80
COMMERCIAL GAS WATER HEATERS Instruction Manual PRINTED 1012 197727-003 PLACE THESE INSTRUCTIONS ADJACENT TO HEATER AND NOTIFY OWNER TO KEEP FOR FUTURE REFERENCE. Read and understand this instruction manual and the safety messages herein before installing, operating or servicing this water heater. Failure to follow these instructions and safety messages could result in death or serious injury. This manual must remain with the water heater. MODELS BTH-120/150/199/250 SERIES 100 & 101 INSTALLATION - OPERATION - SERVICE - MAINTENANCE - LIMITED WARRANTY WARNING: If the information in these instructions is not followed exactly, a fire or explosion may result causing property damage, personal injury or death. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. WHAT TO DO IF YOU SMELL GAS: Do not try to light any appliance. Do not touch any electrical switch; do not use any phone in your building. Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions. If you cannot reach your gas supplier, call the fire department. Installation and service must be performed by a qualified installer, service agency or the gas supplier. www.hotwater.com

COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

  • Upload
    others

  • View
    4

  • Download
    0

Embed Size (px)

Citation preview

Page 1: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

COMMERCIAL GAS WATER HEATERSInstruction Manual

PRINTED 1012 197727-003

PLACE THESE INSTRUCTIONS ADJACENT TO HEATER AND NOTIFY OWNER TO KEEP FOR FUTURE REFERENCE.

����������� ������������������������������������������������������������������������������

Read and understand this instructionmanual and the safety messagesherein before installing, operating orservicing this water heater.

Failure to follow these instructions andsafety messages could result in deathor serious injury.

This manual must remain with thewater heater.

MODELSBTH-120/150/199/250

SERIES 100 & 101INSTALLATION - OPERATION - SERVICE - MAINTENANCE - LIMITED WARRANTY

WARNING: If the information in theseinstructions is not followed exactly, a fireor explosion may result causing propertydamage, personal injury or death.

Do not store or use gasoline or otherflammable vapors and liquids in thevicinity of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS:

Do not try to light any appliance.

Do not touch any electrical switch; donot use any phone in your building.

Immediately call your gas supplierfrom a neighbor’s phone. Follow thegas supplier’s instructions.

If you cannot reach your gas supplier,call the fire department.

Installation and service must beperformed by a qualified installer,service agency or the gas supplier.

��

�����������������������������������!���"��#�$%�&�

www.hotwater.com

Page 2: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

2

'������(����)�������������������������������������������������������������������������������� 25(�����������*�������)������������������������������������������������������������������ 27+�����������*�������)���������������������������������������������������������������� 29!������������*�������)������������������������������������������������������������� 30/�)����!������������*�������)�������������������������������������������������� 31(��������������*�������������������������������������������������������������������������� 34���*�������!����������+�������������(������������������������������������� 36���*�������!����������+��������'������(�������������������������������������� 37

WATER HEATER INSTALLATION��������������������������������������������������������� 38!���������'�����)�������������������������������������������������������������������� 38Supply Gas Line Installation������������������������������������������������������������� 39Gas Line Leak Testing���������������������������������������������������������������������� 40Purging��������������������������������������������������������������������������������������������� 40:������������������������������������������������������������������������������������������������ 41������;����!��������������������������������������������������������������������������� 42�<��(��=��'����������������������������������������������������������������������������� 42

TEMPERATURE REGULATION����������������������������������������������������������� 43>������*��������;�*���!�����?:!@B��������������������������������������������� 43����*�����!������������������������������������������������������������������������������� 43

!@#�C@;�+J+�:K�@�:C��)@#������������������������������������������������������� 44@=��=���������������������������������������������������������������������������������������������� 44!�����+����*�#�=��������������������������������������������������������������������� 44Q����+��������<�!�����+����*�K���������������������������������������������� 47

START UP��������������������������������������������������������������������������������������������� 52Prior to Start up�������������������������������������������������������������������������������� 52Initial Start Up����������������������������������������������������������������������������������� 52!������������V������C�������������������������������������������������������������������� 55>������������)���������������������������������������������������������������������������� 55

LIGHTING THE WATER HEATER�������������������������������������������������������� 56Lighting & Operation Labels������������������������������������������������������������� 56

TROUBLESHOOTING�������������������������������������������������������������������������� 58)�����������!��������������������������������������������������������������������������������� 58+�Z�����@��@��������������������������������������������������������������������������� 58+�Z�����@��@��������V���!����������������������������������������������������� 59@������������ ��*������������������������������������������������������������������������ 60V��������������!����������������������������������������������������������������������� 61

K�)#�:#�#!:������������������������������������������������������������������������������������ 64General��������������������������������������������������������������������������������������������� 64K�����������+��������������������������������������������������������������������������� 64'������������V���������������������������������������������������������������������������� 64V�����������������>������������������������������������������������������������������������ 65+���*����C�*=����������������������������������������������������������������������������� 65;�*��+�����C�*=��������������������������������������������������������������������������� 65������������C������������������������������������������������������������������������� 66'�����(��=��������������������������������������������������������������������������� 66(����+����*������������������������������������������������������������������������������������� 66

DIAGRAMS������������������������������������������������������������������������������������������� 67!![�\�!�������!�����[����;��������������������������������������������������� 67[�>�&]��<�&����������'�����*������������������������������������������������������� 68[�>�&^^�<�]����������'�����*������������������������������������������������������� 69!����������*���������'�����*���������������������������������������������������� 70�������������'�����*���������������������������������������������������������������������� 71

;)K)�:'���CC�#�J��������������������������������������������������������������������������� 78

TABLE OF CONTENTS+�V:�)#+��;;��)@#"�Q+:��#'�+:C()!:������������������������������������������ 3���C@(�;+������������������������������������������������������������������������������������������� 3_:#:C�;�+�V:�J�)#V@CK��)@#������������������������������������������������������� 4

�������������������������������������������������������������������������������������������������� 4_C@Q#')#_�)#+�CQ!�)@#+��������������������������������������������������������� 4>�������_���V��**� �������������������������������������������������������������������� 4

)#�C@'Q!�)@#������������������������������������������������������������������������������������� 6� ��=�������Q������������������������������������������������������������������������������� 6`������������������������������������������������������������������������������������������������ 6�!@KKq�<�[�!����!*���� ���������������������������������������������������������� 6����������V������)���������������������������������������������������������������������� 6

V:��QC:+��#'�!@K�@#:#�+���������������������������������������������������������� 7[�����@����������������������������������������������������������������������������������������� 7���(����������������������������������������������������������������������������������������������� 8+����(�������������������������������������������������������������������������������������������� 10

)#+��;;��)@#�!@#+)':C��)@#+�����������������������������������������������������11C���)��'�*������������������������������������������������������������������������������11;�����������������>�������������������������������������������������������������������� 12:x�������(�������*�������������������������������������������������������������������� 13@�������!������������*������������������������������������������������������������ 13>������������������������������������������������������������������������������������������������ 13!����������*������������������������������������������������������������������������������ 13Insulation Blankets��������������������������������������������������������������������������� 13

INSTALLATION REQUIREMENTS������������������������������������������������������� 14_���+�����+����*������������������������������������������������������������������������� 14Supply Gas Regulator���������������������������������������������������������������������� 14�����+��������������������������������������������������������������������������������������� 14K�x����(��=�������������������������������������������������������������������������������������� 15'�����������K���������������������������������������������������������������������������� 15!�����������+����*���������������������������������������������������������������������� 15����*���:x��������������������������������������������������������������������������������� 15��*�������\��������C������(��=��������������������������������������������������� 16!���������'��������������������������������������������������������������������������������� 17!* ��� ���K��������+��������������������������������������������������������������� 17!���*���������������������������������������������������������������������������������������� 17����C�Z���*���������������������������������������������������������������������������������� 18Q��������+�������������������������������������������������������������������������������� 18!������+������������������������������������������������������������������������������������ 18V���������@��������V��!������+��������������������������������������������� 19@�����������������@�������������������������������������������������������� 19@��������������@���@��������������������������������������������������������� 19@�����������������>��������'����������������������������������������� 19@�����������������(��������'���������������������������������������������� 20����V�*�@�����)����+��������������������������������������������������������������� 20

)#+��;;��)@#�C:`Q)C:K:#�+�\�!@KK@#�:�;�>�@V�K�++�!>Q+:��+������������������������������������������������������������������������������� 21(:#�)#_�)#+��;;��)@#�������������������������������������������������������������������� 22

_�������(�������)���*����������������������������������������������������������������� 22_�������(�������)��������������������������������������������������������������������� 22[�>�&^^�<�]���)����������!����������������������������������������������������� 23(�������C�Z���*�������������������������������������������������������������������������� 24(�������)�����������+�Z�������������������������������������������������������������� 25�����(����)������������������������������������������������������������������������������� 25

Page 3: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

3

SAFE INSTALLATION, USE AND SERVICE

���������������������"�����������=������������������������������x���*�����*������������������������������������������K����������\��������*�������������������������=�� ������=�������������*����������������������������������������������������������������{������������C�������� ��������������*�����������������������������������*�������)�����=�����*����������������*���������������������*������������������ ������������������������"���"������=����������������������

�����������*������������������������������� �������������������"�������������������������������������������*������"�����������=����������������{�������!���������+����'�������������������x���:�����*����������Z���������_=�������!������������ ��������������� ������������� �� ����+�������!��������� �������������"� ������������"�������� ��������=�����*"����� ��Z����� ��������� �������������������x������������ ��������������������������������*����������������+�������!����������������������"� ������������"����������������=�����*����������������������������������=����x��������*��������� ��������������������������

DANGER

WARNING

CAUTION

CAUTION

DANGER indicates an imminentlyhazardous situation which, if not avoided,will result in injury or death.

This is the safety alert symbol. It is used to alert you topotential personal injury hazards. Obey all safetymessages that follow this symbol to avoid possibleinjury or death.

WARNING indicates a potentially hazardoussituation which, if not avoided, could resultin injury or death.

CAUTION indicates a potentially hazardoussituation which, if not avoided, could result inminor or moderate injury.

CAUTION used without the safety alertsymbol indicates a potentially hazardoussituation which, if not avoided, could result inproperty damage.

APPROVALS

NOTE:� �+K:� ���������� ��� ������� �� ���� ���������������=�������������*�����

Page 4: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

4

PRECAUTIONS'@�#@��Q+:��>)+����:C�>:��:C�)V��#J���C��>�+�[::#�Q#':C����:C��)**����������������Z����������=������������� �������� ��������������������� ��*�����������*������������������������� ����������x��)��������������x������������������"������������������������� ���� �������=�� ������ ��=�� ���� *���� �� �� Z�����������=�����������

&�� :x�����������

]�� '�*����

$�� V������������������

GROUNDING INSTRUCTIONS������������������*��� �������������������������������#�������:����������!������~�������������������*��� ��������� ��� ���� ������� V������ �� ����� ����� ������ ���������������*�������������������������������*����������

������������������*��� ����������� �����������*����"����*������ ������� �����*�� �� ��� �Z��*���� ��������������� *��� �� ��� ����� ���� ������� �������� ������������� �� ���� �Z��*���� �������� ���*����� �� ����� �������������������

HYDROGEN GAS FLAMMABLE

Explosion Hazard

Flammable hydrogen gasesmay be present.

Keep all ignition sources awayfrom faucet when turning onhot water.

>������� ���� ���� �� ������� ��� �� ��� ������ �����*� ���=��� �� ������������������ ������������ �������� ����� ��������������*�� ?���������� ��� ������ �� *��B�� >������� ���� ��� �x���*������**� �������������������������{����������������������"����������**�������������������������������=��� �������������������� �������������=�����*������ ����������������������������������������������������������������*��)���������������������������������� � ��� �������������������������������������������������������������� ������������THERE SHOULD BE NO SMOKING @C�@�:#�V;�K:�#:�C��>:�V�Q!:������>:��)K:�)��)+�@�:#��

GENERAL SAFETY INFORMATION

Read and understand this instructionmanual and the safety messagesherein before installing, operating orservicing this water heater.

Failure to follow these instructions andsafety messages could result in deathor serious injury.

This manual must remain with thewater heater.

Water temperature over 125°F (52°C)can cause severe burns instantlyresulting in severe injury or death.

Children, the elderly and thephysically or mentally disabled are athighest risk for scald injury.

Feel water before bathing orshowering.

Temperature limiting devices such asmixing valves must be installedwhen required by codes and toensure safe temperatures at fixtures.

Explosion Hazard

Overheated water can causewater tank explosion.

Properly sized temperature andpressure relief valve must beinstalled in the opening provided.

Verify the power to the water heater is turned off before performing any service procedures.

Improper installation, use and service may resultin property damage.

Do not operate water heater if flood damaged.Inspect anode rods regularly, replace if damaged.Install in location with drainage.Fill tank with water before operation.Properly sized thermal expansion tanks are required on allclosed water systems.

Refer to this manual for installation and service.

CAUTION

Page 5: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

5

GENERAL SAFETY INFORMATION

Fire Hazard

Do not install water heater oncarpeted floor.Do not operate water heater ifflood damaged.

For continued protection againstrisk of fire:

Fire or Explosion Hazard

Read instruction manual beforeinstalling, using or servicing

water heater.

Avoid all ignition sources if you smell gas.

Do not store or use gasoline or other flammable vapors andliquids in the vicinity of this or any other appliance.

Use only the gas shown on the water heater rating label.

Keep ignition sources away from faucets after extendedperiods of non-use.

Maintain required clearances to combustibles.

Do not expose water heater controls to excessive gaspressure.

Do not obstruct water heater air intakewith insulating blanket.Gas and carbon monoxide detectorsare available.Install water heater in accordance withthe instruction manual.

Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.

Breathing Hazard - Carbon Monoxide Gas

Property Damage Hazard

All water heaters eventually leak.

Do not install without adequate drainage.

CAUTION

Fire and Explosion Hazard

Leak test before placing thewater heater in operation.Disconnect gas piping and maingas shutoff valve before leaktesting.Install sediment trap inaccordance with NFPA 54.

Use joint compound or Teflon tapecompatible with propane gas.

Fire and Explosion Hazard

Turn off gas lines during installation.Contact a qualified installer or serviceagency for installation and service.

Excessive gas pressure to gas valve cancause serious injury or death.

Do not use water heater with any gasother than the gas shown on the ratinglabel.

Turn off power to the water heaterbefore performing any service.

Electrical Shock Hazard

Label all wires prior to disconnectingwhen performing service. Wiring errorscan cause improper and dangerousoperation.

Verify proper operation after servicing.

Failure to follow these instructions canresult in personal injury or death.

Jumping out control circuits or components canresult in property damage, personal injury or death.

Service should only be performed by a qualified serviceagent using proper test equipment.Altering the water heater controls and/or wiring in any waycould result in permanent damage to the controls or waterheater and is not covered under the limited warranty.

Any bypass or alteration of the waterheater controls and/or wiring will result

in voiding the appliance warranty.

Altering the water heater controls and/or wiring in any waycould result in altering the ignition sequence allowing gas toflow to the main burner before the hot surface igniter is atignition temperature causing delayed ignition which cancause a fire or explosion.

Page 6: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

6

������J� ��� ���������� ����� ������ �������� �������� ��������������*���������"�����������=�������������� �����������=����

ABBREVIATIONS USED

� ��=�������������������)���������K��������������� �#+)�\��*�������#�������+���������)��������� �+K:�\��*�������+��������K����������:���������� �>C)�\�����!���������"�>�����������C������������)��������� #:!�\�#�������:����������!���� #V���\�#�������V������������������������ Q;�\�Q������������;� ������� !+��\�!��������+������������������

QUALIFICATIONS

QUALIFIED INSTALLER OR SERVICE AGENCY)����������� ���� ���=���� �� ����� ������ ������� ��Z����� � �������Z�=������ �� ����� �� �� `�������������� ?��� ������� ���#+)� ���B���������������=�=����)���������������������������* ���"����������"�=������"��������������������������������������Z������������������������������������������������������*�������=����ANSI Z223.1 2006 Sec. 3.3.83:� �`������� �������� \� ���������=����"���*"�������������*������������������������������������������������=������������������������������ ������?�B����� �����������"� ���������� �������*������������������� ? B� ������������"������������"��������"�������������=������������������������Z��*��������������x��������������������������������*���������������������������Z��������������������*���������������������Z���*���������������������=����{�����������)�����������Z�������?���������� ���#+)�� =�B���������������� ��������� ��� ��Z����� �� ���� �������� ��=���� {������������ �����*� �� ��=��� ����� �� ��� ����*��� �� �����*� ���� �� ������������������� ��� ��� �����*������ )����������������������� �������������=��� ��� �����*��������������*��� �������*�����������������������������*�����

ICOMM™ & BACNET COMPATIBLE

����� ������ ������� ��� �*���� ��� ����� ���� �!@KKq� ��*���*�������� �����*�� ���� �!@KKq� �����*� ��������� ����*�������� � ���=���� ������������������������ )�� ����������� ��*����� ��������� ���������"� ���������� ���� ������� ����� �������*����������� ����������� �!@KKq� �����*� ���� ��*��������� ������ ������������������ =��� �*���� ���~�� �������� ����� ��x�� *�������� ��������������� ��*���������������������!�������������!@KKq������*��������������*���� ��������[�!�����*�����������=����� ������� ���� ������� *�����*���� �����*��� V��*�������*��������������^]�\$%�]�

PREPARING FOR THE INSTALLATION

&�� C���������������*����� ���������*�������������������������������������������������������������������_�������+������)���*������������/�������� )��������� ����� ���������������"������������������*���������������������)���������������������*���"���{������~������������� *����� �������� ����������� ��� ���� �����������"��������"� ���� *����������� �� ���� ������ �������� )�� ��������������������������������*������������*������������ ���������������������������������������������������������������������������������������������������������������

INTRODUCTION'��������������������������*����������������������*������������ ������*�� ����� ���=�� �� ��=���� ���� ���������� ����� ������������� )�� ��� ���������� ����� ���� =������"� ������ ������"� ���������������������� ������������������������������ ��������� ����� �� ��=��� �� ���� �������������� ����**������ ��� ���� �������� ���������� ��� ���� �������������*�����������������������������������������������������������������������������������*�������������������������������������������V�����������!*��������������%���������*������Q���������������������������������������=������*��������������������������+�������)�����������!��������������� ��������������������[������������������������������*��� ��� �����*����*�������������� ��{��*����� ���� �=��� ����������� ���=����������� >��=��"� ���=���� ���� ���������� ��������� ��������� �������*��� ����`�������+��=�����������NOTE:� !���� �� ������� ������������ ������ ���� ��� �=����������������*��������������

]�� [�� ���� �� ���� ��� ����� ����� ������� �� �� ����� ��������������������*���������������������#�=�������������������*�����������������������������������������������

$�� ����������������*�������*�����������������������������������*��������������������������������=����{����������������� ������ �� ��������� ������� ��� ���� ������� ������������=���� {���������� ����� �� �������� ����� ������������ �����������������������Z������������������*�����������������"����������������������)�� ����� �������� ���������"� ���� ������������*����*����������������������������������#�������V���_���!��"��#+)��]]$�&~#V����/���������#�������:����������!��"�#V���%����!�#~!+�\[&/^�&"�����#������_��������������)�����������!��� ���� !+�� !]]�&"� ���� !�������� :���������� !���� ������*����� ���� �=���� ��� ��*� ���� !�������� +������������������"����&�:�������������(������C��"�!��=�����"�@>�//&$&��#V�����*��������������=���� �����*�����#�������V���� ��������� ���������"� &� [������*����� ����"� `����"�K���]]�^�

/�� )�� ������ �������� ����� *����� �� ��=�� ���� Z������� �� ����� ���������� ���� ������ �� ���� ����������"� ����� ���� ����������* ��������� �����=����� �����*����� ��� ����������������������)����������x������������Z���"����������=����������K���"�+����������+�������* �����������������������������������������=���� �������������������������������*��������������������������������������������� ���

��� !������������� ���������*������ ������������������:x�*��������������������������������*�����������������Z���*�������� ;����������� ������ >������ �� ����� &]� ���� ���� C���)��'�*��������������&&�

��� V�����������������!���������������������������*��� �� �������������������=�������������*=������������������Z�����+��� ����������� ��� ������� ������������ ����������)���������� *��� �� ������� ��*� !��������� @����� �� ����+��������������"�&&�]�`�+�����"�+�����&��"�+����*���"�!��^��&&�

%�� K������������ !��� ��Z����� ����� ������ ������� �� ������������������������������K������������]/�\!KC�]�����+�������* ����!�������]/�\!KC����+���!**����������K�������������������]&�

Page 7: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

7

BASIC OPERATION

���� ������ �������� �=����� ��� ����� *����� ��=�� �� �������� �����������������x�������� ����� ���� *������ ��� ��������������������� ������ ��������� K���� [����� ��� �� ������� ������� ����"� ������ *����� �� ���� ��� ���� ����� �������� ������ ���� ������x������������������������������� ��������� ���������������������� ������ ���� ����� �x�������� ����� �������� ���� �x��������������x����~=��������������������������� ��*���������������������+���V�����&�����V�����]�

BLOWERBURNERASSEMBLY

MAINBURNER(radial design)

HEATEXCHANGER

INTAKE AIR(combustion air)CONNECTION3 INCH PVC

HELICALCOIL

VENT (exhaust)OUTLET

Figure 1

FEATURES AND COMPONENTSBLOWER/BURNER ASSEMBLY DETAIL

199,000 & 250,000 Btu/hr MODELS

HOT SURFACEIGNITER

120,000 & 150,000 Btu/hr MODELS

COMBUSTIONBLOWER

FLAMESENSOR

MAINBURNER(radial design)

BLOWERFLANGE

INTAKE AIR(combustion air)CONNECTION3 INCH PVC

HOT SURFACEIGNITER

COMBUSTIONBLOWER ASSEMBLY

FLAMESENSOR

MAINBURNER(radial design)

BLOWERFLANGE

INTAKE AIR(combustion air)CONNECTION3 INCH PVC

Figure 2

Hot Surface Igniter���������������*����������� ����>��+������ )������������&]��(�!� ������ ���� �������� ���*� �� ������� ����� ���� �������� ������������������������������������"��&����V�?�^�]�!B"��������������K����[�����NOTE:�!����*��� ���������������������������������������=���� ��������Flame Sensor���������������*�����*������������*��������������*�����*��������������������K����[������)������*��������=�������������������������������������?$\��������B����������������*������ �**��������� ��\��������� ���� ]/� (��� _��� (��=��� +��� ����+�Z�����@��@��������V���!�������������^�

Page 8: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

8

&���(�������������?�x������� �B�\�$�������(!�&&��!* �����[�����&]��[������:x�����?=���B���������#�*������������������������

��������������������������������������������������������:x����� ?=���B����������������� �� ����������������� ���������������������������������*�*������ ������������������������� ��� �������� �������� ��� ���� �������� ���� ���� ������ ����������������

&$��[�������=�����������#�*�������������������������������������������������������������������������������!* �����[����� ��� ��������� ��������� ���� ������ �����*� *������������������������������� ������������������� ��� ���������������� ������ ����� ���� !* ����� [����� ��� ���������� ������ ���� ��*�� ������ �� �������� ������� +��� +�Z����� @��@������������������

&/����*�������\�������� C������ (��=��� +��� ��*�������\��������C������(��=���������&��

&���Q�������*���������� �"�&���]� ��*���������� ����������������������������������*�*������������� �������������������*�������������������������������������������������Q�������*���������� ���������������:!@�?���������� �B� ������������� ��� �� ��� ��{��� ��� ����� ��*����������*��� ������������ :!@� ������� �������� ���� ��*����� �������������������������*��������������+���>������*��������;�*���!�����?:!@B��������/$�

&�����������������������&�&~]��#���&%��Q)K�?���� ����������*���B������Q)K� �������� ������������

������� ���"� ���� ������ �����*��� ;!'� �������� �������������� ������Q��������{���=����������������������=������������������*������+���!�����+����*�@���������������//�

TOP VIEWS

3

2

4

5

6 8

10

12

112

13

14

16117

15

97

FRONT

120,000 & 150,000Btu/hr MODELSTOP VIEW

BTH 120 & 150 COMPONENTS&�� ������>��������&]��(�!��~����������]�� ������� ����� ����� ���� ������ ��������� �=����� ��� �����

*����� ���� �Z������ ����� ������� ?��� ����������B� �������?�B������[�>�&]��������������������"����������*������������=�������������=���������������� �����������������*�������������*�������������������������������������������������� ���� ������ ���������� �� ����������=�����������������������������������������*�����������������=���������?������B������������������*������������������������

$�� !������� !����� [���� ?!![B� ��������� ����� ������������� ���� ������ �����*��� *���� ������� ����� ���� !![���������� ������ ��*�������� ���� ������� ���� ������ ��������������"�����!�����+����*�@���������������//�

/�� )�������������������\�$�������(!���� &]��(�!� {������ x�� )��*������������������������

��������������*����������+��������+������������&/���� ���������������]/�(���_���(��=��%�� +����� ���� ����� ���������� +��� ���� ��Z���*����� ��� ����

_���+�����+����*���������&/���� ;�� _��� �������� �������� #�*����� ���� �������� �����

����� �� �� ����� ��� ��������� ����� ������� ��� ���� �� ������������ ���� �������� ��� � =�� *���**� ��Z���*���������������������*�*������������������������������� �����������������������������������������������������������������+���_�����������C�Z���*����������� ���$��������&]�

^�� [������ )������ ���� �������� #�*����� ������ �������� ��������������������������������������������������������������?�* ����B� ���� �� ���� ������ ������� ��� ��� ������������ ���������������*�*������������������������������� ����������������������������������������������������������������

Figure 3

Page 9: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

9

_�����������C�Z���*����������� ���$��������&]�&���(�������������?�x������� �B�\�$�������(!�&&��)�������������������\�$�������(!�&]��[������:x�����?=���B���������#�*������������������������

��������������������������������������������������������:x����� ?=���B����������������� �� ����������������� ���������������������������������*�*������ ������������������������� ��� �������� �������� ��� ���� �������� ���� ���� ������ ����������������

&$��[�������=�����������#�*�������������������������������������������������������������������������������!* �����[����� ��� ��������� ��������� ���� ������ �����*� *������������������������������� ������������������� ��� ���������������� ������ ����� ���� !* ����� [����� ��� ���������� ������ ���� ��*�� ������ �� �������� ������� +��� +�Z����� @��@������������������

&/����*�������\�������� C������ (��=��� +��� ��*�������\��������C������(��=���������&��

&���Q�������*���������� �"�&���]� ��*���������� ����������������������������������*�*������������� �������������������*�������������������������������������������������Q�������*���������� ���������������:!@�?���������� �B� ������������� ��� �� ��� ��{��� ��� ����� ��*����������*��� ������������ :!@� ������� �������� ���� ��*����� �������������������������*��������������+���>������*��������;�*���!�����?:!@B��������/$�

&�����������������������&�&~]��#���&%��Q)K�?���� ����������*���B������Q)K� �������� ������������

������� ���"� ���� ������ �����*��� ;!'� �������� �������������� ������Q��������{���=����������������������=������������������*������+���!�����+����*�@���������������//�

3

2

4

5 6

8 10

12

11

2

13

14

16117

15

97

FRONT

199,000 & 250,000Btu/hr MODELSTOP VIEW

BTH 199 & 250 COMPONENTS&�� ������>��������&]��(�!��~����������]�� �������������������������������������=�������������

*����� ���� �Z������ ������� ?��� �����������B� ���������� ���� [�>� &]�� ���� ��� ������� ����"� ���� �����*����� ����� ��=�� ���� �������=�� ������� ��� ���� �� ���������� �����*� �� ���� ������*� ���������� ��� ���� ���� ������������������������������������������������������� ������=�� �������� ������� ���� ������� ����� ��������*�����������������=���������?������B������������������*������������������������

$�� !������� !����� [���� ?!![B� ��������� ����� ������������� ���� ������ �����*��� *���� ������� ����� ���� !![���������� ������ ��*�������� ���� ������� ���� ������ ��������������"�����!�����+����*�@���������������//�

/�� :[K�!* �����[���������* ��� ��������(V'�?=���� ������Z��������=�B"�_���(��=������(��������������������*�

��� &]��(�!� {������ x�� )��*��������������������������������������*����������+��������+������������&/�

��� ���������������]/�(���_���(��=��%�� [������ )������ ���� �������� #�*����� ������ �������� �����

���������������������������������������������������������?�* ����B� ���� �� ���� ������ ������� ��� ��� ������������ ���������������*�*������������������������������� ����������������������������������������������������������������

��� +����� ���� ����� ���������� +��� ���� ��Z���*����� ��� ����_���+�����+����*���������&/�

^�� ;�� _��� �������� �������� #�*����� ���� �������� ���������� �� �� ����� ��� ��������� ����� ������� ��� ���� �� ������������ ���� �������� ��� � =�� *���**� ��Z���*���������������������*�*������������������������������� �����������������������������������������������������������������+���

TOP VIEWS (CONT)

Figure 4

Page 10: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

10

^�� ��*�������\��������C������(��=�����������������\������<��(��=��'��������������C�Z���*�������������&��

&���;������*���������� �"�&���]� ��*���������� ����������������������������������*�*������������� �������������������*��������������������������������������������

&&�������������������\�&�&~]��#������������&]���������������������=��=��&$��+����� ���� ����� ���������� +��� _��� +����� +����*�� ��

�����&/�&/��;��_�����������������"��������������������� ���������

�� ����� ��� +��� _��� �������� C�Z���*����� ���� �� ���$��������&]�

&���(�������������?�x������� �B�\�$�������(!�&���!�������������������&~]�������(!�����������������+���V�����

^��������&%�����!���������'�����)������������������$��

SIDE VIEWS

&�� !������ ������� �����"� �=���� ������ ������� ��������������

]�� !![���������\����� ��������������������������������

$�� )�������������������\�$�������(!�

/�� �������������]/�(���_���(��=��

��� !* �����[�����

��� ����������������\�&�&~]��#������������

%�� Q)K�?���� ����������*���B������Q)K� �������� ������������������� ���"� ���� ������ �����*��� ;!'� �������� �������������� ������Q��������{���=����������������������=������������������*������+���!�����+����*�@���������������//�

��� ��*�������\�������� C������ (��=��� +��� ��*�������\��������C������(��=���������&��

1

2

23

4 56

7

8

9

10

11

12

LEFT SIDE120,000 & 150,000 Btu/hr MODELS

RIGHT SIDE199,000 & 250,000 Btu/hr MODELS

45 1314

15

16

3

Figure 5

Page 11: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

11

ROUGH IN DIMENSIONS

INSTALLATION CONSIDERATIONS

FRONT BACK

CLEANOUT

T & P VALVE

3/4” NPT DRAIN

1 1/2” NPTWATER INLET

VENT CONNECTION3 INCH PVC

(exhaust elbow)

CONDENSATEDRAIN CONNECTION

1/2 INCH PVC

INTAKE AIR CONNECTION3 INCH PVC

SUPPLY GASCONNECTION

E

H

D

CA

I

G

FB

WATER OUTLETHEIGHT

These designs comply with the current edition of the American National Standard for Gas Water Heaters, Volume III, ANSI Z21.10.3 / CSA 4.3as an automatic circulating tank water heater, and automatic storage water heaters.

120,000 & 150,000Btu/hr

MODELS

199,000 & 250,000Btu/hr

MODELS

* Center line of water outlet on top of the water heaters is approximately 7 inches from the front edge of the water heater.

