Galion 118B Grader Parts Manual - Heavy Equipment · 2017-11-06 · ga-p-118b gdr ggaalliioonn parts manual 118b motor grader this is a manual produced byjensales inc.without the

GA-P-118B GDR

GGaall iioonnParts Manual

118BMotor Grader

THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF GALION OR IT’S SUCCESSORS. GALION AND IT’S SUCCESSORS

ARE NOT RESPONSIBLE FOR THE QUALITY OR ACCURACY OF THIS MANUAL.

TRADE MARKS AND TRADE NAMES CONTAINED AND USED HEREIN ARE THOSE OF OTHERS, AND ARE USED HERE IN A DESCRIPTIVE SENSE TO REFER TO THE PRODUCTS OF OTHERS.

Part

s M

anua

l

http://www.jensales.com/products/galion-118b-grader-parts-manual.html

MODEL 118 SERIES B MOTOR GRADER

Serial No. 0760'. - Up

ROLLERS • GRADERS • CRANES

A 60000 T

THE GALION IRON WORKS ':& MFG. CO. OIYISION OF JEFFREY GALION .INC.

PRINTED IN U.S.A.


ALPHABETICAL INDEX

Description Page No.

Accelerator --------------------------------Air Cleaner - Engine -----------------------Air Cle~ner - Hydraulic Oil Tank -----------Air Pump - Tire Pump -----------------------Alternator (Delcotron) ---------------------Axle, Front ---------------------------------Axle, Rear ----------------------------------Axle Carrier, Rear --------------------------

Battery -------------------------------------Bevel Gear & Carrier -----------------------Bits, Moldboard ----------------------------Blade, Moldboard ---------------------------Blade Lift Shaft ---------------------------Blade Lift Hang Rods -----------------------Bracket, Moldboard Adjusting ---------------Brake Controls, Foot -----------------------Brake Control, Parking ---------------------Brake, Hydraulic ---------------------------Brake Lines --------------------------------Brake, Parking -----------------------------Brake Master Cylinder ----------------------Brake Wheel Cylinder -----------------------Bulldozer -----------------------------------

Cab, Deluxe Enclosed Cables:

55 84-94-95

45 126

89-100 12 71 71

87-99 72

25-121 25 35 36

25-29 56 59 77 79 59

61-62 78

11 7

110

Accelerator ------------------------ 55 Electrical ---------------------- 87-89-99-100 Governor Control ------------------- 58-81-98 Throttle --------------------------- 55-57

Circle & Drawbar ---------------------------- 22-23 Circle Reverse Case ------------------------- 33 Clutch, Transmission ------------------------ 102 Controls:

Clutch ----------------------------- 103-105 Accelerator ------------------------ 55 Foot Brake ------------------------- 56 Gear Shift ------------------------- 57-69 High - Low Transmission Range Shift- 57 Hydraulic -------------------------- 45 Parking Brake ---------------------- 59 Throttle ------------------------- 57-58-81-98 Throttle Cable --------------------- 57 Transmission ----------------------- 66 Steering --------------------------- 17

-2-


Description

Cylinders: Bulldozer ------------------------Leaning Wheel --------------------Master (Hydraulic Brake) ---------Moldboard Lift -------------------Moldboard Shift ------------------Moldboard Tilt -------------------Scarifier -------------------------Snow Plow ------------------------Steering --------------------------Wheel (Hydraulic Brake) ----------

Cushions, Operator1s Seat ------------------

Decals -------------------------------------Defroster Fan -----------------------------Door, Enclosed Cab ------------------------Drawbar and Circle -------------------------Drive Line ---------------------------------

Electric:

Page No.

115 14

61-62 37 27 30

114 115

20 78

107

121 109 110

22-23 71

Cables -------------------------- 87-89-99-100 Defroster Fan --------------------- 109 Generator ------------------------- 89-100 Harness --------------------------- 89-100 Instrument Panel ------------------ 89-100 Lighting -------------------------- 123 Starter --------------------------- 89-100 Switches -------------------------- 89-100 Voltage Regulator ----------------- 89-100 Windshield Wiper ------------------ 109

Enclosed Cab ------------------------------- 110 End Bits, Moldboard ------------------------ 25- 121 Engine ------------------------------------- 81-91 Engine Supports ---------------------------- 81-91 Ether Starting Aid ------------------------- 125 Extensions, Moldboard ---------------------- 124

Filter, Clutch Oil ------------------------Filter, Hydraulic Tank --------------------Filter, Oil By-Pass -----------------------Filter, Engine ----------------------------Fluid Motor (Hydraulic) --------------------Frame Parts -------------------------------Front Axle ---------------------------------

-3-

106 47 85

81-85-91 31

108 12

R6


Description

Fuel Lines ---------------------------------Fuel Tank and Connections -------------------

Page No.

81-97 81-86-97

Gauges, Instrument Panel -------------------- 89-100 Gear Shift ---------------------------------- 57-69 Generator (Alternator) (Delcotron) ---------- 89-100 Glass, Enclosed Cab ------------------------- 110 Governor Control Linkage ------------------ 57-58-81-98

Hang Rods, Moldboard Lift ------------------Hang Rod, Side Shift -----------------------Harness, Instrument Panel ------------------Head Lights --------------------------------Heat Indicator, Sending Unit ---------------Heat Indicator, Gauge ----------------------Heater, Cab Hot Water ----------------------Hood Sides ----------------------------------Hood Top -----------------------------------Horn ---------------------------------------Hour Meter ----------------------------------Hydraulic:

36 40

89-100 123

89-100 89-100

109 120

83-93 89-100 89-100

Brakes ----------------------------- 77 Flow Regulator Valve --------------- 46 Hose ----------------------------- 29-49-51-53 Motors ----------------------------- 31 Oil Filter ------------------------- 45 Oil Lines ------------------------ 29-49-51-53 Oil Supply Tank -------------------- 45 Operating Valves ------------------- 43 Pump ------------------------------- 65 Swivel Block ----------------------- 26

Instrument Panel ----------------------------

Leaning Wheel Cylinder ---------------------Lever:

89-100

14

Brake, Parking --------------------- 60 Gear Shift ------------------------- 57-69 Hydraulic Control Valve ------------ 43 Range Shift, Transmission ---------- 57 Throttle Control ------------------- 58

Lift Shaft ---------------------------------- 35 Lights, Head & Tail ------------------------- 123 Lights, Instrument Panel -------------------- 123 Lines, Hydraulic -------------------------- 29-49-51-53

-4-R6


Description

Locks, Cab Door ---------------------------

Manifold, Operating Valve -----------------Master Cylinder ---------------------------Moldboard:

Motor:

Muffler

Brackets, Adjusting --------------Manual Shift ---------------------Extensions -----------------------~ Lift Parts -----------------------Power Shift ----------------------Power Tilt ------------------------

Hydraulic ------------------------Starting -------------------------Supports --------------------------

Oil Clutch Lines --------------------------Oil Filter, Clutch ------------------------Oil Gauge, Instrument Panel ---------------Oil Gauge, Sending Unit -------------------Oil Tank, Hydraulic -----------------------Oil Tank, Fuel ----------------------------Operating Valves, Hydraulic ----------------

Panel, Instrument -------------------------Parking Brake -----------------------------Parking Brake Lever -----------------------Pedals:

Accelerator -----------------------Brake -----------------------------

Pump, Hydraulic ----------------------------Pump, Tire ---------------------------------

Radiator & Connections --------------------Rear Axle & Carrier ------------------------Rear Wheels --------------------------------Regulator, Hydraulic Flow -----------------Regulator, Voltage ------------------------Relief Valve, Hydraulic --------------------Rims ---------------------------------------

Scarifier ----------------------------------Seat and Cushions -------------------------Shifting Controls --------------------------

-5-

Page No.

110

45 61-62

25 25

124 35-36

25 29

31 89-100

81-91 81-91

105 106

89-100 89-91-100

47 81-86-97

45

89-100 59

59-60 ~;

~

55 56 65

126

83-93 71-72

75 46

89-100 46 12

113 107

57-69


Description

Side Shift Gear Case --------------------Side Shift Hydraulic Motor ---------------Snow Plow --------------------------------Starting Aid, Ether ---------------------Starting Motor --------------------------Steering Cylinder -----------------------Steering Gear ---------------------------Steering Wheel --------------------------Swivel Block -----------------------------

Tail Lights -----------------------------Tandem Drives ----------------------------Tank, Fuel -------------------------------Tank, Hydraulic -------------------------Throttle Controls ------------------------Tie Rod ----------------------------------Tilting Moldboard ------------------------Tire Pump -------------------------------Tools ------------------------------------Transmission -----------------------------

Universal Joint --------------------------

Valves: Clutch Control -------------------Flow Control ---------------------Fuel Shut Off --------------------Hydraulic Operating --------------Hydraulic Relief ------------------

Voltage Regulator ------------------------

Wheels: Front ----------------------------Rear ------------------------------Steering -------------------------

Wheel Cylinder, Hydraulic Brake ----------Windshields -----------------------------Windshield Wiper -------------------------

-6-

Page No.

