Upload
others
View
2
Download
0
Embed Size (px)
Citation preview
Fuses and Relays
4 - 1
CONTENTS
PASSENGER COMPARTMENT FUSE AND RELAY BOX (260) 2
ADDITIONAL HEATER 1 AND 2 8
RELAY + COMBUSTION ENGINE RUNNING (1615) 9
UCH (645) 10
PROTECTION AND SWITCHING UNIT (1337) - FUSES - ENERGY MANAGEMENT VERSION 20
PROTECTION AND SWITCHING UNIT (1337) - CONNECTORS - VERSION WITH ENERGY
MANAGEMENT 23
PROTECTION AND SWITCHING UNIT (1337) - FUSES - VERSION WITHOUT ENERGY
MANAGEMENT 29
PROTECTION AND SWITCHING UNIT (1337) - CONNECTORS - VERSION WITHOUT ENERGY
MANAGEMENT 33
ENGINE FUSE AND RELAY BOX (597) ON ENGINES M4R, 2ZV AND 5ZV 39
BATTERY DISCONNECTION MODULE (1144) ON M4R, 2ZV AND 5ZV ENGINES 43
BATTERY RECONNECTION BORNIER (1797) 46
Fuses and Relays
4 - 2
PASSENGER COMPARTMENT FUSE AND RELAY BOX (260)
RETURN TO CONTENTS
Location
This unit is located in the passenger compartment, in the lower left-hand section of the dashboard on
left-hand drive versions.
Fuses and Relays
4 - 3
RETURN TO CONTENTS
Allocation of fuses (according to equipment level)
No. Amps Connection Description
1 -- -- Fuse: not used
2 -- -- Fuse: not used
3 30A BPTJ
Fuse: rear armrest plate (2098) - rear right-hand and left-hand seat
supply relay (2176-2175) - rear right-hand and left-hand seat stop
control (2354-2355)
4 -- -- Fuse: not used
5 -- -- Fuse: not used
6 -- -- Fuse: not used
7 -- -- Fuse: not used
8 15A 172D Fuse: windscreen wiper de-icer (1926)
9 -- -- Fuse: not used
10 -- -- Fuse: not used
11 -- -- Fuse: not used
12 40A 15B Fuse: heated rear screen (200) via anti-interference filter (1886)
13 -- -- Fuse: not used
14 -- -- Fuse: not used
15 -- -- Fuse: not used
16 -- -- Fuse: not used
17 15A BP1L Fuse: flasher unit (137)
18 20A BP75
Fuse: Horn relay control (229) on passenger compartment fuse and
relay box (260)
main electromagnetic horn (105) via horn relay (229) on passenger
compartment fuse and relay box (260)
Fuses and Relays
4 - 4
RETURN TO CONTENTS
Allocation of fuses (according to equipment level)
No. Amps Connection Description
19 20A BP3
Fuse: via passenger compartment electric control unit (645): fuel filler flap
locking motor (844) - rear right-hand door electric control (138) - rear left-
hand door electric control (139)
20 10A BP77 Fuse: passenger compartment electric control unit (645)
21 15A BCP4 Fuse: diagnostic socket (225) - multifunction display (653) - alarm (1838) -
alarm anti-lift sensor (2083) - alarm electric control unit (427)
22 15A BP19
Fuse:
Direction indicator via passenger compartment electric control unit (645):
Via flasher unit (137): rear right-hand lights (172) - rear left-hand lights
(173) - driver's electric rear view mirror (239) - passenger's electric rear
view mirror (240) - right-hand headlight (226) - left-hand headlight (227)
23 30A BP70 Fuse: passenger door multiplexed electric control unit (1123)
24 30A BP55 Fuse: driver's door multiplexed electric control unit (1122)
25 30A BP1B
Fuse: engine running relay control (1615) -
via engine running relay (1615): rear left- and right-hand heated seat
control (2120-2121) - rear armrest plate (2098) - rear left- and right-hand
seat relay (2175-2176) - driver's massage seat electric control unit (2117) -
PASSENGER and DRIVER'S SEAT HEATING AND VENTILATION
CONTROL(2579-2578) - DRIVER'S and PASSENGER SEAT HEATING
AND VENTILATION ELECTRIC CONTROL UNIT (2580-2581)
26 15A BP25
Fuse:
Via passenger compartment electric control unit (645): Rear right-hand and
left-hand fog lights (174-175) - Luggage compartment lid electric locking
(142)
27 -- -- Fuse: not used
28 30A BP93 Fuse: sunroof (304)
29 25A BP89 Fuse: assisted parking brake computer (1217)
30 -- BP47 Fuse location: protected + battery feed towing socket (R360)
Fuses and Relays
4 - 5
RETURN TO CONTENTS
Allocation of fuses (according to equipment level)
No. Amps Connection Description
31 10A BPA7
Fuse:
Via passenger compartment electric control unit (645): right-hand and left-
hand rear lights (172-173) - high level brake light (639)
32 -- -- Fuse: not used
33 25A BP1P Fuse: Radio amplifier (1917)
34 30A BP48
Fuse: multiplexed door matrix control (1667) via electric window relay (703)
on passenger compartment fuse and relay box (260) - child safety relay
