A1SafeTrainig - jh.pdf

8/15/2019 A1SafeTrainig - jh.pdf

1/23

BASIC SAFETY INSTRUCTIONS FOR ALL EMPLOYEES WORKING AT

HAWIYAH GAS PLANT

EXPANSIONKINGDOM OF SAUDI ARABIA

Safety Induction


2/23

Only people with valid IDcards are allowed in the Plant

Respect traffic and driving signalsComply with speed limit indicationsWear safety belts

Rules of behaviour

Eating out ofdesignated

placesis not

permitted

Only authorizedpeople


3/23

Gas explode

Non smoking orlighting fires

Only allow indesignated areas

We are working in a Gas PlantGas does not burnt slowly


4/23

Personal ProtectiveEquipment (PPE)

Personal Protective Protective Equipment All equipment designed to be worn or held by the worker toprotect him against one or more hazards likely to endanger hissafety at work, and any addition or accessory designed to meet

this objective.

When do we need to use PPE?When there is a need to protect the worker from the risks ofthe task the worker is performing if these risks can not becontrolled by other means. Never try to use a PPE in substitution

of proper safe measures

How do we wear or use our PPE?Must be worn or carried by the worker and used in the mannerindicated by the manufacturer.


5/23


IT IS COMPULSORY FOR ALL SITE PERSONNEL TO WEARTHE FOLLOWING ITEMS OF PPE AT TIMES WHEN OUTSIDETHE OFFICE AREAS:

Safety Hard Hat

ANSI Z89.1-1981; ANSI Z89.2-1971Safety Foot wear & Safety Glasses ANSI Z87.1-1989


6/23


AS REQUIRED

Hearing Protection

Finger, Hand and Wrist ProtectionRespiratory Protection

Fall Protection-Safety Harnesses-with twin lanyards and shock absorbingunits

Additional items of PPE may be requiredwhile performing other work activities

http://www.musto.co.uk/media/images/665_666.jpghttp://www.musto.co.uk/media/images/665_666.jpghttp://www.musto.co.uk/media/images/665_666.jpghttp://www.musto.co.uk/media/images/665_666.jpg


7/23

Work Permits

Before start up any task it is necessary to:

-Check if the task require a Work Permit

-If the task require a WP, ask for one toa certified WP receiver

-Follow all safety precautions outlinedby the WP

Working without the proper WP is avery serious safety breach that shall be

dealt with a disciplinary sanction


8/23

Types of Work Permits

HOT WORK

RELEASEHAZARDOUSLIQUIDS ANDGASES


9/23

COLD WORK

CONFINEDSPACE ENTRY

Types of Work Permits


10/23

Mandatory Signboards

ROUND SHAPE

WITH A WHITE

PICTOGRAM ON

A BLUE

BACKGROUND


11/23

Warning signs

TriangularShapeBlack

Pictogram0ver yellow

background

Harmful or irritans materialsOver orange background


12/23

Prohibition signboards

Round shape

Black pictogram

on a whitebackground

red edges and

stripe


13/23

Fire-fighting Equipment

Rectangularor

square shape

Whitepictogram

on redbackground


14/23

First aid and emergencyescape facilities

Rectangularor

square shape.

White pictogramon a

greenbackground


15/23

HandlingChemical Substances

Before start up working wit a chemical substance always:

Check the label of the container Ask for instructions of how to handle the substanceUse the required PPENever stored in unsuitable or unmarked containersClean up and return to safe storage all unused dangeroussubstancesInform ASAP to your supervisor of any incident involving

Chemicals and dangerous substances


16/23

AccidentsIncidents

In case of accident:

Asses the scene and only approach if it is safe to do so andthere is not danger to your own safety

IF FEASIBLE remove the source of the hazard (stopmachinery, shut a valve or electrical switch etc)

Call for help from the Emergency and first aid people asrequired

Do not interfere with the casualties if your are not qualified to

do so

Wait for help until a qualified person allows you to go

Inform to your supervisor ASAP of any incident/ accidentregardless how insignificant the injury may seem


17/23

Emergency andevacuation procedures

Emergency and Evacuation procedures are displayed in eachoffice and other prominent locations through the workplaceand each employees have the duty to know them, learning

how to behave in case of an Emergency and Evacuation

In case of an Emergency /Evacuation allpersonnel including visitors must:

Follow the instructions lay down in the Emergencyand Evacuation plan

Follows the indications of the EmergencyCoordinator

Report to the nearest assembly point on foot


18/23


Alarm Sound and time

Stop work Alarm sound for one minute, a red push bottom isavailable at the stop work station through thePlant, will be activate with a single push; the stopwork alarm is for local plant area

Emergency

disateralarm

The siren will be activated for two continuous

minutes blast

All clear Three blast of the plant siren. Each blast last for 10seconds with a pause of ten seconds between eachblast

Hawiyah Gas Plant Gas Emergency Alarm System


19/23


Alarm test schedule

Stop Work Alarm

Every Saturday at 11,30 hours

Emergency/Disaster

Alarm Every Saturday at 12,30 hours

Remember:

If you are in charge of visitors, you are responsible toadvice them on how to act in case of emergency, ensuringthat they comply with all required Emergency Procedures


20/23

YES

NO

NO

Environment careand waste disposal


21/23

Environment Protection

Industrial waste shall be separated according to theircharacteristics:

Class I Dangerous Waste

Class II Urban solid Waste(biodegradable or chemicaldecomposable waste)

Class III Inert Waste

and disposed of at designated places

All rubbish shall be deposited in the appropriate bins.


22/23

Discipline

Horseplaying, fighting, gambling, possession of deadlyweapons, sleeping on site is STRICTLY PROHIBITED

Driving a vehicle in excess of the stipulated/posted speedlimit

Putting your life or the lives of others at risk (imminentdanger)

Smoking in vehicles, offices and any other unauthorizedarea.

Violating permit conditions or performing work without apermit where an approved permit is needed

The following regulation are an example of behaviourthat wont be permitted on Hawiyah Project:


23/23

Disregarding barriers (unauthorized access into an areamarked as being unsafe or unauthorized access into arestricted area.)

Energizing or de-energizing a power source withoutproper authorization

Operating vehicles or equipment without a license orwithout authorization

Any wilful safety breach or misbehaviourshall carry a disciplinary action

Discipline

Documents

A1SafeTrainig - jh.pdf