AUTOMOTIVE SA PRICE LIST - FEBRUARY 2016 - · PDF fileautomotive sa price list - february 2016 part number description suggested retail repair kit no suggested retail unloader valves

AUTOMOTIVE SA PRICE LIST - FEBRUARY 2016

INDEX

ABS Components-Truck/Bus 17 Levelling Valves 7

ABS Components-Trailer 17 Lift Axle Control Valves 5

ABS/EBS - Speed Sensors 17 Line Filter 10

Actuator / Hydraulic Actuators 9 Load Regulating Valve 10

Adaptor Valves 10 Load Sensing / Levelling Valve Parts 7

Accessories 20 Load Sensing Valves -Air Susp 7

Air Dryers 3 Load Sensing Valves -Mech Susp 6

Air Processing Units 3 Low Pressure Switches 10

Air Reservoirs 12 Manoevering Valve 8

Air Throttle Valves 9 Multi Circuit Protection Valves 4

Brake Chambers 11 Non-Return Valves 10

Brake Chambers -Disc Brakes 11 Nylon Pipes 14

Cartridges - Desiccant 3 Operating Cylinders 9

Charging Valves 9 Pressure Limiting Valves 9

Clutch Servos 8 Proportional Solenoid valves (Gearbox) 4

Compressors 14 Quick Release Valves 8

Compressor spares 14-16 Raise / Lower Valve 10

Condensor Drain Valves 4 Ratio Valves 7

Couplings (Duomatic) 13 Relay Emergency Valves 6

Couplings (F & J) 13 Relay Valves 6

Couplings (Palm) 13 Rubber Hose 13

Diagnostic Software 19 Safety Valves 10

Diaphragms 12 Shut-Off Cock 10

Door Control Valve 10 Silencers 10

Double Check Valves 10 Slack Adjusters 18

Double Diaphragm Spring Brakes 11 Solenoid Valves 12

Double Diaphragm Spares 12 Spiral Binding 20

Drain Valves 8 Spring Boxes 7

EBS Components - Trailers 18 Spring Brakes 11

EBS Components - Truck 18 Spring Brakes -Disc Brakes 11

EBS Software 19 Spring Brake Spares 11

ECAS Truck Components 5 Stop Light Switches 10

Electrical Suzy 13 Suzy Pipes 13

Exhaust Brake Valves 8 TATA Spares 19

Foot Brake Valves 4 Test Equipment ABS 20

Fittings Compression 21 Test Equipment Pneumatic 20

Fittings Push In 25 Trailer Control Valves 7

Fittings Push In PlasticType 29 Trailer Release Valve (PREV) 10

Gearbox / Control / 3/2-way 9 Unloader Valves 3

Governor Valves 3

Hand Control Valves 5


PART NUMBER DESCRIPTION

SUGGESTED

RETAIL REPAIR KIT NO

SUGGESTED

RETAIL

UNLOADER VALVES

975 303 473 0 NEW GENERATION WITHOUT AIR DRYER PORT 8.1 BAR 1060.56 975 303 001 2 648.88

975 303 474 0 NEW GENERATION FOR USE WITH AIR DRYER 8.1 BAR 1060.56 975 303 001 2 648.88

SERVICE KIT For Unloader /473 0 and /474 0 ASA5698 380.31

GOVERNOR VALVES

975 499 017 0 9.2 BAR D2 GOVERNOR 752.07

AIR DRYERS & APUs

432 410 022 0 AIRDRYER With Unloader 9.5 bar PORT 4/23 NISSAN UD460 5188.04 432 410 001 2 190.64

432 410 002 2 449.79

SERVICE KIT ASA7070 815.77

432 410 083 0 AIRDRYER With Unloader 9.3 bar PORT 4/23 SCANIA WITH HEATER 11145.23 432 410 001 2 190.64

432 410 002 2 449.79

CARTRIDGE (SCANIA) 1 1/4" 13 BAR 432 410 927 2 1154.60


432 410 113 0 AIR DRYER With Unloader 12.5 BAR 4286.63


432 410 117 0 AIR DRYER With Unloader 10 BAR MAN F 2000 3123.11 432 410 002 2 449.79


432 410 200 0 AIR DRYER With Unloader 8.1 BAR + Heater (MAN) 6900.24 432 410 002 2 449.79


432 410 202 0 AIR DRYER With Unloader 8.1 BAR 3551.78 432 410 001 2 190.64


432 410 720 0 AIR DRYER With Unloader 12.5 BAR Without Heater 11801.69

For MAN TGA/TGS/TGL/TGM S/S 432 410 120 0

432 413 003 0 AIR DRYER (ROCKWELL) BACKFLOW 0.7 6961.48 432 413 925 2 239.52

Bypass Valve 432 420 926 2 342.55

Turbo Cut Out valve old number 432 413 928 2 432 413 934 2 586.92

Purge Valve 432 413 929 2 806.60

Regeneration kit 432 413 930 2 NLA


432 415 029 0 DRYER With Unloader 8.3 BAR (E R F) 17793.17 432 415 000 2 2351.99

932 400 001 0 DRYER With Unloader 12 BAR (ACTROS) W/O Heater (W/O Port 4/25) NLA See replacement ….024 0

932 400 002 0 DRYER With Unloader 12 BAR (ACTROS) With Heater NLA See replacement ….024 0

932 400 005 0 DRYER With Unloader 12 BAR (ACTROS) W/O Heater (With Port 4/25) NLA See replacement ….024 0

932 400 024 0 DRYER With Unloader 12 Bar With heater Replaces 010/020/050 5281.12 432 410 001 2 190.64

932 400 000 2 1527.15

932 510 009 0 SCANIA AIRDRYER 34905.38

432 420 220 2 CARTRIDGE (ACTROS) M39 20 BAR 1168.40

432 420 002 0 AIR DRYER WITHOUT UNLOADER M12 CONTROL PORT 4486.38 432 410 002 2 449.79


432 421 008 0 AIR DRYER WITHOUT UNLOADER M16 CONTROL PORT 4376.90 432 410 002 2 449.79


432 425 105 0 AIRDRYER FOR VOLVO S/S 432 425 101 0 11047.25 432 425 920 2 1336.56

932 510 956 2 AIRDRYER SCANIA for 932 510 004/5 0 /6 0 15524.07

AIR DRYER CARTRIDGES

432 410 222 7 CARTRIDGE (STD) M39 x 1.5 13 BAR 427.01

432 410 927 2 CARTRIDGE G 1,1/4 13 BAR SCANIA 1154.60

432 420 220 2 CARTRIDGE M39 x 1.5 20 BAR ACTROS 1168.40

432 901 223 2 CARTRIDGE With Coalescing Filter M39x1.5 13 BAR 1080.80

432 410 244 2 CARTRIDGE Coalescing & Oil Filter M39x1.5 13 BAR (GOLD) 1840.00

3of30



SUGGESTED


SUGGESTED

RETAIL

CONDENSOR DRAIN VALVE

432 511 000 0 CONDENSOR DRAIN VALVE 3034.65 432 511 000 2 1553.84

NYLON FILTER 432 511 220 4 432 511 220 4 184.78

MULTI CIRCUIT PROTECTION VALVES

434 700 003 0 2 CIRCUIT PROTECTION VALVE 5165.87 434 700 003 2 2571.98

934 702 100 0 5 PORT 4 X M16 1 X M22 1542.13

934 702 210 0 7 PORT 6 X M16 1 X M22 2123.69 ASA5735 694.78

934 702 221 0 7 PORT 6 X M16 1 X M22 1475.32 ASA5736 694.78

934 702 250 0 5 PORT 4 X M16 1 X M22 1175.76 ASA5394 499.15

934 702 260 0 5 PORT 5 X M22 (VOSS) 1475.32 ASA5394 499.15

934 702 300 0 5 PORT 4 X M16 1 X M22 1223.53 ASA5391 493.67

934 702 320 0 5 PORT 4 X M16 1 X M22 2518.62

934 705 005 0 PROTECTION VALVE (ACTROS) 8444.48 934 705 001 2 1399.42

932 500 501 1 PRESSOR SENSOR FOR 9347050050 replaces 441 043 504 1 2951.65

934 714 003 0 5 PORT 4 X 3/8" 1 X 1/2" 2535.58

934 714 010 0 5 PORT 4 X M16 1 X M22 1709.08

934 714 110 0 5 PORT 4 X M16 1 X M22 2333.82

934 714 145 0 PROTECTION VALVE FOR VOLVO 5355.81

934 714 211 0 4 WAY PROTECTION VALVE 5009.95

934 714 400 0 PROTECTION VALVE MAN TGA 4261.26

934 714 740 0 7 PORT SUPPLY: 1XM22 DEL M14 4550.11

932 510 958 2 SCANIA PROTECTION VALVE Excluding the PC Board 31302.77

PROPORTIONAL SOLENOID VALVE (GEARBOX, VOITH)

472 260 005 0 PROP Solenoid 13040.22

472 260 011 0 PROP Solenoid 1x M22 Voss 13040.22

472 250 000 0 Proportional Solenoid Valve 6640.85

FOOT BRAKE VALVES W/K 20/01 W/K 21/01

461 315 004 0 MERCEDES 1624 M16 SUP/DEL PORTS M12 GAUGE PORTS 2948.95 461 315 005 2 679.11

SERVICE KIT 461 315 915 2 742.33

461 315 008 0 MERCEDES 1928/2633 M16 SUP/DEL PORTS 0.3 PREDOMINANCE 2425.30 461 315 005 2 679.11

SERVICE KIT 461 315 915 2 742.33

461 315 042 0 VOLVO / SCANIA M16 PORTS 4389.94

461 315 180 0 SCANIA PUSH-IN FITTINGS 8177.31 461 315 907 2 1320.54

SERVICE KIT 461 315 924 2 1490.66

461 315 246 0 FOOT VALVE 12220.56

461 315 263 0 MERCEDES AXOR long Silencer 5088.46

461 315 264 0 MERCEDES AXOR 3282.23

SERVICE KIT 461 315 927 2 3445.09

461 315 497 0 VOLVO/DAF M16 SUP/DEL PORTS M12 GAUGE PORTS 3441.35 461 315 005 2 679.11

SERVICE KIT 461 315 915 2 742.33

461 319 008 0 MERCEDES 2638 M16 SUP/DEL PORTS M12 SIGNAL PORT 6644.93 461 319 007 2 909.21

SERVICE KIT 461 319 908 2 968.72

461 319 250 0 MERCEDES S.K. RANGE/POWERLINER 3343.02 461 319 004 2 1152.26

SERVICE KIT 461 319 905 2 1117.69

461 319 270 0 MERCEDES LN2 Econoliner M22 SUP/DEL Ports M16 Signal Port 3343.02 461 319 002 2 710.66

SERVICE KIT 461 319 903 2 710.66

461 319 271 0 MERCEDES 2933.28

461 319 273 0 MERCEDES AXOR 3897.96

461 319 274 0 FOOT VALVE 3418.40

461 324 001 0 MERCEDES 14/18 Repair for Pneumatic Side Only 461 315 005 2 679.11

461 494 502 0 RENAULT Kerax 7275.68

461 499 005 0 DUAL FOOT VALVE MERCEDES 14424.55

470 012 000 0 MERCEDES 2632 C/W SLAVE CYLINDER M16 PORTS 10450.91 461 307 002 2 596.82

461 307 399 0 FOOT VALVE 12986.95

See Page 16 for EBS Truck Brake Signal Transmitters (Foot valves)