control (750) on passenger compartment fuse and relay box (260) - electric
window relay control (703) on passenger compartment fuse and relay box
(260)
35 -- -- Fuse: not used
36 20A BP26 Fuse: radio (261) - assisted parking brake lever control unit (1216) -
navigation assistance control unit (662) - multimedia keypad (1657)
37 10A BP69 Fuse: instrument panel (247)
38 -- -- Fuse: not used
39 20A BT10 Fuse: passenger seat access relay (2357)
40 5A BT4 Fuse: brake light switch (160) - ABS and ESP computer (1094)
41 10A BT6 Fuse: fuel filler flap locking motor (844)
42 25A BPT4
Fuse: driver's massage seat computer (2117) - seat memory computer
(515)
- seat adjustment motor (1400-1402-1404-1471) via driver's seat
adjustment control (1406)
43 25A BPTD Fuse: seat adjustment motors (1401-1403-1405) via front passenger seat
adjustment control (1407) - passenger seat access relay (2357)
Fuses and Relays
4 - 6
RETURN TO CONTENTS
Allocation of fuses (according to equipment level)
No. Amps Connection Description
44 -- -- Fuse: not used
45 -- -- Fuse: not used
46 -- -- Fuse: not used
47 10A BPT7 Fuse: rear electric blind (2064)
48 15A BPTB Fuse: second row accessories socket (1382)
49 10A BT5
Fuse: multi-function display (653) - seat belt warning module (1601)
- rear heating and air conditioning system control (1739) - air quality
control panel (2050) - heating and air conditioning system control panel
(319) - multimedia audio socket (C-box) (1959) - ADDITIONAL HEATING
RELAY control 1 and 2 (1067-1068)
50 30A BT8
Fuse:
On version with rear anti-pinch electric window: rear right-hand electric
window motor (201) - rear left-hand electric window motor (202)
51 5A BT3
Fuse: passenger storage compartment light (168) - left-hand luggage
compartment light (509) - passenger side rear passenger footwell light
(1120) - driver's side rear passenger footwell light (1121) - rear courtesy
light (300) - right-hand and left-hand dashboard ambient light (1932-1933)
- right-hand and left-hand dashboard console ambient light (1934-1935) -
rear right-hand and left-hand courtesy light (214-215) - rear right-hand
and left-hand door light (525-526)
Fuses and Relays
4 - 7
RETURN TO CONTENTS
Allocation of fuses (according to equipment level)
No. Amps Connection Description
52 5A BT1
Fuse: front courtesy light (213) - front passenger footwell light (1118) -
driver's footwell light (1119) - rain and light sensor (1415) - front right-
hand courtesy mirror light (541) - front left-hand courtesy mirror light (588)
53 -- -- Fuse: not used
54 15A BPT9 Fuse: first row cigarette lighter (101)
55 -- -- Fuse: not used
56 15A BPT6
Fuse:
Via steering column controls (1519): Windscreen washer pump (221) -
Passenger compartment electric control unit (645)
57 -- -- Fuse: not used
58 40A BPT5 Fuse: passenger compartment fan assembly power module (1023) -
passenger compartment fan assembly (1156)
Allocation of relays (depending on equipment level)
No. Amps Description
A (R1) 70A Relay: timed non-load shed + battery feed (1762)
B (R2) 40A Relay: timed load shed + battery feed 2 (1761)
C (R3) 20A Micro relay: horn (229)
D (R4) -- Micro relay: not used
F (R5) -- Micro relay: not used
G (R6) -- Micro relay: not used
H (R7) 70A Relay: child safety (750)
I (R8) 70A Relay: heated rear screen (235)
J (R9) 70A Relay: timed load shed + battery feed 1 (1760)
K (R10) 40A Relay: electric window (703)
Fuses and Relays
4 - 8
ADDITIONAL HEATER 1 AND 2
RETURN TO CONTENTS
Location
This unit is located in the central section of the dashboard, on the right-hand side of the passenger
compartment fan assembly.
Allocation of relays (depending on equipment level)
No. Amps Description
A 40A Relay: additional heater 1 (1067)
B 70A Relay: additional heater 2 (1068)
Fuses and Relays
4 - 9
RELAY + COMBUSTION ENGINE RUNNING (1615)
RETURN TO CONTENTS
Location
This relay is located under the passenger seat.
Allocation of relays (depending on equipment level)
Amps Description
40A Internal combustion engine running + relay
Fuses and Relays
4 - 10
UCH (645)
RETURN TO CONTENTS
Location
This unit is located in the passenger compartment, in the lower left-hand section of the dashboard.
