hwmnbtseframes

GERAN

Hardware

Base Transceiver Station Equipment

HWMN:BTSE Frames/Panels

A50016-G5100-A082-01-7620

2 A50016-G5100-A082-01-7620


Id:0900d805800efc24

f Important Notice on Product Safety

DANGER - RISK OF ELECTRICAL SHOCK OR DEATH - FOLLOW ALL INSTALLATION INSTRUCTIONS.

The system complies with the standard EN 60950 / IEC 60950. All equipment connected to the system must comply with the applicable safety standards.Hazardous voltages are present at the AC power supply lines in this electrical equipment. Some components may also have high operating temperatures.Failure to observe and follow all installation and safety instructions can result in serious personal injury or property damage.Therefore, only trained and qualified personnel may install and maintain the system.

The same text in German:

Wichtiger Hinweis zur Produktsicherheit

LEBENSGEFAHR - BEACHTEN SIE ALLE INSTALLATIONSHINWEISE.

Das System entspricht den Anforderungen der EN 60950 / IEC 60950. Alle an das System angeschlossenen Gerte mssen die zutreffenden Sicherheitsbestimmungen erfllen.In diesen Anlagen stehen die Netzversorgungsleitungen unter gefhrlicher Spannung. Einige Komponenten knnen auch eine hohe Betriebstemperatur aufweisen.Nichtbeachtung der Installations- und Sicherheitshinweise kann zu schweren Krperverletzungen oder Sachschden fhren.Deshalb darf nur geschultes und qualifiziertes Personal das System installieren und warten.

Caution:

This equipment has been tested and found to comply with EN 301489. Its class of conformity is defined in table A30808-X3247-X910-*-7618, which is shipped with each product. This class also corresponds to the limits for a Class A digital device, pursuant to part 15 of the FCC Rules.These limits are designed to provide reasonable protection against harmful interference when the equipment is operated in a commercial environment.This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accor-dance with the relevant standards referenced in the manual Guide to Documentation, may cause harmful inter-ference to radio communications.For system installations it is strictly required to choose all installation sites according to national and local require-ments concerning construction rules and static load capacities of buildings and roofs.For all sites, in particular in residential areas it is mandatory to observe all respectively applicable electromagnetic field / force (EMF) limits. Otherwise harmful personal interference is possible.

Trademarks:

All designations used in this document can be trademarks, the use of which by third parties for their own purposes could violate the rights of their owners.

Copyright (C) Siemens AG 2006

Issued by the Communications GroupHofmannstrae 51D-81359 Mnchen

Technical modifications possible.Technical specifications and features are binding only insofar as they are specifically and expressly agreed upon in a written contract.

Copyright (C) Siemens AG 2006

Issued by the Communications GroupHofmannstrae 51D-81359 Mnchen

Technical modifications possible.Technical specifications and features are binding only insofar as they are specifically and expressly agreed upon in a written contract.

A50016-G5100-A082-01-7620

3


Id:0900d805800efc24

Table of ContentsThis document has 124 pages.

Reason for Update . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

1 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 131.1 Purpose of the Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 131.2 Structure of the Manual. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

2 Frames . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 142.1 F:AC/DC1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 152.2 F:AC/DC2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 162.3 F:AC/DCA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 172.4 F:AC/DCD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 182.5 F:AC/DCLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 192.6 F:ACT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 202.7 F:ACOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212.8 F:ACOMBATT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 222.9 F:ACOMCUXS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 232.10 F:ACOMCU. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 242.11 F:BATTERY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 252.11.1 F:BATTERYV1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 262.11.2 F:BATTERYV2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 282.11.3 F:BATTERYV3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 302.11.4 BATTPACKV4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 322.12 F:BATTERYP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 332.13 F:BATTERY4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 342.14 BATTERYM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 352.15 BATTPACK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 362.15.1 BATTPACKF. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 362.15.2 BATTPACKM-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 362.16 F:BATTRAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 382.17 F:CORECU . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 402.18 F:CORECUXS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 412.19 F:COREP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 422.20 F:CU . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 432.21 F:FAN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 442.22 F:NT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 452.23 F:RXCU. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 462.24 MK:LE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 472.24.1 MK:LE6R-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 482.24.2 MK:LE2V1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 482.24.3 MK:LE6V2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48

3 Panels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 503.1 AC Panels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 513.1.1 ACP:AC/DC1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 513.1.2 ACP:AC/DC1/U. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 523.1.3 ACP:AC/DC2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53

4 A50016-G5100-A082-01-7620


Id:0900d805800efc24

3.1.4 ACP:AC/DCLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 543.1.5 ACP:AC/DCLE/U . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 553.2 AC/DC Panels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 563.2.1 ADPAV1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 563.2.2 ADPAV2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 583.2.3 ADPAV3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 603.2.4 ADPA/U . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 623.2.5 ADPA/UV2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 643.2.6 ADP4V1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 663.2.7 ADP4UV1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 673.2.8 ADP-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 683.3 DC Panels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 703.3.1 DCP:LEBREAK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 733.3.1.1 DCP:LEBREAKV1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 733.3.1.2 DCP:LEBREAKV2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 743.3.2 DCP:LEBREAK2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 753.3.2.1 DCP:LEBREAK2V1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 753.3.2.2 DCP:LEBREAK2V2V3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 773.3.3 F:ACTC-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 783.3.4 DCP:R12B . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 793.3.5 DCP:R12E . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 803.3.6 DCP:R12S1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 813.3.7 DCP:R12-2B . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 823.3.8 DCP:R12-2E . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 833.3.9 DCP:R-2B . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 843.3.10 DCP:R-2E . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 853.3.11 DCP:RSH4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 863.3.12 DCP:RSHB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 873.3.12.1 DCP:RSHBV1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 873.3.12.2 DCP:RSHBV2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 883.3.12.3 DCP:RSHBV3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 893.3.13 DCP:RSHE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 903.3.13.1 DCP:RSHEV1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 903.3.13.2 DCP:RSHEV2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 913.3.13.3 DCP:RSHEV3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 923.3.14 DCP:RSHS1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 933.3.14.1 DCP:RSHS1V1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 933.3.14.2 DCP:RSHS1V2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 943.3.15 DCP:RSHS2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 953.3.15.1 DCP:RSHS2V1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 953.3.15.2 DCP:RSHS2V2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 963.3.16 DCP:SER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 973.3.17 DCP:RXS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 983.4 EMI Panels. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1003.4.1 EMI-P:R12B . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1013.4.2 EMI-P:R12E . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1023.4.3 EMI-P:R4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 103

A50016-G5100-A082-01-7620

5


Id:0900d805800efc24

3.4.4 EMI-P:RB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1043.4.5 EMI-P:RE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1053.4.6 EMI-P:RS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1063.4.7 EMI-P:SERP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1073.4.8 EMI-P:SH4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1083.4.9 EMI-P:SHB / EMI-P:SH-2B . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1093.4.10 EMI-P:SH-2DC / EMI-P:SH-2BD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1103.4.11 EMI-P:SHE / EMI-P:SH-2E . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1113.4.12 EMI-P:SHS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1123.4.13 EMI-P:SHS1 / EMI-P:SH-2S1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1133.4.14 EMI-P:SHS2 / EMI-P:SH-2S2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1143.4.15 EMI-P:SHS/U . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1153.4.16 EMI-P:SHS1/U . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1163.4.17 EMI-P:BS-240XS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1173.4.18 EMI Panel Interfaces. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1183.4.18.1 PCM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1183.4.18.2 CAN-Bus . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1203.4.18.3 LPA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1203.4.18.4 -48V . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1203.4.18.5 Serial IF. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1213.4.18.6 CU #..# . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 121

Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 122

6 A50016-G5100-A082-01-7620


Id:0900d805800efc24

List of FiguresFigure 1 F:AC/DC1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15Figure 2 F:AC/DC2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16Figure 3 F:AC/DCAV1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17Figure 4 F:AC/DCD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18Figure 5 F:AC/DCLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19Figure 6 F:ACOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21Figure 7 F:ACOMBATT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22Figure 8 F:ACOMCUXSV1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23Figure 9 F:ACOMCUV1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24Figure 10 F:BATTERYV1 (Front View) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26Figure 11 F:BATTERYV1; Connection Scheme . . . . . . . . . . . . . . . . . . . . . . . . . . . 27Figure 12 F:BATTERYV2 (Front View) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28Figure 13 F:BATTERYV2; Connection Scheme . . . . . . . . . . . . . . . . . . . . . . . . . . . 29Figure 14 F:BATTERYV3 (Front View) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30Figure 15 F:BATTERYV3; Connection Scheme . . . . . . . . . . . . . . . . . . . . . . . . . . . 31Figure 16 BATTPACKV4 (Front View) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32Figure 17 BATTPACKV4; Connection Scheme . . . . . . . . . . . . . . . . . . . . . . . . . . . 32Figure 18 F:BATTERYP Front View . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33Figure 19 F:BATTERYP (Connection Scheme) . . . . . . . . . . . . . . . . . . . . . . . . . . . 33Figure 20 F:BATTERY4 (Side View). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34Figure 21 F:BATTERY4; Connection Scheme . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34Figure 22 BATTERYM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35Figure 23 BATTPACKFV1: Appearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36Figure 24 BATTPACKM-2V1: Appearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37Figure 25 F:BATTRAYV1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38Figure 26 F:BATTRAYV3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38Figure 27 F:BATTRAYBV2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39Figure 28 F:BATTRAYBV3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39Figure 29 F:CORECUV4/V5/V6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40Figure 30 F:CORECUXSV1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41Figure 31 F:COREP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42Figure 32 F:CU . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43Figure 33 F:FAN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44Figure 34 F:NT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45Figure 35 F:RXCU. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46Figure 36 MK:LE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47Figure 37 MK:LE6R-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48Figure 38 MK:LE2V1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48Figure 39 MK:LE6V2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49Figure 40 ACP:AC/DC1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51Figure 41 ACP:AC/DC1/U. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52Figure 42 ACP:AC/DC2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53Figure 43 ACP:AC/DCLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54Figure 44 ACP:AC/DCLE/U . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55Figure 45 ADPAV1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56

A50016-G5100-A082-01-7620

7


Id:0900d805800efc24

Figure 46 ADPAV2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58Figure 47 ADPAV3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60Figure 48 ADPA/UV1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62Figure 49 ADPA/UV2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64Figure 50 ADP4V1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66Figure 51 ADPUV1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67Figure 52 ADP-2: Appearance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68Figure 53 ADP-2: Connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69Figure 54 DC Panels BS-240; Common Interfaces . . . . . . . . . . . . . . . . . . . . . . . . 70Figure 55 DC Panels BS-240 II; Common Interfaces . . . . . . . . . . . . . . . . . . . . . . 71Figure 56 LMT and ETHERNET Interface; Pinning . . . . . . . . . . . . . . . . . . . . . . . . 72Figure 57 DCP:LEBREAKV1: Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73Figure 58 DCP:LEBREAKV1; DC- Terminal Block X10 . . . . . . . . . . . . . . . . . . . 74Figure 59 DCP:LEBREAKV2: Appearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74Figure 60 DCP:LEBREAKV2; DC- Terminal Block X10 . . . . . . . . . . . . . . . . . . . 74Figure 61 DCP:LEBREAK2V1: Breaker. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75Figure 62 DCP:LEBREAK2V1; DC- Terminal Block X10 . . . . . . . . . . . . . . . . . . 76Figure 63 DCP:LEBREAK2V2: Appearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77Figure 64 DCP:LEBREAK2V3: Appearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77Figure 65 F:ACTC-2V1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78Figure 66 F:ACTC-2V1: DC-Terminal Block X29 . . . . . . . . . . . . . . . . . . . . . . . . 78Figure 67 DCP:R12BV1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79Figure 68 DCP:R12EV1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80Figure 69 DCP:R12S1V1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81Figure 70 DCP:R12-2BV1: Appearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82Figure 71 DCP:R12-2BV2: Appearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82Figure 72 DCP:R12-2EV1: Appearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83Figure 73 DCP:R12-2EV2: Appearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83Figure 74 DCP:R2BV1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84Figure 75 DCP:R-2BV2: Appearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84Figure 76 DCP:R2EV1: Appearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85Figure 77 DCP:R2EV2: Appearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85Figure 78 DCP:RSH4V1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86Figure 79 DCP:RSHBV1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87Figure 80 DCP:RSHBV2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88Figure 81 DCP:RSHBV3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89Figure 82 DCP:RSHEV1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90Figure 83 DCP:RSHEV2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91Figure 84 DCP:RSHEV3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92Figure 85 DCP:RSHS1V1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93Figure 86 DCP:RSHS1V2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94Figure 87 DCP:RSHS2V1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 95Figure 88 DCP:RSHS2V2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96Figure 89 DCP:SERV1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97Figure 90 DCP BS-240XS Base Rack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98Figure 91 EMI-P:R12B (Top View)21. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101Figure 92 EMI-P:R12E (Top View). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 102

8 A50016-G5100-A082-01-7620


Id:0900d805800efc24

Figure 93 EMI-P:R4 (Top View) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 103Figure 94 EMI-P:RB (Top View) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 104Figure 95 EMI-P:RE (Top View) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 105Figure 96 EMI-P:RS (Top View) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 106Figure 97 EMI-P:SERP (Top View). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 107Figure 98 EMI-P:SH4 (Top View) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 108Figure 99 EMI-P:SHB: Appearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 109Figure 100 EMI-P:SH-2BV2: Appearance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 109Figure 101 EMI-P:SH-2DC (Top View) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 110Figure 102 EMI-P:SHE (Top View) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 111Figure 103 EMI-P:SHS (Top View) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112Figure 104 EMI-P:SHS1: Appearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 113Figure 105 EMI-P:SH-2S1V3: Appearance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 113Figure 106 EMI-P:SHS2: Appearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 114Figure 107 EMI-P:SHS/U: Appearance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 115Figure 108 EMI-P:SHS1/U (Top View) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 116Figure 109 EMI Panel BS-240XS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117

A50016-G5100-A082-01-7620

9


Id:0900d805800efc24

List of TablesTable 1 ACP:AC/DC1; Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51Table 2 ACP:AC/DC1/U; Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52Table 3 ACP:AC/DC2; Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53Table 4 ACP:AC/DCLE; Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54Table 5 ACP:AC/DCLE; Connectors. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54Table 6 ACP:AC/DCLE/U; Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55Table 7 ACP:AC/DCLE/U; Connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55Table 8 ADPAV1; AC Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57Table 9 ADPAV1; DC Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57Table 10 ADPAV1; Fuses / Switches . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57Table 11 ADPAV1; Connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57Table 12 ADPAV1; AC Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58Table 13 ADPAV2; DC Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58Table 14 ADPAV2; Fuses / Switches . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59Table 15 ADPAV2; Connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59Table 16 ADPAV3; AC Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60Table 17 ADPAV3; DC Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60Table 18 ADPAV3; Fuses / Switches . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61Table 19 ADPAV3; Connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61Table 20 ADPA/UV1; AC Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62Table 21 ADPA/UV1; DC Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62Table 22 ADPA/UV1; Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63Table 23 ADPA/UV1; Connectors. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63Table 24 ADPA/UV2; AC Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64Table 25 ADPA/UV2; DC Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64Table 26 ADPA/UV2; Fuses / Switches . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65Table 27 ADPA/UV2; Connectors. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65Table 28 ADP4V1; AC Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66Table 29 ADP4V1; DC Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66Table 30 ADP4V1; Connectors. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66Table 31 ADP4UV1; AC Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67Table 32 ADP4UV1; DC Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67Table 33 ADP4UV1; Connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67Table 34 ADP-2: AC Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68Table 35 ADP-2: DC Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68Table 36 ADP-2V1: Connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69Table 37 LMT Interface; Sub-D Pinning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72Table 38 ETHERNET Interface; RJ45 Pinning . . . . . . . . . . . . . . . . . . . . . . . . . . . 72Table 39 DCP:LEBREAKV1; Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73Table 40 DCP:LEBREAKV2; Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74Table 41 DCP:LEBREAK2; Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75Table 42 F:ACTC-2V1: Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78Table 43 DCP:R12BV1; Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79Table 44 DCP:R12EV1; Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80Table 45 DCP:R12S1V1; Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81

