Chain hoist instructions

Embed Size (px)

Citation preview

  • 7/29/2019 Chain hoist instructions

    1/8

    2 ton chain hoist

    631

    set up and operating instructions

    V wb : ://www.bf.

    r bf .

    F y.

    saVe this manual.

    Cpright 2000 b Harbr Freight Tls. All rights reserved. N prtin f this manual r an

    artwrk cntained herein ma be reprduced in an shape r frm withut the epress written

    cnsent f Harbr Freight Tls. Diagrams within this manual ma nt be drawn prprtinall.

    Due t cntinuing imprvements, actual prduct ma differ slightl frm the prduct describedherein. Tls reuired fr assembl and service ma nt be included.

    F q , 1-800-444-3353.Revised Manual 11h

  • 7/29/2019 Chain hoist instructions

    2/8

    SKU 631 F q, 1-800-444-3353. Page 2

    saVe this manual

    Keep this manual fr the safet

    warnings and precautins, assembl,

    perating, inspectin, maintenance and

    cleaning prcedures. Write the prducts

    serial number in the back f the manualnear the assembl diagram (r mnth and

    ear f purchase if prduct has n num-

    ber). Keep this manual and the receipt in

    a safe and dr place fr future reference.

    important saFetY

    inFormation

    i , b, f

    v w :

    t fy

    yb. i

    y

    y z. oby

    fy

    fw yb v

    b y .

    danger

    z

    w, f

    v, w

    y.

    Warning

    z

    w, f

    v,

    y.

    caution,

    w fy

    yb,

    z w, f

    v,

    y.

    notice

    y.

    caution, w

    fy

    yb,

    y.

    g sfy r

    Warning r fy

    w .

    Failure to follow the warnings and

    instructions may result in serious

    injury.sv w

    f f

    f.

    Wk fy1.

    K wk wa.

    . Cluttered or dark areas invite

    accidents.

    K by-b.

    wy w .Distractions can cause you to lose

    control.

    p fy2.

    sy , w w y a.

    w . d

    w y

    the inuence of drugs, alcohol or

    . A moment of inat-

    tention while operating a tool may

    result in serious personal injury.

    u v q-b.

    . awy w y -

    . Safety equipment such as

    dust mask, non-skid safety shoes,

    hard hat, or hearing protection

    used for appropriate conditions will

    reduce personal injuries.

  • 7/29/2019 Chain hoist instructions

    3/8

    SKU 631 F q, 1-800-444-3353. Page 3

    d y. d wc.

    wy. K

    y , v

    wy f v . Loose

    clothes, jewelry or long hair can be

    caught in moving parts.

    oy fy q d. b v by -

    y. Unap-

    proved safety equipment may not

    provide adequate protection. Eye

    protection must be ANSI-approved

    and breathing protection must be

    NIOSH-approved for the specic

    hazards in the work area.

    t 3.

    d f . u a.

    f y .

    The correct tool will do the job bet-

    ter and safer at the rating for which

    it was designed.

    s f b.

    f w -

    f w

    .Tools are dangerous in the hands of

    untrained users.

    m y . ck fc.

    b f v-

    , bk f

    y y

    ff . if

    , v

    bf . Many accidents are

    caused by poorly maintained tools.

    u wd.

    , k

    wk

    wk b f.

    Use of the tool for operations differ-

    ent from those intended could result

    in a hazardous situation.

    h sfy W

    B w f y !1. Sud-

    den load movement may briey create

    ecess lad causing prduct failure.

    Use Hist safel. Never use the Hist2.

    t lift a persn r animal. Never wrk

    underneath a suspended lad. D

    nt jstle r twist a suspended lad,

    alwas mve item t the wrk area.

    Lwer and release the Hist befre

    beginning wrk.

    Cnnect the Hist t a slid beam,3.

    capable f supprting the cmbined

    weight f the Hist and lad being

    lifted.

    D nt eceed the 2 Tn (4,000 lb) lift-4.

    ing capacit f this Hist.

    Maintain labels and nameplates n5.

    the tl. These carr imprtant safet

    infrmatin. If unreadable r miss-

    ing, cntact Harbr Freight Tls fr a

    replacement.

    This prduct is nt a t. Keep it ut6.

    f reach f children.

    D nt lubricate the braking sstem.7.

    The warnings, precautins, and8.

    instructins discussed in this instruc-

    tin manual cannt cver all pssible

    cnditins and situatins that ma

    ccur. It must be understd b the

    peratr that cmmn sense and cau-tin are factrs which cannt be built

    int this prduct, but must be supplied

    b the peratr.

