Bobcat 600 Skid Steer Loader Parts Manual - Tractor … · bc-p-600 bboobbccaatt parts manual 600 skid steer this is a manual produced byjensales inc.without the authorization of

BC-P-600

BBoobbccaattParts Manual

600 Skid Steer

THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF BOBCAT OR IT’S SUCCESSORS. BOBCAT AND IT’S SUCCESSORS

ARE NOT RESPONSIBLE FOR THE QUALITY OR ACCURACY OF THIS MANUAL.

TRADE MARKS AND TRADE NAMES CONTAINED AND USED HEREIN ARE THOSE OF OTHERS, AND ARE USED HERE IN A DESCRIPTIVE SENSE TO REFER TO THE PRODUCTS OF OTHERS.

Part

s M

anua

l

http://www.jensales.com/products/bobcat-600-skid-steer-loader-parts-manual.html

• 600

•

• IIfELROE. COJIUIANr


600 ALPHABETICAL INDEX

ADHESIVE •• . • . . • • • • • • . • • . . . • • • • • •• M20 AIR CLEANER •••••.•.••• H12, 113, J7, J9 ALARM, BACKUP .••••••••••••••••• J22 ALTERNATOR .•....•. E17, E19, E22, H23 ALTERNATOR, FLyWHEEL •••••••• F1, F2 ANn-FREEZE •••••••••••.•.•••...• M18 AXLE • • • • • . . • • . . • . • . • • • . .. A23, A24, J20

BATTERy .••••••••.•••••.••••.•• D12-E2 BELT, ALTERNATOR ••••...•• B8, 016, H4 BLACK GOLD. • . . . • . • • • • • • • • • • • • • .• M20 BLOWER, WHEEL •••••••••••••••••• H10 BOB-TACH. •••••••••••••• •••. A17, A18 BRAKES ••••••••••••••••• " A24, J24, K1

CAB •••••••..•••••••••••••••••••••• A15 CAB ENCLOSURE. • • • • • • • • • • • • • • • • .• K4 CABLE, BATTERy ••••••••••••••• D12-E2 CABLE, SHUT-OFF • • • • . • • • • • • • • • • • • • F7 CAMSHAFT •••••••••••••••• F16, H16, 123 CAP, FUEL •••••••••••••••.••••••••• A14 CAP, HYD. OIL •.•.••••••••••••••••• A14 CARBURETOR •••••••••• F23, G1, G6, G7 CHAIN, DRIVE. • • • • • • • • • • • • • • • • • • • •• A21 CLUTCH •••••.••••••••••••••••••• B2, B3 CRANKSHAFT •••••.••••••• F14, H22, 120 CYLINDER BLOCK •••••••• F12, F17, H18 CYLINDER, LIFT • • • • • • • • • • • • • • • C12, C16 CYLINDER, TILT ••••••••••• C14, C17, C18

DECALS ••••••••••••••••••••••••• K6, K8 DIPSTICK, ENG. OIL .••.•••• G12, H18, J2 DiSTRIBUTOR ••••••••••••••••••••• G19 DOOR, CAB. • • • • • • • • • • • • • • • • • • • • • • •• K4 DOOR, REAR •••••••••••••••••••••• A12

ENGINE .................... F4, G22, 110

FILTER, AIR ••••••••••••• H12, 113, J7, J10 FILTER, ENG. OIL •••• G13, G14, 13, 16, 124 FILTER, FUEL ............. G3, H2, 18, J6 FILTER, HYD. OIL .................. B19 FIRE EXTINGUiSHER ............... K10 FLyWHEEL ......... F1, F2, F14, H22, 122 FUEL FILTER ....................... F6 FUELINJECTOR .................... 118 FUEL SYSTEM ....................... 18 FUSE •• 012,014,016,018,020,022,024

GASKET KIT, ENG •••••• F4, F12, G22, H20 GAUGE, AMMETER, .. .. .. .. .... D12-E2 GENERATOR ...................... E24 GLOW PLUG .............. 018,020,022 GOVERNOR ............... F20, H18, J3

HARNESS, WIRING •••••••••••••• D12-E2 HEAD, CyLINDER •••••.•••• F12, H16, 118 HORN ••••••••••••••••••••••••••••• K14 HOURMETER ................... D12-E2

INSTRUMENT PANEL •••••••••• A12, A14

JACKSHAFT .••••••••••••••• A22, B6, B8

LEVER, STEERING .................. B2 LIFT ARM. • • • • • • • • • • • • • • • • • • •• • • • •• A16 LIFT HOOK •••••••.•••••••••••••••• K16 LIGHT .•••..•••••.••.••••••••••.••• K17

AS

LIGHT, FLASHER.. .. . .. .. .. .. .. .... K11 LUBRICANT ....................... M20

MAIN FRAME .................. A11, A14 MANIFOLD ••••••••• F21, G4, G5, H12, 116 MOUNT, ENGINE .•••••.••••••••• H4, 114 MOUNT, HYD. PUMP •••••..••... G16, H5 MUFFLER .................... F5, H2, 113 MUFFLER SCRUBBER.. .. .. .. .. .... K22

OIL •••••••••••••.••.••••••••••••.•• M20 OIL COOLER. • . • • • . • • • • • • • • • • • • • • • • •. 12

PAINT •••••••••.••••••••••••••••••• M20 PEDALS, CONTROL .••••••••••• B11, M6 PISTON.. .. .. .. .. .. .. .. .... F16, H22, 120 POLISH •••••••••••••••••••••••••••• M20 PULPWOOD LOADER .............. K20 PUMP, FUEL ••••••••••••••••••••••••• J6 PUMP, HYD •••••••••••••••••••••••• B24 PUMP, HYD. • • • • • •• C1, C2, C3, C4, C5, C6 PUMP, INJECTION ••••••••••••••••• 18, J6 PUMP, OIL •••••••••••••••••• G15, 12, 124

QUICK COUPLERS ••••••••• J15, J16, J18

REGULATOR •• 016,018,020, E2, F2, G10 RIM, WHEEL •••••••••••••••••••••••• M8 RING GEAR ••••••••• F1, F2, F14, H22, 122

SEALANT.. .. .. .. .. .. .. .. .. .. .. .... M20 SEAT, A14 ••••••••••••••••••••••••• A19 SEAT BAR ••••••••••••••••••••••••• K24 SEAT BELT ........................ A19 SHEAVE, VAR. SPEED, • B9, B10 & 02-08 SHROUD ...................... F10, 115 SHROULD ••••••••••••••••••••••••• H10 SOLENOID .............. E3, E5, E11, E13 STARTER ••• E3, E5, E7, E9, E11, E13, E16 STOP, LIFT ARM ••.••••••••••••••••• K15 STROBE LIGHT ................. M2, M3 SWITCH, ENG. OIL PRESS. •••••• D12-E2 SWITCH, IGNITION •••••••••••••• D12-E2

TANK, LP GAS ..................... G11 THROTTLE •••••••••• F7, F8, G2O, H7, 112 TIGHTNER, CHAIN ••••••••••••••• B4, B5 TIRE GUARD. • • • • • • • • • • • • • • • • • • • • • •• M7 TIRES ••••.•.••••••••••••••••••••••• M8

VALVE COVER ..................... H16 VALVE, ENG •••••••••••••••• F17, H15, 118 VALVE, HYD. LIFT ••••••••••••••••••• C9 VALVE, HYDR. TILT ................. C10 VALVE, VAR. SPEED. • • • • • • • • •• C22, C23 VAPORIZER. • • • • • • • • • • • • • • • • • • • • • • •• G9 , VERTICAL FORKLIFT ............... M12

WINDOW, REAR. • • • • • • ••• • • • •• • •• ••• K4 WINDOW, SIDE.. .. .. .. .... .. .. .. .... K4 WINDSHIELD WIPER ............... M17


600 CONTENTS MAIN FRAME ......................................................................... A11-A19

MAIN FRAME ATIACHING PARTS .............................................................. A11-A14 OPERATOR CAB .................................................................................. A15 LIFT ARM & UPRIGHT ASSEMBLy ................................................................... A16

BOB-TACH .................................................................................... A1i,A18 SEAT & SEAT MOUNTING .......................................................................... A19

DRIVE SYSTEM .................................................•.................... A21-B10 DRIVE TRAIN ..................................................................................... A21 LOWER JACKS HAFT ASSEMBLY ................................................................... A22 AXLE ............................................................................................. A23 FRONT AXLE BRAKE ....... , ...................................................................... A24 CLUTCH CONTROL LINKAGE ........................................................................ B1

CLUTCH ........................................................................................... B3 OUTSIDE CLUTCH CHAIN TIGHTENER ............................................................... B4 INSIDE CLUTCH CHAIN TIGHTENER ................................................................. B5

VARIABLE SPEED JACKS HAFT ...................................................................... B6 VARIABLE SPEED JACKSHAFT ASSEMBLY ........................................................... B7 VARIABLE SPEED DRIVEN SHEAVE .............................................................. B9,B10

HYDRAULIC CiRCUiTRy ............................................................... 811-010 HYDRAULIC CONTROL PEDALS ... . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. B 11 VARIABLE SPEED CONTROL LEVER ................................................................ B12 MAIN FRAME HYDRAULIC CiRCUiTRy ......................................................... B13-818 HYDRAULIC OIL FILTER ............................................................................ B19 HYDRAULIC PUMP CIRCUITRY .... . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. B20-823 HYDRAULIC PUMP ............................................................................ B24-C6 MASTER RELIEF VALVE ............................................................................. C7 CLUTCH PRESSURE RELIEF VALVE ................................................................. C8 LIFT CYLINDER & AUXILIARY VALVE ................................................................. C9 TILT CYLINDER VALVE ............................................................................. C10 LIFT CYLINDER HYDRAULIC CiRCUiTRy ............................................................ C11 TILT CYLINDER HYDRAULIC CiRCUiTRy ............................................................ C13 MAIN FRAME AUXILIARY LINES .................................................................... C15 LIFT CYLINDER ................................................................................... C16 TILT CYLINDER ............................................................................... C17,C18 VARIABLE SPEED DRIVE CiRCUiTRy ........................................................... C19,C20 VARIABLE SPEED VALVE ..................................................................... C21-C23 VARIABLE SPEED DRIVE SHEAVE ............................................................... D1--08 VARIABLE SPEED SWIVEL COUPLiNG ........................................................... D9,D10

ELECTRICAL SySTEM .................................................................. D11-F2 MAIN FRAME ELECTRICAL CiRCUiT ............................................................ D11--E2 STARTERS .................................................................................... E3--E16 ALTERNATOR ................................................................................ E17--E22 BOSCH GENERATOR .............................................................................. E23 FLYWHEEL ALTERNATORS ....................................................................... F1,F2

POWER UNIT (WISCONSIN) ............................................................. F3-G20 WISCONSIN ENGINE ............................................................................... F3 ENGINE ATIACHING PARTS ......................................................................... F5 THROTILE & CHOKE CONTROL LINKAGE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. F7 THROTILE CONTROL .............................................................................. F8 ENGINE SHROUDING ............................................................................... F9 ENGINE BREAKDOWN ......................................................................... F11-F22

CARBURETOR ................................................................................ F23-G2 FUEL FILTERS .................................................................................. G3,G4 LP GAS GROUP .................................................................................... G4 LPG CARBURETOR ............................................................................. G6-G8 LPG VAPORIZER ................................................................................... G9 SECONDARY STAGE REGULATOR .................................................................. G10 LP GAS TANK & ATIACHING PARTS ............. , ................................................... G11

ENGINE OIL GROUP ............................................................................... G12 ENGINE OIL FILTER .......................................................................... G13,G14

ENGINE OIL PUMP ................................................................................ G15 HYDRAULIC PUMP MOUNTING ASSEMBLy .......................................................... G16

IGNITION COIL, CABLES & DISTRIBUTOR DRiVE ..................................................... G17 DISTRIBUTOR ..................................................................................... G19 THROTILE ........................................................................................ G20

A9


600 CONTENTS (Cont'd) POWER UNIT (DEUTZ F2L410) .......................................................... G21-17

DEUTZ DIESEL ENGINE ............................................................................ G21 ENGINE ATTACHING PARTS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. H1-H4 HYDRAULIC PUMP MOUNTING ...................................................................... H5 SHUT DOWN & THROTTLE ARM ........................................... : ......................... H6 THROTTLE CONTROL & LINKAGE ................................................................... H7 AIR BLOWER & SHROUD ........................................................................... H9 AIR CLEANER & MANIFOLD ........................................................................ H11 ENGINE BREAKDOWN ........................................................................ H13-H22 LUCAS ALTERNATOR MOUNTING .................................................................. H23 DELCO ALTERNATOR MOUNTING .................................................................. H24 GENERATOR MOUNTING ............................................................................ 11 OIL COOLER, OIL PUMP & OIL FILTER GROUP ......................................................... 12 FULL FLOW OIL FILTER ........................................................................... 13-16 FUEL SYSTEM ...................................................................................... 17

POWER UNIT (PETTER) .................................................................. 19-J10 PETTER DIESEL ENGINE ............................................................................ 19 ENGINE CONTROL LINKAGE ........................................................................ 112 PETTER ENGINE & ATTACHING PARTS .............................................................. 113 AIR SHROUDING .................................................................................. 115 MANIFOLDS .... ' .................................................................................. 116 ENGINE BREAKDOWN. . . .. . . . . .. . .. . . . .. .. . . .. .. . .... . . .... . . . . . . . . . .. . .. . . .. . . . . . . . .. . . .. . . . .. 117-J6 AIR CLEANER .................................................................................. J7-J10

ACCESSORIES & OPTIONS ............................................................ J13-M15 ALTERNATOR KIT ................................................................................. J13 AUXILIARY HYDRAULIC CONTROL KIT .............................................................. J15 AUXILIARY HYDRAULIC SySTEM ................................................................... J16 AUXILIARY HYDRAULIC LINES ..................................................................... J17 AXLE & BRAKE ASSEMBLy ......................................................................... J19 AXLE SEAL KIT .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. J21 BACK-UP ALARM ................................................................................. J22 BRAKES .......................................................................................... J23 BRAKES & ATTACHING PARTS ...................................................................... K1 CAB ENCLOSURE .................................................................................. K3 DECALS ....................................................................................... K5-K8 EXHIBITION COVER ................................................................................ K9 FIRE EXTINGUiSHER .............................................................................. K10 FLASHER LIGHTS & CiRCUiTRy .................................................................... K11 FLOOR PANEL .................................................................................... K12 FOLD AWAY DRAWBAR ............................................................................ K13 HORN & CiRCUiTRy ............................................................................... K14 LIFT ARM STOPS .................................................................................. K15 LIFT HOOK ........................................................................................ K16 LIGHTS ........................................................................................... K17 PULPWOOD LOADER & ATTACHING PARTS ......................................................... K19 SCRUBBER MUFFLER ............................................................................. K21 SEAT BAR KIT ..................................................................................... K23 SOUND REDUCTION HARDHAT ..................................................................... M1 STROBE LIGHT ................................................................................ M2,M3 THREE PEDAL KIT .................................................................................. M5 TIRE GUARD ....................................................................................... M7 TIRES & RIMS ...................................................................................... M8 VERTICAL FORKLIFT HYDRAULIC CIRCUITRY ........................................................ M9 VERTICAL FORKLIFT .............................................................................. M11 VERTICAL MAST .................................................................................. M13 VERTICAL FORK LIFT TILT CyLINDER ............................................................... M15 VERTICAL FORK LIFT LIFT CYLINDER .............................................................. M16 WINDSHIELD WIPER .............................................................................. M17