39 31

119 125

89-100 20 18 1 7 26

123 75

81-86-97 45

57-58-81-98 12 29

126 121

66

70

103-105 46

81-97 43 46

89-100

1 2 75 17 78

110 109

R6


5

4

I 1~!-

2-(9 3-0

REF. NO. PART NUMBER

2 3

@J 4 5 6 7 8 9

10 11 12 13 14 15 16 17 18 19 20

AG-69417-A

D-44854

D-63096 D-66956 AH-69411-A H-69412-A AG-69416-A D-58226 H-68987 D-68984 D-38834 D-65984 D-65985 H-68988 D-68981 D-68986 H-66945-A D-66941 D-82243 AH-69415-A D-68634

DESCRIPTION

STEERING CYLINDER

CYLINDER ASSEMBLY ----------------------------------Includes the following:

CAP SCREW, 1/2" X 2 1/4" N.C. ----------------------Use: D-33386 Lock Washer 1/2" --------------------

D-71124 Hex Nut 1/2" N.C. -------------------BALL BUSHING ----------------------------------------RING, ball bushing retaining -----------------------END WELDMENT, cylinder anchor -----------------------SHIM ------------------------------------------------CYLINDER - Weldment ---------------------------------NUT, piston rod ------------------------------------PISTON HALF -----------------------------------------V-PACKING, piston ----------------------------------O-RING, piston to rod ------------------------------O-RING, cylinder head to cylinder -------------------BACK-UP WASHER, O-Ring -----------------------------HEAD, steering cylinder ----------------------------V-PACKING, piston rod ------------------------------RING, bearing locating -----------------------------CLAMP RING, cylinder head ---------------------------BRASS PLUG ------------------------------------------SOCKET SET SCREW, 3/8" X 3/8" N.C. -----------------PISTON ROD - Weldment ------------------------------GREASE FITTING --------------------------------------

NUMBER REQ'D.

4 4 4 2 2 1 4 1 1 2 1 1 1 1 1 1 1 1 2 2 1 2

SERIAL NO.

ALWAYS GIVE MODEL AND SERIAL NUMBER R6 -20-


REF. NO.

1 2

3 4 5

6 7 8 9

10 11

8 9 10

1 2 3

PART NUMBER DESCRIPTION NUMBER REQ'D.

G-69021

0-80483 0-80485

0-80484 0-80482 0-80492 0-80481

0-61148 0-80487 0-80488 0-80489 0-80490 0-80491

UNIVERSAL JOINT

UNIVERSAL JOINT ------------------------------ 1 Includes the following:

FLANGE YOKE ---------------------------------- 2 JOURNAL CROSS ASSEMBLY ----------------------- 2

Includes 0-61148 grease fitting ------------ 2 RACE. journal cross assy. -------------------- 8 LOCK STRAP ----------------------------------- 8 CAP SCREW. lock strap ------------------------ 16 KIT. journal cross & bearing (includes Ref.

No.2. 3. 4 & 5) ----------------------- 2 GREASE FITTING ------------------------------- 1 SLEEVE YOKE ASSEMBLY ------------------------- 1 CAP. dust ------------------------------------ 1 CORK WASHER ---------------------------------- 1 STEEL WASHER --------------------------------- 1 Y-SHAFT -------------------------------------- 1

ALWAYS GIVE MODEL AND SERIAL NUMBER -70-

SHIM NO.


REF. NO. I PART NUMBER I DESCRIPTION NUMBER REQ'D.

AG-78147

1 AB-783S1 2 H-64817 3 0-82243 J. 0-66941 ~ 0-60130 6 0-78387 7 0-58614 8 0-78388 9 0-65814

10 0-27856 11 0-78386 12 0-63655 13 D-40375 14 H-78389 15 0-57988 16 AG-78384 17 0-33675

LIFT CYLINDER - SNOW PLOW OR BULLDOZER (Snow Plow & Bulldozer Serial No. 1001 & Up)

CYLINDER ASSEMBLY - complete ------------------------ 1 Includes the following:

PISTON ROD (Includes Ref. No. 17) ------------------- 1 CLAMP RING ------------------------------------------ 1 SET SCREW ------------------------------------------- I 22 BRASS PLUG ------------------------------------------WIPER - piston rod ---------------------------------- 1 GLAND, rod packing ---------------------------------- 1 PACKING, piston rod --------------------------------- 1 HEAD, cylinder -------------------------------------- 1 BACK-UP WASHER -------------------------------------- 1 O-RING, cylinder head ------------------------------- I 1 PLATE, piston --------------------------------------- I 11 PACKING, piston -------------------------------------O-RING; piston to piston rod ------------------------ 1 PISTON ---------------------------------------------- 1 LOCK NUT, piston rod -------------------------------- 1 CYLINDER WELDMENT ----------------------------------- 1 BUSHING, piston rod --------------------------------- 1

ALWAYS GIVE MODEL AND SERIAL NUMBER R6 -115-

SERIAL NO.


NUMERICAL PARTS LIST

PART NUMBER PAGE NO. I PART NUMBER , PAGE NO.

D 10777 75 0 207'41 35 0 10778 75 AH 211.!7 39 () 10779 75 A 21131 36 D 101'10 13 H 21144 30b D 107~0 75 H 21144 31 D 10d19 12 H 213b4 39 D 10819 75 H 214~2 36 to( 112~1 66 AH 21549 57 H 114U9A 79G 0 216~5 39 H 11409A 86 A 218';1 35 H 114U9A 97 0 218~9 35 0 11720 99 l) 21f160 ~6 0 117"0 lOtti R 22210 .~Ot:l 0 117~1 f9f D 22210 31 D 11123 122A 0 224,;4A 39 U 11'~3 123 A 22715A 39 0 12200 23 0 22733 39 H 123~3 75 D 229U2A 29 H 123S7 75 D 230b3 40 0 12678 117 D 23129 119 0 126~9 25 0 23129 119d 0 126'i9 36 0 23131 119b 0 126':t9 40 D 23132 119 D 126'19 113 0 231.32 1191:i D 12699 119t:1 H 23133 119b D 126~9A 25 H 23134 119ti D 126'19A 36 AH 23137 119B D 126':t9A 40 AH 231378 119b D 12699A 113 H 23176 119ti D 12699A 1196 D 23214 40 i) 12830 113 AH 233'18 119b D 13022 113 AD 23404 89ti A 13375A 113 AD 23404 R9U 0 139,3A 29 AD 234U4 1010 0 139S3t3 29 D 23407 119b [) 140~0 39 0 234U8 119li -D 149bO 120 D 240!)6 39 0 17335 117 H 240~7 :;9 0 17335 l17t! [) 241/6 19 0 19400 53 0 243:'8 79B H 19400 120 D 262J3 3] 0 194UOA 79 D 26906 53 l) 20077 35 D 27010 17 0 200H2 .35 0 27071 6f, D 20122 37 D 270"11 67 0 20123 36 0 27l29A lOlD 0 20148 39 0 27130A 122A D 20168 39 AD 27228 109 () 20109 39 0 27233 76 H 20104 23 D 27532 13 D 201b5A 23 D 27537C 13 0 20201A 12 0 275j711 13 0 20736 39 D 27508 12 H 207.38 39 0 27568 108

-130- R6



PART NUMBER PAGE NO. I PART NUMBER , PAGE NO. ..,

~;-

0 27812 30 D 29315 58 0 27656 115 0 29315 Hl D 280d8 30 0 293!')8 55 D 283j2 35 D 293!,)8 98 H 284~2 01 0 29362 89 G 287U2 :iOb D 29362 100 G 28702 31 0 29:,;!0 b1 ~ 2(3703 30B 0 29521A 53 i:i 28llJ4A 30b 0 2<J521A i"91:1 H 287U6A jOb I) 29521A a90 H 28106A ~1 D 2Q521A 101U 0 25709 301::l U 295~1A 105 D 28709 ~1 A 29576 lU9 D 21Hu9 tl5 0 29802 117 D 28710 30b D 29802 119 0 25710 31 H 29802 1198 0 28711 :iOb 0 29919 li 9b 0 28712 30b [) 299t:O 40 D 28712 31 IJ 299t!2 Z9U 0 28113 301::l A 301~4 35 D 28713 31 0 30149 53 0 28114 301:1 D 30149 117 H 28716 30b D 30149 119 0 28716 31 0 301~0 53 0 28718 301::l D 301~0 117 0 26718 31 0 301~0 119 L) 28719A jOb I) 302bO 97

AH 26755 79 D 303U5 58 H 28757 "(9 0 30337 79~

0 28762A 33 0 303j7 81 D 287628 33 I) 30337 91 D 28705 33 D 303.37 102 H 28778A ~O 0 30372 30 0 287tj11::l 33 0 303(2 30A D 287dlC 33 L1 303/2 03 D 267'15 33 0 303(2 <J3 D 287<}6 33 H 30563E. 79F D 28797 33 B 30563E. 89 0 2tlbOO 30b B 30~63E 101.

