Upload
others
View
3
Download
0
Embed Size (px)
Citation preview
Fuel type Percent increase
Electricity 7.7
Natural Gas 33.8
No. 2 44.1
Propane 29.9
Kerosene 54.1
Gasoline 102.5
Key Costs As Percent Of Sales
Cost category Percent of sales
Energy
• Heating Fuel 5.3
• Gas/Diesel 0.5
• Electricity 1.9
• Trucking 0.8
Energy Total 8.5
Labor 24.6
Materials 32.4
Return to operator’s 11.0labor/mgt. and equity capital
Energy costs have skyrocketed in recentyears. With a whopping increase of103 percent since 2003, gasoline hasincreased the most, but other energy
types have gone up as well (see Figure 1, below).This is a constant concern for many growers.
What is the cost of energy? In a survey of 30greenhouse businesses, I looked at total costsand found their energy costs averaged 81⁄2 per-cent of sales (see Figure 2, below). Thisincludes heating fuel, gas/diesel, electricityand trucking costs.
Dealing With Rising Energy Costs
2 4 GPN M a r c h 2 0 0 7
management
Figure 1. While gasoline costs have increased the most, costsfor other types of energy have gone up as well. (Source:Department of Energy)
Figure 2. This information is based on 2003 financial data fromgrowers in the Northeast.
By Robin Brumfield
How do you deal with high
energy costs in your greenhouse?
Since profit equals price minus
cost, to increase profits, you
have to cut costs or increase
prices. This article presents
a number of options for
dealing with rising energy costs.
Fuel Increase Since 2003
*24_Brumfield.qxd 3/14/07 4:48 PM Page 24
Conserve And ReduceEnergy costs can be saved in many areas of
the greenhouse. Here are some suggestionsfor conserving energy and reducing fuel costs:
Fuel Costs• Select the cheapest fuel supplier.• Switch to a different fuel.• Use a dual fuel system.• Buy in the off season.• Consider buying on the spot market, a
possible 20-percent savings.Electricity• Inspect wiring.• Replace inefficient motors.• Replace incandescent bulbs with low-
wattage fluorescent bulbs to save two-thirds on electricity.
Trucks• Regular tune-ups save 10 percent on fuel.• Avoid lengthy idling and save 15-20
percent on fuel.• Run at the proper gear.• Consider hiring trucks or having cus-
tomers pick up products.Watering Systems• Locate hot water tanks near most freq-
uent use.• Heat to 120° F.• Eliminate leaks.
Conserve Energy With Your StructureThere are many ways to conserve energy
when it comes to greenhouse structures.While newer structures have better seals
around the coverings and openingsthan older houses, it is also possibleto make existing structures moreenergy efficient.
Double poly. Double polyeth-ylene (poly) coverings reduceheating costs about 50 percentcompared to single poly cover-ings. Polyethylene films varyfrom 35- to 60-percent heat loss.Select a film that reduces watercondensation to enhance lighttransmission and improve heatretention. Maintain proper infla-tion between layers to maximizethe covering’s insulation value.
Retrofitting. A single layer offilm over glass can reduce annualheating costs 5-50 percent, whereasa double (inflated) layer can reducecosts 40-60 percent. Remember,there is a tradeoff betweenincreased energy efficiency andreduced light transmission withadditional layers of poly. �
management
HORTICULTUREBIOSECURITY FOR
BioSafe Systems line of disease control productsprovide BioSecurity for your greenhouse, nursery andgarden center. Good sanitation and disease controlpractices can help reduce expenditures. Use ZeroTolas a high-level treatment for the control of botrytis,pythium, phytophthora, fusarium, and rhizoctonia.
BROAD-SPECTRUM PREVENTIONOF ALGAE, BACTERIAL AND FUNGAL PATHOGENS
Call us toll-free at 1-888-273-3088or visit us online at www.biosafesystems.com
� Copper-free algaecide for hard surfaces & under benches� Controls insect populations by killing their food source � Excellent application for algae control in irrigation ponds
� Eradicate moss and liverwort on contact � Uses no heavy metals or toxic residual chemistries� Provides barrier on soil to prevent re-establishment
� Chlorine alternative for re-circulating water systems � No pH adjustments / No off-gassing� Ideal for growers with high volumes of recycled water
BioSafe Systems is with you every step of the way...
Write in 704
Waste gas is an alternative fuel choice. (Photo: A.J. Both)
A single layer of film over glass can reduce annual heating costs 5-50percent, whereas a double (inflated) layer can reduce costs 40-60 percent.(Photo: Lawrence Martin)
*24_Brumfield.qxd 3/14/07 4:48 PM Page 25
working neatly around post foot-ings can reduce foundation heatloss by 50 percent. Sidewall insu-lation can reduce annual heatingcosts 5-10 percent. If possible, addwindbreaks outside the green-house along the north wall andinsulate secondary fans and ventsto reduce heat loss throughunused areas during winter.