10 A50016-G5100-A082-01-7620


Id:0900d805800efc24

Table 46 DCP:R12-2B; Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82Table 47 DCP:R12-2E; Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83Table 48 DCP:R-2B; Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84Table 49 DCP:R-2E; Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85Table 50 DCP:RSH4V1; Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86Table 51 DCP:RSHBV1; Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87Table 52 DCP:RSHBV2; Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88Table 53 DCP:RSHBV3; Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89Table 54 DCP:RSHEV1; Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90Table 55 DCP:RSHEV2; Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91Table 56 DCP:RSHEV3; Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92Table 57 DCP:RSHS1V1; Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93Table 58 DCP:RSHS1V2; Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94Table 59 DCP:RSHS2V1; Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 95Table 60 DCP:RSHS2V2; Breakers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96Table 61 DCP:SERV1; Breakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97Table 62 DC Breakers for BS-240XS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99Table 63 Connector Names for the BS-240XS Base Rack . . . . . . . . . . . . . . . . . 117Table 64 PCM0 Interface; Pinning of 25 Pin Sub-D Connector (Without OVPT). 118Table 65 PCM1 Interface; Pinning of 25 Pin Sub-D Connector (Without OVPT). 119Table 66 Serial Interface; Pinning of 9 Pin Sub-D Connector . . . . . . . . . . . . . . . 121

A50016-G5100-A082-01-7620

11

HWMN:BTSE Frames/Panels Reason for Update

Id:0900d8058009dcbe

Reason for UpdateIssue History

Issue 01 for Release BR8.0 (2006/15/12)

F:AC/DCD (2.4)

Additional hardware: F:AC/DCDV2,

BATTPACK (2.15)

Additional hardware: BATTPACKFV1 Additional hardware: BATTPACKFV2

F:BATTRAY (2.16)

Additional hardware: F:BATTRAYBV2 Additional hardware: F:BATTRAYBV3

Issue Date Summary

Issue history for this document with order number A30808-X3247-K82-*-7620

01 06/2002 New release

02 07/2002 Extension due to additional hardware










12 10/2005 Minor changes

13 03/2006 Extension due to additional hardware: DCP:LEBREAKV2,F:ACTC-2V1

Issue history for this document with order number A50016-G5100-A082-*-7620

01 11/2006 Extension due to additional hardware: F:AC/DCDV2, ADP-2V1, DCP:LEBREAK2V2, DCP:LEBREAK2V3, DCP:R-2BV2, DCP:R-2EV2, DCP:R12-2BV2, DCP:R12-2EV2, EMI-P:SH-2S1V3, EMI-P:SH-2BV2, EMI-P:SH-2EDV1, F:BATTRAYBV2, F:BATTRAYBV3, BATTPACKFV1, BATTPACKFV2

12 A50016-G5100-A082-01-7620


Id:0900d8058009dcbe

Reason for Update

ADP-2 (3.2.8)

Additional hardware: ADP-2V1

DCP:LEBREAK2 (3.3.2)

Additional hardware: DCP:LEBREAK2V2 Additional hardware: DCP:LEBREAK2V3

DCP:R12-2B (3.3.7)

Additional hardware: DCP:R12-2BV2

DCP:R12-2E (3.3.8)

Additional hardware: DCP:R12-2EV2

DCP:R-2B (3.3.9)

Additional hardware: DCP:R-2BV2

EMI Panels (3.4)

Additional hardware: EMI-P:SH-2BV2 Additional hardware: EMI-P:SH-2BDV1 Additional hardware: EMI-P:SH-2EDV1 Additional hardware: EMI-P:SH-2EV2 Additional hardware: EMI-P:SH-2S1V2 Additional hardware: EMI-P:SH-2S1V3 Additional hardware: EMI-P:SH-2S2V2

A50016-G5100-A082-01-7620

13

HWMN:BTSE Frames/Panels Introduction

Id:0900d80580063abb

1 Introduction

1.1 Purpose of the ManualThis manual gives an overview of all frames and panels used in the various racks and shelters of all BTSE types.

A frame is the housing for several modules connected to each other via a backplane, forming one unit. A few of them have also a panel for front side connectors or fuses. One and the same frame may be installed in several racks and shelters, whereas the position and the amount of the frames differs from case to case. All frames in a rack or shelter are interconnected via specific cabling on the backplane side.

Panels can be subdivided into 3 categories:

AC Panels

DC Panels

EMI Panels

AC Panels are usually part of an AC/DC frame and provide AC breakers and a service socket in some cases. Other breakers and connectors may be placed at the AC Panel as well.

The DC breakers are united at the DC Panels for the protection of the different modules or groups of modules. Connectors for the LMT or alarm cables are also present.

EMI Panels are placed at the top of the racks or at the bottom of the shelters and function as the electromagnetically protected interface for the outside connection of a BTSE.

1.2 Structure of the ManualIn the main chapter Frames all frames are listed in alphabetical order. The drawings show the mounting position of the modules and panels. More detailed information on each module can be found in the manual HWMN:BTSE Modules by means of its mnemonic name. The relevant panels are listed in the main chapter Panels.

The main chapter Panels is subdivided in the three categories of the panels. The type of a panel can be recognized at the prefix of its mnemonic name:

ACP:xxxxx for the AC Panels

DCP:xxxxx for the DC Panels

EMI-P:xxxxxfor the EMI Panels

14 A50016-G5100-A082-01-7620


Id:0900d805800f1110

Frames

2 Frames

A50016-G5100-A082-01-7620

15

HWMN:BTSE Frames/Panels Frames

Id:0900d805800f1110

2.1 F:AC/DC1Several versions of this frame exist. There are minor differences between the versions F:AC/DC1V3, F:AC/DC1V4 and F:AC/DC1/12V1, which are not evident from outside. The versions F:AC/DC1/UV1 and F:AC/DC1/12UV1 are designed for the U.S. market and use a different AC Panel:

For the specific layout of the AC Panels (ACP:xxx) refer to the relevant subchapter in the section 3, Panels.

Figure 1 F:AC/DC1

F:AC/DC1V3 S30861-B2039-X For European market

F:AC/DC1V4 S30861-B2055-X For European market

F:AC/DC1/UV1 S30861-B2037-X For U.S. market

F:AC/DC1/12V1 S30861-B2070-X For BS-240XL European market

F:AC/DC1/12UV1 S30861-B2082-X For BS-240XL U.S. market

16 A50016-G5100-A082-01-7620


Id:0900d805800f1110

Frames

2.2 F:AC/DC2Several versions of this frame exist. There are minor differences between these versions but they are not evident from the outside:

For the specific layout of the AC Panel (ACP:AC/DC2) refer to the relevant subchapter in the section 3, Panels.

Figure 2 F:AC/DC2

F:AC/DC2V3 S30861-B2040-X

F:AC/DC2V4 S30861-B2056-X

F:AC/DC2/UV1 S30861-B2038-X

A50016-G5100-A082-01-7620

17


Id:0900d805800f1110

2.3 F:AC/DCAOnly one version of this frame exists:

For the specific layout of the AC Panels (ACP:xxx) refer to the relevant subchapter in the section 3, Panels.

