AUSTRALIA IS A UNIQUE NOWHERE QUITE LIKE IT OR LIKE THE ... · AUSTRALIA IS A UNIQUE PLACE, THERE’S NOWHERE QUITE LIKE IT OR LIKE THE PEOPLE IN IT. When it comes to our vehicles

AUSTRALIA IS A UNIQUE PLACE, THERE’S NOWHERE QUITE LIKE IT OR LIKE THE PEOPLE IN IT.

When it comes to our vehicles we push them hard and so does the Australian environment.

Driving to the beach in summer under the bonnet is pushing 80°C, a trip to the corner store can be a 15 minute drive — and the hill on the way home a vertical ascent. Our journeys take in the smoothest of roads and the roughest corrugated red sand. As Australians we need a battery that we can rely on to power our unique lifestyle.

TECHNOLOGY YOU DESERVE

02 Understanding Battery Ratings

04 Cell Assembly Layout

05 Terminal Types

Battery Hold-Down

Special Features Glossary

06 Iss Active

09 Battery Recycling

10 Car & Passenger Vehicles

14 4x4 & SUV’s

18 Truck, Bus & Heavy Equipment

22 Deep Cycle

24 Marine

26 Lawn & Garden

28 Battery Care & Maintenance

29 Quality Guaranteed

Nationwide Warranty

ProudlyAustralian

Made

Contents

11

UNDERSTANDING BATTERY RATINGS

-18o +18o

Twice the power available

BATTERIES ARE RATED ACCORDING TO A RANGE OF SPECIFICATIONS AND STANDARDS. UNDERSTANDING THESE RATINGS AND THEIR RELEVANCE TO THE BATTERY’S APPLICATION AND OPERATING CONDITIONS IS KEY TO SELECTING THE RIGHT BATTERY.

TEMPERATURE PLAYS A KEY ROLE IN A BATTERY’S ABILITY TO DELIVER CCA

CCA (Cold Cranking Amperes)Is a measurement of the discharge current at a high rate that a fully charged battery can deliver for 30 seconds and maintain a voltage of 7.2 volts (12 volt battery) at a temperature of -18°C.

It is used to determine a battery’s ability to supply high cranking current to start the engine and maintain sufficient voltage to power the ignition requirements under severe cold starting conditions.


2

Marine Cranking Amperes (MCA)Similar to CCA, MCA is used to measure the number of amperes a battery can deliver for 30 seconds at a specific temperature, however with MCA the test is conducted at 0°C rather than -18°C. MCA ratings are 20 – 25% higher than a CCA rating and commonly used to rate marine starting batteries.

When comparing battery ratings it is important to compare like for like. Always ensure the CCA rating is compared against CCA and MCA rating against MCA. Some manufacturers may rate the battery according to a CA standard. This test is conducted at the same temperature as the MCA rating and should not be confused with CCA.

Reserve Capacity (RC)Refers to the length of time in minutes, that a fully charged battery at 25°C can deliver a current of 25 Amps until the voltage drops to 10.50V (5.25V for a 6V Battery).

25 Amps represents a typical electrical load under normal running conditions.

RC provides an indication of the time that a vehicle with a normal electrical load will run for if the charging system (alternator) fails.

Ampere-Hour @ 20hr (Ah)Ah refers to the battery’s storage capacity and is the current a fully charged battery will deliver over a 20 hour period before the voltage falls to 10 .50V at 25°C.

The more accessories in use the more available energy consumed. Consumption of the battery’s capacity is referred to as ‘discharging’ the battery.

Available Energy Available Energy

Ignition, Lights, Radio Air ConditioningElectric Windows

It is important to note that although a battery may feature an Ah rating, it does not imply suitability for cyclic use. Repeated deep discharge of a standard starting battery will damage the internal components and lead to premature failure. Deep Cycle batteries are designed to withstand repeated cycling and should only be recommended for cycling applications.

3

UN

DERS

TAN

DIN

G BA

TTER

Y RA

TIN

GS


Cell Assembly Layout

A

C

F

D

H

E

12 volt

Multi-terminals

6 volt

C D

4

Terminal Types

Special Features Glossary

Battery Hold-DownSide Hold-down

Din Style Side Hold-down

End Hold-down

Din Style End Hold-down

Standard Terminal Post (STD)

Small Terminal Post (SP)

Standard / Wing Nut Terminal (STD/WN)

Threaded Terminal (TH)

AGM Absorbed Glass Mat FA Flame Arrestor MR Mud Rack

CH Carry Handles GM Glass Mat Separator PL PlatelockTM Technology

CI State of Charge Indicator LM Low Maintenance PV Pressure Valve

CV Central Venting MF Maintenance Free RP Recessed Post

EFB Enhanced Flooded Battery MIA Made in Australia VR Vibration Resistant

Australian Standard Specifications as shown AS 2149

5

BATT

ERY

TECH

NOL

OGY


ISS ACTIVE AGM & EFBYUASA’S ISS ACTIVE BATTERY RANGE REPRESENTS THE LATEST IN PERFORMANCE AND TECHNOLOGY FOR IDLE STOP START SYSTEMS.

Yuasa ISS Active batteries are specially designed to satisfy the fuel saving and emission reducing benefits of vehicles fitted with Idle Stop Start systems.

The range incorporates innovative design features and advanced raw materials to deliver superior cycling performance, high charge acceptance for rapid recharge in between engine off modes and the extra power to run on-board electrics whilst the engine is switched off.

6

Æ Superior starting power Æ 3 x higher cycling endurance* Æ Deep discharge capability

Yuasa ISS Active AGM batteries deliver the ultimate in performance for advanced Idle Stop Start systems.

A range of premium batteries incorporating Absorbed Glass Mat (AGM) technology that combines to deliver superior starting power, extreme cycle life and discharge capability in advanced Idle Stop Start systems.

