Upload
others
View
9
Download
0
Embed Size (px)
Citation preview
Em-box by nilan
Product data
Domestic Passive heat recovery
Passive heat recovery
2
14
This drawing is the property of Nilan A/S and may not without writtenpermission be copied or turned over to other persons or companies
Denne tegning er Nilan A/S ejendom, og må ikke kopieres ellervideregives til tredjemand uden skriftlig tilladelse
18. januar 2010 12:50:56
D
E
F
C
1 2 3 4
B
A
321 5
C
D
4 6 7 8
A
Overfladebehandling:
g
mål i millimeter og alle vinkler i grader
Fax: 76 75 25 25
: bukkes 90° ned: bukkes 90° op
Med mindre andet er angivet gælder:
B
Mål markeret med O er kontrolmål
ha
ha
Revideret:
Titel:
5. marts 2010 10:23:40
Emhætte-boks
Tegn. af:
Kontr. af:
Godk. af:
Antal pr. anlæg:
Initialer Dato
Tegning nr.
Materiale:
Målestok:1:1 Format: A3 Sheet 1 af 1
Vægt:
Fil: V:\SW_multiuser\Emhætte-boks\Emhætte-boks
Revision
Mål markeret med () er konturmålFor pladedele gælder:
8722 HedenstedNilanvej 2Nilan A/S
www.nilan.dk
Tlf: 76 75 25 00
Hvis andet ikke er specificeret er alle
Info:
Ø160
Ø160
206
750
Ø125
242
The Em-box is an accessory item that can be connected to Nilan's domestic system. An Em-box allows heat recovery from the range hood in the home. Em-box is available as a ceiling model that can be installed on either the left or right side of the range hood.
The Em-box uses the range hood for both basic ventilation and range hood extraction. When the range hood is switched off, the statutory air extraction in the kitchen takes place via the range hood. When the range hood starts, a damper in the range hood will open and the ventilation system will change the air volume setting to the maximum air exchange, ensuring balanced venti-lation while the range hood is running.
The Em-box maintains an unchanged adjusted air volume in the home, extracting the increased ventilation volume via the range hood.
Product description
Standard deliveryEm-box is delivered with the following as standard:
• belimo servomotor
• Control
• Grease filter
AccessoryEm-box can be ordered with the following auxiliaries:
• Steel filter for filter box and Em-box
Technical specifications
Dimensions (b×D×H) 750×242×206 mm Weight 6 kg
Plate type casing Aluzinc 09
Filter class metal grease filter
Duct connections 2 x Ø160 & 2 x Ø125
Supply voltage 230 V
When the range hood is switched off the damper in the range hood will close again, and the ventilation system will revert to the original air volume. The Em-box will continue to maintain the regulated air supply to the home.
If the Em-box cannot be optimally located, a range hood filter box can be used instead. The range hood filter box takes up less space and can be located adjacent to the range hood. The range hood filter box includes a DTbU damper that is placed in the extraction duct leading from the range hood.
The Em-box and range hood filter box are delivered as tested and ready for operation. Installation and commissioning must be performed by an authorised electrician.
14
This drawing is the property of Nilan A/S and may not without writtenpermission be copied or turned over to other persons or companies
Denne tegning er Nilan A/S ejendom, og må ikke kopieres ellervideregives til tredjemand uden skriftlig tilladelse
18. januar 2010 12:50:56
D
E
F
C
1 2 3 4
B
A
321 5
C
D
4 6 7 8
A
Overfladebehandling:
g
mål i millimeter og alle vinkler i grader
Fax: 76 75 25 25
: bukkes 90° ned: bukkes 90° op
Med mindre andet er angivet gælder:
B
Mål markeret med O er kontrolmål
ha
ha
Revideret:
Titel:
5. marts 2010 10:23:40
Emhætte-boks
Tegn. af:
Kontr. af:
Godk. af:
Antal pr. anlæg:
Initialer Dato
Tegning nr.
