHARGER SYSTEM

36/74


(No.2)

0-37-1 TURBOCHARGER

37/74


Part no. qty Part description Engine serial no.3 1-14414-120-0 1 HOUSING; BRG,TURBOCHARGER UP TO 5808687 1-14414-147-0 1 HOUSING; BLOWER,TURBOCHARGER

10 1-14453-099-0 1 REPAIR KIT; TURBOCHARGER UP TO 58086811 1-14419-180-0 1 HOUSING ASM; TURBOCHARGER UP TO 58086818 1-09100-041-0 4 SCREW; THRUST35 8-97245-183-0 1 CLAMP; TURBINE44 1-14425-046-0 1 PLATE; SEAL,TURBOCHARGER60 1-09100-039-0 10 BOLT; BLOWER HSG,TURBOCHARGER UP TO 58086861 8-97245-182-0 1 PIN; TURBINE BRG,TURBOCHARGER

127 9-04138-250-0 6 STUD; TURBOCHARGER136 1-14412-009-0 1 GASKET; TURBINE UP TO 580868144 1-14459-077-0 1 TURBINE KIT; TURBOCHARGER

KEY No.

0-37-1 TURBOCHARGER

38/74


(No.2)

0-37-2 TURBOCHARGER

39/74


Part no. qty Part description Engine serial no.1 8-98241-846-0 1 HOUSING; TURBINE,TURBOCHARGER 580869 - UP3 8-98241-057-0 1 HOUSING; BRG,TURBOCHARGER 580869 - UP5 8-98240-314-0 1 PROTECTOR; HEAT,TURBOCHARGER 580869 - UP7 1-14414-147-0 1 HOUSING; BLOWER,TURBOCHARGER

10 8-98240-306-0 1 REPAIR KIT; TURBOCHARGER 580869 - UP18 1-09100-041-0 4 SCREW; THRUST35 8-97245-183-0 1 CLAMP; TURBINE44 1-14425-046-0 1 PLATE; SEAL,TURBOCHARGER45 1-09100-039-0 4 SCREW; SEAL PLATE,TURBOCHARGER 580869 - UP60 1-09100-039-0 6 BOLT; BLOWER HSG,TURBOCHARGER 580869 - UP61 8-97245-182-0 1 PIN; TURBINE BRG,TURBOCHARGER

127 9-04138-250-0 6 STUD; TURBOCHARGER144 1-14459-077-0 1 TURBINE KIT; TURBOCHARGER

KEY No.

0-37-2 TURBOCHARGER

40/74

(No.1)

(No.2)

0-40 FUEL INJECTION SYSTEM

41/74

Part no. qty Part description Engine serial no.1 8-98091-565-3 1 PUMP ASM; INJ2 8-94399-256-0 3 BOLT; INJ PUMP

M8X286 8-97601-154-1 1 BRACKET; INJ PUMP TO C/BL

16 8-97602-674-3 1 PIPE; INJ NO.117 8-97602-675-3 1 PIPE; INJ NO.218 8-97601-771-3 1 PIPE; INJ NO.319 8-97600-996-4 1 PIPE; INJ NO.420 8-97600-997-3 1 PIPE; INJ NO.521 8-97600-998-3 1 PIPE; INJ NO.631 8-97329-703-6

<8-97329-703-2>6 NOZZLE ASM; INJ UP TO 574127

31 8-98151-837-3 6 NOZZLE ASM; INJ 574128 - 59015631 8-98284-393-0 6 NOZZLE ASM; INJ 590157 - UP61 8-98008-895-0 6 BOLT; CLAMP NOZZLE HOLDER

M8X5466 (A) 8-94173-412-0 6 GASKET; INJ NOZZLE

ID=23.366 (B) 8-98079-248-0

<8-97601-447-2>6 GASKET; INJ NOZZLE

ID=9.2 T=8.168 (A) 1-09701-172-3

<1-09701-172-2>5 CLIP; INJ PIPE UP TO 515424

68 (A) 8-97330-118-3 5 CLIP; INJ PIPE 515425 - UP68 (B) 1-09701-173-2

<1-09701-173-1>5 CLIP; INJ PIPE UP TO 515424

68 (B) 8-97330-119-3 5 CLIP; INJ PIPE 515425 - UP69 1-13319-065-0 1 BRACKET; INJ PIPE CLIP71 (A) 0-28050-870-0 1 BOLT; BRKT

M8X70 FLANGE71 (B) 0-28151-200-0 1 BOLT; BRKT

M12X100 FLANGE94 8-98028-999-1 6 BRACKET; INJ NOZZLE

110 0-91180-106-0 4 NUT; CLIPM6 FLANGE

118 0-28650-625-0 1 BOLT; CLIP,INJ PIPEM6X25 FLANGE

UP TO 515424

118 0-28650-635-0 1 BOLT; CLIP,INJ PIPEM6X35 FLANGE

515425 - UP

121 8-97383-427-0 2 PIPE; FUEL,FEED PUMP,SUCTION UP TO 534685121 8-97383-427-0 4 PIPE; FUEL,FEED PUMP,SUCTION 534686 - UP133 8-98203-705-1 1 PIPE; INJ NOZZLE LEAK OFF134 (A) 1-09675-037-1 6 BOLT; JOINT,LEAK OFF PIPE