4of30



SUGGESTED


SUGGESTED

RETAIL

ECAS SOLENOID VALVES

472 880 001 0 ECAS 2 POINT SOLENOID 7192.10

472 880 030 0 ECAS SOLENOID - TRAILER ECAS and TRUCKS 8681.06

472 900 053 0 WITH 2 HEIGHT SENSORS 6693.26 472 900 009 2 755.26

472 900 060 0 WITHOUT HEIGHT SENSORS 6693.26 472 900 009 2 755.26

472 905 111 0 ECAS SOLENOID - MAN TGA & DAF TRUCKS LIFT AXLES 10503.24 472 905 004 2 2724.59

472 905 114 0 ECAS SOLENOID - TRAILER LIFT AXLES 11344.74

ECAS HEIGHT SENSORS

441 050 012 0 BAYONET WITHOUT LEVER AND TEMPERATURE COMPENSATION 1516.24

441 050 100 0 ECAS LEVELLING VALVE-TRUCK 1922.86



441 050 123 0 BAYONET WITHOUT TEMP COMPENSATION; CROSS LEVER 1615.75

ECAS PRESSURE SENSORS

441 044 102 0 M16 BAYONET WITH O'RING S/S 4410400150 2469.10

ECAS/ELM REMOTE CONTROL UNIT

446 056 116 0 REMOTE CONTROL UNIT 1963.27

LIFT AXLE CONTROL VALVE

463 084 010 0 ELECTRONICALLY CONTROLLED (TRAILER ABS) On request

463 084 020 0 FULLY AUTOMATIC SINGLE CIRCUIT LIFT VALVE 8977.26

463 084 041 0 FULLY AUTOMATIC SINGLE CIRCUIT WITH 8mm FITTINGS PI 4821.09

HAND CONTROL VALVES

961 701 110 0 3 PORT VALVE M14 POARTS (ANTI-CLOCKWISE) 7164.07


961 701 115 0 3 PORT VALVE M14 POARTS (ANTI-CLOCKWISE) 8432.72

961 702 014 0 4 PORT VALVE M14 PORTS 7837.02


961 703 001 0 4 PORT VALVE WITH BUS STOP POSITION M14 PORTS 8741.29 961 703 000 2 1504.10


961 721 000 0 TRAILER BRAKE -IN PRESS -8.5 BAR / OUT = 7.5 BAR SS 9617210410 3661.74 961 721 004 2 1118.28

961 721 004 0 VALVE WITH HANDLE LOCK (TRAILER BRAKE) 4010.62 961 721 004 2 1118.28

961 721 008 0 2 PORT HAND CONTROL (TRAILER BRAKE) 4166.01 961 721 004 2 1118.28

961 721 040 0 SELF RETURN T.C.2 (TRAILER BRAKE) 4738.39 961 721 004 2 1118.28

961 721 045 0 2 PORT with DUST BOOT 2460.88

961 722 151 0 2 PORT SIDE M14 (MB) 4572.59

961 722 230 0 2 PORT SLIDE (LHD BRACKET) (MB) 4715.29 961 722 002 2 1636.63

961 722 232 0 3 PORT HAND CONTROL & SLIDE TYPE CONNECT (VOSS) M14 4370.64 961 722 003 2 1150.05


961 722 252 0 H/CTRL (LHD BRACKET) 3 PORT M14 3330.73 961 722 003 2 1150.05


961 722 258 0 H/CTRL (CENTRE BRACKET) 3 PORT M14 2956.25 961 722 003 2 1150.05


961 722 264 0 HAND CONTROL 4 PORT M14 4939.69 961 722 004 2 2944.85


961 722 272 0 HAND CONTROL INT. (RHD) 3330.73 961 722 003 2 1150.05


961 722 284 0 4 PORT (RHD BRACKET) (MB) 3466.37 961 722 003 2 1150.05


961 722 288 0 3 PORT (RHD BRACKET) M14 PORTS (MB) 5743.13 961 722 003 2 1150.05


961 722 314 0 3 PORT SIDE M14 (SCANIA) 5326.71

961 723 017 0 PARKING HAND CONTROL 2347.77 961 723 000 2 2347.25

961 723 019 0 2 PORT (CENTRE BRACKET) M16 PORTS (MAN) 2790.96 961 723 000 2 2347.25

961 723 100 0 3 PORT (CENTRE BRACKET) M16 PORSTS (MAN) 4144.58 961 723 000 2 2347.25

961 723 104 0 H/CTRL POWER LINER 3 PORT M16 VOSS (SIDE) 3457.69 961 723 000 2 2347.25

5of30



SUGGESTED


SUGGESTED

RETAIL

HAND CONTROL VALVES Continued……………

961 723 118 0 3 PORT (CENTRE BRACKET) M14 VOSS PORTS (MAN) 2197.37

961 723 124 0 3 PORT (CENTRE BRACKET) M16 PORTS (MB) 3232.12

961 723 125 0 H/CTRL (ACTROS) 3 PORT M16 (SIDE) VOSS 4436.53

961 723 201 0 3 PORTS (BOTTOM) M16 CENTRE BRACKET 4779.18 961 723 000 2 2347.25

961 723 203 0 3 PORT (CENTRE BRACKET) M16 PORTS 3366.24 961 723 000 2 2347.25

961 723 213 0 3 PORTS (BOTTOM) M16 CENTRE BRACKET 4374.06

961 723 405 0 H/CTRL 2 PORT M16 (BOTTOM) 2993.14 961 723 001 2 1516.63

961 723 426 0 H/CTRL MAN TGA WITH ELECTRICAL PLUG 5765.21

M302890 HAND CONTROL VALVE 2 PORT WITH LOCK POSITION 911.69

RELAY VALVES

280375 R6 VALVE 753.22

472 195 031 0 ABS SOLENOID RELAY VALVE (TRAILER) 2916.30

480 202 004 0 EBS RELAY VALVE (ACTROS) 9180.31

973 001 010 0 M22 PORTS SQUARE RELAY VALVE 899.75 973 001 000 2 494.05

ASA5198 89.17

973 001 020 0 M16 PORTS SQUARE RELAY VALVE 899.75 973 001 000 2 494.05

ASA5198 89.17

973 001 220 0 M16 SQUARE RELAY VALVE 2061.08 973 001 002 2 NLA

973 003 007 0 M22 SQUARE RELAY (MAN) 3509.69

973 006 001 0 PLASTIC WITHOUT SILENCER M22/M22/M16 VOSS 1411.52

973 006 003 0 PLASTIC WITH SILENCER M22/M22/M16 VOSS 1059.53

973 011 000 0 PORT 1 & 2 M22, PORT 4 M16, NO SILENCER 991.36 ASA7168 106.05

973 011 001 0 M22 PORTS (MAN / SCANIA) PORT 1&2 M22 VOSS/PORT 4 M16 1389.56 ASA7168 106.05

973 011 022 0 3/8" PORTS WITH FLANGE FREIGHTLINER 1517.81 ASA7168 106.05

973 011 050 0 M22 SUPPLY PORTS / DEL PORTS M16 989.16

973 011 200 0 MAN / SCANIA 1374.81 ASA7168 106.05

973 011 206 0 RENAULT PORT 1 & 2 M22, PORT 4 M16, 2350.92

973 011 300 0 ACTROS 2112.51

480 202 005 0 RELAY VALVE(ACTROS) - 8X4 7710.50

480 205 104 0 SOLENOID RELAY VALVE 2099.48

RELAY EMERGENCY VALVES

281672 RE6 VALVE 930.81 266784 355.12

471 005 020 0 RELAY EMERGENCY VALVE On request

971 002 150 0 RELAY EMERGENCY VALVE 4093.18 971 002 003 2 2236.97

971 002 300 0 RELAY EMERGENCY VALVE 4343.29 971 002 008 2 1968.97

971 002 900 0 PARK RELEASE EMERGENCY VALVE (PREV VALVE) 3163.90

LOADSENSING VALVES (MECHANICAL SUSPENSION)

475 702 022 0 LOAD SENSING VALVE / MECHANICALLY CONTROLLED 8320.74

475 710 008 0 M22 PORTS PORT 4 M16 On request 475 710 001 2 983.95


475 710 012 0 M22 PORTS VOSS PORT 4 M16 VOSS (MAN L2000 / M2000 / M2000L) 5506.70

475 710 016 0 M22 VOSS PORTS PORT 4 M16 VOSS (MAN) 3517.62 475 710 001 2 983.95


475 710 020 0 DYNAMIC M16 PORTS 4059.23 475 710 001 2 983.95


475 710 024 0 RELAY LOAD SENSING IVECO PORT 1 M22, 2 & 4 M16 9679.60 475 710 001 2 983.95


475 710 036 0 RELAY LOAD SENSING DYNAMIC 22 DIA DEL. PORTS 2562.14 475 710 001 2 983.95


475 710 128 0 PORT 1 M22. PORT 2 M16 (VOLVO FH12 / FH16) 6194.10

475 710 136 0 M16 VOSS PORTS PORT 1 M22 VOSS (MERCEDES) 4626.85 475 710 001 2 983.95


475 713 501 0 PORT 1/4 M22. PORT 2 M16 Static Valve 2945.23

475 720 003 0 NEW GENERATION MINI LSV DAF 5441.09


475 720 005 0 NEW GENERATION MINI LSV 3409.09

6of30



SUGGESTED


SUGGESTED

RETAIL

LOAD SENSING VALVE (AIR SUSPENSION)

475 711 024 0 CONTROL PRESSURE 0.6 TO 4.3 BAR 4610.25 475 711 000 2 1847.72

475 711 096 0 CONTROL PRESSURE 0.45 TO 6.1 BAR 5941.27 475 711 000 2 1847.72

475 711 115 0 CONTROL PRESSURE 0.6 TO 4.3 BAR 5339.72

475 711 118 0 CONTROL PRESSURE 0.5 TO 3 BAR 6609.53 475 711 000 2 1847.72

475 714 510 0 CONTROL PRESSURE 0.4 TO 3.6 BAR 3359.49

475 721 000 0 M16 PORTS PORT 22 M22 (DAF SCANIA) 0.5 TO 4.7BAR 4831.64


475 721 008 0 NEW GENERATION MINI LSV AXOR 11328.71

475 721 009 0 NEW GENERATION MINI LSV AXOR 5407.25

884 503 224 0 LOADSENSING VALVE 6785.53

LOAD SENSING / LEVELLING VALVE SPARES

433 300 381 4 LINK CONNECTION (RUBBER STRAIGHT) 73.85

433 300 383 4 LINK CONNECTION (RUBBER L SHAPE) 80.32

433 300 385 4 LINK CONNECTION (RUBBER L SHAPE) LEVELLING 231.62

433 401 380 4 RUBBER LINK (464 002 … 0) LEVELLING VALVE 206.31

464 002 730 2 METAL ARM (464 002 … 0) LEVELLING VALVE 393.11

475 701 712 2 LOAD SENSING ARM WITH RUBBER LINK 246.31

475 710 130 4 ROLLER (475 710 … 0) 15.91

475 710 770 4 PLASTIC PLUNGER (475 710 … 0) 53.30

A5349LSU LSU COILED ARM 468.88

A5426 BRACKET (SPRINGBOX MOUNTING/SINGLE AXLE) 114.02

A5427 BRACKET (SPRINGBOX BOUNTING/TANDEM AXLE) 68.37

ASA5080 LINKAGE KIT LSV TANDEM AXLE 354.99

ASA5081 LINKAGE KIT LSV SINGLE AXLE 279.45

433 401 003 0 LINKAGE KIT Levelling Valve 184.00

441 050 718 2 Flat Arm for ECAS Distance Sensor / Levelling Valve 567.52

475 713 710 2 Arm and Cable for 475 713 … 0 Mechanical LSV 1247.35

A6356 DATA PLATE -MECHANICAL/AIR SUSPENSION VALVE 66.53

SPRING BOXES

433 302 002 0 (260MM LONG) 20-35N With Rubber Connector 514.27

433 302 008 0 (160MM LONG) 40-100N With Knuckle Joint 1128.30

433 302 014 0 (220MM LONG) 26-47N WithOUT Rubber Connector 628.15

433 302 026 0 (220MM LONG) 449-145N With Rubber Connector 697.62

RATIO LOAD VALVES

473 300 001 0 3.3:1 RATIO VALVE 5378.60

473 300 004 0 1.5:1 RATIO (EXTRA CONTROL PORT 4) 5975.98

473 301 000 0 2:1 RATIO 4103.51

473 301 001 0 1.5 :1 RATIO 3590.14

473 301 002 0 1.35 :1 RATIO 4338.66

TRAILER CONTROL VALVES

480 204 002 0 ACTROS/ NISSAN/ DAF E.B.S. (REPLACES 001 0 VARIANT) 7108.15

973 002 000 0 WITH SPRING BRAKE PORTS (M22) NO DUMP 6147.53 ASA5741 416.87

973 002 430 0 (M16) PORT NO DUMP NO PREDOMINANCE 3845.00 ASA5741 416.87

973 002 521 0 WITH DUMP VALVE (M16) PREDOMINANCE .2 BAR (Adjustable) 2748.19 ASA5741 416.87