BULK ITEMS .............................................................................. M19 NUMERICAL INDEX ....................................................................... M21

A10


Ref. Part N N b o. urn er D escrlPtlon

1 6515462 CHAIN 6515191 LINK 6515383 LINK

2 6515377 CHAIN 6515187 LINK

3 6515369 CHAIN 6564943 LINK 600761 LINK

4 AXLE ASSV. 5 JACKSHAFT 6 TIGHTENER 7 LINKAGE 8 CLUTCH ASSV 9 TIGHTENER

10 JACKSHAFT

DRIVE TRAIN

R k ernar s #60H connector - #60 half-#60 #50 connector - #50 #40 connector - #40 half-#40 See Page A23 & A24 lower - See Page A22 chain - See Page 85 clutch control- See Page 82 See Page 83 chain - See Page 84 variable speed - See Page 86 & 88

A21

C-1006

S . IN b erla urn er Q. tv, 2 2 2 1 1 1 1 1 1 1 1 1 1 1

1

ModelSOO Loader Parts


Ref. Part N N b o. urn er o escrlptlon

1 6548694 KIT 2 17C-616 BOLT 3 4E~ WASHER 4 610-6 NUT 5 6547315 BRACKET· 6 6517676 LIGHT 7 1010102 GROMMET 8 NAP HARNESS 9 30H-12 CLAMP

10 6515521 SWITCH 11 NAP HARNESS 12 6512052 STRAP 13 6515513 LIGHT 14 17C-612 BOLT 15 6545975 INSTRUCTIONS

LIGHTS

R k ernar s lights - Ref. 2 -15

wiring - Was 6552791

wiring - Was 6552794 retainer rear

K17

15 I

1

C-2264

S 'IN b Q. erla urn er tv, 1 3 3 3 3 2 2 1 5 1 1 3 1 1 1



NUMERICAL INDEX (Cont'd)

P N art o. D . r W C d escrlp110n as o e P age 200032 SEAL 225855 SEAL 229551 WASHER 300232 ROLL PIN 301923 PIN 329884 FAN 335902 BAND 337800 VALVE 522633 CLAMP 536224 ELBOW 550358 NIPPLE 565049 GROMMET 584092 WASHER 585950 GROMMET 600761 LINK 608869 FUSE 614765 VALVE ~618298 ELBOW 618337 BUSHING 620558 ELBOW 620560 ELBOW 633157 PIN 647359 CLAMP 654632 ROLL PIN 655336 VALVE 656598 ADAPTER 657904 CLAMP 658524 SNAP RING 658927 BEARING 659179 CLAMP 660123 ELBOW 661558 HOSE 661844 ELBOW 661877 SPACER 662106 STUD 662487 ELBOW 662768 SEAL 663013 BUSHING 663350 PIN 663365 ADAPTER 664402 WASHER 666587 SNAP RING 666846 ELBOW 666888 ROLL PIN 666939 WASHER 667483 CABLE 668312 PIN 669358 BEARING 672568 WASHER 675181 BEARING 711215 CLAMP Code for disposition of old part number A-Use up B - Use on other application (See PNI)

M21

04,06 B9,Bl0

J6 117,J4

08,010 E20 J7

K22 02

B22 M9

012,014,015,020,022,024,E2 B5

018 A21

012,014,016,018,020,022,024 K20 Gll

B9,Bl0 H4

B21 A17

G2,G8 04

Gll J15,J16,J18

F6 08 02

Jl0 G4

J18 16

J16 H13

C12, C14, C15 J18 C22,C23

B14,B16,B18 Bll, J24, Kl, M6

H2 C22,C23

09 B15,B18

M14 C17 C18

012,014,016 A12 A22

A12,B6

C - File PDR Report with Melroe Parts Sales D - Part Number Error

E18 113

ModelSOO

Loader Parts


*


P N art o. D escrlptlon 713023 BEARING 713024 CUP 715976 AOAPTER 715977 AOAPTER 730146 CLAMP 730963 AOAPTER 731237 BEARING 731918 ELBOW 733642 HOLOER 743367 CABLE 755050 BUSHING 755622 HOSE 784469 WASHER 791355 ROLL PIN 791837 WASHER 794584 WASHER 799087 WASHER 799146 OOWELPIN 850009 FLOAT 850011 SPRING 850018 GASKET SET 850024 PLATE 850313 PIN 850315 RETAINER 850363 COLLAR 850842 WASHER 852074 BOLT 852272 VALVE 852273 FLOAT 852279 PLUG 852287 LEVER 853227 JET 853492 JET 853577 SPRING 854347 TEE 854571 CARTRIOGE 854609 JET 854934 PLATE 854943 COVER 859369 NUT 859377 SCREW 860011 SPRING 860669 BUSHING 860673 WASHER 860818 CONOENSER 861276 WASHER 861741 BEARING 866397 SPRING 868454 PLATE 869686 WASHER 870925 CAP Code for disposition of old part number A-Use up B - Use on other application (See PNI)

W Cd as o e P age A23 A23 G11 G11

H2 B23 H18 M9

012,014,016,018,020,022,024 018,020,022

B20 J14 B23

B9,B10 J10 E20 A23

C1,C5,C6 F24 G2 G2 G2 E4

E19 E4

G2,J6 F12 F24 G2

G2,G8 G2

F24 F24 G2 H2

G13 G2

G19 G19

E20,H24 E4 G7

E4,E6 E4

G19 F12

B4,B5 G6

G2,G6 J2

G19

C - File PDR Report with Metroe Parts Sales 0-Part Number Error

M22 ModelSOO

Loader Parts



Part No. Description 871518 BRUSHES 871521 PIN 871524 PLATE 871545 PLATE 871547 SEAL 871569 DRAIN DISC 872144 MAIN BEARING 872934 GASKET KIT 873959 SPRING 874159 SCREW 874160 NUT 874161 SPRING 874162 COVER 874164 PLATE 874165 PISTON 874168 BUTTON 874169 ORIFICE 874171 FITTING 875248 CLAMP 875587 DIAPHRAGM 875589 INLET 875590 VALVE 875591 SCREW 876586 FILTER 8n650 HOLDER 8n884 NEEDLE 8n886 SHAFT 878103 WASHER 878608 COLLAR 878992 WASHER 879659 REPAIR KIT 880603 HOLDER 880609 BOLT 882619 LEVER 882623 ORIFICE 882634 BRACKET 882635 PLUG 883008 FRAME 884424 RETAINER 884576 SCREW 884581 SOLENOID 885083 HORN ASSY. 885100 O-RING 886527 WASHER 887408 COIL 887839 BUSHING 888670 GUIDE 888968 SPRING 889097 CLAMP 889847 BODY 890272 PLUG Code for disposition of old part number A-Use up B - Use on other application (See PNI)

as o e W Cd P age E4 E4 E6 G7 G6 G2

F16 F24 G9 G9 G9 G9 G9 G9 G9 G9 G9 G9

C12, C14 Gl0 Gl0 Gl0 Gl0

G3 E3,E5

G6 G6,G8

E6 E4 J2

Gl0 E4,E6

E3 G6 G8

G6,G8 G8 E5 G6 E4

E3,E5 K14 B20

J7 D12 D14.D16.G18

E6 D8,Dl0

E3 J7

B24 G18


M23 Model 600

Loader Parts



P N art o. D escnptlon 891055 CUSHION 891056 CUSHION 891057 SPRING 891058 COVER 891059 SPACER 891060 LEVER 892101 BAFFLE 892102 CAP 893638 INDICATOR 894215 KIT 895674 HOUSING 895675 BOLT 896126 LEVER 896144 CAP 896146 SPACER 896147 GUIDE 896149 NUT 896150 VALVE 896152 SPRING 896153 POST 896263 WASHER 896264 WASHER 896265 WASHER 896293 WASHER 897262 CONTACT SET 897298 CLAMPS 897445 STATOR 897451 HEAT SINK 897456 RETAINER 897463 KIT 897467 BOLT 898215 JET 899304 ROTOR 905350 BEARING 905952 TERMINAL ASSY. 906181 REPAIR KIT 907827 SCREW 907828 BUSHING 907953 STATOR 942142 RETAINER 946865 CARTRIDGE 947741 CAP 954573 WASHER 957791 ROTOR 980678 SEAL 980731 SPRING 980732 CAP 980733 SPRING 980734 COLLAR 980735 SEAT 980862 PIN Code for disposition of old part number A-Use up B - Use on other application (See PNI)

W Cd as o e P age A19 A19 G8 G7 G7 G7 J7 J7

J10 B24, C1, C5, C6

E6 E5

E3,E5 B19 B19 B19 B19 B19 B19 B19

C7, 115, 116, 123, 124, J2, J6 C7,D8,D10

C7 117

G19 G19 E18 E17 E18 E17 E19 G2

E17 E19 E20 G9 E4 E4

E19 E4

B19 C7 J2

G19 J20

C22, C23 C22, C23

C22 C23 C22 J24

c - File PDR Report with Melroe Parts Sales D - Part Number Error

M24 Model 600

Loader Parts


*


P rt N a o. D . r W C d eSCrlpl10n as o e P age 990386 FRAME 991101 COIL 991174 WICK 991219 NUT 991992 COVER 992213 WASHER 992997 REPAIR KIT 994378 BOLT 994381 REGULATOR 999041 REPAIR KIT 999306 BEARING 999459 GROMMET 999460 FRAME 999472 PIN 1300294 ELBOW 1304767 PIN 1310052 SNAP RING 1310963 ELBOW 1318237 SEAL 1318320 BUSHING 1318338 SNAP RING 1318339 O-RING 1318377 BUSHING 1318381 GREASEZERK 1318435 SNAP RING 1318464 SCREW 1318538 BEARING 1318539 BEARING 1318542 SNAP RING 1318565 PIN 1319170 SNAP RING 1010102 GROMMET 1526880 PULLEY 1536934 HOSE 1550695 HANOLE 1550697 BLAOE 1550963 SWITCH

1566619 WASHER 1566620 SEAL 1567065 CAN 1567066 GASKET 1577484 PLATE 1619303 NUT 1685085 GASKET 1715312 STA-STRAP 1735188 INOICATOR 1744552 ARM 1810250 BRUSHES 1810770 REGULATOR 2321153 SPRING Code for disposition of old pari number A-Use up B - Use on other application (See PNI)

N1

E18 E6 E4 E4 C2 C2 C2

E20 E19 G8

E19 E4 E3 E3

B22 A17

08,010 J18

C3,C4 04

C9,C10 C9, C10 B9,B10 B9,B10

04 B3

A24,J20 A24,J20

06 K15

08,010 K17 J14 J18 K4

M17 012,014,016,018,020,022,

F6,H2 B19 B19 B19 B19

B24, C1, C5, C6 K14 116

012,014,016, 024, E2 J7

M17 E6

016,020,E2

C - File PDR Report with Melroe Parts Sales D - Pari Number Error

A12

ModelSOO

Loader Parts


*


Part No. D escrlptlon 3291290 WING NUT 3409619 DOWEL PIN 3480270 FAN 3485614 BRUSH SET 3485615 STATOR 3485616 ROTOR ASSY. 3485617 RING 3485618 KIT 3485619 BRACKET 3485620 KIT 3485621 BOLT 3485622 BRACKET 3485623 KIT 3486029 IDLER GEAR 3490597 SEAL 3551966 BOLT 3675725 DIODE 3679995 DRIVE 3725269 NUT 3726889 COIL 3726890 COIL 3726891 STRIP 3726895 BRUSHES 3726896 SPRING 3726897 PLUG 3726898 SCREW 3726900 RETAINER 3726902 KIT 3726903 KIT 3726913 COILS 3726914 COILS 3726916 BUSHING 3726918 SCREW 3726920 BEARING 3726921 BUSHING 3726922 WASHER 3726923 PLATE 3726924 SPRING 3726925 SEAL 3726927 BUSHING 3726929 FRAME 3726930 BUSHING 3726931 BRUSH SET 3726933 COVER 3726935 RELAY ASSY. 3726936 BRACKET 3727305 BUSHING 3727307 BUSHING 3727308 BRUSH SET 3727309 SPRING 3727310 RELAY Code for disposition of old part number A-Use up B - Use on other application (See PNI)

W Cd as o e P age

N2

J7 B24 E22 E22 E22 E22 E22 E22 E22 E22 E22 E22 E22

C1, C5, C6 B24,C1,C5,C6

E9 J14 E4

H12 E24 E24 E24 E24 E24 E24 E24 E24 E24 E24

E8 E8

E16 E7 E8 E8

E8,E10 E8,E10 E8,E10 E8,E10

E8 E7

E7,E9 E8 E8 E7

E7,E9,E16 E10

E10,E16


E10 E10 E9

Model 600

Loader Parts



P N art o. D . r wed eSCrlp1 Ion as o e P age 3734083 BOLT 3737375 SCREW 3739046 BUSHING 3739048 GASKET 3883434 SCREW 3883436 WASHER 3883440 NUT 3883441 WASHER 3883454 SPRING 3883455 BUSHING 3883456 KIT 3883457 BRUSHES 3883459 WASHER 3883461 COIL 3883464 NUT 3883465 GROMMET 3883466 LEAD 3883467 LEVER .3883468 BRAKE SHOE 3883488 SPRING 3883491 SCREW 3883498 FRAME 3883503 ARMATURE 3883505 BUSHING 3883506 BUSHING 3883508 FRAME 3884360 WASHER 4102150 INDICATOR 4109119 REGULATOR 4109428 WASHER 4110763 GASKET 4118967 NOZZLE 4119775 ELEMENT 4121609 ELEMENT 4123591 BALL BEARING 4148021 ARMATURE ASSY. 4148027 FRAME 4148030 FRAME 4148037 GASKET 4148055 ARMATURE 4148057 ARMATURE 4148061 COILS 4148062 COILS 4148070 SPRING 4148076 FRAME 4148080 DRIVE 4148083 DRIVE 4148097 CAP 4149972 GEAR 4151803 WASHER 6061008 SCREW Code for disposition of old part number A-Useup B - Use on other application (See PNI)

