FIGURE 7. ENGINE PREFACE PART SHEET CROSS REFERENCE

DEC/2007 See Last Page for List of C to CX Hammer Upgrade Machines 41RB-7, Page 1

FIGURE 7. ENGINE PREFACE PART SHEET CROSS REFERENCE

DEC/2007 See Last Page for List of C to CX Hammer Upgrade Machines 41RB-7, Page 2

FIGURE 7. ENGINE PREFACE PART SHEET CROSS REFERENCE

DEC/2007 See Last Page for List of C to CX Hammer Upgrade Machines 41RB-7, Page 3

FIGURE 7JD-1. JOHN DEERE ENGINE 4045D w/o AC Compressor

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

ES11792

Rated Horsepower: 85hp@2500 rpm Actual Max HP: 79HP@2200 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750206 John Deere 4045D – Tier I ............................ 1 2 5128943 70 Amp Circuit Breaker............................. 1 3 61231246 Starter Relay............................................. 1 4 74130043 High Speed Solenoid (Trombetta) ............ 1 5 80010006 Timer......................................................... 1 6 5196966 Water Temp Sender (VDO) ...................... 1 7 5193951 Oil Pressure Sender (VDO ....................... 1 8 6090820 Fuel/Water Separator (RE60021) ............. 1 9 3894503 Oil Filter (RE59754) .................................. 1 10 96350866 Drive Assembly (Funk) ............................. 1 11 1614471 Oil Drain Valve.......................................... 1 12 22311162 Engine Enclosure Harness ....................... 1 13 50480822 Donaldson Muffler M065072..................... 1

DEC/2007 41RB-7JD-1, Page 1

FIGURE 7JD-2. JOHN DEERE ENGINE 4045D w/o AC Compressor

BNSF Specification

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

Contact Nordco Service For ES Number

Rated Horsepower: 85hp@2500 rpm Actual Max HP: 79HP@2200 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750208 John Deere 4045D – Tier I ............................ 1 2 5128943 70 Amp Circuit Breaker............................. 1 3 61231246 Starter Relay............................................. 1 4 74130043 High Speed Solenoid (Trombetta) ............ 1 5 80010006 Timer......................................................... 1 6 5193977 Water Temp Sender (SW) ........................ 1 7 5196976 Oil Pressure Sender (SW) ........................ 1 8 6090820 Fuel/Water Separator (RE60021) ............. 1 9 3894503 Oil Filter (RE59754) .................................. 1 10 96350866 Drive Assembly (Funk) ............................. 1 11 1614471 Oil Drain Valve.......................................... 1 12 22311162 Engine Enclosure Harness ....................... 1 13 50480822 Donaldson Muffler M065072..................... 1 14 R1210303 Donaldson “Informer 20” Gage ................. 1 15 1607023 Brass Shutoff Valve (for Coolant Cond.)... 2 16 96410497 Engine Protection System ........................ 1 17 42016800 Pull Handles.............................................. 4 18 50273345 “Cushy Float 55” Vibration Mounts .......... 4

DEC/2007 41RB-7JD-2, Page 1

FIGURE 7JD-3. JOHN DEERE ENGINE 4045D w/o AC Compressor

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

ES11961

Rated Horsepower: 80hp@2500 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

This part number is a Superior Diesel Part Number.

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750214 John Deere 4045D – Tier II ........................... 1 2 5128943 70 Amp Circuit Breaker............................. 1 3 SD2445 90 Amp Alternator..................................... 1 4 74130043 High Speed Solenoid (Trombetta) ............ 1 5 80010006 Timer......................................................... 1 6 5196966 Water Temp Sender (VDO) ...................... 1 7 5193951 Oil Pressure Sender (VDO) ...................... 1 8 Drive Assembly (Funk) ............................. 1 -- 10210155 Drive Shaft ........................................... 1 -- 10213774 Flywheel Cover .................................... 1 -- 29813157 Drive Plate ........................................... 1 -- 37030248 C Pad O-Ring....................................... 1 -- 10213812 C Pump Pad......................................... 1 9 1614485 Oil Drain Valve.......................................... 1 10 22311162 Engine Enclosure Harness ....................... 1 11 50480822 Donaldson Muffler M065072..................... 1 12 1607023 Brass Shutoff Valve (for Coolant Cond.)... 2 13 96410497 Engine Protection System ........................ 1 14 42016802 Pull Handles.............................................. 4 15 Donaldson Air Cleaner.............................. 1 16 1606987 Heater Shutoff Valves............................... 2 CONSUMABLES/WEAR ITEMS: 20 6090825 Fuel Filter (RE62418) ............................... 1 21 3894503 Oil Filter (RE59754) .................................. 1 21 17560016 Serpentine Belt (R123464) ....................... 1 23 6040715 Primary Air Cleaner Filter ......................... 1

This part number is a Superior Diesel Part Number.

AUG/2008 41RB-7JD-3, Rev. A, Page 1

FIGURE 7JD-4. JOHN DEERE ENGINE 4045D with AC Compressor

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

ES11962

Rated Horsepower: 80hp@2500 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

This part number is a Superior Diesel Part Number.

