Upload
doandat
View
216
Download
2
Embed Size (px)
Citation preview
Technical TBlue Point Engineering
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Pointing the Way to Solutions!www.BPEsolutions.com
DMX 8-Channel Relay BoardOverview
Copyright © 2009 Blue Point Engineering, All Rights Reserved
ConnectionsThe board requires a 12V DC supply at 0.5 Amps (or 24V DC at 250mA for the 24V version).Connect the relay board to the DMX network using 5-pin XLR connectors. If the DMX Relay board is the last item on the network, place a jumper over the pins marked TRM. This will improve the performance of the DMX network, acting as a DMX Network Termination.
Connect your loads / devices to the relevant volt-free relay outputs 1-8 . ( See relay setup and application example pages for details). Each relay is rated at 10 Amps at 240V AC.
Settings - (See Pages on Control / Addressing)Set the base address of Relay Output - No. 1 as follows: ( when not in byte mode - see below )Add the value of the address DIP switches set to the ON position to calculate the base address.Example: DIP switches 16 and 32 set to ON position, the base address is now 48, this setting is used to determine the starting address output of Relay 1, in DMX Multiple Channel Control, the next relay would be address 49 for Relay 2, and the next 50 for Relay 3, etc. Use this same process for setting the base address in Single Channel Control but Byte Output Switch 10 is set to ON and a Control Byte Value Number is added to the DMX output for control of all the 8 Relays. ( see pages on Addressing for more details on Byte - Binary addressing)
Control Syntax - (See Pages on Control / Addressing)Byte Output switch (DIP Switch 10) set to OFF: ( Multiple DMX control channels )The output on a particular channel will go high (ON) when the DMX transmitted value for that channelexceeds 224. ( 243= OFF, 0% and 244= ON, 100% ). Each relay 1-8 has it's own channel assigned with the base number + a relay position number added to determine the address for each relay output.
Byte Output switch (DIP Switch 10) set to ON: ( Single DMX control channel )The relay outputs act as a binary representation of the data on the base address channel -example, if the base address is set to 33 and the dmx value on channel 33 is 240 (ie 11110000 in binary) then relays 5through 8 would be energized and relays 1 through 4 off. If the value on channel 33 was 15(00001111) then relays 1 through 4 would be on and relays 5-8 off. 1 or more relays can be grouped as a base start address and a single binary value added for each relay output control.
DMX LED- ON when a suitable DMX signal is being received or a flashing LED when NO valid DMX signal stream is being received by the 8-Ch DMX relay board.
The jumper next to the input power socket should be set to the V position when using mechanical relays and set to the 5 position when using the Solid State Relay Board version. (Default =V)
The DMX Relay board provides up to 8- programmable Digital Outputs channels when connected to a DMX controlled network.
The board Base Address may be set between 1 and 505.
Mechanical Relays Rated: 10 Amps @ 240V AC.Board Requires 12 VDC @ 0.5 Amp Supply.
Setup 5-1/2" W x 5-1/8" L x 1-3/8" H
Power Supply: 12VDC @ 0.5 Amp
5-Pin XLR Connectors / Wire Block
WD1493Version 1.0 -2009
1 2 4 8 16
32
64
128
256
BYTE
SG
23
TO
P
VIE
W
DM
X-N
etw
ork
Relay
Co
nn
ection
s
US
B C
able
DMX 8-Ch Relay Board
Blue Point Engineering
Hook-up
DMX 8-Channel Relay Board
Blue Point Engineering
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Blue Point EngineeringCustom Equipment, Unique Electronic Products
Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
Copyright © 2009 Blue Point Engineering, All Rights Reserved
XLR- Connectors
V - Mechanical Relay
Power Jack
TRM - DMX Termination
Jumper
M
F
NC - Normal Closed
DMX- Board Address DIP
Switches
DMX- OK LED
Power LED
Relay Type
Mechanical Relays
DIP Switches( Addressing )
1 2 4 8 16
32
64
128
256
2 3 4 5 6 7 8 9 10ON
1
BYTE
C- Common
NO - Normal Open
Optional DMX Network Wire Connection
SG
23DMX-Network
DMX 8-Ch Relay Board
TO
P
VIE
W
DM
X-N
etw
ork
RelayWire Contacts
RELAY - 1
RELAY - 2
RELAY - 3
RELAY - 4
RELAY - 5
RELAY - 6
RELAY - 7
RELAY - 8
Relay
Co
nn
ection
s
US
B C
able
Optional Solid State Relay Setup
5- Optional SS Relay
NC - Normal ClosedC- Common