N3

E16 E6

E8,E10 E8

E11 E11 E12 E11

E12,E13 E11

E12,E13 E12,E13

E12 -~-- E12,E13

E12,E13 E11 E11 E11 E12 E11 E12 E11 E12 E12 E12 E12 E12

018,020,022 018

18 G22, H12

18 13 18

E24 E24 E24 E24 E10

E8 E10 E10 E10 E8 E9 E8

E10 E24 H5

E7,E9,E10 E3





P N art o. D escrlptlon 6115800 ARMATURE 6501033 TU8E 6501036 TU8E 6501037 TU8E 6501040 TU8E 6501041 TU8E 6501042 TU8E 6501049 HOSE 6501050 HOSE 6501051 HOSE 6501052 HOSE 6501054 HOSE 6501055 HOSE 6501063 WIRE 6501066 TU8E 6501067 TU8E 6501068 TU8E 6501069 TU8E 6501073 VALVE 6501076 TU8E 6501078 TU8E 6501079 TU8E 6501080 TU8E 6501081 TU8E 6501082 TU8E 6501086 CONTROL 6501103 CYLINDER 6501116 TU8E 6501131 TU8E 6501132 TU8E 6501133 TU8E 6501134 TU8E 6501135 TU8E 6501136 TU8E 6501158 TU8E 6501160 TU8E 6501182 TU8E 6501183 TU8E 6501185 TU8E 6501187 8USHING 6501199 HOSE 6501205 HARNESS 6501209 WIRE 6501293 TU8E 6501294 TU8E 6501297 HOSE 6501380 HARNESS 6501384 PEDAL 6501385 ARM 6501426 SHEAVE 6501430 GUARD Code for disposition of old part number A-Use up . B - Use on other application (See PNI)

W Cd as o e Page

N4

E4 814,816,818

C12 C12 C14 C14 C14 C14 C12 C14 C14 821

C12,16 012

814,815,817 814,816,818 814,815,817 814,815,817

814, 816, 818,C8, M9 J18

814,816,818 C14 C12 C14 C12 112

C12, C16 814,816,818

C12 C12 C14 C14 C15 C15

814,815,817 814 820 820 820 A16

820,822 012,014

012,014,016 J15,J18

J15 J16 018

K1 K1

89,810


K20



*


P N art o. D . r W C d escrlp: Ion as o e P age 6501432 COVER 6501434 SHEAVE ASSY. 6501439 CAM 6501440 HOSE 6501441 HOSE 6501442 TUBE 6501443 TUBE 6501444 MOUNT 6501445 MOUNT 6501451 ROD 6501455 LEVER 6501482 ROD 6501484 BRACKET 6501488 TUBE 6501501 SHIELD 6501507 SCRUBBER 6501508 HEAT SHIELD 6501607 WIRE 6501608 PLATE 6501883 SHROUD 6501885 PIPE 6501886 SCREW 6501894 LINE 6501944 WIRE 6501945 LOCK 6502028 EXHAUST TUBE 6502029 FLANGE ASSY. 6502035 SHEAVE 6502037 BRACKET 6502062 PIN 6502203 CLAMP 6502209 GASKET 6502236 CLIP 6502236 CLIP

6502278 PLATE 6502279 SHAFT 6502281 BOOT 6502282 SPROCKET 6502288 SPACER 6502289 SPACER 6502290 WASHER 6502291 BUSHING 6502293 BRACKET 6502297 CHANNEL 6502311 THREAD 6502312 THREAD 6502315 SPROCKET 6502325 PIN 6502326 PIN 6502337 GASKET Code for disposition of old part number A-Use up B - Use on other application (See PNI)

N5

K20 B8,B10

J20 C19,02

C19, 06, 08 B22 B22

H4 H4

B12 H7 H7 H7

B22 H10 K22 K22 014

H2 H10

H2 H12 G5

G11 G11 K22 K22 08

G16 K13

C12,C14,J15,J16,M12 A23,A24,J20

J14 012,014,016,018,020,022,024,

E2, M17 A22 A22

02 B3

A23,A24,J20 A23 A23

B2 B4

A12 A14 B2,B3 B2,B3 B6 B8

M12 M12

A12. K9

C - File PDR Report with Melroe Parts Sales 0-Part Number Error




P N art o. D . r W C d escnpllon as o e P age 6502340 SCREW 6502341 GASKET 6502344 CLIP 6502352 COLLAR 6502353 SPACER 6502354 BRACKET 6502374 ROO 6502375 RING 6502398 SHAFT 6502400 HOOK 6502415 PIN 6502416 AOAPTER 6502426 CLAMP 6502428 BRACKET 6502459 SAFETY TREAO 6502521 WASHER 6502532 PLATE 6502533 HUB 6502534 HUB 6502535 BAR 6502536 BAR 6502537 BAR 6502538 PLATE 6502539 CAP 6502562 WASHER 6502564 SPACER 6502583 GUARO 6502596 BELLCRANK 6502597 SPROCKET 6502598 SPROCKET 6502599 SPROCKET 6502600 SPROCKET

-6502616 CAP 6502618 ARM 6502619 ARM 6502627 COVER 6502628 COVER 6502630 NUT 6502635 LEVER 6502638 BUSHING 6502639 NUT 6502640 NUT 6502649 WASHER 6502688 CLIP 6502693 PANEL 6502694 GASKET 6502731 FLYWHEEL 6502733 PLATE 6502734 DECAL 6502759 COVER 6502762 BUSHING Code for disposition of old part number A-Useup B - Use on other application (See PNI)

N6

B2 B6,B8

012,014,016 B4

C19 B4

Bll, M6 02 02

A14 B2,B3

B14, B16, B21 J18

--~ M12 A14, K6, M6

B6,B8 B3

A23,A24,J20 A23

B2 B2 B2 B3

A12,B3 04

J18 A14

F6 B3 B5

A22 A22

02 B5 B5

A19 A19

B2 B2

B12,J18 A23 A23 A23 All A14

A12, A14 H22 018

K6 A19 A17





P N art o. D . r wed escnp110n as o e P age 6502772 ROD 6502773 CLAMP 6502774 DECAL 6502775 BRACKET 6502779 PIN 6502781 PIN 6502782 PIN 6502783 PIN 6502784 PIN 6502787 BUSHING 6502798 BUSHING 6502802 BUSHING 6502810 SPLICER 6502822 BUSHING 6502865 LEVER 6502866 WASHER 6502904 NUT

6502908 PLATE 6502910 SHAFT 6502911 ROD 6502912 PEDAL 6502913 PEDAL 6502914 PEDAL 6502917 HOSE 6502923 PANEL 6502957 HOSE 6502974 BRACKET 6502976 STOP 6502981 BELLCRANK 6502983 PANEL 6502986 RO~

6502987 SUPPORT 6502988 BUSHING 6503022 DECAL 6503028 HANDLE 6503047 GUARD 6503063 BRACKET 6503067 ROD 6503070 BLOCK 6503071 BLOCK 6503075 PANEL 6503078 HOSE 6503098 NIPPLE 6503117 STA-5TRAP 6503118 BELLY PAN 6503119 BELLY PAN 6503120 GRILL 6503130 PLATE 6503167 COUNTERWEIGHT 6503180 CAP Code for disposition of old part number A-Useup B - Use on other application (See PNI)

N7

J18 J16 K6

B14,B16,B18 A16, A17

A16 A16

A16, A17 A16 A16 A17 A17

B6,B8 A16, A17 B12,J18

08 012,014,015,018,020,022,024,

E2 B14,B16,B18

B11, J24, K1, M6 B11, M6

B11, K1, M6 B11, M6 B11, M6

B14 A12

F5,J10 F6

F7,112 B11, M6

A12 B11, M6

M6 B11, M6

K8 A17 A14

F6 F6

C15 C12,C14

A12 B20

F6 M12 K20 K20 A11 M7

K20, M12


A23




P N art o. D escnptlon 6503214 HOSE 6503220 GASKET 6503235 HUB 6503238 HUB 6503241 NUT 6503242 WASHER 6503243" ROD 6503348 JACKSHAFT 6503352 JACKSHAFT 6503357 NUT 6503368 HOSE 6503369 HOSE 6503370 WASHER 6503377 SWIVEL 6503378 PLATE 6503388 BLOCK 6503402 PEDAL 6503403 PEDAL 6503404 HOSE 6503408 HOSE 6503410 PANEL 6503411 PANEL 6503413 HOSE 6503414 HOSE 6503430 PANEL 6503439 CAP 6503440 SPACER 6503450 BRACKET 6503451 SPACER 6503457 HOOK 6503467 HOSE 6503470 DECAL 6503491 HOSE 6503498 BUSHING 6503571 COUNTERWEIGHT 6503572 DECAL 6503625 SPRING 6503638 PISTON 6503639 SPACER 6503640 CAP 6503641 GLAND 6503689 PIN 6503691 WASHER 6504024 BLOCK 6504054 BRACKET 6504288 SPACER 6504372 DECAL 6504373 DECAL 6504374 DECAL 6504427 GLAND 6504428 .CAP Code for disposition of old part number A-Use up B - Use on other application (See PNI)

W Cd as o e P age

N8

J10 H5

A24, J20 J20

A24,J20 A24, J20

K1 B8 B8 B8 H2 H4 B8 H2 H5

F8,H7 K1 K1 H4 H2 K1 K1

B14 B22 A12 02

A14 B14,B16,B18

K22 K22

H2 K22

F5 K22 K22

K8,K22 K1 06 06 06 06

A17 A17

F6,114 018 020,022


06 K6 K6 K8 08 08

Model 600

Loader Parts



P N art o. D escrlptlOn 6504446 FILTER 6504461 SPROCKET 6504466 HOSE 6504484 BRACKET 6504510 BELT 6504512 SPROCKET 6504592 PLATE 6504621 COVER 6504622 COVER 6504677 BRACKET 6504681 CAP 6504697 BRACKET 6504698 HOOK 6504707 SHAFT 6504729 BRACKET 6504731 DRAWBAR 6504736 SCREW 6504740 UPRIGHT 6504783 PLATE 6504794 SPROCKET 6504802 HINGE 6504806 CHANNEL 6504807 HINGE 6504827 CUP 6504828 TUBE 6504836 PLATE 6504839 BRACE 6504881 ADAPTER 6504902 MUFFLER 6504904 SHEAVE 6504914 SHEAVE HALF 6504924 STUD 6504925 PLATE 6504926 SPRING 6504933 HEAD 6504934 BOLT 6504937 REPAIR KIT 6504938 CYLINDER 6504940 VALVE 6504941 VALVE 6504942 VALVE 6504945 SEAL KIT 6504946 REPAIR KIT 6504950 ROD 6504951 ROD 6504954 CLAMP 6504955 CLAMP 6505027 ADAPTER 6505029 U-BOLT 6505039 BOLT 6505041 .WASHER Code for disposition of old part number A-Use up 8 - Use on other application (See PNI)

W Cd as o e P age

N9

H2O B8 18

024 B6,B8

B4 A22 A12 A12 J18 04 02

K16 B2

K15 K13

H2 A16 B14

A23,A24,J20 A12 A12 A12

02 B20 B14 A16 B22 113 08

B10 B9,B10 B9,B10 B9,B10

M15 A22

09 A14,D2

B14,B16,B18,C7 B14,B16,B18,C9,C12,C15

B14,B16,B18,C10,C14,J18

C - File PDR Report with Melroe Parts Sales 0- Part Number Error

06 010 C16 M15 G11 G11

H2 K15

B4 B2 B3

Model 600

Loader Parts


*

*

*

*

* *


Part No. D escrlptlon 6505049 WASHER 6505050 WASHER 6505053 PIN 6505056 PIN 6505059 SCREW 6505065 CAP 6505076 SPRING 6505085 SPRING 6505103 PIN 6505111 SCREW 6505241 BRACKET 6505241 BRACKET 6505248 BRACKET 6505251 BELLCRANK 6505255 PLATE 6505260 HOSE 6505261 HOSE 6505262 BLOCK 6505263 BAR 6505265 BRACKET 6505265 BRACKET 6505286 HARNESS 6505288 ROD 6505289 ROD 6505291 PLATE 6505292 TUBE 6505293 TUBE 6505294 TEE 6505295 TUBE 6505296 HOSE 6505324 COVER 6505358 SHIM 6505359 SPROCKET 6505361 WASHER 6505362 WASHER 6505370 PANEL 6505371 BELT 6505371 BELT 6505377 SHEAVE 6505378 SHEAVE 6505403 HOSE 6505409 TUBE 6505412 KEY

6505433 FUEL FILTER 6505434 ADAPTER 6505456 HARNESS 6505456 HARNESS 6505457 WIRE 6505458 WIRE 6505537 TUBE Code for disposition of old part number A-Useup B - Use on other application (See PNI)

as o e W Cd P age

N10

A22 A22 K13

B12,J18 A12, A14

K22 B2

A17 B11, J18, M6

04 J14

016,E2 114 114

B23 B23

B16,B18 C12 114 J14

016,E2 E2 114 112

B16 C15 C15 B23 B16

B16,B18,B23 A19 A16

B6 B8 B8

K12 J14

B8,016 B9 B9 113

H18 012,014,015,018,020,022,024,


E2 H418

16 J14 016 J14 J14 H14

Mode\SOO Loader Parts


*


P N art o. D . f wed eSCrlp1 Ion as o e P age 6505540 COLLAR 6505541 SPACER 6505542 O-RING 6505565 KIT 6505571 END 6505588 SHIELD 6505623 WASHER 6505660 CLAMP 6505676 PLATE 6505680 HOSE 6505688 HOSE 6505689 TUBE 6505690 TUBE 6505737 HINGE 6505739 PLATE 6505747 ADAPTER 6505749 HARNESS 6505750 BRACKET 6505765 PULLEY 6505766 NUT 6505780 KIT 6505813 ADAPTER 6505825 COLLAR 6505851 RETAINER 6505852 SHAFT 6505854 SPRING 6505860 DEFLECTOR 6505861 SPACER 6505863 HOSE 6505864 PLATE 6505865 ADAPTER 6505888 HARNESS 6505893 BRACKET 6505998 CAP 6505999 SEAL 6506065 HARNESS 6506069 PULLEY 6506074 BUSHING 6506076 PLATE 6506077 RESISTER 6506078 HARNESS 6506080 STRAP 6506135 PULLEY 6506171 HARNESS 6506172 BRACKET 6506189 HANDLE 6506455 COVER 6506492 KIT 6506492 KIT 6506504 GUARD 6506516 SHIELD Code for disposition of old part number A-Use up B - Use on other application (See PNI)

N11

H14 H14

G22, H14 C7 112

A12 F8, G20

C14 C19, C20

04,06 B21 B21 B21 A11 A12

H23,H24 022

13 H23 H23 08

F6, H2, J6 04

02,06 09 09 115 114 J6

114 114

018 A12 09 09

020 H24

H23,H24 020 022


020 020 H24 E22 024 024

F8 K9

J14 F4

K20 A12

ModelSOO

Loader Parts


*


P N art o. D escrlptlon 6506642 MAST 6506646 BRACE 6506647 BRACE 6506648 GUARD 6506649 SUPPORT 6506650 HOSE 6506651 HOSE 6506652 CYLINDER 6506654 HOSE 6506655 PIN 6506656 ROD 6506657 HOSE 6506677 STOP 6506678 BUSHING 6,506693 MAST 6506695 HOSE 6506810 SHIELD 6507125 HOSE 6508041 YOKE 6508066 KIT 6508073 BRACKET 6508128 BUSHING 6508134 SPACER 6508137 BUSHING 6508139 BOWL 6508291 LEVER 6508292 BRACKET 6508299 BUTTON 6508305 PLUG 6508569 TUBE 6508570 FLANGE 6508741 SEAL KIT 6508743 BUSHING 6509153 RIM 6509579 . HOSE 6509653 ROD 6509711 WEDGE 6509712 BOLT 6509739 DECAL 6509762 FORK 6509766 COUPLER 6509791 FLANGE 6509822 WIRE 6510084 CABLE 6510091 SHROUD 6510277 CRANKSHAFT 6510299 GRIP 6510793 WHEEL 6510868 STUD 6510871 FLYWHEEL 6510924 PUMP Code for disposition of old part number A-Use up B - Use on other application (See PNI)