M8X18 EYE-BOLT134 (B) 8-94396-711-0 2 BOLT; JOINT,LEAK OFF PIPE

M10X21 FLANGE135 (A) 1-09630-083-0 4 GASKET; JOINT BOLT,LEAK OFF PIPE

ID=10.2 OD=15.2UP TO 574127

135 (B) 8-97600-925-0 6 GASKET; JOINT BOLT,LEAK OFF PIPEID=8.3

UP TO 574127

135 (B) 8-98065-992-0 6 GASKET; JOINT BOLT,LEAK OFF PIPEID=8.3

574128 - UP

135 (C) 8-98079-755-0 1 GASKET; JOINT BOLT,LEAK OFF PIPEID=10.2 OD=17

574128 - UP

135 (D) 8-97240-975-0 1 GASKET; JOINT BOLT,LEAK OFF PIPEID=10.6

574128 - 576049

135 (D) 8-98231-393-0 1 GASKET; JOINT BOLT,LEAK OFF PIPEID=10.6

576050 - UP

154 9-09561-111-0 6 GASKET; CONNECTORID=11.0

UP TO 574127

KEY No.


42/74



154 0-95690-111-0 6 GASKET; CONNECTORID=11.0

574128 - UP

169 (A) 0-91180-110-0 2 NUT; BRKTM10 FLANGE

169 (B) 0-91180-112-0 1 NUT; BRKTM12 FLANGE

176 (A) 1-09675-095-1 2 BOLT; EYE,FEED PUMPM16X30 FLANGE

UP TO 534685

176 (A) 1-09675-095-1 4 BOLT; EYE,FEED PUMPM16X30 FLANGE

534686 - UP

176 (B) 8-98011-269-0 1 BOLT; EYE,FEED PUMPM10X38 EYE BOLT

177 1-09630-086-0 4 GASKET; EYE BOLT,INL,FUEL FEEDPUMP

UP TO 534685

177 1-09630-086-0 8 GASKET; EYE BOLT,INL,FUEL FEEDPUMP

534686 - UP

199 8-97602-218-0 2 GASKET; EYE BOLT200 8-98008-791-0 1 PIPE; FUEL FEED205 8-98023-581-0 1 SENSOR; FUEL TEMP210 8-97603-307-0 1 PIPE; INJ,C/R211 8-98152-950-2

<8-97323-019-0>1 RAIL ASM; COMMON

212 1-09040-091-1 2 BOLT; RAIL ASMM10X34 FLANGE REAMER

216 8-97602-173-0 1 BOLT; EYE265 8-98074-955-0 1 VALVE; FEED PUMP271 (A) 1-09623-464-0 1 GASKET; INJ PUMP

ID=139.6271 (B) 8-98031-844-0 1 GASKET; INJ PUMP

ID=52288 (A) 1-09630-083-0 3 GASKET

ID=10.2 OD=15.2288 (B) 1-09630-085-0 3 GASKET

ID=14.2 OD=19.2UP TO 585209

288 (B) 8-98251-345-0 3 GASKETID=14.2 OD=19.2

585210 - UP

382 8-97375-384-0 1 KEY; DRIVE SHAFT UP TO 574127382 8-98161-995-0 1 KEY; DRIVE SHAFT 574128 - UP392 0-91180-110-0 2 NUT; RAIL ASM

M10 FLANGE424 8-98181-831-0 1 OVERHAUL KIT; SUPPLY PUMP

43/74


(No.2)

0-41-1 FUEL FILTER AND BRACKET

44/74


Part no. qty Part description Engine serial no.1 (A) 8-98143-826-1 1 FILTER ASM; FUEL2 (A) 8-98143-041-1 1 ELEMENT KIT; FUEL FILTER8 (A) 8-98018-529-3 1 COVER; FUEL FILTER

11 8-98008-842-0 1 GASKET; CASE TO BODY,FUEL FILTER UP TO 52390411 8-98008-842-0 2 GASKET; CASE TO BODY,FUEL FILTER 523905 - UP17 8-98008-849-0 1 FLOAT; FUEL FILTER UP TO 52390417 8-98008-849-0 2 FLOAT; FUEL FILTER 523905 - UP35 (A) 8-98014-254-0 1 FILTER ASM; SUB FUEL UP TO 53468536 8-98021-936-0 1 ELEMENT; FUEL FILTER UP TO 53468556 8-98008-847-1 1 PLUG; FUEL FILTER UP TO 58868866 (A) 8-98008-843-0 1 GASKET; PLUG,FUEL FILTER92 1-13226-005-0 1 CAP; FUEL FILTER UP TO 53468594 8-98008-846-1

<8-98008-846-0>1 VALVE; FUEL FILTER UP TO 530585

94 8-98008-846-1<8-98008-846-0>

2 VALVE; FUEL FILTER 530586 - UP

105 (A) 8-98008-844-0 1 CASE; FUEL FILTER106 8-98014-903-0 1 PIPE; FUEL119 (A) 8-98008-848-0 1 PLUG; DRAIN,FUEL FILTER131 (A) 8-98122-953-0 2 PIPE; FILTER UP TO 534685132 8-97329-623-0 2 PLUG; FILTER UP TO 534685

KEY No.