ISS ACTIVE AGM

SUPERIORCYCLING

PERFORMANCE

3

FOR ADVANCEDSTOP START

SYSTEMS

ABSORBEDGLASS MAT

TECHNOLOGY

†Conditions apply. Refer to individual warranty statements attached to each battery. *Compared to conventional flooded batteries.

ITEM

ID

BATT

ERY

TYPE

WAR

RANT

Y

VOLT

S

CCA

-18º

C

RC @

25º

C

AH @

20H

R

H TH

L W

KG

(all measurements in mm) POLARITY

H TH

L W

KG

WEIGHT

H TH

L W

KG

TERM. TYPE

H TH

L W

KG

HOLD DOWN

H TH

L W

KG

SPECIAL FEATURES

H TH

L W

KG

L W H TH

ISS ACTIVE AGM

106222 DIN53LH AGM 36 12 640 100 60 242 175 190 190 C 17.3 STD SIDE/END AGM, CH, FA, MF, RP




106228 DIN110LHAGM 36 12 950 190 105 393 175 190 190 C 30.5 STD SIDE/END AGM, CH, FA, MF, RP

3636

77

ISS

ACTI

VE

Æ Dependable starting power Æ 2 x higher cycling performance* Æ Durable grid design Æ Lithium Carbon Additive

Yuasa ISS Active EFB batteries deliver the ultimate in performance for advanced Idle Stop Start systems.

A range of Enhanced Flooded Batteries (EFB) designed to aid the reduction of CO2 emissions and fuel consumption in vehicles fitted with standard Idle Stop Start systems.

ISS ACTIVE EFB

ADVANCED CYCLING

PERFORMANCE

FOR ADVANCEDSTOP START

SYSTEMS

ENHANCED FLOODED BATTERY

†Conditions apply. Refer to individual warranty statements attached to each battery. *Compared with conventional flooded batteries. ^Available November 2020.

3636

ITEM

ID

BATT

ERY

TYPE

WAR

RANT

Y

VOLT

S

CCA

-18º

C

RC @

25º

C

AH @

20H

R

H TH

L W

KG


H TH

L W

KG

WEIGHT

H TH

L W

KG

TERM. TYPE

H TH

L W

KG

HOLD DOWN

H TH

L W

KG

SPECIAL FEATURES

H TH

L W

KG

L W H TH

ISS ACTIVE EFB

106220 Q85 36 12 650 112 67 232 173 200 225 C 17.3 STD - EFB, LM

106210 Q85R 36 12 650 113 67 232 171 200 225 D 18.3 STD - CH, CI, EFB, LM

106211 S95 36 12 760 127 68 260 173 200 225 C 19.4 STD - EFB, LM

106201 T110 36 12 810 155 80 303 173 200 225 C 22.2 STD - EFB, LM

ISS ACTIVE EFB MF

116200 Q85 MF 24 12 550 110 65 230 171 202 222 C 17.0 STD - CH, CI, EFB, FA, MF

116210 Q85R MF 24 12 550 110 65 230 171 202 222 D 17.0 STD - CH, CI, EFB, FA, MF

116211 S95 MF 24 12 680 130 70 258 172 199 220 C 19.9 STD - CH, CI, EFB, FA, MF

116201 T110 MF 24 12 760 150 95 302 170 200 222 C 22.5 STD SIDE CH, CI, EFB, FA, MF

116212 DIN53LH EFB^ 24 12 560 100 60 242 175 190 190 C 16.5 STD SIDE/END CH, EFB, FA, MF, RP

106216 DIN65L EFB 24 12 650 110 65 275 175 175 175 C 17.0 STD SIDE/END CH, EFB, FA, MF, RP


106217 DIN75L EFB 24 12 730 135 75 313 175 175 175 C 19.1 STD SIDE/END CH, EFB, FA, MF, RP


8

Battery Recycling

Why recycle?98% of a lead acid battery can be reclaimed through recycling. The lead, plastic and acid components are re-processed and manufactured into an array of other products including guide posts, cabling and detergents.

1. SULFURIC ACID Sulfuric acid is converted to sodium sulfate to be used in the manufacture of glass, textiles, laundry detergents and fertilisers.

2. LEADBattery plates, inter cell connectors and posts made from lead are melted down in a smelter furnace. The molten lead is then formed into ingots for re-use.

3. POLYPROPYLENEBattery containers and lids are chipped and sent for recycling into rubbish bins, plant pots etc.

Æ Help build a cleaner Australia for future generations Æ Prevent harm to humans and wildlife Æ Protect the environment

Æ Conserve natural resources Æ Reduce the amount of waste to landfill

At Yuasa we are dedicated to caring for the environment and believe that scrap batteries should be recycled and disposed of responsibly. Our Used Lead Acid Battery (ULAB) program and commitment to environmental sustainability has seen Century Yuasa achieve SAI Global ISO14001 environmental accreditation, an international standard outlining the requirements for a structured approach to environmental protection and responsibility.

Used batteries are collected from resellers.

Consumers return used batteries to resellers.

Used batteries are recycled into new products.

New batteries are sold and installed

by resellers.

Century Yuasa delivers new batteries to resellers.

Our recycling process

Benefits of recycling

99


CAR & PASSENGER VEHICLEYUASA’S CAR AND PASSENGER VEHICLE BATTERIES ARE THE ULTIMATE IN BATTERY PERFORMANCE AND MAINTENANCE FREE TECHNOLOGY. FEATURING SPECIALIST INTERNAL COMPONENTS, UNIQUE DESIGN FEATURES AND INDUSTRY LEADING TECHNOLOGIES TO COMBAT THE CAUSES OF BATTERY FAILURE AND DELIVER RELIABILITY, LONGER LIFE AND SUPERIOR PERFORMANCE.

