GÖNKA Inc. Azerbaijan References

GÖNKA

BÝle

suva

r O

lym

pic

Tra

inin

g C

om

ple

x

20

08

2/3

BÝle

suva

r O

lym

pic

Tra

inin

g C

om

ple

x

Bilesuvar Olympic Training Complex

The Whole Mechanical Contracting ; piping, duct work, heating system, boiler room, cooling system, were made by GONKA. All HVAC equipment is supplied by GONKA.

Swimming pool & olympic training facilities are completed in the complex the, finshed in 2008

Air Cooled Water Chillers

Fan Coils Ceiling & Wall Type

Air Handling Units

Are used in complex

20

08

Ba

ku T

urk

ish A

na

tolia

n H

igh S

cho

ol

4/5

Baku Turkish Anatolian High School

Baku Turkish Anatolian High School

20

09

Gö

yça

y O

lym

pic

Tra

inin

g C

om

ple

x

Göyçay Olympic Training Complex

The Mechanical Contracting ; piping, duct work, heating system, boiler room, cooling system, were made by GONKA Inc. All HVAC equipment is manufactured and supplied by GÖNKA

Swimming pool, & olympic training facilities and remaining works are completed in 2009

6/7

Air cooled water chillers

Fan Coils Ceiling & Wall Type

Air Handling Units

Are used in complex

Boiler room, pump station and piping. Ductwork

20

09

Hö

vsa

n O

lym

pic

Tra

inin

g C

om

ple

x

Hövsan Olympic Training Complex

8/9

GONKA Screw compressor air cooled water cooling groups,

with its models in the range of high efficiency and high

capacity, are ideal for cooling operations related to comfort

and industrial purposes. R22 , R134a or R407c options.

Compressors; Half hermetic screw compressors.

Compressors changing between 1 and 4 according to

cooling capacity.

Condenser; Highly efficient, original condenser situated in V

type and condensation provided through 900 cyclical and

low sound level axial fans situated in the open edge of the

condenser.

Evaporator; Shell- tube evaporator whose cooling liquid side

and water side have one-circuit, multiple transitional, two

mirrored construction.

Refrigerating Circuit;Cooling Circuit; Cooling circuit and

circuit elements entirely independent for every compressor.

Electrical Screen and Control Board; board including switch

and micro-processor controlled module and control cards

as well as elements such as systemic control elements and

f u s e , t h e r m i c m a g n e t i c s w i t c h a n d r e l a y.

Micro-processor based Control System; Full control over all

the cooling circuits. Connections on board through simplified

device failure follow-up and easily recognized electrical

diagram.

Low noise level.

Multiple compressor, multiple cyclical, high efficiency.

%25-%100 continuous modulating capacity control in every

compressor.

Hardconstruction and long life. Easy handling, installation

and service.

Effortless service.

C o m p a t i b l e w i t h a v a i l a b l e B M S s y s t e m s .

Meeting consumer requirements in the most suitable way

through broad accessory and option alternatives.

Newly improved use of screw compressor with high COP

value. Trouble-proof operations under high temperatures.

Rational control.

Air cooled liquid chiller

Serin

Ho

tel B

aku

20

06

10/11

Serin Hotel Baku

Air cooled liquid chiller

Ba

lake

n O

lym

pic

Tra

inin

g C

om

ple

x2

00

9

Balaken Olympic Training Complex

12/13

The Mechanical Contracting ; piping, duct work, heating system, boiler room, cooling system, were made by GONKA Inc. All HVAC equipment is manufactured and supplied by GÖNKA

Swimming pool, & olympic training facilities and remaining works are completed in 2009

Chiller Air Cooled

Fan Coils Ceiling & Wall Type

Air Handling Units

Are used in complex

Ba

ku A

dm

inis

tra

tion O

f Th

e N

atio

na

l Arc

hiv

e B

uild

ing

20

08

14/15

Baku Administration Of The NationalArchive Building

Air handling unit

Optional Accessories;

! GONKA vapor humidifier, standard vapor cylinder, immersion electrodes, stainless vapor distributor and microprocessor control unit.

! Mufflers which are made up of coulisses to provide required sound holding capacity.

! Plate heat exchanger or Heat recovery wheel for recovery of the heat emitted with exhaust air.

! Electrical board.

! Frequency Converter

Standard Series

Application Area: business centers, schools,

hospitals, factories, hotels and restaurants.

! 8 different models which provide required humidity

and temperature by conditioning air volume in the

range of 3000m³/h and 100.000 m³/h.

! The framework which is formed by combination of

aluminum frames, which are connected specially, with

plastic and aluminum comers.

! Boards which are made up of double skilled

galvanized iron in a standard way.