TOP VIEWS

45°

18°

CLEANOUT

T & P VALVE

DRAIN

VAL VE

45°

35°

64°

*1 1/2” NPTWATEROUTLET

SUPPLY GASCONNECTION

VERTICAL

FRONT

INTAKE AIR3 INCH PVC

VENT

3 IN

CHPV

C

35°

22°

68°

45°

18°

45°

CLEANOUT

T & P VALVE

DRA

IN VALVE

*1 1/2” NPTWATEROUTLET

FRONT

INTAKE AIR3 INCH PVC

GAS

VENT

3 IN

CHPV

C

MODEL

DIMENSIONS SHIP

WEIGHT

STD

SHIP

WEIGHT

ASMEA B ! D E V G H I

)#!>:+~!K )#!>:+~!K )#!>:+~!K )#!>:+~!K )#!>:+~!K )#!>:+~!K )#!>:+~!K )#!>:+~!K )#!>:+~!K ;[+~�_ ;[+~�_

BTH 120 $~%��] ]%�%�~%��� ��$~&� $�~���^ ����~&/& /�~&]&�^ &&~]%�^ /]~&���% /%��~&]��� /��~]�� /^�~]]]

BTH 150 $~%��] ]%�%�~%��� ��$~&� ����~&/& %���~&^&�� ����~&%/ &&~]%�^ �$~&�� �^~&%��$ ���~]�] �^�~]%�

BTH 199 $~%��] ]%�%�~%��� ��$~&� ����~&/& %���~&^&�� %���~&^&�� &&~]%�^ �$~&�� �^~&%��$ ���~]�] �^�~]%�

BTH 250 $~%��] ]%�%�~%��� ��$~&� ����~&/& %���~&^&�� %���~&^&�� &&~]%�^ �$~&�� �^~&%��$ ���~]�] �^�~]%�

Figure 6

Page 12: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

12

STORAGE CAPACITIESTABLE 2MODEL Q��+��_�;;@#+ LITERSBTH 120 60 227

BTH 150 100 379BTH 199 100 379BTH 250 100 379

GAS LINE CONNECTION SIZETABLE 1† MODEL SERIES NATURAL GAS PROPANE GASBTH 120 &��~&�& $~/��#�� $~/��#��BTH 150 &��~&�& $~/��#�� $~/��#��BTH 199 &��~&�& $~/��#�� $~/��#��BTH 250 &��~&�& $~/��#�� $~/��#��

��'��������������������������Z�=������������"����~�������* ������������������������"�������������������������*�����=���� ������������ ���������*���**���Z�����������\�����_���;����+�������������$^�

��� ;����������������������������������Z���������������������� ����* ���������=�������������� �� ��������+�������C�Z���*������������&��

^�� ;��������������������������������=�������������������������"������ ���������"� ����� ��*���� ������� ���� *�x�**� �Z�=����������������������+���(�������C�Z���*������������]/�

&���'� ��� ������ ���� ������ ������� ������ ����� ?���� ������� !* ����� [����B� ������ ��*��� �������� ����� �� {������ ��������{������������

&&��'� ��� ������ ���� ������ ������� ������ ���� � ��Z���������������� �� ���� =���� ?�x����B� �� ������� ���� ���*������������ �� {������ ��� ��� �� ����� ��� ���� ���*������?�B����������������������������������������*�����������������+���(�������)������������������]]�

Fire or Explosion Hazard

Read instruction manual beforeinstalling, using or servicing

water heater.

Avoid all ignition sources if you smell gas.

Do not store or use gasoline or other flammable vapors andliquids in the vicinity of this or any other appliance.

Use only the gas shown on the water heater rating label.

Keep ignition sources away from faucets after extendedperiods of non-use.

Maintain required clearances to combustibles.

Do not expose water heater controls to excessive gaspressure.

LOCATING THE WATER HEATER

!�������� ����� �� ������� ��� ���� ���� ������ �������� ���������*���������=�����*������������������������������������������������������ ������������������*������*����������������������������

Property Damage Hazard

All water heaters eventually leak.

Do not install without adequate drainage.

CAUTION

����������������������x������������������������������������������������������������������ ���=�����������������������������&�� �����������������*��� ���������������]�� �����������������*������ ����������������������������������

��� {�����������������*���������$�� ;����������������������������������������������� {������

�����������*���� ����*=����=�������/�� ;����������������������������=������������� ;�������������������������������������������������������������

����������������������������������������������������������������������������*�����������������{���������������������������������������������������������������������������� ���=����"����������**�������������*��������������"����Z�������������"� ����������������������������������

��� ;����������������������������������������*�{����������������%�� ;����� ���������������������� ����&]��(�!�������������

+��������+������������&/������Z���*�����

GAS PRESSURE REQUIREMENTSTABLE 3MODEL K�#)V@;'��C:++QC: K)#)KQK�+Q��;J��C:++QC: K��)KQK�+Q��;J��C:++QC:

NATURAL GAS PROPANE GAS NATURAL GAS PROPANE GAS NATURAL GAS PROPANE GASBTH 120 /�����!��?&������B &������!��?]�/^����B /�^�����!��?&�]]����B &&�����!��?]�%/����B &��������!��?]��]����B &/�����!��?$�/^����B

BTH 150 /�����!��?&������B &������!��?]�/^����B /�^�����!��?&�]]����B &&�����!��?]�%/����B &��������!��?]��]����B &/�����!��?$�/^����B

BTH 199 ������!��?�����B ������!��?�����B /�^�����!��?&�]]����B &&�����!��?]�%/����B &��������!��?]��]����B &/�����!��?$�/^����B

BTH 250 ������!��?�����B ������!��?�����B /�^�����!��?&�]]����B &&�����!��?]�%/����B &��������!��?]��]����B &/�����!��?$�/^����B

RECOVERY CAPACITIESTABLE 4

U. S. GALLONS/HR & LITTERS/HR AT TEMPERATURE RISE INDICATED

K��� Type ofGas

Input �V $��V /��V ���V ���V %��V ���V ^��V &���V &&��V &]��V &$��V &/��V[�~�� kW �! &%�! ]]�! ]��! $$�! $^�! //�! ���! ���! �&�! �%�! %]�! %��!

BTH 120 Natural &]�"��� 35 GPH 461 345 276 230 197 173 154 138 126 115 106 99Propane LPH 1744 1308 1046 872 747 654 581 523 476 436 402 374

BTH 150 Natural &��"��� 44 GPH 576 432 345 288 247 216 192 173 157 144 133 123Propane LPH 2179 1635 1308 1090 934 817 726 654 594 545 503 467

BTH 199 Natural &^^"^�� 58 GPH 767 575 460 384 329 288 256 230 209 192 177 164Propane LPH 2904 2178 1743 1452 1245 1089 968 871 792 726 670 622

BTH 250 Natural ]��"��� 73 GPH 960 720 576 480 411 360 320 288 262 240 221 206Propane LPH 3632 2724 2179 1816 1557 1362 1211 1090 991 908 838 778

C��=������������������� �������^�������*�������������

Page 13: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

13

���������������������������� ����������������������������������������������*�"�����������������������������������"��������**� ��� ��Z���� �� ������� ���=��� �Z��*���� �� =�������� ���������"���������������������V��**� ���=������������=���������=�������������������*��� ���������� �������������������������������K����[�������*�����������������x�������V��**� ������*�"���������������������������������������������������������������*�����=��� ���������������{������ �������������������CLEARANCE TO COMBUSTIBLE MATERIALS���� ������ �������� �=����� ��� ����� *����� ���� ����=��� ������������������* ��� ���������������������������* ��� �����������* ��� �������������*��������� ����� ��������� ���� ������������������������������������������������������������������=���������������������������=��NOTE:����Z��������������������=����������� ��*������������������������������+���+��=����!��������� ����

TOP VIEW

0

00

ALCOVE

FRONT VIEW

CLEARANCES TO COMBUSTIBLEAND NON COMBUSTIBLE

CONSTRUCTION MATERIALS

WATERHEATERFRONT

TOP COVER

FRONT

Figure 7

SERVICE CLEARANCE�����=����������������]/��������?�&��*B������ ��*������������*� ���=���� ��� ������ ���� ��� �����<�� =��=�"� ������ �����*��*������"�����=��=�"���������������"�������=��=�"������=�������������?�x������� �B��������������������������;��=�����*��� �*� ��� ���� ��� � =�� ���� ������ ������� ���� ����� �����x������� �����������������+���V�����^��������&%�INTAKE AIR AND VENT PIPE CLEARANCES����*���**�������������*��* ��� ���*����������������=����?�x����B����������������������������� ������������(�����������������������������������������* ��� ������������������*��� ��������������?��{����B�

EXTENDED VENT TERMINATIONS

�������������������=����� �������*��������� �����������������$��������������������������������~��=�����������������*�x�**�������Z�=�����������?&��]�*B���������������������~��=��������������� ���x�����������&]���Z�=�����������?$����*B� �������������/������������+�������(�������C�Z���*������������]/������ ������ ������� ������ ��*� ���� ������� ����� ��� ?]B� $� ��������*�������� ����� ���� /��� �(!� �� ��� ����� �� �� ���� �����������������������/�������������������=���������������������"����������������/���������*��������*��� �������!�������������������� ��������������������������*����������* ���������������� �����=����������*������������/���������*������?�B�

OPTIONAL CONCENTRIC TERMINATIONS

�������������������=�������������*��������� �����������������'������(������������������������������������������*���������+���!������������*�������)������������������$��

HARD WATER������ ����� ������ ��������� �x���"� ������ ��������� �� ������������� ����� �� ������ �����*���� ��� ���**������� ����� ������������ ���� �����������"� ������ ���"� ������ �������"� �����������������������Z��*�����+���K�������������������/� �������*����������*����������*=������������

CIRCULATION PUMPS��������������*���������������������*���Z�������������������������������������������������������{�����������������������������+��� �����������������'�����*�� ����������������%&�������������������������������������*����

+��� !��������� �*�� ������� '�����*�� �� ����� %�� �������������� ���� ����*������ )������� ��� ���������� ����� �������������������� ����#�������:����������!��"�#V���%���� ����!��������:����������!��"�!+��!]]�&�

���\ ����� ����������� �*��� ���� ���**������ ��� ���� ������**���������������������

+*��������������*�������*���������������������� ����������������� ��Z���� ������� � ���������+*��������������*���*��� �� ������������ ������ C����� �� ���� �*�� *��������������������������� ����������Z���*�����

INSULATION BLANKETS

Do not obstruct water heater air intakewith insulating blanket.Gas and carbon monoxide detectorsare available.Install water heater in accordance withthe instruction manual.

Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.

Breathing Hazard - Carbon Monoxide Gas

)�������� �������������=���� ������������������ ��������x���������� �� ���� ������ �������� �� ���� ��� ���������� ����� �������������������������������������� ��������������������������� ������� �������������������������� ���������������������������������=����� �������*�����*�������x���������:����������������������������������������������������������� �������������Z���*����"�*������������������ ������������������

+���� �� ����� �� ������ ��� ��������� ������� �� �����������"� ������� ����� ������ ������������+��� ����V����������� !*������� ������� �� ����� *����� ��� ������������� ���*�������*�������� �����V��������������������������������������������������������Z���������������* ����"���������������������������"������x�����"�����������������{�����������

�� DO NOT�������������������������������������������"������������������������������������������������ ���������* ���

�� DO NOT��=������������������*�;!'��������������������������� DO NOT��=���������*�������\��������C������(��=���� DO NOT��=�����������������*�������������������������������

������������������� ���������������������� DO� ����� ���� �������� ���� ���������� �� ���� ��*� ����

*���������� ��� �����*���� �� ���� ������� ��������� =��� �����x��������� ����

�� DO� �������� ���� ��������� ������� ���Z������ ��*������������ �������������"������ �� ����������* ������������

Page 14: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

14

&�� �����=�����\�����������������������*��� �������������� =�����������[�~����������������������������������������

]�� +��������������������������=��������������������������������������������*���**�����������������������������������������������������+����� ����"������]$�

$�� �����=�����\���������������������?�B������ �������������������������$������?&�*����B���������������������������?]�/�*�����B���*���������������������������������������

/�� ������ ����������� ���������=�� ���\�������������� �������?�B�������������*�����������������������������%������!�������������������������������������������**���������������������������=�����������������������������+*������������{��*����*�� ����Z�������������*�����������������������������������

��� ����� ����������� *������� ������ �������� ��� ���� ��*�� ���������� �����*� ��� ��� ���**������ ����� ����=����� �����=�����\�� ���� �������� ��������� �� ���������� ��� ����� ������*�������������������������������������������

POWER SUPPLY�������������������=����� ��� �����*����� ��Z������&]��(�!"�&��?������������B"���>�"�&���*�����������������*������� ���������������������������������������������������"��������� �����������������"����������#�������:����������!��"��#+)~#V���%��������!��������:����������!��"�!+��!]]�&�

POWER FLUCTUATIONS AND ELECTRICAL NOISE���������� ��������� ������ �����*� ��Z������� ������� ��� ���������������������������������������!������������������������������ ���������������������� {������������������=��������=���������������������������������:K)�?�������*��������������������B���CV)�?��������Z�����������������B�*���������������������������*�������������*����������

�������Z����������������������~��������������������������;����*����+:;V~�\&��+������+!\;����Z�=������*��� �������������������� =������������x�����!������������������������������* ���������������� �����=����������*��������*�������*������

NOTE:�K���������������� ������������������������������������������������������������������=����������������*��������������

DEDICATED POWER WIRING AND BREAKERS'��������� ����� ������ �����"� ����� ������� ���� ����������������� ����������������=���������������������������������� ���������������������������������������������

POLARITY SENSITIVE���������������*����������������������=�������������*�������� �������� �������=��� ���������� ��*�� �������� ��Z����� ���������������� ���� ������ �����*� ��� �����**��� �� *����� �������*����������������)������>������#�������������������&]��(�!������������������=�����"����������������*����������������V���������������������"���������������������� ������ ����������������������������������������������������������*��������������������!�C�=�������V����*�������������;!'�

+���:������������������������/&���������������������������

GAS SUPPLY SYSTEMS;���������� ����������������������*��������������������������*�� ����� ������ ����� ���� ����*�������� �x����� &/����!��?&~]��+)�_���B�������������*���������Z���������������������� K�����*����� ����� �� ������ �� ������ ����� �������������������� �������������������������Z���*���������������������������������������������C������������� ��������������������� �������Z��*�������?��������������B������������������ �������Z��*���� ������� ��� *�x�**� ����� ?����*��� �������B�� ����������������������*��� ����� ����������&������!����*���������� ����*��� �������� �� ��=���� ��� �����*������ ������������� ����� �x����� &���� ��!�� *��� ����� ���� ��������"� ������* ������� ��������������� )����������� ������� ��� �������������������������������*�������������������������������=���������� ��*���� �� ���������� ���� =��=���� )�� ��� ��� �������������*� ���� #@�� *���� ������ ��Z���*����"� ���� ���������� ���������� ��������������������

>���� �������� ������� ������ �����*�� ��� ��������� ������x�����&/����!��?&~]��+)�_���B�������������*��*������������������� ��������� �� ����� ���������������� �� ����� �����&/����!��?&~]��+)�_���B������������������Z�������������������������������������������������������������������������=���������������������������������������_��������������*�����������������x���������+)��������Z����*�����������������������=��������������������+����*������x����������+)� �������������������� ����������� ����������=������������������� ���������*����������������������������������������������*��������x�����&/����!��?&~]��+)�_���B����������*��*��� ���Z�������������������������������

����*�������Z������*���**���������������������/�^����!��������������������&&������!�� �������������������*���**������� �������� ��� *������� ������ ���� ��� ������ ?����*����������B�� ���� ������ �������� ����� ��=��� ����� ���� /�^����!��������������������&�������!����������������������������������� ����� �� *������� ����� ���� ���� ����� ���������������������������**��*���������������������������)�������������������� ����� *��� ����� &���� ��!�� ��� ���� ������ �� ��� ������������������� ������������������������*����������������������� ���~�� ���� ���� �������� *��� �� ����������� �� �����������+��� +����� _��� C������� ������� ���� _��� ������� ������� �������*��������������=��=��������*�����������*�x�**���������������������*�����&/����!������*�x�**������������������*�����������������������������?��������������B�

&/����!������*�x�**������������������*�����������������������������?��������������B�

SUPPLY GAS REGULATOR���� *�x�**� ����� ��� ���� ������ �������� ��� ����� ������������� ���&�������������!��?]��]����B�������������������&/������������!��?$�/^����B������������)��������������=�����\����������������������������������������������������������������������x�����������������������������*��

)���������=�����\���������������Z���������������������������

INSTALLATION REQUIREMENTS

Page 15: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

15

HOT WATEROUTLET

TO TANKINLET

CHECKVALVE

MIXINGVALVE

COLDWATERINLET

TEMPERED WATEROUTLET

12” TO 15”(30-38 cm)

CHECKVALVE

Figure 8

����#�������+���������V��������������**�����������������&���V�?�]�!B�������������������������"�������������������� �� =���� ������� �� ����� ��� ���� ��� ����� ���� ������������� �������������������������������������������������� ��{������������=����&���V�?�]�!B�������������������������\���������������������*��������

��{��� ��� �� ���������� �� ���� ���� ���� =��=�� ���������� ��� �������������������������������������������*���#�=������������������������������������*���+��������������������'�����*�� ����������������%&�

NOTE:����*���������#+V�+������������������������Z���*��������� ��*��������������������*��� ��������������������������������� ������������������=��������������� =���������

CLOSED WATER SYSTEMS

������ ������ �����*�� *��"� ������ �� ���� ��Z���*������� ���� ��������� ��� ����� ����� �������"� �*��� �����"� ��=������������ ��=����� ���� ��� �������� �������� =��=��"� ������=��=��"����� ����������=��������'�=��������������������������������������*��� ���������������*�

THERMAL EXPANSION

��� ������ ��� ������"� ��� �x������ ?����*��� �x������B�� )�� �������������*�����=�*���������������������������������������������=�*�������������������������� ���������������������������������������������������*����x������������*����x�������������������*�����������������?�������B������������ �� ������� ��� ��� �=����� ����� ���� ��*����� ��������������*����x�������������������������*���������*�������\��������C������(��=���������������������������� ��*�����=��=����� ���x�����=���������� �������������������� ������ �=����� ����� ���� ��*����� ���������� ���� ��*�������\��������C������(��=�� ������ ������������ �������������������������*����x�������

�� �������� ������ ����*��� �x������� ����� *��� �� ���������� ������ ������ �����*�� �� ������ ���� ���*��� �������� �� ����*����x��������!�������� �������* �������=����������� ����=��������*����x����������������������

+���������;����!����������������/]����������������������'�����*�� ����������������%&�

MIXING VALVES

Water temperature over 125°F (52°C)can cause severe burns instantlyresulting in severe injury or death.

Children, the elderly and thephysically or mentally disabled are athighest risk for scald injury.

Feel water before bathing orshowering.

Temperature limiting devices such asmixing valves must be installedwhen required by codes and toensure safe temperatures at fixtures.

�������������������*�����������������������������������������"�������������"�������������������������������������������������*������ ��{��� ��� �������� +���� ��������� �������� ������������� ���*����������������������������*�����������������������������x��������������������������*���������������� ������]��V�?&&�!B�+*�� ������ ���� *��� ������� �� �� ���*�������� ��{���� ����� ������ ����� ������������� ������� ���� �������"� ��������"� ��������*� ���� ���� ����������~*�������� ���� ������� ��� �� ����� ��������x�*���� ��*�\�\ ��� ������������ ��� ��*��� ����� ������)�� ������ ����� ��� ������ ��=����� �� ���� ������ ������� ������������������������������������������������������������������������������Z������������������������*������������������������"������������������������*��� ��������)������������������������������� �����*������������������������������������*�����������������������K�x����(��=������� ��������������� �����������������?����V������B������ ��������������������������������������*���������*��������K�x����=��=��������=���� ��������* �����������������!������� `������� )��������� �� +��=���� �������� V���� *�x���� =��=��*��������������������������������������������=��=���TABLE 6

��������*������� �V�?�!B

��*�����&���'������[�� ?;����+�=����[���B

��*��������*������[��� ]���<�$���'�����

?K���+�=����[���B&&��?/$B ?��*�����������*��B&&��?/%B ?�������������B&&��?/%B $��*����� /��*�����&]]�?��B &�*���� ��*�����&$&�?��B �������� ]��������&/��?��B ]������� ��������&/^�?��B &������ ]�������&�/�?��B instantaneous &������

?Q�+��_=���*����K�*����*"�!���+�!�"�������;����*�����"�+�����&�"�&^%�B

DISHWASHING MACHINES

���� ������������ *�������� *������� ���� #������� +���������V������� ��Z���*����� ���� ��������� �� ������� ����� ������������������ �������&������]������������Z���������?&�$���������&%$����B��V������������� =��]������������Z���������?&%$����B"��� ����&������������Z���������?&�$����B"����������������*�������������������������������������������������"����������������������������������������������=��=������� �� ���� ��� ���� &���V� ?�]�!B� ����� �� ���� ������������*������� ���� ����� �� ��{����� �� ����=��� ������ �������� ���������������*����

Page 16: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

16

������ ������Z����Z��������� ����� ����*����������*����� )��������������������������������������������������������� ���*����"��������������*������������������*����

Water Damage Hazard

Temperature-Pressure Relief Valve dischargepipe must terminate at adequate drain.

CAUTION

T&P Valve Discharge Pipe Requirements:�� +�������� ���*������ �������� �������������������������� ����

=��=�"�����=������������������������������������������� +�������� ����������� �������� +�������� ���x������������������*����������� +����� ����*��������������������������������� ������ +����� �������������������������*����������������� �������

��*�������\��������C������(��=��������������������������� K������*��������*�x�**�����x��������� =�������������

���x������������� ��������)���������*����"����������**������������������������������ �����*����������������Z��������������������� �������

�� +����� ��� ��=������ =��=���� ����� �������� ������� �����������=��=����������������

Burn hazard.

Hot water discharge.

Keep clear of Temperature-Pressure Relief Valvedischarge outlet.

���� ��*�������\�������� C������ (��=�� *��� �� *��������������� ��� ������ ������ �� ������ !����� ����� �� ������ �������������?&B��������� ��� ������������������������� ������*�������\�������� C������ (��=�� ���������� ����"� ���� ?]B� ���������� *������� ����������� ����� ��� ����� ���� ����� ��{��� ���������� ��*���� ������ ���� ������ *��� �� �x���*���� ���� )�������� *������� ��������� ���� =��=�"� ��� ������ �� �*�������� ���������������������������������"��**���������������������������������� �� ����������������"� ����� ������������� ����������� ��� �����*����"�������������������*�������\��������C������(��=����������������������~�������������NOTE:�����������������*�������\��������C������(��=����������=�����x�����=����*������������������������������������������ ���� �<�� =��=�� ��� ��� ��������� ��� ���� �������� ������� ������*����x����������������������������*����x������������*��� �����������������������������*��������������*����x������"�����!�����������+����*����������*���:x��������������&��)�� �� �� ��� ���������� ������ ����������� �� ��=�� ����Z�����������������������*�������\��������C������(��=���������������������* ���������������� �����=����������*�����������������������������

TEMPERATURE-PRESSURE RELIEF VALVE

Explosion Hazard

Temperature-Pressure Relief Valvemust comply with ANSI Z21.22-CSA 4.4 and ASME code.

Properly sized temperature-pressure relief valve must beinstalled in opening provided.

Can result in overheating andexcessive tank pressure.

Can cause serious injury or death.

����� ������ ������� ��� ��=����� ����� �� �������� �����~������ ������������� �* ������� ��*�������\�������� C������ (��=�� ?�<��=��=�B� ������*���������������=��=�������������� ���������������������������������� �����������*����������������������������� �������� �� ������� �Z��*���� �� *��������� ��� *������� ������Z���*����� ���C������(��=��� ���>��������+�����+����*�"��#+)��]&�]]���!+��/�/"���������������Z���*��������+K:�)�� ��������"� ���� ���� �<�� =��=�� *��� *���� ���� ��Z���*������� ����� ����"� �� ��� ����� ����� �� �* ������� ��*�������\�������� C������ (��=�� �����~������ ���� ��������� ��� ���������� ������� � =�� ����������� ���� ���� =��=�� *��� �� *������ ����� ��*�x�**� ���� �������� ��� �� �x����� ���� *������ ���������������������������������������������?&������� �&"�$�����B��������������������������������������������������������[�~�����������������������������������������������*������������� ���NOTE:�)�����������������������������������*�������\��������C������(��=��������������������"��������*��������������������*��� ��������������������������������������������������*���������=�� ��������������������"� ��������������=�����*�������\�������� C������ (��=�� ����������� !���� ���� ���� ����� ����������������������* ��� ������������� �����=����� �����*�������������������������������������������*�������\��������C������(��=�������*����������������V���������������������������������"�������*�������\��������C������(��=��*������ ����*=�����*�������������������������� �������� ���� ��*�������\�������� C������ (��=�� *��� ������������������������������������������������������������������������������=��=���)���������������������������������������������������x����������������������������?&��]��*B�� =��������Z������������"����x������� �� ���� �������� )���������*����� ��� ��� ���**�������������� �����*����������������Z��������������������� ��������[���������������������������*���������������=����������������������������������������*������ �� ������������������������������������*���������:x�����=��������"�=���$�������?^�&/�*B"��������*������������� ��������������������������������������������������������������=��=��#� =��=�� �� ����� �������� ��� �� �� ������� ������� ������*�������\��������C������(��=����������������'��������������������� ������� ��������� �� ���� ������ ������ �� ��� ?&��]� �*B����� ���� ��� ��=������ �� ���=���� ����� ��{��"� ������� �� ����"� ������������*���"������������=��=��*��� ���������������������

Page 17: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

17

CONDENSATE DRAIN���� ������ �������� �=����� ��� ����� *����� ���� ��������������������� ���� ��Z���� �� ������� ������ �� �� ������� ��� �������x�*�����������������������������������������

!������������������*��������������������������x������� ������������ ���� ��*����������� �������������������������� �����*��� ��� �� ���=����� � =�� ���� ���������� ������ ����������� �������������� ����"� ����V�����^�� )�� ��������������������� ������ �������� ��� ����� ���� �� ��� ���� �x����� ?=���B� �� ������������� ��������� ��������� ������������������ ����[������:x������������������������������������������������������*�*������ ���� �������� ��������"� ��� ���� [������ :x����� +���������������������� ���������������*������ �������������� ����������� ��������� ���� �[������ :x������ V���� *������� ����� �����������������������������*���;!'"�����V��������������!�������� �����������������&�

NOTE:�)�������[������:x�������V����*�����������=������������������������������*�;!'"��������������������������������������������������� ������

CONDENSATE DRAINLINE - FIELD INSTALLED

CONDENSATE DRAINLINE CONNECTION

EXHAUST (VENT)ELBOW

BUILDINGDRAIN

FACTORY INSTALLEDCONDENSATE TRAP

CLEANOUTPLUG ISREMOVEDTO CLEARDRAIN

Figure 9CONDENSATE DRAIN WATER TRAP

Ensure a functioning water trap isinstalled in the condensate drain.Gas and carbon monoxide detectorsare available.Install water heater in accordance withthe instruction manual.

Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.

Breathing Hazard - Carbon Monoxide Gas

DO NOT� ��*=�� ���� ������� �������������������� ����� ������������"� ���� V����� ^�� ���� ������ ��������� =���� ����� ��� ������� ������� �����=�� ������������� ������ ����� ���=����� ��� ��������*���������� ���� ���� �����������������+���!���������'�����)������������������$��

CONDENSATE PH LEVEL���� ���������� ������� ��*� ���� ������ ��������� �=����� �������� *����� ��=�� �>� ��=���� ������� /�$� ���� ����� )������� ���**����������=���� ������������������������Z����� ������������

NOTE:�;�����>���=����������������'�������������*���������������"� ���� ��� �����"� �� ���� ������ ������� ��� ����� ������� +���!���������'�����)������������������$��

COMBUSTIBLE MATERIAL STORAGE

Fire or Explosion Hazard

Read instruction manual beforeinstalling, using or servicing

water heater.

Avoid all ignition sources if you smell gas.

Do not store or use gasoline or other flammable vapors andliquids in the vicinity of this or any other appliance.

Use only the gas shown on the water heater rating label.

Keep ignition sources away from faucets after extendedperiods of non-use.

Maintain required clearances to combustibles.

Do not expose water heater controls to excessive gaspressure.

�����������������������������������������* ��� ���*��������"��������������������**� ���=�����������Z����

CONTAMINATED AIR

Breathing Hazard - Carbon Monoxide GasInstall water heater in accordance withthe Instruction Manual and NFPA 54 orCAN/CSA-B149.1.To avoid injury, combustion and ventilationair must be taken from outdoors.Do not place chemical vapor emittingproducts near water heater.

Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.

!������������������������=���������*�*������������������* ����� �������� �������� ���*����� =������ +��� �������*�����������������������������������x������

!* ����� ���� ����� ��� ����*������� ���� �������� ��*������ ��������� ����� �� ���� ������ ������� ���� ������ ������� �*������������������������������������� ��������������������������������"� ����� ���� �������"� ������ �������� ���*������ �������*������������������������������������������������������������* ����"�=�������������* ������������������������*����

'��������������������������������������������������������������� �������������������������������������������������������������������*�������)�����������"������*���������������� �� ���������*���*����������������������*����������������� =����� ����� ������� �� ������ ������� ��� ��� �� �� �����=����*�������� ?+��� ��*����� ��������� ��� �*������ ���*�� ������������B�

)������������������������ ��������� ���������"� �� �������"���������� ���� ����*����"� �� ����\���=���� ��������� ����� ��������������Z��*���"���� ����*������=�����������������������?�B� �����������������'������(���������������������������������* ������������=��������������*�����������*���������������������������������������+���(�������)������������������]]�

Page 18: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

18

UNUSUALLY TIGHT CONSTRUCTION)����������������� ��� �������"� �����������*��� �����Z������ ��=���� ���� ��� �* ����"� =���������� ���� ������� �� ����������>��=��"���� ���������������������������������?����x�*���"� �������� ���������"� ���=���� ��������"� ������"� =���� ������"�����B���������������*��� ����=��������������*������������ ����������!������+�����������������������

CONFINED SPACE��!������+����������������=�*��IS LESS THAN����� ������������&"����[�~���?/����*�������B����������������������������������������������������������������

@��������*��� ����������������=������������������* ����"�=���������������������������������������������Z��������������������������������������������*�������������=���������������������������������AND����������[�~�������������������������������������������������������

DIRECT VENT APPLIANCES��������������������������'������(�����������������������=��������������* �������*�����������*��������������������������������������������������������������������������������[�~�������������������������*�������������������������=����������������������������������

EXHAUST FANS�������x�����������������������"��������������������� ����=������� �������� �����x���������������������x����� ���� ��� ������������� ���� ��*�� ������ ����� �� ������ ������"� ��������� �������� ����=���� ������ ���� *��� �� ��=����� ����� ���**����� ������Z���*�������������������������������*����������x����������Q����������������������� ��������� �� �������� ���� ���� �*��������������������������=���������*������������* ������+����"���������*���������������������������������������������x������*����������)�������������������������������x������

LOUVERS AND GRILLES��������������������������������������������������������������������������������������������������������=���"����������������������������������

���� ��Z����� ����� �� �������� ��� �* ����"� =���������� ��������������������� �� ��������������������������������������������������������������������������������=������������������������ ����"� ��� ������ �� ���� ��� ����������� ���� ����� �� ���������Z���������=���������������������������������������=����������������������������������������������"� ��������� �����*������������=�����������=��]�����������������*������=�����������������������=��%��������������#��*��������=���������������������� ���x���������������������

AIR REQUIREMENTS

Breathing Hazard - Carbon Monoxide GasInstall water heater in accordance withthe Instruction Manual and NFPA 54 orCAN/CSA-B149.1.To avoid injury, combustion and ventilationair must be taken from outdoors.Do not place chemical vapor emittingproducts near water heater.

Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.