D 28800 31 D 306~6 105 0 288u7 33 AH 306<}2 11'6 0 28812 79 H 307~9 126 0 28813 79 0 30730 126 0 28814 79 0 30746 55 0 289~9 17 D 30746A 56 H 29000 1~1 Ii 30916 23 0 29075 12 0 30998 25 0 290r5 17 0 30998 29 0 29112A 75 0 31035 23 0 29205A 1 7 0 31035 25 H 29309A 58 Ali 31036 39 Ii 29312 ~8 0 31138 97 D 29314' 58 0 31140 97 D 29314 81 0 31142 97

-131- R6




D 311 08 79b 0 32fU3 1() 1 0 311b8 19G 0 32834 79F D 312~9 47 [) 3283i. 59 0 312i9 55 [) 32b34 100 U 31229 79C 0 32834 1;?2j.1. 0 312~9 89 0 32835 ;"122~

0 31229 44 0 328.;i5 1£:3 D 312~9 100 II 329~0 11 7 IJ 312~9 105 [2 3~2~Q 117d 0 31219 39 0 32903 49 lJ 312(9 77b D 32~b3 51 tj 31~boD 113 AH 33106C 12"4 H 312b1C 113 AH 33107C 1t:4 H 315u9 25 AH 33108 124 H 315u9 36 Ah 331u9 124 H 315u9 40 h 33110H 79F H 3150.9 113 H 331108 59 0 31509 119t:l H 33110tJ 100 11 32002 105 [) 331'11 79(,; 0 320U3 29 0 331Yl 01 0 320U3 ~3 D 331'11 91 l) 320U3 113 D 331\)1 102 0 320U4 ~3 [) 33366 69 [) 320!:>2 29 LJ 33367 t.6 Ll 320tlO ~t D 33367 69 H 32435 117H f) 33308 71 H 32436 11 7 b 0 33369 ~6 A 32570 121 0 33369 67 0 326U4 11 333Zn ;H 0 32604 5 U 33311 69 D 326U4 79t3 D 33374 69 0 32()U4 89 D 333b4 17 0 326U4 91 D 3330Ll '13 D 326/::':6 65 D 3331:)4 55 D 326j7 67 D 333b4 b3 0 32744 49 D 333d4 67 D 32744 51 [) 333t>4 09 D 32746 49 0 333b4 73 D 32746 51 D 333b4 7" 9F 0 32746 ~3 0 333ti4 8iL D 32746 117 0 333ti4 87 0 32746 119 D 33304 69 D 321':J7 ~3 0 333d4 99 0 327':J7 117 [) 33304 1 () 0 IJ 327!:>7 119 0 333b4 1(;10 U 327:>8 53 0 333t!4 105 0 321':J~ 113 D 33305 66

AD 327Y8 109 D 333d5 69 0 32829 109 D 333b5 lOe; 0 32~30 7C)r 0 333b6 19b 0 32830 89 Q 333b6 17 0 32830 101 D 33306 37 0 32830 122A 0 333b6 56 U 32833 ' 79F 0 33306 57

-132- R6




0 333~6 73 AH 34124A 11 7 jj 333b7 36 AH 34124A 119 [) 33.3tH 40 0 341j2 ?9 [) 333~7 57 [) 34303 122A L) 33307 75 D 34475 53 D 333b7 63 [) 3~O/1 29 jj 333~7 93 D 35209 1 14 jj 0 33307 119b [) 35341 58 0 333d8 39 0 35342 58 D 33308 tlO 0 3~343 58 0 3331;8 56 D 35344 58 [) 33308 67 0 35345 58 [) 33388 75 0 35377 40 D 33308 119~ AD 35421 109 D 333':)0 69 0 354d5 79C U 333<Jl 69 0 35618 81 0 333'ifl Q9 Q .3!:1f218 91 D 333Y6 100 i) 356=>2 120 D 333Y7 36 D 356~2 123

·-1)333'18 :i 6 A 35805 ~w

D 333'18 40 0 ;258U7 57 0 33398 67 H 35865 30 LJ 333Y8 119jj D 3591Q 39 0 33400 57 D 35915A ~~ 3 [j 33400 67 D 35915A 11 3 D 33400 69 0 35963 87 0 334U2 69 0 35963 99 0 33405 69 AD 35972 87 0 33407 67 AD 359f2 99 0 33408 66 D 36332 105 0 334U9 66 D 365,;7 105 0 33410 6f'l AO 36~b6 89b 0 33412 QI tl 368'13 ~1 0 33413 67 B 36893 102 D 33418 66 D 369:'7 61 J 33419

0:::',

67 [) 370U1 "f4 0 334£1 66 0 37004 791::j [) 33430 69 0 370U4 84 0 334j2 t-7 0 37005 19b 0 33434 67 D 370'i4 12 D 33436 66 0 37094 55 0 3-"J43"6- 67 0 37094 79~

0 33437 69 U 370Y4 103 II 33475 117 U 371.13 17 0 33415 117H D 37113 At 0 33475 j 19 D 37114 18 0 33475 119b D 3Zl~3 1 Z 0 33494 117 0 371~4 55 0 33494 117b 0 3Z1i::l,l 1 Q.3 0 33512 53 0 372~8 100 0 33513 53 A!j 31,J2 99 0 33603 75 0 37322 87 0 336/5 114 D 373~2 99 0 33615 ' 115 AD 37346 123

-133- R6




D 373~0 ?9 A 424b7 89 0 37';)70 12?A 0 42407 100 H 37Sf5A 1~4 u 42504 25 H 37576A 11'4 f) 42504 36 D 377u2A 79f 0 42564 113 0 37702A 89 11 42Sb4A 40 I) 377U2A 101 0 42502 29 tJ 3l7Y9 120 AH 43254 i~ 0 0 38370 105 AH 43254A 40 IJ 38395 1148 AD 43404 1 (j 1 b 0 38395 117b H 43579 53 0 383'15 1 19 i::i H 43579 11 7 D 38405 ')3

H 43579 119 H 38616 29 H 435b4 S3 0 38648 ')5 AD 43607 89U D 38651 ')7 AD 43607 101U 0 38652 63 0 436~8 79b D 3871:)2 29 0 436~8 64 0 38d34 20 0 436~8 94 D 38834 30A D 43647 79F

AH 38854 117 RD 43647 89 AH 388S4L 117b HD 43647 101

0 38857 11 7 RD 43647 12?A H 38857 117b 0 43661 10'5 0 38857 119 H 436b9A 81 0 38857 119b 0 436(2 79f

AH 38867 117 A 437't.7 12~ AH 38867 1171:i H 43750A 121

H 38872 117 0 43800 39 H 38872 117b AG 439760 119 AH 39015 119 AG 43916G 119b

AK 390t:8A 119b H 44001A 91 H 39196 j3 D 44051 29 G 39214fj 33 H 44075A 55 B 39215A 33 H 440'5A 81 AH 39414 79(j AH t~ 417 7 119 AH 39414 (j6 B 441b3 84 AH 39414 97 A 44197 89

i-3 39926A 75 A 441~8 89 * H 40042 22 [) 44212 33 0 40061 23

0 44215 33 D 4011b2 23 0 442.:s2 25 0 40079 105 H 44247 1?1 0 40079 120 H 44251 121 0 401b3 25 0 442d6 49 0 403)0 25 D 44206 51 D 40350 29 0 44266 53 0 40373 114b 0 442b7 29

0 40374 ] 14 b D 442b7 53 D 40375 14 AH 44325 53 [) 403{5 27 AH 443~7 53 0 40375 37 AH 44329 53 0 40375 114 AH 443.:11 53 0 40375 115 AH 44345 53 0 42213 33

* Obso lete N umbel -134- R6




AH 44347 ,3 D 45716 39 {J; i ~

0 44379 It'7 0 45717 39 A(j 443Y6E 117 () 45718 39

p. 44408 1 1 7 H 4~719 j9 AH 44518 29 H 45720 39

I) 44776 t'3 0 45736 30A IJ 448U3 43 D 45761 (, 3

0 448U3 49 D 45761 ;3 U 44803 ~1 A 4~805 :'9 0 448U3 79b 1:1 45813 "5 0 44>303 83 H 45813L 113 D 448U3 93 D 459~4 122A IJ 44847 55 D 46005 39 () 448'4 "0 0 46006 :;9

0 448~4 ~7 D 461';1 113 0 448'4 73 H 46397 121 D 44854 105 0 46410A 46

0 44858 23 0 46410A 1,;7

0 448,8 75 0 46410b 46 0 44859 67 G 46410B ~1

0 44860 119b A 464';3 122A 0 44870 17 D 46475A 113 0 44H70 43 D 46522 87 U 44870 55 0 46522 l~ 9 0 44870 t:l4 D 465~2 ~9~

0 448/0 87 0 465~2 £\9LJ D 44870 99 IJ 46522A 79F 0 44tH 1 56 A 46524 89 0 448/2 58 0 46524 b9b 0 44872 79b D 465~4 G9LJ 0 448(2 103 0 46524 101b 0 44872 109 0 46524 lOll) 0 44888 39 A 46579 1 7

0 44976 94 8 46500 17 0 44976 95 H 465b1 17

0 45076 75 AH 465061:1 126 0 45338 79F D 46807 39 0 45338 89 0 46809 39 0 45338 101 AS 47124 98

0 45342 12 H 47164 75

H 45348 81 H 47164A 75

H 45348 102 H 47164t3 75 0 45412 '22A 0 47195 39 0 45420 75 0 471Y6 39 H 454"(1 124 AD 47357 89LJ H 454d3 119b AD 47357 1010 H 454b4A 124 0 475~9 75 A 454bSA '24 H 47500A ~3

0 454()6 119t.i H 47560A 93 H 454B6A 124 0 47571 1t!O 0 45657 121 D 47576 ]09 0 45699 49 0 475"(6 122A [) 45699 51 0 47576 1?3 D 45715 39 0 47611 13

-135- R6




D 47611 39 0 49210 12 AH 476b7b 36 0 49211 12 AIj 47 70 3 113 Q ~2212 13 A8 47713~ 113 0 49213 13