45/74


(No.2)


46/74


Part no. qty Part description Engine serial no.1 (A) 8-98143-826-1 1 FILTER ASM; FUEL2 (A) 8-98143-041-1 1 ELEMENT KIT; FUEL FILTER2 (C) 8-98074-288-1 1 ELEMENT KIT; FUEL FILTER

YELLOW534686 - UP

8 (A) 8-98018-529-3 1 COVER; FUEL FILTER11 8-98008-842-0 2 GASKET; CASE TO BODY,FUEL FILTER 523905 - UP17 8-98008-849-0 2 FLOAT; FUEL FILTER 523905 - UP23 8-98076-256-0 1 PLUG; COVER 534686 - UP35 (B) 8-98075-855-3 1 FILTER ASM; SUB FUEL 534686 - UP37 8-98076-261-2

<8-98076-261-1>1 COVER; FUEL FILTER 534686 - UP

38 8-98074-292-0 1 PLUG; DRAIN 534686 - UP56 8-98008-847-1 1 PLUG; FUEL FILTER UP TO 58868856 8-98074-297-0 1 PLUG; FUEL FILTER 588689 - UP57 8-98074-297-0 1 GASKET; PLUG 534686 - UP66 (A) 8-98008-843-0 1 GASKET; PLUG,FUEL FILTER94 8-98008-846-1

<8-98008-846-0>2 VALVE; FUEL FILTER 530586 - UP

105 (A) 8-98008-844-0 1 CASE; FUEL FILTER105 (B) 8-98074-290-1 1 CASE; FUEL FILTER 534686 - UP106 8-98014-903-0 1 PIPE; FUEL119 (A) 8-98008-848-0 1 PLUG; DRAIN,FUEL FILTER

KEY No.


47/74

Part no. qty Part description Engine serial no.144 0-91180-106-0 1 NUT; CLIP

M6 FLANGE145 (A) 1-09701-180-0 1 CLIP; FUEL PIPE

ID=9 & 9 L=25145 (B) 8-94393-280-3 1 CLIP; FUEL PIPE

ID=9 & 9 L=25145 (C) 8-97216-188-6 1 CLIP; FUEL PIPE146 8-97601-008-0 1 BRACKET; FUEL END147 0-28650-635-0 1 BOLT; CLIP,FUEL PIPE

M6X35 FLANGE148 0-28050-812-0 2 BOLT; BRKT

M8X12 FLANGE258 1-15416-877-0 1 PIPE ASM; FUEL,LEAK OFF

KEY No.

0-42 FUEL PUMP AND PIPE

48/74


Part no. qty Part description Engine serial no.2 1-13240-232-2 1 ELEMENT; OIL FILTER

20 8-94396-753-0 1 PLUG; COOLER BODY21 8-94396-755-0 1 GASKET; PLUG

M2425 1-13219-324-0 4 NUT; CORE TO BODY

M10 FLANGE26 1-21723-066-0 1 CORE ASM; OIL COOLER27 9-09164-510-0 4 WASHER; PL,CORE TO BODY

ID=10.528 (A) 1-21729-117-0 1 GASKET; CORE TO BODY28 (B) 8-94394-930-0 1 GASKET; CORE TO BODY31 0-28151-025-0 1 BOLT; OIL PIPE

M10X25 FLANGE31 0-28151-090-0 3 BOLT; OIL PIPE

M10X90 FLANGE102 1-13201-066-3 1 COOLER ASM; OIL103 8-97365-376-0

<0-28080-822-0>24 BOLT; OIL COOLER

M8X22 FLANGE103 0-28650-835-0 1 BOLT; OIL COOLER


M8X55 FLANGE170 8-94390-078-2 1 PIPE; BYPASS196 8-97600-936-0 1 THERMOSTAT; OIL COOLER

90 CELSIUS197 8-94399-279-0 1 GASKET; THERMOSTAT

ID=25.7321 (A) 8-94399-339-0 1 GASKET; OIL FILTER TO C/BL

ID=9.8

KEY No.

0-50-1 OIL COOLER AND OIL FILTER

49/74

(UP TO ENGINE SERIAL NO. 530585)Part no. qty Part description Engine serial no.