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750215 John Deere 4045D – Tier II ........................... 1 2 5128943 70 Amp Circuit Breaker............................. 1 3 SD2445 90 Amp Alternator..................................... 1 4 74130043 High Speed Solenoid (Trombetta) ............ 1 5 80010006 Timer......................................................... 1 6 5196966 Water Temp Sender (VDO) ...................... 1 7 5193951 Oil Pressure Sender (VDO ....................... 1 8 Drive Assembly (Funk) ............................. 1 -- 10210155 Drive Shaft ........................................... 1 -- 10213774 Flywheel Cover .................................... 1 -- 29813157 Drive Plate ........................................... 1 -- 37030248 C Pad O-Ring....................................... 1 -- 10213812 C Pump Pad......................................... 1 9 1614485 Oil Drain Valve.......................................... 1 10 22311162 Engine Enclosure Harness ....................... 1 11 50480822 Donaldson Muffler M065072..................... 1 12 1607023 Brass Shutoff Valve (for Coolant Cond.)... 2 13 96410497 Engine Protection System ........................ 1 14 42016802 Pull Handles.............................................. 4 15 Donaldson Air Cleaner.............................. 1 16 1606987 Heater Shutoff Valves............................... 2 17 25730008 Air Conditioning Compressor Kit............... 1 CONSUMABLES/WEAR ITEMS: 20 6090825 Fuel Filter (RE62418) ............................... 1 21 3894503 Oil Filter (RE59754) .................................. 1 21 17560016 Serpentine Belt (R123464) ....................... 1 22 NF2088 Coolant Filter Element .............................. 1 23 6040715 Primary Air Cleaner Filter ......................... 25 17519210 A/C Compressor Belt ................................ 1

This part number is a Superior Diesel Part Number.

AUG/2008 41RB-7JD-4, Rev. A, Page 1

FIGURE 7JD-5. JOHN DEERE ENGINE 4045D with AC Compressor

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

ES11963

Rated Horsepower: 80hp@2500 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750216 John Deere 4045D – Tier II ............................ 1 2 5128943 70 Amp Circuit Breaker............................. 1 3 SD2445 90 Amp Alternator..................................... 1 4 74130043 High Speed Solenoid (Trombetta) ............ 1 5 80010006 Timer......................................................... 1 6 5193977 Water Temp Sender (SW) ........................ 1 7 5196976 Oil Pressure Sender (SW) ........................ 1 8 Drive Assembly (Funk) ............................. 1 -- 10210155 Drive Shaft ........................................... 1 -- 10213774 Flywheel Cover .................................... 1 -- 29813157 Drive Plate ........................................... 1 -- 37030248 C Pad O-Ring....................................... 1 -- 10213812 C Pump Pad......................................... 1 9 1614485 Oil Drain Valve.......................................... 1 10 22311162 Engine Enclosure Harness ....................... 1 11 50480872 Donaldson Muffler M065074..................... 1 12 7028300 Donaldson “Informer 25” Gage ................. 1 13 1607023 Brass Shutoff Valve (for Coolant Cond.)... 2 14 96410497 Engine Protection System ........................ 1 15 42016802 Pull Handles.............................................. 4 16 50273346 “Cushy Float 65” Vibration Mounts .......... 4 17 Donaldson Air Cleaner.............................. 1 18 1606987 Heater Shutoff Valves............................... 2 19 25730008 Air Conditioning Compressor Kit............... 1 20 74130043 Shut Off Solenoid (Trombetta).................. 1 CONSUMABLES/WEAR ITEMS: 21 6090825 Fuel Filter (RE62418) ............................... 1 22 3894503 Oil Filter (RE59754) .................................. 1 23 17560016 Serpentine Belt (R123464) ....................... 1 24 NF2088 Coolant Filter Element .............................. 1 25 6040715 Primary Air Cleaner Filter ......................... 26 17519210 A/C Compressor Belt ................................ 1

AUG/2008 41RB-7JD-5, Rev. A, Page 1

FIGURE 7JD-6. JOHN DEERE ENGINE 4045D w/o AC Compressor

AUG/2008 41RB-7JD-6, Rev. A, Page 1

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

Contact Nordco Service For ES Number

Rated Horsepower: 80hp@2500 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750229 John Deere 4045D – Tier II ........................... 1 2 5128943 70 Amp Circuit Breaker............................. 1 3 SD2445 90 Amp Alternator..................................... 1 4 74130043 High Speed Solenoid (Trombetta) ............ 1 5 80010006 Timer......................................................... 1 6 5196966 Water Temp Sender (VDO) ...................... 1 7 5193951 Oil Pressure Sender (VDO) ...................... 1 8 Drive Assembly (Funk) ............................. 1 -- 10210155 Drive Shaft ........................................... 1 -- 10213774 Flywheel Cover .................................... 1 -- 29813157 Drive Plate ........................................... 1 -- 37030248 C Pad O-Ring....................................... 1 -- 10213812 C Pump Pad......................................... 1 9 1614485 Oil Drain Valve.......................................... 1 10 22311162 Engine Enclosure Harness ....................... 1 11 50480822 Donaldson Muffler M065072..................... 1 12 1607023 Brass Shutoff Valve (for Coolant Cond.)... 2 13 96410497 Engine Protection System ........................ 1 14 42016802 Pull Handles.............................................. 4 15 Donaldson Air Cleaner.............................. 1 16 1606987 Heater Shutoff Valves............................... 2 17 Espar Heater............................................. 1 18 1607023 Brass Shutoff Valve (for Coolant Cond.)... 2 CONSUMABLES/WEAR ITEMS: 20 6090825 Fuel Filter (RE62418) ............................... 1 21 3894503 Oil Filter (RE59754) .................................. 1 21 17560016 Serpentine Belt (R123464) ....................... 1 22 NF2088 Coolant Filter Element .............................. 1 23 6040715 Primary Air Cleaner Filter ......................... 1

This part number is a Superior Diesel Part Number.