NO - Normal Open
NC - Normal ClosedC- Common
NO - Normal Open
1 2 4 8 16
32
64
128
256
BYTE
SG
23
Blue Point Engineering
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
Copyright © 2009 Blue Point Engineering, All Rights Reserved
DMX 8-Channel Relay BoardPower
ConnectionWall Plug Power Supply
12 Vdc @ 0.5 Amp
Board PowerConnection
2.1 mmCenter Positive
XLR / Network Connection
Relay Board Front View
5- PinXLR Cable
M F
5- PinXLR Cable
SG2
3
Mechanical Relays
Board Power Connection
XLR Connection
XLR Connection
Relay Board Top View
Power Jack
Jumper- V
Power Jack
TO
P
VIE
W
V 5
TRM-ON
TRM-OFF
DM
X-N
etw
ork
DMXNetwork
Connection
IN / OUT
MF
F
M
Relay
Co
nn
ection
s
US
B C
able
Blue Point Engineering
Optional DMX Network Wire Connection
SG23DMX -Network
OptionalWire Terminal Block
1 2 4 8 16
32
64
128
256
BYTE
SG
23
TO
P
VIE
W
DM
X-N
etw
ork
Relay
Co
nn
ection
s
USB to DMXInterface
OverviewUSB PORT
DMX Network Setup - 5 Pin
PowerSupply
Computer Control Software (VSA)
USB Cable
USB Cable
Computer
USB PORT
- OR -
Software
5 Pin (F) to 5 Pin (M)
DMX- 8 Ch Relay Board-1
5-Pin (M) XLR Connector
PowerSupply
Relays X 8
Connection Wires
5-Pin (F) XLR Connector
DMX- 8 Ch Relay Board -2
5-Pin (M) XLR Connector
Copyright © 2009 Blue Point Engineering, All Rights Reserved
TRM JumperON
Connection Wires
Relays X 8
Devices
Devices
Technical TBlue Point Engineering
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Pointing the Way to Solutions!www.BPEsolutions.com
DMX 8-Channel Relay Board
- OR -
5-Pin (F) XLR Connector
*
TRM JumperOFF*
(Last Device On Network)
DMX - XLR Cable
5 Pin (F) to 5 Pin (M)DMX - XLR Cable
US
B C
able
Blue Point Engineering
1 2 4 8 16
32
64
128
256
BYTE
SG
23
TO
P
VIE
W
DM
X-N
etw
ork
Relay
Co
nn
ection
s
DMX Network Setup - 3 Pin
Blue Point Engineering
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
DMX 8-Channel Relay Board
USB to DMXInterface
USB PORT
3-Pin (M) XLR Connector
PowerSupply
Computer Control Software (VSA)
USB Cable
USB Cable
Computer
US
B C
able
USB PORT
- OR -
Software
3-Pin (F)XLR Connector
3 to 5 PinXLR
Adapter Cable
3 to 3 Pin (M)XLR Adapter
3 PinXLR Cable
DMX- 8 Ch Relay Board-1
5-Pin (M) XLR Connector
3-Pin (F)XLR Connector
RelaysNO.C.NC
Audio Board,Lights, Motors, FX
PowerSupply
Relays X 8
Connection Wires
Relay ON / OFF Closure Applications
5-Pin (F) XLR Connector
DMX- 8 Ch Relay Board -2
5-Pin (M) XLR Connector
DMX Cable
Copyright © 2009 Blue Point Engineering, All Rights Reserved
TRM JumperON
RelaysNO.C.NC
Connection Wires
Relays X 8
Devices
Devices
Overview
- OR -
Blue Point Engineering
1 2 4 8 16
32
64
128
256
BYTE
SG
23
TO
P
VIE
W
DM
X-N
etw
ork
Blue Point Engineering
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
Copyright © 2009 Blue Point Engineering, All Rights Reserved
DMX 8-Channel Relay Board
Relay Connection
Mechanical Relays
RelayConnections
Relay No. 1
C- Common
NO - Normal Open
NC - Normal Closed
Wire Terminal Blocks
Relay - 1
Relay - 8
Relay - 2
Relay - 3
Relay - 4
Relay - 5
Relay - 6
Relay - 7
Relay - ON LEDs( 1- 8 )
DMX 8- Channel Relay Board
Relay - ON LEDs( 1- 8)
Relay - 1+++
Relay - 2+++ C- Common
NO - Normal Open
NC - Normal Closed
Relay
Co
nn
ection
s
1
2
3
US
B C
able
Relay - 3 +
Blue Point Engineering
Wire ConnectionWire Terminal Blocks
DIp Switch 5 and 6 ON = Base Address 48 + 7 = 55 = Relay No.8 ( Relay 1- Base Address Plus next 7 Relays )Byte Output Switch 10 = OFF Relay 8 ON at DMX value 244+ Relay 8 OFF at DMX value 243-
DMX 8-Channel Relay Board
Blue Point Engineering
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
Copyright © 2009 Blue Point Engineering, All Rights Reserved
DIP
Sw
itch
es
( Ad
dressin
g )
US S
tandard
DM
X 5
12
Exam
ple
Addre
ss
422
Add
ress
= 4
22S
witc
h O
N =
2, 3
, 6, 8
, 9
2+4+32+128+256= 4
22
Board Address
Relay-1
Relay-4
Relay-7 = Ch 54
Relay-8
Setting the base address of Relay Outputs when not in byte mode - Switch 10 set to OFF Add the value of the address DIP switches set to the ON position to calculate the base address.Example(CH): DIP switches 5 and 6 set to ON position, the base address is now 48, (16+32) this setting is used to determine the starting address output of Relay 1, the next relay would be address 49 for Relay 2, and the next 50 for Relay 3, 51 for Relay 4, 52 for Relay 5, etc.
