Grove TMS!E - CraneNetwork.com · 2013-02-20 · Grove TMS""E Denotes optional equipment! Superstructure, continued Hoist speciﬁcations main and auxiliary hoists#model HP$"A#%&G

Features

!" t or !! t #!" USt or $" USt% capacity

&& m ' ((,! m #($ ft ' &&" ft% four)section, full power sequenced synchronized boom

&",& m ' &* m #(( ft ' !$ ft% o+settable bi)fold lattice swingaway extension

Optional $,& m #," ft% or &,,, m #-" ft% swingaway extension inserts

Grove MEGAFORMTM boom

Up to *-.- kg #&$,!"" lb% hydraulically installed and removed counterweight

Grove TMS!""EProduct Guide

MEGAFORMTM boom!e 11 m – 33,5 m (36 ft – 110 ft) four-section full power sequenced synchronized MEGAFORM™ boom is designed for maximum vertical and lateral strength.

Swingaway extension insertsOptional 6,1 m (20 ft) or 12,2 m (40 ft) swingaway extension inserts o"er excellent capacities with an unprece dented tip height of up to 212 ft.

Cummins diesel carrier engineCummins ISM 450 diesel carrier engine delivers the horsepower and torque needed to negotiate tough job sites and achieve highway travel speeds.

Suspension systemStandard front and rear air ride suspension provides a comfortable ride at maximum speed of 105 km/h (65 mph).

Features

Contents

Specifications -

Dimensions *

Travel proposals .

Working range /

Main boom and swingaway charts &"

Working range with inserts &.

Swingaway charts with inserts &/

Load handling ,&

Symbols glossary ,,

*Denotes optional equipment-

Superstructure

Boom

11 m – 33,5 m (36 ft – 110 ft) four (4) section, full power sequenced synchronized boom. Maximum tip height: 35,9 m (118 ft).

Folding lattice extension

10,1 m – 17,1 m (33 ft – 56 ft) folding lattice swingaway extension offsettable at 0°, 25° or 45°. Stows alongside base boom section. Maximum tip height: 52,6 m (172.5 ft).

*Lattice extensions

Two (2) 6,1 m (20 ft) lattice extensions used with the swingaway extension to increase the length to 23,2 m (76 ft) or 29,3 m (96 ft). Maximum tip height: 64,6 m (212 ft).

Boom nose

Quick reeving type boom nose with 3 nylatron sheaves (TMS750E), (4 for TMS760E [60 ton rating]) mounted on heavy duty tapered roller bearings with removable pin-type rope guards. Removable auxiliary boom nose with removable pin type rope guard.

Boom elevation

One double acting hydraulic cylinder with integral holding valve provides elevation from -3˚ to 78˚.

Load moment and anti#two block system

Standard “Graphics Display” load moment and anti-two block system with audio-visual warning and control lever lockout. These systems provide electronic display of boom angle, boom length, radius, tip height, relative load moment, maximum permissible load, load indication and warning of impending two-block condition. The standard “Work Area Definition System” allows the operator to pre-select and define safe working areas. If the crane approaches the pre-set limits, audio-visual warnings aid the operator in avoiding job-site obstructions.

Specifications

Cab

High visibility, all steel cab with acoustical lining and tinted safety glass throughout. Deluxe seat with armrest mounted hydraulic single axis controls. Dash panel incorporates gauges for all engine functions. Other standard features include: sliding side and rear windows, hot water heat, electric windshield wash/wipe, circulating air fan, sliding skylight with sunscreen and electric skylight wiper, fire extinguisher, cup holder, air conditioning.

Swing

Planetary swing with foot applied multi-disc wet brake. Spring applied, hydraulically released parking brake. Two position plunger type and 360˚ mechanical house locks operated from cab.Maximum speed: 2.0 rpm.

Counterweight

4990 kg (11,000 lb) consisting of (2) 2495 kg ([2] 5500 lb) sections. *Optional “Heavy Lift” package consisting of (1) additional 2495 kg (5500 lb) section, for a total of 7484 kg (16,500 lb). Hydraulic installation/removal.

Hydraulic system

Four main gear pumps with a combined capacity of 513 L/m (135.4 gpm). Individual pressure compensated valve banks. Maximum operating pressure: 27,6 Mpa (4000 psi). Return line type filter with full flow by-pass protection and service indicator. Replaceable cartridge with beta rating of 5/12/16. 643 L (170 gal) reservoir. Remote mounted oil cooler with thermostatically controlled electric motor driven fan.

*Denotes optional equipment !Grove TMS*""E

Superstructure, continued

Hoist specificationsmain and auxiliary hoists#model HP$"A#%&G

Planetary reduction with integral automatic brake, electronic hoist drum rotation indicator, and hoist drum cable follower. Grooved drum.

Single line pull: 1st layer: 8226 kg (18,134 lb) 3rd layer: 6994 kg (15,420 lb) 5th layer: 6084 kg (13,413 lb)

Maximum single line speed: 162 m/min (531 fpm)

Maximum permissible line pull: 7620 kg (16,800 lb) with standard 6 x 37 class rope

7620 kg (16,800 lb) with optional 35 x 7 class rope

Rope diameter: 19 mm (.75 in)

Rope length: 152 m (500 ft)

Rope type: 6 x 36 EIPS IWRC special flexible Optional 35 x 7 rotation resistant

Maximum rope stowage: 256 m (841 ft)

Carrier

Chassis

Triple box section, four-axle carrier, fabricated from high strength, low alloy steel with towing and tie-down lugs.

Outrigger system

Four hydraulic telescoping, single stage, double box beam outriggers with inverted jack and integral holding valves. Quick release type steel outrigger floats 610 mm (24 in) diameter. Three position setting with fully extended, intermediate (50%) extended and fully retracted capacities.

Outrigger controls

Located in the superstructure cab and both sides of chassis. Level indicator at each control station.

Engine

Cummins ISM 450, 10,8 L diesel (On Highway EPA Certified) six cylinders, after cooled, 336 kW (450 bhp) at 2000 rpm. Maximum torque 2102 Nm (1550 ft-lb) at 1200 rpm.

Fuel requirement — Maximum of 15 ppm sulfur content (ultra low sulfur diesel).

Equipped with engine compression brake, block heater, cold start aid (less canister) and audio-visual engine distress system.

*Engine 'required for sale outside North America(

Cummins QSM 402, 10,8 L diesel (Off Highway EPA Certified) six cylinders, after cooled 300 kW (402 bhp) at 1800 rpm. Maximum torque 1898 Nm (1400 ft lb) at 1400 rpm.Fuel requirement — Maximum of 5000 ppm sulfur content.Equipped with engine compression brake, block heater, cold start aid (less canister) and audio-visual engine distress system.

Fuel tank capacity

379 L (100 gal).

Transmission

Roadranger 11 speeds forward, 3 reverse.

