ENVIRONMENT MANAGEMENT PLAN - … · Sidhant Minerals Prop. Mr ... • Garland drain will be properly channelized so that ... • Reclamation and rehabilitation will be started at

ENVIRONMENT MANAGEMENT PLAN

FOR

VILLAGE : Bansarai

TEHSIL : Rajnagar

DISTRICT : Chhatarpur (M.P.)

AREA : 7.450 Hectare

MINERAL : Crusher Stone

KHASRA No : 313

PRODUCTION CAP : 50411 Cu.mt/year (avg.) Crusher Stone

APPLICANT

M/s. Sidhant Minerals

Prop. Mr. Shreekant Dixit

Resi.- Tikuriya Mohalla, Near Madiya Talab, panna,

Dist.- Panna, Madhya Pradesh

Prepared by

Charles Pradeep Singh

Near LIC Office, Jabalpur Road

Bargawan, Katni MP

RQP/DGMMP/061/2013-18

EMP: Bansarai Stone Quarry

Page 2 of 16

CONTENTS

Sr No PARTICULARS Page No

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

INTRODUCTION

NAME OF THE LESSEE

DETAILS OF THE AREA

DETAILS OF THE MACHINES TO BE USED IN MINING OPERATION

DETAILS OF MEASUREMENT OF QUARRY PIT EARLIER EXCAVATED IN THE

AREA TO BE SANCTIONED AND DETAILS OF MINERAL CONCESSIONS

SITUATED WITHIN 100 METERS PERIPHERY OF THIS AREA

SCHEME OF THE PLANTATION

DETAILS OF APPROXIMATE DISTANCE OF NATIONAL PARK, SANCTUARY,

BIODIVERSITY AREA, INTERSTATE BOUNDARY SITUATED WITHIN

PERIPHERY OF 10 KM FROM THE AREA TO BE SANCTIONED

PROPOSED ANNUAL PRODUCTION OF MINERAL

EFFECT ON GROUND WATER LEVEL DUE TO MINING OPERATION AND ITS

PREVENTIVE MEASURES:

DETAILS OF SCHEME OF CONTINUOUS RECLAMATION AND REHABILITATION

OF THE LAND DEGRADATION DUE TO MINING OPERATION:

DETAILS OF PREVENTIVE AND CONTROL SCHEME OF AIR AND WATER

POLLUTION:

PROVISIONS FOR SEPARATE STACKING OF SURFACE SOIL EXCAVATED FROM

MINING OPERATION AND IT’S UTILITY:

DETAILS OF SOCIAL AND ECONOMIC UP GRADATION OF MINING EFFECTED

AREA DUE TO PROPOSED PROJECT

DETAILS OF BUDGETARY ARRANGEMENT FOR ENVIRONMENTAL

MANAGEMENT

ANY OTHER DETAILS DESIRED TO BE SUBMITTED BY MINERAL CONCESSION

HOLDER

4

5

6 – 7 - 8

9

9

9 - 10

11

11

12

12 - 13

13 – 14 -

15

16

16

17


Page 3 of 16

SCHEME FOR ENVIRONMENTAL MANAGEMENT PLAN FOR

VILLAGE : Bansarai

TEHSIL : Rajnagar



MINERAL : Crusher Stone

KHASRA No : 313

PRODUCTION CAP : 50411 Cu.mt/year (avg.)

1. INTRODUCTION

Nature is very kind on the human to provide all kind of materials on earth. All kinds

of minerals are available in their raw form in the earth . Mining operations disturb

the terrestrial configuration and natural beauty of the area. The magnitude of

disturbance depends upon how the minerals are extracted from the mining area

and the environmental impact depends upon the location and size of deposits and

the methods adopted for its exploration. By adopting good mining practices it is

moving towards harmonious development where both the operational and

environmental aspects are accorded due weightage.

Every quarry lease holder shall take all possible precautions for the protection of

environment and control of pollution while conducting quarry operation. Under the

mining operation the this management plan is required.

The mining plan has been approved by Directorate of Geology & Mining Regional

Office jabalpur vide letter no. 743 on dtd. 07-03-2017. The Collector office (Khanij

Shakha) Chhatarpur vide letter No. 464/Khanij/2017, dated-28/02/2017.


