H O INTERNATIONAL SA WATER FILTER AND · PDF fileSpun sediment filters are ALWAYS made of polypropylene. Polypropylene is a type of thermoplastic that can be melted and bonded which

H2O INTERNATIONAL SA

WATER FILTER AND PURIFIER CARTRIDGE PRICELIST

A FEW NOTES ON SEDIMENT FILTERS All sediment filters are measured and classified according to their filtration capability

based on micron (µm) size.

By definition, a micron is a metric unit of length equal to one thousandth of a millimeter,

which is smaller than can been seen by the naked eye. The diameter of a human hair is

roughly 25 microns.

If a filter is rated to be 5 micron nominal then it means that 80% of pores on that filter are

5 micron and the rest could be larger.

If a filter is rated to be 5 micron absolute then 99.9% of the pores are 5 micron and the

rest could be larger.

All sediment filters lower the water pressure of a given water source. Sediment filters

require very little water pressure to operate - about 5 psi.

DIFFERENT TYPES OF SEDIMENT FILTERS

Spun "Melt blown" Sediment Filters

These types of filters are most economical and are

most widely seen on the market.

They are noticeable for their hard cotton-like

appearance.

Typically, these are made of 3-4 different layers and

are usually made to have the largest micron on the

outer most layers to the smallest micron on the inner

most layers.

The rating of the filter is based on the smallest micron

and most inner layer of that filter.

A spun polypropylene filter with this type of construction is

known as a depth filter or graded density filter. To be a true

depth filter, a cartridge must be able to retain contaminants

throughout the entire cross section of the filter.

A graded density allows larger particles to be trapped near

the surface while smaller particles penetrate the larger open

areas to be trapped nearer the center of the filter in the

smaller openings.

Without graded density, a spun filter will operate in practice

only as a surface filter.

Spun sediment filters are ALWAYS made of polypropylene. Polypropylene is a type of

thermoplastic that can be melted and bonded which is how the term "melt blown"

came about.

Spun "melt blown" filters are typically described to look like a clean white paint roller.

Although they are sometimes slightly pleated (circling the sediment filter).

You will never see rubber gaskets on a sediment filter. Rubber gaskets are used to help

separate the product water and the source "feed" water and is seen on EVERY other filter

except spun filters. Sediment filters are self sealing when properly used.

Their dirt holding capacity is considered to be better than pleated but worse than string

wound filters. Their main purpose is to remove silt, oil, grease, and other forms of sand.

It is very commonly used as a general filter to remove more than the above mentioned

(i.e. dirt, particulate rust/iron, etc).

Spun filters are an all around average filter which can be used in almost any situation.

String Wound Sediment Filters

It is not recommended to use string wound filters for water with high amounts of oils and

grease. Because oils attach to the surface of the filter, it will deliberately clog the filter.

This will increase the pressure drop until it is completely clogged.

One other caution when using string wound filters is that channeling along the windings

can sometimes occur, allowing particles to penetrate the filter.

String wound filters have the appearance of a spool with yarn.

They have a lot in common with spun "melt blown" sediment

filters. They both are ALWAYS made of polypropylene and like

spun filters these also do not use rubber gaskets to seal the filter.

For dirt, silt and sand situations, it is always recommended to use

a string wound sediment filter. These have the largest of the

pressure drops as well as the largest of dirt holding capacity.

It is very common for people with well water to use these types

of filters due to the fact that they have large amounts of

dirt/sand/silt in their well.

A string wound filter showing

channeling and inconsistent

density.

A single density spun filter

showing surface filtration only

and poor dirt holding capacity.

A graded density spun filter showing

particles trapped throughout depth

of filter (good dirt holding capacity).

Pleated Sediment Filters

They require the use of rubber gaskets to seal properly. Pleated filters have the least

amount of pressure drop due to the thickness and most of the time can be washed and

reused several times before it is tossed away. The surface area of a pleated filter is much

larger than any non-pleated filter.

Polyester pleated filters are used for removing suspended solids from water and are the

most durable of the pleated filters because of their material. They are the most resistant

to bacterial growth. Polyester filters are constructed of pleated non-woven polyester

fabric that is bonded on the ends to thermoset plastisol or "end caps."

Polyester is resistant to many chemicals and to bacterial damage, making them an

excellent choice for removing suspended solids from non-chlorinated water supplies such

as lake and well water.

Polypropylene pleated filters are the most economical filters. They have a higher dirt

capacity than polyester filters. Polypropylene construction is excellent chemical

compatibility. It is a very good general filter like polyester.

