INSTRUCTION MANUAL

TO-1 80 TO-1 80 082887 082887

Revised 040390 Revised 040390

with

ILLUSTRATED PARTS LIST

for

OPTIONAL FIFTH WHEEL TRAILER

used in mounting

DEUTZ ENGINE DRIVE

GENERATOR SETS

KIT, TRAILER, & FENDER PART NUMBERS

280359-l and 280359-2

HOBART BROTHERS COMPANY

AIRPORT SYSTEMS DIVISION

TROY, OHIO 45373

U.S.A.

HOBART BROTHERS COMPANY

AIRPORT SYSTEMS DIVISION

TROY, OHIO 45373

U.S.A.

This page intentionally left blank.

Addendum

1. Scope This addendum increases the coverage of Hobart Manual TO-l 80 to include Trailer Kit No. 280359-2.

2. Description Part No. 280359-2 trailer kit is basically the same as 280359-l except for a unique towing tongue assembly that incorpoates a protector leg and handles. The remainder of the physical appearance, service and operation will remain the same as the 280359-l specifications.

3. Manual Changes For easy reference, your manual (TO-1 80) may be marked from this addendum to include information and items specific to Part No. 280359-2. If marking the manual in this manner, the following changes should be noted in the manual:

Page 4, Figure 3

Add Item No. 53, Part No. 281730, TONGUE, TOWING AY.

4. Customer Service If you have any questions concerning your Hobart Power Systems Group equipment, you are invited to contact our service department by mail, telephone or FAX.

Write: Hobart Brothers Company Airport Systems Group 1177 Trade Square East Service Department Troy, OH 45373 U.S.A.

Phone: (513) 332-5060 - Service (513) 3325050 - Repair Parts

FAX: (513) 332-5121

TO-180 Addendum 4/3/90

,-

KIT, TRAILER & FENDER ASSY.

1. General

The purpose of the fifth wheel trailer (see Fig. 1) is to add mobility to a Deutz, engine-driven generator set. A Prototype trailer with fifth wheel steering is offered as optional equipment with generator set.

Kit, Trailer & Fender Assy. Figure 1

NM?

Creane, Automotive and Induatrlal

Crease, Automotlvt

Federal W-G-632

ltl11tm-y ML-L-2104B or equivalent

Mlftary !fIL-G-10924B or equivalent

NOTES

Sinclair Lltholtnt Industrial No. 2; "Hobllc-Mobilplex" 47, or equivalent.

SAE-30, Summer ME-IO, Ulnttr

Wheel bearings

Trailer Lubricants

TO-180

Ml Pivot Pin

I 1

D Dally 7 hours u Weekly, or 50 hours BW Biweekly, or 100 hours n Monthly, or 200 hours SA Semi-annually, or 1200 hours A Annually, or 2400 hours

Lubrication Chart Symbols and l'lat Intervals

Shackle

Wheel Bearings

Shackle

Page 2 mLubri-c-a-tion.Chart

Figure 2 Lug 28187

TO-180

I 2 3456 I I , I I 7,8 B ‘O ” I I I I ‘: ‘I3 :’

~

--.

: --.

-

I1 I I I ,/ rr ret ril

c--- -----3 I

35 36 35 34 26 24 23 20

33,32,31,30,29,28,27,26 25 ,

21,22 19 15,16,1~18 I \ I

Kit, Trailer & Fender Assy. Figure 3

k- 65” Track -{

Aug 28187 Page 3

,

FIGURE ITEM NO.

3-

1 488174 2 488253 3 280323 4 488238 5 488172 6 488526 7 280363 8 280361 9 280362 10 280315 11 280317 12 280379 13 280311 14 280352 15 w-11439-1 16 408781-l 17 280321 18 280360 19 280365 20 280310 21 488249 22 488247 23 280319 24 280313 25 488155 26 488171 27 488302-2 28 488302-l 29 402086-3 30 488245 31 5CW-2048 32 488165 33 488166 34 488170 35 488231 36 488251 37 488176

* 38 488163 * 39 488164 * 40 76A-1131 * 41 488184 * 42 488204 * 43 402037-12 * 44 488269-l * 45 488269-3

HOBART PART NO.

