Embed Size (px)
Citation preview
Technical Service Bulletin
Subject
Group
CIRCULATE TO: [ ] GENERAL MANAGER
[X] SERVICE MANAGER[X] SERVICE ADVISOR [X] WARRANTY
[X] PARTS MAN
TRANSAXLE
Number09-AT-017
DateSEPTEMBER, 2009
2006~ SONATA, 2001~ ELANTRA,
ModelMGR
AGER
SANTA FE & XG300/350, 2003~ TIBURON, 2005~ TUCSON, 2006~
AZERA, 2007~ ENTOURAGE
AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST
[ ] SALES MANAGER
[X] TECHNICIAN
This TSB supersedes TSB 08-AT-001 to provide 2009 model information.
NOTE: The printed shop manuals listed below are the last publications available. Shop manuals are online at hmaservice.com for other models.
DESCRIPTION:
Always check for DTCs in both “Engine” and “Automatic Transaxle” menus. When canceling DTCs, it is necessary to cancel codes separately in both menus.
DTC information can be found in the shop manuals and TSBs listed below:
.
DTC DESCRIPTION
SHOP MANUAL REFERENCE PAGE
TSB2009
SONATA2008
ELANTRA2008
TIBURON
2008SANTA
FE
2009AZERA
2009 TUCSON
2008 ENTOU-RAGE
P0500 Vehicle speed sensor circuit malfunction N/A N/A N/A 2004:
FL-26 N/A N/A N/A 00-36-011
P0501 Vehicle speed sensor range/performance FLA-545 FL-346 FL-328
FLA-381FL-489
FLA-474 FL-507 FL-328FLA-370 FL-489 00-36-011
P0504 Brake switch A/B FL-364 FLA-550
P0560 System voltage FL-387 FL-365FL-344
FLA-401 AT-19
N/A N/AFL-343
FLA-386AT-48
N/A
Page 1 of 5
DTC DESCRIPTION
SHOP MANUAL REFERENCE PAGE
TSB2009
SONATA2008
ELANTRA2008
TIBURON
2008SANTA
FE
2009AZERA
2009 TUCSON
2008 ENTOU-RAGE
P0605 EEPROM abnormal 2008:FL-445
FL-374AT-32
FL-353FLA-408
AT-22N/A N/A
FL-351FLA-394
AT-50N/A
P0606 ECM/PCM processor (ECM-self test failed) FLA-591 FL-377 N/A FL-541
FLA-524 FL-547 N/A FL-537
P061BInternal control mod-ule torque calculation performance
FLA-592 N/A N/A FL-542FLA-525 FL-548 N/A FL-539
P0630VIN not programmed or incompatible ECM/PCM
FL-408FLA-593 FL-386 FL-356
FLA-411FL-544
FLA-526 FL-549 FL-353FLA-396 FL-541
P0700 TCU request for MIL On
2008: FL-495 FL-392 FL-362
FLA-417 N/A N/A FL-357FLA-413 N/A 05-40-011
P0703 Stop lamp switch - short circuit
2008:AT-62 N/A AT-24 N/A N/A AT-52 N/A
P0705 Range switch signal problem N/A N/A N/A N/A N/A N/A N/A 09-AT-013
P0707 Range switch - open circuit
AT-8 ATA-10 AT-34 AT-30 AT-48
ATA-20 AT-21 AT-56 AT-20 09-AT-013
P0708 Range switch - multi-ple inputs
AT12 ATA-15 AT-40 AT-37 AT-55
ATA-25 AT-27 AT-61 AT-26 09-AT--013
P0711 A/T temperature sen-sor - rationality check
AT-14 ATA-17 AT-43 AT-41 AT-58 AT-29 AT-63 N/A 04-40-016
07-40-012
P0712 A/T temperature sen-sor signal - short circuit
AT-19 ATA-21 AT-49 AT-47 AT-64
ATA-28 AT-35 AT-68 AT-29 04-40-01607-40-012
P0713 A/T temperature sen-sor signal - open circuit
AT-20 ATA-22 AT-50 AT-50 AT-66
ATA-34 AT-36 AT-71 AT-36 04-40-01607-40-012
P0715 No input speed sen-sor signal - open/short N/A N/A AT-55 N/A N/A AT-74 N/A 08-AT-014
09-AT-016
P0716 Input speed sensor range/performance N/A AT-53 N/A N/A N/A N/A N/A 08-AT-014
09-AT-016
P0717 Input speed sensor cir-cuit - no signal
