34
ECO Rain® Root Zone Irrigation Mat

ECO Rain® Root Zone Irrigation Mat - Technical Guide

  • Upload
    vodien

  • View
    236

  • Download
    1

Embed Size (px)

Citation preview

Page 1: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain®

Root Zone Irrigation Mat

- Technical Guide -

���������������� �� �����������������

Page 2: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 2

1� About this Technical Guide ....................................................................................................................... 3�

2� Introduction and Overview ....................................................................................................................... 3�2.1� Operating principle 3�2.2� Difference to conventional irrigation 4�2.3� Installation principle 6�2.4� Efficiency 6�2.5� Research and development 7�2.6� Experiences and References 8�

3� Areas of use…………………………………….. ........................................................................................................ 9�

4� Advantages…………………………………….. ....................................................................................................... 10�

5� Technical Specification............................................................................................................................. 12�5.1� Installation depth 12�5.2� Fill in soil 13�5.3� Load 14�5.4� Technical Data 15�

6� Installation components .......................................................................................................................... 16�

7� Tools……………………………………………….. ........................................................................................................ 19�

8� Installation steps …………………………….. ..................................................................................................... 20�8.1� Assambler 20�8.2� Preparation of the area to be irrigated 20�8.3� Installation of the inlet pipe 20�8.4� Installing the Irrigation Mat 21�8.5� Connection of the Mat panels 23�8.6� Filling 26�8.7� Leakage test 27�8.8� Valve box 27�8.9� Controller and Rain sensor 28�8.10� Initial Operation 28�

9� Advice for planning…………………………….. ................................................................................................. 29�

10� Irrigation times…………………… ................................................................................................................... 30�

11� Water quality………………………………….. ...................................................................................................... 31�

12� Maintenance and repairs ........................................................................................................................ 32�12.1� Maintenance 32�12.2� Winter proofing 33�12.3� Damage to fleece and pipes 33�12.4� Clogging of the outlet drippers 33�

13� Notice of liability…………….. ....................................................................................................................... 34�

14� Further Information………………………………… ............................................................................................ 34�

��������������� �����������������������������

������������������

������������ �����!��" �����������#��$�%�&&&&��'��(������������)���'�����������!(!������������������(��!������������ �������)����!������� ������*�'��������%���+���!�����#������

�,��!��������

�*����(

�����������!����#������-��%�.���,������������������������!�����!������������'������������������

���/��)�!��!(!����!����� ������

0�������!���%�

�������������(��!������!(!����1���������������2��������������3�!�����������,3�!������������/��%������!4������0����������������$���)�����!�������+���"!��!��������'�'���+�(*��������+��������������%��������)����2���!��+�"�!(!���� ������

������(�������)��

�� ��������'���������

��5���������(

����,�������(!(!��������,���'������!(!����2�+��'�����������������������������)�

�����(������"���!�

3�#��������������

Page 3: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 3

1 ABOUT THIS TECHNICAL GUIDE In the following chapters of this Technical Guide the professional irrigation system engineer

will learn about all technical details for design, installation, initial operation and mainten-ance of irrigation systems with the ECO Rain® Root Zone Irrigation Mat

2 INTRODUCTION AND OVERVIEW 2.1 Operating principle The ECO Rain® Root Zone Irrigation Mat is protected by national

and international patents, it is a very innovative product for the ir-rigation technology:

The ECO Rain® Root Zone Irrigation Mat is based on the combina-tion of economical drip irrigation and the use of a special geotex-tile. PE- pipes with integrated, pressure balanced drippers will be enveloped with a special PP fleece and then stitched with two more fleece layers. Hereby the drippers simply serve to saturate the Irrigation Mat with water. The actual irrigation is carried out through the wick-shaped structure of a specially designed fleece and the associated capillary action that supplies water to the roots.

�������/����������(����(������#�����6$����7�����8

�������/����������(����(������#�����6$����7�����8

�� �!�"/����������(����(������#�����6$����7�����8

#� $ �"/����������(����(���������

5������������,9��������

���������%���������& �� �

'��(�#)����(

*�+�,����-�& �� �� . /0!�1!2�3333

��������������� �����������������������������

*��!����%�������������������������������������!�'����������#�!����������'���+���������������#�������������:�������:�����'�����-���,"'�����������!(!���4!�'������������������� ��������������

*���,��'�������������� ��������������%������"����������������������'���������������4& �������������,��!�����������7���'��������!���!�&

��������������� ��������������%!��'������(�����,�����-!�������������$�����������������,�!�������$����7����&2��(��(�������������������,!����$���������������)�!������'����!�����������%��������!�������$����7������!����"'�+�����'���"��!��($����7�����&5������)�!�����%��!��($����7�����:��������'�������������������&9�(!����#��������!���!������,����������������������4%�����(!�����!�����!����7���������!�����������"��$���)���!��(���������������"��"������"��������������!(!��������������!����&

Page 4: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 4

2.2 Difference to conventional irrigation Compared to conventional irrigation using sprinklers or drip pipes, the ECO Rain® Root Zone

Irrigation Mat distinguishes itself in the following three points:

� The enveloped drip pipe enables, an optimal water distribution, alongside the drip pipe as well as between the pipes. Almost 100% even water distribution over the entire area that is to be irrigated, therefore water is supplied directly at the roots, this supports an excellent plant growth. In contrast to that are the conventional drip pipes, where the water distribution is only selective. Or spray irrigation systems, which through incorrect planning and/or bad po-sitioning do not cover the whole area to be irrigated. Yellow and/or bare patches are the consequence.

Waterfront Jebel Ali, Dubai / UAE:

Irrigation of the grass with Irrigation of the grass ECO Rain® Root Zone Irrigation Mat with conventional techniques

� 45",6 7� � + ����8�"9!4��,�/ ��&"9!�6��:9!

��������������� �����������������������������

*��������!������)�����!�������)����,���������������,�'�������������� ��������������%!��'����!����#����'�%�������!����%�������,�����;

���������������������,:���%������������,:�������)��'��������������,����&9�!���,������(%�������"���������������"����������'���������������������������'<�(&*�!������%��������,������%��!�������������'���!�����,(���(&

0������(!����������'������������������%!��'��%��=����!������!�����������������������,:���%�'�������������������������!���",����"��������!(!���4!��!�������)�:�����������(���'��������������!����(����'���������������(6�(++!�����,����(8���!����%������>��������������6����:!����(:%�����!��,(&&8

������������� �� ��������

��� ��������������������������������

��� ��������������� ��� �!"��#��$����%�

Page 5: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 5

Irrigation of shrubs with Irrigation of shrubs ECO Rain® Root Zone Irrigation Mat with conventional techniques

Root development of turf 10 weeks Root development with after installation (arid climate zone) pre cultivated mats (moderate climate)

� In addition to this is the high water storage capacity of the special fleece, which mainly enhances the storage capacity of the soil in arid and semiarid climate zones. Water that cannot be absorbed by the roots in the moment of irrigation inevitably flows off into the ground water and is lost when using conventional irrigation systems. In contrast to that stores the special fleece of the ECO Rain® Root Zone Irrigation Mat 4 liter of water per m², this water is available to the roots.

This explains the high water saving effect of the ECO Rain® Root Zone Irrigation Mat of

up to 70%.

� Through the enveloped pipes as well as through the top fleece layer sufficient water is available over the entire area, it prevents the natural propagation of the roots growing into the drip pipes. This also prevents clogging of the drippers, which is a problem when using conventional irrigation systems with subsurface installed drip pipes.