FIGURE 7JD-7. JOHN DEERE ENGINE 5030T w/o AC Compressor

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

ES20102

Rated Horsepower: 83hp@2500 rpm Actual Max HP: 77HP@2200 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750234 John Deere 5030T........................................... 1 2 5128792 105 Amp Circuit Breaker........................... 1 3 37580033 75 Amp Alternator..................................... 1 4 61231247 Starter Relay............................................. 1 5 10061012 Addco Throttle (See Next Page)............... 1 6 80010006 Timer......................................................... 1 7 5196966 Water Temp Sender (VDO) ...................... 1 8 5193951 Oil Pressure Sender (VDO) ...................... 1 9 Drive Assembly (Funk) ............................. 1 -- 10210155 Drive Shaft ........................................... 1 -- 10213774 Flywheel Cover .................................... 1 -- 29813157 Drive Plate ........................................... 1 -- 37030248 C Pad O-Ring....................................... 1 -- 10213812 C Pump Pad......................................... 1 10 1614485 Oil Drain Valve.......................................... 1 11 22311189 Engine Enclosure Harness ....................... 1 12 D60-0014 Nelson Muffler........................................... 1 13 42016800 Pull Handles.............................................. 4 14 G082525 Donaldson Air Cleaner.............................. 1 15 1606987 Heater Shutoff Valves............................... 2 16 27296865 Engine Enclosure...................................... 1 CONSUMABLES/WEAR ITEMS: 20 3894512 Fuel/Water Separator (RE508202) ........... 1 21 3894511 Oil Filter (RE519626) ................................ 1 22 17560016 Serpentine Belt (R123464) ....................... 1

This is a Superior Diesel Part Number.

AUG/2008 41RB-7JD-7, Rev. A, Page 1

FIGURE 7JD-7. JOHN DEERE ENGINE 5030T w/o AC Compressor

AUG/2008 41RB-7JD-7, Rev. A, Page 2

FIGURE 7JD-8. JOHN DEERE ENGINE 5030T with AC Compressor

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

ES20106

Rated Horsepower: 84hp@2800 rpm Actual Max HP: 77HP@2200 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750235 John Deere 5030T........................................... 1 2 5128792 105 Amp Circuit Breaker........................... 1 3 37580033 75 Amp Alternator..................................... 1 4 61231249 Starter Relay............................................. 1 5 10061012 Addco Throttle (See Next Page)............... 1 6 80010006 Timer......................................................... 1 7 5196966 Water Temp Sender (VDO) ...................... 1 8 5193951 Oil Pressure Sender (VDO) ...................... 1 9 96412838 Drive Assembly (Hayes) ........................... 1 10 1614485 Oil Drain Valve.......................................... 1 11 22311189 Engine Enclosure Harness ....................... 1 12 60-0014 Nelson Muffler........................................... 1 13 42016800 Pull Handles.............................................. 4 14 G082525 Donaldson Air Cleaner.............................. 1 15 1606987 Heater Shutoff Valves............................... 2 16 27296865 Engine Enclosure...................................... 1 17 25730008 Air Conditioning Compressor Kit............... 1 CONSUMABLES/WEAR ITEMS: 20 3894512 Fuel/Water Separator (RE508202) ........... 1 21 3894511 Oil Filter (RE519626) ................................ 1 22 17560016 Serpentine Belt (R123464) ....................... 1 23 17519210 A/C Compressor Belt ................................ 1

This is a Superior Diesel Part Number. The Hayes Pump Drive is only available as a complete unit. Repair items

are not available.

AUG/2008 41RB-7JD-8, Rev. A, Page 1

FIGURE 7JD-8. JOHN DEERE ENGINE 5030T with AC Compressor

AUG/2008 41RB-7JD-8, Rev. A, Page 2

FIGURE 7JD-9. JOHN DEERE ENGINE 5030T with AC Compressor

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

ES20105

Rated Horsepower: 84hp@2800 rpm Actual Max HP: 77HP@2200 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750236 John Deere 5030T........................................... 1 2 5128788 80 Amp Circuit Breaker............................. 1 3 37580033 75 Amp Alternator..................................... 1 5 10061012 Addco Throttle (See Next Page)............... 1 6 80010006 Timer......................................................... 1 7 5193977 Water Temp Sender (SW) ........................ 1 8 5196976 Oil Pressure Sender (SW) ........................ 1 9 96412838 Drive Assembly (Hayes) ........................... 1 10 1614485 Oil Drain Valve.......................................... 1 11 22311189 Engine Enclosure Harness ....................... 1 12 60-0014 Nelson Muffler........................................... 1 13 42016800 Pull Handles.............................................. 4 14 G082525 Donaldson Air Cleaner.............................. 1 15 1606987 Heater Shutoff Valves............................... 2 16 27296865 Engine Enclosure...................................... 1 17 25730008 Air Conditioning Compressor Kit............... 1 18 96410497 Engine Protection System ........................ 1 19 1607023 Brass Shutoff Valve (for Coolant Cond.)... 2 CONSUMABLES/WEAR ITEMS: 20 3894512 Fuel/Water Separator (RE508202) ........... 1 21 3894511 Oil Filter (RE519626) ................................ 1 22 17560016 Serpentine Belt (R123464) ....................... 1 23 17519210 A/C Compressor Belt ................................ 1 24 NF2088 Coolant Filter Element .............................. 1

This is a Superior Diesel Part Number.

The Hayes Pump Drive is only available as a complete unit. Repair items Are not available.