Specifications

*Denotes optional equipment$

Carrier, continued

Drive

Drive 8 x 4 x 4.

Steering

Front axles, single circuit, mechanical steering with hydraulic assist.

Axles

Front: (2) beam-type steering axles, 2,1 m (83.3 in) track.

Rear: (2) single reduction drive axles, 1,9 m (75.1 in) track. Inter-axle differential lock.

Brakes

S-cam, dual system operating on all wheels. Spring applied air released parking brake acting on rear axles.

Suspension

Front: Walking beam with air bags and shock absorbers.

Rear: Walking beam with air bags and shock absorbers.

Tires

Front: 445/65R 22.5, tubeless, mounted on aluminum disc wheels.

Rear: 315/80R 22.5, tubeless, mounted on aluminum disc wheels, steel inner.

Lights

Full lighting package including turn indicators, head, tail, brake, and hazard warning lights.

Cab

One man design, all steel fabricated with acoustical lining and tinted safety glass throughout. Deluxe fabric covered, fully adjustable air ride seat. Complete driving controls and engine instrumentation including tilt telescope steering wheel, tachometer, speedometer, voltmeter, water temp., oil pressure, fuel level, air pressure gauge with A/V warning and engine high temp./low oil pressure A/V warning. Other standard items include hot water heater/defroster, electric windshield wash/wipe, fire extinguisher, seat belt, air conditioning, air horn and door lock.

Electrical system

Two (2) 12V batteries. 12V lighting/starting. Battery disconnect standard equipment.

Maximum speed

104 km/h (65 mph)

Gradeability 'theoretical(

70%

Miscellaneous standard equipment

Aluminum fenders with rear storage compartments; dual rear view mirrors; electronic back-up alarm; pump disconnect; tire inflation kit; air cleaner restriction indicator; headache ball stowage; chrome package which includes aluminum wheels, and LMI event recorder.

*Optional equipment

Auxiliary Lighting and Convenience Package — includes amber strobe for superstructure and carrier cabs, dual boom base mounted floodlights, and LMI light bar (in cab)Trailing Boom Package — includes trailer air and electrical disconnects, no spin differential and trailing boom kit (less dolly)Wind speed indicatorHook blocksRear pintle hookCross axle differential locksWinter front radiator coverAluminum outrigger padsTow cableLMI calibration for on rubber

Specifications

*Grove TMS*""E

Counterweight configurationZero,-/! kg #!!"" lb% -//" kg #&&,""" lb%*-.! kg #&$,!"" lb%

& , (

Dimensions

.

&!,- mm#!'%

&!,- mm#!'%

!$(/ mm#&..!'%

Basic machine including &&" ft #((.! m% main boom,main and auxiliary hoists with cable, driver and no counterweight. *-,*&, #(( ../% (*,"/* #&$ .,*% (*,$&! #&* "$,%Additions:!!"" lb #,-/! kg% counterweight pinned on superstructure !!"" #,-/!% ),,&- #&""-% **&- #(-//%&&,""" lb #-//" kg% counterweight pinned on superstructure &&,""" #-//"% )--,. #,""/% &!-,. #$//.%&$,!"" lb #*-.! kg% counterweight pinned on superstructure &$,!"" #*-.-% )$$-, #("&(% ,(,&-, #&",-/*%!!"" lb #,-/! kg% counterweight stowed on carrier deck !!"" #,-/!% -$/, #,&,.% .". #($*%&&,""" lb #-//" kg% counterweight stowed on carrier deck &&,""" #-//"% /(.- #-,!*% &$&$ #*((%Swingaway carrier brackets ((" #&!"% ,., #&,.% -. #,,%(( ft. #&".& m% swingaway &*(" #*.!% &/*, #./!% ),-, #)&&"%(( ) !$ ft. #&".& ) &*.& m% swingaway ,-." #&&,!% ,!", #&&(!% ),, #)&"%Auxiliary boom nose &(" #!/% ,!& #&&-% )&,& #)!!%-" ton #(! mt% hookblock stowed in trough ."" #($(% &&-, #!&.% )(-, #)&!!%!" ton #-! mt% hookblock stowed in trough &""" #-!-% &-,. #$-.% )-,. #)&/-%$" ton #!! mt% hookblock stowed in trough &,!" #!$*% &*.! #.&"% )!(! #),-(%..( ton #*.! mt% headache ball stowed in trough (*& #&$.% !(" #,-"% )&!/ #)*,%Air conditioning superstructure cab ,.! #&,/% &" #!% ,*! #&,!%Air conditioning chassis cab .. #-"% &&! #!,% ),* #)&,%

&!,- mm#!'%

!$(/ mm#&..!'%

&!,- mm#!'% (/$, mm

#&('%

&* !!$ mm#!*.$'%

&(*, mm#-.!'%

Basic machine including &&" ft. #((.! m% main boom, mainand auxiliary hoists with cable, driver, no counterweight and$,""" lb #,,*,, kg% tandem axle dolly. .",*(* #($,$,,% ((,-*/ #&!,&.$% ,/,,*! #&(,,,*/% &*,/.( #.,&!*%Additions:!,!"" lb #,,-/! kg% counterweight stowed on carrier deck. !,!"" #,,-/!% -,$/, #,,&,.% .". #($*% " #"%&&,""" lb #-,//" kg% counterweight stowed on carrier deck. &&,""" #-,//"% /,(.- #-,,!*% &,$&$ #*((% " #"%(( ft #&".& m% swingaway with brackets. ,,"$" #/(-% ,.& #&,.% ,(/ #&".% &,!-" #$//%(( ) !$ ft #&".& ) &*.& m% swingaway with brackets. ,,.&" #&,,*!% (.- #&*-% (,$ #&-.% ,,&"" #/!(%Auxiliary boom nose. &(" #!/% ),- #)&&% )," #)/% &*- #*/%-" ton #(! mt% hookblock hanging at boom nose. ."" #($(% )&,$ #)!*% )&"* #)-/% &,"(( #-$/%!" ton #-! mt% hookblock hanging at boom nose. &,""" #-!-% )&!* #)*&% )&(- #)$&% &,,/& #!.$%$" ton #!! mt% hookblock hanging at boom nose. &,,!" #!$*% )&/* #)./% )&$* #)*$% &,$&- #*(,%..( ton #*.! mt% headache ball hanging at boom nose. (*& #&$.% )!. #),$% )!" #),(% -*/ #,&*%

Boom over front

Boom over front

Unit configuration kg (lb) Gross Front RearBasic machine including ((,! m #&&" ft% main boom,main and auxiliary hoists with cable, driver and no counterweight. (( $(- #*-,&-/% &$ $$- #($,*(.% &$ /*" #(*,-&&%

Additions:

,-/! kg #!!"" lb% counterweight pinned on superstructure,-/! #!!""% &""- #),,&-% (-// #**&-%