W Cd as o e P age

6516438

N12

M14 M12 M12 M12 M12 M12 M12

M12, M15 M9, M12

M12 M12

M9 M15

M12, M14 M14

M9, M12 A12 B14

B11, J24, K1, M6 13

H23,H24 H24 H23 H24 G3

H13 H14 H14 H14 K22 K22 M16

A16, A17 M8 J6

J24 A17 A17

K8 114

G16 113 116

J14 F7

F10 F14

F7 K20 M8

A F12 F14 C5


ModelSOO

Loader Parts



P rt N a o. D . r W C d escnp110n as o e P age 6510925 GEAR 6511033 CONNECTOR 6511050 FITTING 6511128 GASKET 6511296 NUT 6511300 PLATE 6511309 SEAL 6511352 CAMSHAFT 6511355 SHIM 6511364 BLOWER 6511366 BLADING 6511367 SHIELD 6511393 FUEL FILTER 6511607 SEAL 6511610 ROD 6511629 ARMATURE 6511660 PLATE 6511721 SCREW 6511833 COVER 6511834 GASKET 6511859 ADAPTER 6511880 PIN 6511935 CAP 6511954 FRAME 6511957 BOLT 6511961 ROD 6512052 STRAP 6512232 HOUSING 6512392 SLEEVE 6512393 HOUSING 6512532 SEAL 6512552 HEAD 6512553 BOX 6512559 INJECTOR 6512584 GLOW PLUG 6512807 GAUGE

6512841 CAP 6512873 HORN 6512910 CAP 6513350 ARMATURE 6513351 BEARING 6513352 BUSHING 6513353 DRIVE 6513354 FRAME 6513355 LEVER 6513356 WASHER 6513357 BOLT 6513358 RELAY 6513359 . SCREW 6513360 COILS Code for disposition of old part number A-Useup B - Use on other application (See PNI)

991100

6516620

N13

C5 H4,18

B18 G22, H16

J10 F16 F16 H16

18 H10 H10 H10

A1, F6, G3, H2, J6 -- G22, H14

H22 A E6

F6 H22 H2O

G22, H2O B14, B16, B18, M9

A18 H13 E19 E19 Jl0 K17 120

A F20 F20 B19 H15 H16

18 D18,D20,D22,H16

D12 D14,D15 D18 D20,D22,D24 E2

A14 K14 A14 E16 E16 E16 E16 E16 E16 E16 E16 E16 E16 E16




*


Part No. D escnptlon 6513361 FRAME 6513362 SPRING 6513363 COVER 6513364 BUSHING 6513365 SCREW 6513366 WASHER 6513367 COVER 6513368 BRUSHES 6513369 WASHER SET 6513369 WASHER SET 6513391 STARTER 6513641 FILTER 6513658 BRACKET 6513734 HOLDER 6513748 WASHER 6513756 WASHER 6513757 WASHER 6513808 SHIM 6513809 PIPE 6513811 SCREW 6513824 GUIDE 6513839 BEARING 6513842 BEARING 6513845 GASKET 6513845 GASKET 6513846 GASKET 6513846 GASKET 6513870 BEARING 6513871 BEARING 6513894 LEVER 6513963 GRIP 6514501 SPACER 6514504 CABLE 6514516 BOLT 6514578 BOLT 6514898 CAP

6515000 SEAL 6515012 COLLAR 6515014 COLLAR 6515015 DISC .. 6515016 SPRING 6515017 ELEMENT 6515019 GASKET 6515022 GASKET 6515024 HOUSING 6515025 PRE-CLEANER 6515030 CAP 6515033 CAP 6515034 SPRING 6515036 CHANNEL· Code for disposition of old part number A-Use up B - Use on other application (See PNI)

W C as ode Page

6517910

6516029

6515964

1GM-660

6516020

6516001

N14

E16 E16 E16 E16 E16 E16 E16 E16 E16

A E8,E10 E16 G14 K14

A H18 H18

A H18 H18

18 12

A H14,12 H16 H22 H22 G22

A H18 G22

A H18 H22 H22 H14

A17, B2 C16

D24,E2 A16 A12

012, 014, 016, 018, 020 022, 024, E2

A23, A24, J20, J21 C22

C9,C10 C9, C10

C9 J10

C9, C10 J10 J9

J10 C9 C10

C10 C10

J9


Model 600

Loader Parts


*


P rt N a o. D . r W C d eSCrlp110n as o e P age 6515039 COLLAR 6515045 TUBE 6515050 SPACER 6515055 SPRING 6515061 SPRING 6515064 SPRING 6515068 BEARING 6515069 RACE 6515078 POPPET 6515082 SPRING 6515084 CONNECTOR 6515105 HOUSING 6515106 COLLAR 6515109 GRIP 6515115 DOWEL PIN 6515116 BUSHING 6515132 CLAMP 6515134 TEE 6515158 HOSE 6515159 ADAPTER 6515160 HOSE 6515161 HOSE 6515167 PLUG 6515168 CAP 6515169 CABLE 6515173 CAP 6515186 LINK 6515187 LINK 6515191 LINK 6515194 BALL JOINT 6515195 QUAD RING 6515196 STRAP 6515202 BUSHING 6515221 ADAPTER 6515222 ADAPTER 6515224 HOSE 6515227 NUT 6515228 WASHER 6515232 PLUG 6515233 PLUG 6515234 ~ING

6515239 WASHER 6515251 SEAL 6515252 BEARING 6515253 BEARING 6515254 SNAP RING 6515255 ~ING

6515259 ~ING

6515271 BELT 6515275 NUTSERT 6515287 HUB Code for disposition of old part number A-Useup B - Use on other application (See PNI)

6515529

N15

C9 M8

C8,16 B19 C7 C9 B3

B4,B5 C9, Cl0 C9,Cl0

C9 B6,B8 B6,B8

B12,J18 C3 C3

B14, B16, B18, Jl0 B14,B16,B18

B16 H2,J6

D2 D4,D6

J15,J16,J18 J15,J16,J18

F7 A14, M9 Bll, M6

A21 A21

F6,H2 H7 A12,B3

D18,D20,D22 A12, F6, H2, 114

F20, G13 F22, G13, G14

F6, G13 G14 C8,16

C9,Cl0 Cl0

C9,Cl0 C7

C9 Cl0 D9 D9 D9 D9 D9

D H16 B6,B8

A14,K20 G16





P N art o. D escrlptlon 6515297 HUB 6515313 SEAL 6515315 SWITCH 6515316 WASHER 6515317 CHANNEL 6515318 CHANNEL 6515319 CHANNEL 6515320 CHANNEL 6515321 CYLINOER 6515322 CYLINOER 6515326 HEAO 6515328 ROO 6515329 ROO 6515334 PISTON 6515335 WASHER 6515336 NUT 6515338 CARRIAGE 6515339 ANCHOR 6515340 PIN 6515342 CHAIN 6515343 CHAIN 6515344 NUT 6515345 PIN 6515346 BEARING 6515347 ROLLER 6515348 WASHER 6515349 RETAINER 6515350 RACE 6515351 PAO 6515352 RING 6515353 ROLLER 6515354 BUSHING 6515355 ENO 6515356 PIN 6515369 CHAIN 6515377 CHAIN 6515383 LINK 6515427 LIGHT

6515431 COUPLER 6515432 COUPLING 6515442 O-RING 6515462 CHAIN 6515466 WASHER 6515467 WASHER 6515468 WASHER 6515470 MUFFLER 6515472 SWITCH 6515482 ORAINCOCK 6515494 CABLE 6515499 PIN Code for disposition of old part number A-Useup B - Use on other application (See PNI)

W Cd as o e P age

N16

B23, G16 C9, C10

014 B2

M14 M14 M14 M14

M14, M16 M14, M16

M16 M16 M16

-._--

M16 M16 M16 M14 M14 M14 M14 M14 M14 M14 M14 M14 M14 M14 M14 M14 M14 M14 M14 M14 M14 A21 A21 A21

012,014,015,018,020,022,024, E2

G16 06,010

C22 A21

B6,B8 B5

B4,09,010 F5,H2,J10

024 E2 114 K22

018,020,022


K15

Model 600

Loader Parts



P rt N a o. D . r W C d escnp110n as o e P age 6515502 SCREW 6515513 LIGHT 6515521 SWITCH 6515529 ~RING

6515534 DIPSTICK 6515535 TANK 6515537 RESTRICTOR 6515541 ELEMENT 6515556 ASPIRATOR 6515557 AIR CLEANER 6515558 GAUGE 6515571 SNAP RING 6515575 CLAMP 6515576 CLAMP 6515580 PISTON ASSY. 6515600 HANDLE 6515601 CAP 6515603 GROMMET

.6515605 ELEMENT 6515615 ELBOW 6515616 ~ING

6515619 ~ING

6515627 ADAPTER 6515635 YOKE 6515642 PIN 6515745 KIT 6515752 SWITCH 6515779 CAP 6515792 WHEEL 6515793 SCREW 6515795 STARTER 6515795REM STARTER 6515797 BOLT 6515799 FIELDS COIL 6515817 WASHER 6515886 SEAL 6515888 KNOB 6515897 NUT 6515899 TIRE 6515900 SEAL 6515901 SNAP RING 6515909 DOWEL PIN 6515913 ~ING

6515915 MUFFLER 6515917 AIR CLEANER 6515923 SCREW 6515925 STUD 6515926 STUD 6515927 STUD 6515928 STUD 6515929 STUD Code for disposition of old part number A-Use up B - Use on other application (See PNI)

6562781

N17

B12 K17

K11, K17, M17 G22 H18 G11 C12

16 J10 J9

K14 D8

F6,F22,H2,J6 H2, 113, K22

D8 K4

J10 D12,D14,D16,D24,E2

G11 B20

G22, H18, 114 D6

A14 B11, J18, M6

K22 J20

D18,D20,D22,H2 H14

A M8 A23

D16,F6 E3 E4 E4

B4,B5 D8

F7, F8, H7, 112 F22 M8 D2 D2

H18 H4,H5

F5 H2 H12

H14 H10 H10 H14 H12 H12


ModelSOO

Loader Parts



P rt N a o. D . f W C d eSCrlp110n as o e P age 6515937 WASHER 6515942 WASHER 6515946 WASHER 6515952 FLANGE 6515953 GASKET 6515954 GASKET 6515955 BEARING 6515956 BEARING 6515957 BEARING 6515958 BEARING 6515959 VALVE 6515960 SPRING 6515961 CAP 6515963 WASHER 6515966 WASHER 6515967 SOFTPLUG 6515969 WASHER 6515970 DOWEL PIN 6515971 DOWEL PIN 6515972 BEARING 6515973 BEARING 6515974 BEARING 6515975 BEARING 6515977 BEARING 6515981 SPRING 6515982 SHAFT 6515983 SPRING 6515986 ~ING

6515988 SHIM 6515991 PLUG 6515992 GOVERNOR 6515999 HOLDER 6516000 SEAL 6516002 WASHER 6516003 SHIM 6516004 PULLEY 6516005 DRIVE 6516006 WASHER 6516008 PLATE 6516012 ~ING

6516013 BAND 6516015 BEARING 6516016 BLOCK 6516018 SCREW 6516019 FLYWEIGHTS 6516021 STRAP 6516022 SCREW 6516027 WASHER 6516028 COVER 6516033 TUBE 6516036 LINER Code for disposition of old part number A-Use up B - Use on other application (See PNI)

N18

G22, H2O H18

H6,H14 H12

G22, H12 G22, H14

H18 H18 H18 H18 H2O H2O H2O H18 H18 H18

H20,H22 H2O H2O H2O H2O H2O H2O H14 H14 H13 H14

G22, H14 H14 H2O H18 H18

G22, H18 H14 H14 H14 H18 H18 H2O

G22, H18


H2O H18 H18 H14 H18 H2O H2O H14 H14 M8

H15




P N art o. D escrlptlon 6516037 O-RING 6516038 SHIM 6516041 SEAT 6516042 SEAT 6516044 SCREW 6516045 WASHER 6516046 VALVE 6516047 VALVE 6516048 WASHER 6516049 SPRING 6516050 CAP 6516051 KEEPERS 6516052 CIRCLIP 6516053 COVER 6516055 STUD 6516056 BUSHING 6516057 NUT 6516058 LIFTER 6516059 O-RING 6516060 PLATE 6516061 PUSH ROD 6516062 ARM 6516064 TAPPET 6516065 TUBE 6516067 WASHER 6516069 WIRE 6516071 CONNECTOR 6516073 NUT 6516074 SLEEVE 6516076 O-RING 6516077 CUP 6516078 SPRING 6516079 PUMP 6516080 COOLER 6516081 SPACER 6516082 SPACER 6516083 SCREW 6516084 SCREW 6516085 CLAMP 6516086 SPACER 6516087 CRANKSHAFT 6516088 COUNTERWEIGHT 6516089 GEAR 6516091 DOWEL PIN 6516096 BUSHING 6516097 PISTON 6516100 PIN 6516101 RINGS 6516102 RINGS 6516103 RINGS 6516104 WASHER Code for disposition of old part number A-Use up B - Use on other application (See PNI)

W Cd as o e P age

N19

G22,H15 H15 H15 H15 H16 H16 H15 H15

G22, H16 H16 H16 H16 H16 H16 H16 H16 H16 H16

G22, H16 H16 H16 H16 H16 H16 H16

D18,D22,H16


H15 12 12

12,13 12 12 12 12 12 12 12 12 12 12

H22 H22 H22 H22 H22 H22 H22 H22 H22 H22 H22




P N art o. D escriptlon 6516106 RING GEAR 6516107 PUMP 6516109 HEAD 6516112 LINE 6516114 PUMP 6516115 HOUSING 6516116 KIT 6516117 KIT 6516118 O-RING 6516121 LINE 6516122 LINE 6516127 BEARING 6516128 BEARING 6516129 SHIELD 6516130 PLATE 6516132 PULLEY 6516138 POT 6516139 GASKET 6516140 SCREEN 6516142 GASKET 6516143 BRACKET 6516146 PRECLEANER 6516151 MANIFOLD 6516156 PULLEY 6516157 WASHER 6516158 SPACER 6516159 SHIM 6516160 STRAP 6516161 SPACER 6516162 SHIM 6516163 SHIM 6516164 V-BELT 6516172 PIN 6516174 SLEEVE 6516175 SPRING 6516176 SCREW 6516177 ARM 6516178 PIN 6516179 SCREW 6516180 NUT 6516182 SPRING 6516183 NUT 6516184 ARM 6516185 O-RING 6516186 SPRING 6516188 GENERATOR 6516195 KIT 6516196 PLATE 6516201 PISTON 6516216 ROD 6516222 STARTER Code for disposition of old part number A-Use up B - Use on other application (See PNI)