Up to 85 percent of greenhouseheat loss occurs at night. An energy/shade curtain can reduce energyconsumption 20-50 percent. Selecta porous curtain material to pre-vent condensation from the under-side of the roof from poolingabove the plants. Keep the curtainopen during snowstorms to allowheat to reach the roof and preventsnow accumulation.
Maintain Efficient SystemsMaintaining the existing heating
system’s maximum efficiency is crit-ical to reducing heating costs. Startby checking thermostat accuracy.Aspirated thermostats placed near
CD2-Chemdose measures precise doses of chemicals every time.
Integrated Plant [email protected]
www.dramm.com920.684.0227
Perfect for precise PGR and systemic insecticide applications.
Call to learn how the CD2 can accurately dispense your chemicals.
Easy to ProgramAccurate Doses Portable
The
The Right Dose Matters!
Write in 710
Winterize openings. A tightgreenhouse with few air leaksaround vents, fans or doors willcost less to heat.
Reduce air leaks. To help reduceair leaks, caulk and weatherstripdoor frames, windows and other
openings; lubricate louvers; and sealall cracks in walls. Keep vents ingood working condition so they closetightly. Repair any holes in plastic,glass or doors and keep doors closed.
Maximize insulation. Use thehighest R-value for insulation.
Insulate greenhouse end walls,especially the north end wall thatprovides very little light for cropproduction. Installing 1-2 inches of1- to 2-ft.-deep insulation aroundthe foundation wall being carefulnot to leave gaps or openings and
2 6 GPN M a r c h 2 0 0 7
management
Install roll-up greenhouse sides for moreefficient cooling. (Photo: Lawrence Martin)
*24_Brumfield.qxd 3/14/07 4:49 PM Page 26
the plant canopy can save 2-3 per-cent of the total fuel bill byimproving fan and heater opera-tion. Solid-state electronic ther-mostats can reduce the differentialbetween the on and off modes to1° F instead of the 3-4° F ofmechanical thermostats. Calibratesensors to avoid chilling damageto the crop especially if you arelowering growing temperatures.
Perform annual maintenance:Check for physical damage to anysystem parts. Check the vent pipeand air inlet or discharge pipes forobstructions. Clean and adjust fur-naces, motors, pumps, heatingpipes and other radiation surfacesat least once per year. A one-eighth-inch layer of soot canincrease fuel consumption by asmuch as 10 percent. Periodicallycheck system performance toensure the boiler, burner and
backup systems are operating atpeak efficiency. Also check theoperation of mixing valves.
For maximum efficiency, use thesystem’s proper fuel. Insulate boileror distribution pipes in areas whereheat is not needed, and install an
horizontal air flow (HAF) fans 2-3 ft.above the plants aligned parallel tothe sidewalls of your greenhouseso the air is circulated around thehouse in a rotational pattern. HAFfans help maintain uniform �temperature and humidity, reduce
air inlet pipe for direct-firedheaters to provide fresh air forcombustion from outside thegreenhouse. Additionally, under-bench heat allows the temperatureto be set 5-10 degrees lower.
Install a sufficient number of
management
Horizontal air flow fans help maintain uniformtemperature and humidity. (Photo: A.J. Both)
Dealing with rising energy costs can be verypuzzling even to the most experienced grower.
M a r c h 2 0 0 7 GPN 2 7
For righteous growth control on a host of ornamental plants, no other product outshines B-Nine® PGR. Easy to mix and apply, B-Nine is so forgiving you can’t overdo it. Still the industry standard, B-Nine is the product of choice for new varieties and extremely effective as a tankmix partner with other growth regulators. Don’t forget the PGR that forgives like no other. Ask your chemical supplier for B-Nine, the trouble-free way to produce plants your customers will worship.
Forgiveness is Divine
Always read and follow label directions. B-Nine is a registered trademark of Chemtura Corporation.©2006 Chemtura Corporation BN-ad04-0506 CCP11606
www.pgrx.info
Write in 709
*24_Brumfield.qxd 3/14/07 4:49 PM Page 27
investment and operating costs. Here aresome examples of alternative heating fuelsand heating systems:
• Solar (hot water heating)• Other solid biomass (corn)• Biodiesel• Waste oil (fast food industry)• Waste gas (landfill/co-generation)• Geothermal (hot water/steam)• Wood (waste wood/firewood)• Hot water boilers • Hot water unit heaters• Infrared radiant systems
cold pockets and improve plant quality anduniformity.