973 009 001 0 WITH DUMP VALVE (M22 VOSS) POWERLINER 3476.16 973 009 000 2 1320.05

973 009 006 0 WITH DUMP VALVE (M22 VOSS) MAN 3476.16 973 009 000 2 1320.05

973 009 014 0 WITH DUMP VALVE (M16) PREDOMINANCE 0,4 BAR (Adjustable) 4863.20 973 009 000 2 1320.05

973 009 015 0 WITH DUMP VALVE (M16) VOLVO 0.1 PREDOMINANCE 4863.20 973 009 000 2 1320.05

973 009 010 0 WITH DUMP VALVE (M16) 0.2 PREDOMINANCE 6055.86

LEVELLING VALVES

464 002 330 0 2 STAGE (INT) WITH ARM (VOLVO/IVECO) 2126.80 464 002 008 2 533.68

464 002 440 0 2 STAGE -WITH ARM (M.A.N.) 2665.79 464 002 008 2 533.68

464 006 002 0 2 STAGE -WITH ARM (M.A.N./B.P.W.) 1903.27 464 006 000 2 1054.98

464 006 100 0 2 STAGE -WITH ARM (DAF/TRAILER) 2618.77

464 007 001 0 CAB SUSPENSION (PUSH-IN) 2272.72

464 007 010 0 CAB SUSPENSION (M10 X 1) 2514.90

7of30



SUGGESTED


SUGGESTED

RETAIL

CLUTCH SERVOS

970 051 111 0 M.A.N. (STROKE 85MM / DIA 80.5MM) 5413.55 970 051 905 2 NLA

970 051 114 0 HINO/FIAT (STROKE 67MM / DIA 80.5MM) 5809.94 970 051 904 2 2891.21

BOOT 897 754 882 4 176.69

970 051 126 0 NISSAN/HINO (STROKE 85MM / DIA 80.5MM) 4273.46 970 051 904 2 2891.21

BOOT 897 754 882 4 176.69

970 051 127 0 CLUTCH SERVO SCANIA (STROKE 58.5MM / DIA 108MM) 8341.29 970 051 906 2 2891.21

BOOT 897 754 882 4 176.69

970 051 128 0 CLUTCH SERVO MERC. (STROKE 58.5MM / DIA 108MM) 12788.20 970 051 906 2 2891.21

BOOT 897 754 882 4 176.69

970 051 131 0 MERCEDES (STROKE 72MM / DIA 90MM) 8204.10 970 051 903 2 1038.40

M B HOUSING … 131 0 SERVO 970 051 527 2 1163.83

GUIDE …131 0 SERVO 970 051 371 4 NLA

BOOT 897 754 320 4 120.56

970 051 151 0 MERCEDES (STROKE 72MM / DIA 90MM) 13289.85 970 051 917 2 6244.40

970 051 157 0 CLUTCH SERVO MAN (STROKE 85MM / DIA 108MM) 12075.00 970 051 911 2 NLA

970 051 159 0 MERCEDES (NEW GENERATION) (STROKE 85MM / DIA 108MM) 10664.66 970 051 916 2 2909.83

970 051 164 0 MERCEDES LN2 (STROKE 85MM / DIA 108MM) 6076.75 970 051 945 2 #N/A

BOOT 897 754 882 4 176.69

970 051 406 0 MAN F2000 (STROKE 85MM / DIA 75MM) 5591.41 970 051 952 2 6298.43

970 051 412 0 CLUTCH SERVO FOR MAN TGA –MINERAL OIL 10304.53 970 051 971 2 4772.07

970 051 414 0 MAN F2000 (STROKE 85MM / DIA 108MM) 4757.82 970 051 961 2 2785.02

BOOT 897 754 882 4 176.69

970 051 424 0 HINO 700 (STROKE 85MM / DIA108MM) 6426.97 970 051 961 2 2785.02

BOOT 897 754 882 4 176.69

970 051 431 0 ACTROS (STROKE 85MM / DIA 102MM) Kit Includes Main Seal 6398.90 970 051 974 2 3951.18

BOOT 897 754 882 4 176.69

970 051 432 0 CLUTCH SERVO MAN TGM (STROKE 85MM/DIA 80MM) MINERAL OIL 12765.51

970 051 435 0 MAN (STROKE 85MM / DIA 75MM) 9742.91 970 051 970 2 3125.93

BOOT 897 754 882 4 176.69

970 051 438 0 CLUTCH SERVO FOR RENAULT (INCL. 3/2 DIR. CONTR. VALVE) 13425.85 970 051 984 2 4493.29

970 051 439 0 CLUTCH SERVO FOR MAN (STROKE 25 / DIA 108MM) 11583.71 970 051 984 2 4493.29

970 051 441 0 ACTROS/AXOR - MINERAL OIL Kit Excludes main Seal 7317.85 970 051 987 2 1029.32

970 150 001 0 ACTROS MP11 (Alternative for 9701500020) 19779.71 970 150 000 2 5316.69

NOTE: SPECIAL INSTALLATION INSTRUCTIONS

970 051 187 0 CLUTCH SERVO 7290.44

DRAIN VALVES

SF1280 MANUAL DRAIN VALVE 1/4"NPTM 63.99

934 300 003 0 MANUAL TILT TYPE M22 82.89

934 300 006 0 MANUAL DRAIN VALVE 1/2" NPT 153.50

934 301 000 0 AUTO DRAIN VALVE M22 1273.43

934 301 003 0 AUTO DRAIN VALVE M22 1343.48

QUICK RELEASE VALVES

973 500 000 0 M22 PORTS 296.70

973 500 014 0 1/2" X 3/8" X 3/8" PORTS 361.30

973 500 031 0 POWER LINER M22 (VOSS) (4 PORT) 594.22

973 500 051 0 WITH ANTI-COMPOUND, DOUBLE CHECK VALVE FOR EBS TRAIL. 1078.41

MANOEUVERING VALVES

ASA1689 PUSH AND HOLD TYPE WITH FITTINGS 1135.04

EXHAUST BRAKE VALVES

463 013 111 0 SHORT STEM -2 X M12 PORTS WITHOUT LOCK NUT 599.31 ASA5705 85.12

463 013 112 0 SHORT STEM -2 X M12 PORTS WITHOUT LOCK NUT 591.55 ASA5705 85.12

463 013 114 0 LONG STEM -2 X M12 PORTS WITHOUT LOCKNUT 591.55 ASA5705 85.12

463 013 116 0 SHORT STEM -2 X M12 PORTS WITH LOCKNUT 706.68 ASA5705 85.12

463 013 130 0 SHORT STEM -3 X M16 PORTS (VOSS) WITHOUT LOCKNUT 852.79

463 013 200 0 SHORT STEM -3 X M16 PORTS (VOSS) WITHOUT LOCKNUT 989.14

463 013 210 0 SHORT STEM -2 X M16 -1 X M12 PORTS (VOSS) WITHOUT LOCKNUT 982.00

891 500 464 4 LOCK NUT M26 14.00 19.25

8of30



SUGGESTED


SUGGESTED

RETAIL

OPERATING CYLINDERS

421 411 070 0 CYLINDER - DIA 35MM, STROKE 85MM 2341.66



421 429 003 0 A.D.E. CYLINDER 407/400 / DIA : 28MM -STROKE 48MM 1755.48

AIR THROTTLE

361 064 050 0 AIR THROTTLE VALVE 10471.61 361 050 000 2 330.93

DIAPHRAGM FOR (423 020 016 0) 897 121 030 4 1264.68

ACTUATOR / SERVO UNITS

425 307 012 0 ACTUATOR 100MM X 80MM STROKE 10477.96 425 307 000 2 1279.88

AGA199 MADE UP 425 307 012 0 + CLEVIS 10477.96

921 399 025 0 AIR/HYDRAULIC ACTUATOR 7873.69

974 010 006 0 SERVO MASTER SUPERCEDED TO 974 010 008 0 NLA

974 010 008 0 SERVO MASTER MAN TGL (WITH MASTER CYLINDER) on request

GEARBOX VALVES / DIRECTIONAL CONTROL VALVES

463 022 020 0 VALVE M10 PORTS 1744.35

463 036 001 0 DIFLOCK M10 PORTS WITH KNOB WITHOUT LOCKNUT 736.85

463 036 010 0 M16 VOSS PORTS WITHOUT KNOB WITHOUT LOCKNUT 811.81

463 036 016 0 DIFF LOCK SWITCH (M28 MOUNTING) 1268.90

463 037 001 0 M10 4/2 CONTROL VALVE WITHOUT HANDLE & LOCKNUT 1411.66

463 039 006 0 DAIMLER ZF BOX 4161.70 463 039 000 2 NLA

463 063 002 0 5/2 RANGE CHANGE (DAIMLER) Port 22: RHS 5369.89 463 063 000 2 1789.49

463 063 003 0 5/2 RANGE CHANGE (MAN) Port 22: LHS 5799.48

563 020 000 0 3/2 CONTROL VALVE (MAN) -M10 2257.01

571 040 000 0 3/2 CONTROL VALVE 3 X M14 -1 X M10 1566.93

891 500 520 4 M28 LOCKNUT FOR 463 037 001 0 160.10

899 851 810 4 HANDLE FOR 463 037 001 0 301.82

A5821 WASHER FOR M28 LOCKNUT 48.35

ASA5910 MADE UP 463 036 001 0 & WASHER & NUT 963.20

CHARGING VALVES

434 100 023 0 5.5 BAR WITH BACKFLOW (M22) 642.04 ASA5699 101.66

434 100 024 0 6.0 BAR WITH BACKFLOW 760.59 ASA5699 101.66

434 100 122 0 4.5 BAR WITHOUT BACKFLOW (M22) 502.64 ASA5699 101.66



434 100 220 0 4.5 BAR WITH LIMITED BACKFLOW (M22) 608.83 ASA5700 NLA

434 100 222 0 6.2 BAR WITH LTD BACK FLOW 1071.44 ASA5700 NLA




PRESSURE LIMITING VALVES

475 009 008 0 SET AT 0.7 BAR (MAN) 1795.62

475 009 026 0 SET AT 3.0 BAR 2533.87

475 010 010 0 PRESSURE LIMITING VALVE (3.5 TO 6 BAR) 2305.13

475 010 300 0 SET AT 8.5 BAR (MAN) 895.24

475 010 301 0 SET AT 10.0 BAR (MAN) 1031.10

475 010 333 0 PRESSURE LIMITING VALVE MAN TGA. 1473.01

475 010 400 0 SET AT 8 BAR (DAF) 1643.57 475 010 002 2 1069.83

475 015 001 0 SET AT 7.4 BAR (MAN- MERCEDES) 1284.36 475 015 001 2 477.02

475 015 004 0 PRESSURE LIMITING VALVE (SET AT 3.5 BAR) (MAN- Merc) 881.22 475 015 001 2 477.02

475 015 009 0 PRESSURE LIMITING VALVE (SET AT 5.3 BAR) (Renault) 1155.15 475 015 001 2 477.02

475 015 061 0 PRESSURE LIMITING VALVE (SEE 421 355 931 2 kit) ZF Gearbox see kit 421 355 931 2 4603.25