Ll !:!Z~~5 'tB Q 49214 12 H 4"18;8 98 Ai-! ~92J5 57 0 47tj64 87 t; 49246 1? 0 47tj64 99 8 49246A 12 0 48014 58 tj ~~2lZ 1 J 0 48015 39 f.j 49218 13 D 4A015 ~~ H g9279 13 0 4b015 77b 0 49200 13 0 48015 100 0 492tjl 13

AR 48117 120 D 492b2 13 A 481'-7 113 H 49383A 77 A 4Bl~6A 113 AH 49419~ 27 0 48193 ~5 AG 49425 114b 0 482U3 29 A.H 494~8 114b D 482U3 49 A~ 49431 114b 0 482U3 51 B 494.;4 30 D 48203 ~3 0 495427 13 - 0 48203 101U 0 495j3 79F () 48203 117 0 49533 59 0 48203 119 D 49,j3 j () 1 0 482~9 113 0 49563 105 II 48494 49 D 49747 1:? 0 48494 51 0 497~1 49 0 48494 79F 0 497'1 51 l) 48494 101 H g2831 110

AH 4851i'U. 79F 0 49833 110 D 48~~8 58 0 g2836 110 H 48663 114B AG 50019K 113 0 4b664 14 !.l 50121 45 0 45664 27 D 501J{ 29 0 48664 37 Q SOLH 71 0 413664 114 AD 50146 120 H 48664 1111fj AD 5Q14l 1.20 D 48665 114t:! AD 50148 120 0 487e::9 12 A 501'38 120 0 41:1729 17 A 50153C 120 H 48807 121 A 5u1::>3D 120 R 4A808 121 D 501:>8 122A H 488u9 25 0 50169 30

AD 488(1 122A D 50110 30 AD 481::1(2 122A 0 50171 30

H 48961A 94 D 502~9 191::j 0 48979 79F 0 502~9 84 0 48979 1'11 U 50338 87 D 490~8A 114 0 50338 89

AG 49015C 14 0 50338 89B H 49076 114b D 503b8 87 8 49142 62 0 50392 55 D 49162 12 D 503'i2 79C 0 49162- 1198 0 50399 122A

-136- R6



PART NUMBER PAGE NO. I PART NUMBER PAGE NO.

D 50443 55 0 526'74 106

0 50443 98 [) 52708 79b D 50513 :'6 AG 52848A 30 LJ 50513 63 AG 528488 jOA I:l 50643 69 AG 528~OA 30 D 50644 69 AH 52852 30

0 506~51:l 13 0 528b7 83

H 506b8 30 [) 528b9 83

H 506d8 30A 0 528b9 <;3

D 50701 95 AG 52'f14C 27

0 50706 29 At; 529156 '?7 D 50706 53 0 530Y3 87 L1 50'()6 105 0 5301,/3 89 0 50718 43 [) 53119A lOlL) R sorbS 94 H 53333A 91 0 50892 49 D 53431 105 0 508<';2 51 0 53474 lU5 D 50892 105 B 53526A 25 0 50893 29 0 536b5 1 7

D 50893 49 AD 53667 17 0 501393 51 0 53862 61 [) 50B93 53 0 53940 69 D 5081.)3 81 l) 53956 65 0 50893 105 0 54017A '79F D 50893 113 0 54017A 89 A 50942 126 0 54017A 101 A 51115 114b D 541~3 17 0 51257 128 D 54158 45 0 51493 12 0 54158 105 0 51720 49 A,H 54235 53

0 51720 51 AH 54235 113 0 51720 81 AH 54236 53

0 51721 43 AH 54236 113

D 51871 84 AH 54296 53

D 51860 85 AH 54296 117

H 519b6 79(; AH 54296 1 19

0 52035 f;7 AH 542Y7 53

0 52035 89U AH 54297 117

D 52035 99 AH 542Y7 119

D 52035 1011) 0 544b9 105

0 52045 17 H 54635 12 A 52062 81 H 54636 12 A 52002 125 H 54637 12 A 520~4A 120 H 54657C 12 A 52095A 120 B 54842 8~

A 52096A 120 0 55073 33 0 52140 94 0 55146 17 0 52106 79C 0 55146 40

Au 52508 83 0 55146 126 G 52509 93 1:3 551b8 39 H 526t13 55 1:3 55185 39 H 526(:)3 791:3 D 551()7 49 H 526tl3 98 D 551d7 51 0 52694 57 0 55200 55

-137- R6




[j 5~4U4 791:3 0 56974 13

D 55404 R9 0 56974 75 D 554V4 91 D 56'108 19b l) 554u4 lOO

[) 569B8 R4

0 5541;10A lOS [j 569b8 94 U 554YOA 106 H 569'18 81 D 55611 1?0 D 57200 30 H 5564t) 39 D 57200 30A Ij 55648b J9 0 572£:6 120 A 556491j 39 0 574j9 65 I::i 55f3:,3 93 D 57677 43 t.J 55941b 9Ll D 576(7 49 D 55941D 94 D 57677 51 0 55949 '(>0 D 57618 49 D 56112 r9u 0 ~76(8 ~1 I) 56112 f;3 0 57680 49 t.J 56112 8A D 576t;0 51 0 56112 93 D 57601 49 0 56112 97 D 576b1 ~1

A 5bl~5 121) H 57602 49

D 562:'2 19 H ~76b2 51 D 562:'3 19 [) 57686 49 0 562(5 18 D 576b6 ~1

0 56217 19 D 57609(; 49

D 562'72 18 0 576b9(; 51 D 562~3 lR [) 578~O 79C [) 563J;? 55 0 578(:;0 89 t.J 563:'6 ~6 0 57820 91

AH 563~8 :'6 0 57820 100 G 563bO ~6 0 :, 7tH 1 103 D 56458 7911 0 57905 ':)7 0 56458 83 * D 57988 27

* D 57988 37 0 564~8 fl6 * D 57988 114 n 564:'8 93 0 57908 115 [l 564:'8 97 G 57991C 27 R ';64b8 93 b 58010 30b 0 56486 55 0 58010A 31 0 564b6 79b AH 581:,5A 37 [) 564b6 98 AG 58159~ 37

0 56466 103 AG 58160B 37 B 56740 94 0 58207 11 3 D 56907 17 D 58226 20

A 5b954 35 0 58226 30A

0 56957 35 0 58294 ~9

A 569~8 35 0 58307 t07

A 569b1 35 [j 58368 107

A 569b2 35 0 58370 39

H 56903 35 0 583bO 39

1:3 56964 35 D 58420 1.7

B 56965 35 0 5b4t:0 33

H 56966 35 0 58453 81

0 56967 35 0 58502 79i..J

AG 569bRA 35 H 58545 ci4

Au 569b9A 35 H 58547 94 0 58570 49

-138- R6 * Obsolete Number




D 58570 51 d 593~5A 43 0 58570 53 d 593~6A '43

AH 51;500 84 0 594~9 79b 0 58614 14 D 59429 d6 0 58614 27 D 59429 97 IJ 58614 37 0 59429A Q I~

0 58614 114 0 59430 7911 0 5b614 111:) 0 59430 tl6 D 586&!O 11 '3 0 59430 97 D 586~O 117 I) 59455 43 lJ 586(::0 117" 0 59490A 33 0 586;!O 119 D 595b4 45 D 58620 11913 U 595<.14 91 I) 581111:i 128 l> 5951;4 105 D 58~51 29 D 595ti5 45 0 58d::>1 53 U 595b8 29 D 58851 L 13 0 59508 49 [j 588::>1 117 u 59508 51 0 58851 119 0 596vO 122A I) 58853 43 AH 596U5 79 0 588~3 105 AH 596u7 7Q [) 58ti~7A 43 G 59614 93 0 58657A 49 AH 59669 35 D 588:>7A 51 AH 59669 108 0 58857A 105 A 596(8 35 H 58944 65 0 598U3 43 I) 58944i::l 65 D 59805 43 D 589&45 65 D 598~1 ~7 0 58947 65 D 59822A ':)7

D 590"6 113 0 59851 49 0 590dO 66 D 59851 51 0 5901:)0 102 U 59916 79~

0 590b1 56 D 59916 tOO L) 5901:)2 'S6 0 59919 128 D 59124 113 AH 59";~1 81 i( 591J3A 77 AH 599~1 91 ;( 59134A 77 0 59939 120 H 591"'3 113 D 59941 95 D 591 f1 79F D 599411\ 94 D 59171 tOO D 59941A 95 H 59191 84 0 59941t; 95 0 59198 43 D 599410 91:) D 591Y9 105 AG 59953[) 12 0 592.31 94 AG 599b7jj 14 D 59231 9'; AH 599708 14 H 59253 (5 D 600'17 12 H 59276A ~3 U 600'}S 13 D 59340 43 0 60099 12 [) ~9343 43 Au 60121 30tj 0 593438 43 jj 601£2 30~ [) 59344 43 i3 60122 31

AH 59353 43 D 601,,0 14 AH 593',3A 43 0 60130 27

8 59354A 43 U 60130 37

-139- R6

________ 0 ______



PART NUMBER PAGE NO. t PART NUMBER , PAGE NO.