Advanced grid designs and optimised paste formulation, combined with Century Yuasa’s revolutionary maintenance free lid technology delivers superior starting power, exceptional corrosion resistance, longer life and the performance to handle the demands of today’s modern vehicles.

10

Æ Advanced technology for superior starting power Æ Enhanced active material to reduce water loss Æ Improved strength and durability Æ Reduced self-discharge for improved battery life

Yuasa Power Series Ultra batteries are the ultimate in battery performance and maintenance free technology.

Featuring specialist internal components, unique design features and industry leading technology to combat the causes of battery failure and deliver reliability, longer life and superior performance.

POWER SERIES ULTRA

†Conditions apply. Refer to individual warranty statements attached to each battery. ãSelected items only.

ITEM

ID

BATT

ERY

TYPE

WAR

RANT

Y

VOLT

S

CCA

-18º

C

RC @

25º

C

AH @

20H

R

H TH

L W

KG


H TH

L W

KG

WEIGHT

H TH

L W

KG

TERM. TYPE

H TH

L W

KG

HOLD DOWN

H TH

L W

KG

SPECIAL FEATURES

H TH

L W

KG

L W H TH

POWER SERIES ULTRA

107220 67 MF 40 12 640 115 64 231 171 184 205 D 15.6 STD SIDE/ENDCH, CI, CV, FA, MF, MIA, MR

107221 67EF MF 40 12 640 115 64 231 171 184 208 D 15.6 STD -CH, CI, CV, FA, MF, MIA, MR

107222 68 MF 40 12 640 115 64 231 171 184 205 C 15.6 STD SIDE/ENDCH, CI, CV, FA, MF, MIA, MR

107224 75D23L MF 40 12 620 120 70 231 171 202 225 C 16.8 STD SIDECH, CI, CV, FA, MF, MIA, MR

107223 75D23R MF 40 12 620 120 70 231 171 202 225 D 16.8 STD SIDECH, CI, CV, FA, MF, MIA, MR

107226 NS40ZLX MF 40 12 410 65 42 196 128 201 220 C 10.9 SP -CH, CI, CV, FA, MF, MIA, MR

107228 NS40ZLSX MF 40 12 410 65 42 196 128 201 220 C 10.9 STD -CH, CI, CV, FA, MF, MIA, MR

107232 NS60LSX MF 40 12 480 80 50 235 128 201 220 C 12.7 STD -CH, CI, CV, FA, MF, MIA, MR

107231 NS60SX MF 40 12 480 80 50 235 128 201 220 D 12.7 STD -CH, CI, CV, FA, MF, MIA, MR

POWER SERIES ULTRA DIN

113206 DIN65LHX MF 40 12 760 145 77 277 175 190 190 C 19.5 STD SIDE/ENDCH, CI, CV, FA, MF, MIA, MR, RP

113207 DIN65RHX MF 40 12 760 145 77 277 175 190 190 D 19.5 STD SIDE/ENDCH, CI, CV, FA, MF, MIA, MR, RP

109204 DIN75LHX MF 40 12 910 180 90 315 175 190 190 C 21.3 STD SIDE/ENDCH, CI, CV, FA, MF, RP

109205 DIN75RHX MF 40 12 910 180 90 315 175 190 190 D 21.3 STD SIDE/ENDCH, CI, CV, FA, MF, RP

4040ã

1111

CAR

& P

ASSE

NGE

R VE

HIC

LE


Yuasa Power Series batteries feature hard wearing internal components to reduce corrosion and enhance vibration resistance, while producing dependable power and performance.

Æ Advanced technology for longer service life Æ Enhanced active material to reduce water loss Æ Improved internal components for superior

corrosion resistance

POWER SERIES

†Conditions apply. Refer to individual warranty statements attached to each battery. ãSelected items only.

Yuasa Power Series DIN batteries have been designed and manufactured to deliver longer life and performance while meeting the fitment requirements of European and imported vehicles.

Æ Calcium technology for reliable starting power Æ Specialist plate design to reduce self-discharge and