Figure 3 F:AC/DCAV1

F:AC/DCAV1 S30861-B4022-X for European market

18 A50016-G5100-A082-01-7620


Id:0900d805800f1110

Frames

2.4 F:AC/DCD

For the specific layout of the AC Panels (ACP:xxx) refer to the relevant subchapter in the section Panels.

Figure 4 F:AC/DCD

F:AC/DCDV1 S30861-B4020-X For European market

F:AC/DCDV2 S30861-B4049-X For European market

A50016-G5100-A082-01-7620

19


Id:0900d805800f1110

2.5 F:AC/DCLETwo versions of this frame are designed depending on the market to be used:

Only the AC Panel (ACP:xxx) is different. All other modules and the mounting positions are identical. For the specific layout of the AC Panel refer to the relevant subchapter in the section 3, Panels.

The two slots in the lower section of the frame are intended for link equipment (LE #) which can be any kind of 19 modules and not necessarily from Siemens.

Figure 5 F:AC/DCLE

F:AC/DCLEV1 S30861-B2044-X For European market

F:AC/DCLE/UV1 S30861-B2068-X For U.S. market

20 A50016-G5100-A082-01-7620


Id:0900d805800f1110

Frames

2.6 F:ACTPlease refer to chapter 3.3.3, F:ACTC-2.

A50016-G5100-A082-01-7620

21


Id:0900d805800f1110

2.7 F:ACOMThere are several versions of this frame, all with only minor differences which are not evident from the outside:

Figure 6 F:ACOM

F:ACOMV4 S30861-B2041-X

F:ACOMV5 S30861-B2057-X

F:ACOMV6 S30861-B2096-X

22 A50016-G5100-A082-01-7620


Id:0900d805800f1110

Frames

2.8 F:ACOMBATTOnly one version of this frame exists:

Figure 7 F:ACOMBATT

F:ACOMBATTV1 S30861-B2045-X

A50016-G5100-A082-01-7620

23


Id:0900d805800f1110

2.9 F:ACOMCUXSThe frame for Antenna Combining and Carrier Units provides slots for the installation of:

Up to two Carrier Units (CU or FlexCU)

One Basic Antenna Combiner unit BCOM

Figure 8 F:ACOMCUXSV1

F:ACOMCUXSV1 S30861-B2090-X

24 A50016-G5100-A082-01-7620


Id:0900d805800f1110

Frames

2.10 F:ACOMCUOnly one version of this frame exists:

1) The module number depends on the mounting position of the frame in the rack.

Figure 9 F:ACOMCUV1

F:ACOMCUV1 S30861-B2095-X

A50016-G5100-A082-01-7620

25


Id:0900d805800f1110

2.11 F:BATTERY

Types of F:BATTERY

BATTPACKV1 S30861-U2322-X Sonnenschein; 85Ah The same Batteries as in F:BATTERYV1 without all accesso-ries.

BATTPACKV4 S30861-U4138-X Hawker; 92Ah Batteries without all acces-sories.

BATTPACKV5 S30861-U2356-X Oerlikon; 85Ah Similarly Batteries as in F:BATTERYV2 without all accessories.

BATTPACKV7 S30861-U2431-X Oerlikon; 60Ah Batteries without all acces-sories, for use in MK: BATTPACKV7.

F:BATTERYV1 S30861-B2018-X Sonnenschein; 85Ah

F:BATTERYV2 S30861-B2020-X Oerlikon; 80Ah

F:BATTERYV3 S30861-B2048-X Oerlikon; 100Ah

26 A50016-G5100-A082-01-7620


Id:0900d805800f1110

Frames

2.11.1 F:BATTERYV1Battery and mounting equipment, supplier Sonnenschein 48V (4x12V), 85Ah

Figure 10 F:BATTERYV1 (Front View)

air vent kit

fixing straps

A50016-G5100-A082-01-7620

27


Id:0900d805800f1110

Figure 11 F:BATTERYV1; Connection Scheme

+ +

++

1

2 3

4

- 48 V (blue)+ 0 V (black)

tempresistor cable(color as shown not relevant)

air vent kit (routed via EMI and IP panel outside the shelter)

28 A50016-G5100-A082-01-7620


Id:0900d805800f1110

Frames

2.11.2 F:BATTERYV2Battery and mounting equipment, supplier Oerlikon, 48V (4x12V), 80Ah


bridges

air vent kit

battery cables

Example Photo

A50016-G5100-A082-01-7620

29


Id:0900d805800f1110


+- +++ - - -

- 48 V (blue) 0 V (black)

temperature sensorcable

air venting tubes

to MK: Battery

to F:ACDC1 2 3 4

30 A50016-G5100-A082-01-7620


Id:0900d805800f1110

Frames

2.11.3 F:BATTERYV3Battery and mounting equipment, supplier Oerlikon, 48V (4x12V), 100Ah


bridges

air vent kit

battery cables

A50016-G5100-A082-01-7620

31


Id:0900d805800f1110


+- +++ - - -



air venting tubes

to MK: Battery

to F:ACDC1 2 3 4

32 A50016-G5100-A082-01-7620


Id:0900d805800f1110

Frames

2.11.4 BATTPACKV4Battery and mounting equipment, supplier Hawker, 48V (4x12V), 92Ah

Figure 16 BATTPACKV4 (Front View)

Figure 17 BATTPACKV4; Connection Scheme

bridges air vent kit battery cables

+- +++ - - -



air venting tubes

to MK: Battery

to F:ACDC1 2 3 4

A50016-G5100-A082-01-7620

33


Id:0900d805800f1110

2.12 F:BATTERYPOnly one version of this frame exists:

Battery and mounting equipment, supplier Sonnenschein 48V (4x12V), 37Ah

Figure 18 F:BATTERYP Front View

Figure 19 F:BATTERYP (Connection Scheme)

F:BATTERYPV1 S30861-B2065-X Sonnenschein; 37Ah

-+ + + +---

fixing straps

-+ + + +---

bridges

battery cables- 48 V (blue) 0 V (black)

34 A50016-G5100-A082-01-7620


Id:0900d805800f1110

Frames

2.13 F:BATTERY4There are two versions of this frame, both with only minor differences which are not evident from the outside:

Batteries and mounting equipment, supplier Sonnenschein 48V (4x12V), 12Ah

Figure 20 F:BATTERY4 (Side View)

Figure 21 F:BATTERY4; Connection Scheme

F:BATTERY4V1 S30861-B2046-X

F:BATTERY4V2 S30861-B2047-X

fixing straps

to AC/DC converters

A50016-G5100-A082-01-7620

35


Id:0900d805800f1110

2.14 BATTERYMg BATTERY can be installed with ACPSC only!Only one version of this battery exists:

Figure 22 BATTERYM

BATTERYMV1 S30861-U2153-X Sonnenschein; 4,5Ah/48V

Main Switch

BATTERYM backplane side BATTERYM front side

36 A50016-G5100-A082-01-7620


Id:0900d805800f1110

Frames

2.15 BATTPACK

2.15.1 BATTPACKFBattery Package for BS-40 II; BS240_II; BS-241 II; BS-240XL II; NB-441; SR-U; NB-881

Figure 23 BATTPACKFV1: Appearance

2.15.2 BATTPACKM-2Battery Package for BS-82II EMicro.

BATTPACKFV1 S30861-U4299-X 92 Ah 48 V (412 V) battery pack with mounting equipment

BATTPACKFV2 S30861-U4301-X 70 Ah 48 V (412 V) battery pack with mounting equipment

BATTPACKM-2V1 S30861-U2397-X 5.5 Ah 48 V (412 V) battery pack with mounting equipment

BATTPACKM-2V2 S30861-U2447-X 7 Ah 48 V (412 V) battery pack with mounting equipment