��������������� �����������������������������

��� �������!��&���������������������

��� ��������� ��'�!��&��(���%�"��#��$����%�

)!����$��*���+��*"��'�� ���� �"��� ���� ���(

)!����$��*���+��*"����������#$�&�"�#$�#����!"�����"

'"����� �"��� ���� ���(

*���'�"'�"�+�����������������(!��������$����7�����&9�!���%�������(��?����(���@&��%�!�������,�'��)��������������������,!��,��������(6���������%�������4�(8���������!)������4���4!����!�����,��������(�4�������'�����������!������������!(!����&������%����������'�����(:����������"�����'�����!�����&

�����!�����(!������#����-!���(���(6���ABC������!(!���4�!������)�����!�������)�8������� ��������������&

������"�����'���������(������'�������������+�����'�"�������%���,�'��)����4!��������4���������)4�����,:���%�%����'��%�"�+����'�������������������������������,��&

Page 6: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 6

2.3 Installation principle The Root Zone Irrigation Mat is installed in the soil underneath the roots. This is the basic

difference to conventional systems that have been used for years for irrigation above the ground using sprinklers.

This picture shows the installation of the Root Zone Irrigation Mat on a vegetation ground with gravel. Later on the pipe in

the middle will be fold down.

2.4 Efficiency The ECO Rain® Root Zone Irrigation Mat was invented with the aim to provide a water-

saving irrigation system on a basis of textile to the global market. There are in fact a variety of well operating irrigation systems on the market; however

these systems differ in their efficiency to lead the water to the vegetation. A lot of these ir-rigation systems have an efficiency of under 30%. Especially in arid and semiarid climate zones, where agriculture and landscaping depend on artificial irrigation, you can find a va-riety of outworn, defective and inefficient systems.

�;+,�5�"7� �& 76 ����,�&�� . /��& �� �

'8 �� ��� . /��& �� �

��������������� �����������������������������

,��� � ���������������#-&#��+�! ����� ����.�/���*&�����������+�'#�����������$�&�����0�����&����"0$��"/

�� #��&��&��*�# �+(1

������ ��������������!���!����%�����$���)���!���D�����������!(!���& �����%����'�"%+��'��������������)��!(!���4�:�����%!��'������(��������������!�����!����&

5��!����'���������!(!���(!��!�������)�:,"��"�(�������������!�"�":�����%!-)����!����+=EBC&*����!�"������"�������%�������������'����(���(:�����������%,�'������&

���������������� ��������������,(�(������(�����(!������,�������������$������!�"���"������������!�(!���������������-!���'�����������(&

Page 7: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 7

With water savings of up to 70 % compared to conventional irrigation systems (60% in semiarid climate zones are already empirical proven; complete documentation can be provided upon request), the ECO Rain® Root Zone Irrigation Mat is able to fight the most pressing environmental and developmental issues, which is water shortage.

2.5 Research and development

Extensive research and developmental programs prove the continuous further development of the ECO Rain® Root Zone Irrigation Mat. In the year 2007 the ECO Rain® Root Zone Irri-gation Mat obtained the Innovation Prize for new products at the „techtextil“ exhibition in Frankfurt/Main.

�;4��9�<�,�5+=����!

�<4+!9��<� 2

��������������� �����������������������������

@BBF

�����

G&�����@BBF

@&�����@BBF

E&�����@BBF

?&�����@BBF

H&�����@BBF

I&�����@BBF

A&�����@BBF

F&�����@BBF

J&�����@BBF

GB&�����@BBF

GG&�����@BBF

G@&�����@BBF

GE&�����@BBF

G?&�����@BBF

K�! 2�)�! �������

G@�

K��������"����E

9�+L

�,��)��

�,��)��

�,��)��

/����)��

/����)��

/����)��

/����)��

/����)��

����� ��!�������)�

/�����,����(��ED�����

9�,�'������������������

����� �������!�������)� ��!�������)� ��!�������)� ��!�������)������ �����

�!�������(������!&

��!�������)�C

/�����!����

/�����,����(�����������@����

M�������;NO3N0 N��!�#����:P��������DQ���"�!��

2���!;2�����GA:H�7A:H�RHI:@H�@ ����������'���6�����82�����@A:H�7A:H�RHI:@H�@��!������!�������)�6��!�������)�8

*���������!����� ����(���,���-)����!� ����������������������!�����������'���������(IBC�%����������(���"������)��������������!������������"!�����,(���(&

*���% ����������������������!���������)�%�:�����@BBA����,��'!�������'���������S����#�������1������

Page 8: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 8

2.6 Experiences and References The ECO Rain® Root Zone Irrigation Mat has already shown its economic efficiency in nu-

merous successful projects worldwide, in different climatic zones (moderate, semiarid and arid) and in different areas (gardens, public green areas, roof greening, golf courses,…).

Diverse test projects have proven the outstanding characteristics of the Root Zone Irrigation Mat.

The company ECO Rain® International, the manufacturer and mer-chandiser of the Root Zone Irrigation Mat, has an excellent knowledge in the field of irrigation with more than 20 years of experience. They are member of the International Irrigation Association, the worldwide leading professional association in the field of Irrigation.

A list of references is available upon request.

�+!$�� �� ���0����&�

��������������� �����������������������������

������ ��������������%�������'��(!����������������!����"�����������%���������+����������������,��!�����������!�"�"6����:�����:!��������8�����"���4'�������������'�4!�,��(����6'�����(:����%�������(:!���+�'�����(��'����"��!�����(:!������������(�$��#������+�"&&&&8&*��+���������������������������� �����������'��(�(!����-)����!���(����%�����������!���(����,��&

/����)��!� ������3������������:����,�����!���,�������������������!�'�����������!(!���(��������,�'��+���!��& �)�����1�'�������'���������!������3���$�����N!!��������:�����%�������!�"������!�����!�����%�'�����������#�!�����(&

/�'���������������#�����%����!��'������������&

Page 9: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 9

3 AREAS OF USE

The ECO Rain® Root Zone Irrigation Mat is especially suit-able for use in the following areas:

� Grass verges and sowings � Bushes and smaller plants � Shrubs � Small wood plants Bigger wood plants, palms ... have a higher demand of water, which

cannot be covered by the Root Zone Irrigation Mat. For such plants it is necessary to install a separate irrigation system with conventional irrigation; this can be integrated in the already existing irrigation system and can be controlled with the same controller.

Main areas of use of the Root Zone Irrigation Mat:

� Gardens � easy irrigation of difficult areas � Public parks and areas � Roof Greening � Sport grounds, especially golf courses � Grass verges alongside roads and tram

tracks � Extreme slopes and vertical greening � Agriculture (plants with special demands)

The areas of use of the ECO Rain Root Zone Ir-rigation Mat are versatile and have not yet been fully exploited.

�>��?��#�����

��������������� �����������������������������

������ ��������������������%!��������'�%�������!����%�����������;

5��%���������'����"���������/������,������������(*�+�����(�(��!���,:����:������(1��+������(�����!����(

*"�+������(�!����(&&&���%�!�����,(���(����'�"�(++:���������'�����������������&9�����)�%�������������������(��!�������!���!������!�������'����������"����=��!�����,����(����)�"%+����!����&/���'��%�"�'�����!�������������!���!�����!������!��%���������%�������&

.�����,��!���(����'��������������� ��������������;

������(�������"!��������������������(*���%�������(�'����"��!�����(/���+�'�����(/������������(�����������!(�����'����"���������:������%�����!(/���(!�7������!������*����������������������(

1����!���(���������%!�������������'�����+�!�������!����!��,%���%�����,��!���(����&

Page 10: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 10

4 ADVANTAGES

� Due to the basic textile structure of the Mat

� increased water storage capacity of the soil � up to 70% water saving compared to con-

ventional irrigation systems � Reduction of soil erosion

� improved greening of sparsely vegetated areas

� good root penetration, avoiding stagnant moisture and reduced infestation by pests through dry topsoil

� Improved plant growth due to � almost 100% even water distribution over

the whole area to be irrigated � water supply directly at the roots � possible supplementation with fertilizer � Due to the underground installation � no loss of water through evaporation � no exposure to wind through underground

installation � Improved application

� Irrigation is possible at any time / Area can be utilized during the irrigation period

