Upload
buiminh
View
218
Download
0
Embed Size (px)
Citation preview
2 WAY CASSETTE TYPERAV-104TUH-1-PERAV-134TUH-1-PE/RAV-134AH-PERAV-164TUH-1-PE/RAV-164AH-PERAV-134TU-1-PE/RAV-134A-PERAV-164TU-1-PE/RAV-164A-PE
AIR-CONDITIONERSPLIT TYPE, HEAT PUMP
COOLING ONLY
FILE NO. A90-0031
Printed in UK NOVEMBER 2000
TOSHIBA
SERVICE MANUAL
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
3
CONTENTS
1. SPECIFICATIONS 42. CONSTRUCTIONS VIEWS 73. WIRING DIAGRAMS 94. SPECIFICATIONS OF ELECTRICAL PARTS 135. REFRIGERANT PIPING DIAGRAMS 186. PERFORMANCE CHARACTERISTICS 237. EXPLODED VIEWS AND PARTS LISTS 26
The units referred to within this Manual conform with the protection requirements of Directives 89/336/EECElectromagnetic Compatibility and 73/23/EEC Low Voltage.
Operating conditions of units are as follows:
SUMMARY
OUTDOOR TEMPERATURE
ROOM TEMPERATURE
ROOM HUMIDITY
-2 to 43˚C (COOL)-10 to 21˚C (HEAT)
18 to 32˚C (COOL)15 to 29˚C (HEAT)
LESS THAN 80% (COOL)
Diameter (mm)
Nominal Diameter (inch)
6.4 9.5 12.7 15.9 19 22
1/4 3/8 1/2 5/8 3/4 7/8
Cooling Capacity is based on the following temperature conditions:Indoor air inlet temperature 27˚C DB, 19˚C WB.Outdoor air inlet temperature 35˚C DB.
Heating Capacity is based on the following temperature conditions:Indoor air inlet temperature 20˚C DB.Outdoor air inlet temperature 7˚C DB, 6˚C WB.
For details on Control Circuits, refer to Service Manual A90-9925.
Metric/Imperial pipe conversion:
Note 1:
Note 2:
Note 3:
Note 4:
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
4
1. SPECIFICATIONS
Cooling capacityHeating capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)Refrigerant
Interconnectionpipe
Condensate drain pipe diameterAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputCeiling Panel ModelAppearance Colour
Dimensions
Net WeightAir Filter
kWkWPhaseVHzkW%AAdB(A)
mm
mm
mm
mmmmmmkg
m3/hrW
mmmmmmkg
2.52.81
220-24050
0.0793
0.330.6
40/36/34R407Cø12.7Flareø6.4Flare
ø25.5 (OD)Grey (galvanized steel & thermal insulation)
19091048023
Finned tubeTransverse flow fan
5507 x 2
RBC-U134PG(W)-ESilky white (Munsell 2.9Y8.9/0.8)
251,0505504.5
Washable
Indoor Unit (High/Med/Low)Name of RefrigerantLarger side sizeCoupler styleSmaller side sizeCoupler style
HeightWidthDepth
HeightWidthDepth
RAV-104TUH-1-PE
Specifications are subject to change without notice
Item Model
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
5
1. SPECIFICATIONS
Cooling capacityHeating capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)
Refrigerant
Refrigerant control
Interconnection pipe
Condensate drain pipe diameterINDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputOUTDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeOutdoor fan typeAir flow volumeFan motor output
Compressor
Protective device
CEILING PANEL modelAppearance colour
Dimensions
Net weight
Air filter
kWkWPhaseVHz
kW%AAdB(A)dB(A)
kgg/m
mm
mm
m
m
mmmm
mmmmmmkg
m3/hW
mmmmmmkg
m3/hW
kW
mmmmmmkg
3.64.21
220-24050
COOLING HEATING2.0 2.1588 909.9 10.4
6040/36/34
50R407C
1.0535
Capillary tube & Expansion valveø12.7Flareø6.4Flare7.5
30
1530
ø25.5 (OD)RAV-134TUH-1-PE
Grey (galvanized steel & thermal insulator)
19091048023
Finned tubeTransverse flow fan
7007 x 2
RAV-134AH-PEBronze white (Munsell 6Y7.5/1)
74088031061
Finned tubePropeller fan
2,70039
PG330X3F-4LS1.5
RBC-U134PG(W)-ESilky white (Munsell 2.9Y8.9/0.8)
25
1,050
550
4.5
Washable
4.55.01
220-24050
COOLING HEATING2.2 2.290 89
10.6 10.760
41/37/3550
R407C1.235
Capillary tube & Expansion valveø12.7Flareø6.4Flare7.5
30
1530
ø25.5 (OD)RAV-164TUH-1-PE
Grey (galvanized steel & thermal insulator)
19091048023
Finned tubeTransverse flow fan
7507 x 2
RAV-164AH-PEBronze white (Munsell 6Y7.5/1)
74088031061
Finned tubePropeller fan
2,70039
PG350X3F-4LS1.5
RBC-U134PG(W)-ESilky white (Munsell 2.9Y8.9/0.8)
25
1,050
550
4.5
Washable
Indoor Unit (High, Med, Low)Outdoor UnitName of RefrigerantCharge VolumeAdd. Volume (20-30m)
Larger side sizeCoupler styleSmaller side sizeCoupler styleStandard lengthMaximum actual pipe length(of one way)Maximum height differenceIf Indoor Unit higherIf Outdoor Unit higher
HeightWidthDepth
HeightWidthDepth
ModelOutput
HeightWidthDepth
Specifications are subject to change without notice
High pressure switch, fuse, crankcase heater, inner overload relay, bi-metal thermostat