D 60130 114 H 60994 If) 0 60130 t15 0 60Y'1:, 12 H 60131A 14 0 60996 12 H 60131A 27 I) 6U9<;7 1t' H 60131A 37 U 610~9 12 H 60131A 114 G 61102A 12 [) 60164 98 (j 61104A 12 0 601li4 93 H 61106 12 0 60216 51 H 611U7 1~ tl 602~8 301::j H 611 08 12 B 60228 31 H 61109 12 0 602e::9 33 0 61110 12 B 60230 33 0 61111 11' L1 60235A 33 0 61112 12

Ali 6U2.:S6A 33 0 61114 12 0 602:H 94 D 6111 ~ 12 D 60208 95 0 61116 12 ti 602b9 95 0 61117 12 D 60211n 95 0 61118 12 0 602'17 94 0 61119 12 0 602~7 <;5 D 611eO 12 0 60324 29 [) 611~1 12 D 603~4 53 D 611'=2 12 0 60314 105 H 61132 75 [) 60390 117 D 61148 12 [) 60390 117t:s [) 61148 17 D 60416 :'6 D 61148 23 0 60416 57 0 61148 36 0 60416 63 U 61148 39 H 60440 t:s1 U 61148 ~5 D 60478 81 0 61148 :'6 U 604(8 98 0 61148 70 0 60478 103 D 61149 12 0 60479A 103 D 611:'0 13 H 60515 119b 0 61150 17 [) 605i7 119b U 611!;;0 36 D 60527A 119tj U 611:>0 40 0 6U539 75 D 61150 56 H 605:'6 33 D 611!:>1 121 lJ 606:'0 .:SO D 611!:>3 121 [) 60680 97 0 61156 121

AH 60b71 Hl 0 61157 121 AH b0873 81 0 61160 109

A 60877A 120 D 61163 79lj A b0878A 120 0 61236 89 D 60918 19 G 612!;;7C 23

AO 6092'1 109 D 61340 109 H 609d9 12 AG 61340B 109 H 609'10 13 0 61347 109 H 60991 12 D 61376 109 H 609Y1A 17 D 61377 109 D 60992 12 0 613'12 109 D 609~3, 12 0 61393 9 D 609936 17 0 61393 109

-140- R6




D 61443 5~ AU 638~3 1 3 0 615.;6 61 AD 638~4 13 D 61546 87 0 639~2 lll!:> D 61')1+6 99 G 63951 56 0 615'4 39 8 6,+0(;)9 00 G f>1')(1 9'; B 641(;)4~ 18 A 6161.17 ,2?A () 641b5 89 0 61653 122A I; 643b4 55 [) 61653 It!3 H 64305 55 f:l 61rl1A 67 H 64306 55 H 61711A b1 B 643b7A ,5

I-IH 617:"8 B7 ;\l) 6 11 3'12 1 t'6 AH 61738 99 AU 643~4 126 ~;' I'

[1 618"3 122A ti 644u6 55 [) 62047 56 Ab 644u7A 55 H 6201.j7 03 AH 64412A 55 H 62106 17 U 64415 55 H 621'2 17 D 64416 55 D 62175 58 U 64417 55 [) 62230 30 B 64419 96 H 62249 51 AH 644~lA 55 [) 62250 51 At; 6441.j1 58 [) 62'U9 87 l) 645u4 98 0 62439 99 [) 6LtSU5 98 D 62543 87 0 645u6 96 0 62543 99 11 645U7 96 D 62')62 55 H 645U8 96 D 62637 43 0 645~6 95 D 62641 43 0 64560 43 D 62641 105 [) 64560 49 D 6261.12 43 0 64560 Sl 0 62642 10'; AH 64501 49 D 62644 105 AH 64501 51 D 629bO 49 [) 64575. 62 D 62~oO 51 H 647£9 75 [) 63007 75 H 64746 75 D 630'16 12 H 64746A 75 D 630Y6 14 H 64746t3 1'5 0 630Yb 17 H 64817 115 n 63096 20 H 64i:So3 75 H 63103 111 0 o48t1b 109 H 63103 (~ 7 D 64905 43 H 631U3 37 8 64969 43 H 63103 114 L) 65021 1<19 H 63105A 27 H 65030 17 H 63105A 37 I) 65130 79b [) 63163 13 D 65130 100 (J b3200 122A H 653~2A 14 U 6321:)3 53 H 653~2A 114

AH 633jl~ 79f 0 65452 105 AG 63336 13 0 654d2 43

U 63~42 1 3 [) 65614 115 D 636,5 115 ~ 65840 17 0 638~2 105 H 65860 79£j

-141- R6




t1 658bO t:i9 0 66t)~O ,,9

8 65860 100 H 66667 49 B 65861 790 H 66607 51 b 65801 100 D 66703 105

A<i 6~8Y6 114 0 667~0 ~1

AG 6~897 114 0 667~2 49 AH 658'18 1 1 4 [l 667~2 ~1

H 659t!4 T1 D 667~2 ~6 H 659~4 75 H 66762 ';,5 0 6~'I~8 87 D 667'19 100 D 6~9~8 '19 D 668uO i9b 0 659:>8 121 D 66dUO b9 D 0~9ti4 20 0 66800 100 0 6~9t:)5 20 D 66809 49 D 66033 14 D 66941 14 D 660J3 27 0 66941 tlO U 660 .. ;3 37 D 66941 ~:7

D 66033 114 D 66Q41 37 D 660j4 1 LI 0 66941 114 I) 660j4 ~7 D 66941 115 u 66034 37 H 66945A 20 I) 660;;4 1.14 0 669~6 17 0 66035 14 0 669:>6 20 D 660;;5 27 AH 66973 ~3

D 66035 37 0 670uO 89 D 66035 114 ~H 670U4 29 H 660';6 14 AH 670u5 29 H 66036 37 AH 67013 '19 H 66036 llL1 AH 67013 51 8 660j7A 14 D 671~8 122A Ij 66037A 27 K 6710111 71 I:i 660j7A 37 0 67219 64 13 66037A 114 H 67300 49 b 66095 "J7 H 67300 51

A8 66U96 37 H 67301 49 0 66100 37 H 673ul 51 H 66~~8 128 AU 673651.: f.i9

AB 66211 43 AD 673b6A 89 A8 66271A 43 H 67373 45 ~8 662718 43 D 67413 121 AI:; 66271C 43 AD 674JOA 89

D 66318 123 H 674758 f:S9 0 66365 75 AH 67569 ~3

AG 66408 13 D 67600 18 D 664;::8 13 D 67607 18 0 66434 127 K 67610B 71 D 66475 120 D 67616 18 D 66~11 49 0 67617 18 D 66511 51 0 676"-6 l~ D 6653~ 122A 0 67627 18 D 665~2A 61 0 676';4 ~8

D 6651}1 79~ 0 67693 13 0 66~Y 1 ' fi9 G 67704 75 0 66591 101 AH 677b2 109

-142- R6




~ 67793 75 (, b'i343A t 3 ~ b77'13A 75 H 69344 1 3 l) 678U2 100 0 6'i347 13 0 678b9 100 D 693 .. 8 , 3 H 67890 79F H 69349 13 H 678YO 100 H 693~O 1 3 8 b78Yl 79F H 6Y3~OA 13 t! 678<.11 69 8 6'i3~1 17 ,";

[3 6781.i1 lOO 8 693~2 13 {J 678<;9 79F L1 b930B 105 H 679u9 105 H 694U8 12 b 6?9b9 i5 AH 69"11~ ~O 0 68004 75 H 69412A 20 b 65007 75 AH 6941~A ,0

AG 66132H 75 AG 69416A 20 i'

i,' AG 68133b 75 AG 69 tH 7 A (10 AD 6e2..i2 l22A 0 69440 13 AD 66233 122A 0 69534 100

D 68238 83 At; 6'i;lLl 117 H 66239 ~1 AG 695714 119 0 663b3 75 D 695Cl8 43

AR 684~7 107 AH 6958<} 43 D 68625 79F H 6<,169~ 100 D 686~5 100 II H 696'18 lUO D 68634 20 AH 697'9 13 0 6B6j5 13 AH 6<}761 13 0 66635 103 D 69763 119

AU 6H7:,lA lOO At:' 69707 100 D 689bl (0 H 69770 100 D 609b1 30A AG 69762 119 0 689d4 20 0 691311 1 u 3 0 6b9b6 20 lJ 69826 43 H 6&9b7 ~O AK 6<}86HA 1 10 H 6ti9b8 20 0 698(8 73 0 6b990 57 0 6<;8/8A 73 f') 689'i0 5~ 0 69~85 73 G 690e.'1 70 0 698bH 71 0 69024 73 U 69914 69 U 690~5 73 l) 641916 57 [) 69046 49 0 69916 67 0 69046 51 0 6Y916 09 D 6'1046 lu5 0 699~0 66 [) 692U3 12 [) 699(:0 69 0 69210 71 0 699i1 57 D 6'1210 75 0 699~1 69 H 69215 17 0 69924 67 0 692;;7 13 0 699c.7 69 0 692bl 149 0 699~8 69 U 692b1 51 0 699';0 69 U 692bl 105 0 69932 69