� Increased water saving through the possibil-ity to irrigate at night

� Reduced risk of vandalism / reduced risk of damage during maintenance work

� No unpleasant smell if treated water is used � No danger through water on the street

����(@

��������������� �����������������������������

����'��'��+�������������(�4�(-!���(���(���IBC���+���������������������������������!�!(!���(!��!�������)�����'�����'�����'��������"%+����%��!�����������'����"��������������,��������%����������!(!������!����:���+��!�(������,�+�4��4��(!���������������$���)���!��(

���"�GBBC������"�����!���,�����'�������������+�������������������'<�(�����!���������������������%����!(!����

,�'�'�������(�������,�'�����>�����"������(��������������!������

�'�'�������������!���"��(�����D�����(%�������(���������4,"��'�����������)�'��������������%�+�"����'�"%+�-!��������(����'�����'�����,�'��)��+��'��!(!�����������!���)���������(-���,(,�''������������������������(������������!����4����!�������)4!�"���������������

�6!/ �"1� ��A� , "�� . / � �� ��

���, ��-2$"�<� 2� ��, �5"+6

# 57 ��&. �; ����,�&�� . /�

�67 &+:�<. 56+ �&�7�!� �� ��

Page 11: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 11

� Simplified and quick installation

� Opening up of new markets for � Grass verges alongside roads and tram

tracks � Slope irrigation � Irrigation for green roofs in hot climatic

zones � Further Advantages of the ECO Rain® Root Zone

Irrigation Mat � Erosion control on slopes � Stimulation of vertical growth of the root system � Low installation height on roofs � No fixation difficulties on roofs � Infiltration when heavy rainfalls

� Reduction of fungal decay

��������������� �����������������������������

*�5� 5!&.;��6&.,; ����,�&�

� �:+ �&�78�"B�$��"7� �=4�:�7, +�&�

(�,$"�<. 56� . /"����� �� �� ��

�����������!(���������������������%�������������������!������!���4�����������'����"����!������!���+���'�����

���'�����'���!��'��/�����������������������%�����������!(!���4*�����'�����!����)���+����!��������/�������!��������!�����������+���!������!������!�����'�����,����������,

Page 12: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 12

5 TECHNICAL SPECIFICATION 5.1 Installation depth The ECO Rain® Root Zone Irrigation Mat has been tested successfully in depths of up to 40

cm.

Installation depth 30 cm or more: Lawn (from seed) Turf Shrubs Small woods plants

Installation depth 15 - 30 cm:

Lawn (from seed) Turf

Shrubs

Installation depth 10 - 15 cm:

Lawn (from seed) Turf

The irrigation expert should consult with a landscape gardener or architect to determine the optimal installation depth prior to commencement of work.

The final decision of the level of installation of the Irrigation Mat should be dependent on the following

� location/position of the area � Type of soil � Type of plants � Specification of machines/appliances used for the maintenance of the vegetation (lawn

mower, riding mower, lawn thatcher, aerating tool, etc.) Deeper installation depths may be dependent on the appliances being used in order to avoid damage during maintenance work. Greater installation depths of the Irrigation Mat may require manual watering to be carried out above ground during the first few weeks to ensure healthy development of the plants. (see irrigation times, point 10).

��������%?#���C������'(�*�

�, !D+�!, /��"� . /�

��������������� �����������������������������

��������������� ��������������,(�(-!�"+�"��!�����(������,����������?B�����'�������!������#�����������&

.���,����!������EB������;

.���,����!������GH=EB��;

.���,����!������GB=GH��;

/���������(5�,������������(5���1���������(

/���������(5�,������������(5���

/���������(5�,������������(

2�����������������4��'�"������)�%������'�����������,��������!'������������������:!���������������'�)�#���������+��'�������!�������!�,%���(&

5���)����'������������"����,�(������������'���!'�%��������!����%���#��������;

M�������D��������������(�(��4�(�(�������������!����/����#�������������$�D�������!�4:�����,�����������(���-���,�=�����������+��'����������!�&���������������,

2���"�+����,��������������%�����������������'������������)������!����'���������'�������&0����!�'�����(��!������'���!����"���!������������������"���������$���)���!��(6���+��#��!����9�,('���������=,��GB8&

Page 13: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 13

Different installation depths will not reduce the capillary water rising. The speed of which the water rises from the deeper soil layers might be reduced depending on the soil. Due to the good capillary action in sandy soils, a quick rising of the water was observed already af-ter a few minutes. This process was slowed down in soils rich in humus, through the high water storage capacity.

Water distribution approx. 5 minutes after activation Water distribution approx. 30 minutes after activation Testfield Abu Dhabi, United Arab Emirates Testfield Abu Dhabi, United Arab Emirates

5.2 Fill in soil

A slightly sandy soil is recommended for filling in on top of the Irrigation Mat. In any case special attention has to be paid to the fact that the soil does not contain any large or sharp edged stones or rubble as this may cause damage to the Mat drip pipes as any activities above ground, such as the laying of turf, etc., will cause compression of the filling in material.

�&.����;������

��������������� �����������������������������

�4'������,����������!����%����������'�����!����(&0�����"!����������(�'����(�4��,��������,+�������������������"���(����!������������'�������(&*�!�)�����4����%���'��������(�����'�������(%�����"��������������&0�������!�����������������%���������4�%������!�'��������'�"������%+!����������(!�����������������4��������'����&

�������� ���&+� ��#�23�"���� ��#��#�.�/��0�� ��+14����� ��# ��������������5��& �*�������*��"����+

�������� ���&+� ��#�6�"���� ��#��#�.�/��0�� ��+14����� ��# ��������������5��& �*�������*��"����+

������������4���4!�������)�%������������������'���!�����������!���%����'����D�!)���'����(&*�����������"!��(����%����������!(������'����:������,!���%�!��������������()������"�(�����,(����(�������"��'�����'�4!�,����+��'�����������������,�������&*�+����)����!��:������������#����������������,���6������������������,���4:!�)��:�4'��'�4!�,(�������������������&8'�4!�,�%!���)������$���)���!��(���������������&�!���������)�!����,(�������('�4!�,����+��'���������������,��&

Page 14: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 14

5.3 Load The following load test was carried out with an 8 ton heavy vehicle. The Root Zone Irriga-

tion Mat was installed in a depth of approx. 10 cm in ground soil. The heavy vehicle drove several times across the test field. No damage could be found on the Mat or on the drippers.

����7 ��&. �:. 4��"/��"

��������������� �����������������������������

P(�����������!�������!����������������������,����%�'����������!���������!��F&BBB�$&�������������,(����!�����������GB�������������&*�'������%��"������)��!��������������&0�������������������������,����,(����'��������������+��'��&

Page 15: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 15

5.4 Technical Data � Outside diameter drip pipe: 16 mm � Quantity of water per dripper: 2.2 l/h, pressure compensated � Distance between drippers in the pipe: 33 cm � Outside diameter of enveloped pipe: 35 cm � Fleece 2-layers à 250 g/m² � Measurement of installed Mat: 0.80 m x 75 m (= 60 m²) � Dry weight of Irrigation Mat / m²: ca. 1000g � Wet weight of Irrigation Mat (saturated) / m²: ca. 5000g � Maximum water saving capacity / m² 4.0 l/m² � Maximum quantity of water per m² and hour: approx. 18 l � Maximum length (depends on pressure rate): up to 140m � Work pressure (in let pipe): 1-4 bar � Weight per roll 50 kg � Measurement per roll 1.20 m outside diameter 0.40 m inside diameter 0.42 m width � Maximum quantity of rolls per 20' container approx. 56 rolls � Maximum quantity of rolls per 40' HC container approx. 124 rolls � Maximum quantity of rolls per truck approx. 170 rolls