Fuses and Relays
4 - 11
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
PE1 (40-track connector) BLACK
Track Connection Description
1 26AZ Keyless vehicle steering column lock CAN H signal
2 -- Not used
3 26BA Keyless vehicle steering column lock CAN L signal
4 6BN Passenger's door CAN L signal
5 6BM Front passenger's door CAN H signal
6 64Q Central flasher unit timer control
7 19F + dimmer switch
8 -- Not used
9 -- Not used
10 26BV UCH line protection signal, protection and switching unit
11 -- Not used
12 -- Not used
13 -- Not used
14 20M Door locking LED
15 -- Not used
16 20DE Passenger door locking signal on version with additional equipment for Korea
17 20DC Driver's door locking signal
18 -- Not used
19 -- Not used
20 20G Tailgate motor opening control
Fuses and Relays
4 - 12
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
PE1 (40-track connector) BLACK
Track Connection Description
21 -- Not used
22 CANH CAN H fault finding signal
23 CANL CAN L fault finding signal
24 6AP Door multiplex CAN L signal
25 6AN Door multiplex CAN H signal
26 87B Right-hand rear position 1 switch - signal
27 87H Driver's position 1 signal switch
28 20AW One-touch door locking/unlocking control
29 87G Passenger position 1 switch - signal
30 26B Card presence + signal
31 87A Left-hand rear position 1 switch - signal
32 -- Not used
33 67G Electric control unit reactivation signal > horn
34 65A Brake lights + control
35 5A Brake pedal switch + signal supply
36 87T Rear luggage compartment door position 1 switch signal
37 16A Windscreen washer pump + control feed
38 -- Not used
39 24A Rear screen washer pump + control
40 14S Rain sensor serial line signal
Fuses and Relays
4 - 13
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
PE2 (40-track connector) GREY
Track Connection Description
1 64F Hazard warning lights indicator light + control
2 26BC Card location LED control
3 26M Engine running indicator light control
4 26BH + Card reader
5 141D Column-mounted information display control line 3 signal
6 141L Column-mounted information display control column 2 signal
7 141K Column-mounted information display control column 1 signal
8 141N Column-mounted information display control column 4 signal
9 141H Column-mounted information display control line 5 signal
10 141G Column-mounted information display control line 4 signal
11 141R Steering column control information display column 6 signal
12 141P Column-mounted information display control column 5 signal
13 141M Column-mounted information display control column 4 signal
14 26BD Card reader/UCH synchronisation signal
15 134D Timed non-load shed + battery feed 2 relay control on rear seat type 02 version
16 23Y Rear right-hand anti-pinch electric window motor serial signal on version with
opening panoramic roof and rear electric window with anti-pinch function
17 26J Safety Hall sensor - control feed
18 26BG Card reader/UCH data signal
19 141Q Steering column control information display line 6 signal
20 38MY Engine running relay control
Fuses and Relays
4 - 14
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
PE2 (40-track connector) GREY
Track Connection Description
21 -- Not used
22 -- Not used
23 20DA Fuel filler flap interior opening control
24 -- Not used
25 -- Not used
26 -- Not used
27 -- Not used
28 26N Engine start/stop + signal feed
29 26BK - Card reader
30 141C Column-mounted information display control line 2 signal
31 141B Column-mounted information display control line 1 signal
32 23X Rear left-hand anti-pinch window motor serial signal
33 134A Timed load shed + battery feed relay control
34 -- Not used
35 23EA Rear electric window relay control
36 38JU PASSENGER COMPARTMENT HEATING RESISTANCE CONTROL RELAY 1
37 67D Horn relay control
38 134B Timed non-load shed + battery feed relay control
39 15M Heated rear screen relay - control
40 38JV PASSENGER COMPARTMENT HEATING RESISTANCE CONTROL RELAY
2PASSENGER
Fuses and Relays
4 - 15
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
PE3 (40-track connector) GREEN
Track Connection Description
1 26AX Keyless vehicle internal aerial 3 signal 1
2 26AY Keyless vehicle central internal aerial 2 signal
3 -- Not used
4 -- Not used
5 26AM Keyless vehicle boot lid external aerial signal
6 26AD Keyless vehicle right-hand front door external aerial signal 2
7 26AC Keyless vehicle front passenger door external aerial signal
8 26AU Keyless vehicle front internal aerial 2 signal
9 26AT Keyless vehicle internal aerial 1 signal 1
10 26AB Keyless vehicle driver's door external aerial signal B
11 26AA Keyless vehicle driver's door external aerial signal
12 -- Not used
13 -- Not used
14 -- Not used
15 -- Not used
16 -- Not used
17 -- Not used
18 -- Not used
19 -- Not used
20 26P + Door handle infrared sensor feed
Fuses and Relays
4 - 16
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
PE3 (40-track connector) GREEN
Track Connection Description
21 26AN Keyless vehicle boot lid external aerial signal 2
22 26AV Keyless vehicle internal aerial 2 signal 1
23 26AW Keyless vehicle internal aerial 2 signal 2
24 13AS Interior opening control lighting control on version with equipment level EA3
