13
Attachment 14 Heat and Material Balance

Attachment 14 Heat and Material Balance - Alberta.ca · 2019. 2. 14. · SUNCOR LEWIS PH 1 2 HEAT MATERIAL BALANCE TABLE. 2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011

  • Upload
    others

  • View
    2

  • Download
    0

Embed Size (px)

Citation preview

Page 1: Attachment 14 Heat and Material Balance - Alberta.ca · 2019. 2. 14. · SUNCOR LEWIS PH 1 2 HEAT MATERIAL BALANCE TABLE. 2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011

Attachment 14

Heat and Material Balance

Page 2: Attachment 14 Heat and Material Balance - Alberta.ca · 2019. 2. 14. · SUNCOR LEWIS PH 1 2 HEAT MATERIAL BALANCE TABLE. 2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011

SUNCOR LEWIS PH 1 2HEAT MATERIAL BALANCE TABLE

1000 1001 1002 1003 1004 1005 1006 1007 1008 1009 1010 1011 1012 1013 1014 1015 1016 1017 1018 1019Produced emulsion

De‐gassed Emulsion

Cooled Emulsion  Cooled Emulsion  Wet dilbit Produced Water  Produced Gas  Produced Gas  Produced Water  Produced Water  Dilbit Dilbit Dilbit Produced Gas  Produced Gas  Produced Gas  DiluentRecovered Diluent

Recovered Diluent

Produced Gas 

CPF B/L  Inlet Separator Emul./BFW HE Static Mixer FWKO FWKO  Inlet Separator FWKO Treater FWKO / Treater Treater Dilbit Cooler  Dilbit Header Treater Gas Boot PG HeaderDiluent Rec. 

Cooler Diluent Rec. Trim Cooler

Diluent Rec. Pumps 

Diluent Rec.  Separator

Inlet Separator Emul./BFW HE Static Mixer FWKO Treaters PW HeaderEvap. Vent Condenser

PG Header PW Header CFU Gas Boot Dilbit Header HC Tank farm PG Header PG HeaderDiluent Rec. 

CoolerDiluent Rec. Trim Cooler

Diluent Rec. Separator

FWKO Feed Header

MFG Drum

Vapour Fraction 0.000 0.000 0.000 0.001 0.008 0.000 1.000 1.000 0.000 0.000 0.265 0.000 0.062 1.000 1.000 1.000 0.087 0.019 0.000 1.000Operating Temperature °C 193.0 194.6 141.1 136.1 135.5 136.1 181.3 127.3 135.5 136.1 122.1 55.0 53.0 127.4 120.5 122.1 54.0 12.0 12.6 11.5

Operating Pressure kPaa 2,000 1,794 1,494 1,394 1,294 1,179 423 460 1,179 1,179 600 530 93 460 460 460 410 403 1,394 353Mass Flow kg/h 1,088,173 1,105,337 1,105,337 1,168,296 361,942 804,523 651 1,831 34,454 838,977 326,071 304,526 304,526 1,417 22,546 30,138 30,138 30,138 29,835 303

Mass Density kg/m3 862.0 870.2 918.1 851.8 759.7 915.0 2.1 6.9 917.5 915.2 133.0 970.4 128.4 7.1 8.0 8.0 86.1 284.6 657.8 4.4Molecular Weight kg/kgmole 23.58 23.46 23.46 24.26 102.70 18.04 18.49 48.02 18.02 18.04 206.00 261.20 261.20 49.15 53.77 53.96 53.96 53.96 54.44 28.68

Mass Heat Capacity kJ/kg‐C 4.21 4.23 3.95 3.87 2.45 4.50 2.05 2.11 4.51 4.50 2.14 1.88 1.86 2.11 2.09 2.10 2.54 2.34 2.35 1.73Thermal Conductivity W/m‐K 0.000 0.477 0.483 0.000 0.000 0.686 0.037 0.027 0.688 0.686 0.000 0.115 0.000 0.026 0.024 0.024 0.000 0.000 0.114 0.025

Combined Liquid 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0Mass Flow kg/h 1,088,024 1,105,337 1,105,337 1,166,465 360,525 804,487 0 0 34,454 838,942 303,494 304,526 300,182 0 0 0 27,782 29,835 29,835 0

Std Ideal Liq Vol Flow m3/h 1,088 1,105 1,105 1,197 388 806 0 0 35 841 319 320 313 0 ‐ 0 42 46 46 ‐Actual Volume Flow m3/h 1,248 1,270 1,204 1,290 410 877 0 0 38 915 331 314 308 0 ‐ 0 45 45 45 ‐

Mass Density kg/m3 872.2 870.2 918.1 904.3 879.5 916.9 940.8 915.3 917.5 917.0 917.9 970.4 974.3 917.4 ‐ 976.3 617.6 657.4 657.8 ‐Molecular Weight kg/kgmole 23.58 23.46 23.46 24.24 103.15 18.04 535.10 322.88 18.02 18.04 260.94 261.20 274.49 323.53 ‐ 392.08 54.50 54.44 54.44 ‐

Viscosity cP 2.55 2.51 9.64 1.24 3.71 0.20 55.90 17.81 0.20 0.21 4.00 127.81 175.75 18.37 ‐ 83.16 0.21 0.28 0.28 ‐Thermal Conductivity W/m‐K 0.47 0.48 0.48 0.42 0.11 0.69 0.12 0.11 0.69 0.69 0.10 0.12 0.12 0.11 ‐ 0.11 0.10 0.11 0.11 ‐

OilMass Flow kg/h 268,337 268,274 267,779 326,955 324,440 1,176 0 0 0 1,176 303,494 304,334 144,259 0 0 0 25,388 27,399 27,400 0

Std Ideal Liq Vol Flow m3/h 266 266 266 356 352 1 0 0 ‐ 1 319 320 143 0 ‐ 0 40 44 44 ‐Actual Volume Flow m3/h 296 297 286 375 371 1 0 0 ‐ 1 331 314 141 0 ‐ 0 43 43 43 ‐

Mass Density (Note 3) kg/m3 901.1 900.2 932.6 854.7 856.8 856.3 941 915 ‐ 856.3 856.3 933.6 934.8 917 ‐ 976 597 637 638 ‐API Gravity (STD) °API 10 10 10 14 21 10 68 98 ‐ 10 22 17 17 95 ‐ 88 88 88 87 ‐Molecular Weight kg/kgmole 413.35 415.31 433.10 214.99 217.40 229.26 535.10 322.88 ‐ 229.23 260.94 263.44 374.40 323.53 ‐ 392.08 67.36 66.37 66.36 ‐Viscosity (Note 4)  cP 9.91 9.90 39.17 3.90 4.10 4.04 55.90 17.81 ‐ 4.00 4.00 127.89 175.75 18.37 ‐ 83.16 0.17 0.24 0.23 ‐

Thermal Conductivity W/m‐K 0.129 0.130 0.124 0.094 0.095 0.097 0.121 0.109 ‐ 0.097 0.103 0.115 0.122 0.109 ‐ 0.111 0.095 0.106 0.105 ‐Water

Mass Flow kg/h 819,687 837,063 837,558 839,510 36,085 803,311 0 0 34,454 837,766 0 192 0 0 0 0 2,393 2,436 2,435 0Std Ideal Liq Vol Flow m3/h 821 839 839 841 36 805 ‐ ‐ 35 839 ‐ 0 ‐ ‐ ‐ ‐ 2 2 2 ‐Actual Volume Flow m3/h 951 973 918 915 39 876 ‐ ‐ 38 914 ‐ 0 ‐ ‐ ‐ ‐ 2 2 2 ‐

Mass Density kg/m3 861.8 859.9 912.6 917.1 917.6 917.0 ‐ ‐ 917.5 917.0 ‐ 984.5 ‐ ‐ ‐ ‐ 985.3 1,017.2 1,017.1 ‐Viscosity cP 0.14 0.14 0.19 0.20 0.20 0.20 ‐ ‐ 0.20 0.20 ‐ 0.50 ‐ ‐ ‐ ‐ 0.51 1.23 1.21 ‐

Thermal Conductivity W/m‐K 0.669 0.668 0.688 0.688 0.688 0.688 ‐ ‐ 0.688 0.688 ‐ 0.649 ‐ ‐ ‐ ‐ 0.648 0.590 0.591 ‐Vapour

Mass Flow kg/h 149 0 0 1,831 1,417 36 651 1,831 0 35 22,577 0 4,344 1,417 22,546 30,138 2,356 303 0 303Std Gas Flow STD_m3/h 192 ‐ ‐ 901 682 17 832 901 ‐ 17 9,925 ‐ 1,709 682 9,915 13,207 1,155 250 ‐ 250

Molecular Weight kg/kgmole 18.3 ‐ ‐ 48.0 49.1 49.3 18.5 48.0 ‐ 49.2 53.8 ‐ 60.1 49.1 53.8 54.0 48.2 28.7 ‐ 28.7Mass Density kg/m3 9.9 ‐ ‐ 22.4 21.3 19.2 2.1 6.9 ‐ 19.2 10.6 ‐ 2.1 7.1 8.0 8.0 7.7 5.0 ‐ 4.4

Viscosity cP 0.014 ‐ ‐ 0.011 0.011 0.011 0.013 0.011 ‐ 0.011 0.010 ‐ 0.007 0.010 0.009 0.010 0.010 0.011 ‐ 0.011Cp/(Cp‐R) (Ideal Gamma) 1.1 ‐ ‐ 1.1 1.0 1.1 1.3 1.1 ‐ 1.1 1.0 ‐ 1.0 1.1 1.1 1.1 1.1 1.1 ‐ 1.2

Z Factor 0.9 ‐ ‐ 0.9 0.9 0.9 1.0 1.0 ‐ 0.9 0.9 ‐ 1.0 1.0 0.9 0.9 0.9 1.0 ‐ 1.0Thermal Conductivity W/m‐K 0.0 ‐ ‐ 0.0 0.0 0.0 0.0 0.0 ‐ 0.0 0.0 ‐ 0.0 0.0 0.0 0.0 0.0 0.0 ‐ 0.0

H2O 0.9867 0.9871 0.9871 0.9684 0.5790 0.9998 0.7838 0.2293 1.0000 0.9998 0.0766 0.0109 0.0109 0.2418 0.2590 0.2421 0.2421 0.2421 0.2467 0.0035H2S 0.00000 0.00000 0.00000 0.00001 0.00003 0.00000 0.00032 0.00043 0.00000 0.00000 0.00006 0.00001 0.00001 0.00042 0.00019 0.00021 0.00021 0.00021 0.00019 0.00131CO2 0.0001 0.0001 0.0001 0.0001 0.0009 0.0001 0.0204 0.0251 0.0000 0.0001 0.0016 0.0002 0.0002 0.0219 0.0054 0.0072 0.0072 0.0072 0.0053 0.1078

Helium 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Nitrogen 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

Air 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Methane 0.0003 0.0001 0.0001 0.0003 0.0024 0.0000 0.1937 0.1214 0.0000 0.0000 0.0036 0.0002 0.0002 0.0908 0.0129 0.0232 0.0232 0.0232 0.0114 0.6345Ethane 0.0000 0.0000 0.0000 0.0001 0.0008 0.0000 0.0000 0.0176 0.0000 0.0000 0.0016 0.0003 0.0003 0.0161 0.0052 0.0064 0.0064 0.0064 0.0056 0.0483

Propane 0.0000 0.0000 0.0000 0.0004 0.0049 0.0000 0.0000 0.0507 0.0000 0.0000 0.0099 0.0032 0.0032 0.0501 0.0285 0.0315 0.0315 0.0315 0.0308 0.0666C4+ 0.0129 0.0127 0.0127 0.0307 0.4120 0.0001 0.0018 0.5555 0.0000 0.0001 0.9067 0.9852 0.9852 0.5788 0.6888 0.6893 0.6893 0.6893 0.7000 0.1380

NOTES:1. Values are for each 40,000 bpd phase for Phases 1 & 2. SUNCOR LEWIS PH 1 & 2

AREA 1000 ‐ OIL TREATINGHEAT AND MATERIAL BALANCE

PROJECT # DRAWING NUMBER REVISION

 40,000 BPSD

Stream Number

To

Overall Composition Mole Fraction

Overall

Stream Name

From

Area 1000 HMB (1,2) - Page 1 of 12

lehanson
Typewritten Text
Figure 1
Page 3: Attachment 14 Heat and Material Balance - Alberta.ca · 2019. 2. 14. · SUNCOR LEWIS PH 1 2 HEAT MATERIAL BALANCE TABLE. 2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011

SUNCOR LEWIS PH 1 2HEAT MATERIAL BALANCE TABLE

2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011 3000 3001 3002 3003 3004 3005 3006 3007

Produced water CFU froth De‐oiled waterDe‐oiled / 

makeup waterCasing gas  Slop vapours  Slop oil  Slop water Produced Gas Produced Gas PG Condensate Produced Gas Evap vapors