321 (B) 8-94399-399-0 2 GASKET; OIL FILTER TO C/BLID=22

323 8-97363-840-3 1 COVER; OIL PORT352 8-97222-125-0 1 ADAPTER; OIL FILTER444 8-94396-810-0 2 GASKET; ELEMENT TO BODY UP TO 574127447 1-09623-588-0 2 GASKET; BYPASS PIPE

ID=17.8448 0-28050-830-0 4 BOLT; BYPASS PIPE

M8X30 FLANGE469 (A) 8-94399-002-0 1 GASKET; OIL COOLER TO C/BL469 (B) 8-94399-279-0 1 GASKET; OIL COOLER TO C/BL

ID=25.7UP TO 515424

469 (B) 8-98045-449-0 1 GASKET; OIL COOLER TO C/BLID=20

515425 - UP

496 8-98304-243-0<8-97324-386-1>

1 FILTER ASM; OIL

517 8-94391-731-0<1-21729-118-0>

1 PLUG; THERMOSTAT,OIL COOLER

518 0-28050-816-0 2 BOLT; PLUG,THERMOSTATM8X16 FLANGE

558 1-09605-025-0 2 PLUG; COVER,OIL PORTPT3/4

UP TO 530585

560 1-13160-035-0 1 VALVE; RELIEF,OIL PORT COVER UP TO 530585569 1-13711-857-0 1 PIPE; WATER,EGR571 8-98027-456-0 1 SENSOR; OIL PRESSURE572 1-09630-085-0 1 GASKET; OIL PRESSURE

ID=14.2 OD=19.2UP TO 585209


KEY No.

50/74


Part no. qty Part description Engine serial no.2 1-13240-232-2 1 ELEMENT; OIL FILTER

13 1-13160-035-0 1 VALVE; RELIEF 530586 - UP20 8-94396-753-0 1 PLUG; COOLER BODY21 8-94396-755-0 1 GASKET; PLUG

M2425 1-13219-324-0 4 NUT; CORE TO BODY

M10 FLANGE26 1-21723-066-0 1 CORE ASM; OIL COOLER27 9-09164-510-0 4 WASHER; PL,CORE TO BODY

ID=10.528 (A) 1-21729-117-0 1 GASKET; CORE TO BODY28 (B) 8-94394-930-0 1 GASKET; CORE TO BODY31 0-28151-025-0 1 BOLT; OIL PIPE

M10X25 FLANGE31 0-28151-090-0 3 BOLT; OIL PIPE

M10X90 FLANGE102 1-13201-066-3 1 COOLER ASM; OIL103 8-97365-376-0

<0-28080-822-0>24 BOLT; OIL COOLER



M8X55 FLANGE170 8-94390-078-2 1 PIPE; BYPASS196 8-97600-936-0 1 THERMOSTAT; OIL COOLER

90 CELSIUS197 8-94399-279-0 1 GASKET; THERMOSTAT

ID=25.7


KEY No.

51/74

(FROM ENGINE SERIAL NO. 530586)Part no. qty Part description Engine serial no.

288 1-09605-025-0 2 PLUG; OIL DRAINPT3/4

530586 - UP

321 (A) 8-94399-339-0 1 GASKET; OIL FILTER TO C/BLID=9.8

321 (B) 8-94399-399-0 2 GASKET; OIL FILTER TO C/BLID=22

323 8-97363-840-3 1 COVER; OIL PORT352 8-97222-125-0 1 ADAPTER; OIL FILTER444 8-94396-810-0 2 GASKET; ELEMENT TO BODY UP TO 574127444 1-09623-299-0 2 GASKET; ELEMENT TO BODY

ID=38.7574128 - UP

447 1-09623-588-0 2 GASKET; BYPASS PIPEID=17.8

448 0-28050-830-0 4 BOLT; BYPASS PIPEM8X30 FLANGE

469 (A) 8-94399-002-0 1 GASKET; OIL COOLER TO C/BL

469 (B) 8-98045-449-0 1 GASKET; OIL COOLER TO C/BLID=20

496 8-98304-243-0<8-97324-386-1>

1 FILTER ASM; OIL

517 8-94391-731-0<1-21729-118-0>

1 PLUG; THERMOSTAT,OIL COOLER

518 0-28050-816-0 2 BOLT; PLUG,THERMOSTATM8X16 FLANGE

569 1-13711-857-0 1 PIPE; WATER,EGR571 8-98027-456-0 1 SENSOR; OIL PRESSURE572 1-09630-085-0 1 GASKET; OIL PRESSURE

ID=14.2 OD=19.2UP TO 585209

572 8-98251-345-0 1 GASKET; OIL PRESSUREID=14.2 OD=19.2

585210 - UP


KEY No.