AH 692ti7 30 0 6995? 66 AG 69207 30A 0 70019 39

G 693i?OA 17 D 70019 79C G 69343 13 U 70019 100

-143- R6




D 70106 17 D 71346 18 D 70106 63 0 71347 18 D 70106 81 D 713:'3 18 0 70106 91 0 713:'8 18 IJ 70106 101U 0 713~9 18 D 70107 57 [) 7130] 19 n 70107 09 0 71302 18 H 701~8 56 0 71366 18 0 70243 13 D 71309 18 D 702431\ 13 0 713(0 18 H 702L1L1A 09 0 713 f1 18

IIH 70200 49 [) 713(3 19 AH 70200 51 [) 713('6 18 AH 702(2 53 L) 7t3/7 18

B 70510 1.23 D 713U1 18 D 70S17A '-23 D l13d3 19 0 705:'5 49 0 713l:)/~ 19 U 705::>5 51 D 713U5 19 D 70502 73 0 71366 18 D 706()2 79 n 713tl7 18

AD 70610 79 I) 71388 18 [) 70609 73 0 713~1 18 D 70722 71 H 71428 17 D 70764 73 0 71L1Y1 17 0 70804 73 D 714~~ 17 0 70805 73 Il 714\13 17 0 70636 18 0 7\5~5 ,~ 5 0 7()839 18 0 715~6 45 [) 70843 19 U (1~£7A 45 G 710~0 17 H 71529A 45 U 71002 60 D 71534A 45 [) 71063 00 0 71550U lO5 0 71005 60 AH 715::>4A 45 [) 7100/'i bO 0 71So3 73 0 71007 60 D 71564 73 D 7100R 60 D 71505 73 0 71009 60 AG 7164.12 45 [) 71011 bO H l17~lC tl5 D 11074 60 H 71722 65 [) 71075 60 H 71722A 05 D 71017 09 H 717~2(j 65 L) 7l0/'8 69 ~ 717't:.6A 05 D 71079 69 0 717~8 65 0 710bO 69 0 71728A 65 D 710yS 103 0 717:;0 65 0 711 ~4 17 AG 71812 ·/9 \J D 71124 56 AG '(1819 1 ?1 0 7l1~4 57 AG 71S~2A ~5

0 711~4 119~ AG 71d93 25 0 711u3 101b AO .,1944 109 D 71103 101LJ H 719'17 45 U 71207 39 H 71997 105 0 71342' 18 H 71999 45 0 71344 18 H 72000 45

-144- R6



PART NUMBER PAGE NO. I PART NUMBER , PAGE NO. ;i:.

H 72001 l~ 5 0 72827 71 H 720(J2 45 0 728~8 71 H 720v2 05 0 72831 71 H 72003 45 0 (2832 71 H 72003 05 D 72833A 73 H 7?OU4 45 0 72835 71 H 72005 45 0 72836 11 H 720U6 45 l) 72837 71 :';'

AD 720~3 "(5 0 72838 71 D 72054 75 G 72900 46 0 72055 75 H 729~9 2'5

AG 72072 75 H 72930 25 K 72100 66 0 72963 71

AG 72131 45 0 72964 71 G 72201A 63 H 729'18 45 G 722U2A 83 0 73000 71 B 72206 43 B 730'i4 102

AH 72206A 43 [) 73100 67 B 72233 84 D 73101 1,7

/oiG 72244 86 D 73102 67 AG 72244 97 D 731U3 67 AS 72247 86 0 73104 67 AH '12247 97 0 73136 43 AS 7?248 86 G 73174 79C AB 72248 97 G 7~174 81 AS .,2439 79G G 73174 102 AB 724j9 86 8 73175 102 A~ 72439 97 B 73176 102

G 72443A 83 G 73177 102 0 '724!;)8 81 D 73195 67

AK 72491 108 D 73196 67 AH 7251+3 69 AS 73198 113

G 72500 33 A8 73200 113 0 725\;0 25 A8 732~8 91 0 725-;0 113 AS 73229 91 D 72590 117 AB 73248 81 0 72590 1178 0 7324'1A 65 [) 72590 119 0 73316 17 0 726U2 71 0 73318 17 0 72603 84 AD 73319 17 D 72671 84 8 73330 65 0 72674 71 H 73331 65 D 726e1 67 AG 733~6D 65 D 726e6 17 AG 73356E 65 0 72694 fl7 0 733578 65 0 72723 66 0 ·73301 65 0 72764 67 B 73391 49 D 72780 35 B 73391 51 0 727dO 36 0 73400 39 D 72780 39 H 73414A 49 D 727b1 67 H 73414A 51

A~ 72821 79C AH 73409A 108 AS 728?2 79C 0 735~0 99

0 72626 71 AG 73552 87

-145- R6




AG 73552 99 U 73901 94 H 73569 79ti 0 73902 94

AG 73607 87 [) "3903 'J4 AG 736U7 99 0 73904 94

[) 73611 91 [) 739U5 94 D 73613 61 0 73906 94 0 73614 61 0 73907 94 0 73615 61 0 73910 84 l) 73616 61 0 73911 84 () 73617 61 0 7391.7 'l6 0 7361'3 61 0 73927 47 u 736i9 61 0 73933 46 0 736t::0 61 0 739.n 47 0 73621 61 0 73934 46 0 73622 61 0 73935 46 D 736i3 61 0 73935 47 0 736~4 61 0 73936 46 0 736~5 61 0 73936 47 0 73627 61 0 73937 125 0 73630 6\ 0 73938 125 H 73635 121 0 739J9 125 0 73642 61 0 739~0 125 0 73645 61 0 73941 25 0 73647 61 0 739~7 105 0 736~8 61 0 739:'8 105 0 73649 61 H 739,9 105 0 736'0 61 d 73900A 105 0 73659 13 A8 73961A 105 0 73662 18 H 73913 49 H 73739 17 D 739(3 51

AH 73740 I~ 9 AG 73978 29 AH 73"40 51 D '140UO 125 AH 73741 49 0 74001 125 AH '73742 49 t) 74002 125 AH 73742 51 0 740()3 125 AH 73743 49 0 740 fJ4 125 AH 73743 31 0 74005 125

0 738(3 9'5 0 740U6 60 D '73805 79F 0 74007 60 0 738b5 89 [) 740U8 78 0 738d5 1 V 1 0 74009 60 0 738b6 18 0 74011 60 0 738b8 18 0 74012 60 0 73890 18 L) 74013 60 0 '738Yl ~5 0 74016 60 0 73892 94 0 74017 (;0 0 738"'2 95 0 74018 00 0 738'14 95 U 74019 60 0 738\}5 95 iJ 74020 60 0 73896 95 0 740~1 60 0 738'17 95 0 740~3 60 0 7381}8 95 0 74024 60 D 73899 95 0 740~3 77 0 73900 95 D 74044 '77

-146- R6





D 74045 77 D 740'19 1 .~ 6 D 74100 U6 0 7401+6 17 0 741ul 1),6 0 74047 17 D 74102 126 0 7401+8 77 D 74103 126 0 140t+9 77 0 741u4 126 IJ 140~0 77 \) 74103 126 0 74051 '(7 0 741v6 1 :~6 0 '740:;2 77 0 741U1 1~6 0 140:J3 77 Ll 14108 1;~ 6 0 740:>4 77 0 74109 1.26 I) 74055A 77 \) 74110 126 0 740::>6 17 t) 74111 t26 0 74057 77 D 74112 1~6 0 740~8 7' 0 74113 1~6 0 740:)9 '77 D 74114 126 0 740eO 77 \) 7411'S 126 0 740bl 77 0 7 '·d 16 127 U 74062 17 lJ 74117 127 0 740b3 77 0 1H 18 127 lJ 74004 17 i) 74119 127 0 74065A 17 * 0 74120 127

0 14005A 77'd 0 74121 1~7 0 14066 77 [) 741~2 127 0 74067 77 () 74123 61 0 74009 77 U 74124 61 0 740(0 77 0 741~5 61 0 .,4071 l26 [) 741ti~ 62 0 74072 126 D 741~6 !)1 0 74073 1;26 0 741i7 61 U 74014 126 0 741i8 61 0 74015 1?6 0 7412Q 61 D 74016 126 [) 74129 62 0 74077 126 iJ 741.~O 01 0 74018 126 0 74131 01 0 74079 126 0 74132 61 0 740bO 126 D 741J3 01 0 74001 126 0 74134 61 0 740t12 1d6 D 74135 61 0 740d3 126 LJ 741J5 63 0 740b4 126 I) 741,,6 61 0 740b5 t :~6 0 74136 63 l) 74006 1£6 0 74137 61 0 740d7 126 0 741j7 63 0 740d8 126 [) 741.;1 79 () 7401j9 1~6 [) 74138 79 0 74090 126 0 74138 61 0 .,4092 126 0 74138 63 0 740Y3 116 0 74139 61 0 74094 126 0 74139 63 .. U 740'15 126 79 0 741J9 D 74096 126 0 74140 61 0 74097 126 0 74140 63 0 740!18 1),6 0 14140 19 0 740<i8 127 0 74141 61






PART NUMBER PAGE NO. I PART NUMBER , PAGE NO. D 74142 61

0 7411.)7 00 D 74143 61 B 742't5 83 0 "414q 78

0 74145 78 AH 74299 81 i) 74146 7A 0 74302 84

l) 74147 78 D 74321 84

L> 74148 78 0 7432'- 84

0 74149 78 0 74327 84 0 741:'0 78 0 74328 791-"