Page 4 of 16

2. NAME & ADDRESS OF LESSEE:


Prop. Mr. Shreekant Dixit

Resi.- Tikuriya Mohalla, Near Madiya Talab, panna,

Dist.- Panna, Madhya Pradesh

SALIENT FEATURES OF THE PROJECT:

Particulars Details

Name of the project Bansarai Stone Quarry

Land use pattern Individual Owner

Mineral Crusher Stone

Mining Lease area 7.450Hect.

Khasra No. 313

Land Use Govt. Land

Lease Validity 10 Years

Production Capacity Crusher Stone Production: 50411 Cu.mt/year (avg.)

Village Bansarai

Tehsil Rajnagar

District Chhatarpur

Latitude& Longitude

1. 24 44 31.30n, 79 50 49.47e

2. 24 44 32.20n, 79 50 48.46e

3. 24 44 32.87n, 79 50 35.69e

4. 24 44 23.82, 79 50 36.62e

Estimated project cost 40 Lacs

EMP Cost 3.9 Lacs

Man Power 25-30

Water demand and supply 8-10KLD

Nearest habitation/town The nearest village is Bansarai which is about 1.8KMS

in S-E direction from mine site.

Nearest Airport The nearest Airport is Khajurao which is about 10.5

KMS from mine site.

Nearest Connectivity NH-75 Road, which is about 3.8 km from mine site.

Nearest Railway Station The nearest Railway Station is Chhatarpur which is

about 27 KMS from mine site.


Page 5 of 16

3. DETAILS OF THE AREA

VILLAGE : Bansarai

TEHSIL : Rajnagar



MINERAL : Crusher Stone (Gitti)

KHASRA No : 313

PRODUCTION CAPACITY : 50411 Cu.mt/year (Avg.)

Period : 10 Years

The details of the lease area to be grant, ownership etc. is as below:

District & State Tehsil Village Area in

hect.

Khasra

No.

Mineral

Name

Lease

Period

Chhatarpur,

Madhya Pradesh

Rajnagar Bansarai 7.450 313 Crusher

Stone

10Years

Whether area is recorded in forests : No

Existance of Public road : No public road passes

TOPO SHEET : Area falls in survey of India

54 P/14


Page 6 of 16

Khasra Map:


Page 7 of 16

Satellite Image of the mining area:


Page 8 of 16

4. DETAILS OF MACHINE TO BE USED IN MINING OPERATION:

• Proposed Mining/excavation will be done according to the proposed manner of

Manual, Dumpers, Tractor & Water Tank, Jack, Hammer, Wagon Drill will be

required to deploy on hire basis for transport purpose.

• Details given in Mining Plan.

5. DETAILS OF MEASUREMENT OF QUARRY PIT EARLIER

EXCAVATION IN THE AREA TO BE SANCTIONED AND DETAILS

OF MINERAL CONCESSIONS SITUATED WITHIN 100 METER

PERIPHERY OF THIS AREA

• No seasonal perennial drainage exists within the lease area

• No pit was excavated in the past since this is new lease quarry.

• The area in surroundings up to 100meters forms a plain topography with

miner undulations of waste land form.

6. . SCHEME OF TREE PLANTATION:

• Main objective of green belt is to provide a barrier between the source of

pollution and the surrounding areas.

• Green belt helps to capture the fugitive emission and to attenuate the noise

generated apart from improving the aesthetics.

• While making choice of plant species for cultivation in green belts priority is

to be given to create bio – climate.

• The authorities responsible for making green belt must ensure proper

selection of plant species and adequate provision of watering and protection

of saplings exist at site.


Page 9 of 16

• Healthy tree species will be recommends for plantation.

• Each plant must cover 2.5 x 2.5 meter and its 100 % survival should be

achieved

• Suitable Mali will take care of survival conditions.

• During the plan period about 0.445Ha area will be used for plantation

purposes with in 7.5m barrier zone & plantation will be undertaken towards

the southwest slope.