V���������������������Z�����������������������*���������������* ���������=����������*��� ����=�����

��� ����������� ������ �� ���� ���� ����� ������������ ���* ����� ������� ��������� ��� ����*������� ����� *��� ������������������+���������������������������������������"��*���� ����� ��*�"� ������� ������ �� ���� �* ��������* ��"� ������ ���� ��� � ��� ���� �������� �� ����� �������x������

'������������ �����������������������������������������������Z��������������������* ���������=������������� ������������������������������*������������ ����������!������+������������������������

#�=��� ���������������=���������������)������=������� �����Z�������������"����������������������V����������=���������������*������* �������������������������������x�������������������������*���"������� �������{�����������

UNCONFINED SPACE���Q��������+����������������=�*��IS NOT LESS THAN ���� ������������&"����[�~���?/���� ���*������������B�����������������������������������������������������������������C*���**��������������������������������"����������������������������� ���������"� ������ �������� ��� ��������� ����� ���"� �����������������������������������������

K����� ���� ��Z���*����� ��� ���� �������� �� �x����� ����"���������=���������������*�"��������������������������������������� ������������ ��������*������ �������Z�������������� ����=�����* ����"�=�������������������������

Page 19: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

19

���������=����������������*������������"��**��������������&]��������?$���**B�����������������������"������� ����=������+��� V����� &&�� ���� ������ ������� ������ ��=�� ����������� �� ���������&������?]��**B���*��������������� �����������������?����**B���*���������������������������������������������������������**������������������������������**���������������=����������������������� �� ����������������������� ��������**���������������������������������=����*���**�������������������������&�� &��Z�������������$����[�~���?%$$�**]�������B������������

��������������������������������������������������"����]�� #�����������������*�������������������=����������������

����������

OUTDOOR AIR THROUGH TWO HORIZONTAL DUCTS

Figure 12

���� ������� ������ ������ �� ��=����� ����� ��� ���*�������������������"�����**��������������&]��������?$���**B������������������**��������������&]��������?$���**B������� ��*�����������������������������������������**�������������������������������+���V�����&]�:�����������������������=����*���**�������������&��Z�������������]"����[�~���?&&���**]�������B����������������������������������������������������������������������������������������"������������ ����������*��������������������� ��� ���� ����� ����� �� ���� �������� �� ������ ����� ������������*���**���*���������������������������������� ���������������$���������

FRESH AIR OPENINGS FOR CONFINED SPACES

���� �������� ����������� ������ �� ���� �� ��������� ���� ����"��* ��� ���� �����*���� �� �������� ��=������ ������ ���� ����* ����"� =���������� ���� ������� ��� ������� �������� ������������������������������������������*������������������������ ���� �������� ����� ��=���� ������ ���� ���� ������� ������������DO NOT������������������������������������������=����������������� +��� (������� )����������� �� ����� ]]� ��� �*������=������������������������������

OUTDOOR AIR THROUGH TWO OPENINGS

Figure 10

���� ������� ������ ������ �� ��=����� ����� ��� ���*�������������"�����**��������������&]��������?$���**B������������������**��������������&]��������?$���**B������� ��*�����������������������������������**�������������������������������+���V�����&��:�������������������=����*���**�������������&��Z�������������/"����[�~���?����**]�������B���������������������������������������������� ���������� ��� �������������:�������������������� ������������&����Z�����������?�/���*]B��

OUTDOOR AIR THROUGH ONE OPENING

Figure 11

Page 20: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

20

�����������������"������������ ����������*��������������������� ��� ���� ����� ����� �� ���� �������� �� ������ ����� ������������*���**���*���������������������������������� ���������������$��������?%��]��*B�

AIR FROM OTHER INDOOR SPACES

Figure 14

���� ������� ������ ������ �� ��=����� ����� ��� ���*�������������"�����**��������������&]��������?$���**B������������������**��������������&]��������?$���**B������� ��*����������������+���V�����&/�:���� ������� ������ �**������� ��������� ����� ��� �����������*?�B������������=�*��������������* �����=�*���������������*������������������������Q��������+�����:�������������������=����*���**�������������&��Z������������� &"���� [�~��� ?]]��� **]� ���� ��B� �� ���� ���������� �������������������������������������������������������:�������������������� ������������&����Z�����������?�/���*]B��

OUTDOOR AIR THROUGH TWO VERTICAL DUCTS

���� ������������ ����� ��� ����� ������� �� ���� *����� ���� ������������ ��� ���� �������� ����� ��=���� ������ ���� ���� ������������������DO NOT� ������ �� ������ ������������ ��� ���� ������ �� =����������������� +��� (������� )����������� �� ����� ]]� ��� �*������=������������������������������

Figure 13

����������������������� ����=����������������*������=������������"�����**��������������&]��������?$���**B������������������**��������������&]��������?$���**B������� ��*��������������������=��������������������**�������������������������������+���V�����&$�:�����������������������=����*���**�������������&��Z�������������/"����[�~���?����**]�������B������������������������������������������������������������������������

Page 21: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

21

COMMONWEALTH OF MASSACHUSETTS

V�������������������*������"������������=�����������=���"��������=���"�����������������=������������������������������������������=������������"� ������������������������������������������������������������"������������������������������ ������!**���������������������������������x�����=�������*���������� ����� �������=���?%B� ������ =���������������� ��� ���������������=������"���������� �������*�����������������������"���������������Z���*����������� �����������

INSTALLATION OF CARBON MONOXIDE DETECTORS

��� ���� ��*�� �� ������������ �� ���� ����� ����� ��������� =���������� �������Z��*���"� ���� �������������* �������������������� ���=�� ����� �� ����� ������ ��� �� *�x���� �������� ����� �������*����� ������� ���\��������������������������=������������������Z��*��������� �������������)���������"������������������* ��� �� ��������� ������ ���=�� ����� �� ������� �������� ���������������� ��*�x������������������������*���������������� ����� ���������� ��=��� �� ���� ��������"� ������� �� �����������=��� ������������������������=�����������������Z��*�����)�������� ������������� ����������������������������������������=�������Z��������������������������������������������������������������� ��*�x�������������

)�� ���� �=���� ����� ���� ����� ����� ����������� =������ ���� �������Z��*��������������������������������������������"������������������� ��*�x���������������������*����� ������� ���\��*��� ��������������������x����{�����������=���

)�� ���� �=���� ����� ���� ��Z���*����� �� ����� � ��=����� ���� ��� ��*������������*�����*��������������������"������������������=�� �� ������ �� ������� ?$�B� ����� �� �*���� ����� ���� � =����Z���*�������=����������������������������?$�B����������"��� ������������������ ��*�x������������������������*������� ������������

APPROVED CARBON MONOXIDE DETECTORS

:������� ��*�x�����������������Z���������������������������� =����=�������������*���������#V���%]������ ���#+)~Q;�]�$/������������!+�����������

SIGNAGE

�� *����� �� �������� ������������� ������ ������ �� ���*��������*����� �� �����x�������� ���� ������������*���**����������������?�B������� =�����������������������������������x�����=�������*�����������������������=�������������������������������������Z��*������������������������"�����������������������������\�����?&~]B�������������"�“GAS VENT DIRECTLY BELOW. KEEP CLEAR OF ALL OBSTRUCTIONS.”

INSTALLATION REQUIREMENTS - COMMONWEALTH OF MASSACHUSETTSINSPECTION

���� ������ �� ����� ���� ��������� �� ���� ����� ����� �����������=���������� �������Z��*�����������������=�� ���� �����������������"� ��� ���������"� ���� ��������� ���=��� ��� ��*�x�����������������������������������������������������������=��������]/��!KC�����?]B?�B�&�������/�

EXEMPTIONS

���� ���������Z��*���� ����x�*��� ��*�]/��!KC�����?]B?�B&�������/�

&�� �����Z��*��������������!�������&������������:Z��*����#��C�Z�������[��(��������������*�������������������#V����/����������� ������[��������

]�� ����������=��� ����� ����� ����������� =������ ���� �������Z��*��������������������*����������������������*�������������"� ������"� �� ������������ ���������� ��� ����� ����������������������

MANUFACTURER REQUIREMENTS - GAS EQUIPMENT VENTING SYSTEM PROVIDED

����� ���� *���������� �� ������ ����=��� ����� ���������������� =������ ���� �Z��*���� ��=����� �� =������� �����*����������=������������*��*������������ �����Z��*���"� �����������������=����� ������*���������� ��� �������������� �����Z��*������������=������������*��������������

&�� '��������������������������������������������=������������*��������������=������������*��*�����������

]�� ���*������������������������=������������*����������=������������*�

MANUFACTURER REQUIREMENTS - GAS EQUIPMENT VENTING SYSTEM NOT PROVIDED

����� ���� *���������� �� �� ������ ����=��� ����� ����������������=���������� �������Z��*�������������=���� ���������� ��� =������� ���� ��� �����"� �� ���������� ��������� =������������*�"�� ���� �������� ��Z���*����� ������ �� ��������� �� ����*����������

&�� ���� ����������� ��������� =������� �����*�� ����������� ������ �� �������� ����� ���� ���������� �� �Z��*���� ����������� �����������������

]�� �������������=������������*��������� ������������=��� ������[���"���������������������������������*����������������������������������������������������������������

�� ���� �� ���� ������������ ����������� ��� ���� ����������=������������������������=���������� �������Z��*���"����� =�����������������"� ���� ������ ������ ��� =������� ����������"� ���~�� ����=������� ������� ����������� ������ ��*���� ����� ���� ���������� �� �Z��*������������*�������������������������

Page 22: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

22

]�� )�� ���� ������ ������� ��� �� �� ���������� ��� �� ����� ���"� �� ��� ���"� ��������� ���� ����*���"� �� ������� ����� ��������������Z��*�������������������������*������������������*������=�� ����� ���� ������ ������?�B� �� ���������� ��� �� '������(���� ���������� �� ����� ���� ���� ��� �* ����� ��� ����=�����*�����������*�������

$�� ����=��������������������������*������*�����������

/�� ����*���**�������������*��* ��� ���*��������� ��� ����=����?�x����B����������������������������� ������������(����������������������������* ��� ������������������*��� ��������������?��{����B�

��� �����������������*��� �������������*����������������������������������������

��� ����=����?�x����B������*������ ���* ���������������������������������������=���������*������*����

%�� ���� ����������������*������ ���* ���������������� �����������������������������������������

��� ;��������������������������������=����?�x����B������������������������������*���������������*�x�**��Z�=����������������������+���(�������C�Z���*������������]/�

^�� '����������������=�����������������������������*����������������������������� ������������������������

&���(����������*��� ������������*���**�����&~/������������� �����������������������?���������������������������B�

&&��'��������������=������ ������������������������������*��������"����������������������� �������������������������������������=����=� �������������*� ����������*������

&]��Q�����������=���=���~��������������������������*����������+���(�������C�Z���*������������]/�

&$��Q������� ���������������=�������� ��������������������������*���������+�������(�������C�Z���*������������]/�

&/��'� ��� ������ ���� =���� ?�x����B� �� ������� ���� ���*�������������� ����� ���� �� {������ ��� ��� �� ����� ��� �������*������?�B����������������������������������������*����������������

&���'������=����������������������������������������"�����*�"����� ������� ������� ���� ����� ������������ �� ��� �������C����������� �� ��� ������ ����� ����� �����"� ���*������������ �� ���� ����� �x�������� ���� ������ �� ���� �* ��������� ������� ������ ��=���� ���� ��������� �� ���=���� ���������������� �� ��� �����"� *�������� ��� *��� ��������� ������� ��� ��������������������������=�������*��������

&���'��������������=�������*�������=������ ���������������������������=������������������������������������

&%��:������������������������������������������*�����������������������������������=���� ��������������=���������*�

&���+��������=�����������~������������ ������������������������� ���*������ ������������� )�� ������ ����� ���*��� ���� ���� �� ���������������������"���������������������*=��������������������������������"����������*��� ����������"������������*������������*��� ����*������������������������������x�������)��������������������*���*�����������������

&^��:�������������������������������������������������������������[�>�&^^~]���*����"����������]$���������������

]���!�����������������(�������C�Z���*������������]/�����������������������(�������)�����������+�Z������������]��

VENTING INSTALLATION

Breathing carbon monoxide can cause brain damage or death.Always read and understand the instruction manual.

Install vent system in accordance with codes. Do not operate water heater if flood damaged.Special consideration must be taken with installationsabove 10,000 feet (3,048 m) refer to high altitudesection of this manual.

Breathing Hazard - Carbon Monoxide Gas

Do not operate if soot buildup.

Do not obstruct water heater air intake with insulatingjacket or blanket.

Do not place chemical vapor emitting products nearwater heater.

Gas and carbon monoxide detectors are available.

Never operate the heater unless it is vented to theoutdoors and has adequate air supply to avoid risksof improper operation, fire, explosion or asphyxiation.

Analyze the entire vent system to make sure thatcondensate will not become trapped in a section ofvent pipe and therefore reduce the open crosssectional area of the vent.

#�=���������������������������������������=������������������

������������������������������������*�����*��� ������������=����������* �������������������������������+������������ ����� ������ �� ���� �* ����� ���* ��"� �������������� �����������������������������x������

GENERAL VENTING INFORMATION���� ������ �������� �=����� ��� ����� *����� ���� �������������Z�=������ �� !������� )(� ����������� ���� *��� �� ���������� �����������������(������'������(��������������

CATEGORY IV APPLIANCE!������� )(� ����������� ������� ����� �� �����=�� =���� ?�x����B�������������������������=�������� ��*��������� �������� �������������������������=�����������POWER VENT CONFIGURATION����� (���� ����������� ����=�� ���� �* ����� ���� ��*� �����*� ������ ����� ���� ���������� ���� ���������� ���� ��� ������ ������������*������� ���������������=���� ?�x����B������������=�����������������=�����=����������������������������������������������� �����*������������=��������������������������*�����+���V�����/������V�����/&��������$/�DIRECT VENT CONFIGURATION'������(�������������������=�������* ��������������������*����� ���� ��*������� ������ �� ������� ������� ���� ����� �������������� ���� ��� ������ �� ���� ���� ��*������� ������ ���������=����?�x����B�������'������(�����������������=����������� ��������� �� ���� ������ ������"� ��� =���� ����� ���� ��������������������'������(������������������� �����*������������� �� ��x� ���������� �������*������ +��� V����� /]� �� ����� $/�������V�����/%��������$��

GENERAL VENTING INSTRUCTIONS�����������������*��� ����������������������������

&�� DO NOT������������������������������������(�������������������� ������ ��� ���Z���� ������ �� ������ ���"� ���� ����C�Z���*����� �� ����� &��� )�� ���� ������������ ������ ���������=����������Z���������������������������������������*��� �����������������'������(��������������

Page 23: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

23

���� ������� ���� ���� ������� ��� ������� ���������� ����� ���� &~]� ����� �������������� �� ���������������������������x�*������&$�������� =������ ��*� ���� ���"� ���� V����� &��� ���� ���� ���������&~]� ����� �������������� �� �*��� ��� ������������� �����?������� ���� ����B� ����� ����� ������� ������������� ��������������"��� ����^���������"�����������=������������������������������������ ���INSPECT/ADJUST INTAKE AIR TEE FITTING)������� ������������ �����������������&~]� ����� �������������� �� �������=���������*������������������"�����V�����&���)�������������� ���������������&~]� ����� �������������� �� � ��� ��������������"���{��*��������� �����������������{��������������������������������������������������������� ����Adjustment Procedure:&�� :������������������������������������������~������������

����������������������������]�� '�������������[������)�������������������������� �"�����

V�����/��������^�����������$�� ;���� ���� ������ ���� ���*�� �� ���� V����� ������� �����

�������� ���� ����������� �������������� �� ����!* ����� ����"�����V�����&%�

/�� ��{�����������������������������������������&~]������ �������������� �� �����������������������������������V�����&��

��� C��������� ���� �������������*��������!* �����[����������������V�����������"

��� C������������[������)�������������������������� ��*����������������������� ������������������������� �������������������������

INTAKE AIR CONNECTION PIPE199,000 & 250,000 Btu/hr MODELS

LARGE HOSECLAMP

3 INCH PVCINTAKE AIRTEE FITTING

FERNCOCOUPLING

Figure 17

BTH 199 & 250 INTAKE AIR CONNECTION

[�>� &^^� ���� ]��� *����� ���� ������� �Z������ ����� �� ��Z��!* �����[������������������������������������������������������$��x�$��x�&~]������������������������������������������������������� �� ������������������&~]������ �������������������[������)�������������������������� �"�����V�����&��

FACTORY INSTALLEDINTAKE AIR TEE FITTING

COMBUSTION BLOWER ASSEMBLY199,000 & 250,000 Btu/hr MODELS

COMBUSTION BLOWER

1/2 INCHBRANCH

HOSE BARB FITTING FORBLOCKED INTAKE AIRSWITCH SENSING TUBE

FERNCOCOUPLING

Figure 15

:������������� �� � ���������� ������������������ IS NOT� ���������������������������?&����\���������������B� �����=������������������� ����������� �� ��������*��� ��������� �������^���������*��������&$��������������V�����&����)������ �� ����������� ����������"� �������� ���������� ���������������� ��*�� ������� �������������������������� ���� ����[������ )��������������������������������������������� ��������*��������������������������������������������[������)�������������������������������������������������*��������

90° TO 130°

CORRECT ORIENTATIONINTAKE AIR TEE FITTING

END VIEW

Figure 16

Page 24: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

24

�Z�=������ ����� ?$���� *B�� ):�� @�� '������ (���� ������������� ������������� ������&]���Z�=�����������?$����*B�

MINIMUM EQUIVALENT LENGTHSThree Inch Pipe���� ������ �������� �=����� ��� ����� *����� ���� ��������� �� ��*���**� ������� �� $� ����� ����� ��� ���� =���� ?�x����B� �� %��Z�=������ ����� ?]�&� *B�� ������ ��� �� *���**� �Z�=������ �������Z���*���������������������������Four Inch Pipe���� ������ �������� �=����� ��� ����� *����� ���� ��������� ���� *���**� ������� �� /� ����� ����� ��� ���� =���� ?�x����B� �� ����Z�=������ ����� ?&��]�*B�������� �����*���**��Z�=������ �������Z���*���������������������������MAXIMUM NUMBER OF ELBOWSThree Inch Pipe����=���������*�����=����*�x�**������̂ ����� ������������������$� ���������� ��� �������������� ����������������*���������=����*�x�**��� ���^����� ��� ����������� ):�� �����'������(������������������������������=���� �� ���^����� �������������Four Inch Pipe����=���������*�����=����*�x�**�����x�^����� ������������������/� ���������� ��� �������������� ����������� �����*���������=����*�x�**�����x�^����� ��������������):�������'������(������������������������������=��������x�^����� �������������FACTORY SUPPLIED FITTINGS���� ������ ������� ������ ����� ��� ?]B� ������� �������� $� ��������*�������� ?�(!� /��� �� ��� ����� �� ���� ������B�� V�������������� =���� ���� ������� ���� ���*�������� �� �������������*�������� *��� �� ����� V������ �������� ���*�������� ����������������������?�x������� ������ �������������������B����������Z�=�����������������=��������������������������

TABLE 7Number of 90° Elbows Installed

3 Inch Pipe 4 Inch PipeMaximum Feet (Meters) Maximum Feet (Meters)

@���?&B /�������?&$�%�*�����B &&�������?$����*�����B���?]B /�������?&]�]�*�����B &&�������?$$���*�����B������?$B $�������?&��%�*�����B &��������?$]���*�����BV��?/B $�������?^�&�*�����B &��������?$����*�����BV�=��?�B #~� ^�������?]^���*�����B+�x�?�B #~� ^�������?]%�/�*�����B

4 INCH EXTENDED VENT TERMINATIONS

�����/�������������������=���������������������"����������������/���������*��������*��� �������!�������������������� ��������������������������*����?������* ���������������� �����=����������*����B��������/���������*������?�B�OPTIONAL CONCENTRIC TERMINATIONS�������������������=����� �������*�����*��� �����������������'������(���������������������/�������������������*��������!��������� ���*�������� *��� �� ������� ������������ !�������������������� ��������������������������*����������* ���������������� �����=����������*������������Concentric Vent Termination Part Numbers:

�� /��!������������*�������¡�^���$]����

VENTING REQUIREMENTS

APPROVED MATERIALS����=���=������������������������*��������������*��� �������������Q������+������

�� �(!�+�������/��?�+�K�'�]]/&�~�!+��[&�&�]"��+�K�'�&%���~�!+��[&$%�$

�� !�(!�+�������/��?�+�K�V\/&&�~�!+��[&$%��B�� �[+�?�+�K�'\]��&B

����=���=������������������������*��������������*��� ���������!������

�� Q;!�+�$���(!�~�!�(!

FIELD SUPPLIED FITTINGSV�������������������������� ���Z�=�������������������*�������� ����������������V��������������~��������������������������Z�=�����������������=������ ��������������������� ���������� ���������������������~���������� �������� ���� ������� *��� �� �������� ���� �����Z�=�����������������������

�� ^����� ���?����������������B������Z�=����������������������?&�]��*B���������

�� /����� ���?����������������B������Z�=��������]���������������?%���*B��������

PRIMER AND CEMENT�������������� ?�>VB� ���*��� ����� �� ���� �� �������� ������������������������������������=�������������)��!�(!����[+�������������������������"������������������*����*��� ��������� ���� {����"� ��������� {������ ���� ����� �� ���� ������� ��=��������*�������� ?�(!� *�������B�� �(!� K��������� ����� ����+�K�'\]��/�_�����!�*�����!�(!�K������������������+�K�V\/^$�_����� !�*���� ���� �[+� K��������� ����� ��� �+�K� '\]]$��_�����!�*����

PIPE SIZE REQUIREMENTS�������������������=�������������*������������������������������$�����/������������������=����?�x����B������������������������)�����������������Z�=���������������������������������=���������������� ����������?&��]�*B�������"�$�����������*��� �������)�����������������Z�=������������������ ��*����������������?&��]�*B"�/�����������*��� ������

NOTE:�)�����������������������Z�����������������������Z�=���������������������������������������� ):��)�� ���� ��������������������� ������Z�=��������������������������=��������������*������������Z�=��������������������������������*��� �����������������$�������������������=����*��� �����������������/�����������

MAXIMUM EQUIVALENT LENGTHSThree Inch Pipe���� ������ �������� �=����� ��� ����� *����� ���� ��������� ���� *�x�**� ������� �� $� ����� ����� ��� ���� �x����� =��������������*���� �� ��� �Z�=������ ����� ?&��]� *B�� ���� ���������*�x�**� ���������$� ���������� ��� ������������������ �����������Z�=������ ����� ?&��]� *B�� ):�� @�� '������ (���� ������������� ������������� ����������Z�=�����������?&��]�*B��

Four Inch Pipe���� ������ �������� �=����� ��� ����� *����� ���� ��������� ���� *�x�**� ������� �� /� ����� ����� ��� ���� �x����� =��������������*���� �� &]�� �Z�=������ ����� ?$���� *B�� ���� ���������*�x�**����������/���������������������������������������&]��

Page 25: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

25

^�� ����=����?�x����B�������*��� ������������*���**�����&~/������������� �����������������������?���������������������������B�

&���)�� ����������� $� ����� =���� ����� ������� ���� =���� ����� �� �����x������� ���������������������

&&��)�������������/�����������������������$�������������������x������� ��������������������������������V�����&���������������������� $�� ����� ������� ���� �x����� �� �� ���� ���� /�� x�$��������������������� ��&���������?/���*B��� ���������������

DIRECT VENT INSTALLATION

&�� C���� ���� _������� (������� )���������� �� ����� ]]� ����(�������C�Z���*������������]/� ������������������������������������� ��Z���*�����*��� �� ������� ������������� ���� ����������� ���� ����� ���� �������� ��� '������ (���������������

]�� '����*���� ������ '������ (���� �������*���� ����� �� ���� ������� ������������� ������ ���� ��x� ?�B� '������ (���� �������*�����������+����V�����/]�<�V�����/$��������$/�����V�����//�������V�����/%��������$��

$�� '����*����=�������� ��������������������� �� ������ ��� ���������������������(�������C�Z���*������������]/�

/�� ��������������������=�������������������������� �����������*� ���� ���*������� ����� ����� �� ���� ������ ��������;���� ����=�������� ������������������ �������*���**�������������� ���

��� )��������������*��������������)�� ��������� ���*�������� ���� ����� ���� ���� ���� ������� ������ =���� ������� ����� ���*������ =���������"� ������ �� ��"� ����(�����������*�������)������������������]%��)��������������*������������ ������������������������������=�������������������*����������������"�����������������"�����+�����������*�������)������������������]^��)�� �� ���������� ���*������?�B� ����� �� ���� ���� !������������*�������)������������������$��

��� ����� ������������ �� ���� ���*������?�B� ��� �*������ )�������������������������������������������������������������=����������� �����������������������

%�� ���� ���������������=�����������*��� ���������������������=��� ��������� �������������������������*�������������**��������������=�������������������������� �����������=�����������?&�]��*B���=����������������=����$������?^&��*B���������������

��� '����������������=�����������������������������*����������������������������� ������������������������

^�� ������������������������������������������������������� �����������������������������������������������������������������������*�������������=���������*������������������������� ��������� �x��������� ����� �*������� ���� ������ ��������� �� ����� ��������Z���������������������� ��*����������������������������+���V�����]&��������]��NOTE:�+��� ����������������������������������������������*�������������������x�����=���*���������������*������������*������������������*�����������*"��*�����������������������x�����=����������������������������������������������*���������*������������������*�������

&����������������������=����?�x����B��������*��� ������������*���**�����&~/������������� �����������������������?���������������������������B�

VENTING INSTALLATION SEQUENCE

&�� C���� ���� _������� (������� )���������� �� ����� ]]� ����(�������C�Z���*������������]/� ��������������������������������� ���� ��Z���*����� *��� �� ������� �� �����������������

]�� '����*���� �������� ���� ������ ������� ����� �� ���������� ����� ����� (���� �� '������ (���� ���������� ���� ������ =���������*��������*��������� ��������������������������+�������=�����=��������������*�������������$/�����$��

$�� �������������������� ���������������� �����(����)������������������]���� '������(����)������������������]��

POWER VENT INSTALLATION

&�� C���� ���� _������� (������� )���������� �� ����� ]]� ����(�������C�Z���*������������]/� ������������������������������������� ��Z���*�����*��� �� ������� ������������� ���� ����������� ���� ����� ���� �������� ��� ����� (���������������

]�� '����*���������������(�����������*��������� ������ ��������������������=����������������������*��������+���V�����/������V�����/&��������$/�

$�� '����*��������=��������������������������������"�����(�������C�Z���*������������]/�

/�� ����� ���� ����� �� ���� =���� ������� ��������� ��*� �������*������� ����� ����� �� ���� ������ �������� ;���� ����=������������������*���**�������������� ���

��� )��������������*������������)������=�������������������*������=���������"�����������"�����(�����������*�������)������������������]%��)�� ���� =���� ������� ����� ���*������ ����������"� ������ ����������"�����+�����������*�������)������������������]^��

��� ����� ������������ �� ���� ���*������� ��� �*������ �����������������������������������������������=����������� �����������������������

%�� ����=���������*��� ���������������������=��� ����������������������������������*�������������**��������������=��������� �����������=�����������?&�]��*B���=����������������=����$������?^&��*B���������������

��� '����������������=����������������*����������������������������� ������������������������

3” PIPE FIELDSUPPLIED

EXHAUST ELBOWVENT CONNECTIONFACTORY INSTALLED

4” PIPE FIELDSUPPLIED

4” x 3” REDUCERFIELD SUPPLIED

VENT (EXHAUST) CONNECTION

Figure 18

Page 26: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

26

&/��)�������������$����������������������������������������������������������������������������������������������

&���)�������������/����������������������������������$������������������ ����������� ����������� ���������� ������� ��� ����� ���V�����]����������������������$������� ������������������������������� ���� ���� /�� x� $�� ������� ������� ����� �� &���������?/���*B������������������

3” PIPE FACTORYINSTALLED

4” PIPE FIELDSUPPLIED

3” PIPE FIELDSUPPLIED

4” x 3” REDUCERFIELD SUPPLIED

3” COUPLING OR TEEFACTORY INSTALLEDINTAKE AIR CONNECTION

INTAKE AIR CONNECTION

INTAKE AIR

COMBUSTIONBLOWER

Figure 20

INSTALL TEE FITTING AS CLOSE TO WATER HEATERINTAKE AIR CONNECTION AS POSSIBLE

INTAKE AIR CONDENSATE TEE INSTALLATION

FIELD SUPPLIED3” x 3” x 1/2” TEEWITH HOSE BARBFITTING INSTALLED

FACTORYINTAKE AIRCONNECTION

INTAKEAIR

PIPING

CONNECT FIELDSUPPLIED FLEXIBLEDRAIN HOSE TO BARBFITTING AND FORM ALOOP WATER TRAP INDRAIN HOSE

RUN DRAIN HOSETO SUITABLE FLOORDRAIN SEPARATELYFROM OTHERCONDENSATE DRAINS

Figure 21

&&��)�� ����������� $� ����� =���� ����� ������� ���� =���� ����� �� �����x������� ���������������������

&]��)�� �����������/� �����=��������� ���������� ��$� ������������� �����x������� ��������������������������������V�����&���������]����������������������$������� ������������x������� ����������/��x�$��������������������� ��&���������?/���*B������������������

&$��:���������)����������+������������)����������!��������������������������������*=��� �������������������������������������������������������+���V�����&^��

Do not obstruct water heater air intake.

Gas and carbon monoxide detectorsare available.

Install water heater in accordance withthe instruction manual.

Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.