9of30



SUGGESTED


SUGGESTED

RETAIL

DOUBLE CHECK VALVES

434 208 024 0 VALVE WITH 3/8"NPT PORTS 596.15

434 208 029 0 VALVE WITH INTEGRAL BRACKET (M22) PORTS 382.02

NON-RETURN VALVES

434 014 000 0 M22 PORTS 227.36

SAFETY VALVES

434 612 004 0 ACTROS M22 13 BAR 450.60

SHUT OFF COCKS

452 002 132 0 M22 WITH EXHAUST 180º 485.30

LOAD REGULATING VALVE

475 800 301 0 OPERATING PRESSURE 7.35 BAR (M22) 7973.12 475 800 004 2 1926.48

LOW PRESSURE SWITCH

441 014 004 0 L.P. SWITCH 5.5+0.6 Bar (M12) Normally Closed 532.39






AGA987 L.P. SWITCH 4.5Bar 1/4" NPT Normally Closed 563.69

ADAPTOR VALVES

975 001 000 0 0.6 TO 0.8 BAR 1183.76

975 002 001 0 1 TO 1 RATIO AT 5.8 BAR 2856.70

975 002 017 0 1 TO 1 RATIO AT 4 BAR 2571.98

DOOR CONTROL VALVE

472 017 480 0 24V M12 PORTS 7374.88 472 017 000 2 2604.80

SILENCERS

432 407 060 0 M22 -13 BAR SCREW ON 181.97

432 407 070 0 SNAP-ON -11 BAR 234.65

RAISE / LOWER VALVE

463 032 020 0 SUPPLY -M16. DEL -M12 3147.39

TRAILER RELEASE VALVE

963 001 051 0 PARK / SHUNT VALVE 4011.66

971 002 900 0 PREV (Park Relay Emergency Valve) EBS Trailer systems 3163.90

STOP LIGHT SWITCH

262625 STOPLIGHT SWITCH 1/4"NPT 1107.44

441 014 001 0 STOPLIGHT SWITCH 2 BAR (M12) 506.72

441 014 019 0 STOPLIGHT SWITCH 0.15 BAR (M12) 925.77

441 014 021 0 STOPLIGHT SWITCH 0.5 BAR (M12) 433.54

LINE FILTER

432 500 020 0 LINE FILTER M22 X M22 227.70

10of30



SUGGESTED


SUGGESTED

RETAIL

BRAKE CHAMBERS

AGA109 TYPE 20 756.96

AGA339 TYPE 12 1100.43

AGA448 TYPE 24 LONG STROKE REPLACES AGA351 460.00

AGA449 TYPE 30 LONG STROKE REPLACES AGA354 840.08

423 105 111 0 T20 WITH STUDS 1843.55

423 106 292 0 T24 WITH STUDS 2156.85

423 107 900 0 T30 (M16 PORTS) 1471.01

423 109 001 0 T27 WITH STUDS 2466.46

423 205 101 0 T20 WITHOUT STUDS 2362.68

423 206 700 0 T24 WITHOUT STUDS On Request

423 206 701 0 T24 WITHOUT STUDS On Request

BRAKE CHAMBER (DISC BRAKE)

423 104 710 0 T16 2002.60

SPRING BRAKES / TRI-STOP

925 320 502 0 TRISTOP TYPE 20-30 WELDED PUSH ROD 8450.06 925 320 002 2 497.35

925 321 463 0 Springbrake 8781.91

925 321 473 0 Springbrake 8781.91





925 424 100 0 TRI-STOP TYPE 16-24 WELDED PUSH ROD 4156.63

925 424 101 0 TRISTOP TYPE 16-24 WELDED PUSH ROD 4532.19

425 451 052 0 TRISTOP TYPE 24-24 WEDGE TYPE RIGHT - NISSAN 10697.98

425 451 053 0 TRISTOP TYPE 24-24 WEDGE TYPE LEFT - NISSAN 10697.97

925 490 902 0 TRISTOP TYPE 20-24 WELD PUSH ROD REPLACES 925 420 902 0 7415.84 925 320 001 2 488.31

925 490 041 0 UNIVERSAL TYPE 16-24 NO Clevis, nuts and washers, see AGA432 5976.63



925 492 102 0 UNIVERSAL TRISTOP TYPE 30-30 5331.66

AGA431 UNVERSAL (9254909250) 20-24 with Clevis, nuts and washers 5255.40

AGA430 UNVERSAL (9254911410) 24-24 with Clevis, nuts and washers 6203.36

AGA432 UNIVERSAL (9254940410) 16-24 with Clevis, nuts and washers 5976.63

SPRING BRAKES (DISC BRAKES)

925 424 800 0 TRISTOP TYPE 16-16 (M22 VOSS) LHS 4750.36

925 424 801 0 TRISTOP TYPE 16-16 (M22 VOSS) RHS 4750.36

925 426 200 0 TRISTOP TYPE 14-16 (M22 VOSS ) LHS 4502.18

925 426 201 0 TRISTOP TYPE 14-16 (M22 VOSS ) RHS 4502.18

925 480 004 0 TRISTOP TYPE 20-24 (M22 VOSS) 5953.79


925 481 013 0 TRISTOP TYPE 24-24 (M22 VOSS) RHS 5875.54

925 488 012 0 TRISTOP TYPE 14-24 (M22 VOSS) RHS On request


925 488 020 0 TRISTOP TYPE 14-24 (M22 VOSS) RHS On request

925 488 021 0 TRISTOP TYPE 14/24 (M22 VOSS) On request

SPRING BRAKES/DOUBLE DIAPHRAGM

AGA445 DOUBLE DIAPHRAGM TYPE 24/30 LS REPLACES AGA349 1898.36

AGA447 DOUBLE DIAPHRAGM TYPE 30/30 L S REPLACES AGA350 2336.46

SPRINGBRAKE SPARES

895 801 513 2 M16 X 14MM PIN CLEVIS 150.02

897 750 980 4 DUST BOOT (1 HOLE) 53.20

897 751 010 4 DUST BOOT (1 X LARGE HOLE) 53.20

897 753 261 4 DUST BOOT (2 HOLE) 77.87

925 321 010 2 TYPE 16/24 REAR HOUSING (STEEL) 896.47



A5803 DUST BOOT MAXI BOOSTER T24 252.30

ASA6194 KIT MAXI BOOSTER T24 442.10

11of30



SUGGESTED


SUGGESTED

RETAIL

DOUBLE DIAPHRAGM SPARES

A5948 CENTRE SEAL KIT 32.48

ASA1779 T24 PUSH ROD 109.69

ASA1780 T30 PUSH ROD 132.22

ASA5267 5/8" CLEVIS X 1/2" PIN 170.53

ASA6294 CLEVIS M16 X 1.5 X 1/2" PIN 149.32

895 801 513 2 CLEVIS M16 X 1.5 X 1/2" PIN 150.02

ASA6868 LONG CLEVIS 5/8" Thread X 1/2" PIN 174.76

DIAPHRAGMS

897 121 030 4 TYPE 3 1264.68

234433M TYPE 9 NLA

234226M TYPE 12 NLA

897 121 610 4 WABCO TYPE 14 322.46

A6447 TYPE 16 121.21

897 120 510 4 WABCO TYPE 16 222.03

A6448 TYPE 20 121.21

897 120 520 4 WABCO TYPE 20 226.71

897 120 525 4 TYPE 20 DEEP DISH 728.47

A2400 TYPE 24 65.65

897 120 530 4 WABCO TYPE 24 259.39

897 120 536 4 TYPE 24 DEEP DISH 473.94

897 121 925 4 TYPE 27 683.70

A3000 TYPE 30 72.22

897 120 540 4 WABCO TYPE 30 309.50

897 120 546 4 WABCO TYPE 30 LONG STROKE 326.68

234362M TYPE 36 NLA

SOLENOID VALVES

472 070 639 0 (24V M16 PORTS) NORMALLY CLOSED 1360.75

472 090 202 0 (24V 1/4" PORTS) NORMALLY CLOSED 1899.39

472 102 040 0 24V NORMALLY OPEN 3560.07

472 132 198 0 (24V M12 PORTS) NORMALLY CLOSED 2181.08

472 170 600 0 24V NORMALLY CLOSED M12 (Kostal) 1393.24

472 172 600 0 24V NORMALLY CLOSED M12 (Kostal) 2593.15

472 172 620 0 24V NORMALLY CLOSED M12 2535.40

472 172 626 0 24V NORMALLY CLOSED 1180.18

472 172 686 0 24V NORMALLY CLOSED DAF 1139.08

472 173 700 0 24V NORMALLY OPEN 3193.52

472 174 504 0 24V NORMALLY CLOSED M12 5350.22

472 176 316 0 24V NORMALLY OPEN M16 ACTROS/DAF 2184.27

472 172 606 0 24V NORMALLY CLOSED Bayonet 1118.65

AIR RESERVOIRS

8" DIA (203MM) Length

AGA179 5 LITRE RESERVOIR 816.53 195MM

051010004M 10 LITRE RESERVOIR 957.30 355MM



A6104 TANK STRAP 8" DIA (SINGLE) 129.55

11" DIA (276MM)





