IC-F11/F12 series Service Manualhamradio.online.ru/ftp2/serman_icf11_12.pdf · 1130007020 S.IC TC7S66FU IC-F11 MAIN UNIT 1 piece 8810009510 Screw BO M 2 x 4 NI-ZU IC-F11 Chassis 10

SERVICEMANUAL

1-1-32, Kamiminami, Hirano-ku, Osaka, 547-0003, JapanS-13806IZ-C1V

© 2001 Icom Inc.

VHF TRANSCEIVERS

INTRODUCTION

DANGER

ORDERING PARTS

REPAIR NOTES

This service manual describes the latest service informationfor the IC-F11/IC-F11S/IC-F11BR/IC-F12/IC-F12S at thetime of publication.

NEVER connect the transceiver to an AC outlet or to a DCpower supply that uses more than 16 V. Such a connectioncould cause a fire hazard and/or electric shock.

DO NOT expose the transceiver to rain, snow or any liquids.

DO NOT reverse the polarities of the power supply when con-necting the transceiver.

DO NOT apply an RF signal of more than 20 dBm (100mW)to the antenna connector. This could damage the transceiv-er’s front end.

Be sure to include the following four points when orderingreplacement parts:

1. 10-digit order numbers2. Component part number and name3. Equipment model name and unit name4. Quantity required

<SAMPLE ORDER>1130007020 S.IC TC7S66FU IC-F11 MAIN UNIT 1 piece8810009510 Screw BO M 2 x 4 NI-ZU IC-F11 Chassis 10 pieces

Addresses are provided on the inside back cover for yourconvenience.

1. Make sure a problem is internal before disassembling the transceiver.2. DO NOT open the transceiver until the transceiver is disconnected from its power source.3. DO NOT force any of the variable components. Turn them slowly and smoothly.4. DO NOT short any circuits or electronic parts. An insulated turning tool MUST be used for all adjustments.5. DO NOT keep power ON for a long time when the transceiver is defective.6. DO NOT transmit power into a signal generator or a sweep generator.7. ALWAYS connect a 40 dB to 50 dB attenuator between the transceiver and a deviation meter or spectrum analyzer when

using such test equipment.8. READ the instructions of test equipment thoroughly before connecting equipment to the transceiver.

To upgrade quality, all electrical or mechanical parts andinternal circuits are subject to change without notice or oblig-ation.

IC-F11/IC-F12 IC-F11BR/IC-F11S/IC-F12S

TABLE OF CONTENTS

SECTION 1 SPECIFICATIONS

SECTION 2 INSIDE VIEWS

SECTION 3 DISASSEMBLY INSTRUCTIONS

SECTION 4 CIRCUIT DESCRIPTION4-1 RECEIVER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-1

4-2 TRANSMITTER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-2

4-3 PLL CIRCUIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-3

4-4 POWER SUPPLY CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-4

4-5 PORT ALLOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-4

SECTION 5 ADJUSTMENT PROCEDURES 5-1 PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-1

5-2 PLL ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-4

5-3 SOFTWARE ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-5

SECTION 6 PARTS LIST

SECTION 7 MECHANICAL PARTS AND DISASSEMBLY

SECTION 8 SEMI-CONDUCTOR INFORMATION

SECTION 9 BOARD LAYOUTS9-1 MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9-1

9-2 SW-A AND SW-B UNITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9-3

SECTION 10 BC-146 OPTIONAL DESKTOP CHARGER INFORMATION10-1 PARTS LIST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10-1

10-2 DISASSEMBLY INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10-1

10-3 VOLTAGE DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10-2

10-4 BOARD LAYOUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10-2

SECTION 11 BLOCK DIAGRAM

SECTION 12 VOLTAGE DIAGRAM12-1 MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12-1

12-2 SW-A AND SW-B UNITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12-2

SECTION 1 SPECIFICATIONS

1 - 1

All stated specifications are subject to change without notice or obligation.

Frequency coverage

Type of emission

Number of channels

Power supply requirement

Antenna impedance

Input impedance (Mic)

Output impedance (Audio)

Intermediate frequency

Operating temperature range

High power

Low power

stand-by

Rated audio

Dimensions(Projections not included)

Weight

RF output power (at 7.2 V DC)

Modulation system

Max. permissible deviation

External mic.connector

Frequency error

Spurious emissions

Adjacent channel power

Audio harmonics distortion

FM Hum and noise

Residual modulation

Limiting charact of modulator

Receive system

Intermediate frequencies

Sensitivity

Audio output power (at 7.2 V)

Adjacent channel selectivity

Spurious response

Intermodulation

FM Hum and noise (Typical)

Squelch sensitivity

EIA-152-C/204D or TIA-603 ETS 300 086

RE

CE

IVE

RT

RA

NS

MIT

TE

RG

EN

ER

AL

151.505 MHz–158.4075 MHz [F11BR] only 146.000 MHz–174.000 MHz146.000 MHz–174.000 MHz

16K0F3E (at 25 kHz / 30 kHz), 8K50F3E (at 12.5 kHz)

2 channel (IC-F11BR / F11S / F12S), 16 channel (IC-F11 / F12)

7.2 V (negative ground)

50 Ω normal

2.2 kΩ normal

8 Ω normal

1st: 31.050 MHz, 2nd: 450 kHz

–30 ˚C to +60 ˚C (–22˚F to +140˚F) –25 ˚C to +55 ˚C (–13˚F to +131˚F)

1.6 A (5 W) except [F11BR], 1.1 A (2 W) [F11BR] only

0.7 A (1 W)

70 mA

250 mA

54(W) × 128(H) × 37(D) mm; 21⁄8(W) × 51⁄25(H) × 115⁄32(D) inch

310 g; 10.1 oz (with BP-209), 300 g; 10.6 oz (with BP-222)

High: 5.0 W ([F11BR]: 2.0 W), Low1: 2.0 W (except [F11BR]), low2: 1.0 W

Variable reactance frequency modulation

± 5.0 kHz (25 kHz), ± 2.5 kHz (12.5 kHz)

3-conductor 2.5 mm (1⁄10 in) (2 kΩ)

±5.0 ppm ±2.0 kHz (25 kHz), ± 1.5 kHz (12.5 kHz)

73 dBc (typical) 0.25 µW @ < 1 GHz, 1.00 µW > 1 GHz

70 dB*1 (25 kHz), 60 dB*1 (12.5 kHz)

3 % typical at 1 kHz, 40 % deviation 5 % typical at 1 kHz 60 % deviation

46 dB typ. (25 kHz), 40 dB typ. (12.5 kHz) –

– 45 dB typ. (25 kHz), 43 dB typ. (12.5 kHz)

70 % – 100 % of max. deviation

Double-conversion super heterodyne

1st: 31.050 MHz, 2nd 450 kHz

0.25 µV (typical) for 12 dB SINAD 0.25 µV (typical) for 12 dB SINAD0.63 µV EMF (typical) for 20 dB SINAD

0.5 W at 5 % distortion with an 8 Ω load, 0.6 W at 5 % distortion with 6 Ω load

70 dB typ. (25 kHz), 65 dB typ. (12.5 kHz) 70 dB typ (25 kHz), 60 dB typ. (12.5 kHz)

70 dB*1

70 dB 65 dB

46 dB*2 (25 kHz), 40 dB*2 (12.5 kHz) 45 dB*3 (25 kHz), 43 dB*3 (12.5 kHz)

0.3 µV typical at threshold

Cur

rent

dra

in(a

t 7.

2 V

) Tx

Rx

*1EIA-152-C/204D or TIA-603 is typical value, *2EIA-152-C/204D only, *3With CCITT filter

2 - 1

SECTION 2 INSIDE VIEWS

• MAIN UNIT

Power amplifier(Q1: 2SK2974)

Antenna switching circuit D1: 1SV307 D9: ISV307 D10: MA77

TOP VIEW BOTTOM VIEW

RF amplifier(Q15: 3SK294)

VCO circuit

FM IF IC(IC3: TA31136FN)

Low-pass filter circuit(IC12,16: NJM12904V)

Expander IC(IC15: BU4094BCFV)

TX/RX switch(D3, D4: MA77)

Analog switch(IC6: BU4066BCFV)

APC(IC2: TA75S01F)

AF amplifier(IC4: TA7368F)

1st mixer(Q16: 3SK272)

CPU(IC7: HD6433664A24FP)

EEPROM(IC11: BR24C16FV-E2)

D/A converter(IC9: M62363FP-650C)

PLL reference oscillator(X1: CR-664A)

Crystal filter(FI1: FL-311)

PLL IC(IC1: MB15A02PFV-1)

YGR amplifier(Q4: 2SC5110 O)

Pre-drive(Q2 : 2SK2973)

( )

3 - 1

SECTION 3 DISASSEMBLY INSTRUCTIONS

• REMOVING THE CHASSIS¡ Unscrew 1 nut, A, and remove 2 knobs, B, C.™ Unscrew 2 screws, D.£ Unscrew 2 screws, H, to separate the Jack panel and the

Front panel.¢ Take off the chassis in the direction of the arrow.∞ Unplug J6 to separate the front panel and the chassis.

• REMOVING THE MAIN UNIT¡ Remove the searing rubber.™ Unsolder 2 points, E, and unscrew 2 nuts, F.£ Unscrew 9 screws, G, (silver, 2mm) to separate the chassis and the MAIN unit.¢ Take off the MAIN unit in the direction of the arrow.

Front panel

J6 (Speaker connector)

Jack panel

Chassis

CB

(Black, 2mm) x 2 D

A

(Black, 2mm) x 2 H

Guide holesMAIN unit

Sealing rubber

Chassis

E

F

Side plate

([F11BR], [F11S], [F12S] only) G

G

G

G

SECTION 4 CIRCUIT DESCRIPTION

4 - 1

4-1 RECEIVER CIRCUITS4-1-1 ANTENNA SWITCHING CIRCUITThe antenna switching circuit functions as a low-pass filterwhile receiving. However, its impedance becomes very highwhile D9 and D10 are turned ON. Thus transmit signals areblocked from entering the receiver circuits. The antennaswitching circuit employs a λ⁄4 type diode switching system.

Received signals are passed through the low-pass filter (L1,L2, C1–C5). The filtered signals are applied to the λ⁄4 typeantenna switching circuit (D9, D10).The passed signals are then applied to the RF amplifier cir-cuit.

4-1-2 RF CIRCUITThe RF circuit amplifies signals within the range of frequen-cy coverage and filters out-of-band signals.

The signals from the antenna switching circuit are amplifiedat the RF amplifier (Q15) after passing through the 2 stagestunable bandpass filter (D12, L21, C104, C105, D13, L54,C106, C111, C113). The amplified signals are applied to the1st mixer circuit (Q16) after out-of-band signals are sup-pressed at the 2 stages tunable bandpass filter (D14, C116,C117, D15, L24, C120, C122).

Varactor diodes are employed at the bandpass filters thattrack the filters and are controlled by the CPU (IC7) via theD/A convertor (IC9) using T1–T4 signals. These diodes tunethe centre frequency of an RF passband for wide bandwidthreceiving and good image response rejection.

4-1-3 1ST MIXER AND 1ST IF CIRCUITSThe 1st mixer circuit converts the received signal into a fixedfrequency of the 1st IF signal with a PLL output frequency.By changing the PLL frequency, only the desired frequencywill pass through a crystal filter at the next stage of the 1stmixer.

The signals from the RF circuit are mixed at the 1st mixer(Q16) with a 1st LO signal (114.95–142.95 MHz) comingfrom the VCO circuit to produce a 31.05 MHz 1st IF signal.

The 1st IF signal is applied to a crystal filter (FI1) to sup-press out-of-band signals. The filtered 1st IF signal isapplied to the IF amplifier (Q17), then applied to the 2ndmixer circuit (IC3, pin 16).

4-1-4 2ND IF AND DEMODULATOR CIRCUITSThe 2nd mixer circuit converts the 1st IF signal into a 2nd IFsignal. A double conversion superheterodyne system (whichconverts receive signals twice) improves the image rejectionratio and obtains stable receiver gain.

The 1st IF signal from the IF amplifier is applied to the 2ndmixer section of the FM IF IC (IC3, pin 16), and is mixed withthe 2nd LO signal to be converted into a 450 kHz 2nd IF sig-nal.

The FM IF IC contains the 2nd mixer, limiter amplifier, quad-rature detector and active filter circuits. A 2nd LO signal(30.6 MHz) is produced at the PLL circuit by tripling it’s ref-erence frequency.

The 2nd IF signal from the 2nd mixer (IC3, pin 3) passesthrough a ceramic filter (FI2) to remove unwanted hetero-dyned frequencies. It is then amplified at the limiter amplifi-er (IC3, pin 5) and applied to the quadrature detector (IC3,pins 10, 11) to demodulate the 2nd IF signal into AF signals.

4-1-5 AF CIRCUITAF signals from the FM IF IC (IC3, pin 9) are applied to theanalog switch (IC6, pin 1) after being passed through thehigh-pass filter (IC5B, pins 5, 7) via the “DET” signal. Thesignals pass through the low-pass filter (IC5D, pins 13, 14),and then applied to the analog switch (IC6, pins 9, 10) again.The output signals from the analog swtich (IC6, pin 11) areapplied to the AF power amplifier (IC4, pin 4) after beingpassed through the [VOL] control (SW-A/SW-B unit; R143)via the “VOLIN” and “VOLOUT” signals.

2ND IF AND DEMODULATOR CIRCUITS

Mixer

16

Limiteramp.

2nd IF filter450 kHz

PLL ICIC1

X115.3 MHz

IC3 TA31136F12

1st IF from the IF amplifier (Q17)

"RSSI" signal to the CPU pin 59

11109

8 7 5 3

AF signal "DET"

R5V

X2

R98C155 C154

R100R99

R93

"SQLIN" signal to the D/A convertor (IC9, pin 23)

R92

C138 C139

C140

2

2 1

Activefilter

FI2

Noisedetector

FMdetector

13

"NOIS" signal to the CPU pin 53

RSSI

Noisecomp.

×2

R94

Q18

4 - 2

The applied AF signals are amplified at the AF power ampli-fier circuit (IC4, pin 4) to obtain the specified audio level. Theamplified AF signals output from pin 10 as “AFOUT”signalare applied to the internal speaker (SP1) as the “SP” signalvia the [SP] jack when no plug is connected to the jack.

4-1-6 SQUELCH CIRCUITA squelch circuit cuts out AF signals when no RF signals arereceived. By detecting noise components in the AF signals,the squelch switches the AF mute switch.

A portion of the AF signals from the FM IF IC (IC3, pin 9) as“DET” signal are applied to the D/A convertor IC (IC9, pin24). The signals from the D/A convertor (IC9, pin 23) as“SQLIN” signals are applied to the active filter section (IC3,pin 8) where noise components are amplified and detectedwith an internal noise detector.

The active filter section amplifies noise components. The fil-tered signals are rectified at the noise detector section andconverted into “NOIS” (pulse type) signals at the noise com-parator section. The “NOIS” signal output from IC3, pin 13,and is applied to the CPU (IC7, pin 53).