    REV 09j

  • 7/29/2019 Chain hoist instructions

    4/8

    SKU 631 F q, 1-800-444-3353. Page 4

    speciFications

    Hist Capacit 2 Tn (4,000 Punds)

    Maimum Lift Height 10 Feet

    Lad Chain 6mm Grade 80 Steel

    unpacKing

    When unpacking, make sure the

    item is intact and undamaged. If an parts

    are missing r brken, please call Harbr

    Freight Tls at the number shwn n the

    cver f this manual as sn as pssible.

    n: Fr additinal infrmatin regarding

    the parts listed in the fllwing pages,

    refer t the Assembl Diagram nearthe end f this manual.

    operating instructions

    r entire important

    saFetY inFormation

    b f

    x

    b bf f .

    Designate a wrk area that is clean1.

    and well-lit. The wrk area must nt

    allw access b children r pets t

    prevent distractin and injur.

    Select a lcatin r machine (such2.

    as a gantr crane) with a suitable

    cnnectin pint that can supprt the

    cmbined weight f the Hist andlad.

    Hk the tp Hk (38) f the Chain3.

    Hist nt the histing supprt. mk

    k f y

    w fy , -

    F 1, bv.

    Hk the bttm Hk nt the lad4.

    t be lifted. If straps r chain arebeing used, verif that their lad

    rating capacit eceeds the weight

    f the lad. Make sure that the lad

    is centered and that bth Hks are

    fastened securel.

    Use the Hand Chain (15) t raise the5.

    lad ff grund. See Figure 1 belw.

    Warning! u x

    f y f.

    Wait fr the lad t stp mving and6.

    then slwl raise the lad t the de-

    sired height.

    7. Warning! o

    , y -

    . B w f y

    ! Sudden lad mvement

    may briey create excess load caus-

    ing prduct failure.

    Maintain a minimum clearance f 68.

    between the Hist and Hk as-

    sembl as it ma lck and prevent

    lwering f the lad (shuld the Hk

    assembl cntact the Hist.)

    Strap

    Tp Hk

    (38)

    Hand

    Chain (15)

    Pull dwn

    this side

    t raise

    lad

    LadChain (1)

    F 1

    REV 10c

  • 7/29/2019 Chain hoist instructions

    5/8

    SKU 631 F q, 1-800-444-3353. Page 5

    T lwer the lad, slightl pull n9.

    the up chain and then start pulling

    n the dwn chain. See Figure 2,

    belw.

    Warning!10. d

    .

    11. Warning! t v

    y; keep bstanders and

    pets awa when a lad is raised r

    is being lwered. D nt wrk under

    a raised lad. n: If the lad is t

    be mved and there are n means t

    supprt the weight f the lad during

    the mve, lwer it as clse t the

    grund as pssible befre t attempt-

    ing t relcate the lad.

    Avid cntact Lad Chain cming in12.

    cntact with the grund. Clean all

    dirt and debris frm chain after each

    Stre the Chain Hist indrs ut f

    childrens reach.

    user-maintenance

    instructions

    Procedures not specically

    x

    be performed only by a qualied

    .

    to preVent

    serious injurY

    From tool Failure:

    d

    q. if b

    , v b

    bf f .

    c, m, lb

    BeFore each use,1. inspect the

    general cnditin f the tl. Check

    fr lse screws, misalignment r

    binding f mving parts, attachment

    and peratin f safet catches,

    cracked r brken parts and an

    ther cnditin that ma affect its safe

    peratin.

    periodicallY,2. lubricate the mving

    parts f the Hist with white lithium

    grease, but nt the braking sstem.

    aFter use,3. clean surfaces f the

    tl with clean clth.

    n: If this Chain Hist is t be used in a

    dirt envirnment, hang a clean plas-

    tic bucket (such as a paint bucket)

    adjacent t and just belw the Hist

    bd and the guide the verhanging

    lad chain int the bucket.

