Upload
others
View
5
Download
0
Embed Size (px)
Citation preview
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Green BuildingThe need for Water Born ProductsGreen BuildingThe need for Water Born Products
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Learning track and objectives
Insight
•Need to build green•Green building benefits•Key market drivers & sectors
Know
•Main Certification Standards•LEED v4 and relevant knowledge
•Jotun’s support
Act
•LEED Project Approach•Jotun’s Green Building Solutions•Why water born coatings?
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Global Warming
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Scary future
Green forest converted to deserts
SINCE RIO 1992, GLOBAL FOREST COVER HAS DECREASED BY THREE MILLION SQUARE KILOMETRES
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective Global Population
9 billion 2045
7 billion 2011
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Cities grew as well
Disturbed eco balance
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Mass consumption, mass production, mass waste
Mass Consumption of natural resources Mass‐Consumption
Mass‐Production Mass Energy productionGBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Cities consume 75% of the world’s energy and produce 80% of its green house gas emission
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
WHO says air pollution in many cities is breaching its guidelines
• The World Health Organization says 1,600 cities in 91 countries revealed that nearly 90% of people in urban centers breathe air that fails to meet levels deemed safe!
• Half of the world's urban population is exposed to pollution at least 2.5 times higher than it recommends.
• Beijing had the highest recorded pollution in April 2014
• Tehran Air Pollution Keeps Iran's Capital Shut Down 2013
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Greenhouse effect – is it good or bad?
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Scary future
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Green Building
US Environmental Protection Agency defines green building as:
•the practice of creating structures and using processes that are environmentally responsible and resource-efficientthroughout a building's life-cycle.
•also known as a sustainable or high performance building
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Conventional vs.
GreenBuildings
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Social benefits: Health & Productivity
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Cost premium: perception gap
Source: The Business Case for Green Building, World Green Building Council
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Green building standards - examples
LEED: Leadership in Energy & Environmental Design
BREEAM: Building Research Establishment Environmental Assessment Methodology
HKGBC: Hong Kong Green Building Counsel
"Estidama" is the Arabic word for sustainability
Three Star
BCA Green Mark
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
LEED v4 goals
LEED v4 assigns the highest values to credits that will most significantly further one or more of these goals:
LEED v4 evaluates building projects based on their ability to fulfill the following goals:
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
LEED v4 – certification levels
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
LEED v4 aiming for zero impact
V4
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Green building solutions for long-term protection and beautification of green buildings
DECORATIVE COATINGInterior/Exterior
FIRE PROTECTION
FLOOR COATING
POWDER COATING
CONCRETE PROTECTION
STEEL PROTECTION
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Jotun’s contribution to points
Building product disclosure and optimization:Up to 2 points for powder, decorative and protective
Building product disclosure and optimization:Up to 2 points for powder, decorative and protective
Heat island reduction: Up to 2 points for Powder and Decorative
Heat island reduction: Up to 2 points for Powder and Decorative
Total: Up to 7 (11) points with products from Jotun
Low-emitting materials(VOC): Up to 3 points for decorative and protective
Low-emitting materials(VOC): Up to 3 points for decorative and protective
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Impact of point contribution from Jotun
up to 27-23
%
up to 18-22
%
up to 14-18
%
up to 10-14
%
up to 10-14
%
Typical value of paint in a project = 0.5-2%
approx.!
Typical value of paint in a project = 0.5-2%
approx.!
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
• “Same, same, but different”Alkyds
Acrylic
Epoxy
Polyurethane
• A coating where the traditional solvents are replaced with waterDependant on the choice of binder, small amounts of special
solvent (co-solvent), are added to melt the polymer particles together during drying
What are the water-borne coatings?
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
STEEL PROTECTION
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Green and fast
• Water-borne single pack acrylic primer & topcoat
• Low Gloss and Aluminium finishes available
• Excellent HSE profile– Reduced impact on applicator health and
environment
• Contributes towards satisfying:– Credits EQ and MR under LEED® v4
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
• Water-borne 2 pack epoxy− With visible end of pot life− Transport and storage down to sub-zero
temperatures
• Minimises health risk− Low VOC and high flash point
• Meet ISO 12944- up to CX very high durability in a full system (
• Contributes towards satisfying:− Credits EQ and MR under LEED® v4
Fast and friendly
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
• Penguard WF fully complies with LEED v4 requirements for VOC content and VOC emission|
Green and friendly
A water-borne epoxy coating satisfying LEED® v4 requirements
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
FIRE PROTECTION
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Thermosafe: Implementation reviewSeptember – February 2018
Fire protection engineered for a better environment.
SteelMaster
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
• Waterborne fire protection• HAPS free, low odor• Safe for multiple trades for onsite application• Up to 180 minutes fire protection• Contributes towards satisfying:
– Credits EQ and MR under LEED® v4
Steelmaster 1200WB
The most efficient 120 minute thin film intumescent product globally available within it’s category
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Best performing 60 minute fire protection in the market
• Waterborne Fire Protection• Specifically designed:
– Single coat application for a majority of 60 minute steel sections– High volume solids, low odour
• Contributes towards satisfying:– Credits EQ and MR under LEED® v4
Steelmaster 600WB
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Why water born costings?
• LOW VOC
• SAFER INDOOR
APPLICATION
• LOW ODOR
• EASY MAINTENCE
BETTER HSE
WB Intumescent paint application
GBS & WB coatings / Ashraf Wassef / August 2018
Jotun Protective
Summary
Insight
•Need to build green•Green building benefits•Key market drivers & sectors
Know
•Main Certification Standards•LEED v4 and relevant knowledge
•Jotun’s support
Act
•LEED Project Approach•Jotun’s Green Building Solutions•Why water born coatings?