The CPU detects the receiving signal strength from thenumber of the pulses, and outputs “EXST”, “SO”, “SCK” sig-nals. The signals are applied to the expander IC (IC15, pins1, 2, 3), and then outputs “RMUT” signal from pin 4. Thissignal controls the analog switch (IC6, pin 13) to cut the AFsignal line.

4-2 TRANSMITTER CIRCUITS4-2-1 MICROPHONE AMPLIFIER CIRCUITThe microphone amplifier circuit amplifies audio signals with+6 dB/octave pre-emphasis characteristics from the micro-phone to a level needed for the modulation circuit.

The AF signals from the microphone are applied to themicrophone amplifier circuit (IC5c, pin 10) after being passthrough the high-pass filter (C186, C187). The amplified AFsignals are passed through the low-pass filter circuit (IC5d,pins 13, 14) via the mute switch (IC6, pins 2, 3, 4). The fil-tered AF signals are applied to the modulator circuit afterbeing passed through the mute switch (IC6, pins 8, 9, 10).

4-2-2 MODULATION CIRCUITThe modulation circuit modulates the VCO oscillating signal(RF signal) using the microphone audio signal.

The audio signals change the reactance of a diode (D6) tomodulate an oscillated signal at the VCO circuit (Q10, Q11).The oscillated signal is amplified at the buffer-amplifiers (Q5,Q7), then applied to the T/R switching circuit (D3, D4).

4-2-3 DRIVE/POWER AMPLIFIER CIRCUITSThe signal from the VCO circuit passes through the T/Rswitching circuit (D3) and is amplified at the YGR (Q4), pre-drive (Q2) and power amplifier (Q1) to obtain 5 W ([F11BR]is 2 W) of RF power (at 7.2 V DC). The amplified signalpasses through the antenna switching circuit (D1) via thepower detector (D2), and low-pass filter and is then appliedto the antenna connector.

The bias current of the YGR amplifier (Q4), pre-drive (Q2)and the power amplifier (Q1) is controlled by the APC circuit.

4-2-5 APC CIRCUITThe APC circuit (IC2) protects the drive and the poweramplifiers from excessive current drive, and selects HIGH orLOW output power.

The signal output from the power detector circuit (D2) isapplied to the differential amplifier (IC2, pin 3), and the “T4”signal from the expander (IC9, pin 11), controlled by theCPU (IC7), is applied to the other input for reference.

When the driving current is increased, input voltage of thedifferential amplifier (pin 3) will be increased. In such cases,the differential amplifier output voltage (pin 4) is decreasedto reduce the driving current.

APC CIRCUIT

Q1Poweramp.

Q2Pre-driveramp.

IC2

+

—

Q4YGRamp.

VCC

T5V

RF signalfrom PLL

to antenna

T4

TXCQ14

S5VAPC control circuit

Power detectorcircuit (D2)

D2

LPF

D1, D9, D10ANTSW

AFamp.

LPF

HPF

"DET" signalfrom IC3, pin 9

"NWC" signalfrom IC15, pin 14

Q21

Analogswitch

IC6

IC5B

IC5D

AF VOL.R1

SW-A/SW-Bunit

IC4SP

111

9, 102, 3

AF CIRCUIT

4 - 3

4-3 PLL CIRCUIT4-3-1 GENERALA PLL circuit provides stable oscillation of the transmit fre-quency and receive 1st LO frequency. The PLL output com-pares the phase of the divided VCO frequency to the refer-ence frequency. The PLL output frequency is controlled by acrystal oscillator and the divided ratio (N-data) of a pro-grammable divider.

The PLL circuit, using a one chip PLL IC (IC1), directly gen-erates the transmit frequency and divided ratio based onserial data from the CPU and compares the phases of VCOsignals with the reference oscillator frequency. The PLL ICdetects the out-of-step phase and output from pin 5. The ref-erence frequency (15.3 MHz) is oscillated by X1.

4-3-2 TX LOOPThe generated signal at the VCO (Q10, Q11, D5, D7) entersthe PLL IC (IC1, pin 8) and is divided at the programmabledivider section and is then applied to the phase detectorsection.

The phase detector compares the input signal with a refer-ence frequency, and then outputs the out-of-phase signal(pulse-type signal) from pin 5.

The pulse-type signal is converted into DC voltage (lockvoltage) at the loop filter (R40–R42, C75, C76), and thenapplied to varactor diodes (D5, D7) of the VCO to stabilizethe oscillated frequency.

4-3-3 RX LOOPThe generated signal at the VCO (Q10, Q11, D5, D7) entersthe PLL IC (IC1, pin 8) and is divided at the programmabledivider section and is then applied to the phase detectorsection.

The phase detector compares the input signal with a refer-ence frequency, and then outputs the out-of-phase signal(pulse-type signal) from pin 5.

The pulse-type signal is converted into DC voltage (lockvoltage) at the loop filter (R40–R42, C75, C76), and thenapplied to varactor diode (D5) of the VCO to stabilize theoscillated frequency. The lock voltage is also used for thereceiver circuit for the bandpass filter center frequency. Thelock voltage from the loop filter is amplified at the bufferamplifier (Q13) and then applied to the CPU (IC7, pin 60).The signal is analyzed at the CPU, and then applied to theD/A convertor (IC9). The D/A convertor outputs “T1”, “T2”,“T3”, “T4” signals to RF bandpass filters D12–D15 to sup-press harmonic components.

4-3-4 VCO CIRCUITThe VCO outputs from Q11 and Q10 are buffer amplified atQ7 and Q5, and are then sent to the T/R switch (D3, D4).The receive LO signal is applied to the 1st mixer circuit(Q16) through an attenuator, and the tramsmit signal isapplied to the YGR amplifier (Q4). A portion of the VCO out-put is reapplied to the PLL IC (IC1, pin 8) via the bufferamplifier (Q6) and low-pass filter (L18, R53, C89–C91).

Shift register

PrescalerPhasedetector

Loopfilter

Programmablecounter

Programmabledivider

X115.3 MHz

30.6 MHz signalto the FM IF IC

Buffer

Buffer

Buffer

Q5

Q6

Q7

91011

SCK

IC1 (PLL IC)

SOPLST

to transmitter circuit

to 1st mixer circuit

D3

D4

2

1

5 8

Q10, Q11, D5, D7

VCO

Crystaloscillator

×2

Q18

LPF

PLL CIRCUIT

MOD

D6"DEV" signal from theD/A convertor (IC9, pin 22)

4 - 4

4-4 POWER SUPPLY CIRCUITSVOLTAGE LINE

LINE

HV

VCC

CPU5V

T5V

R5V

S5V

+5V

VCO5V

DESCRIPTION

The voltage from the attached battery pack.

The same voltage as the HV line (battery volt-age) which is controlled by the power swtich([VOL] control).

Common 5 V converted from the VCC line by the+5 regulator circuit (IC10). The output voltage isapplied to the CPU (IC7), reset circuit (IC8) andetc.

5 V for transmitter circuits regulated by the T5regulator circuit (Q27).

5 V for receiver circuits regulated by the R5 reg-ulator circuit (Q26).

Common 5 V converted from the VCC line by theS5 regulator circuit (Q24, Q19).

The same voltage as the CPU5V line for the ana-log swtich (IC6), buffer amplifier (Q13), etc.

The same voltage as the +5V line for the VCO(Q10, Q11) and buffer amplifiers (Q5–Q7).

4-5 PORT ALLOCATIONS4-5-1 CPU (IC7)

Pinnumber

7

13141920

232425

28

29

30

36

37

38

39

40

41

42

43

44

45

46

5152

53

54

55

57

58

59

60

Portname

RES

SENC0SENC1SENC2SENC3

CENC0CENC1CENC2

SCK

SO

BEEP

PLST

DAST

EXST

PTT

TXC

RLED

TLED

AFON

ESDA

CLI

CLO

F1F2

NOIS

UNLK

TEMP

CDEC

SDEC

RSSI

LVIN

Description

Input port for RESET signal.

Outputs single tone encode signal.

Outputs CTCSS/DTCS data signal.

Outputs serial clock signal to the PLLIC (IC1), EEPROM (IC11), etc.

Outputs data signal to the PLL IC(IC1) and D/A convertor (IC9).

Outputs beep audio signal.

I/O port for strobe signal from/to PLLIC (IC9).

• Outputs strobe signal to the D/A con-vertor (IC9).

• Input port for the initial version sig-nal.

Outputs strobe signal for the expanderIC (IC15).

Input port for [PTT] swtich signal.High: While [PTT] switch is pushed.

Outputs TX mute control signal.High: While transmitting

Outputs BUSY LED control signal.High: While receiving.

Outputs TX LED control signal.high: While transmitting.

Outputs control signal for the regulatorcircuit of AF power amplifier.High: While squelch is open, etc.

I/O port for data signal from/to theEEPROM (IC11).

Input port for cloning signal.

Outputs the cloning signal.

Input ports for the customization keysignals.

Input port for the noise pulse signal forthe squelch function.

Input port for PLL unlock signal.High: PLL is locked.

Input port for the transceiver’s internaltempereture detection.

Input port for CTCSS/DTCS signals.

Input port for single tone decode sig-nal.

Input port for the RSSI voltage.

Input port for the PLL lock voltage.

4 - 5

Pinnumber

61

62

Portname

BDET

BATV

Description

Input port for the battery’s type detec-tion.

Input port for battely voltage detection.

4-5-3 D/A CONVERTOR IC (IC9)

Pinnumber

2, 3,10, 11

14

15

22

Portname

T1–T4

REF

BAL

DEV

Description

Output tunable bandpass filters con-trol signals.

Outputs differential voltage for the ref-erence oscillator (Q31, D19, X1).

Outputs DTCS balance control signal.

Outputs modulating signal for themodulator circuit (D6).

CPU (IC7)–continued

4-5-2 OUTPUT EXPANDER IC (IC15)

Pinnumber

4

5

6

7

11

12

13

14

Portname

CSFT

RMUT

MMUT

DUSE

T5C

R5C

S5C

NWC

Description

Outputs clock shift control signal forCPU.

Outputs RX mute control signal.

Outputs TX mute control signal.

Outputs low-pass filter cut-off frequen-cy control signal when DTCS is acti-vated.

Outputs T5 regulator control signal.Low: While transmitting.

Outputs R5 regulator control signal.Low: While receiving.

Outputs S5 regulator control signal.Low: While power is ON.

Outputs Narrow/Wide of channelspacing control signal.Low: While Narrow is selected.

5 - 1

5-1 PREPARATIONWhen you adjust the contents on page 5-5 or 5-6, SOFTWARE ADJUSTMENT, the optional CS-F11 ADJ ADJUSTMENT SOFTWARE(Rev. 1.0 or later), OPC-478 CLONING CABLE and a JIG CABLE (see illustration at page 5-2) are required.

REQUIRED TEST EQUIPMENT

SECTION 5 ADJUSTMENT PROCEDURES

EQUIPMENT

DC power supply

RF power meter(terminated type)

Frequency counter

FM deviation meter

Digital multimeter

GRADE AND RANGE

Output voltage : 7.2 V DCCurrent capacity : 5 A or more

Measuring range : 1–10 WFrequency range : 300–600 MHzImpedance : 50 ΩSWR : Less than 1.2 : 1

Frequency range : 0.1–600 MHzFrequency accuracy : ±1 ppm or betterSensitivity : 100 mV or better

Frequency range : DC–600 MHzMeasuring range : 0 to ±5 kHz

Input impedance : 10 MΩ/V DC or better

EQUIPMENT

Audio generator

Attenuator

Standard signal generator (SSG)

DC voltmeter

Oscilloscope

AC millivoltmeter

GRADE AND RANGE

Frequency range : 300–3000 HzOutput level : 1–500 mV

Power attenuation : 40 or 50 dBCapacity : 10 W or more

Frequency range : 120–600 MHzOutput level : 0.1 µV–32 mV

(–127 to –17 dBm)

Input impedance : 50 kΩ/V DC or better

Frequency range : DC–20 MHzMeasuring range : 0.01–20 V

Measuring range : 10 mV–10 V

SYSTEM REQUIREMENTS• IBM PC compatible computer with an RS -232C serial port

(38400 bps or faster)• Microsoft Windows 95 or Windows 98• Intel i486DX processor or faster (Pentium 100 MHz or

faster recommended)• At least 16 MB RAM and 10 MB of hard disk space• 640×480 pixel display (800×600 pixel display recommend-

ed)

ADJUSTMENT SOFTWARE INSTALLATIONq Boot up Windows.

- Quit all applications when Windows is running.w Insert the cloning software CD-ROM into the appropriate

CD-ROM drive.e Select ‘Run’ from the [Start] menu.r Type the setup program name using the full path name,

then push the [Enter] key. (For example; D:\ setup)t Follow the prompts.y Program group ‘CS-F11’ appears in the ‘Programs’ folder

of the [Start] menu.

STARTING SOFTWARE ADJUSTMENTq Connect transceiver and PC with the optional OPC-478

and the JIG cable.w Boot up Windows, and turn the transceiver power ON.e Click the program group ‘CS-F11 ADJ’ in the ‘Programs’

folder of the [Start] menu, then CS-F11 ADJ’s window isappeared.

r Click ‘Connect’ on the CS-F11’s window, then appearstransceiver’s up-to-date condition.

t Set or modify adjustment data as desired.

IBM is a registered trademark of International BussinessMachines Corporation in the U.S.A. and other countries.Microsoft and Windows are registered trademarks ofMicrosoft Corporation in the U.S.A. and other countries.Screen shots produced with permission from MicrosoftCorporation. All other products or brands are registeredtrademarks or trademarks of their respective holders.

5 - 2

JIG CABLE

+( CLONE)

( GND)

+( SP)

( SPE)

3-conductor 3.5(d) mm plug

OPC-478JIG cableto IC-F4GT/GS [SP] jack

CS-F11 ADJ Rev.1.0File

COM 1: OPEN

Option

Connect Reload (F5) Disp para

[A / D]VIN : 197 : C5h : 7.73 VTEMPS : 190 : BEh : 32.23 ’CLVIN : 98 : 62h : 1.92 VSD : 0 : 00h : 0.00 VREMOT : 14 : 0Eh : 0.27 VBDET : 255 : FFh : 5.00 V

Power (Hi) : 98 [ # # # # # # # # ] Power (L2) : 54 [ # # # # ]Power (L1) : 255 [ # # # # # # # # # # # # # # # # # # # ]DTCS BAL : 132 [ # # # # # # # # # # ]

MOD W : 92 [ # # # # # # # ]MOD N : 50 [ # # # # ]

SQL : 85 [ # # # # # # # ]BPF ALL : [Enter] to sweepBPF T1 : 23 [ # # # # # # # # # # # # ] [Enter] to sweepBPF T2 : 22 [ # # # # # # # # ] [Enter] to sweepBPF T3 : 9 [ # # # # # # # # # # # ] [Enter] to sweepBPF T4 : 7 [ # # # # # # # # # ] [Enter] to sweep

TXF : [Enter] to start

[D / A]BPF T1 : 90 : 5Ah : 1.76 VBPF T2 : 45 : 2Dh : 0.88 VBPF T3 : 76 : 4Ch : 1.49 VT4/POW : 60 : 3Ch : 1.18 VREF : 112 : 70h : 2.20 VDTCS BL. : 141 : 8Dh : 55.29 Dev : 45 : 2Dh : 0.88 VSQL Lev : 150 : 96h : 58.96

CH No. : 01 (RX Freq = 216.050, TX Freq = < ) RF Power: High

: Transceiver’s connection state: Reload adjustment data: Receive sensitivity measurement: Connected DC voltage: PLL lock voltage: Operating channel select: RF output power

NOTE:

SCREEN DISPLAY EXAMPLE

1

5

11

1234567

891011121314

: DTCS wave balance: FM deviation: Squelch level: Receive sensitivity (automatically): Receive sensitivity (manually): Reference frequency: Adjustment items

The above values for settings are example only. Each transceiver has its own specific values for each setting.