water loss Æ Superior grid strength delivering improved corrosion

resistance

POWER SERIESDIN

3030

3030

ã

ã

12

ITEM

ID

BATT

ERY

TYPE

WAR

RANT

Y

VOLT

S

CCA

-18º

C

RC @

25º

C

AH @

20H

R

H TH

L W

KG


H TH

L W

KG

WEIGHT

H TH

L W

KG

TERM. TYPE

H TH

L W

KG

HOLD DOWN

H TH

L W

KG

SPECIAL FEATURES

H TH

L W

KG

L W H TH

POWER SERIES

103220 57 MF 30 12 560 100 57 231 171 184 205 D 14.9 STD SIDE/ENDCH, CI, CV, FA, MF, MIA, MR

103221 57EF MF 30 12 560 100 57 231 171 184 205 D 14.9 STD -CH, CI, CV, FA, MF, MIA, MR

103222 58 MF 30 12 560 100 57 231 171 184 205 C 14.9 STD SIDE/ENDCH, CI, CV, FA, MF, MIA, MR

103225 55D23L MF 30 12 540 105 60 231 171 202 225 C 15.3 STD SIDECH, CI, CV, FA, MF, MIA, MR

103224 55D23R MF 30 12 540 105 60 231 171 202 225 D 15.3 STD SIDECH, CI, CV, FA, MF, MIA, MR

103231 NS40ZL MF 30 12 330 60 40 196 128 201 220 C 10.3 SP -CH, CI, CV, FA, MF, MIA, MR

103230 NS40Z MF 30 12 330 60 40 196 128 201 220 D 10.3 SP -CH, CI, CV, FA, MF, MIA, MR

105218 NS40ZLB MF 30 12 360 63 38 187 136 201 220 C 10.0 SP SIDECH, CI, FA, MF, MR, PL, VR

103233 NS40ZLS MF 30 12 330 60 40 196 128 201 220 C 10.3 STD -CH, CI, CV, FA, MF, MIA, MR

103232 NS40ZS MF 30 12 330 60 40 196 128 201 220 D 10.3 STD -CH, CI, CV, FA, MF, MIA, MR

103227 NS60L MF 30 12 430 75 45 235 128 201 220 C 11.9 SP -CH, CI, CV, FA, MF, MIA, MR

103226 NS60 MF 30 12 430 75 45 235 128 201 220 D 11.9 SP -CH, CI, CV, FA, MF, MIA, MR

103229 NS60LS MF 30 12 430 75 45 235 128 201 220 C 11.9 STD -CH, CI, CV, FA, MF, MIA, MR

103228 NS60S MF 30 12 430 75 45 235 128 201 220 D 11.9 STD -CH, CI, CV, FA, MF, MIA, MR

POWER SERIES DIN

115212 DIN44L MF 30 12 420 70 43 208 175 175 175 C 11.5 STD SIDE/ENDCH, CI, CV, FA, MF, RP, VR

115227 DIN44LH MF 30 12 420 85 50 208 175 190 190 C 11.5 STD SIDE/ENDCH, CI, CV, FA, MF, RP, VR



115215 DIN53R MF 30 12 500 90 54 242 175 175 175 D 13.5 STD SIDE/ENDCH, CI, CV, FA, MF, RP, VR


112202 DIN65LH MF 30 12 660 130 68 277 175 190 190 C 18.4 STD SIDE/ENDCH, CI, CV, FA, MF, MIA, MR, RP

115217 DIN65R MF 30 12 580 120 63 277 175 175 175 D 15.5 STD SIDE/ENDCH, CI, CV, FA, MF, RP, VR

112203 DIN65RH MF 30 12 660 130 68 277 175 190 190 D 18.4 STD SIDE/ENDCH, CI, CV, FA, MF, MIA, MR, RP


115232 DIN75LH MF 30 12 750 160 90 315 175 190 190 C 20.9 STD SIDE/ENDCH, CI, CV, FA, MF, RP

115231 DIN75RH MF 30 12 750 160 90 315 175 190 190 D 20.9 STD SIDE/ENDCH, CI, CV, FA, MF, RP


115220 DIN85LH MF 30 12 760 165 88 353 175 190 190 C 21.5 STD SIDE/ENDCI, CV, FA, MF, RP, VR


1313

CAR

& P

ASSE

NGE

R VE

HIC

LE


4x4 & SUVsKEEPING YOU OFF-ROAD FOR LONGER

WHETHER VENTURING INTO THE OUTBACK, ENJOYING THE HINTERLANDS OR SAMPLING THE TOP END, IT IS IMPORTANT TO HAVE THE RIGHT EQUIPMENT AND THAT INCLUDES YOUR BATTERY.

Excessive under bonnet temperatures, continuous vibration, repeated impact from rough uneven roads and the demands of power hungry accessories, place extreme demands on a battery’s internal components. Yuasa 4x4 batteries are designed and built tough using robust internal components and advanced manufacturing processes to withstand the challenges of Australia’s extreme off-road conditions.

14

IN VEHICLES FITTED WITH MULTIPLE ACCESSORIES WITH HEAVY POWER REQUIREMENTS SUCH AS FRIDGES, A DUAL BATTERY SYSTEM UTILISING A SECONDARY DEEP CYCLE BATTERY IS RECOMMENDED.Dual battery systems run a dedicated starting battery and a Deep Cycle battery in conjunction with each other. This allows the starting battery to be used for cranking the engine and then isolated when the engine is switched off. The Deep Cycle battery is then used to power accessories such as the fridge, without compromising the performance of the starting battery. Yuasa has an extensive range of Deep Cycle batteries ideal for use in 4WD dual battery systems. See the Deep Cycle battery section for more information on the Yuasa Deep Cycle range.

Dual Battery Systems

OVERLANDER 4x4

†Conditions apply. Refer to individual warranty statements attached to each battery. ãSelected items only. #Available November 2020.

Æ Hybrid technology for reliable starting power Æ Dual purpose – starting and semi cycling capabilities for

4WD accessories Æ Thicker full frame cast plates for improved strength and

durability in 4x4 conditions Æ Glass mat separator for enhanced endurance and

vibration resistance

Yuasa Overlander 4x4 batteries are ideal for true off-road enthusiasts, designed and built tough here in Australia to suit our extreme climate and harsh off road conditions. Built from incredibly strong internal components to provide reliable long lasting performance.

ITEM

ID

BATT

ERY

TYPE

WAR

RANT

Y

VOLT

S

CCA

-18º

C

RC @

25º

C

AH @

20H

R

H TH

L W

KG


H TH

L W

KG

WEIGHT

H TH

L W

KG

TERM. TYPE

H TH

L W

KG

HOLD DOWN

H TH

L W

KG

SPECIAL FEATURES

H TH

L W

KG

L W H TH

OVERLANDER 4X4

122235 N70ZZXHD 36 12 735 180 100 305 171 202 225 D 24.3 STD/WN SIDECH, CI, GM, LM, MR, MIA, PL, VR

122236 N70ZZLXHD 36 12 735 180 100 305 171 202 225 C 24.3 STD/WN SIDECH, CI, GM, LM, MR, MIA, PL, VR

125238 DIN65L HD MF# 30 12 650 110 65 275 175 175 175 C 17.0 STD SIDE/ENDCH, CI, FA, MF, PL, RP, VR

125235 DIN65LHHDMF 30 12 650 120 70 275 175 190 190 C 19.1 STD SIDE/ENDCH, CI, FA, MF, PL, RP, VR

125239 DIN75L HD MF# 30 12 730 135 75 313 175 175 175 C 19.1 STD SIDE/ENDCH, CI, FA, MF, PL, RP, VR

125236 DIN75LHHDMF 30 12 730 145 80 313 175 190 190 C 21.2 STD SIDE/ENDCH, CI, FA, MF, PL, RP, VR

3636ã

1515

4X4

& S

UVs


POWER SERIES ULTRA

POWER SERIES

Æ Advanced technology for superior starting power Æ Full frame cast positive plates for improved strength

and durability^ Æ Reduced self-discharge for improved battery life

Æ Advanced technology for reliable starting power Æ Specialist plate design to reduce electrical resistance and

water loss

Yuasa Power Series Ultra batteries are ideal for road based and soft off-road use in the latest urban 4x4s and SUVs. Designed and built for Australian conditions from hard wearing durable materials.