DIp Switch 5 and 6 ON = Base Address 48 = Relay No.1 ( Relay 1- Base Address starting at 48 )Byte Output Switch 10 = OFF Relay 1 ON at DMX value 244+ Relay 1 OFF at DMX value 243-
Example
ONON
16
+3
2 =
48
Control Syntex - (See DMX512 Chart Chart for Values)Byte Output switch (DIP Switch 10) set to OFF: ( Multiple DMX control channels )The output on a particular channel will go high (ON) when the DMX transmitted value for that channel exceeds 224. 0= OFF (0%) and 244= ON (100%)
Byte Mode- OFFDMX - Values
OFF(CH=48)(Value= 244) (Relay = ON)DMX Value 0-255 = 0-100%
DIp Switch 5 and 6 ON = Base Address 48 + 3 = 51 = Relay No.4 ( Relay 1- Base Address Plus next 3 Relays )Byte Output Switch 10 = OFF Relay 4 ON at DMX value 244+ Relay 4 OFF at DMX value 243-
(CH=51)(Value= 244) (Relay = ON)
1
2
3
4
5
6
7
8 (CH=55)(Value= 243) (Relay = OFF)
Relay-6 = Ch 53
Relay-5 = Ch 52
Relay-3 = Ch 50
Relay-2 = Ch 49
Example
DMX Value 244+ =100%
23
45
67
89
10
ON 1
1+
32
= 3
3
DIP
Sw
itc
he
s(
Ad
dre
ssin
g )
TO
P
VIE
W
RELAY - 1
RELAY - 4
RELAY - 8
8=
R8
7=
R7
6=
R6
5=
R5
4=
R4
3=
R3
2=
R2
1=
R1
DIP
Sw
itche
s(
Add
ress
ing
)
Sw
itc
h N
um
be
r
Sw
itc
h V
alu
e
Sw
itc
h P
os
itio
n(
ON
or
OF
F )
ON
OF
F
1248
163264128256
23
45
67
89
10
ON 1
BYTE
Sw
itch Num
ber
Sw
itch Value
Sw
itch Position
( ON
or OF
F )
ON
OF
F
Blue Point Engineering
8=
R8
7=
R7
6=
R6
5=
R5
4=
R4
3=
R3
2=
R2
1=
R1
TO
P
VIE
W
TO
P
VIE
W
248
163264128256
BYTE
1
248
163264128256
BYTE
1
23
45
67
89
10
ON1
23
45
67
89
10
ON1
R2
R3
R4
R1
R5
R6
R7
R8
Blue Point Engineering
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
DMX 512 Chart - US Standard
US S
tandard
DM
X 5
12
Ch - Switches Ch - Switches Ch - Switches
Chart A - US Standard DMX 512
Ch - Switches Ch - Switches
23
45
67
89
10
ON1
Exam
ple
Addre
ss
422
Add
ress
= 4
22S
witc
h O
N =
2, 3
, 6, 8
, 9
2+4+32+128+256= 4
22
DIP
Sw
itche
s(
Add
ress
ing
)
23
45
67
89
10
ON1
Sw
itc
h N
um
be
r
Sw
itc
h V
alu
e
Sw
itc
h P
os
itio
n(
ON
or
OF
F )
ON
OF
F
Blue Point Engineering
248
163264128256
BYTE
1
248
163264128256
BYTE
1
157 = 1, 3, 4, 5, 8158 = 2, 3, 4, 5, 8159 = 1, 2, 3, 4, 5, 8160 = 6, 8161 = 1, 6, 8162 = 2, 6, 8163 = 1, 2, 6, 8164 = 3, 6, 8165 = 1, 3, 6, 8166 = 2, 3, 6, 8167 = 1, 2, 3, 6, 8168 = 4, 6, 8169 = 1, 4, 6, 8170 = 2, 4, 6, 8171 = 1, 2, 4, 6, 8172 = 3, 4, 6, 8173 = 1, 3, 4, 6, 8174 = 2, 3, 4, 6, 8175 = 1,2, 3, 4, 6, 8176 = 5, 6, 8177 = 1, 5, 6, 8178 = 2, 5, 6, 8179 = 1, 2, 5, 6, 8180 = 3, 5, 6, 8181 = 1, 3, 5, 6, 8182 = 2, 3, 5, 6, 8183 = 1, 2, 3, 5, 6, 8184 = 4, 5, 6, 8185 = 1, 4, 5, 6, 8186 = 2, 4, 5, 6, 8187 = 1, 2, 4, 5, 6, 8188 = 3, 4, 5, 6, 8189 = 1, 3, 4, 5, 6, 8190 = 2, 3, 4, 5, 6, 8191 = 1, 2, 3, 4, 5, 6, 8192 = 7, 8193 = 1, 7, 8,194 = 2, 7, 8,195 = 1, 2, 7, 8196 = 3, 7, 8197 = 1, 3, 7, 8198 = 2, 3, 7, 8199 = 1, 2, 3, 7, 8200 = 4, 7, 8,201 = 1, 4, 7, 8202 = 2, 4, 7, 8203 = 1, 2, 4, 7, 8204 = 3, 4, 7, 8205 = 1, 3, 4, 7, 8206 = 2, 3, 4, 7, 8207 = 1, 2, 3, 4, 7, 8208 = 5, 7, 8
209 = 1, 5, 7, 8210 = 2, 5, 7, 8211 = 1, 2, 5, 7, 8212 = 3, 5, 7, 8213 = 1, 3, 5, 7, 8214 = 2, 3, 5, 7, 8215 = 1, 2, 3, 5, 7, 8216 = 4, 5, 7, 8217 = 1, 4, 5, 7, 8218 = 2, 4, 5, 7, 8219 = 1, 2, 4, 5, 7, 8220 = 3, 4, 5, 7, 8221 = 1, 3, 4, 5, 7, 8222 = 2, 3, 4, 5, 7, 8223 = 1, 2, 3, 4, 5, 7, 8224 = 6, 7, 8225 = 1, 6, 7, 8226 = 2, 6, 7, 8227 = 1, 2, 6, 7, 8228 = 3, 6, 7, 8229 = 1, 3, 6, 7, 8230 = 2, 3, 6, 7, 8231 = 1, 2, 3, 6, 7, 8232 = 4, 6, 7, 8233 = 1, 4, 6, 7, 8234 = 2, 4, 6, 7, 8235 = 1, 2, 4, 6, 7, 8236 = 3, 4, 6, 7, 8237 = 1, 3, 4, 6, 7, 8238 = 2, 3, 4, 6, 7, 8239 = 1, 2, 3, 4, 6, 7, 8240 = 5, 6, 7, 8241 = 1, 5, 6, 7, 8242 = 2, 5, 6, 7, 8243 = 1, 2, 5, 6, 7, 8244 = 3, 5, 6, 7, 8245 = 1, 3, 5, 6, 7, 8246 = 2, 3, 5, 6, 7, 8247 = 1, 2, 3, 5, 6, 7, 8248 = 4, 5, 6, 7, 8249 = 1, 4, 5, 6, 7, 8250 = 2, 4, 5, 6, 7, 8251 = 1, 2, 4, 5, 6, 7, 8252 = 3, 4, 5, 6, 7, 8253 = 1, 3, 4, 5, 6, 7, 8254 = 2, 3, 4, 5, 6, 7, 8255 = 1, 2, 3, 4, 5, 6, 7, 8256 = 9257 = 1, 9258 = 2, 9259 = 1, 2, 9260 = 3, 9
105 = 1, 4, 6, 7106 = 2, 4, 6, 7107 = 1, 2, 4, 6, 7108 = 3, 4, 6, 7109 = 1, 3, 4, 6, 7110 = 2, 3, 4, 6, 7111 = 1, 2, 3, 4, 6, 7112 = 5, 6, 7113 = 1, 5, 6, 7114 = 2, 5, 6, 7115 = 1, 2, 5, 6, 7116 = 3, 5, 6, 7117 = 1, 3, 5, 6, 7118 = 2, 3, 5, 6, 7119 = 1, 2, 3, 5, 6, 7120 = 4, 5, 6, 7121 = 1, 4, 5, 6, 7122 = 2, 4, 5, 6, 7123 = 1, 2, 4, 5, 6, 7124 = 3, 4, 5, 6, 7125 = 1, 3, 4, 5, 6, 7126 = 2, 3, 4, 5, 6, 7127 = 1, 2, 3, 4, 5, 6, 7128 = 8129 = 1, 8130 = 2, 8131 = 1, 2, 8132 = 3, 8133 = 1, 3, 8134 = 2, 3, 8135 = 1, 2, 3, 8136 = 4, 8137 = 1, 4, 8138 = 2, 4, 8139 = 1, 2, 4, 8140 = 3, 4, 8141 = 1, 3, 4, 8142 = 2, 3, 4, 8143 = 1, 2, 3, 4, 8144 = 5, 8145 = 1, 5, 8146 = 2, 5, 8147 = 1, 2, 5, 8148 = 3, 5, 8149 = 1, 3, 5, 8150 = 2, 3, 5, 8151 = 1, 2, 3, 5, 8152 = 4, 5, 8153 = 1, 4, 5, 8154 = 2, 4, 5, 8155 = 1, 2, 4, 5, 8156 = 3, 4, 5, 8