! Polyurethane insulated panels, which are 30 mm in

thickness, for thermal and acoustic insulation in a

standard way.

Standard Accessories;

! Filter Chambers; Chamber design which provides easy mounting and de-mounting in filters and filters with different productivity levels on demand.

! Heating and Cooling Coils; Seamless cooper tubes. In heating coils, 4 options: warm water, vapor, hot water, electrically heated; in cooling coils, 2 options: chilled water and DX (direct expansion).

! Dampers; Rigid aluminum frame in multi airfoil structure which is the least resistant against airflow. Rubber gaskets which reduce air leakage through blades to the minimum level.

! Fans; Statically and dynamically balanced aspirators and ventilators in double inlet belt driven centrifugal type. Forward curved fans in systems with low, medium and high duct pressures,.

Hb

Clin

ique

Ba

ku2

00

7

16/17

Hb Clinique Baku

Laminar flow air system

! HEPA filters which clean filtrated air before going into

operating room.

! Mounting situated in ceiling of the operating theatre in

such a way that it should locate over operating table.

! Stainless steel air distribution box, Hepa filters, transparent

air distributor (laminarizator) and pendant operating

table lighting connection.

! Easy maintenance and disinfection because of

transparent air distributor's being pulled down. Operating

theatre lighting system made up of airproof

construction.

! A laminar, vertical air flow from transparent air distributor

through operating table prevents turbulent air flow in

conventional air systems and offers a high level

cleanliness class around the operating table during the

operati

! The system which remove particulates and microbes

from operation part due to laminar flow.

! Special design for operation theatres which require

especially high level sterilization in accordance with DIN

1946.

! Differential pressure sensors. Easy connection differential

pressure sensors and leakage testing.

! Easy installation to all kinds of ceilings.

Packaged hygienic air conditioner

! Highly efficient filtration of supply and extract air.

! Maximum function control: room temperature and relative humidity control throughout the year.

! Meeting fresh air that surgical operations require

! Quiet and non-vibrating operation that operating theatres require.

! An independent system which is under direct control of authorized health staff.

! Pressure control in aseptic and septic surgical operations.

! Continuous control of room temperature and humidity.

! Quiet and non-vibrating operation.

! Replacing the old installation in available places and generally, because their sizes are small, occupying less room than any time before, however available air canal and water installation could be, easy erection in any type of health institutions.

! In fan part, one or two directly actuated highly static pressurized fans to provide required air volumetric flow rate even when filters are choked.

! Fans with inverter; St316 stainless steel fans which are used as a higher standard in respect to epoxy dyed standard fans in terms of hygiene and endurance. With a view to achieving continuous speed control, inverter equipment in supply and extract fans.

! Air Filters; F5 class filter in fresh air input and F9 class filters on the extract side.

! Dx battery;

! Vapor humidifiers; Standard steam cylinder, dipping electrodes, stainless steam distributor and micro-process control.

! Compressor; 1 or 2 Scroll Compressors according to the capacity.

! Electrical Board; All of the elements required for the trouble-proof operation of master switch and device.

! Micro-processor; AC micro-processor control of temperature and relative humidity over all of the operation and safety functions integrally (I) or rational- integrally (PI).

! PCO2 micro-processor of device control and adjustment system which provides remote control terminal with erection inside the clean room.

Ba

ku M

inis

try

Of H

ea

lth T

op

çub

aþo

v H

osp

ital

20

08

Laminar flow system

! HEPA filters which clean filtrated air before going into

operating room.

! Mounting situated in ceiling of the operating theatre in

such a way that it should locate over operating table.

! Stainless steel air distribution box, Hepa filters, transparent

air distributor (laminarizator) and pendant operating

table lighting connection.

! Easy maintenance and disinfection because of transparent air distributor's being pulled down. Operating theatre lighting system made up of airproof construction.

! A laminar, vertical air flow from transparent air distributor through operating table prevents turbulent air flow in conventional air systems and offers a high level cleanliness class around the operating table during the operatic

! The system which remove particulates and microbes

from operation part due to laminar flow.

! Special design for operation theatres which require

especially high level sterilization in accordance with DIN

1946.

! Differential pressure sensors. Easy connection differential

pressure sensors and leakage testing.

! Easy installation to all kinds of ceilings.

18/19

Baku Ministry Of Health Topçubaþov Hospital

Laminar flow system

Serin

Ho

spita

l Aze

rba

ijan

20

08

20/21

Serin Hospital Azerbaijan

Serin

Ho

spita

l Aze

rba

ijan

20

08

Packaged hygienic air conditioner

! Highly efficient filtration of supply and extract air.

! Maximum function control: room temperature and relative humidity control throughout the year.

! Meeting fresh air that surgical operations require

! Quiet and non-vibrating operation that operating theatres require.