-//" kg #&&,""" lb% counterweight pinned on superstructure -//" #&&,"""% ,""/ #)--,.% $//. #&!,-,.%*-.! kg #&$,!"" lb% counterweight pinned on superstructure *-.- #&$,!""% ("&( #)$$-,% &" -/* #,(,&-,%,-/! kg #!!"" lb% counterweight stowed on carrier deck ,-/! #!!""% ,&,. #-$/,% ($* #.".%-//" kg #&&,""" lb% counterweight stowed on carrier deck -//" #&&,"""% -,!* #/(.-% *(( #&$&$%Swingaway carrier brackets &!" #(("% &,. #,.,% ,, #-.%&",& m #(( ft% swingaway *.! #&*("% ./! #&/*,% )&&" #),-,%&",& m ' &*,& m #(( ft ) !$ ft% swingaway &&,! #,-."% &&(! #,!",% )&" #),,%Auxiliary boom nose !/ #&("% &&- #,!&% )!! #)&,&%(! t #-" USt% hook block stowed at bumper ($( #.""% !!* #&,,/% )&/! #)-,/%-! t #!" USt% hook block stowed at bumper -!- #&"""% $/* #&!($% ),-( #)!($%!! t #$" USt% hook block stowed at bumper !$* #&,!"% .*& #&/,"% )("- #)$*"%*,! t #..( USt% headache ball stowed in trough &$. #(*&% ,-" #!("% )*, #)&!/%Air conditioning superstructure cab &,/ #,.!% ! #&"% &,! #,*!%Air conditioning chassis cab -" #..% !, #&&!% )&, #),*%

Unit configuration kg (lb) Gross Front Rear Dolly

Basic machine including ((,! m #&&" ft% main boom, mainand auxiliary hoists with cable, driver, no counterweight and,*,, kg #$""" lb% tandem axle dolly.

($ (!* #.",&!,% &! "," #((,&&(% &( &*( #,/,"-&% .&$- #&*,//.%

Additions:

,-/! kg #!!"" lb% counterweight stowed on carrier deck.,-/! #!!""% ,&,. #-$/,% ($* #.".% " #"%

-//" kg #&&,""" lb% counterweight stowed on carrier deck. -//" #&&,"""% -,!* #/(.-% *(( #&$&$% " #"%&",& m #(( ft% swingaway with brackets. /(- #,"$"% &"* #,($% /& #,"&% /($ #&$,(%&",& m ' &*,& m #(( ft ' !$ ft% swingaway with brackets. &,*! #,.&"% &/- #-,*% &$! #($(% /&$ #,","%Auxiliary boom nose. !/ #&("% )&& #),-% )/ #),"% */ #&*-%(! t #-" USt% hook block hanging at boom nose. ($( #.""% )!* #)&,$% )-/ #)&"*% -$/ #&"((%-! t #!" USt% hook block hanging at boom nose. -!- #&"""% )*& #)&!*% )$& #)&(-% !.$ #&,/&%!! t #$" USt% hook block hanging at boom nose. !$* #&,!"% )./ #)&/*% )*$ #)&$*% *(, #&$&-%*,! t #..( USt% headache ball hanging at boom nose. &$. #(*&% ),$ #)!.% ),( #)!"% ,&* #-*/%

Travel proposals

/Grove TMS*""ETHIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE.

The individual crane’s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.

OPERATING RADIUS IN FEET FROM AXIS OF ROTATION

#BOOM DEFLECTION NOT SHOWN%

HEI

GH

T FR

OM

GR

OU

ND

IN F

EET

BOO

M L

ENG

TH A

ND

EXT

ENSI

ON

IN F

EET

!)°Max.BoomAngle

AXIS OFROTATION

&."

&*"

&$"

%*"

&-"

&("

&,"

&&"

%""

/"

."

*"

$"

*"

-"

("

,"

&"

"&$" &-" &," %"" ." $" -" ,"%*" &(" &&" /" *" *" (" &" "

*+' EXT

$$' EXT

%%"

%""

&"

)"

!"

+"

*"

,"$+

"°

%"°

-"°

$"°

,"°

*"°

+"°

!"°

//.(" &"-.&"Dimensions are for largest Grove furnished hook block and headache ball, with anti)two block activated.

$+ ft . %%" ft main boom and $$ ft . *+ ft lattice extension

Working range

THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane’s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.&"

TMS!+"E load charts

BoomRadius

BoomRadius

Outriggers

Outriggers

Rotation

Rotation

Boom

Boom

Counterweight

Counterweight

$+ ft . %%" ft %+,*"" lb %""% $+"˚ -" ft

$+ ft . %%" ft %+,*"" lb %""% -" ft

/"""%

/"""%

Main boom length in feetFeet $* ," *" **+" !" )" &" %"" %%"&" &,","""

#$/% .-,-""

#*,%.",,""

#*$%*$,,!""

#*.%&, &"","""

#$!.!%.-,-""#$..!%

.",,""#*(.!%

$,,!""#**%

*($,.""#*.%

&! .*,(""#!/.!%

.,,*""#$(.!%

.",,""#*"%

$&,"""#*-%

($,.""#*$.!%

*($,.""#*.%

*(&,"""#*.%

," $.,,!"#-/%

$!,"""#!!%

$-,(""#$(.!%

!",$!"#$/%

($,.""#*,%

($,.""#*!%

(&,"""#**%

*,/,&""#*.%

*,-,"""#*.%

,! !-,/""#($%

!(,&""#-!%

!,,"""#!$.!%

-&,.""#$(.!%

($,.""#$.%

(-,"""#*&%

(","""#*(.!%

,*,"""#*$%

,-,"""#**.!%

(" (/,(!"#(&.!%

(.,*""#-..!%

(*,.!"#!*.!%

((,-""#$(%

,/,"""#$*%

,!,(""#*".!%

,-,,""#*,.!%

,,,"""#*!%

(! ,/,-""#-"%

,.,-""#!&.!%

,.,*""#!.%

,!,"""#$(%

,,,,""#$*%

,&,*!"#$/.!%

,","""#*,%

-" ,(,"!"#,.%

,,,&""#-!%

,,,*!"#!(%

,,,"""#!/%

,",,""#$(%

&/,"""#$$.!%

&.,!""#$/%

-! &*,!!"#(*%

&.,,!"#-*.!%

&.,.""#!-.!%

&*,.""#!/.!%

&*,(""#$(%

&*,(""#$$.!%

!" &-,"!"#,$.!%

&-,.!"#-&%

&!,$""#-/.!%

&$,"""#!!.!%

&$,"""#$"%

&$,"""#$(.!%

!! &,,,""#((.!%

&,,/!"#--.!%

&(,$!"#!&%

&-,&""#!$.!%

&-,&""#$"%

$" &","!"#,-%

&",.!"#(..!%

&&,$""#-*%

&,,"""#!,.!%

&,,,""#!*%

$! /&&"#(&.!%

//""#-,%

&",,!"#-..!%

&",$""#!(.!%

*" *$!"#,,.!%

.-!"#($.!%

..,"#--.!%

/"""#!"%

*! *,&"#("%

*!."#-"%

*.""#-$.!%

." $&!"#,&.!%

$-/"#(-.!%

$$""#-,.!%

.! !!!"#,..!%

!.""#(.%

/" -*("#,".!%

!"""#((%

/! -,*"#,*.!%

&"" ($""#&/.!%

Minimum boom angle #deg% for indicated length #no load% "Maximum boom length #ft% at " degree boom angle #no load% &&"