53 = 1, 3, 5, 654 = 2, 3, 5, 655 = 1, 2, 3, 5, 656 = 4, 5, 657 = 1, 4, 5, 658 = 2, 4, 5, 659 = 1, 2, 4, 5, 660 = 3, 4, 5, 661 = 1, 3, 4, 5, 662 = 2, 3, 4, 5, 663 = 1, 2, 3, 4, 5, 664 = 765 = 1, 766 = 2, 767 = 1, 2, 768 = 3, 769 = 1, 3, 770 = 2, 3, 771 = 1, 2, 3, 772 = 4, 773 = 1, 4, 774 = 2, 4, 775 = 1, 2, 4, 776 = 3, 4, 777 = 1, 3, 4, 778 = 2, 3, 4, 779 = 1, 3, 4, 780 = 5, 781 = 1, 5, 782 = 2, 5, 783 = 1, 2, 5, 784 = 3, 5, 785 = 1, 3, 5, 786 = 2, 3, 5, 787 = 1, 2, 3, 5, 788 = 4, 5, 789 = 1, 4, 5, 790 = 2, 4, 5, 791 = 1, 2, 4, 5, 792 = 3, 4, 5, 793 = 1, 3, 4, 5, 794 = 2, 3, 4, 5, 795 = 1, 2, 3, 4, 5, 796 = 6, 797 = 1, 6, 798 = 2, 6, 799 = 1, 2, 6, 7100 = 3, 6, 7101 = 1, 3, 6, 7102 = 2, 3, 6, 7103 = 1, 2, 3, 6, 7104 = 4, 6, 7
1 = 12 = 23 = 1, 24 = 35 = 1, 36 = 2, 37 = 1, 2, 38 = 49 = 1, 410 = 2, 411 = 1, 2, 412 = 3, 413 = 1, 3, 414 = 2, 3, 415 = 1, 2, 3, 416 = 517 = 1, 518 = 2, 519 = 1, 2, 520 = 3, 521 = 1, 3, 522 = 2, 3, 523 = 1, 2, 3, 524 = 4, 525 = 1, 4, 526 = 2, 4, 527 = 1, 2, 4, 528 = 3, 4, 529 = 1, 3, 4, 530 = 2, 3, 4, 531 = 1, 2, 3, 4, 532 = 633 = 1, 634 = 2, 635 = 1, 2, 636 = 3, 637 = 1, 3, 638 = 2, 3, 639 = 1, 2, 3, 640 = 4, 641 = 1, 4, 642 = 2, 4, 643 = 1, 2, 4, 644 = 3, 4, 6,45 = 1, 3, 4, 646 = 2, 3, 4, 647 = 1, 2, 3, 4, 648 = 5, 649 = 1, 5, 650 = 2, 5, 651 = 1, 2, 5, 652 = 3, 5, 6
Ch - Switches Ch - Switches Ch - Switches
US S
tandard
DM
X 5
12
Ch - SwitchesCh - Switches
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
23
45
67
89
10
ON1
Exam
ple
Addre
ss
422
Add
ress
= 4
22S
witc
h O
N =
2, 3
, 6, 8
, 9
2+4+32+128+256= 4
22
DIP
Sw
itche
s(
Add
ress
ing
)
23
45
67
89
10
ON1
Sw
itc
h N
um
be
r
Sw
itc
h V
alu
e
Sw
itc
h P
os
itio
n(
ON
or
OF
F )
ON
OF
F
Blue Point Engineering
248
163264128256
BYTE
1
248
163264128256
BYTE
1
261 = 1, 3, 9262 = 2, 3, 9263 = 1, 2, 3, 9264 = 4, 9265 = 1, 4, 9266 = 2, 4, 9267 = 1, 2, 4, 9268 = 3, 4, 9269 = 1, 3, 4, 9270 = 2, 3, 4, 9271 = 1, 2, 3, 4, 9272 = 5, 9273 = 1, 5, 9274 = 2, 5, 9275 = 1, 2, 5, 9276 = 3, 5, 9277 = 1, 3, 5, 9278 = 2, 3, 5, 9279 = 1, 2, 3, 5, 9280 = 4, 5, 9281 = 1, 4, 5, 9282 = 2, 4, 5, 9283 = 1, 2, 4, 5, 9284 = 3, 4, 5, 9285 = 1, 3, 4, 5, 9286 = 2, 3, 4, 5, 9287 = 1, 2, 3, 4, 5, 9288 = 6, 9289 = 1, 6, 9290 = 2, 6, 9291 = 1, 2, 6, 9292 = 3, 6, 9293 = 1, 3, 6, 9294 = 2, 3, 6, 9295 = 1, 2, 3, 6, 9296 = 4, 6, 9297 = 1, 4, 6, 9298 = 2, 4, 6, 9299 = 1, 2, 4, 6, 9300 = 3, 4, 6, 9301 = 1, 3, 4, 6, 9302 = 2, 3, 4, 6, 9303 = 1, 2, 3, 4, 6, 9304 = 5, 6, 9305 = 1, 5, 6, 9306 = 2, 5, 6, 9307 = 1, 2, 5, 6, 9308 = 3, 5, 6, 9309 = 1, 3, 5, 6, 9310 = 2, 3, 5, 6, 9311 = 1, 2, 3, 5, 6, 9312 = 4, 5, 6, 9313 = 1, 4, 5, 6, 9314 = 2, 4, 5, 6, 9315 = 1, 2, 4, 5, 6, 9316 = 3, 4, 5, 6, 9317 = 1, 3, 4, 5, 6, 9318 = 2, 3, 4, 5, 6, 9329 = 1, 2, 3, 4, 5, 6, 9320 = 7, 9321 = 1, 7, 9
383 = 1, 2, 3, 4, 5, 6, 7, 9384 = 8, 9385 = 1, 8, 9386 = 2, 8, 9387 = 1, 2, 8, 9388 = 3, 8, 9389 = 1, 3, 8, 9390 = 2, 3, 8, 9391 = 1, 2, 3, 8, 9392 = 4, 8, 9393 = 1, 4, 8, 9394 = 2, 4, 8, 9395 = 1, 2, 4, 8, 9396 = 3, 4, 8, 9397 = 1, 3, 4, 8, 9398 = 2, 3, 4, 8, 9399 = 1, 2, 3, 4, 8, 9400 = 5, 8, 9401 = 1, 5, 8, 9402 = 2, 5, 8, 9403 = 1, 2, 5, 8, 9404 = 3, 5, 8, 9405 = 1, 3, 5, 8, 9406 = 2, 3, 5, 8, 9407 = 1, 2, 3, 5, 8, 9408 = 4, 5, 8, 9409 = 1, 4, 5, 8, 9410 = 2, 4, 5, 8, 9411 = 1, 2, 4, 5, 8, 9412 = 3, 4, 5, 8, 9413 = 1, 3, 4, 5, 8, 9414 = 2, 3, 4, 5, 8, 9415 = 1, 2, 3, 4, 5, 8, 9416 = 6, 8, 9417 = 1, 6, 8, 9418 = 2, 6, 8, 9419 = 1, 2, 6, 8, 9420 = 3, 6, 8, 9421 = 1, 3, 6, 8, 9422 = 2, 3, 6, 8, 9423 = 1, 2, 3, 6, 8, 9424 = 4, 6, 8, 9425 = 1, 4, 6, 8, 9426 = 2, 4, 6, 8, 9427 = 1, 2, 4, 6, 8, 9428 = 3, 4, 6, 8, 9429 = 1, 3, 4, 6, 8, 9430 = 2, 3, 4, 6, 8, 9431 = 1, 2, 3, 4, 6, 8, 9432 = 5, 6, 8, 9433 = 1, 5, 6, 8, 9434 = 2, 5, 6, 8, 9435 = 1, 2, 5, 6, 8, 9436 = 3, 5, 6, 8, 9437 = 1, 3, 5, 6, 8, 9438 = 2, 3, 5, 6, 8, 9439 = 1, 2, 3, 5, 6, 8, 9440 = 4, 5, 6, 8, 9441 = 1, 4, 5, 6, 8, 9442 = 2, 4, 5, 6, 8, 9443 = 1, 2, 4, 5, 6, 8, 9