Combined vapors

Condensate  Condensate  Distillate Evaporator BD Vapors Ejector gas

Produced water header 

CFU CFUProducedWater Surge Drum

B/L Pipeline Slop Vessel Slop Vessel Slop VesselProduced Gas 

HeaderProduced Gas Condenser

PG Condensate Pump

PG Condenser Separator

Evaporator  HeaderEvap Vent Condenser

Evap Cond. Pumps 

Evaporator  Evaporator Evap Vent Cond 

Separator Fuel gas header

CFU  Slop VesselProducedWater Surge Drum

Evaporator  Slop vesselProduced Gas 

HeaderGas Boot  CFU

Produced Gas Condenser

PG Condenser Separator

Slop VesselProduced Gas 

HeaderEvap. Vent Condenser

Evap. Vent Condenser

Evap Vent Cond Separator

PW Surge DrumBFW Surge 

DrumDisposal Water Treatment

Produced Gas header

 Produced gas header

Vapour Fraction 0.000 0.163 0.000 0.000 1.000 1.000 0.000 0.000 1.000 0.430 0.000 1.000 1.000 1.000 0.001 0.000 0.000 0.000 1.000 1.000Operating Temperature °C 135.9 121.1 135.1 123.3 176.3 130.4 131.0 131.1 134.7 60.0 60.0 59.8 112.2 112.4 60.0 60.0 115.6 55.0 60.0 20.3

Operating Pressure kPaa 1,179 493 779 507 594 423 600 1,200 423 403 493 353 151 151 100 507 172 150 100 353Mass Flow kg/h 868,631 30,458 840,794 947,591 2,716 6,664 1,002 29,654 7,315 7,315 4,104 3,211 28,786 28,838 28,838 28,786 890,736 28,049 41 1,684

Mass Density kg/m3 915.4 17.2 917.1 928.0 3.0 2.4 938.6 921.5 2.3 6.3 978.1 2.4 0.9 0.9 473.9 980.6 946.1 985.5 1.3 2.6Molecular Weight kg/kgmole 18.04 18.67 18.02 18.02 18.02 18.56 426.02 18.02 18.55 18.55 18.26 18.94 18.02 18.03 18.03 18.02 18.02 18.02 36.27 18.14

Mass Heat Capacity kJ/kg‐C 4.50 4.01 4.51 4.46 1.99 2.14 2.11 4.49 2.14 3.36 4.29 2.16 1.92 1.92 4.32 4.33 4.24 4.18 1.05 2.09Thermal Conductivity W/m‐K 0.686 0.000 0.688 0.687 0.032 0.036 0.124 0.688 0.036 0.000 0.638 0.036 0.026 0.026 0.000 0.654 0.686 0.649 0.021 0.031

Combined LiquidMass Flow kg/h 868,597 25,516 840,792 947,591 0 0 1,002 29,654 0 4,104 4,104 0 0 0 28,796 28,786 890,736 28,049 0 0

Std Ideal Liq Vol Flow m3/h 870 26 843 950 ‐ ‐ 1 30 0 4 4 ‐ ‐ ‐ 29 29 893 28 ‐ ‐Actual Volume Flow m3/h 947 27 916 1,021 ‐ ‐ 1 32 0 4 4 ‐ ‐ ‐ 29 29 941 28 ‐ ‐

Mass Density kg/m3 917.1 930.7 917.7 928.0 ‐ ‐ 938.6 921.5 876.7 978.1 978.1 ‐ ‐ ‐ 980.5 980.6 946.1 985.5 ‐ ‐Molecular Weight kg/kgmole 18.04 18.69 18.02 18.02 ‐ ‐ 426.02 18.02 314.94 18.26 18.26 ‐ ‐ ‐ 18.02 18.02 18.02 18.02 ‐ ‐

Viscosity cP 0.20 0.25 0.20 0.22 ‐ ‐ 53.63 0.21 10.26 0.48 0.48 ‐ ‐ ‐ 0.46 0.46 0.24 0.50 ‐ ‐Thermal Conductivity W/m‐K 0.686 0.652 0.688 0.687 ‐ ‐ 0.124 0.688 0.119 0.638 0.638 ‐ ‐ ‐ 0.653 0.654 0.686 0.649 ‐ ‐

OilMass Flow kg/h 1,177 955 26 0 0 0 1,001 0 0 61 61 0 0 0 0 0 0 0 0 0

Std Ideal Liq Vol Flow m3/h 1 1 0 ‐ ‐ ‐ 1 ‐ 0 0 0 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐  ‐ Actual Volume Flow m3/h 1 1 0 ‐ ‐ ‐ 1 ‐ 0 0 0 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐  ‐ 

Mass Density (Note 3) kg/m3 885.8 948.6 943.0 ‐ ‐ ‐ 938.6 ‐ 876.7 840.6 840.7 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐API Gravity (STD) °API 10.16 36.96 10.15 ‐ ‐ ‐ 9.00 ‐ 127.48 127.48 10.48 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Molecular Weight kg/kgmole 228.88 437.69 446.34 ‐ ‐ ‐ 426.03 ‐ 314.94 161.84 161.84 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Viscosity (Note 4)  cP 7.33 84.85 60.66 ‐ ‐ ‐ 53.63 ‐ 10.26 8.96 8.95 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Thermal Conductivity W/m‐K 0.097 0.125 0.125 ‐ ‐ ‐ 0.124 ‐ 0.119 0.115 0.115 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Water

Mass Flow kg/h 867,420 24,561 840,766 947,591 0 0 0 29,654 0 4,043 4,043 0 0 0 28,796 28,786 890,736 28,049 0 0Std Ideal Liq Vol Flow m3/h 869 25 842 950 ‐ ‐ 0 30 ‐ 4 4 ‐ ‐ ‐ 29 29 893 28 ‐ 0Actual Volume Flow m3/h 946 26 916 1,021 ‐ ‐ 0 32 ‐ 4 4 ‐ ‐ ‐ 29 29 941 28 ‐ ‐

Mass Density kg/m3 917.2 930.0 917.7 928.0 ‐ ‐ 921.3 921.5 ‐ 980.5 980.5 ‐ ‐ ‐ 980.5 980.6 946.1 985.5 ‐ ‐Viscosity cP 0.20 0.23 0.20 0.22 ‐ ‐ 0.21 0.21 ‐ 0.46 0.46 ‐ ‐ ‐ 0.46 0.46 0.24 0.50 ‐ ‐

Thermal Conductivity W/m‐K 0.688 0.687 0.688 0.687 ‐ ‐ 0.688 0.688 ‐ 0.653 0.654 ‐ ‐ ‐ 0.653 0.654 0.686 0.649 ‐ ‐Vapour

Mass Flow kg/h 35 4,942 2 0 2,716 6,664 0 0 7,314 3,211 0 3,211 28,786 28,838 41 0 0 0 41 1,684Std Gas Flow STD_m3/h 17 6,280 3 ‐ 3,564 8,490 ‐ ‐ 9,323 4,008 ‐ 4,008 37,781 37,811 27 ‐ ‐ ‐ 27 2,195

Molecular Weight kg/kgmole 49.23 18.61 17.60 ‐ 18.02 18.56 ‐ ‐ 18.55 18.94 ‐ 18.94 18.02 18.03 36.27 ‐ ‐ ‐ 36.27 18.14Mass Density kg/m3 19.2 2.8 4.1 ‐ 3.0 2.4 ‐ ‐ 2.3 2.8 ‐ 2.4 0.9 0.9 1.3 ‐ ‐ ‐ 1.3 2.6

Viscosity cP 0.011 0.013 0.013 ‐ 0.011 0.012 ‐ ‐ 0.012 0.012 ‐ 0.012 0.013 0.013 0.014 ‐ ‐ ‐ 0.014 0.011Cp/(Cp‐R) (Ideal Gamma) 1.114 1.125 1.114 ‐ 1.301 1.264 ‐ ‐ 1.265 1.154 ‐ 1.255 1.317 1.317 1.119 ‐ ‐ ‐ 1.281 1.280

Z Factor 0.888 0.988 0.985 ‐ 0.969 0.987 ‐ ‐ 0.987 0.992 ‐ 0.993 0.988 0.988 0.995 ‐ ‐ ‐ 0.995 0.990Thermal Conductivity W/m‐K 0.028 0.038 0.041 ‐ 0.032 0.036 ‐ ‐ 0.036 0.036 ‐ 0.036 0.026 0.026 0.021 ‐ ‐ ‐ 0.021 0.031

H2O 0.9998 0.9048 1.0000 1.0000 0.9988 0.5717 0.0176 1.0000 0.5906 0.5906 0.9983 0.0500 1.0000 0.9992 0.9992 0.9998 1.0000 1.0000 0.2001 0.0039H2S 0.0000 0.0000 0.0000 0.0000 0.0000 0.0002 0.0000 0.0000 0.0002 0.0002 0.0000 0.0005 0.0000 0.0001 0.0001 0.0001 <hidden> <hidden> 0.0605 0.0012CO2 0.0001 0.0015 0.0000 0.0000 0.0003 0.0071 0.0002 0.0000 0.0083 0.0083 0.0000 0.0193 0.0000 0.0006 0.0006 0.0002 <hidden> <hidden> 0.6661 0.0193

Helium 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0001 0.0000 0.0000 0.0000 0.0000 <hidden> <hidden> 0.0018 0.0001Nitrogen 0.0000 0.0004 0.0000 0.0000 0.0000 0.0019 0.0000 0.0000 0.0017 0.0017 0.0000 0.0040 0.0000 0.0000 0.0000 0.0000 <hidden> <hidden> 0.0110 0.0046

Air 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 <hidden> <hidden> 0.0000 0.0000Methane 0.0000 0.0834 0.0000 0.0000 0.0009 0.3797 0.0053 0.0000 0.3631 0.3631 0.0000 0.8446 0.0000 0.0000 0.0000 0.0000 <hidden> <hidden> 0.0604 0.9010Ethane 0.0000 0.0046 0.0000 0.0000 0.0000 0.0211 0.0008 0.0000 0.0192 0.0192 0.0000 0.0447 0.0000 0.0000 0.0000 0.0000 <hidden> <hidden> 0.0001 0.0500

Propane 0.0000 0.0013 0.0000 0.0000 0.0000 0.0060 0.0005 0.0000 0.0055 0.0055 0.0000 0.0128 0.0000 0.0000 0.0000 0.0000 <hidden> <hidden> 0.0000 0.0139C4+ 0.0001 0.0038 0.0000 0.0000 0.0000 0.0123 0.9756 0.0000 0.0113 0.0113 0.0016 0.0242 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0059

NOTES:1. Values are for each 40,000 bpd phase for Phases 1 & 2. SUNCOR LEWIS PH 1 & 2

AREA 2000/3000 ‐ OIL REMOVAL, WATER TREATMENTHEAT AND MATERIAL BALANCE

PROJECT # DRAWING NUMBER REVISION

Overall Composition Mole Fraction

 40,000 BPSD

Overall

Stream Number

Stream Name

From

To

Area 2000 HMB (1,2) - Page 2 of 12

lehanson
Typewritten Text
Figure 2
Page 4: Attachment 14 Heat and Material Balance - Alberta.ca · 2019. 2. 14. · SUNCOR LEWIS PH 1 2 HEAT MATERIAL BALANCE TABLE. 2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011

SUNCOR LEWIS PH 1 2HEAT MATERIAL BALANCE TABLE

5000 5001 5002 5003 5004 5005 5006 5007 5008 5700 5701 5702 5703 5704 5705 7000 7001 9000 9001

LP BFW LP BFW HP BFW HP BFW HP BFW HP Steam HP Steam CBD Combined CBD CBD  HP Steam Cold glycol Cold glycol Cold glycol Hot glycol Disposal water Disposal water Raw water Raw water

LP BFW PumpsEmulsion / BFW 

exchangerHP BFW pumps  HP BFW header HP BFW header

HP Steam generator

HP Steam header

HP Steam generators

HRSG/ HP Steam Gen.