W Cd as o e P age

N20

H22 18 18 18 18 18 18 18 18 18 18

H10 H10 H10 H10 H10 H12 H12 H12

G22, H12 H12 H12 H12

11 H23, H24, 11

11 11

H23,11 H23, H24,I1


11 11

H4 H6 H6 H6 H6 H6 H6 H6 H6 H6 H6 H6 H6 H6

E24,11 J20 J20 02

04,06 E5.114




P N art o. D ·r escnp110n 6516232 BRACKET 6516234 SCREW 6516236 PUSH ROD 6516237 GUIDE 6516238 SPRING 6516239 SPRING 6516241 BALL 6516242 REPAIR KIT 6516243 FLOAT DETENT 6516245 VALVE 6516248 DRIVE GEAR 6516251 GEAR 6516254 GEAR 6516255 DRIVE GEAR 6516256 COVER 6516259 BODY 6516261 WEAR PLATE 6516264 DOWEL PIN 6516265 WASHER 6516266 WASHER 6516268 DRIVE SHAFT 6516271 IDLER SHAFT 6516273 BLOCK 6516281 PUMP 6516284 ALTERNATOR 6516286 SNAP RING 6516288 HEAD 6516289 ADAPTER 6516298 SHEAVE 6516299 ROTOR 6516301 SEAL 6516302 SPRING 6516303 SHAFT 6516304 SWIVEL 6516308 BELT 6516312 BALL BEARING 6516344 BRACKET 6516345 SWITCH 6516346 STUD 6516348 STUD 6516349 BRACKET 6516350 KIT 6516351 SHROUD 6516352 SHROUD 6516353 SHROUD 6516354 SHROUD 6516355 SHROUD 6516356 SHROUD 6516357 SHROUD 6516358 SHROUD 6516359 RING Code for disposition of old part number A-Use up B - Use on other application (See PNI)

w as

N21

C d o e P age C22 C22 C22 C22 C22 C22 C22

C9 C9 C9 C6

B24 B24

C1 C4 C4 C4 C4 C4 C4 C4 C4 C3 C4

D22,D24,E22,H23 C5 13 13

B23 D10

D8,D10 D8,D10

D8 D8

B23 D8,D10

F6 D12,D14,D16,F6

F6 F6 F6 F6

F10 F10 F10 F10 F10 F10 F10 F10 F10


Model 600

Loader Parts



P rt N a 00 D Of eSCripllOn 6516360 CLIP 6516361 BOLT 6516363 BRACE 6516364 BRACE 6516365 WASHER 6516366 DEFLECTOR 6516367 DEFLECTOR 6516370 SCREEN 6516371 SHROUD 6516372 TUBE 6516373 TUBE 6516374 FUEL PUMP 6516379 ADAPTOR 6516380 ADAPTOR 6516381 GASKET 6516382 GASKET 6516383 COVER 6516384 PLUNGER 6516385 PLUNGER 6516386 CAP 6516388 KIT 6516389 LINE 6516390 ADAPTOR 6516391 HOSE 6516392 ADAPTOR 6516393 ELBOW 6516394 HORN 6516395 HORN 6516396 GASKET 6516397 MANIFOLD 6516398 GASKET 6516399 GASKET 6516401 STUD 6516403 MANIFOLD 6516404 MANIFOLD 6516405 GASKET 6516406 STUD 6516407 STUD 6516408 GASKET 6516409 SCREW 6516410 DEFLECTOR 6516414 FUEL LINE 6516415 CONNECTOR 6516418 MANIFOLD 6516419 BOLT 6516421 VAPORIZER 6516422 LINE 6516424 NUT 6516425 GASKET 6516427 ELBOW 6516431 HEAD Code for disposition of old part number A-Useup B - Use on other application (See PNI)

w as

N22

C d o e P age F10 F10 F10 F10

F10, G12 F10 F10 F10 F10 F22 F22 F22 F22 F22

F4,F22 F4, F22, G4

G4 F22 F22 F22 F22 F22 F22 F22 F22 F22 F22

F22, G5 F4,F22

F22 F4,F22,F24,G2,G4,G5,G6,G8

F4,F22 F22 F22 F22

F4, F22, G4 F22 F22 F22 G5 G5 G5 G5 G5 G5

G4, G5, G9 G5 G5 G5 G5

F12





Part No. escriptlon as o e D W C d Page 6516432 HEAD 6516433 HEAD 6516434 GASKET 6516435 PLUG 6516436 BOLT 6516437 GASKET 6516439 CRANKCASE 6516440 PLUG 6516441 PLUG 6516442 PLATE 6516443 SUPPORT 6516444 GASKET 6516448 WASHER 6516449 NUT 6516450 SLINGER 6516451 GEAR 6516452 MAIN BEARING 6516453 CRANKSHAFT 6516454 RETAINER 6516455 SEAL 6516456 GASKET 6516457 SHIM 6516458 GASKET 6516460 SHIM 6516461 BOLT 6516462 BUSHING 6516463 RETAINER 6516464 RING SET 6516465 RING SET 6516466 RING SET 6516467 RING SET 6516468 RING SET 6516469 RING SET 6516470 RING SET 6516471 RING SET 6516472 PISTON 6516473 PISTON 6516474 PISTON 6516475 PISTON 6516476 PIN 6516485 ROD 6516486 BEARING 6516487 BEARING 6516488 BEARING 6516489 BEARING 6516490 BEARING 6516491 VALVE 6516492 VALVE 6516493 SEAT 6516494 SEAT 6516495 .GUIDE

Code for disposition of old part number A-Use up B - Use on other application (See PNI)

N23

F12 F12

F4,F12 F12 F12

F4,F12 F12 F12 F12 F12 F12

F4,F12 F14 F14 F16 F16 F16 F14 F16 F16

F4,F16 F4,F16 F4,F16


F16 F16 F14 F14 F14 F14 F14 F14 F14 F14 F14 F14 F16 F16 F16 F16 F14 F14 F14 F14 F14 F14 F14 F17 F17 F17 F17 F17




P N art o. D escn~tlon 6516496 BLOCK 6516497 BLOCK 6516498 GASKET 6516499 COVER 6516500 WASHER 6516501 SPRING 6516502 SPRING 6516503 RETAINER 6516504 ROTATOR 6516505 LOCK 6516506 SCREW 6516507 TAPPET 6516508 GASKET SET 6516509 DIPSTICK 6516510 TUBE 6516511 TUBE 6516512 LINE 6516513 ADAPTER 6516514 GASKET 6516515 SCREW 6516516 CAMSHAFT 6516517 CAMSHAFT 6516518 SPRING 6516519 PLUNGER 6516520 GEAR 6516521 WASHER 6516522 BUTTON 6516523 STUD 6516524 GEAR KIT 6516525 PLATE 6516526 SEAL 6516527 COVER 6516529 GASKET 6516530 SPACER 6516531 GASKET 6516532 DOWEL PIN 6516534 U-BOLT 6516535 BRACKET 6516536 SCREEN 6516538 TUBE 6516539 CAP 6516540 GROMMET 6516546 PLUG 6516549 CAP 6516550 CABLE 6516552 CAP 6516553 WIRE 6516555 DISTRIBUTOR 6516556 ARM 6516557 IGNITION 6516558 DRIVE Code for disposition of old part number A-Use up B - Use on other application (See PNI)

W Cd as o e P age

N24

F17 F17

F4,F17 F17

F12, F17, G16 F17 F17 F17 F17 F17 F17 F17 F17 G12 G12 G12 F12 G12

F4, G12, G14 F12 F16 F16 F16 F16 F16 F16 F16 F16 F16 F16 F12

F1,F2,F12 F4,F12

F12 F4,F12


F12 G12 G12 G12 G12 G12 G18 G18 G18 G18 G18 G18 G19 G18 G18 G18

Model 600

Loader Parts



P N art o. D escr~tlon 6516559 SEAL 6516560 O-RING 6516561 HOUSING 6516563 SHAFT 6516564 BEARING 6516568 BEARING 6516569 RING 6516570 SHAFT ASSY. 6516571 GEAR 6516572 SPACER 6516573 RETAINER 6516574 GASKET 6516576 DISC 6516580 SHAFT 6516585 VENTURI 6516586 SHAFT 6516587 JET 6516589 REPAIR KIT 6516590 CARBURETOR 6516601 EXCHANGER 6516605 SHAFT 6516606 SCREW 6516607 PLATE 6516610 SPRING 6516611 SHAFT 6516612 SEAL 6516613 PIN 6516614 ROD 6516617 GASKET 6516619 PIN 6516621 ROLL PIN 6516626 SHAFT 6516627 FLYWEIGHT 6516628 CONTROL 6516629 PIN 6516630 LEVER 6516631 NUT 6516632 PIN 6516633 RETAINER 6516634 SPRING 6516635 SCREW 6516636 OIL PUMP 6516637 SCREW 6516638 GEAR 6516640 NOZZLE 6516645 GASKET 6516647 WASHER 6516649 SPRING 6516650 SCREEN 6516654 ROTOR 6516662 CAM Code for disposition of old part number A-Useup B - Use on other application (See PNI)

W Cd as o e P age

01

G18 G18 G18 G18 G18 G18 G18 G18 G18 G18 G18

F4, G18 G16

G2 G2 G2 G2 G2

F22,F24 G9 G6 G6 G6

F20 F20 F20 F20 F20

F4,F12,F20 F20

Fl,F2 F20 F20 F20 F20 F20 F20 F20 F20 F20 F20 G15 G15 G15 G15 G15

Fl, F2, G15


G15 G15 G19 G19




P N art o. D escrlptlon 6516673 GEAR 6516680 GASKET 6516681 FLYWHEEL 6516682 RING GEAR 6516685 STATOR ASSY. 6516686 WIRE 6516689 INSULATOR 6516690 REGULATOR 6516691 RECTIFIER 6516692 FLYWHEEL 6516693 RECTIFIER 6516694 STATOR ASSY. 6516709 O-RING 6516710 ADAPTER 6516711 BREATHER 6516712 VALVE 6516713 HOSE 6516714 CLAMP 6516717 MANIFOLD 6516718 GASKET 6516719 GASKET 6516724 COVER 6516725 REGULATOR 6516726 RECTIFIER 6516727 BRUSH 6516728 STARTER 6516729 BOLT 6516731 SOLENOID 6516732 SCREW 6516733 BRACKET 6516734 BAND 6516735 SPRING 6516736 DRIVE ASSY. 6516758 GROMMET 6516759 BRACKET 6516760 BRACKET 6516761 STUD 6516762 PAD 6516763 BLOCK 6516764 RATCHET 6516765 COLLAR 6516766 SPACER 6516767 STUD 6516768 STUD 6516769 DOWEL 6516770 PLATE 6516771 BAFFLE 6516772 CLIP 6516773 GROMMET 6516774 SUPPORT 6516775 WASHER Code for disposition of old part number A-Useup B - Use on other application (See PNI)

W Cd as o e P age

02

G19 G3 F2

F1,F2,F14 D14,F2

F2 F2

D14,F2 D14,F2

F1 012, F1 012, F1

13 13

H18 H18 H18 H18 H12 H12 H12 E22 E22 E22 E22

E11,114 E11, E13

E11 E12 E12

E12,E13 E12,E13

E12 J2

114 114

114,120 118 118 118 118 122 114

114, J2 114 120 115

110,118


115 118 122

ModelSOO

Loader Parts

.. ' ~;,



Part No. Description 6516776 SHROUD 6516777 EXTENSION 6516778 GUIDE 6516779 NUT 6516780 GUIDE 6516781 ROCKER ARM 6516782 PLATE 6516783 BRACKET 6516784 BAFFLE 6516785 COVER 6516788 STUD 6516789 MANIFOLD 6516790 NUT 6516791 INJECTOR 6516792 STUD 6516794 CAP 6516795 WASHER 6516796 NUT 6516797 SEAL 6516798 LEVER 6516799 WASHER 6516800 SPRING 6516801 SEAL 6516802 SHAFT 6516803 GASKET 6516804 GUIDE 6516805 SEAL 6516806 COVER 6516807 STUD 6516808 GUARD 6516809 GASKET 6516810 STUD 6516811 PUSH ROD 6516812 SHIM 6516813 SHIM 6516814 CYLINDER 6516815 VALVE 6516816 INSERT 6516817 INSERT 6516818 VALVE 6516819 BEARING 6516821 SPRING 6516822 SCREW 6516823 SCREW 6516824 PAWL 6516825 ARM 6516826 BUSHING 6516827 CAP 6516828 KEY 6516829 COLLAR 6516830 SPRING Code for disposition of old part number A-Use up B - Use on other application (See PNI)

Was

03

Code Page 11 11

5 5

115 115 115 118 115 115 115 118 116 116 116 118 116 117 117 117 118

117, J4 110, 118

117 117 117

110, 117 117

110, 117 117

118, J6 J1 117

117, J2 118 118 118 118 118 118 118 118 J1

118 118 118 118 118 118 118 118 118 11 8 . .