Cellulose pleated filters are also used for removing suspended solids from water. Pleated

cellulose is bonded to the end caps of the thermoset plastisol. Cellulose pleated

sediment filter are designed for use on chlorinated water supplies such as lakes & rivers.

The main purpose for these types of filters is to remove more solidified particulates like

grit, sand, particulate rust and other larger sediment particles. Pleated filters have the

least dirt holding capacity when compared to spun and string wound filters.

Pleated filters are recognized for their paper thin

appearance.

Their appearance resembles a well folded piece of paper

that is in the shape of a circle. These types only have 1 layer

of filtration.

It can be made of several types of materials that include

cellulose, polypropylene, and polyester - each with its own

advantages and disadvantages.

Both absolute and nominal filters are available because of the way

these are made. Absolute micron filters are priced higher than nominal

filters because of the production cost.

For general filtration, nominal microns are more economical than

absolute. Absolute is used in more strenuous situations, for example in

laboratories, where micron size plays a very important function.

Image Right: Argonide’s range of Nanoceram specialized absolute

0.2 Micron pleated filters.

Although they may be used for dirt filtration, they may not perform well for dirt holding

capacity.

Pleated filters are recommended for homes that cannot afford the pressure drop but

have the presence of sand, grit, or sediment particulates.

FILTER HOUSING SIZES

KEY FOR FILTER/CARTRIDGE APPLICATION

37 Bell Crescent, Westlake Business Park, Tokai

Suite 220, Postnet X18, Rondebosch, 7700

Tel: +27 21 702 3262 Fax: +27 21 702 3270

Customer Care: 0800 4 WATER

Website: www.h2o.co.za E-mail: [email protected]

H2O International SA (PTY) LTD Registration number : 2003/002835/07

H2O International (Pty) Ltd

Pricelist as at 09 June 2011

SEDIMENT FILTERS - 10"PREMIER MELT BLOWN POLYPROPYLENE FILTERS

1

Product Code Product Description Retail Incl VAT Retail Ex VAT Manufactured in Certification Application

ROU009Melt Blown Polypropylene

Sediment Filter for RO - 10" - 1

Micron

R 100.00 R 87.72

ROU010Melt Blown Polypropylene

Sediment Filter for RO - 10" - 5

Micron

R 100.00 R 87.72

CAR004Melt Blown Polypropylene

Depth Filter - 10" - 5 Micron R 110.00 R 96.49


Depth Filter - 10" - 1 Micron R 110.00 R 96.49


Depth Filter - 10" - Nominal

0.2 Micron

R 110.00 R 96.49

ECONOMY MELT BLOWN POLYPROPYLENE FILTERS

CAR041UE-POE Sed 10" - 1 Micron

Polyprop R 26.00 R 22.81









PREMIER STRING WOUND FILTERS

Product Code Product Description CAR028 Incl Retail Ex VAT Manufactured in Certification Application

CAR016String Wound Sediment Filter -

10" - 5 MicronR 65.00 R 57.02

CAR034String Wound Sediment Filter -

10" - 1 MicronR 65.00 R 57.02

ROU043KENT String Wound Sediment

Filter - 10" R 125.00 R 109.65

CAR036String Wound Sediment Filter

with GAC - 10" - 5 MicronR 185.00 R 162.28

ECONOMY STRING WOUND FILTERS


String Wound Filter R 40.00 R 35.09


String Wound Filter R 40.00 R 35.09

PREMIER PLEATED / WASHABLE FILTERS

Product Code Product DescriptionPREMIER STRING WOUND FILTERS Incl Retail Ex VAT Manufactured in Certification Application

CAR014Pleated/Washable Sediment

Filter - 10" - 1 MicronR 410.00 R 359.65


Filter - 10" - 5 MicronR 410.00 R 359.65


Filter - 10" - 20 MicronR 375.00 R 328.95

CAR089NANOCERAM

Pleated/Washable Filter - 10" -

Absolute 0.2 Micron

R 375.00 R 328.95

Product Image

Product Image

Product Image

SEDIMENT FILTERS - 20"


