Embed Size (px)
Citation preview
Appliance Diagnostic Modes Refrigerator
GE Consumer & Industrial Technical Training
2 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
RefrigeratorTable of Contents
• GSS & PSS23/25/27/29 Series (#31-9072)• GSS20/22/25 Series (#31-9071)• ESS & HSS22/25 Series (#31-9071)• SSS25 Series (#31-9071)• ETS/GTS/HTS/PTS/STS22 Series (#31-9077)• PTS25 Series (#31-9077)• PDS & GBS20/22P Series (#31-9112)• PSH23S & PSH25S Series (#31-9090)• PSH23P/PSH25P/PSH27P/PSH30P Series (#31-9118)
3 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
RefrigeratorTable of Contents
• ZIS360/420/480NM Series (#31-9091)• ZIC360N Series (#31-9079)• ZIS360/420/480NR Series (#31-9117)• ZIC360NR/ZICS360NR Series (#31-9122)• PSB42/48L Series (#31-9125)• Electronic Ice Maker (#31-9063)• Electronic Quick Reference Cart (#31-9097)
4 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Arctica SxS
5 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Arctica SxSMake sure controls are set to either “5” & “5” or “37” & “0”
Now press any other pad between the FF & FRZ displays to lock test mode.
6 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
* NOTE: Only do this test if model was built in 2002 or later.
(SG35)
*
7 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG54)
16K
8 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Arctica SxS
(SG13)
J8 J9 J11
9 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Arctica SxS
(SG39)
10 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Arctica SxS
(SG39)
11 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG40)
12 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Arctica SxS
(SG41)
13 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG61)
Arctica SxS
J8
J9
J11
N
14 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Arctica SxS
(SG42)
15 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG42)
16 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG43)
Arctica SxS
17 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG43)
18 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Arctica SxS
(SG44)
19 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG44)
20 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Arctica SxS
(SG45)
21 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG45)
22 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Arctica SxS
(SG46)
23 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG46)
24 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG47)
Arctica SxS
25 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG48)
Arctica SxS
26 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG48)
27 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Arctica SxS
(SG49)
28 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG49)
29 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Arctica SxS
(SG50)
30 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG50)
31 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Arctica SxS
(SG51)
32 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG51)
33 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG52)
Arctica SxS
34 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG53)
Arctica SxS
35 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
GE SxS
36 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Press any key pad in the middle to lock in test.
GE Electronic Refrigerator Diagnostic Aid - SxS
37 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
38 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
16K
39 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
GE SxS
(SG12)
J8 J9 J11
40 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
GE SxS
(SG36)
41 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
GE SxS
(SG37)
42 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
GE SxS
(SG38)
43 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG59)
N
GE SxS
44 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
GE SxS
(SG39)
45 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG39)
46 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG40)
GE SxS
47 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG40)
48 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG41)
GE SxS
49 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG41)
50 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
GE SxS
(SG42)
51 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG42)
52 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG43)
GE SxS
53 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG43)
54 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG44)
GE SxS
55 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG45)
GE SxS
56 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
GE SxS
(SG46)
57 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG46)
58 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG47)
GE SxS
59 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG48)
GE SxS
60 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
GE TMNF
61 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
GE Electronic Refrigerator Diagnostic Aid - TMNF
62 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Press any key pad in the middle to lock in test.
GE Electronic Refrigerator Diagnostic Aid - TMNF
63 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
64 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
16K
65 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
GE TMNF
(SG12)
J8 J9 J11
66 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG31)
GE TMNF
67 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG31)
GE TMNF
68 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG32)
GE TMNF
69 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG32)
GE TMNF
70 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG36)
GE TMNF
J8
J9
J11
N
71 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG45)
GE TMNF
72 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG45)
73 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG46)
GE TMNF
74 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG46)
75 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG47)
GE TMNF
76 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG47)
77 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG48)
GE TMNF
78 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG49)
GE TMNF
79 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG50)
GE TMNF
80 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG51)
GE TMNF
81 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG51)
82 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG52)
GE TMNF
83 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG52)
84 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG53)
GE TMNF
85 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
GE BMNF
86 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG18)
GE Electronic Refrigerator Diagnostic Aid - BMNF
87 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Press any key pad in the middle to lock in test.