AUG/2008 41RB-7JD-9, Rev. A, Page 1

FIGURE 7JD-9. JOHN DEERE ENGINE 5030T with AC Compressor

AUG/2008 41RB-7JD-9, Rev. A, Page 2

FIGURE 7JD-10. JOHN DEERE ENGINE 5030T w/o AC Compressor

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

ES20129

Rated Horsepower: 84hp@2800 rpm Actual Max HP: 77HP@2200 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750239 John Deere 5030T........................................... 1 2 5128792 105 Amp Circuit Breaker........................... 1 3 37580033 75 Amp Alternator..................................... 1 5 10061012 Addco Throttle (See Next Page)............... 1 6 80010006 Timer......................................................... 1 7 5193977 Water Temp Sender (SW) ........................ 1 8 5196976 Oil Pressure Sender (SW) ........................ 1 9 96412838 Drive Assembly (Hayes) ........................... 1 10 1614485 Oil Drain Valve.......................................... 1 11 22311189 Engine Enclosure Harness ....................... 1 12 60-0014 Nelson Muffler........................................... 1 13 42016800 Pull Handles.............................................. 4 14 G082525 Donaldson Air Cleaner.............................. 1 15 1606987 Heater Shutoff Valves............................... 2 16 27296865 Engine Enclosure...................................... 1 17 1607023 Brass Shutoff Valve (for Coolant Cond.)... 2 18 Contact Nordco Espar Heater............................................. 1 CONSUMABLES/WEAR ITEMS: 20 3894512 Fuel/Water Separator (RE508202) ........... 1 21 3894511 Oil Filter (RE519626) ................................ 1 22 17560016 Serpentine Belt (R123464) ....................... 1 23 NF2088 Coolant Filter Element .............................. 1

This is a Superior Diesel Part Number. The Hayes Pump Drive is only available as a complete unit. Repair items

are not available.

AUG/2008 41RB-7JD-10, Rev. A, Page 1

FIGURE 7JD-10. JOHN DEERE ENGINE 5030T w/o AC Compressor

AUG/2008 41RB-7JD-10, Rev. A, Page 2

FIGURE 7JD-11. JOHN DEERE ENGINE 4045D with AC Compressor

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

ES12362

Rated Horsepower: 80hp@2500 rpm Actual Max HP: 77HP@2200 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750300 John Deere 4045D Tier II ................................ 1 2 5128683 90 Amp Circuit Breaker............................. 1 3 SD2445 90 Amp Alternator..................................... 1 5 10061012 Addco Throttle (See Next Page)............... 1 6 80010006 Timer......................................................... 1 7 5193977 Water Temp Sender (SW) ........................ 1 8 5196976 Oil Pressure Sender (SW) ........................ 1 9 Drive Assembly (Funk) ............................. 1 -- 10210155 Drive Shaft ........................................... 1 -- 10213774 Flywheel Cover .................................... 1 -- 29813157 Drive Plate ........................................... 1 -- 37030248 C Pad O-Ring....................................... 1 -- 10213812 C Pump Pad......................................... 1 10 1614485 Oil Drain Valve.......................................... 1 11 22311162 Engine Enclosure Harness ....................... 1 12 50480872 Donaldson Muffler M065074..................... 1 13 42016802 Pull Handles.............................................. 4 14 G100297 Donaldson Air Cleaner.............................. 1 15 1606987 Heater Shutoff Valves............................... 2 17 25730008 Air Conditioning Compressor Kit............... 1 18 96410497 Engine Protection System ........................ 1 19 1607023 Brass Shutoff Valve (for Coolant Cond.)... 2 20 74130043 Shut Off Solenoid (Trombetta).................. 1 21 50273346 “Cushy Float 65” Vibration Mounts .......... 4 22 R1210303 Donaldson “Informer 20” Gage ................. 1 CONSUMABLES/WEAR ITEMS: 25 Contact Nordco Fuel/Water Separator (RE67901) ............. 1 26 3894507 Oil Filter (RE504836) ................................ 1 27 17560016 Serpentine Belt (R123464) ....................... 1 28 17519210 A/C Compressor Belt ................................ 1 29 3894504 Coolant Filter Element .............................. 1

This is a Superior Diesel Part Number.

AUG/2008 41RB-7JD-11, Rev. A, Page 1

FIGURE 7JD-11. JOHN DEERE ENGINE 4045D with AC Compressor

AUG/2008 41RB-7JD-11, Rev. A, Page 2

FIGURE 7JD-12. JOHN DEERE ENGINE 4045T with AC Compressor

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

ES12400

Rated Horsepower: 99hp@2200 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750302 John Deere 4045T Tier II ................................ 1 2 5128683 90 Amp Circuit Breaker............................. 1 3 SD2445 90 Amp Alternator..................................... 1 5 10061012 Addco Throttle (See Next Page)............... 1 6 80010006 Timer......................................................... 1 7 5193977 Water Temp Sender (SW) ........................ 1 8 5196976 Oil Pressure Sender (SW) ........................ 1 9 96412838 Drive Assembly (Hayes) ........................... 1 10 1614485 Oil Drain Valve.......................................... 1 11 22311162 Engine Enclosure Harness ....................... 1 12 50480872 Donaldson Muffler M065074..................... 1 13 42016802 Pull Handles.............................................. 4 14 SD1296 Donaldson Air Cleaner.............................. 1 15 1606987 Heater Shutoff Valves............................... 2 17 25730008 Air Conditioning Compressor Kit............... 1 18 96410497 Engine Protection System ........................ 1 19 1607023 Brass Shutoff Valve (for Coolant Cond.)... 2 20 74130043 Shut Off Solenoid (Trombetta).................. 1 21 50273346 “Cushy Float 65” Vibration Mounts .......... 4 22 R1210303 Donaldson “Informer 20” Gage ................. 1 CONSUMABLES/WEAR ITEMS: 25 Contact Nordco Fuel/Water Separator (RE67901) ............. 1 26 3894507 Oil Filter (RE504836) ................................ 1 27 17560016 Serpentine Belt (R123464) ....................... 1 28 17519210 A/C Compressor Belt ................................ 1 29 3894504 Coolant Filter Element .............................. 1

This is a Superior Diesel Part Number. The Hayes Pump Drive is only available as a complete unit. Repair items

are not available.