AT-22 ATA-24 AT-60 AT-62 AT-69
ATA-36 AT-38 AT-79 AT-38 08-AT-01409-AT-016
P0720 No output speed sen-sor signal - open/short N/A N/A AT-65 N/A N/A AT-84 N/A 08-AT-014
09-AT-016
P0721No output speed sen-sor signal - open/short AT-27 N/A AT-71 N/A N/A AT-89 N/A 09-AT-016
P0722 Output speed sensor circuit - no signal
AT-32 ATA-29 AT-62 AT-75 AT-76
ATA-43 AT-44 AT-94 AT-46 08-AT-01409-AT-016
P0725 Crankshaft position sensor system
2004: TR-19TR-39
N/A N/A N/A N/A N/A N/A 03-40-006
P0731 1st gear incorrect ratio AT-33 ATA-34 AT-69 AT-77 AT-83
ATA-49 AT-48 AT-97 AT-53 03-40-005
Page 2 of 5
Technical Service Bulletin
Group
Number
TRANSAXLE
09-AT-017
DTC DESCRIPTION
SHOP MANUAL REFERENCE PAGE
TSB2009
SONATA2008
ELANTRA2008
TIBURON
2008SANTA
FE
2009 AZERA
2009 TUCSON
2008 ENTOU-RAGE
P0732 2nd gear incorrect ratio AT-38 ATA-39 AT-76 AT-83 AT-89
ATA-55 AT-53 AT-101 AT-59 03-40-005
P0733 3rd gear incorrect ratio AT-43 ATA-43 AT-82 AT-88 AT-94
ATA-60 AT-57 AT-105 AT-64 03-40-005
P0734 4th gear incorrect ratio AT-48 ATA-47 AT-88 AT-93 AT-99
ATA-65 AT-61 AT-109 AT-69 03-40-005
P0735 5th gear incorrect ratio ATA-51 N/A N/A ATA-69 AT-65 N/A AT-73 03-40-005
P0736 Reverse gear incor-rect ratio ATA-55 N/A AT-97 N/A N/A 2008:
AT-137 N/A 03-40-005
P0740Torque converter clutch control system problem
N/A N/A N/A 2004:TR-48 N/A N/A N/A 05-40-006
P0741 Torque converter clutch stuck off
AT-52 ATA-59 AT-92 AT-102 AT-103
ATA-73 AT-69 AT-112 AT-77 05-40-00609-AT-011
P0742 Torque converter clutch stuck on ATA-61 AT-96 AT-105 AT-106
ATA-77 AT-71 AT-114 AT-81 05-40-00609-AT-011
P0743 TCC solenoid valve - open/short
AT-54 ATA-62 AT-100 AT-108 AT-109
ATA-80 AT-73 AT-116 AT-84 05-40-00609-AT-011
P0746Pressure control sole-noid valve A (VFS) - Performance
2008:ATA-100 N/A N/A N/A AT-76 N/A N/A 05-40-006
P0748Pressure control sole-noid valve A (VFS) - Electrical
ATA-66 AT-108 N/A AT-117ATA-88 AT-85 N/A AT-92 05-40-006
09-AT-011
P0750 L & R solenoid valve - open/short
AT-58 ATA-72 AT-116 AT-114 AT-124
ATA-95 AT-88 AT-121 AT-99 05-40-00609-AT-011
P0755 UD solenoid valve - open/short
AT-62 ATA-77 AT-124 AT-120 AT-131
ATA-103 AT-93 AT-125 AT-106 05-40-00609-AT-011
P0760 2ND solenoid valve - open/short
AT-66 ATA-82 AT-133 AT-126 AT-138
ATA-110 AT-98 AT-130 AT-113 05-40-00609-AT-011
P0765 OD solenoid valve - open/short
AT-70 ATA-88 AT-141 AT-131 AT-145
ATA-117 AT-104 AT-134 AT119 05-40-00609-AT-011
P0770 RED solenoid valve - open/short
AT-75ATA-94 N/A N/A ATA-124 AT-110 N/A AT-125 05-40-006
P0880 TCM power signal error AT-80 AT-149 N/A N/A N/A N/A N/A
P0885 A/T relay circuit mal-function ATA-100 N/A AT-137 AT-152
ATA-131 AT-116 AT-138 AT-131 04-40-015
P0890 A/T relay - low circuit ATA-105 N/A N/A AT-157ATA-137 AT-122 N/A AT-138
Page 3 of 5
DTC DESCRIPTION
SHOP MANUAL REFERENCE PAGE
TSB2009
SONATA2008
ELANTRA2008
TIBURON
2008SANTA
FE
2008AZERA
2009 TUCSON
2008 ENTOU-RAGE
P0891 A/T relay - open circuit ATA-106 N/A N/A AT-158ATA-138 AT-124 N/A AT-140
