Upload
others
View
11
Download
0
Embed Size (px)
Citation preview
Bulletin 592 E1 PLUS Overload Relay Application and InstallationApplication et installation du relais de surcharge Famille 592 E1 PLUS(Cat 592-EEKF; 592-EEMG)
InstallationInstalación
PN-75218DIR 10000015209 (Version 02)Printed in U.S.A.
28 - 40 lb-in
NEMA Size 5Calibre NEMA 5
NEMA Size 6Calibre NEMA 6
2
4
6
3
1
To prevent electrical shock, disconnect from power source before installing or servicing. Install in suitable enclosure. Keep free from contaminants.
Pour éviter les risques d'électrocution, débranchez du secteur avanttoute installation ou toute réparation. Installez l'appareil dans un boîtier approprié. Gardez-le à l'abri de tout produit contaminant.
176 - 184 lb-in
WARNING
AVERTISSEMENT
5
5 lb-in
100 - 160 lb-in
320 - 480 lb-in2
1
E1 PLUS FeaturesCaractéristiques du E1 PLUS
(2)
= FLA1.73
S.F. < 1.15
S.F. _ _ FLA _ _
S.F. 1.15
Y
= .9 X FLA
= 1 X FLA
= FLA1.73
STAR DELTA (Y )
= 1 X FLADOL
FLA _ _
To adjust trip current, turn dial until the desired current isaligned with the pointer. Trip rating is 120% of dial setting. Pour régler l'intensité du déclencheur,faites tourner le cadran et alignez le pointeur sur l'intensité désirée. Lavaleur nominale du déclenchement est de120% supérieure à celle du cadran.
RESET MODE
193*-EE
A M
TRIP CLASS
10 15
20 30
Push to ResetEnfoncer pour réinitialiser
A = Automatic/Manual Reset ModeA = Mode de réinitialisation automatique/manuel
M = Manual Reset ModeM = Mode de réinitialisation manuel
Push To TestAppuyez pour tester
Trip Indicator WindowYellow indicator not visible: Not Tripped.Yellow indicator visible: Tripped.Fenêtre-témoin de déclenchement Indicateur jaune non visible: aucun déclenchement. Indicateur jaune visible: déclenchement.
Selectable Trip ClassSélections des classes de déclenchement
Contact StatusConfiguration des contacts
ClosedOpenOpen
OpenOpenClosed
TrippedTestNormal
95
97 98
96
97 95
98 96
97 95
98 96
97 95
98 96
Do not use automatic reset mode in applications where unexpected automatic restart of the motor can cause injury to persons or damage to equipment. N'utilisez pas le mode Remise à zéro automatique dans les applications où un redémarrage automatique inattendu du moteur pourrait provoquer des blessures personnelles ou des dégâts matériels.
95
L2 L3 13L1
14
A1
A2
T2 T3T1
96 97 98
T1 T3T2
S.C.P.D.
1
95
3 5
13
1
14
A1
A2
4 6296 97 98
U WV
S.C.P.D.
1
Wiring Diagram - 3 Phase Full Voltage DOL StarterSchéma de câblage - Pleine tension triphasée Démarreur DOL (direct en ligne)
Connection must befitted by user
Connexion à régler parl'utilisateur
1
1
PN-75218DIR 10000015209 (Version 02)
Rotate to Manually TripFaire pivoter pour déclencher manuellement
WARNING
AVERTISSEMENT
(3)
Rated Insulation Voltage (Ui):Rated Operational Voltage (Ue) IEC/UL:Rated Operating Current (Ie):
690V AC690V AC/600V ACB600 N.O. / N.C.