NOTE: ( ) Boom angles are in degrees. #LMI operating code. Refer to LMI manual for instructions. *!is capacity is based on maximum boom angle.Lifting capacities at zero degree boom angle

Main boom length in feetBoomangle $* ," *" **+" !" )" &" %"" %%"

"° ,/,"!"#,/..%

,-,-!"#(-.,%

&*,"!"#--.,%

&&,$""#!-.$%

.!*"#$-.,%

$$&"#*-.,%

!(."#.-.,%

-&,"#/-.,%

(&&"#&"-.,%

NOTE: ( ) Reference radii in feet.**"# ft boom length is with inner-mid extended and outer-mid & fly retracted. A$).,/)&"&(&.

Main boom length in feetFeet $* ," *" **+" !" )" &" %"" %%"&" &,",""

#$/%.-,-""

#*,%.",,""

#*$%*$,,!""

#*.%&, &"","""

#$!.!%.-,-""#$..!%

.",,""#*(.!%

$,,!""#**%

*($,.""#*.%

&! .*,(""#!/.!%

.,,*""#$(.!%

.",,""#*"%

$&,"""#*-%

($,.""#*$.!%

*($,.""#*.%

*(&,"""#*.%

," $.,,!"#-/%

$!,"""#!!%

$-,(""#$(.!%

!",$!"#$/%

($,.""#*,%

($,.""#*!%

(&,"""#**%

*,/,&""#*.%

*,-,"""#*.%

,! !!,$!"#($%

!(,&""#-!%

!,,"""#!$.!%

-&,.""#$(.!%

($,.""#$.%

(-,"""#*&%

(","""#*(.!%

,*,"""#*$%

,-,"""#**.!%

(" --,&""#(&.!%

(/,$""#-..!%

(.,"""#!*.!%

((,-""#$(%

,/,"""#$*%

,!,(""#*".!%

,-,,""#*,.!%

,,,"""#*!%

(! (,,-""#-"%

,/,*!"#!&.!%

,.,*""#!.%

,!,"""#$(%

,,,,""#$*%

,&,*!"#$/.!%

,","""#*,%

-" ,$,"!"#,.%

,!,!""#-!%

,(,$""#!(%

,,,"""#!/%

,",,""#$(%

&/,"""#$$.!%

&.,!""#$/%

-! ,","""#(*%

&/,*""#-*.!%

&.,.""#!-.!%

&*,.""#!/.!%

&*,(""#$(%

&*,(""#$$.!%

!" &*,.!"#,$.!%

&$,.""#-&%

&$,!""#-/.!%

&$,"""#!!.!%

&$,"""#$"%

&$,"""#$(.!%

!! &-,/""#((.!%

&-,$!"#--.!%

&-,&""#!&%

&-,&""#!$.!%

&-,&""#$"%

$" &(,"!"#,-%

&,,.""#(..!%

&,,,""#-*%

&,,,""#!,.!%

&,,,""#!*%

$! &&,-!"#(&.!%

&",.""#-,%

&",$""#-..!%

&",$""#!(.!%

*" &",&""#,,.!%

/-!"#($.!%

/"""#--.!%

/"""#!"%

*! .,/"#("%

*.""#-"%

*.""#-$.!%

." *&-"#,&.!%

$.""#(-.!%

$$""#-,.!%

.! !.""#,..!%

!.""#(.%

/" !"""#,".!%

!"""#((%

/! ---"#,*.!%

&"" (.."#&/.!%




"° ,/,"!"#,/..%

,-,-!"#(-.,%

&*,"!"#--.,%

&&,/!"#!-.$%

/$-"#$-.,%

*.&"#*-.,%

$(/"#.-.,%

-**"#/-.,%

((!"#&"-.,%

NOTE: ( ) Reference radii in feet.**"# ft boom length is with inner-mid extended and outer-mid & fly retracted. A$).,/)&"&(&/

Over rear

&&Grove TMS*""ETHIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE.

The individual crane’s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.

*

*

*

*

*

NOTES:

&. All capacities above the bold line are based

on structural strength of boom extension.

,. (( ft and !$ ft boom extension lengths may

be used for single line lifting service.

(. Radii listed are for a fully extended boom

with the boom extension erected. For main

boom lengths less than fully extended, the

rated loads are determined by boom angle.

Use only the column which corresponds to

the boom extension length and offset for

which the machine is configured. For boom

angles not shown, use the rating of the next

lower boom angle.

-. WARNING: Operation of this machine with

heavier loads than the capacities listed is

strictly prohibited. Machine tipping with

boom extension occurs rapidly and without

advance warning.

!. Boom angle is the angle above or below

horizontal of the longitudinal axis of the

boom base section after lifting rated load.

$. Capacities listed are with outriggers properly

extended and vertical jacks set only.

Load charts

THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane’s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.&,

TMS!+"E load charts

BoomRadius

BoomRadius

Outriggers

Outriggers

Rotation

Rotation

Boom

Boom

Counterweight

Counterweight

$+ ft . %%" ft %%,""" lb %""% $+"˚ -" ft

$+ ft . %%" ft %%,""" lb %""% -" ft

/"%"%

/"%"%


#$/%.-,-""

#*,%.",,""

#*$%*$,,!""

#*.%&, &"","""