Yuasa Power Series Ultra batteries are ideal for use in road based 4x4s and SUVs. Designed and built for Australian conditions providing dependable performance and durability.

†Conditions apply. Refer to individual warranty statements attached to each battery. ^Positive plate only.

3030

2020

16

ITEM

ID

BATT

ERY

TYPE

WAR

RANT

Y

VOLT

S

CCA

-18º

C

RC @

25º

C

AH @

20H

R

H TH

L W

KG


H TH

L W

KG

WEIGHT

H TH

L W

KG

TERM. TYPE

H TH

L W

KG

HOLD DOWN

H TH

L W

KG

SPECIAL FEATURES

H TH

L W

KG

L W H TH

POWER SERIES ULTRA

127220 N70ZZX MF 30 12 810 185 95 305 171 202 225 D 23.4 STD SIDECH, CI, CV, FA, MF, MIA, MR, PL, VR

127221 N70ZZLX MF 30 12 810 185 95 305 171 202 225 C 23.4 STD SIDECH, CI, CV, FA, MF, MIA, MR, PL, VR

127236 NS70X MF 30 12 720 160 85 259 171 202 225 D 19.5 STD SIDECH, CI, CV, FA, MF, MIA, MR, PL, VR

127237 NS70LX MF 30 12 720 160 85 259 171 202 225 C 19.5 STD SIDECH, CI, CV, FA, MF, MIA, MR, PL, VR

ITEM

ID

BATT

ERY

TYPE

WAR

RANT

Y

VOLT

S

CCA

-18º

C

RC @

25º

C

AH @

20H

R

H TH

L W

KG


H TH

L W

KG

WEIGHT

H TH

L W

KG

TERM. TYPE

H TH

L W

KG

HOLD DOWN

H TH

L W

KG

SPECIAL FEATURES

H TH

L W

KG

L W H TH

POWER SERIES

123220 N70ZZ MF 20 12 720 170 85 305 171 202 225 D 21.9 STD SIDECH, CI, CV, FA, MF, MIA, MR

123221 N70ZZL MF 20 12 720 170 85 305 171 202 225 C 21.9 STD SIDECH, CI, CV, FA, MF, MIA, MR

123236 NS70 MF 24 12 650 140 75 259 171 202 225 D 18.7 STD SIDECH, CI, CV, FA, MF, MIA, MR

123237 NS70L MF 24 12 650 140 75 259 171 202 225 C 18.7 STD SIDECH, CI, CV, FA, MF, MIA, MR

1717

4X4

& S

UVs

TRUCK, BUS & HEAVY EQUIPMENTBATTERIES BUILT TOUGH FOR AUSTRALIAN CONDITIONS

YUASA TRUCK, BUS AND HEAVY EQUIPMENT BATTERIES REPRESENT THE LATEST IN PERFORMANCE AND RELIABILITY FOR HAULAGE AND LIGHT COMMERCIAL VEHICLES. DESIGNED AND BUILT IN AUSTRALIA* TO BETTER SUIT OUR HARSH ENVIRONMENT AND EXTREME CLIMATE, THEY DELIVER WHAT DRIVERS AND FLEET MANAGERS REALLY WANT — LONGER LIFE WITH LESS DOWN TIME.

Delivering more than just superior starting power, Yuasa Truck, Bus and Heavy Equipment batteries can sustain constant current loads over extended periods, to run on-board accessories for longer.

*Selected items only.


18

Æ Hybrid technology for superior performance and to sustain constant current loads for on-board accessories^

Æ Thicker full frame cast plates for improved strength and durability in commercial conditions^

Æ Glass mat separator for enhanced endurance and vibration resistance^

Æ Platelock™ technology to combat vibration and damage from rough uneven roads

Yuasa Power Series Ultra batteries are the clear choice for professional drivers. Incorporating industry leading design features and specialist internal components, these batteries provide exceptional performance and longer life in heavy haulage applications.

†Conditions apply. Refer to individual warranty statements attached to each battery. ^Selected items only.

POWER SERIES ULTRA

ITEM

ID

BATT

ERY

TYPE

WAR

RANT

Y

VOLT

S

CCA

-18º

C

RC @

25º

C

AH @

20H

R

H TH

L W

KG


H TH

L W

KG

WEIGHT

H TH

L W

KG

TERM. TYPE

H TH

L W

KG

HOLD DOWN

H TH

L W

KG

SPECIAL FEATURES

H TH

L W

KG

L W H TH

POWER SERIES ULTRA

122232 N70ZZHX 18 12 730 180 95 305 171 202 225 D 23.9 STD SIDECH, CI, GM, LM, MIA, MR, PL, VR

122233 N70ZZLHX 18 12 730 180 95 305 171 202 225 C 23.9 STD SIDECH, CI, GM, LM, MIA, MR, PL, VR

127234 NS70HX MF 18 12 720 160 85 259 171 202 225 D 19.5 STD SIDECH, CI, MF, MIA, MR, PL, VR

127235 NS70LHX MF 18 12 720 160 85 259 171 202 225 C 19.5 STD SIDECH, CI, MF, MIA, MR, PL, VR

1818

1919

TRU

CK, B

US

& H

EAVY

EQU

IPM

ENT

RAN

GE

^

^

1212


POWERSERIES

HEAVY DUTY

Æ Calcium technology for lower self-discharge and reduced water loss

Æ Thicker positive plates for improved strength and durability in short-haul conditions^