4

2

8

3

6

7

9

12

10

13 14

5 - 3

to an RS-232C port

Personalcomputer

to [MIC]

to [SP]

JIG cable

DB9 female plug(incl. level converter circuit)

CONNECTION

to the antenna connector

RF power meter0.1 10 W/50

Frequencycounter

Attenuator40 dB or 50 dB

FMdeviation meter

Standard signal generator0.1 V to 32 mV

( 127 dBm to 17 dBm)

SINAD meter

Speaker (8 )

Audio generator

OPC-478

CAUTION:DO NOT transmit while an SSG is connected to the antenna connector.

DC POWERSUPPLY

GND

+

Battery type detectorBattery type detector

DC POWER CABLE CONNECTIONS

NOTE: When you adjust the output power (highpower), the battery type detector must be con-nected to GND (see illustration at above).Ohterwise the transceiver does not transmit highpower, the output power will be low.

5 - 4

L16PLL lock voltage adjustment

TOP VIEW

RF power meter

LVPLL lock voltage check point

5-2 PLL ADJUSTMENT

PLL LOCKVOLTAGE

1

2

3

• Operating frequency: 174.000 MHz

• Transmitting

• Operating frequency: 146.000 MHz

• Receiving

• Transmitting

MAIN Connect a digital multimeter to check pointLV.

4.0 V

0.8–1.8 V

0.8–1.8 V

MAIN L16

Verify

ADJUSTMENT ADJUSTMENT CONDITIONSUNIT LOCATION

VALUEUNIT ADJUST

MEASUREMENT ADJUSTMENT

5 - 5

1

1

2

3

1

2

1

• Operating frequency: 174.000 MHz*1

158.4075 MHz*2

• High/Low switch : Low• Connect the RF power meter or 50 Ω

dummy load to the antenna connector.• Transmitting


151.505 MHz*2

• High/Low switch : High• Transmitting

• High/Low switch : Low2• Transmitting

• High/Low switch : Low1• Transmitting

• Operating frequency:146.000 MHz*1

151.505 MHz*2

• High/Low switch : Low1• Channel spacing : Wide• Connect the audio generator to the

[MIC] jack and set as: 1.0 kHz/150 mVrms

• Set the FM deviation meter as:HPF : OFFLPF : 20 kHzDe-emphasis : OFFDetector : (P–P)/2

• Transmitting

• Channel spacing : Narrow• Transmitting


158.4075 MHz*2

• High/Low switch : Low1• No audio applied to the [MIC] jack.• DTCS code : 007• Transmitting

REFERENCEFREQUENCY[TXF]

OUTPUTPOWER[POWER(Hi)]

[POWER(L2)]

[POWER(L1)]

FMDEVIATION(Wide)[MOD W]

(Narrow)[MOD N]

DTCS WAVEFORM[DTCS BAL]

Toppanel

Toppanel

Toppanel

Toppanel

Loosely couple a frequnecycounter to the antenna connec-tor.

Connect an RF power meter tothe antenna connector.

Connect an FM deviation meterto the antenna connectorthrough the attenuator.

Connect an FM deviation meterwith an oscilloscope to theantenna connector through anattenuator.

174.0000 MHz*1

158.4075 MHz*2

5.0 W*1

2.0 W*2

2.0 W

1.0 W

Between ±4.05 kHzand ±4.15 kHz

Between ±2.05 kHzand ±2.15 kHz

ADJUSTMENT ADJUSTMENT CONDITIONMEASUREMENT

VALUEUNIT LOCATION

5-3 SOFTWARE ADJUSTMENTSelect an operation using [↑ ] / [↓ ] keys, then set specified value using [←] / [→] keys on the connected computer keyboard.

Set to flat wave form

*1IC-F11, F11S, F12 and F12S. *2IC-F11BR only.

5 - 6

Minimum distortionlevel

12 dB SINAD

At the point wherethe audio signals

just appears.

1 • Operating frequency:146.000 MHz*1

151.505 MHz*2

• Channel spacing :Narrow• Connect a standard signal generator to

the antenna connector and set as:Frequency : 146.000 MHz*1

151.505 MHz*2

Level : 10 µV* (–87 dBm)Modulation : OFFDeviation : ±1.75 kHz

• Receiving


156.956 MHz*2

• Channel spacing : Wide• Connect a standard signal generator to

the antenna connector and set as:Frequency : 160.000 MHz*1

156.956 MHz*2

Level : 0.2 µV* (–121 dBm)Modulation : 1 kHzDeviation : ±3.5 kHz

• Receiving

• Receiving

RXSENSITIVITY[BPF T1]–[BPF T4]

SQUELCHLEVEL[SQL]

Toppanel

Toppanel

Connect a SINAD meter with an8 Ω load to the [SP] jack.

Connect a SINAD meter with an8Ω load to the [SP] jack.

ADJUSTMENT ADJUSTMENT CONDITIONMEASUREMENT

VALUEUNIT LOCATION

*The output level of the standard signal generator (SSG) is indicated as the SSG’s open circuit.

SOFTWARE ADJUSTMENT – continuedSelect an operation using [↑ ] / [↓ ] keys, then set specified value using [←] / [→] keys on the connected computer keyboard.

CONVENIENT: The BPF T1–BPF T4 can be adjusted automatically.q-1: Set the cursol to “BPF ALL” on the adjustment program and then push [ENTER]

key.q-2: The connected PC tunes BPF T1–BPF T4 to peak levels.

orw-1: Set the cursol to one of BPF T1, T2, T3, or T4 as desired.w-2: Push [ENTER] key to start tuning.w-3: Repeat w-1 and w-2 to perform additional BPF tuning.

1

2

*1IC-F11, F11S, F12 and F12S. *2IC-F11BR only.

[MAIN UNIT][SW-A UNIT] ([F11] AND [F12] ONLY)

Q1 1590003020 S.TRANSISTOR XP4216-(TX)

R1 7210003060 VARIABLE TP76N00N-15F-10KA-2251R2 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω)R3 7030003410 S.RESISTOR ERJ3GEYJ 561 V (560 Ω)

F1 5210000710 S.FUSE KAB 2402 322 NA29

DS1 5040002070 S.LED LNJ107W5PRW

S1 2250000450 ENCODER TP70QF4161-16F-2458A

EP1 0910054463 PCB B 5603C

Q1 1590003020 S.TRANSISTOR XP4216-(TX)

R1 7210003060 VARIABLE TP76N00N-15F-10KA-2251R2 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω)R3 7030003410 S.RESISTOR ERJ3GEYJ 561 V (560 Ω)

F1 5210000710 S.FUSE KAB 2402 322 NA29

DS1 5040002070 S.LED LNJ107W5PRW

W1 7120000470 JUMPER ERDS2T0W2 7120000470 JUMPER ERDS2T0

EP1 0910054473 PCB B 5604C

IC1 1140005990 S.IC MB15A02PFV1-G-BND-ERIC2 1110002750 S.IC TA75S01F (TE85R) IC3 1110003490 S.IC TA31136FN (D,EL) IC4 1110001810 S.IC TA7368F (TP1) IC5 1110005320 S.IC NJM13403V-TE1IC6 1130008090 S.IC BU4066BCFV-E1IC7 1140009850 S.IC HD6433664A24FPIC8 1130009110 S.IC S-80942ANMP-DD6-T2IC9 1190000350 S.IC M62363FP-650CIC10 1110005350 S.IC NJM2870F05-TE1IC11 1130010490 S.IC BR24C16FV-E2IC12 1110005330 S.IC NJM12904V-TE1IC13 1130007020 S.IC TC7S66FU (TE85R) IC15 1130007570 S.IC BU4094BCFV-E2IC16 1110005330 S.IC NJM12904V-TE1

S.=Surface mount

Q1 1560001050 S.FET 2SK2974Q2 1560001020 S.FET 2SK2973 (MTS101P) Q4 1530003420 S.TRANSISTOR 2SC5110-O (TE85R) Q5 1530003310 S.TRANSISTOR 2SC5107-O (TE85R) Q6 1530003310 S.TRANSISTOR 2SC5107-O (TE85R) Q7 1530003310 S.TRANSISTOR 2SC5107-O (TE85R) Q8 1590000430 S.TRANSISTOR DTC144EUA T106Q10 1530003230 S.TRANSISTOR 2SC5085-Y (TE85R) Q11 1530003230 S.TRANSISTOR 2SC5085-Y (TE85R) Q12 1590001190 S.TRANSISTOR XP6501-(TX) .ABQ13 1560000540 S.FET 2SK880-Y (TE85R) Q14 1590000720 S.TRANSISTOR DTA144EUA T106Q15 1580000750 S.FET 3SK294 (TE85L) Q16 1580000660 S.FET 3SK272-(TX) Q17 1530002600 S.TRANSISTOR 2SC4215-O (TE85R) Q18 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R) Q19 1520000460 S.TRANSISTOR 2SB1132 T100 RQ20 1590001190 S.TRANSISTOR XP6501-(TX) .ABQ21 1590000430 S.TRANSISTOR DTC144EUA T106Q22 1590002530 S.TRANSISTOR UN911H (TX) Q23 1590000720 S.TRANSISTOR DTA144EUA T106Q24 1520000460 S.TRANSISTOR 2SB1132 T100 RQ25 1590001190 S.TRANSISTOR XP6501-(TX) .ABQ26 1510000920 S.TRANSISTOR 2SA1577 T107 QQ27 1510000920 S.TRANSISTOR 2SA1577 T107 QQ28 1590000430 S.TRANSISTOR DTC144EUA T106Q29 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R) Q30 1590001770 S.TRANSISTOR XP1213 (TX) Q31 1530002600 S.TRANSISTOR 2SC4215-O (TE85R) Q32 1590000660 S.TRANSISTOR DTC144TU T107Q33 1560000840 S.FET 2SK1829 (TE85R) A onlyQ35 1590000430 S.TRANSISTOR DTC144EUA T106Q36 1560000840 S.FET 2SK1829 (TE85R)

D1 1750000580 S.DIODE 1SV307 (TPH3) D2 1790001670 S.DIODE RB706F-40T106D3 1790000620 S.DIODE MA77 (TX) D4 1790000620 S.DIODE MA77 (TX) D5 1720000780 S.VARICAP HVU350B TRFD6 1790001260 S.DIODE MA2S077-(TX) D7 1720000780 S.VARICAP HVU350B TRFD9 1750000580 S.DIODE 1SV307 (TPH3) D10 1790000620 S.DIODE MA77 (TX) D12 1720000780 S.VARICAP HVU350B TRFD13 1720000780 S.VARICAP HVU350B TRFD14 1720000780 S.VARICAP HVU350B TRFD15 1720000780 S.VARICAP HVU350B TRFD16 1790000620 S.DIODE MA77 (TX) D17 1790001670 S.DIODE RB706F-40T106D18 1790001250 S.DIODE MA2S111-(TX) A onlyD19 1750000830 S.VARICAP HVC362TRFD20 1790001250 S.DIODE MA2S111-(TX) D21 1790001250 S.DIODE MA2S111-(TX) D22 1790000620 S.DIODE MA77 (TX) D23 1790001250 S.DIODE MA2S111-(TX) D24 1720000360 S.DIODE HSU88TRFD25 1790001250 S.DIODE MA2S111-(TX)

FI1 2030000130 S.XTAL FL-333 (31.05 MHz) FI2 2020001840 CERAMIC ALFYM450F=K

X1 6050011070 S.XTAL CR-664A (15.300 MHz) X2 6070000210 S.DISCRIMINATOR CDBCA450CX24 X3 6050011180 S.XTAL CR-702 (14.7456 MHz)

L1 6200008580 S.COIL 0.30-1.4-6TL 32NL2 6200009800 S.COIL 0.26-1.1-7TR 30NL3 6200002860 S.COIL NL 252018T-4R7JL4 6200008280 S.COIL 0.30-1.7-7TL 50NL5 6200008230 S.COIL 0.30-1.3-5TL 22NL6 6200003590 S.COIL EXCCL3225U1

6 - 1

SECTION 6 PARTS LIST

REF ORDER DESCRIPTIONNO. NO.REF ORDER DESCRIPTIONNO. NO.

A: [F12] and [F12S] B: [F11], [F11BR] and [F11S]C: [F11]and [F12] D: [F11BR], [F11S] and [F12S]

[SW-B UNIT] ([F11BR], [F11S] AND [F12S] ONLY)REF ORDER DESCRIPTIONNO. NO.

[MAIN UNIT]REF ORDER DESCRIPTIONNO. NO.