��&.� &+;5���

��������������� �����������������������������

*�"%+��4�"����������������,;GI��*�����������!�����(��G�������);@:@�D�:������'��������/����������)4������,;EE��/���������������,���������;EH��T����7�����;@��!��(�@HB$D�@��'�"�(��'������������;B:FB�7AH�6RIB�@8.�����!�/U�.V������D�@;���GBBB$.�����!�*M.5V������6��!(���������8D�@;���HBBB$1�7�������������������������D�@;?:B�D�@1�7���������!�����(���@'�������;���GF����41�7����������!��%�������!46�'���!��!�����!����������8;��G?B�2����������6�!���������,8;G=?,���.�����!�����;HB�$��'�"�(����;G:@B���"%+��4�"�B:?B���������4�"�B:?@�+�������

1�7���������!������@BW�����%�������HI���1�7���������!������?BW�����%�������G@?���1�7���������!����������������GAB���

Page 16: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 16

6 INSTALLATION COMPONENTS

The ECO Rain® Root Zone Irrigation Mat is a member of the family of micro-irrigation prod-ucts. This means that the use of a filter and pressure regulating device is necessary even where clean drinking water is used for irrigation. In this way obstructions of or damage to the integrated dripper in the drip pipe are prevented.

� Controller The controller is the „brain“ of every irrigation system. This is

where the start- and irrigation times, which open and close the electronic valves, are programmed.

� Rain sensor (if necessary) The rain sensor helps to create a good working flow between nat-

ural weather and irrigation system. If the area to be irrigated is saturated enough through natural rainfall, the rain sensor stops the programmed irrigation with the controller. As soon as the soil is dry again and water is needed, the rain sensor activates the programmed irrigation in the controller.

Rain sensors will only be installed in moderate climate zones. � Electromagnetic Valve The valves open and enable that the water from the main pipe

flows into the irrigation circuit behind the respective electromag-netic valves. This circuit will be closed again, as soon as the pro-grammed irrigation time is expired. This operation is controlled by an impulse of the controller.

� Pressure reducing valve

Irrigation systems with the ECO Rain® Root Zone Irrigation Mat work in a low pressure range. Therefore a pressure reducing valve is neces-sary, to adjust the present water pressure down to the needed water pressure. (1-4 bar).

� Filter Using a filter is necessary, even if the irrigation system is supplied

by the public water circuit. This way it is ensured that no pollutants get into the drippers integrated in the drip pipes. This would cause clogging of the very fine labyrinth seal. When using other sources of water, especially wells, special attention needs to be paid that the water is clean.

?��E�?��?@?�%��?������& �� �

��������������� �����������������������������

��������������� ��������������������!�����(����,�4��������'�����(&��������4����%���������!�'��+����4��'��������������'��������6�����)�������8���)�!�������(6�������#�������G@B��!�8���*Q �.0X����������(������'���%��)���"����%������������&2����������������������������'�$���������!����������������,��#�����!(!����&

��,;5�&"2�5� �+��6��:9!

E 5,���;/�+�7=5�"�,.+ ��

�,�+�� 9�1��� &+:���� ,6

��5!+8�"���� ,

C ,���&�

�������%�������%�Y��'���Y�������'�����������!(!����&2����%������(!���!����%�����������������'������'�����������!(!����& �������!���%����������������������(�������������(:!��������)�!(����������������,�&M'������%������(%��!��!�����@?*N�:����,��������!��!�����J*9�6!�������������(!J*9�!�������(8

K����!����������>�%�)����!��������%������(��'�����"���)����"!�#�!��������������������������'�����!�����&5�����)�")������'�!����%)����!��������%������(������"��!����)���������'�����!�����:���(!�����)����%������������������������%������(��"��,�����&*�����)�������'����%��!��!���,������'�������������������:���!��'���%���������)����:�����!���+�������������������!���!���&

��������$�������������(������%D�'����%��������('������������������'������!��)��������,&2����'�������������������4��)�%���!������������%������(&M'������%��@?N�������(�J*9�������(6!����!,����������%���������8���:���������!��'���@EB*&

���������!(!���!�������������������������%�!��������"�'��������'��������&9��!����#�����������������������������,�!��%�����������)��������'����!(!������������(++����?,��(&3�!����%����������$��������������������!�������:�,(!������'��������(,�������'��'G=?,��(&*�����!�:�(����������������)����������6��$������������8,(�"�'���'�"!����#������'�����������%������&*�����"�����,(��������%�������%��������63�� �8:����������������)����������*�+���������������)&

2����������,��!�������#�����!(!����%��������!��������������'��������#����!#�����)���!�����G@B��!�6G@H������48=������%�%��!����:�����!����#������������������)�����������)�!���8&S���������%��*Z9X�������"����%��������%�������������:���'���%�%���%�����&!�����:�����:�����:����%�#���������!�������&

Page 17: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 17

� Valve box The valve box is the „Heart“ of the irrigation system. This is where

electromagnetic valves mount to a distributor, as well as filter and pressure reducing valve.

� ECO Rain® Root Zone Irrigation Mat The Root Zone Irrigation Mat is supplied in rolls of 0.80 x

75 m. Installation is carried out with the green side on the top.

� Air relief valve Recommended to prevent pull- and pressure effects in the pipe system,

as well as the pollution of the pipes and drippers. To be installed on the highest position of the irrigation system in a valve box.

� other components � Clamp saddle for sub-distribution of the water supply from the inlet

pipe (e.g. 32 mm PE pipe) to the drip pipes of the Irrigation Mat (16 mm diameter)

� 16 mm coupling for the connection of several Irrigation Mats � 16 mm elbow piece for the connection of the outlet pipe of

Irrigation Mats in corner regions

� 16 mm offtake valve as closure of the outlet pipe to flush and controll the system (in small valve boxes)

��������������� �����������������������������

���� , �;$�&.��

�;�,�. �;� . /����� �� �� ��

�5�45!$F ��&"G7B �45!$F ��&"���� ,6

3335�,$"� !8;�� �6��:9!

*��������+�����'�%�+L�%���,����!�������������$��������������4����%�%�����!��������'�"%+!����!&*�����(��!����%�����(��������+����(:��,�������%�+�����&

����� ��������������!�������������B:FB�7AH�����(&������IB�@&3�!����%�!����(� M 0�U$����7����������[

9�����)�%�!���!��������(��������(!��������������������!�������#����:������'�������!���+�"���(����!����&������#����4�����!�������������)�!����������4�������)4��!����%�%����������!��&3�!����%������%�'�����"%+:��!�&��%�(++�!��!(!���������������+�������&

0����������!(������%���������'��������,�(����!�������������������,GI��&0�����%������������������!4������������+���������'���!��'�(���!������!����)�#���(

GI��!��%�(�������%�����������������,

GI���������������%�����������������,�GI�������,,�'�������)4

GI��6GD@Y8�������������������(����������������������������,=��!����%�!��������������+����(

Page 18: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 18

��������������� �����������������������������

���������� ���������

����������������������

���� ���������� ��

!�� ���"������ ����"������#

$���� �������� ������%&������'&�()

*��������������+�

��,�������� ����������%-����

.�� ���/��0���

�����������

�����������

1��������������������

2�� ���������

� ���3��������� ����0���+�4��,������������������5

.�� ���/��0��

� ���3��������� ����0���+�4��,������������������5

*���6�$)7�*����*����8����

&/��9�������������0���� �������9����/

7���9:�������������

Page 19: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 19

7 TOOLS For an easy and exact installation of an irrigation system with the Root Zone Irrigation Mat,

every installer should be equipped with a complete selection of tools. The following tools are needed: � Cordless screwdriver or ratchet � with socket for ratchet 10” for clamp saddle A05-3216 � with socket for ratchet 7“ for hose clamp e.g. C17-SL12 � Pliers

� if using the time saving hose clamps instead of the conventional hose clamps, which need to be tightened with pliers