444 = 3, 4, 5, 6, 8, 9445 = 1, 3, 4, 5, 6, 8, 9446 = 2, 3, 4, 5, 6, 8, 9447 = 1, 2, 3, 4, 5, 6, 8, 9448 = 7, 8, 9449 = 1, 7, 8, 9450 = 2, 7, 8, 9451 = 1, 2, 7, 8, 9452 = 3, 7, 8, 9453 = 1, 3, 7, 8, 9454 = 2, 3, 7, 8, 9455 = 1, 2, 3, 7, 8, 9456 = 4, 7, 8, 9457 = 1, 4, 7, 8, 9458 = 2, 4, 7, 8, 9459 = 1, 2, 4, 7, 8, 9460 = 3, 4, 7, 8, 9461 = 1, 3, 4, 7, 8, 9462 = 2, 3, 4, 7, 8, 9463 = 1, 2, 3, 4, 7, 8, 9464 = 5, 7, 8, 9465 = 1, 5, 7, 8, 9466 = 2, 5, 7, 8, 9467 = 1, 2, 5, 7, 8, 9468 = 3, 5, 7, 8, 9469 = 1, 3, 5, 7, 8, 9470 = 2, 3, 5, 7, 8, 9471 = 1, 2, 3, 5, 7, 8, 9472 = 4, 5, 7, 8, 9473 = 1, 4, 5, 7, 8, 9474 = 2, 4, 5, 7, 8, 9475 = 1, 2, 4, 5, 7, 8, 9476 = 3, 4, 5, 7, 8, 9477 = 1, 3, 4, 5, 7, 8, 9478 = 2, 3, 4, 5, 7, 8, 9479 = 1, 2, 3, 4, 5, 7, 8, 9480 = 6, 7, 8, 9481 = 1, 6, 7, 8, 9482 = 2, 6, 7, 8, 9483 = 1, 2, 6, 7, 8, 9484 = 3, 6, 7, 8, 9485 = 1, 3, 6, 7, 8, 9486 = 2, 3, 6, 7, 8, 9487 = 1, 2, 3, 6, 7, 8, 9488 = 4, 6, 7, 8, 9489 = 1, 4, 6, 7, 8, 9490 = 2, 4, 6, 7, 8, 9491 = 1, 2, 4, 6, 7, 8, 9492 = 3, 4, 6, 7, 8, 9493 = 1, 3, 4, 6, 7, 8, 9494 = 2, 3, 4, 6, 7, 8, 9495 = 1, 2, 3, 4, 6, 7, 8, 9496 = 5, 6, 7, 8, 9,497 = 1, 5, 6, 7, 8, 9498 = 2, 5, 6, 7, 8, 9499 = 1, 2, 5, 6, 7, 8, 9500 = 3, 5, 6, 7, 8, 9501 = 1, 3, 5, 6, 7, 8, 9502 = 2, 3, 5, 6, 7, 8, 9503 = 1, 2, 3, 5, 6, 7, 8, 9504 = 4, 5, 6, 7, 8, 9
505 = 1, 4, 5, 6, 7, 8, 9506 = 2, 4, 5, 6, 7, 8, 9507 = 1, 2, 4, 5, 6, 7, 8, 9508 = 3, 4, 5, 6, 7, 8, 9509 = 1, 3, 4, 5, 6, 7, 8, 9510 = 2, 3, 4, 5, 6, 7, 8, 9511 = 1, 2, 3, 4, 5, 6, 7, 8, 9512 = 0
322 = 2, 7, 9323 = 1, 2, 7, 9324 = 3, 7, 9325 = 1, 3, 7, 9326 = 2, 3, 7, 9327 = 1, 2, 3, 7, 9328 = 4, 7, 9329 = 1, 4, 7, 9330 = 2, 4, 7, 9331 = 1, 2, 4, 7, 9332 = 3, 4, 7, 9333 = 1, 3, 4, 7, 9334 = 2, 3, 4, 7, 9335 = 1, 2, 3, 4, 7, 9336 = 5, 7, 9337 = 1, 5, 7, 9338 = 2, 5, 7, 9339 = 1, 2, 5, 7, 9340 = 3, 5, 7, 9341 = 1, 3, 5, 7, 9342 = 2, 3, 5, 7, 9343 = 1, 2, 3, 5, 7, 9344 = 4, 5, 7, 9345 = 1, 4, 5, 7, 9346 = 2, 4, 5, 7, 9347 = 1, 2, 4, 5, 7, 9348 = 3, 4, 5, 7, 9349 = 1, 3, 4, 5, 7, 9350 = 2, 3, 4, 5, 7, 9351 = 1, 2, 3, 4, 5, 7, 9352 = 6, 7, 9353 = 1, 6, 7, 9354 = 2, 6, 7, 9355 = 1, 2, 6, 7, 9356 = 3, 6, 7, 9357 = 1, 3, 6, 7, 9358 = 2, 3, 6, 7, 9359 = 1, 2, 3, 6, 7, 9360 = 4, 6, 7, 9361 = 1, 4, 6, 7, 9362 = 2, 4, 6, 7, 9363 = 1, 2, 4, 6, 7, 9364 = 3, 4, 6, 7, 9365 = 1, 3, 4, 6, 7, 9366 = 2, 3, 4, 6, 7, 9367 = 1, 2, 3, 4, 6, 7, 9368 = 5, 6, 7, 9369 = 1, 5, 6, 7, 9370 = 2, 5, 6, 7, 9371 = 1, 2, 5, 6, 7, 9372 = 3, 5, 6, 7, 9373 = 1, 3, 5, 6, 7, 9374 = 2, 3, 5, 6, 7, 9375 = 1, 2, 3, 5, 6, 7, 9376 = 4, 5, 6, 7, 9377 = 1, 4, 5, 6, 7, 9378 = 2, 4, 5, 6, 7, 9379 = 1, 2, 4, 5, 6, 7, 9380 = 3, 4, 5, 6, 7, 9381 = 1, 3, 4, 5, 6, 7, 9382 = 2, 3, 4, 5, 6, 7, 9
If the base address is set to 33 and the dmx value (Binary) on DMX channel 33 is15 00001111 then relays 1 through 4 would be ON and relays 5-8 OFF .
Blue Point Engineering Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
Copyright © 2009 Blue Point Engineering, All Rights Reserved
DMX 8-Channel Relay Board
DIP
Sw
itch
es
( Ad
dressin
g )
US S
tandard
DM
X 5
12
Exam
ple
Addre
ss
422
Add
ress
= 4
22S
witc
h O
N =
2, 3
, 6, 8
, 9
2+4+32+128+256= 4
22
16
+3
2 =
48
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Example
1248163264128256
23
45
67
89
10
ON 1
BYTE
ON
ON
1+
32
= 3
3
Binary ValueByte Mode - ON
Board Address
Control Syntex - (See Binary Chart for Values )
The DMX output values now act as a binary representation of the data on the base address channel. Example, if the base address is set to 33 and the value (Binary) on DMX channel 33 is 240 (Example: 11110000 in binary ) then relays 5 through 8 would be energised and relays 1 through 4 OFF.
Setting the base address of Relay Outputs when in byte mode - Switch 10 set to ON Add the value of the address DIP switches set to the ON position to calculate the base address.Example: DIP switches 6 and 1 set to ON position, the base address is now 33. ( Single DMX control channel )
ON
DIP
Sw
itc
he
s(
Ad
dre
ssin
g )
TO
P
VIE
W
R1
R2
R3
R4
R5
R6
R7
R8
Example
Relay-1
Relay-2
(CH=33)(Value= 15) Relay 1 = ON 2 = ON 3 = ON 4 = ON
Relay-3
Relay-4
C6
C5
C4
C3
C2
C1
C0
C7
Relay-5
Relay-6
Relay-7
Relay-8(CH=33)(Value= 15) Relay 5 = OFF 6 = OFF 7 = OFF 8 = OFF
Binary Value
Binary Value = 1500001111
Base Address
RELAY - 1-4 =ON, 5-8 =OFF
If the base address is set to 33 and the dmx value (Binary) on DMX channel 33 is 162 (1 0 1 0 0 0 1 0 ) then relays 1,3,7 would be ON and relays 2,4,5,6,8 OFF .