Model 600

Loader Parts



P N art o. D escrlptlon 6516831 CUP 6516832 STUD 6516833 STUD 6516834 PLATE 6516835 DOWEL 6516836 ROLL PIN 6516837 HEAD 6516838 ROLL PIN 6516839 WASHER 6516840 NOZZLE 6516843 WASHER 6516844 STUD 6516845 PLUG 6516846 BUSHING 6516847 BRACKET 6516848 SNAP RING 6516849 TUBE 6516851 DOWEL 6516852 GASKET 6516853 PLUG 6516854 PLUNGER 6516855 COVER 6516856 SEAL 6516857 SCREW 6516858 TUBE 6516859 PLATE 6516860 GASKET 6516861 PLUG 6516862 DOWEL 6516863 STUD 6516864 STUD 6516865 PLUG 6516866 NUT 6516867 PLUG 6516868 PLATE 6516869 SUMP 6516870 GASKET 6516871 GASKET 6516872 PLATE 6516873 PLATE 6516874 PLUG 6516875 PLUG 6516876 STUD 6516878 GASKET 6516879 SEAL 6516881 KEY 6516883 PIN 6516884 HOUSING 6516885 GASKET 6516886 CRANKSHAFT 6516887 HOUSING· Code for disposition of old part number A-Use up B - Use on other application (See PNI)

W C as ode Page

04

118 118 118 118

118, J6 118 118 118

110,118 118 J1 J1 J1 J2 J2

124 J2 J2 J2 J2

124 J2 J2 J2 118 J2 J2 J2 J2 J2 J2 J2 J1 J2 J2 J2 J2 J2 J2 J2 J1 J2

120 120 124 120

120,123


120 120 120 120

ModelSOO

Loader Parts



P rt N a o. D . r W C d escnp1lon as o e P age 6516888 PIN 6516889 ROD 6516899 PISTON 6516901 PISTON 6516902 SNAP RING 6516903 PIN 6516904 BUSHING 6516905 SCREW 6516906 BEARING 6516908 BEARING 6516910 BEARING 6516911 BEARING 6516913 BEARING 6516915 BEARING 6516916 DOWEL 6516917 BEARING 6516921 BEARING 6516922 GEARWHEEL 6516923 SCREW 6516924 SCREW 6516925 WASHERPLATE 6516926 WASHER 6516927 SEAL 6516928 SHAFT 6516929 FLYWHEEL 6516931 RING GEAR 6516932 RING GEAR 6516933 DOWEL 6516934 FAN 6516935 SCREW 6516936 CAMSHAFT 6516937 TAPPET 6516938 TAPPET 6516940 WASHER 6516941 GASKET 6516942 HOUSING 6516943 STUD 6516944 GEARWHEEL 6516945 SEAL 6516946 PLATE 6516947 SCREW 6516948 BEARING 6516949 STUD 6516950 FUEL LINE 6516951 RING SET 6516952 CLIP 6516953 MOUNT 6516954 SCREW 6516955 WASHER 6516956 PUSH ROD 6516958 , WASHER


05


120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 122 122 122 122 122 122 122 122 122 122 123 123 123 123 123 123 123 123 123 123 123 123 114 J5

120 J5 J6 J5 J5 J6 'J6

Model GOO

Loader Parts



Part No. D escrlptlon 6516959 UNION 6516960 SCREW 6516961 RING SET 6516962 SCREW 6516963 RING SET 6516964 SCREW 6516965 WASHER 6516966 STUD 6516967 GASKET 6516968 ELEMENT 6516969 FUEL FILTER 6516970 HOSE 6516971 FUEL LINE 6516972 SCREW 6516973 HOSE 6516974 SCREW 6516978 PUMP 6516979 SHIM 6516980 SHIM 6516981 SHIM 6516983 WASHER 6516984 WASHER 6516985 GASKET 6516986 GASKET 6516987 PLATE 6516988 ELEMENT 6516989 GASKET 6516990 HEAD 6516991 DOWEL 6516992 STUD 6516999 PUMP ASSV. 6517000 SEAL 6517001 STRAINER 6517002 DOWEL 6517003 RACK 6517004 PILLAR 6517005 SCREW 6517006 SPRING 6517007 STIR-UP 6517010 CONE 6517011 BALL 6517013 BEARING 6517014 WASHER 6517015 WASHER 6517016 WASHER 6517017 SNAP RING 6517018 SHAFT 6517019 WASHER 6517020 SEAL 6517021 STUD 6517027 .LEVER Code for disposition of old part number A-Use up B - Use on other application (See PNI)

w as

06

C d o e P age J6 J6

120 J6

120 J6 J6 J6 J6 J6 J6 J6

J5,J6 J6 J6 J6 J6 J6 J6 J6

124 124 124 124 124 124 124 124 124 124 124 124 124 124 J3 J3 J3 J3 J3 J3 J4 J4

E10,J4 J4 J4 J4 J4 J4 J4 J4 J4





P rt N a o. o . r W C d escnplon as o e P age 6517028 PIN 6517029 SETSCREW 6517030 PLATE 6517031 BOSS 6517032 SEAL 6517033 SHAFT 6517034 PLATE 6517035 SPRING 6517036 LEVER 6517037 SNAP RING 6517246 VALVE 6517280 HARNESS 6517284 GASKET 6517285 GASKET 6517286 GASKET 6517467 RESTRICTOR 6517472 ROD 6517473 PIN 6517474 PIN 6517475 BEARING 6517476 BEARING 6517477 BEARING 6517478 BEARING 6517479 BEARING 6517480 DIPSTICK 6517495 CONNECTOR 6517513 KIT 6517514 BEARING 6517516 LIGHT 6517517 LENS 6517676 LIGHT 6517839 SHROUD 6517840 SHROUD 6517841 WASHER 6517842 FLANGE 6517882 SPRING 6517883 LEVER 6517884 PIN 6517900 NUT 6517901 SCREW 6517902 NUT 6517903 TERMINAL 6517905 SCREW 6517906 BOLT 6517907 SCREW 6517908 WASHER 6517909 SCREW 6517911 FRAME 6517912 SCREW 6517913 WASHER 6517914 WASHER Code for disposition of old part number A-Use up 8 - Use on other application (See PNI)

6557903

07

-----

A

J J J J

4 4 4 4

J4 J4 J4 J4 J4 J4 G8

014 116 116 J6 J6

F14 F14 F14 F14 F14 F14 F14 F14 G12

E5 F4, G18

F16 K11 K11 K17 H10 H10 H12 H12 M14 M14 M14

E7,E9,E16 E7,E9,E16 E7,E9,E16

E7 E7 E8

E8,E10 E8,E10

E8,E16,E24 E8 E8 E9 E8




*


P rt N a o. D . r W C d eSCrlp110n as o e P age 6517916 KEY 6517918 CONNECTOR 6517922 SCREW 6518088 GASKET KIT 6518089 GASKET KIT 6518094 SPRING 6518095 SPRING 6518098 DRUM 6518121 PLUG 6518187 STARTER 6518192 AIR CLEANER 6518200 GREASEZERK 6518227 SCREW 6518228 FRAME 6518229 LEVER 6518230 O-RING 6518231 O-RING 6518233 BEARING 6518234 SCREW 6518235 LEAD. 6518236 COVER 6518238 TERMINAL 6518524 GASKET KIT 6518605 TEE 6518763 SWITCH

6518862 BEARING 6518920 NUT 6518966 ADAPTER 6519000 LEVER 6519001 BREAKER 6519001 BREAKER 6519055 CABLE 6519100 BEARING 6519101 SEAT BELT 6519102 VH4DG ENGINE 6519138 BUSHING 6519177 SEAL 6519179 LATCH 6519193 KIT 6519219 SHAFT 6519220 JET 6519223 ROD 6519224 LEVER 6519227 CARBURETOR 6519228 MANIFOLD 6519231 HOSE 6519235 BRACKET 6519257 SEAL 6519258 FUSE 6519259 GASKET Code for disposition of old part number A-Useup B - Use on other application (See PNI)

6509275

08

E24 K11 E24

110,118 J2

J20 J20 J20 C15

H2 H2, 113, J7

M14 E10 E10

E9 E8,E10 E8,E10

E10 E9

E7,E9 E10 E9

G22, H2O J18

D12, D15, D18, D20,D22,D24,E2

A B6,B8 A22

J6 J24 J14

D15,E2 112 B3

A19 F4

A15 K4 K4

F4,G5 G8 G8 G8 G8

G4 G7 G4 G4 G4

H14 D18, D20, D22

G22 H16


ModelSOO

Loader Parts



P N art o. D escrlptlon 6519267 TUBE 6519268 O-RING 6519273 RINGS 6519278 PUMP 6519332 SHROUD 6519333 SHROUD 6519392 CRANKCASE 6519396 SHAFT 6519397 SPRING 6519398 PLUNGER 6519399 SPRING 6519400 KNOB 6519401 LEVER 6519402 BUSHING 6519403 NUT 6519404 BODY 6519406 PUMP ASSY. 6519411 STARTER 6519412 BEARING 6519413 BEARING 6519421 HANDLE 6519484 GROMMET 6519594 MUFFLER 6519595 STUD 6519621 COLLAR 6519635 O-RING 6519636 O-RING 6519971 COVER 6519976 PLATE 6519986 FRAME 6519987 BUSHING 6519988 BOLT 6519989 LEVER 6519990 WASHER 6519991 PIN 6519992 DRIVE ASSY. 6519993 BRACKET 6519995 FRAME 6519996 BUSHING 6519997 WASHER 6519998 SOLENOID 6529330 ROD 6530884 HOSE 6531681 CYLINDER 6531682 CASE 6538595 HEAD 6538595 HEAD 6539323 HEAD 6540057 BRACKET 6540094 BRACKET 6540097 PIN Code for disposition of old part number A-Use up B - Use on other application (See PNI)

w as

6516882

6551375

6504933 6504932

09

C d o e P age H1 6

G22, H16 H2 2 C2

F10 F10 J1 J4 J4 J4 J4 J4 J4 J4 J4 J4

124 E13

A24, J20 A24,J20

K4 F7

F5,H2 A23,M8

A 120 J4 J4 C2 C2

E13 E13 E13 E13 E13 E13 E13 E13 E13 E13 E13 E13

A C17 C20 C18 C18 C18

A C17 A C16

A17 114 11 4


ModelSOO

Loader Parts



P N art o. D escrl~tlon 6540098 END 6540106 BUSHING 6540178 FORK 6540179 FORK 6540180 FORK 6540181 FORK 6540478 RACE 6540558 NUT 6540559 NUT 6540685 FRAME 6540701 BRACKET 6540716 HOSE 6541121 ROD 6541193 FILTER ASSY. 6541218 MOUNT 6541297 BRACKET 6541299 GASKET 6541372 PIN 6541404 NUT 6541415 BRACKET 6541418 PIN 6541451 FRAME 6541462 WINDOW ASSY. 6541469 WINDOW ASSY. 6541514 SPRING 6541515 RETAINER 6541628 U-BOLT 6541824 BRACKET 6541902 PULLEY 6541950 ACTUATOR 6541964 SPACER 6541981 PIN 6541991 SUPPORT 6541993 SUPPORT 6541995 GUARD 6541996 GUARD 6542213 BRACKET 6542223 PANEL 6542249 PANEL 6542259 BRACE 6542284 PANEL 6542285 PANEL 6542545 DOOR 6542553 AXLE 6542554 AXLE 6542555 AXLE 6542651 SEAL 6542665 STOP 6542686 WINDOW 6542728 HUB 6542731 SAFETY TREAD Code for disposition of old part number A-Use up B - Use on other application (See PNI)

W Cd as o e Page

010

112 J24 M14 M14 M14 M14

B2,B3 B2,B3 B2,B3

K4 A15

J6 F6

-- - 16 A14, A15

J18 G22,H4,K22

K15 B3

K15 K15

K4 K4 K4

K15 K15 K15 G14 E20 J22 K15 K15 J22 J22 J22 J22 J22 K4 K4 K4 K4 K4

K20 A23 A23

A24,J20 K4

A24 K20

A24,J20 K4


ModelSOO

Loader Parts


*

*


P rt N a o. D . f W C d escrlp' Ion as o e P age 6542885 FUSE ASSY. 6542938 ANCHOR 6543844 HOSE 6544004 BRACKET 6544044 HOSE 6544056 HOSE 6544372 PEDAL 6544374 BAR 6544377 PIVOT 6544488 KIT 6544495 RING 6544556 GUARD 6544654 BUSHING 6544704 HOSE 6545780 INSTRUCTIONS 6545917 INSTRUCTIONS 6545962 INSTRUCTIONS 6545963 INSTRUCTIONS 6545965 INSTRUCTIONS 6545968 INSTRUCTIONS 6545969 INSTRUCTIONS 6545972 INSTRUCTIONS 6545973 INSTRUCTIONS 6545975 INSTRUCTIONS 6546096 BRACKET 6546211 CAM 6546212 CAM 6546265 DECAL 6546543 TUBE 6546545 PLATE 6546664 HINGE 6546807 BRACKET 6546844 STRIP 6546945 LINK 6547125 BRACKET 6547125 STRAP 6547192 PANEL 6547193 PANEL 6547315 BRACKET 6547472 GUARD 6547482 TUBE 6547483 TUBE 6547554 SAFETY TREAD 6547555 SAFETY TREAD 6547556 GUARD 6547557 ROD 6547558 BRACKET 6547559 BRACKET 6547652 BUSHING 6547840 MOUNT 6547842 MOUNT Code for disposition of old part number A-Use up B - Use on other application (See PNI)

011

M17 115 H2

G11 F6 F6

J24 J24 J24 A15

K4 A14

B2,K24 13

J24 J14 J22 J18 M17 K11 K14 J15 J16 K17

J15,J18 J20 J20 K6

B18 B18 A12 G11

F7 F7

J14 D16D24,E2

K4 K4

K17 A14,J24

J16 J16

A14,J24 A14,J24 A14,K4


F7 K4 K4

C17 H4 H4

ModelSOO

Loader Parts


*


P N art o. D escrlptlon 6547846 BLOCK 6547917 STOP 6547933 PIN 6547951 BRACKET 6547963 BRACKET 6547968 LATCH 6547997 BRACKET 6547998 BRACKET 6548194 REPAIR KIT 6548195 REPAIR KIT 6548407 SPRING 6548541 LINK 6548581 LINK 6548605 STUD 6548613 COUNTERWEIGHT 6548650 KIT 6548657 KIT 6548664 KIT 6548690 KIT 6548694 KIT 6548912 WEDGE 6548913 WEDGE 6549857 INSTRUCTIONS 6550826 TIRE 6550828 TIRE 6550829 TIRE 6551114 JACKSHAFT 6551201 PULLEY 6551201 PULLEY 6551289 KIT 6551395 ROD 6551463 BLOCK 6551636 PIN 6551668 BOB-TACH 6552292 BRACKET 6552293 ROD 6552443 KIT 6552487 SCREEN 6552854 ELBOW 6553094 CABLE

6553557 GRIP 6553937 CAB 6554100 SAFETY TREAD 6554806 KIT 6554939 COVER 6555106 CLAMP ASSY. 6555113 HOSE 6555140 HARNESS 6555236 DECAL 6555384 BUSHING Code for disposition of old part number A-Use up B - Use on other application (See PNI)

W C as ode Page

6551202

6565721

012

H4 A12 A12

F7 A12 A12 A12 A12 F24 G19 A18 A18 A18 A18

K20, M12 J10 J22 J18 J16 K17 A18 A18 K10 M8

K20, M8 M8

B6,B8 J14

A B8 E4

H2,H7 F7, G20, H7, 114

A16, A18 A A18

A12 A12 J18 A15 C19

A14,D12,D14,D16,D18, D20,D22,D24,E2

G20 A15 M6

K10 A14 G11 G11

D12, D14, D16 K8

A18


ModelSOO

Loader Parts



P N art o. D escrl~tlon 6555477 FILTER

6555658 HOSE 6555738 LEVER 6555740 LEVER 6555797 SCREEN 6555798 SPACER 6555923 SCREW 6555985 SAFETY TREAD 6556500 MANUAL 6557224 DECAL 6557323 WASHER 6557412 DECAL 6557413 DECAL 6557904 FLASHER 6558196 PISTON 6558268 WASHER 6558309 WIRE ROPE 6558310 SLEEVE 6558832 KIT 6558951 DECAL 6559095 BRACKET 6559097 ROD 6559336 ROD 6559502 STUD 6559546 PLATE 6559547 LEVER 6559550 STOP 6559552 HARDHAT 6559775 EARMUFFS 6559940 PLATE 6560034 BOLT 6560045 SHIM 6560046 SHIM 6560203 FILTER 6560227 VH4D ENGINE 6560227REM ENGINE 6561379 DECAL 6561383 DECAL 6561384 DECAL 6561385 DECAL 6561436 KIT 6562126 SPRING 6562127 WASHER 6563016 SPRING 6563181 GUIDE 6563182 LINKAGE 6563184 LINKAGE 6563198 BRACKET 6563200 PLUNGER 6563208 PLATE Code for disposition of old part number A-Use up B - Use on other application (See PNI)