Æ Platelock™ technology to combat vibration and damage from rough uneven roads^

Æ Superior starting power Æ Thicker plates and denser active material for improved

strength and durability in commercial conditions Æ Designed to combat damage from vibration and impact

Yuasa Heavy Duty batteries are manufactured using some of the toughest internal components and materials available in the battery industry. Yuasa Heavy Duty batteries are designed and built tough to provide superior power and performance in truck, bus and heavy equipment vehicles.

SUPERIORSTARTING POWER

†Conditions apply. Refer to individual warranty statements attached to each battery. ^Selected items only.

Yuasa Power Series batteries are designed and built tough in Australia to provide dependable performance and reliability in short haul off- highway applications.^

^^

^

1212

20

ITEM

ID

BATT

ERY

TYPE

WAR

RANT

Y

VOLT

S

CCA

-18º

C

RC @

25º

C

AH @

20H

R

H TH

L W

KG


H TH

L W

KG

WEIGHT

H TH

L W

KG

TERM. TYPE

H TH

L W

KG

HOLD DOWN

H TH

L W

KG

SPECIAL FEATURES

H TH

L W

KG

L W H TH

HEAVY DUTY

125207 86Z MF 12 12 950 180 95 330 170 217 238 H 24.0 STD -CH, CI, CV, FA, MF, MR, PL, VR

125208 86ZT MF 12 12 950 180 95 330 170 217 238 H 24.0 TH -CH, CI, CV, FA, MF, MR, PL, VR

121221 94 Squat 12 12 890 255 135 506 206 180 203 E 35.7 STD -CH, CV, FA, GM, LM, MR, PL, VR

125209 N100 MF 12 12 740 182 100 405 175 210 235 D 25.1 STD -CH, CI, CV, FA, GM, MF, MR, PL, VR

125214 N100L MF 12 12 740 182 100 405 175 210 235 C 25.1 STD -CH, CI, CV, FA, GM, MF, MR, PL, VR

125210 N120 MF 12 12 900 230 135 505 180 210 240 F 32.1 STD -CH, CI, CV, FA, MF, MR, PL, VR

125230 N120L MF 12 12 900 230 135 505 180 210 240 E 32.1 STD -CH, CI, CV, FA, MF, MR, PL, VR


125216 N150L MF 12 12 1000 300 155 500 220 210 235 E 38.4 STD -CH, CI, CV, FA, MF, MR, PL, VR


ITEM

ID

BATT

ERY

TYPE

WAR

RANT

Y

VOLT

S

CCA

-18º

C

RC @

25º

C

AH @

20H

R

H TH

L W

KG


H TH

L W

KG

WEIGHT

H TH

L W

KG

TERM. TYPE

H TH

L W

KG

HOLD DOWN

H TH

L W

KG

SPECIAL FEATURES

H TH

L W

KG

L W H TH

POWER SERIES

123224 N70ZZH MF 12 12 780 160 90 305 171 202 225 D 23.9 STD SIDECH, CI, CV, FA, MF, MR, MIA, PL, VR

123225 N70ZZLH MF 12 12 780 160 90 305 171 202 225 C 23.9 STD SIDECH, CI, CV, FA, MF, MR, MIA, PL, VR

123232 NS70H MF 12 12 650 140 75 259 171 202 225 D 18.7 STD SIDECH, CI, CV, FA, MF, MIA, MR

123233 NS70LH MF 12 12 650 140 75 259 171 202 225 C 18.7 STD SIDECH, CI, CV, FA, MF, MIA, MR

2121

TRU

CK, B

US

& H

EAVY

EQU

IPM

ENT


DEEP CYCLE RELIABLE DEEP CYCLE POWERYUASA DEEP CYCLE BATTERIES ARE MANUFACTURED USING THE TOUGHEST INTERNAL COMPONENTS AND LATEST DESIGN FEATURES TO DELIVER LONG-LASTING, DEPENDABLE DEEP CYCLE POWER.

A range of maintainable and maintenance free batteries built strong for Australia’s harsh environment and tough operating conditions. Designed to provide superior deep cycling performance in a diverse range of recreational and commercial applications.

SEASONAL USE For seasonal use, fully recharge the battery before putting into storage. Check the state-of-charge or voltage regularly. Should the voltage drop below 12.5V, recharge the battery.

It is important to check the battery completely before reconnecting to the electrical devices.

22

ITEM

ID

BATT

ERY

TYPE

WAR

RANT

Y

VOLT

S

CCA

-18º

C

RC @

25º

C

AH @

20H

R

H TH

L W

KG


H TH

L W

KG

WEIGHT

H TH

L W

KG

TERM. TYPE

H TH

L W

KG

HOLD DOWN

H TH

L W

KG

SPECIAL FEATURES

H TH

L W

KG

L W H TH

DEEP CYCLE FLOODED

141209 12A 12 6 - - 105 227 173 184 205 A 15.8 STD - CH, GM, LM

145203 D23LT MF 12 12 - - 65 230 171 202 222 C 17.1 STD - CH, CI, FA, MF

145202 D23RT MF 12 12 - - 65 230 171 202 222 D 17.1 STD - CH, CI, FA, MF

141228 N70T 18 12 - - 102 305 171 202 222 D 25.1 STD/WN -CH, CI, GM, LM, MIA, MR, PL, VR

145200 N70TX MF 12 12 - - 95 302 172 202 225 D 21.2 STD/WN SIDECH, CI, CV, FA, GM, MF, MR, PL, VR

145201 NS70TX MF 12 12 - - 82 260 171 202 222 D 18.6 STD/WN SIDECH, CI, CV, FA, GM, MF, MR, PL, VR

ã

1818

Æ Full frame cast plates for improved strength and durability Æ Designed to withstand repeated recharge and

discharge cycles Æ Maintainable design for maximum battery life and superior

performance in hotter environments#

Yuasa Flooded Deep Cycle batteries are designed and built to suit Australia’s extreme climate and harsh operating conditions.