Item Model RAV-164TUH-1-PERAV-134TUH-1-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
6
1. SPECIFICATIONS
Cooling capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)
Refrigerant
Refrigerant control
Interconnection pipe
Condensate drain pipe diameterINDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputOUTDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeOutdoor fan typeAir flow volumeFan motor output
Compressor
Protective device
CEILING PANEL modelAppearance colour
Dimensions
Net weight
Air filter
kWPhaseVHz
kW%AAdB(A)dB(A)
kgg/m
mm
mm
m
m
mmmm
mmmmmmkg
m3/hW
mmmmmmkg
m3/hW
kW
mmmmmmkg
3.61
220-24050
COOLING2.0889.960
40/36/3450
R407C1.0535
Capillary tubeø12.7Flareø6.4Flare7.5
30
1530
ø25.5 (OD)RAV-134TU-1-PE
Grey (galvanized steel & thermal insulator)
19091048023
Finned tubeTransverse flow fan
7007 x 2
RAV-134A-PEBronze white (Munsell 6Y7.5/1)
74088031058
Finned tubePropeller fan
2,70039
PG330X3F-4LS1.5
RBC-U134PG(W)-ESilky white (Munsell 2.9Y8.9/0.8)
25
1,050
550
4.5
Washable
4.51
220-24050
COOLING 2.290
10.660
41/37/3550
R407C1.235
Capillary tubeø12.7Flareø6.4Flare7.5
30
1530
ø25.5 (OD)RAV-164TU-1-PE
Grey (galvanized steel & thermal insulator)
19091048023
Finned tubeTransverse flow fan
7507 x 2
RAV-164A-PEBronze white (Munsell 6Y7.5/1)
74088031058
Finned tubePropeller fan
2,70039
PG350X3F-4LS1.5
RBC-U134PG(W)-ESilky white (Munsell 2.9Y8.9/0.8)
25
1,050
550
4.5
Washable
Indoor Unit (High, Med, Low)Outdoor UnitName of RefrigerantCharge VolumeAdd. Volume (20-30m)
Larger side sizeCoupler styleSmaller side sizeCoupler styleStandard lengthMaximum actual pipe length(of one way)Maximum height differenceIf Indoor Unit higherIf Outdoor Unit higher
HeightWidthDepth
HeightWidthDepth
ModelOutput
HeightWidthDepth
Specifications are subject to change without notice
fuse, crankcase heater
RAV-164TU-1-PERAV-134TU-1-PEItem Model
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
7
2. CONSTRUCTION VIEWS
48033076 76
190
70840
Hanger bolt(4-M10)
A
190
25
Drain pipe joint(outer ø25.5)
Refrigerant piping joint(Liquid ø6.4)
Refrigerant piping joint(Gas ø12.7)
66
73
Panel outer dimension 1050
Ceiling opening 1010Hang bolt pitch 930
840
2040
7040
2040
11090
Pan
el o
uter
dim
ensi
on 5
50
Cei
ling
open
ing
510
480
Han
g bo
lt pi
tch
410
TOSHIBA
1050
550
600Minimum
600Minimum
600Minimum
200
Space required for service and installation
View A
(Unit: mm)96 13
1
156
Wiring connection
2.1 Indoor UnitRAV-104TUH-1-PERAV-134TUH-1-PERAV-164TUH-1-PERAV-134TU-1-PERAV-164TU-1-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
8
880Air outlet
104
500
380
320
37 566Blow out guidemounting hole(4-ø3 embosses)
90
88
Handle(Both sides)
310
Electricparts box
Earth screw (M6)
Terminal cover
740
364
18
12
165117
40
340
12 4550
790
70
360
280
30
5070
45
Hole for drain(2xø19 hole)
Knock-out hole for drain(2-20x60 slots)
Anchor bolt hole(4-12x18slots)
Refrigerant pipe connection(Liquid ø6.4)
Refrigerant pipe connection(Gas ø12.7)
When installed with theinlet facing the wall
(Space for wiringand piping)
500
300
100
OutletOutlet (Space for wiringand piping)
100 100
500
Space required for service
When installed with theoutlet facing the wall
2. CONSTRUCTION VIEWS
2.2 Outdoor UnitRAV-134AH-PERAV-164AH-PERAV-134A-PERAV-164A-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
9
3. WIRING DIAGRAMS
1
3
1
3
1
3
1
32 2
4 4
TR
CN01(TRANS)
CN12
3
1
3
122
CN15(LAN)
53113571357 531
TA
CN04(TA)
CN05(TC)
TC
RE
MO
CO
N
RY02
RY03
RY04
UL
L
M
H
CN07(FAN)
RY01 RY06
CN10(PUMP)
F (L1) (N)CN03
(SERIAL)
RY07
X Y A B C
X Y
CentralRemote
Controller(Optional)
A B C
RemoteController(Optional)
Indoor unit
RE
D
PU
R
RE
D
GR
Y
BLK
RY01(output)
RED
YEL
BLU
ORG
BLK
Outdoor unit
1 2 3
1 2 3
NL
F2
(1 Phase model)
PowerSupply220/240V~50Hz
123456789
101112131415
123456789
101112131415
DM
CS
F3
TR
InterfacePCB
SM01
SM02
WH
I
RED
YELBLU
ORGBLK
WHI
RED
123456
123456
123456
123456
FM02
FM01
RED
WH
I
WHI
REDYEL
ORGBLU
BLK
RC02
RC01
WH
I
WH
I
1 12 2
GR
Y
GR
YCN09(WHI)
(LOUVER) BLK
BLK
EarthScrew
GRN/YEL
CN02
YELORG
BLU
RE
D
GRYGRY
ORGBLUBLKYEL
WH
I
CN21
1 351 35
22
664
4
1 1
3 3
5 5
7 7
9 9
3.1 RAV-104TUH-1-PERAV-134TUH-1-PERAV-164TUH-1-PE
Shows terminal block and figures show terminal numbers.Broken lines show wiring at site.