AUG/2008 41RB-7JD-12, Rev. A, Page 1

FIGURE 7JD-12. JOHN DEERE ENGINE 4045T with AC Compressor

AUG/2008 41RB-7JD-12, Rev. A, Page 2

FIGURE 7JD-13. JOHN DEERE ENGINE 4045T w/o AC Compressor

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

ES12399

Rated Horsepower: 99hp@2200 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750303 John Deere 4045T Tier II ................................ 1 2 5128683 90 Amp Circuit Breaker............................. 1 3 SD2445 90 Amp Alternator..................................... 1 5 10061012 Addco Throttle (See Next Page)............... 1 6 80010006 Timer......................................................... 1 7 5196966 Water Temp Sender (VDO) ...................... 1 8 5193951 Oil Pressure Sender (VDO) ...................... 1 9 96412838 Drive Assembly (Hayes) ........................... 1 10 1614485 Oil Drain Valve.......................................... 1 11 22311162 Engine Enclosure Harness ....................... 1 12 M090594 Muffler....................................................... 1 13 42016802 Pull Handles.............................................. 4 14 G100297 Air Cleaner................................................ 1 15 1606987 Heater Shutoff Valves............................... 2 CONSUMABLES/WEAR ITEMS: 20 Contact Nordco Fuel/Water Separator (RE67901) ............. 1 21 3894507 Oil Filter (RE504836) ................................ 1 22 17560016 Serpentine Belt (R123464) ....................... 1

This is a Superior Diesel Part Number. The Hayes Pump Drive is only available as a complete unit. Repair items

are not available.

AUG/2008 41RB-7JD-13, Rev. A, Page 1

FIGURE 7JD-13. JOHN DEERE ENGINE 4045T w/o AC Compressor

AUG/2008 41RB-7JD-13, Rev. A, Page 2

FIGURE 7JD-14. JOHN DEERE ENGINE 4045T w/o AC Compressor

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

ES12425

Rated Horsepower: 99hp@2200 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750304 John Deere 4045T Tier II ................................ 1 2 5128943 70 Amp Circuit Breaker............................. 1 3 SD2445 90 Amp Alternator..................................... 1 5 10061012 Addco Throttle (See Next Page)............... 1 6 80010006 Timer......................................................... 1 7 5196966 Water Temp Sender (VDO) ...................... 1 8 5193951 Oil Pressure Sender (VDO) ...................... 1 9 Drive Assembly (Funk) ............................. 1 -- 10210155 Drive Shaft ........................................... 1 -- 10213774 Flywheel Cover .................................... 1 -- 29813157 Drive Plate ........................................... 1 -- 37030248 C Pad O-Ring....................................... 1 -- 10213812 C Pump Pad......................................... 1 10 1614485 Oil Drain Valve.......................................... 1 11 22311162 Engine Enclosure Harness ....................... 1 12 M090594 Muffler....................................................... 1 13 42016802 Pull Handles.............................................. 4 14 G100297 Air Cleaner................................................ 1 15 1606987 Heater Shutoff Valves............................... 2 16 1607023 Brass Shutoff Valve (for Coolant Cond.)... 2 17 Contact Nordco Espar Heater............................................. 1 18 43800029 Oil Pan Heater .......................................... 1 CONSUMABLES/WEAR ITEMS: 20 Contact Nordco Fuel/Water Separator (RE67901) ............. 1 21 3894507 Oil Filter (RE504836) ................................ 1 22 17560016 Serpentine Belt (R123464) ....................... 1 23 96411246 Coolant Filter Element (Spin-On).............. 1

This is a Superior Diesel Part Number.

AUG/2008 41RB-7JD-14, Rev. A, Page 1

FIGURE 7JD-14. JOHN DEERE ENGINE 4045T w/o AC Compressor

AUG/2008 41RB-7JD-14, Rev. A, Page 2

FIGURE 7JD-15. JOHN DEERE ENGINE 4045T with AC Compressor

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

ES12412

Rated Horsepower: 99hp@2200 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750306 John Deere 4045T Tier II ................................ 1 2 5128683 90 Amp Circuit Breaker............................. 1 3 SD2445 90 Amp Alternator..................................... 1 5 10061012 Addco Throttle (See Next Page)............... 1 6 80010006 Timer......................................................... 1 7 5196966 Water Temp Sender (VDO) ...................... 1 8 5193951 Oil Pressure Sender (VDO) ...................... 1 9 96412838 Drive Assembly (Hayes) ........................... 1 10 1614485 Oil Drain Valve.......................................... 1 11 22311162 Engine Enclosure Harness ....................... 1 12 M090594 Muffler....................................................... 1 13 42016802 Pull Handles.............................................. 4 14 G100297 Air Cleaner................................................ 1 15 1606987 Heater Shutoff Valves............................... 2 16 25730008 Air Conditioning Compressor Kit............... 1 CONSUMABLES/WEAR ITEMS: 20 Contact Nordco Fuel/Water Separator (RE67901) ............. 1 21 3894507 Oil Filter (RE504836) ................................ 1 22 17560016 Serpentine Belt (R123464) ....................... 1 23 17519210 A/C Compressor Belt ................................ 1

This is a Superior Diesel Part Number. The Hayes Pump Drive is only available as a complete unit. Repair items

are not available.