1675062M TANK STRAPS 11" DIA. (PAIR) 253.98

390mm DIA

A6741 FATBOY 90 LITRE RESERVOIR 3698.75

A6742 FATBOY TANK STRAPS (PAIR) 761.24

12of30



SUGGESTED


SUGGESTED

RETAIL

F & J COUPLINGS AND SPARE PARTS

Standard

0520010022 1/2" Female std 77.28

A6722 M22 x 1.5 Female with striker plug assembled Trailer 146.97

APSA1519 1/2" Female with striker plug assembled Trailer 94.88

A6723 M22 Female F&J with short stem shut off valve Truck 246.10

0520010062 1/2" Female F&J with short stem shut off valve Truck 158.70

0520003005 M16 x 1.5 Female F&J with short stem shut off valve Truck 176.36

ASA531/2 1/2" Female F&J with short stem shut off valve Truck 227.70

0520010032LB 1/2" Short stem Shut off valve only With Long Body 122.35

0520020032LB M22 Short stem Shut off valve only With Long Body 163.14

4000 M22 Female Coupling with short Stem Shut Off Valve NEW EURO SPEC 863.17

4625 M22 x 1.5 Female F&J + Striker NEW EURO SPEC 445.88

0520000014 1/2" Male Coupling std Trailer 36.74

0520000024 M22 x 1.5 Male Coupling std Trailer 66.14

0520030052 1/2" Male F&J with long stem shut off valve Truck 94.69

0520030062 1/2" Male F&J with long stem shut off valve Truck 410.23

A6704 M22 x 1.5 Male F&J with long stem shut off valve Truck 164.12

0520001005 M16 x 1.5 Male F&J with long stem shut off valve Truck 128.60

0520030012 1/2" long stem Shut off valve only 61.57

0520030012LB 1/2" long stem Shut off valve only With Long Body 122.35

0520030112LB M22 long stem Shut off valve only With Long Body 163.14

AP11168 1/2" STRIKER PLUG / Operating Plug 41.46

4072 M22 Male Coupling with Shut Off Valve NEW EURO SPEC 583.07

4001 M22 x 1.5 Male Coupling NEW EURO SPEC 102.89

A5776 M22 x 1.5 STRIKER PLUG 50.21

0520030022 Dust cover (Female dummy) for male couplings with Chain and bracket 178.75

0520030142 Dust Flap Nylon for Female Couplings 32.33

1178075 Dust Plug male for female couplings with chain and bracket 150.00

A1121 Service Tag 13.97

A1122 Emergency Tag 13.97

0520030152 Plastic Mounting Bracket 20.21

PALM COUPLINGS

897 550 020 4 REPLACEMENT SEAL (PALM COUPLING) 24.50

952 200 021 0 EMERGENCY PALM (TRAILER) COUPLING 272.42

952 200 022 0 SERVICE PALM (TRAILER) COUPLING 272.42

952 200 221 0 EMERGENCY PALM (TRUCK) COUPLING 437.06

952 200 222 0 SERVICE PALM (TRUCK) COUPLING 437.06

DUOMATIC COUPLINGS

452 802 009 0 M16 X 1.5 TRUCK 3089.80

452 804 012 0 M16 X 1.5 TRAILER 660.92

ELECTRICAL SUZY

AGA347 7 PIN COIL & PLUGS ISO 7638 2157.23

A7184 7 PIN COIL & PLUGS ISO 7638 ABS/EBS SMALL COIL 3.5m (ADR) 1807.80

AGA348 15 PIN ISO 12098 COIL WITH PLUGS 3535.23

A7185 15 PIN ISO 12098 COIL WITH PLUGS SMALL COIL 3.5m (ADR) 2587.50

A7186 GREEN MAMBA - THE ORIGINAL ONE ! 7pin Venter type plug 3.5m 747.50

AGA780 15 pin ISO to 12v 7pin Venter type plug 3.5m 3404.00

A7187 15 pin ISO to 12v 7pin Venter type plug 3.5m IMPORTED 1943.50

A6698 7 PIN FEMALE SOCKET EASY CONNECTION 538.66

A6699 7 PIN MALE PLUG EASY CONNECTION 538.66

A6701 15 PIN MALE PLUG EASY CONNECTION 1043.16

A6700 15 PIN FEMALE SOCKET EASY CONNECTION 873.57

RUBBER HOSE

A3626 1/2" S.A.E. SPEC. HOSE PER METRE (SAE J1402) 79.46

SUZY PIPES

ASA5477 RED SUZI WITH SPRINGS & 1/2" FITTINGS 368.00

ASA5478 YELLOW SUZI WITH SPRINGS & 1/2" FITTINGS 368.00

A7188 NEW GENERATION SUZI black Red tail 4.0m M18 fitting* 457.70

A7189 NEW GENERATION SUZI black Yellow tail 4.0m M18 fitting* 457.70

* Kink proof from Twisting, Memory coil

13of30



SUGGESTED


SUGGESTED

RETAIL

NYLON PIPES Prices are indicated Per/ Metre

828 251 908 6 06 BLACK 15.84

A6038 06 RED 15.84

A6041 06 YELLOW 15.84

A6119 06 BLUE 15.84

A6245 06 GREEN 15.84

828 251 907 6 08 BLACK 20.88

A5914 08 RED 20.88

A6244 08 YELLOW 20.88

A6241 08 BLUE 20.88

A5912 08 GREEN 20.88

828 251 906 6 010 BLACK 27.67

A3005/N/10R 010 RED 29.34

A3005/N/10SY 010 YELLOW 29.34

A5606 011 BLACK (PUSH ON) 54.29

A5632 012 RED 45.48

A5633 012 GREEN 45.48

A5634 012 YELLOW 45.48

A5635 012 BLUE 45.48

A5782 012 BLACK 45.48

A5607 013 BLACK (PUSH ON) 59.47

828 251 904 6 015 BLACK 63.92

COMPRESSORS

411 003 011 0 SINGLE 150CC COMPRESSOR (SELF LUBE) 18151.92

411 034 501 0 NLA REPLACED BY 411 142 711 0 NLA

411 141 000 0 SINGLE 75MM BORE COMPRESSOR (MONO BLOCK) 15481.69

411 142 711 0 SINGLE 90MM BORE COMPRESSOR (M/BENZ) 11255.45

411 145 507 0 SINGLE 75MM BORE (MAN) 12676.16

411 151 008 0 SINGLE 85MM WATER COOLED (M/BENZ) On request

411 154 004 0 SINGLE 85MM BORE (ACTROS/ATEGO) REPLACES 411 154 003 0 12982.35

411 553 003 0 COMPRESSOR FOR ATEGO BUS S/S 411 553 001 0 38012.91

412 100 806 2 MAN HEAD ONLY (F2000) NO GASKET S/S 412 100 805 2 3346.13

412 352 003 0 SINGLE 85MM BORE (MAN) 11267.70

412 352 027 0 AXOR COMPRESSOR ESS 11984.18

912 110 140 4 Mounting Flange gasket for 412 352 027 0 220.46

412 704 008 0 TWIN 85mm Bore (VOLVO) with ESS 5 Hole Mount (20701801) 21065.70

412 704 014 0 COMPRESSOR FOR VOLVO FM 9 with ESS 5 Hole Mount (20842990) 34342.53

911 155 521 0 COMPRESSOR CUMMIN'S ISC ENGINE 16577.79

911 504 506 0 COMPRESSOR FOR DAF 95X S/S 911 504 504 0 ESS 19044.63

911 505 150 0 TWIN COMPRESSOR VOLVO FL7 3 Hole Mount centre 20593.27

911 506 505 0 TWIN 75MM BORE (IVECO) 27800.31

912 117 000 0 MAN COMPRESSOR 14268.34

912 510 103 0 TWIN 85mm Bore (AXOR) REPLACES 912 510 104 0 (move plug) 34040.00

912 510 104 0 TWIN 85mm Bore (AXOR) 34040.00

912 512 008 0 NLA REPLACED BY 912 512 029 0 NLA

912 512 029 0 VOLVO B13 Replaces 912 512 008 0 29141.03

412 704 018 0 TWIN 85mm Bore (VOLVO) ESS 3 Hole Mount off centre (21172036) 31593.65

M101170 COMPRESSOR FOR MAN CLA Replaced by M101610

M101610 COMPRESSOR FOR MAN CLA 13100.80

911 153 921 2 ISX CUMMINS HEAD-9111535100/60 12541.44

411 553 923 2 REPAIR KIT FOR 4115530030 6319.66

14of30



SUGGESTED


SUGGESTED

RETAIL

COMPRESSOR SPARES

411 003 000 0 COMPRESSOR SUPERCEDED TO 411 003 011 0 NLA

ASA5272 GASKET KIT INCLUDING OIL SEAL 293.55

ASA5273 RING SET (75MM BORE) 428.45

411 003 340 4 CON ROD BEARING 567.54

411 141 623 2 PISTON COMPLETE 1855.44

411 003 011 0 SELF LUBE 150CC COMPRESSOR S/S 411 003 000 0

ASA5272 GASKET KIT (INCL. OIL SEAL) 293.55

ASA5273 RINGS (75MM BORE) 428.45

ASA6282 HEAD KIT 1407.00

411 003 340 4 CON ROD BEARING 567.54

411 011 000 0



ASA6283 GASKET KIT WITH OIL SEAL 250.09

411 042 340 4 MAIN BEARING BUSH 215.52

411 042 341 4 CON ROD BEARING PER HALF 77.83

411 041 845 0


ASA5279 RING SET (75MM BORE) NLA



411 141 000 0 DEUTZ / IVECO / BELL COMPRESSOR 15481.69


411 141 205 4 MAIN BUSH 267.22

ASA5279 RING SET (75MM BORE) NLA


ASA6313 GASKET KIT 347.07

411 142 711 0 SINGLE 229CC 90MM BORE COMPRESSOR (M/BENZ 1924) 11255.45

411 142 651 4 HEAD KIT On Request

411 142 002 2 GASKET KIT 938.64

ASA5410 RING SET 293.66

411 143 805 0 DEUTZ / IVECO COMPRESSOR On request

411 141 205 4 BUSH 267.22

811 408 040 4 OIL SEAL 76.87

897 316 999 4 GASKET 209.32

897 670 190 4 O' RING FRONT 7.24



411 145 507 0 MAN COMPRESSOR 12676.16

411 041 050 4 VALVE PLATE 222.95

411 041 051 4 LEAF VALVE 290.00

411 042 341 4 CON ROD BEAING PER HALF 77.83

411 145 000 2 GASKET KIT 987.33

411 145 653 2 CYLINDER HEAD 1581.44

411 151 008 0 MERCEDES S/S 4111510030 On request

411 154 002 2 HEAD 3653.39

911 501 624 2 PISTON & RINGS 1360.73

411 154 000 2 GASKET KIT 636.87

ASA6690 RINGSET Per Piston 85MM 315.38

411 154 003 0 MERCEDES ATEGO & BELL S/S 411 154 000 0 On request

411 151 052 4 GASKET FOR BARREL AND VALVE PLATE On request

411 154 000 2 GASKET KIT 636.87

411 154 002 2 CYLINDER HEAD 3653.39

911 145 738 2 CON ROD 503.92

911 501 624 2 PISTON AND RINGS (85MM) 1360.73


15of30



SUGGESTED


SUGGESTED

RETAIL

COMPRESSOR SPARES Continued …….

412 352 003 0 MAN COMPRESSOR

412 352 001 2 GASKET KIT 921.59


911 145 738 2 CON ROD 503.92

911 501 624 2 PISTON WITH RINGS (85MM) 1360.73

412 352 924 2 HEAD L SHAPED HEAD 4776.53


412 704 008 0 TWIN CYLINDER COMPRESSOR (VOLVO)

412 704 920 2 GASKET KIT 1853.03

412 704 932 2 COMPLETE HEAD 8209.76

911 501 624 2 PISTON WITH RING 1360.73

911 505 732 2 CONROD 761.60


412 704 014 0 COMPRESSOR FOR VOLVO FM 9

412 704 933 2 HEAD 11154.98

911 501 624 2 PISTON WITH RING 1360.73

412 704 018 0 VOLVO COMPRESSOR (S/S 412 704 015 0)

412 704 933 2 HEAD 11154.98

911 506 505 0 IVECO COMPRESSOR

911 506 928 2 GASKET KIT 1790.11

A6608 RING SET X 2 371.18

ASA7073 COMPLETE REPAIR KIT 2927.74

911 504 506 0 TWIN CYL - DAF COMPRESSOR Replaces 9115045040

911 504 920 2 CYLINDER HEAD 11158.26

411 141 623 2 PISTON WITH RING 1855.44

A6608 RINGS x 2 371.18

411 033 801 2 ADE 400 HEAD (THIN PLATE) - M/BENZ - kit only available


412 090 803 2 MAN COMPRESSOR HEAD ONLY NO GASKET 4962.74

912 510 103 0 AXOR TWIN COMPRESSOR

912 510 920 2 CYLINDER HEAD 15133.98

912 551 001 0 NISSAN UD 460 NLA Replaced by 912 551 002 0 (Exclusive to UD)