    Strap

    Tp Hk

    (38)

    HandChain (15)

    Pull dwn

    this side

    t lwer

    lad

    Lad

    Chain (1)

    F 2

  • 7/29/2019 Chain hoist instructions

    6/8

    SKU 631 F q, 1-800-444-3353. Page 6

    parts list

    p d Qy

    1 Lad Chain 1

    2 Right Side Plate 1

    3 Lwer Sta 1

    4 Chain Sprcket 15 Driving Shaft 1

    6 Spine Gear 1

    7 Pinin Gear 1

    8 Desk Gear 1

    9 Hand Wheel 1

    10 Brake Seat 1

    11 Frictin Plate 1

    12 Rller 1

    13 Bearing Race 1

    14 Ratchet Disk 1

    15 Hand Chain 1

    16 Pawl Spring 1

    17 Pawl 1

    18 Hand Wheel Cver 1

    19 Snap Ring 1

    20 Pawl Pin 6

    parts list

    p d Qy

    21 Spring Washer 1

    22 Suspensin Plate 1

    23 Suspensin Pin 1

    24 Chain Latch 125 Snap Ring 1

    26 Pin 1

    27 Guide Rller 1

    28 Bearing Race 1

    29 Upper Sta 1

    30 Hk Hanger 1

    31 Bent Plate 1

    32 Rller 1

    33 Sheet Cver 1

    34 Shaft 1

    35 Needle 1

    36 Idle Sheave 1

    37 Hk Hlder 1

    38 Hk 2

    39 Lifting Chain 1

    r p s nb h:

    n: If prduct has n serial number, recrd mnth and ear f purchase instead.

    n: Sme parts are listed and shwn fr illustratin purpses nl, and are nt available indi-

    viduall as replacement parts.

    please read the FolloWing careFullY

    THE MANUFACTURER AND/oR DISTRIBUToR HAS PRoVIDED THE PARTS LIST

    AND ASSEMBLy DIAGRAM IN THIS MANUAL AS A REFERENCE TooL oNLy.

    NEITHER THE MANUFACTURER oR DISTRIBUToR MAKES ANy REPRESENTATIoN

    oR WARRANTy oF ANy KIND To THE BUyER THAT HE oR SHE IS qUALIFIED

    To MAKE ANy REPAIRS To THE PRoDUCT, oR THAT HE oR SHE IS qUALIFIED

    To REPLACE ANy PARTS oF THE PRoDUCT. IN FACT, THE MANUFACTURER

    AND/oR DISTRIBUToR ExPRESSLy STATES THAT ALL REPAIRS AND PARTS

    REPLACEMENTS SHoULD BE UNDERTAKEN By CERTIFIED AND LICENSED

    TECHNICIANS, AND NoT By THE BUyER. THE BUyER ASSUMES ALL RISK AND

    LIABILITy ARISING oUT oF HIS oR HER REPAIRS To THE oRIGINAL PRoDUCT

    oR REPLACEMENT PARTS THERETo, oR ARISING oUT oF HIS oR HER

    INSTALLATIoN oF REPLACEMENT PARTS THERETo.

  • 7/29/2019 Chain hoist instructions

    7/8

    SKU 631 F q, 1-800-444-3353. Page 7

    partsdia

    gram

  • 7/29/2019 Chain hoist instructions

    8/8

    SKU 631 F q, 1-800-444-3353. Page 8

    90 dy Wy

    Harbr Freight Tls C. makes ever effrt t assure that its prducts meet high ualit

    and durabilit standards, and warrants t the riginal purchaser that this prduct is free

    frm defects in materials and wrkmanship fr the perid f 90 das frm the date f

    purchase. This warrant des nt appl t damage due directl r indirectl, t misuse,abuse, negligence r accidents, repairs r alteratins utside ur facilities, criminal ac-

    tivit, imprper installatin, nrmal wear and tear, r t lack f maintenance. We shall in

    n event be liable fr death, injuries t persns r prpert, r fr incidental, cntingent,

    special r cnseuential damages arising frm the use f ur prduct. Sme states

    d nt allw the eclusin r limitatin f incidental r cnseuential damages, s the

    abve limitatin f eclusin ma nt appl t u. This warrant is epressl in lieu f

    all ther warranties, epress r implied, including the warranties f merchantabilit and

    tness.

    T take advantage f this warrant, the prduct r part must be returned t us with trans-

    prtatin charges prepaid. Prf f purchase date and an eplanatin f the cmplaint

    must accompany the merchandise. If our inspection veries the defect, we will either

    repair r replace the prduct at ur electin r we ma elect t refund the purchase price

    if we cannt readil and uickl prvide u with a replacement. We will return repaired

    prducts at ur epense, but if we determine there is n defect, r that the defect re-

    sulted frm causes nt within the scpe f ur warrant, then u must bear the cst f

    returning the prduct.

    This warranty gives you specic legal rights and you may also have other rights whichvar frm state t state.

    3491 Mission Oaks Blvd. PO Box 6009 Camarillo, CA 93011 (800) 444-3353

    REV 11h