25 109B Variable power-assisted steering motor phase B control
26 109A Variable power-assisted steering motor phase A control
27 109D Variable power-assisted steering motor phase C control
28 109E Variable power-assisted steering motor phase D control
29 -- Not used
30 -- Not used
31 -- Not used
32 -- Not used
33 -- Not used
34 26AP Keyless vehicle driver's side doors switch/locking signal
35 26Q Passenger side door handles infrared sensor signal
36 26T Driver's door handle infrared sensor signal
37 -- Not used
38 -- Not used
39 -- Not used
40 -- Not used
Fuses and Relays
4 - 17
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
PP1 (12-track connector) BLACK
Track Connection Description
1 64C left-hand direction indicator control
2 18A Luggage compartment light control
3 13C courtesy light control - left-hand direction indicator control
4 -- Not used
5 64D right-hand direction indicator control
6 -- Not used
7 APCB Protected + after ignition feed/steering column lock normally closed contact fuse
8 -- Not used
9 26I + steering column lock
10 -- Not used
11 -- Not used
12 BP77 Protected + battery feed > passenger compartment ECU
Fuses and Relays
4 - 18
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
PP2 (12-track connector) BROWN
Track Connection Description
1 -- Not used
2 MAY Cab earth
3 BPA7 Brake lights protected battery + feed
4 65K Brake lights/ UCH control
5 13AY Rear courtesy light control
6 -- Not used
7 20D Central door locking closing + control
8 20BD Front/rear passenger door opening motors control
9 -- Not used
10 20S Tailgate opening motor authorised supply
11 9P Protected + rear fog lights control feed
12 -- Not used
Fuses and Relays
4 - 19
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
PA (4-track connector) BLACK
Track Connection Description
1 BP19 Protected + battery > central flasher unit timer feed
2 MAY Cab earth
3 BP25 Rear screen wiper protected + battery feed
4 BP3 Electric central door locking fuse protected + battery feed.
Aerial connector (1895) - Mark 1
Track Connection Description
1 26H Radiofrequency signal
2 26K Radiofrequency signal reference
Fuses and Relays
4 - 20
PROTECTION AND SWITCHING UNIT (1337) - FUSES - ENERGY MANAGEMENT VERSION
RETURN TO CONTENTS
Location
This unit is located on the engine interconnection unit (in the engine compartment).
Fuses and Relays
4 - 21
RETURN TO CONTENTS
Allocation of fuses (according to equipment level)
No. Amps Connection Description
F1 30A 14K
Fuse: windscreen wiper motor (212) 14L
F2 30A BP14 Fuse: ABS and/or ESP computer (1094)
F3 20A
3N Fuse: fuel level/temperature/level sensor (1993)
3BS Fuse: transistorised coils (1309-1310-1311-1312-1313-1314)
-- Fuse: not used
F4 5A AP44
Fuse: Brake light switch (160)
On version with discharge bulb: right-hand headlight (226) - left-hand
headlight (227)
F5 15A AP10
Fuse: shift pattern control (129) - diagnostic socket (225) - Heated rear
screen relay control (235) on passenger compartment fuse and relay box
(260) - speed limiter and cruise control on/off switch (1081) - gear lever
display (1129) - parking distance control electric control unit (1222) - blind
spot warning electronic control unit (2391) - interior rear view mirror (1340)
On discharge bulb version: discharge bulb electric control unit (989) - left-
hand and right-hand headlight adjustment motor (537-538)
F6 10A AP25
Fuse: airbag/pretensioner electric control unit (756) - electric steering
column lock (1088) with keyless vehicle version - steering wheel controls
(1519)
Fuses and Relays
4 - 22
RETURN TO CONTENTS
Allocation of fuses (according to equipment level)
No. Amps Connection Description
F7 7.5A AP4
Fuse: automatic gearbox multifunction switch (779) - gearbox input speed
sensor (1060) - gearbox electric control unit (119) - windscreen wiper relay
control (1140)
F8 -- -- Fuse: not used
F9 20A
38R Fuse: air conditioning clutch (171)
39H Fuse: headlight washer pump (219)
39G Fuse: headlight washer pump (219)
-- Fuse: not used
F10 25A
3FB Fuse: injection electric control unit (120)
3FB1 Fuse: left-hand and right-hand side upstream oxygen sensor (1464-1465)
3FB2
Fuse: right-hand and left-hand side camshaft dephaser (1462-1463) - left-
hand and right-hand side downstream oxygen sensor (1466-1467) - petrol
vapour absorber (371) - variable inlet solenoid valve (768) - fuel tank
breather solenoid valve (788)
F11 15A 3FB3 Fuse: injectors (193-194-195-196-197-198) - injection air flowmeter (799)
F12 10A AP11
Fuse:
via reversing lights relay (602) on engine fuse and relay box (597): Rear
right-hand and left-hand lights (172-173) via protection and switching unit
(1337) - Rear electric blind (2064)
F13 5A AP15 Fuse: injection electric control unit (120)
F14 20A BP42 Fuse: gearbox electric control unit (119)
F15 25A 1A Fuse: starter (163)
Fuses and Relays
4 - 23
PROTECTION AND SWITCHING UNIT (1337) - CONNECTORS - VERSION WITH ENERGY
MANAGEMENT
RETURN TO CONTENTS
Location
This unit is located on the engine interconnection unit (in the engine compartment).