GE Electronic Refrigerator Diagnostic Aid - BMNF
88 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG19)
GE BMNF
89 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG12)
GE BMNF
16K
90 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG22)
GE BMNF
91 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG23)
GE BMNF
92 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Inverter Compressor
PSH23SGNAFBSPSH25SGNAFBS
93 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Arctica SxS Inverter CompressorMake sure controls are set to either “37” & “0”
Now press any other pad between the FF & FRZ displays to lock test mode.
94 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG35)
95 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
16K
96 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Inverter Compressor
(SG22)
97 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG12)
Inverter Compressor
98 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG12/13)
J11
Inverter Compressor
See next slide for testing for a compressor not running.
99 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG12/13)
Inverter Test• Put Refrigerator into Diagnostic Mode.• Set for the “1 – 2 Test” – Compressor Run Time.• Pull Refrigerator away from the wall.• Remove rear machine cover.• Set meter to ACV.• Place meter leads on Inverter wire connector (Black & Orange).• Should read line voltage – if not check wires & repair, otherwise go to next step.• Set meter to DCV.• Place meter leads on Inverter wire connector (Blue & Purple).• Should read between 4VDC & 6VDC – if not go to next step, otherwise checkcompressor windings – any two terminals should read 10W & also check eachterminal to case, replace compressor if any windings are defective – if not,replace Inverter.
• Remove cover from Main Control Board.• Place meter leads on J3-10 & J4-3.• Should read between 1.5VDC & 3.5VDC – if not replace Main Board.• If correct DCV at J3-10 & J4-3, replace Current-Source Circuit Board.
100 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG26)
Inverter Compressor
101 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG26)
Inverter Compressor
102 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG26)
Inverter Compressor
103 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG27)
Inverter Compressor
104 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG27)
Inverter Compressor
105 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG28)
Inverter Compressor
106 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG28)
Inverter Compressor
107 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG40)
J9
J11
N
Inverter Compressor
108 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG29)
Inverter Compressor
109 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG29)
110 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG30)
Inverter Compressor
111 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG30)
112 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG31)
Inverter Compressor
113 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG32)
Inverter Compressor
114 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG32)
115 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG33)
Inverter Compressor
116 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG33)
117 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG34)
Inverter Compressor
118 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG34)
119 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG35)
Inverter Compressor
120 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG35)
121 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG36)
Inverter Compressor
122 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG37)
Inverter Compressor
123 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Inverter Compressor
(SG38)
124 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
PSH23PGRPSH23PSRPSH25PGRPSH25PSRPSH27PGRPSH27PSRPSH30PGRPSH30PSR
ClimateKeeper
125 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Arctica SxS ClimateKeeperMake sure controls are set to either “37” & “0”
Now press any other pad between the FF & FRZ displays to lock test mode.
126 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
ClimateKeeper
(SG41)
127 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
ClimateKeeper
(SG42)
128 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
ClimateKeeper
(SG18)
16K
129 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
ClimateKeeper
(SG12)
130 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
ClimateKeeper
(SG13)
131 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
ClimateKeeper
(SG25/26)
132 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG25/26)
ClimateKeeper Inverter Test• Put Refrigerator into Diagnostic Mode.• Set for the “1 – 2 Test” – Compressor Run Time.• Pull Refrigerator away from the wall.• Remove rear machine cover.• Set meter to ACV.• Place meter leads on Inverter wire connector (Black & Orange).• Should read line voltage – if not check wires & repair, otherwise go to next step.• Set meter to DCV.• Place meter leads on Inverter wire connector (White & Red).• Should read between 4VDC & 6VDC – if not go to next step, otherwise checkcompressor windings – any two terminals should read 10W & also check eachterminal to case, replace compressor if any windings are defective – if not,replace Inverter.