DEEP CYCLE FLOODED

†Conditions apply. Refer to individual warranty statements attached to each battery. ãN70T only. #12A and N70T only.

#

RECREATIONALVEHICLES

MARINESYSTEMS

MOBILITYSCOOTERS

GOLFCARTS

SOLARSYSTEMS

WORK PLATFORMS/SCISSOR LIFTS

BOOMLIFTS

DUAL BATTERYSYSTEMS

FLOOR SWEEPERS& SCRUBBERS

4X4CARAVAN &CAMPER TRAILERS


MARINESYSTEMS

MOBILITYSCOOTERS

GOLFCARTS

SOLARSYSTEMS


BOOMLIFTS

DUAL BATTERYSYSTEMS




MARINESYSTEMS

MOBILITYSCOOTERS

GOLFCARTS

SOLARSYSTEMS


BOOMLIFTS

DUAL BATTERYSYSTEMS




MARINESYSTEMS

MOBILITYSCOOTERS

GOLFCARTS

SOLARSYSTEMS


BOOMLIFTS

DUAL BATTERYSYSTEMS




MARINESYSTEMS

MOBILITYSCOOTERS

GOLFCARTS

SOLARSYSTEMS


BOOMLIFTS

DUAL BATTERYSYSTEMS




MARINESYSTEMS

MOBILITYSCOOTERS

GOLFCARTS

SOLARSYSTEMS


BOOMLIFTS

DUAL BATTERYSYSTEMS




MARINESYSTEMS

MOBILITYSCOOTERS

GOLFCARTS

SOLARSYSTEMS


BOOMLIFTS

DUAL BATTERYSYSTEMS



2323

DEEP

CYC

LE


MARINE TECHNOLOGY YOUR BOAT DESERVES

The Yuasa Seafarer range includes a comprehensive selection of superior quality marine batteries, incorporating advanced design features and specialist hard-wearing components for all marine applications. The range is equipped to handle the rigours of wave pounding, engine vibration and trailer transport while delivering reliable starting power and performance.

Warning: Threaded Terminal Usage The small threaded terminals on Yuasa Seafarer batteries are designed for powering low current draw accessories such as fish finders or GPS units, and should never be used for engine starting purposes.

In rare instances, running a sustained high current draw (such as cranking an engine repeatedly and for extended periods of time) through the small threaded terminals could possibly damage your battery. This is due to the smaller terminals having a higher resistance when compared to the main terminals, with more heat being generated under high loads as a result.

24

Æ Superior starting power Æ Thicker full frame cast plates for improved strength and

durability in marine applications^ Æ Dual purpose - starting and semi cycling capabilities for

on-board accessories Æ Designed to combat the effects of wave pounding, engine

vibration and damage from trailer transportation

Yuasa Seafarer batteries are the ultimate in marine battery performance, designed and built tough here in Australia to suit our conditions.

SEAFARER RANGE

Car Batteries V Marine BatteriesUnlike car batteries which generally travel on smooth, sealed roads, marine

batteries must be able to resist vibration from wave pounding and trailer transport.

Repeated vibration and wave impact on non-marine batteries can cause damage

and cracks to appear in the battery’s internal components and outer case. This

can cause shedding of active materials, accelerate corrosion, electrolyte leaks and

ultimately lead to battery failure.

Car batteries are designed to deliver concentrated bursts of power to crank over and start the engine. The capacity used is replaced by the alternator which charges the battery during the journey. Marine batteries must not only have the starting power to crank over high compression engines but also provide the reserve capacity needed to run on board accessories.When choosing a marine battery it is critical to invest in a battery that has been designed and manufactured specifically to handle the extreme demands of marine environments and modern extensive electrical systems.

†Conditions apply. Refer to individual warranty statements attached to each battery. ^Positive plate only. *Not recommended for semi-cycling applications. #N70ZM MF only.

2424

ITEM

ID

BATT

ERY

TYPE

WAR

RANT

Y

VOLT

S

CCA

-18º

C

MCA

@0º

C

RC @

25ºC

AH @

20H

R

DIMENSIONS (MM)

POLA

RITY

WEI

GHT

TERM

. TYP

E

HOLD

DOW

N

SPEC

IAL

FEAT

URES

STAR

TS

ENGI

NES

ELEC

TRIC

S

L W H TH

SEAFARER

133200 D23RM MF* 24 12 580 750 120 65 231 171 202 225 D 16.4 STD -CH, CI, LM, MIA, MR, PL, VR

Up to 70hp

-

133201 NS70M MF 24 12 680 880 155 75 260 171 202 225 D 21.0 STD/WN SIDECH, CI, GM, LM, MIA, MR, PL, VR

Up to 150hp

Basic

133202 N70ZM MF 24 12 780 1000 180 100 305 171 202 225 D 25.1 STD/WN -CH, CI, GM, LM, MIA, MR, PL, VR

Up to 350hp

Basic+ 2 optional electrics

#

2525

MAR

INE

LAWN & GARDEN POWER & PERFORMANCE FROM SEASON TO SEASON

Yuasa Yard Master batteries represent the latest in small engine starting technology for ride-on mowers, personal watercraft, generators and some small cars, built tough for Australia’s extreme climate and harsh conditions.