Fuses and Relays
4 - 24
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
CL (2-track connector) BLACK
Track Connection Description
1 BP12 Protected battery feed > passenger compartment 2
2 BP13 Protected battery feed > passenger compartment 3
CT1 (12-track connector) GREY
Track Connection Description
1 4DM ABS multiplex line H SIGNAL
2 CANH CAN H fault finding signal
3 133B Instrument panel CAN H signal > ECU
4 -- Not used
5 32B Oil level sensor signal 1
6 32A Oil level sensor signal 2
7 4DN ABS multiplex line L SIGNAL
8 133C Instrument panel CAN L signal > ECU
9 CANL CAN L fault finding signal
10 -- Not used
11 26BV UCH line protection signal / protection and switching unit
12 3M Canister bleed solenoid valve (petrol vapour absorber) - control
CM (6-track connector) GREEN
Track Connection Description
1 MAS Front left-hand side member electrical earth
2 3N + fuel pump
3 BP14 Protected + battery feed > ABS system
4 14K + Windscreen wiper low-speed timer control feed
5 14L + Windscreen wiper high-speed timer control feed
6 AP10 Brake lights fuse protected + after ignition feed
Fuses and Relays
4 - 25
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
CT2 (12-track connector) GREY
Track Connection Description
1 5KH - front one-touch control
2 66G Reversing lights switch/engine protection unit control
3 5KC Decrease speed one-touch control signal
4 -- Not used
5 -- Not used
6 -- Not used
7 5KB Increase speed one-touch control signal
8 -- Not used
9 -- Not used
10 -- Not used
11 -- Not used
12 -- Not used
CN2 (16-track connector) BROWN
Track Connection Description
1 -- Not used
2 -- Not used
3 -- Not used
4 AP25 + protected after ignition airbag fuse feed
5 NAN Left-hand dashboard cross member electronic earth
6 14M Windscreen wiper park position control > computer
7 -- Not used
8 39H Headlight washer relay 2 + control feed
9 39G Headlight washer relay 1 + control feed
10 RPG + Left-hand protected main beam headlight
11 LPD + Protected right-hand side light
12 CPD + Right-hand protected dipped beam headlight feed
13 11T Left-hand daytime running light protected + control
14 8E + Front left-hand fog light > Resistor
15 -- Not used
16 Rear left-hand
light connection
+ Protected left-hand side light feed
Fuses and Relays
4 - 26
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
MM (6-track connector) GREY
Track Connection Description
1 49B Fan assembly + control
2 BP31 Injectors fuse protected + battery feed > Fuel pump
3 -- Not used
4 49T Low speed fan assembly relay high speed relay control 2
5 1A Starter solenoid + control > relay
6 BP42 protected + battery feed > automatic gearbox computer
MT1 (12-track connector) BLACK
Track Connection Description
1 BP1C Protected + battery > protection and switching unit
2 28A Oil pressure warning light - Control
3 -- Not used
4 -- Not used
5 3M Petrol vapour absorber canister bleed solenoid valve - control
6 32A Oil - oil level sensor signal 2
7 -- Not used
8 2N Alternator sequenced bit signal
9 49X Relay 2 parallel control
10 2Y Battery disconnection unit current sensor signal
11 -- Not used
12 32B Oil - oil level sensor signal 1
Fuses and Relays
4 - 27
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
MT2 (12-track connector) BROWN
Track Connection Description
1 -- Not used
2 -- Not used
3 49V Serial/parallel fan assembly relay coil - control
4 5KC Decrease speed one-touch control signal
5 66G Reversing lights switch/engine protection unit control
6 5KH - front one-touch control
7 2U Battery disconnection unit switch control 1
8 2V Battery disconnection unit switch control 2
9 -- Not used
10 -- Not used
11 -- Not used
12 5KB Increase speed one-touch control signal
MN (16-track connector) WHITE
Track Connection Description
1 3BS Ignition coil control
2 AP4 + Protected automatic gearbox fuse after ignition feed
3 -- Not used
4 -- Not used
5 3FB2 + Injection > Protective relay
6 -- Not used
7 -- Not used
8 -- Not used
9 AP11 Reversing lights fuse protected + after ignition feed
10 38R Air conditioning clutch + control feed
11 3AC Fuel pump relay coil - control
12 3FB3 + Injection > Protective relay
13 3FB1 + Injection > Protective relay
14 66G Reversing lights switch/engine protection unit control
15 -- Not used
16 3AA Injection authorisation relay coil - control feed
Fuses and Relays
4 - 28
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
CN1 (16-track connector) GREY
Track Connection Description
1 NBE Lining electronic earth
2 3FB + Injection supply > protective relay
3 -- Not used
4 AP15 Protected + after ignition feed/Engine functions fuse
5 66H Reversing lights/engine protection unit control
6 -- Not used
7 CPG + Left-hand protected dipped beam headlight feed
8 -- Not used
9 LPDA + Protected right-hand side light
10 APCB Protected + after ignition feed/steering column lock normally closed contact
fuse
11 8F + Front right-hand fog light > Resistor
12 -- Not used
13 AP44 Electric power-assisted steering ECU fuse protected + after ignition feed
14 LPG + Protected left-hand side light feed
15 RPD + Right-hand protected main beam headlight
16 11S Right-hand daytime running light protected + control
Fuses and Relays
4 - 29
PROTECTION AND SWITCHING UNIT (1337) - FUSES - VERSION WITHOUT ENERGY
MANAGEMENT
RETURN TO CONTENTS
Location
This unit is located on the engine interconnection unit (in the engine compartment).
Fuses and Relays
4 - 30
RETURN TO CONTENTS
Fuse allocation (according to equipment level).