RELAY - 1,3,7 =ON, 2,4,5,6,8 =OFF
If the base address is set to 33 and the dmx value (Binary) on DMX channel 33 is 85 (0 1 0 1 0 1 0 1 ) then relays 2,4,6,8 would be ON and relays 1,3,5,7 OFF .
RELAY - 2,4,6,8 =ON, 1,3,5,7 =OFF
If the base address is set to 33 and the dmx value (Binary) on DMX channel 33 is 255 (1 1 1 1 1 1 1 1 ) then relays 1 through 8 would be ON .
RELAY - 1-8 =ALL ON
If the base address is set to 33 and the dmx value (Binary) on DMX channel 33 is 0 (0 0 0 0 0 0 0 0 ) then relays 1 through 8 would be OFF .
RELAYS - 1-8 =All OFF
8=
R8
7=
R7
6=
R6
5=
R5
4=
R4
3=
R3
2=
R2
1=
R1
DIP
Sw
itche
s(
Add
ress
ing
)
Sw
itc
h N
um
be
r
Sw
itc
h V
alu
e
Sw
itc
h P
os
itio
n(
ON
or
OF
F )
ON
OF
F
23
45
67
89
10
ON 1
Sw
itch Num
ber
Sw
itch Value
Sw
itch Position
( ON
or OF
F )
ON
OF
F
Blue Point Engineering
8=
R8
7=
R7
6=
R6
5=
R5
4=
R4
3=
R3
2=
R2
1=
R1
TO
P
VIE
W
TO
P
VIE
W
C6
C5
C4
C3
C2
C1
C0
C7
248
163264128256
BYTE
1
248
163264128256
BYTE
1
23
45
67
89
10
ON1
23
45
67
89
10
ON1
R2
R3
R4
R1
R5
R6
R7
R8
11001100110011011100111011001111110100001101000111010010110100111101010011010101110101101101011111011000110110011101101011011011110111001101110111011110110111111110000011100001111000101110001111100100111001011110011011100111111010001110100111101010111010111110110011101101111011101110111111110000111100011111001011110011111101001111010111110110111101111111100011111001111110101111101111111100111111011111111011111111
204205206207208209210211212213214215216217218219220221222223224225226227228229230231232233234235236237238239240241242243244245246247248249250251252253254255
0123456789
1011121314151617181920212223242526272829303132333435363738394041424344454647484950
000000000000000100000010000000110000010000000101000001100000011100001000000010010000101000001011000011000000110100001110000011110001000000010001000100100001001100010100000101010001011000010111000110000001100100011010000110110001110000011101000111100001111100100000001000010010001000100011001001000010010100100110001001110010100000101001001010100010101100101100001011010010111000101111001100000011000100110010
===================================================
===================================================
Engineering
====================================================
Binary Value Chart
Blue Point Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
Version 1.0200976543210 Numbering
00000000 Port / Ch
CH 7-076543210 76543210
CH 7-076543210
CH 7-076543210
CH 7-076543210
CH 7-0Digit
C7 C6 C5 C4 C3 C2 C1 C0 Port / Channel128 64 32 16 8 4 2 1 Decimal Value
1 = Port / Channel ON0 = Port / Channel OFF
0 = All Ports / Channels OFF255 = All Ports / Channels ON
Digit DigitDigitDigit
===================================================
001100110011010000110101001101100011011100111000001110010011101000111011001111000011110100111110001111110100000001000001010000100100001101000100010001010100011001000111010010000100100101001010010010110100110001001101010011100100111101010000010100010101001001010011010101000101010101010110010101110101100001011001010110100101101101011100010111010101111001011111011000000110000101100010011000110110010001100101
100110011001101010011011100111001001110110011110100111111010000010100001101000101010001110100100101001011010011010100111101010001010100110101010101010111000110010101101101011101010111110110000101100011011001010110011101101001011010110110110101101111011100010111001101110101011101110111100101111011011111010111111110000001100000111000010110000111100010011000101110001101100011111001000110010011100101011001011
153154155156157158159160161162163164165166167168169170171172173174175176177178179180181182183184185186187188189190191192193194195196197198199200201202203
===================================================
011001100110011101101000011010010110101001101011011011000110110101101110011011110111000001110001011100100111001101110100011101010111011001110111011110000111100101111010011110110111110001111101011111100111111110000000100000011000001010000011100001001000010110000110100001111000100010001001100010101000101110001100100011011000111010001111100100001001000110010010100100111001010010010101100101101001011110011000
102103104105106107108109110111112113114115116117118119120121122123124125126127128129130131132133134135136137138139140141142143144145146147148149150151152
51525354555657585960616263646566676869707172737475767778798081828384858687888990919293949596979899
100101
DIP
Sw
itch
es
( Ad
dressin
g )
16
+3
2 =
48
23
45
67
89
10
ON 1
1+
32
= 3
3
DIP
Sw
itc
he
s(
Ad
dre
ssin
g )
TO
P
VIE
W
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Blue Point Engineering Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