#$!.!%.-,-""#$..!%

.",,""#*(.!%

$,,!""#**%

*($,.""#*.%

&! .*,(""#!/.!%

.,,*""#$(.!%

.",,""#*"%

$&,"""#*-%

($,.""#*$.!%

*($,.""#*.%

*(&,"""#*.%

," $.,,!"#-/%

$!,"""#!!%

$-,(""#$(.!%

!",$!"#$/%

($,.""#*,%

($,.""#*!%

(&,"""#**%

*,/,&""#*.%

*,-,"""#*.%

,! -.,!!"#($%

-.,(!"#-!%

-*,$!"#!$.!%

-&,.""#$(.!%

($,.""#$.%

(-,"""#*&%

(","""#*(.!%

,*,"""#*$%

,-,"""#**.!%

(" (-,(""#(&.!%

((,$!"#-..!%

(,,.""#!*.!%

((,-""#$(%

,/,"""#$*%

,!,(""#*".!%

,-,,""#*,.!%

,,,"""#*!%

(! ,!,,!"#-"%

,-,(!"#!&.!%

,!,"""#!.%

,!,"""#$(%

,,,,""#$*%

,&,*!"#$/.!%

,","""#*,%

-" &/,!""#,.%

&.,*""#-!%

&/,(!"#!(%

,","!"#!/%

,",,""#$(%

&/,"""#$$.!%

&.,!""#$/%

-! &-,$!"#(*%

&!,(!"#-*.!%

&$,"!"#!-.!%

&$,*!"#!/.!%

&*,(""#$(%

&*,(""#$$.!%

!" &&,!!"#,$.!%

&,,(!"#-&%

&(,"!"#-/.!%

&(,*!"#!!.!%

&-,(""#$"%

&-,.!"#$(.!%

!! //$"#((.!%

&",*""#--.!%

&&,-!"#!&%

&&,/""#!$.!%

&,,-""#$"%

$" ."-"#,-%

..!"#(..!%

/!/"#-*%

&","""#!,.!%

&",-""#!*%

$! *,."#(&.!%

."*"#-,%

.-!"#-..!%

..("#!(.!%

*" !/*"#,,.!%

$*$"#($.!%

*&-"#--.!%

*-."#!"%

*! !$$"#("%

$","#-"%

$(!"#-$.!%

." -*&"#,&.!%

!"!"#(-.!%

!(*"#-,.!%

.! -,""#,..!%

-!&"#(.%

/" (-$"#,".!%

(*!"#((%

/! ("."#,*.!%

&"" ,-."#&/.!%




"° ,/,"!"#,/..%

,-,-!"#(-.,%

&$,"""#--.,%

/(-"#!-.$%

$*&"#$-.,%

!"("#*-.,%

-","#.-.,%

,/,"#/-.,%

,"("#&"-.,%

NOTE: ( ) Reference radii in feet.**"# ft boom length is with inner-mid extended and outer-mid & fly retracted. A$).,/)&"&(,"


#$/%.-,-""

#*,%.",,""

#*$%*$,,!""

#*.%&, &"","""

#$!.!%.-,-""#$..!%

.",,""#*(.!%

$,,!""#**%

*($,.""#*.%

&! .*,(""#!/.!%

.,,*""#$(.!%

.",,""#*"%

$&,"""#*-%

($,.""#*$.!%

*($,.""#*.%

*(&,"""#*.%

," $.,,!"#-/%

$!,"""#!!%

$-,(""#$(.!%

!",$!"#$/%

($,.""#*,%

($,.""#*!%

(&,"""#**%

*,/,&""#*.%

*,-,"""#*.%

,! !,,/""#($%

!,,*""#-!%

!,,"""#!$.!%

-&,.""#$(.!%

($,.""#$.%

(-,"""#*&%

(","""#*(.!%

,*,"""#*$%

,-,"""#**.!%

(" -&,*!"#(&.!%

(/,$""#-..!%

(.,"""#!*.!%

((,-""#$(%

,/,"""#$*%

,!,(""#*".!%

,-,,""#*,.!%

,,,"""#*!%

(! (,,-""#-"%

,/,*!"#!&.!%

,.,*""#!.%

,!,"""#$(%

,,,,""#$*%

,&,*!"#$/.!%

,","""#*,%

-" ,$,"!"#,.%

,!,!""#-!%

,(,$""#!(%

,,,"""#!/%

,",,""#$(%

&/,"""#$$.!%

&.,!""#$/%

-! ,","""#(*%

&/,*""#-*.!%

&.,.""#!-.!%

&*,.""#!/.!%

&*,(""#$(%

&*,(""#$$.!%

!" &$,$!"#,$.!%

&$,.""#-&%

&$,!""#-/.!%

&$,"""#!!.!%

&$,"""#$"%

&$,"""#$(.!%

!! &-,!""#((.!%

&-,$!"#--.!%

&-,&""#!&%

&-,&""#!$.!%

&-,&""#$"%

$" &,,&""#,-%

&,,.""#(..!%

&,,,""#-*%

&,,,""#!,.!%

&,,,""#!*%

$! &",/!"#(&.!%

&",.""#-,%

&",$""#-..!%

&",$""#!(.!%

*" /,/"#,,.!%

/-!"#($.!%

/"""#--.!%

/"""#!"%

*! .,/"#("%

*.""#-"%

*.""#-$.!%

." *&-"#,&.!%

$$""#(-.!%

$$""#-,.!%

.! !.""#,..!%

!.""#(.%

/" !"""#,".!%

!"""#((%

/! ---"#,*.!%

&"" (.""#&/.!%




"° ,/,"!"#,/..%

,-,-!"#(-.,%

&*,"!"#--.,%

&&,/!"#!-.$%

/$-"#$-.,%

*.&"#*-.,%

$(/"#.-.,%

-**"#/-.,%

((!"#&"-.,%

NOTE: ( ) Reference radii in feet.**"# ft boom length is with inner-mid extended and outer-mid & fly retracted. A$).,/)&"&(,&

Over rear

&(Grove TMS*""E

Pounds

!" ft # $$% ft $$,%%% lb $%%%&% ft

!"%°!! ft" #$ ft

Feet

!! ft length #$ ft length%&'(' %&'(( %&'(! %&')' %&')( %&')!&°

O*set(#°

O*set)#°

O*set&°

O*set(#°

O*set)#°

O*set

*

*

*

*

*

NOTES:

&. All capacities above the bold line are based on

structural strength of boom extension.

,. (( ft and !$ ft boom extension lengths may be

used for single line lifting service.

(. Radii listed are for a fully extended boom with

the boom extension erected. For main boom

lengths less than fully extended, the rated

loads are determined by boom angle. Use only

the column which corresponds to the boom

extension length and offset for which the

machine is configured. For boom angles not

shown, use the rating of the next lower boom

angle.





advance warning.






Load charts

THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane’s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.

THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane’s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.&-

TMS!+"E load charts

BoomRadius

BoomRadius

Outriggers

Outriggers

Rotation

Rotation

Boom

Boom

Counterweight

Counterweight

$+ ft . %%" ft **"" lb %""% $+"˚ -" ft

$+ ft . %%" ft **"" lb %""% -" ft

/"-"%

/"-"%

Main boom length in feetFeet $* ," *" **+" !" )" &" %"" %%"&" &&.,!""

#$/%.-,-""

#*,%.",,""

#*$%*$,,!""