[MAIN UNIT][MAIN UNIT]

S.=Surface mount

L9 6200005710 S.COIL ELJRE 27NG-FL10 6200006980 S.COIL ELJRE R10G-FL11 6200006980 S.COIL ELJRE R10G-FL15 6200004920 S.COIL MLF1608A 2R2K-TL16 6200008190 S.COIL 0.25-1.9-8TL 80NL17 6200002860 S.COIL NL 252018T-4R7JL18 6200005720 S.COIL ELJRE 33NG-FL19 6200008280 S.COIL 0.30-1.7-7TL 50NL20 6200008280 S.COIL 0.30-1.7-7TL 50NL21 6200007750 S.COIL LQN21A 56NJ04L22 6200007750 S.COIL LQN21A 56NJ04L24 6200007750 S.COIL LQN21A 56NJ04L25 6200009180 S.COIL ELJRE R10J-F3L26 6200005540 S.COIL ELJNC R47K-FL27 6200001980 S.COIL NL 252018T-1R0JL28 6200001980 S.COIL NL 252018T-1R0JL29 6200009210 S.COIL NL 252018T-390JL50 6200009180 S.COIL ELJRE R10J-F3L51 6200007690 S.COIL LQN21A 18NJ04L52 6200008260 S.COIL 0.30-1.7-8TL 60NL53 6200008510 S.COIL 0.30-0.9-4TR 10.5NL54 6200007750 S.COIL LQN21A 56NJ04L56 6200002690 S.COIL MLF1608A 1R0M-T

R1 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) R2 7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω) R3 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) R4 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R5 7030003240 S.RESISTOR ERJ3GEYJ 220 V (22 Ω) R6 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R7 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R8 7030003300 S.RESISTOR ERJ3GEYJ 680 V (68 Ω) R9 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) R10 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R13 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) R16 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) R17 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R18 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R19 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) R20 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R21 7030004040 S.RESISTOR ERJ3GEYJ 4R7 V (4.7 Ω) R22 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω) R23 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R24 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) R26 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R27 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R28 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)R29 7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω)R31 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R32 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R34 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R35 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) R36 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R37 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R38 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ)R39 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R40 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)R41 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)R42 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 Ω) R43 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ) R44 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R45 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R46 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ) R47 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) R48 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) R49 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R50 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R51 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R52 7410000950 S.ARRAY EXB-V8V 102JVR53 7030003290 S.RESISTOR ERJ3GEYJ 560 V (56 Ω) R54 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R55 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) R56 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R57 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R58 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ) R59 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ) R60 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) R61 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R62 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R63 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)

R64 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ) A7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) B

R65 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ) A7030003730 S.RESISTOR ERJ3GEYJ 274 V (270 kΩ) B

R66 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R68 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R70 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R71 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R72 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R73 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R74 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R75 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R76 7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω)R77 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R78 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R79 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R80 7030003210 S.RESISTOR ERJ3GEYJ 120 V (12 Ω) R81 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R83 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) R85 7030003410 S.RESISTOR ERJ3GEYJ 561 V (560 Ω) R86 7030003330 S.RESISTOR ERJ3GEYJ 121 V (120 Ω) R88 7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω) R89 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R90 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ) R91 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω) R92 7030003470 S.RESISTOR ERJ3GEYJ 182 V (1.8 kΩ) R93 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω) R94 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) R95 7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω) R96 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ) R97 7030003780 S.RESISTOR ERJ3GEYJ 684 V (680 kΩ) R98 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R99 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ) R100 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R102 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) R103 7030003260 S.RESISTOR ERJ3GEYJ 330 V (33 Ω) R104 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R105 7030003490 S.RESISTOR ERJ3GEYJ 272 V (2.7 kΩ) R106 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ) R107 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R109 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R110 7030004910 S.RESISTOR ERJ3GEYF 332 V (3.3 kΩ) R111 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ) R112 7030004730 S.RESISTOR ERJ3GEYF 222 V (2.2 kΩ) R113 7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω)R114 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R115 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ) R116 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) R117 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R118 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R119 7030003730 S.RESISTOR ERJ3GEYJ 274 V (270 kΩ) R120 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) R121 7030010320 S.RESISTOR ERJ3GEYF 153 V (15 kΩ)R122 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R123 7030008090 S.RESISTOR ERJ3EKF 1503 V (150 kΩ) R124 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ) R125 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) R126 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ) R127 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R128 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R129 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R130 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) R131 7030003530 S.RESISTOR ERJ3GEYJ 562 V (5.6 kΩ) R132 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R133 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) R134 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R136 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R137 7030005270 S.RESISTOR ERJ3GEYJ 204 V (200 kΩ)R138 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R139 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R140 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) B onlyR141 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R142 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R143 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R146 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R147 7410000950 S.ARRAY EXB-V8V 102JVR148 7410000950 S.ARRAY EXB-V8V 102JVR149 7410000950 S.ARRAY EXB-V8V 102JVR151 7510001280 S.THERMISTOR NTCCM20124AG473J-TR152 7030003940 S.RESISTOR ERJ3GEYF 104 V (100 kΩ) R153 7030003940 S.RESISTOR ERJ3GEYF 104 V (100 kΩ)

6 - 2



S.=Surface mount


R154 7030003940 S.RESISTOR ERJ3GEYF 104 V (100 kΩ) R155 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) R156 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) R157 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) R158 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) R159 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) R160 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R161 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R163 7410000950 S.ARRAY EXB-V8V 102JVR164 7410000950 S.ARRAY EXB-V8V 102JVR165 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R166 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) R167 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) R168 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) R169 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R170 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) R171 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R172 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R173 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R174 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R175 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) R176 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R177 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R178 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ) R179 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ) R180 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R181 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R182 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R183 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R184 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R185 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) R187 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R188 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) R189 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R190 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R191 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R192 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ) R193 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R194 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R195 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ) R196 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R197 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R198 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R199 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R200 7410000770 S.ARRAY EXB-V4V 102JV (1 kΩ) R201 7410000950 S.ARRAY EXB-V8V 102JVR202 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R203 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ) R204 7030003750 S.RESISTOR ERJ3GEYJ 394 V (390 kΩ) R205 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ) R206 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) R207 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ) R208 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R209 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R210 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ) R211 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R212 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) R213 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R214 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R215 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R216 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R217 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R218 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R219 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R220 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) R221 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R222 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R223 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R224 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R225 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R226 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R227 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) A onlyR228 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) A onlyR229 7030003530 S.RESISTOR ERJ3GEYJ 562 V (5.6 kΩ) A onlyR230 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ) R232 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ) R233 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R234 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R238 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R239 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R240 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)

R241 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R242 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R243 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)R244 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) R245 7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω) B

7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) AR246 7030003240 S.RESISTOR ERJ3GEYJ 220 V (22 Ω) R247 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R248 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 Ω) R249 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ)R250 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ)R251 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ)R252 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)R253 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)

C1 4030007000 S.CERAMIC C1608 CH 1H 090D-T-AC2 4030006980 S.CERAMIC C1608 CH 1H 070D-T-AC3 4030009650 S.CERAMIC C1608 CH 1H 240J-T-AC4 4030011530 S.CERAMIC C1608 CH 1H 110J-T-AC5 4030007050 S.CERAMIC C1608 CH 1H 220J-T-AC6 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC7 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC8 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC9 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC10 4030007040 S.CERAMIC C1608 CH 1H 180J-T-AC11 4030007030 S.CERAMIC C1608 CH 1H 150J-T-AC12 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC13 4030007030 S.CERAMIC C1608 CH 1H 150J-T-AC14 4030007030 S.CERAMIC C1608 CH 1H 150J-T-AC15 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC17 4030007110 S.CERAMIC C1608 CH 1H 680J-T-AC18 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC20 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC21 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC23 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC24 4030017430 S.CERAMIC ECJ0EC1H101JC25 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC26 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC27 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC33 4030007130 S.CERAMIC C1608 CH 1H 101J-T-AC34 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC35 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC36 4030007040 S.CERAMIC C1608 CH 1H 180J-T-AC37 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC38 4030007000 S.CERAMIC C1608 CH 1H 090D-T-AC39 4030007020 S.CERAMIC C1608 CH 1H 120J-T-AC40 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC41 4030006980 S.CERAMIC C1608 CH 1H 070D-T-AC42 4030007050 S.CERAMIC C1608 CH 1H 220J-T-AC43 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC44 4030009520 S.CERAMIC C1608 CH 1H 020B-T-AC45 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC46 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC48 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC49 4030009500 S.CERAMIC C1608 CH 1H 0R5B-T-AC51 4030009520 S.CERAMIC C1608 CH 1H 020B-T-AC56 4550006450 S.TANTALUM ECST1EY105RC57 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC58 4510004630 S.ELECTROLYTIC ECEV1CA100SRC59 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC60 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC61 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC62 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC63 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC64 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC65 4030009520 S.CERAMIC C1608 CH 1H 020B-T-AC66 4030008750 S.CERAMIC C1608 CH 1H 360J-T-AC67 4030006870 S.CERAMIC C1608 JB 1H 222K-T-AC69 4030007120 S.CERAMIC C1608 CH 1H 820J-T-AC70 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC71 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC72 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC73 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC75 4550006450 S.TANTALUM ECST1EY105RC76 4550006600 S.TANTALUM ECST0JY335RC78 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC80 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC81 4030007130 S.CERAMIC C1608 CH 1H 101J-T-AC82 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC83 4030007130 S.CERAMIC C1608 CH 1H 101J-T-A

6 - 3




S.=Surface mount

C84 4030006900 S.CERAMIC C1608 JB 1E 103K-T-AC85 4510005860 S.ELECTROLYTIC ECEV1HA2R2SRC86 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC87 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC88 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC89 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC90 4030007100 S.CERAMIC C1608 CH 1H 560J-T-AC91 4030007100 S.CERAMIC C1608 CH 1H 560J-T-AC92 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-AC93 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC94 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC95 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC96 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC97 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC98 4030006900 S.CERAMIC C1608 JB 1E 103K-T-AC99 4030011530 S.CERAMIC C1608 CH 1H 110J-T-AC100 4030007040 S.CERAMIC C1608 CH 1H 180J-T-A A

4030007050 S.CERAMIC C1608 CH 1H 220J-T-A BC101 4030007010 S.CERAMIC C1608 CH 1H 100D-T-A A

4030009910 S.CERAMIC C1608 CH 1H 040B-T-A BC102 4030009910 S.CERAMIC C1608 CH 1H 040B-T-A A

4030011770 S.CERAMIC C1608 CH 1H 060B-T-A BC103 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC104 4030007060 S.CERAMIC C1608 CH 1H 270J-T-A B

4030007090 S.CERAMIC C1608 CH 1H 470J-T-A AC105 4030009530 S.CERAMIC C1608 CH 1H 030B-T-A A

4030009550 S.CERAMIC C1608 CH 1H 2R5B-T-A BC106 4030009510 S.CERAMIC C1608 CH 1H 010B-T-AC107 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC108 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC109 4030006900 S.CERAMIC C1608 JB 1E 103K-T-AC110 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC111 4030009530 S.CERAMIC C1608 CH 1H 030B-T-A A

4030009910 S.CERAMIC C1608 CH 1H 040B-T-A BC112 4030006900 S.CERAMIC C1608 JB 1E 103K-T-AC113 4030007100 S.CERAMIC C1608 CH 1H 560J-T-AC114 4030017460 S.CERAMIC ECJ0EB1E102KC115 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC116 4030009550 S.CERAMIC C1608 CH 1H 2R5B-T-AC117 4030007120 S.CERAMIC C1608 CH 1H 820J-T-AC118 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC119 4030009540 S.CERAMIC C1608 CH 1H 1R5B-T-AC120 4030007070 S.CERAMIC C1608 CH 1H 330J-T-A B

4030007110 S.CERAMIC C1608 CH 1H 680J-T-A AC121 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC122 4030009350 S.CERAMIC C1608 CH 1H 3R5B-T-A A

4030011770 S.CERAMIC C1608 CH 1H 060B-T-A BC123 4030007040 S.CERAMIC C1608 CH 1H 180J-T-AC124 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC125 4030007060 S.CERAMIC C1608 CH 1H 270J-T-AC126 4030007070 S.CERAMIC C1608 CH 1H 330J-T-AC127 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC128 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC129 4030007100 S.CERAMIC C1608 CH 1H 560J-T-AC130 4030006900 S.CERAMIC C1608 JB 1E 103K-T-AC132 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC133 4030009510 S.CERAMIC C1608 CH 1H 010B-T-AC134 4030007000 S.CERAMIC C1608 CH 1H 090D-T-AC136 4030006900 S.CERAMIC C1608 JB 1E 103K-T-AC137 4030007130 S.CERAMIC C1608 CH 1H 101J-T-AC138 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC139 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC140 4030007140 S.CERAMIC C1608 CH 1H 121J-T-AC142 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC143 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC144 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC145 4030008680 S.CERAMIC C2012 JF 1C 105Z-T-AC146 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC147 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC148 4030007010 S.CERAMIC C1608 CH 1H 100D-T-AC149 4030007040 S.CERAMIC C1608 CH 1H 180J-T-AC150 4030009520 S.CERAMIC C1608 CH 1H 020B-T-AC151 4030007040 S.CERAMIC C1608 CH 1H 180J-T-AC152 4030007010 S.CERAMIC C1608 CH 1H 100D-T-AC153 4030006900 S.CERAMIC C1608 JB 1E 103K-T-AC154 4030007170 S.CERAMIC C1608 CH 1H 221J-T-AC155 4030007170 S.CERAMIC C1608 CH 1H 221J-T-AC156 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC157 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A

C158 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC159 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC160 4510004640 S.ELECTROLYTIC ECEV1CA470SPC161 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC162 4030006850 S.CERAMIC C1608 JB 1H 471K-T-AC163 4510006940 S.ELECTROLYTIC EEVFC0J101PC164 4030008920 S.CERAMIC C1608 JB 1C 473K-T-AC165 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC166 4550006700 S.TANTALUM ECST1AY106RC167 4030008920 S.CERAMIC C1608 JB 1C 473K-T-AC168 4030009660 S.CERAMIC C1608 JF 1C 224Z-T-AC169 4550006650 S.TANTALUM ECST1CY685RC170 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-AC171 4030009660 S.CERAMIC C1608 JF 1C 224Z-T-AC172 4510006090 S.ELECTROLYTIC ECEV0GA470SRC173 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC174 4030007150 S.CERAMIC C1608 CH 1H 151J-T-AC175 4030008770 S.CERAMIC C1608 JB 1H 562K-T-AC176 4030009970 S.CERAMIC C1608 JB 1H 182K-T-AC177 4550006170 S.TANTALUM ECST1AY225RC178 4030006900 S.CERAMIC C1608 JB 1E 103K-T-AC179 4030008680 S.CERAMIC C2012 JF 1C 105Z-T-AC181 4030008920 S.CERAMIC C1608 JB 1C 473K-T-AC182 4030008920 S.CERAMIC C1608 JB 1C 473K-T-AC183 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC184 4030007160 S.CERAMIC C1608 CH 1H 181J-T-AC185 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC186 4030008770 S.CERAMIC C1608 JB 1H 562K-T-A B

4030006870 S.CERAMIC C1608 JB 1H 222K-T-A AC187 4030008880 S.CERAMIC C1608 JB 1C 223K-T-A B onlyC188 4510004630 S.ELECTROLYTIC ECEV1CA100SRC189 4030006850 S.CERAMIC C1608 JB 1H 471K-T-AC190 4030008920 S.CERAMIC C1608 JB 1C 473K-T-AC191 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-AC192 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-AC193 4030007050 S.CERAMIC C1608 CH 1H 220J-T-AC194 4030007030 S.CERAMIC C1608 CH 1H 150J-T-AC195 4030007110 S.CERAMIC C1608 CH 1H 680J-T-AC196 4030006850 S.CERAMIC C1608 JB 1H 471K-T-AC197 4510005430 S.ELECTROLYTIC ECEV0JA220SRC198 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-AC199 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC200 4030008890 S.CERAMIC C1608 JB 1C 273K-T-AC201 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC202 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC203 4030006900 S.CERAMIC C1608 JB 1E 103K-T-AC204 4030006900 S.CERAMIC C1608 JB 1E 103K-T-AC205 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-AC206 4550006200 S.TANTALUM ECST0JY106RC207 4510004630 S.ELECTROLYTIC ECEV1CA100SRC208 4030006900 S.CERAMIC C1608 JB 1E 103K-T-AC209 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-AC210 4510005430 S.ELECTROLYTIC ECEV0JA220SRC211 4030006900 S.CERAMIC C1608 JB 1E 103K-T-AC212 4030006900 S.CERAMIC C1608 JB 1E 103K-T-AC213 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC214 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC215 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC216 4030006900 S.CERAMIC C1608 JB 1E 103K-T-AC217 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC218 4030008910 S.CERAMIC C1608 JB 1C 393K-T-AC219 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC220 4030009490 S.CERAMIC C1608 JB 1H 821K-T-AC221 4030006900 S.CERAMIC C1608 JB 1E 103K-T-AC222 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC223 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC224 4030008900 S.CERAMIC C1608 JB 1C 333K-T-AC225 4510004650 S.ELECTROLYTIC ECEV1EA4R7SRC226 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC227 4030006900 S.CERAMIC C1608 JB 1E 103K-T-AC228 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC229 4030009880 S.CERAMIC C1608 JB 1H 682K-T-AC230 4030006900 S.CERAMIC C1608 JB 1E 103K-T-AC231 4030008910 S.CERAMIC C1608 JB 1C 393K-T-AC232 4030010020 S.CERAMIC C1608 JB 1H 122K-T-AC233 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC234 4030009490 S.CERAMIC C1608 JB 1H 821K-T-AC235 4030009490 S.CERAMIC C1608 JB 1H 821K-T-AC236 4030008880 S.CERAMIC C1608 JB 1C 223K-T-AC237 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC238 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A