Do not operate the units with the magnetic contactor pushed in.
Symbol Name Symbol NameFM01, 02 Fan Motor F Fuse (PCB)RC01,02 Running Capacitor F3 Fuse (Interface) PCB
TR Transformer DM Drain PumpTA Sensor SM01, 02 Stepper MotorTC Sensor CS Float Switch
RY01~RY07 Relay
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
10
3. WIRING DIAGRAMS
RED
YEL
BLU
ORG
BLK
1 2 3
123456789
101112131415
123456789
101112131415
DM
CS
F3
TR
SM01
SM02
WH
I
RED
YELBLU
ORGBLK
WHI
RED
123456
123456
123456
123456
FM02
FM01
REDW
HI
WHI
REDYEL
ORGBLU
BLK
RC01
RC02
WH
I
WH
I
BLK
BLK
GRN/YEL
1
3
1
3
1
3
1
32 2
4 4
TR
CN12
3
1
3
1
CN02
22
A B C
YELORG
BLU
RE
D
ORGBLU
BLKYEL
WH
I
5
7
5
766
CN01(TRANS)
TA
CN04(TA)
CN05(TC)
TC
RY02
L
M
H
CN07(FAN)
F(L1) (N) C
N03
1
3
5
7
1
3
5
7
99
75317531
3131
CN11(FLOAT)
RY03
RY01 RY14RY07
RY11
135135
A B C
1 2 3
NL
F2
4 634 63
55
221
1
43
1
3
5
43
6
4 2 8 743
RE
MO
CO
N
CN10(PUMP)
RY01(output)
CN09(WHI)(LOUVER)
InterfacePCB
Powersupply
220/240V~50HzOutdoor
unit
Earthscrew
(1 Phasemodel)
Indoor unit
RemoteController(Optional)
3.2 RAV-134TU-1-PERAV-164TU-1-PE
Shows terminal block and figures show terminal numbers.Broken lines show wiring at site.
Do not operate the units with the magnetic contactor pushed in.
Symbol Name Symbol Name
FM01, 02 Fan Motor F Fuse (PCB)RC01, 02 Running Capacitor F3 Fuse (Interface) PCB
TR Transformer DM Drain PumpTA Sensor SM01, 02 Stepper MotorTC Sensor CS Float Switch
RY01~RY14 Relay 43 Relay
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
11
3. WIRING DIAGRAMS
3.3 RAV-134AH-PERAV-164AH-PE
A B C 1 2 3
1 2 3
Indoor unit
Outdoor unit
Earth
EarthScrew TR
BLK WHI WHI
RY05
RY07Wave
ControlCircuit TE
TL
RED
F
BLU
BLK
654321
654321
RED
WHIFM0WHIGRY
RED
BLK
RCo
321
321
B
52CA
9 121110
F2
20SR
L C
26HD
63H
20SF
L N
49C
52C RCc
CM
CH
1 2
3 4
13 14
31 32Power Supply 220/240V~50Hz
RED
TD
Shows terminal block and figures show terminal numbers. Broken lines show wiring at site.
Do not operate the units with the magnetic contactor pushed in.