Breathing Hazard - Carbon Monoxide Gas

NOTE:� '� ��� ���=�� ���� ������� ������� ���� )������ ����!�������� ��� '������ (���� �������������� @���� ���� ��������������������������������������������� �����������*�=��������*��� ��*���������������� ����=�����*�������������������*�������* ���������*������� ����� ��[������ )�������������������������������������������������*��������

INTAKE AIR SCREEN(remove for Direct Vent)

120,000 & 150,000Btu/hr MODELS

199,000 & 250,000Btu/hr MODELS

3 INCH INTAKE AIR CONNECTIONSFACTORY INSTALLED

INTAKE AIR SCREEN

Figure 19

Page 27: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

27

VERTICAL TERMINATION INSTALLATION

&�� '����*�������������������������*������?�B�NOTE:��������������=����������������������*������������������������������"�����V�����]]�

]�� )�� ��������������� ����=���� ?�x����B� ������� ����������(�������������� =���������� ������ ���� ���� ������ ����� �����x������ =�������� ���������� ��Z���*����� ����� ��� V�����]$�����V�����]/��������]������ �����*������������������������������������������� ������������������������*��� ��*����������NOTE:�@��������������������������=�������*�������*��� ����*���**���]/��������?����*B�� =�������������"�=������������������������������&�������?$�*B�������������+���V�����]/��������]��

$�� )�� ����������� ��� ���������������=����������� �����'������(�������������� =���������� ������ ���� ���� ������ ����� �����x������ =�������� ���������� ��Z���*����� ����� ��� V�����]$�����V�����]/��������]������ �����*������������������������������������������� ������������������������*��� ��*����������NOTE:�@������ ��� ������������� ���� ��������������� ����=�������*��������*��� ����*���**���]/��������?����*B�� =������ �������"� =�������� ����� �� �������� ������� &�� ����� ?$� *B�������������+���V�����]/��������]��

/�� )�����������������=���������������������(��������������=����������������������������������������������*��� �������������=�������*�������*��� ������������������������������������V�����]$�����V�����]/��������]������ ��*������������=�������*�������*��� ����*���**���&]��������?$���*B"�&���������?/���*B����!�����"�� =�������=���������x�������������=��������������V�����]$��������]���

��� )�� ����������� ��� ���������������=����������� �����'������(�������������� =���������� ������ ���� ��� ���� �������������������*��� ����������������������������=����������*�������������������*���������������������������V�����]���������]���������������������=�������*��������*��� ��������������������������������������*����������������������V�����]���������]��

�������������������=�������*��������*�����=����*���**�������������]/��?�&��*B�*��������������������������������V�����]���������]��� )�����������*������������������������� �����������������������/���������?&]]��*B����� ��*� ����� �� ���� ������� ���� ���� =���� ���*��������*��� ����*���**���&]��������?$���*B"�&���������?/���*B���� !�����"� � =�� ���� �=������ �� �x������� ���� ��=��� �����������V�����]$�����V�����]���������]��

��� ����� ���� ������� ���� ���~�� =���� ������� ��*� *������������� �������� ����� ���*������ ��� ���� ��*�� ������� ���� =�������*�������� ���� �� ������ �������� ��� ����� ��x�*���� ��������~��������)�������������*���������������� ��������������������������x�*������������~������������ ��������� ������� ���� ������� =���� ���� ������� �������*�������� *��� �� �� *���**� �� ]/� ������� ?�&� �*B���� ����� ��� V����� ]�� �� ����� ]��� )�� ������ ���*������������������������� �����������������������/���������?&]]��*B�

%�� !����/������?&���*B����*������������$��������������������?&$��*B����*������������/�������������������������?�B������������������������NOTE:�[������������������������������������������������������������

��� +������ ���� ����?�B� ������ ������� �� ���� ����� �������������*������������������Z�=������������*��������������������V�����]$��������]��

^�� +����� �� ��� �� �� �Z�=������ �������� =��� ���� ����� ���������� ��� �� �� �Z�=������ �������� �� ��� ���� ���������� ���� ����������� ����� ���V�����]$"�V�����]/�����V�����]���������]��

&���)����������������������������������������~��=�������*������?�B��������������������������������������������^����� ���������� ���V�����]$��������]������������ ��������������������������� ������������������������^����� ����������������������������*�������*������ ���x�����=����������������� �x����� ������ �� ����� ����� ������ �� �� *��� ����� ]��������?���*B"�����V�����]$��������]��

&&��C����� �� ����� (���� )����������� �� ����� ]�� �� '������(���� )������������������]�� ���*������ ���� ��������������������������������~��=����������� ��������������*������?�B����������������������

STANDARD FACTORY SUPPLIED TERMINATIONS

INTAKE AIR TERMINATION45° ELBOW WITHDOME SHAPED DEBRISSCREEN

VENT TERMINATION45° ELBOW WITHRECESSED DEBRISSCREEN

Figure 22

Page 28: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

28

2” (5 cm)MAXIMUM FACTORY SUPPLIED

STANDARD TERMINATIONPOINTED DOWN TOWARDS

THE GROUND

VERTICAL TERMINATION(S) INSTALLATIONINTAKE AIR AND/OR VENT (EXHAUST)

FIELDSUPPLIED90° ELBOW

FIELDSUPPLIEDSTRAP/SUPPORT

FIELD SUPPLIEDPLUMBINGROOF BOOTOR FLASHING

MAINTAIN 12” (30 cm)18” (45 cm) FOR CANADAMINIMUM CLEARANCEABOVE HIGHEST ANTICIPATEDSNOW LEVEL.

NOTE: INTAKE AIRTERMINATIONSHOWN HERE

Figure 23

INTAKE AIR AND/OR VENTTERMINATION(S) MUST BE A MINIMUM OF 24 INCES (60 cm) ABOVE ANY PARAPET, VERTICALWALL OR STRUCTURE WITHIN10 FEET (3 m) HORIZONTALLY.

VERTICAL TERMINATION(S) FLAT ROOF CLEARANCEINTAKE AIR AND/OR VENT (EXHAUST)

24 INCHES (60 cm)MINIMUM HEIGHT ABOVE

IF LESS THAN

10 FEET (3 m)

NOTE: VENTTERMINATIONSHOWN HERE

Figure 24

VERTICAL TERMINATION - DIRECT VENTSTANDARD TERMINATIONS

24 INCHES (61 cm) MINIMUM48 INCHES (122 cm) IN COLDER CLIMATES

FACTORY SUPPLIEDSTANDARD TERMINATIONSPOINTED DOWNWARD

FIELDSUPPLIED90° ELBOW

VENT (EXHAUST)TERMINATION

INTAKE AIRTERMINATION

FIELD SUPPLIEDPLUMBINGROOF BOOTSOR FLASHINGS

MAINTAIN 12” (30 cm)18” (45 cm) FOR CANADAMINIMUM CLEARANCEABOVE HIGHEST ANTICIPATED SNOW LEVEL.

Figure 25

Page 29: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

29

SIDEWALL TERMINATION INSTALLATION

&�� '����*�������������������������*������?�B�NOTE:��������������=����������������������*������������������������������"�����V�����]]��������]%�

]�� )�� ����������� ���� =���� ?�x����B� ������� ��� �� ����� (�������������� ������ �� ���������� ������ ����� ���� �x���������������������������Z���*����� ��� ���� ���*������"��������� V����� /�� �� ����� $�"� ���� ����� *����������� �������������������������������� ������������������������*��� ��*����������

$�� )�� ����������� ��� ���������������=����������� �����'������(�������������� ������ �� ���������� ������ ����� ���� �x���������������������������Z���*���������������*�������"���������V�����/^��������$%"��������=����������������������*����������� �����*������������������������������������������� ������������������������*��� ��*�����������

/�� )�� ����������� ��� ��� ������� ���� ���� =���� ���*������� ��� ��'������ (���� ���������� ������ �� ��������� ������ *��� ����*���**���]/� ������� ?�&��*B����������"�*��������� =�������� ������� ����"� ������� ���� ������� ���� ���� =�������*�������"�����V�����]��NOTE:�)�����������*������������������������� �������������� ��� ������ /�� ������� ?&]]� �*B� ������� ���� ������� ���� ����=�������*����������������������������=��������������������*�����\���������� �������������������������������� ���������� ������ �� ����� =��� ��*� ����� ������ ������ �x�����=�������������������������*�����������������**���������!���������������������

��� )�� ����������� ������������������=�������*�������������'������(���� ���������� ������ �� ��������� ���� ������� ���� ����=���� ���*�������� *��� �� ���������� ��� ���� ��*�� ���=�����*������������������������������\�����V�����]��

VENT (EXHAUST)TERMINATION

INTAKE AIRTERMINATION

INSTALL ONELEVATION

CENTERLINE

24 INCHES (61 cm) MINIMUM

48 INCHES (122 cm) IN COLDER CLIMATES

KEEP INTAKE AND VENTTERMINATION SCREENS

CLEAR OF DEBRIS

SIDEWALL TERMINATION - DIRECT VENTSTANDARD TERMINATIONS

Figure 26

��� ����� ���� ��������������~��=����������� ��*�*�����������������������������*���������������*�������������������������"����� =���� ���*�������� ���� �� ������ �������� ��� �������x�*���� \� �� ������~�������� ���� ������� ���� ���*���������������� ��������������������������x�*����\���������~��������>��=��"�������������� ������������������=������������������� ���*��������*��� ����*���**���]/� ������� ?�&��*B��)�����������*������������������������� �����������������������/���������?&]]��*B��+���V�����]��

%�� !����/������?&���*B����*������������$��������������������?&$��*B����*������������/�������������������������?�B��������������������������NOTE:�[��������������������������������������������������������������

��� !�� �� ������?�B� �� ����� ����� ����������$��� ������� ?��^� �*B���^����������?]/�&��*B����������������������������������������������+���V�����]%�NOTE:� (���� ���*������� ¢� �x����� ������ �� ����� ����������������� ����������&/��V�� )���������*�����������=���� ��������x������������������������������������=��������������=�����x�������� �������������=�������������������������x������ ������� ��������� ���� =���� ���*������� ����� ��������� ������ ����� =���� ���� ���� ��������� �����������������������������:x�������������x�����=�����������������*�x�**�������������?&��]��*B����*����������������=������*� ����� �������� ����� �� ��������� ������ �� �=��� ������� ��*"�����=������������ �����*�������=����������������������"�����(�����������*�������)������������������]%�

^�� !�*����������������������~��=�������*�������������������?�B���������������������������� =��+����

&���+�����������������*���������������?�B�=�����������?�B��������������� ���� ������� ���� ���~�� =���� ���*�������� ������ �*���������� �������� ?����� �������B� �� ���� ���� �� ���� ����������?�B�����������������������

&&��������� ��*� �����"� ������ ���� ����� ���� ���*������?�B�����* ������������ =������������������������:������������*������?�B� ��� ������� ���� ������� ���� ������ +���V�����]%�

INTERIOR WALL EXTERIOR WALL

FROMWATERHEATER

COUPLING

SIDEWALL TERMINATION INSTALLATION INTAKE AIR AND/OR VENT (EXHAUST)

METAL PLATESINSTALL INSIDEAND/OR OUTSIDE

FACTORY SUPPLIEDSTANDARD TERMINATIONPOINTED DOWN TOWARDS THE GROUND

INCREASE EXPOSED VENTPIPING UP TO A MAXIMUMOF 6 INCHES (15.2 cm) FROM WALL TO HELP PREVENT VAPORFROM DISCOLORING THE WALLSURFACE IN COLDER CLIMATES

Figure 27

&]���������� ����������������������?������������B�������������� �������������������������?�B���������������������������������������� ���������������?�B����������

&$��������������������������������������������������&/��������� ��*� ���� ������������������������������������

���� ������ ���� ������������������?�B� ������ ��� ����������������������������������=���������������������?�B�

&���)������������������������������������?�B������������ ��������[����� ���� �������� �������� ���� ��*�� �� �*�������� ���� �������� ���� ������� ���� ������ ���� ���*������?�B� ��� �����������������������������������+���V�����]%�

&���C������������(����)������������������]����'������(����)������������������]�����*��������������������������������������� ���~�� =���� ������� ������� ���� ���*������?�B� ���� �����������������

Page 30: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

30

NOTE:� )�� �������Z�����&�����?$�*B���������������������"�=�������� ����� �� �������� ������ �� *���������"� ������������*�������� *��� �� ����� +��� (�������� ���*�������)������������������]%�

��� �������������������������������*������������������������������� ����������x���������������������������Z���*����� ������� ���*������"������ ���V�����/^��������$%"����� �����*������������������������������������������� ������������������������*��� ��*����������

��� ����� ����������� *������� ���������� ���*�������� =���������������������������������������������������������������Z���������������� ����������*����������������������*������� ���*�������� ���� *����������� +��� ������ $]� ����$$����*�������*�����

%�� !�� �� �� ����� ?&$� �*B� ���*����� ���� ��� ���� /� ����� �������������*��������������������*�������������������������������������

NOTE:�[�������������������������������������������������������������������

��� ����� ����������� *������� ���������� ���*�������� =���������������� ���� ��� ��� ������*�� ������� ���� ���*��������������� ���� ���������� ���*�������� *��� �� ��� ���� ��*�� �������*���������*�������+���K�������!������������*��������������*������������$$�

^�� '����*���� ��� ���� ���������� ���*������� ����� ����� �� �����������������������������**�������Z������������������ �� ������ ���� =���� ����� ���� ��� ���� ��*�� ������� ����������������*����������*��������=��������������������������������*���������

+���V�����]^��������$&� ��� ����*�x�**�����*���**�����������������������/�������������������*�������

����� �x�������� ���� ������� �� �� ���������� ���*�������DO NOT� ��� ��������� ���� ��� �� �������� ����� ������������ ������ ���� ���*������� ���� *��� ����� �*�������* �������������*������������������������=����������*��� ���������������� ���������������� ������*�������*��������������x����������������������������*�������

Q��� ���� +'C\]�� ����� �� �x����� ���� /� ����� �������������*�������

����� ���������� ���� ������� �� ���� ���*������� ���������*������ ���� ��� ���� ������� ?������� ���B� ����� ������ !�� ������*���*��������������������*������?=���B������

&���������� �� /� )���� !��������� ���*������� )����������� �������$&�

CONCENTRIC TERMINATION INSTALLATION&�� !��������� ���*�������� *��� �� ������� ������������ [�>�

&]��\�]���*�����*����������/�������������������*�������������#* ����^���$]������!�������������������� ��������������������������*����������* ��������� �����=����������*�������������������������*��������

]�� '����*�������������������������*�������

NOTE:�C�����*�������������������������������������������� �������*���"���������������������������������*�����������=����=��������������=��� ���

$�� �������������������������������*�������=����������������������������������������x������=��������������������Z���*�������� �������������� ���*������"���������V�����$���������$&� ���� ����� *����������� ������ ����������� ���� ����������� ������������������������*��� ��*����������

/�� �������������������������������*�������=������������������������"��������*���������=��������*��� ����*���**���&�������?$�*B��������*������������"�=����������������������������������V�����]���

CONCENTRIC TERMINATION(S)MUST BE A MINIMUM OF 10 FEET(3 m) AWAY FROM ANY PARAPET,VERTICAL WALL OR STRUCTURE.

CONCENTRIC TERMINATIONFLAT ROOF CLEARANCE

Figure 28

Page 31: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

31

4 INCH CONCENTRIC TERMINATION INSTALLATION

4 INCH CONCENTRIC TERMINATION KITFOUR PIECE KIT - FIELD ASSEMBLY REQUIRED

VENT PIPE

INTAKE AIR CONNECTION3 INCH PVC

VENT CONNECTION - 3 INCH PVC

INTAKE AIR PIPEY FITTING ASSEMBLY

VENT CAPVENT PIPE ASSEMBLY

VENT PIPE IS 2 1/2 INCH SDR-26 PIPESUPPLIED LENGTH 37 INCHES (94 cm)MAXIMUM ALLOWABLE LENGTH 73 INCHES (185 cm)MINIMUM ALLOWABLE LENGTH 25 INCHES (64 cm)

INTAKE AIR PIPE IS 4 INCH SDR-26 PIPESUPPLIED LENGTH 24 INCHES (60 cm)MAXIMUM ALLOWABLE LENGTH 60 INCHES (152 cm)MINIMUM ALLOWABLE LENGTH 12 INCHES (30 cm)

VENT CAP

INTAKE AIR PIPE

3” x 3” x 4”Y FITTING

Figure 29

����* �������������������/�������������������*��������C�������V�����]^"�V�����$������V�����$&���������������������&�� !�*��������J������������������������*���������������������]�� +�����������������������������J������������* �����*������������

������� ������ ����������� ��� ���� ���*������� ��� �������������������:������� �������*���������������� ������������*��������������������* ���

$�� +��������������������J������������* ���������������������*������������������Z�=������������*���������

/�� @�� ������������� ���������� ������ ���� ��� ������ �� ���������������* ���� ���������������=������������������J������������* �������������������������

��� +���������������* ���� ������������������ !�*��������=���������������=����������������������������\

������������������������������*��� ������������������]��*������� �������������������������* ��� ����������� ������������������������*��� ����������������������������=������*���~���������������=�����������~��=���������

%�� )�����������=�������~=�������������* ����������������������J������������* ��"�:������*�������*�����=��������������*���������� ��*����������J��������

��� ����� ����������� $� ����� ������� ���� ���� =���� ������� �������������*���� ������������������ �� �������������� ���*��������

����������������/���������������������=���������\��������������������������������������*�������������������������/��x�$�� ������������������������ ����������$� ���������� ?&���������������B�������!�*����������������������������������

^�� C�������'������(����)������������������]�����*���������������������� �� ���� ������� ���� ���� =���� ������� ������� �����������������*����������������������������

NOTE: SECURING STRAP MUST BE FIELD INSTALLED TO PREVENT MOVEMENT OF TERMINATION KIT

MAINTAIN 12” (30 cm)18” (45 cm) FOR CANADAMINIMUM CLEARANCEABOVE HIGHEST ANTICIPATEDSNOW LEVEL. MAXIMUM OF24” (60 cm) ABOVE ROOF.

ROOF FLASHING(field supplied)

STRAP(field supplied)

VENTPIPE

INTAKEAIR PIPE

COMBUSTIONAIR

VENT

4 INCH CONCENTRIC TERMINATIONVERTICAL INSTALLATION

Figure 30

NOTE: SECURING STRAP MUST BEFIELD INSTALLED TO PREVENTMOVEMENT OF TERMINATION KITIN SIDEWALL.

STRAP(field supplied)

VENTPIPE

INTAKEAIR PIPE

COMBUSTIONAIR

VENT

1 INCHMAXIMUM

4 INCH CONCENTRIC TERMINATIONSIDEWALL INSTALLATION

Figure 31

Page 32: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

32

Four Concentric Terminations&�� ��������������������������������*���������������������

���������������������������x�*���������*��� �������������������������������������������V�����$/�������������������������������V�����$��

]�� V���������*�x�**��* ������������������*�������������*��� �� ���������� ��� �� ���� ������ ���� ���*�������� ���� ����������x�*���������������V�����$/�

A

A

A = 0 - 2 INCHES (0 - 5 cm)CLOSE PROXIMITY

CONCENTRICTERMINATION

CAPS END VIEW

FOUR CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)

V�����$/

A B A

FOUR CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)

A = 0 - 2 INCHES (0 - 5 cm)CLOSE PROXIMITY

B = 24 INCHES (61 cm)OR GREATER

CONCENTRICTERMINATION

CAPS END VIEW

V�����$�Groups Of Terminations&�� ����� ����������� *������� ����� �� ���������� ���*��������

������������������������������ ����������x�*������������� �� ���������� ���� �������� ����� �� ��� ��� ����� ���V�����$���;����������������������������V�����$��*��� ����*�����=������� �������������������*���� ���*�������������������������=���� ���������

A

A B

A = 0 - 2 INCHES (0 - 5 cm)CLOSE PROXIMITY

CONCENTRICTERMINATION

CAPS END VIEW

EIGHT CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)

B = 24 INCHES (61 cm)OR GREATER BETWEEN

GROUPS OF FOUR

V�����$�

MULTIPLE CONCENTRIC TERMINATION CLEARANCES ����������������*��������������������*��������=������������������ ��� �� ����������� ������ �� ��������� ������ ���� ��Z���������������� ?���������B� ������� ���*�������� ���� *�����������:����� *������� ���*�������� ���� ��������� �� ������ �����Z�����NOTE:� ������ ����������� *��� �� *���������� �� ���=���� ������������������=����?�x����B�������������������������!��������������*������� ������������������������������������*����������������� �����������*����������������� ���*�������� �������� ����� ����������������� �������������������� ���V�����$]�*��� ��*�����������+���K�������!������������*��������������*������������$$�Close Proximity & Standard Clearance&�� �������������� �������*����������*������������*��� ����

�������?������B�����*�x�**���]��������?���*B"���*��������\�V�����$]"������������������������������*������������������x�*�����+���V�����$%��������$$�

]�� ���� ���������� ������� *������� ���*������� ����� *��� ����������������*���**���]/��������?�&��*B"���*������[�\�V�����$]"����������������������������x�*����?� =�B����������� �����������������������������������

A

OR

B

A = 0 - 2 INCHES (0 - 5 cm)

CONCENTRICTERMINATION CAPS

END VIEW

TWO CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)

B = 24 INCHES (61 cm)OR GREATER

CLOSE PROXIMITY STANDARD CLEARANCE

Figure 32

Three Concentric Terminations&�� �����������������������������������*�������������������

������������������� �������������*�������*��� ����������������������x�*����������������� ����*�����������V�����$$��

]�� )�� ����� ��x�*���� ������������ �� ���� ������ ���*������� ��� ������� ��� �������������*�������*��� �� ������������� ���������� ����*������[����V�����$$�

A = 0 - 2 INCHES (0 - 5 cm)CLOSE PROXIMITY

CONCENTRICTERMINATION

CAPS END VIEW

THIRDTERMINATION

THREE CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)

A

A B

B = 24 INCHES (61 cm)OR GREATER

V�����$$

Page 33: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

33

SIDEWALL

ROOF

Figure 38Eight Concentric Terminations:����� ���������� ���*�������� *��� �� ���������� ��� ��� ��������������� ��"� ��� �������x�*���"��������� ���V�����$^��+���V�����$���������$]�����������������*�������������������;������� ����� �� ��� ��� ����� ��� V����� $�� �� ����� $]�*��� ����*�����=��������������������������*�������*�������������������������=���� ���������

SIDEWALL

ROOF

Figure 39

MULTIPLE CONCENTRIC TERMINATION ARRANGEMENTS���� ������������ �� ����� ����� ���� �*�� �� ���� �������������������*����� ��� *������� ���������� ���*�������� ����� �����������

+��� K������� !��������� ���*������� !���������� �� �����$]� ��� ��������� ����*����� �� ����������� ���� �����������������*����������

NOTE:� ����� *������� ���������� ���*�������� ���� ������������������������������*����������������*������������*��� �����������*���������*���������*�����������

Two Concentric Terminations����������������*��������*��� ����������������������x�*������� ����� ��� V����� $%� �� ����� ��������� ����������� ����� ������������*���� ��� ��� ���� ���� +��� V����� $]� �� ����� $]� ������������ ����*�������������������+���V�����$$��������$]������������������������������������*��������

SIDEWALL

ROOF

Figure 37

Four Concentric TerminationsV���������������*��������*��� ����������������������x�*������������ ���V�����$���+���V�����$/�����V�����$���������$]� ��� ��������� ����*����� �� ����������� ���� �����������������*����������

Page 34: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

34

VENTING ARRANGEMENTS

Power Vent VerticalFigure 40

Direct Vent VerticalFigure 42

Power Vent HorizontalFigure 41

Direct Vent HorizontalFigure 43

Page 35: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

35

VENTING ARRANGEMENTS

Direct Vent Vertical Vent Horizontal IntakeFigure 44

Direct Vent Vertical ConcentricFigure 46

Direct Vent Horizontal Vent Vertical IntakeFigure 45

Direct Vent Horizontal ConcentricFigure 47

Page 36: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

36

TERMINATION CLEARANCES SIDEWALL POWER VENT

V XVENT TERMINAL AIR SUPPLY INLET AREA WHERE TERMINAL IS NOT PERMITTED

v

v

A

GV

FIXEDCLOSED

FIXEDCLOSED

OPERABLE

OPERABLEV

C B B

BBF

B

V

V

A J

V

H

MX

XV

VK

B

E

D

L

POWER VENT(using room air for combustion)

EXTERIOR CLEARANCES FOR SIDEWALL VENT TERMINATION

Figure 48

������������ ������ �������������������������������������������� ��������������������������� ��������

CANADIAN INSTALLATIONS 1 US INSTALLATIONS 2 CANADIAN INSTALLATIONS 1 US INSTALLATIONS 2

A!���������� =�������"�=������"�����"�������� �����

&]��������?$���*B &]��������?$���*B H!������������������������������������x�������� =��*����~�������������* ��

$������?^&��*B�����������������&�������?/���*B�� =������*����~ ������������* ��

$������?^&��*B�����������������&�������?/���*B�� =������*����~������������* ��¤

B!���������������������������*��� �������

���������?&���*B�������������������&�"����[�~���?$���B"�&]��������?$���*B��������������� �������&�"����[�~���?$���B�����&��"����[�~���?$����B"�$���������?^&��*B���������������� =��&��"����[�~���?$����B

/������?&�]�*B� �����������������������&����?$���*B�� =��opening

I!��������������=������������=��������

$������?^&��*B $������?^&��*B¤

C!��������������*�������������������

&]��������?$���*B¤ &]��������?$���*B¤ J!����������������*������������������������������ ����������* �����������������������������������

���������?&���*B�������������������&�"����[�~���?$���B"�&]��������?$���*B��������������� �������&�"����[�~���?$���B�����&��"����[�~���?$���B"�$���������?^&�*B���������������� =��&��"����[�~���?$����B

/������?&�]�*B� �����������������������&���� ?$���*B�� =���������

D

(��������������������=����������������������� =���������*����������������������������������]������?�&��*B���*��������������������������*����

&]��������?$���*B¤ &]��������?$���*B¤ K!�������������*��������������������inlet

�������?&��$�*B

$������?^&��*B�� =������������&�������?$�*B�����������

E !������������=�������������� &]��������?$���*B¤ &]��������?$���*B¤ L

!���������� =����=����������������=������=��������������� �����������

%������?]�&$�*B� %�������?]�&$�*B

F !���������������������� ]������?����*B¤ ]������?����*B¤ M

!��������������=������"�����"�����"��� �����

&]��������?$���*B�¥ &]��������?$���*B�¥

G !����������������������� &���������?/���*B¤ &���������?/���*B¤

&�)����������������������������!+��[&/^�&"�#������_��������������)�����������!���

]�)�����������������������������#+)��]]$�&~#V����/"�#�������V���_���!���

����=����������������*���������������� =�����������������=������=�������������������� �������������������*���������������������=��� �������������� ���������*������������������������������*�����������{����������������������

¥����*�������������=������"�����"�����"��� ����������������������*���**������������ ��������������

¤�!�����������������������������������������������������������Z���*�������������������������������*�����������������������������������

Page 37: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

37

TERMINATION CLEARANCES SIDEWALL DIRECT VENT

V XVENT TERMINAL AIR SUPPLY INLET AREA WHERE TERMINAL IS NOT PERMITTED

v

v

A

GV

FIXEDCLOSED

FIXEDCLOSED

OPERABLE

OPERABLEV

C B B

BBF

B

V

V

A J

V

H

MX

XV

VK

B

E

D

L

DIRECT VENT(using outdoor air for combustion)

EXTERIOR CLEARANCES FOR SIDEWALL VENT TERMINATION

Figure 49

������������ ������ ����������� ������������������������ ������� ������������������������������� ��������CANADIAN INSTALLATIONS 1 US INSTALLATIONS 2 CANADIAN INSTALLATIONS 1 US INSTALLATIONS 2

A!���������� =�������"�=������"�����"�������� �����

&]��������?$���*B &]��������?$���*B H!������������������������������������x�������� =��*����~������������* ��

$������?^&��*B�����������������&�������?/���*B�� =������*����~ ������������* ��

$������?^&��*B�����������������&�������?/���*B�� =������*����~������������* ��¤

B !���������������������������*��� �������

���������?&���*B�������������������&�"����[�~���?$���B"�&]��������?$���*B��������������� �������&�"����[�~���?$���B�����&��"����[�~���?$����B"�$���������?^&��*B���������������� =��&��"����[�~���?$����B

���������?&���*B�������������������&�"����[�~���?$���B"�^��������?]$��*B��������������� �������&�"����[�~���?$���B�������"����[�~���?&����B"�&]��������?$���*B���������������� =����"����[�~���?&����B

I !��������������=������������=�������� $������?^&��*B $������?^&��*B¤

C!��������������*�������������������

���������?&���*B¤ ���������?&���*B¤ J!����������������*������������������������������ ����������* �����������������������������������

���������?&���*B�������������������&�"����[�~���?$���B"�&]�������� ?$���*B��������������� �������&�"����[�~���?$���B�����&��"����[�~���?$����B"�$���������?^&��*B� ��������������� =��&��"����[�~���?$����B

���������?&���*B�������������������&�"����[�~���?$���B"�^��������?]$��*B��������������� �������&�"����[�~���?$���B�������"����[�~���?&����B"�&]��������?$���*B���������������� =����"����[�~���?&����B

D

(��������������������=����������������������� =���������*����������������������������������]������?�&��*B���*��������������������������*����

&]��������?$���*B¤ &]��������?$���*B¤ K!�������������*��������������������inlet

�������?&��$�*B $������?^&��*B�� =������������&�������?$�*B�����������

E !������������=�������������� &]��������?$���*B¤ &]��������?$���*B¤ L

!���������� =����=����������������=������=��������������� �����������

%������?]�&$�*B� %������?]�&$�*B�¤

F !���������������������� ]������?����*B¤ ]������?����*B¤ M

!��������������=������"�����"�����"��� �����

&]��������?$���*B�¥ &]��������?$���*B�¥¤

G !����������������������� &���������?/���*B¤ &���������?/���*B¤

&�)����������������������������!+��[&/^�&"�#������_��������������)�����������!���

]�)�����������������������������#+)��]]$�&~#V����/"�#�������V���_���!���

����=����������������*���������������� =�����������������=������=�������������������� �������������������*���������������������=��� �������������� ���������*������������������������������*�����������{����������������������

¥����*�������������=������"�����"�����"��� ����������������������*���**������������ ��������������

¤�!�����������������������������������������������������������Z���*�������������������������������*�����������������������������������

Page 38: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

38

WATER HEATER INSTALLATION�����&~]�������(!���������

$�� DO NOT���*=�"�*���������������������������������������

INSTALLATION INSTRUCTIONS&�� :�������������������������~��������������������������������]�� )������� �� &~]� ����� �(!� ���������� ������ ����� ������� ����

�������������������������������!���������'�������������������� ��� ������������"�����V������������V������&�

$�� ���*������������������������������������������� ��� =�������������:������������������������������x������������������������������*�����������������?&��]��*B�� =�������� ��� ������������"����x������������� ������"�����V��������NOTE:� )���������*����� ��� ��� ���**�������������������������� �����*���������������� �������������������� �������

/�� :���������������������������������������=������ =�����������������������������������������"�����V������&�

��� [��������������������������������������*���������������=���������������

��� :����� ���� ���������� ������� ������� ������ ������ �"� ����+�����Q����������]�

CONDENSATE DRAIN INSTALLATION

)����������� *��� ����*� ����� ������ ����������� ���� ����� ������������V�������������*�����������Z���������������������������

�� ����=����(!���*���������(!����*����� &~]�������(!������\�*���**�����������Z�����������������

���������������������������������� ��� ��������������� &~]�������(!���������?�� ��������������B�������������

������������������������������� �����������!���������'��������������* ������������� ��� �������������

�� V���*���������������� ��������������������INSTALLATION NOTES&�� ��������������������� ��*���������������������=����� ��

����� ������������=���>���=���� �������/�$���������� )����������**����������=���� ������������������� �����Z����� �������������;�����>���=����������������'�������������*��������������� ������ ����"� ���� ��� ������ ����"� �� ���� ���������������������������

]�� ���� ����� ���������� ���������� ������ ����� *��� ��� �� �����

CONDENSATE DRAINLINE - FIELD INSTALLED

DRAIN LINE TOTERMINATE NOMORE THAN 6INCHES (15.2 cm)ABOVE DRAIN

BUILDINGDRAIN

FACTORY INSTALLEDCONDENSATE TRAP

CLEANOUT PLUG SHOULDFACE TOWARDS THE FRONTOF THE WATER HEATER FORSERVICE ACCESS

EXHAUST (VENT)ELBOW

CONDENSATE TRAP DETAIL

PVC PIPE PLUG1 ¼” NPT

CLEANOUT PIPEPLUG SHOULDBE ORIENTED TOTHE FRONT OF THEWATER HEATER FORSERVICE ACCESS

PVC BUSHING1 ½” SLIP x 1 ¼” NPT

PVC BUSHING1 ½” SLIP x ½” SLIP

PVC TEE FITTING1 ½” SLIP x 1 ½” SLIP x ½” NPT

PVC PIPE NIPPLE½” NPT

½” PVC 90° ELBOWCONDENSATE DRAINCONNECTION. FIELDINSTALLED DRAINLINE CONNECTS HERE

½” PVC 90° STREET ELBOW

½” PVC PIPE NIPPLE

Figure 50

Figure 51

Page 39: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

39

SUPPLY GAS LINE INSTALLATION

!��������������������������*���������������������Z�������� ���=���� ��� �=���� ��� ���� �� ��=���� ������� ��� ����������������������������[�������������������*������������������������������������������������������������������������������������������Z���*������� ���� ����� ���� ����� �Z��*���� �������� �� ���� *������ )�� ��������*�����������������"����������*������������=��������������������������������*�����

Fire and Explosion Hazard

Turn off gas lines during installation.Contact a qualified installer or serviceagency for installation and service.

Excessive gas pressure to gas valve cancause serious injury or death.