52/74

(No.1)

(No.2)

0-51 OIL PUMP AND OIL STRAINER

53/74

Part no. qty Part description Engine serial no.1 8-94390-414-3 1 PUMP ASM; OIL UP TO 5741271 8-97641-835-0 1 PUMP ASM; OIL 574128 - UP2 5-13165-004-0 1 SEAT; SPR3 0-81124-030-0

<9-08104-030-0>1 PIN; SPLIT

L=305 5-09580-098-0 1 SPRING; COIL8 8-97602-115-0 1 GEAR; DRIVEN,OIL PUMP UP TO 5741278 8-97641-838-0 1 GEAR; DRIVEN,OIL PUMP 574128 - UP

20 8-97602-132-1 1 GEAR; DRIVE,OIL PUMP UP TO 57412720 8-97641-839-0 1 GEAR; DRIVE,OIL PUMP 574128 - UP29 0-28050-825-0 4 BOLT; OIL PUMP

M8X25 FLANGE41 5-09843-003-0 1 BALL; OIL RELIEF VLV50 8-94399-398-0 1 GASKET; OIL PIPE,STRAINER TO PUMP

ID=24.551 (A) 1-13314-049-1 1 STRAINER & PIPE ASM; OIL UP TO 57412751 (A) 8-98209-097-0 1 STRAINER & PIPE ASM; OIL 574128 - UP63 0-28080-814-0 2 BOLT; OIL PIPE,STRAINER TO PUMP

M8X14 FLANGE81 8-94393-596-1 2 BUSHING; GEAR SHAFT,OIL PUMP82 1-13119-003-0

<9-13119-022-0>2 DOWEL; OIL PUMP

117 0-28156-015-0 2 BOLT; STAY TO CRANKCASEM10X150 FLANGE

KEY No.

0-51 OIL PUMP AND OIL STRAINER

54/74

Part no. qty Part description Engine serial no.2 (A) 1-09675-229-0 1 BOLT; EYE,OIL PIPE

M12X24 EYE-BOLT2 (B) 8-98037-823-0 1 BOLT; EYE,OIL PIPE

M10X283 (A) 8-97331-137-1 1 GASKET; EYE BOLT,OIL PIPE

ID=12.63 (B) 9-09571-410-0 2 GASKET; EYE BOLT,OIL PIPE

ID=10.2 OD=16.040 (A) 0-28050-840-0 2 BOLT; OIL PIPE

M8X40 FLANGE40 (B) 0-28650-825-0 2 BOLT; OIL PIPE

M8X25 FLANGE44 0-28080-814-0 4 BOLT; CLIP,OIL PIPE

M8X14 FLANGE63 8-98007-000-2 1 PIPE; OIL,TURBOCHARGER FEED

135 0-91180-210-0 1 NUT; CLIPM10 FLANGE

147 8-94390-641-1 1 GASKET; OIL PIPE TO149 1-13313-949-2 1 PIPE; OIL RETURN,TURBOCHARGER150 8-94394-671-0 1 GASKET; OIL PIPE TO C/BL

ID=30

KEY No.

0-52 OIL AND VACUUM PIPING; ENGINE

55/74

Part no. qty Part description Engine serial no.1 8-98001-191-2 1 VALVE; EGR UP TO 5741271 8-98238-249-0

<8-98238-249-1>1 VALVE; EGR 574128 - UP

2 0-28060-825-0 4 BOLT; EGR VLVM8X25 FLANGE

4 8-98001-024-0 1 GASKET; EGR VLV17 (A) 8-97367-918-0 2 GASKET; EGR PIPE17 (B) 8-97601-836-0 1 GASKET; EGR PIPE17 (C) 8-98001-023-0 1 GASKET; EGR PIPE

270 (A) 0-28050-845-0 2 BOLTM8X45 FLANGE

270 (B) 0-28050-860-0 3 BOLTM8X60 FLANGE

270 (C) 0-28050-880-0 1 BOLTM8X80 FLANGE

270 (D) 0-28060-825-0 2 BOLTM8X25 FLANGE

270 (E) 8-98158-604-0 3 BOLTM8X60

270 (F) 8-98186-000-0 2 BOLTM6X14

574128 - UP

681 8-97061-401-1 3 NUT; EGR PIPEM8 FLANGE

703 8-98240-064-1 1 DUCT; EGR709 0-28151-230-0 3 BOLT; EGR COOLER

M12X30 FLANGE710 8-98021-539-0 1 BRACKET; EGR COOLER716 5-09500-012-0 3 WASHER; EGR PIPE

T=1.9718 8-98006-995-4 1 COOLER; EGR

KEY No.