26

FOR LAWN AND GARDEN EQUIPMENT

ITEM

ID

BATT

ERY

TYPE

WAR

RANT

Y

VOLT

S

CCA

-18º

C

RC @

25º

C

AH @

20H

R

H TH

L W

KG


H TH

L W

KG

WEIGHT

H TH

L W

KG

TERM. TYPE

H TH

L W

KG

HOLD DOWN

H TH

L W

KG

SPECIAL FEATURES

H TH

L W

KG

L W H TH

YARD MASTER

160202 U1 MF 12 12 300 45 28 195 125 155 182 D 7.8 LUG -CH, CV, FA, MF, MR, PL, VR

160203 U1R MF 12 12 300 45 28 195 125 155 182 C 7.8 LUG -CH, CV, FA, MF, MR, PL, VR

2727

LAW

N &

GAR

DEN

Æ Maintenance free design Æ Calcium technology for lower self-discharge and longer life Æ Platelock™ technology to combat vibration damage Æ Sealed design for added protection against dirt, dust

and grass

Developed from some of the most advanced technical resources, Yuasa Yard Master Maintenance Free batteries are designed to deliver superior starting power and performance in constant stop start applications.

YARD MASTER

†Conditions apply. Refer to individual warranty statements attached to each battery.

DESIGNEDFOR AUSTRALIAN

CONDITIONS

BUILT TO COMBAT

VIBRATION

FOR LAWN AND GARDEN EQUIPMENT

1212

1. Check the battery’s state of charge. Most batteries have a State of Charge Indicator on top of the battery that will give you an on the spot diagnosis of the battery condition. However, a more reliable way to check is with a voltmeter to determine the stabilised voltage or if the vent caps are removable a hydrometer to determine the specific gravity (SG) of the electrolyte. A charged Century battery will have a stabilised voltage above 12.5 volts and an SG reading above 1.240.

2. Ensure the battery top is clean, dry, free of dirt and grime. A dirty battery can discharge across the grime on top of the battery casing.

3. Inspect the terminals, screws, clamps and cables for breakage, damage or loose connections. These should be clean, tight and free of corrosion.

4. Apply a thin coating of high temperature grease or battery terminal spray to posts and cable connections for added protection.

5. Inspect the battery case for obvious signs of physical damage or warpage. This usually indicates the battery has been overheated or has been overcharged.

6. If a maintainable battery, it is important to check if the battery has sufficient electrolyte covering the battery plates. If topping up is required, do not over fill as the fluid levels will rise when the battery is fully charged and may overflow. Top up using distilled or demineralised water and never fill with sulphuric acid.

7. When servicing a sealed maintenance free (SMF) battery, check the State of Charge Indicator (SOC) on top of the battery. The SOC Indicator (depicted right) gives you a snap shot of the batteries condition and whether the battery needs to be charged or replaced. The vehicle may still start although the indicator outlines to replace the battery. If the charge indicator advises ‘Replace Battery’ it is important to contact an Century Yuasa representative for further testing and evaluation. If the electrolyte levels are too low exposing the lead plates the battery will need to be replaced to prevent the risk of an internal explosion.

8. For batteries used in seasonal applications and stored long term, fully recharge the battery prior to storing. Check the state of charge or voltage regularly. Should the voltage drop below 12.5 volts, recharge the battery. It is important to check the battery completely before reconnecting to electrical devices.

Use the following as a guide when examining the battery:

^ Always follow manufacturers guidelines.† State of Charge Indicator for locally made product depicted. Appearance may vary.

Battery Care & Maintenance^

REGULAR TESTING AND INSPECTION WILL HELP TO MAXIMISE BATTERY LIFE. A ROUTINE INSPECTION AT LEAST ONCE A MONTH IS RECOMMENDED TO MAINTAIN OPTIMUM PERFORMANCE.

28

Quality GuaranteedCentury Yuasa operates a quality management system that complies with the requirements of ISO/TS16949 : 2009, a quality management system that provides for continual improvement, defect prevention and the reduction of variation in the automotive industry supply chain.

Century Yuasa Nationwide Warranty

Each Yuasa battery is supplied with a warranty against defects for the period and application, as detailed on each battery. Call 1300 361 161 for your nearest warranty claim location.

If our testing determines the battery is defective we will replace it, however the costs of delivering it to the warranty location and collecting it and any replacement are yours. The claim must be made within the warranty period listed on top of the battery. Dated proof of purchase is required. The warranty period for replacement starts on the date of purchase of the defective battery it replaces. Call 1300 361 161 to make a claim. This warranty does not cover defects due to normal wear, abuse, damage, neglect, over or under charging or incorrect application, installation or maintenance.

This warranty is in addition to other rights and remedies available at law. Our goods come with guarantees that cannot be excluded under the Australian Consumer Law. You are entitled to a replacement or refund for a major failure and for compensation for any other reasonably foreseeable loss or damage. You are also entitled to have the goods repaired or replaced if the goods fail to be of acceptable quality and the failure does not amount to a major failure.

Century Yuasa Batteries Pty Limited, 37–65 Cobalt Street, Carole Park QLD 4300, 1300 362 287.

29

BATT

ERY

CARE

& M

AIN

TEN

ANCE

- C

ENTU

RY Y

UAS

A N

ATIO

NW

IDE

WAR

RAN

TY

For more information on the Yuasa range of products and services, contact your nearest

Yuasa Sales office on 1300 362 287

YU103-2844

Documents

AUSTRALIA IS A UNIQUE NOWHERE QUITE LIKE IT OR LIKE THE ... · AUSTRALIA IS A UNIQUE PLACE, THERE’S NOWHERE QUITE LIKE IT OR LIKE THE PEOPLE IN IT. When it comes to our vehicles