Do not use water heater with any gasother than the gas shown on the ratinglabel.

K�������������������������*�������������������������������������������� ������� ������ �������� �=����� ��� ����� *����� ���� ��� ��������� ��������������������������&��������!��?]��]����B�������������������&/�������!��?$�/^����B����������������������������"������� ���$��������&]���������������������=�������������*�������Z�������������������������*����������Z������������������������:x��������������������������������*����������*�����������������������������������������������x�������)��=�������������� ������� ���� ��� ������ �*������ �������� �� ���� ������ ��*��������� �� ���� ������ �����*� ���� ������ ��������� ���� =��=��*��� �������������������������� ����̀ �������+��=������������:�������������������=�������������������������=����=��=������������������������ �������������������*��������� �������������������*"���� ������������������(���� �������*��������������������*��)�� ��� �*������� �� ����� �������� ���� =��=�� ������ ��*�����*������������������������+���������*���������*�������������"��������x�������)���������������������������������*��� �������������������������������������������=����

REGULATED GASSUPPLY LINE

MAIN GASSHUTOFF VALVE

TEE FITTING

PIPE CAP

SEDIMENT TRAP

Figure 52

:���������������������������������������� �������������������������������������������*������������������������������������*���������*��� �����������������������V������]����������*���������*��� ����������������� ����������� {�������������������������)��������������������������������**��������������������������������*�����

GAS LINE SIZING'�����������������=�������Z�=����������������~�������* ������������������������������**��*���"����������������������������*�����=���� ������������+���� ���������~*�������� ����?�B� �������������������� ��������� ���^������=��������=�������� ����������� ���^�����������������������������������������������!��?&]����B������������"����������������������*����������������������*���#������������������������� ��������������������������������������������+�������/��+�������������)�������������������������*���������������������������������������������)������*������=�����������������������**�����������������������=������������#�������V���_���!������!��������+���������+������ ����?!++�B���������������������������������������������SUPPLY GAS LINE SIZING U. S. UNITSTABLE 8LENGTH

INV::�

#@CK�;��)C@#��)�:�+)�:+�?)#!>:+B)#�Q��)#��>@Q+�#'+�[�Q~>C

&~]� $~/� &� &�&~/� &�&~]� ]�10 175 360 680 1400 2100 396020 120 250 485 950 1460 275030 97 200 375 770 1180 220040 82 170 320 660 990 190050 73 151 285 580 900 168060 66 138 260 530 810 152070 61 125 240 490 750 140080 57 118 220 460 690 130090 53 110 205 430 650 1220100 50 103 195 400 620 1150125 44 93 175 360 550 1020150 40 84 160 325 500 950175 37 77 145 300 460 850200 35 72 135 280 430 800

SUPPLY GAS LINE SIZING METRIC UNITSTABLE 9LENGTH

INMETERS

#@CK�;��)C@#��)�:�+)�:+�?)#!>:+BINPUT IN kW

&~]� $~/� &� &�&~/� &�&~]� ]�$�� 51 105 199 410 615 1160��& 35 73 142 278 428 805^�& 28 59 110 225 346 644&]�] 24 50 94 193 290 556&��] 21 44 83 170 264 492&��$ 19 40 76 155 237 445]&�$ 18 37 70 143 220 410]/�/ 17 35 64 135 202 381]%�/ 16 32 60 126 190 357$��� 15 30 57 117 182 337$��& 13 27 51 105 161 299/��% 12 25 47 95 146 278�$�$ 11 23 42 88 135 249�&�� 10 21 40 82 126 234

Page 40: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

40

GAS LINE CONNECTION&�� ���� ������ �������� �=����� �� ����� *����� ���� ��������

��*����� ������������$~/� ���������������������������������������������*������ ���*�����������$~/�������!����������������������������������������������]/�(���_���(��=����� ���������� ����� ���� ������� ��� ����� ���� �������� ������Z���*������

]�� '��������� �� ���� ��=������ �Z�=������ ������� ���~�� �����* ������������������������������**��*���"������������ �������������� �����*�����=�� �� �� ���������"�����_���;����+�������������$^��)���������������������*��� ����\������������������**����������������������������������������*������� ����������� ��� ������� �������� ���� ����� ������������������������������������������������������V������$��NOTE: Make the transition to the larger supply gas line as ������������������������������������� ���

FIELD INSTALLEDPIPE NIPPLE

INSTALL A REDUCERCOUPLING WHEN ALARGER SUPPLY GASLINE IS REQUIRED

SUPPLY GAS LINE CONNECTION120,000 & 150,000 Btu/hr MODELS

24 VOLTGAS VALVE

TO MAINBURNER

FLOW

Figure 53

$�� ������ ������� �������� �*����� ?����� ���~����� ����B�������������������������*�����������������������{������'�������������������*���������������������������Q������������������������*��������� �������������������������������Z���������*�?;�~������B�������

LOW GAS PRESSURESWITCH

COMBUSTIONBLOWER

SUPPLY GAS CONNECTIONFACTORY INSTALLEDTEE FITTING

SUPPLY GAS LINE CONNECTION199,000 & 250,000 Btu/hr MODELS

Figure 54

/�� Q����������*���{�����{��� ����������?���������*�����������B������ ������������ ���������]/�(���_���(��=����������������������������������������������� ���������=��=���DO NOT���������������������������?+�������������B������*���������{������������*������*����������*��������=��=��

��� Q��������������������������?+�������������B������ ���������������������������������������� =������������������������������������������������������������������=��������]/�(���_���(��=�����������������������*����������������������������

��� �� ���=���� ��*���"� ����� *��� �� ������ ��� �� ������ ��*��� ��Z�� ����� ���������� ���� ������ ���� ����� �� ������������������

%�� )�������������*��������������������V������]��������$^���� )������� �� K���� _��� +����� =��=�� ��� ���� ������ ���� ����� ���

��������V������]��������$^�

NOTE:�+����=����������������������������������� ��������"������������K����_���+�����=��=���������������������

GAS LINE LEAK TESTING

Fire and Explosion Hazard

Leak test before placing thewater heater in operation.Disconnect gas piping and maingas shutoff valve before leaktesting.Install sediment trap inaccordance with NFPA 54.

Use joint compound or Teflon tapecompatible with propane gas.

������*����������������������������������*������*����������������=����������� ���������������x������&�� V�����������������x��������&~]�����?$�/�����B�����������

���� ������ ������� ���� ���� K���� _��� +����� (��=�� ��*� �������� ������ ������� �����*� ������ �������"� ���� V����� �]��� ����� $^�� ���� ���� ������ ����� *��� �� ������� �������������������*������������������

]�� V�� ����� ��������� �� &~]� ���� ?$�/�� ���B� �� ����"� ���� ��������������������� �������������"� ��*��� �� ����������*����� ������ ���� ����� �� ������� ���� K���� _��� +����� (��=����������������

$�� �������������������������{�������������������������*����������������������������������������������������������������������[ �������������������������'�������*������"��������"���*����������������������������������������

/�� C���������������� �����������������������������������������

PURGING_��������������������Z����������������������������*��������������������������������������� �������*���������������������������#V����/�����#�������V���_���!���

Page 41: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

41

?):�����������B����������������������������*��������!![������������=����������������*��������������Connecting An External Supervisory Control������� ��~���� ���������� ������������ ��*�����!![���¦�����������������!![��������"����� ������������������������������!![����������V�*����������������������������? ����B�{*������������������� ������������������&&�������¦�����"�����V����������������%�������������¦������)���������������������������� ��~���� ����������&�� ���� ��� ����� ��� ���� ������ ��������� �~��� ������� ���� ����

��������������������������������������������]�� ;���������!![���������$�� C�*=�� ���� ������� ��*� ���� !![� �������� �=��� ����

�����������������!![����������#���������������������������������������=����� ������������=����������������������������

/�� ����=����������� ��~���� ���������������������+&�����������������!!["�����V����������������%���� ������+&�����������¡]�������������������� ������+&�����������¡$������������������

��� ;����� ���� ����� {*��������� �����������������&&�������!![�¦�����"�����V����������������%�����V������������������

��� !������ �����{*����������������*������%�� +���������x�*������&~]�������������������*�������������

������ �����{*������������ Q��������������������� ���������������������������� ��

������������������ �����{*����������������������������������������������������������

^�� �������������������������������!![�������������������������������������������������������!![����������=����:��������������������������������������������������=�����������������������:����������������� �������������

&���C�������������!![����������=����������������������&&��C��� ���� ������ ������ ������� ���� {������ x� �� ���� ���

�� ����������������"����� ������������������ �� ������ ����{������ x��Q�������=���� �������\�����������������������������{������ x�

&]��)������� ����� ������������������������������� ��� ��Z����� �� �������� ���� ����� ����� ������� ���� ������ ���������{������ x����� �����x������� ����=����� �������!�������������������*������x������������������������������������������{������ x�����������������������������������

&$��!������ ���� ������ ������� �� �� ���� �� ���� �������� �� �����x��������������V��������������*�������������������������*����������������

&/��C������������������������������NOTE:� �����=��� ���� �x������� ������ ����� ���� ���� ������ �������� ���"� �������� �������� ����� �� ���� ����������=��� ���� �x������� ������ ������ ���� ���� �� ������������ ���"� �������� �������� ����� �� ��� ����� ����������������������������������=�����������**��������������������������*��������������������������������������� �����+�������+�����)��������������������� ���&&��������/��NOTE:� :����� ���� ������ ������� ��� ��������� ��*� �����������*��������� ����� �������� �������� ��� ���� ����� '�*���� ������������������������� �������������*����������������=����������������*��������������

ELECTRICAL WIRING

���� ����������� ���� *��� �� ���������� ��� ���������� ����� ����#������� :���������� !��"� �#+)~#V��� %�� �� ���� !��������:����������!��"�!+��!]]�&������������Z���*�������������������"������������������*��� ���������������������������������������������������"��������� �����������������"����������#�������:����������!��"��#+)~#V���%��������!��������:����������!��"�!+��!]]�&�)����������������������������������������������������������*��� ����������"� ���*��� ����������������&���!���������������� �����Z�=�����"��x������������ ������������)���������������]���!������������*��� ������POWER SUPPLY CONNECTIONSC����������Z���*�����������������+������������&/� ��������������������Correct Polarity:���� ������ ��������� ������ �����*� ��� �������� �������=�� ��������� �������������� ������������������� ��� �������������� ��������� ������ ��� ��=������� ���� ������ �����*� ����� �������� ������!� C�=������� V���� *������� �� ���� ;!'������ &]�� (�!� ����������*����������������*���������������� �����������������{������ x���������&]��(�!�������������*����������������������������������{������ x����������������������������������������*��� ��*��������������&�� :����� ���� ����� ������ ��� ������ ��� ��� ���� ������� ��

�����������������]�� C�*=������{������ x��=����+��� ���������������������

{������ x���������$�� !����������&]��(�!�����������*����������������������

�����������������{������ x�����������������������������������������������������������������������������������������������������������+����������������*��V����������������������V������%���������^�

/�� !����������&]��(�!���������������*����������������������������������������{������ x������������������������������������������������������+����������������*��V����������������������V������%���������^�

��� !������ ���� ����� ����� ��*� ���� ����� ������ �� ������������ ��� ������� ���� {������ x��+����������������*��V����������������������V������%���������^�

��� C������� ���� {������ x� �=��� ����� ���������� �����*������

NOTE:�'���������������������������������� ���������������������*�����������������������������������������������ENABLE/DISABLE CIRCUIT���� ������ �������� �=����� ��� ����� *����� ���� �Z������ �������� ��� ��~���� ��� ������� ��� ��� ����� ����� �������� �x�����������=����� ������� ���� ��� ��*�� ������ �� ������� [�������K�����*����+����*���������� ��~���� ����������*��� ������������ ����������������������������������������� ���������������������������������*������������������ ��� ���� ��� ��~���� ��� ������� ��� *��� ����� �� ����=����� ���������������+&��������������������������������!![�?�������������� ���B"�����V����������������%��V����������������������� ����� ���������� ������� �������������������!![���������������������������?��=�����������B���������������������x��������������NOTE:����������������������� ��~���� ���������� ���������������������������'�����������x�������=������������������� ����

Page 42: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

42

T&P VALVE DISCHARGE PIPE

Explosion Hazard

Temperature-Pressure Relief Valvemust comply with ANSI Z21.22-CSA 4.4 and ASME code.

Properly sized temperature-pressure relief valve must beinstalled in opening provided.

Can result in overheating andexcessive tank pressure.

Can cause serious injury or death.

����� ������ ������� ��� ��=����� ����� �� �������� �����~������ ������������� �* ������� ��*�������� \� �������� ?�<�B� �������=��=�� �� ���� *����������� +��� ��*�������\�������� C������(��=�� �� ����� &�� ��� ����*����� �� �������*���� ���� �������Z���*�����

Water Damage Hazard

Temperature-Pressure Relief Valve dischargepipe must terminate at adequate drain.

CAUTION

)������������������������ ������������<��=��=����������������������� �� ���� ��� ��� ������� '� ��� ������� ���������� ���������������� �� ��������������������� ?&��]��*B��������� �����=�����������=���� �������{��"��������������"�������������*���"������������ =��=�� *��� �� ������� �� ���������� ������ ��� ���Z����Z������������������*����������*�����)��������������������������������������������������������� ���*����"��������������*������������������*����T&P Valve Discharge Pipe Requirements:

�� +�������� ���*��������������������������������������������=��=�"�����=�����������������������������������������

�� +�������� ����������� �������� +�������� ���x������������������*����������� +����� ����*��������������������������������� ������ +����� �������������������������*����������������� �������

��*�������\��������C������(��=��������������������������� K������*��������*�x�**�����x��������� =�������

���������x������������� ��������)���������*����"����������**������������������������������ �����*����������������Z��������������������� �������

�� +����������=������=��=��������� �������� ������������������=��=����������������

WATER LINE CONNECTIONS

�����������������������������*�������*������������������������ ������ ����������������� ��������������=���� {�����������_�������������Z�����������������=��������� ����������C���� ���� ���=�� ���� ��Z���*����� ��� ���� �������� �������� ������������������������������������ ������&�� K�x����(��=����������&��]�� '�����������K���������������&��$�� ��*�������\��������C������(��=���������&��/�� !�����+����*����������*���:x��������������&����� V�� *������� ������ ������� ������������� ���� ������ �������

'�����*�� ����������������%&�WATER PIPING DIAGRAMS�����*�������=���������������������������������*�������������*���������������������������������������"������������������'�����*�� ���������%&������������������*��� �� ���������� �� ������"�������������������������� ������ ����� ���� ����� �� ��������� ������� ����"� ��������������*��� ��������� �����=������ ��*������� ������������*����������������������*��������"� ��� ��� �*����������������������������������� ������������������������ ����*���**����� ��������������������������������������������{��� ��� �� ���������� �� ���� ���� ���� =��=�� ���������� ��� �������������������������������������������*���#�=������������������������������������*���+��������������������'�����*�� ����������������%&�NOTE:�)�����������������������������������*�������\��������C������ (��=�� ?�<�� =��=�B� �� ���� ������ ������"� ����� ��*��������������������*��� �������������������������������������������������� *��� ���� ��=�� ���� ��� �������� �����"� ������ ��������=�����*�������\��������C������(��=�������������!���� ���� ���� ����� ����������������������* ��� ��������� ���� �����=����������*���������������������������������������<��=��=�������*����������������THERMOMETERS (NOT SUPPLIED)����**������ ���� ���������� ��� ���� ������ ������� �����*� ��� ��*����� �� ���������� ���� ��*�������� �� ���� ��� ������ ��������� ��������� ������ ��� ���� �����*�� V����� �������� ����**����������� �� ����������������������+����������������'�����*���������%&�WATER (POTABLE) HEATING AND SPACE HEATING&�� ������������������*�����������������������������������

�������������������������������������������� ������ ��� �������������� ���������

]�� �x��� ���*�����"� ���� ��� ����� ���� ��� ����� �����*���"�*���#:(:C� �������������������������*�

$�� ���� ������ �������� �=����� ��� ����� *����� *��� ��=��� ����������� �������x��������������������*����*�����?�B����=����������������\��� ���������������������������

/�� ����� ���� �����*� ��Z����� ������ ��� ������ �������� ������x������������*�������������*�������������x�������*�x����=��=��*��� �����������"�����K�x����(��=����������&��

��� ������ ������ �������� ������ �� ���� ��� ������ ������������������������

Page 43: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

43

+�����������@���������+�����������&]��V�?/^�!B��������������������� �� �������� +*�� +������ ��Z���� ��������� ��� �������� �������*���������TABLE 10

��������*������� �V�?�!B

��*�����&���'������[�� ?;����+�=����[���B

��*��������*������[��� ]���<�$���'�����

?K���+�=����[���B&&��?/$B ?��*�����������*��B&&��?/%B ?�������������B&&��?/%B $��*����� /��*�����&]]�?��B &�*���� ��*�����&$&�?��B �������� ]��������&/��?��B ]������� ��������&/^�?��B &������ ]�������&�/�?��B instantaneous &������

?Q�+��_=���*����K�*����*"�!���+�!�"�������;����*�����"�+�����&�"�&^%�B

���� ������ �������� �=����� ��� ����� *����� ���� �Z������ �����������������������������*��� �������� ���������� ��*�����������������������������������������������*����������*����������*� ��� ������� ���������� ��*���������� ��"���� ���������� ������� ����� ����������� ������������ ��������������� ���� ��*"�+������(������������������V��������������&���������������� �@��������� +��� ������ ��� ��{����� �� �������� ��������*���������������������������������������������{��� ��������������� ��� ���������� �����*��� ���*���������K������������������ ������ �����*�*����������������� ������ ����Q)K� ?��������������*���B� ��������� ���� ������� ����������������"�����V������������@���������+�������������{��� �����*�^��V�?/]�!B���&���V�?�]�!B������������������������&]��V�?/^�!B��+���@���������+������������'��������������{��*�����������/%������������������������{�������@���������+������������������������������+�������@���������+���������������������������������������������������� ��������������������������������������=��������*���������������������������HIGH TEMPERATURE APPLICATIONS>������ ��������� ��*��������� ����� *��� ����� �� ���� �������������� ���� ����� ��������� ���� ����� ����� �� ���� ������ ��������!������� ����������� �� �*���� ����� ������ ������� ��� �������*�������������������"� ��������**������������������"� �������������������*����������*���������������*�������������������������������������������*��������!�������������������� ������������������������������������* ��� ������� �� ���� ���� �=��� �� ����� *����� ��� ����������������������������

Tank Temperature 103°FOperating Set Point 120°FStatus: Heating

MENU HELP

UP

DNGAS

OFFON

MANUFACTURER / MODEL INFORMATION

Figure 55

HIGH TEMPERATURE LIMIT CONTROL (ECO)

����������������������Z��������������:!@�?�����������B������{��� ����������*����������*���������������:!@��������*����������������������������?����=����B���������������*������������:!@����������������������Q�������*���������� ��?������������B"�����������������^����������������:!@��������������������� ���� ����� ���� ������ ��*�������� �������� ����x�*������]�]�V�?^/�!B�����������������x�*������&/��V�?/^�!B��)�� ���� :!@� ����=����� ?�������� ���B� ��� �� � ��*����� ����������� ��*��������� ��� ����������� ����� ���������� �����*�������**��������� ��\��������� ���� ]/� (��� _��� (��=�� ���� ���� �����������������������������������������*������������������ ������������ �������� ��������� ���� ������ �����*� ����� �������� �����:������ !�� @�� ?:!@B�� V���� *������� �� ���� ;!'� ��������)�� ��� �*������� ����� �� `������� +��=���������� �� ��������� �������*���������������������:!@�����=����� �������������������:!@��@������������������ ���������*����������������������:!@����� �����������������+��������:!@�����=���"�������������*��������*������� ����&/��V�?/^�!B� ��������������������*����� ���������@����������������*����������������� ������������������������������������������������*��� ����������������������������������������������*�

THERMOSTAT CONTROL

Water temperature over 125°F (52°C)can cause severe burns instantlyresulting in severe injury or death.

Children, the elderly and thephysically or mentally disabled are athighest risk for scald injury.

Feel water before bathing orshowering.

Temperature limiting devices such asmixing valves must be installedwhen required by codes and toensure safe temperatures at fixtures.

>����������*�����������Z����������*��������������������������������������������� ��������������������������������{��� ���~�� ������� �� ��� &�� ����� ���� ����x�*���� ��*�\�\ ��������������������*�������������������*�������������������{��������=��������������������������� ���� ������� �� �x������ ���� ������ �������� ��*�� ����������"������������������� ��������������������������������������*��)������������������������=����� ������������������� ������������������������������������������������������������������ ������ ���� ��Z�������� �������������� ��*����������� �������������"������������������������*��� ��������)������������������������������� �����*������������������������������ ���� ��*���� �� ���� ����������� �� *�x���� =��=�� ���� ��������������������������������?����V��������������&�B��������������������������������������������*���������*��������#�=���������*������������������������������������������������� �����������#�=������=���������������� ������������������������� ���� �������������������������������� ��������������������������������������� �������������=�����������������*���������

TEMPERATURE REGULATION

Page 44: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

44

����������������������������������������� ���������*�����������"������������������������������� ��������x������������������������� =������� ����������;!'���������

THE DESKTOP SCREEN'����� ��*��� �������� ���� ������ �����*� ����� �������� �����'���������������� ����;!'������� ��� ����������������������������������*������������������'����������������������������������=��V���� �������� ���������������� ���������� ��������������������=�����*�������

�� K���������������������������*��������*���������������������������[�������������������'��������������K�������������������������������������[����������=�����������������������*�*����

�� �����������*�������������������'������������"��������*�������"����������*�����������������������������������������������������������

�� ������������*�������������������'��������������������@���������+�������������@���������+�����������������*��������������������������������*������*������������������������������������������

�� [�����������@���������+����������������+����������������+�����������������������������������������������������������*�����������*�"������� ���&]��������/������������������������=����������������������

�� ����'�����������������������������*������+�����)���������=�����������������*����"������� ���&&��������/�����������������������+�����)����

OVERVIEW

�������������������=�������������*����������Z�����������������������������������*�����������������������*������������������� ������� ������>������� ����������� ������������*������� ������ ������ �����*�� ���� :!@� ?������� ��� �B"� ��*�� �����"��������� ��������� ���� ��*�������� �� ��� ���� *������� �����������������*������!* �����[����"��������"�]/�(���_���(��=������������������������������ �����������������*��

���� *���� �*������� �� ���� ������ �����*� ���� �� Q)K� ?��������������*���B�������!![�?�������������� ���B������Q)K������������������������������������������������������!![����*���������������������������������������������=�����������+��� V������� ���� !*������� �� ����� %� ��� ������� ������������������������������*�������

CONTROL SYSTEM NAVIGATION

�������������� ����*������������������������������������������������� ��*� ����Q)K������Q)K������ ���������� �����*���;!'� ?��Z��� �������� �������B� ���� �=�� ����� ������� ?**������B����� ����� ������ ��� �"� ���� ���� ������ ?$B� *���� ������������������� ����� ��������;!'"�����V��������

User Input Buttons�� �������������� �����������������=������*��������

��{�����������������

�� �������������� ��������������������~�x���*���"��������*������*�"�����=������{��*����*������������*�

CONTROL SYSTEM OPERATION

Tank Temperature 103°FOperating Set Point 120°FStatus: Heating

MENU HELP

GAS

OFFON

MANUFACTURER / MODEL INFORMATIONLCD ScreenInformationDisplay

Status Icons

3 Operational buttons:enter/exit menus,select menu items,activate adjustment modes,confirm/cancel changes.

Up & Down buttons:navigate menus,adjust user settings

Title Bar

Operational buttons are multi functional. Their current function is defined bythe text that appears directly above each button on the LCD screen.

UIM (user interface module)Desktop Screen Shown

UP

DN

Figure 56

Page 45: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

45

STATUS ICONS����+�����)������������������������'�������������������=�������������������������������*������������������������� ������������ ��� �����+���V���������������//���������+�Z�����@��@�������������������TABLE 11

Icon Description��������*��������������������������������+��������������������*���������**�������������������������������������������������*���������������������������������������*�����Q���������;������*���������� ����+��� ����������������������V��������������&����������������*���������� ���

��������*������������������������������������@���������+������������������������*������������+���� ��*���

��������������� �����������������������������������������������������=�����V������������������������ �����������������*������������:�� ��~'��� ����������������������������V��*�������*���������:�� ��~'��� ���!�������������/&�

����!* �����[�������� ���������������

����[�������=����������������������������=�������������������*�����������=���������*���������������������+��� ���������������������[�������=���+�������������

����>��+������)���������� ����������������+���V�����]��������%����>��+������)��������������

���������������� ���������������������������������*������������������Z�����*���**���������������������������*�����������=���������*�������*���**�����������������+�������+�Z�����@��@���������������������*���**��������?�!��*��B�����*�����

GAS

OFFON

����]/�(���_���(��=����� ���������������

���������������*��������������*���������K����[�������*�������*���������+�������+�Z�����@��@��������V���!�������������^�����V�����]��������%�

���������� �����*����������������V���� ������������*��� �� ���������~���=����� ����`�������+��=�����������V����*������������������� ��=�������������!������V����*����>���������������������� ����?�����B���������������������������������V�����������������������������������������*��� �����������������������������������������*��NOTE:�!�����������������������������������������*�������������������������������V����������� �������������

���������������*�����������������������������������*��� �����������~���=����� ����`�������+��=������������������������������������������������������������������������

Page 46: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

46

OPERATING STATES�����������������������������������������������������������������'���������������������+������������**����������������������������� ������������ ��� ������+���V���������������//���������+�Z�����@��@������������������TABLE 12

State Description+���� � ���������������������������������=�����������������):�������������*����������������� =������@���������+��������

)����(��������� ���������������*�������������������������������������� ���������������������������

+����!�����'���� ���������������*��������������������\���������*�����������x����� �����������������������������������������=����������\����������������������������������������������*������������������>��+������)�����������!* �����[������NOTE:�)�����������������*�����������������������������������������'�����������������������������*���������*�����������������������������

Pre-Purge ����!* �����[�������������������������������������������*������* ��������* ������������������

)����������*�Q� ����>��+������)���������������������������������������*����������������������������+�������+�Z�����@��@���������������������*���**��������?�!��*��B�����*�����

)�����������=���� ����]/�(���_���(��=��������������������������������������������������K����[�����

)�������(��������� ���������������*����*��������������*�����������������Z�����*���**���*�����������������+�������+�Z�����@��@���������������������*���**���*�����������������?'!�*�����*��B�����*�����

Inter-Purge ����!* �����[������������������������������������������*������* ��������* ������������������������������*���

Heating )�������������������"���*��������������������� �������� ���������������������������������������� ������������

Post-Purge ����!* �����[�������������������������������������������*������* ��������* ��������������������������������

V��� ���������������*����������������V�������������>���������������������� �������������V�������������������������������������������������*��� �����������������������������������������*��NOTE:�!�����������������������������������������*�������������������������������V����������� �������������

CONTROL SYSTEM MENUSV�*�����'��������������������������@������������������� �����K����������;!'�������������������K����K���������������������������������*�*���������������������� ��� ���������� ������������������*�*����TABLE 13

Menu Description��*�������� K����**�������������*����!�����������@���������+������������'�������������������������

Heater Status �����*�������������������������������������������������������������:!@�?���~�����B�������~����������� ����!* �����[����"�����=��=�"��������"���*�����������������*���������������������*�����������������������������*���

Display Settings ��*�������������?�V����!B"�����;!'������������? ���������~�������B����� ���������������������{��� �������������������������������*���

>������)���*���� :������� ��*�����������"� ������������������� ��*�"������������������"����������� ��*������������Q)K�����!![�����������=���������� ��=��������������*���

!������V��� '���������������������������V����*��������

V����>����� ����������������*�*����������������������������������?^B�V��������������*�����������������*�����*���������������=���������������������������

V����@�������� ����������������*�*������������������������������*������*��������V�����������������������������������������������������������������

C������V������'������ ����������� �����*� ������������� �������� �� ������������� �����*�������������� �� ������ �������������� ����������'�������+���������������������C:�#@������������������������������������������

>����+������ ��x�� ���������������������������*������x���������������������������������"���=���������������������*�*������������������������

Page 47: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

47

USER SETTINGS & CONTROL SYSTEM MENUSTEMPERATURES MENUOperating Set Point And Differential Adjustment����@���������+�������� �����{��� ��� ��*�^��V�?/]�!B� ��&���V�?�]�!B������ ��������������� ���&]��V�?/^�!B������'������������ �����{��� �����*�]����]����������������������������������������������������������������*�������*���������*���������������������������������x�������������{������������������������=���������������������*�*���������������������*��������������� �����������������*���*��������?�������������B���*���������� ���������������@���������+�����������������������*�������������������������������������������������� ������=�����������������������������������*������������� ��������@���������+��������*��������'��������������������NOTE:� ;���� '������������ ��������� *��� ����� �x�����=�� �������� ������� ?����\�������B� ������ ���� ����� ���*����� ������� ���*�������������� ����>��+������ )��������+��� ����'��������������� ������������������������������������������� �������������������+�������@���������+��������������������������������������������������� ���������������������*���������������

DESCRIPTION/ACTION DISPLAYV�*�����'������������"�����������@����������[���������K:#Q�������K����K���������������� ������������

Tank Temperature 120°FOperating Set Point 120°FStatus: Standby

MENU HELP

MANUFACTURER / MODEL INFORMATION

����K����K���������������������������*�*��������������"������� ���&$��������/��������*���������������������������������������*�*�����Q�������Q������'���[�������=�������������������*�*������*�����K����K���

�������*���������*������������?��������������� ����B��������K����K���������"�����������@����������[����������+:;:!�����������������*���������*���

)��������*���������*�������������������������Q������'���[�������������������*������*�

TemperaturesHeater StatusDisplay SettingsHeater InformationCurrent Fault

SELECT BACK HELP

Main Menu

���������@���������+��������������������������*���������*��"�����������@����������[���������������!>�#_:��������=����������{��*����*�����������*������*�

)��@���������+������������������������������Q������'���[�������������������*������*�

NOTE:�>��������*��������������������������������������������������+�������@���������+��������������������������������������������������� ��������������������������������������=��������*������������������������������������������

Operating Set Point 120°FDifferential 8°FTank Temperature 120°FUpper Temperature 122°FLower Temperature 118°F(Heater Regulated to Tank)Upper Probe Offset 0°F

CHANGE BACK HELP

Temperatures

�����������{��*����*����������@���������+������������=������������������ �����������������*��� ������������� �����������

Q�������Q������'���[���������������������������������

����������@����������[����������Q�'��:������=�����������������������������@����������[����������!�#!:;���������������������������������������=�������=�����������

NOTE:�Q����������*�����������������������'�������������������������������{��� ����������������������������������*�*����

Operating Set Point 140°FDifferential 8°FTank Temperature 120°FUpper Temperature 122°FLower Temperature 118°F(Heater Regulated to Tank)Upper Probe Offset 0°F

UPDATE CANCEL

Temperatures

Page 48: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

48

TEMPERATURES MENU (CONT)

DESCRIPTION/ACTION DISPLAY�� Tank Temperature�\������{��� ���\������������*�

���������*��������?�=���������*�����������������*���������� ��B�

�� Upper Temperature�\������{��� ���\������������*����������*����������*�����Q�������*���������� ��

�� Lower Temperature�\������{��� ���\������������*����������*����������*�����;������*���������� ��

�� (Heater Regulated to Tank)�\������{��� ���\���������������*�����

�� Upper Probe & Lower Probe Offset�\���{��� ��������������"�������\�����§���?�����������������B��NOTE:������������������������� ���������������������������� ��*�������� =������ �������� ��*� ���� @��������� +���������������������Q���������;������ ��@��������������� ������ ����������������*���*�������������������������� �*��=�� �����������������*�������������� ���������������������������������������������������������� ���������*����������� ������� ������������ ���� ?��� ������ ��������� �� ���������������B������*��������������������������������*���������*�������:x�*����� )�� ���� ������� ������� ��*�������� ��*� ����*���������� �����&]��V�?/^�!B���������@������������������������ �������{���������=����������������"����������������*��������� ������� �������� ����������� ��*����������*������� �����������=��������������*���������>�������������� ���� �� ����=����� ���� ������=����� ����� �� �������� ������?�����B���*�����������������������������{��������������*������������ ����������@���������+������������'��������������{��*�����������/%�

Top of Menu

Operating Set Point 140°FDifferential 8°FTank Temperature 120°FUpper Temperature 122°FLower Temperature 118°F(Heater Regulated to Tank)Upper Probe Offset 0°F

CHANGE BACK HELP

Temperatures

[��*���K��

Differential 8°FTank Temperature 120°FUpper Temperature 122°FLower Temperature 118°F(Heater Regulated to Tank)Upper Probe Offset 0°FLower Probe Offset 0°F

CHANGE BACK HELP

Temperatures

HEATER STATUS MENU

DESCRIPTION/ACTION DISPLAY+������ >������ +����� ��*� ���� K���� K��� ���� ������ ����@���������� [���� ����� �+:;:!��� �� ������ ����� *���� �����*����������������{��� �����������������*������Q�������Q��<�'���[���������=����������*���

�� Status�\���������������������@���������+����"������� ���&]��������/��

�� ECO Contact"�Low Gas PS"�Blocked Inlet PS"�Blocked Outlet PS"�Blower Prover PS�\�������������������������������������������������������������

�� Blower On"�Igniter On"�Gas Valve On�\��������������������������������������*��������������������������������������������*������������ ����������"��� ���\����������

�� Igniter Current�\��������������������������������������*��������������������Z�����*���**�������"�����+�Z�����@��@������������������

�� Flame Detected�\��������������������������������������*��������������K����[�������*������������������*�������*��������

�� External Input Enable�\���������������������������+&���������������=�� ������������������=����������� ��~���� ���������"�����:�� ��~'��� ���!�������������/&�

�� Ignition Trials�\���������������������������+&���������������=�� �������������������&���$������������������� �������������������)�������V�������V�����������"���������!![�\�!�������!�����[����;������������%�

Top of Menu

Status StandbyECO Contact ClosedLow Gas PS ClosedBlocked Inlet PS ClosedBlocked Outlet PS ClosedBlower Prover PS OpenBlower On No

BACK HELP

Heater Status

[��*���K��

Blower On NoIgniter On NoIgniter Current NoGas Valve On NoFlame Detected NoExternal Input Enable NoIgnition Trials 3

BACK HELP

Heater Status

Page 49: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

49

DISPLAY SETTINGS

DESCRIPTION/ACTION DISPLAY+������ '������� +�������� ��*� ���� K���� K��� ���� ������ ����@���������� [���� ����� �+:;:!��� �� ������ ����� *���� �����*�������������{��� ��������������������=�����������*������� ���� Q)K��� ;!'� �������� Q��� ���� Q�� <� '��� [����� ����=����������*���

�� Temperature Units�\���{��� ������������������������������*�����������������������!�������!���V�����������V�

�� Backlight Delay�\���{��� �������������������������*����������������Q)K���;!'� �����������*��������*����������������������� ��������������=���� ������������������������@��"�&�"�$�������������������������@��

�� Contrast�\���{��� �������������������{�������Q)K���;!'���������������� ���������x������ ��������NOTE: ������ ��������� ���� ��{����� ��� ���� ��*�� ���������� ��� ��� ���� @��������� +��� ����� ���� '��������������{��*�����������/%�

Temperature Units °FBacklight Delay 30sContrast 60%

CHANGE BACK HELP

Display Settings

HEATER INFORMATION

DESCRIPTION/ACTION DISPLAY+������>������ )���*����� ��*� ����K����K������������� ����@���������� [���� ����� �+:;:!��� �� ������ ����� *���� �����*����������������{��� �����������������*�����

�� Elapsed Time�\���������*��������*�����������������*�?������������B����� ��������������

�� Burner On Time�\���������*��������*�����������������*����� ����������������������������������� ����������*��

�� Cycle Count \���������*����������������������������� CCB Version \�+�������=����������������������� ������ UIM Version \�+�������=�����������������������*����

NOTE: >������������������������������!![���*�*����)�������!![����������������������=�������������������������������!![� ������������������� ���������������������������������������� ��������� �� ������ ������� ����������� ������� �� ���������������������:���������*�"�[�����@����*������!�����!���������������"���������������)�� ���� !����� !��� ���� ���� ��� ����� ?��=���� ������ ���� ������� �������*������������������B��� ����������������� ��������?�����*���� ���������*�������*�����"���=���� ������� ��*�� ����� *������ �� ������ ���B� �������� ������� ����'������������ �������� �� �=��� ����� �������� ���� �x�����=���*����������"�����@���������+������������'��������������{��*�����������/%������ ���������� ����� ���� ���� �� ���� �� ������� �����������*�������������������������������������*�������Z��*������������=������������������������������������������������

Elapsed Time 10 day 0 hrs 0 minsBurner On Time 5 hrs 22 minsCycle Count 00000035CCB Version X.XXUIM Version X.XX

CHANGE BACK HELP

Heater Information

Page 50: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

50

CURRENT FAULT

DESCRIPTION/ACTION DISPLAY+������ !������ V���� ��*� ���� K���� K��� ���� ������ ����@���������� [���� ����� �+:;:!��� �� ������ ����� *���� �����*����������������{��� �����������������*������Q�������Q��<�'���[���������=����������*�������� *��� �������� ���� ������� V���� �������� ����� *��������������*������V������������*������������������������������� ������� �������������������������������������������V������������ �������� �������� ���� ������ ��������� ���� @����������[���� ����� ��'(�#!:'�� ����� ��=�� *��� ��������� ���=��������*����������� ����������� ��������� ��� ����V���������������������+���V��������������K����������������]����*����������������*����������������������������)�� ������ �����V������������ ������������=�� �����*��������������������������*����"��?���B������� ���������x����!������V�����������K����*���

CHANGE BACK ADVANCED

Blocked ExhaustFault occurred 2 mins ago

The exhaust is blocked orrestricted. Ensurecondensate hose is draining.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

FAULT HISTORY

DESCRIPTION/ACTION DISPLAY+������ V���� >������ ��*� ���� K���� K��� ���� ������ ����@���������� [���� ����� �+:;:!��� �� ������ ����� *���� �����*����������������{��� �����������������*������Q�������Q��<�'���[���������=����������*�������� *��� �������� �� ����� �� ���� ����� ����� ?^B� V���� ����������*�����������������*�����*���������������=�������������������������������������@����������[����������():�����=������������ ��������V������������*�������������

1: Blocked Air Intake (A7) 51 mins ago2: Blocked Exhaust (A8) 54 mins ago3: Low Gas Pressure (A6) 57 mins ago4: Blower Prover Failure (AC)

VIEW BACK HELP

Fault History

FAULT OCCURRENCE

DESCRIPTION/ACTION DISPLAY+������ V���� @��������� ��*� ���� K���� K��� ���� ������ ����@���������� [���� ����� �+:;:!��� �� ������ ����� *���� �����*����������������{��� �����������������*������Q�������Q��<�'���[���������=����������*�������� *��� �������� �� ������� ����� �� ��� *���� ��*��� �����V���� �������� ���� ������� ������ ���� ������ ������� ���� ���������������NOTE: >��������� ����� ��� ������ ��� ���� !![��� *�*���� )�� �����!![����������������������=�������������������������������!![� ����� �������������� �� �������������������� ��� ��������������� �������������������������������������������������������������

Ignition Failure 10ECO 0Low Gas Pressure 10Blocked Intake Air 0Blocked Exhaust 0Thermostat Input 4 0Blower Prover 3

BACK HELP

Fault Occurrence

RESTORE FACTORY DEFAULTS

DESCRIPTION/ACTION DISPLAY+������C������V������'���������*�����K����K�����������������@����������[����������+:;:!����������������*����� ������� ���� ��{��� ��� ���� ��������� �� ������ ������� ���������������� ������ ���� @���������� [���� ���������� �J:+��������������� ����� ���� ��x�� ����*���� ���� ������� ������� �����������=�� ������������������ ���� @���������� [���� ���������� �[�!��� �� �x��� ����C������V������'�������*���

YES NO

Restore Factory Defaults

Are you sure you want torestore the system to factorydefaults?

Page 51: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

51

SERVICE CONTACT INFORMATION���������������*����������������*��������)�����������������������~�����=�����������������������������������������*�����������������*���������������������*���������� ���������������������V��������������*��������

DESCRIPTION/ACTION DISPLAYV�*�����'������+������?����V���������������//B��������������� ���� ���� *������ ?�*�����B� @���������� [���� ��� $���������������������������������� ����� ������ �� ��������� *��� ������ ������������ �����������*��������� ����������Q���������Q������'@�#� ������������?��������������� ����B������+���!������)���*������*������*�

����������@����������[����������!>�#_:��������=����������{��*����*���������������*�����

Show Contact Information NoChange Contact NameChange Contact PhoneCurrent Contact Info:

(000) 000-0000Access Code

CHANGE BACK HELP

Service Contact Information

�����������{��*����*�������+���!������)���*����������=������������������ �����������������*��� ������������� �����������

Q�������Q������'���[����������������������������*��#�����J������������������@����������[���������������Q�'��:������=������������������

NOTE:������������!���������� ��*�������+��=����!������)���*������������������*������������������������������������������������������������������*�������������������������*������*��

Show Contact Information YesChange Contact NameChange Contact PhoneCurrent Contact Info:

(000) 000-0000Access Code

UPDATE CANCEL

Service Contact Information

Q���������Q������'@�#� ������������?��������������� ����B������!������!������#�*���*������*�

����������@����������[����������+:;:!�������������!������!������#�*��*���

Show Contact Information YesChange Contact NameChange Contact PhoneCurrent Contact Info:

(000) 000-0000Access Code

SELECT BACK HELP

Service Contact Information

V�����������������������������������������*����������*��������*�����������������*�x�**���]���������������������������������

�����������������������@����������[�����Q�'��:������=����������!������#�*������������������*���������������������������*���

Enter the service contact below:

NAME: _

Use the > and < keys to move betweencharacters. Use the UP and DOWN keys tochange the character.

- -

< > UPDATE- -Q���������Q������'@�#� ������������?��������������� ����B������!������!������������*������*���������������@����������[����������+:;:!���

V������������������������������������������!������������* �����������������@����������[����������Q�'��:������=����������������* ����

�������������!������#�*������!������������* �����=�� ��� ����������"�����������@����������[����������[�!�����������������'������������� BACK HELP

Show Contact Information YesChange Contact NameChange Contact PhoneCurrent Contact Info:YOUR COMPANY NAME HERE(123) 456-7890Access Code

Service Contact Information

Page 52: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

52

PRIOR TO START UP

)����������� ���� ������ �� �� ����� ������ ������� ��Z����� � ��������������������Z�=��������������������������������*�����������������=�=��"�����`��������������������

'������������������������������������������������������ ��������� ������� )**��������� ����� �� Z������� ���=���� ����������� ���������� ������������������������������������������ ���������������*����������������������������� ����������������

;����� ���� ������ ������� ��� ���������� ����� ���� ;�������� ����@��������)����������� ����������������������������������*����� �������������������

�������������������=����� �������*����������Z������������������������ ������ �����*� ?���� � ����� //B� ������ ��*�����������Z����������!* �����[����"���������������������������* ����� ���* ��"� ����>��+������ )������"� ����]/�(���_���(��=�"� K���� [����� �������"� ���� ��*�� ��������� ���� �����������*����������������������������������������������*����

[����� ����*������ ������ �"� �������� ����� ���� ��*��������������������������x����+�Z�����@��@�������"�����������������+�Z����� @�� @�������� �� ����� ��� ���� ���� +�Z����� @��@��������V���!�������������^�

[����������������������������������������������"���������������������*��������������������������������������������������������������������������������:���������������������=��=�����������

FILLING THE WATER HEATERV������������������������������������������������������&�� !���������������������=��=��]�� @���������� ����������������������*�����������������������*�

���������$�� V����������������������������=��=�������������������������

������������������������������/�� !��������������������������������+����]�����������������

�����SUPPLY GAS LINE PURGING

Fire or Explosion Hazard

Read instruction manual beforeinstalling, using or servicing

water heater.

To avoid risk of fire or explosion purge discharge must notenter into confined areas or spaces where ignition can occur.

The area must be well ventilated and all sources of ignitionmust be deactivated or removed.

Gas line purging is required with new piping or systems inwhich air has entered.

Use only the gas shown on the water heater rating label.

Keep ignition sources away from faucets after extendedperiods of non-use.

&�� !��������K����_���+�����(��=�"�����V������]��������$^�

]�� ���������������*�������������������������������������������K����_���+�����(��=��

$�� ����� ���� ���� ���� ���� ������ ��*� ���� ������ ���� ����"���������������������������������������

/�� !�����������������"�����_���;����;�������������������/�"��������������������������

INITIAL START UP

REQUIRED TEST EQUIPMENT�� ���Q\� ��*��*�����"����**���������������\&/����!��

?�\$������B������\$�����!��?�\��%����B�������������������� �����������*��*���������� �����������������Q\� ��

*��*�����������������������C��**��������������\&/������§&/�������!��?�\$������B������������&����!�������\$�����!��?�\��%����B�����������&�����!�

NOTE:� ���� ����� �Z��*���� *��� �� �����*����� �� �* �������*�������� ��������� �������������PREPARATION&�� Q��������������������*�*���"������������@���������+���

����� �� ���� ������ ��*���������������"�����@���������+������������'��������������{��*�����������/%�

]�� ������������������������~����������������������������$�� !��������K����_���+���@���(��=�"�����V������]��������$^�/�� ������=��?�B�*������������������������������������ !���������*��*�����?������������B�������=���� ��������

�������������������������������������������������@��[�>�&]������&���*����������������&~���#������������������ ����� ������� ���������� ��� ���� ;�� _��� �������� ��������� ���� ������ ������� ����]/�(���_���(��=���������&~���������������������������C�*=������&~������������������*����� ��*�������������������������������� �� ���������������������*��*�������������� �"�����V����������������$�@��[�>�&^^�����]���*���������������������������������������*��������������������������������������=��=���Q��������*���������������������������=���\����������������=��=��������� ���� ������������������ ����� ���� ��� ���� ������������� �����������=��=�������������\��������� ������ ����=��=����+���������*��*�������������� ��=������������������������"�����V������^�����V����������������$�

��� !���������*��*����� ?����� �����B� ������=���� ��� ������������*�������������������������K����[�����[�>�&]��<�&���*��������*=������&~������������������*����� �������������=��=�������������������������������� �� ���������������������*��*�������������� �"�����V������%���������$�[�>� &^^� <� ]��� *������ Q����� �� �*���� ���� ���� ������������ ���=��� \� ���� ���� ������� =��=�� ������� ���� *����������� �������� ����� ���� ��� ���� ���� ����� ���� ���� �������=��=�������������\��������� ������ ����=��=���+����� ����*��*������������� � ��=��� ���� ����� ���� ��������"� ����V������^�����V����������������$�

%�� @��������K����_���+�����(��=����� K�������������������������������������"��������������������

������������������ ��������������� ����������������� ���������������{���������������������������������"�����+�����_�������������{��*������������/�

START UP

Page 53: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

53

��� !*��������������������������������������������������� =�� �� ���� ��Z����� *���**~*�x�**� =����� ��=������ �� ��� $� �� ����� &]�� ��{��� ������ ���� ����������� ���������"� ���� +����� _��� ����������{��*���� ��������/�

^�� ����� �*������ ���� ��� ���� �� ���� ������ ������"� ��������������� �� ����� ���� '��������� � *��*���������� ���������������������� ��*=��� ��� ���������:��������� ����� ���� ������� =��=��� ������ ������ �������� �����*���������������

MANIFOLD GASPRESSURETEST PORT

SUPPLY GASPRESSURETEST PORT

GAS VALVE / VENTURI ASSEMBLY TOP VIEW199,000 & 250,000 Btu/hr MODELS

VENTURI

COMBUSTIONAIR INLET

GASVALVE

COMBUSTIONBLOWERCONNECTION

Figure 59

MANIFOLD GASPRESSURETEST PORT

SUPPLY GASPRESSURETEST PORT

GAS VALVE TOP DETAIL VIEW199,000 & 250,000 Btu/hr MODELS

Figure 60

GAS VALVE / VENTURI ASSEMBLY SIDE VIEW199,000 & 250,000 Btu/hr MODELS

VENTURI

LOW GASPRESSURESWITCH

SUPPLY GASCONNECTION

GASVALVE

COMBUSTIONAIR INLET

Figure 61

LIGHTING THE WATER HEATER&�� [�>� &]�� <� &��� *������ ���� ���� �~��� ������� �� ���� ����

=��=������������������"�����V������%�����V���������]�� ������������������������~���������������������������$�� �����������������������*����*���������� ������Z������

���� '������ ������� ������� ���� ������� @��������� +�������������������*������������� �����������������������������*���;!'���������� ������Z���������*������

/�� Q����� ���� ������ �����*� *���� ���� Q)K� ?���� ����������*���B"������������@���������+�������������������������������� ����������� ����� ��*�������������������� ���������������*�;!'���������'��������������������������=�����������������������+���!�����+����*�@���������������//�

ON

OFF

MANIFOLD GASPRESSURE REGULATORCOVER SCREW

GAS VALVE TOP VIEW120,000 & 150,000 Btu/hr MODELS

MANIFOLD GASPRESSURE TAP1/8’ NPT PLUG

SUPPLY GASPRESSURE TAP1/8’ NPT PLUG

INLET OUTLET

ON/OFFSWITCH

Figure 57��� C���������*����������������������������]/�(���_���(��=��

���������������������K����[���������������"��������*���������=��=�� ���� ����� �� ���������� �� ���� '������ ������� �� ���������������*���;!'���������������������*���������������]/�(���_���(��=�"������*�������*�����������������������K���� [����� �������� ��� ��������"� ���� ���� +����� )��������������������� ���&&��������/��

GAS VALVE SIDE VIEW120,000 & 150,000 Btu/hr MODELS

MANIFOLD GASPRESSURE TAP1/8’ NPT PLUG

SUPPLY GASPRESSURE TAP1/8’ NPT PLUGBOTTOM OF TEE

1/8” NPTTEE FITTING

GAS VALVEOUTLET

ON/OFFSWITCH

LOW GASPRESSURESWITCH

Figure 58��� !*���������������*������������������������������������

� =����������Z�����*���**~*�x�**�=�������=�������� ���$� �� ����� &]����{��� *������� ���� �������� ��� ���������"�����K�������_�������������{��*������������/�

%�� C������������������������������������]/�(���_���(��=�����������������������K����[��������������������������������*���������������������������������������������������������

Page 54: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

54

SUPPLY GAS PRESSURE ADJUSTMENT

Fire and Explosion Hazard

Turn off gas lines during installation.Contact a qualified installer or serviceagency for installation and service.

Excessive gas pressure to gas valve cancause serious injury or death.

Do not use water heater with any gasother than the gas shown on the ratinglabel.

+����������������������� ��*������������������������������������������?��������������B�AND�������������������������������������������������?����*����������B��)������������������������������������������������� �������������Z�����*���**�����*�x�**�=�������=�������� ���$��������&]���{�����������������������������������������{����������������� �������?�B� ���� ���� �������� *������������ ����������� �������=��������Z�����������������������*����������������������Multiple Water Heater Installations:)�� *������� ������ ������� ������������� �� ��� ������������� ���������� ����������������������?�B����������**������������*����������������������������������� ����������������������������� ��*�����������������������������������������������������������������������**��*��������������������������@�� *������� ������ ������� ������������� ���� ������ ���� �������������� ������ �� ��{����� �� ��=���� ���� �������� �� �����������������������������*���**�����*�x�**�����������������Z���*����� ������� ��� �� ��� $� �� ����� &]� ����� ���� ���� ������������������������������**������*��������������������������NOTE:�����������������*��������&�������!��?��$%����B����������K����[���������������������������������������Z���������������������������������������������"���������������~���������������)����������*��������&�������!��?��$%����B������������������������������������K����[����� �������"������� �������������������������������?�B����������������������������������+���������Z���*��������+�����_���C�����������_���+�����+����*�� �� ����� &/�� +��� +����� _��� ;���� )����������� ������� $^� ���� +����� _��� C������� �� ����� &/�� :����� ������Z���*������������������������������������*����������MANIFOLD GAS PRESSURE ADJUSTMENT

Fire and Explosion Hazard

Gas and carbon monoxide detectors areavailable.

Overfiring could result in fire orexplosion.

Under no circumstances should the input exceed the rate shown on the water heater’s rating label.

Breathing Hazard - Carbon Monoxide Gas

Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.

Under no circumstances shouldthe input exceed the rate shownon the water heater’s rating label.

Overfiring could result in damage tothe water heater and sooting.

Gas and carbon monoxide detectorsare available.

:����� ���� �����*���� ������ ���� �������� ��� � =�� ����*���**� ��Z���*����� ��� �� ��� $� �� ����� &]� ����� ������{��*���������*����������*������������������������*��������{���*��������������������������������������������������������������������=����������������������������������������������*����+���+�����_�������������{��*����������������

NOTE:�K������������������������\��{��� �����[�>�&^^�����[�>�]���*����������*���������������������������*����������������������������� ���������{������)������*������������������������������������������*����������� ��*��������±���$�����!����*������������=���������� ���$��������&]��������������������������������* ���������������� �����=����������*���������������������������

V�������������� ��������{�������*���������������������[�>�&]������&���*�����

&�� V���� ���� ����������� ��� )������� +����� Q�� �� ����� �]����������*��*����������������������*�����������������������������������������������������

]�� C�*=�� ���� *������� ���� �������� �������� �=��������"�����V������%���������$�

$�� Q��������*���� ����� �������������=��� ���� ������{��*������������������������������*�������������������������������������������������*�������������������

NOTE:� ���� ���� *������� ���� �������� ��{��*��������������*���� �����*�����?��*��������&~/����B��������������*������������������������ �����������=�����*������ �����*���������������{��*�����

/�� C��������������������������������=���������

��� !����� ���� ����� �� ���� ��� ��=����� ��*��� �� ��������������

Page 55: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

55

CHECKING THE FIRING RATE

)�� ������ �������{��*���� ��� ��Z����� ����� ������ ����������� �������*��������������������������������������������&�� :�����������������������������������������������������

��������*���������������������������]�� !�����������������������������*����������������=���"� ���

[������� �����"�����������������$�� !������ �� *��*����� �� ���� *������� ���� �������� �����

V����������������������)�������+�����Q����������]�/�� +����������������������������������������������� !���������*������������������"������� ���� ���$��������

&]� ��� ������� ��������� +��� K������� _��� ����������{��*������������/������{��*�����������������

��� ;�������������*��������=���������������������%�� ��*���������?���������B����������������� ������������

�� ���������������������������������������������������������� Q���������*��� ���������������������*��������������*����

���������������������������������������� �������������������=����?[������� �����B�����������������

x H = Btu/hr3600T

x 1050 = 300,000 Btu/hr (87.9 kW)360012.6

Example:

�� $���� ������������������� �� ���*�"����������"��� ������� �������������� >� ���������=�������������[������� ��������� [�~��� �������������������������������������

NOTE:�&����[������� ��������������������=�������������������+�������������������[������������]����[������� �������[��=�����*������������������������������������������=�������!�������������������������������*�����

TO TURN OFF GAS&�� !������ ����@���������+�������� �� ���� ������ ��*��������

�������"�����@���������+������������'��������������{��*�����������/%�

]�� ���������������������������*���������������������Z������������������������� ��*��"�������������������������~����������������������������

$�� !��������K����_���+�����(��=�"�����V������]��������$^�

HIGH ALTITUDE INSTALLATIONS

Fire and Explosion Hazard

Gas and carbon monoxide detectors areavailable.

Overfiring could result in fire orexplosion.

Under no circumstances should the input exceed the rate shown on the water heater’s rating label.

Breathing Hazard - Carbon Monoxide Gas

Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.

Under no circumstances shouldthe input exceed the rate shownon the water heater’s rating label.

Overfiring could result in damage tothe water heater and sooting.

Gas and carbon monoxide detectorsare available.

[�>�&]������&���*������������������������������*�������������������������%"%��������?]"$/%�*B�[�>�&^^�����]���*������������������������������*�������������������������&�"&��������?$"�%��*B�K�������������� �*���������\����� ���������� ����������������"�*���������������������������������������������������V�� �������������� =������������������=�������������� =���������������������������������* ���������������� �����=����������*�������������������������������������!���������������������������*�������=������[������� ������������� �������������������������������������������=�����������*������=���� ���NOTE:�����������������������������������������*�������x��������� ����� ������� �� ���� ������ ��������� ������� �� ��� ����� ��������*��������NOTE:� '�� �� ���� ����� ������� �������� ��� ����� ��������"� ��������������������������������������������������������� ���*���������������������������������Z��*�������������������

Page 56: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

56

LIGHTING THE WATER HEATER

OFF

RE

GA

DJU

ST

ON

FLOW

FOR YOUR SAFETY READ BEFORE OPERATING

TO TURN OFF GAS TO APPLIANCE

OPERATING INSTRUCTIONS

Wait five (5) minutes to clear out any gas. If you thensmell gas, STOP! Follow “B” in the safety informationabove on this label. If you don’t smell gas, go on tothe next step.

IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY A FIRE OR EXPLOSIONMAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE.

A.

B.

1.

2.

C.

D.

This appliance does not have a pilot. It is equipped withan ignition device which automatically lights the burner.Do not try to light the burner by hand.

STOP! Read the safety information above on thislabel.

Do not try to light any appliance.

Do not touch any electrical switch; do not use any telephonein your building.

Immediately call your gas supplier from a neighbor’s

telephone. Follow the gas supplier’s instructions.

If you cannot reach your gas supplier, call the firedepartment.

Use only your hand to push in or turn the gas controlknob. Never use tools. If the knob will not push in orturn by hand, don’t try to repair it, call a qualified servicetechnician. Force or attempted repair may result in fireor explosion.

Do not use this appliance if any part has been under water.Immediately call a qualified service technician to inspectthe appliance and to replace any part of the control systemand any gas control which has been under water.

BEFORE OPERATING smell all around the appliance areafor gas. Be sure to smell next to the floor because somegas is heavier than air and will settle on the floor.

Set thermostat to lowest setting.

1. Set the thermostat to lowest setting.

8. Set thermostat to desired setting.

9. If the appliance will not operate, follow the instructions“To Turn Off Gas To Appliance” and call your servicetechnician or gas supplier.

3. Turn off all electrical power to the appliance.

2. Turn off all electrical power to the appliance if service is to be performed.

7. Turn on all electrical power to the appliance.

6.

3. MOve “Off/On” switch to the “Off” position. Do not force.

4. This appliance is equipped with an ignition device whichautomatically lights the burner. Do not try to light theburner by hand.

5. Move “Off/On” switch to the “Off” position.

Move “Off/On” switch to the “On” position.

“WHAT TO DO IF YOU SMELL GAS”

WARNING

On/Off Switch

LIGHTING & OPERATION LABELS

���������������� ��� ����������x�������������������������=����� �������*�����������������������*��� �����������������������������������������������������

BTH 120 AND 150 MODELS ONLY

Page 57: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

57

Tank Temperature 103°FOperating Set Point 120°FStatus: Heating

MENU HELP

UP

DNGAS

OFFON

MODEL INFORMATION

ON/OFF SWITCH

FOR YOUR SAFETY READ BEFORE OPERATING

TO TURN OFF GAS TO APPLIANCE

OPERATING INSTRUCTIONS

IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY A FIRE OR EXPLOSIONMAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE.

A.

B.

C.

D.

This appliance does not have a pilot. It is equipped withan ignition device which automatically lights the burner.Do not try to light the burner by hand.

Do not try to light any appliance.

Do not touch any electrical switch; do not use any telephonein your building.

Immediately call your gas supplier from a neighbor’s

telephone. Follow the gas supplier’s instructions.

If you cannot reach your gas supplier, call the firedepartment.

Use only your hand to push in or turn the gas controlknob. Never use tools. If the knob will not push in orturn by hand, don’t try to repair it, call a qualified servicetechnician. Force or attempted repair may result in fireor explosion.

Do not use this appliance if any part has been under water.Immediately call a qualified service technician to inspectthe appliance and to replace any part of the control systemand any gas control which has been under water.

BEFORE OPERATING smell all around the appliance areafor gas. Be sure to smell next to the floor because somegas is heavier than air and will settle on the floor.

2. Set the ON/OFF switch on the control panel tothe “ON” position.

8. Set the ON/OFF switch on the control panel tothe “ON” position.

1. Set the thermostat to lowest setting.

3. Set the thermostat to the lowest setting.

3. Turn off all electrical power to the appliance if service is to be performed.

7. Turn on all electrical power to the appliance.

2. Set the ON/OFF switch on the control panel to the “OFF” position.

Wait five (5) minutes to clear out any gas. If you thensmell gas, STOP! Follow “B” in the safety informationabove on this label. If you don’t smell gas, go on tothe next step.

6.

4. Set the ON/OFF switch on the control panel to the“Off” position.

10. If the appliance will not operate, follow the instructions“TO TURN OFF GAS TO APPLIANCE” and call your servicetechnician or gas supplier.WARNING: TURN OFF ALL ELECTRICALPOWER BEFORE SERVICING.

9. Set thermostat to desired setting.CAUTION: Hotter water increases the risk ofscald injury. Consult the instructionmanual before changing temperature.

“WHAT TO DO IF YOU SMELL GAS”

5. This appliance is equipped with an ignition device whichautomatically lights the burner. DO NOT TRY TO LIGHT THE BURNER BY HAND.