0-57 EMISSION PIPING

56/74

Part no. qty Part description Engine serial no.719 (A) 8-98308-087-0 1 PIPE; EGR719 (B) 8-98006-996-0 1 PIPE; EGR724 8-98117-171-1 1 VALVE; REED UP TO 574127724 8-98184-264-0 1 VALVE; REED 574128 - UP773 0-91280-110-0 4 NUT; CASE

M10 FLANGE774 8-98021-393-1 1 CASE; REED VLV775 9-03486-612-0 2 SCREW; REED VLV UP TO 574127776 8-97374-517-0 2 GASKET; CASE782 (A) 1-09604-094-0 1 PLUG; EGR COOLER 518174 - 574602782 (B) 8-98072-712-0 1 PLUG; EGR COOLER 574603 - UP783 9-09571-410-0 1 GASKET; PLUG

ID=10.2 OD=16.0518174 - UP

0-57 EMISSION PIPING

KEY No.

57/74


(No.2)

0-60-1 ENGINE ELECTRICAL CONTROL PARTS

58/74


Part no. qty Part description Engine serial no.1 8-98141-206-3 1 STARTER ASM

24V5.0KW MITSUBISHI2 1-81200-603-7 1 GENERATOR ASM

24V50A MITSUBISHI7 0-91110-514-0 2 NUT; STARTER

M1410 (A) 8-98005-631-1 1 RELAY; STARTER10 (B) 8-98013-790-0 1 RELAY; STARTER16 1-09000-251-2 1 BOLT; GEN

M14X150513708 - UP

17 0-91610-514-0 1 WASHER; PL,GENID=15

18 0-91510-514-0 1 WASHER; LK,GENID=14.2

19 (A) 1-19711-136-1 1 BRACKET; GEN23 1-19711-029-0 1 NUT; GEN

M14 W/BRKT26 0-28151-080-0 3 BOLT; GEN BRKT

M10X80 FLANGE46 (A) 8-94460-706-1 1 RELAY; GLOW PLUG88 8-94396-396-1 1 ADAPTER; SW

101 0-28650-840-0 4 BOLT; HARNESSM8X40 FLANGE

116 9-09571-416-0 1 GASKET; ADAPTERID=16.2 OD=24

251 8-94474-926-0 1 SPACER; GEN 513708 - UP252 8-98051-537-0 1 COVER; GEN 513708 - UP

KEY No.


59/74

(UP TO ENGINE SERIAL NO. 574127)Part no. qty Part description Engine serial no.

260 8-98023-717-0<8-97170-327-0>

1 SENSOR; WATER TEMP

292 0-91510-514-0 2 WASHER; LK,STARTERID=14.2

459 9-09661-005-0 1 PLUGM16X8 PLUG

613 8-98124-548-2<8-98064-368-0>

1 CONTROL UNIT; ENG

645 (A) 8-98013-790-0 1 RELAY; ENG CONT690 (A) 8-94390-858-1 2 CONNECTOR690 (B) 8-94443-789-0 1 CONNECTOR UP TO 574127715 (A) 5-82550-030-0 1 RELAY; FUEL PUMP

BLACK740 0-91180-108-0 4 NUT

M8 FLANGEUP TO 574127

752 (A) 8-94391-310-0 2 GASKET796 8-97217-778-0 1 SENSOR; MAP797 8-12146-830-0 1 SENSOR; MAT813 (A) 8-98177-447-0 1 HARNESS; INJECTOR813 (B) 8-98177-448-0 1 HARNESS; INJECTOR898 1-80220-014-0 1 SENSOR; BOOST


KEY No.

60/74


(No.2)


61/74


Part no. qty Part description Engine serial no.1 8-98141-206-3 1 STARTER ASM

24V5.0KW MITSUBISHI2 1-81200-603-7 1 GENERATOR ASM

24V50A MITSUBISHI7 0-91110-514-0 2 NUT; STARTER

M1410 (A) 8-98005-631-1 1 RELAY; STARTER10 (B) 8-98013-790-0 1 RELAY; STARTER16 1-09000-251-2 1 BOLT; GEN

M14X15017 0-91610-514-0 1 WASHER; PL,GEN

ID=1518 0-91510-514-0 1 WASHER; LK,GEN

ID=14.219 (A) 1-19711-136-1 1 BRACKET; GEN23 1-19711-029-0 1 NUT; GEN

M14 W/BRKT26 0-28151-080-0 3 BOLT; GEN BRKT

M10X80 FLANGE46 (A) 8-94460-706-1 1 RELAY; GLOW PLUG88 8-94396-396-1 1 ADAPTER; SW

101 0-28650-840-0 4 BOLT; HARNESSM8X40 FLANGE

116 9-09571-416-0 1 GASKET; ADAPTERID=16.2 OD=24

251 8-94474-926-0 1 SPACER; GEN252 8-98051-537-0 1 COVER; GEN


KEY No.

62/74

(FROM ENGINE SERIAL NO. 574128)Part no. qty Part description Engine serial no.