To achieve efficient cooling, consideradding an open-roof greenhouse or installingroll-up greenhouse sides or evaporative cool-ing. Keep doors closed when fans are on.
Consider Alternative OptionsYou may want to consider changing
your primary heating system, especially ifyou have an older system. You will need toevaluate the efficiencies of a new systemversus your current system as well as the
management
Write in 706
Partial Budgeting Formula
Add: Before drop After drop Net change
Reduced Costs = 12% lower fuel costs $271,152 $238,614 $32,538
Added Revenues $0
Subtract:
Added Costs $0
Reduced Revenues = 11% less revenue $2,294,310 $2,041,936 -$252,374
Net Return or Loss -$219,836
2003 Costs As Percentage Of Sales
2003 Now Increase prices 5%
Sales $2,294,310 $2,294,310 $2,409,026
Return to labor/mgt $216,606 $134,241 $248,956and equity capital
Percent profit 9.4 5.9 10.3
Heating fuel $136,036 $196,014 $196,014
Gas/diesel $4,407 $8,924 $8,924
Electricity $33,424 $36,001 $36,001
Trucking $14,920 $30,213 $30,213
Energy total $188,787 $271,152 $271,152
Percent energy costs 8.2 11.8 11.3
Figure 3. This figure represents the partial budgeting effect of a 4° F reduction in temperature.
Figure 4. Costs as a percentage of sales in 2003, currently with an energy increase and with a 5 percent increase in prices.
Left: Burning wood is an alternative heating method. (Photo: A.J. Both) Right: Put hanging baskets over other floor- orbench-grown crops. (Photo: Lawrence Martin)
*24_Brumfield.qxd 3/14/07 4:50 PM Page 28
B & K Installations’ greenhouses and shade houses are not just engineered to stand up to the harshest weather conditions; they’re engineered to give you an advantage every day.
Our proven superior-strength construction protects your plants as much as your investment, providing thestrongest shelter from risks to your business’ productivity. From Alaska to the center of hurricane country-and any location in-between- our sales, design and engineering team will work with you and your budget.Recommending or custom-building a greenhouse or shadehouse to your requirements at a price you canafford, along with all the correct equipment that meets your specific needs. Get the advantage of a B&Kstructure today, and grow more confidently, whatever the challenges from Mother Nature.
VALUE THROUGH ENGINEERING 246 S.W. 4th Avenue, Homestead, FL 33030
T. 305.245.6968 F. 305.245.8119
Toll Free-USA 1.800.523.3870
Toll Free-Florida 1.800.624.7612
G R E E N H O U S E S • S H A D E H O U S E S • H E A T I N G • C O O L I N G • E Q U I P M E N T • C O V E R I N G S • H A R D W A R E
Visit us on the web: www.bkinstall.com
Use Space WiselyGroup plants according to tem-
perature tolerances so some housescan be run cooler than others.Consider adding higher efficiencybench or floor heating systems inroot zones of areas that requirehigher temperatures. Maximizethe use of heated greenhousespace: Keep growing areas full,and don’t bring the next green-house online until absolutelynecessary. Consider peninsular ormovable benches, install multi-level racks for low-light crops andput hanging baskets over benches.
Analyzing Costs To analyze alternative costs,
you need to know your productioncosts. This will allow you to deter-mine the impact on changes ininput costs, such as fuel, on theprofitability per unit and persquare foot. You can develop yourown enterprise budget using penand paper or a spreadsheet. A freegreenhouse cost accountingspreadsheet is available at theRutgers Farm Management Website: http://aesop.rutgers.edu/~farmmgmt.
When considering switching toalternative fuels, crops, etc.,remember to compare apples toapples. For example, compare allfuel sources on a cost-per-heatingequivalent, for example, dollarsper million Btus ($/MBtu) and
Write in 720
alternative crops on an equivalentreturn for time and space.
Consider dependability andsustainability of alternatives. Forexample when you evaluatealternative fuels, make sure suffi-cient quantities of an acceptable
verting to the new alternative andthe labor involved in operating thenew system. For example, coal andwood-fired boilers or furnacesrequire additional labor to operate, and the waste product(ashes) will need to be disposed. �
quality will be available whenneeded. If you are consideringcool-season crops, make sure youhave a dependable market forthose crops.
In addition to out-of-pocketcosts, calculate the cost of con-
management
One way to
increase costs
is to add a
fuel surcharge.
Consumers are
facing their
own increased
energy costs
for gasoline
and heating
and understand
your costs have
increased as well.
*24_Brumfield.qxd 3/14/07 4:50 PM Page 29
f i r s t c l a s s p l a n t s . c o mRequest our new catalog today!
Call 800-955-5644 or visit our website firstclassplants.com.