0 741:)1 78 0 74328 84

D741~2 78 0 743J1 78 * D 74153 62 0 743J,~ 8tl

I) 741::>4 62 H 74424 25 0 741S5 62 AG 744(20 23 0 741~6 62 0 '(4514 66 0 74157 62 Ali 74'j~1 23 0 741~8 62 AG 74521 29 0 .,4159 62 0 74542 d9l) D 74160 62 D 74'543 tOlD D 74161 62 0 7 1.54 ') 30A 0 74102 62 H (,,.547 30A 0 74163 02 0 .,4548 30A 0 74164 62 0 74549 30A D 74105 62 0 74778 61 0 74166 62 I,) 74819 6~ 0 74107 62 0 74820 62 0 74168 62 H 74ts21 30A 0 74169 62 H 74822 30A 0 741(0 62 0 74908 18 0 74111 62 0 74913 57 0 14172 62 t< 74913 66 0 741(2 63 D 749';9 18 0 74173 62 0 74940 18 0 74114 62 D 74941 18 D 74175 62 0 75014 17 0 74176 02 0 75014 5'5 0 74117 62 0 7501' .. 87 0 741(8 62 D 75014 89 D 74179 62 0 75014 Y9 0 741t)O 62 0 75014 100 0 74181 62 0 75147 110 D 741Cl2 62 0 15147A 110 0 741~3 62 0 75148 111 D 741b4 62 0 75151 110 D 741t:s5 62 I,) 751~2 110 0 74186 62 0 75154 110 D 741tH 62 0 75155 111 0 741d8 62 0 7510Q 110 0 741d9 62 0 75173 110 0 74190 62 0 75200 13 0 741';11 62 D 75211 110 D 74193 62 [) 75213 110 0 741'14 63 0 7~216 110 0 "41115' 62 0 71)217 111 D 741Y6 60 [) 75218 110

* Obsolete Number -148- R6




D 75219 111 U 76102 67 D 752~O 111 D 76104 67 f) 75221 111 D 76108 66 U 75223 111 0 7611i1 66 H 7~2(H 49 D "6192 66 H 75218 51 D 76194 66 U 752/9 49 0 761'16 07 H 75'2.'19 105 0 76197 b7 H 75219A 51 0 76198 67 G 75402 06 D 761Y9 06 H 75403 06 0 76200 66 H 75404 66 0 76201 66

AG 7550i~ 105 I) 76204 66 AG 756~4 81 U 76208 67 AB 756~9b 91 0 7620CJ 67 ACi 7';)6/9 29 0 70210 67 AG 75600 29 0 76211 67

I) 7S/o5 105 0 76212 67 0 75707 65 D 76213 07

AD 757CJ4 109 0 76214 67 R 7~827 65 D 76216 67 H 75828 79F 0 76217 67 H 75d~8 89 I) 70222 07 H 7:>8~(j 100 0 762~4 67 0 758.37 79F 0 76225 67

AB 75844 29 U 76240 67 At:! 75844 53 0 76243 79C At! 75846 29 8 76252 66 Arl 75846 53 0 762~3 66 AH 75912 29 D 76254 66 AB 75913 29 0 76255 66 AG 75917 25 0 762~7 67 AG 75918 25 U 762':;)8 67 AG 75922 25 0 76259 07 All 75924 25 0 76200 67 AG 75926 25 0 76264 66

U 759~1 99 D 76205 67 0 759~1 101tj 0 76206 67 0 75951 101U 0 76267 67 0 759'10 105 0 76208 67 H 75992 67 0 76209 07 0 70040 57 I) 76270 67 0 76040 1191j 0 76271 b6 0 76042 1178 0 76272 66 0 76000 11713 0 76261 67 0 160bO 119t1 0 762b2 07 H 76101 105 0 762b5 07 0 761~4 b9 H 762d6 66 U 761~5 110 0 702t:l9 67 0 761~9 110 0 762'i0 b7 0 761::>6 67 0 .,6291 b7 0 761~7 07 0 762114 67 U 761~9 67 0 76301 69 0 76161 66 0 76302 69

-149- R6




D 763()4 69 AH 76614 ~,

U l63u5 69 D 767v3 ('\C:;

0 763U8 69 () 70710 j6 0 76310 69 iJ 76710 40 0 76311 09 L) 767';2 r9F [} 76312 57 0 767';9 101LJ D 76312 66 At; l670S ~9 U 76313 ~) 7 AG 7(:.766 99 D 76313 66 AC, 76"07 99 S 76314 06 0 76834 ] t' D 76315 69 I) 76f:U6 79F 0 76316 69 D 76ed6 ('\9

0 76318 09 I.) 768;)6 1(10 0 763~0 69 H 77014 51 0 l63~1 69 AH 77()tj2 ~1 U 763~2 69 H 77113 06 D 763'£6 b9 H 77113 105 D 763'tJ 09 H 17117 109 0 763;!-9 69 D 77218 69 0 763,:;0 69 0 77219 69

AU 76300 103 D 775U5 71 AD 76303 103 0 77506 71 AIj 76371 66 D 77510 73 Ab 76371 105 u 77512 73

H 763~4 67 () 77515 73 AH 76410 103 D 77516 73

0 76~15 (:,7 LJ 77'S17 73 8 76416 66 D ,·,S18 73

AH 764(:5 103 0 77519 73 AG 764j6 75 D l75i.O 73 AG 764.;7 75 [) 77');21 73

LJ 76443 75 ~.t3 77559 ~3 0 76456 13 0 77562 66 0 76457 105 U 77747 lOt'

AU 7b4b4 105 lJ 77748 102 AD 76405 79F D 7"(749 102 AU 76405 100 [) 77750 102 AD 764(j6 79f [) 177'J1 102 AD 76406 ]00 U 777'J2 102

0 76407 ti5 0 777'J3 102 0 704b8 8') U 777'J4 102 0 764b9 65 D 777':;5 102 D 764':10 65 iJ 777';)6 102 0 764':11 85 D 7'1"7 lO? j) 7b4Y3 85 0 777';)8 102 0 76494 85 0 77759 102 0 76495 b5 0 77760 102 D 764"16 85 0 77763A 109 0 76497 £'·5 H 77705 40 0 764':18 b5 H 778Ul 126 0 '64c.;9 85 A~ 77822A 105 0 76500 85 Ali 7/824 53 0 70559 10? B 77B42 43

AH 76611 ~1 tj 77642A 43

-150- R6


·;--" .. -.-' ,-~.;


PART NUMBER PAGE NO. I PART NUMBER , PAGE NO. ;:~

H 77d42t:! u,3 0 783~6 110 Ab 77879 ~9 [) 78327 110 ~H 771'301 ~9 L) 7B3~9 111) AH 77803 29 D 783~1}A. 110 A8 7780':> 29 [) 78330 110 AR 77895 53 0 'f83J2 110 A8 l78~7 ':>3 0 '03.)3 110 A8 (78'19 ~3 U Hi3j6 110

U 779"17 109 D 783.37 110 A8 779Y9 13 Ll 783j8 1 to AG 780uO 13 0 78339 110

U 7t;OlJ2 1 3 I) 75340 ,. 10 0 78()U3 13 f) 78340A 110 () 780()4 13 I) 7ti341 1.11 H 78006 1 3 [} 7t;342 111 [) 78008 13 () 78343 110 IJ 78009 13 [) 78344 110

AD 7801? 119b D 78345 110 AH 78014 119b !J 78346 110 AH 78015 119b I) 78341 110

[) 780l7A 119b I) 78348 110 AH 78018 119 b U 78349 111 I-IH 78021 119t:! 0 783':>0 110

D 78040 84 [) 783':>1 111 IJ 78004 77 I) 783':>2 110 t) 780bS 77 U 763':>2A t1.0 [) 78000 "6 0 78302 111 n 7B081 66 AD 703(6 S3 0 780d2 "'6 At) 7U377 ~3

0 780d3 06 A8 78301 115 D 780b8 06 A\i 783d~ 115 1I 780b9 fl6 0 783d~ 1-13 A 18107 33 0 783t;SA 43 0 78lU8

8 '. 0 7830SH 43

D 78109 H4 D 78~3b~C 'l3 AG 78135 191;j D 7B306 115 AG 78135 1 17 t;; D 78307 115 AB 751j6 1178 L) 7B.3B8 11'; A8 78136 1198 H 783b9 1\5 AK 78142 119t; 0 78406 91 AG (8147 115 i.l 7t;448 73 At:! 78149 119t:S AK 78Su5 119ti A~ 781::>2 119b 0 f8S06 119t;

D 78103 105 H 78507 119t:! 0 7Blb5 66 0 78508 119t; 0 781b6 66 G 785':>6 93 0 78302 73 Ci 785~6 91 0 78303 73 li 785':>7 Q] 0 783u4 73 C1 785':>7 93 D 783u5 73 Af3 785:J8 91 D 78306 73 A~ 78S':>8 93 D 78313 73 D 785b2 99 0 78314 73 D 78633 18 D 78j1S 73 I) 78647 79f

-151- R6




D 78647 94 I) 79264 73 H 7d6'S7 89t:l AH 79200 105 B lH6'::>7 101t:; AH 79202 105 8 75668 89 [) 793';:)9 106 H 75660 1191j 0 79.,60 106 H 786t;2 117t:; D 79301 106

H 786U3 117d 0 79302 106 H 75653 119t:; 0 79303 106

AH 786Cl4 1191;; 0 79304 106 AH 78655 11913 0 79365 106

H 786d6 1191j I) 7~366 106 AK 78657 119b 0 79367 106 AG 786b8 119t:l 0 79308 106 AK 113609 1198 0 19309 106