AUG/2008 41RB-7JD-15, Rev. A, Page 1

FIGURE 7JD-15. JOHN DEERE ENGINE 4045T with AC Compressor

AUG/2008 41RB-7JD-15, Rev. A, Page 2

FIGURE 7JD-16. JOHN DEERE ENGINE 4045T with AC Compressor

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

ES12434

Rated Horsepower: 99hp@2200 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750307 John Deere 4045T Tier II ................................ 1 2 5128683 90 Amp Circuit Breaker............................. 1 3 SD2445 90 Amp Alternator..................................... 1 5 10061012 Addco Throttle (See Next Page)............... 1 6 80010006 Timer......................................................... 1 7 5196966 Water Temp Sender (VDO) ...................... 1 8 5193951 Oil Pressure Sender (VDO) ...................... 1 9 96412838 Drive Assembly (Hayes) ........................... 1 10 1614485 Oil Drain Valve.......................................... 1 11 22311162 Engine Enclosure Harness ....................... 1 12 M090594 Muffler....................................................... 1 13 42016802 Pull Handles.............................................. 4 14 G100297 Air Cleaner................................................ 1 15 1606987 Heater Shutoff Valves............................... 2 16 25730008 Air Conditioning Compressor Kit............... 1 17 43800029 Oil Pan Heater .......................................... 1 16 1607023 Brass Shutoff Valve (for Coolant Cond.)... 2 CONSUMABLES/WEAR ITEMS: 20 Contact Nordco Fuel/Water Separator (RE67901) ............. 1 21 3894507 Oil Filter (RE504836) ................................ 1 22 17560016 Serpentine Belt (R123464) ....................... 1 23 17519210 A/C Compressor Belt ................................ 1 24 96411246 Coolant Filter Element (Spin-On).............. 1

This is a Superior Diesel Part Number. The Hayes Pump Drive is only available as a complete unit. Repair items

are not available.

AUG/2008 41RB-7JD-16, Rev. A, Page 1

FIGURE 7JD-16. JOHN DEERE ENGINE 4045T with AC Compressor

AUG/2008 41RB-7JD-16, Rev. A, Page 2

FIGURE 7JD-17. JOHN DEERE ENGINE 4045T with AC Compressor

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

ES12453

Rated Horsepower: 99hp@2200 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750310 John Deere 4045T Tier II ................................ 1 2 5128683 90 Amp Circuit Breaker............................. 1 3 SD2445 90 Amp Alternator..................................... 1 5 10061012 Addco Throttle (See Next Page)............... 1 6 80010006 Timer......................................................... 1 7 5196966 Water Temp Sender (VDO) ...................... 1 8 5193951 Oil Pressure Sender (VDO) ...................... 1 9 96412838 Drive Assembly (Hayes) ........................... 1 10 1614485 Oil Drain Valve.......................................... 1 11 22311162 Engine Enclosure Harness ....................... 1 12 M090594 Muffler....................................................... 1 13 42016802 Pull Handles.............................................. 4 14 G100297 Air Cleaner................................................ 1 15 1606987 Heater Shutoff Valves............................... 2 16 25730008 Air Conditioning Compressor Kit............... 1 17 1607023 Brass Shutoff Valve (for Coolant Cond.)... 2 18 C-50849-T Reversible Fan.......................................... 1 CONSUMABLES/WEAR ITEMS: 20 Contact Nordco Fuel/Water Separator (RE67901) ............. 1 21 3894507 Oil Filter (RE504836) ................................ 1 22 17560016 Serpentine Belt (R123464) ....................... 1 23 17519210 A/C Compressor Belt ................................ 1 24 96411246 Coolant Filter Element (Spin-On).............. 1

This is a Superior Diesel Part Number. The Hayes Pump Drive is only available as a complete unit. Repair items

are not available.

AUG/2008 41RB-7JD-17, Rev. A, Page 1

FIGURE 7JD-17. JOHN DEERE ENGINE 4045T with AC Compressor

AUG/2008 41RB-7JD-17, Rev. A, Page 2

FIGURE 7JD-18. JOHN DEERE ENGINE 4045T with AC Compressor

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

ES12453

Rated Horsepower: 99hp@2200 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750312 John Deere 4045T Tier II ................................ 1 2 5128683 90 Amp Circuit Breaker............................. 1 3 SD2445 90 Amp Alternator..................................... 1 5 10061012 Addco Throttle (See Next Page)............... 1 6 80010006 Timer......................................................... 1 7 5193966 Water Temp Sender (VDO) ...................... 1 8 5193951 Oil Pressure Sender (VDO) ...................... 1 9 96412838 Drive Assembly (Hayes) ........................... 1 10 1614485 Oil Drain Valve.......................................... 1 11 22311162 Engine Enclosure Harness ....................... 1 12 M090594 Muffler....................................................... 1 13 42016802 Pull Handles.............................................. 4 14 G100297 Air Cleaner................................................ 1 15 1606987 Heater Shutoff Valves............................... 2 16 25730008 Air Conditioning Compressor Kit............... 1 17 1607023 Brass Shutoff Valve (for Coolant Cond.)... 2 18 C-50849-T Reversible Fan.......................................... 1 19 Contact Nordco Espar Heater............................................. 1 20 43800029 Oil Pan Heater .......................................... 1 CONSUMABLES/WEAR ITEMS: 25 Contact Nordco Fuel/Water Separator (RE67901) ............. 1 26 3894507 Oil Filter (RE504836) ................................ 1 27 17560016 Serpentine Belt (R123464) ....................... 1 28 17519210 A/C Compressor Belt ................................ 1 29 96411246 Coolant Filter Element (Spin-On).............. 1

This is a Superior Diesel Part Number.

The Hayes Pump Drive is only available as a complete unit. Repair items are not available.