280359-l

* NOT ILLUSTRATED-

NOMENCLATURE

1234567

KIT, TRAILER & FENDER ASSY. (For NHA See Fig. 1)

. RAIL, CABLE, OUTPUT

. FENDER, REAR, LT. AY.

. FRAME, MTG.,90 KVA DEUTZ AY.

. PANEL, DUCT, ENG, AY.

. PLATE, COVER TOP

. COVER, OIL DRAIN AY.

. PANEL, FLOOR, GEN. LT. AY.

. STRIP, MTG. PANEL

. PANEL, FLOOR, GEN. RT. AY.

. FENDER, FRONT, LT AY.

. RAIL, OUTPUT AY.

. PANEL FLOOR GEN. FRONT AY.

. RAIL, CABLE SUPPORT AY.

. SUPPORT, CABLE TRAY

. FITTING, GREASE, SCREW TYPE

. PIN, SPIROL

. BLOCK, REAR AXLE

. TRAILER, REWORK AY.

. PANEL, FLOOR "V" BRACE

. TRAY, CABLE SUPPORT

. DEFLECTOR, AIR AY.

. BRACKET, MTG. DEFLECTOR

. RAIL, CABLE OUTPUT

. FENDER, FRONT, RT AY.

. FENDER, SIDE CENTER AY.

. PANEL, COVER BATTERY AY.

. CABLE, BATTERY NEG. TO NEG.

. CABLE, BATTERY POS. TO POS.

. BATTERY, 12V

. CLAMP, HOLD DOWN BATTERY

. ROD, HOLD DOWN, BATTERY

. SUPPORT, BATTERY

. SIDE, BATTERY BOX

. PANEL, COVER BATTERY AY.

. PANEL, BOTTOM FUEL TANK

. FENDER, REAR RIGHT AY.

. RAIL, CABLE SUPPORT AY.

. SUPPORT, FENDER

. GUARD, END REAR

. TUBING, Z-FLEX

. PANEL, SEAL, GEN. AY.

. PANEL, LOWER ENGINE FRONT

. GROMMET, RUBBER

. ROD, BRAKE

. ROD, BRAKE

TO-18~0

UNITS

per ASSY

1 1 1 1 1 1 1 1 1 1 1 1 1 2 2 2 4 1 1 1 1 2 1 1 2 1 1 1 2 2 4 1 1 1 1 1 1 2 1 6" 1 1 3 2 1

Page 4 -~ ~- Aug 28187

FIGURE HOBART ITEM NO. PART NO.

3-

* 46 * 47 * 48 * 49 * 50 * 51 * 52

-

TO-180

NOMENCLATURE

1234567

UNITS per

ASSY

280359-l KIT, TRAILER & FENDER ASSY. (For NHA See Fig. 1) 1

488268 . SHIELD, BRAKE LEVER 488270 . SUPPORT, ROD, BRAKE AY. 488275 . SUPPORT, BRAKE RIGGING AY. 489814 . ROD, RIGGING, BRAKE REWORK 430278 . GROMMET 280366 . SUPPORT, BRAKE HANDLE 848-1054-l . REFLECTOR

* NOT ILLUSTRATED

Aug 28187

I I DIA. B.C. 4 PC. 3712 WHEEL HUB CAP W/O 4.00 RIM 5 ON 5-1,‘2

5/32 DISH FOR 6.00 x 9 TlRES 10 PLY

4 PC. 4-3712 WHE<L AND TIRE AY. 690 x 9 10 PLY (H.B. P/N 76A-1140) PRIMER BY PROTOTYPE

Trailer Assembly Figure 4

Page 6 Aug 28187

TO-180

Customer Service

If you have any questions concerning your Hobart Ground Power Division equipment, you are invited to contact our service department by mail, telephone, or FAX.

Write: Hobart Brothers Company Airport Power Division 1177 Trade Road East Troy, Ohio 45373, U.S.A.

Telephone: (513) 3325060 (Service Assistance)

(513) 3325050 (Parts Replacement)

FAX: (513) 332-5121

April 3/90 Revised Page 7