0 786110 t19t:l 0 193{0 6 [) 786~1 !191::l 0 19371 106

AK 78698 119t:l D 79372 106 H 78749 71 D 79313 106 1:3 71:3749 7S 0 793'14 66 I) '18940 105 0 193Y6 67

AH 19007 121 D 19397 67 t. 790f1 100 D 193118 67

D 79060 87 0 79399 67 I) 190bO 89b H 794()O 66

0 79000 39l.i H 194Ul 66

0 190bO 99 0 79433 891j

AH 1901.}4 105 0 194J3 89U 0 790"16 105 U 79491 1S D 19197 1 !)S H 19523 91

AH 19198 105 A 795t.6 121 Ll 79201 105 B 79549 121

AH 79203 105 1:3 795:>1 121 AH 79211 tOS B 79'):>3 121 AH 79215 57 0 795')7 7~

H 19~16 49 G 79552 71 H 79216 51 AH 7951:)3 120 0 792't.2 79F At3 7951:)4 120 0 79222 d9 At3 19'jtl5 120 0 792t.2. 101 A8 795(;6 120 D 792.30 105 AH 1951:H 120

AG 19231 89 AH 795b8 120 AG 792.31 100 0 795'73 29

R 79~32 89 AH 79595 25 H 79232 101

* 0 79595 29 AH 797d9 30A

0 792.3/~ 56 D 804bl 70 H 79'l.36 49 0 80402 70 8 79236 51 0 804d3 70 0 79248 790 0 80404 70 0 192':;)7 73 0 804ti5 70 L) 79258 73 0 80457 70 0 792';)9 73 0 804d8 70 0 79260 73 0 80489 70 D 79262. 73 0 804~0 70 U 79263 73 0 804'11 70



~. ,.¢>t. _

:'.~. --"""""';l"::\



D 80492 70 0 82148 117t; A 80613 65 0 821~1 ~5

AH 80813 124 j) 821~1 100 AS 80t314 124 0 821::>4 39

A 809~7 36 0 821~6 23 A 809~'A 36 0 821,8 35 0 810~2 77t; D 82105 35 0 810iO 77'd U 82107 55 H 81043 13 0 82167 798 0 81078 67 0 82111 45 () 81078 89B i.) 82173 100 [) 61079 99 U 821f 4 35 0 810/9 101b U 82H5 13 [) 610(9 1011.) D 82175 117t; H 811U7 89b n 82191 30 G 81112 89'd 0 82202 40 () 81205 120 0 52203 117ti

AiJ 81209 120 U 622u3 1198 A(, 81312 120 l) 822U4 39

D tH330 110 0 H2204 117b l) 81.3 . .11 110 U 622u4 1191::i 0 81332 110 i} 62207 117t! 0 81333 110 u 82210 117'd D 81H 1 79b 0 62211 114'd H 81402 17 D 82211 119b 0 81537 31 0 62212 117t) D 81538L 31 H 82233 77'd tJ 81539 31 0 82243 14 D 81649 120 0 82243 20 [) 81679 120 [) 82243 37 0 81703 75 D 82243 114 8 81704 75 0 52243 115 D 81746 101b D 82273 19 !::! 81871 1391.) 0 8221,,4 '7 B 81till 101tJ AH 62366 79(, 0 618(2 89U AH 82367 79C 0 81872 101U AH 82370 79U 0 819b5 23 AG 823f1 79F D 81968 23 R 82312 79F 0 82062 5, 0 823(3 79'd D 82062 79t3 AS 82376 790 D 82062 103 AI::i 825u2 79U 0 82003 94 0 825U7 79b U 82086 79b D 82507 79~ 0 62006 84 H 62508 79tj U 820~8 94 ,.

82510 791:1 u U 82088 91) G 82510 79f U 82068 100 tj 62543 890 D 82104 17 H 8C:!S"3 101U l) 82106 119B H 82546 791:1 D 82117 81 0 825~5 73 0 82118 75 0 825:J6 73 D 82118 1191:1 AG 82574 75 D 821t:4 790 AG 82575 "5

-153- R6


~~f/'·:



AG 62576 75 AG 84811 1191:i U 82S'i5 73 AG 84M14 1191:j D 8?ft4 36 AG M4854 1191j 0 62f~5 39 H 848!J6 119b 0 827~8 23 0 848':>7 ltqb 0 82742 35 D 849t:'5 94 iJ 821£+5 71 D 850U8 120 I) 821::>0 11 3 [) 85065 78 u 82778 5'5 D 850(5 r, 1 0 8(!/o4 ~C; l) 850/7 i~

* 0 82792 35 [) 85077 39 D 82lY8 :56 H 851~6 10'5 II 82818 19f * 0 85137 31 [) 82H35 100 * 0 85138 31

* 0 85139 31 U 82850 78 B 85153 .3 1 0 ~2852 139 0 851ct7 7QC U 82808 113 AK 852U2 11 QI:)

U 82808 117tj AH d52U5 119b () 8(!8()9 791:;; AG 852U6 119b 0 829;::0 19b AK 852u7 119b I) 82975 f9C AK 852U8 119b 0 82919 105 AK 85209 1190 U 829b2 45 H 85234 128 D 829Y8 75 L> 852J6 12R 0 830UO "9\j AG 85239 1~~

0 830Ul 75 0 85253 7~

0 830U5 75 AG 852::>7 75 0 83006 33 AG 852~8 .,5 [) 83058 1VO 0 852"i3 l7b [) 830()1 105 D 85302 128 0 830t)2 45 H 853U4 79b

AH 838U8 109 A8 853~4 f9\j

D 838~5 35 AH 85325 79\j U 838~5 39 AD 85328 79C

* 0 83826 35 0 853()0 35 U 83dc9 23 U ti41,,6 f9c G B54u4 31 0 841,,7 790 0 85415 75 H 841£+3 67 A8 8~465 105

AU 84309 101b H 6541,;1 79C U 643~3 103 G 8541,;3 OQ()

AO 84347 123 G 85508 10lU D 84348 100 D 85~18 81 .0 84371 79F 0 ~5574 "(9tj D 844Ul 46 0 B57~2 4(' U B4401 47 D 857~2 47

H B4495 117ti D 65754 46 0 84496 1171:)

[} 85754 47 H 84503 8t

D 85755 4('

G 84604 75 D 85755 147 U 847e.7 56 0 B5f56 46

AD 84776 12.3 U 65756 47 Au B47l7 123

0 657~;r 46 AG 84779 123 0 85757 47 AU 84793 123 0 857~8 46 At) 84794 23 U 65758 47

* Obsolete Number -154- * Obsolete Number R6




D 857:;'9 i~ 6 H 89814 'it; 0 857~9 '+ 7 D 90512 94 [') 85760 I~ 6 0 906t10 93 0 8~700 47 19 90d')2 1J8 D 85701 46 G 90942 75 l) 85761 47 () 909b4 7t; G 8srf8 '(1 0 909b5 r5 AH 85819 7'5 AS 90969 75 A8 858~1 l5 A8 909/0 75 AG 858~3 75 0 909(1 rrs AG 858~4 75 D 90972 /5 D 861),;7 79F G 90976 75 [) 860,;8 79f 0 91330 94 0 86040 79F IJ 91560 33 0 86041 19F 0 '11"01 33 [) 1362(5 57 J~ G 91563 23

H 86276 ':J7 8 91';04 33 H 86218 'i7 AG Y1644 75 * D 86325 778 LJ 864~8 106 AG 91645 75 d df:>S19 109 AD 917ijr 17 0 86612 77b AG 91807 33 0 86613 17b 0 9'2./62 62 IJ 86614 r7b 0 92763 63 U 8661'5 77b D 929fS 62 D 86616 77b AG 931:;,1 33 0 86617 77b 0 9](?US 14 0 86618 17d 0 93205 27 l) 86619 77t3 U Q32V5 37 0 B6f>(:0 77b 0 93205 1.14 D 8664::1 77b G 93217 13 D ti66~2 17b 0 93333 Ii 7 0 866~3 f7d 0 960bl 62 t) 866(::'4 7713 G 96139 12 U 86b~5 r7d 8 96140 12 II 866~6 77~ 0 963dH 113 D 86o~7 77'0 /) 96309 11 3 * D 86628 778 0 964J5 73 0 806~9 77'0 0 /366.30 770 n 964,Y r3 IJ 86631 !7t3 D <i6'i27 47 0 86632 77b A 96860 75 H 86611 55 A 96d61 75 0 130'104 12 A 90do2 75 0 867tj4 15 A 961;63 75 IJ 86t3U9 111 AG 96cH 1 113 0 868,;1 ttl 0 961;d5 73 I) ti68J2 111 0 973J4 )14 0 d68J4 111 D 97335 94 D 86d35 111 0 973j6 94 D tl7100 \14 '0 0 97337 94 D 87831 81 0 97338 94 H 87876 lil l) 97347 47 0 138844 93 H 89066 55 0 890'17 1~3

* o bso lete Number -155- R6 . ..r''''''


Documents

Galion 118B Grader Parts Manual - Heavy Equipment · 2017-11-06 · ga-p-118b gdr ggaalliioonn parts manual 118b motor grader this is a manual produced byjensales inc.without the