/

MqKMotionI HP to 50HP lM er JP Close CoupledHigh Efficiency NEMA l2-l I Motors

Applications:Close-coupled pumps when the pump impeller is required to be mounted directly on the motor shaft in damp

and dirty environments, and operating directly across the line orfrom a variable frequency inverter.:;^;;fiTAW* {[i:fi[]tri"!ufi

Wffiffi

Wwffi

@

K&ilIIIII

ffi

ffi

ffi

W

wffire

xa€IIIIII

$silNl$$

ffi$

ffi*

wg

ffitffitE

ffi$

g!gtXT

II

EI

Features:. Design - NEMAStandard MG-1 Design B

. Agency listings and standards - NEMA, IEEE, CSA, CSAus, lEC, CE, NRCan.

. Electrical Supply - At 60Hz: 575V and 208-2301416-480V dual rated for 50Hz: 1 90/380-41 5.

. Voftage and Frequency Variation - +h10% voltage variation and +15% frequency variation

. Windings - High quality copper magnet wire class F insulation system with class H VPI epoxy

resin protection.

. Bearings - 143T to 215T are double sealed and grease fllled; 254T and larger are regreasable

with brass grease nipples and retaining bearing caps.

. Bearing lubricant - Frame 143T to 215T is lithium grease, -30 Deg C to 180 Deg C Amb. Frames

254T and larger are long life Mobil Polyrex EM, -29 Deg C to 177 Deg C.

. Enclosure Protection - Totally Enclosed Fan Cooled meeting IEC standard 1p55.

. Conduit Box - Oversize cast iron diagonally split and can be rotated in g0 Deg steps. Lead

separator gasket to seal conduit box from frame and gasketed cover. Grounding terminal inside

conduit box and threaded conduit entry.

. lnverter Duty - Suitable for lnverter application at 230V 460V, and 575V for speed ranges of

2.1 constanl torque and 10:1 variable torque.

. Nameplate - Corrosion resistant stainless steel showing all data, connection diagrams and certifications.

. Drain Plugs - Located at the lowest point of each end bracket.

. Warranty - 30 months from installation or 36 months from shipment whichever is first.

//

axMotion1HP to 50HP lM & lP Close Coupled High Efficiency NEMA l2-1 1 Motors

MaxMotion Sedes IIEMA Close Coupled High Efficiency Per{ormance Data*

iNllit.,

WffiiffiffiE

!9.:--.:3*M*d

trlfl::":::i# €#ffi ffi&B

F"ffi-SffiffiFsffi#ffiffie

iffiffiffiFWffiW$NltMWffiSsl{fw$sffffiw ffiR*si$s*ffiw$w m**6 sgfl*

ffiWW8

wffiK*

ffiWKI

ffiilllroEXt

rilrilIlrilllIIlI

ltFliT. # at8,:t0/4r5.

{80v

:.,ril,CtTi,*,57w tP!{

,rrE,.i:,o.

Iriilu,:.:. t:r.\.::E..:{:

.r,'rDati at:!OHz

llEf,Sf;'I,,85..:

', Sl

'z...:.2

:ij:<::ii:A::ii;s

': .,.i::::.:..''fLt,;i:.,ls$Y/460v

crotL.R.

AlilPS

.:FlA

rlSY.-

575V[.:n]