� PE-Hose scissors, to cut � 32” PE-pipe hard � 16 mm PE-pipe soft

� drip pipe in the Root Zone Irrigation

� Gas burner � to head up the pipes and for adoption of the molded parts

� Inch rule or measuring tape

� Cutter for textiles � e.g. Bosch Xeo Akku-Universal cutter � for cutting large areas of the Root Zone

Irrigation Mat � Professional carpet cutter � for cutting of smaller mat pieces

��)�(���?���*�

��������������� �����������������������������

#� 0�� �;,�"B�4�8+�+ D��&=

� ��8�"B�4�8+��+�� �

�-B"&"7;�9

� �+ �45!$�;7 �� ,�

#� 0�� �;,�"B�4�8+�G�=/+6#�7 ��!D"

�,�$�-

#� 0�� �;,�"�+!9!,;� � �<$� !D �;+

2��!������:�(������!�����������������������!(!���4!����� ��������������%����,�,���(,������������������&2�������"�������!����#��������!���%4%�����������&

9�����)�%���������������!���%�;

������������������������!4�������������������!���������������������,6���#���%������!�����,%��(�����8

�������������'%������'�����!��������,����!������!����������

����'������6.98�����,����"�)���2 �����,����������������,���������������

������������������!���������������46������������,������������('���'���8

����P�/�.\ �N����'��4%)���3�� ��=�����'���"�+�������������

���%�����+��)�!�������

Page 20: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 20

8 INSTALLATION STEPS 8.1 Assambler Irrigation systems with the Root Zone Irrigation Mat are installed ideally of at least two

Assamblers. If they should have no experience with installing a Root Zone Irrigation Mat, it is highly recommended to contact an experienced assambler from the ECO Rain® headquarters. Because the installation is fundamentally different compared to conventional irrigation systems.

8.2 Preparation of the area to be irrigated � Excavating the area, considering the instal-

lation depth � Removing any sharp edged stones or ob-

jects and create an even ground � Final decision of controller and valve box

location 8.3 Installation of the inlet pipe � Excavation of the trench for the inlet pipe � Installing the inlet pipe; regular as 32“ PE-

pipe; varying depending on the size of the area to be irrigated

*�(������%����@��?������?@?�%��?������& �� �

� ��;/�"7��& ��"&

#B"7����7 5+,�5!4��,�/ ���:7, &.6

�����,�&�7B"� 5�". 7 ��!D"H.,���"B�5I

��������������� �����������������������������

����������!(!���!����� ��������������!�������"��!����%�����������������=��!������%�%���������:������"����)���!����#���:�����%�����+�%����!������!����������'�����������!(!���4!��!��������!�������)�&2����,��������'(:��)��"��������%��3�� �&

3

���"������������'����(!�'������"����������������,�(�������*(������������������������:��!����"��+��������4��!������������,%���4:�����,(����(��+������������������,�������

5���)����!�"�+����(!#������:�������������(:���'��+>���������������(���+�"����������

*������������������,3�!�������������������,=!�������%�2 E@��:������"��4�"�������%�'���!����������!��'���������������(

Page 21: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 21

8.4 Installing the Irrigation Mat � Supply of the Mat in rolls of 0.80 x 75 m

Rolling out the Mat Rolling out the Mat

Opening of the mat panels Installation with 20 cm overlapping

� Bigger wood plants, palms, ... that cannot

be irrigated with the ECO Rain® Root Zone Irrigation Mat are spared out

� Important: � Installation with the green side on the

top � Mats laying next to each other should

overlap with approx. 10%, i.e. 8 cm; In doing so the water will be distributed over the whole area to be irrigated

�����,�&�� . /��& �� �

��������������� �����������������������������

/��������,������������������%�+RB:FB�7�����AH�

*���������� ���6��*����8��� *���������� ���6��*����8���

*��������������6��5� ���6��*����8��� ;� ������� ����� ���"������ /����!����<+����#��3� ��� ������ �"� ������������=>��

2���"�+��!����(:������(:����(:�����,������!�������'�������������������)�%�����������(�'���������(

94������;3�!����%�������*Z9X'������$����7����0N.��U �����������!(������,(!��"�(�������������GBC�%&F��&2��%�'�%�+�"��������"�����!���,������(��'�������������+�

Page 22: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 22

Cutting large areas with special cutters Cutting smaller pieces with a professional carpet cutter

� Some projects require different dimensions than the standard width of 80 cm:

Adjusting the overall width with Cutting the standard mat 20 cm wide fleece strips in 2 x 40 cm wide strips � During and after installing the mat panels, please keep off the al-

ready installed mat or rather be very careful when stepping on the mat. Otherwise the pipes in the mat might be damaged.

Small bends in the drip pipes might occur during production or han-

dling and transport. These can be controlled and straightened during the installation. The parts where the bend is to extreme should be fixed (cf. Damage on fleece and pipes, point 12.3)

� Fixing pins may be used to secure the Irrigation Mat on slopes to

prevent sliding of the panels.

��������������� �����������������������������

?� ������� � ���6�� ��������������� @��������9������ ��� ���6���������������� ��

(��������������5�9���/� ���������"���� �/� ���6������������"� ���

@����� ����� ���� ���6����������� /�9� ��5%����+� �����������������

���������3�9A������ ���/

2���"��������%���(%����,�����+����'�"���!��������+��(+RB:FB�

P"�����!�����������!��������!4������!�!��������'�����(,��%����!��������������=��%�����(,��������4:����������!�4&14����%����+��'��������������������������,&

2������,":,���������!������4����%�����%��)���������������������'��)�������������������,&���'��"�+����!���������������������������,�������!������&*�7�����������"%����,�����+���-!�������,�������6!����G@&E8&

2����!���������������7�������!��'��D!�������������)�%��������'�%�+L����!���(:�,(��!(��������!����'����(&

Page 23: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 23

8.5 Connection of the Mat panels

� The connection of the mat panels with the inlet pipes should be carried out according to the following schematic diagram; in practice there will be more options.

� The inlet pipe is generally a hard PE-pipe 32 mm (depending on the size of the irrigation system); other pipes are soft 16 mm PE-pipes

� The enveloped drip pipe has a diameter of 16 mm, therefore 16 mm fittings (coupling,

elbow and tee-pieces, clamp saddle, stop valve,…) are necessary to connect these drip pipes to the inlet pipe.

� Connecting the mat panels to the inlet pipe (generally 32 mm PE-pipe) is carried out

with clamp saddles � After installation of the Irrigation Mat panels, the system engineer fits the

clamps to the inlet pipe according to the intervals of drip pipes inside the Mat.

Inlet pipe, e.g. 32 mm PE pipe

Mini clamp saddles used as connector to drip pipe the Mat

Panel A

Panel B

8cm overlap of panel and panel B

16mm soft PE pipe as run-off pipe

16 mm shut-off valve at the end for flushing and checking

?7 2 �;�"7;�=� . /��& �� �

��������������� �����������������������������

)���<�+��������� ������B�C���D

2���3������� ����������� /������������� /

������������ ����$�����E�=���-�3���������� �3���

8��� ��������+��0������ ���!��������3��*C;2�D;*(�( �������

2�( ��#

�0���!������F�G#���� �������������� ��� ������������������ ��

/��%����%�������������!��4��,���������������&�����������'�4!�,��&/���'��%�":����7�%���������'�4!�,4&

*!����D�����������,,����+��,���"2 E@��6!���'��%�"�'���!��!����������!��!(!����[[8�!���������,����������'����������������%����,���GI7G:B��=�'�&�����,,�'�������)4&5������������,�����������4�"�GI��:�����%����,���������������%����!4�������+�����������(GI��!'�%�+L������!������&U��'��>�%�������������������������������,:���������!���%�20?=�%&��?,��4&

2����%������!4�������������,!�������������������������!4

2���!������D���������!4!�������������%��!������������,�������������������!4=������������������!��������������������,���!���&

����������� ����������� ��������������� ��������������� ������������������������� �������������������� ������ ����������!��������������"�����#�������������� ������������ ����#$$����%���� � ������&�'�� ������������� ����� ��������("$����!����� �������������&���������������!��� ���� �� �� �)**+,&

Page 24: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 24

Connection to the inlet pipe using a clamp saddle

Connection to the inlet pipe using Connection to the inlet pipe using a clamp saddle / single a clamp saddle / double

� On smaller areas, with only short panels of the irriga-tion mat, not every drip pipe needs to be connected to the inlet pipe using a clamp saddle. In this case it is suf-ficient to install two to three clamp saddles and the remaining drip pipes (similar to the principle at the dis-charge pipe using 16mm soft PE-pipe and tee- as well as elbow pieces.)

