Electronic Advertising Contract Bids open Thursday, January 19, 2012 OSD Dated November 14, 2011 IH

12

STATE OF CALIFORNIA DEPARTMENT OF TRANSPORTATION

NOTICE TO BIDDERS AND

SPECIAL PROVISIONS FOR CONSTRUCTION ON STATE HIGHWAY IN ORANGE COUNTY IN SAN CLEMENTE

AND DANA POINT FROM 0.1 MILE SOUTH OF CAMINO DE ESTRELLA OVERCROSSING TO 0.2 MILE SOUTH OF VIA CALIFORNIA OVERCROSSING AT CAMINO DE ESTRELLA

In District 12 On Route 5 Under

Bid book dated November 14, 2011 Standard Specifications dated 2006

Project Plans approved February 14, 2011 Standard Plans dated 2006

Identified by

Contract No. 12-0F0604

12-Ora-5-5.6/6.6

Project ID 1200000110

Federal-Aid ProjectACIM-005-2(960)78E

*******************************************************************************************

SPECIAL NOTICES

*******************************************************************************************

Refer to Section 8-1.07, "Liquidated Damages," of the Amendments to the Standard Specifications for your project-specific liquidated damages based on your total bid.

The Department is providing an electronic Information Handout for this project. Refer to Section 2-1.03B,

"Supplemental Project Information," in the Amendments to the Standard Specifications for the location of this information.

The Department is allowing contractors to submit electronic payroll records to the District Labor Compliance

Office. Refer to section titled "Electronic Submission of Payroll Records" under Section 5, "General," of these special provisions.

Contract No. 12-0F0604

i

TABLE OF CONTENTS NOTICE TO BIDDERS ....................................................................................................................................................... 1COPY OF BID ITEM LIST .................................................................................................................................................. 3SPECIAL PROVISIONS ...................................................................................................................................................... 9SECTION 1 (BLANK) ........................................................................................................................................................ 9SECTION 2 BIDDING ........................................................................................................................................................ 9

2-1.01 TIE BID RESOLUTION .................................................................................................................................... 92-1.02 DISADVANTAGED BUSINESS ENTERPRISES ........................................................................................... 92-1.03 OPT OUT OF PAYMENT ADJUSTMENTS FOR PRICE INDEX FLUCTUATIONS ................................. 10

SECTION 3 CONTRACT AWARD AND EXECUTION ................................................................................................ 113-1.01 SMALL BUSINESS PARTICIPATION REPORT ......................................................................................... 113-1.02 CALTRANS BIDDER - DBE INFORMATION FORM ................................................................................. 11

SECTION 4. BEGINNING OF WORK, TIME OF COMPLETION, AND LIQUIDATED DAMAGES ....................... 11SECTION 5 GENERAL .................................................................................................................................................... 11

5-1.01 EMISSIONS REDUCTION ............................................................................................................................ 115-1.02 PERFORMANCE OF DBES ........................................................................................................................... 125-1.03 PERFORMANCE OF UDBES ......................................................................................................................... 125-1.04 PAYMENT ADJUSTMENTS FOR PRICE INDEX FLUCTUATIONS ........................................................ 125-1.05 SURFACE MINING AND RECLAMATION ACT ........................................................................................ 155-1.06 ELECTRONIC SUBMISSION OF PAYROLL RECORDS............................................................................ 165-1.07 TRAINING ...................................................................................................................................................... 165-1.08 FORCE ACCOUNT PAYMENT .................................................................................................................... 165-1.09 AREAS FOR CONTRACTOR'S USE ............................................................................................................ 175-1.10 PAYMENTS ................................................................................................................................................... 175-1.11 SUPPLEMENTAL PROJECT INFORMATION ............................................................................................ 175-1.12 RELATIONS WITH CALIFORNIA REGIONAL WATER QUALITY CONTROL BOARD ...................... 185-1.13 NONHIGHWAY FACILITIES (INCLUDING UTILITIES) .......................................................................... 185-1.14 DAMAGE REPAIR ........................................................................................................................................ 205-1.15 RELIEF FROM MAINTENANCE AND RESPONSIBILITY ....................................................................... 20

SECTION 6. (BLANK) ..................................................................................................................................................... 20SECTION 7. (BLANK) ..................................................................................................................................................... 20SECTION 8. MATERIALS ............................................................................................................................................... 20SECTION 8-1. MISCELLANEOUS ................................................................................................................................. 20

8-1.01 PREQUALIFIED AND TESTED SIGNING AND DELINEATION MATERIALS ...................................... 208-1.02 STATE-FURNISHED MATERIALS .............................................................................................................. 268-1.03 SLAG AGGREGATE ..................................................................................................................................... 26

SECTION 8-2. CONCRETE ............................................................................................................................................. 278-2.01 PORTLAND CEMENT CONCRETE ............................................................................................................. 278-2.02 CORROSION CONTROL FOR PORTLAND CEMENT CONCRETE ......................................................... 288-2.03 RAPID STRENGTH CONCRETE FOR STRUCTURES ............................................................................... 288-2.04 PRECAST CONCRETE QUALITY CONTROL ............................................................................................ 328-2.05 SELF-CONSOLIDATING CONCRETE FOR PRECAST ELEMENTS ........................................................ 35

SECTION 8-3. WELDING ................................................................................................................................................ 378-3.01 WELDING ....................................................................................................................................................... 37

WELDING QUALITY CONTROL ..................................................................................................................... 38WELDING FOR OVERHEAD SIGN AND POLE STRUCTURES ................................................................... 41

SECTION 9. DESCRIPTION OF BRIDGE WORK ......................................................................................................... 42SECTION 10. CONSTRUCTION DETAILS ................................................................................................................... 42SECTION 10-1. GENERAL .............................................................................................................................................. 42

10-1.00 CONSTRUCTION PROJECT INFORMATION SIGNS .............................................................................. 4210-1.01 ORDER OF WORK ...................................................................................................................................... 4310-1.02 WATER POLLUTION CONTROL .............................................................................................................. 4410-1.03 CONSTRUCTION SITE MANAGEMENT .................................................................................................. 5710-1.04 STREET SWEEPING .................................................................................................................................... 6710-1.05 TEMPORARY HYDRAULIC MULCH (BONDED FIBER MATRIX)....................................................... 6810-1.06 TEMPORARY CONCRETE WASHOUT BIN ............................................................................................. 7010-1.07 TEMPORARY FIBER ROLL ....................................................................................................................... 72