HRSG HRSGCogen Glycol 

Pumps Cogen Glycol 

HeaderCogen Glycol 

HeaderGTG

Disposal water treatment

Disposal Water Pumps

Source water Raw water pumps 

Emulsion / BFW exchanger

HP BFW pumps HP BFW headerSteam 

GeneratorHRSG

HP Steam header

B/L Well padsBlowdown header

Inlet SeparatorBlowdown header

HP Steam header

Cogen Glycol Header

Cogen Glycol Filter

GTGCogen Glycol 

CoolersDisposal Water 

TankDisposal wells CPF B/L PW Surge Drum

Vapour Fraction 0.000 0.000 0.000 0.000 0.000 1.000 1.000 0.000 0.000 0.000 1.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000Operating Temperature °C 115.9 179.2 180.8 180.8 180.8 286.7 286.7 286.7 286.7 286.7 286.7 50.0 50.0 50.0 56.3 55.0 55.6 15.5 15.7

Operating Pressure kPaa 2,009 1,909 7,493 7,493 7,493 7,093 7,093 7,093 7,093 7,093 7,093 793 793 793 490 150 5,022 363 1,670Mass Flow kg/h 890,736 890,736 890,736 529,491 361,245 518,902 872,921 10,590 17,815 7,225 354,020 381,399 18,965 362,434 362,434 28,049 28,049 78,043 78,043

Mass Density kg/m3 946.8 888.2 890.2 890.2 890.2 37.1 37.1 738.2 738.2 738.2 37.1 1,050.8 1,050.8 1,050.8 1,045.5 985.5 987.3 1,014.5 1,014.7Molecular Weight kg/kgmole 18.02 18.02 18.02 18.02 18.02 18.02 18.02 18.02 18.02 18.02 18.02 28.55 28.55 28.55 28.55 18.02 18.02 18.02 18.02

Mass Heat Capacity kJ/kg‐C 4.23 4.40 4.38 4.38 4.38 5.08 5.08 5.43 5.43 5.43 5.08 3.45 3.45 3.45 3.46 4.18 4.17 4.32 4.31Thermal Conductivity W/m‐K 0.686 0.677 0.676 0.676 0.676 0.042 0.042 0.564 0.564 0.564 0.042 0.413 0.413 0.413 0.416 0.649 0.649 0.596 0.596

Combined Liquid 0 0 0 0Mass Flow kg/h 890,736 890,736 890,736 529,491 361,245 0 0 10,590 17,815 7,225 0 381,399 18,965 362,434 362,434 28,049 28,049 78,043 78,043

Std Ideal Liq Vol Flow m3/h 893 893 893 531 362 ‐ ‐ 11 18 7 ‐ 362 18 344 344 28 28 78 78Actual Volume Flow m3/h 941 1,003 1,001 595 406 ‐ ‐ 14 24 10 ‐ 363 18 345 347 28 28 77 77

Mass Density kg/m3 946.8 888.2 890.2 890.2 890.2 ‐ ‐ 738.2 738.2 738.2 ‐ 1,050.8 1,050.8 1,050.8 1,045.5 985.5 987.3 1,014.5 1,014.7Molecular Weight kg/kgmole 18.02 18.02 18.02 18.02 18.02 ‐ ‐ 18.02 18.02 18.02 ‐ 28.55 28.55 28.55 28.55 18.02 18.02 18.02 18.02

Viscosity cP 0.24 0.15 0.15 0.15 0.15 ‐ ‐ 0.09 0.09 0.09 ‐ 1.54 1.54 1.54 1.36 0.50 0.50 1.12 1.12Thermal Conductivity W/m‐K 0.686 0.677 0.676 0.676 0.676 ‐ ‐ 0.564 0.564 0.564 ‐ 0.413 0.413 0.413 0.416 0.649 0.649 0.596 0.596

Oil 0 0 0 0Mass Flow kg/h 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0

Std Ideal Liq Vol Flow m3/h ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Actual Volume Flow m3/h ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Mass Density (Note 3) kg/m3 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐API Gravity (STD) °API ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Molecular Weight kg/kgmole ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Viscosity (Note 4)  cP ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Thermal Conductivity W/m‐K ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Water 0 0 0 0

Mass Flow kg/h 890,736 890,736 890,736 529,491 361,245 0 0 10,590 17,815 7,225 0 381,399 18,965 362,434 362,434 28,049 28,049 78,043 78,043Std Ideal Liq Vol Flow m3/h 893 893 893 531 362 ‐ ‐ 11 18 7 ‐ 362 18 344 344 28 28 78 78Actual Volume Flow m3/h 941 1,003 1,001 595 406 ‐ ‐ 14 24 10 ‐ 363 18 345 347 28 28 77 77

Mass Density kg/m3 946.8 888.2 890.2 890.2 890.2 ‐ ‐ 738.2 738.2 738.2 ‐ 1,050.8 1,050.8 1,050.8 1,045.5 985.5 987.3 1,014.5 1,014.7Viscosity cP 0.24 0.15 0.15 0.15 0.15 ‐ ‐ 0.09 0.09 0.09 ‐ 1.54 1.54 1.54 1.36 0.50 0.50 1.12 1.12

Thermal Conductivity W/m‐K 0.686 0.677 0.676 0.676 0.676 ‐ ‐ 0.564 0.564 0.564 ‐ 0.413 0.413 0.413 0.416 0.649 0.649 0.596 0.596Vapour 0 0 0 0

Mass Flow kg/h 0 0 0 0 0 518,902 872,921 0 0 0 354,020 0 0 0 0 0 0 0 0Std Gas Flow STD_m3/h ‐ ‐ ‐ ‐ ‐ 681,047 1,145,691 ‐ ‐ ‐ 464,643 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Molecular Weight kg/kgmole ‐ ‐ ‐ ‐ ‐ 18.0 18.0 ‐ ‐ ‐ 18.0 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Mass Density kg/m3 ‐ ‐ ‐ ‐ ‐ 37.1 37.1 ‐ ‐ ‐ 37.1 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Viscosity cP ‐ ‐ ‐ ‐ ‐ 0.019 0.019 ‐ ‐ ‐ 0.019 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Cp/(Cp‐R) (Ideal Gamma) ‐ ‐ ‐ ‐ ‐ 1.1 1.1 ‐ ‐ ‐ 1.1 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Z Factor ‐ ‐ ‐ ‐ ‐ 0.7 0.7 ‐ ‐ ‐ 0.7 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Thermal Conductivity W/m‐K ‐ ‐ ‐ ‐ ‐ 0.0 0.0 ‐ ‐ ‐ 0.0 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

0.00000 0.00000 0.00000 0.00000H2O 1.0000 1.0000 1.0000 1.0000 1.0000 1.0000 1.0000 1.0000 1.0000 1.0000 1.0000 1.0 (24% EG) 1.0 (24% EG) 1.0 (24% EG) 1.0 (24% EG) 1.0000 1.0000 1.0000 1.0000H2S 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000CO2 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

Helium 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Nitrogen 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

Air 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Methane 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Ethane 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

Propane 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000C4+ 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

NOTES:1. Values are for each 40,000 bpd phase for Phases 1 & 2. SUNCOR LEWIS PH 1 & 2

AREA 5000 & 5700 ‐ BFW & STEAM GENERATIONAREA 7000 & 9000 ‐ DISPOSAL & RAW WATER SYSTEMS

HEAT AND MATERIAL BALANCE

Overall Composition Mole Fraction

Overall

Stream Number

Stream Name

From

To

 40,000 BPSD

Area 5000-5700 HMB (1,2) - Page 3 of 12

lehanson
Typewritten Text
Figure 3
Page 5: Attachment 14 Heat and Material Balance - Alberta.ca · 2019. 2. 14. · SUNCOR LEWIS PH 1 2 HEAT MATERIAL BALANCE TABLE. 2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011

SUNCOR LEWIS PH 1 2HEAT MATERIAL BALANCE TABLE

6000 6001 6002 6003 6004 6005 6006 6007 6008 6009 6010 6011 6012 6013 6014 6015 6016 6017 6018

Cold glycol Cold glycol  Hot glycol Cold Glycol Hot glycol Cold Glycol Warm glycol Hot glycol Hot glycol Hot glycol Hot glycol Hot glycol Cold glycol Cold glycol Hot glycol Cooled glycol Cold Glycol Cold Glycol Hot glycol

Glycol Circ. pump

 Cold glycol supply header 

Evaporator Cold glycol 

supply header Dilbit Coolers

 Cold glycol supply header 

Sample / seal flush cooling

Dilbit Coolers / Evaporator

bypass lineHot glycol 

Supply headerCombustion Air Preheaters

Hot glycol Supply header

Natural gas heater

Heating glycol system

Glycol main return header

Glycol Aerial Coolers 

Glycol Circ. Pumps

 Cold glycol supply header 

Produced Gas Condenser

 Cold glycol supply header 

EvaporatorHot glycol 

Return headerDilbit Coolers

Hot glycol Return header

Sample / seal flush cooling

Warm glycol return header

Hot glycol return header

Glycol Return header

Combustion Air Preheaters

Cold glycol return header

Natural gas heater

Cold glycol return header

Glycol return header

Glycol Aerial Coolers

Expansion Drum Glycol FilterProduced Gas Condenser

Hot glycol Return header

Vapour Fraction 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000Operating Temperature °C 40.0 40.0 90.0 40.0 90.0 40.0 70.0 90.0 90.0 90.0 50.0 90.0 40.0 50.0 69.5 40.0 40.0 40.0 90.0

Operating Pressure kPaa 1,094 1,094 794 1,094 794 1,094 404 794 404 654 404 654 153 404 404 153 153 1,094 794Mass Flow kg/h 475,043 48,953 48,953 251,489 251,489 54,750 54,750 365,543 169,081 183,369 183,369 13,093 13,093 183,369 407,200 407,200 54,750 65,101 65,101

Mass Density kg/m3 1,074.7 1,074.7 1,038.2 1,074.7 1,038.2 1,074.7 1,054.3 1,038.2 1,038.2 1,038.2 1,068.3 1,038.2 1,074.7 1,068.3 1,054.7 1,074.7 1,074.7 1,074.7 1,038.2Molecular Weight kg/kgmole 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17

Mass Heat Capacity kJ/kg‐C 3.19 3.19 3.41 3.19 3.41 3.19 3.32 3.41 3.41 3.41 3.23 3.41 3.19 3.23 3.31 3.19 3.19 3.19 3.41Thermal Conductivity W/m‐K 0.351 0.351 0.336 0.351 0.336 0.351 0.342 0.336 0.336 0.336 0.348 0.336 0.351 0.348 0.342 0.351 0.351 0.351 0.336

Combined LiquidMass Flow kg/h 475,043 48,953 48,953 251,489 251,489 54,750 54,750 365,543 169,081 183,369 183,369 13,093 13,093 183,369 407,200 407,200 54,750 65,101 65,101

Std Ideal Liq Vol Flow m3/h 434 45 45 230 230 50 50 334 154 167 167 12 12 167 372 372 50 59 59Actual Volume Flow m3/h 442 46 47 234 242 51 52 352 163 177 172 13 12 172 386 379 51 61 63

Mass Density kg/m3 1,074.7 1,074.7 1,038.2 1,074.7 1,038.2 1,074.7 1,054.3 1,038.2 1,038.2 1,038.2 1,068.3 1,038.2 1,074.7 1,068.3 1,054.7 1,074.7 1,074.7 1,074.7 1,038.2Molecular Weight kg/kgmole 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17

Viscosity cP 4.82 4.82 1.41 4.82 1.41 4.82 2.16 1.41 1.41 1.41 3.57 1.41 4.82 3.57 2.18 4.82 4.82 4.82 1.41Thermal Conductivity W/m‐K 0.351 0.351 0.336 0.351 0.336 0.351 0.342 0.336 0.336 0.336 0.348 0.336 0.351 0.348 0.342 0.351 0.351 0.351 0.336

OilMass Flow kg/h 475,043 48,953 48,953 251,489 251,489 54,750 54,750 365,543 169,081 183,369 183,369 13,093 13,093 183,369 407,200 407,200 54,750 65,101 65,101

Std Ideal Liq Vol Flow m3/h 434 45 45 230 230 50 50 334 154 167 167 12 12 167 372 372 50 59 59Actual Volume Flow m3/h 442 46 47 234 242 51 52 352 163 177 172 13 12 172 386 379 51 61 63

Mass Density (Note 3) kg/m3 1074.7 1074.7 1038.2 1074.7 1038.2 1074.7 1054.3 1038.2 1038.2 1038.2 1068.3 1038.2 1074.7 1068.3 1054.7 1074.7 1074.7 1074.7 1038.2API Gravity (STD) °API ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41Molecular Weight kg/kgmole 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17Viscosity (Note 4)  cP 4.82 4.82 1.41 4.82 1.41 4.82 2.16 1.41 1.41 1.41 3.57 1.41 4.82 3.57 2.18 4.82 4.82 4.82 1.41

Thermal Conductivity W/m‐K 0.351 0.351 0.336 0.351 0.336 0.351 0.342 0.336 0.336 0.336 0.348 0.336 0.351 0.348 0.342 0.351 0.351 0.351 0.336Water 0 0 0 0 0 0 0 0 0

Mass Flow kg/h 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0Std Ideal Liq Vol Flow m3/h ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Actual Volume Flow m3/h ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Mass Density kg/m3 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Viscosity cP ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Thermal Conductivity W/m‐K ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Vapour

Mass Flow kg/h 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0Std Gas Flow STD_m3/h ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Molecular Weight kg/kgmole ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Mass Density kg/m3 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Viscosity cP ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Cp/(Cp‐R) (Ideal Gamma) ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Z Factor ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Thermal Conductivity W/m‐K ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

H2O 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 ( 60%TEG) 1.0 ( 60%TEG) 1.0 ( 60%TEG) 1.0 ( 60%TEG)H2S 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000CO2 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

Helium 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Nitrogen 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

Air 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Methane 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Ethane 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

Propane 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000C4+ 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

NOTES:1. Values are for each 40,000 bpd phase for Phases 1 & 2. SUNCOR LEWIS PH 1 & 2

AREA 6200 ‐ GLYCOL SYSTEMHEAT AND MATERIAL BALANCE

PROJECT # DRAWING NUMBER REVISION

Overall Composition Mole Fraction

 40,000 BPSD

Overall

Stream Number

Stream Name

From

To

Area 6000 HMB (1,2) - Page 4 of 12

lehanson
Typewritten Text
Figure 4
Page 6: Attachment 14 Heat and Material Balance - Alberta.ca · 2019. 2. 14. · SUNCOR LEWIS PH 1 2 HEAT MATERIAL BALANCE TABLE. 2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011