ECONOMY POLYPROPYLENE FILTERS









ECONOMY PLEATED / WASHABLE FILTERS

CAR063UE-POE Sed 20"- 20 Micron

Pleated Filter R 120.00 R 105.26


Pleated Filter R 120.00 R 105.26

SEDIMENT FILTERS - BB10

PREMIER POLYPROPYLENE FILTERS


CAR029Spun Polypropylene Depth

Filter - BB10 - 5 Micron R 375.00 R 328.95




Filter - BB10 - Nominal 0.2

Micron

R 375.00 R 328.95


CAR051UE-POE Sed for BB10" - 1

Micron PolypropR 110.00 R 96.49



CAR053UE-POE Sed for BB10" -10









Filter - BB10 - 20 MicronR 435.00 R 381.58





CAR092NANOCERAM

Pleated/Washable Filter -

BB10 - Absolute 0.2 Micron

R 900.00 R 789.47


CAR065UE-POE Sed for BB10 - 20

Micron Pleated R 165.00 R 144.74



Product Image

Product Image

Product Image

SEDIMENT FILTERS - BB20

PREMIER POLYPROPYLENE FILTERS







Filter - BB20 - Nominal 0.2

Micron

R 695.00 R 609.65




















CAR093NANOCERAM

Pleated/Washable Filter -

BB20 - Absolute 0.2 Micron

R 1,600.00 R 1,403.51






Product Image

Product Image

HIGH TEMPERATURE FILTERS

10" POLYPROPYLENE FILTERS


CAR112Hot Water 10" Polyp.

Cartridge - 1 Micron R 100.00 R 87.72





10" STRING WOUND FILTERS

CAR106Hot Water 10" String Wound

Filter - 0.3 MicronR 100.00 R 87.72


Filter - 5 MicronR 85.00 R 74.56


Filter - 10 Micron R 85.00 R 74.56

20" STRING WOUND FILTERS


Filter - 0.3 MicronR 200.00 R 175.44


Filter - 5 MicronR 175.00 R 153.51


Filter - 10 Micron R 175.00 R 153.51

CERAMIC / ADDED BACTERIA REMOVAL FILTER CARTRIDGES - OBE

PREMIER CERAMIC CARTRIDGES


ABR010CERAMIKX Extruded Carbon

Filter - 10" - Nominal 0.2

Micron

R 595.00 R 521.93

ABR007DOULTON STERASYL Ceramic

Filter Cart. - 10" - 0.5-0.9

Micron

R 685.00 R 600.88

ABR008DOULTON ULTRACARB

Ceramic Filter Cart. - 10" - 0.5-

0.9 Micron

R 865.00 R 758.77

WCU043DOULTON RIO 2000 Ceramic

Filter - BB10 - 0.5-0.9 Micron R 3,250.00 R 2,850.88

WCU044DOULTON RIO 2000 - Single

Replacement Ceramic Candle -

0.5-0.9 Micron

R 425.00 R 372.81

ECONOMY CERAMIC CARTRIDGES

ABR012Economy Ceramic Filter

Cartridge - 10" - 0.5-0.9 Micron R 75.00 R 65.79

ABR043X-GREEN Ceramic Filter Cart. -

10" - 0.5-0.9 Micron R 235.00 R 206.14

ABR044X-GREEN ULTRA Ceramic Filter

Cart. With GAC - 10" - 0.5-0.9

Micron

R 295.00 R 258.77

Product Image

Product Image

CERAMIC FILTER CANDLES

PREMIER CERAMIC CANDLES

Product Code Product Description ABR008 Incl Retail Ex VAT Manufactured in Certification Application

ABR022DOULTON SUPER STERASYL

Ceramic/GAC Filter Candle - 7" -

0.5-0.9 Micron

R 615.00 R 539.47

ABR003

DOULTON ATC SUPER STERASYL

Ceramic/GAC/Heavy Metal

Removal Filter Candle - 7" - 0.5-

0.9 Micron

R 695.00 R 609.65

ABR038

DOULTON ULTRACARB

Ceramic/Carbon Block/Heavy

Metal Removal Filter Candle - 9.5"

- 0.5-0.9 Micron

R 855.00 R 750.00

ECONOMY CERAMIC CANDLES

ABR039POZZANI Ceramic/GAC Filter

Candle - 3" - 0.9 MicronR 100.00 R 87.72

ABR004RAMA Ceramic/GAC Filter

Candle - 7" - O.9 MicronR 120.00 R 105.26

ABR002STEFANI Ceramic/GAC Filter

Candle - 4" - 0.9 MicronR 125.00 R 109.65

CARBON BLOCK FILTER CARTRIDGES

PREMIER CARBON BLOCK CARTRIDGES

Product Code Product Description ABR022 Incl Retail Ex VAT Manufactured in Certification Application

ROU017Carbon Block Filter Cart. For

RO - 10" - 5 MicronR 90.00 R 78.95

ROU044KENT Carbon Block Filter Cart.