912 551 921 2 CYLINDER HEAD 13147.17


412 352 027 0 MERC AXOR SINGLE CYLINDER

911 501 624 2 PISTON WITH RING 1360.73


412 352 923 2 GASKET KIT 946.29

412 352 922 2 CYLINDER HEAD 10165.43

912 110 140 4 GASKET FOR MOUNTING FLANGE 220.46

M100960 TATA Single Cylinder 5465.63

M111410 Valve Plate 1174.45

MSP1/226 RING SET 276.30

MSP1/216 GASKET KIT 649.52

M101610 MAN CLA Single Cylinder Replaces M101170 13100.80

M112000 VALVE PLATE 3036.00

MSP1/311 RING SET 1104.00

MSP1/310 REPAIR KIT 1161.50

16of30



SUGGESTED


SUGGESTED

RETAIL

ABS COMPONENTS -TRUCK AND BUSES

ECU'S

446 004 335 0 ECU 4 CHANNEL 24V E-VERSION 10012.33

ABS-SOLENOID VALVES

472 195 082 0 SOLENOID VALVE 12V FREIGHTLINER 1/2" LHS (472 195 078 0) 2875.00

472 195 083 0 SOLENOID VALVE 12V FREIGHTLINER 1/2"RHS (472 195 079 0) 2875.00

472 195 016 0 SOLENOID VALVE 24V (MAN) M22 Bayonet 2617.35

472 195 018 0 SOLENOID VALVE 24V (TRUCK AND BUS) M22 Voss Bayonet 2811.39

472 195 006 0 SOLENOID VALVE 24V (TRUCK AND BUS) 1/2" M22 Voss Bayonet 5728.82

ABS COMPONENTS -TRAILERS

ABS UNITS (ECU)

400 500 081 0 VCS II 24V (MIXED POWER SUPPLY) 2S/2M 4S/2M 4S/3M 9516.31

400 500 083 0 VCS II 12V 2S/2M 10606.34

400 500 070 0 VCS II 24V 2S/2M ONLY 9516.31

400 500 088 0 ABSCOM 4S/2M 7973.81

ABS MODULATOR RELAY VALVES

472 195 031 0 24V M22 BAYONET 2916.30

472 195 033 0 12V 1/2" 2580.29

472 195 041 0 24V M22 BAYONET (BOXER) VCS1 7906.92

472 195 037 0 24V M22 BAYONET 3082.39

ABS SENSOR CABLES (TRUCK & TRAILER)

441 032 808 0 SENSOR -400MM 382.12

441 032 823 0 SENSOR -2000MM 918.56

441 032 851 0 SENSOR -1500MM 440.91

441 032 905 0 SENSOR BPW (DISC/CALIPER) 350MM Straight 957.75

441 032 920 0 SENSOR TRUCK STRAIGHT 2.5M 597.68

441 032 921 0 SENSOR TRUCK STRAIGHT 3.0M 609.93

449 712 023 0 VCS EXTENSION CABLE 2300MM 144.87



SENSOR BUSH

899 760 510 4 SENSOR COPPER BUSH 60.99

ABS CABLES AND POWER SUPPLY

449 423 060 0 SOLENOID VALVE EXTENTION CABLE -VARIO "C" -6M 733.27

449 423 120 0 SOLENOID VALVE EXTENTION CABLE -VARIO "C" -12M 868.42

449 615 030 0 DIAGNOSTIC CABLE VCSII -3M 703.93

449 616 158 0 3RD MODULATOR/DIAGNOSTIC CABLE 15/3M 2192.54

449 384 333 0 6M Y CABLE 12M STOPLIGHT POWER CABLE 3796.73

449 133 120 0 12M 7PIN ISO FEMALE SOCKET - SEMI TRAILER 2602.46

449 233 100 0 12M 7PIN ISO MALE SOCKET - DRAWBAR TRAILER 3256.33

ABS WARNING LIGHT

A6609 ABS WARNING LIGHT (ROUND -TANKERS) 131.28

17of30



SUGGESTED


SUGGESTED

RETAIL

EBS-D COMPONENTS -TRAILERS

CONTROL UNITS AND VALVES

480 102 010 0 EBS D MODULATOR (ECU) 4S/2M 23852.43

480 102 014 0 EBS D MODULATOR (ECU) 4S/3M WITH RSS 42303.30

480 102 015 0 EBS D MODULATOR (ECU) 4S/2M WITH RSS FOR TCE ONLY 23695.95

480 102 060 0 EBS E PREMIUM NO PEM NO FITTINGS 24667.50

480 102 066 0 EBS E PREMIUM + PEM and FITTINGS 21214.05

480 102 080 0 EBS E PREMIUM MULTIVOLTAGE 24403.00

480 207 001 0 EBS 3RD MODULATOR VALVE (DRAWBAR) 6978.52

449 372 130 0 EBS 3RD SOLENOID CABLE - TRAILERS 3410.56

EBS-E COMPONENTS -TRAILERS

CONTROL UNITS AND VALVES

480 102 030 0 MODULATOR (ECU) 2S/2M 4 GIO 24V RSS 23863.60

480 102 080 0 MODULATOR (ECU) 4S/2M Multi Voltage ABS 12/24V RSS 24403.00

480 102 063 0 MODULATOR (ECU) 4S/3M 7 GIO + PEM 24V RSS 22461.95

480 207 001 0 EBS 3RD MODULATOR 24V (DRAWBAR) 6978.52

EBS E 3RD MODULATOR Multi Voltage 12/24V

446 192 110 0 SMARTBOARD With Battery 10937.02

446 192 111 0 SMARTBOARD Without Battery ADR Compliant 9675.53

449 911 040 0 SMARTBOARD to EBS E CABLE 954.89

EBS COMPONENTS -TRUCKS

AXLE MODULATORS

480 103 011 0 EBS AXLE (4X2) 1999 MERCEDES 16156.84




480 103 033 0 EBS AXLE (6X4) NISSAN UD 440 19052.74

480 103 042 0 EBS AXLE (6X4) DAF 18915.77

480 104 002 0 EBS AXLE 16731.50

480 104 003 0 EBS AXLE DAF 19441.83

480 104 106 0 EBS AXLE MAN 2005 (Replacement for 480 104 104 0) 14619.95

BRAKE SIGNAL TRANSMITTER

480 001 000 0 ACTROS WITHOUT SILENCER M22 VOSS PORT 4 M16 8612.15

480 001 011 0 ACTROS WITH SILENCER WITHOUT SIGNAL PORT (4) M22 VOSS 7736.89

480 001 010 0 M22 VOSS PORT 4 M16 WITH SILENCER 7460.55

480 001 400 0 M22 VOSS NO PORT 4 WITH SILENCER (NISSAN UD440) 8367.99

480 001 500 0 M22 VOSS NO PORT 4 WITH SILENCER DAF 8595.40

480 020 003 0 CENTRAL BRAKE UNIT CBU MAN TGM On request

480 003 000 0 BRAKE SIGNAL TRANSMITTER 7451.55

EBS. ECU (ELECTRONIC CONTROL UNITS)

446 130 014 0 MB-ECU ACTROS 4X2 RIGID 6X2, 6X4 12688.41

446 130 015 0 MB-ECU ACTROS 4X2 12020.92

446 130 053 0 MB-ECU ACTROS MPII 11605.80

TRAILER CONTROL VALVE

480 204 002 0 T.C.U (MERCEDES IVECO DAF 75 85 95 SERIES) NISSAN 7108.15

SUPERCEDES "001 0" VERSION

EBS BACKUP VALVE

480 205 001 0 Backup Valve 3966.08

SLACK ADJUSTERS

433 576 502 0 Slack adjuster 6725.03

433 576 503 0 Slack adjuster 6725.03

433 506 103 0 Slack adjuster 2830.54

18of30



SUGGESTED


SUGGESTED

RETAIL

TATA SPARES AND COMPONENTS

M100960 TATA SINGLE CYLINDER COMPRESSOR 5465.63

M111410 Valve Plate 1174.45

MSP1/226 RING Set 276.30

MSP1/216 GASKET KIT 649.52

M600781 FOOT VALVE (Not Stocked - only Repair kit)

MSP6/20 Repair kit 472.63

M600900 FOOT VALVE (Not Stocked - only Repair kit)


M304941 AIRDRYER 6109.89

MSP3/96 REPAIR KIT INCLUDES CARTRIDGE 2440.16

M305201 AIRDRYER WITH PROTECTION VALVE Diam: 110mm Leng:160mm 5645.02


M311700 CARTRIDGE ONLY 1729.28

M303510 AIRDRYER Diam: 130mm Length:120mm

MSP3/75 REPAIR KIT INCLUDES CARTRIDGE 1887.28

M311370 CARTRIDGE ONLY 1619.34

DIAGNOSTIC EQUIPMENT Please Speak to WABCO Sales personnel for Diagnostic pricing

ESSENTIAL EQUIPMENT

446 301 030 0 Diagnostic Interface & PC cable S/S 4463010220 On Request

446 300 329 2 Diagnostic Cable for Trailer VCSI VCSII TCE EBS On Request

446 300 360 0 Diagnostic Inter Adapter CAN Cable EBS-E On Request

446 300 361 0 Diagnostic Cable CAN for 4463003600 above EBS-E On Request

446 300 430 0 Compact Tester: Truck and Trailer ABS replaces 4463004100 On Request