No. Amps connector Connection Description
F1 10A
AN track 1 LPDA Fuse: right-hand headlight (226)
CN track 5 LPD
Fuse: first row cigarette lighter (101) - rear right-hand light
(172) - ESP on/off button (1106) - assisted parking brake
lever control unit (1216) - parking proximity sensor switch
(1440) - hazard warning lights switch (1391) - headlight
adjustment rheostat switch (1390) - ashtray light (1498) -
fuel filler flap control (1515) - right-hand number plate light
(166) - left-hand number plate light (167) - rear left-hand
heated seat control (2120) - rear right-hand heated seat
control (2121) - blind spot warning system control (2378) -
front courtesy light (213) - gear lever display (1129)
F2 10A
AN track 5
Rear left-
hand light
connection
Fuse: left-hand headlight (227)
CN track 12 LPG Fuse: rear right-hand electric window control (130) - rear left-
hand electric window control (131) - rear left-hand light (173)
F3 15A CN track 11 39H
Fuse: headlight washer pump (219) CN track 7 39G
F4 20A AN track 2 8E Fuse: front left-hand fog light(177)
AN track 3 8F Fuse: front right-hand fog light (176)
F5 10A AN track 7 RPG Fuse: left-hand headlight (227)
F6 10A AN track 8 RPD Fuse: right-hand headlight (226)
F7 15A CM track 1 AP10
Fuse: shift pattern control (129) - heated rear screen relay
control (235) on board (260) - gear lever display (1129) -
parking distance control electric control unit (1222) - blind
spot warning electronic control unit (2391) - interior rear-view
mirror (1340) - DIAGNOSTIC SOCKET (225)
Fuses and Relays
4 - 31
RETURN TO CONTENTS
Allocation of fuses (according to equipment level)
No. Amps Connector Connection Description
F8 30A CM track 2 BP14 Fuse: anti-lock braking unit/electronic stability program
electric control unit (1094)
F9 30A CN track 4 14L Fuse: windscreen wiper motor (212)
CN track 9 14K Fuse: windscreen wiper motor (212)
F10 10A CN track 8 AP25
Fuse: airbag/pretensioner electric control unit (756) -
electric steering column lock (1088) - steering wheel
controls (1519)
F11 -- MN track 06 -- Fuse: not used
F12 7.5A MN track 13 AP4
Fuse:
On continuously variable transmission automatic gearbox
version: gearbox primary sensor (1724) - multifunction
switch (485) - gearbox electric control unit (119) -
windscreen wiper relay control (1140)
F13 25A
CN track 6 3FB Fuse: injection electric control unit (120)
MN track 1 3FB1 Fuse: engine functions
MN track 2 3FB2 Fuse: engine functions
F14 15A MN track 3 3FB3 Fuse: engine functions
F15 20A MN track 8 BP42 Fuse: gearbox electric control unit (119)
F16 5A CN track 3 AP44
Fuse: brake light switch (160) - right-hand headlight (226)
- left-hand headlight (227)
MN track 4 AP44 Fuse: power-assisted steering pump assembly (186)
F17 10A MN track 14 AP11
Fuse:
via reversing lights switch relay (602) on board (597)
- REAR RIGHT-HAND and LEFT-HAND LIGHT (172-
173) via protection and switching unit (1337)
F18 15A CN track 10 APCB Fuse: steering column electric lock (1088) via passenger
compartment electric control unit (645)
F19 25A MM track 3 1A Fuse: starter (163)
F20 -- -- -- Fuse: not used
Fuses and Relays
4 - 32
RETURN TO CONTENTS
Allocation of fuses (according to equipment level)
No. Amps connector Connection Description
F21 20A MN track 15 BP44
Fuse: injection computer supply (120) via motorised
throttle valve relay (1534) on board (597) - motorised
throttle valve relay control (1534) on board (597)
F22 10A MN track 10 38R Fuse: air conditioning clutch (171)
F23 5A CT1 track 4 AP15 Fuse: injection electric control unit (120)
F24 20A AN track 4 CPG Fuse: left-hand headlight (227)
F25 20A AN track 6 CPD Fuse: right-hand headlight (226)
Fuses and Relays
4 - 33
PROTECTION AND SWITCHING UNIT (1337) - CONNECTORS - VERSION WITHOUT ENERGY
MANAGEMENT
RETURN TO CONTENTS
Location
This unit is located on the engine interconnection unit (in the engine compartment).
112 6
13
MM
46
19
15
13
18
AN
CN
02
501
09
03
1
41 3
8
8
MN
CM
41
05 06 04
12M
T2
11
MT
1
17
7
10
14
16
21
12
23
SE2672
1
CL
71
2
712
6
CT
1C
T2
16
63
07
22
24
08 25
16
71
7
61
12
612
Fuses and Relays
4 - 34
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
CL (2-track connector) BLACK
Track Connection Description
1 BP12 Protected battery + feed > passenger compartment 2
2 BP13 Protected + battery feed > passenger compartment 3
CM (6-track connector) BLACK
Track Connection Description
1 AP10 Brake lights fuse protected + after ignition feed