#*.%&, &"","""

#$!.!%.-,-""#$..!%

.",,""#*(.!%

$,,!""#**%

*($,.""#*.%

&! .*,(""#!/.!%

.,,*""#$(.!%

.",,""#*"%

$&,"""#*-%

($,.""#*$.!%

*($,.""#*.%

*(&,"""#*.%

," $$,"""#-/%

$!,"""#!!%

$-,(""#$(.!%

!",$!"#$/%

($,.""#*,%

($,.""#*!%

(&,"""#**%

*,/,&""#*.%

*,-,"""#*.%

,! -&,&""#($%

-&,"""#-!%

-",$""#!$.!%

-",&!"#$(.!%

($,.""#$.%

(-,"""#*&%

(","""#*(.!%

,*,"""#*$%

,-,"""#**.!%

(" ,.,-""#(&.!%

,.,&!"#-..!%

,*,*!"#!*.!%

,.,-!"#$(%

,/,"""#$*%

,!,(""#*".!%

,-,,""#*,.!%

,,,"""#*!%

(! ,",*""#-"%

,",(""#!&.!%

,&,"""#!.%

,&,*!"#$(%

,,,,""#$*%

,&,*!"#$/.!%

,","""#*,%

-" &!,$""#,.%

&!,(!"#-!%

&$,"!"#!(%

&$,*!"#!/%

&*,!""#$(%

&*,/""#$$.!%

&.,(""#$/%

-! &&,*!"#(*%

&,,!""#-*.!%

&(,,""#!-.!%

&(,/!"#!/.!%

&-,(""#$(%

&-,*""#$$.!%

!" /"-"#,$.!%

/.!"#-&%

&",!!"#-/.!%

&&,,!"#!!.!%

&&,$!"#$"%

&,,"""#$(.!%

!! **,"#((.!%

.!""#--.!%

/,&"#!&%

/!*"#!$.!%

//-"#$"%

$" $"&"#,-%

$.&"#(..!%

*!!"#-*%

*/""#!,.!%

.,$"#!*%

$! !-&"#(&.!%

$&/"#-,%

$!-"#-..!%

$.."#!(.!%

*" -,!"#,,.!%

!","#($.!%

!-""#--.!%

!*-"#!"%

*! -"("#("%

--,"#-"%

-**"#-$.!%

." (&/" #,&.!%

(!*"#(-.!%

(/-"#-,.!%

.! ,.("#,..!%

(,""#(.%

/" ,&."#,".!%

,!!"#((%

/! &/."#,*.!%

&"" &-*"#&/.!%




"° ,.,.!"#,/..%

,&,.""#(-.,%

&,,!""#--.,%

*"."#!-.$%

-.("#$-.,%

(-&"#*-.,%

,!*"#.-.,%

&*&"#/-.,%

&"."#&"-.,%

NOTE: ( ) Reference radii in feet.**"# ft boom length is with inner-mid extended and outer-mid & fly retracted. A$).,/)&"&(,,


#$/%.-,-""

#*,%.",,""

#*$%*$,,!""

#*.%&, &"","""

#$!.!%.-,-""#$..!%

.",,""#*(.!%

$,,!""#**%

*($,.""#*.%

&! .*,(""#!/.!%

.,,*""#$(.!%

.",,""#*"%

$&,"""#*-%

($,.""#*$.!%

*($,.""#*.%

*(&,"""#*.%

," $$,"""#-/%

$!,"""#!!%

$-,(""#$(.!%

!",$!"#$/%

($,.""#*,%

($,.""#*!%

(&,"""#**%

*,/,&""#*.%

*,-,"""#*.%

,! !","!"#($%

-/,.!"#-!%

-/,!""#!$.!%

-&,.""#$(.!%

($,.""#$.%

(-,"""#*&%

(","""#*(.!%

,*,"""#*$%

,-,"""#**.!%

(" (.,&""#(&.!%

(.,,""#-..!%

(.,"""#!*.!%

((,-""#$(%

,/,"""#$*%

,!,(""#*".!%

,-,,""#*,.!%

,,,"""#*!%

(! ,.,*""#-"%

,.,$""#!&.!%

,.,*""#!.%

,!,"""#$(%

,,,,""#$*%

,&,*!"#$/.!%

,","""#*,%

-" ,,,,""#,.%

,,,,""#-!%

,(,"""#!(%

,,,"""#!/%

,",,""#$(%

&/,"""#$$.!%

&.,!""#$/%

-! &*,$""#(*%

&.,-""#-*.!%

&.,.""#!-.!%

&*,.""#!/.!%

&*,(""#$(%

&*,(""#$$.!%

!" &-,&""#,$.!%

&-,/!"#-&%

&!,*!"#-/.!%

&$,"""#!!.!%

&$,"""#$"%

&$,"""#$(.!%

!! &,,,!"#((.!%

&(,"!"#--.!%

&(,.""#!&%

&-,&""#!$.!%

&-,&""#$"%

$" &","!"#,-%

&",/""#(..!%

&&,$!"#-*%

&,,"""#!,.!%

&,,,""#!*%

$! /&""#(&.!%

/./"#-,%

&",,""#-..!%

&",!!"#!(.!%

*" *!/"#,,.!%

.(."#($.!%

.*-"#--.!%

/"""#!"%

*! *&""#("%

*-."#-"%

*.""#-$.!%

." !//"#,&.!%

$(*"#(-.!%

$$""#-,.!%

.! !-&"#,..!%

!**"#(.%

/" -!*"#,".!%

-/,"#((%

/! -&."#,*.!%

&"" (!,"#&/.!%




"° ,/,"!"#,/..%

,-,-!"#(-.,%

&*,"!"#--.,%

&&,$""#!-.$%

.!!"#$-.,%

$!,"#*-.,%

!&/"#.-.,%

(/!"#/-.,%

(","#&"-.,%

NOTE: ( ) Reference radii in feet.**"# ft boom length is with inner-mid extended and outer-mid & fly retracted. A$).,/)&"&(,(

Over rear

&!Grove TMS*""E

Pounds

!" ft # $$% ft &&%% lb $%%%'% ft

!"%°!! ft " #$ ft

Feet

!! ft length #$ ft length%&''( %&''' %&''! %&')( %&')' %&')!&°

O*set'#°

O*set)#°

O*set&°

O*set'#°

O*set)#°

O*set

*

*

*

*

*

NOTES:

&. All capacities above the bold line are based

on structural strength of boom extension.

,. (( ft and !$ ft boom extension lengths may

be used for single line lifting service.

(. Radii listed are for a fully extended boom

with the boom extension erected. For main

boom lengths less than fully extended, the

rated loads are determined by boom angle.

Use only the column which corresponds to

the boom extension length and offset for

which the machine is configured. For boom

angles not shown, use the rating of the next

lower boom angle.





advance warning.






Load charts


THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane’s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.&$

TMS!+"E load charts

BoomRadius

BoomRadius

Outriggers

Outriggers

Rotation

Rotation

Boom

Boom

Counterweight

Counterweight

$+ ft . %%" ft " lb %""% $+"˚ -" ft

$+ ft . %%" ft " lb %""% -" ft

/")"%

/")"%

Main boom length in feetFeet $* ," *" **+" !" )" &" %"" %%"&" &&*,!""

#$/%.-,-""

#*,%.",,""

#*$%*$,,!""

