Green Note Books

7/31/2019 Green Note Books

1/29

Green Note books

The search for ecofriendly note

book..

Arul Vignesh & Sasikumar (PSGIM)


2/29

the Indian pulp and paper industry

Ranks at no. 15 in the world

consumption at around 9.1 million tonnes/yr

Highly fragmented

600 separate production units with capacitiesranging from 5 tonnes/day to 1,000tonnes/day.

28 mills based on wood fiber, 200 agro-based,(bagasse and straw) and 360 on recoveredpaper


3/29

Major players in india

ITC

TNPL

JK

BILT

SESHAYEE

WEST COST


4/29

TNPL

production capacity 4,00,000 tonnes

Largest bagasse based Paper Mill in the world.

consumes more than 1 million tones ofbagasse every year.

Environmental Strategy of the Year Award

Sales turn over - 1,184.45


5/29


6/29

Itc classmates

Unit of itc

Sales over 2000 crores

4 units at Badrachalam, Kovai , Tribeni etc. Cost of note RS 35


7/29

JK

Headquarters: New Delhi

Branch location: New Delhi, Mumbai,

Kolkata, Chennai

No. of employees: close to 300 employees

Turnover: RS. 1300 Cr

Growth rate: 10%


8/29

BILT

Headquarter: Ballarpur.

Branch Location: Ahmedabad, Chennai, Kolkata,

Mumbai, New Delhi

No. of employees: 2476

Turnover: Rs.4498.1 Cr

Growth Rate: 18.2%

A4 size Bilt Copier is Rs. 140.00 Note book cost - RS 33


9/29

Parameters

Raw material efficiency

Clean Technology

Energy Effluent management

Forestry


10/29

Raw materials

Tnpl 80 % bagasse based and 20 % woodpulp . Few products are 100 % baggasse based

55 kL water / MT

BILT - 2,88,293 hectares of forest timberavailable for bilt. 70% of wood is from FSC

controlled forestry. Most of the procurementis from its own plantation in malaysia andfrom farm forestry in India.


11/29

ITC

ITC uses raw materials like Waste papers and

Pulps, Hardwood and mesta, bamboo, lime burnt

and rosins.

50 KL / MT

JK

JK papers uses Hard wood, Pulp and Bamboo as itraw materials for production.


12/29

Score card

0

1

2

3

4

5

6

raw materials

tnpl

itc

jk

bilt


13/29

Technology

TNPL

process of implementing a 600 tpd Cement plant forconverting mill wastes namely lime and fly ash tocement

Pulp expansion - bagasse and deinking

Bio-methanation plant for generation of methane gasfrom bagasse wash water subsequently augmented


14/29

Energy Efficiency Improvement in Chemical

Recovery boiler.

Projects under Validation:

13.75 MW Grid connected wind electricity

generation project at Devarkulam by TNPL.

Project under Planning:

Installation of Energy Efficient Boiler for

Higher Steam and Power Generation.


15/29

ITC

Indias first company to adopt chlorine freetechnology and upgraded to light ECF with ozonetreatment.

Its manufacturing unit in bhadrachalam was ratedthe greenest unit with 46% while the industryaverage was only 29%.

JK

ECF bleaching not yet adopted

BILT

Information not available


16/29

Technology

0

1

2

3

4

5

6

technology

tnpl

itc

jk

bilt


17/29

ITC - energy

ITC is 98% self sufficient through co-

generation of energy from bio-mass waste

from wood pulp plantations.

ITC has been 'carbon positive' four years in a

row sequestering /storing twice the amount of

CO2 that the company emits.

ITC ventured into wind energy generation

with 14 MW capacity and solar heaters.


18/29

TNPL 35 MW OF Green energy

20 MW of bio energy produced

BILT

Only 9% of the energy used is from bio mass andremaining conventional energy is still used.

But many energy saving measures are being

taken.

JK

Only conventional energy is mostly used.


19/29

Ratings

0

0.5

1

1.5

2

2.5

3

energy

tnpl

itc

jk

bilt


20/29

Effluents

TNPL

TNPL Effluent Water Lift Irrigation Society(TEWLIS)

"Activated Sludge Process".

Around 1700 acres of arid land are irrigated with the treated effluent

water under TEWLIS scheme.ITC

ITC has been 'Water Positive' for seven years in a row - creating two

times more Rainwater Harvesting Potential than ITC's net

consumption.

ZERO SOLID WASTE MANAGEMENT fly ash, chipper dust, and plastic

100%recycled.


21/29

Bilt Bilts plant bhigwan mill is certifies zero waste water discharge mill.

At Bhigwan, an extensive effluent treatment plant to 88% percent of

treated effluent.

Participatory Water Management - Water User Association (WUA) and

Water User Group (WUG)

JK Activated sludge treatment process used. Lime kiln plant to regenerate

line from lime sludge.

Minimization of water consumption in different process through reuseand minimize waste water discharge upto 17%


22/29

Water effluent discharge

efluent Bod COD Totalsuspended

solids

treatedeffleunt

discharge

Tnpl < 10 180 - 200 40 45 ppm 40 KL / MT

itc 23 172 60 44 KL / MT

jk not available

bilt Not availbale


23/29

Ratings

0

1

2

3

4

5

6

efflent discharge

tnpl

itc

jk

bilt


24/29

Forestry

TNPL - 60 , 000 acres ( increase to 1 lac )

ITC - 2,71,000 acres

Jk - 35 , 000 acres BILT 40,000 acres


25/29

Ratings for forestry

0

1

2

3

4

5

6

forestry

tnpl

itc

jk

bilt


26/29

CSR initiatives

Itc wow

Tnpl 3 % PAT - Education and water


27/29

Overall rating.

53.5

1 2

4.5

3.5

2 1

5

4

2 3

5

5

2.52.5

2.5

2

1 0

0

5

10

15

20

25

tnpl itc jk bilt

energyforestry

effluents

technology

raw materilals


28/29

Recommendation

Buy TNPL note books which are the most

ecofriendly notebooks produced in India.

ITC class mate is the second option.


29/29

Thank you

Documents

Green Note Books