W Cd as o e P age A1,B1~B16,B1~B1~

B20,B21,B22 J16 A18 A18 A15

A15,K24 18

K8 K8 K6

A23 K8 K8

K11 C16, C17, C18, M15

B8 6558305 A K8

K8 G18

K6 A19

F7 G20

A23, A24, M8 G20 G20

6563449 A K15 M1 M1 M6

K24 G16 G16

A1, G13 F4 F4 K8 K6 K8 K6 F8

K24 G20,K24

K24 K24 K24 K24 K24 K24 K24


013 ModelSOO

Loader Parts


*


P N art o. D escnptlon 6563214 SEAT BELT 6563328 BLACK GOLD 6563330 BLACK GOLD 6563336 KIT 6563382 DECAL 6563423 DECAL 6563442 KIT 6563470 BRACKET 6563473 BRACKET 6563477 HANDLE 6563480 BRACKET 6563544 SEAT BAR 6563603 BRACKET 6563616 HOSE 6563666 KIT 6563817 DECAL 6564041 KIT 6564048 SPACER 6564049 BRACKET 6564669 NUT 6564844 DECAL 6564943 LINK 6566056 INSTRUCTIONS 6566074 INSTRUCTIONS 6566139 INSTRUCTIONS 6566250 INSTRUCTIONS 6567594 KIT 6567623 KIT 6567806 KIT 6568905 DECAL 6569022 DECAL 6569849 DECAL 6579509 DECAL 6579511 DECAL 6579528 DECAL 6579639 DECAL 6587333 ROD 6587526 KIT 6587790 SEAL KIT 6587790 SEAL KIT 6589831 SEAL KIT 6590765 ROD 6592030 CASE 6598060 COLLAR 6598229 HOUSING 6598310 VALVE 6598440 BUSHING 6598475 LATCH 6598484 SLEEVE 6598485 SEALANT 6598499 CLAMP Code for disposition of old part number A-Use up B - Use on other application (See PNI)

w as

6501053

6519169

6564844

6565980 6565254

6504960 6586298

C d o e P age A19

A1, M20 A1, M20

K15 K8

K15 A23, A24, J21

K24 K24 K24 K24 K24 K15

A C14,J18 K24 K24 M6 M6

K24 A A23, A24, M8

A15 A21 K15 J21 K24 M6

A16 K8

K6,K8 A K8

K6 K6 K6

A K8 A K6

K6 C18 M3

C18 A C17, M15 A C16

J24 C16 E20 E20 M8

E13 K4

J21 J21 K24


014 Model 600

Loader Parts



Part No. D escrlptlon 6598755 QUICK COUPLER 6598756 QUICK COUPLER 6599360 SEALANT 6599449 SOLENOID 6599700 EXTINGUISHER 6599719 GREASE 6599766 BOLT 6599767 RECTIFIER 6599768 BOLT 6599769 DIODE 6599770 HOLDER 6599772 ROTOR 6605024 BRANCH GUARD 6630154 CAP

6630155 CAP

6630188 POLISH 6630189 POLISH 6630190 POLISH 6630191 POLISH 6630238 REPAIR KIT 6630277 SPRING 6630278 BUSHING 6630280 SHAFT 6630380 LOOP 6630381 HOOK 6630402 HOLDER 6630411 CENTER PLATE 6630412 WASHER 6630417 PLUNGER 6630708 PISTON 6630709 PISTON 6630710 PISTON 6630711 PISTON 6630712 RING SET 6630713 RING SET 6630714 RING SET 6630715 RING SET 6631616 HOUSING 6631939 SOLENOID 6632000 BOLT 6632004 BOLT 6632528 CAP 6632529 FITTING 6632530 GASKET 6632565 CHANNEL 6632634REM ENGINE 6632973 SWITCH 6633583 SEALANT 6634393 LUBRICANT. Code for disposition of old part number A-Useup B - Use on other application (See PNI)

as o e W Cd P age

891252

600259

015

J15,J16,J18 J15,J16,J18

M20 E3

K10 M20 E19 E19 E19 E19 E19 E19 M3

012,014,016,018,020,022, 024,E2

012,014,016,018,020,022, 024,E2

M20 M20 M20 M20

G9 H14 H16 H14

K8 K8

A E4 E4 E4 E3

F16 F16 F16 F16 F14 F14 F14 F14 E4

018,020,022 C1, C5 C6

B24 G9 G9 G9 K4 F4

A 018,020, 022,J22, K14 M20 M20


Model 600

Loader Parts


* * *

*


P N 'art o. o . r W C d escnp'lon as o e p age 6640795 ALARM 6644952 SPRING 6645247 DRIVE ASSY. 6645259 TERMINAL 6646494 FILTER 6648774 BEARING 6648775 BEARING 6648776 BEARING 6649871 LINING 6650388 SEALANT 6650407 ADHESIVE 6652488 CAP 6652818 ADHESIVE 6652919 PIN 6652920 CLIP 6653517 REDUCER 6653518 PRIMER 6654208 GAUGE 6654209 ALTERNATOR 6654209 ALTERNATOR 6654210 CAPACITOR 6656398 HOLDER 6656399 SPRING 6656399 SPRING 6656404 INSULATOR 6657299 OIL 6657300 OIL 6657301 OIL 6657302 OIL 6657303 OIL 6657304 OIL 6657760 LOCK VALVE 6657761 VALVE 6658266 GREASE 6658896 STARTER 6658897 ARMATURE 6658899 FRAME & SHIELD 6658903 PLUNGER 6658926 GASKET 6659353 KIT BONNET 6659354 KIT RELIEF 6659474 TIRE 6659543 PLUG 6660109 HOURMETER

6660248 GEAR 6661220 MOTOR 6661221 ARM & BLADE 6661301 SEAL KIT 6661320 SEAL KIT 6661441 SEAL KIT Code for disposition of old part number A-Use up B - Use on other application (See PNI)

6519359 850032 899271 897263 889098 743778 743777 743777 6502424

663879

6518226

891252

871517

6552874 850272 6551203

6516524

6504961 6561718 6561717

A J22. A G8 A E6 A G19 A A1, J7 A A23, A24, J20 A J20 A A23, A24 A B3

M20 M20

A J7 M20 F20 F20 M20 M20

A B14,B16,B18 J14 E19 E19

A E6 E4

A E6 E4

A1, M20 A1, M20 A1, M20 A1, M20 A1, M20 A1, M20

C20 C20, C23

M20 E3 E4 E4 E3 E3

C23 C23

A M8 A G6 A 012,014,016,018,020,022,

024.E2 A F16

M17 M17

A 04 A C22 A 08

c - File PDR Report with Melroe Parts Sales 0- Part Number Error

016 ModelSOO

Loader Parts


*

*

* * *

*

* *


Part N o. D escrlptlon 6664964 GASKET KIT 6664964 GASKET KIT 6665021 LENS 6665022 FLASH TUBE 6665023 GASKET 6665025 LENS 6665228 BATTERY

6665409 KEY 6666396 SCREW 6666864 CLAMP 6702265 DECAL 6702430 SPRING 6702641 KIT 6704180 TIRE 6704453 SPRING 6708929 DECAL 6720539 INSTRUCTIONS 6720856 INSTRUCTIONS 6722344 BLACK GOLD 6722781 PAINT 6722782 PAINT 6722783 PAINT 6722784 PAINT 6722785 PAINT 6722786 PAINT 6722787 PAINT 6722788 PAINT 6722789 PAINT 6724094 ANTI-FREEZE 6724354 ANTI-FREEZE


W C as ode P age 6516447 A F4 6516447 A F12

M3 M3 M3 M3

6633910 A A1,D12,D14,D16,D18,D20, D22,D24,E2

K4 6514745 A H4,18 756853 A B20 6509185 A K6 6563149 C K24

C20 M8

6503387 A F8,G20,H7 K8

C20 M2,M3

A1, M20 M20 M20 M20 M20 M20 M20 M20 M20 M20

6658230 A M20 M20


017 Model 600

Loader Parts



P N art o. D . r W C d escnpllon as o e P age 1CM-685 SCREW 1CM-860 SCREW 1CM-880 SCREW 1CM-1290 SCREW 1CM-8100 SCREW 1CM-8180 SCREW 1DM-6 NUT 1DM-8 NUT 1DM-10 NUT 1EM-60 WASHER 1EM-80 WASHER 1EM-120 WASHER 1F-208 COTTER PIN 1 F-21 0 COTTER PIN 1F-308 COTTER PIN 1F-312 COTTER PIN 1F-316 COTTER PIN 1F-412 COTTER PIN 1F-416 COTTER PIN 1F-424 COTTER PIN 1F-628 COTTER PIN 1F-632 COTTER PIN 1FM-60100 WASHER 1FM-80115 WASHER 1GM-612 SCREW 1GM-650 SCREW 1GM-820 SCREW 1GM-840 SCREW 1JM-5028 PIN 1JM-5036 PIN 1JM-6016 SPRING PIN 1KM-10 SCREW 1KM-16 PLUG 2EM-6 WASHER 2EM-10 WASHER 2F-6106 PIN 2FM-10160 WASHER 2FM-12155 WASHER 2FM-12180 WASHER 2FM-14180 GASKET 2FM-16200 WASHER 2FM-16220 WASHER 2FM-18240 WASHER 3CM-1050 SCREW 3FM-12 PLUG 3FM-14 PLUG 4CM-610 SCREW 4CM-612 SCREW 4CM-616 SCREW 4CM-618 SCREW 4CM-620 SCREW


018

H5 H23, H24, 11

H10 H2O H12

11 E8, E10, E16, H6, Hi 0, 12, J2, J4

H12, 11, 18, 117, 123, J2, J6 E16, H12, 114, 118, 120

H10, 12, 18 H6,H10,H12,H16

H2O F20 114

812, F7, G20 J18,J24

811, M6, M14 J24, K1, M14

811, G15, H7, 114, M6 A23,83

A24, J20 M6, M12

H14, H16, 12, 18 H13, H16, 18

H16 H14

H5 H16

H6 H18 H22 H18 H14

115,118,120, J3, J5 117,120, J2

J24 12

H4, H18, 18 12

G22, H2, H20, 18 H14

H6--,-H20 13

H22 H14 H16

H10,H14,H16,H18 H10, 115, J1->J2

J3 H18, 115

H10 H20, 120


ModelSOO

Loader Parts



P N art o. D . r W C d escnp'lon as o e P age 4CM-625 SCREW 4CM-650 SCREW 4CM-812 SCREW 4CM-814 SCREW 4CM-818 SCREW 4CM-820 SCREW 4CM-825 SCREW 4CM-1016 SCREW 4CM-1020 SCREW 4CM-1025 SCREW 4CM-1040 SCREW 4CM-1215 SCREW 4CM-1225 SCREW 4CM-1235 SCREW 4CM-1245 SCREW 4CM-1440 SCREW 4CM-1450 SCREW 40-18 NUT 4E-4 WASHER

4E-5 WASHER

4E..o WASHER

4E-7 WASHER 4E-8 WASHER

4E-9 WASHER 4E-10 WASHER 4E-12 WASHER 4GM-615 SCREW 4GM-820 SCREW 4GM-850 SCREW 4GM-1035 SCREW 4GM-1040 SCREW 4GM-1080 SCREW 5E-14 WASHER 5J-405 KEY 5J-605 KEY 5J-806 KEY 5J-808 KEY 5J-1010 KEY 5JM-8 CIR--CLIP 5JM-14 CI R--C LIP 5K-108 NIPPLE


12 H6 115 J4

H18 H2, H12, H14, J5

11,115,124 J2 13

122 H4

H18 H2 H4 H4 H4 H4

A24,J20 A17,C19,C22,D16,D18,D20,D22, E4,E5,F6,F10,F20,F22,G5,G12,

H14, 16, 118, J10 A12,814,D12,D14,D16,D24,E2, E6,E7,E9,F5,F10,F12,F20,F22,

G12, G18, H2, H23, H24, 112, 118, K22

A11, A14, A16, A19, 814, 816, 818, 823, D16, D24, E2, F6,F7,F16,G5, G16, G18, H2, H5, H7, H10, 114, 116,

J9,K1, K4,K17,K20, K22 F12

A12, A16, 85, 86, 88, 811, F6, F12, G11, 13, 16, 114, K15, K20, K22, M6,

M7, M12, M14 E22

A16, H2, K13 K22

18 J6

H16 H22 H22 H2O

82,83 82, 83, H23

G16--,-G18 86,88, J14

H2 88

H14 H6

F6,F22


019 Model 600

Loader Parts



P N art o. D escnptlon 5K-207 NIPPLE 5K-216 NIPPLE 5K-224 NIPPLE 5K-409 NIPPLE 5K-611 NIPPLE 5K-l013 NIPPLE 5K-l020 NIPPLE 60-14 NUT 6E-6 WASHER 6E-6 WASHER 6E-7 WASHER 6E-8 WASHER 6EM-40 WASHER 6EM-60 WASHER 6EM-60 WASHER 6EM-80 WASHER 6EM-l00 WASHER 6EM-120 WASHER 6EM-140 WASHER 6J-204 KEY 6J-606 KEY 6J-606 KEY 6J-808 KEY 6J-l011 KEY 7C-616 BOLT 7C-620 BOLT 7C-632 BOLT 7C-636 BOLT 7C-820 BOLT 7C-836 BOLT 70-6 NUT 70-8 NUT 70M-6 NUT 70M-8 NUT 7G-612 SCREW 7J-2013 KEY 7J-2014 KEY 7J-3200 KEY 7JM-30 CIR-CLIP 7JM-32 CIRCLIP 8C-612 BOLT 8C-709 BOLT 80-6 NUT 80-6 NUT 80-7 NUT 80-8 NUT 80-9 NUT 80-10 NUT 80-12 NUT 8EM-80 WASHER 8J-6200 KEY Code for disposition of old part number A-Use up B - Use on other application (See PNI)

W Cd as o e P age G5

C19,02 Gll

K22,M9 B14,B16,B18,B21

K22 K22

A23,B3 B3,F14

A12,A14, B2,02, 06, 08, H2 A22

B9,Bl0,F6,J9 E7,E24

-- E8 H5, Hl0, H18, 12

H2, H5, H12, H14, H16, 11, 18 E7, E9, E16, H4, H12, 13

H2, H20, 11 H4

G15 F14 123

F6, 113 F14

84, J9 K22

F8, G20 A12

A12, A14, 13, 16, K20 A14

F8, Kl, K24 A17, A18

115 114

F14 C6 C2

B6,B8 H22 Hl0

B3 A22 G6

Bll, Kl, M6 G15

Bll, M6 E22

04 06 04,06

H18 04


020 Model 600

Loader Parts



P rt N a o. D . r W C d escnp'lon as o e P age 9E-4 WASHER 9JM-90 CIR-CLIP 9K-1 REOUCER 10F-6 PLUG 10H-25 GREASEZERK 10H-35 GREASEZERK 10J-12 BALL 10JM-6010 PLUG 10K-6 TEE 11H-25 GREASEZERK 120-8 NUT 12E-10 WASHER 12F-12 PLUG 12H-15 GREASEZERK 130M-6 NUT 13G-612 SETSCREW 13GM-650 SCREW 13GM-6010 SCREW 13GM-6012 SCREW 13G~090 SCREW 140-8 NUT 140-10 NUT 14J-.3716 ROLL PIN 14J-.3724 ROLL PIN 15E-10 WASHER 15F-2 PLUG 15G-406 SETSCREW 15G-505 SETSCREW 15G-604 SETSCREW 15G-606 SETSCREW 16F-2 PLUG 16F-6 PLUG 16F-12 PLUG 16JM-365 KEY 17C-406 BOLT 17C-408 BOLT 17C-410 BOLT 17C-412 BOLT