#*.%&, &"","""

#$!.!%.-,-""#$..!%

.",,""#*(.!%

$,,!""#**%

*($,.""#*.%

&! .*,(""#!/.!%

.,,*""#$(.!%

.",,""#*"%

$&,"""#*-%

($,.""#*$.!%

*($,.""#*.%

*(&,"""#*.%

," !$,"""#-/%

!!,*!"#!!%

!!,(""#$(.!%

!",$!"#$/%

($,.""#*,%

($,.""#*!%

(&,"""#**%

*,/,&""#*.%

*,-,"""#*.%

,! (-,(!"#($%

(-,(""#-!%

((,.!"#!$.!%

((,-""#$(.!%

(-,&""#$.%

(-,"""#*&%

(","""#*(.!%

,*,"""#*$%

,-,"""#**.!%

(" ,(,(!"#(&.!%

,(,&""#-..!%

,,,*""#!*.!%

,(,-""#$(%

,-,&!"#$*%

,-,.!"#*".!%

,-,,""#*,.!%

,,,"""#*!%

(! &$,$!"#-"%

&$,,!"#!&.!%

&$,/!"#!.%

&*,*""#$(%

&.,-""#$*%

&.,.!"#$/.!%

&/,(""#*,%

-" &,,,!"#,.%

&,,"""#-!%

&,,$!"#!(%

&(,-""#!/%

&-,&""#$(%

&-,!!"#$$.!%

&-,/!"#$/%

-! ../"#(*%

/$,"#-*.!%

&",(""#!-.!%

&&,"!"#!/.!%

&&,-!"#$(%

&&,.""#$$.!%

!" $!&"#,$.!%

*(("#-&%

."-"#-/.!%

.*!"#!!.!%

/&("#$"%

/!&"#$(.!%

!! !-*"#((.!%

$,!"#--.!%

$/$"#!&%

*(,"#!$.!%

*$/"#$"%

$" (//"#,-%

-*/"#(..!%

!!("#-*%

!.."#!,.!%

$,-"#!*%

$! (!."#(&.!%

-(!"#-,%

-*""#-..!%

!"!"#!(.!%

*" ,!$"#,,.!%

((-"#($.!%

(*&"#--.!%

-"$"#!"%

*! ,-."#("%

,.*"#-"%

(,,"#-$.!%

." &*-"#,&.!%

,&("#(-.!%

,!""#-,.!%

.! &-."#,..!%

&.!"#(.%

/" &,/"#((%

Minimum boom angle #deg% for indicated length #no load% &- ,$Maximum boom length #ft% at " degree boom angle #no load% /"


Main boom length in feetBoomangle $* ," *" **+" !" )" &"

"° ,(,*""#,/..%

&*,$!"#(-.,%

/!!"#--.,%

-.&"#!-.$%

,/$"#$-.,%

&.-"#*-.,%

&,&"#.-.,%

NOTE: ( ) Reference radii in feet.**"# ft boom length is with inner-mid extended and outer-mid & fly retracted. A$).,/)&"&(,-


#$/%.-,-""

#*,%.",,""

#*$%*$,,!""

#*.%&, &"","""

#$!.!%.-,-""#$..!%

.",,""#*(.!%

$,,!""#**%

*($,.""#*.%

&! .*,(""#!/.!%

.,,*""#$(.!%

.",,""#*"%

$&,"""#*-%

($,.""#*$.!%

*($,.""#*.%

*(&,"""#*.%

," $,,-""#-/%

$,,,""#!!%

$&,.""#$(.!%

!",$!"#$/%

($,.""#*,%

($,.""#*!%

(&,"""#**%

*,/,&""#*.%

*,-,"""#*.%

,! -*,,!"#($%

-*,"!"#-!%

-$,*""#!$.!%

-&,.""#$(.!%

($,.""#$.%

(-,"""#*&%

(","""#*(.!%

,*,"""#*$%

,-,"""#**.!%

(" (,,/!"#(&.!%

((,&""#-..!%

((,"!"#!*.!%

((,-""#$(%

,/,"""#$*%

,!,(""#*".!%

,-,,""#*,.!%

,,,"""#*!%

(! ,-,$""#-"%

,-,!""#!&.!%

,!,(!"#!.%

,!,"""#$(%

,,,,""#$*%

,&,*!"#$/.!%

,","""#*,%

-" &.,.""#,.%

&.,*!"#-!%

&/,$""#!(%

,",-!"#!/%

,",,""#$(%

&/,"""#$$.!%

&.,!""#$/%

-! &-,$!"#(*%

&!,!""#-*.!%

&$,(""#!-.!%

&*,&""#!/.!%

&*,(""#$(%

&*,(""#$$.!%

!" &&,!!"#,$.!%

&,,-""#-&%

&(,,""#-/.!%

&-,"""#!!.!%

&-,(!"#$"%

&-,*!"#$(.!%

!! ///"#((.!%

&",.""#--.!%

&&,!!"#!&%

&&,/""#!$.!%

&,,(""#$"%

$" .","#,-%

..$"#(..!%

/$,"#-*%

//."#!,.!%

&",(""#!*%

$! *,-"#(&.!%

."("#-,%

.(*"#-..!%

.*,"#!(.!%

*" !./"#,,.!%

$$."#($.!%

*"-"#--.!%

*(."#!"%

*! !!,"#("%

!/&"#-"%

$,-"#-$.!%

." -!-"#,&.!%

-/&"#(-.!%

!,*"#-,.!%

.! -"!"#,..!%

--&"#(.%

/" ((""#,".!%

($!"#((%

/! ,/."#,*.!%

&"" ,(."#&/.!%




"° ,/,"!"#,/..%

,-,-!"#(-.,%

&!,,!"#--.,%

/(,"#!-.$%

$$$"#$-.,%

-/("#*-.,%

(.,"#.-.,%

,*-"#/-.,%

&/-"#&"-.,%

NOTE: ( ) Reference radii in feet.**"# ft boom length is with inner-mid extended and outer-mid & fly retracted. A$).,/)&"&(,!

Over rear

&*Grove TMS*""E

Pounds

!" ft # $$% ft $%%%&% ft

!"%°!! ft # '" ft

Feet

!! ft length '" ft length(%)&$ (%)&& (%)&! (%)*$ (%)*& (%)*!%°

O+set&'°

O+set*'°

O+set%°

O+set&'°

O+set*'°

O+set

*

*

*

*

*

! lb

NOTES:








loads are determined by boom angle. Use

only the column which corresponds to the

boom extension length and offset for which

the machine is configured. For boom angles

not shown, use the rating of the next lower

boom angle.





advance warning.






Load charts


THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane’s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.&.

,,"

,&"

-""

&/"

&."

&*"

&$"

%*"

&-"

&("

&,"

&&"

%""

/"

."