6 - 4



S.=Surface mount

[MAIN UNIT]

C239 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC240 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC242 4030008470 S.CERAMIC C1608 JB 1H 272K-T-AC243 4030008770 S.CERAMIC C1608 JB 1H 562K-T-AC244 4030007160 S.CERAMIC C1608 CH 1H 181J-T-AC245 4030009630 S.CERAMIC C1608 JB 1H 822K-T-AC246 4030007110 S.CERAMIC C1608 CH 1H 680J-T-AC247 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC248 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC249 4030017480 S.CRAMIC C1608 JB 1A 474K-T-N A onlyC252 4030007130 S.CERAMIC C1608 CH 1H 101J-T-AC253 4030007000 S.CERAMIC C1608 CH 1H 090D-T-AC255 4030007050 S.CERAMIC C1608 CH 1H 220J-T-AC257 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC258 4030007090 S.CERAMIC C1608 CH 1H 470J-T-AC259 4030006900 S.CERAMIC C1608 JB 1E 103K-T-AC260 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC261 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC262 4030011600 S.CERAMIC C1608 JB 1C 104KT-NC265 4030006980 S.CERAMIC C1608 CH 1H 070D-T-AC266 4550000530 S.TANTALUM TESVA 1V 104M1-8LC267 4030011770 S.CERAMIC C1608 CH 1H 060B-T-AC268 4030009550 S.CERAMIC C1608 CH 1H 2R5B-T-AC269 4030006860 S.CERAMIC C1608 JB 1H 102K-T-AC270 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A

J1 6910013720 CONNECTOR IMSA-9230B-04Z120-T C onlyJ2 6910013730 CONNECTOR IMSA-9230B-07Z120-TJ3 6510021900 S.CONNECTOR BM02B-ASRS-TFJ4 6450001680 CONNECTOR HSJ1122-010010J5 6450001690 CONNECTOR HSJ1456-01-220

MC1 7700002540 MICROPHON SKP-4538

S1 2230001060 S.SWITCH EVQ-PUL 02KS2 2230001060 S.SWITCH EVQ-PUL 02KS3 2230001060 S.SWITCH EVQ-PUL 02K

W8 7030003860 S.JUMPER ERJ3GE JPW VW11 7030003860 S.JUMPER ERJ3GE JPW V D onlyW12 7030003860 S.JUMPER ERJ3GE JPW V D onlyW13 7030003860 S.JUMPER ERJ3GE JPW V D only

EP1 0910054482 PCB B 5680B EP4 6910013370 S.BEAD BLM11B221SBEP5 6910013370 S.BEAD BLM11B221SBEP6 6910013370 S.BEAD BLM11B221SBEP7 6910013370 S.BEAD BLM11B221SB A only

6 - 5

REF ORDER DESCRIPTIONNO. NO.


SECTION 7 MECHANICAL PARTS AND DISASSEMBLY

7 - 1

REF. NO. ODER NO. DESCRIPTION QTY.

SP1 2510001100 Speaker 036D0601 1

MP1 8210017710 2458 front panel 1MP4 8930054680 2458 release button 1MP6 8930054690 2458 lens 1MP7 8210017730 2458 jack panel 1MP8 8930054881 2458 plus terminal-1 1MP9 8010018501 2458 chassis-1 1MP10 8930054710 2458 A-main seal A 1

8930054720 2458 B-main seal B 1MP11 8930042350 1922 mic sheet 1MP12 8930050840 2251 minus terminal 1MP13 8830001550 Nut (J) 1MP14 8830001570 Nut (K) B 1

8830001550 Nut (J) A 1MP15 8950005320 2337 contact 1MP18 8610010910 Knob N-281 1MP19 8610010920 Knob N-282 A only 1MP20 8810004860 Screw PH M 2 x 6 ZK 2MP21 8810000100 Screw PH M 2 x 4 ZK 2MP22 8810009560 Screw B0 M 2 x 6 ZK 2MP26 8930053680 Spring (AG) 1MP27 8210017090 2337 terminal holder 1MP28 8930052840 2337 T-rubber 1MP29 8810009510 B0 M02 x 4 NI-ZU (BT) 10MP30 8930043760 1923 Mic seal 1MP32 8950004671 ANT connector 101A 1MP33 8830001250 ANT connector 101 nut 1MP34 8930055110 2458 side plate 1MP35 8810009510 Screw B0 M 2 x 4 NI-ZU (BT) B only 1MP39 8810009180 Screw B0 M 2 x 5 NI-ZU (BT) 1

[CHASSIS PARTS]REF. NO. ODER NO. DESCRIPTION QTY.

MP1 8510013000 2336 VCO case 1MP2 8510011101 1922 VCO cover-1 1MP6 8510013800 2458 main shield 1

[MAIN UNIT]

Screw abbreviations B0, BT: Self-tappingPH: Pan headNI: NickelZK: BlackNI-ZU: Nickel-zinc


EP1 Optional product Antenna FA-SC55U 1EP2 Optional product Battery BP-222 [F11BR] 1

Optional product Battery BP-209 [OTHER] 1EP4 Optional product BC-147A C only 1EP5 Optional product BC-146 ACC C only 1

MP1 Optional product 1922 Belt clip 1

[ACCESSORIES]

EP1

EP2

EP4

MP1

EP5

A: [F11], [F12] B: [F11BR], [F11S], [F12S]C: [F11BR], [F11S]*1

*1: For [USA] only.

7 - 2

UNIT abbreviation (C): CHASSIS PARTS, (M): MAIN UNIT

MAIN unit

MP28 (C)MP15 (C)

MP10 (C)

MP21 (C)

MP32 (C)

MP8 (C)

MP29 (C)

MP29 (C)

MP12 (C)

MP9 (C)

MP22 (C)

IC-F11BR, F11S, F12S

MP34 (C)

MP27 (C)

MP14 (C)MP13 (C)

MP39 (C)

MP29 (C)

MP35 (C)([F11BR, F11S, F12S] only)

MP29 (C)

MP7 (C)

MP20 (C)

MP11 (C)

MP30 (C)

MP29 (C)

MP29 (C)MP2 (M)

MP1 (M)

MP1 (C)

MP6 (M)

MP6 (C)

MP4 (C)

MP26 (C)

MP33 (C)

MP19 (C)([F11, F12] only)

MP18 (C)

SP1 (C)

SECTION 8 SEMI-CONDUCTOR INFORMATION

8 - 1

2SC5085 Y(Symbol: MCY)

2SK1829(Symbol: K1)

2SC5107 O(Symbol: MFO)

2SC5110 O(Symbol: MGO)

2SK880 Y(Symbol: XY)

2SK2974(Symbol: K2974)

2SC4116 GR(Symbol: LG)

2SA1577 Q(Symbol: HQ)

2SB1132 R(Symbol: BARB)

3SK272(Symbol: K)

2SC4215 O(Symbol: QO)

2SK2973(Symbol: K1)

DTC144 TU(Symbol: 06)

DTC144 EU(Symbol: 26)

UN911 H(Symbol: 6P)

XP1213(Symbol: 9L)

3SK294(Symbol: UV)

DTA144 EU(Symbol: 16)

• TRANSISTOR AND FET’S

B

E

C

B

E

C

B

E

C

G

S

D

S

D

G(top view)

S

B

E

C

B

E

C

B

E

C

B

E

C

B

E

C

B

C

E

E1

B1

B2

C1

C2

E

C

B

E

B

E

C

S

D

G

G1

G2

S

D

XP6501 AB(Symbol: 5N)

XP4216 TX(Symbol: 8U)

E1

E2

B2

C1

B1

C2

B

E

C

G1

G2

S

D

E1

C2

B1

C1

E2

B2

• DIODES

MA77(Symbol: 4B)

HVU350 B(Symbol: 4)

MA2S077(Symbol: S)

HSU88 TRF(Symbol: 9)

MA2S111(Symbol: A)

MA368(Symbol: 6L)

1SV307(Symbol: TX)

RB706F-40(Symbol: 3J)

A C

A C

HVC362(Symbol: V2)

AC

SECTION 9 BOARD LAYOUTS

9 - 1

9-1 MAIN UNIT• TOP VIEW

C196

R159

C194

R15

6C

193

X3

C24

2 R222

R223

C244

R22

4

C24

3 R21

5

C24

6R

155

R22

5R

226

C24

5

R122

C223

R143

R146

IC16

C19

1

R151

R16

3 R50

C25

8

R24

8

R51

D19

R23

0

C84

IC15

R164

C253 C25

2

X1

C86

R250

C87

C19

7

C210

C20

1

L29

C20

8

Q23

R24

6 C88

Q24

C20

9

R17

0 Q25

C206

R16

9 R15

3

C192

C71 R

34

R35

R39 D

6

C67

C66

C25

9

IC10

C20

5

C207

C73

C69

R249

Q36

R25

1

C85

C43

R22

C62

C63 Q8

D22

R32 Q11

R24

R23

L11

Q6

C46

R26

L50

C44

C22

5

C58

W11R

194

R195R193 C226

C269

R187

C22

4

R19

1

R188 R190

IC12

C229

R18

9

IC13

R192

C23

0

Q30

R196

C228 R19

7

C94

C18

8

C231

R198

FI2

C40

C41

Q7

R19

R20

C267

L10

Q5R21

C61 C60

R31R

29C

48

C38

L15

C65 C51

Q10

L17 L16

C26

8

D5

D7

R21

4C163

C16

6

R23

8

R10

2C

164

J3

C21

3

X2

C140

R221

R78

C12

4

R77

D4

R18

R92 C145

C143

C34

C12

5 R80

R81

R13

R79

C37

R16

D3

R17

C36

R24

3

R25

3

R24

4

C26

0

S2

C17

2

R16

6

R16

7

C20

4

R16

8

R11

1

R11

0

R112 R123

R94

C177

R121

R114

R120

C185

R138

R11

5

C21

4

R136

C18

4

R13

7

C175

R116

C174R113

IC5

S3

R12

8

R129

R11

7

R13

9

C270

C23

4

R204

R205

R20

8

R20

6

R20

7

C235

R203

C233 C232

C35

C26

1Q

4 L9C

33

C21

L51

EP

6

C20 C

18

Q2

R9

C26

2 R8

C26

R10

C27 R7

C255

R6

C25

R25

2C

24

R5

C23

R56

R54

C17

Q1

R55

Q14

C95

D24 C23

7

R4

D2

C15

R3

L53

R1

C8

C9

L3

L52

C11

4

C10

3

R71 R63

C159

C158

C157

C156

R2

L6

C236

R209

C16

0

R104

C93 S1

X3

X1

MC1

X2

J3J5

J4VHF

B5680B

J1J2

A J2 to the SW-A/B units

1

7 GNDTLEDRLEDVCCVOLINVOLOUTCBI0

J1 to the SW-A unit

1

4 CBI3CBI2CBI1CBI0

J3 to the speaker

12G

ND

SP

9 - 2

• BOTTOM VIEW

R13

4

D18

C161

C162

C18

2

R133

R22

8 C18

3

C18

1 R130

Q21

R229Q33

R13

1

R13

2

R12

6

R22

7

C25

7

C10

7

R65

C10

2

C10

5

L21

D12

D10

C101R62

L20

C106

C10

4

R70

D13

L54

C11

1

C113 R66

C24

9

C26

5C

108

C100

D9

L19

C99 D1

C5 C6

L1

C4

L2

C7

C14

C13

L4 C12

L5

C1

C2 C3

C10 C11

EP

4

EP

5

W8

IC2 C97

R58

R59

C96

R57

R21

3

D25

Q32

D17

C23

8

C165

C23

9

C24

0

C98R60 R61

R68

C11

0

C10

9

C115

R125

C17

3

R242

C119Q

15

R64

L22

C11

6

R24

5

D14

D15

L24

C12

2

C11

2

L56 R73

C118R

72

C11

7

C12

0

R74

C121

R75

R12

4

C176

R127 R118

R119

C17

9

C178

IC6 IC9

R165 C203

C186

R140

C187

R141

C189 C19

0

R14

2

R100C202

C138

R99

C154

R93

C123

R76

Q16

C126

L25

C13

9C

144

C127

L26

R85

C128

R86

C137

R89

C136

IC3

R91

Q17

R90

R95

C39

R88

C129 C13

2

R83

C13

3

C13

0

C167

R109D2

3

R103 R247

C17

1

R10

7

Q20

FI1

C134

Q19

IC4 R

106

C17

0

C16

8

C169

R105

C21

5

R17

5

R211

C75

R40

C26

6

R41

C76

R28

C45

L27

C56

C14

9

C15

1

C57

C49

R36

C155

R98

C147

L28

R185

R97

C146

C148

C15

0

Q18

C153

C142

C152

R220

Q12

Q22

Q28

Q35

Q29C

222 R184

C219

R18

3

C227

C21

8

C22

0C

221

R96

R181

R182

W12

C217

R180

R177

R176

R233

R234

W13

R17

8

R17

9R

201

R200

R21

6

R21

7

R199

C24

8

R24

1 IC7

R14

8

R239 R147

C42

C59 C91

L18

R202 R16

1

C90

R53

R38

C72

R45

Q13

R37 C70

C64

R43

C78

R44

R24

0

R27

R42

D20

IC1

C89

C216

C92

C80

R232

R52

C211

R172

Q26

R171

R173

Q27

R174

C212

C83

R46

C81

Q31

C82

D21

R49

R48

R47

IC11

R149 R15

2

R212

R210

R154

C19

8

R21

8

R21

9 C195

R158

C24

7

R15

7

C20

0

D16

IC8

R16

0

C19

9

MP5

9 - 5

9-2 SW-A AND SW-B UNITS• TOP VIEW

SW-A UNIT

F1

Q1 DS

1

B56

03C

SW-B UNIT

F1

Q1 DS

1

9 - 6

• BOTTOM VIEWSW-A UNIT

SW-B UNIT

R2

R3

R1S1

J2 to the MAIN unit J2

1 7

CB

I0V

OLO

UT

VO

LIN

VC

CR

LED

TLE

DG

ND


1 4

CB

I0C

BI1

CB

I2C

BI3

S1

W1 R2

R3

W2 R1

B5604C


1 7

CB

I0V

OLO

UT

VO

LIN

VC

CR

LED

TLE

DG

ND

10 - 1

SECTION 10 BC-146 OPTIONAL DESKTOP CHARGER INFORMATION


MP1 8010018620 2447 case (A) 1MP2 8110007450 2447 cover 1MP3 8930039620 Leg cushion (A) 4MP4 8930055020 2480 spacer 1MP5 8930055030 2480 BC-spacer 1MP6 8810008660 Screw B0 M 3 x 8 NI-ZU (BT) 1

[CHASSIS UNIT]

10-1 PARTS LIST 10-2 DISASSEMBLY INFORMATION

MP1

MP2

MP6

MP3

MP4

MP5

MP3

CHARGE unit

MP3

MP3 NOTE:BA :CHASSIS UNIT

:CHARGE UNIT

A

A

A

MP1 B

MP2 B

A

A

A

A

A

A


[CHARGE UNIT]

R1 7010007550 RESISTOR ERG3SJ680H 1R2 7010007100 RESISTOR PSD1/4V 1 kΩ 1 J1 6510021470 CONNECTOR HEC0470-01-230 1

DS1 5040001390 LED TLG124A 1

EP1 0910053820 PCB B 5650 1

MP1 8930051340 2338 TERMINAL 1MP2 8930051340 2338 TERMINAL 1

Screw abbreviations B0, BT:Self-tappingNI-ZU :Nickel-Zinc

NOTE: BC-146 is included with IC-F11BR and IC-F11S (For USA).