The Season'sGreatest Present
Poinsettias 2007
Apricot Candy�
NEW!
Christmas Carol Pink�
NEW!
Christmas Feelings Crazy�
NEW!
Write in 717
Partial Budgeting AnalysisThe partial budgeting analysis
in Figure 3, page 28, shows theeffects of lowering night tempera-ture 4° F. It reduces fuel consump-tion and, thus, fuel cost 12 percent(3 percent per degree), or $32,538,but delays crops by 11 percent.Assume delaying crops by 11 per-cent means that 11 percent fewercrops can be produced and, thus,revenue will be 11 percent lower,or a reduction of $252,374.
Using these assumptions, a 4° Freduction in greenhouse night tem-perature would result in a net lossof $219,836. This is an example ofan energy-saving alternative (low-ering night temperature) that cre-ates other problems (delayingcrops) and results in a net loss.
Reducing night temperature byjust 1° F can reduce greenhouseheating costs 3 percent. Someplants are more sensitive to lowertemperatures than others and maycease to grow when a base temper-ature is met. Consider growingcool-season plants, keeping inmind what consumers want.Avoid overcrowding and providehorizontal air movement to ensureuniform temperatures and dryfoliage. Crowding plants to reducecosts will not work if this reducesplant quality and consumerdemand. Consider using heatedirrigation water in the morning towarm the growing medium andincrease nutrient uptake.
Increasing PricesIn 2003, energy costs were 8.2 per-
cent of sales in greenhouses in theNortheast. If everything else is heldconstant and energy components areinflated based on Department of
management
Additional Energy Conservation ReferencesEnergy Conservation for Commercial GreenhousesGreenhouse Engineeringwww.nraes.org
Energy Conservation for Greenhouse Growershttp://msucares.com/pubs/infosheets/is1618.html
Greenhouse Energy Conservation Checklistwww.hort.uconn.edu
Dealing with the High Cost of Energy forGreenhouse Operations www.ext.vt.edu
*24_Brumfield.qxd 3/14/07 4:50 PM Page 30
Dazide® 85 WSG contains 85% daminozide. Dazide® 85 WSG is a trademark of Fine Holdings, Ltd.
ALWAYS READ AND FOLLOW LABEL DIRECTIONS BEFORE USE.
Dazide® 85 WSG, the new daminozide plant growth regulator
brought to you by Fine, experts in PGR technology for more than 20 years.
• Proven performance in major university trials.
• Reliable results bring improved plant quality and increased durability.
• Easy to use formulation can be applied to a wide range of ornamentals.
• Exceptional value for effective growth control.
Excellence in PGR technology
Call your distributor today to place an order!
For a list of distributors or further product information, please visit Fine Americas’ web site at
www.fine-americas.com, or call 1-888-474-3463.
plant growth regulator for ornamentals
®
85 WSG
Energy data, energy becomes 11.8percent of sales. The 2003 profit mar-gins in 2003 of 9.4 percent drop to 5.9percent with these energy costincreases. One way to recover thesecosts is to increase prices. An increaseof only 5 percent recovers all of thecosts and brings profits up to 10.3percent. (See Figure 4, page 28)
Many growers are not comfort-able increasing prices. One way toincrease costs is to add a fuel sur-charge. Consumers are facing theirown increased energy costs for gaso-line and heating and understandyour costs have increased as well.Furthermore, there seems to be aperception that greenhouse energycosts are a larger percent of salesthan they actually are, so this is agood time to add a fuel surcharge.
SummaryProfits may not be the only objec-
tive of the business. You will alsowant to analyze how these alterna-tives address the firm’s other objec-tives. Here are some questions to ask:
•Which alternative enables me to reach my objectives?
•Which alternative best matches my firm’s skills and resources (financial, technical, personnel, etc.)?
•Which alternative best meets my preferences or sense of social responsibility?
•Which alternative minimizes the creation of new problems?
•How will each alternative affect my current activities?
•How much time will be required to incorporate each alternative?
Selecting the final strategy may
Write in 713
involve trade-offs among variousobjectives. One alternative mayoffer the greatest financial returns,but it may be inconsistent withother objectives. At that point, youmust decide which objectives aremost important. GGPPNN
Robin Brumfield is a specialist in farmmanagement. She can be reached [email protected].
M a r c h 2 0 0 7 GPN 3 1
management
Reader InterestReview Please write in the appropriate number on the ReaderService Card to indicate your level ofinterest in this article.
High 1503 Medium 1504 Low 1505
Squeezing the most profits out of yourgreenhouse requires a thorough examination ofall of your expenses.
LearnMore For moreinformation related to this article, go towww.gpnmag.com/lm.cfm/gp030702
*24_Brumfield.qxd 3/14/07 4:50 PM Page 31