260 8-98023-717-0<8-97170-327-0>

1 SENSOR; WATER TEMP

292 0-91510-514-0 2 WASHER; LK,STARTERID=14.2

459 9-09661-005-0 1 PLUGM16X8 PLUG

613 8-98124-548-2<8-98064-368-0>

1 CONTROL UNIT; ENG

645 (A) 8-98013-790-0 1 RELAY; ENG CONT690 (A) 8-94390-858-1 2 CONNECTOR715 (A) 5-82550-030-0 1 RELAY; FUEL PUMP

BLACK740 0-91180-108-0 2 NUT

M8 FLANGE574128 - UP

752 (A) 8-94391-310-0 2 GASKET796 8-97217-778-0 1 SENSOR; MAP797 8-12146-830-0 1 SENSOR; MAT813 (A) 8-98177-447-0 1 HARNESS; INJECTOR813 (B) 8-98177-448-0 1 HARNESS; INJECTOR836 0-28050-812-0 2 BOLT; CONNECTOR

M8X12 FLANGE574128 - UP

898 1-80220-014-0 1 SENSOR; BOOST


KEY No.

63/74

Part no. qty Part description Engine serial no.2 8-98152-868-0 1 CASE; PINION,STARTER 574128 - UP6 8-94475-688-0 1 STOPPER; PINION STARTER7 1-81129-759-0 1 CLUTCH ASM; PINION,STARTER UP TO 5873337 8-98245-549-0 1 CLUTCH ASM; PINION,STARTER 587334 - UP

11 8-97116-484-0 1 WASHER; GEAR SHAFT STARTER13 8-98152-277-0 1 YOKE; STARTER 574128 - UP16 1-81121-075-0 1 ARMATURE; STARTER17 (A) 1-81129-837-0 1 BEARING; ARMATURE,STARTER20 1-81116-066-0 2 BRUSH; (+),STARTER21 1-81129-768-0 4 SPRING; BRUSH HOLDER STARTER22 1-81121-066-0 1 HOLDER; BRUSH STARTER UP TO 58733322 8-98245-553-0 1 HOLDER; BRUSH STARTER 587334 - UP23 1-81115-229-0 1 COVER; RR COVER STARTER27 (A) 1-81129-769-0 1 BOLT; THROUGH,STARTER28 1-81129-762-0 1 LEVER; SHIFT,STARTER31 8-98237-257-0 1 SWITCH; ENGAGE STARTER 574128 - UP46 (A) 8-97178-153-0 1 GEAR; CLU STARTER UP TO 58733346 (A) 8-97116-485-0 1 GEAR; CLU STARTER 587334 - UP48 8-97116-515-0 1 BALL; PINION,STARTER54 1-81129-761-0 1 CLUTCH; PINION,STARTER55 8-98060-835-0 1 PINION; CLU,STARTER 517402 - UP90 1-81129-767-0 2 GASKET; ARMATURE91 1-81129-764-0 1 COVER; STARTER96 8-97116-489-0 1 GASKET; FRT CASE97 8-97116-490-0 4 GEAR; STARTER

128 1-81129-758-0 1 BEARING; STARTER133 1-81129-765-0 1 SCREW SET; STARTER140 8-97376-390-0 1 GROMMET; RR COVER

KEY No.

0-65 STARTER

64/74

Part no. qty Part description Engine serial no.1 1-81214-363-2 1 COVER ASM; RR,GEN2 1-81221-102-0 1 ROTOR; GEN3 (A) 1-81229-769-0 1 BEARING; ROTOR,GEN3 (B) 1-81229-770-0 1 BEARING; ROTOR,GEN6 1-81260-017-0

<1-81260-017-1>1 REGULATOR ASM; VOLTAGE,GEN

10 (A) 1-81219-125-0 1 RECTIFIER; GEN16 1-81229-803-0 1 TERMINAL ASM; RECTIFIER,GEN17 1-81213-101-0 1 COVER ASM; FRT,GEN19 1-81222-136-2 1 PULLEY; GEN UP TO 57460219 8-98238-727-0 1 PULLEY; GEN 574603 - UP22 1-81211-129-0 1 STATOR; GEN23 8-98200-173-0 1 COIL; ROTOR GEN27 (A) 1-81229-772-0 1 NUT; RECTIFIER,GEN36 1-81229-768-0 1 SCREW; FRT COVER43 (A) 1-81229-773-0 1 SCREW; RR END COVER43 (B) 1-81229-774-0 1 SCREW; RR END COVER43 (C) 1-81229-832-0 1 SCREW; RR END COVER69 1-81229-836-0 1 CLIP; WIRE,GEN86 8-97178-134-0 1 NUT SET; PULLEY,GEN

127 1-81229-767-0 1 BOLT SET; GEN

KEY No.