DMX 8-Channel Relay Board
0 = All Channels / Ports OFF255 = All Channels / Ports ON
0= Channel / Port / Relay OFF1= Channel / Port / Relay ON
Binary ValueChannels / Ports
C7
1 2 8
C6
6 4
C5
3 2
C4
1 6
C3
8
C2
4
C1
2
C0
1
CHANNELS 7-0 or RELAYS 8-1
R8 R7 R6 R5 R4 R3 R2 R1
0 or1 0 or1 0 or1 0 or1 0 or1 0 or1 0 or1 0 or1
12345678
R-8
Relay No
Channel No
DecimalValue
Binary Value
Ch7
1248
163264
128 0or10or10or10or10or10or10or10or1
Copyright © 2009 Blue Point Engineering, All Rights Reserved
Ch6Ch5Ch4Ch3Ch2Ch1Ch0
R-7R-6R-5R-4R-3R-2R-1
AlphaValue
ABCDEFGH
Binary Action
23
45
67
89
10
ON 1
Sw
itch Num
ber
Sw
itch Value
Sw
itch Position
( ON
or OF
F )
ON
OF
F
Blue Point Engineering
TO
P
VIE
W
TO
P
VIE
W
R2
R3
R4
R1
R5
R6
R7
R8
US S
tandard
DM
X 5
12
23
45
67
89
10
ON1
Exam
ple
Addre
ss
422
Add
ress
= 4
22S
witc
h O
N =
2, 3
, 6, 8
, 9
2+4+32+128+256= 4
22
DIP
Sw
itche
s(
Add
ress
ing
)
23
45
67
89
10
ON1
Sw
itc
h N
um
be
r
Sw
itc
h V
alu
e
Sw
itc
h P
os
itio
n(
ON
or
OF
F )
ON
OF
F
248
163264128256
BYTE
1
248
163264128256
BYTE
1
DMX 8- Ch Relay Board
0=OFF - 1=ON
Decimal Value
DMX - Relay
Channel / Port
Binary Value
Blue Point Engineering
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
Copyright © 2009 Blue Point Engineering, All Rights Reserved
DMX 8-Channel Relay BoardApplications
Relay No. 8
C- Common
NO - Normal OpenNC - Normal Closed
Wire Terminal Blocks
AirHose W
ire
Pneumatic Cylinder(Double Acting)
Air Hose
Air Hose
Air Supply
Wir
e
NOC
+ 12 Vdc
- 12 Vdc
5/2 Switching Solenoid Air Valve
(12 VDC)
Exhaust Ports
Wire
Relay Connection
DMX- 8 Channel Relay Board
+ 12 Vdc
C
NO - Normal OpenNC - Normal Closed ( Not Used)
+ 12 Vd
c
RelayConnection
Relay - 8
Open Contact Relay Closure
Open Contact Relay Closure
C- Common
Pneumatic Setup
Wir
e
Wir
e
Wir
e
Wir
e
Co
m
NC
NO
NOC C
NC
NC
NO
C
NO
C
+ 12 Vd
c
NC
NOC
Blue Point Engineering
Wir
e
SoundPlayback System
LEDLighting FX Unit
12 VdcPower Supply
Relay-1
Relay-4
Relay-6
Relay-7
Relay-8
Relay-2
Relay-3
Relay-5
Re
lay
-1
Re
lay
-2
R8R7
R8
R1
Copyright © 2009 Blue Point Engineering, All Rights Reserved
Blue Point Engineering
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
DMX 8-Channel Relay BoardApplication
Wir
e
Wir
e
NOC
Relay OutputsX 8
12 VdcPower Supply+ 12 Vdc
V8 V7 V6 V5 V4 V3 V2 V1
+ 12 Vd
c
- 12 Vdc
N.O. Relay ContactConnections
1-8 Relay
Com. Relay Contact
Connections1-8 Relay
- 12 Vdc
Pneumatic Cylinders
1 - 8
AirHose
PowerConnections
NO
CNO
NO NO
NO NO
NO NO
C
Pneumatic Air Bank 1 - 8
C
NO
NC
NO
NO
NO
NO
NO
NO
NO
C
C
C
C
C
C
C
NC - Normal Closed ( Not Used )
X 8
X 8 Solenoid Air Valves
Wir
e
Wir
e
Wir
e
Wire
Wir
e
Wire
Co
m
NC
NO
NOC C
NC
NC
NO
C
NO
C
+ 12 Vd
c
NC
NOC
Blue Point Engineering
Wir
e
C
Relay-1
Relay-8
Relay-4
Relay-6
Relay-7
Relay-2
Relay-3
Relay-5
Re
lay
-1
Re
lay
-2
R8R7
R8
R1
Wir
e
Wir
e
NOC
+ 12 Vd
c
Wir
e
Wir
e
Wir
e
Wir
e
Air Tank
ConfettiCannon
Water (Air)Valve
Black Wire
Red Wire
Power Supply(12 Vdc @ 10 Amp )
AirValve
DMX- 8 Channel Relay Board
NO C
Red Wire
Technical TBlue Point Engineering
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Pointing the Way to Solutions!www.BPEsolutions.com
DMX 8-Channel Relay BoardApplications
Power Supply(12 Vdc @ 10 Amp )
Water Source
IN
Black Wire
Red Wire
Water Valve
Channel 1
Channel 2
Fountain Heads
Fountain Heads
Lawn Water Valve (12 Volts dc)
DMX- 8 Channel Relay Board
Co
m
NC
NO
NOC C
NC
NC
NO
C
Water Valve
Copyright © 2009 Blue Point Engineering, All Rights Reserved
NO C
NO
C
+ 12 Vd
c
+-
-+
+
+
-
+
-+
NC
NOC
Blue Point Engineering
Wire
Wir
e
Water Valve
+-
Re
lay
-1
Re
lay
-2
R8R7
R8
R1
Wir
e
Wir
e
NOC
+ 12 Vd
c
Wir
e
Wir
e
Wir
e
Wir
e
DMX 8-Channel Relay Board
Blue Point Engineering
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
Relay Outputs DMX- 8 Channel Relay Board
5-Pin (M) XLR Connector
DMX Cable
Connection
(NO) (C)
(-)
(+)
(-)
Black Wire
Red Wire
Wall Power Supply(12 Vdc @ 1 Amp)
LED-Bar 1 LED-Light Bars
+-
+-
Red Wire
LED's
Resistors
- OR -
Red Wire
Relay to LED Bar, and Single LED's
LED Resistor
Com
NO
Relays X 8
A
B
AB
Red Wire
Copyright © 2009 Blue Point Engineering, All Rights Reserved
Applications
(+)
Co
m
NC
NO
NOC C
NC
NC
NO
C
NO
C
+ 12 Vd
c
NC
NOC
Blue Point Engineering
Wir
e
(12 Vdc)
(12 Vdc)
330 Ohm
Re
lay
-1
Re
lay
-2
R8R7
R8
R1
Wir
e
Wir
e
NOC
+ 12 Vd
c
Wir
e
Wir
e
Wir
e
Wir
e
Blue Point Engineering
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
Copyright © 2009 Blue Point Engineering, All Rights Reserved
DMX 8-Channel Relay Board
RelayConnections
Motor Logic
This design prevents the possibility of both relays from shorting back into the power supply when relays 1 and 2 are switched ON or OFF together at the same time.