BATTPACKM-2V3 S30861-U2466-X 7 Ah 48 V (412 V) battery pack only

A50016-G5100-A082-01-7620

37


Id:0900d805800f1110

Figure 24 BATTPACKM-2V1: Appearance

Temperature sensorconnection

Protective Cover-48 V Connection

0 V Connection

Fixing strap

38 A50016-G5100-A082-01-7620


Id:0900d805800f1110

Frames

2.16 F:BATTRAY

Figure 25 F:BATTRAYV1

Figure 26 F:BATTRAYV3

Types of F:BATTRAY

F:BATTRAYV1 S30861-B4018-X

F:BATTRAYV3 S30861-B2110-X

F:BATTRAYBV2 S30861-B4068-X

F:BATTRAYBV3 S30861-B4076-X

A50016-G5100-A082-01-7620

39


Id:0900d805800f1110

Figure 27 F:BATTRAYBV2

Figure 28 F:BATTRAYBV3

40 A50016-G5100-A082-01-7620


Id:0900d805800f1110

Frames

2.17 F:CORECUSeveral versions of this frame exist:

* The Module number depends on the mounting position of the frame in the rack.

Figure 29 F:CORECUV4/V5/V6

F:CORECUV4 S30861-B2043-X



A50016-G5100-A082-01-7620

41


Id:0900d805800f1110

2.18 F:CORECUXSThe frame for CORE and Carrier Units provides slots for the installation of: Up to four Carrier Units One Core Controller module (COBA) DC Panel including the DC breakers of the rack

Figure 30 F:CORECUXSV1

F:CORECUXSV1 S30861-B2092-X

42 A50016-G5100-A082-01-7620


Id:0900d805800f1110

Frames

2.19 F:COREPg Not part of BR8.0 and aboveOnly one version of this frame exists:

Figure 31 F:COREP

F:COREPV1 S30861-B2034-X

A50016-G5100-A082-01-7620

43


Id:0900d805800f1110

2.20 F:CU


Figure 32 F:CU

F:CUV1 S30861-B2099-X

44 A50016-G5100-A082-01-7620


Id:0900d805800f1110

Frames

2.21 F:FANThree versions of this frame are designed, but there are only minor differences that are not evident from the outside:

Figure 33 F:FAN

F:FANV2 S30861-B2017-X

F:FANV3 S30861-B2064-X

F:FAN-2V1 S30861-B2087-X

A50016-G5100-A082-01-7620

45


Id:0900d805800f1110

2.22 F:NTThe following versions of this frame exist:

This frame is designed for the housing of network termination equipment. The frame has to be mounted into a rack or shelter by means of the mounting kit MK:LE.

It will require the space of 3 height units (HU), that is the height of 3 LEs as shown in the chapter 2.24, MK:LE.

Figure 34 F:NT

F:NTV1 S30861-B2022-X

F:NTV2 S30861-B4030-X

46 A50016-G5100-A082-01-7620


Id:0900d805800f1110

Frames

2.23 F:RXCUSeveral versions of this frame exist. There are minor differences between the versions but they are not evident from the outside. Version F:RXCU12V1 is designed for the BS-240XL:


Figure 35 F:RXCU

F:RXCUV4 S30861-B2042-X

F:RXCUV5 S30861-B2058-X

F:RXCUV6 S30861-B2097-X

F:RXCU12V1 S30861-B2071-X For BS-240XL

A50016-G5100-A082-01-7620

47


Id:0900d805800f1110

2.24 MK:LEOnly one version of this mounting kit exists:

Figure 36 MK:LE

MK:LEV1 S30861-K2032-X

48 A50016-G5100-A082-01-7620


Id:0900d805800f1110

Frames

2.24.1 MK:LE6R-2

Figure 37 MK:LE6R-2

2.24.2 MK:LE2V1

Figure 38 MK:LE2V1

2.24.3 MK:LE6V2

MK:LE6R-2V1 S30861-K2171-X

MK:LE2V1 S30861-K4042-X

LE

LE

MK:LE6V2 S30861-K4083-X

A50016-G5100-A082-01-7620

49


Id:0900d805800f1110

Figure 39 MK:LE6V2

50 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3 Panels

A50016-G5100-A082-01-7620

51

HWMN:BTSE Frames/Panels Panels

Id:0900d805800efd00

3.1 AC PanelsThe AC Panels are part of various frames F:AC/DCxx and provide access not only to the AC breakers, but also to specific DC breakers and in some versions to a service socket depending on the market to be used. AC and DC distribution is managed behind the panel. The AC line supply cables for the modules AC/DC are passed through gaps in the panel.

3.1.1 ACP:AC/DC1The AC Panel ACP:AC/DC1 is part of the frame F:AC/DC1 and is designed for the European market

Figure 40 ACP:AC/DC1

AC breakers and a service socket, protected by a false current switch, are provided. Additionally, DC breakers for the backup batteries are placed on the right hand side of the panel.

AC Panel Types

ACP:AC/DC1 For frame F:AC/DC1, European market

ACP:AC/DC1/U For frame F:AC/DC1, U.S. market

ACP:AC/DC2 For frame F:AC/DC, market independent

ACP:AC/DCLE For frame F:AC/DCLE, European market

ACP:AC/DCLE/U For frame F:AC/DCLE, U.S. market

Breaker Rating Meaning

FC1 25 A / 30 mA Protection for the service socket (AC)

Table 1 ACP:AC/DC1; Breakers

Service Socket FC1

BR11

BR12

BR13BR14 BR15

52 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.1.2 ACP:AC/DC1/UThe AC Panel ACP:AC/DC1/U is part of the frame F:AC/DC1 and is designed for the U.S. market

Figure 41 ACP:AC/DC1/U

BR11 20 A Mains power supply L1 (AC)



BR14 50 A BATT 0; battery 0 protection (DC)









Table 2 ACP:AC/DC1/U; Breakers

Service Socket

BR11 BR12BR13BR14

A50016-G5100-A082-01-7620

53


Id:0900d805800efd00

3.1.3 ACP:AC/DC2The AC Panel ACP:AC/DC2 is part of the frame F:AC/DC2 and is independent of the market to be used.

Figure 42 ACP:AC/DC2





BR16 BR17

54 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.1.4 ACP:AC/DCLEThe AC Panel ACP:AC/DCLE is part of the frame F:AC/DCLE and is designed for the European market

Figure 43 ACP:AC/DCLE


FC1 25 A / 30 mA Protection for the service socket (AC)



Table 4 ACP:AC/DCLE; Breakers

Connector Meaning

T0 For temperature sensor at BATT 0 (base rack/shelter)

T1 For temperature sensor at BATT 1 (service2 rack/shelter)

Table 5 ACP:AC/DCLE; Connectors

Service Socket FC 1 BR11 BR13

T1

TD

A50016-G5100-A082-01-7620

55


Id:0900d805800efd00

3.1.5 ACP:AC/DCLE/UThe AC Panel ACP:AC/DCLE/U is part of the frame F:AC/DCLE and is designed for the U.S. market

Figure 44 ACP:AC/DCLE/U





Table 6 ACP:AC/DCLE/U; Breakers

Connector Meaning

T0 For temperature sensor at BATT 0 (base rack/shelter)

T1 For temperature sensor at BATT 1 (service2 rack/shelter)

Table 7 ACP:AC/DCLE/U; Connectors

Service Socket

BR11 BR12 BR13

T1

TD

56 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.2 AC/DC PanelsVarious AC/DC Panels (ADP) are used in the BTSE racks and shelters. The AC/DC Panels provide access not only to the AC breakers and specific DC breakers, but also to connectors for internal alarms, collected by the ACTC and in some versions to a service socket depending on the market to be used. AC and DC distribution is managed behind the panel.