SUNCOR LEWIS PH 1 2HEAT MATERIAL BALANCE TABLE

6200 6201 6202 6203 6204 6205 6206 6207 6208 6209 6210 6211 6212 6213 6214 6215 6216

Natural gas Natural gas Natural gas Natural gas HP fuel gas HP fuel gas HP fuel gasCombined Fuel 

Gas Mixed fuel gas Mixed fuel gas Mixed fuel gas

Blanketing Natural gas

Purge gas Natural gas Natural gas Bubble gas Mixed Fuel Gas

CPF B/L HeaderDiluent Rec. Trim Cooler

Natural Gas Heater

Header HeaderHP Fuel Gas Coalescer

NG / PG HeaderMixed Fuel Gas 

DrumMixed fuel gas 

headerMixed fuel gas 

headerPipeline

Critical fuel gas header

LP Fuel gas header

LP Fuel gas header

MP fuel gas header

Produced Gas Header

HeaderDiluent Rec. Trim Cooler

Natural Gas Heater

HeaderEvaporator Vent 

EjectorHP Fuel Gas Coalescer

GTGMixed Fuel Gas 

DrumMixed fuel gas 

headerHP Steam Generator

HRSG Wellpads HP Flare headerHRSG pilot burner

Steam Gen. Pilot burner

CFU NG / PG Header

Vapour Fraction 1.000 1.000 1.000 1.000 1.000 1.000 1.000 1.000 1.000 1.000 1.000 1.000 1.000 1.000 1.000 1.000 0.998Operating Temperature °C 7.0 7.0 34.3 50.0 34.2 34.2 30.8 23.3 23.3 23.3 23.3 7.0 19.1 19.8 19.8 26.1 46.9

Operating Pressure kPaa 7,068 7,068 6,968 6,868 3,193 3,193 2,506 353 353 353 353 7,068 443 443 443 1,595 353Mass Flow kg/h 50,467 50,290 50,290 50,290 1,600 19,205 19,205 31,776 31,776 24,528 7,248 156 21 93 151 2,621 5,156

Mass Density kg/m3 67.5 67.5 56.2 51.2 23.8 23.8 18.6 2.6 2.6 2.6 2.6 67.5 3.3 3.3 3.3 11.8 2.5Molecular Weight kg/kgmole 17.67 17.67 17.67 17.67 17.67 17.67 17.67 17.86 17.86 17.86 17.86 17.67 17.67 17.67 17.67 17.67 18.97

Mass Heat Capacity kJ/kg‐C 2.88 2.88 2.69 2.64 2.38 2.38 2.32 2.14 2.14 2.14 2.14 2.88 2.15 2.16 2.16 2.25 2.13Thermal Conductivity W/m‐K 0.038 0.038 0.040 0.042 0.036 0.036 0.035 0.032 0.032 0.032 0.032 0.038 0.032 0.032 0.032 0.034 0.000

Combined LiquidMass Flow kg/h 0 0 0 0 0 0 0 1 0 0 0 0 0 0 0 0 12

Std Ideal Liq Vol Flow m3/h ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0Actual Volume Flow m3/h ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0

Mass Density kg/m3 ‐ ‐ ‐ ‐ ‐ ‐ ‐ 858.0 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 976.2Molecular Weight kg/kgmole ‐ ‐ ‐ ‐ ‐ ‐ ‐ 160.2 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 19.5

Viscosity cP ‐ ‐ ‐ ‐ ‐ ‐ ‐ 30.0 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0.7Thermal Conductivity W/m‐K ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0.1 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0.6

OilMass Flow kg/h 0 0 0 0 0 0 0 1 0 0 0 0 0 0 0 0 1

Std Ideal Liq Vol Flow m3/h ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0Actual Volume Flow m3/h ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0

Mass Density (Note 3) kg/m3 ‐ ‐ ‐ ‐ ‐ ‐ ‐ 858.0 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 841.4API Gravity (STD) °API ‐ ‐ ‐ ‐ ‐ ‐ ‐ 310.2 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 281.9Molecular Weight kg/kgmole ‐ ‐ ‐ ‐ ‐ ‐ ‐ 160.2 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 153.9Viscosity (Note 4)  cP ‐ ‐ ‐ ‐ ‐ ‐ ‐ 30.0 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 11.0

Thermal Conductivity W/m‐K ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0.1 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0.1Water

Mass Flow kg/h 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 11Std Ideal Liq Vol Flow m3/h ‐ ‐ ‐ ‐ 0 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0 ‐ ‐ 0Actual Volume Flow m3/h ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0

Mass Density kg/m3 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 990.8Viscosity cP ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0.6

Thermal Conductivity W/m‐K ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0.6Vapour

Mass Flow kg/h 50,467 50,290 50,290 50,290 1,600 19,205 19,205 31,776 31,776 24,528 7,248 156 21 93 151 2,621 5,144Std Gas Flow STD_m3/h 67,546 67,310 67,310 67,310 2,141 25,704 25,704 42,056 42,056 32,463 9,593 208 28 124 202 3,508 6,412

Molecular Weight kg/kgmole 17.67 17.67 17.67 17.67 17.67 17.67 17.67 17.86 17.86 17.86 17.86 17.67 17.67 17.67 17.67 17.67 18.97Mass Density kg/m3 67.5 67.5 56.2 51.2 23.8 23.8 18.6 2.6 2.6 2.6 2.6 67.5 3.3 3.3 3.3 11.8 2.5

Viscosity cP 0.013 0.013 0.013 0.014 0.012 0.012 0.012 0.011 0.011 0.011 0.011 0.013 0.011 0.011 0.011 0.012 0.012Cp/(Cp‐R) (Ideal Gamma) 1.195 1.195 1.212 1.217 1.247 1.247 1.254 1.277 1.277 1.277 1.277 1.195 1.280 1.279 1.279 1.265 1.258

Z Factor 0.795 0.795 0.856 0.883 0.928 0.928 0.940 0.990 0.990 0.990 0.990 0.795 0.988 0.988 0.988 0.959 0.992Thermal Conductivity W/m‐K 0.038 0.038 0.040 0.042 0.036 0.036 0.035 0.032 0.032 0.032 0.032 0.038 0.032 0.032 0.032 0.034 0.034

H2O 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0049 0.0049 0.0049 0.0049 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000H2S 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0001 0.0001 0.0001 0.0001 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000CO2 0.0058 0.0058 0.0058 0.0058 0.0058 0.0058 0.0058 0.0081 0.0081 0.0081 0.0081 0.0058 0.0058 0.0058 0.0058 0.0058 0.0058

Helium 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001Nitrogen 0.0046 0.0046 0.0046 0.0046 0.0046 0.0046 0.0046 0.0045 0.0045 0.0045 0.0045 0.0046 0.0046 0.0046 0.0046 0.0046 0.0046

Air 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Methane 0.9180 0.9180 0.9180 0.9180 0.9180 0.9180 0.9180 0.9088 0.9088 0.9088 0.9088 0.9180 0.9180 0.9180 0.9180 0.9180 0.9180Ethane 0.0510 0.0510 0.0510 0.0510 0.0510 0.0510 0.0510 0.0504 0.0504 0.0504 0.0504 0.0510 0.0510 0.0510 0.0510 0.0510 0.0510

Propane 0.0142 0.0142 0.0142 0.0142 0.0142 0.0142 0.0142 0.0144 0.0144 0.0144 0.0144 0.0142 0.0142 0.0142 0.0142 0.0142 0.0142C4+ 0.0063 0.0063 0.0063 0.0063 0.0063 0.0063 0.0063 0.0088 0.0088 0.0088 0.0088 0.0063 0.0063 0.0063 0.0063 0.0063 0.0063

NOTES:1. Values are for each 40,000 bpd phase for Phases 1 & 2. SUNCOR LEWIS PH 1 & 2

AREA 6200 ‐ FUEL GAS SYSTEMHEAT AND MATERIAL BALANCE

PROJECT # DRAWING NUMBER REVISION

 40,000 BPSD

Overall Composition Mole Fraction

Overall

Stream Number

Stream Name

From

To

Area 6200 HMB (1,2) - Page 5 of 12

lehanson
Typewritten Text
Figure 5
Page 7: Attachment 14 Heat and Material Balance - Alberta.ca · 2019. 2. 14. · SUNCOR LEWIS PH 1 2 HEAT MATERIAL BALANCE TABLE. 2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011

SUNCOR LEWIS PH 1-3HEAT MATERIAL BALANCE TABLE

4000 4001 4002 4003 4004 4005 4006 4007

Diluent Diluent Diluent Trim diluent DilbitDilbit / Diluent 

vaporsRecovered liquids

VRU Gas

Supply pipeline Diluent pumps Diluent supply 

headerDiluent supply 

headerDilbit tank

Dilbit/Offspec/ Diluent tanks 

VRU package VRU package

CPF B/LDiluent supply 

headerFWKO/Treaters

CPF B/L (Trim blending)

CPF B/L (Dilbit product pumps)

VRU package Dilbit headerDiluent Rec. 

Cooler

Vapour Fraction 0.000 0.000 0.000 0.000 0.000 1.000 0.000 1.000Operating Temperature °C 15.0 15.8 15.8 15.8 53.0 53.0 53.3 126.6

Operating Pressure kPaa 593 1,613 1,613 1,613 93 93 896 460Mass Flow kg/h 220,646 220,646 33,124 121,274 900,483 13,066 0 4,355

Mass Density kg/m3 676.4 676.5 676.5 676.5 974.3 2.1 934.8 8.9Molecular Weight kg/kgmole 66.12 66.12 66.12 66.12 274.54 60.13 221.30 60.13

Mass Heat Capacity kJ/kg‐C 2.15 2.15 2.15 2.15 1.86 1.79 1.90 2.13Thermal Conductivity W/m‐K 0.109 0.109 0.109 0.109 0.118 0.017 0.114 0.024

Combined LiquidMass Flow kg/h 220,646 220,646 33,124 121,274 900,483 0 0 0

Std Ideal Liq Vol Flow m3/h 326 326 49 179 940 ‐ ‐ ‐

Actual Volume Flow m3/h 326 326 49 179 924 ‐ ‐ ‐

Mass Density kg/m3 676.4 676.5 676.5 676.5 974.3 ‐ ‐ ‐Molecular Weight kg/kgmole 66.12 66.12 66.12 66.12 274.54 ‐ ‐ ‐

Viscosity cP 0.32 0.32 0.32 0.32 183.74 ‐ ‐ ‐Thermal Conductivity W/m‐K 0.109 0.109 0.109 0.109 0.118 ‐ ‐ ‐

OilMass Flow kg/h 220,646 220,646 33,124 121,274 900,483 0 0 0

Std Ideal Liq Vol Flow m3/h 326 326 49 179 940  ‐   ‐   ‐ 

Actual Volume Flow m3/h 326 326 49 179 924  ‐   ‐   ‐ 

Mass Density (Note 3) kg/m3 676.4 676.5 676.5 676.5 974.3  ‐   ‐   ‐ API Gravity (STD) °API 77.61 77.61 77.61 77.61 16.10  ‐   ‐   ‐ Molecular Weight kg/kgmole 66.12 66.12 66.12 66.12 274.54  ‐   ‐   ‐ Viscosity (Note 4)  cP 0.32 0.32 0.32 0.32 183.74  ‐   ‐   ‐ 

Thermal Conductivity W/m‐K 0.109 0.109 0.109 0.109 0.118  ‐   ‐   ‐ Water

Mass Flow kg/h 0 0 0 0 0 0 0 0

ndard Ideal Liquid Volume Flow m3/h  ‐   ‐   ‐   ‐   ‐   ‐   ‐   ‐ 

Actual Volume Flow m3/h  ‐   ‐   ‐   ‐   ‐   ‐   ‐   ‐ 

Mass Density kg/m3  ‐   ‐   ‐   ‐   ‐   ‐   ‐   ‐ Viscosity cP  ‐   ‐   ‐   ‐   ‐   ‐   ‐   ‐ 

Thermal Conductivity W/m‐K  ‐   ‐   ‐   ‐   ‐   ‐   ‐   ‐ Vapour

Mass Flow kg/h 0 0 0 0 0 13,066 0 4,355

Std Gas Flow STD_m3/h  ‐   ‐   ‐   ‐  ‐ 5,138 ‐ 1,713Molecular Weight kg/kgmole  ‐   ‐   ‐   ‐  ‐ 60.13 ‐ 60.13

Mass Density kg/m3  ‐   ‐   ‐   ‐  ‐ 2.1 ‐ 8.9Viscosity cP  ‐   ‐   ‐   ‐  ‐ 0.007 ‐ 0.009

Cp/(Cp‐R) (Ideal Gamma)  ‐   ‐   ‐   ‐  ‐ 1.084 ‐ 1.069Z Factor  ‐   ‐   ‐   ‐  ‐ 0.977 ‐ 0.933