Symbol Name Symbol Name Symbol Name20SF Solenoid coil (4 way valve) CM Compressor F2 Fuse (T5A)
RY05, 07 Relay 52C Magnetic contactor 63H High pressure switch49C Inner overload relay FMo Fan motor CH Crankcase heater
20SR Solenoid coil (2 way valve) TL Sensor F Fuse (on PCB)RCc Running capacitor (compressor) TE Sensor TR TransformerRCo Running capacitor (fan motor) 26HD Bimetal thermostat TD Sensor (Dummy)
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
12
3. WIRING DIAGRAMS
49C
CM
654321
654321
52C
1 2
3 4
13 14
31 32
B52CA
321
321
FM0
3
1
6
5
4 2
L N
1 2 3
1 2 3
BLK
WHI
REDBLU
RC o
ORNBLK
WHI
REDBLUORN
BLK
BLUORN
RED
BLKRED
WHI
RC cRED
CH
F
Surge Absorber
6 3 F2
6 3 F1
Earthscrew
Indoor unit
Outdoor unit
Power Supply 220/240V~50Hz
3.4 RAV-134A-PERAV-164A-PE
Shows terminal block and figures show terminal numbers. Broken lines show wiring at site.
Do not operate the units with the magnetic contactor pushed in.
Symbol Name Symbol Name
49C Inner overload relay CM Compressor
RCc Running capacitor (compressor) 52C Magnetic contactor
RCo Running capacitor (fan motor) FMo Fan Motor
F Fuse (T5A) CH Crankcase heater
63F1, 2 Pressure Switch (2 Stage)
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
13
4. SPECIFICATIONS OF ELECTRICAL PARTS
No PARTS NAME TYPE SPECIFICATIONS
Output (rated) 7W, 4 pole, 230V, 1 Phase, 50Hz
AC 450V, 0.5µF
AC 187-264V
DC 12V, 80mNm
AC 230V, 0.2A
AC 230V, 0.5A
Maximum input38mA
Maximum input15.5mA
PAF-230-7-4
EVM45M504UF
ST-10568
MP35EA2
PJV-0764
FS-085-003B
Indoor unit fan motor (x2)
Running capacitor forindoor fan motor (x2)
Transformer (Indoor Unit)
Stepper motor (x2)
Drain pump
Float switch
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
1
2
3
4
5
6
7
8
RAV-104TUH-1-PE
˚C 15 20 25 30 40
kΩ 16.1 12.6 10.0 8.0 5.2
˚C -12 10
kΩ 67.5 21.3
No PARTS NAME TYPE SPECIFICATIONS
Output (rated) 7W, 4 pole, 230V, 1 Phase, 50Hz
AC 500V, 1.0µF
AC 187-264V
DC 12V, 80mNm
AC 230V, 0.2A
AC 230V, 0.5A
Maximum input38mA
Maximum input15.5mA
PAF-230-7-4
EEP2H105HQA105
ST-10568
MP35EA2
PJV-0764
FS-085-003B
Indoor unit fan motor (x2)
Running capacitor forindoor fan motor (x2)
Transformer (Indoor Unit)
Stepper motor (x2)
Drain pump
Float switch
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
1
2
3
4
5
6
7
8
RAV-134TUH-1-PE
˚C 15 20 25 30 40
kΩ 16.1 12.6 10.0 8.0 5.2
˚C -12 10
kΩ 67.5 21.3
No PARTS NAME TYPE SPECIFICATIONS
Output (rated) 7W, 4 pole, 230V, 1 Phase, 50Hz
AC 500V, 1.0µF
AC 187-254V
DC 12V, 80mNm
AC 230V, 0.2A
AC 230V, 0.5A
Maximum input38mA
Maximum input15.5mA
PAF-230-7-4
EEP2H105HQA105
ST-10568
MP35EA2
PJV-0764
FS-085-003B
Indoor unit fan motor (x2)
Running capacitor forindoor fan motor (x2)
Transformer (Indoor Unit)
Stepper motor (x2)
Drain pump
Float switch
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
1
2
3
4
5
6
7
8
RAV-164TUH-1-PE
˚C 15 20 25 30 40
kΩ 16.1 12.6 10.0 8.0 5.2
˚C -12 10
kΩ 67.5 21.3
4.1
4.2
4.3
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
14
4. SPECIFICATIONS OF ELECTRICAL PARTS
4.4
No PARTS NAME TYPE SPECIFICATIONS
Output (rated) 7W, 4 pole, 230V, 1 Phase, 50Hz
AC 500V, 1.0µF
AC 187-264V
DC 12V, 80mNm
AC 230V, 0.2A
AC 230V, 0.5A
Maximum input38mA
Maximum input15.5mA
AC 240V, 2ab
PAF-230-7-4
EEP2H105HQA105
ST-9586
MP35EA2
PJV-0764
FS-085-003B
LY2F-L
Indoor unit fan motor (x2)
Running capacitor forindoor fan motor (x2)
Transformer (Indoor Unit)
Stepper motor (x2)
Drain pump
Float switch
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
Relay
1
2
3
4
5
6
7
8
9