• The lease area is marked by large exposure of barren land. The lease area is

rocky terrain so it is only feasible to undertake the plantation with in lease

hold area under 7.5 m barrier after spreading top soil over the strip

plantation shall also be undertaken over complete benches. 100 no. trees will

be planted per year.

• The tree species recommended are Tactonagrandis (Teak),

Azadirachtaindica (Neem),Mangiferaindica (Aam), Acacia Catechu (Khair),

Emblicaofficinalis (Amla),MahuncaLatitolia (Mahua), Planting should be

done in large sized 90 cm x 90 cm.pits dug in advance and filled with manure

about 50 days before planting. The plantation raised earlier should be

carefully maintained. Mortalities should be replaced by fresh saplings.

Post Plantation Care:

• Green belt area must be guarded by suitable fencing to avoid damage by cattle

grazing.

PROPOSED PLANTATION DURING FIRST FIVE YEARS

YEAR NO OF TREES SURVIVAL

RATE

(ANTICIPATED)

SPECIES OF PLANTS

1ST

2ND

3RD

4TH

5TH

100

100

100

100

100

70 %

70 %

70 %

70 %

70 %

MANGO, SUBABOOL

KARANJ, TEAK, NEEM,

KHAIR OR AS SUGGESTED

BY FOREST DEPARTMENT


Page 10 of 16

7. . DETAILS AND APPROXIMATE DISTANCE OF NATIONAL

PARK, SANCTUARY, BIODIVERSITY AREA, INTERSTATE

BOUNDARY SITUATED WITHIN PERIPHERY OF 10 KM FROM

THE AREA TO BE SANCTIONED

Sr No Proposed project is located in whole or in part within 10 km.

from the boundary of

YES/NO

1 Protected areas notified under the Wild Life (Protection) - Act,

1972

NO

2 National Park NO

3 Critically polluted areas as notified by the Central Pollution

Control Board from time to time

NO

4 Notified Eco-sensitive areas NO

5 Inter-state boundaries and international boundaries NO

8. PROPOSED ANNUAL PRODUCTION OF MINERAL

-The yearly production from the quarry is proposed Crusher Stone is 50411

Cu.mt/year (Avg.) with Semi Mechanized and Semi Mechanical opencast mining

system.

-Entire details are given in the mining plan.

9. EFFECT ON GROUND WATER LEVEL DUE TO MINING

OPERATION AND ITS PREVENTIVE MEASURES:

• It is a surface mining upto the depth of 30 meters

• Mining will not be done below the water table.

• Mining will be done in non- monsoon period.

• There is no perennial water body in the area. Therefore mining activities

will not cause adverse impacts as the mineral is non toxic in nature.

• Lease area is fairly flat reducing the possibility of soil erosion.


Page 11 of 16

• Garland drain will be properly channelized so that the rain water and

wash offs goes into in sedimentation ponds.

• As the manpower likely to be deployed from nearby village, therefore

discharge of domestic waste water is not much and will be easily

controlled with the provision of septic tank and soak pit.

• The stored water will be used for dust suppression and greenbelt

development, etc.

The pit exposed due to mining will become a source for catchment of

rain water and in future it will be helpful to improve the water table of

the area.

10. DETAILS OF SCHEME OF CONTINUOUS RECLAMATION

AND REHABILITATION OF THE LAND DEGRADATION DUE TO

MINING OPERATION:

• Land degradation is one of the major adverse impacts of open cast mining

activities and any effort to control adverse impacts would be incomplete

without appropriate land reclamation strategy.

• It is a mining below five hectares lease area, which is very small in nature

therefore no damage of the land is anticipated.

• The area is likely to be degraded due to quarrying, pitting & roads.

• The impact on the land form or Physiography will be limited to the

modification of the slope.

• The landscape and land use will undergo a radical change due to open cast

mining. The impact during plan period is limited as benches will be formed on

the already degraded land.

• Besides these benches, roads will also modify the Physiography.

• By the completion of project period plantation will grow up and will form

green belt around the Quarry Land area.

• During the plan period, benches will reach the ultimate pit limit. The total

exploited Crusher Stone shall be transported to crusher plant of making

aggregates therefore no waste shall be generated.