17C-416 BOLT 17C-418 BOLT 17C-420 BOLT 17C-448 BOLT 17C-456 BOLT 170-508 BOLT 170-510 BOLT 170-512 BOLT

170-516 BOLT

170-518 BOLT

Code for disposition of old part number A-Use up 8 - Use on other application (See PNI)

021

J3 H14 C20 F12

C16, C17, C18, M15 B2, F6, 114

C22 H18 J15

B12, 02, 04, 06, 08, J18, J24 E19 04 E6

B11, K1, M6 H10, 120, 122

B9 H18

H10,18 120

H12 F24, G2, G6, G8

F6,H2,H7 K24 K24

E5 F12

B8,J14 F7, G20, H7, 114

04 B6, B8, 04, M15

E4,E6,F20,G15 C22 K22

C5, H5, 11 018,020,022

F10, F22, K4, K10 F7

A17, 018, 020, 022, F6, F22, 16, 114, 115, J10 016,E2

B23,H14 F22 J22 C15 F10 F12

B14,B16, B18, 012, 014, 016, F5, F12, F22, G16, G18, H2, J22

A12,016,024,E2,F6,F16,F17, F22, G12, G14, 114, J14, K22


G4

ModelSOO

Loader Parts


NUMER ':.- INDEX (Cont'd)

Part No. D escrlptlon 17C-520 BOLT 17C-524 BOLT

17C-528 BOLT 17C-532 BOLT 17C-536 BOLT 17C-540 BOLT 17C-592 BOLT 17C-608 BOLT 17C-612 BOLT 17C-614 BOLT 17C-616 BOLT

17C-620 BOLT

17C-624 BOLT 17C-628 BOLT 17C-632 BOLT 17C-636 BOLT 17C-640 BOLT

17C-648 BOLT 17C-652 BOLT 17C-660 BOLT 17C-712 BOLT 17C-816 BOLT 17C-820 BOLT 17C-824 BOLT 17C-832 BOLT 17C-836 BOLT 17C-840 BOLT 17C-848 BOLT 17C-856 BOLT 17C-872 BOLT 17C-880 BOLT 17C-896 BOLT 17C-1024 BOLT 17C-1032 BOLT 17C-1048 BOLT 17C-1064 BOLT 17C-1072 BOLT 17C-1248 BOLT 17C-8104 BOLT 17C-8120 BOLT 17E-4 WASHER 17E~ WASHER 17E-10 WASHER 17K-5 ELBOW 18C-544 BOLT 18C-624 BOLT


W C as ode P aae A17,024,F12,H24

B11, 016, 024, E2, H23, J14,J24,K1

J24 A16, H23

A16,B24,C1,C5,C6 A17, A18, C1, C2, C5, C6, G20, 112

H23,H24 A18,C19,G4,K4

A12,A19,024,J9,K1,K17,K2C A14,B23,K4

B14, B16, B18, 016, E2, G11, H2, H5,J14,J15,J16,J18,K15,K17,

K20, K24, M12 A12,B23,C14,F16,J15,J18,K1,

M12 02, 06, 08, G16, Hi 0, 116, K12

A18,B12,J18 A14, C20, F6, G18, 114

K24 A16,B9,B14,B16,B18,F7,

J16,J18 016, E2, M12

K15 J18 J20

B6,B8,K22 A12, J20, K16

A16, B5, B6, B8, F12, 114 114 F6

A11 A12, M12, M14

K20 M12 M12

A18, M7 K13

H4 A15,H4

H4 A15 K22

B11, M6 K22 G2 G8

F24. G2. G8 C18, C20

B6,B8,B24 B2


022 ModelSOO

LO:C"{"'r Parts



P rt N a o. D . r W C d escnp'lon as o e P age 18C-920 BOLT 18C-928 BOLT 18F-4 TEE 18F-7 FITTING 18G-804 SCREW 18K-5 AOAPTER 19F-5 BUSHING 19F-7 BUSHING 19F-9 AOAPTER 19F-14 BUSHING 19F-16 BUSHING 19F-18 BUSHING 20C~35 SCREW 20C~60 SCREW 21G-1008 SCREW 21G~8 SETSCREW 22G-1016 SCREW 23C-648 BOLT 23E-5 WASHER 23E-6 WASHER 23F-7 ELBOW 24E-4 WASHER 24F-8 ELBOW 24K-5 PLUG 25E-8 WASHER 25E-13 WASHER 25E-15 WASHER

25E-16 WASHER 25E-17 WASHER

25E-18 WASHER 25E-19 WASHER 25E-20 WASHER 25E-21 WASHER 25E-29 WASHER 25F-5 ELBOW 25K-20005 O-RING 25K-20014 O-RING 25 K-20 1 02 O-RING 25K-20300 O-RING 25K~0012 O-RING 25K~0020 O-RING 25K~0130 O-RING 25K-40024 O-RING 25K-40026 O-RING 25K-40028 O-RING 25K-40100 O-RING 25K-40112 O-RING


023

B5 B5 M9

K22 M17 C20

C19, C20, M9 A14 J18 K22

B14,B16,B18,B20,B21,B22 K22 118 124 04 J4

F1,F2 J14 J14

F22, G4, J14 K22

C22,C23,E4 K22 C20

A14, K16 C15, 018, 020, 022, H10, H13, 16 B16, B18, 016, 024, E2,F20, H7,

H23, H24, 114, J14 114

A11,A14,A18,A19,B11,B14,C12, C14, C19, F6, G18, H2, H7, H10,

114, J9, J15, J18, K1, K4, K12, K20, M6, M12

A15 B16,B18,K9

112 A11, A14, H2, 13, 16, 114, K20

J24, M6 B21, B22 08,010

C22 C7

B24, C1, C5, C6 C22,C23

04 06 C3,C4

16 J15 J18 B2,B20 04,06

A24 J20


Model GOO Loader Parts



P N art o. D escrlptlon 25K-40120 ~ING

25K-40200 O-RING 25K-40212 O-RING 25K~0120 O-RING 26F-4 ELBOW 26~ ELBOW 26K-204 ELBOW 27DM-12 NUT 27DM-8 NUT 27E~ WASHER 28K-204 TEE 30H-12 CLAMP 30H-34 CLAMP 30K-304 ADAPTER 32DM-50 NUT 32D~O NUT 32DM-80 NUT 35G-a03 SCREW 36DM-8 NUT 36H-25 GREASEZERK 36K~ CAP 37~16 BOLT 38F-7 FITTING 40K-2 PLUG 40K-4 PLUG 40K-8 PLUG 40K-12 PLUG 41G-a05 SCREW 41G-a16 SCREW 41G-a28 SCREW 420-4 NUT 42F-3 ELBOW 42G-1004 SCREW 42G-1010 SCREW 42G-1016 SCREW 42H-32 CLAMP

430-12 NUT 43F-7 ELBOW 43G-408 SCREW 43G-410 SCREW 43G-412 SCREW 45G-a07 SCREW 45G-1008 SCREW 46G-a07 SCREW 46G-a08 SCREW 47G-401 SCREW 47G-408 SCREW 47G-412 SCREW 47G-416 SCREW 47G-432 SCREW


W Cd as o e P age 16

D4 A23,D2

D4 B14, B16, B18, M9

B14, B16, B18, B21 C19,D2

11 H16 K24 G11 K17 C19 G11

J4 118

H13,118 G7

H16 A16

J15, J18, M9 6514537 A G20

F22 A14, G2, G3 A12, A14, 16

C22,K22 A12, A14

G9 C22,C23

B19 J22

F6, F12, F22, G14 G9

F24, G2 G2,G8

B14 B16 B18, B21, B22, B23, F6, H2, 113, J10

M15 G5 E6

C22 E4 G2

E19 F24 F24 F10

F10 G4 G18 F10 G12

G5


024 ModelSOO

Loader Parts



P N art o. D escrlptlon 47G-514 SCREW 47K-:2 PLUG 550-6 NUT 56F-2 TEE 570-6 NUT 57F-2 SLEEVE 58F-2 NUT 58K-12 O-RING 58K-:22 O-RING 58K-:216 O-RING 58K-325 O-RING 59G-1208 SCREW 610-4 NUT

610-5 NUT

610-6 NUT

610-8 NUT

610-10 NUT 610-12 NUT 620-6 NUT 620-7 NUT 620-9 NUT 620-14 NUT 62F-6 ELBOW 63F-l TEE 68G-l016 SCREW 73G-414 SCREW 73G-540 SCREW 75G-l008 SCREW 77F-6 ELBOW 79K-3 O-RING 79K-6 O-RING 79K-8 O-RING 79K-l0 O-RING 80F-5 NUT 810-4 NUT 810-5 NUT 810-6 NUT

810-8 NUT 820-5 NUT Code for disposition of old part number A-Useup B - Use on other application {See PNI}

W Cd as o e P a~e

P1

F20 C18 C20

J6 G20

J5 J5

C22 C7 08 08 K4

A17,C15,C19,016,018,020, 022, E4, F6, FlO, G12, Hl0, H14, 115,

Jl0,Kl0 A12,B12,016,024,E2,F5,G18, G20, H2, H23, H24, 112, 114, J14,

J22,K22 All, A14, A16, A19, B14, B18, B16, B23,016,024,E2,F6,F7,F8,Gll,

G16, G18, G20, H2, H7, Hl0, 114, 116, J9, J14, J16, Kl, K4, K9, K17,

K22 All, A16, B9, Bl0, Bll, F6, 13, 16, 114, K15, K16, K20, K22, M6, M7,

M12, M14 H2,K13

K22 B2,H5

F12 B5

B2,B3 G4 G5 G7

G16 C2 K4

C12, C14 C18

C9, C18 C9 Cl0

B23 C20

018.020. F7. H13 K4 A16,A17,A18,Bll,J14,J24,K20

A12,A15,B2,B4,B9,Bl0,B12, C12, C14 C19 G20, J14, J15 J18,

Kl, M12 A14,A23,A24,B4,B6,B8,J20


B6-,B8

ModelSOO

Loader Parts


* * * * * * *


P N art o. D . r W C d escnp1 Ion as o e P age 83F-3 ELBOW' ':;'-'-'

,t,. •

83F-5 ELBOW 83~ ELBOW 83F-10 ELBOW 84F-5 ELBOW 84G-3716 BOLT 850-6 NUT 850-10 NUT 85F-3 ELBOW 85F-5 ELBOW 85G-624 SCREW 85G-1005 SCREW 860-5 NUT 860-12 NUT 86G-808 SCREW 86G-1008 SCREW 86G-1020 SCREW 87F~ BUSHING 87F-6 ADAPTER 89F-3 ADAPTER 89F~ ADAPTER 89G-408 SCREW 920-12 NUT 920-12 NUT 93F-5 ADAPTER 93~20 BOLT 93G-624 BOLT 98~ TEE

NAP GROMMET NAP KEY NAP "KIT NAP MANIFO!-D NAP PUMP NAP RING NAP SEAT NAP ADAPTER NAP ADAPTER NAP ALTERNATOR NAP ARM NAP BEARING NAP BLACK GOLD NAP BOLT NAP CAM NAP CASE NAP CHANNEL 'NAP CHANNEL Code for disposition of old part number A-Useup B - Use on other application (See PNI)

C16 E4

860-12

6515206 6516253 6547224 6519331 6516957 6516240 6515423 6516756 715975 1536554 6515980' 6516919 6563329 6518232 6516661 6592029 6541505 ,6541506

P2

B14, B16 B14,B15,B17,C12,C14,C20,M12

B14, B15, B17, B21 B14,B20

16 M6

K15, K24 A15, A16

B14,B16,B18 16

C8,16 C3,C4

F16

G15 G15

B14,B16,B18 J16 B18

B14, B15, B17, C12, C14, 16, M12 C9, C10, C22, C23

C18 B C17

16 C3,C4

C3 B14,B15,B17

A 018, 020, 022 A B24,C1 A J24 A 116 A J6 A C22 A A19 A 113 A G11 A E17 A H14 A 120 A M20 A E10 A G19 A C17 A K4 A K4


Model 600

Loader Parts



P N art o. D . r W C d escnpllon as o e P age NAP COLLAR NAP CYLINDER NAP DIPSTICK NAP DISTRIBUTOR NAP DOWEL NAP EXTINGUISHER NAP GOVERNOR NAP GRIP NAP GRIP NAP HARNESS NAP HOLDER NAP HOSE NAP KIT NAP KIT NAP KIT NAP LPKIT NAP MANIFOLD NAP MOTOR NAP OIL FILTER NAP PISTON NAP PISTON NAP PISTON NAP PLUNGER NAP PUMP NAP REGULATOR NAP RETAINER NAP RINGS NAP RINGS NAP ROD NAP SCREW NAP SCREW NAP SHEAVE NAP SHEAVE NAP SHEAVE ASSY. NAP SHEAVE HALVES NAP STROBE LIGHT NAP SWITCH NAP VALVE NAP VALVE

NSS FIELDS NSS PLATE NSS PLATE NSS SCREW NSS SEAL NSS WASHER NSS WIRE


6516173 6501108 6516850 6516554 219277 6505083 6510833 6518999 6552791 6552794 6515968 6516976 6504728 6519236 6541963 6519236 6516411 1550696 6515424 6516098 6516099 6516900 6516793 6516246 6516426 6515437 6519275 6519275 6551375 6516842 6518237 6502003 6502004 6501610 6501609 6587526 6519264 6504944 6515197

6513677 6515053 6519225 874174 6512232 892810 6515330

P3

A H6 A C17 A J2 A G19 A 02 A K22 A F20 A J24 A K17 A K17 A H2O A J6 A K15 A --- F4 A K15 A G4 A G5 A M17 A G13 A H22 A H22 A 120 A 117 A B23,C6 A G10 A C3,C4 A H22 A H22 A C17 A 114 A E10 A 08 A 08,114 A 06 A 06 A M2 A 024, E2, 110 A C22 A K22

A E4 A C8,16 A G8 A G9 A 120 A G6 A M16




Documents

Bobcat 600 Skid Steer Loader Parts Manual - Tractor … · bc-p-600 bboobbccaatt parts manual 600 skid steer this is a manual produced byjensales inc.without the authorization of