*"

$"

*"

"

-"

("

,"

&"

-"" &." &$" &-" &," %"" ." $" -" ,"&/" &*" %*" &(" &&" /" *" *" (" &" "

#BOOM DEFLECTION NOT SHOWN%

HEI

GH

T FR

OM

GR

OU

ND

IN F

EET

BOO

M L

ENG

TH A

ND

EXT

ENSI

ON

IN F

EET

*+' EXT.

$$' EXT.

&&"

&""

/"

."

*"

$"

!"

-"($

AXIS OFROTATION

OPERATING RADIUS IN FEET FROM AXIS OF ROTATION

"°

%"°

-"°

$"°

,"°

*"°

+"°

!"°

,*°

-*°

"°

//.(" &"-.&"

!)°Max.BoomAngle

Dimensions are for largest Grovefurnished hook block and headacheball, with anti)two block activated.

Working range

$+ ft . %%" ft main boom and $$ ft . *+ ft lattice extension with ," ft insert

&/Grove TMS*""E

Pounds

!" ft # $$% ft $%%%&% ft

!"%°!! ft # '" ft &% ft $",'%% lb

Feet

!! ft length '" ft length(%%") (%%"' (%%"" (%%*) (%%*' (%%*"%°

O+set&'°

O+set)'°

O+set%°

O+set&'°

O+set)'°

O+set*

*

*

*

*

NOTES:













angle.





advance warning.


horizontal of the longitudinal axis of the boom

base section after lifting rated load.



Load charts


THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane’s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.,"

Pounds

!" ft # $$% ft $%%%&% ft

!"%°!! ft # '" ft (% ft $",'%% lb

Feet

!! ft Length '" ft Length)%%"( )%%"' )%%"" )%%*( )%%*' )%%*"%°

O+set&'°

O+set('°

O+set%°

O+set&'°

O+set('°

O+set

*

*

Load charts

NOTES:













angle.





advance warning.


horizontal of the longitudinal axis of the boom

base section after lifting rated load.



,&Grove TMS*""E

Bold lines determine the limiting position of any load for operation within working areas indicated.

Wire Hoist line pulls Drum rope

Rope Two speed hoist Capacity 'ft(

Layer Low High

Available lb* Available lb* Layer Total

& &.,&(- /"$* &"& &"&

, &$,$$. .((- &&" ,&&

( &!,-," **&" &," ((&

- &-,(-* *&*- &,/ -$"

! &(,-&( $*"* &(/ !//

$ &,,!/- $,/* &-/ *-.

*Max. lifting capacity: $x(* or (!x* class = &$,."" lb

$$ ft#*+ ft folding boom extension

*(( ft extension #erected% -(!" lb

*!$ ft extension #erected% /-!" lb

Folding ext. with -" ft insert

*(( ft extension #erected% /-&" lb

*!$ ft extension #erected% &$,"&" lb

Folding ext. with ," ft insert

*(( ft extension #erected% &$,,." lb

*!$ ft extension #erected% ,-,(/" lb

Auxiliary boom nose &(* lb

Hook blocks and headache balls:

$" Ust, ! sheave &&,! lb +

!" Ust, ( sheave &"*! lb +

-" Ust, ( sheave *.! lb +

..( Ust Headache ball #non)swivel% (!" lb +

..( Ust Headache ball #swivel% (*" lb +

Permissible Nominal

Hoists Cable/Specs. Line pulls Cable length

(/- in #&/ mm% $x(* Class,

Main EIPS, IWRC Special Flexible &$,."" lb !"" ft

Min. Breaking Strength !.,."" lb.

&/ mm #.*! in% Flex)X (!

Main & Aux Rotation resistant #non)rotating% &$,."" lb !"" ft

Min breaking strength .!,."" lb

The approximate weight of (/- in wire rope is &.! lb/ft

Load handling

Weight reductions for load handling devices Line pulls and reeving information

Hoist performance

Working area diagram

*Reduction of main boom capacities(no deduct required for stowed boom extension)

When lifting over swingaway and/or jib combinations, deduct total weight of all load handling devices reeved over main boom

nose directly from swingaway or jib capacity.

+ Refer to rating plate for actual weight.

NOTE: All load handling devices and boom attachments are considered part of the load and suitable allowances

MUST BE MADE for their combined weights. Weights are for Grove furnished equipment.


Symbols glossary

,,

Drive

RotationElectrical system

Suspension

Fuel tank capacity

Tires

Engine

Brakes

Outrigger controls

Axles Outriggers

Transmission

Frame

Steering

Lights

Boom elevation

Cab

Swing

Hydraulic system

Hoist

Boom nose

Radius

Boom extension

Boom length

Grade

Gear

Boom

Counterweight

Speed

Oil

Extension

HookblockH

Heavy duty jib

Notes

,(Grove TMS*""E

!is document is non-contractual. Constant improvement and engineering progress make it necessary that we reserve the right to make specification, equipment, and price changes without notice. Illustrations shown may include optional equipment and accessories and may not include all standard equipment.

AmericasBrazilAlphavilleMexicoMonterreyChileSantiago

Europe, Middle East, AfricaCzech RepublicNetvoriceFranceBaudemontCergyDecinesGermanyLangenfeldHungaryBudapestItalyLainateNetherlandsBredaPolandWarsaw

PortugalBaltarRussiaMoscowU.A.E.DubaiU.K.Buckingham

Asia - PacificAustraliaBrisbaneMelbourneSydneyChinaBeijingChengduGuangzhouIndiaDelhiHyderabadPuneKoreaSeoulPhilippinesMakati CitySingapore

FactoriesBrazilAlphavilleChinaTaiAnZhangjiagangFranceCharlieuLa ClayetteMoulinsGermanyWilhelmshavenIndiaPuneItalyNiella TanaroPortugalBaltarFânzeresSlovakiaSarisUSAManitowoc Port WashingtonShady Grove

Regional o!ces

Manitowoc - Asia Pacific Shanghai, China Tel: +.$ ,& $-!* ""$$Fax: +.$ ,& $-!* -/!!

Manitowoc - Europe, Middle East, Africa Ecully, France Tel: +(( #"%- *, &. ," ," Fax: +(( #"%- *, &. ," ""

Manitowoc - Americas Manitowoc, Wisconsin, USA Tel: +& /," $.- $$,& Fax: +& /," $.( $,**Shady Grove, Pennsylvania, USA Tel: +& *&* !/* .&,& Fax: +& *&* !/* -"$,

0,"&" ManitowocPrinted in USAForm No. TMS*""EPart No. "")",-),M)&&&" www.manitowoc.com

Regional headquarters

Documents

Grove TMS!E - CraneNetwork.com · 2013-02-20 · Grove TMS*""E *Denotes optional equipment! Superstructure, continued Hoist speciﬁcations main and auxiliary hoists#model HP$"A#%&G

Grove TMS!E - CraneNetwork.com · 2013-02-20 · Grove TMS""E Denotes optional equipment! Superstructure, continued Hoist speciﬁcations main and auxiliary hoists#model HP$"A#%&G