WARNING

BEFORE OPERATING: ENTIRE SYSTEM MUST BE FILLED WITH WATER AND AIR PURGED FROM ALL LINES

1. STOP! Read the safety information above on thislabel.

LIGHTING & OPERATION LABELS

���������������� ��� ����������x�������������������������=����� �������*�����������������������*��� �����������������������������������������������������

BTH 199 AND 250 MODELS ONLY

LIGHTING THE WATER HEATER

Page 58: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

58

SEQUENCE OF OPERATION

C���� ���� +�Z����� �� @�������� ���� ����� ����*������ ��������� ���� ���������� �� ��*��� C����� �� ���� V������� ����!*������� ������� ��������� �� ����� %� ��� ���� ���������=�������������������*������������� ��� �����+��� ����+�Z�����@��@��������V���!�������������^�����&�� ����� ���� ������ �����*� ��� ����� ������"� ������ ��

�"� ��� ����� �������� ������ ������� *���� ����*����� ����������������������������� ����**����� ���������������*�;!'���������������������Q)K�?��������������*���B���������������������������������������������'��������������

]�� )�� ���� ������ �����*� �����*����� ����� ���� ������ ��������*�������� ������� ���� ����� ��� ���� ���� �����**���@���������+��������*��������'�������������������"������������������������=�����

$�� ���������������*�����������*��������������������������*��������� ����� �������� ����*���� ���� ��� ���� �������"� ������ �x����"� ������ ������� ���� :!@� ?������� ����B�������������������������������[�������=���+����������������������*�������

/�� )��������������������������������������������"����������������*���������������!* �����[�����������\�����

��� ���������������*�*�������*�����[�������=���+�����������������������������!* �����[������������������

��� )�� ����[�������=���+������ ������������ ����*������������������������*���������������>��+������)�������������������������*\��������

%�� ���� ������ �����*� *������ ���� �������� ������� ���� *�����������*���**���]����!��*������������������������*���������?&]\&%�������B�

��� )�� �������� �*������� ��� ����*��� ��� �� � =�� ���� ��Z�����*���**����������������*���������������]/�(���_���(��=�������������������������K����[������

^�� ���������������*���\��������������>��+������)�������&������������������*�*������������*��������������*���

��*��������������������K����[������)������*��������=����������������� �����������������������������������*������ ���� ������������������*�����*����)����*��������� ��=������������������� ������� ��� �������"� ���������������*������ �����������������������)�������V�������V����*�������

&&��)�� �� ��*�� ��� =������"� ���� ������ �����*� ����� ������ ������������*��������� �������� ��������������� �������������������@���������+��������������������������������"����������������*��������\�������������]/�(���_���(��=�������������������\�����������?����x�*������$��������B�

&]������!* �����[������������������������������������\����� ������ �� ����� ���� ������ ������� �� ���� �* �������������������������\���������������*�����"����� ����������\��������������������������������

&$������ ������ �����*� ��� ������� ���� ����� �� *��� ��������������� �� *����� ���� ��������� ������� ����� ��������*�������� ���� ���� ������ �� ����� �����*� ��=������ )�� �����������*������������� ��������@���������+��������*��������'�������������������"������������������*�����������������+����]�������������������������������

TROUBLESHOOTINGINSTALLATION CHECKLIST

���� ����� ���� ������������*���� ����*��� ��������� ��������������Z���*���������"������=������"������������ ��������������� ��*�"� ���� ��*�� ���� ��������� ������ �������*����� �������� ��� �� �*������ ������ [����� �����*���� ���� �� ������������������ ��� ���� ����� ���� �� ������ ��� ������������ �������!���� �� ������� ������������ ������ ���� ��� �=����� ����� ������*����� ���������� :����� ���� ������������ ��Z���*����� �����������������������*�������=�� ����*���������������������WATER HEATER LOCATION&�� :����� ������ ����������� �� �* ��� ���� ���� *����������

�����������������������*������=����������������������+���!�����������!* ��� ���K����������������&$�

]�� :�����������������������������=�����*�����������**� ���*����������+������������������������&%�

VENTING$�� :�����������������������~��=����?�x����B����������������������

����� ��� ���� ���������� ��������+���(�������C�Z���*������������]/�

/�� :����� ����*�x�**��Z�=������ ������������������� �����x����������������������������~��=����������+����� ���%��������]/�

��� :����� ���� *�x�**� �* ��� �� �� ��� ���� ��� �����x������� ��� ���� ������� ���� ���~�� =���� ������ +��� (�������C�Z���*������������]/�

��� :����� ���� ������� ���� ������� ���� ���� ��*=��� ��*� ���������������������������������������������������������������������������� �����'������(���� �����������+���V�����&^��������]��

%�� :����� ���� �x������ ����������� ��� ���� ������� ���"� =���� �������������� ���*�������� ���� *����������� +��� (�����������*������� )����������� �� ����� ]%"� +�������� ���*�������)������������������]^�����!������������*�������)������������������$����������������������������������� ������������������������*��� ��*����������

GAS SUPPLY AND PIPING��� :����� �� ������ ���� �������� ���� ���� ���������� ��� �����

��������������+���������Z���*����������+�����_���C��������������&/�����+�����_���C��������������&/�

^�� :����� ���� ������ ���� ����� �� ����� ������ ������� *��������� *���**� ������ ���� ����� ����� ��Z���*������ +��� ������Z���*����� ��� ����_���+�����+����*���������&/���������������������������������������$^�����/��

CONDENSATE DRAIN&���:����� ���� ���������� ������ ��� �������� ��������� �� ����

�x������� ������������������������������������������������� �������������+���V�����̂ ��������&%�����!���������'�����)������������������$��

ELECTRICAL CONNECTIONS&&��:�����������������������������������������������������

����������������+���������Z���*�����������������+������������&/�����:������������������������/&�

&]��:�����������������������������������������V��*������������Z�����������Z����������������)�����������������������������������������������������)�������V������

Page 59: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

59

SEQUENCE OF OPERATION FLOW CHART

YES NO

Water is heated to set point

24 Volt Gas Valvede-energized

30 secondInter-Purge cycle

24 Volt Gas Valvede-energized

Retries up totwo more times

30 secondPost-Purge cycle

Control System Locks Out

“Ignition Failure” Fault Msg is displayed

Water heater goes into standby mode

If tank temperature drops below Operating Set Point minus Differential setting a heating cycle is activated

Blower Prover switch contacts confirmed closed by control system

Igniter is energized for warm up period

24 Volt Gas Valve is energizedgas flows to Main Burner

Is flame sensed at the Main Burner?(control system monitors the flame sensor)

Control System Locks OutDisplays Fault MsgNO

Control System Locks Out“Blower Prover Open”Fault Msg is displayed

NO

Control System Locks Out “Low Igniter Current”

Fault Msg is displayedNO

Combustion Blower is energizedPre-Purge cycle

Does Control System sense minimum Igniter amps?

Control System performs diagnostic checksNormal State of all pressure switches and ECO are checked

Blower Prover pressure switch verified openAll other pressure switches and ECO are verified closed

2.0 minimum AC amps

Figure 62

Page 60: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

60

�� :x�����=��*�������������������\������� ���$��������&]�����K�������_�������������{��*������������/�

�� (����?�x����B������������������������=���������������������������*����������'������(�����������������\�����'������(����)������������������]��

�� :x�����=���Z�=������������������������������~��=����?�x����B������������������\�����(�������C�Z���*������������]/�

�� '� �����������~ ����������������������������?�B�\�����V�����&^��������]������V�����]���������]^�

�� '� �����������~ �����������K����[�����\�����V�����]��������%�

MOMENTARY IGNITION

Burn Hazard

Do not reach into the burner housing orcombustion chamber if the water heateris still hot.

Allow the water heater to cool and always usegloves when handling the main burner.

The combustion chamber and burner sleeve and housing become very hot during operation.

CAUTION

)�� ���� K���� [����� �������� **��������� �� ���� ��� ��������������� ����� ���� ������ ������� �� ���� �� ������� �� �� ��� *�����*�������������������*����������������)�������V������V����*�������������������������������������*���;!'��)�����������������������x����������������������\�����C���+�������"�C���@���������������������V��**����������������� ��*���������������������������������������

�� )��������*������� ������������ \� ������ ��� $�������� &]�����K�������_�������������{��*������������/�

�� Q�������������������������?���=�*�������������B�\�����_���+�����+����*���������&/�

�� +����� ���� �������� ��� ��� ���������� ���� ��������������Z���*����� ?�������� ���� ������ =�*�~��������B� \� ����+�����_���C��������������&/�

�� +������������������ ����������������������������������������������)�������V������V����*���������������]�

�� '� �����������~ ����������������������������?�B�\�����V�����&^��������]������V�����]���������]^�

�� '� �����������~ �����������K����[�����\�����V�����]��������%�

NOT ENOUGH OR NO HOT WATER�� #������������������������"������� ������"��������������

��������������~������������ >��������������=��=�?�B����x������������� @���������+�������������������"�'���������������������������

��������+���!�����+����*�@���������������//��� Q��������~��;������ ��@������������������������������

��������������������*���������*�������\�������*���������K���?���B��������/��

�� :����������������������x�����������=�����������?������������ ��~���� ���������B����� ����������������������+���:�� ��~'��� ���!�������������/&�

�� �������������������������������������������� �����x������"����������������������� �����*������*����

OPERATIONAL PROBLEMS

Read and understand this instructionmanual and the safety messagesherein before installing, operating orservicing this water heater.

Failure to follow these instructions andsafety messages could result in deathor serious injury.

This manual must remain with thewater heater.

������������������*������������������� �����������������������**�������������� ��*�"��������������������=�����������������*��� �� � ��� �� ���=�� ���� ������� �������� �� ��*�� ������*���������������� ����������������� ����������� ������������������� ��� ��� ��\����� ������ �� �������� �������� >��=��"� ����Z������� ���=���� ������"� ��� ������� ��� `����������� �� ������"� ����� ����������� ����� �Z��*���"� ����� �����*� �������=���������������������������������NOTE:� !���� ���� ���������� ������ ����� �* ��� ������� �� ���� �����=����������*������������������������������������������������Z����������=���������������������INSTALLATION ERRORS@������������ ��*��������������������������������������������������������Z���*������������=�� ����=�������������������������� �*�������� ):�� �� �;�� _��� ��������� V���� �����������*�������������� ��������������������������������������������=��;��_�������������������C���������������� ��������������������������� �������������������������������~������� ����������������������������������������������������� �� �����*���� ���� ���������� ������� �������� ���� ������������� ������������ �� ������ ���� ������������ ��Z���*����� ��������������� ��=�� ���� *���������� ���� �������� +��� ����)�����������!������������������NOTE:�!���������������������������������������=����������������*��������������ROUGH STARTING, ROUGH OPERATION

Fire and Explosion Hazard

Turn off gas lines during installation.Contact a qualified installer or serviceagency for installation and service.

Excessive gas pressure to gas valve cancause serious injury or death.

Do not use water heater with any gasother than the gas shown on the ratinglabel.

�� Q�������������������������?���=�*�������������B�\�����_���+�����+����*���������&/��

�� +���������������������������������������������������Z���*�����?������������������=�*�~��������B�\�����+�����_���C��������������&/�

�� :x�����=��������������������\������� ���$��������&]�����+�����_�������������{��*������������/�

Page 61: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

61

ALERT CONDITIONS��������������������*����������������������������������������������������*������������������������*���;!'��������Z�������¶��*������������������������������������������������������������������ �� �����������������*��� �����=����� ����Z����������=����������������������� ���RESETTING CONTROL SYSTEM LOCK OUTS�� ������ ���������������*� ��*��� ��������������� ���� �������������������������x�*������]������������������ ���������������*�����������������������������������V����������� ������������"����������������*���������������������DIAGNOSTIC CHECKS

Turn off power to the water heaterbefore performing any service.

Electrical Shock Hazard

Label all wires prior to disconnectingwhen performing service. Wiring errorscan cause improper and dangerousoperation.

Verify proper operation after servicing.

Failure to follow these instructions canresult in personal injury or death.

���� �������� ������"� V�������������� K�������� �� ����� �]"��������*��������*�����������������������*��������������������;!'���������������������������� ��*�����������������*���������������������������������V��������������*�������������� �������������� ���� ����������� ������������� ������� �������������������@���� Z������� ���=���� ������"� ��� ������� ��� `����������� ��������"����������������� ������Z��*���"� ����������*��������=���������������������������������NOTE:� )�� �� ���� ��� Z������� ���� ��������� �� ��������� �����Z����� �� ��������������=���� {���������� �������*�����=�����������������*����������*��������������������������=������������������� ��������������������������)�����������������������������������������������������������������*����������*��������������!������������������������������* ���������������� �����=����� ����� *����� ��� ������� ���������� ����������� �� �� ������ ��Z����������=���������������������

Jumping out control circuits or components canresult in property damage, personal injury or death.

Service should only be performed by a qualified serviceagent using proper test equipment.Altering the water heater controls and/or wiring in any waycould result in permanent damage to the controls or waterheater and is not covered under the limited warranty.

Any bypass or alteration of the waterheater controls and/or wiring will result

in voiding the appliance warranty.

Altering the water heater controls and/or wiring in any waycould result in altering the ignition sequence allowing gas toflow to the main burner before the hot surface igniter is atignition temperature causing delayed ignition which cancause a fire or explosion.

�� !��������*������������*��������������������������*����Z������������������������������*��������

�� >��������������������"�����������"��������������������=��=����������������

�� +���*��������*�����������*������*��� ����������������������������������+���K�������������������/��������*����������*����������*=������������

�� ������������������������������������������!�����*������������������"������������������������/��!����������������������������������������"��������������������������

WATER IS TOO HOT�� @���������+�����������������������+���@���������+��������

����'��������������{��*�����������/%��� Q��������~��;������ ��@����������������*������������\�

������*���������K���?���B��������/���� )*�������������������\�����������*�� ����������������%&�

NOISY OPERATION�� +���*��������*�����������*�����������������* �����

���������������������������������������+�������K�������������������������*����� �����������������/��������*����������*����������*=������������

�� #�*�������������������������������*��������!* �����[����"��������*����*"��������������������

WATER LEAKAGE IS SUSPECTED�� :����������������������������=��=��������������������� !����������������������������\�����V��������������&���� !����������~������������������������������*���������� !�����������*�������\��������C������(��=��

�� :x�����=����������*���������� :x�����=������������������ '������=����*�������\��������C������(��=��

NOTE:�:x�����=�����������������������*����**�����������*�������\�������� C������ (��=�� ��������� :x�����=�� �����������*��������� ���*�������������� �� �����*����x�������������������������*���+�������*���:x�����������!�����������+����*���������&���������*�������\��������C������(��=���������������������������������������������*����x���������*�������\��������C������(��=����������������������� ����������������������*���������������=��������*����x�����������������������������=����������������*�������������������*����x�������������*��� �����������������������������������*��REPLACEMENT PARTSC������*���� ������ *��� �� ������� ��*� ���� *���������"�������������=��������������������� ������������������������ ����������=�������*�������������������K����#* ��"�+������#* �������+������#* ����=���� ��������� ����*��������� ��������������������� ������x����������������������C����� �� ���� ������ ����� �������� ����� ���� ������ ������� ��*� ����������� ��� *��� ����*����� �� ����� ���� ������ ������*���� ������������������������* ���������������� �����=����������*��������������������������

FAULT AND ALERT CONDITIONS

FAULT CONDITIONS��������������������*������������V������������������������������V����*������������������������*���;!'����������x���*������·�� *��������� ������ �����*� ����� ���� �� ���� ���� ��� ���������������������������������������������������������������*��� �����=����� ����Z����������=���������� ����������������� ����������

Page 62: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

62

FAULT AND ALERT MESSAGES!������������������������������* ���������������� �����=����������������������������������������������Z����������=���������������������

POSSIBLE CAUSES - CHECK/REPAIR DISPLAYED FAULT/ALERT MESSAGE�� ������������������������������*�������������������=���������������

���������� ��������������������������������������������������������=����������������������*��������������������!�C�=�������V����*�������������;!'������������������+��������+�����!����������������/&����������������������������������������������������NOTE:�:�����������*������������Z��������������������������������#'�����������������������������������������������K����[���������������������*��������=����������������� ������������ ���������������������������������������+�������)�������V������V����*�����������*����� ���� CHANGE BACK ADVANCED

AC ReversedFault occurred 2 mins ago

Power supply to water heaterhas reversed polarity.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

�� ���������������*�������������������������K����[������� ���������������������������������"���������������������

������K����[�����\����������+�����!����������������/&��� !��������*�������"���������*��������������������������

?�������������*����B�\�����V�����]��������%��� ;������������������������*���������� ;����������������������]/�(���_���(��=���� ]/�(���_���(��=���~�����������������������������\�����V������%�

����V����������������$��� +�����������������"��������=�*��\����������$^��� )�������������~��=����������������������������*������������������\�

����(�������)������������������]]��� ;������*�������������������������K����[�����\�����)�������

+�����Q����������]�

CHANGE BACK ADVANCED

Ignition FailureFault occurred 2 mins ago

The water heater has failed toignite the burner.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

�� ���������������*������������������;��_�����������+����������������������

�� ;����������������������;��_�����������+������\����� ����������������������������

�� +�������������������� ����������Z�����*���**���������\������� ���$��������&]��

�� +����������������������������K����+�����(��=���� +����������������������������������������������������������

�����**�������������������������������� ;��=�*��������������\�����+�����_���;����)�������������

�����$^�����������Z���*������������_���+�����+����*���������&/�����+�����_���C��������������&/�

CHANGE BACK ADVANCED

Low Gas PressureFault occurred 2 mins ago

The supply gas pressure to thewater heater is low.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

�� ���������������*������������������������?�!��*��B���*�����>��+������)�����������������������*�*�������������������������������������������V�������������������������������������� =�����������**���*���**���Z���*����\���������+�Z�����@��@���������������������*���**����������*����Z���*�����

�� ;����������������������>��+������)�������\�����V�����]��������%�������������������

�� '�*����"������������������>��+������)�������NOTE:�>�����������������������������������������������������������������������������������>��������������������� ��=�������������>������)���*�����*���\�����>������)���*������������/^��)��������������'���������������������������������������������\�����@���������+������������'��������������{��*�����������/%�

CHANGE BACK ADVANCED

Low Igniter CurrentFault occurred 2 mins ago

Igniter current is low.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

�� ���������������*������������������[������:x�����+����������������������

�� ����������������������� ������������������x������� �������������\���������������������������\�����V�����^��������&%�

�� ;����������������������[������:x�����+������\����� �����������������������������������

�� C���������~ ������=�����������\�������������������������������� :x�����=���Z�=�����������������"��x�����������*�x�**��* ���

��^����� �������������������������������=����������������*�\�����(�������C�Z���*������������]/�

�� :x�����=����������������������������=���������*���������� :x�����=��������=�������������������������������������

CHANGE BACK ADVANCED

Blocked ExhaustFault occurred 2 mins ago

The exhaust is blocked orrestricted. Ensurecondensate hose is draining.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

Page 63: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

63

FAULT AND ALERT MESSAGES (CONT)!������������������������������* ���������������� �����=����������������������������������������������Z����������=���������������������

POSSIBLE CAUSES - CHECK/REPAIR DISPLAYED FAULT/ALERT MESSAGE�� ���������������*������������������[�������=���+������

��������������������������������� ������������� ���������������������������\���������+�Z�����@��@������������������

�� �������~�������[�������=���+�������������\����� �����������������������������������

�� ¦*������������������������[�������=���+������\���*=��{*����������¦*����������*�����=��� �����"���������������������������&�

�� :x�����=����������������������������=���������*���������� :x�����=��������=������������������������������������� CHANGE BACK ADVANCED

Blower Prover FailureFault occurred 2 mins ago

The blower prover switch isclosed out of sequence.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

�� ���������������*������������������[�������=���+��������������������*��������������������������������*�������������������!* �����[�����\���������+�Z�����@��@������������������

�� ;����������������������[�������=���+������\����� �����������������������������������

�� [�������=���+������������������� �������������"�������"��������������������"���*���������������\������������������� ��

�� !* �����[����������������������������������� ;����������������������������������!* �����[����� CHANGE BACK ADVANCED

Blower Prover OpenFault occurred 2 mins ago

The blower prover switch remainsopen after the blower has beenenergized.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

�� ���������������*������������������[������)����������+����������������������

�� ;����������������������[������)����������+������\����� �����������������������������������

�� :x�����=���Z�=�����������������"��x�����������*�x�**��* �����^����� ������������������������������������������������������*�\�����(�������C�Z���*������������]/�

�� )��������������������������*=��������������������������������������������������������������������������~ ������������� ����\�����V�����&^��������]��

�� [�>�&^^�<�]���*����������������������������������������[������)������������������������������������ �"�����[�>�&^^�<�]���)����������!���������������]$�

�� :x�����=��������=�������������������������������������

CHANGE BACK ADVANCED

Blocked Air IntakeFault occurred 2 mins ago

The combustion air intake isrestricted.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

�� ���������������*������������������:!@�?�����������B�+����������������������

�� ����:!@���������������*����������������������������������*������������������=�����x�����=����������*��������������������������������:!@����������������������Q�������*���������� ��?������������B�\����� ���������������������Q������� ���������

�� ;����������������������:!@���������������Q�������*���������� ��\��������������

�� )*�����������������*�����������~���x�����=���������������?�����������B������������*��������\����������������������'�����*�� ����������������%&�

CHANGE BACK ADVANCED

Energy Cut Out (ECO)Fault occurred 2 mins ago

Tank temperature is excessive.The water heater has beendisabled.

Call a service professional:Your Company Name Here(press [DOWN] for more....)

�� ���������������*���������������������=��������*���������������������\����� ����������������������������

�� #���������������������������� ;������������������������������������������������\�����

������������������������������ �������������������������������������� ��������������������������������������\����������+�����

!����������������/&��� ;���������������������� ����������?$~/������ �����B����������������������������

��������������������������������������\��������������������������������������"������������*=��������������������� �����?�B�

CHANGE BACK ADVANCED

No Anode VoltageAlert:

Alert occurred 2 mins ago

No voltage detected fromPowered Anode(s).

Call a service professional:Your Company Name Here(press [DOWN] for more....)

Page 64: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

64

MAINTENANCE SCHEDULE

TABLE 14COMPONENT OPERATION INTERVAL REQUIRED

Tank +���*����C�*=�� +�*��������� V������

Tank ;�*��+�����C�*=�� +�*��������� UN-LIME®

�����C�� )���������!������� Annually !�����+�����

Deposits�<��(��=� Test Operation +�*��������� Test

(����+����* )�������� Annually���*�������

+�������!����C�����~C�����

DRAINING AND FLUSHING)��������**���������������������������������������� �������������� ������ �=���� �� *����� �� ������ ����*���� ������ ���������������������� ������������� ������������������������������*���������� +��� V������� ���� !*������� �� ����� %� ����������������������������������*������������� ��� ����

Burn harzard.

Hot water discharge.

Keep hands clear of drainvalve discharge.

To drain the water heater storage tank:&�� �����������������������������������������������]�� ����������������������������K����_���+�����(��=���������

����������������������� �����������������x��������������$�� :�������������������������=��=���������/�� @���������� �����������������������������������������������

����������������������� !�������������������������������������=��=���������*������

�����������Z������������� !������������������������=��=��%�� @���������������������������=��=���������������������������

��������*�������������������� !���� ���� ������ ������� ������ =��=�� ����� ���� ������ ��� ����

������������������������^�� !��������������������������������+����/�&���)����������������������������� �����������������x�������

�����"�����������=��=������� �����������To Flush the tank perform the following steps:&�� �����������������������������������������������]�� :�������������������������=��=���������$�� @���������� ����������� ���������� ���� ���������� ��������

������������������������������������������������������/�� !������ �� ���� �� ���� ������ =��=�� ���� ���*������ ��� �� ���

���Z����������

MAINTENANCEGENERAL

����� ������ ������� ����� ������ ���� ����� ��*� �* ��� ���*��������"��������������������**� ���=�����������Z�����+���;�����������������>�������������&]��������������*����������� ���������������� ������������������������"����� ��*=����� ��*������������������������������� �� ���������� ���� ��{����� �� *�������� ������ �* ������+��� )������� +����� Q�� �� ����� �]���� �������� ���������� �� ����=������������*������ ��*��������������"�������������������*�?�B������ �����������������������*��*��������������**���������

PRECAUTIONS

Do not operate the water heater if it has been exposed to or exhibits the following:

Flooding at or above the level of the burner or controls.External damage.Firing without water.Sooting.

Do not operate the water heater until all corrective stepshave been made by a qualified service agent.

CAUTION

#�=��� ������� ���������� ������������� ����� ����� �������� ��� ��������� ����� ������ ���� �� �������� ������ ���� ������ ��*�������\��������C������(��=�����������������������������=��=��������������� ������ �������� +��� ��*�������\�������� C������ (��=�� �������&��

Explosion Hazard

Overheated water can causewater tank explosion.

Properly sized temperature andpressure relief valve must beinstalled in the opening provided.

+����=�������������������������������������������"�����������K����_���+�����=��=���+���V������]��������$^�

�������������*���������������������������������������������������"�������*=�������*������������������������������� �� ���������� ���� ��{����� �� *�������� ������ �* ������C��������������������� ������������������������������=������������*� ����� �� *����� ������ ���"� ���� ������ ������������*������� ���������������� �� �����*��*���������������**���������

Page 65: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

65

TANKCLEANOUTOPENING

CLEANOUTCOVER

CLEANOUTGASKET

CLEANOUTACCESS PANEL

Figure 63

MANUAL LIME SCALE REMOVALNOTE:�!�������������������� ��������������������������*����������* ��������� �����=����������*���������������������������������>�=������������������=���� ��� �������*=����������������=������� ������� ������� ��� ����� ��� V����� �$�� �� ��*=�� ��*��������*�����������������������������������������������&�� �����������������������������������������������]�� �����������������*��� ���������"�����'������������V�������

��������/"���������������������������������������������������

$�� C�*=����������������������������*������������������������������{������

/�� C�*=��������������=�����*������������������ C�*=�� ��*�"� ������ ���~�� ����*���� ����� ����� ��� ��

��*�������������\���������� )��������������������������������Z�����%�� C���������������������=�����[���������������������������

������������������������������� !���������������������������=��=��^�� V���������������������\�����V�����������������>��������������]�&������������������������������������������������������� ����

������������+���)�������+�����Q����������]�&&���������������������������*��������=����������������������

�����������������������������&]��!����������������������&$��C���������������������������������CHEMICAL LIME SCALE REMOVAL�������=��������*=��*����� �����*���������������"�Q#\;)K:¹������������'���*�������� �������Q#\;)K:¹������������'���*����������������������������������� ������ ����� ��*������ ������������ ��� ��*�� ������ ��*=�����*�������������������������Z��*�����>���������� ����������*��� ��� �� ���� �� ����*�� ���� ������ �������� �=����� ��� �����*�����V���� ���� ����������� �� ���� Q#\;)K:¹� �� ����*�� ���� �������������NOTE:� !���� ���� ������ ������*���� ����� �* ��� �� ���� �����=����� �����*����� �������Q#\;)K:¹������������'���*����+�����[;:�&���������������������* ����

��� :����������������������������� ������������������������������������������V���������������*�������������*�������������������������������������������

��� @���������������������������=��=�������������������������%�� V�������������������������������������*=������*��������

����������������������������������������� !���������������������������=��=������������������*�������^�� C�*=����������������&���V���������������������\�����V�����������������>��������������]�&&������������������������������������������������������ ����

������������+���)�������+�����Q����������]�&]���������������������������*��������=����������������������

�����������������������������

FILLING THE WATER HEATER

+���V�����������������>��������������]�

SEDIMENT REMOVAL

����� ���� �*����������������� ���������������� ���� ������������������������������*���������������*���������� ��*������������V�� ��=�������"� ����*���� ��*=��� ���� ��*�� ������ ��*=�������� �������*������������*����*��

LIME SCALE REMOVAL

����������� ���������������=���*�������� ��� ����������������������*� ���� *������*� ��� ����� ?��*�� �����B� ��*�� ������� ���� ��� ���� ������ ��*�������� ������ ������ *�������� ���������������������������������������� �*��� �� ��*�� ������ ��������� ��*� ������ ��� ��� �������������������������*�����������������������������������������*��������������������"�����*�����*�������������������������������������������������������������� ��*�����������*������������ ������*����������������� �����������*�"�������������������������*�����*�������������������������;�*������������������������������������ ������*������ ��������������� ��������>������� ��������� �������� ��*���������������*�� ������ �������� ������ ���������� ���� ����� �� ������� ���������� �������� ;�*�� ������ �������� ���� ���� ����� �* �����������������������������*������������������������*����������������������������;�*�����������*������������������������������������������������V���������������������������������������*��������� ������������ ������ �� ��*�� ���*������ ��� ���� ��*� �� ���� ������������� ����� �� *������� ������������� )������� �� ��*=�������� ������� �=��� ���� �=���� �� *����� ��� ������ '���*����*����������� ����� ����� �� �����*��� ����� �� ���� ��*�� ������������&������?]����*B�����*�������*������������ ��*��������������������+���*����������*����������*=���*��� �����*��������*����������������������������������������������������������"�����V������$��

Page 66: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

66

DISCHARGE PIPE

TEMPERATURE-PRESSURERELIEF VALVE

V������/)�� ���� ��*�������\�������� C������ (��=�� �� ���� ������ ������������� �� ����������� �����������"� ����� *��� �� ��� �� ����*����x�������NOTE:�:x�����=�����������������������*����**�����������*�������\�������� C������ (��=�� ��������� :x�����=�� �����������*��������� ���*�������������� �� �����*����x�������������������������*���+�������*���:x�����������!�����������+����*���������&���������*�������\��������C������(��=���������������������������������������������*����x���������*�������\��������C������(��=����������������������� ����������������������*���������������=��������*����x�����������������������������=����������������*�������������������*����x�������������*��� �����������������������������������*��DO NOT PLUG THE TEMPERATURE-PRESSURE RELIEF VALVE OPENING. THIS CAN CAUSE PROPERTY DAMAGE, SERIOUS INJURY OR DEATH.

Explosion Hazard

Temperature-Pressure Relief Valvemust comply with ANSI Z21.22-CSA 4.4 and ASME code.

Properly sized temperature-pressure relief valve must beinstalled in opening provided.

Can result in overheating andexcessive tank pressure.

Can cause serious injury or death.

VENT SYSTEM

:x�*��������=���������*��������������������������������������������&�� !�������� ������������~�������������������������������

���~��=����������������������������������=�������*���������C��������**����������������������

]�� ���� �� ���� �������� ��� ���� ������� ���� ���� =���� ���*������������� �� ����� �� �������� �� ������� *�������� ���� ����+���V�����]���������]^�NOTE:�'���������������������=�������������������������������������

$�� !���������=���������*�������������������������������������������������������

TABLE 15

UN-LIME® PROFESSIONAL DELIMERPart Number Description9005416105 /�\�&�������?����B9005417105 1 - 5 gallon

POWERED ANODE RODS�� ������ �� ���"� �� ��\����� ��������� ����"� ���� ������ ���������=����� ��� ����� *����� ���� ������� �Z������ ����� �� �����������������*��������������� ?]B������������*����������������� �� ��� ����� ���������� ������ ��*������ )��������� ������������������ �������*��������������

NOTE:�V�������������������������������������������������������� �� ����� �/� ������ C�*=�� ���� ������� ������ ��*� ����������������� ��������������$~/��#��� �������������*��������� �� ���� ������� '� ��� �������* ��� ���� ���������� ��� ������������*�������*�������������������������������������������"������������ ��������� *��� ����� ������� ���� ������ C�*=�� ���� ���������������� ��*����������������������� �� �����������!����� ��������������������������������������������V������������������������������������������������������]��������������

DRAIN VALVE AND ACCESS PANELS�������������������=����� ��� �����*����������Z������������������� =��=�"� ���� V������� ���� !*������� �� ����� %� ����������� ���� ������ �������� �=����� ��� ����� *����� ���� �����Z��������������������������� �������*�������� ��*����������*=����+���V������$�����������

TEMPERATURE-PRESSURE RELIEF VALVE TEST

Burn hazard.

Hot water discharge.

Keep clear of Temperature-Pressure Relief Valvedischarge outlet.

)�� ��� ���**������ ����� ������*�������\��������C������(��=������� �� �������� �� ������ ����� ��� ��� ��� ��������� ���������=������*�������������������������*�������\��������C������(��=���������"�*�������������?&B�������������������������������������������*�������\��������C������(��=������������ ����"�����?]B� ����������������������������������������������������*���"��������������*��� ���x���*��������Q����������������������=��=���������=��=��*��� ������� ������ ���� ������� =��=�"� ����� ���� ��=��� ��� ���� ���� �� ���� =��=����=�������*��"�����V������/������=��=��������������������������������������)��������*��������������������=��=�"�������������*������������������ �������� �� �������� �����"� �**��������� ����� ���� ���������� ������ �� ��������������������������� ����������������"�����'������������ V������� �� ����� �/�� C������� ������*�������\��������C������(��=����������������������~������������"�������*�������\��������C������(��=���������&�������������������������*����

Page 67: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

67

DIAGRAMSCCB - CENTRAL CONTROL BOARD LAYOUT

1 Retry

Use Yes

Type Tstat

Spare

ExtInput

3Retries

No

Vent

Spare

OPE

N

1

2 3

4

3

2

1

6

5

4

9

8

7

12

11

10

15

14

13

J6

J7 3 24 1

1

2

J15

84

5

6

7

1

2

3

J13

3

4

1

2

J10

1

3

5

2

4

J1

1

3

4

2

J2

1

4

2 1

2

J3 J5 J4

S1 DIPSWITCH

J16

J9

J11

S1 DIPSWITCH DETAIL

CCB (CENTRAL CONTROL BOARD)

1 Retry

Use Yes

Type Tstat

Spare

ExtInput

3Retries

No

Vent

Spare

OPE

N

1

2 3

4

Dipswitch Operation:Along one side of the dipswitch array there are numbers, 1-4. On the other side of the dipswitchis the word “OPEN.” The dipswitches are rocker type switches, if one side of the rocker is down the other side will be up. Pressing a rocker down on the side of the array labeled “OPEN,” opens the switch.Pressing a rocker down on the side of the array labeled with the numbers 1-4 closes the dipswitch.