��������������� �����������������������������

�����3������������������ ����$����������� ����������� � ��� � ��"��������� ��

�����3������������������ ����$��������H$(27I.*C22J�7���� ����������� � ��� � ��"��

������� ��

�����3������������������ ����$��������7D7KI.*C22J�7���� ����������� � ��� � ��"�;�

������� /

��,(�����������������'�,��"=�'�!��%���"�������!4��������('�����������GI�������,��������'���������������%��%��������������=������������!�����������������������,&

Page 25: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 25

� 16 mm discharge valves are installed at the endings,

these are necessary for flushing the drip pipes and to control a regular operation of the irrigation mat. The discharge valves can be installed into small valve box-es due to a better operation and for optical reasons.

Discharge pipe with offtake valve in a valve box

� Attention: Any rough edges left from cutting the panels to measure during the installation process have to be accurately cut with the help of clippers.

� The connection of the Mat drip pipes may be done at a

later stage, if sufficient space is left at both ends of the Irrigation Mat.

��������������� �����������������������������

&/��9�������� ��� ����� �����F�/��9���������������������������������5�9��������!&DL�<#

9�����)�%�����!��������������!����GI������������������6����PS����&��,�����!����������������8&/�����������������!���������������#���)��!��!����&���������������!����%�������������+�����)�(*PABF����&

2���!��������!4������%����,���+���������!��:�����,���!����������%�������'�������������������������4�������,���'����&

2����%��D'�������������4�������'�!���'��%�"�����!����'�"%+#�'���!������6������'��'����(8:�����!����,����������!4���������!����)�����!�����������%��&

Page 26: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 26

8.6 Filling � Filling in on top of the installed Irrigation Mats with substrate can be done with differ-

ent machines:

Truck Wheel loader

Skid loader Excavator

By hand

� To avoid damage to the drip pipes, it is very important that the machines do not drive on already installed areas. The procedure when filling in should be planned prior to the installation, since every construction project is individual.

���;/��"�!+,;5;�"��1���8�"&.������

��������������� �����������������������������

0��������$���)���!��(D������D'����(����!(���������������'�������"���!����%��������'��;

2���������������F�2$&HMN(O.�2C�*7�7N�PP 2��������F�2$&HMN(O.�2C�*7�7N�PP

*/������ ����������F ��������6����F�2$&HMN(O.�2C�*7�7N�PP I��������� /�����F���������F�2$&HMN(O.�2C�*7�7N�PP

Q������

N,(!������+����+��'��������D���������������,D�����%�����������,%�Z3*��0]9^M Z3�V!�������������!������������$���)���!��(D������D'����(����!(������%�+�"�������!����!�����������& �'���'����%��"���%����!����������!(��������������&

Page 27: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 27

8.7 Leakage test

� If water is available on the construction side, the installed areas should be tested on their leak tightness. For this purpose every irrigation circuit will be opened manually with the electromagnetic valve for 20-30 min.

� Provided this is not possible, due to a missing water supply, the test run concerning the

leak tightness will be carried out with already filled in soil. 8.8 Valve box � exact positioning of the valve box � regular installation of the distributor (magnetic valve, filter and pressure reducer) � on bigger sites the valve box is installed as an inspection chamber, to inspect the

moisture penetration of the Mat.

�+ !$+��-�� �� �7� � 4�"4+ !$+6

���� , �:$�&.� &�

��������������� �����������������������������

2����%�!���,"���!��'�������������������������)�%��������!�'���+�(���"!��!�%�+�"��������'��'����(&��������!�����������"����������������6��!���������:���+���,����,����[[8�����@B=EB���:����������,�������!��������������&2�'������7����������'������!(!����������!�(:�������!����!������?,��([

2�����'��'����(������)�%��������!���!�'����=%��������+��'������������'����(

;� �������9������+����� ��������� ��� ���6��+�&D�%�'������&D'��

�'��)�����!�����'���*Q �.�����������+������/��������+����(�,!���%����$������(:��$������(�����:#����&&&&0��"�+��!(!������!�������)�%��!������!���)���������+������������������'���)��������

Page 28: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 28

� Optional, but recommended from the ECO Rain® headquarters is the installation of an air relief valve

� it prevents a low pressure effect in

the pipe system, which could cause pollution of the pipes and drippers.

� avoids high pressure when opening the electromagnetic valves

� to be installed on the highest position of the irrigation system in a valve box

8.9 Controller and Rain sensor � The controller will be installed at the very end, which opens the electromagnetic valves � A rain sensor can be installed, depending on the climatic zone. The irrigation stops as

soon as there is sufficient moisture in the soil due to natural weather conditions. 8.10 Initial Operation

� before the initial operation, all pipes will be flushed with open offtake valves, to remove any residues in the drip pipes

� After that the controller will be programmed (cf. Notes for the irrigation times, point 10)

� Finally the whole system will be explained and handed over to the customer � Handing over of the maintenace manual

��,;5�&"2�5� �+��8 5, ��;/�+

#���"�7!$�-�"�6��:9!�& �� �

��������������� �����������������������������

*���,��������)�%���!���������'��+>������D����'��+>�������������&

���'�%�!���#�������(����!���:������4��(�4!�,������������)�!���������������������)4���'�%����������'(�!(!���������������������������43�!����%������%�(++D��%�'�����"%+�!���!(!���������������+�������*PABF��,�*PJGB

�������%�������!(!����:������������������������(��!����%���'��"���������&���������,��(������)�%�����!������������������������,����&5���#��7����&

/(!����'������������������!��'��46!�����:�����!������&8

2��������!��+�"�����!(!�����)���"���������"�"������������4������%�����������!���=��!�����������)�!���(:�����!��!(!����%�!�",�����(!�(�������������(,(�������)�������,

2��������$����%���������%�������6,��GB=��!�������,('���������8

���������������!(!�����������'���'�����2�������������������'�-���,�

�����9:���������������9������+�&D�%�'������&D'��

Page 29: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 29

9 ADVICE FOR PLANNING � The Mat panels will be rolled out in direction of the maximum length, to avoid waste

and unnecessary cutting, hence to install the Mat in an efficient way.

� Sidewise overlap of the Mat panels with 10%, as 8 cm

� depending on the modeling of the

area, the maximum length of 130m - 150m per drip pipe must not be exceeded as the pipe fric-tion loss inside the drip pipe will not give sufficient water supply at the ends of the panels.

� Furthermore in larger projects the

exact water pressure (in bar) as well as the accessible water quantity (in m³/h) has to be known in order to figure out the correct ratio of the amount of Irrigation Mats to be fed and the magnetic valves and dimensions of the inlet pipes (feeder pipes) to supply them with water.

On the side you will see a draft showing

a plan for the installation of an Irriga-tion Mat. For easier understanding two panels parallel to each other are shown in different colors.