! An independent system which is under direct control of authorized health staff.

! Pressure control in aseptic and septic surgical operations.

! Continuous control of room temperature and humidity.

! Quiet and non-vibrating operation.

! Replacing the old installation in available places and generally, because their sizes are small, occupying less room than any time before, however available air canal and water installation could be, easy erection in any type of health institutions.

! In fan part, one or two directly actuated highly static pressurized fans to provide required air volumetric flow rate even when filters are choked.

! Fans with inverter; St316 stainless steel fans which are used as a higher standard in respect to epoxy dyed standard fans in terms of hygiene and endurance. With a view to achieving continuous speed control, inverter equipment in supply and extract fans.

! Air Filters; F5 class filter in fresh air input and F9 class filters on the extract side.

! Dx battery;

! Vapor humidifiers; Standard steam cylinder, dipping electrodes, stainless steam distributor and micro-process control.

! Compressor; 1 or 2 Scroll Compressors according to the capacity.

! Electrical Board; All of the elements required for the trouble-proof operation of master switch and device.

! Micro-processor; AC micro-processor control of temperature and relative humidity over all of the operation and safety functions integrally (I) or rational- integrally (PI).

! PCO2 micro-processor of device control and adjustment system which provides remote control terminal with erection inside the clean room.

22/23

Serin

Ho

spita

l Aze

rba

ijan

20

08

24/25

Serin Hospital Azerbaijan

Aze

rba

ijan M

ilita

ry H

osp

ital 3

00

Be

d2

00

7

Laminar flow system

! HEPA filters which clean filtrated air before going into

operating room.

! Mounting situated in ceiling of the operating theatre in

such a way that it should locate over operating table.

! Stainless steel air distribution box, Hepa filters, transparent

air distributor (laminarizator) and pendant operating

table lighting connection.

! Easy maintenance and disinfection because of transparent air distributor's being pulled down. Operating theatre lighting system made up of airproof construction.

! A laminar, vertical air flow from transparent air distributor through operating table prevents turbulent air flow in conventional air systems and offers a high level cleanliness class around the operating table during the operati

! The system which remove particulates and microbes

from operation part due to laminar flow.

! Special design for operation theatres which require

especially high level sterilization in accordance with DIN

1946.

! Differential pressure sensors. Easy connection differential

pressure sensors and leakage testing.

! Easy installation to all kinds of ceilings.

26/27

Azerbaijan Military Hospital 300 Bed

HVAC equipment related to operating theatres are supplied

by GONKA Inc.

Ce

ntra

l Ba

nk

of A

zerb

aija

n R

ep

ub

lic2

00

9

28/29

Central Bank of Azerbaijan RepublicHVAC equipment periodic maintenance are being provided

by GONKA Inc.

HVAC equipment periodic maintenance is being provided

by GONKA Inc.

Aze

rba

ijan M

c D

ona

ld’s

20

02

Azerbaijan Mc Donald’s

Centrifugal roof extracts

Technical specification The manufactured centrifugal roof

extract unit has been designed for the effective exhaust. it is

possible to montage in the desired angle with the small

sound Ievel it may be used in for the industrial applications

and kitchens. It has been designed for Iong service Iife

without maintenance. The manufacturing range 500-

12.000 m³/h air and 0-50 mmSS pressure.

Body It is designed according to the bat environment

conditions Galvanized stell frame, aluminium upper cover

are used. Moto-fan group Cenrifugal ventilatör is statically

and dynamically balanced.Motor serves 380V/50 Hz 900-

1400d/d as astandard and directly coupled with d-phase

electirical motor.By this way, it works quitely and without

vibration.

Fan has dense f imed, low sound level and

highperformance.It is easy to open the fan and clean the

fin at shot notice. By the help aof special protection cover,

itwork many years without any problem. Centrifugal roof

extract units designed as direct extraction or combined

with a duct type.

30/31

Ba

ku S

tate

Univ

ers

ity

20

08

32/33

Baku State University

Air handling unit

Optional Accessories;

! GONKA vapor humidifier, standard vapor cylinder, immersion electrodes, stainless vapor distributor and microprocessor control unit.

! Mufflers which are made up of coulisses to provide required sound holding capacity.

! Plate heat exchanger or Heat recovery wheel for recovery of the heat emitted with exhaust air.

! Electrical board.

! Frequency Converter

Standard Series

Application Area: business centers, schools,

hospitals, factories, hotels and restaurants.

! 8 different models which provide required humidity and

temperature by conditioning air volume in the range of

3000m³/h and 100.000 m³/h.

! The framework which is formed by combination of

aluminum frames, which are connected specially, with

plastic and aluminum comers.