AUG/2008 41RB-7JD-18, Rev. A, Page 1

FIGURE 7JD-18. JOHN DEERE ENGINE 4045T with AC Compressor

AUG/2008 41RB-7JD-18, Rev. A, Page 2

FIGURE 7JD-19. JOHN DEERE ENGINE 4045T with AC Compressor

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

ES12559

Rated Horsepower: 99hp@2200 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750317 John Deere 4045T Tier II ................................ 1 2 5128683 90 Amp Circuit Breaker............................. 1 3 SD2445 90 Amp Alternator..................................... 1 5 10061012 Addco Throttle (See Next Page)............... 1 6 80010006 Timer......................................................... 1 7 5193966 Water Temp Sender (VDO) ...................... 1 8 5193951 Oil Pressure Sender (VDO) ...................... 1 9 96412838 Drive Assembly (Hayes) ........................... 1 10 1614485 Oil Drain Valve.......................................... 1 11 22311162 Engine Enclosure Harness ....................... 1 12 M090594 Muffler....................................................... 1 13 42016802 Pull Handles.............................................. 4 14 G100297 Air Cleaner................................................ 1 15 1606987 Heater Shutoff Valves............................... 2 16 25730008 Air Conditioning Compressor Kit............... 1 17 1607023 Brass Shutoff Valve (for Coolant Cond.)... 2 CONSUMABLES/WEAR ITEMS: 25 Contact Nordco Fuel/Water Separator (RE67901) ............. 1 26 3894507 Oil Filter (RE504836) ................................ 1 27 17560016 Serpentine Belt (R123464) ....................... 1 28 17519210 A/C Compressor Belt ................................ 1 29 3894504 Coolant Filter Element (Spin-On).............. 1

This is a Superior Diesel Part Number.

The Hayes Pump Drive is only available as a complete unit. Repair items are not available.

AUG/2008 41RB-7JD-19, Rev. A, Page 1

FIGURE 7JD-19. JOHN DEERE ENGINE 4045T with AC Compressor

AUG/2008 41RB-7JD-19, Rev. A, Page 2

FIGURE 7JD-20. JOHN DEERE ENGINE 4045HF with AC Compressor

Due to the different configurations available for engines, drawings will not be provided. The following list details this engine only. When calling Superior Diesel for support on this Engine,

Reference the ES Code number listed below. Make certain you Have the S/N of the engine available at time of service call.

ES12430

Rated Horsepower: 140hp@2200 rpm Operating RPM: 2400 rpm high idle 1100 rpm low idle

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

1 31750301 John Deere 4045T Tier II ................................ 1 2 5128683 90 Amp Circuit Breaker............................. 1 3 SD2445 90 Amp Alternator..................................... 1 5 10061012 Addco Throttle (See Next Page)............... 1 6 80010006 Timer......................................................... 1 7 5193977 Water Temp Sender (SW) ........................ 1 8 5196976 Oil Pressure Sender (SW) ........................ 1 9 Drive Assembly (Funk) ............................. 1 -- YZ102231 Drive Shaft ........................................... 1 -- 10213774 Flywheel Cover .................................... 1 -- 29813157 Drive Plate ........................................... 1 -- 37030248 C Pad O-Ring....................................... 1 -- 10213812 C Pump Pad......................................... 1 10 1614485 Oil Drain Valve.......................................... 1 11 22311162 Engine Enclosure Harness ....................... 1 12 50480872 Donaldson Muffler M065074..................... 1 13 42016802 Pull Handles.............................................. 4 14 SD1296 Donaldson Air Cleaner.............................. 1 15 1606987 Heater Shutoff Valves............................... 2 17 25730008 Air Conditioning Compressor Kit............... 1 18 96410497 Engine Protection System ........................ 1 19 1607023 Brass Shutoff Valve (for Coolant Cond.)... 2 20 74130043 Shut Off Solenoid (Trombetta).................. 1 21 50273346 “Cushy Float 65” Vibration Mounts .......... 4 22 R1210303 Donaldson “Informer 20” Gage ................. 1 CONSUMABLES/WEAR ITEMS: 25 Contact Nordco Fuel/Water Separator (RE67901) ............. 1 26 3894507 Oil Filter (RE504836) ................................ 1 27 17560016 Serpentine Belt (R123464) ....................... 1 28 17519210 A/C Compressor Belt ................................ 1 29 3894504 Coolant Filter Element .............................. 1

This is a Superior Diesel Part Number.

AUG/2008 41RB-7JD-20, Page 1

FIGURE 7JD-20. JOHN DEERE ENGINE 4045HF with AC Compressor

AUG/2008 41RB-7JD-20, Page 2

FIGURE 7P-1. PUMP PVH098

S/N 410500-410695, Except RBUG’s

ITEM PART UNITS PER NO. NO. DESCRIPTION ASSEMBLY

NOTE: Item 1 (Pump) is no longer available for purchase. Items 2-5 are still

available as repair part items. Refer to Figure 41RB-7P-1A when ordering a new pump.