Thermal Conductivity W/m‐K  ‐   ‐   ‐   ‐  ‐ 0.017 ‐ 0.024

H2O 0.0000 0.0000 0.0000 0.0000 0.0016 0.1510 0.0016 0.1509

H2S 0.0000 0.0000 0.0000 0.0000 0.00001 0.0004 0.00001 0.0004

CO2 0.0000 0.0000 0.0000 0.0000 0.0001 0.0070 0.0001 0.0070Helium 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

Nitrogen 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Air 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

Methane 0.0000 0.0000 0.0000 0.0000 0.0000 0.0027 0.0000 0.0027Ethane 0.0012 0.0012 0.0012 0.0012 0.0000 0.0031 0.0000 0.0031

Propane 0.0045 0.0045 0.0045 0.0045 0.0013 0.0297 0.0014 0.0297C4+ 0.9943 0.9943 0.9943 0.9943 0.9970 0.8061 0.9970 0.8062

NOTES:1. Trim diluent flow rate is based on meeting 350 cSt dilbit viscosity at 7.5 °C pipeline winter reference temperature. SUNCOR LEWIS PH 1‐32. Streams 4002, 4006, and 4007 are per 40,000 bpd phase for each of Ph 1 ‐ 3. AREA 4000 ‐ HC TANK FARM

HEAT AND MATERIAL BALANCE

PROJECT # DRAWING NUMBER REVISION

Stream Number

Stream Name

From

To

Overall

Overall Composition Mole Fraction

Area 4000 HMB (1-3) - Page 6 of 12

lehanson
Typewritten Text
Figure 6
Page 8: Attachment 14 Heat and Material Balance - Alberta.ca · 2019. 2. 14. · SUNCOR LEWIS PH 1 2 HEAT MATERIAL BALANCE TABLE. 2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011

SUNCOR LEWIS PH 3 4HEAT MATERIAL BALANCE TABLE

1000 1001 1002 1003 1004 1005 1006 1007 1008 1009 1010 1011 1012 1013 1014 1015 1016 1017 1018 1019Produced emulsion

De‐gassed Emulsion

Cooled Emulsion  Cooled Emulsion  Wet dilbit Produced Water  Produced Gas  Produced Gas  Produced Water  Produced Water  Dilbit Dilbit Dilbit Produced Gas  Produced Gas  Produced Gas  DiluentRecovered Diluent

Recovered Diluent

Produced Gas 

CPF B/L  Inlet Separator Emul./BFW HE Static Mixer FWKO FWKO  Inlet Separator FWKO Treater FWKO / Treater Treater Dilbit Cooler  Dilbit Header Treater Gas Boot PG HeaderDiluent Rec. 

Cooler Diluent Rec. Trim Cooler

Diluent Rec. Pumps 

Diluent Rec.  Separator

Inlet Separator Emul./BFW HE Static Mixer FWKO Treaters PW HeaderEvap. Vent Condenser

PG Header PW Header CFU Gas Boot Dilbit Header HC Tank farm PG Header PG HeaderDiluent Rec. 

CoolerDiluent Rec. Trim Cooler

Diluent Rec. Separator

FWKO Feed Header

MFG Drum

Vapour Fraction 0.000 0.000 0.000 0.001 0.008 0.000 1.000 1.000 0.000 0.000 0.265 0.000 0.062 1.000 1.000 1.000 0.087 0.019 0.000 1.000Operating Temperature °C 193.0 194.6 141.1 136.1 135.5 136.1 181.3 127.3 135.5 136.1 122.1 55.0 53.0 127.4 120.5 122.1 54.0 12.0 12.6 11.5

Operating Pressure kPaa 2,000 1,794 1,494 1,394 1,294 1,179 423 460 1,179 1,179 600 530 93 460 460 460 410 403 1,394 353Mass Flow kg/h 1,088,173 1,105,337 1,105,337 1,168,296 361,942 804,523 651 1,831 34,454 838,977 326,071 304,526 304,526 1,417 22,546 30,138 30,138 30,138 29,835 303

Mass Density kg/m3 862.0 870.2 918.1 851.8 759.7 915.0 2.1 6.9 917.5 915.2 133.0 970.4 128.4 7.1 8.0 8.0 86.1 284.6 657.8 4.4Molecular Weight kg/kgmole 23.58 23.46 23.46 24.26 102.70 18.04 18.49 48.02 18.02 18.04 206.00 261.20 261.20 49.15 53.77 53.96 53.96 53.96 54.44 28.68

Mass Heat Capacity kJ/kg‐C 4.21 4.23 3.95 3.87 2.45 4.50 2.05 2.11 4.51 4.50 2.14 1.88 1.86 2.11 2.09 2.10 2.54 2.34 2.35 1.73Thermal Conductivity W/m‐K 0.000 0.477 0.483 0.000 0.000 0.686 0.037 0.027 0.688 0.686 0.000 0.115 0.000 0.026 0.024 0.024 0.000 0.000 0.114 0.025

Combined Liquid 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0Mass Flow kg/h 1,088,024 1,105,337 1,105,337 1,166,465 360,525 804,487 0 0 34,454 838,942 303,494 304,526 300,182 0 0 0 27,782 29,835 29,835 0

Std Ideal Liq Vol Flow m3/h 1,088 1,105 1,105 1,197 388 806 0 0 35 841 319 320 313 0 ‐ 0 42 46 46 ‐Actual Volume Flow m3/h 1,248 1,270 1,204 1,290 410 877 0 0 38 915 331 314 308 0 ‐ 0 45 45 45 ‐

Mass Density kg/m3 872.2 870.2 918.1 904.3 879.5 916.9 940.8 915.3 917.5 917.0 917.9 970.4 974.3 917.4 ‐ 976.3 617.6 657.4 657.8 ‐Molecular Weight kg/kgmole 23.58 23.46 23.46 24.24 103.15 18.04 535.10 322.88 18.02 18.04 260.94 261.20 274.49 323.53 ‐ 392.08 54.50 54.44 54.44 ‐

Viscosity cP 2.55 2.51 9.64 1.24 3.71 0.20 55.90 17.81 0.20 0.21 4.00 127.81 175.75 18.37 ‐ 83.16 0.21 0.28 0.28 ‐Thermal Conductivity W/m‐K 0.47 0.48 0.48 0.42 0.11 0.69 0.12 0.11 0.69 0.69 0.10 0.12 0.12 0.11 ‐ 0.11 0.10 0.11 0.11 ‐

OilMass Flow kg/h 268,337 268,274 267,779 326,955 324,440 1,176 0 0 0 1,176 303,494 304,334 144,259 0 0 0 25,388 27,399 27,400 0

Std Ideal Liq Vol Flow m3/h 266 266 266 356 352 1 0 0 ‐ 1 319 320 143 0 ‐ 0 40 44 44 ‐Actual Volume Flow m3/h 296 297 286 375 371 1 0 0 ‐ 1 331 314 141 0 ‐ 0 43 43 43 ‐

Mass Density (Note 3) kg/m3 901.1 900.2 932.6 854.7 856.8 856.3 941 915 ‐ 856.3 856.3 933.6 934.8 917 ‐ 976 597 637 638 ‐API Gravity (STD) °API 10 10 10 14 21 10 68 98 ‐ 10 22 17 17 95 ‐ 88 88 88 87 ‐Molecular Weight kg/kgmole 413.35 415.31 433.10 214.99 217.40 229.26 535.10 322.88 ‐ 229.23 260.94 263.44 374.40 323.53 ‐ 392.08 67.36 66.37 66.36 ‐Viscosity (Note 4)  cP 9.91 9.90 39.17 3.90 4.10 4.04 55.90 17.81 ‐ 4.00 4.00 127.89 175.75 18.37 ‐ 83.16 0.17 0.24 0.23 ‐

Thermal Conductivity W/m‐K 0.129 0.130 0.124 0.094 0.095 0.097 0.121 0.109 ‐ 0.097 0.103 0.115 0.122 0.109 ‐ 0.111 0.095 0.106 0.105 ‐Water

Mass Flow kg/h 819,687 837,063 837,558 839,510 36,085 803,311 0 0 34,454 837,766 0 192 0 0 0 0 2,393 2,436 2,435 0Std Ideal Liq Vol Flow m3/h 821 839 839 841 36 805 ‐ ‐ 35 839 ‐ 0 ‐ ‐ ‐ ‐ 2 2 2 ‐Actual Volume Flow m3/h 951 973 918 915 39 876 ‐ ‐ 38 914 ‐ 0 ‐ ‐ ‐ ‐ 2 2 2 ‐

Mass Density kg/m3 861.8 859.9 912.6 917.1 917.6 917.0 ‐ ‐ 917.5 917.0 ‐ 984.5 ‐ ‐ ‐ ‐ 985.3 1,017.2 1,017.1 ‐Viscosity cP 0.14 0.14 0.19 0.20 0.20 0.20 ‐ ‐ 0.20 0.20 ‐ 0.50 ‐ ‐ ‐ ‐ 0.51 1.23 1.21 ‐

Thermal Conductivity W/m‐K 0.669 0.668 0.688 0.688 0.688 0.688 ‐ ‐ 0.688 0.688 ‐ 0.649 ‐ ‐ ‐ ‐ 0.648 0.590 0.591 ‐Vapour

Mass Flow kg/h 149 0 0 1,831 1,417 36 651 1,831 0 35 22,577 0 4,344 1,417 22,546 30,138 2,356 303 0 303Std Gas Flow STD_m3/h 192 ‐ ‐ 901 682 17 832 901 ‐ 17 9,925 ‐ 1,709 682 9,915 13,207 1,155 250 ‐ 250

Molecular Weight kg/kgmole 18.3 ‐ ‐ 48.0 49.1 49.3 18.5 48.0 ‐ 49.2 53.8 ‐ 60.1 49.1 53.8 54.0 48.2 28.7 ‐ 28.7Mass Density kg/m3 9.9 ‐ ‐ 22.4 21.3 19.2 2.1 6.9 ‐ 19.2 10.6 ‐ 2.1 7.1 8.0 8.0 7.7 5.0 ‐ 4.4

Viscosity cP 0.014 ‐ ‐ 0.011 0.011 0.011 0.013 0.011 ‐ 0.011 0.010 ‐ 0.007 0.010 0.009 0.010 0.010 0.011 ‐ 0.011Cp/(Cp‐R) (Ideal Gamma) 1.1 ‐ ‐ 1.1 1.0 1.1 1.3 1.1 ‐ 1.1 1.0 ‐ 1.0 1.1 1.1 1.1 1.1 1.1 ‐ 1.2

Z Factor 0.9 ‐ ‐ 0.9 0.9 0.9 1.0 1.0 ‐ 0.9 0.9 ‐ 1.0 1.0 0.9 0.9 0.9 1.0 ‐ 1.0Thermal Conductivity W/m‐K 0.0 ‐ ‐ 0.0 0.0 0.0 0.0 0.0 ‐ 0.0 0.0 ‐ 0.0 0.0 0.0 0.0 0.0 0.0 ‐ 0.0

H2O 0.9867 0.9871 0.9871 0.9684 0.5790 0.9998 0.7838 0.2293 1.0000 0.9998 0.0766 0.0109 0.0109 0.2418 0.2590 0.2421 0.2421 0.2421 0.2467 0.0035H2S 0.00000 0.00000 0.00000 0.00001 0.00003 0.00000 0.00032 0.00043 0.00000 0.00000 0.00006 0.00001 0.00001 0.00042 0.00019 0.00021 0.00021 0.00021 0.00019 0.00131CO2 0.0001 0.0001 0.0001 0.0001 0.0009 0.0001 0.0204 0.0251 0.0000 0.0001 0.0016 0.0002 0.0002 0.0219 0.0054 0.0072 0.0072 0.0072 0.0053 0.1078

Helium 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Nitrogen 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

Air 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Methane 0.0003 0.0001 0.0001 0.0003 0.0024 0.0000 0.1937 0.1214 0.0000 0.0000 0.0036 0.0002 0.0002 0.0908 0.0129 0.0232 0.0232 0.0232 0.0114 0.6345Ethane 0.0000 0.0000 0.0000 0.0001 0.0008 0.0000 0.0000 0.0176 0.0000 0.0000 0.0016 0.0003 0.0003 0.0161 0.0052 0.0064 0.0064 0.0064 0.0056 0.0483

Propane 0.0000 0.0000 0.0000 0.0004 0.0049 0.0000 0.0000 0.0507 0.0000 0.0000 0.0099 0.0032 0.0032 0.0501 0.0285 0.0315 0.0315 0.0315 0.0308 0.0666C4+ 0.0129 0.0127 0.0127 0.0307 0.4120 0.0001 0.0018 0.5555 0.0000 0.0001 0.9067 0.9852 0.9852 0.5788 0.6888 0.6893 0.6893 0.6893 0.7000 0.1380

NOTES:1. Values are for each 40,000 bpd phase for Phases 3 & 4. SUNCOR LEWIS PH 3 & 4

AREA 1000 ‐ OIL TREATINGHEAT AND MATERIAL BALANCE

PROJECT # DRAWING NUMBER REVISION

 40,000 BPSD

Stream Number

Stream Name

From

To

Overall

Overall Composition Mole Fraction

Area 1000 HMB (3,4) - Page 7 of 12

lehanson
Typewritten Text
Figure 7
Page 9: Attachment 14 Heat and Material Balance - Alberta.ca · 2019. 2. 14. · SUNCOR LEWIS PH 1 2 HEAT MATERIAL BALANCE TABLE. 2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011