CHANGING NUMBER OF IGNITION TRIALS BEFORE LOCK OUT

NOTE: Always turn off power to the water heater before changing dipswitch settings.

Set dipswitch #4 to the open position for 1 trial for ignition before Ignition Failure lock out. Set dipswitch#4 to the closed position for 3 trials for ignition before Ignition Failure lock out.

Figure 65

Page 68: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

68

BTH 120 & 150 WIRING DIAGRAM

2 GREEN

WHITE

RED BLACK

1

1

2

BLACK

3

WHITE

COMBUSTIONBLOWER

UPPER TEMPERATURE PROBE

1 RED (ECO)

4 RED (ECO)

2 BLACK3 BLACK

1 BLACK120 VAC HOT

3 WHITE 120 VAC NEUTRAL4 YEL 24 VAC

4 YEL 24 VAC

LOWER TEMPERATURE PROBE

HOT SURFACE IGNITER

FLAME SENSOR

BLOCKED AIR INTAKE

BLOCKED EXHAUST

BLOWER PROVER

24 VAC GAS VALVE

B (C

EN

TR

AL C

ON

TR

OL B

OA

RD

)C

C6J

5J4J

7J51

J

61J

01J

31J

2J3J

1J

TRANSFORMER INSIDE CCBENCLOSURE50VA

GROUND STRIPBURNER GROUND(BURNER BOLT)

ON/OFFSWITCH

GROUND

120 VAC NEUTRAL

120 VAC HOT

LOW GASPRESSURE SWITCH

1 BLACK2 WHITE

RED

1 BLACK

2 BLACK

1 BLACK

2 WHITE

MU

SE

R IN

TER

FAC

E M

OD

ULE

IU

1

21541451067

8

13

11

LN

ANODE 1

ANODE 2

1 GREEN

2 BLUE

2 RED

GREENWHITE

NOIT

CN

UJX

OB

GREEN

NE

ER

G

NE

ER

G

ENABLE/DISABLE CIRCUITJUMPER WIRE BETWEEN PINS8 AND 11 ON J6 PLUG

120 VAC 1 Ø POWER

Figure 66

Page 69: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

69

BTH 199 & 250 WIRING DIAGRAM

2 GREEN

WHITE

RED BLACK

1

1

2

BLACK

3

WHITE

COMBUSTIONBLOWER

UPPER TEMPERATURE PROBE

1 RED (ECO)

4 RED (ECO)

2 BLACK3 BLACK

1 BLACK120 VAC HOT

3 WHITE 120 VAC NEUTRAL4 YEL 24 VAC

4 YEL 24 VAC

LOWER TEMPERATURE PROBE

HOT SURFACE IGNITER

FLAME SENSOR

BLOCKED AIR INTAKE

BLOCKED EXHAUST

BLOWER PROVER

24 VAC GAS VALVE

B (C

EN

TR

AL C

ON

TR

OL B

OA

RD

)C

C6J

5J4J

7J51

J

61J

01J

31J

2J3J

1J

TRANSFORMER INSIDE CCBENCLOSURE50VA

GROUND STRIPBURNER GROUND(BURNER BOLT)

ON/OFFSWITCH

GROUND

120 VAC NEUTRAL

120 VAC HOT

LOW GASPRESSURE SWITCH

1 BLACK2 WHITE

RED

1 BLACK

2 BLACK

1 BLACK

2 WHITE

MU

SE

R IN

TER

FAC

E M

OD

ULE

IU

1

21541451067

8

13

11

LN

ANODE 1

ANODE 2

1 GREEN

2 BLUE

1 4 5

3 WHITE/GREEN

7 WHITE/BLUE

8 WHITE/BROWN

2 RED

GREENWHITE

NOIT

CN

UJX

OB

GREEN

NE

ER

G

NE

ER

G

ENABLE/DISABLE CIRCUITJUMPER WIRE BETWEEN PINS8 AND 11 ON J6 PLUG

NOTE: COMBUSTION BLOWERASSEMBLY CONSISTS OF MOTOR, BLOWER AND INTEGRALVFD (variable frequency drive).

120 VAC 1 Ø POWER

PWM (pulse width modulation)SPEED INSTRUCTION SIGNALWIRES FROM CCB TO BLOWERMOTOR VFD (variable frequency drive).

Figure 67

Page 70: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

70

CIRCULATION PUMP WIRING DIAGRAMS

Figure 68

Figure 69

CIRCULATING PUMP WIRING DIAGRAMSTORAGE TANK OR BUILDING RECIRCULATION

FIELD SUPPLIED TEMPERATURE CONTROLINSTALLED IN THE STORAGE TANKOR CIRCULATING LOOP RETURN LINE

CIRCPUMP

MOTOR

L1 HOT

L2 NEUTRAL

120 VACPOWER

NOTE: USE SEPARATE 120 VAC POWER SUPPLY FOR PUMP CIRCUIT. DO NOT SHARE POWER WITH WATER HEATER AS THIS MAY CAUSE ELECTRICAL LINE NOISE AND LEAD TO ERRATIC CONTROL SYSTEM OPERATION.

CIRCULATING PUMP WIRING DIAGRAMDISHWASHER LOOP WITH TOGGLE SWITCH

FIELD SUPPLIED TEMPERATURECONTROL INSTALLED IN THECIRCULATING LOOP RETURN LINE

DISHWASHERTOGGLESWITCH

CIRCPUMP

MOTOR

L1 HOT

L2 NEUTRAL

120 VACPOWER

NOTE: USE SEPARATE 120 VAC POWER SUPPLY FOR PUMP CIRCUIT. DO NOT SHARE POWER WITH WATER HEATER AS THIS MAY CAUSE ELECTRICAL LINE NOISE AND LEAD TO ERRATIC CONTROL SYSTEM OPERATION.

Page 71: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

71

/��

+��

�!�

����

+��

��*

����

����

��*

���:

x���

���

���

����

�&��

���

+��

����

���;

����

!�

����

���

���

����

�/]�

���

)����

�*

����

� ��

�����

����

����

���

����

���

����

����

�����

����

���

�����

���

����

��

�����

����

����

���

���

��

�����

����

���

����

�V��

���

���

����

���%

���

%��

)����

�*

����

� ��

�����

����

����

����

����

����

���

���

��

���

����

����

���

����

����

����

����

�*

*��

����

����

����

�����

�����

���

����

���V

���

����

���V

���

���^

���

����

�%��

WAT

ER P

IPIN

G D

IAG

RA

MS

[��

���

����

����

����

���

����

����

����

��=�

�����

���

���

����

&��

+��

�K�x

����

(��=

���

����

���&

��]�

�+

���'

����

����

���K

����

����

���

����

&��

$��

+��

���*

����

���

\���

���

��C

����

��(��

=��

����

���&

��

ON

E W

AT

ER

HE

AT

ER

, SIN

GLE

TE

MP

ER

AT

UR

EW

ITH

BU

ILD

ING

RE

CIR

CU

LAT

ION

LEG

EN

DTE

MP

ER

ATU

RE

& P

RE

SS

UR

ER

ELI

EF

VALV

E

PR

ES

SU

RE

RE

LIE

F VA

LVE

CIR

CU

LATI

NG

PU

MP

TAN

K O

R L

INE

TEM

PER

ATU

RE

CO

NTR

OL

DR

AIN

FULL

PO

RT

BA

LL V

ALV

E

TEM

PE

RAT

UR

E G

AG

E

WAT

ER

FLO

W S

WIT

CH

CH

EC

K V

ALV

EW

AR

NIN

G: T

HIS

DR

AWIN

G S

HO

WS

SU

GG

ES

TED

PIP

ING

CO

NFI

GU

RAT

ION

AN

D O

THE

R D

EV

ICE

S;

CH

EC

K W

ITH

LO

CA

L C

OD

ES

AN

D O

RD

INA

NC

ES

FOR

AD

DIT

ION

AL

RE

QU

IRE

ME

NTS

.

FIN

ISH

ED

FLO

OR

EX

PAN

SIO

NTA

NK

HO

T W

ATE

R O

UTL

ET

PIP

E T

&P

TO

OP

EN

DR

AIN

CO

LDW

ATE

RS

UP

PLY

HO

T W

ATE

RR

ETU

RN

LIN

E T

EM

PE

RA

TUR

EC

ON

TRO

L

Page 72: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

72

/��

+��

�!�

����

+��

��*

����

����

��*

���:

x���

���

���

����

�&��

���

+��

����

���;

����

!�

����

���

���

����

�/]�

���

)����

�*

����

� ��

�����

����

����

���

����

���

����

����

�����

����

���

�����

���

����

��

�����

����

����

���

���

��

�����

����

���

����

�V��

���

���

����

���%

���

%��

)����

�*

����

� ��

�����

����

����

����

����

����

���

���

��

���

����

����

���

����

����

����

����

�*

*��

����

����

����

�����

�����

���

����

���V

���

����

���V

���

���^

���

����

�%��

WAT

ER P

IPIN

G D

IAG

RA

MS

[��

���

����

����

����

���

����

����

����

��=�

�����

���

���

����

&��

+��

�K�x

����

(��=

���

����

���&

��]�

�+

���'

����

����

���K

����

����

���

����

&��

$��

+��

���*

����

���

\���

���

��C

����

��(��

=��

����

���&

��

ON

E W

AT

ER

HE

AT

ER

, TW

O T

EM

PE

RA

TU

RE

WIT

H H

IGH

TE

MP

ER

AU

RE

LO

OP

RE

CIR

CU

LAT

ION

WIT

H B

UIL

DIN

G R

EC

IRC

ULA

TIO

N

LEG

EN

DTE

MP

ER

ATU

RE

& P

RE

SS

UR

ER

ELI

EF

VALV

E

PR

ES

SU

RE

RE

LIE

F VA

LVE

CIR

CU

LATI

NG

PU

MP

DR

AIN

FULL

PO

RT

BA

LL V

ALV

E

TEM

PE

RAT

UR

E G

AG

E

WAT

ER

FLO

W S

WIT

CH

CH

EC

K V

ALV

E

MIX

ING

VA

LVE

WA

RN

ING

: TH

IS D

RAW

ING

SH

OW

S S

UG

GE

STE

DP

IPIN

G C

ON

FIG

UR

ATIO

N A

ND

OTH

ER

DE

VIC

ES

;C

HE

CK

WIT

H L

OC

AL

CO

DE

S A

ND

OR

DIN

AN

CE

SFO

R A

DD

ITIO

NA

L R

EQ

UIR

EM

EN

TS.

HO

T W

ATE

R

OU

TLET

HO

12” T

O 1

5”M

INIM

UM

T

CO

LD

TEM

PE

RE

DW

ATE

RTO

FIX

TUR

ES

CO

LD W

ATE

RS

UP

PLYTE

MP

ER

ED

WAT

ER

RE

TUR

N

HO

T W

ATE

RR

ETU

RN

EX

PA

NS

ION

TAN

K

PIP

E T

&P

TO

OP

EN

DR

AIN

LIN

E TE

MPE

RATU

RECO

NTR

OL

LIN

E TE

MPE

RATU

RECO

NTR

OL

TAN

K O

R L

INE

TE

MP

ER

ATU

RE

CO

NTR

OL

MIX

ING

VA

LVE

Page 73: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

73

/��

+��

�!�

����

+��

��*

����

����

��*

���:

x���

���

���

����

�&��

���

+��

����

���;

����

!�

����

���

���

����

�/]�

���

)����

�*

����

� ��

�����

����

����

���

����

���

����

����

�����

����

���

�����

���

����

��

�����

����

����

���

���

��

�����

����

���

����

�V��

���

���

����

���%

���

%��

)����

�*

����

� ��

�����

����

����

����

����

����

���

���

��

���

����

����

���

����

����

����

����

�*

*��

����

����

����

�����

�����

���

����

���V

���

����

���V

���

���^

���

����

�%��

WAT

ER P

IPIN

G D

IAG

RA

MS

[��

���

����

����

����

���

����

����

����

��=�

�����

���

���

����

&��

+��

�K�x

����

(��=

���

����

���&

��]�

�+

���'

����

����

���K

����

����

���

����

&��

$��

+��

���*

����

���

\���

���

��C

����

��(��

=��

����

���&

��

ON

E W

AT

ER

HE

AT

ER

, SIN

GLE

TE

MP

ER

AT

UR

EW

ITH

VE

RT

ICA

L S

TOR

AG

E T

AN

K F

OR

CE

D R

EC

IRC

ULA

TIO

NW

ITH

BU

ILD

ING

RE

CIR

CU

LAT

ION

LEG

EN

DTE

MP

ER

ATU

RE

& P

RE

SS

UR

ER

ELI

EF

VALV

E

PR

ES

SU

RE

RE

LIE

F VA

LVE

CIR

CU

LATI

NG

PU

MP

DR

AIN

FULL

PO

RT

BA

LL V

ALV

E

TEM

PE

RAT

UR

E G

AG

E

WAT

ER

FLO

W S

WIT

CH

CH

EC

K V

ALV

EW

AR

NIN

G: T

HIS

DR

AWIN

G S

HO

WS

SU

GG

ES

TED

PIP

ING

CO

NFI

GU

RAT

ION

AN

D O

THE

R D

EV

ICE

S;

CH

EC

K W

ITH

LO

CA

L C

OD

ES

AN

D O

RD

INA

NC

ES

FOR

AD

DIT

ION

AL

RE

QU

IRE

ME

NTS

.

FIN

ISH

ED

FLO

OR

HO

T W

ATE

R

OU

TLET

HO

T W

ATE

RR

ETU

RN

CO

LD W

ATE

RS

UP

PLY

EX

PA

NS

ION

TAN

K

ALT

. CO

LD W

ATE

RC

ON

NE

CTI

ON

PIP

E T

&P

TO

OP

EN

DR

AIN

TAN

K O

R L

INE

TEM

PER

ATU

RE

CO

NTR

OL

LIN

E T

EM

PE

RA

TUR

EC

ON

TRO

L

TAN

K T

EM

PE

RA

TUR

EC

ON

TRO

L

NO

TE:

The

wat

er h

eate

r’s O

pera

ting

Set

Poi

nt s

houl

d be

set

high

er th

an th

e Ta

nk T

empe

ratu

re C

ontro

l in

the

auxi

liary

sto

rage

tank

.

AOSSTORAGE TANK

Page 74: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

74

/��

+��

�!�

����

+��

��*

����

����

��*

���:

x���

���

���

����

�&��

���

+��

����

���;

����

!�

����

���

���

����

�/]�

���

)����

�*

����

� ��

�����

����

����

���

����

���

����

����

�����

����

���

�����

���

����

��

�����

����

����

���

���

��

�����

����

���

����

�V��

���

���

����

���%

���

%��

)����

�*

����

� ��

�����

����

����

����

����

����

���

���

��

���

����

����

���

����

����

����

����

�*

*��

����

����

����

�����

�����

���

����

���V

���

����

���V

���

���^

���

����

�%��

WAT

ER P

IPIN

G D

IAG

RA

MS

[��

���

����

����

����

���

����

����

����

��=�

�����

���

���

����

&��

+��

�K�x

����

(��=

���

����

���&

��]�

�+

���'

����

����

���K

����

����

���

����

&��

$��

+��

���*

����

���

\���

���

��C

����

��(��

=��

����

���&

��

ON

E W

AT

ER

HE

AT

ER

, SIN

GLE

TE

MP

ER

AT

UR

EW

ITH

HO

RIZ

ON

TA

L S

TO

RA

GE

TA

NK

FO

RC

ED

RE

CIR

CU

LAT

ION

WIT

H B

UIL

DIN

G R

EC

IRC

ULA

TIO

N

LEG

EN

DTE

MP

ER

ATU

RE

& P

RE

SS

UR

ER

ELI

EF

VALV

E

PR

ES

SU

RE

RE

LIE

F VA

LVE

CIR

CU

LATI

NG

PU

MP

DR

AIN

FULL

PO

RT

BA

LL V

ALV

E

TEM

PE

RAT

UR

E G

AG

E

WAT

ER

FLO

W S

WIT

CH

CH

EC

K V

ALV

E

MIX

ING

VA

LVE

WA

RN

ING

: TH

IS D

RAW

ING

SH

OW

S S

UG

GE

STE

DP

IPIN

G C

ON

FIG

UR

ATIO

N A

ND

OTH

ER

DE

VIC

ES

;C

HE

CK

WIT

H L

OC

AL

CO

DE

S A

ND

OR

DIN

AN

CE

SFO

R A

DD

ITIO

NA

L R

EQ

UIR

EM

EN

TS.

FIN

ISH

ED

FLO

OR

HO

T W

ATE

R

OU

TLET

ALT

ER

NA

TE T

AN

KTE

MP

ER

ATU

RE

CO

NTR

OL

LOC

ATI

ON

EX

PA

NS

ION

TAN

K

HO

T W

ATE

RR

ETU

RN

CO

LD W

ATE

RS

UP

PLY

PIP

E T

&P

TO

OP

EN

DR

AIN

LIN

E T

EM

PE

RA

TUR

EC

ON

TRO

L

TAN

K T

EM

PE

RA

TUR

EC

ON

TRO

L

NO

TE:

The

wat

er h

eate

r’s O

pera

ting

Set

Poi

nt s

houl

d be

set

high

er th

an th

e Ta

nk T

empe

ratu

re C

ontro

l in

the

auxi

liary

sto

rage

tank

.

TAN

K O

R L

INE

TE

MP

ER

ATU

RE

CO

NTR

OL

AO

SS

TOR

AG

E T

AN

K

Page 75: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

75

/��

+��

�!�

����

+��

��*

����

����

��*

���:

x���

���

���

����

�&��

���

+��

����

���;

����

!�

����

���

���

����

�/]�

���

)����

�*

����

� ��

�����

����

����

���

����

���

����

����

�����

����

���

�����

���

����

��

�����

����

����

���

���

��

�����

����

���

����

�V��

���

���

����

���%

���

%��

)����

�*

����

� ��

�����

����

����

����

����

����

���

���

��

���

����

����

���

����

����

����

����

�*

*��

����

����

����

�����

�����

���

����

���V

���

����

���V

���

���^

���

����

�%��

WAT

ER P

IPIN

G D

IAG

RA

MS

[��

���

����

����

����

���

����

����

����

��=�

�����

���

���

����

&��

+��

�K�x

����

(��=

���

����

���&

��]�

�+

���'

����

����

���K

����

����

���

����

&��

$��

+��

���*

����

���

\���

���

��C

����

��(��

=��

����

���&

��

TW

O W

AT

ER

HE

AT

ER

S, S

ING

LE T

EM

PE

RA

TU

RE

WIT

H B

UIL

DIN

G R

EC

IRC

ULA

TIO

NLE

GE

ND

TEM

PE

RAT

UR

E &

PR

ES

SU

RE

RE

LIE

F VA

LVE

PR

ES

SU

RE

RE

LIE

F VA

LVE

CIR

CU

LATI

NG

PU

MP

DR

AIN

FULL

PO

RT

BA

LL V

ALV

E

TEM

PE

RAT

UR

E G

AG

E

WAT

ER

FLO

W S

WIT

CH

CH

EC

K V

ALV

EW

AR

NIN

G: T

HIS

DR

AWIN

G S

HO

WS

SU

GG

ES

TED

PIP

ING

CO

NFI

GU

RAT

ION

AN

D O

THE

R D

EV

ICE

S;

CH

EC

K W

ITH

LO

CA

L C

OD

ES

AN

D O

RD

INA

NC

ES

FOR

AD

DIT

ION

AL

RE

QU

IRE

ME

NTS

.

FIN

ISH

ED

FLO

OR

HO

T W

ATE

R

OU

TLET

HO

T W

ATE

RR

ETU

RN

CO

LD W

ATE

RS

UP

PLY

EX

PA

NS

ION

TAN

K

PIP

E T

&P

TO

OP

EN

DR

AIN

PIP

E T

&P

TO

OP

EN

DR

AIN

TAN

K O

R L

INE

TEM

PER

ATU

RE

CO

NTR

OL

LIN

E T

EM

PE

RA

TUR

EC

ON

TRO

L

Page 76: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

76

/��

+��

�!�

����

+��

��*

����

����

��*

���:

x���

���

���

����

�&��

���

+��

����

���;

����

!�

����

���

���

����

�/]�

���

)����

�*

����

� ��

�����

����

����

���

����

���

����

����

�����

����

���

�����

���

����

��

�����

����

����

���

���

��

�����

����

���

����

�V��

���

���

����

���%

���

%��

)����

�*

����

� ��

�����

����

����

����

����

����

���

���

��

���

����

����

���

����

����

����

����

�*

*��

����

����

����

�����

�����

���

����

���V

���

����

���V

���

���^

���

����

�%��

WAT

ER P

IPIN

G D

IAG

RA

MS

[��

���

����

����

����

���

����

����

����

��=�

�����

���

���

����

&��

+��

�K�x

����

(��=

���

����

���&

��]�

�+

���'

����

����

���K

����

����

���

����

&��

$��

+��

���*

����

���

\���

���

��C

����

��(��

=��

����

���&

��

TH

RE

E W

AT

ER

HE

AT

ER

S, S

ING

LE T

EM

PE

RA

TU

RE

WIT

H B

UIL

DIN

G R

EC

IRC

ULA

TIO

NLE

GE

ND

TEM

PE

RAT

UR

E &

PR

ES

SU

RE

RE

LIE

F VA

LVE

PR

ES

SU

RE

RE

LIE

F VA

LVE

CIR

CU

LATI

NG

PU

MP

DR

AIN

FULL

PO

RT

BA

LL V

ALV

E

TEM

PE

RAT

UR

E G

AG

E

WAT

ER

FLO

W S

WIT

CH

CH

EC

K V

ALV

EW

AR

NIN

G: T

HIS

DR

AWIN

G S

HO

WS

SU

GG

ES

TED

PIP

ING

CO

NFI

GU

RAT

ION

AN

D O

THE

R D

EV

ICE

S;

CH

EC

K W

ITH

LO

CA

L C

OD

ES

AN

D O

RD

INA

NC

ES

FOR

AD

DIT

ION

AL

RE

QU

IRE

ME

NTS

.

FIN

ISH

ED

FLO

OR

HO

T W

ATE

R

OU

TLET

HO

T W

ATE

RR

ETU

RN

CO

LD W

ATE

RS

UP

PLY

EX

PA

NS

ION

TAN

K

PIP

E T

&P

TO

OP

EN

DR

AIN

PIP

E T

&P

TO

OP

EN

DR

AIN

PIP

E T

&P

TO

OP

EN

DR

AIN

LIN

E TE

MPE

RATU

RECO

NTR

OL

TAN

K O

R L

INE

TE

MP

ER

ATU

RE

CO

NTR

OL

Page 77: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

77

/��

+��

�!�

����

+��

��*

����

����

��*

���:

x���

���

���

����

�&��

���

+��

����

���;

����

!�

����

���

���

����

�/]�

���

)����

�*

����

� ��

�����

����

����

���

����

���

����

����

�����

����

���

�����

���

����

��

�����

����

����

���

���

��

�����

����

���

����

�V��

���

���

����

���%

���

%��

)����

�*

����

� ��

�����

����

����

����

����

����

���

���

��

���

����

����

���

����

����

����

����

�*

*��

����

����

����

�����

�����

���

����

���V

���

����

���V

���

���^

���

����

�%��

WAT

ER P

IPIN

G D

IAG

RA

MS

[��

���

����

����

����

���

����

����

����

��=�

�����

���

���

����

&��

+��

�K�x

����

(��=

���

����

���&

��]�

�+

���'

����

����

���K

����

����

���

����

&��

$��

+��

���*

����

���

\���

���

��C

����

��(��

=��

����

���&

��

FOU

R W

AT

ER

HE

AT

ER

S, S

ING

LE T

EM

PE

RA

TU

RE

WIT

H B

UIL

DIN

G R

EC

IRC

ULA

TIO

NLE

GE

ND

TEM

PE

RAT

UR

E &

PR

ES

SU

RE

RE

LIE

F VA

LVE

PR

ES

SU

RE

RE

LIE

F VA

LVE

CIR

CU

LATI

NG

PU

MP

DR

AIN

FULL

PO

RT

BA

LL V

ALV

E

TEM

PE

RAT

UR

E G

AG

E

WAT

ER

FLO

W S

WIT

CH

CH

EC

K V

ALV

EW

AR

NIN

G: T

HIS

DR

AWIN

G S

HO

WS

SU

GG

ES

TED

PIP

ING

CO

NFI

GU

RAT

ION

AN

D O

THE

R D

EV

ICE

S;

CH

EC

K W

ITH

LO

CA

L C

OD

ES

AN

D O

RD

INA

NC

ES

FOR

AD

DIT

ION

AL

RE

QU

IRE

ME

NTS

.

FIN

ISH

ED

FLO

OR

HO

T W

ATE

R

OU

TLET

HO

T W

ATE

RR

ETU

RN

CO

LD W

ATE

RS

UP

PLY

EX

PA

NS

ION

TAN

K

PIP

E T

&P

TO

OP

EN

DR

AIN

PIP

E T

&P

TO

OP

EN

DR

AIN

PIP

E T

&P

TO

OP

EN

DR

AIN

PIP

E T

&P

TO

OP

EN

DR

AIN

LIN

E TE

MPE

RATU

RECO

NTR

OL

TAN

K O

R L

INE

TE

MP

ER

ATU

RE

CO

NTR

OL

Page 78: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

78

LIMITED WARRANTY���@��+*����!�������"�������������"��x������������������;)K)�:'���CC�#�J��������������������������������&��THE TANK)�����������\����������������������������������������=������x�*������� �������������������=������������������������������*���� ����������������"�����������������>C::��������������������������������"����������������������������������*�������������� ���������������������*�������������@��+*��������������������Z�=����������������������*����������������������������+*���=���*�������������������Z��������������������������������������������������)�������=������������������ ������������*�������Z�=������������������������"�����@��+*�����������=������*�����������*����������������������������������"����������������������*�������� ���������������������������������� �����������������������*����������������������������*������Z��������������������������������*���������������������� ����*�������������x���������*������������������������]��ALL OTHER PARTS

)���������@#:���������������������������������������������������"��������������������������=������x�*������� ����������������� ���������=�����*�������������*������"�����������������������������������������������������������������$��!@#')�)@#+��#'�:�!:��)@#+������������������������������������������������������������������������������������������* �������� �����������"������������������������"��������������������������=����������������������������������������)���������"�����*���������������������������=��=�"���������� ��!+����������=��� �������*�������+��������K����������:��������"�*�����=�� ��������������� ����������������������������������������������������������� � ?&B������ ������������������������ � ?]B����������*�������������x������������*�x�**�������������������*������ � ?$B��������������������������x���������������������������������������������� � ?/B�������������������������������*����������������������������������**���� � ?�B������������������������ ��������"��������������������������*����� � ?�B������������\�����=��������\����*���������*�������� � ?%B���������������������=�������?�B������������ � ?�B������������������������������������ � ?^B��������Q������+�����"���������������������������"�����!������� � ?&�B��������������������������������������������Z�������**���������������������� � ?&&B� ����������������������������������� �����������"�������������*=����x����������Z����� ���������������� � ?&]B����������������������������������������������������������������������� � ?&$B�*����������������������������������������������������������*������������������������������������ ���������������������������������"�����*����"�� ���?�����������������B�����������������"�����������������������*��������*"�����������*���

�������������������������=������������������ ��������������������=����������=���������������� ���������=��������=����?������=��=�������B���������������������������������������������������

����������"�����������������=��*���������������������*����x�������������������������������������?�B������������������������*��� � � ������*���������������������������=��=����������������������������not����������� ���*����� /��+:C()!:��#'�C:��)C�:��:#+:+Q�����������*����������������������������������=�����������������*���������������������������������������������������� ���������������������+��������*���������� �����������*�������� ���;� ����������������=������*=��"��������������������������������������������������*������������ ��+�������"�����=���"���������"�������*���������=�����������������������������������������������*�����������*������������������� ���������������

������������*����������=���������������������������� ���� �����������������������������������������*�����������~�����*������Z���������������������������������*�������LIMITATIONS ON IMPLIED WARRANTIES)*����������������"�������������������������*�������� �������*���������������������������������������������������*����������?&B����������������������������������������������+*���������������������*���������������������*��������������������"�������� =����*�������*�������������������!;�)K��C@!:'QC:���� ����*� ����� ���� ��������� ����� �� ���������� ����� ���� ������� ��� ���� ���� ������ ������"� �� ����� ���� ����� ������� ��������� ���� ���������� ��������)��������������������� ��"���������������������� Q�+��!��*��� !��������!��*���� � � � � ���@��+*����!�������� ���@��+*����:�����������;���� � � � � ���������������������������� ���@��[x"�$&��\�%���:����+������ � � � � ��������!���"��#�$%�&�� +��������?@�����B��#�����$� � � � � ����������&\?���B\$]$\]�$�� ����������&\?���B�]��\��]�� ������������������������������������*�����������������������*�������������������������������������������*������������������ ���� ���������������� ��'�������������*���������*����� {��������\���������=��������� �����������%��')+!;�)K:C+#@�@�>:C�:��C:++���CC�#�J�>�+�[::#�@C��);;�[:�K�':�)#�[:>�;V�@V��>:���CC�#�@C��)�>�C:+�:!���@��>:�K:C!>�#��[);)�J�@V���>:��>:��:C��@C��>:�)#+��;;��)@#"�@�:C��)@#"�C:��)C�@C�C:�;�!:K:#��@V��>:����:C��>:��:C���>:���CC�#�@C�+>�;;�#@��[:�C:+�@#+)[;:�V@C����:C�'�K�_:"�;@++�@V�Q+:�@V��>:�Q#)�"�)#!@#(:#):#!:"�;@++�@C�'�K�_:��@��:C+@#�;��C@�:C�J�@C�@�>:C�!@#+:`Q:#�)�;�'�K�_:���>:���CC�#�@C�+>�;;�#@��[:�;)�[;:�[J�()C�Q:�@V��>)+���CC�#�J�@C�@�>:C�)+:�V@C�'�K�_:��@��#J��:C+@#+�@C��C@�:C�J"��>:�>:C�')C:!��@C�)#')C:!�"��#'��>:�>:C��C)+)#_�)#�!@#�C�!��@C��@C��� ���+*������������������������x����������*������������������������������Z���������*���"�������� =����*�����������x�������*����������������� ������������������=�������������������������"�������*���������=��������������������=������*���������������

V����������������������������������������Keep it���C�������������������������������������������*����������������* ���������������������������������������

'����)��������»»»»»»»»»»»»»»»»»»»»»»»»K����#�»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»+������#�»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»

'��������#�*� »»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»�����#�»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»

'���������������»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»!��������+����»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»����!��»»»»»»»»»»»»»»»»

FILL IN WARRANTY AND KEEP FOR FUTURE REFERENCE.

Page 79: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

79

Page 80: COMMERCIAL GAS WATER HEATERS · Property Damage Hazard All water heaters eventually leak. Do not install without adequate drainage. CAUTION Fire and Explosion Hazard Leak test before

�����������������������������������!���"��#�$%�&�

www.hotwater.com