• Remove cover from Main Control Board.• Place meter leads on J15-1 & J15-2.• Should read between 4VDC & 6VDC – if not replace Main Board.• If correct DCV at J15-1 & J15-2, repair broken wire or reconnect loose plug/pin.
133 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
3-Way Valve Coil
• The valve coil receives 12 VDC pulsesfrom the main board to change theposition of the valve.
• These pulses come too quickly tomeasure with a volt meter.
• The coil does have a resistance value ofapproximately 46Ω.
• The resistance can be measured betweenthe the following pins on the coil.
(SG27)
134 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Testing the 3-Way Valve• The valve returns to “home” at the end of every freezer defrost cycle &whenever the refrigerator is reconnected to power.
• To test the valve, disconnect the refrigerator from power forat least 15 seconds, place a finger on top of the valve &reconnect power.
• The main control overdrives the valve to the “home”position.
• You should be able to “feel” thevalve move as it returns to the homeposition.
• If movement is present, themain board and valve coil areoperating correctly.
(SG29)
135 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Refrigerant Flow
(SG14/15/16)
136 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
ClimateKeeper
(SG43)
J9
J11
N
137 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram SxS
138 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG6)
Monogram SxS
139 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG43)
Monogram SxSMake sure controls are set to either “37” & “0”
Now press any other pad to lock test mode.
140 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG52)
141 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG25)
Monogram SxS
142 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG30)
Monogram SxS
143 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG30)
Monogram SxS
144 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG30)
Monogram SxS
145 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG29)
Monogram SxS
146 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG30)
16K
147 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG49)
Monogram SxS
148 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG53)
Monogram SxS
149 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG53)
150 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram SxS
(SG54)
151 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG55)
Monogram SxS
152 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG55)
153 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG56)
Monogram SxS
154 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05 (SG56)
155 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG57)
Monogram SxS
156 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram SxS
(SG58)
157 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG58)
158 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG59)
Monogram SxS
159 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG59)
160 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG60)
Monogram SxS
161 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram SxS
(SG61)
162 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram SxS
(SG62)
163 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
164 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
(SG7)
165 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
(SG36)
Make sure controls are set to either “37” & “0”
Now press any other pad to lock test mode.
166 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
(SG36)
167 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
(SG30)
16K
168 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
(SG17)
169 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
(SG26)
170 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
(SG26)
171 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
(SG27)
172 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
(SG27)
173 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
(SG28)
174 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG32)
Monogram BMNF
175 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
(SG37)
176 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG37)
177 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
(SG38)
178 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG38)
179 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
(SG39)
180 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG39)
181 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
(SG40)
182 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG40)
183 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG41)
Monogram BMNF
184 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
(SG42)
185 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG42)
186 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
(SG43)
187 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG43)
188 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
(SG44)
189 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram BMNF
(SG45)
190 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG46)
Monogram BMNF
191 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram Inverter SxS
192 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram Inverter SxS
(SG7)
193 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG61)
Monogram Inverter SxSMake sure controls are set to either “37” & “0”
Now press any other pad to lock test mode.
194 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG61)
195 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram Inverter SxS
(SG18)
196 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG31)
197 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG31)
198 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG31)
Monogram Inverter SxS
199 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram Inverter SxS
(SG30)
200 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG30)
16K
201 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG57)
Monogram Inverter SxS
46
202 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG57)
Monogram Inverter Test• Put Refrigerator into Diagnostic Mode.• Set for the “1 – 2 Test” – Compressor Run Time.• Lift up top hinged door.• Remove cover from Main Control Board.• Set meter to ACV.• Place meter leads on Inverter wire connector (Black & Orange).• Should read line voltage – if not check wires & repair, otherwise go to next step.• Set meter to DCV.• Place meter leads on Inverter wire connector (White & Red).• Should read between 4VDC & 6VDC – if not go to next step, otherwise checkcompressor windings – any two terminals should read 10W & also check eachterminal to case, replace compressor if any windings are defective – if not,replace Inverter.