SUNCOR LEWIS PH 3 4HEAT MATERIAL BALANCE TABLE

2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011 3000 3001 3002 3003 3004 3005 3006 3007

Produced water CFU froth De‐oiled waterDe‐oiled / 

makeup waterCasing gas  Slop vapours  Slop oil  Slop water Produced Gas Produced Gas PG Condensate Produced Gas Evap vapors

Combined vapors

Condensate  Condensate  Distillate Evaporator BD Vapors Ejector gas

Produced water header 

CFU CFUProducedWater Surge Drum

B/L Pipeline Slop Vessel Slop Vessel Slop VesselProduced Gas 

HeaderProduced Gas Condenser

PG Condensate Pump

PG Condenser Separator

Evaporator  HeaderEvap Vent Condenser

Evap Cond. Pumps 

Evaporator  Evaporator Evap Vent Cond 

Separator Fuel gas header

CFU  Slop VesselProducedWater Surge Drum

Evaporator  Slop vesselProduced Gas 

HeaderGas Boot  CFU

Produced Gas Condenser

PG Condenser Separator

Slop VesselProduced Gas 

HeaderEvap. Vent Condenser

Evap. Vent Condenser

Evap Vent Cond Separator

PW Surge DrumBFW Surge 

DrumDisposal Water Treatment

Produced Gas header

 Produced gas header

Vapour Fraction 0.000 0.163 0.000 0.000 1.000 1.000 0.000 0.000 1.000 0.430 0.000 1.000 1.000 1.000 0.001 0.000 0.000 0.000 1.000 1.000Operating Temperature °C 135.9 121.1 135.1 123.3 176.3 130.4 131.0 131.1 134.7 60.0 60.0 59.8 112.2 112.4 60.0 60.0 115.6 55.0 60.0 20.3

Operating Pressure kPaa 1,179 493 779 507 594 423 600 1,200 423 403 493 353 151 151 100 507 172 150 100 353Mass Flow kg/h 868,631 30,458 840,794 947,591 2,716 6,664 1,002 29,654 7,315 7,315 4,104 3,211 28,786 28,838 28,838 28,786 890,736 28,049 41 1,684

Mass Density kg/m3 915.4 17.2 917.1 928.0 3.0 2.4 938.6 921.5 2.3 6.3 978.1 2.4 0.9 0.9 473.9 980.6 946.1 985.5 1.3 2.6Molecular Weight kg/kgmole 18.04 18.67 18.02 18.02 18.02 18.56 426.02 18.02 18.55 18.55 18.26 18.94 18.02 18.03 18.03 18.02 18.02 18.02 36.27 18.14

Mass Heat Capacity kJ/kg‐C 4.50 4.01 4.51 4.46 1.99 2.14 2.11 4.49 2.14 3.36 4.29 2.16 1.92 1.92 4.32 4.33 4.24 4.18 1.05 2.09Thermal Conductivity W/m‐K 0.686 0.000 0.688 0.687 0.032 0.036 0.124 0.688 0.036 0.000 0.638 0.036 0.026 0.026 0.000 0.654 0.686 0.649 0.021 0.031

Combined LiquidMass Flow kg/h 868,597 25,516 840,792 947,591 0 0 1,002 29,654 0 4,104 4,104 0 0 0 28,796 28,786 890,736 28,049 0 0

Std Ideal Liq Vol Flow m3/h 870 26 843 950 ‐ ‐ 1 30 0 4 4 ‐ ‐ ‐ 29 29 893 28 ‐ ‐Actual Volume Flow m3/h 947 27 916 1,021 ‐ ‐ 1 32 0 4 4 ‐ ‐ ‐ 29 29 941 28 ‐ ‐

Mass Density kg/m3 917.1 930.7 917.7 928.0 ‐ ‐ 938.6 921.5 876.7 978.1 978.1 ‐ ‐ ‐ 980.5 980.6 946.1 985.5 ‐ ‐Molecular Weight kg/kgmole 18.04 18.69 18.02 18.02 ‐ ‐ 426.02 18.02 315.04 18.26 18.26 ‐ ‐ ‐ 18.02 18.02 18.02 18.02 ‐ ‐

Viscosity cP 0.20 0.25 0.20 0.22 ‐ ‐ 53.62 0.21 10.27 0.48 0.48 ‐ ‐ ‐ 0.46 0.46 0.24 0.50 ‐ ‐Thermal Conductivity W/m‐K 0.686 0.652 0.688 0.687 ‐ ‐ 0.124 0.688 0.119 0.638 0.638 ‐ ‐ ‐ 0.653 0.654 0.686 0.649 ‐ ‐

OilMass Flow kg/h 1,177 955 26 0 0 0 1,001 0 0 61 61 0 0 0 0 0 0 0 0 0

Std Ideal Liq Vol Flow m3/h 1 1 0 ‐ ‐ ‐ 1 ‐ 0 0 0 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐  ‐ Actual Volume Flow m3/h 1 1 0 ‐ ‐ ‐ 1 ‐ 0 0 0 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐  ‐ 

Mass Density (Note 3) kg/m3 885.8 948.6 943.0 ‐ ‐ ‐ 938.6 ‐ 876.7 840.6 840.7 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐API Gravity (STD) °API 10.16 36.96 10.15 ‐ ‐ ‐ 9.00 ‐ 127.48 127.48 10.48 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Molecular Weight kg/kgmole 228.88 437.69 446.34 ‐ ‐ ‐ 426.03 ‐ 315.04 161.84 161.84 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Viscosity (Note 4)  cP 7.33 84.85 60.66 ‐ ‐ ‐ 53.62 ‐ 10.27 8.96 8.95 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Thermal Conductivity W/m‐K 0.097 0.125 0.125 ‐ ‐ ‐ 0.124 ‐ 0.119 0.115 0.115 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Water

Mass Flow kg/h 867,420 24,561 840,766 947,591 0 0 0 29,654 0 4,043 4,043 0 0 0 28,796 28,786 890,736 28,049 0 0Std Ideal Liq Vol Flow m3/h 869 25 842 950 ‐ ‐ 0 30 ‐ 4 4 ‐ ‐ ‐ 29 29 893 28 ‐ 0Actual Volume Flow m3/h 946 26 916 1,021 ‐ ‐ 0 32 ‐ 4 4 ‐ ‐ ‐ 29 29 941 28 ‐ ‐

Mass Density kg/m3 917.2 930.0 917.7 928.0 ‐ ‐ 921.3 921.5 ‐ 980.5 980.5 ‐ ‐ ‐ 980.5 980.6 946.1 985.5 ‐ ‐Viscosity cP 0.20 0.23 0.20 0.22 ‐ ‐ 0.21 0.21 ‐ 0.46 0.46 ‐ ‐ ‐ 0.46 0.46 0.24 0.50 ‐ ‐

Thermal Conductivity W/m‐K 0.688 0.687 0.688 0.687 ‐ ‐ 0.688 0.688 ‐ 0.653 0.654 ‐ ‐ ‐ 0.653 0.654 0.686 0.649 ‐ ‐Vapour

Mass Flow kg/h 35 4,942 2 0 2,716 6,664 0 0 7,315 3,211 0 3,211 28,786 28,838 41 0 0 0 41 1,684Std Gas Flow STD_m3/h 17 6,280 3 ‐ 3,564 8,490 ‐ ‐ 9,323 4,008 ‐ 4,008 37,781 37,811 27 ‐ ‐ ‐ 27 2,195

Molecular Weight kg/kgmole 49.23 18.61 17.60 ‐ 18.02 18.56 ‐ ‐ 18.55 18.94 ‐ 18.94 18.02 18.03 36.27 ‐ ‐ ‐ 36.27 18.14Mass Density kg/m3 19.2 2.8 4.1 ‐ 3.0 2.4 ‐ ‐ 2.3 2.8 ‐ 2.4 0.9 0.9 1.3 ‐ ‐ ‐ 1.3 2.6

Viscosity cP 0.011 0.013 0.013 ‐ 0.011 0.012 ‐ ‐ 0.012 0.012 ‐ 0.012 0.013 0.013 0.014 ‐ ‐ ‐ 0.014 0.011Cp/(Cp‐R) (Ideal Gamma) 1.114 1.125 1.114 ‐ 1.301 1.264 ‐ ‐ 1.265 1.154 ‐ 1.255 1.317 1.317 1.119 ‐ ‐ ‐ 1.281 1.280

Z Factor 0.888 0.988 0.985 ‐ 0.969 0.987 ‐ ‐ 0.987 0.992 ‐ 0.993 0.988 0.988 0.995 ‐ ‐ ‐ 0.995 0.990Thermal Conductivity W/m‐K 0.028 0.038 0.041 ‐ 0.032 0.036 ‐ ‐ 0.036 0.036 ‐ 0.036 0.026 0.026 0.021 ‐ ‐ ‐ 0.021 0.031

H2O 0.9998 0.9048 1.0000 1.0000 0.9988 0.5717 0.0176 1.0000 0.5906 0.5906 0.9983 0.0500 1.0000 0.9992 0.9992 0.9998 1.0000 1.0000 0.2001 0.0039H2S 0.0000 0.0000 0.0000 0.0000 0.0000 0.0002 0.0000 0.0000 0.0002 0.0002 0.0000 0.0005 0.0000 0.0001 0.0001 0.0001 <hidden> <hidden> 0.0605 0.0012CO2 0.0001 0.0015 0.0000 0.0000 0.0003 0.0071 0.0002 0.0000 0.0083 0.0083 0.0000 0.0193 0.0000 0.0006 0.0006 0.0002 <hidden> <hidden> 0.6661 0.0193

Helium 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0001 0.0000 0.0000 0.0000 0.0000 <hidden> <hidden> 0.0018 0.0001Nitrogen 0.0000 0.0004 0.0000 0.0000 0.0000 0.0019 0.0000 0.0000 0.0017 0.0017 0.0000 0.0040 0.0000 0.0000 0.0000 0.0000 <hidden> <hidden> 0.0110 0.0046

Air 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 <hidden> <hidden> 0.0000 0.0000Methane 0.0000 0.0834 0.0000 0.0000 0.0009 0.3797 0.0053 0.0000 0.3631 0.3631 0.0000 0.8446 0.0000 0.0000 0.0000 0.0000 <hidden> <hidden> 0.0604 0.9010Ethane 0.0000 0.0046 0.0000 0.0000 0.0000 0.0211 0.0008 0.0000 0.0192 0.0192 0.0000 0.0447 0.0000 0.0000 0.0000 0.0000 <hidden> <hidden> 0.0001 0.0500

Propane 0.0000 0.0013 0.0000 0.0000 0.0000 0.0060 0.0005 0.0000 0.0055 0.0055 0.0000 0.0128 0.0000 0.0000 0.0000 0.0000 <hidden> <hidden> 0.0000 0.0139C4+ 0.0001 0.0038 0.0000 0.0000 0.0000 0.0123 0.9756 0.0000 0.0113 0.0113 0.0016 0.0242 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0059

NOTES:1. Values are for each 40,000 bpd phase for Phases 3 & 4. SUNCOR LEWIS PH 3 & 4

AREA 2000/3000 ‐ OIL REMOVAL, WATER TREATMENTHEAT AND MATERIAL BALANCE

PROJECT # DRAWING NUMBER REVISION

 40,000 BPSD

Stream Number

Stream Name

From

To

Overall

Overall Composition Mole Fraction

Area 2000 HMB (3,4) - Page 8 of 12

lehanson
Typewritten Text
Figure 8
Page 10: Attachment 14 Heat and Material Balance - Alberta.ca · 2019. 2. 14. · SUNCOR LEWIS PH 1 2 HEAT MATERIAL BALANCE TABLE. 2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011

SUNCOR LEWIS PH 3 4HEAT MATERIAL BALANCE TABLE

5000 5001 5002 5003 5005 5006 5007 7000 7001 9000 9001

LP BFW LP BFW HP BFW HP BFW HP Steam HP Steam CBD Disposal water Disposal water Raw water Raw water

LP BFW PumpsEmulsion / BFW 

exchangerHP BFW pumps  HP BFW header

HP Steam generator

HP Steam header

HP Steam generators

Disposal water treatment

Disposal Water Pumps

Source water  Raw water pumps 

Emulsion / BFW exchanger

HP BFW pumps HP BFW headerSteam 

GeneratorHP Steam header

B/L Well padsBlowdown header

Disposal Water Tank

Disposal wells CPF B/L PW Surge Drum

Vapour Fraction 0.000 0.000 0.000 0.000 1.000 1.000 0.000 0.000 0.000 0.000 0.000Operating Temperature °C 115.9 179.2 180.8 180.8 286.7 286.7 286.7 55.0 55.6 15.5 15.7

Operating Pressure kPaa 2,009 1,909 7,493 7,493 7,093 7,093 7,093 150 5,022 363 1,670Mass Flow kg/h 890,736 890,736 890,736 890,736 872,921 872,921 17,815 28,049 28,049 78,043 78,043