• Reclamation and rehabilitation will be started at the end of mine life which

required sufficient quantity of waste etc. for back filling. Availability of waste

at the closing time of mine will be very less to meet requirement; hence the

mined out pit will be developed as water reservoir in future.

• Experience of scientific mining work will be achieved by the applicant and

workers which can be utilized for further achievements related to mining.


Page 12 of 16

11. DETAILS OF PREVENTIVE AND CONTROL SCHEME OF

AIR AND WATER POLLUTION:

Air Pollution Control:

• The proposed site is located in the remote area having a clean atmosphere.

Therefore the quality of ambient air will be as good as heaven.

• As the mining is of small scale, the potential sources of air pollution arising

from mining operations would be Drilling, haul roads, exhaust fumes of

internal combustion machines, combusting of fuel oil and transportation of

• Due to this mining activities air quality will undergo certain significant

change.

• Air pollution caused by mining and associated activities can be classified into

the following categories:

• Gaseous Pollutants (Nitrogen Oxides, Sulphur Dioxide and Carbon Monoxide)

• Suspended Particulate Matter.

The present level of mining is not anticipated to raise the concentration of the

pollutants beyond the prescribed limits. However, the following measures are being

adopted in the proposed mining activity to mitigate the PM levels in ambient air.

Mitigation Measure:

Mining activities will generate certain quantities of dust during drilling, blasting,

loading and transportation operations. The following measures willbe taken to

mitigate the fugitive dust from different operations:

� To avoid the dust generation from the drilling operations, wet drilling method

will be adopted.

� Drill machines will be equipped with dust collectors.

� Dust mask will be provided to all workers.

� Provision of dust filters/ mask to workers working at highly dust prone and

affected areas.

� Provision of green belt all along the periphery of the lease area.

� Periodical monitoring of ambient air quality in and around the lease area.


Page 13 of 16

� Lying of haul road as per the standards Regular maintenance of haul road and

service road to reduce air – borne dust.

� Watering of haul road and other road at regular intervals.

� Dense plantation being carried in and around the proposed mines will help in

combating air pollution.

� In case of long transportation the trucks after loading will be covered with

tarpaulin sheets.

� Speed of the vehicles will be maintained within the prescribed limits.

� Trucks will not be over loaded and will be maintained to the optimum body level.

Water Management and Water Pollution Control:

� Mining activities will not cause adverse impacts as the mineral is non toxic in

nature.

� Lease area is fairly flat reducing the possibility of soil erosion.

� Garland drain will be properly channelized the rain water and wash offs in

sedimentation ponds.

� As the manpower is likely to be deployed from nearby village, therefore the

discharge of domestic waste water will not be much and will be easily

controlled with the provision of septic tank and soak pit.

� The stored water will be used for reduction of Particular Matter of Ambient

Air, and for the development of greenbelt etc.

Following control measures will be taken to minimize water Pollution due to mining

activity;

� The stored water will be used for reduction of Particular Matter of Ambient Air,

and for the development of greenbelt etc.

� A drain should be created around the quarry land and connected to the proposed

water body.

Water

Consumption

(Avg.)

8-10 kld

Waste Water

Generation

Only from domestic section, taken care by Soak pit/

Septic tank arrangement

Source of water Nearby Village


Page 14 of 16

Noise Environment:

Movement of truck/ dumper will create the transitional noise level. However noise

generated by these will be of low level and will be within the prescribed desired

limit.

Following control measures will be taken to minimize negative impact due to

mining activity.

� Machinery and equipments of improved designs

� Proper maintenance of all machines will be carried out which will reduce noise

generation during operations.

� Use of PPE,s personal protective devices i.e. earmuffs and earplugs by workers,

working in high noise areas.

� Provision of green belt all along the periphery of the lease area.

� Conducting periodical medical checkup of all workers for any noise related health

problems

� Proper training to personnel to create awareness about adverse noise level

effects.

� Noise barriers, silencers and enclosures shall be incorporated in the equipments,

which emit noise levels.

� Unnecessary use of horns by the drivers of the vehicles shall be avoided.