RAV-134TU-1-PE
˚C 15 20 25 30 40
kΩ 16.1 12.6 10.0 8.0 5.2
˚C -12 10
kΩ 67.5 21.3
No PARTS NAME TYPE SPECIFICATIONS
Output (rated) 7W, 4 pole, 230V, 1 Phase, 50Hz
AC 500V, 1.0µF
AC 187-264V
DC 12V, 80mNm
AC 230V, 0.2A
AC 230V, 0.5A
Maximum input38mA
Maximum input15.5mA
AC 240V, 2ab
PAF-230-7-4
EEP2H105HQA105
ST-9586
MP35EA2
PJV-0764
FS-085-003B
LY2F-L
Indoor unit fan motor (x2)
Running capacitor forindoor fan motor (x2)
Transformer (Indoor Unit)
Stepper motor (x2)
Drain pump
Float switch
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
Relay
1
2
3
4
5
6
7
8
9
RAV-164TU-1-PE
˚C 15 20 25 30 40
kΩ 16.1 12.6 10.0 8.0 5.2
˚C -12 10
kΩ 67.5 21.3
4.5
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
15
4. SPECIFICATIONS OF ELECTRICAL PARTS
4.6
No PARTS NAME TYPE SPECIFICATIONS
Compressor
Outdoor unit fan motor
Running capacitor for outdoor fan motor
Magnetic contactor
High pressure switch
Solenoid coil for four-way valve
Crankcase heater
Sensor for defrosting
Fuse
Sensor for cooling operation in lowambient temperature
Solenoid coil for two-way valve
Running capacitor for compressor
Transformer (Outdoor Unit)
Bimetal thermostat
1
2
3
4
5
6
7
8
9
10
11
12
13
14
RAV-134AH-PE
˚C -12 10
kΩ 67.5 21.3
˚C -12 10
kΩ 67.5 21.3
PG330X3F-4LS
SMF-230-39N-2
EEP2G405HQA114
FMCa-1S-02
ACB-2TB04W
CHV-AC240V
NEV AC 240V
MT-44MP456W
FT-67
CS-12A
Output (rated) 1.5kW, 2 pole, 220/240V, 1 Phase, 50Hz
Output (rated) 39W, 6 pole, 230V, 1 Phase, 50Hz
AC 400V, 4µF
AC 220-240V, 50Hz
Tripping pressure 30kgf/cm2GResetting pressure 23kgf/cm2G
AC 220-240V
AC 240V, 28W
Maximum input15.5mA
T5A
Maximum input15.5mA
AC 220-240V, 50Hz
AC 440V, 45µF
AC 187-264V
Tripping temperature: 110˚CResetting temperature: 90˚C
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
16
4. SPECIFICATIONS OF ELECTRICAL PARTS
4.7
No PARTS NAME TYPE SPECIFICATIONS
Compressor
Outdoor unit fan motor
Running capacitor for outdoor fan motor
Magnetic contactor
High pressure switch
Solenoid coil for four-way valve
Crankcase heater
Sensor for defrosting
Fuse
Sensor for cooling operation in lowambient temperature
Solenoid coil for two-way valve
Running capacitor for compressor
Transformer (Outdoor Unit)
Bimetal thermostat
1
2
3
4
5
6
7
8
9
10
11
12
13
14
RAV-164AH-PE
˚C -12 10
kΩ 67.5 21.3
˚C -12 10
kΩ 67.5 21.3
PG350X3F-4LS
SMF-230-39N-2
EEP2G405HQA114
FMCa-1S-02
ACB-2TB04W
CHV-AC240V
NEV AC 240V
MT-44MP456W
FT-67
CS-12A
Output (rated) 1.5kW, 2 pole, 220/240V, 1 Phase, 50Hz
Output (rated) 39W, 6 pole, 230V, 1 Phase, 50Hz
AC 400V, 4µF
AC 220-240V, 50Hz
Tripping pressure 30kgf/cm2GResetting pressure 23kgf/cm2G
AC 220-240V
AC 240V, 28W
Maximum input15.5mA
T5A
Maximum input15.5mA
AC 220-240V, 50Hz
AC 440V, 45µF
AC 187-264V
Tripping temperature: 110˚CResetting temperature: 90˚C
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
17
4. SPECIFICATIONS OF ELECTRICAL PARTS
4.8
No PARTS NAME TYPE SPECIFICATIONS
Compressor
Outdoor unit fan motor
Running capacitor for outdoor fan motor
Magnetic contactor
Pressure switch (2-Stage)
Crankcase heater
Fuse
Running capacitor for compressor
1
2
3
4
5
6
7
8
RAV-134A-PE
PG330X3F-4LS
SMF-230-39N-3
EEP2G405HQA114
FMCa-1S-02
STB-X602
MT-44MP456W
Output (rated) 1.5kW, 2 pole, 220/240V, 1 Phase, 50Hz
Output (rated) 39W, 6 pole, 230V, 1 Phase, 50Hz
AC 400V, 4µF
AC 220-240V, 50Hz
Tripping pressure 19kgf/cm2G, 21kgf/cm2GResetting pressure 13kgf/cm2G,15kgf/cm2G
AC 240V, 28W
T5A
AC 440V, 45µF
No PARTS NAME TYPE SPECIFICATIONS
Compressor
Outdoor unit fan motor