Mass Density kg/m3 946.8 888.2 890.2 890.2 37.1 37.1 738.2 985.5 987.3 1,014.5 1,014.7Molecular Weight kg/kgmole 18.02 18.02 18.02 18.02 18.02 18.02 18.02 18.02 18.02 18.02 18.02

Mass Heat Capacity kJ/kg‐C 4.23 4.40 4.38 4.38 5.08 5.08 5.43 4.18 4.17 4.32 4.31Thermal Conductivity W/m‐K 0.686 0.677 0.676 0.676 0.042 0.042 0.564 0.649 0.649 0.596 0.596

Combined Liquid 0 0 0 0Mass Flow kg/h 890,736 890,736 890,736 890,736 0 0 17,815 28,049 28,049 78,043 78,043

Std Ideal Liq Vol Flow m3/h 893 893 893 893 ‐ ‐ 18 28 28 78 78Actual Volume Flow m3/h 941 1,003 1,001 1,001 ‐ ‐ 24 28 28 77 77

Mass Density kg/m3 946.8 888.2 890.2 890.2 ‐ ‐ 738.2 985.5 987.3 1,014.5 1,014.7Molecular Weight kg/kgmole 18.02 18.02 18.02 18.02 ‐ ‐ 18.02 18.02 18.02 18.02 18.02

Viscosity cP 0.24 0.15 0.15 0.15 ‐ ‐ 0.09 0.50 0.50 1.12 1.12Thermal Conductivity W/m‐K 0.686 0.677 0.676 0.676 ‐ ‐ 0.564 0.649 0.649 0.596 0.596

Oil 0 0 0 0Mass Flow kg/h 0 0 0 0 0 0 0 0 0 0 0

Std Ideal Liq Vol Flow m3/h ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Actual Volume Flow m3/h ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Mass Density (Note 3) kg/m3 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐API Gravity (STD) °API ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Molecular Weight kg/kgmole ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Viscosity (Note 4)  cP ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Thermal Conductivity W/m‐K ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Water 0 0 0 0

Mass Flow kg/h 890,736 890,736 890,736 890,736 0 0 17,815 28,049 28,049 78,043 78,043Std Ideal Liq Vol Flow m3/h 893 893 893 893 ‐ ‐ 18 28 28 78 78Actual Volume Flow m3/h 941 1,003 1,001 1,001 ‐ ‐ 24 28 28 77 77

Mass Density kg/m3 946.8 888.2 890.2 890.2 ‐ ‐ 738.2 985.5 987.3 1,014.5 1,014.7Viscosity cP 0.24 0.15 0.15 0.15 ‐ ‐ 0.09 0.50 0.50 1.12 1.12

Thermal Conductivity W/m‐K 0.686 0.677 0.676 0.676 ‐ ‐ 0.564 0.649 0.649 0.596 0.596Vapour 0 0 0 0

Mass Flow kg/h 0 0 0 0 872,921 872,921 0 0 0 0 0Std Gas Flow STD_m3/h ‐ ‐ ‐ ‐ 1,145,691 1,145,691 ‐ ‐ ‐ ‐ ‐

Molecular Weight kg/kgmole ‐ ‐ ‐ ‐ 18.0 18.0 ‐ ‐ ‐ ‐ ‐Mass Density kg/m3 ‐ ‐ ‐ ‐ 37.1 37.1 ‐ ‐ ‐ ‐ ‐

Viscosity cP ‐ ‐ ‐ ‐ 0.019 0.019 ‐ ‐ ‐ ‐ ‐Cp/(Cp‐R) (Ideal Gamma) ‐ ‐ ‐ ‐ 1.1 1.1 ‐ ‐ ‐ ‐ ‐

Z Factor ‐ ‐ ‐ ‐ 0.7 0.7 ‐ ‐ ‐ ‐ ‐Thermal Conductivity W/m‐K ‐ ‐ ‐ ‐ 0.0 0.0 ‐ ‐ ‐ ‐ ‐

0.00000 0.00000 0.00000 0.00000H2O 1.0000 1.0000 1.0000 1.0000 1.0000 1.0000 1.0000 1.0000 1.0000 1.0000 1.0000H2S 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000CO2 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

Helium 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Nitrogen 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

Air 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Methane 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Ethane 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

Propane 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000C4+ 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

NOTES:1. Values are for each 40,000 bpd phase for Phases 3 & 4. SUNCOR LEWIS PH 3 & 4

AREA 5000 & 5700 ‐ BFW & STEAM GENERATIONAREA 7000 & 9000 ‐ DISPOSAL & RAW WATER SYSTEMS

HEAT AND MATERIAL BALANCE 40,000 BPSD

Stream Number

Stream Name

From

To

Overall

Overall Composition Mole Fraction

Area 5000-5700 HMB (3,4) - Page 9 of 12

lehanson
Typewritten Text
Figure 9
Page 11: Attachment 14 Heat and Material Balance - Alberta.ca · 2019. 2. 14. · SUNCOR LEWIS PH 1 2 HEAT MATERIAL BALANCE TABLE. 2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011

SUNCOR LEWIS PH 3 4HEAT MATERIAL BALANCE TABLE

6000 6001 6002 6003 6004 6005 6006 6007 6008 6009 6010 6011 6012 6013 6014 6015 6016 6017 6018

Cold glycol Cold glycol  Hot glycol Cold Glycol Hot glycol Cold Glycol Warm glycol Hot glycol Hot glycol Hot glycol Hot glycol Hot glycol Cold glycol Cold glycol Hot glycol Cooled glycol Cold Glycol Cold Glycol Hot glycol

Glycol Circ. pump

 Cold glycol supply header 

Evaporator Cold glycol 

supply header Dilbit Coolers

 Cold glycol supply header 

Sample / seal flush cooling

Dilbit Coolers / Evaporator

bypass lineHot glycol 

Supply headerCombustion Air Preheaters

Hot glycol Supply header

Natural gas heater

Heating glycol system

Glycol main return header

Glycol Aerial Coolers 

Glycol Circ. Pumps

 Cold glycol supply header 

Produced Gas Condenser

 Cold glycol supply header 

EvaporatorHot glycol 

Return headerDilbit Coolers

Hot glycol Return header

Sample / seal flush cooling

Warm glycol return header

Hot glycol return header

Glycol Return header

Combustion Air Preheaters

Cold glycol return header

Natural gas heater

Cold glycol return header

Glycol return header

Glycol Aerial Coolers

Expansion Drum Glycol FilterProduced Gas Condenser

Hot glycol Return header

Vapour Fraction 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000 0.000Operating Temperature °C 40.0 40.0 90.0 40.0 90.0 40.0 70.0 90.0 90.0 90.0 50.0 90.0 45.0 50.0 69.9 40.0 40.0 40.0 90.0

Operating Pressure kPaa 1,094 1,094 794 1,094 794 1,094 404 794 404 654 404 654 153 404 404 153 153 1,094 794Mass Flow kg/h 475,043 48,953 48,953 251,489 251,489 54,750 54,750 365,543 175,668 183,369 183,369 6,506 6,506 183,369 413,786 413,786 54,750 65,101 65,101

Mass Density kg/m3 1,074.7 1,074.7 1,038.2 1,074.7 1,038.2 1,074.7 1,054.3 1,038.2 1,038.2 1,038.2 1,068.3 1,038.2 1,071.5 1,068.3 1,054.4 1,074.7 1,074.7 1,074.7 1,038.2Molecular Weight kg/kgmole 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17

Mass Heat Capacity kJ/kg‐C 3.19 3.19 3.41 3.19 3.41 3.19 3.32 3.41 3.41 3.41 3.23 3.41 3.21 3.23 3.32 3.19 3.19 3.19 3.41Thermal Conductivity W/m‐K 0.351 0.351 0.336 0.351 0.336 0.351 0.342 0.336 0.336 0.336 0.348 0.336 0.349 0.348 0.342 0.351 0.351 0.351 0.336

Combined LiquidMass Flow kg/h 475,043 48,953 48,953 251,489 251,489 54,750 54,750 365,543 175,668 183,369 183,369 6,506 6,506 183,369 413,786 413,786 54,750 65,101 65,101

Std Ideal Liq Vol Flow m3/h 434 45 45 230 230 50 50 334 160 167 167 6 6 167 378 378 50 59 59Actual Volume Flow m3/h 442 46 47 234 242 51 52 352 169 177 172 6 6 172 392 385 51 61 63

Mass Density kg/m3 1,074.7 1,074.7 1,038.2 1,074.7 1,038.2 1,074.7 1,054.3 1,038.2 1,038.2 1,038.2 1,068.3 1,038.2 1,071.5 1,068.3 1,054.4 1,074.7 1,074.7 1,074.7 1,038.2Molecular Weight kg/kgmole 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17

Viscosity cP 4.82 4.82 1.41 4.82 1.41 4.82 2.16 1.41 1.41 1.41 3.57 1.41 4.13 3.57 2.17 4.82 4.82 4.82 1.41Thermal Conductivity W/m‐K 0.351 0.351 0.336 0.351 0.336 0.351 0.342 0.336 0.336 0.336 0.348 0.336 0.349 0.348 0.342 0.351 0.351 0.351 0.336

OilMass Flow kg/h 475,043 48,953 48,953 251,489 251,489 54,750 54,750 365,543 175,668 183,369 183,369 6,506 6,506 183,369 413,786 413,786 54,750 65,101 65,101

Std Ideal Liq Vol Flow m3/h 434 45 45 230 230 50 50 334 160 167 167 6 6 167 378 378 50 59 59Actual Volume Flow m3/h 442 46 47 234 242 51 52 352 169 177 172 6 6 172 392 385 51 61 63

Mass Density (Note 3) kg/m3 1074.7 1074.7 1038.2 1074.7 1038.2 1074.7 1054.3 1038.2 1038.2 1038.2 1068.3 1038.2 1071.5 1068.3 1054.4 1074.7 1074.7 1074.7 1038.2API Gravity (STD) °API ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41 ‐2.41Molecular Weight kg/kgmole 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17 38.17Viscosity (Note 4)  cP 4.82 4.82 1.41 4.82 1.41 4.82 2.16 1.41 1.41 1.41 3.57 1.41 4.13 3.57 2.17 4.82 4.82 4.82 1.41

Thermal Conductivity W/m‐K 0.351 0.351 0.336 0.351 0.336 0.351 0.342 0.336 0.336 0.336 0.348 0.336 0.349 0.348 0.342 0.351 0.351 0.351 0.336Water 0 0 0 0 0 0 0 0 0

Mass Flow kg/h 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0Std Ideal Liq Vol Flow m3/h ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Actual Volume Flow m3/h ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Mass Density kg/m3 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Viscosity cP ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Thermal Conductivity W/m‐K ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Vapour

Mass Flow kg/h 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0Std Gas Flow STD_m3/h ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Molecular Weight kg/kgmole ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Mass Density kg/m3 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Viscosity cP ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Cp/(Cp‐R) (Ideal Gamma) ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

Z Factor ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐Thermal Conductivity W/m‐K ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐

H2O 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 (60% TEG) 1.0 ( 60%TEG) 1.0 ( 60%TEG) 1.0 ( 60%TEG) 1.0 ( 60%TEG)H2S 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000CO2 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

Helium 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Nitrogen 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

Air 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Methane 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Ethane 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

Propane 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000C4+ 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

NOTES:1. Values are for each 40,000 bpd phase for Phases 3 & 4. SUNCOR LEWIS PH 3 & 4

AREA 6200 ‐ GLYCOL SYSTEMHEAT AND MATERIAL BALANCE

PROJECT # DRAWING NUMBER REVISION

 40,000 BPSD

Stream Number

Stream Name

From

To

Overall

Overall Composition Mole Fraction

Area 6000 HMB (3,4) - Page 10 of 12

lehanson
Typewritten Text
Figure 10
Page 12: Attachment 14 Heat and Material Balance - Alberta.ca · 2019. 2. 14. · SUNCOR LEWIS PH 1 2 HEAT MATERIAL BALANCE TABLE. 2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011

SUNCOR LEWIS PH 3 4HEAT MATERIAL BALANCE TABLE

6200 6201 6202 6203 6204 6207 6208 6209 6211 6212 6214 6215 6216

Natural gas Natural gas Natural gas Natural gas HP fuel gasCombined Fuel 

Gas Mixed fuel gas Mixed fuel gas

Blanketing Natural gas

Purge gas Natural gas Bubble gas Mixed Fuel Gas

CPF B/L HeaderDiluent Rec. Trim Cooler

Natural Gas Heater

Header NG / PG HeaderMixed Fuel Gas 

DrumMixed fuel gas 

headerPipeline

Critical fuel gas header

LP Fuel gas header

MP fuel gas header

Produced Gas Header

HeaderDiluent Rec. Trim Cooler

Natural Gas Heater

HeaderEvaporator Vent 

EjectorMixed Fuel Gas 

DrumMixed fuel gas 

headerHP Steam Generator

Wellpads HP Flare headerSteam Gen. Pilot 

burnerCFU NG / PG Header

Vapour Fraction 1.000 1.000 1.000 1.000 1.000 1.000 1.000 1.000 1.000 1.000 1.000 1.000 0.998Operating Temperature °C 7.0 7.0 41.4 50.0 34.2 22.4 22.4 22.4 7.0 19.1 19.8 26.1 46.9