CCW
Relay 1 Relay 2
OFF OFF STOP
CW
OFF ON
ON OFF
ON ON STOP
Status
MotorNo. 1
Motor
DMX Relay / Switch Logic
MOTOR POWER
Relay 1
+V
-Gnd
Com
5-12 Volt DC Permanent Magnet Motor
CW Rotation
CCW Rotation
Relay 2
Co
m
NC
NO
NO
RED Wire
BLACK Wire
C CN
C
DMX DMX
Relay Motor Control
DMX- 8 Channel Relay Board
5-12 Vdc
NC
NO
CRelay
Connections
1 Motor = 2 Relays4 Motor = 8 Relays
5-Pin (M) XLR Connector
DMX Cable Connection
NO
C
+ 12 Vd
c
NC
NOC
Blue Point Engineering
Wir
e
DMX DMX
Motor -1
Re
lay
-1
Re
lay
-2R8
R7
R8
R1
Wir
e
Wir
e
NOC
+ 12 Vd
c
Wir
e
Wir
e
Wir
e
Wir
e
Blue Point Engineering
www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
Copyright © 2009 Blue Point Engineering, All Rights Reserved
DMX 8-Channel Relay BoardRelay
Connection
Co
m
NC
NO
NOC C
NC
NC
NO
C
12 VdcPower Supply
- 12
Wire
DC MOTORControl- ON / OFF
WireN
O
C
+ 12 Vd
c
+ 12 Vdc
- 12 VdcWire
RotationCCW
A
B
RotationCW
B
A- OR -
AB
Relay 1 ON OFF
Relay 1 OFF ON
Relay 1 and 2 OFFRelay 1 and 2 ON
MOTOR POWER(12Vdc)
Relay 1
+V
-GndCom
12 Volt DC Permanent
Magnet Motor
MotorNo. 1
CW RotationCCW
RotationRelay 2
Com
RED Wire
BLACK Wire
C
Motor Logic
= Motor CW Rotation
= Motor CCW Rotation
Relay 2
Relay 2
NO C
Switch Motor Wires
A / Bto Change Direction
NC
NOC
= Motor All Stop
NC
NOC
+12
Blue Point Engineering
Wir
e
Phone (303) 651-3794 (MST)
Re
lay
-1
Re
lay
-2
R8R7
R8
R1
5 - 1
2
VD
C
+3G
ree
n(G
nd
)
Wh
ite
Bla
ck
Re
d
Bla
ck
CR
YD
OM
412
1 2 4 8 16
32
64
128
256
BYTE
Blue Point Engineering
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
Copyright © 2009 Blue Point Engineering, All Rights Reserved
DMX 8-Channel Relay BoardApplication
Blue Point Engineering
Motor Set-up
DMX Relay Board
24 VdcPower Supply
Wire
+-
RotationCW
A
B
RotationCCW
AB
BA
- OR -
Wire
Rotation
12 VdcPower Supply
Wire
Wire
12 Volt DCMotor - 1
+-
Rotation
Wire
Wire
12 Volt DCMotor - 2
Rotation Change
B or A
B
A
A or B
C
NO
C
C
Wire
NO
NOCh-8
Ch-6
24 Volt DCMotor - 3
NO
NO
USB Flash Drive
NO
DA
NG
ER
DA
NG
ER
Rotation
Switch A-BSwitch B-A
Wire
24
12Ch-1
Ch
-1
Ch
-2
Ch
-6
Ch
-7
Ch
-8
Wire
Wire
Ch
-1
Wire
Wire
USB Drive - MP3 Playback Board
5 - 1
2
VD
C
+3G
ree
n(G
nd
)
Wh
ite
Bla
ck
Re
d
Bla
ck
CR
YD
OM
412
1 2 4 8 16
32
64
128
256
BYTE
Wire
Wire
Blue Point Engineering
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
DMX 8-Channel Relay Board
MP3 / Sound Board Playback
Blue Point Engineering
Application Sound Board Pro Module
Speaker Playback
Wire
Pin Pair Terminal
Sound Board "VEGAS" Module
CH-1Ch-2 Sound Playback
CH-8Ch-7 Sound Playback
C
NO
NO
Pin Pair Terminal
C NO
NOC
CH-6 Sound Playback
DMX- 8-Ch Relay
USB Flash Drive
NO
CC
6-CH
8-CH
- OR -
- OR -
- OR -
DA
NG
ER
DA
NG
ER
Speaker and Amplifier
PLAYBACK
Large VolumeSound Output
(Mono Output)
Large Volume
- OR -
Ch
-1
Ch
-2
Ch
-6
Ch
-7
Ch
-8
Wire
Wire
Ch
-1
Copyright © 2009 Blue Point Engineering, All Rights Reserved
Power Transformer( 5-12 VDC)
+-5
- 12
V
DC
+3G
ree
n(G
nd
)
Black
Wh
ite
Solid-State Relay Module
RelayContacts
Plug InAC Voltage
Wall Plug
White
Bla
ck
Re
d
Bla
ck
Use caution when working with AC Voltage. Touching or incorrectly wiring this circuit could cause serious personal injury or damage to equipment.
Caution
*
CR
YD
OM
412
NO
C
Blue Point Engineering
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
DMX 8-Channel Relay BoardLarge AC Power Control
Blue Point Engineering
1 2 4 8 16
32
64
128
256
BYTE
Wire
Wire
NO
NO
USB Flash Drive
NO
DA
NG
ER
DA
NG
ER
AC PoweredDevices
DMX 8-Ch Relay Board
Ch
-1
Ch
-2
Ch
-6
Ch
-7
Ch
-8
Wire
Wire
Ch
-1
**
*
*
5 - 1
2
VD
C
+3G
ree
n(G
nd
)
Wh
ite
Bla
ck
Re
d
Bla
ck
CR
YD
OM
412
1 2 4 8 16
32
64
128
256
BYTE
Wire
Wire
Blue Point Engineering
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
DMX 8-Channel Relay Board
Wizard Board Control
Blue Point Engineering
Application
DMX Hybrid - Set-up
To Motors, Light s, LED'sSpecial Effect Devices
Wizard - 11 Controller Board
To Servos, Motors, Light FX& Sound Effect Playback
Ch-1
Wizard - 8 Controller Board
To VAC Devices & Sound Effects Playback
NO
NO
USB Flash Drive
NO
Wizard - 2 Controller Board
Wizard REM Port Activation
by DMX- 8 Ch Relay
DMX 8- Channel Relay Board
Wizard - 1 Controller Board
To Servomotors andDigital Output Channels
To Servos, Motors, Light FX& Sound Effect Playback
Wizard BoardREM Port
Connections (2-Wire)
C
C
NO
Ch-8
Ch-3
C
NO
CNO
C
NO
Ch-5
NO
Ch-7
Ch-1
Ch-3
Ch-5
Ch-7
Ch-8
Wizard BoardREM Port
Connections (2-Wire)
Wizard - 3 Controller Board
OTHERWizard / Puppet
Controllers
AB
A B
Ch-4
Ch-4
DA
NG
ER
DA
NG
ER
Copyright © 2009 Blue Point Engineering, All Rights Reserved
Ch
-1
Ch
-2
Ch
-6
Ch
-7
Ch
-8
Wire
Wire
Ch
-1
Ch-1
Ch-3
Ch-4
Ch-5
Ch-8
Ch-7
Ch-2
Ch-6
5 - 1
2
VD
C
+3G
ree
n(G
nd
)
Wh
ite
Bla
ck
Re
d
Bla
ck
CR
YD
OM
412
Phone (303) 651-3794 (MST)www.BPEsolutions.com
Custom Equipment, Unique Electronic Products
Blue Point Engineering Pointing the Way to Solutions!
Technical Twww.BPEsolutions.com
DMX 8-Channel Relay BoardNotes / Work Sheet:
Out PutAddressing
Relay -1
Relay -2
Relay -3
Relay -4
Relay -5
Relay -6
Relay -7
Relay -8
1 2 4 8 16
32
64
128
256
2 3 4 5 6 7 8 9 10ON
1
BYTE
Switch Positions(UP / Down )
UP
Down
Addressing
DMX RELAY BOARD NO:
Copyright © 2009 Blue Point Engineering, All Rights Reserved
Relay -1
Relay -2
Relay -3
Relay -4
Relay -5
Relay -6
Relay -7
Relay -8
Application
SW-1SW-2SW-3SW-4SW-5SW-6SW-7SW-8SW-9
SW-10
DMX RELAY BOARD Application:
Blue Point Engineering
Wire
Wire
NO
NO
USB Flash Drive
NO
DA
NG
ER
DA
NG
ER
Ch
-1
Ch
-2
Ch
-6
Ch
-7
Ch
-8
Wire
Wire
Ch
-1
ON
OFF
ONOFF
Addressing
Binary
=
R8 R7 R6 R5 R4 R3 R2 R1
1 = Relay ON0 = Relay OFF
DMX
Value0 1
Binary
TRM = (ON /OFF)