0-66 GENERATOR

65/74

Part no. qty Part description Engine serial no.1 1-14210-516-2 1 CLEANER ASM; AIR2 1-14217-003-0 2 NUT; WING,ELEMENT3 9-14219-177-0

<1-14219-032-0>2 WASHER; SEAL,WING NUT

4 9-14219-143-0 1 GASKET; COVER TO BODY26 1-14215-034-1

<1-14215-034-0>1 FILTER; ACL,INNER

27 1-14215-188-0<1-14215-046-1>

1 FILTER; ACL,OUTER

33 (A) 1-14219-200-0 1 BAFFLE; ACL33 (B) 9-14219-144-0 1 BAFFLE; ACL89 1-14219-212-0

<9-14219-141-0>1 INDICATOR; ACL

90 1-14219-114-0 1 CUP; ACL91 9-14217-060-0 1 CLAMP94 1-14219-065-0 1 VALVE; VACUATOR

KEY No.

1-30 AIR CLEANER

66/74


Part no. qty Part description Engine serial no.127 8-98009-397-1 1 PUMP ASM; FUEL,ELEC414 8-97047-266-0 2 GROMMET; PUMP MTG,ELEC FUEL415 8-97047-265-0 2 COLLAR; GROMMET,ELEC FUEL PUMP418 8-98071-404-0 1 GASKET; FUEL PUMP484 8-94437-022-0

<8-94337-022-0>1 REPAIR KIT; FUEL PUMP

PAPER FILTERUP TO 520296

KEY No.

1-40 FUEL TANK

67/74


Part no. qty Part description Engine serial no.127 8-98009-397-1 1 PUMP ASM; FUEL,ELEC414 8-97047-266-0 2 GROMMET; PUMP MTG,ELEC FUEL415 8-97047-265-0 2 COLLAR; GROMMET,ELEC FUEL PUMP418 8-98071-404-0 1 GASKET; FUEL PUMP484 8-98173-165-0 1 REPAIR KIT; FUEL PUMP

MESH FILTER520297 - UP

646 8-98071-401-0 1 FILTER; FUEL PUMPMESH FILTER

520297 - UP

1-40 FUEL TANK

KEY No.

68/74

Part no. qty Part description Engine serial no.313 8-98170-586-0 1 COOLER ASM; FUEL 574128 - UPKEY No.

1-41 FUEL PIPING; CHASSIS

69/74

Part no. qty Part description Engine serial no.84 1-14145-192-0 1 GASKET; EXH PIPE

KEY No.

1-50 EXHAUST PIPE AND SILENCER

70/74

Part no. qty Part description Engine serial no.13 1-82641-351-6 1 HARNESS; ENG

KEY No.

8-10 WIRING HARNESS AND FUSE

71/74

(No.1)

(No.2)

8-15 FIXING PARTS; WIRING HARNESS

72/74

Part no. qty Part description Engine serial no.14 (A) 5-09707-030-1 2 CLIP; BAND,HARNESS

L=250UP TO 574127

14 (A) 8-98216-430-0 2 CLIP; BAND,HARNESSL=250

574128 - UP

304 (A) 0-28050-812-0 7 BOLT; ENG HARNESS CLIPM8X12 FLANGE

UP TO 518173

304 (A) 0-28050-812-0 6 BOLT; ENG HARNESS CLIPM8X12 FLANGE

518174 - UP

304 (B) 0-28050-816-0 5 BOLT; ENG HARNESS CLIPM8X16 FLANGE

304 (C) 0-28151-020-0 2 BOLT; ENG HARNESS CLIPM10X20 FLANGE

305 (A) 1-09700-329-1<1-09700-607-1>

1 CLIP; ENG HARNESSID=28 L=30

305 (B) 1-09700-766-1 1 CLIP; ENG HARNESSID=24 L=32

305 (C) 8-97367-984-1 3 CLIP; ENG HARNESSID=12

305 (D) 8-94443-021-1 2 CLIP; ENG HARNESSL=100

305 (E) 0-95235-855-0 1 CLIP; ENG HARNESSID=19 L=28

305 (F) 0-95235-886-0 2 CLIP; ENG HARNESSID=19 L=50

305 (G) 9-09917-356-0 1 CLIP; ENG HARNESSID=19.5X2 L=24.5

305 (H) 8-97367-985-1 2 CLIP; ENG HARNESSID=18 L=44

308 (A) 8-98025-683-0 1 BRACKET; CLIP,ENG HARNESS308 (B) 1-47475-868-0 1 BRACKET; CLIP,ENG HARNESS308 (C) 1-47477-088-1 1 BRACKET; CLIP,ENG HARNESS308 (D) 8-97602-870-1 2 BRACKET; CLIP,ENG HARNESS308 (E) 8-98025-684-0 2 BRACKET; CLIP,ENG HARNESS

KEY No.

8-15 FIXING PARTS; WIRING HARNESS

73/74

Part no. qty Part description Engine serial no.58 8-94402-500-0

<1-82313-005-0>1 SWITCH; IGNITION

63 8-94402-500-0 1 SWITCH ASM; STARTER434 8-94402-498-0 1 KEY; STARTER SW

KEY No.

8-25 SWITCH AND RELAY; INSTRUMENT PANEL

74/74

Documents

ISUZU DIESEL ENGINE 6HK1 XYGD01 PARTS CATALOG