3.2.1 ADPAV1

Figure 45 ADPAV1

AC/DC Panel Types

ADPAV1 For European market



ADPA/U For U.S. market

ADP4V1 For European market

ADP4UV1 For U.S. market

ADP-2 for European and U.S. market

ADPAV1 S30861-D2123-X

ACT-C BR28 BR29 BR30 BR25 BR26 BR27 X29,1 X29,2 Fu01 Fu02

BR21 BR22 BR23 FISwitch

Service Socket

B-48V

E1-48V

E2-48V

E1+

E2+

B+

BAT0+

BAT1+

BAT0-48V

BAT1-48V

A50016-G5100-A082-01-7620

57


Id:0900d805800efd00

The AC/DC Panel ADPAV1 is designed for the European market





Table 8 ADPAV1; AC Breakers


BR24 10 A ACT-C DC-IN

BR25 10 A FAN

BR26 25 A S2

BR27 25 A LE

BR28 80 A B (-48V)

BR29 80 A E1 (-48V)

BR30 80 A E2 (-48V)

Table 9 ADPAV1; DC Breakers

Fuse/Switch Rating Meaning

FI Switch 30 mA Fault current protection device

Fu 01 180 A Battery supply


Table 10 ADPAV1; Fuses / Switches

Connector Meaning

X29,1 For temperature sensor at BATT 0 (base rack/shelter)

X29,2 For temperature sensor at BATT 1 (service2 rack/shelter)

Table 11 ADPAV1; Connectors

58 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.2.2 ADPAV2

Figure 46 ADPAV2


ADPAV2 S30861-D2133-X

ACT-C BR28 BR29 BR30 BR25 BR26 BR27 X29,1 X29,2 Fu01 Fu02

BR21 BR22 BR23 FISwitch

Service Socket

B-48V

E1-48V

E2-48V

E1+

E2+

B+

BAT0+

BAT1+

BAT0-48V

BAT1-48V








BR26 10 A FAN

BR27 25 A X29.1 LE

BR28 80 A B (-48V)

BR29 80 A E1 (-48V)


A50016-G5100-A082-01-7620

59


Id:0900d805800efd00

BR30 80 A E2 (-48V)



BR33 180 A Battery supply

BR 34 160 A Battery supply


Connector Meaning






60 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.2.3 ADPAV3

Figure 47 ADPAV3


ADPAV3 S30861-D2135-X

BR28 BR29 BR30 BR25 BR26 BR27 X29,1 X29,2 ACT-C

FISwitch

Service Socket

B-48V

E1-48V

E2-48V

E1+

E2+

B+

BAT0-48V

BAT1-48V

BR21 BR22 BR23 BR33








BR26 10 A FAN

BR27 25 A X29.1 LE

BR28 80 A B (-48V)

BR29 80 A E1 (-48V)

BR30 80 A E2 (-48V)


A50016-G5100-A082-01-7620

61


Id:0900d805800efd00





Connector Meaning




62 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.2.4 ADPA/U

Figure 48 ADPA/UV1

The AC/DC Panel ADPA/UV1 is designed for the US market

ADPA/UV1 S30861-D2132-X

ACT-C BR28 BR29 BR30 BR25BR26 X29,1 X29,2 Fu01 Fu02BR27

BR22 BR23 ServiceSocket

B-48V

E1-48V

E2-48V

B0V

E10V

E20V

BAT0V

BAT-48V




Table 20 ADPA/UV1; AC Breakers



BR25 10 A FAN

BR26 25 A S2

BR27 25 A LE

BR28 80 A B (-48V)

BR29 80 A E1 (-48V)

BR30 80 A E2 (-48V)

Table 21 ADPA/UV1; DC Breakers

A50016-G5100-A082-01-7620

63


Id:0900d805800efd00

Fuse Rating Meaning



Table 22 ADPA/UV1; Fuses

Connector Meaning



Table 23 ADPA/UV1; Connectors

64 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.2.5 ADPA/UV2

Figure 49 ADPA/UV2

The AC/DC Panel ADPA/UV2 is designed for the US market

ADPA/UV2 S30861-D2134-X

ACT-CBR28 BR29 BR30 BR25 BR26 BR27 X29,1 X29,2

Service Socket

B-48V

E1-48V

E2-48V

E1+

E2+

B+

BAT0+

BAT0-48V

BR33BR21 BR22 BR23


BR21 Not used



Table 24 ADPA/UV2; AC Breakers



BR26 10 A FAN

BR27 25 A X29.1 LE

BR28 80 A B (-48V)


A50016-G5100-A082-01-7620

65


Id:0900d805800efd00

BR29 80 A E1 (-48V)

BR30 80 A E2 (-48V)



Table 26 ADPA/UV2; Fuses / Switches

Connector Meaning



Table 27 ADPA/UV2; Connectors



66 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.2.6 ADP4V1

Figure 50 ADP4V1

The AC/DC Panel ADP4V1 is designed for the European market

ADP4V1 S30861-D2137-X

X107 FAN

BR22 BR23 FISwitch

Service Socket

BAT1-48V

BAT10V

BR33 BAT00V

BAT0-48V


BR22 25 A Mains power supply L (AC)

BR23 25 A Mains power supply N (AC)

Table 28 ADP4V1; AC Breakers



Table 29 ADP4V1; DC Breakers

Connector Meaning

X107 Testconnector

Table 30 ADP4V1; Connectors

A50016-G5100-A082-01-7620

67


Id:0900d805800efd00

3.2.7 ADP4UV1

Figure 51 ADPUV1

The AC/DC Panel ADP4UV1 is designed for the US market

ADP4UV1 S30861-D2138-X

X107 FAN

BR21 BR22 Service Socket

BAT1-48V

BAT10V

BR33 BAT00V

BAT0-48V




Table 31 ADP4UV1; AC Breakers



Table 32 ADP4UV1; DC Breakers

Connector Meaning

X107 Testconnector

Table 33 ADP4UV1; Connectors

68 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.2.8 ADP-2

Figure 52 ADP-2: Appearance

g The AC/DC Panel in fig. ADP-2V1: Appearance is shown including a mounting kit for power supply with three phases. Mounting kits for 2 or 1 phase connection are also available.

Breakers

Connectors

The connectors for DC power supply of base shelter, extension shelters and battery are hidden behind the right cover plate.

ADP-2V1 S30861-D4026-X AC/DC Panel 2nd Generation





Table 34 ADP-2: AC Breakers


BR30 80 A Extension 2 cabinet

BR29 80 A Extension 1 cabinet

BR28 80 A Base cabinet

BR33 180 A Battery

Table 35 ADP-2: DC Breakers

A50016-G5100-A082-01-7620

69


Id:0900d805800efd00

Figure 53 ADP-2: Connectors

Connector Meaning

E2 -48 V Extension 2 cabinet

GND 0 V

E1 -48 V Extension 1 cabinet

GND 0 V

Base -48 V Base cabinet

GND 0 V

Batt -48 V Battery

GND 0 V

Table 36 ADP-2V1: Connectors

70 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.3 DC Panels

Various DC Panels are used in the BTSE racks and shelters. Apart from the DC breakers (mainly on the left hand side of the panel), the connectors for internal alarms, collected by the ACTC, are provided on the right hand side. Connectors for the LMT and the ETHERNET access are also available, but for base rack panels only.