Materiale:
Målestok:1:1 Format: A3 Sheet 1 af 1
Vægt:
Fil: V:\SW_multiuser\Emhætte-boks\Emhætte-boks
Revision
Mål markeret med () er konturmålFor pladedele gælder:
8722 HedenstedNilanvej 2Nilan A/S
www.nilan.dk
Tlf: 76 75 25 00
Hvis andet ikke er specificeret er alle
Info:
Ø160
Ø160
206
750
Ø125
242
Dimensional drawingAll dimensions are in mm
14
This drawing is the property of Nilan A/S and may not without writtenpermission be copied or turned over to other persons or companies
Denne tegning er Nilan A/S ejendom, og må ikke kopieres ellervideregives til tredjemand uden skriftlig tilladelse
18. januar 2010 12:50:56
D
E
F
C
1 2 3 4
B
A
321 5
C
D
4 6 7 8
A
Overfladebehandling:
g
mål i millimeter og alle vinkler i grader
Fax: 76 75 25 25
: bukkes 90° ned: bukkes 90° op
Med mindre andet er angivet gælder:
B
Mål markeret med O er kontrolmål
ha
ha
Revideret:
Titel:
5. marts 2010 10:23:40
Emhætte-boks
Tegn. af:
Kontr. af:
Godk. af:
Antal pr. anlæg:
Initialer Dato
Tegning nr.
Materiale:
Målestok:1:1 Format: A3 Sheet 1 af 1
Vægt:
Fil: V:\SW_multiuser\Emhætte-boks\Emhætte-boks
Revision
Mål markeret med () er konturmålFor pladedele gælder:
8722 HedenstedNilanvej 2Nilan A/S
www.nilan.dk
Tlf: 76 75 25 00
Hvis andet ikke er specificeret er alle
Info:
Ø160
Ø160
206
750
Ø125
242
EM-boxØ 160
Range hood filter box
206
750
242
258
182
Ø 125
Ø 125
160
194
14
EM-box
3
Range hood filter box
Ventilation system with counterflow heat exchangers
45 l/s or forced, distributed on rooms
range hood filter boxProtects the system from grease
M
M controlled by ventilation system
15 l/sbath-room
10 l/sutility room
the range hood sends a signal to the ventilation system
20 l/s forced basic extraction when the range hood is running
control on normal operation the dtbu damper is fully open, with basic extraction by the range hood of 20 l/s. When the range hood is in operation the system runs both intake and extraction. the dtbu damper is controlled to maintain extraction of 25 l/s, and the forced extraction is led to the range hood.
dtbu damper
Principle diagramsEM-box
discharge Supply
Ventilation system with counterflow heat exchangers
Electric heatingelement(if installed)
20 l/s forced basic extrac-tion when the range hood is
running
Grease filter
15 l/sbath-room
10 l/sutility room
the servomotor is run by the ventilation sys-tem, which is activated when the range hood is activated. the damper maintains 15 l/s in the bathroom and 10 l/s in the utility room while the range hood is running
EM-box
45 l/s or forced, distributed on rooms
EM-box by nilan
Electric heatingelement(if installed)
discharge Supply
Ver.
1.0
Nila
n A
/S a
ssum
es n
o re
spon
sibi
lity
for
any
erro
rs o
r om
issi
ons
in th
e pr
inte
d in
form
atio
n m
ater
ial o
r fo
r lo
ss o
r da
mag
e th
at m
ay fo
llow
from
the
use
of s
uch
publ
ishe
d m
ater
ials
- w
heth
er s
uch
loss
of d
amag
e is
cau
sed
by e
rror
s or
in
expe
dien
cies
in th
e m
ater
ial o
r ot
herw
ise.
Nila
n A
/S r
eser
ves
the
righ
t wit
hout
pri
or n
otic
e to
cha
nge
prod
ucts
and
info
rmat
ion
mat
eria
l. A
ll tr
adem
arks
are
the
prop
erty
of N
ilan
A/S
. All
righ
ts r
eser
ved.
EM-BOX BY NILAN
PRODUKTDATA
Bolig Passiv varmegenvinding
Passiv varmegenvinding
inforMation froM a to ZNilan develops and manufactures premium-quality, energy-saving ventilation and heat pump solutionsthat provide a healthy indoor climate and low-level energy consumption with the greatest consideration forthe environment. In order to facilitate each step in the construction process – from choosing the solutionthrough to planning, installation and maintenance – we have created a series of information material whichis available for download at www.nilan.dk.
WWW.nilan
.dk
Visit us at www.nilan.dk to find outmore about our company and solutions,download further information and findyour nearest dealer.
brochureGeneral information about the solution and its benefits.
Product dataTechnical information to ensure correct choice of solution.
Installation instructionsDetailed guide for installation and initial adjustment of the solution.
User manualDetailed guide for regulation of the solution to ensure optimum day-to-day operation.
Drawing materialNilan is happy to make 2D CAD drawings available for integrated planning with the solution.
nilan a/Snilanvej 28722 Hedensteddenmarktel. +45 76 75 25 00fax +45 76 75 25 [email protected]