10 - 2

10-3 VOLTAGE DIAGRAM

10-4 BOARD LAYOUT

MP1R1 68

J1HEC0470-01-230

R21k

DS1TLG124A

MP2

C : 13.8VN : 13.8V

C : 7.2VN : 13.8V

C : 9.2VN : 13.8V

J1

MP1

MP2

B5650

R1

R2

DS1

11 - 1

SECTION 11 BLOCK DIAGRAM

ANT440–470MHz

Q12SK2974

D1 1SV307D9,D10 MA77

D2RB706F-40Q2

2SK2973Q32SC3585

Q42SC5107

VCOSW

D3,D4MA77Q7

2SC5107Q52SC5107

Q8 DTC144EUQ9 XP1214

R5VS5V

RX VCO

Q12XP6501

Q10 2SC5085D5 HVU350

Q11 2SC5085D7 HVU350

LVIN BUFF

Q132SK880

IC1MB15A02PFV1

X1CR-671A

REF

BAL

DEV

15.3MHz

Q182SC4116

REF

Q312SC4215D19HVC362

393.65–470MHz

DET

PLSTSOSCKUNLK

2nd MIXERIF AMPSQL AMPDETECTOR

MOD TX VCO

2ndLO45.9 MHz

D6MA368

IC3TA31136FN

IF ICNOIS

Q62SC5107

Q172SC4215

FI1FL-313

46.35MHz

Q193SK272

1stLO393.65–423.65 MHz

D15HVU350

D14HVU350

D13HVU350

AGCCONT

RSSI

Q333SK1829

PWRDET

T4

IC2TA75S01F

D12HVU350

MUTESW

LPFANTSW

PWRAMP

YGRAMP

YGRAMP

PREDRIVE

APCAMP

Q14DTA144EU

TXC

EXT.MIC

T1

MC1KUC3523

+5V

PTTSW

Q22UN911H

J4

HSJ1122 010010

T2

Q153SK293

PTT

T4

T3

1st MIXER

FI2

RSSI

450kHz

X2CDBCA450CX24

ALFYM450F=K

SQ

LIN

MICDET

DEV

DET

D/A

T1T2T3T4

Q21DTC144EU

IC5CNJM13403V

IC5BNJM13403V

IC9M62363FP

IC6BU4066BCFV

IC5DNJM13403V

IC6BU4066BCFV

ANALOGSW

ANALOGSW

R1AF VR

VOLIN

2ch VERSIONS1 AS-244-A13

VCC

CH SELECT/EMERGENCY

S1SW-A TP70QF4161SW-B (EMER) SKHHLP014A

VOLOUT

CBI0

AF AMPREG

AFONSP+

SP–

Q19 2SB1132Q20 XP6501

AFOUT

S3

J5

HSJ1456-01-220A

INT.SP

PTT

INT.MIC

F1

F2

EXT.SPIC4TA7368F

CLI,CLO

CLONE

CLONEBUFF Q32 DTC144TU

F1

F2

PTT

TXC

D17 RB706F-40

BATT

FUSE

F1

LED SW

Q1 XP4216

HV

CBI0CBI1CBI2CBI3

RLEDTLED

TX LED

BUSY LED

DS1LNJ107W5PRW

IC16NJM12904V

SWW/NNWC

DASTSCKSO

Q292SC4116

CTCSS/DTCS

REF

BAL

IC12ANJM12904V

RESTO-RATION

FILSW

FILSW

CDEC

IC12BNJM12904V

Q30XP1213

Q28DTC144EU

ANALOGSW

IC13TC7S66FU

DUSE

CENC0CENC1CENC2

SENC0SENC1SENC2SENC3

+5REG

S5REG

VCC

+5V

S5V

IC10NJM2870

Q242SB1132

S5CONT

Q23DTA144EU

Q25XP6501 EEPROM

RESET

CPU5V

RES

IC8S-8094ANMP

RMUT

MMUT

DUSE

SOSCKEXST

IC15

SCKESDA

CPUIC7HD6433664

IC11HN58X2416TI

X3CR-702

BEEP

NOIS

RSSI

LVIN

BDET

TEMP

BATV

D16MA77SHIFT

SW

EXP-ANDER

NWC

CSFTS5CR5C

T5C

BU4094BCFV

R5REG

T5REG

R5V

T5V

Q262SA1577

Q272SA1577

SDEC

IC5ANJM13403V

Explanatory notes

COMMON LINE

TX LINE

RX LINE

CONTROL LINE

BPFBPFBPFBPF RFAMP

TX / RXSWBUFFBUFF

BUFFATT

XTRLBPFAMP

RIPPLEFIL

LOOPFIL

PLLIC

BPF

LPF

x 3

CERAMICBPF

MIC

AF AMP

LPF

AMP

HPF

HPF

LPF LPF

BE

EP

TO

NE

TO

NE

RM

UT

RM

UT

MM

UT

CT

CS

S

R5C

LPFDET

DETLPF

MAIN UNIT

SW-A/SW-B UNIT

R47 47

Q112SC5085 Y

VCC

CBI0CBI1CBI2CBI3

RLEDTLED

CBI0

C1560.001

C1570.001

C1580.001

C1590.001

W13D only

W12D only

W11D only

VOLINVOLOUT

C9347 P

C9447 P

F1

F2

C840.01

R5147 k

D19HVC362

C852.2

R5010 kREF

BAL

R521k

C920.1

D20MA2S111

R232150 k

OSCINOSCOUT

VPVCC

DOGND

LDFINCLOCK9

DATA10LE11 FC12NC13FOUT14P15 R

16

87654321

R246 22

SCKUNLK

PLSTSO

LVIN

DEV

R5VS5V

R5VS5V

DEV

R5VS5V

VCCS5V+5V

VOLIN

VOLOUTAFOUT

C860.001

C1502 P

C1530.01

R961.2 k

R97680 kC152

10 P C14918 P

L281.0 H

C15118 P

R10047 k

R991.2 k

R438.2 k

R4510 k

R4947 k

D21MA2S111

C8047 P

R4882 k

C83100 P

C81100 P

R461.2 k

X1CR-664A

C252100 P

C890.001

C9056 P

R421

R5356 C91

56 PC8747 P

L1833 nH

C880.1

C1440.001C145

1C1460.001

C1470.1

C14810 P

R9447

R221100 k

C1430.001

FI2ALFYM450F=k

O I

R95150

R9847 k

L271.0 H

C154220 P

C155220 P

C780.001

R441 kC82

0.1

C7347 P

C1380.001

C1390.001

NO

IS

RS

SI

DE

T

R93330

X2CDBCA450CX24

C140120 P

R921.8 k

C763.3

R40220

R412.2 k

T5VVCO5V

C480.001

2

3

R5VS5V

RSSI

C12747 P

C1280.001

C1300.01

C1320.001

C1331 PC134

9 P

C1360.01

R83100

R85560

R88820

R89470

R90120 k

R91680

R86120

L260.47 H

C12956 P

C137100P

MIC MIC

C189470 P

C1900.047

R141470

R142100 k

C18810

PTT

C1820.047

C1830.1

C184180 P

C1850.1

R13610 k

R138470

R139100 k

R14015 k B only

C1860.0056 B0.0022 A

8 9

10

C1870.022 B only

R137200 k

R1344.7 k

VCCS5V+5V

C1810.047

R12710 k7

R13210 k

R126180 k

R12847 k

R12910 k

C2570.1

R13312 k

R13012 k

R1315.6 k

R24222 k

VOLIN

VOLOUT

SQLIN

VCC

AFOUT

R165470

SCKSO

T1T2T3T4DAST

SCKSO

T1T2

DASTSCKSO

T1T2

T3T4

DAST

SQLINVCC

+5V

R16910k

1 32

456

VOLIN

VO

LIN

VOLOUT

VO

LOU

T

AFOUT

SQLIN

SQLIN

SQ

LIN

VCC

VC

C

+5V

+5V

R5V

R5V

S5V

S5V

R5V

S5V

R5V

S5V

T5V

T5V

VC

C

+5V

R5V

S5V

T5V

AF

OU

T

+5V

MIC

R17110 kR173

10 kC2130.001

MIC

OPTMIC

C2150.001

C2370.001

R17533 k

EP4

EP5

J4

C21447 P

MC1MIC

PTT

EXT.MIC

EXT.SP

BDET

C21022

C2110.01

C2120.01

R1724.7 k

R1744.7 k

R210120 k

R211100 k R217

47 kR218100 k

D17RB706F-40

R213470

R21622 k

R2481

S5V S5V

R5V

C20710

C2080.01

C2090.1

R1702.2 k

C2050.1

R219220 k

C2590.01

C20610

C2030.01

C2040.01

C235820 P

R166470 k

R167470 k

R168470 k

R20356 k

R204390 k

R205180 k

R20682 k

R20739 k

R208100 k

R209100 k

C2360.022 1

23

11

4

R5V

C2240.033

C2260.1

C2290.0068

C2300.01

C2330.1

C234820P

R188470 k

R189100 k

R19047k

R19147k

R19218 k

R193220 k

R19468 k

R195120 k

R19722 k

54 3

2

1

3

21 5

4

C2270.01

C2280.1

R19622 k

C2320.0012

3

21

4

8

56

7

C2254.7

C2310.039

R19822 k

R22468 k

R22568 k

R22668 k

C2430.0056

C2450.0082

3

21

4

8

C244180 P

C24668 P

C22347 P

R2141 k

R22268 k R223

68 k

C2420.0027

C25847 P

R21522 k

AFOUTSPCLONE

C2390.001

C24047 P

J5

VCC

+5V

+5V +5V

S5V

C2380.001

4

56 1

SP

C5810

C5947 P

LV C5747 P

VCCT5V

S5V

R2202.2 k

L174.7 H

C751

C490.5 P

R3533 k

R3882 k

T5C

CLI

CLO

R5C

BD

ET

SE

NC

3

SE

NC

2

TO

NE

DE

T

SD

EC

CD

EC

SE

NC

1

S5C

SE

NC

0

5

67

VCCT5V

S5V+5V

+5V +5V

+5V

VCC

NW

C

MM

UT

R5C

I/O1

O/I2

O/I3

I/O4

CONT.B5

CONT.C6

VEE7

141312111098I/O

O/IO/II/O

CONT.DCONT.A

VDD

CT

RL

GN

DV

B

VIN

VO

UT

RE

F

REF

DUSE

BA

L

BAL

DEV

+5V

DETSQLIN

S1

S2

1234

J1C only

FromSW-A UNIT

From/toSW-A and SW-BUNITS

1234567

J2

C1610.001

C162470 P

C16047

SPEAKER

W1CHASSIS UNIT

OPC-963

12

SP1

12

J3

S3

910111213141516

87654321

OSCOUTOSCIN

MIXOUTVCCIFINDECFILOUTFILIN AFOUT

QUADIFOUT

RSSIN-DETN-REC

GNDMIXIN

C1420.001

VIN11

VOUT12

VOUT23

VIN24

VDD5

LD6

CLK7

DI8

VIN39

VOUT310

VOUT411

VIN412

242322212019181716151413VIN5

VOUT5VOUT6

VIN6DO

VDAREFRESET

GNDVIN7

VOUT7VOUT8

VIN8

6

5

Q102SC5085 Y

Q8DTC144EU

Q163SK272

Q172SC4215 O

IC6 BU4066BCFVIC5B NJM13403V

Q21 DTC144EU

IC9 M62363FP-650CIC10NJM2870

Q262SA1577 QQ27

2SA1577 Q

Q182SC4116 GR

IC1 MB15A02PFV-1

Q312SC4215 O

IC3 TA31136FN

Q132SK880 Y

Q12 XP6501 AB

IC5ANJM13403V

IC13TC7S66FU

Q30 XP1213

IC12BNJM12904V

IC12ANJM12904V

IC16B NJM12904V

Q24 2SB1132 R

Q25XP6501 AB Q23

DTA144 EU

IC16ANJM12904V

Q32DTC144TU

Q22 UN911H

IC5C NJM13403V

FI1FL-311

1 3

5 4 2

D24HSU88

C2690.001

C2539 P

R249 470 k

R23027 k

R250 470 kR251120 k

EP7 A only

C720.001

R2847

R29820

C700.001

C640.1

C630.001

C561

C6982 P

C670.0022

C6636 P

R47 47

C2700.001

Q362SK1829 R31

4.7 k

C512 P

C600.001

Q112SC5085 Y

C610.001

C652 P

R324.7 k

L152.2 H

L1680 nH

D7HVU350B

D5HVU350B

C2682.5 P

R37220 k R27

10 kR2401 k C71

0.001

R361 k

D22MA77

C620.1

R3447 k

R391 kD6

MA2S077

4.9 V

4.8 V15.3 MHz0.75 V P-P

4.7 V0 V

UNLOCK 0.5 VLOCK 4.5 V

2.9 V0 V

PTT ON 4.8VPTT OFF 0V

WIDE 4.8 VNAR 0 V

2.1 V

1.0 V0 V

3.1 V P-PCTCSS code

2.5 V

0.7 V0 V

3 V P-P

5/2 tonecodetransmitting

4.8 V

4.9 V0 V

0 V4.9 V

2.1 V

3.5 V0 V

4.5 V0 V

10

SECTION 12 VOLTAGE DIAGRAM

12 - 1

NOTE: A: [F12] and [F12S] B: [F11], [F11BR] and [F11S] C: [F11] and [F12] D: [F11BR], [F11S] and [F12S]