Figure 54 DC Panels BS-240; Common Interfaces

Types of DC Panels

DCP:LEBREAK link equipment breaker for service 2 rack - 2nd design

DCP:LEBREAK2 link equipment breaker for service 1 rack - 2nd design

F:ACTC-2 frame for ACTC - 2nd design

DCP:R12B DC-Panel for BS-240 XL base cabinet

DCP:R12E DC-Panel for BS-240 XL extension cabinet

DCP:R12S1 DC-Panel for BS-240 XL service 1 cabinet

DCP:R12-2B DC-Panel for BS-240 XL II base cabinet

DCP:R12-2E DC-Panel for BS-240 XL II extension cabinet

DCP:R-2B DC-Panel for BS-240 II / BS-241 II base cabinet

DCP:R-2E DC-Panel for BS-240 II / BS-241 II extension cabinet

DCP:RSH4 DC-Panel for BS-40 / BS-41 base / service cabinet

DCP:RSHB DC-Panel for base cabinet

DCP:RSHE DC-Panel for extension cabinet

DCP:RSHS1 DC-Panel for service 1 cabinet

DCP:RSHS2 DC-Panel for service 2 cabinet

DCP:SER DC-Panel for PicoBTS server

DCP:RXS DC-Panel for BS-240 XS base cabinet

ETHERNET connector LMT connector

For the specifc DC breakers refer to the relevant subchapter

For detailed information, see ACTC

A50016-G5100-A082-01-7620

71


Id:0900d805800efd00

Figure 55 DC Panels BS-240 II; Common Interfaces

ETHERNET connector LMT connector

For the specifc DC breakers refer to the relevant subchapter

For detailed information, see ACTC

From Service Rack

OV -48V

72 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

LMT and ETHERNET Interface

The connectors for the LMT and ETHERNET are located at the DC Panel and the pinning is as follows:

Figure 56 LMT and ETHERNET Interface; Pinning

Pin No. Signal Name Pin No. Signal Name Pin No. Signal Name

1 --- 6 LMT_SA 11 LMT_RB

2 LMT_TA 7 --- 12 LMT_IB

3 LMT_CA 8 GND 13 LMT_SB

4 LMT_RA 9 GND 14 ---

5 LMT_IA 10 LMT_TB 15 ---

Table 37 LMT Interface; Sub-D Pinning

RJ45 Pin No. Signal Name RJ45 Pin No. Signal Name

1 10BT_TD+ 2 10BT_TD-

3 10BT_RD+ 4 ---

5 --- 6 10BT_RD-

7 --- 8 ---

Table 38 ETHERNET Interface; RJ45 Pinning

1

8

9

15 1 8

Sub-D RJ45

A50016-G5100-A082-01-7620

73


Id:0900d805800efd00

3.3.1 DCP:LEBREAKThe Frame DCP:LEBREAK is a power distribution frame. It is used in several cabinets: service 1a cabinet: if link equipment is installed into the cabinet service 2 cabinet: to extend the amount of breakers for link equipment. (the manda-

tory frame DCP:LEBREAK2 offers 6 breakers)

3.3.1.1 DCP:LEBREAKV1

Figure 57 DCP:LEBREAKV1: Breakers

g The total electric current must not exeed 50 A.If a breaker with a rating of 25 A is used, the neighboring breakers must not exeed a rating of 4 A.

Types of DCP:LEBREAK

DCP:LEBREAKV1 S30861-D2122-X

DCP:LEBREAKV2 S30861-D2143-X

Breaker Rating Connected to

BR01 Max. 25A LE/Wave 0








Table 39 DCP:LEBREAKV1; Breakers

BR01 BR08

74 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

Figure 58 DCP:LEBREAKV1; DC- Terminal Block X10

3.3.1.2 DCP:LEBREAKV2

Figure 59 DCP:LEBREAKV2: Appearance

g The total electric current must not exeed 50 A.If a breaker with a rating of 25 A or more is used, the neighboring breakers must not exeed a rating of 4 A.

Figure 60 DCP:LEBREAKV2; DC- Terminal Block X10

1 2

0V -48V

3 4


BR01 Max. 25 A LE/Wave 0








Table 40 DCP:LEBREAKV2; Breakers

1 2

0V -48V

A50016-G5100-A082-01-7620

75


Id:0900d805800efd00

3.3.2 DCP:LEBREAK2The DCP:LEBREAK2 is a power distribution frame. It is present in each service 2 cabinet.

It offers 6 breakers for link equipment. If more breakers are required, an additional frame DCP:LEBREAK can be installed.

3.3.2.1 DCP:LEBREAK2V1

Figure 61 DCP:LEBREAK2V1: Breaker

g The total electric current must not exeed 25 A.

Types of DCP:LEBREAK2

DCP:LEBREAK2V1 S30861-D2126-X 25 A DC terminals, ACTC3










BR07 10 A ACTC:FAN if frame F:FAN-2 installed

Max. 25 A LE / Wave 6

BR08 10 A ACTC:DC IN, ACTP, smoke detector

Table 41 DCP:LEBREAK2; Breakers

BR01 BR08

76 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

If a breaker with a rating of 25 A is used, the neighboring breakers must not exeed a rating of 4 A.

Figure 62 DCP:LEBREAK2V1; DC- Terminal Block X10

1 2

0V-48V

A50016-G5100-A082-01-7620

77


Id:0900d805800efd00

3.3.2.2 DCP:LEBREAK2V2V3

Figure 63 DCP:LEBREAK2V2: Appearance

Figure 64 DCP:LEBREAK2V3: Appearance

g The total electric current must not exeed 50 A.If a breaker with a rating of 25 A is used, the neighboring breakers must not exeed a rating of 4 A.

78 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.3.3 F:ACTC-2

Figure 65 F:ACTC-2V1

Figure 66 F:ACTC-2V1: DC-Terminal Block X29

ACTC

For detailed information please refer to book HW:BTSE Modules, chapterM:ACTC-4.