P1500 Vehicle speed sensor - open/short N/A N/A AT-144 N/A N/A AT-143 N/A
P1529TCM MIL request to ECM (Check “Trans” menu for DTC)
N/A N/A 2004:FL-285
2004:FL-413 N/A N/A N/A 00-40-012
P1602 Serial communication line problem with TCM N/A N/A 2004:
FL-2862004:
FL-414 N/A N/A N/A
P1603 CAN communication BUS OFF N/A N/A N/A N/A N/A 2007:
AT-185 N/A
P1604 No ID from ECU to CAN N/A N/A N/A N/A N/A 2007: AT-
188 N/A
P1630 CAN BUS - off N/A N/A N/A 2004:TR-25 N/A N/A N/A
P1631 CAN - time out ECM N/A N/A N/A 2004:TR-25 N/A N/A N/A
P1701 TPS signal to TCM malfunction N/A N/A N/A N/A N/A N/A N/A
P1702 TPS misadjustment N/A N/A N/A 2004:TR-41 N/A N/A N/A
P1703 TPS voltage low - open circuit N/A N/A 2004:
TR-292004:TR-41 N/A N/A N/A
P1704 TPS voltage high - short circuit N/A N/A 2004:
TR-292004:TR-41 N/A N/A N/A
P1707Auto cruise control brake switch malfunc-tion
N/A N/A N/A 2004:FLA-24 N/A N/A N/A
P1716Steering wheel angle sensor signal (CAN error)
N/A N/A N/A N/A N/A 2005:TR-22 N/A
P1717 Steering wheel angle sensor 1 - input signal N/A N/A N/A N/A N/A 2005:
TR-36 N/A
P1718 Steering wheel angle sensor 2 - Input signal N/A N/A N/A N/A N/A 2005:
TR-42 N/A
P1719 Steering wheel angle sensor C - Input signal N/A N/A N/A N/A N/A 2005:
TR-46 N/A
P1723 A/T control relay - open/short N/A N/A N/A 2004:
TR-54 N/A N/A N/A 04-40-015
P1726 Acceleration pedal position signal N/A N/A N/A N/A N/A 2005:
TR-49 N/A
P1728 Electromagnetic clutch open/short to battery N/A N/A N/A N/A N/A 2005:
TR-55 N/A
P1729 Electromagnetic clutch shorted to ground N/A N/A N/A N/A N/A 2005:
TR-61 N/A
Page 4 of 5
Technical Service Bulletin
Group
Number
TRANSAXLE
09-AT-017
CAN COMMUNICATION DTC:
DTC DESCRIPTION
SHOP MANUAL REFERENCE PAGE
TSB2009
SONATA2008
ELANTRA2008
TIBURON
2008SANTA
FE
2009 AZERA
2009 TUCSON
2008 ENTOU-RAGE
P1738 4WD ECU invalid part number N/A N/A N/A N/A N/A 2005:
TR-22 N/A
P1749 Serial communication link - open/short N/A N/A N/A 2004:
TR-25 N/A N/A N/A
P1750 Wheel speed sensor signal (FL) N/A N/A N/A N/A N/A 2005:
TR-63 N/A
P1751 Wheel speed sensor signal (FR) N/A N/A N/A N/A N/A 2005:
TR-69 N/A
P1752 Wheel speed sensor signal (RL) N/A N/A N/A N/A N/A 2005:
TR-75 N/A
P1753 Wheel speed sensor signal (RR) N/A N/A N/A N/A N/A 2005:
TR-81 N/A
P1764 CAN controller circuit malfunction N/A N/A N/A 2004:
TR-25 N/A 2005:TR-87 N/A
P1765 TCS-4WD CAN error N/A N/A N/A N/A N/A 2005:TR-93 N/A
P1766 CAN communication BUS off N/A N/A N/A N/A N/A 2005:.
TR-22 N/A
P1767 ABS active signal (CAN error) N/A N/A N/A N/A N/A 2005:
TR-22 N/A
DTC DESCRIPTION
SHOP MANUAL REFERENCE PAGE
TSB2009
SONATA2008
ELANTRA
2008TIBU-RON
2008SANTA
FE
2009 AZERA
2009 TUC-SON
2008 ENTOU-RAGE
U0001 CAN communication BUS OFF
FL-571FLA-784
AT-84
FL-450AT-153
FL-378AT-146
FL-780FLA-748 FL-737 FL-372
AT-144 FL-757
U0100 CAN-time out ECM AT-87 AT-157 AT-148 N/A N/A FLA-48AT-147 N/A
U0101Serial communication problem with TCM (timeout)
FL-575 FL-456 FL-386FLA-434 N/A N/A FL-377
FLA-428 N/A
Page 5 of 5