Running capacitor for outdoor fan motor
Magnetic contactor
Pressure switch (2-Stage)
Crankcase heater
Fuse
Running capacitor for compressor
1
2
3
4
5
6
7
8
RAV-164A-PE
PG350X3F-4LS
SMF-230-39N-3
EEP2G405HQA114
FMCa-1S-02
STB-X603
MT-44MP456W
Output (rated) 1.5kW, 2 pole, 220/240V, 1 Phase, 50Hz
Output (rated) 39W, 6 pole, 230V, 1 Phase, 50Hz
AC 400V, 4µF
AC 220-240V, 50Hz
Tripping pressure 21kgf/cm2G, 23kgf/cm2GResetting pressure 15kgf/cm2G,17kgf/cm2G
AC 240V, 28W
T5A
AC 440V, 45µF
4.9
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
18
Indoor unit
Cooling
Heating
Refrigerant pipe (Gas)ø12.7mm (1/2")
Refrigerant pipe (Liquid)ø6.4mm (1/4")
Distributor strainercapillary tube
TC Sensor
Heat exchanger
Strainer
5. REFRIGERANT PIPING DIAGRAMS
Indoor UnitRAV-104TUH-1-PE
5.1
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
19
Indoor unit
Cooling
Heating
Packed valve
Strainer
Liquid receiver
Capillary tubeø3.0x600Lx1P
Dryer
Expansionvalve Check
valve
Heat exchangerTL sensor
Distributor
TE sensor
Refrigerant pipe (Gas)ø12.7mm (1/2")
Refrigerant pipe (Liquid)ø6.4mm (1/4")
P2Packed valve
Line pressure
Cooling Heating
P1 High pressure Low pressure
P2 High pressureLow pressure
Strainer
Compressor
Four-way valve
High pressure switch
P1
Check joint
Outdoor unit
Capillary tubeø2.6x400Lx1P
Accumulator
Capillary tubeø0.8x1000Lx1P
2-wayvalve
Distributor strainercapillary tube
TC Sensor
Heat exchanger
Strainer
5. REFRIGERANT PIPING DIAGRAMS
5.1 Indoor Unit Outdoor UnitRAV-134TUH-1-PE RAV-134AH-PE
INDOOR UNIT OUTDOOR UNIT
Model Capillary ModelMain Bypass Cooling Bypass
Capillary Capillary Capillary
RAV-134TUH-1-PE IDø2.4x300Lx2P RAV-134AH-PE IDø2.6x400Lx1P IDø0.8x1000Lx1P IDø3x600Lx1P
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
20
5. REFRIGERANT PIPING DIAGRAMS
Distributor strainercapillary tube
TC Sensor
Indoor unit
Heat exchanger
Strainer
Cooling
Heating
Packed valve
Strainer
Liquid receiver
Capillary tubeø3.0x600Lx1P
Dryer
Expansionvalve Check
valve
Heat exchangerTL sensor
Distributor
TE sensor
Refrigerant pipe (Gas)ø12.7mm (1/2")
Refrigerant pipe (Liquid)ø6.4mm (1/4")
P2Packed valve
Line pressure
Cooling Heating
P1 High pressure Low pressure
P2 High pressureLow pressure
Strainer
Compressor
Four-way valve
High pressure switch
P1
Check joint
Outdoor unit
Capillary tubeø2.6x400Lx1P
Accumulator
Capillary tubeø0.8x1000Lx1P
2-wayvalve
5.2 Indoor Unit Outdoor UnitRAV-164TUH-1-PE RAV-164AH-PE
INDOOR UNIT OUTDOOR UNIT
Model Capillary ModelMain Bypass Cooling Bypass
Capillary Capillary Capillary
RAV-164TUH-1-PE IDø2.2x200Lx2P RAV-164AH-PE IDø2.6x400Lx1P IDø0.8x1000Lx1P IDø3x600Lx1P
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
21
5. REFRIGERANT PIPING DIAGRAMS
Indoor unit
Packed valve
Liquid tank
DryerHeat exchanger
Distributor
Refrigerant pipe (Larger side)ø12.7mm (1/2")
Refrigerant pipe (Smaller side)ø6.4mm (1/4")
Packed valve
Strainer CompressorPressure switch
Outdoor unit
Capillary tube
Accumulator
Distributor strainer& capillary tube
TC Sensor
Heat exchanger
Strainer
5.3 Indoor Unit Outdoor UnitRAV-134TU-1-PE RAV-134A-PE
INDOOR UNIT OUTDOOR UNIT
Model Capillary ModelMain Bypass
Capillary Capillary
RAV-134TU-1-PE IDø2.4x300Lx2P RAV-134A-PE IDø2.6x400Lx1P
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
22
5. REFRIGERANT PIPING DIAGRAMS
Indoor unit
Packed valve
Liquid tank
DryerHeat exchanger
Distributor
Refrigerant pipe (Larger side)ø12.7mm (1/2")
Refrigerant pipe (Smaller side)ø6.4mm (1/4")
Packed valve
Strainer CompressorPressure switch