Types of F:ACTC-2

F:ACTC-2V1 S30861-B2116-X


BR25 Max. 10 A ACTC / FAN

BR26 Max. 10 A FAN

BR27 Max. 50 A LE/Wave

Table 42 F:ACTC-2V1: Breakers

X29 BR27BR25

ACTCBR26

0 V

-48 V

A50016-G5100-A082-01-7620

79


Id:0900d805800efd00

3.3.4 DCP:R12B

Figure 67 DCP:R12BV1

Types of DCP:R12B

DCP:R12BV1 S30861-D2011-X

Breaker Rating Inrush Curve

Connected to

BR01 16 A Medium CU 0/1






BR07 10 A Medium DIAMCO / ACOM / ACT P/ SMOKE

BR08 10 A Medium Internal FAN

BR09 4 A Medium CORE (=COBA,COSA) / DC 0

BR10 4 A Medium Redundant CORE (=COBA,COSA) / DC 1

BR11 4 A Medium DC external

Table 43 DCP:R12BV1; Breakers

BR01 BR11

80 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.3.5 DCP:R12E

Figure 68 DCP:R12EV1

Types of DCP:R12E

DCP:R12EV1 S30861-D2012-X

DCP:R12-2EV1 S30861-D2029-X


Connected to

BR01 16A Medium CU 0/1






BR07 10A Medium DIAMCO / ACOM / ACT P/ SMOKE

BR08 10A Medium Internal FAN

Table 44 DCP:R12EV1; Breakers

BR01 BR08

A50016-G5100-A082-01-7620

81


Id:0900d805800efd00

3.3.6 DCP:R12S1

Figure 69 DCP:R12S1V1

Types of DCP:R12S1

DCP:R12S1V1 S30861-D2013-X


Connected to

BR01 50A Long SERVICE 2 RACK

BR02 80A Long BASE RACK

BR03 80A Long EXTENSION 1 RACK

BR04 4A Medium ACT P / SMOKE

BR05 10A Medium INTERNAL FAN

BR06 10A Medium LE 0-2


Table 45 DCP:R12S1V1; Breakers

BR01 BR11

82 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.3.7 DCP:R12-2B

Figure 70 DCP:R12-2BV1: Appearance

Figure 71 DCP:R12-2BV2: Appearance

Types of DCP:R12-2B

DCP:R12-2BV1 S30861-D2128-X with ACTC-3

DCP:R12-2BV2 S30861-D2146-X with ACTC-4


Connected to







BR07 10A Medium DIAMCO, ACOM, ACT M

BR08 16A Medium FAN 07, ACT, SMOKE

BR09 4A Medium CORE 0, CORE 1


Table 46 DCP:R12-2B; Breakers

BR01 BR10

A50016-G5100-A082-01-7620

83


Id:0900d805800efd00

3.3.8 DCP:R12-2E

Figure 72 DCP:R12-2EV1: Appearance

Figure 73 DCP:R12-2EV2: Appearance

Types of DCP:R12-2E

DCP:R12-2EV1 S30861-D2129-X

DCP:R12-2EV2 S30861-D2147-X


Connected to







BR07 10A Medium DIAMCO / ACOM / ACTP

BR08 16A Medium FAN 07, ACT, SMOKE

BR09 -- -- Not used, if present

Table 47 DCP:R12-2E; Breakers

BR01 BR09

84 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.3.9 DCP:R-2B

Figure 74 DCP:R2BV1

Figure 75 DCP:R-2BV2: Appearance

Types of DCP:R-2B

DCP:R-2BV1 S30861-D2021-X

DCP:R-2BV2 S30861-D2144-X


Connected to





BR05 10A Medium DIAMCO / ACOM / ACT M

BR06 10A Medium FAN 0...5, SMOKE



Table 48 DCP:R-2B; Breakers

BR01 BR08

BR01 BR08

A50016-G5100-A082-01-7620

85


Id:0900d805800efd00

3.3.10 DCP:R-2E

Figure 76 DCP:R2EV1: Appearance

Figure 77 DCP:R2EV2: Appearance

Types of DCP:R-2E

DCP:R-2EV1 S30861-D2124-X

DCP:R-2EV2 S30861-D2145-X


Connected to





BR05 10A Medium DIAMCO, ACOM, ACTP

BR06 10A Medium FAN 05, SMOKE, ACT

Table 49 DCP:R-2E; Breakers

BR01 BR06

86 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.3.11 DCP:RSH4

Figure 78 DCP:RSH4V1

Types of DCP:RSH4

DCP:RSH4V1 S30861-D2006-X


Connected to

BR01 16A Medium BP:CU 0/1


BR03 4A Medium BP: DIAMCO; BP: ACOM / ACT P/ SMOKE (not BS-40 U)


BR05 4A Medium BP: CORE / COBA, COSA

BR06 4A Medium BP: CORE / COBA, COSA Red.

BR07 4A Medium -48V EXTERNAL


BR09 50A Medium DC Service Rack

BR10 50A Medium BAT Service Rack

Table 50 DCP:RSH4V1; Breakers

BR01 BR11

A50016-G5100-A082-01-7620

87


Id:0900d805800efd00

3.3.12 DCP:RSHB

3.3.12.1 DCP:RSHBV1

Figure 79 DCP:RSHBV1

Types of DCP:RSHB

DCP:RSHBV1 S30861-D2001-X




Connected to









BR09 4A Medium DC external

BR10 10A Medium EXTERNAL FAN (HEX) only installed in shelter with HEX

Table 51 DCP:RSHBV1; Breakers

BR01 BR10

88 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.3.12.2 DCP:RSHBV2



Connected to











BR01 BR09

A50016-G5100-A082-01-7620

89


Id:0900d805800efd00

3.3.12.3 DCP:RSHBV3



Connected to











BR01 BR09

90 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.3.13 DCP:RSHE

3.3.13.1 DCP:RSHEV1

Figure 82 DCP:RSHEV1

Types of DCP:RSHE

DCP:RSHEV1 S30861-D2002-X




Connected to








Table 54 DCP:RSHEV1; Breakers

BR01 BR06 BR10

A50016-G5100-A082-01-7620

91


Id:0900d805800efd00

3.3.13.2 DCP:RSHEV2



Connected to








BR01 BR06

92 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.3.13.3 DCP:RSHEV3



Connected to








BR01 BR06

A50016-G5100-A082-01-7620

93


Id:0900d805800efd00

3.3.14 DCP:RSHS1

3.3.14.1 DCP:RSHS1V1

Figure 85 DCP:RSHS1V1

Types of DCP:RSHS1

DCP:RSHS1V1 S30861-D2003-X



Connected to

BR01 50A Long SERVICE 2 RACK/SHELTER

BR02 50A Long EXTENSION 2 RACK/SHELTER


BR04 50A Long BASE RACK/SHELTER

BR05 4A Medium ACT P / SMOKE (not BS-241 U)





Table 57 DCP:RSHS1V1; Breakers

BR01 BR08 BR10

94 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels




Connected to

BR01 50A Long SERVICE 2 RACK/SHELTER



BR04 50A Long BASE RACK/SHELTER






BR01 BR08

A50016-G5100-A082-01-7620

95


Id:0900d805800efd00

3.3.15 DCP:RSHS2



Types of DCP:RSHS2




Connected to








BR05 BR10

96 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels




Connected to







BR05 BR9

A50016-G5100-A082-01-7620

97


Id:0900d805800efd00

3.3.16 DCP:SER

g Not part of BR8.0 and above

Figure 89 DCP:SERV1

Types of DCP:SER

DCP:SERV1 S30861-D2005-X


Connected to

BR01 16A Medium CCINT 0






BR07 4A Medium CORE, ACTM

BR08 4A Medium Redundant CORE

BR09 4A Medium 48V external

BR10 10A Medium FAN

Table 61 DCP:SERV1; Breakers

BR01 BR10

98 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.3.17 DCP:RXS

Figure 90 DCP BS-240XS Base Rack

Types of DCP

DCP:RXSV1 S30861-D2127-X

LMT Interface

Ethernet Interface

BR01- BR02 for CU 0-3

BR03 = CU 4-5BR04 = FAN 0-1,COBA, BCOM,ACTC

A50016-G5100-A082-01-7620

99


Id:0900d805800efd00


BR01 16A CU 0-1

BR02 16A CU 2-3

BR03 16A CU 4-5

BR04 16A FAN 0-1, COBA, BCOM, ACTC

Table 62 DC Breakers for BS-240XS

100 A50016-G5100-A082-01-7620


Id:0900d805800efd00

Panels

3.4 EMI Panels

In order to fulfill the EMC requirements, all external cabling to/from the racks/shelters is lead through the EMI Panel. For the AC and DC power supply the attendant electromag-netic noise is blocked by means of EMI-filters which are part of the corresponding Mains Supply Unit (MSU). Cable entry bars secure a good electrical connection between the screen of the coax jumper cables and the EMI gasket. Other interfaces are protected by using appropriate connectors with internal filters.

Types of EMI Panels

EMI-P:R12B for base rack BS-240XL

EMI-P:R12E for extension rack BS-240XL

EMI-P:R4 for base rack BS-40

EMI-P:RB for base rack BS-240

EMI-P:RE for extension rack

EMI-P:RS for service rack

EMI-P:SERP for server rack BS-242 Pico

EMI-P:SH4 for base shelter BS-41

EMI-P:SHB / EMI-P:SH-2B for base shelter BS-241 / 241 II

EMI-P:SH-2DC / EMI-P:SH-2BD for base shelter BS-241 II DC

EMI-P:SHE / EMI-P:SH-2E for extension shelter

EMI-P:SHS for service shelter

EMI-P:SHS1 / EMI-P:SH-2S1 for service1 shelter

EMI-P:SHS2 / EMI-P:SH-2S2 for service2 shelter

EMI-P:SHS/U for service shelter, U.S. market

EMI-P:SHS1/U for service1 shelter, U.S. market

EMI-P:BS-240XS for BS-240XS

A50016-G5100-A082-01-7620

101


Id:0900d805800efd00

3.4.1 EMI-P:R12BOnly one version of this panel e

Documents

hwmnbtseframes