Upload
others
View
5
Download
0
Embed Size (px)
Citation preview
Corrosion ProtectionSystem for
Electrical Conduitand Fittings
What Does Corrosion Look Like?What Does Corrosion Look Like?What Does Corrosion Look Like?
What Does Corrosion Look Like?What Does Corrosion Look Like?What Does Corrosion Look Like?
What Does Corrosion Look Like?What Does Corrosion Look Like?What Does Corrosion Look Like?
Corrosion AgentsCorrosion AgentsCorrosion Agents
Corrosion AgentsCorrosion AgentsCorrosion Agents
The ProcessThe ProcessThe Process
820ft. sections of Black Steel Pipe are cut into 9ft.-10 inch sections
8Water and Acid baths clean rust from the conduit
8Conduit is then Threaded8Conduit is then immersed in a flux
bath to insure adhesion of Zinc to the bare steel.
The ProcessThe ProcessThe Process
8Conduit is then dipped, one piece at a time, into a vat of molten Zinc. (850 degree F).
8Threads on both ends of the conduit are cleaned by running a coupling of the same size onto the conduit.(Chasing vs. Rolling threads)
The ProcessThe ProcessThe Process
8An Acrylic phenolic coating is applied to the zinc coated conduit to facilitate bonding of PVC to the zinc of the conduit
8Conduit is then heated to 500 degrees F and rolled 2 1/4 turns through a room temperature vat of liquid PVC.(40 mils)
8Conduit is then cured in an oven at 380 degrees for 14 minutes.
The ProcessThe ProcessThe Process
82 mils of Blue Urethane is applied to the interior of the conduit and to the exterior of the threads and dried in open air.
Coating FittingsCoating FittingsCoating Fittings
8T&B, Crouse or Appleton fittings are sprayed on the inside and the outside with 2 mils of Blue Urethane.
8Fittings are then cured in an oven. (This causes the urethane to darken to a green color.)
Coating FittingsCoating FittingsCoating Fittings
8The acrylic phenolic coating is applied to the fittings to facilitate bonding the PVC to the fitting.
8Fittings are then re-assembled with the proper template, heated to 500 degrees and dipped in liquid PVC. (40 Mils)
8The fittings are cured at 380 degrees for 14 minutes to complete the bonding process.
Installation Installation Installation 8Specify Installation Criteria8Require Installation Certification
8What’s Wrong with this Picture?
InstallationInstallationInstallation
8T&B Ocal can offer Installation Training to make sure you can depend on Installations like This:
InstallationInstallationInstallation
Certificate of CompletionThis Certificate of Completion is awarded to
for successfully completing the OCAL Installation Seminar
Date
Instructor Ken Gibbon, Product Manager
The Major PlayersThe Major PlayersThe Major Players
8Rob Roy - 1961 to 20008Perma-Cote - 1974 to 20008Ocal - 1965 to 2000
** RobRoy buys Perma-Cote - 2000 **** Thomas & Betts buys Ocal - 1999 **
Recognize the PlayersRecognize the PlayersRecognize the Players
8Ocal /T&B - Blue Urethane
8RobRoy - Red Urethane
8Perma-Cote - Green Urethane
The UL IssueThe UL IssueThe UL Issue
8Properties of Zinc not investigated.
8Properties of PVC not investigated
8
Hot Dip galvanized threads on full sections of conduit
8
Spray galvanized threads on full sections of conduit
T&B T&B T&B RobRoyRobRoyRobRoy
8
We have the ability to supply custom colored PVC coatings
8
RobRoy Grey is the only color available
T&B T&B T&B RobRoyRobRoyRobRoy
8
PVC sealing flange extends to cover screw hole on form 8 fittings
8
Stainless steel cover screws on form 7 and form 8 conduit bodies are encapsulated in PVC
8
PVC sealing flange does not extend over screw holes on form 8 fittings
8
Stainless steel cover screws on form 8 conduit bodies are encapsulated in PVC
T&B T&B T&B RobRoyRobRoyRobRoy
8
Form 7 and Form 8 conduit bodies use a flat PVC flange to join cover to the fitting. 1/2” through 4”.
8
Form 8 conduit bodies use a “V Seal” to join cover to the fitting - 1/2” to 2” only. 2 1/2” and above reverts back to flat PVC flange seal.
T&B T&B T&B RobRoyRobRoyRobRoy
8Properties of zinc coating were not investigated under UL6 requirements.
•2 mil coating of red urethane applied to inside of coated fittings only
8
Properties of the Zinc coating and the PVC coating were investigated under UL6 requirements
8
2 mil coating of blue urethane applied to inside and outside of all coated fittings
Corrosion Protection
T&B /Ocal Provides SUPERIOR
T&B T&B T&B RobRoyRobRoyRobRoy