- 10" - 5 MicronR 175.00 R 153.51

CAR022MATRIKX CTO/2 Carbon Block

Filter cart. - 10" - 5 MicronR 275.00 R 241.23

CAR038Carbon Block filter Cartridge

for RCT-UV - 10" R 485.00 R 425.44

CAR025MATRIKX CTO/2 Carbon Block

Filter cart. - BB10 - 5 MicronR 1,075.00 R 942.98

ECONOMY CARBON BLOCK CARTRIDGES

CAR069UE-Carbon Block Cartridge 10"

- 10 Micron R 95.00 R 83.33

CAR070UE-Carbon Block Cartridge 20"

- 10 Micron R 225.00 R 197.37

CAR071UE-Carbon Block Cart. for

BB10 - 10 Micron R 175.00 R 153.51

CAR072UE-Carbon Block Cart. for

BB20 - 10 Micron R 380.00 R 333.33

GAC FILTER CARTRIDGES

PREMIER GAC CARTRIDGES


ROU042 KENT GAC Filter Cart. - 10" R 175.00 R 153.51

CAR039 GAC Filter Cart. - BB10 TBA TBA

ECONOMY GAC CARTRIDGES

ROU019Economy GAC Filter Cart. For

RO - 10" R 90.00 R 78.95

CAR073 UE - GAC Cartridge R 90.00 R 78.95

Product Image

Product Image

Product Image

H2O INTERNATIONAL GAC/KDF PURIFIER CARTRIDGES

PREMIER GAC/KDF CARTRIDGES

Product Code Product Description PREMIER GAC CARTRIDGES Incl Retail Ex VAT Manufactured in Certification Application

CAR001H2O INTERNATONAL -

GAC/KDF/Riolyte Purifier Cart.

- 10" - 19,000lt

R 645.00 R 565.79


GAC/KDF Purifier Cart. - 10" -

19,000lt

R 645.00 R 565.79

CAR077

H2O INTERNATONAL - DELUXE


with Pre-sed Filter Pad - 10" -

19,000lt

R 645.00 R 565.79

CAR082Pre-Filter Set for

GAC/KDF/Riolyte cart.R 55.00 R 48.25

UCU001H2O INTERNATIONAL - RC

GAC/KDF/Riolyte Refrigerator

Cart. - 11,350lt

R 1,150.00 R 1,008.77

CAR020H2O INTERNATIONAL - CTP


- 56,000lt

R 1,945.00 R 1,706.14

CAR003H2O INTERNATIONAL - US4


- 132,000lt

R 3,250.00 R 2,850.88

ECONOMY GAC/KDF CARTRIDGES


Economy GAC/KDF Purifier

Cart. - 10" - 11,350lt

R 535.00 R 469.30

UCU016H2O INTERNATIONAL - E-RC

GAC/KDF Refrigerator Cart. -

6,000lt

R 825.00 R 723.68

CAR023H2O INTERNATIONAL E-CTP

GAC/KDF Purifier Cart. -

38,000lt

R 1,675.00 R 1,469.30

PURIFICATION MEDIA PER KILOGRAM


CAR011Coconut Shell/Steam Washed/

Green GAC - 1 KgR 245.00 R 214.91

CAR012KDF 55 Purification Media - 1

Kg R 755.00 R 662.28

CAR013Gravel for Whole House

Water Purification Systems - 1

Kg

R 25.00 R 21.93

WCU010 Water Softner Resin - 1 Kg R 78.00 R 68.42

WCU004 Mikrophos Chrystals - 1 Kg R 285.00 R 250.00

BAYONET QUICK CONNECT FILTER CARTRIDGES FOR EVERPURE/OMNIPURE SYSTEMS


CAR083Omnipure E5620 1M Carbon

Block Cart. R 625.00 R 548.25

CAR097Omnipure Ice Machine Cart. -

10 Micron R 700.00 R 614.04

CAR098Omnipure Ice Machine Cart. -

1 Micron R 845.00 R 741.23

CAR099Omnipure Espresso Machine

Anti-scale Cart.R 585.00 R 513.16

CAR100Omnipure Espresso Machine

Carbon Block Cart - 10 MicronR 595.00 R 521.93

CAR101Omnipure Coffee Machine

Cart. Carbon + Anti-scale R 675.00 R 592.11

Product Image

Product Image

Product Image

DOMESTIC REVERSE OSMOSIS FILTERS AND MEMBRANES

PREMIER REVERSE OSMOSIS FILTERS

Product Code Product Description Product Code Incl Retail Ex VAT Manufactured in Certification Application