446 300 400 0 Compact Tester V1,75 Vario C, VCS I and VCSII On Request

GENERAL SOFTWARE

446 301 501 0 Diagnostic Software for Trailer VCSI On Request

446 301 510 0 Diagnostic Software for Trailer VCSII On Request

446 301 542 0 Diagnostic Software for Trailer EBS D On Request

446 301 588 0 Diagnostic Software for Trailer EBS E On Request

446 301 589 0 Diagnostic Software for Trailer EBS E On Request

446 301 682 0 Diagnostic Software for Trailer TCE On Request

446 301 545 0 Diagnostic Software for Truck EBS (Europe) On Request

446 301 556 0 Diagnostic Software for Truck EBS (Asia) On Request

446 301 628 0 Diagnostic Software D+ ABS E Gen Hino Toyota On Request

446 301 547 0 Diagnostic Software for Daimler Chrysler (Actros) On Request

446 301 732 0 Diagnostic Software IVTM On Request

446 301 874 0 Diagnostic Software ENR Actros/Merc ECAS On Request

446 301 572 0 Diagnostic Software HPB BAE software On Request

446 301 692 0 Diagnostic Software ODR Tracker On Request

GENERAL DIAGNOSTICS CABLES

446 300 408 0 ABS/ASR E vers. Inter-Adapter Cable Hino Toyota On Request

446 300 327 0 ABS, ECAS Inter Adaptor 35Pin Old version Truck On Request

446 300 317 0 ECAS / ATC Inter adapter 25pin On Request

446 300 344 0 EBS Diagnostic. Asia Vehicles OLD Nissan UD On Request

446 300 401 0ND EBS Diagnostic. Nissan UD On Request

446 300 454 0 EBS (EPB) Cable MPII (Actros, Axor, defender) On Request

446 300 340 0 EBS / ECAS (EPB) Cable (Actros Axor) old cable On Request

446 300 345 0 ZBR MAN cable (TGA MAN ECAS etc) On Request

446 300 348 0 CAN (yellow trailer plug) and IVTM Cable On Request

19of30



SUGGESTED


SUGGESTED

RETAIL

ACCESSORIES AND GENERAL COMPONENTS

MOISTURE REPELLING AND PROTECTIVE SPRAY

A7178 NANO PROTECH 100ml can 400.00 LAUNCH PRICE

CONSPICUITY TAPE

A7190 Yellow Tape Continuous 50mm wide 50m roll ECE 104 75.90

A7191 Yellow Tape Segmented Curtainsiders 50mm W 50m roll 89.70

A7192 Yellow Tape Segmented Tankers 50mm wide 50m roll ECE 104 92.00

SPIRAL BINDING

A900 SPIRAL BINDING (CLEAR) PER METRE 12.05

TEST EQUIPMENT -PNEUMATIC

1189386 TRAILER TEST KIT C/W GAUGES X 2 HOSES (6M) X 2 5513.14

453 004 007 0 WABCO TEST GAUGE 1368.50

AGA211 AIR GAUGE 0-10 BAR (DASH BOARD) 845.25

ASA5896* HOSE TEST GAUGE 519.12

TEST EQUIPMENT -ABS

SPEAK TO SALES COUNTER FOR SPECIAL PRICING

TEST GAUGE

453 004 007 0 PRESSURE GAUGE 0-16 Bar 1368.50

20of30



SUGGESTED


SUGGESTED

RETAIL

STANDARD FITTINGS

UNIONS

893 800 294 0 M10-06 41.15

893 800 304 0 M10-08 91.33

893 800 014 0 M12-06 32.60

893 800 234 2 M12-08 31.01

893 800 044 0 M12-010 39.73

893 800 984 0 M12-012 66.93

893 800 064 0 M14-06 45.63

893 800 244 0 M14-08 37.67

893 800 073 0 M14-010 46.19

1677039 M14-012 115.67

893 809 010 0 M16-06 44.65

893 809 020 0 M16-08 48.23

893 801 994 0 M16-010 44.65

893 800 974 0 M16-012 66.87

893 800 022 0 M22-06 53.25

893 800 224 0 M22-08 50.18

893 800 109 0 M22-010 55.62

893 800 964 0 M22-012 75.90

893 800 033 0 M22-015 (STOSS) 110.24

ASA5223 M22-015 (SHORT) 82.55

893 800 264 0 M26-015 (STOSS) 133.96

ASA7077 M26-015 (SHORT) 163.10

893 800 254 0 M26-018 (STOSS) 209.32

893 801 000 0 1/8" BSP-06 55.76

893 800 371 0 1/4" BSP-06 61.23

893 800 904 0 1/4" NPT-08 46.05

ASA5128 1/2"BSP-012 (STEEL) 103.23

ASA931 1/2"NPT-012 116.47

ASA5182 1/2"NPT-012 (STEEL) 142.34

ASA5315 1/2"NPT-015 (STEEL) 133.96

893 800 354 0 1/4"BSP-010 53.03

ASA1347 1/4"NPT-010 78.15

893 801 314 0 1/4"NPT-012 (STEEL) 63.12

ASA1790 3/8"NPT-010 (STEEL) 69.77

ASA5208 3/8"NPT-012 58.97

ASA932 3/8"NPT-012 (BRASS) 97.58

ASA1025 3/8"NPT-015 134.38

ELBOWS

893 830 104 0 M12-08 (BULKHEAD) 155.96

ASA6503 M16-08 160.76

893 830 214 0 M16-012 (BULKHEAD) 144.62

893 830 770 0 M22-08 (BULKHEAD) 186.31

893 830 204 0 M22-012 (BULKHEAD) 86.00 143.74

893 830 042 0 M22-015 (STOSS) 202.34

ASA5225 M22-015 SHORT NUT 173.04

893 890 063 0 M22 (M) -M22 (FEM) 214.91

ASA1342 010SW-010 144.52

ASA1258 012SW-012 149.71

ASA1261 06SW-06 129.14

ASA1263 08-08 B/H 205.70

ASA1476 08SW-08 106.05

ASA965 1/2"NPT-012 (BRASS) 193.25

ASA6579 1/4" NPT-08 161.29

ASA5313 1/4"NPT-012 243.03

ASA963 1/4"NPT-012 (BRASS) 184.67

ASA1237 1/8"NPT-06 146.97

ASA1435 3/8"NPT-012 164.12

893 830 091 0 M26-015 (BULKHEAD) 337.81

21of30



SUGGESTED


SUGGESTED

RETAIL

TEES

893 860 053 0 010-010-010 186.49

ASA1504 010SW-010-010 173.04

893 860 374 0 012-012-012 (STEEL) 9 179.40

ASA1259 012-012SW-012 212.27

893 860 394 0 012-06-012 397.71

893 850 314 0 012-M22-012 345.37

ASA1260 012SW-012-012 196.57

ASA5258 012SW-06-012 176.02

ASA5207 012SW-TEST-012 415.38

893 860 014 0 06-06-060 130.25

ASA1345 06-06SW-06 172.38

ASA1336 06SW-06-06 198.08

893 860 194 0 08-06-080 199.11

893 860 144 0 08-08-080 186.99

ASA5242 08-08SW-08 223.27

ASA5443 08SW-08-08 145.13

A1012 1/2" HOSE TEE 78.92

A844T 1/4"(F)-1/4"(F)-1/4"(F) (T-BLOCK) 80.39

A636 1/4"(M)-1/4"(F)-1/4"(F) (T-BLOCK) 79.51

A637 3/8"(M)-3/8"(F)-3/8"(F) (T-BLOCK) 93.30

A6605 3/8"(M)-1/4"(F)-3/8"(F) 100.01

A6606 M16(M)-1/4"(F)-3/8"(F) 100.01

893 850 660 0 M16-012-012 199.96

893 850 324 0 M22-012-012 300.06

893 850 394 0 M22-M22-012 523.19

893 500 044 4 M22-M22-M22 208.55

BULKHEAD STRAIGHTS

ASA5366 012-1/2"BSP 158.92

ASA1009 1/2"-012 B/H (BRASS) 158.38

893 821 234 0 M16-012 148.66

893 103 900 4 M16-M22 (BODY ONLY) 92.22

893 821 224 0 M22-012 (BULKHEAD STRAIGHT) 93.50

893 890 040 0 M22-1/2"BSP 159.49

893 890 014 0 M22-M22 66.98

LINE CONNECTORS

893 820 024 0 010-010 55.11

893 820 160 0 010-010 (BULKHEAD LINE CONNECTOR) 118.24

893 820 564 0 012-012 64.50


ASA5231 015-015 (SHORT NUT) 106.05

893 820 061 0 015-015 (STOSS) 142.34

ASA5261 016-016 (SHORT NUT) 329.34

893 820 012 0 06-060 46.72


893 820 134 0 08-080 42.87

ASA5255 08-08 (BULKHEAD LINE CONNECTOR) 79.61

TEST CONNECTORS

463 703 106 0 M14 (FEM) 174.38

ASA5254 M16 (FEM) 168.44

463 703 114 0 M16 (M) 122.46

463 703 107 0 M18 (FEM) 221.15

ASA5207 012SW-TEST-012 TEE 415.38

463 705 102 0 1/4"NPT (MALE) 127.26

897 753 940 4 RUBBER DUST BOOT 27.69

22of30



SUGGESTED


SUGGESTED

RETAIL

'O' RINGS

897 071 110 4 M12 1.74

897 770 070 4 M14 1.89

897 770 250 4 M16-M18 1.38

897 080 400 4 M22 1.98

THRUST RINGS

893 030 070 4 M12 7.75

893 030 080 4 M14 17.91

893 030 014 4 M15 14.93

893 030 170 4 M16 6.59

893 030 020 4 M18 27.47

893 030 040 4 M22 7.25

LOCKNUTS

5000112 M8 2.37

5000113 M10 3.83

810 304 031 4 M16 (BOOSTERS) 13.25

810 315 004 4 M16 10.34

810 315 005 4 M18 14.20

891 500 454 4 M22 11.61

891 500 464 4 M26 19.25

891 500 520 4 M28 (EXHAUST BRAKE VALVE 3./2 WAY DIR. CONT. V) 160.10

A6001 M8 (NYLOC) 1.89

INSERTS

893 040 210 4 06L 2.34

893 040 220 4 08L 3.16

893 040 230 4 10L 3.89

893 040 240 4 12L 4.58

893 040 250 4 15L 6.04

CUTTING RINGS

893 050 014 4 06L 6.53

893 050 054 4 08L 7.16

893 050 024 4 10L 7.81

893 050 144 4 12L 10.02

893 050 034 4 15L 10.48

A5554 16L 16.77

893 050 040 4 18L 16.24

PIPE NUTS

893 070 054 4 06 (M12) 6.00

893 070 104 4 08 (M14) 7.11

893 070 834 4 012 (M18) 10.94

893 070 065 4 015 (LONG) 43.93

893 070 174 4 015 (SHORT) NLA

KOR'S

ASA5252 08-060 60.86

ASA1267 012-060 121.72

ASA1351 012-080 58.22

ASA1350 012-010 61.40

ASA5490 016-012 On request

ADAPTORS/HOSE TAILS

A23 1/2"NPT-1/2" HOSE 62.55

A24 3/8"NPT-1/2" HOSE 20.70

A25 1/4"-1/2" HOSE 33.62

A588 Ø12 PIPE STEM-1/2" HOSE 64.83

A646 M22-1/2" HOSE 98.62

4087055F M16 M HOSE ADAPTOR WITH O RING replaces 893 120 414 4 83.32

23of30



SUGGESTED


SUGGESTED

RETAIL

PLUGS

893 010 030 4 M12 28.39

893 010 011 4 M14 35.85

893 011 710 4 M16 37.00

893 011 711 4 M16 (FOOTBRAKE) 35.85

893 010 020 4 M22 54.26

893 010 230 4 M26 53.91

A174 1/8"NPT 14.06

A31 1/4"NPT 17.15

A30 3/8"NPT 17.15

A29 1/2"NPT 40.44

NIPPLES

893 100 035 4 M22-M22 42.20

893 100 164 4 M22-1/2"BSP 113.78

893 103 900 4 M16-M22 BULKHEAD ADAPTOR 92.22

893 890 014 0 M22-M22 BULKHEAD 66.98

893 890 040 0 M22-1/2" BULKHEAD 159.49

A60 1/4"NPT-1/4"NPT 37.23

A6217 1/2"-1/2"NPT 69.48

SOCKETS

893 240 224 4 M12 39.87

893 300 011 4 M22 (LONG) 77.74

893 300 012 4 M22 (SHORT) 47.54

W103/8 1/2"NPT 61.47

CABLE TIES

A1134 200MM PRICE PER BUT SOLD IN PACK OF 100 0.78

A6153 395MM PRICE PER BUT SOLD IN PACK OF 100 3.38

REDUCERS

893 180 034 4 M16 (M-M22F) 71.79

893 180 274 4 M16M-1/2"FEM 150.08

893 180 880 4 M26(M)-M22(F) 197.18

893 181 184 4 M22(M)-M16(F) 54.26

A34 3/4"NPT(M)-1/2"NPT(F) 64.47

A36 3/8"NPT(M)-1/4"NPT(F) 24.90

A39 1/2"NPT(M)-1/4"NPT(F) 50.21

A498 M22(M)-1/4"NPT(F) 42.87

A499 M22(M)-3/8"NPT(F) 42.87

A5379 M16(M)-3/8"NPT(F) 61.60

A6181 1/4"NPT(M)-1/8"NPT(F) 16.73

A672 1/2"NPT(M)-M22(F) 93.14

A673 M22(M)-1/2"NPT(F) 76.79

PIPE CLIPS / CLAMP

893 511 110 4 06 P-CLIP 21.92

893 511 030 4 08 P-CLIP 16.75

893 511 000 4 012 P-CLIP 12.68

893 511 010 4 015 P-CLIP 17.59

A5370 1/2" HOSE P-CLAMP 5.71

A6669 1/2" HOSE P-CLAMP (12 - 22MM) 11.66

A6183 1/2" HOSE P-CLAMP (16 - 25MM) 13.68

A6720 1/2" HOSE P-CLAMP (20 - 22MM) 32.60

24of30



SUGGESTED


SUGGESTED

RETAIL

PUSH IN FITTINGS

STRAIGHT UNIONS

893 803 035 0 M10 - 6mm (M10x1 thread) on request

893 803 022 0 M12 - 6mm (alternative 4100916M) 73.93

893 803 023 0 M16 - 6mm 79.70

893 803 024 0 M22 - 6mm on request

893 803 025 0 M10 - 8x1 mm (M10x1 thread) 93.20

893 800 007 2 M12 - 8x1 mm (8938034900, 4100888M) ** 66.98

893 800 001 2 M16 - 8x1 mm (8938035400, 4100911M) ** 63.71

893 800 005 2 M22 - 8x1 mm (8938034000, 4100913M) ** 80.94

893 800 002 2 M16 - 12x1.5 mm (8938034300, 4100915M) ** 67.06

893 800 008 2 M22 - 12x1.5 mm (8938034400, 4100914M) ** 89.88

893 800 004 2 M22 - 15x1.5 mm (8938037800, 4101056M) ** 106.61

893 803 420 0 M22 - 10x1 mm 114.01

893 803 410 0 M16 - 10x1 mm 109.51

893 803 990 0 M26 - 15x1.5 mm 331.06

893 800 005 2 M16 - 16 x 1 ** 80.94 Plastic Release Tool

** This type of fitting has pipe removable using a tool below

899 700 001 4 8mm Nylon Pipe Extraction tool plastic 37.13

899 700 002 4 12mm Nylon Pipe Release tool plastic 38.70

899 700 003 4 15mm Nylon Pipe Release tool plastic 42.57

899 700 012 4 8mm Nylon Pipe Release tool stainless steel 1388.50

899 700 014 4 12mm Nylon Pipe Release tool stainless steel 1388.50

899 700 015 4 15mm Nylon Pipe Release tool stainless steel 1388.50 Stainless Release Steel