fl{PSCODE

1 JMQ.2 JMP-2 1740 143JM 1.15 3.0t1.5 15 1,2 12 82.5 M 6206/6205 15.2

1.5 JMQ-7 JMP.7 1744 145JM 1.15 4.412.2 2A 1-8 16 B4 M 51 6206t6205 18-2

2

JMO-11 JMP.11 3500 '145Jtvl 1.15 4.4t2.4 25 1.9 20 a4 L 44 6206t6245 16.2

JMO-12 JMP-12 1744 145JM 1.15 5.6t2,8 25 2.2 20 a4 L 53 6206/6205 16.2

JPQ-12 JPP.12 1740 145JP 1.15 5.6/2.8 23 ,n 84 L E? 6206/6205 19.3

J

JMO-165 JMP-16S 3510 145JM 1.15 7_4t3.7 32 3-0 25.6 85.5 K 55 620616205 16.2

JMQ.16 JMP-16 3510 182JM 1.15 7.4t3.7 32 3.0 25.6 85.5 K u 620816306 17.5

JMQ-17 JMP-17 1745 182JM 1,15 8,0/4.0 32 3.2 zc.b 87.5 K 75 6208t6306 17.5

JPQ.17 JPP-17 1745 182JP 1.15 8.0/4.0 JZ 3.2 25.6 87.5 K 75 6208t6306 20.5

5

JMO-21 JMP-21 3515 184JM 1.15 11,61s.8 46 4.7 Jb-6 87.5 J 97 620816306 18.5

JMQ-22 JMP-22 1745 184JM 1.15 1316.5 46 5.2 36.8 87.5 J 93 6208/6306 18.5

JPA-22 JPP-22 1745 184JP 1.15 13t6.5 46 5.2 36.8 87.5 J 93 620816306 21.5

7.5

JMQ.26S JMP.26S 3525 184JM 1.1s 17.618.8 63 7.0 50.4 88.5 u 106 620816306 18.5

JMQ.26 JMP.26 3525 213JM 1.15 17.618.8 63 7-B 50.4 88.5 H 140 630St6308 20.8

JMO-27 JMP-27 'i750 213JM 1.15 18.4t9.2 OJ 7_4 50.4 s9.5 H 133 630S16308 20.8

JPQ-27 JPP-27 1750 213JP 1.15 18.4t9.2 h-1 7,4 50.4 8S-5 H 133 630516308 24.7

IU

JMQ-31 JMP-31 ?.qr6 215JM 1.15 23t1't.5 81 s-1 65 89.5 n to I 6309/6308 22.3

JFO-31 JPP-31 3525 215JP 1.15 23n1.5 81 5t 65 BS.5 H 161 630916308 t6.t

JMQ-32 JMP.32 1750 215JM 1-15 24,4t12,4 81 9.6 65 89.5 H 165 6309/6308 22.3

JPQ-32 JPP-32 1750 215JP 1.15 24.O112.A 81 9.6 65 89.5 H 165 630316308 26-2

15

JMQ-36S JMP-36S 3515 21sJM 1.15 36.6t12.2 tto 13.8 oa s0.2 G 176 630S16308 22.3

JMO*36 JMP.36 3515 254JM 1.15 34.4t17.2 116 13.8 6? 90.2 r: 2s2 6309/6309 24.7

JPO-36S JPP-36S 3515 215JP 1.15 M.4t17-2 116 13-8 5,1 s0.2 G 176 630916308 26.2

JPQ-36 JPP-36 3515 254JP 1.15 34.4t17.2 1't6 13.8 s3 90.2 G 252 6309/630S 27.6

JMQ-37 JMP-37 1750 254JM 1_1s 36"4t18.2 116 14.6 93 s0"2 251 630316309 24,7

2AJMQ.41 JMP.41 3530 256JM 1.15 45f22.5 145 18.0 116 90.2 G too 630916309 zb-3

JMA-42 JMP.42 1750 256JM 1,15 48.4t24.2 145 19.4 I tb 91 2S3 630Si6309 26-5

25

JMQ-46S JMP.46S 3530 256JM 1.15 56t28 182 22.4 146 91 (j 310 6309/6309 26.5

JMG.46 JMp-46 3530 28lJM 1.15 56t28 1&2 22.4 146 s1 G 361 6311/6311 27_5

JMQ.47 JMP-47 1760 284JM 1 _15 60/30 1&2 24-A 146 92.4 L' 365 6311/6311 29.1

30JMQ-51 JMP.51 3530 286JM 1.15 67.4133.7 217 27.O 174 91 396 631116311 29.1

JM0-52 JMP-52 1764 2B6JM 1.15 70 6/35.3 217 28.2 174 s2.4 u 397 631 1/631 1 29.1

40

JMQ-56S JMP-56S 3540 286JM 1,15 85t44,5 290 35_6 232 91.7 G 431 6311i6311 29.1

JMQ-56 JMP-56 3s40 324JM 1.15 85t44.5 2S0 35.6 232 91.7 u 493 6312t6312 30

JMQ-57 JMP-57 t/otl 324JM 1.15 s3.2/46.6 290 232 s3 G 51S 6312t6312 30

50 JM0-61 .JMtr-61 3545 326JM 10155 440 2go s2.4 G s43 6312t6312 31.5