2 BP14 Protected + battery feed > ABS system
3 MAS Left-hand front side member electronic earth
4 -- Not in use
5 -- Not in use
6 NBE Front left-hand wing lining 3 electronic earth
CN (12-track connector) BROWN
Track Connection Description
1 -- Not in use
2 66H Reversing lights/engine protection unit control
3 AP44 Electric power-assisted steering ECU fuse protected + after ignition feed
4 14L Windscreen wiper high speed timer + control supply
5 LPD + Protected right-hand side light
6 3FB + Injection supply > protective relay
7 39G Headlight washer relay 1 + control feed
8 AP25 + protected after ignition airbag fuse feed
9 14K Windscreen wiper low speed timer + control supply
10 APCB Protected + after ignition feed/column lock normally closed contact fuse
11 39H Headlight washer relay 2 + control feed
12 LPG + Protected left-hand side light feed
Fuses and Relays
4 - 35
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
CT1 (12-track connector) GREY
Track Connection Description
1 CAN L CAN L fault finding signal
2 4DN ABS CAN L signal
3 4DM ABS CAN H signal
4 AP15 Engine functions fuse protected + after ignition feed
5 -- Not in use
6 -- Not in use
7 3SN Engine CAN L signal
8 CAN H CAN H fault finding signal
9 3SM Engine CAN H signal
10 14M Front wiper park position control > Computer
11 -- Not in use
12 -- Not in use
CT2 (12-track connector) GREY
Track Connection Description
1 4GK Flywheel speed A signal
2 4GL Flywheel speed B signal
3 -- Not in use
4 26BV UCH line protection signal / protection and switching unit
5 -- Not in use
6 -- Not in use
7 -- Not in use
8 -- Not in use
9 -- Not in use
10 -- Not in use
11 NAN Instrument panel right-hand upper cross member electronic earth
12 -- Not in use
Fuses and Relays
4 - 36
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
AN (8-track connector) BROWN
Track Connection Description
1 LPDA + Protected right-hand side light
2 8E + Front left-hand fog light > Resistor
3 8F + Front right-hand fog light > Resistor
4 CPG + Left-hand protected dipped beam headlight feed
5
Rear left-
hand light
connection
+ Protected left-hand side light feed
6 CPD + Right-hand protected dipped beam headlight feed
7 RPG + Left-hand protected main beam headlight
8 RPD + Right-hand protected main beam headlight
MT1 (12-track connector) BLACK
Track Connection Description
1 2N Alternator synchronous bit signal (charge signal controlled by Protection and
Switching Unit
2 -- Not in use
3 BP1C Protected + battery feed > protection and switching unit
4 -- Not in use
5 -- Not in use
6 -- Not in use
7 28A Oil pressure warning light - Control
8 -- Not in use
9 49X Fan assembly relay coil serial/parallel - control
10 -- Not in use
11 -- Not in use
12 -- Not in use
Fuses and Relays
4 - 37
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
MT2 (12-track connector) BROWN
Track Connection Description
1 -- Not in use
2 -- Not in use
3 -- Not in use
4 -- Not in use
5 4GL Flywheel speed B signal
6 4GK Flywheel speed A signal
7 -- Not in use
8 -- Not in use
9 -- Not in use
10 -- Not in use
11 -- Not in use
12 -- Not in use
MM (6-track connector) GREY
Track Connection Description
1 -- Not in use
2 49L Fan assembly low speed resistor + control
3 1A + starter motor solenoid control > relay
4 BP31 Injector fuse protected + battery supply > fuel pump
5 -- Not in use
6 BP7 protected + battery feed > engine cooling fan assembly fuse 1
Fuses and Relays
4 - 38
RETURN TO CONTENTS
Allocation of connectors (depending on equipment level)
MN (16-track connector) WHITE
Track Connection Description
1 3FB1 + Injection supply > protective relay
2 3FB2 + Injection supply > protective relay
3 3FB3 + Injection supply > protective relay
4 AP44 Electric power-assisted steering ECU fuse protected + after ignition feed
5 3AA Injection locking relay coil - control
6 -- Not in use
7 -- Not in use
8 BP42 Protected + battery feed > automatic gearbox computer
9 -- Not in use
10 38R + Air conditioning clutch control feed
11 66G Reversing lights switch/engine protection unit control
12 -- Not in use
13 AP4 protected + after ignition feed automatic gearbox fuse
14 AP11 Reversing lights fuse protected + after ignition feed
15 BP44 + Protected battery > injector power
16 -- Not in use
Fuses and Relays
4 - 39
ENGINE FUSE AND RELAY BOX (597) ON ENGINES M4R, 2ZV AND 5ZV
RETURN TO CONTENTS
Location
This board is located in the engine compartment connection unit.