MALE BULKHEAD BARREL TEE BLOCK

893 851 400 0 M22-M16F-M16F * (alternative 4101087M) 219.21

893 851 390 0 M16-M16F-M16F * (alternative 4101086M) 205.13

4101083M M12-M12F-M12F 134.72

* WITH Lock nut, Thrust ring and O ring

MALE BULKHEAD STUD BLOCK

4101005M M22 / M22 - M16F B/H stud * (alternative 8931042962) 136.76

4101017M M16 / M22 - M16F B/H stud * (alternative 8931042972) 161.39


MALE BULKHEAD ELBOW BLOCK

893 401 008 4 M12 - M12F B/H Elbow stud * on request



893 890 450 0 M22 - M22F B/H Elbow stud * 152.33

4101105M M22-M16F B/H Elbow stud 202.32



* WITHOUT Lock nut, Thrust ring and O ring

FEMALE TEE BLOCK

4100994M M12F - M12F - M12F TEE Block (alternative 8935010054) 173.88

893 501 191 4 M16F-M16F-M16F TEE BLOCK (alternative 4100993M) 72.57

893 501 197 4 M22-M22F-M22F TEE BLOCK (alternative 4101198M) 180.70

25of30



SUGGESTED


SUGGESTED

RETAIL

MALE BULKHEAD TEE BRANCH BLOCK

890 159 586 4 M16F -M22 - M16F TEE Branch * 261.89

4101096M M16F-M22-M16F TEE BRANCH (alternative 8901595864 *) 176.62

4101095M M16F -M16 - M16F TEE Branch (alternative 8935010014 * ) #N/A

4101091M M12F -M12 - M12F TEE Branch (alternative 893 501 006 4 * ) on request

A6605 3/8M - 1/4F - 3/8F TEE Branch (replaces A36 & A637) 100.01

A6606 M16M -1/4F - 3/8F TEE Branch 100.01

* WITHOUT Lock nut, Thrust ring and O ring

SCREW THREAD WITH SWIVEL PLUG

893 920 827 2 M 10x1 Swivel Plug P5 on request

893 129 191 2 M 12x1.5 Swivel Plug P5 58.60

893 129 192 2 M 16x1.5 Swivel Plug P5 50.99

893 129 193 2 M 22x1.5 Swivel Plug P5 64.37

SWIVEL PLUG ELBOW

893 401 827 2 M12x1.5 Elbow for P5 plug 76.40

893 401 015 2 M 16x1.5 Elbow for P5 plug 71.76

SWIVEL PLUG BARREL TEE

893 501 193 4 M12x1.5 Barrel Tee for P5 plug on request

893 501 194 4 M 16x1.5 Barrel Tee for P5 plug on request

SWIVEL PLUG BRANCH TEE

893 501 195 4 M12x1.5 Branch Tee for P5 plug on request

893 501 196 4 M 16x1.5 Branch Tee for P5 plug 166.99

BULKHEAD UNIONS

ASA7098 M16 - 12mm * 250.77

ASA7169 M22 - 12mm * (Alternative: ASA7100) 209.01

ASA7099 M22 - 08mm * 195.60

ASA7123 M22 - 12mm * M18 body 244.96

ASA7124 M22 - 08mm * M18 body 293.07


BULKHEAD ELBOWS

ASA7101 M22 - 12mm Swivel Type Short P5 plug (alternative: ASA7170) 257.50

ASA7102 M12 - 08mm * (Alternative: 893 831 291 0 * ) 185.99

ASA7103 M16 - 08mm Swivel Type Short P5 plug (Alternative: 893 831 293 0 *) 226.85

ASA7187 M22 - 15mm * 303.73


TEES

ASA7105 08-08-08 374.82

ASA7182 12-12-12 (Alternative: ASA7104) 364.45

ASA7106 15-15-15 (Alternative: ASA7183) 522.83

ASA7177 012-08-012 327.42

ASA7203 012-08-08 386.27

26of30



SUGGESTED


SUGGESTED

RETAIL

BRANCH TEES (ASSEMBLED)

ASA7107 012-M22-08 * (replaces: 8938510200) 342.22

ASA7109 012-M22-012 * (replaces 8938509700 and ASA7202) 300.11

ASA7164 08-M22-08 * 540.20


BARREL TEES (ASSEMBLED)

ASA7108 M22-012-08 * (replaces 8938510500) 297.69

ASA7110 M22-012-012 * 298.84

ASA7115 M12-08-08 * (replaces 8938510600) 247.64


TEST POINT TEES (ASSEMBLED)

ASA7111 M22 - TP - 08 * 331.05

ASA7112 M22 - TP - 012 * 336.81

ASA7113 M16 - TP - 012 * 318.32

ASA7114 M16 - TP - 08 * 333.12

ASA7097 M12 - TP - 08 * 297.61


LINE CONNECTORS

893 803 034 0 6mm-6mm 175.59

893 803 037 0 08mm - 08mm (replaces 4101064M) 170.34

893 803 039 0 12mm - 12mm (replaces 4101066M) 194.80

893 803 041 0 15mm - 15mm On request

VEE NUTS

893 771 236 4 VEE Nut 6x1 Pipe M12 66.41

893 771 234 4 VEE Nut 8x1 Pipe M14 66.41

893 771 235 4 VEE Nut 12x1.5 Pipe M18 101.19

O-RINGS

897 071 110 4 M12 1.74

897 770 250 4 M16 1.38

897 080 400 4 M22 1.98

THRUST RINGS

893 030 070 4 M12 7.75

893 030 170 4 M16 6.59

893 030 040 4 M22 7.25

27of30



SUGGESTED


SUGGESTED

RETAIL

VARIOUS

891 503 076 2 Locknut with O ring M22 On request

891 500 454 4 Locknut withOUT O ring M22 11.61

4101058M M16 M Test point (alternative 4637031140) 99.95

4101057M M12 M Test point (replaces 4637020030) 100.95

893 022 014 4 M16 M Plug with Oring (alternative 4101061F) 35.85

893 022 015 4 M22 M Plug with Oring (alternative 4087057F) 58.67

A6735 3/8" - 1/2" Hose Tail 56.94

4087055F M16 - 1/2" Hose Tail with Oring (alternative 8931294452 ) #N/A

4087063F M22 - 1/2" Hose Tail with Oring (alternative 8931294462) 87.97

ASA7127 M16M - 1/2"hose - 1/2" hose

893 104 058 4 M22 Bulkhead Stud ID M16 (alternative 4100992M) On request

(No Locknut)

899 360 210 4 Thread Filter M 12x1.5 On request

899 360 260 4 Thread Filter M 16x1.5 15.91

899 360 140 4 Thread Filter M 22x1.5 52.96

4101163M M18 - M16 Socket 72.55

A6717 M16 - 1/2" Socket On request

28of30



SUGGESTED


SUGGESTED

RETAIL

COMPOSITE FITTINGS (PLASTIC)

UNION PLUG (Threadless)

893 800 091 2 UNION 8x1 mm pipe REGULAR 65.99

893 800 096 2 UNION 8x 1 mm pipe SMALL 61.21

893 800 093 2 UNION 12x 1.5mm pipe REGULAR 76.85

893 800 098 2 UNION 15 x 1.5 mm pipe HEAVY

UNION TEE BLOCK

893 503 071 4 UNION T&L SMALL 80.93

893 503 072 4 UNION T&L REGULAR 73.46

893 503 073 4 UNION T&L HEAVY #N/A

TEST POINT (Threadless)

893 880 011 0 Test Point REGULAR 72.12

SWIVEL BODY (Threaded)

893 920 313 2 SWIVEL M12 x 1.5 SMALL 55.20

893 920 314 2 SWIVEL M12 x 1.5 REGULAR 59.80

893 920 316 2 SWIVEL M16 x 1.5 SMALL 53.83



893 920 320 2 SWIVEL M22 x 1.5 HEAVY On Request

PUSH IN ELBOW

893 920 323 2 90 DEG 8 x 1 mm pipe SMALL 115.63

893 920 324 2 90 DEG 8 x 1 mm pipe REGULAR 118.54

893 920 326 2 90 DEG 12 x 1.5 mm pipe REGULAR 123.77

893 920 327 2 90 DEG 15 x 1.5 mm pipe HEAVY M18 body On Request

BULKHEAD ELBOWS

ASA7101P M22 - 12mm pipe Swivel Type 197.58

ASA7102P M12 - 08mm pipe Swivel Type 176.24

ASA7103P M16 - 08mm pipe Swivel Type



29of30



SUGGESTED


SUGGESTED

RETAIL

TEE

ASA7105P 08-08-08 mm pipe 264.57

ASA7182P 12-12-12 mm pipe 304.03

ASA7106P 15-15-15 mm pipe



BULKHEAD SWIVEL TEE

ASA7107P 012-M22-08 mm pipe 284.74

ASA7109P 012-M22-012 mm pipe 295.61

ASA7164P 08-M22-08 mm pipe

BULKHEAD SWIVEL BARRELTEE

ASA7108P M22-012-08 284.74

ASA7110P M22-012-012 295.61

ASA7115P M12-08-08 258.13

ASA7218P M16-12-12

ASA7261P M16-08-12

BULKHEAD SWIVEL TEST POINT BARRELTEE

ASA7111P M22 - TP - 08 276.79

ASA7112P M22 - TP - 012 290.86

ASA7113P M16 - TP - 012 267.40

ASA7114P M16 - TP - 08 256.51

ASA7097P M12 - TP - 08 270.19

30of30

AUTOMOTIVE SOUTH AFRICA

PRICE LIST FEBRUARY 2016

Pinetown Branch Main Branch Johannesburg Cape Town Branch

Unit 4 Pastel Park 10 Sunrock Close Unit 21 Drill Park,

5A Wareing Road, Pinetown Sunnyrock Ext 2, Germiston Drill Road, Montague Gardens

Telephone +27 (031) 701-6351 Telephone + 27 (0) 11 450-2052 Telephone +27 (021) 552-1231

Telefax +27 (031) 701-4543 Telefax + 27 (0) 11 450-3022/3 Telefax +27 (021) 552-1204

Documents

AUTOMOTIVE SA PRICE LIST - FEBRUARY 2016 - · PDF fileautomotive sa price list - february 2016 part number description suggested retail repair kit no suggested retail unloader valves