Q112SC5085 Y

C324 P

C522 P

C60.001

R182 k

D11SV307

L132 nH

L230 nH

C8 47P

C90.001C18

47 PC200.001

R2150

L34.7 H

T5V

C340.001

C3547 P

R1310

L6EXCCL3225UC45

47 P R16100R19

100R22220

R24100

T5VVCO5V

C480.001

R5VS5V

RSSI

R5V

VCO5V

S5V

RSSI RSSI

C370.001

C389 P

C3912 P

C400.001

C417 P

C4222 P

C430.001

C442 P

C460.001

R1710 k

R181 k

R2047 k

R214.7

R2368 k

R2668 k

D3MA77

L100.1 HL11

0.1 H

D4MA77

S5V

C210.001

C260.001

C3618 P

R868

L927 nH

C270.001

R104.7 k

R933 k

C33100 P

C25522 P C7

0.001C120.001

C150.001

C250.001

R315 k

R44.7 k

R522

L450 nH

MP5

L522 nH

R6100 k

R74.7 k

D2RB706F-40

L5260 nH

C230.1

C24100 P

C1315 P

C1415 P

C1768 P

R552.2 k

R5610 k

R5768 k

R239100 k

R5410 kC96

0.1

T4

TX

C

C970.1

R58150 kR60

100

R611 k

D9ISV307

L1950 nH

1

34

5

2

C980.01

C9911 P

L2050 nH

C100 18 P A22 P B

D10MA77

R59120 k

W8

C1024 P A6 P B

C1030.001

C10427 P B47 P A

C1090.01

C11047 P R62

220 k

R6310 k

D12HVU350B

C1070.001

C10847 P

L2256 nH

L2156 nH

R65120 k A270 k B

R6418 k A100 k B

R2295.6 k A only

R228470 k A only

D18MA2S111 A only

R22710 k A only

R6610 k

R68470

C249 0.47 A only

C1053 P A 2.5 P B

C1061 P

C1120.01

C1140.001

C1180.001

C1191.5 P

C1210.001

C12318 P

C1240.001

C12527 P

C12633 P

R70220 kR71

10 k

R72220 k

R7310 k

R7510 k

R76820

R771 k

R7810 k

R8012

D14HVU350B

D15HVU350B

L250.1 H C120

33 P B 68 P A

C11782 P

R79470

R81470

L2456 nH C122

3.5 P A6 P B

C1162.5 P

C1150.001

C12747 P

C1280.001

C1300.01

C1320.001

C1331 P

R83100

R85560

R86120

L260.47 H

C12956 P

VCCS5V

VCCS5V

ANT

VCCS5V+5V

R126180 k R242

22 k

C1772.2

C1780.01C179

1 R117100 k

R12210 k

R12427 k

R1251 M

C248 0.1

R12082 k

R12115 k

R11633 k

R123150 k

R118220 k

R119270 k

C1760.0018

R11127 k

R1122.2 k

R1103.3 k

1413

12 R238100 k

R11410 k

R115120 k

C174 150 P

R113820

C1730.1

C17247

R10968 k

D23MA2S111

R1052.7 k

R1063.3 k

R1071 k

NC1

VCC2

NC3

VIN4

RIPPLE5

109876NF

PHASEPREGNDPWGND

POUT

C1700.1

C1696.8

1 2 3

456 R10410 k

C1670.047

R2471 k

C1710.22

C1680.22

C1640.047

C16547 P

R10210R103

33

C16610

C163100

AFOUT

R21215k

VOLOUT

REMO

R143100 k

R1491 k

R2411 k

VOLOUT

AFOUT

AF

ON

CPU5V

CPU5V

OSC1

TEMP

BATV

C1910.1

R152100 k

R153100 k

R154100 k

R151NTCCM20124AG473JCT

C19568 P

C20147 P

C2020.001

R15712 k

L29 39 H

R16010 k

VOLIN

VOLOUT

SQLIN

VCC

AFOUT

R165470

CKO

2

ASTSCKSO

T1T2

T3T4

DAST

C2030.01

C2040.01

R20356 k

R204390 k

R205180 k

123

11

4

C196470 P

C1990.001

R15912 k

R177 22 k

R18010 k

R17856 k

D16MA77

R1631 k

R17622 k

C2000.027 R158

12 k

R179180 k

CENC1

CENC2

CS

FT

MMUTRMUT

RES RES

CPU5V

OSC2

R1561 M

C1980.1

12315

R15510

X3 CR-702

C19322 P

C19415 P

EXSTSOSCK

PLSTDASTEXSTPTT

TXCRLEDTLEDAFONESDACLICLO

R146100 k

R19947 k

BE

EP

SO

SC

KC

BI3

CB

I2C

EN

C2

CE

NC

1C

EN

C0

SE

NC

3S

EN

C2

CB

I1C

BI0

SE

NC

1S

EN

C0

R2011 k

C2160.01

R202100 k

C2470.1

R2001 kR161

10 k

DUSE

C2180.039

C2190.1

C220820 P

R18147 k

R18247 k

R18515 k

R187470

R1641 k

R18447 k

C2220.1

T5C

S5CR5C

NWC

C2240.033

6

C2330.1

R188470 k

R189100 k

R19047k

R19147k

R19218 k

R193220 k

54 3

2

1

3

21 5

4

C2320.0012

56

7

C2254.7

R74220 k

C19722

C490.5 P

C1750.0056

SD

EC

CD

EC

STRD

CLKOE

Q1Q2Q3Q4Q5Q6Q7Q8

QS9

QS10

8

16

A0 1

A1 2

A2 3

VSS 4SDA5 SCL6 WP7VCC8

NC1

OSC210

NC16

NC

NC

P52

/WK

P2

P53

/WK

P3

P54

/WK

P4

P55

/WK

P5/

AD

TR

GP

10/T

MO

WP

11P

12P

56/S

DA

P57

/SC

LP

74/T

MR

IVP

75/T

MC

IVP

76/T

MO

VN

CN

C

NC

NC

PB

0/A

N0

PB

1/A

N1

PB

2/A

N2

PB

3/A

N3

PB

7/A

N7

PB

6/A

N6

PB

5/A

N5

PB

4/A

N4

P17

/IRQ

3/T

RG

VP

16/IR

Q2

P15

/IRQ

1P

14/IR

Q0

NC

NC

P51/WKP114

NC15

NC2

AVCC3

X24

X1X1 5

VCLVCL 6

RES7

TESTTEST 8

VSSVSS 9

OSC1

OSC2OSC1 11

VCCVCC 12

P50/WKP013

17 26 3230 3118 19 20 21 22 23 24 25 27 28 29

6364 54 50 4962 61 60 59 58 57 56 55 53 52 51

48

39

33

3534

4746454443424140

383736

NC

NCNC

NMIP80/FTCI

P81/FTIOAP82/FTIOBP83/FTIOCP84/FTIOD

P85P86P87

P20/SCK3P21/RXDP22/TXD

NC

C1920.1

BD

ET

LVIN

RS

SI

SD

EC

CD

ES

UN

LKN

OIS

F2

F1

VCC

MM

UT

R5C RM

UT

TO

NE

BEEP

T4

T3

T2

I/O1

O/I2

O/I3

I/O4

CONT.B5

CONT.C6

VEE7

141312111098I/O

O/IO/II/O

CONT.DCONT.A

VDD

RE

F

REF

S5V

DUSE

BA

L

BAL

DE

V

DEV

+5V

DE

T

DETSQLIN

VCC VCC

T5V

S5V

VIN11

VOUT12

VOUT23

VIN24

VDD5

LD6

CLK7

DI8

VIN39

VOUT310

VOUT411

VIN412

242322212019181716151413VIN5

VOUT5VOUT6

VIN6DO

VDAREFRESET

GNDVIN7

VOUT7VOUT8

VIN8

ES

DA

SC

K

R234100 k

R233100 k

Q102SC5085 Y

Q8DTC144EU

Q163SK272

IC6 BU4066BCFV

IC9 M62363FP-650C

Q52SC5107 O

Q62SC5107 O

Q72SC5107 O

Q42SC5110 O

Q15 3SK294

IC5DNJM13403V

Q22SK2973 Q1

2SK2974

Q332SK1829 A only

Q192SB1132 R

Q20XP6501 AB

Q14DTA144EV

IC2TA75S01F

IC4 TA7368F

IC7HD6433664A24FP

IC15BU4094BCFV

IC11BR24C16FV-E2

Q28 DTC144EU

IC8 S-80942ANMP-DD6

IC5ANJM13403V Q29

2SC4116 GR

IC13TC7S66FU

Q30 XP1213

IC12BNJM12904V

T1

OUT 1

VDD2

VSS3NC4

CD5

1LO

4567

14131211

R1471 k

R1481 k

CENC0

C2170.1

Q35DTC144EU

R1831 k

C2210.01

R2847

L5310.5 nH

R25210

EP6

C2620.1

C2600.001

R244100

C2676 P

L561 H

C101 10 P A4 P B

C950.001

D25MA2S111

L5456 nH

C1113 P A4 P B

C2657 P

C11356 P

D13HVU350B

R245820 B2.2 k A

C2610.001

R253470

R29820

C2700.001

C19 P

C411 P

C27 P

C1018 P

C1115 P

L500.1 H

R314.7 k

C512 P

C600.001

Q112SC5085 Y

C610.001

C652 P

R324.7 k

L152.2 H

D7HVU350B

D5HVU350B

C710.001

R361 k

C620.1

L5118 nH

R2431.5 k

4.1 V

3.7 V 3.3 V 3.5 V

1.0 V0 V

2.0 V0 V

0 V3.7 V

0 V2.1 V

4.6 V0 V

4.6 V0 V

2.0 V0 V

3.1 V0 V

0.6 V0 V

2.1 V

1.2 V1.3 V

0 V2.4 V

3.4 VAF ON

7.5 VAF ON

4.8 VAF ON

4.9 V

4.4 V1.6 V

1.1 V P-P14.7456 MHz

4.5 VDTCS

3.1 V P-PCTCSS code transmitting

2.5 V

4.8 V

4.5 V0 V

4.9 V

1.8 V0 V

R47 47

Q112SC5085 Y

VCC

CBI0CBI1CBI2CBI3

RLEDTLED

CBI0

C1560.001

C1570.001

C1580.001

C1590.001

W13D only

W12D only

W11D only

VOLINVOLOUT

C9347 P

C9447 P

F1

F2

C840.01

R5147 k

D19HVC362

C852.2

R5010 kREF

BAL

R521k

C920.1

D20MA2S111

R232150 k

OSCINOSCOUT

VPVCC

DOGND

LDFINCLOCK9

DATA10LE11 FC12NC13FOUT14P15 R

16

87654321

R246 22

SCKUNLK

PLSTSO

LVIN

DEV

R5VS5V

R5VS5V

DEV

R5VS5V

VCCS5V+5V

VOLIN

VOLOUTAFOUT

C860.001

C1502 P

C1530.01

R961.2 k

R97680 kC152

10 P C14918 P

L281.0 H

C15118 P

R10047 k

R991.2 k

R438.2 k

R4510 k

R4947 k

D21MA2S111

C8047 P

R4882 k

C83100 P

C81100 P

R461.2 k

X1CR-664A

C252100 P

C890.001

C9056 P

R421

R5356 C91

56 PC8747 P

L1833 nH

C880.1

C1440.001C145

1C1460.001

C1470.1

C14810 P

R9447

R221100 k

C1430.001

FI2ALFYM450F=k

O I

R95150

R9847 k

L271.0 H

C154220 P

C155220 P

C780.001

R441 kC82

0.1

C7347 P

C1380.001

C1390.001

NO

IS

RS

SI

DE

T

R93330

X2CDBCA450CX24

C140120 P

R921.8 k

C763.3

R40220

R412.2 k

C324 P

C522 P

C60.001

R182 k

D11SV307

L132 nH

L230 nH

C8 47P

C90.001C18

47 PC200.001

R2150

L34.7 H

T5V

C340.001

C3547 P

R1310

L6EXCCL3225UC45

47 P R16100R19

100R22220

R24100

T5VVCO5V

C480.001

2

3

R5VS5V

RSSI

R5V

VCO5V

S5V

RSSI RSSI

C370.001

C389 P

C3912 P

C400.001

C417 P

C4222 P

C430.001

C442 P

C460.001

R1710 k

R181 k

R2047 k

R214.7

R2368 k

R2668 k

D3MA77

L100.1 HL11

0.1 H

D4MA77

S5V

C210.001

C260.001

C3618 P

R868

L927 nH

C270.001

R104.7 k

R933 k

C33100 P

C25522 P C7

0.001C120.001

C150.001

C250.001

R315 k

R44.7 k

R522

L450 nH

MP5

L522 nH

R6100 k

R74.7 k

D2RB706F-40

L5260 nH

C230.1

C24100 P

C1315 P

C1415 P

C1768 P

R552.2 k

R5610 k

R5768 k

R239100 k

R5410 kC96

0.1

T4

TX

C

C970.1

R58150 kR60

100

R611 k

D9ISV307

L1950 nH

1

34

5

2

C980.01

C9911 P

L2050 nH

C100 18 P A22 P B

D10MA77

R59120 k

W8

C1024 P A6 P B

C1030.001

C10427 P B47 P A

C1090.01

C11047 P R62

220 k

R6310 k

D12HVU350B

C1070.001

C10847 P

L2256 nH

L2156 nH

R65120 k A270 k B

R6418 k A100 k B

R2295.6 k A only

R228470 k A only

D18MA2S111 A only

R22710 k A only

R6610 k

R68470

C249 0.47 A only

C1053 P A 2.5 P B

C1061 P

C1120.01

C1140.001

C1180.001

C1191.5 P

C1210.001

C12318 P

C1240.001

C12527 P

C12633 P

R70220 kR71

10 k

R72220 k

R7310 k

R7510 k

R76820

R771 k

R7810 k

R8012

D14HVU350B

D15HVU350B

L250.1 H C120

33 P B 68 P A

C11782 P

R79470

R81470

L2456 nH C122

3.5 P A6 P B

C1162.5 P

C1150.001

C12747 P

C1280.001

C1300.01

C1320.001

C1331 PC134

9 P

C1360.01

R83100

R85560

R88820

R89470

R90120 k

R91680

R86120

L260.47 H

C12956 P

C137100P

VCCS5V

VCCS5V

ANT

MIC MIC

C189470 P

C1900.047

R141470

R142100 k

C18810

PTT

C1820.047

C1830.1

C184180 P

C1850.1

R13610 k

R138470

R139100 k

R14015 k B only

C1860.0056 B0.0022 A

8 9

10

C1870.022 B only

R137200 k

R1344.7 k

VCCS5V+5V

C1810.047

R12710 k7

R13210 k

R126180 k

R12847 k

R12910 k

C2570.1

R13312 k

R13012 k

R1315.6 k

R24222 k

C1772.2

C1780.01C179

1 R117100 k

R12210 k

R12427 k

R1251 M

C248 0.1

R12082 k

R12115 k

R11633 k

R123150 k

R118220 k

R119270 k

C1760.0018

R11127 k

R1122.2 k

R1103.3 k

1413

12 R238100 k

R11410 k

R115120 k

C174 150 P

R113820

C1730.1

C17247

R10968 k

D23MA2S111

R1052.7 k

R1063.3 k

R1071 k

NC1

VCC2

NC3

VIN4

RIPPLE5

109876NF

PHASEPREGNDPWGND

POUT

C1700.1

C1696.8

1 2 3

456 R10410 k

C1670.047

R2471 k

