Electronic Advertising Contract Bids open Tuesday, June 18, 2013 OSD Dated April 29, 2013 IH

10

STATE OF CALIFORNIA DEPARTMENT OF TRANSPORTATION

NOTICE TO BIDDERS AND

SPECIAL PROVISIONS FOR CONSTRUCTION ON STATE HIGHWAY IN SAN JOAQUIN COUNTY NEAR

TERMINOUS FROM MOKELUMNE RIVER BRIDGE TO LITTLE POTATO SLOUGH BRIDGE

In District 10 On Route 12 Under

Bid book dated April 29, 2013 Standard Specifications dated 2006

Project Plans approved December 24, 2012 Standard Plans dated 2006

Identified by

Contract No. 10-0G8004

10-SJ-12-0.1/R4.4

Project ID 1000000052

Federal-Aid ProjectACNH-P012(112)E

***********************************************************************************

SPECIAL NOTICES

*********************************************************************************** Effective July 6, 2010, the Department will receive bids for projects in Districts 1 through 6, 9, and 10 at

1727 30th Street, Bidders' Exchange, MS 26, Sacramento, CA 95816. Refer to the Notice to Bidders for this project's bid opening date, time, and location.

For federal-aid projects, the Department is modifying its DBE program. Refer to Section 8-1.07, "Liquidated Damages," of the Amendments to the Standard Specifications for your

project-specific liquidated damages based on your total bid. The Department is providing an electronic Information Handout for this project. Refer to Section 2-1.03B,

"Supplemental Project Information," in the Amendments to the Standard Specifications for the location of this information.

The Department is allowing contractors to submit electronic payroll records to the District Labor

Compliance Office. Refer to section titled "Electronic Submission of Payroll Records" under Section 5, "General," of these special provisions.

Contract No. 10-0G8004 i

TABLE OF CONTENTS

NOTICE TO BIDDERS ....................................................................................................................................................... 1COPY OF BID ITEM LIST ................................................................................................................................................. 3SPECIAL PROVISIONS ..................................................................................................................................................... 9SECTION 1 (BLANK) ........................................................................................................................................................ 9SECTION 2 BIDDING ....................................................................................................................................................... 9

2-1.01 TIE BID RESOLUTION ................................................................................................................................... 92-1.02 DISADVANTAGED BUSINESS ENTERPRISES ........................................................................................... 92-1.03 OPT OUT OF PAYMENT ADJUSTMENTS FOR PRICE INDEX FLUCTUATIONS ................................. 10

SECTION 3 CONTRACT AWARD AND EXECUTION ............................................................................................... 103-1.01 SMALL BUSINESS PARTICIPATION REPORT ......................................................................................... 103-1.02 CALTRANS BIDDER - DBE INFORMATION FORM ................................................................................. 11

SECTION 4. BEGINNING OF WORK, TIME OF COMPLETION, AND LIQUIDATED DAMAGES ....................... 11SECTION 5 GENERAL .................................................................................................................................................... 11

5-1.01 EMISSIONS REDUCTION ............................................................................................................................ 115-1.02 SUBCONTRACTOR AND DISADVANTAGED BUSINESS ENTERPRISE RECORDS ........................... 115-1.03 PERFORMANCE OF DISADVANTAGED BUSINESS ENTERPRISES ..................................................... 125-1.04 PARTNERING DISPUTE RESOLUTION .................................................................................................... 125-1.05 PAYMENT ADJUSTMENTS FOR PRICE INDEX FLUCTUATIONS ........................................................ 135-1.06 SURFACE MINING AND RECLAMATION ACT ........................................................................................ 165-1.07 ELECTRONIC SUBMISSION OF PAYROLL RECORDS ........................................................................... 165-1.08 TRAINING ...................................................................................................................................................... 175-1.09 FORCE ACCOUNT PAYMENT .................................................................................................................... 175-1.10 PAYMENTS ................................................................................................................................................... 185-1.11 SUPPLEMENTAL PROJECT INFORMATION ............................................................................................ 185-1.12 HIGHWAY CONSTRUCTION EQUIPMENT .............................................................................................. 195-1.13 SPECIES PROTECTION ................................................................................................................................ 195-1.14 BIRD PROTECTION ...................................................................................................................................... 215-1.15 RELATIONS WITH CALIFORNIA REGIONAL WATER QUALITY CONTROL BOARD ...................... 215-1.16 ENVIRONMENTALLY SENSITIVE AREA ................................................................................................. 225-1.17 AIR POLLUTION CONTROL DISTRICT REQUIREMENTS ..................................................................... 22

SECTION 6. (BLANK) ..................................................................................................................................................... 22SECTION 7. (BLANK) ..................................................................................................................................................... 22SECTION 8. MATERIALS .............................................................................................................................................. 22SECTION 8-1. MISCELLANEOUS ................................................................................................................................. 22

8-1.01 PREQUALIFIED AND TESTED SIGNING AND DELINEATION MATERIALS ...................................... 22SECTION 8-2. CONCRETE ............................................................................................................................................. 28

8-2.01 PORTLAND CEMENT CONCRETE ............................................................................................................. 288-2.02 RAPID STRENGTH CONCRETE FOR STRUCTURES ............................................................................... 30

SECTION 8-3. WELDING ............................................................................................................................................... 348-3.01 WELDING ...................................................................................................................................................... 34

WELDING QUALITY CONTROL ..................................................................................................................... 36STEEL PIPE PILING QUALIFICATION AUDIT ............................................................................................. 39

SECTION 9. DESCRIPTION OF BRIDGE WORK ........................................................................................................ 40SECTION 10. CONSTRUCTION DETAILS ................................................................................................................... 40SECTION 10-1. GENERAL ............................................................................................................................................. 40

10-1.00 CONSTRUCTION PROJECT INFORMATION SIGNS ............................................................................. 4010-1.01 ORDER OF WORK ...................................................................................................................................... 4010-1.02 WATER POLLUTION CONTROL .............................................................................................................. 4210-1.03 CONSTRUCTION SITE MANAGEMENT .................................................................................................. 5610-1.04 TEMPORARY HYDRAULIC MULCH ....................................................................................................... 6710-1.05 STREET SWEEPING ................................................................................................................................... 6910-1.06 TEMPORARY MULCH ............................................................................................................................... 7010-1.07 TEMPORARY CONCRETE WASHOUTS .................................................................................................. 7310-1.08 TEMPORARY FIBER ROLL ....................................................................................................................... 7610-1.09 TEMPORARY FENCE (TYPE ESA) ........