• Place meter leads on J15-1 & J15-2.• Should read between 4VDC & 6VDC – if not replace Main Board.• If correct DCV at J15-1 & J15-2, repair broken wire or reconnect loose plug/pin.
203 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG49)
204 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG50)
205 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG51)
206 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG52)
207 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG53)
208 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG54)
209 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG62)
Monogram Inverter SxS
210 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG62)
211 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Monogram Inverter BMNF
212 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG31)
Monogram Inverter BMNF
213 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG40)
Monogram Inverter BMNFMake sure controls are set to either “37” & “0”
Now press any other pad to lock test mode.
214 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG40)
Monogram Inverter BMNF
215 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG16)
Monogram Inverter BMNF
216 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG27)
217 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG27)
218 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG27)
Monogram Inverter BMNF
219 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG26)
Monogram Inverter BMNF
220 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG26/28)
Monogram Inverter BMNF
16K
221 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG35)
Monogram Inverter BMNF
46
222 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG35)
Monogram BMNF Inverter Test• Put Refrigerator into Diagnostic Mode.• Set for the “1 – 2 Test” – Compressor Run Time.• Lift up top hinged door.• Remove cover from Main Control Board.• Set meter to ACV.• Place meter leads on Inverter wire connector (Black & Orange).• Should read line voltage – if not check wires & repair, otherwise go to next step.• Set meter to DCV.• Place meter leads on Inverter wire connector (White & Red).• Should read between 4VDC & 6VDC – if not go to next step, otherwise checkcompressor windings – any two terminals should read 10W & also check eachterminal to case, replace compressor if any windings are defective – if not,replace Inverter.
• Place meter leads on J15-1 & J15-2.• Should read between 4VDC & 6VDC – if not replace Main Board.• If correct DCV at J15-1 & J15-2, repair broken wire or reconnect loose plug/pin.
223 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG30)
224 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Profile 42/48 Built-In
225 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG12)
Profile 42/48 Built-In
226 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Enter Diagnostic Mode
• To enter Diagnostic Mode, the temp display MUST be lit up.• Press the freezer & fresh food temp adjust pads simultaneously for 3 seconds.• The temp displays will now flash “0”.• Press any other key pad to lock in the Diagnostic Mode.• Select the test mode by using the freezer or fresh food temp pads (colder/warmer).• See chart on next page.• To exit Diagnostic Mode, either do a “1” “5” Reset or a “1” “6” Test Exit – you can
also disconnect power for 15 seconds or after 15 minutes of no pads pressed, modewill reset to normal operation.
(SG52)
227 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Diagnostic Test Chart
(SG53)
228 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG53)
229 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG54)
230 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG54)
231 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Profile 42/48 Built-In
(SG39)
232 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG23)
233 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Profile 42/48 Built-In
(SG24)
234 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Profile 42/48 Built-In
(SG24)
235 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Profile 42/48 Built-In
(SG25)
236 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Profile 42/48 Built-In
(SG25)
237 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Profile 42/48 Built-In
(SG25)
238 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG55)
Troubleshooting Notes
239 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG56)
240 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
(SG57)
241 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Electronic IM
(SG1)
242 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Electronic IM Update
243 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Electronic IM Cycle
(SG5)
244 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Electronic IM Harvest Fix Cycle
(SG3)
245 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
Electronic IM Test Cycle
(SG5)
• Make sure IM is on – green indicator is lit.
• Turn IM off.• Wait at least 20 seconds.• Turn IM back on.• Move feeler arm in 3 full times.
• IM initiates harvest test cycle.• Motor starts to turn rake & mold heater is on.• Rake turns 3600.• Water valve energized for 5.1 seconds.
246 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
247 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
248 GE CONFIDENTIAL AND PROPREITARY INFORMATION - NOT FOR PUBLIC DISCLOSURECopyright 2005 General Electric Company2/1/05