8 cm Overlap of mat panels

Valve box with solenoid valve, filter and pressure regulator 16 mm enveloped drip pipe between two Irriga-tion Mat panels 16 mm soft PE pipe as connecting pipe with 16 mm shut-off valve for flushing and function check

32 mm PE inlet pipe

�����?@?�%��J��(@�(�#���E��

��������������� �����������������������������

2�!(���������_����!�"����7���������(:���'��������!����&3�!������%��������%�#������"%+

P�)����!����!4����,��������)�%����GBC6F��8

*'���!��!���������'���������������(:��7����������+�7+ ��&"��!D+6H��7;�=I,(���"�����!������GEB=GHB�!����������������'����(���������������������,&2��������)����������(��,���������������!�����������������������������,��!����)��&

U�"�+�����%���4!�������)�%�����)�(����"��������'����,��������:�������������4�������������'���������!(!����&*(��)�"��������!���4�������%���������!����&

*���������'����!��������������!��������������������&2���"�+���������!�%!�����(�������������!(������'��)��(����+���,�����

�$�=���������������� ���

&���������9������+� �����R���������-�4��� ����� �R���� ���

����

�0���������������� ����� �������5��� ���6��$)7�

*����*����8���

<������ ����� B� ���6�

� ���3����!��� ������#�����B��� B��0������ ����!( �������

�����������B#-����������� ���3���������9:��������������� �����F� �����������������������

9�����

Page 30: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 30

10 IRRIGATION TIMES

� The following values are based only on the water demand of the particular plants, without considering the climatic situation, soil conditions, …

� The moment and especially the actual irrigation duration depend on differnt factors;

type of plants, climatic zone, season and the condition of the soil

� Especially in the first weeks after the installation of the irrigation system, the system should be inspected regulary, to check the irrigation results visually and to adjust the irrigation times if needed.

Irrigation times for Irrigation Systems with ECO Rain® Root Zone Irrigation Mat The following values are based only on the water demand of the particular plants, without considering the climatic situation, soil conditions. Should the Irrigation system be programmed based on these values, it is important to check the irrigation result visually.

Type of vegetation climate 1st – 2nd month after Installation *

From 3rd month after installation *

Turf humid

17-30 min/day (5-9 l/day)

7-17 min/day (2-5 l/day)

arid 24-30 min/day (7-9 l/day)

10-30 min/day (3-9l/day)

Lawn (from seed) humid

17-40 min/day (5-12 l/day)

7-17 min/day (2-5 l/day)

arid 24-40 min/day (7-12 l/day)

10-30 min/day (3-9 l/day)

Shrubs humid

17-40 min/day (5-12 l/day)

7-30 min/day (2-9 l/day)

arid 24-40 min/day (7-12 l/day)

10-30 min/day (3-9 l/day)

Small woody plants humid

17-40 min/day (5-12 l/day)

7-30 min/day (2-9 l/day)

arid 24-40 min/day (7-12 l/day)

10-30 min/day (3-9 l/day)

*The times relate to the irrigation months of April till October, but as mentioned above they vary, depending on the type of plants, soil conditions, the climatic zone and the weather conditions.

*��(���������������J�������& �� �

��������������� �����������������������������

0���������'�������������)�-��%�%!��'������(���'����,���������,"������������!����,�'�����������������#�����4:�4�����������:&&&&&

*�����#��������:��)��!����4�'�%������,�'�����('���!������!��#�����4:�(����!����:����������'<�":��)���,��,:�4�������������:!��������������������+��&&

��%����������������������!������%������)����!�!(!�������������"�����������:��'����"����������������!��������"�����,(���������,�'����������������%��'�4!�,��

-�����.����� �.�����!�������������!� ��!����������+,/�0���0�� �1�

*!����� ��!���� 2���������� #�(������������ �����

3������������ ������ �����

0���������'�������������)�-��%�%!��'������(���'����,���������,"������������!����,�'�����������������#�����4:�4�����������:&&&&&��%����������������������!������%������)����!�!(!�������������"�����������:��'����"����������������!��������"�����,(���������,�'����������������%��'�4!�,��

. ������+����� ��

. ������+� ��"

1���

Q��5� � ��/���������/

�����F������

���F� ����

�����F������

�����F������

�����F������

���F� ����

���F� ����

���F� ����

U������'�������������)�-��%���������,��,��,������!�����:���%��%��,(����������"�������%!��'������(���'����,���������,"������������!����,�'�����������������#�����4:�4���������������+������4&

�L+=�����F���!>+'��F���#

L+�L����F���!�+>��F���#

�%+=�����F���!L+'��F���#�L+%�����F���!>+����F���#�%+%�����F���!L+����F���#�L+%�����F���!>+����F���#�%+%�����F���!L+����F���#�L+%�����F���!>+����F���#�%+%�����F���!L+����F���#

L+�L����F���!�+>��F���#��+=�����F���!=+'��F���#L+�L����F���!�+>��F���#��+=�����F���!=+'��F���#L+=�����F���!�+'��F���#��+=�����F���!=+'��F���#L+=�����F���!�+'��F���#��+=�����F���!=+'��F���#

Page 31: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 31

� It is recommended to schedule several shorter irrigation phases per day, instead of one

long phase, since the Mat itself has a water storage capacity of 4 liters per hour it can not store excessive water.

� In the inicial growing phase it is necessary to manually irrigate from the top areas with

lawn (from seed) and if needed other vegatation areas as well, until the roots have developed enough.

� This might be necessary, if the soil layer on top of the mat is relatively high � or if the system is installed during a very hot period � after a few months, when the plants have grown in properly, the irrigation times

can be reduced step by step. 11 WATER QUALITY In the drippers of the drip pipes are fine labyrinths, of which the water is released. To avoid

clogging on these labyrinths, it is recommended to use a high water quality according to the following survey:

Chemical water quality for the clogging potential of micro irrigation

Description Clogging danger with the following concentration

low moderate high

Particulate matter* < 50 50 - 100 > 100

PH-value* < 7,0 7,0 - 7,5 > 7,5

solute salts* < 500 500 – 2.000 > 2.000

Ferrous* < 0,1 0,1 - 1,5 > 1,5

Manganese* < 0,1 0,1 - 1,5 > 1,5

Calcium* < 40 40 - 80 > 80

Carbonate density* < 150 150 - 300 > 300

Hydrosulfide* < 0,2 0,2 - 2,0 > 2,0

Bacteria (quantity/ml) < 10.000 10.000 – 50.000 > 50.000

*Concentration in mg per liter (mg/l) or parts per million (ppm) Several companies offer a water analysis or it could also be requested from the ECO Rain®

headquarters. Should the irrigation system be connected to the public drinking water, it can basically be assumed the values mentioned above. But to be sure, these values can be re-quested at the local water supply company.

���������(@

��������������� �����������������������������

94��'�"������)�%������!����������)�!4!����+��,��'�����(���4,"������!��%���������+���(���&*�����������������%�?����(D�@:��������(���������%����������������������&

*-����#�'���)����(�������������������������!(!����!�������)�%�'�������������"��������"!�����6'�%�������!���������(8'�%���������;

*�$���)���!���%���������"�(!���3�!���������������������"�������!������,��,2��"�������"!�����'���%������������!(!����:�'���,('�����������!����"'��������&

5������������,��%�������)�!��������"%������������������,(����(&N,(!������+����������"������,(����4%����,��,('������������!��>�������!����%���������(;

*�+����������',��(��!�(��%���������#����:������"�����%��������������,(�"�(,���(��-��%����������(!���"�(&9�����(,(�"����!�(������!���������!��!����)��!�&

����� ������� �������� ��� ������������� �������������

0'�� /����� *(!���

2����)�!����`8

.�������.`8

��'��+�"��!���`8

Z���'�`8

.��)�`8

*����`8

U���)����(`8

.(���!��#��(`8

P�������6����!��D��8

`85������������$������6�$D�8��,�������������

,������������ �����!��������������.�����������% �� ������������

Page 32: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 32

� Clogging of the outlet dripper

� to avoid organic and inorganic pollution in the irrigation water, which might lead to a clogging of the outlet dripper, the manufacturer of the drip pipes recommends