C1710.22

C1680.22

C1640.047

C16547 P

R10210R103

33

C16610

C163100

AFOUT

R21215k

VOLOUT

REMO

R143100 k

R1491 k

R2411 k

VOLOUT

AFOUT

AF

ON

CPU5V

CPU5V

OSC1

TEMP

BATV

C1910.1

R152100 k

R153100 k

R154100 k

R151NTCCM20124AG473JCT

C19568 P

C20147 P

C2020.001

R15712 k

L29 39 H

R16010 k

VOLIN

VOLOUT

SQLIN

VCC

AFOUT

R165470

SCKSO

T1T2T3T4DAST

SCKSO

T1T2

DASTSCKSO

T1T2

T3T4

DAST

SQLINVCC

+5V

R16910k

1 32

456

VOLIN

VO

LIN

VOLOUT

VO

LOU

T

AFOUT

SQLIN

SQLIN

SQ

LIN

VCC

VC

C

+5V

+5V

R5V

R5V

S5V

S5V

R5V

S5V

R5V

S5V

T5V

T5V

VC

C

+5V

R5V

S5V

T5V

AF

OU

T

+5V

MIC

R17110 kR173

10 kC2130.001

MIC

OPTMIC

C2150.001

C2370.001

R17533 k

EP4

EP5

J4

C21447 P

MC1MIC

PTT

EXT.MIC

EXT.SP

BDET

C21022

C2110.01

C2120.01

R1724.7 k

R1744.7 k

R210120 k

R211100 k R217

47 kR218100 k

D17RB706F-40

R213470

R21622 k

R2481

S5V S5V

R5V

C20710

C2080.01

C2090.1

R1702.2 k

C2050.1

R219220 k

C2590.01

C20610

C2030.01

C2040.01

C235820 P

R166470 k

R167470 k

R168470 k

R20356 k

R204390 k

R205180 k

R20682 k

R20739 k

R208100 k

R209100 k

C2360.022 1

23

11

4

C196470 P

C1990.001

R15912 k

R177 22 k

R18010 k

R17856 k

D16MA77

R1631 k

R17622 k

C2000.027 R158

12 k

R179180 k

CENC1

CENC2

CS

FT

MMUTRMUT

RES RES

CPU5V

OSC2

R1561 M

C1980.1

12315

R15510

X3 CR-702

C19322 P

C19415 P

EXSTSOSCK

PLSTDASTEXSTPTT

TXCRLEDTLEDAFONESDACLICLO

R146100 k

R19947 k

BE

EP

SO

SC

KC

BI3

CB

I2C

EN

C2

CE

NC

1C

EN

C0

SE

NC

3S

EN

C2

CB

I1C

BI0

SE

NC

1S

EN

C0

R2011 k

C2160.01

R202100 k

C2470.1

R2001 kR161

10 k

DUSE

C2180.039

C2190.1

C220820 P

R18147 k

R18247 k

R18515 k

R187470

R1641 k

R18447 k

C2220.1

T5C

S5CR5C

NWCR5V

C2240.033

C2260.1

C2290.0068

C2300.01

C2330.1

C234820P

R188470 k

R189100 k

R19047k

R19147k

R19218 k

R193220 k

R19468 k

R195120 k

R19722 k

54 3

2

1

3

21 5

4

C2270.01

C2280.1

R19622 k

C2320.0012

3

21

4

8

56

7

C2254.7

C2310.039

R19822 k

R22468 k

R22568 k

R22668 k

C2430.0056

C2450.0082

3

21

4

8

C244180 P

C24668 P

C22347 P

R2141 k

R22268 k R223

68 k

C2420.0027

C25847 P

R21522 k

AFOUTSPCLONE

C2390.001

C24047 P

J5

VCC

+5V

+5V +5V

S5V

C2380.001

4

56 1

R74220 k

SP C19722

C5810

C5947 P

LV C5747 P

VCCT5V

S5V

R2202.2 k

L174.7 H

C751

C490.5 P

R3533 k

R3882 k

C1750.0056

T5C

CLI

CLO

R5C

BD

ET

SE

NC

3

SE

NC

2

TO

NE

DE

T

SD

EC

CD

EC

SE

NC

1

S5C

SE

NC

0

5

67

STRD

CLKOE

Q1Q2Q3Q4Q5Q6Q7Q8

QS9

QS10

8

16

A0 1

A1 2

A2 3

VSS 4SDA5 SCL6 WP7VCC8

NC1

OSC210

NC16

NC

NC

P52

/WK

P2

P53

/WK

P3

P54

/WK

P4

P55

/WK

P5/

AD

TR

GP

10/T

MO

WP

11P

12P

56/S

DA

P57

/SC

LP

74/T

MR

IVP

75/T

MC

IVP

76/T

MO

VN

CN

C

NC

NC

PB

0/A

N0

PB

1/A

N1

PB

2/A

N2

PB

3/A

N3

PB

7/A

N7

PB

6/A

N6

PB

5/A

N5

PB

4/A

N4

P17

/IRQ

3/T

RG

VP

16/IR

Q2

P15

/IRQ

1P

14/IR

Q0

NC

NC

P51/WKP114

NC15

NC2

AVCC3

X24

X1X1 5

VCLVCL 6

RES7

TESTTEST 8

VSSVSS 9

OSC1

OSC2OSC1 11

VCCVCC 12

P50/WKP013

17 26 3230 3118 19 20 21 22 23 24 25 27 28 29

6364 54 50 4962 61 60 59 58 57 56 55 53 52 51

48

39

33

3534

4746454443424140

383736

NC

NCNC

NMIP80/FTCI

P81/FTIOAP82/FTIOBP83/FTIOCP84/FTIOD

P85P86P87

P20/SCK3P21/RXDP22/TXD

NC

C1920.1

BD

ET

LVIN

RS

SI

SD

EC

CD

ES

UN

LKN

OIS

F2

F1

VCCT5V

S5V+5V

+5V +5V

+5V

VCC

NW

C

MM

UT

R5C RM

UT

TO

NE

BEEP

T4

T3

T2

I/O1

O/I2

O/I3

I/O4

CONT.B5

CONT.C6

VEE7

141312111098I/O

O/IO/II/O

CONT.DCONT.A

VDD

CT

RL

GN

DV

B

VIN

VO

UT

RE

F

REF

S5V

DUSE

BA

L

BAL

DE

V

DEV

+5V

DE

T

DETSQLIN

VCC VCC

T5V

S5V

S1

S2

1234

J1C only

FromSW-A UNIT

From/toSW-A and SW-BUNITS

1234567

J2

C1610.001

C162470 P

C16047

SPEAKER

W1CHASSIS UNIT

OPC-963

12

SP1

12

J3

S3

910111213141516

87654321

OSCOUTOSCIN

MIXOUTVCCIFINDECFILOUTFILIN AFOUT

QUADIFOUT

RSSIN-DETN-REC

GNDMIXIN

C1420.001

VIN11

VOUT12

VOUT23

VIN24

VDD5

LD6

CLK7

DI8

VIN39

VOUT310

VOUT411

VIN412

242322212019181716151413VIN5

VOUT5VOUT6

VIN6DO

VDAREFRESET

GNDVIN7

VOUT7VOUT8

VIN8

6

5

ES

DA

SC

K

R234100 k

R233100 k

Q102SC5085 Y

Q8DTC144EU

Q163SK272

Q172SC4215 O

IC6 BU4066BCFVIC5B NJM13403V

Q21 DTC144EU

IC9 M62363FP-650CIC10NJM2870

Q262SA1577 QQ27

2SA1577 Q

Q182SC4116 GR

IC1 MB15A02PFV-1

Q312SC4215 O

IC3 TA31136FN

Q132SK880 Y

Q12 XP6501 AB

Q52SC5107 O

Q62SC5107 O

Q72SC5107 O

Q42SC5110 O

Q15 3SK294

IC5DNJM13403V

Q22SK2973 Q1

2SK2974

Q332SK1829 A only

Q192SB1132 R

Q20XP6501 AB

Q14DTA144EV

IC2TA75S01F

IC4 TA7368F

IC7HD6433664A24FP

IC15BU4094BCFV

IC11BR24C16FV-E2

Q28 DTC144EU

IC8 S-80942ANMP-DD6

IC5ANJM13403V Q29

2SC4116 GR

IC13TC7S66FU

Q30 XP1213

IC12BNJM12904V

IC12ANJM12904V

IC16B NJM12904V

Q24 2SB1132 R

Q25XP6501 AB Q23

DTA144 EU

IC16ANJM12904V

Q32DTC144TU

Q22 UN911H

IC5C NJM13403V

T1

OUT 1

VDD2

VSS3NC4

CD5

1LO

4567

14131211

FI1FL-311

R1471 k

R1481 k

CENC0

C2170.1

Q35DTC144EU

R1831 k

C2210.01

1 3

5 4 2

D24HSU88

C2690.001

C2539 P

R249 470 k

R23027 k

R250 470 kR251120 k

EP7 A only

C720.001

R2847

L5310.5 nH

R25210

EP6

C2620.1

C2600.001

R244100

C2676 P

L561 H

C101 10 P A4 P B

C950.001

D25MA2S111

L5456 nH

C1113 P A4 P B

C2657 P

C11356 P

D13HVU350B

R245820 B2.2 k A

C2610.001

R253470

R29820

C700.001

C640.1

C630.001

C561

C6982 P

C670.0022

C6636 P

R47 47

C2700.001

Q362SK1829

C19 P

C411 P

C27 P

C1018 P

C1115 P

L500.1 H

R314.7 k

C512 P

C600.001

Q112SC5085 Y

C610.001

C652 P

R324.7 k

L152.2 H

L1680 nH

D7HVU350B

D5HVU350B

C2682.5 P

R37220 k R27

10 kR2401 k C71

0.001

R361 k

D22MA77

C620.1

R3447 k

R391 kD6

MA2S077

L5118 nH

R2431.5 k

4.9 V

4.8 V15.3 MHz0.75 V P-P

4.7 V0 V

UNLOCK 0.5 VLOCK 4.5 V

2.9 V0 V

PTT ON 4.8VPTT OFF 0V

WIDE 4.8 VNAR 0 V

2.1 V

4.1 V

3.7 V 3.3 V 3.5 V

1.0 V0 V

2.0 V0 V

0 V3.7 V

0 V2.1 V

4.6 V0 V

4.6 V0 V

2.0 V0 V

3.1 V0 V

0.6 V0 V

2.1 V

1.2 V1.3 V

0 V2.4 V

3.4 VAF ON

7.5 VAF ON

4.8 VAF ON

4.9 V

4.4 V1.6 V

1.1 V P-P14.7456 MHz

4.5 VDTCS

3.1 V P-PCTCSS code transmitting

2.5 V

0.7 V0 V

3 V P-P

5/2 tonecodetransmitting

4.8 V

4.9 V0 V

0 V4.9 V

2.1 V

3.5 V0 V

4.5 V0 V

4.9 V

1.8 V0 V

SECTION 12 VOLTAGE DIAGRAM

12 - 1

NOTE: A: [F12] and [F12S] B: [F11], [F11BR] and [F11S] C: [F11] and [F12] D: [F11BR], [F11S] and [F12S]

12 - 2

12-2 SW-A AND SW-B UNITS• SW-A UNIT

TP76N00N-15F-10KA-2251R1

Q1 XP4216

R3 560

R2 330

DS1LNJ107W5PRW

C 1 1 22 34 48 5

S1CP10

CP11CP12

CBI0CBI1

CP13CBI2CBI3

CP8

HVF1

654 3

2 1

CP3CP4CP5CP6

CP2

CP9 CBI0

VOLINVOLOUT

VCCRLEDTLEDGND

CP1

G

R

RX (SQL OPEN) 4.1 V

RX (SQL OPEN) 0 V

RX (SQL OPEN) 2.1 V

RX (SQL OPEN) 4.8 V

TX 4.8 V

RX (SQL OPEN) 0 VTX 2.4 V

TX 0 V

TX 4.1 V

TX 0 V

TX 0 V

RX (SQL OPEN) 0 V

• SW-B UNIT

CHASSIS UNIT2CH VERSION

S1

W1 W2

EMERGENCY VERSIONS1

CP8HV

TP76N00N-15F-10KA-2251R1

F1CP3CP4CP5CP6

CP9

CP1CP2

654 3

2 1

Q1 XP4216

CBI0VOLOUTVOLINVCCRLEDTLEDGND

R3 560

R2 330

DS1LNJ107W5PRW

G

R

RX (SQL OPEN) 4.1 V

RX (SQL OPEN) 0 V

RX (SQL OPEN) 2.1 V

RX (SQL OPEN) 4.8 V

TX 4.8 V

RX (SQL OPEN) 2.1 V

TX 0 V

TX 0 V

TX 0 V

TX 4.1 V

RX (SQL OPEN) 0 V

TX 0 V

INTRODUCTION

DANGER

ORDERING PARTS

REPAIR NOTES

This service manual describes the latest service informationfor the IC-F11/IC-F11S/IC-F11BR/IC-F12/IC-F12S at thetime of publication.

NEVER connect the transceiver to an AC outlet or to a DCpower supply that uses more than 16 V. Such a connectioncould cause a fire hazard and/or electric shock.

DO NOT expose the transceiver to rain, snow or any liquids.

DO NOT reverse the polarities of the power supply when con-necting the transceiver.

DO NOT apply an RF signal of more than 20 dBm (100mW)to the antenna connector. This could damage the transceiv-er’s front end.

Be sure to include the following four points when orderingreplacement parts:

1. 10-digit order numbers2. Component part number and name3. Equipment model name and unit name4. Quantity required

<SAMPLE ORDER>1130007020 S.IC TC7S66FU IC-F11 MAIN UNIT 1 piece8810009510 Screw BO M 2 x 4 NI-ZU IC-F11 Chassis 10 pieces

Addresses are provided on the inside back cover for yourconvenience.

1. Make sure a problem is internal before disassembling the transceiver.2. DO NOT open the transceiver until the transceiver is disconnected from its power source.3. DO NOT force any of the variable components. Turn them slowly and smoothly.4. DO NOT short any circuits or electronic parts. An insulated turning tool MUST be used for all adjustments.5. DO NOT keep power ON for a long time when the transceiver is defective.6. DO NOT transmit power into a signal generator or a sweep generator.7. ALWAYS connect a 40 dB to 50 dB attenuator between the transceiver and a deviation meter or spectrum analyzer when

using such test equipment.8. READ the instructions of test equipment thoroughly before connecting equipment to the transceiver.

To upgrade quality, all electrical or mechanical parts andinternal circuits are subject to change without notice or oblig-ation.

IC-F11/IC-F12 IC-F11BR/IC-F11S/IC-F12S

SERVICEMANUAL

1-1-32, Kamiminami, Hirano-ku, Osaka, 547-0003, JapanS-13806IZ-C1V

© 2001 Icom Inc.

VHF TRANSCEIVERS

Documents

IC-F11/F12 series Service Manualhamradio.online.ru/ftp2/serman_icf11_12.pdf · 1130007020 S.IC TC7S66FU IC-F11 MAIN UNIT 1 piece 8810009510 Screw BO M 2 x 4 NI-ZU IC-F11 Chassis 10