Upload
etheque
View
215
Download
0
Embed Size (px)
Citation preview
8/6/2019 Instrument Eng Should Know
1/5
What an instrument engineer should know?Posted on | March 11, 2010 | 2 Comments
A. Instrument Specifications
- Allocation Gas Metering Specification
- Automation System Network Spec
- Control Panel, Cabinet and Rack Specification
- Control Valve Specification
- Fusible Plug Panel Specification
- General Instrument Design
- HSSD Specification
- Instrument / Telecom cable Specification
- Instrumentation & Control Section of The Basis of Design
- MCS, PSD, & ESD System Specification
- Specification for Pressure Safety and Relief Valves
- Specification for Shutdown Valves & Blowdown Valves and Actuator Assemblies
- Typical System Functional Design Spec.
- Wellhead Control Panel Specification
B. Instrument Philosophies
- Automation System Philosophy
- Automation System Reset & Override Philosophy
- Fire and Gas Philosophy
- Instrument Earthing Philosophy
- Shutdown Philosophy
C. Documents Related To Automation System
- Fire & Gas Cause / ESD and Effect Chart
- Serial Link Data Listings and Addresses Allocation Gas Meter, Chemical Injection, Wet Gas Meter,
Fire Water Pump, Glycol Reboiler, MV SWGR, Fire Water Pump
- Graphic for F&G, MCS, PSD/ESD (Review)
Object1
http://instrumentation.web.id/?p=12http://instrumentation.web.id/?p=12#commentshttp://instrumentation.web.id/?p=12#commentshttp://instrumentation.web.id/?p=128/6/2019 Instrument Eng Should Know
2/5
- Instrument Cable Block Diagram-MCS, PSD/ESD, TCS
- Instrument Logic Diagram for Actuated Valve, ESD/PSD, F&G, Pump & Fan Motor, MCS, TCS
- Instrument loop safety integrity level listing (SIL).
- Logic sequence flow step charts.
- Master Alarm & Trip Schedule
- Network Architecture (Review)
- PSD/ESD Cause and Effect Chart
- Serial Link Data Listings and Addresses
- Shutdown Hierarchy (Shutdown flow block diagram identifying each level and causes & effects)
- Instrument I/O List MCS, PSD, ESD, F&G, TCS
- Instrument & Automation Equipment List
D. Miscellaneous Documents
- Instrument Installation, testing, Pre-Commissioning, and Commissioning- Instrumentations Tools
- Intruder and CCTV management
- Laboratory Equipment List
- List of Test Equipmets
E. Instrument Calculations
- Calculation of Actuator sizing.
- Calculation of Control valve sizing and noise.
- Calculation of Flowmeter sizing.
- Calculation of Heat dissipation.
- Calculation of Hydraulic tank, pumps and accumulator sizing calculations.
- Calculation of Instrument power cable sizing calculations.
- Calculation of Instrument utilities consumption.
- Calculation of Relief valve sizing and noise.
- Calculation of Restriction orifice sizing and stress and noise.
- Calculation of Thermowell and other insertion device stress and wake frequency.
- Calculation of Tubing sizing calculations (Hydraulic)
- Calculation of Valve speed calculations (where required)
F. Instrument Datasheets
- Datasheet of Actuated Ball Valves
- Datasheet of Actuated ON/OFF Valves
- Datasheet of Annubar Flow Meter
8/6/2019 Instrument Eng Should Know
3/5
- Datasheet of Anti-Surge Control Valve
- Datasheet of Bubble Type Level Transmitters
- Datasheet of Choke Valves
- Datasheet of Control Valves
- Datasheet of Coriolis Flow Meter
- Datasheet of Deluge Valves
- Datasheet of Dew Poin Analyser
- Datasheet of Differential Pressure Indicating Transmitters
- Datasheet of Differential Pressure Indicators
- Datasheet of Displacer Level Transmitters
- Datasheet of Duplex RTD
- Datasheet of Electrical Hand Switches
- Datasheet of Flanged Thermowells- Datasheet of Flow Meter (Ultrasonic)
- Datasheet of Flow Switch
- Datasheet of Gas Analyzer Chromatograph
- Datasheet of Guide Wave Radar Level Transmitters
- Datasheet of H2 Detectors
- Datasheet of HC Gas Detectors (Open Path)
- Datasheet of HC Gas Detectors (Point)
- Datasheet of Heat Detectors
- Datasheet of Infra Red Flame Detectors
- Datasheet of Intruder Detectors
- Datasheet of Junior/Senior Flow Elements
- Datasheet of Magnetic Flow Meter
- Datasheet of Magnetic Level Gauge
- Datasheet of Magnetostrictive Level Transmitters
- Datasheet of Moisture Analyser
- Datasheet of Orifice Flow Element
- Datasheet of Pig Indicators
- Datasheet of Pig Signaller Intrusive
- Datasheet of Pneumatic Pressure Pilot
- Datasheet of Pressure Indicating Transmitters
- Datasheet of Pressure Indicator
8/6/2019 Instrument Eng Should Know
4/5
8/6/2019 Instrument Eng Should Know
5/5
I. Instrument Material Take Off
- MTO Cable Glands
- MTO Earthing Devices
- MTO Fusible Plugs
- MTO Installation Support
- MTO Instrument & Telecom Cable
- MTO Instrument Cable & Tubing Tray
- MTO Instrument Cable Accessories
- MTO Instrument Cable Ladder & Tubing Tray
- MTO Instrument Distribution Manifold
- MTO Instrument Fittings
- MTO Instrument Junction Box
- MTO Instrument Manual Valves- MTO Instrument Tubing
- MTO Multiple Cable Transit (MCT)
J. Instrument Schedules
- Instrument Cables Schedule
- Instrument Index
- Instrument Junction Box Schedule
- Hazardous Area Equipment Schedule