AntiBlocTM

� The application is however preventive; for the acute clogging of the drip pipe, see “Clogging on outlet drippers”, point 12.4

- AntiBlocTM by the company „YARA GmbH & Co.KG“ is applied especially against clogging in line systems, like for example drip pipes

- AntiBlocTM consists of a solution of different, special activated and condensed Phosphates

- AntiBlocTM is mainly applied preventive, to avoid or reduce pollution through mineral deposit (Calcium and iron phosphate)

� AntiBlocTM is ideally added using a fertilizer spreader

12 MAINTENANCE AND REPAIRS 12.1 Maintenance

� Right after the installation of the Irrigation System it is important to watch the irriga-tion result/plant growth and thereby optimize the irrigation times

� At least once a year, the system should be flushed with open offtake valves; or more often if needed

'(��>���#���@?@?�%��?���������� �

'5�/D�

��������������� �����������������������������

U�����������4�������)4

2�����'����$�������������$��������'��)�+�"�'�����������(:������4����!��������������4�������)4:����,��������)�%��������������N���P���&

N���������������%�����������:�����+�����,����!%�����������������)�����'�%�����,��G@&?Y���������������������)�Y

2�������YN���P���Y#���(XN�NT�,.���&5T%���������������"����'���������������������,���!(!���4:%��������������������������,N���P���!�!�����'��'�����4'����!���������#�!#��4

N���P���!�����������������"��4!�,���������������������������6!���)����(�����������'�8

N���P���!�������������%��������)���������������%���%�9�!���������&

3��������!�������!��+�"�'�����������!(!����!����� ������%�������4������!������������'!(!����D�4!������%��!�����!��)�!�"���������#�����������,�'���������&0�%���"%�������)�"������)�%���!(!������������������������������D�(���+�"����������4��%�����������!�����&*�����"�����,(������"%��������������)�!�"%�&

Page 33: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 33

12.2 Winter proofing � Depending on the climatic zone, frozen water can permanently damage the irrigation

system. To prevent this, the Irrigation Systems in this climatic zones will be emptied of the water prior to the first frost via compressed air. The right time for this winter proof-ing is, if it is foreseen that the temperatures will be permanently below zero.

� Procedure: � In every separate irrigation circuit the water will be blown off � At first the offtake valve (mostly in the ECO1-Box) of the particular circuit will be

opened � Than the according magnetic valve will be opened manually � Afterwards air is blown with an air compressor with a maximum of 4 bar over the

angle valve into the irrigation circuit; this can take 5 – 15 minutes and is finished as soon as there is no more water coming out of the offtake valve

� Offtake valve and electromagnetic valve can now be closed again � This procedure needs to be repeated for every magnetic valve /every irrigation

circuit 12.3 Damage to fleece and pipes Damaging on the ECO Rain® Root Zone Irrigation Mat is rare. Should they still occur, they

are easy and fast to repair: � Should the fleece be damaged, a new piece

of fleece can simply be put on the dam-aged area; only keep in mind the overlap of approx. 8 cm, to ensure a good water dis-tribution

� Damages to the pipe (cuts, bends, ...) will be removed using a repair coupling; there-fore the pipe will be cut at the according area and then assembled with a coupling

12.4 Clogging of the outlet drippers Should the outlet drippers in the drip pipe be clogged, they can simply be replaced: � The pipe should be cut on both sides with a distance to the outlet of approx. 10 cm � Afterwards an intact outlet dripper with the same linear dimensions will be assembled

using couplings.

��4 9 �;�"�6��:9!J7B"7������4 9!

��������������� �����������������������������

*�,��!����:����'�����,��,���!�����������,�����'�:�4������'��'������,����'������������+�����'���������!(!���&2����%���������������������������'4����!(!�������������������Y���#�������Y!���)�����'������'���������������������!���&

2�!���;*����(#����"��'��+���!���!����������,��������4D!���!(!����0�%���������������������������D�(���+�"��������(��%�����������!��������������������"���������$���������������!��+��!���������������������+�"%���'����'������!�����!����&*(����%��!���'������������������!���)������'�����&1�7����������'�����6?,��(8���"%������%��%�+�"����������������:���!�����%��,%���'�����=������[�����>����!����������"%��H=GH�����:��������������'�(���+�"������������(��������&����%��������!����'���������������������(���+�"���������&2�!��������_�����������!����!(!����&*�����"�����,(6������)�%���[8��!����"�������������%��:����!�)�!������,��!(!�������(,�%�!������:���(��������%��:'��'�(���+�"������������(��������&

# $+ 4��"� . /��+�7+ ��&"&.��!D�+

2�+��'������� ��������������!�!����'������(&2���������%����!����:%��������!�������(�����������;

�7����!&7��:. +�7+ ��8�

2����+��'��$����7�����D������%������+������������+��'����!���������!���&2�����%�������!�����F��:����,(,(��'�%�+�"����,����!���,������(&

2�+��'������&���,��6���!�����:'�����&&&8��������(!���������+��'�����-!������,�(�������������������,��������6!�������)����,�,�'�������)�=���������'�����+��'�����!�"������),(�)��������8&2����%��52!��%�(GI���'�%�+L����������(&

2������%���������������)��'���!�������(�����(�"���;

�!�����������������,!��������������)���(!�����"��!GB�����!�������,"!����(&0����_�������������!���GI�����������������,����P���9�������@:@�D�������%��!��%����GI��!'�%�+L������������(&

Page 34: ECO Rain® Root Zone Irrigation Mat - Technical Guide

ECO Rain® Root Zone Irrigation Mat Technical Guide _____________________________________________________________________________________________________________

_____________________________________________________________________________________________________________ Version 091231 page 34

13 NOTICE OF LIABILITY � The company ECO Rain International can only extend warranty of the Mat, if the Mat

was installed by experienced assemblers and on the basis of this Technical Guide. The same applies to the connecting parts mentioned in this Technical Guide; these need to be supplied by ECO Rain or should be of equal quality.

� Every Irrigation System is individual and should be planned and carried out due to the

particular local condition. Therefore the instructions in this Technical Guide can only be standard guidelines and need to be adjusted to the requirements on the site. If neces-sary it should be planned and installed differing to this Technical Guide. For questions please contact the ECO Rain® headquarters.

� The latest version of the Technical Guide is valid. � Subject to technical changes. 14 FURTHER INFORMATION You will receive further information, support, ... from ECO Rain® International GmbH & Co. KG Neukirchner Str. 6, D-65510 Hünstetten Germany Tel.: +49-6126-1313 Fax: +49-6126-3696 Email: [email protected] www.ecorain.eu We would like to thank you for your trust in our products and wish you and your customers

a lot of pleasure with the Irrigation System!

��C�������#�(#���

�����@���(#��K(��?�

��������������� �����������������������������

9��+������(���#������'!����;

3�� �!&�&�&N�/1��������GBI@HGBGa)��(�2���(K�!������,����

���&;b?@B=E@E=IGI@@@S�7&;b?@B=E@E=IGI@@E ����;'�����(c�����&�'ddd&��������'������&�'

*���,������� ������3��������������!�(��%�'��������'������!������,������'�������":��,(����!����������,��������������(��!������!����������������������&/��%����������%�����������������+!��%������������:�������!����������������%���%�(++�!�������4��,���&

5����'���������!(!���%�!����#�����%����(���,�'��������2��%�������������������'���!��!�����!�������������&�������������!�(��%����'�'�������������������)�������!����������������,����������:�����%��'���!��!�����!��������������������,���������������D���%������������"���"�������&

*�����"����'4���%�!��!���������%������'����,�����,��&

0������'�1���������(�����'�%����"���'��������'&

���������'�"�(%!���(���'��(&

-���������� ��������%����!�+,/�0���������������4����� ������� ����������������������������������!� ������������ !�0�� �1�&