Terminal Screw
M3 0.5 … 2.5 mm²
0.55 Nm0.2 … 0.75 mm²
0.55 Nm0.5 … 4 mm²
0.55 Nm0.2 … 1.5 mm²
0.55 Nm24 … 10 AWG
5 lb-in 22 … 16 AWG
5 lb-in
0.6 x 3.5 mm
1x
2x
1x
2x
1x
2x
#1
Control ConnectionsBornes de Commande
PN-75218DIR 10000015209 (Version 02)
Multiple of FLAMultiples de l'intensité pleine charge
Trip CurveCourbe de déclenchement
Short Circuit Ratings
HOT STARTDÉMARRAGE À CHAUD
COLD STARTDÉMARRAGE À FROID
Class 10 Class 15 Class 20 Class 30
0.1
1
10
100
1000
1 80.1
1
10
100
1000
1 80.1
1
10
100
1000
1 8
0.1
1
10
100
1000
1 8
Table 1 Standard Fault Short Circuit Ratings per UL508 and CSA 22.2 No.14Max. available fault
current (kA)Max. voltage
(V)S.C.P.D.
592EEKF 10 600
E1 Plus Cat. No.
Table 2 High Fault Short Circuit Ratings per UL508 and CSA 22.2 No.14
ContactorSize
MAX.available
fault current(KA)
MAX.voltage
(V)
592
R J
65kA with 400 ACircuit BreakerEEKF 5 100
CircuitBreaker/ Limiter
E1 Plus Cat. No. Max. UL Class R orClass J fuse (A)
480600
240400400
400600600
600
Not resticted to fusing only
EEMG 18 600Not resticted to fusing only
Accessories
PN-75218DIR 10000015209 (Version 02)Printed in U.S.A.
NEMA Size 5Calibre NEMA 5
For Use With Cat. No. Current Adjustment Shield
193-BC8
592-EE (all)
RESETAREA
RESETAREA
3.37(85.6)
3.37(85.6)
ø .56 (ø 14.2)(4 Mtg. Holes)
ø .34 (ø 8.6)(5 Mtg. Holes)
1/2-13 UNC(4 Bolts)
17.12(434.8)
25.11(637.8)
23.09(586.5)
21.00(533.4)
9.01(228.8)
1.70(43.2)
11.81(300)
13.26(336.8)
8.91(226.3)
10.00(254)
11.09(281.7)
8.51(216.2)
3.59(91.2)
.89(22.6)
7.09(180.1)
2.95(74.9)
1.17(29.7)
in(mm)
3.41(86.6)
1.64(41.6)
2.95(74.9)
5/16-18 UNC(4 Bolts)
NEMA Size 6Calibre NEMA 6
in(mm)
16.9(429.3)
10.78(273.8)
1.76(44.7)
6.5(165.1)
2.16(54.9)2.16
(54.9)1.17
(29.7)
9.84(249.9)
.38(9.6)
14.96(380)
15.81(401.6)
8.35(212.1)
8.06(204.7)
1.21[30.7]
6.31(160.3)
7.38(187.5)
CONFIDENTIAL AND PROPRIETARY INFORMATION. THIS DOCUMENT CONTAINS CONFIDENTIAL AND PROPRIETARY INFORMATION OF
ROCKWELL AUTOMATION, INC. AND MAY NOT BE USED, COPIED OR DISCLOSED TO OTHERS, EXCEPT WITH THE AUTHORIZED WRITTEN
PERMISSION OF ROCKWELL AUTOMATION, INC.
Sheet
Size Ver
Of 11
A 0010000021658Dr. DateG. USHAKOW 2-10-10
SPECIFICATIONS FOR4 PAGE INSTRUCTION SHEET4-1/4” W x 2-3/4” H - FINAL FOLD
MATERIALSIZE
FOLD
TWO SIDES PRINTEDBODY STOCK WHITE
BODY INK BLACK4-1/4" W x 2-3/4" H
FLAT
8-1/2"
PAGE 2
PAGE 1
11"
8-1/2"
PAGE 3
PAGE 4
17" W x 11" H
Note: After folding---Printed in (Country where printed)* and instruction sheet number in lower left corner should be visible.
* The printing vendor may change the instruction sheet files to show the correct country.
Page Layout
Final Fold
4-1/4”
2-3/4”PN-12345DIR 100000000 (Version 00)Printed in U.S.A.