Outdoor unit
Capillary tube
Accumulator
Distributor strainer& capillary tube
TC Sensor
Heat exchanger
Strainer
5.4 Indoor Unit Outdoor UnitRAV-164TU-1-PE RAV-164A-PE
INDOOR UNIT OUTDOOR UNIT
Model Capillary ModelMain Bypass
Capillary Capillary
RAV-164TU-1-PE IDø2.2x200Lx2P RAV-164A-PE IDø2.6x400Lx1P
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
23
6. PERFORMANCE CHARACTERISTICS
2.88
3.06
3.24
3.42
3.60
3.78
3.96
4.14
4.32
3.60
3.82
4.05
4.28
4.50
4.73
4.95
5.18
5.40
RAV-134AH-PE RAV-164AH-PE
5.04
4.83
4.62
4.41
4.20
3.99
3.78
3.57
3.36
3.15
2.94
2.73
2.52
2.31
6.00
5.75
5.50
5.25
5.00
4.75
4.50
4.25
4.00
3.75
3.50
3.25
3.00
2.75
RAV-134AH-PE RAV-164AH-PE
Capacity Ratio (%)
Capacity Ratio (%)
Room Temp. (Wet Bulb) (°C)
Room Temp. (Dry Bulb) (°C)
Am
bien
t Tem
p. (
Dry
Bul
b) (
°C)
Am
bien
t Tem
p. (
Wet
Bul
b) (
°C)
Cooling capacity
Heating capacity
(kW)
(kW)
6.1
6.2
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
24
6. PERFORMANCE CHARACTERISTICS
Cooling Capacity Ratio
Piping Length L (m) Piping Length L (m)
Out
door
Uni
t H
eigh
t H
(m
)
Out
door
Uni
t H
eigh
t H
(m
)
Heating Capacity Ratio
Cooling capacityRAV-134AH-PERAV-164AH-PE
Cooling capacityRAV-134A-PERAV-164A-PE
6.3
6.4
INDOORUNIT
H L
Cooling Capacity Ratio
Piping Length L (m)
Out
door
Uni
t H
eigh
t H
(m
)
INDOORUNIT
H L
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
25
6. PERFORMANCE CHARACTERISTICS
Piping Length/Additional Refrigerant Volume
The amount of refrigerant put into the outdoor unit at the factory is sufficient to fill up to 20m ofrefrigerant pipework.
If the length of the refrigerant pipework is 20m or less, addition of refrigerant at the installation siteis unnecessary.
If the length of the pipework exceeds 20m, extra refrigerant must be added. Refer to the tablebelow for details of the extra amounts.
Overcharge or undercharge of refrigerant in the outdoor unit will cause malfunction ofthe compressor.
The prescribed amount of the replenishment of the refrigerant is shown in the table below:
!
!
!
!
ADD ONLY R407C REFRIGERANT TO THESE UNITS!
6.5
134AH-PE
164AH-PE
134A-PE
164A-PE
0.18 0.35 — — — — 0.79 1.05 1.23 1.4 — — — —
0.18 0.35 — — — — 0.94 1.2 1.38 1.55 — — — —
0.18 0.35 — — — — 0.79 1.05 1.23 1.4 — — — —
0.18 0.35 — — — — 0.94 1.2 1.38 1.55 — — — —
MODEL(RAV-)
Recharge amount if unit is reclaimed(kg)±50g
Lessthan5m
Lessthan20m
Lessthan25m
Lessthan30m
Lessthan35m
Lessthan40m
Lessthan45m
Lessthan50m
Additional amount of refrigerant to add at installation site (kg)±50g
Lessthan20m
Lessthan25m
Lessthan30m
Lessthan35m
Lessthan40m
Lessthan45m
Lessthan50m
Filledat
Factory
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
26
7. EXPLODED VIEWS AND PARTS LISTS
1817
16
15 57
6
4
3
10
123
12
89
11
14
13
25/24
22
18
17
21
21
5
15
19
2
20
7.1 Indoor UnitRAV-104TUH-1-PERAV-134TUH-1-PERAV-164TUH-1-PERAV-134TU-1-PERAV-164TU-1-PE
RefPart No. Description ModelNo.
1 43A22007 Blower Base Assembly All2 43020288 Fan-C-F All3 43A51002 Float Switch All4 43A70008 Pump Assembly All5 43020253 Bearing All6 43071019 Drain Connection All7 43A70009 Drain Hose All8 43A60010 Terminal ABC XY All9 43A60001 Terminal 1, 2, 3 All10 43A69008 Interface PC Board All11 37555721 MF Capacitor RAV-104TUH-1-PE11 43155100 MF Capacitor RAV-134/164TU/TUH-1-PE12 43A69010 PC Board (AI) RAV-104/134/164TUH-1-PE12 43A69005 ASM Cont PC IN RAV-134/164TU-1-PE13 43A58004 Transformer (AI) RAV-104/134/164TUH-1-PE13 43A58002 Transformer RAV-134/164TU-1-PE
RefPart No. Description ModelNo.