! Boards which are made up of double skilled galvanized

iron in a standard way.

! Polyurethane insulated panels, which are 30 mm in

thickness, for thermal and acoustic insulation in a

standard way.

Standard Accessories;

! Filter Chambers; Chamber design which provides easy mounting and de-mounting in filters and filters with different productivity levels on demand.

! Heating and Cooling Coils; Seamless cooper tubes. In heating coils, 4 options: warm water, vapor, hot water, electrically heated; in cooling coils, 2 options: chilled water and DX (direct expansion).

! Dampers; Rigid aluminum frame in multi airfoil structure which is the least resistant against airflow. Rubber gaskets which reduce air leakage through blades to the minimum level.

! Fans; Statically and dynamically balanced aspirators and ventilators in double inlet belt driven centrifugal type. Forward curved fans in systems with low, medium and high duct pressures,.

Aze

rba

ijan G

ön

ka O

ffic

e a

nd

Sh

ow

roo

m2

00

9

34/35

Azerbaijan Gönka Office and Showroom

! The most important feature of decorative type Fan-Coil

units is their use both with casing and without casing

(concealed) in every position. While ceiling cabinet and

cabinet floor types are mounted inside the room,

concealed types are mounted within ceilings or walls.

Unit models which operate both heating and cooling or

only heating are available.

! Low sound level; quality is high level for providing quiet

study environment.

! Ideal acoustic and thermal insulation.

! Functional remote control.

! 2 or 3-way On/ Off or rational control.

! Outer casing; It is made from DKP sheet steel, outside

and inside of the unit are painted with electrostatic

powder paint against rust and external effects.

! Internal frame; Mounting upon originally designed

framework made from galvanized steel together with

battery, fan, motor group, dried pan and dropper.

! Battery; Copper pipe, aluminum fins.

! Fan and engine group; 1 or 2 fans to provide required

capacity in devices in accordance with capacity table.

Fan coil units

Ata

Oku

l Aze

rba

ijan

20

08

36/37

Ata Okul Azerbaijan

Ha

sano

glu

Furn

iture

Fa

cto

ry2

00

9-2

01

0

38/39

Hasanoglu Furniture Factory

Air Cooled Water Chillers, Chambered Exhaust Fans, Air Handling Units, Roof Extract Fans are manufactured, supplied and installed by GONKA Inc.

Unit heaters with radial fan

GÖNKA GDA series unit heaters are designed to meet the

heating requirements of workshops, warehouses, factories,

stores, garages, sporting halls etc. They are manufactured so

as to be connected either to hot water, superheated water or

steam lines. There are 13 models in order to handle heating

capacities between 4.000-60.000Kcal/h and they are

available in two types; wall mounted and ceiling.

Technical specification Casing Manufactured from

phosphatized steel sheets finished with oven baked

electrostatic paint. Centrifugal fan-motor group As a

standard the centrifugal fans are directly coupled to three-

phase electric motor, which has high starting torque. The fans

are statically and dynamically balanced to ensure vibration

and noise free operation. Air mixing box

In case fresh air intake is necessary, a mixing box is mounted

on the air inlet to provide the required air mixture.Air

discharge louvers In order to direct the airflow to desired

direction adjustable discharge louvers, consisting of parallel

moving flaps and frames, are used. Coil connections

Connection of the coils to the hot water or steam lines is done

easily via coil union stems, manufactured to fit standard

pipes

Organize Sanayi Bölgesi

Göktürk Cad. No:6

Sincan / ANKARA / TURKEY

Tel :0 312 267 09 90 (pbx)

Fax:0 312 267 09 93

FACTORY and MAIN OFFICE

Nerimanov rayonu,

Y. V. Çemenzeminli Sok.

1996-cý mahalle AFEN Plaza

Baku - AZERBAIJAN

Tel / Fax: (00 994) 12 564 07 04

117 Tsereteli avenue

Tbilisi - GEORGIA

Tel: (00 995) 32 921 821

Fax:(00 995) 32 941 120

AZERBAIJAN BRANCH OFFICE

GEORGIA BRANCH OFFICE

GÖNKA Azerbaijan References

- Hövsan Olympic Training Complex

- Baku Turkish Anatolian High School

- Göyçay Olympic Training Complex

- Serin Hotel Baku

- Balaken Olympic Structure

- BÝlesuvar Olympic Structure

- Baku Administration Of The National

Archive Building

- Hb Clinique Baku

- Azerbaijan Baku Endos. Hospital

- Azerbaijan Military Hospital 300 Bed

- Karwan Mtk Azerbaijan

- Ata Okul Azerbaijan

- Serin Hospital Azerbaijan

- Baku Ministry Of Health Topçubaþov

Hospital

- Baku State University Kitchen And

Restaurant