ROU009Spun Polypropylene Sediment

Filter for RO - 10" - 1 Micron R 100.00 R 87.72

ROU010Spun Polypropylene Sediment

Filter for RO - 10" - 5 Micron R 100.00 R 87.72

ROU003Silver Impregnated GAC Post

Filter for ROR 435.00 R 381.58

ROU002DOW FILMTEC RO Membrane

50 GPD R 1,050.00 R 921.05

ROU048KENT / DOW FILMTEC RO

Membrane in Sealed Housing

75 GPD

R 1,000.00 R 877.19

ROU040KENT / DOW FILMTEC RO

Membrane 75 GPD R 1,000.00 R 877.19

ECONOMY REVERSE OSMOSIS FILTERS



ROU016Economy Silver Impregnated

GAC Post Filter for ROR 90.00 R 78.95

ROU017Carbon Block Filter Cart. For

RO - 10" - 5 MicronR 90.00 R 78.95

ROU019Economy GAC Filter Cart. For

RO - 10" R 90.00 R 78.95

ROU015VOLTRON Economy RO

Membrane 50 GPD R 925.00 R 811.40

KENT MINERAL RO INLINE FILTERS

Product Code Product Description ROU048 Incl Retail Ex VAT Manufactured in Certification Application

ROU038 KENT Inline Sediment Filter R 150.00 R 131.58

ROU039 KENT Inline Carbon Filter R 150.00 R 131.58

ROU045 KENT Micronic Filter R 145.00 R 127.19

ROU048KENT RO Membrane in Sealed

Housing 75 GPDR 1,000.00 R 877.19

GE MERLIN DIRECT FLOW RO FILTERS


ROU031MERLIN 5 Micron Sediment

Pre-Filter R 250.00 R 219.30

ROU033MERLIN Replacement Carbon

Pre-Filter R 435.00 R 381.58

ROU034MERLIN Replacement

Membrane Element R 2,150.00 R 1,885.96

ROU032MERLIN Replacement Carbon

Post Filter R 350.00 R 307.02

Product Image

Product Image

Product Image

SPECIAL APPLICATION FILTER CARTRIDGES


CAR074 UE - Resin Filter Cartridge R 90.00 R 78.95

CAR002Fluoride Reduction Cartridge -

10" R 550.00 R 482.46

CAR080ARIES Tannin Removal Resin

Cartridge - 10" R 625.00 R 548.25


Cartridge - 20" R 1,125.00 R 986.84


Cartridge - BB10 R 1,350.00 R 1,184.21


Cartridge - BB20 R 2,450.00 R 2,149.12

CAR103Carbon Block Cartridge with

Ultra-filter core - 10"TBA TBA

GRAVITY FILTER CARTRIDGES

Product Code Product Description Product Code Incl Retail Ex VAT Manufactured in Certification Application

CAR079KENT Gravity Filter Sediment

Filter Pad R 30.00 R 26.32

CAR091KENT Carbon Pellets (180

gram Sachet) R 80.00 R 70.18

CAR090KENT Gravity Ultra Filter

Cartridge R 200.00 R 175.44

CAR033Ceramic Primary Cartridge for

YK2 R 165.00 R 144.74

CAR032Mixed Media Bed Cartridge

for YK1 & YK2 R 165.00 R 144.74

FAUCET MOUNT & SHOWER FILTER CARTRIDGES

FAUCET MOUNT FILTER CARTRIDGE

Product Code Product Description GRAVITY FILTER CARTRIDGES Incl Retail Ex VAT Manufactured in Certification Application

CAR105Faucet Mount Silver/GAC

Filter CartridgeR 95.00 R 83.33

SHOWER FILTER CARTRIDGE

CAR018Replacement Cartridge for RV

Shower Unit R 395.00 R 346.49

CTU028Replacement Cartridge for

Standard & Deluxe Filter

Shower Heads

R 350.00 R 307.02

CTU032Inline Handheld Shower Filter


JUG FILTER CARTRIDGES

CTU020AQUA SELECT PLUS Jug filter

Cartridges - Set of 3R 150.00 R 131.58

CTU039GAIA Jug Filter Green Carbon


Product Image

Product Image

Product Image

Documents

H O INTERNATIONAL SA WATER FILTER AND · PDF fileSpun sediment filters are ALWAYS made of polypropylene. Polypropylene is a type of thermoplastic that can be melted and bonded which