14 43154141 Relay – LY2F-L RAV-134/164TU-1-PE15 43A21014 Fan Motor (PAF-230-7-4) All16 43A50006 Sensor Holder All17 43A22008 Motor Band L All18 43A22009 Motor Band R All19 43A44060 Refrigeration Assembly RAV-104TUH-1-PE19 43A44061 RefrigerationAssembly RAV-134TU/TUH-1-PE19 43A44062 Refrigeration Assembly RAV-164TU/TUH-1-PE20 43A72010 Drain Pan All21 43A83001 Drain Guide Assembly All22 43A88011 Owner Manual All23 43150118 Sensor – Room Temperature RAV-134/164TU-1-PE23 43A50008 Sensor – Room Temperature RAV-104/134/164TUH-1-PE24 43A50004 Sensor – Heat Exchanger All25 43A35005 TC Adapter RAV-104/134/164TUH-1-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
27
7. EXPLODED VIEWS AND PARTS LISTS
13
21
12307
229
11
10
18
15
39
29
23
525
248
40
16
19
14
32
136
17
32
41
3833
35
6
4
27
20
2631
28
34
42
44
43
7.2 Outdoor UnitRAV-134AH-PERAV-164AH-PE
RefPart No. Description ModelNo.
1 43120156 Propeller Fan All2 43A21003 Fan Motor All3 43A43016 Condensor All4 43049132 Base Spring, B All5 43149212 Base Spring, A All6 43149198 Spring Buffer All7 43A69011 PC Board All8 43A49001 High Pressure Switch All9 43060479 Terminal Block, 4P All10 43A60003 Terminal Block, 2P All11 43A60001 Terminal Block, 4P All12 43152334 Magnetic Contactor All13 43A19001 Fan Guard All14 43119368 Hanger All15 43A46004 Solenoid Coil All16 43162027 Cover, Electrical Parts All17 43107215 Sensor Holder All18 43A63001 Cord Clamp All19 43148105 Accumulator All20 43A45004 Dryer All21 43155115 MF Capacitor – Compressor All22 43155080 MF Capacitor – Fan All
RefPart No. Description ModelNo.
23 43A41506 Comp – PG330X3F-4LS RAV-134AH-PE23 43A41507 Comp – PG350X3F-4LS RAV-164AH-PE24 43146406 Packed Valve (12.7mm) All25 43A46013 Packed Valve (6.35mm) All26 43A46015 Check Joint All27 43A46014 Expansion Valve All28 43A46016 Coil, 2-Way Valve All29 43146283 Check Valve All30 43A58003 Transformer Power All31 43046151 2-Way Valve All32 43A50001 Sensor – Heat Exchanger (TL) All33 43A19001 Sensor – Heat Exchanger (TC) All34 43193063 Spring All35 43157167 Heater, Crankcase All36 43150122 Thermostat, Bi-metal All38 43A60006 Fuse T5A All39 43146418 4-Way Valve All40 43A47037 Capi Form All41 43A91016 ASM Roof Plate All42 43A91019 ASM Side Cabinet All43 43A91017 ASM Air-Out Cabinet All 44 43A91023 Fin-Guard (back) All
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
28
7. EXPLODED VIEWS AND PARTS LISTS
28
19
18
118
26
7
10
12
9
15
2024
5
4
6 2122
17
23
16
27
14
29
13
31
3
30
2
1
7.3 Outdoor UnitRAV-134A-PERAV-164A-PE
RefPart No. Description ModelNo.
1 43120156 Propellor Fan All2 43A21012 Fan Motor All3 43A43016 Condensor All4 43049132 Base Spring, B All5 43149212 Base Spring, A All6 43149198 Spring Buffer All7 43169584 Surge Absorber All8 43A49003 Pressure Switch (2 stage) All9 43A60003 Terminal Block, 2P All10 43A60001 Terminal Block, 4P All11 43152334 Magnetic Contactor All12 43A19001 Fan Guard All13 43119368 Hanger All14 43162027 Cover, Electrical Parts All15 43A63001 Cord Clamp All16 43148105 Accumulator All
RefPart No. Description ModelNo.
17 43A45001 Dryer All18 43155115 MF Capacitor – Compressor All19 43155080 MF Capacitor – Fan All20 43A41506 Comp – PG330X3F-4LS RAV-134A-PE20 43A41507 Comp – PG350X3F-4LS RAV-164A-PE21 43146406 Packed Valve (12.7mm) All22 43A46013 Packed Valve (6.35mm) All23 43193063 Spring All24 43157167 Heater, Crankcase All26 43A60006 Fuse T5A All27 43A47041 Capi Form All28 43A91016 ASM Roof Plate All29 43A91019 ASM Side Cabinet All30 43A91017 ASM Air-Out Cabinet All 31 43A91023 Fin-Guard (back) All
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
29
7. EXPLODED VIEWS AND PARTS LISTS
7.4 Ceiling PanelRBC-U134PG(W)-E
10
8
10
7
2
5
4
7
6
9
1
3
RefPart No. DescriptionNo
1 43080392 Filter2 43007108 Plate Connect (Long)3 43009504 ASM-Grille-Out4 43007107 Bushing5 43007109 Plate Connect (Short)
RefPart No. DescriptionNo
6 43009503 Grille-L-R7 43007124 Support Plate8 43009499 ASM-Grille-Out9 43421531 ASM-Motor
10 43007125 Support Plate
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
NOTES
30
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
TOSHIBAAIR CONDITIONING
www.toshiba-aircon.co.uk
MADE IN UKA90-0031
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807