1 59427921 Main Pump (Vickers PVH098 – 24V, 60GPM)....... 1 2 54218492 Destroke Valve ............................................... 1 3 1698956 Destroke Valve Cartridge ................................ 1 4 25534019 Valve Coil ............................................... 1 5 25700101 Compensator ............................................... 1 6 1702100 Inline Check Valve ............................................... 1 7 1990825 90° Split Flange Nipple – 2-1/2” ............................. 1 8 32510040 Split Flange Kit, 2-1/2”............................................ 1 -- 35705451 O-Ring ........................................ 1 9 32510032 Split Flange Kit, 1” ............................................... 1 10 96350866 Funk Pump Drive (Not part of pump) ............ REF The following are used to mount the pump to the pump drive: 15* 2775301 HH Capscrew, ½ x 1-1/2 ........................................ 4 16* 3064476 1/2" Lockwasher..................................................... 4 17* 3060476 1/2" SAE Washer ................................................... 4

Includes Flanges, O-Ring, Capscrews, and lockwashers

DEC/2007 41RB-7P-1, Page 1

FIGURE 7P-1A. PUMP PVM098

S/N 410696 AND ABOVE

DEC/2007 41RB-7P-1A, Page 1

IntroductionTable of ContentsFigure 1 - Operator StationSeats and ControlsHand ControllersOptional Swivel SeatOptional Park/Run SwitchOperator Guard (Option)

Figure 2 - Axles3-Inch Demountable3.44" DemountableFloating Frame w/3-Inch AxleFloating Frame w/3.44" AxleFloating Frame Greasing Kit

Figure 3 - BrakesBrake KitsBrake Service KitBrake Cylinder Replacement Kit

Figure 5 - Propulsion and DriveFront Axle DriveRear Axle Drive

Figure 6 - Frame AccessoriesBatteryBattery Cable Installation

Canopy, Lights and HornsBumpers and JackstandsHitchesRemovable StepsFixed StepsDecals

Figure 7 - Engines and PumpsEngine Parts Sheet Cross ReferenceJohn Deere EnginesFigure 7JD-1Figure 7JD-2Figure 7JD-3Figure 7JD-4Figure 7JD-5Figure 7JD-6Figure 7JD-7Figure 7JD-8Figure 7JD-9Figure 7JD-10Figure 7JD-11Figure 7JD-12Figure 7JD-13Figure 7JD-14Figure 7JD-15Figure 7JD-16Figure 7JD-17Figure 7JD-18Figure 7JD-19Figure 7JD-20

Cummins Engines

PumpsS/N 410500-410695, Except RBUGSS/N 410696 and Above, including RBUGS

Figure 8 - Hydraulic Tanks98 Gallon Tank115 Gallon Tower Style Tank110 Gallon Tank (Current Std Tank)Top Off Assembly - ManualTop Off Assembly - Electric

Figure 9 - Oil CoolersW/Bosch Fan (White Blades)Bosch to Spa Upgrade Kit

W/Spal Fan (Black Blades)

Figure 10 - Fuel Tank60 Gallon - Rectangular120 Gallon - Round

Figure 11 - CarriageGuns 1 and 3 w/3" Shaft Left Gun CarriageGuns 2 and 4 w/3" Shaft Right Gun CarriageGuns 1 and 3 w/4" Shaft Left Gun CarriageGuns 2 and 4 w/4" Shaft Right Gun Carriage

Figure 12 - Guide RollersGuide RollersNon-Insulated without Power LockupsInsulated without Power LockupsNon-Insulated with Power LockupsInsulated with Power Lockups

Power LockupsGreasing TubesGuide Roller KitsInsulated Guide Roller Kit

Figure 13 - WorkheadHammer and MountingAnvil and Jaw MountingPower LockupsTravel LockupsWorkhead KitsJaw Mounting KitsStainless Steel Guide Rods - 5/8" FlaredChrome Guide Rods - 5/8" FlaredChrome Guide Rods - 5/8" Straight

Anvil Sleeve KitsNon-Curved Sleeve KitCurved Sleeve Kit

Hammer Lifting Eye Kit

Figure 14 - Spike TraysLeft Hand Spike TraysLeft Hand Standard SpikesLeft Hand Fat SpikesLeft Hand Lewis Bolt

Right Hand Spike TraysRight Hand Standard SpikesRight Hand Fat SpikesRight Hand Lewis Bolt

Spike Tray KitsDust Chute Kit

Figure 15 - Workhead PositioningPattern AdjustCarriage Centering

Figure 16 - NippersUp/Down Cylinder and Prox MountingNipper FramePower LockupsNipper KitsOptional Spherical BearingsWithout Power LockupsWith Power Lockups

Rebuild KitNipper Link Pin Kit

Figure 17 - Gager BuggyWinch SystemFrame SystemRH Buggy WheelLH Buggy Wheel

Figure 18 - GagerGager HousingGager LeversNon-Insulated without Power LockupsInsulated without Power LockupsNon-Insulated with Power LockupsInsulated with Power LocksPower Lockups

Gager KitsGager Overhaul KitNon-InsulatedInsulated

Figure 20 - Standard Spike BinWithout BulkloaderWith Auger-Style Bulkloader

Figure 22 - Push Style BulkloaderS/N 410500-410813S/N410814-410893, and RBUGsS/N410894 and Above, and RBUGsOptional WalkwayOptional Flexible StepsOptional Removable PlatformOptional Bin CoverDust Collector OptionOptional Dust Vacuum SystemFan and MountingAir Manifold and DuctingDust Vacuum System - Inside Cab

Figure 23 - Boom and WinchFigure 24 - TurntablesS/N 410500-410587S/N 410588-410606S/N410607 and AbovePower Lockups

Figure 25 - Cab StructureDoors and WindowsLeft SideRight SideFrontRearSpike Bin only - Long Side WindowsSpike Bin Only - Short Side WindowsBul Loader S/N 410500-410756Bulk Loader S/N 410757-410762Bulk Loader S/N 410763 and Above

Rear Door OptionDoor Latches

Windshield WipersFrontRear

Rear Window ScreensLights and HornsVandalism ScreensLeft SideRight SideFrontRear

Figure 26 - Canopy Curtains & PanelsFront CurtainsRight Side CurtainsLeft Side CurtainsRear Panel