Operating Pressure kPaa 7,068 7,068 6,968 6,868 3,193 353 353 353 7,068 443 443 1,595 353Mass Flow kg/h 40,540 40,363 40,363 40,363 1,600 41,055 41,054 41,054 156 21 244 2,621 5,156

Mass Density kg/m3 67.5 67.5 54.2 51.2 23.8 2.6 2.6 2.6 67.5 3.3 3.3 11.8 2.5Molecular Weight kg/kgmole 17.67 17.67 17.67 17.67 17.67 17.82 17.82 17.82 17.67 17.67 17.67 17.67 18.97

Mass Heat Capacity kJ/kg‐C 2.88 2.88 2.67 2.64 2.38 2.14 2.14 2.14 2.88 2.15 2.16 2.25 2.13Thermal Conductivity W/m‐K 0.038 0.038 0.041 0.042 0.036 0.032 0.032 0.032 0.038 0.032 0.032 0.034 0.000

Combined LiquidMass Flow kg/h 0 0 0 0 0 0 0 0 0 0 0 0 12

Std Ideal Liq Vol Flow m3/h ‐ ‐ ‐ ‐ ‐ 0 ‐ ‐ ‐ ‐ ‐ ‐ 0Actual Volume Flow m3/h ‐ ‐ ‐ ‐ ‐ 0 ‐ ‐ ‐ ‐ ‐ ‐ 0

Mass Density kg/m3 ‐ ‐ ‐ ‐ ‐ 862.9 ‐ ‐ ‐ ‐ ‐ ‐ 976.2Molecular Weight kg/kgmole ‐ ‐ ‐ ‐ ‐ 166.2 ‐ ‐ ‐ ‐ ‐ ‐ 19.5

Viscosity cP ‐ ‐ ‐ ‐ ‐ 36.5 ‐ ‐ ‐ ‐ ‐ ‐ 0.7Thermal Conductivity W/m‐K ‐ ‐ ‐ ‐ ‐ 0.1 ‐ ‐ ‐ ‐ ‐ ‐ 0.6

OilMass Flow kg/h 0 0 0 0 0 0 0 0 0 0 0 0 1

Std Ideal Liq Vol Flow m3/h ‐ ‐ ‐ ‐ ‐ 0 ‐ ‐ ‐ ‐ ‐ ‐ 0Actual Volume Flow m3/h ‐ ‐ ‐ ‐ ‐ 0 ‐ ‐ ‐ ‐ ‐ ‐ 0

Mass Density (Note 3) kg/m3 ‐ ‐ ‐ ‐ ‐ 862.9 ‐ ‐ ‐ ‐ ‐ ‐ 841.4API Gravity (STD) °API ‐ ‐ ‐ ‐ ‐ 311.4 ‐ ‐ ‐ ‐ ‐ ‐ 281.9Molecular Weight kg/kgmole ‐ ‐ ‐ ‐ ‐ 166.2 ‐ ‐ ‐ ‐ ‐ ‐ 153.9Viscosity (Note 4)  cP ‐ ‐ ‐ ‐ ‐ 36.5 ‐ ‐ ‐ ‐ ‐ ‐ 11.0

Thermal Conductivity W/m‐K ‐ ‐ ‐ ‐ ‐ 0.1 ‐ ‐ ‐ ‐ ‐ ‐ 0.1Water

Mass Flow kg/h 0 0 0 0 0 0 0 0 0 0 0 0 11Std Ideal Liq Vol Flow m3/h ‐ ‐ ‐ ‐ 0 ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0Actual Volume Flow m3/h ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0

Mass Density kg/m3 ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 990.8Viscosity cP ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0.6

Thermal Conductivity W/m‐K ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ ‐ 0.6Vapour

Mass Flow kg/h 40,540 40,363 40,363 40,363 1,600 41,054 41,054 41,054 156 21 244 2,621 5,144Std Gas Flow STD_m3/h 54,260 54,023 54,023 54,023 2,141 54,474 54,474 54,474 208 28 327 3,508 6,412

Molecular Weight kg/kgmole 17.67 17.67 17.67 17.67 17.67 17.82 17.82 17.82 17.67 17.67 17.67 17.67 18.97Mass Density kg/m3 67.5 67.5 54.2 51.2 23.8 2.6 2.6 2.6 67.5 3.3 3.3 11.8 2.5

Viscosity cP 0.013 0.013 0.014 0.014 0.012 0.011 0.011 0.011 0.013 0.011 0.011 0.012 0.012Cp/(Cp‐R) (Ideal Gamma) 1.195 1.195 1.214 1.217 1.247 1.278 1.278 1.278 1.195 1.280 1.279 1.265 1.258

Z Factor 0.795 0.795 0.868 0.883 0.928 0.990 0.990 0.990 0.795 0.988 0.988 0.959 0.992Thermal Conductivity W/m‐K 0.038 0.038 0.041 0.042 0.036 0.032 0.032 0.032 0.038 0.032 0.032 0.034 0.034

H2O 0.0000 0.0000 0.0000 0.0000 0.0000 0.0038 0.0038 0.0038 0.0000 0.0000 0.0000 0.0000 0.0321H2S 0.0000 0.0000 0.0000 0.0000 0.0000 0.0001 0.0001 0.0001 0.0000 0.0000 0.0000 0.0000 0.0006CO2 0.0058 0.0058 0.0058 0.0058 0.0058 0.0076 0.0076 0.0076 0.0058 0.0058 0.0058 0.0058 0.0210

Helium 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001 0.0001Nitrogen 0.0046 0.0046 0.0046 0.0046 0.0046 0.0045 0.0045 0.0045 0.0046 0.0046 0.0046 0.0046 0.0040

Air 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Methane 0.9180 0.9180 0.9180 0.9180 0.9180 0.9109 0.9109 0.9109 0.9180 0.9180 0.9180 0.9180 0.8576Ethane 0.0510 0.0510 0.0510 0.0510 0.0510 0.0505 0.0505 0.0505 0.0510 0.0510 0.0510 0.0510 0.0468

Propane 0.0142 0.0142 0.0142 0.0142 0.0142 0.0143 0.0143 0.0143 0.0142 0.0142 0.0142 0.0142 0.0153C4+ 0.0063 0.0063 0.0063 0.0063 0.0063 0.0082 0.0082 0.0082 0.0063 0.0063 0.0063 0.0063 0.0225

NOTES:1. Values are for each 40,000 bpd phase for Phases 3 & 4. SUNCOR LEWIS PH 3 & 4

AREA 6200 ‐ FUEL GAS SYSTEMHEAT AND MATERIAL BALANCE

PROJECT # DRAWING NUMBER REVISION

 40,000 BPSD

Stream Number

Stream Name

From

To

Overall

Overall Composition Mole Fraction

Area 6200 HMB (3,4) - Page 11 of 12

lehanson
Typewritten Text
Figure 11
Page 13: Attachment 14 Heat and Material Balance - Alberta.ca · 2019. 2. 14. · SUNCOR LEWIS PH 1 2 HEAT MATERIAL BALANCE TABLE. 2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011

SUNCOR LEWIS PH 4HEAT MATERIAL BALANCE TABLE

4000 4001 4002 4003 4004 4005 4006 4007

Diluent Diluent Diluent Trim diluent DilbitDilbit / Diluent 

vaporsRecovered liquids

VRU Gas

Supply pipeline Diluent pumps Diluent supply 

headerDiluent supply 

headerDilbit tank

Dilbit/Offspec/ Diluent tanks 

VRU package VRU package

CPF B/LDiluent supply 

headerFWKO/Treaters

CPF B/L (Trim blending)

CPF B/L (Dilbit product pumps)

VRU package Dilbit headerDiluent Rec. 

Cooler

Vapour Fraction 0.000 0.000 0.000 0.000 0.000 1.000 0.000 1.000Operating Temperature °C 15.0 15.8 15.8 15.8 53.0 53.0 53.3 126.6

Operating Pressure kPaa 593 1,613 1,613 1,613 93 93 896 460Mass Flow kg/h 73,549 73,549 33,124 40,425 300,161 4,355 0 4,355

Mass Density kg/m3 676.4 676.5 676.5 676.5 974.3 2.1 934.8 8.9Molecular Weight kg/kgmole 66.12 66.12 66.12 66.12 274.54 60.13 221.30 60.13

Mass Heat Capacity kJ/kg‐C 2.15 2.15 2.15 2.15 1.86 1.79 1.90 2.13Thermal Conductivity W/m‐K 0.109 0.109 0.109 0.109 0.118 0.017 0.114 0.024

Combined LiquidMass Flow kg/h 73,549 73,549 33,124 40,425 300,161 0 0 0

Std Ideal Liq Vol Flow m3/h 109 109 49 60 313 ‐ ‐ ‐

Actual Volume Flow m3/h 109 109 49 60 308 ‐ ‐ ‐

Mass Density kg/m3 676.4 676.5 676.5 676.5 974.3 ‐ ‐ ‐Molecular Weight kg/kgmole 66.12 66.12 66.12 66.12 274.54 ‐ ‐ ‐

Viscosity cP 0.32 0.32 0.32 0.32 183.74 ‐ ‐ ‐Thermal Conductivity W/m‐K 0.109 0.109 0.109 0.109 0.118 ‐ ‐ ‐

OilMass Flow kg/h 73,549 73,549 33,124 40,425 300,161 0 0 0

Std Ideal Liq Vol Flow m3/h 109 109 49 60 313  ‐   ‐   ‐ 

Actual Volume Flow m3/h 109 109 49 60 308  ‐   ‐   ‐ 

Mass Density (Note 3) kg/m3 676.4 676.5 676.5 676.5 974.3  ‐   ‐   ‐ API Gravity (STD) °API 77.61 77.61 77.61 77.61 16.10  ‐   ‐   ‐ Molecular Weight kg/kgmole 66.12 66.12 66.12 66.12 274.54  ‐   ‐   ‐ Viscosity (Note 4)  cP 0.32 0.32 0.32 0.32 183.74  ‐   ‐   ‐ 

Thermal Conductivity W/m‐K 0.109 0.109 0.109 0.109 0.118  ‐   ‐   ‐ Water

Mass Flow kg/h 0 0 0 0 0 0 0 0

ndard Ideal Liquid Volume Flow m3/h  ‐   ‐   ‐   ‐   ‐   ‐   ‐   ‐ 

Actual Volume Flow m3/h  ‐   ‐   ‐   ‐   ‐   ‐   ‐   ‐ 

Mass Density kg/m3  ‐   ‐   ‐   ‐   ‐   ‐   ‐   ‐ Viscosity cP  ‐   ‐   ‐   ‐   ‐   ‐   ‐   ‐ 

Thermal Conductivity W/m‐K  ‐   ‐   ‐   ‐   ‐   ‐   ‐   ‐ Vapour

Mass Flow kg/h 0 0 0 0 0 4,355 0 4,355

Std Gas Flow STD_m3/h  ‐   ‐   ‐   ‐  ‐ 1,713 ‐ 1,713Molecular Weight kg/kgmole  ‐   ‐   ‐   ‐  ‐ 60.13 ‐ 60.13

Mass Density kg/m3  ‐   ‐   ‐   ‐  ‐ 2.1 ‐ 8.9Viscosity cP  ‐   ‐   ‐   ‐  ‐ 0.007 ‐ 0.009

Cp/(Cp‐R) (Ideal Gamma)  ‐   ‐   ‐   ‐  ‐ 1.084 ‐ 1.069Z Factor  ‐   ‐   ‐   ‐  ‐ 0.977 ‐ 0.933

Thermal Conductivity W/m‐K  ‐   ‐   ‐   ‐  ‐ 0.017 ‐ 0.024

H2O 0.0000 0.0000 0.0000 0.0000 0.0016 0.1510 0.0016 0.1509

H2S 0.0000 0.0000 0.0000 0.0000 0.00001 0.0004 0.00001 0.0004

CO2 0.0000 0.0000 0.0000 0.0000 0.0001 0.0070 0.0001 0.0070Helium 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

Nitrogen 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000Air 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000 0.0000

Methane 0.0000 0.0000 0.0000 0.0000 0.0000 0.0027 0.0000 0.0027Ethane 0.0012 0.0012 0.0012 0.0012 0.0000 0.0031 0.0000 0.0031

Propane 0.0045 0.0045 0.0045 0.0045 0.0013 0.0297 0.0014 0.0297C4+ 0.9943 0.9943 0.9943 0.9943 0.9970 0.8061 0.9970 0.8062

NOTES:1. Trim diluent flow rate is based on meeting 350 cSt dilbit viscosity at 7.5 °C pipeline winter reference temperature. SUNCOR LEWIS PH 42. Streams 4002, 4006, and 4007 are per 40,000 bpd phase for each of Ph 1 ‐ 3. AREA 4000 ‐ HC TANK FARM

HEAT AND MATERIAL BALANCE

PROJECT # DRAWING NUMBER REVISION

 40,000 BPSD

Stream Number

Stream Name

From

To

Overall

Overall Composition Mole Fraction

Area 4000 HMB (4) - Page 12 of 12

lehanson
Typewritten Text
Figure 12