Fuses and Relays
4 - 40
RETURN TO CONTENTS
Allocation of fuses (according to equipment level)
No. Amps Connection Description
FH1 80A BP11
Fuse:
- supply of fuses F28, F29, F30, F31 on passenger compartment fuse
and relay box (260) - Timed relay control (1760) on passenger
compartment fuse and relay box (260)
- supply of fuses F45, F46, F47, F48, F53, F54, F55, F56, F57 and F58
on passenger compartment fuse and relay box (260) via timed relay
(1760) on passenger compartment fuse and relay box (260)
FH2 80A BP12
Fuse: supply of fuses F39, F40, F41, F42, F43, F44, F49, F50, F51 and
F52 on passenger compartment fuse and relay box (260) via timed relay
(1762) on passenger compartment fuse and relay box (260) - protection
and switching unit (1337) - Timed relay control (1762) on passenger
compartment fuse and relay box (260)
FH3 40A BP8 Fuse: ABS and/or ESP computer (1094)
FH4 80A BP23
Fuse: supply of fuses F8 and F12 on passenger compartment fuse and
relay box (260) via heated rear screen relay (235) on passenger
compartment fuse and relay box (260) - supply of fuses F32, F33, F34,
F35 on passenger compartment fuse and relay box (260)
FH5 60A BP91 Fuse: passenger compartment additional heater (1113) via additional
heater relay 2 (1068)
FH6 60A BPT3
Fuse: supply of fuse F3 on passenger compartment fuse and relay box
(260) via timed load shed relay 2 (1761) on passenger compartment fuse
and relay box (260) - timed load shed relay 2 control (1761) on
passenger compartment fuse and relay box (260) - supply of fuses F25,
F26 and F27 on passenger compartment fuse and relay box (260)
FH7 30A BP9 Fuse: passenger compartment additional heater (1113) via additional
heater 1 relay (1067)
FH8 -- -- Fuse: not used
Fuses and Relays
4 - 41
RETURN TO CONTENTS
Allocation of fuses (according to equipment level)
No. Amps Connection Description
FM1 60A
BP7B
Fuse on version 2ZV AND 5ZV : via fan assembly high-speed
relay (1856) on engine fuse and relay box (597): cooling and air
conditioning fan assembly (262) - protection and switching unit (1337)
BP7
Fuse for M4R engine:
Protection and Switching Unit (1337) - Fan assembly high speed relay
control (1856) on engine fuse and relay box (597)
- via fan assembly high-speed relay (1856) on engine fuse and relay
box (597): fan assembly (188) - AIR CONDITIONING FAN ASSEMBLY
RESISTOR (321)
FM2 -- -- Fuse: not used
FM3 -- -- Fuse: not used
FM4 40A BP7A
Fuse: cooling fan assembly (188) - serial/parallel fan assembly relay
control (1831) on engine fuse and relay box (597) - fan assembly high-
speed relay control (1856) on engine fuse and relay box (597)
FM5 -- -- Fuse: not used
FM6 -- -- Fuse: not used
FM7 -- -- Fuse: not used
FM8 -- -- Fuse: not used
FM9 -- -- Fuse: not used
Fuses and Relays
4 - 42
RETURN TO CONTENTS
Allocation of fuses (according to equipment level)
No. Amps Connection Description
FM10 30A BP33
Fuse on M4R version:
via LPG pump module relay (2014) on board (597): LPG pump module
(2013) - LPG pump filter cut-off solenoid valve (2018) - LPG rail cut-off
solenoid valve (2019)
FM11 -- -- Fuse: not used
FM12 -- -- Fuse: not used
FM13 -- -- Fuse: not used
D1 -- -- Diode: not used
D2 -- -- Diode: not used
D3 -- 49A Diode: engine cooling fan (188)
D4 -- -- Diode: not used
Allocation of relays (depending on equipment level)
No. Amps Description
A 20A Relay: reversing light (602)
B 20A
Motorised throttle valve safety relay (1315) on version 2ZV AND 5ZV
Or
Motorised throttle valve (1534) relay on version M4R
C -- Relay: not used
D -- Relay: not used
E 70A Relay: fan assembly high speed (1856)
F -- Relay: not used
G -- Relay: not used
H 40A Relay: LPG pump module (2014) on version M4R
J 40A Relay: serial/parallel fan assembly (1831)
Fuses and Relays
4 - 43
BATTERY DISCONNECTION MODULE (1144) ON M4R, 2ZV AND 5ZV ENGINES
RETURN TO CONTENTS
Location
This unit is located on the side of the battery.
Fuses and Relays
4 - 44
RETURN TO CONTENTS
Location: This unit is located on the battery side.
Allocation of fuses (according to equipment level)
Connector A
No. Amps Connection Description
F4 300A BPDB
Fuse: alternator (103) - Supply to fuses (FH1-FH2-FH3-FH4-FH5-
FH6-FH7-FH8 & FM1-FM2-FM3-FM4-FM5-FM6-FM7-FM8-FM9) on
engine fuse and relay box (597)
Connector B
No. Amps Connection Description
F1 Rating 3 BPDA Fuse: Starting (163) on M4R engines
Connector C
No. Amps Connection Description
F3 80A BP13 Fuse: Supply of fuses (F36, F37, F38) on passenger compartment
fuse and relay box (260) - protection and switching unit (1337)
F2 50A BPS1 Fuse: supply of fuses (F17-F18-F19-F20-F21-F22-F23-F24) on
passenger compartment fuse and relay box (260)
Fuses and Relays
4 - 45
RETURN TO CONTENTS
Allocation of fuses (according to equipment level)
Connector D
No. Amps Connection Description
F6 35A BP31
Fuse: protected + battery feed: protection and switching unit (1337) -
On version 2ZV AND 5ZV: supply to control and power circuit of
throttle valve motor relay (1315) on engine relay unit (597)
On M4R version: fuse F10 supply on engine fuse and relay box
(597)
F5 80A BP81 Fuse: power-assisted steering pump assembly (186)
Connector E (fuse F7 and battery disconnection control outputs)
Track Amps Connection Description
1 (F7) 5A BP1C Fuse: protection and switching unit (1337) - battery current sensor
(928)
2 -- 2V Battery disconnection unit switch control 2
3 -- 2U Battery disconnection unit switch control 1
Connector F
Track Amps Connection Description
1 -- -- Not in use
Fuses and Relays
4 - 46
BATTERY RECONNECTION BORNIER (1797)
RETURN TO CONTENTS
Location
This unit is situated in the boot on the battery side.
Allocation of fuses (according to equipment level)
No. Amps Connection Description
F1 300A BPDA Fuse:
via shunt unit (466): battery disconnection module (1144) - starter (163)
F2 -- -- Not in use
F3 60A BPS1 Fuse: Supply of fuses (F17-F18-F19-F20-F21-F22-F23-F24) on
passenger compartment fuse and relay box (260)