12. PROVISIONS FOR SEPARATE STACKING OF SURFACE SOIL

EXCAVATED FROM MINING OPERATION AND IT’S UTILITY:

� Top soil in the lease area is very scanty.

� Available soil will be removed and kept stacked for utilizing for plantation in

the backfilled area, when the mine reaches the ultimate limits.

� Grasses will be planted on the soil along the slopes to prevent wash offs

during monsoon and prevent landslides.

13. DETAILS OF SOCIAL AND ECONOMIC UP GRADATION OF

MINING EFFECTED AREA DUE TO PROPOSED PROJECT:

EMP:

� 7.450 Hectares Bansarai

� Mine has undertaken community development works in order to improve the

amenities in nearby villages as a part of commitment towards social and

economic up liftment of the area

on socio-economic life of people living in n

� No impact on agricultural lands has been reported due to mining, nor has

mining affected the climate of the area.

� There has been rather an improvement in the status of the people because of

increase in income due to direct or indirect emp

� Mining has created awareness amongst the people for education and general

upliftment particularly in the womenfolk.

14. ENVIRONMENTAL MANAGEMENT IMPLEMENTATION BUDGET:

Sr. No. Particular

1 Garland Drain with

2 Tree Plantation (including post

plantation care, protection)

@ 500 tree/plant

3 Pollution Control (Water tanker ect.

4 Monitoring (twice a year)

5 Road maintenance Contribution

6 Miscellaneous

Total

: Bansarai Stone

Bansarai Stone Quarry of M/s. Sidhant Minerals

undertaken community development works in order to improve the


liftment of the area. Mining is expected to have positive impact

economic life of people living in nearby villages.

No impact on agricultural lands has been reported due to mining, nor has

mining affected the climate of the area.

There has been rather an improvement in the status of the people because of

increase in income due to direct or indirect employment

Mining has created awareness amongst the people for education and general

upliftment particularly in the womenfolk.

. ENVIRONMENTAL MANAGEMENT IMPLEMENTATION BUDGET:

Amount Per Year (In

Thousand)

with septic tank 1,00,000 (Fixed)

Tree Plantation (including post

plantation care, protection)

@ 500 tree/plant

50,000

lution Control (Water tanker ect.) 1,00,000

(twice a year) 40,000

Road maintenance Contribution 50,000

50,000 (Fixed)

3,90000/-

Bansarai Stone Quarry

Page 15 of 16


undertaken community development works in order to improve the


. Mining is expected to have positive impact

No impact on agricultural lands has been reported due to mining, nor has

There has been rather an improvement in the status of the people because of

Mining has created awareness amongst the people for education and general

. ENVIRONMENTAL MANAGEMENT IMPLEMENTATION BUDGET:

Amount Per Year (In

0,000 (Fixed)

(Fixed)

EMP:

Sr. No. Particular

1 Social Welfare activities i.e.

material (Books, copies etc.

students every year

2 Contribution for Sports activity in school & villages area

3 Contribution for digital India (

4 Distribution of solar cooker

5 Contribution for Swachchh Bharat Abhiyan

Total

15. ANY OTHER DETAILS DESIRED TO BE SUBMITTED BY

MINERAL CONCESSION HOLDER:

All information regarding EMP has been mentioned above point. Other information is

given in Form-1, PFR & Mining plan.

: Bansarai Stone

Amount Per Year

Social Welfare activities i.e. Distribution of study

Books, copies etc.) and clothes to Poor

every year

3

Contribution for Sports activity in school & villages area 2

Contribution for digital India (1 Computer) 40

Distribution of solar cooker 20

Contribution for Swachchh Bharat Abhiyan 2

1,

OTHER DETAILS DESIRED TO BE SUBMITTED BY

MINERAL CONCESSION HOLDER:


1, PFR & Mining plan.

Bansarai Stone Quarry

Page 16 of 16

Amount Per Year

(In thousand)

30,000

20,000

40,000

20,000

20,000

1,30,000

OTHER DETAILS DESIRED TO BE SUBMITTED BY


Documents

ENVIRONMENT MANAGEMENT PLAN - … · Sidhant Minerals Prop. Mr ... • Garland drain will be properly channelized so that ... • Reclamation and rehabilitation will be started at